Volkswagen submits Recall Plan For 2-liter Diesel Cars to California Air Resources Board
 |
SACRAMENTO November 18, 2015; Today the Volkswagen Group of America
(VW) submitted a recall plan to the California Air Resources Board
responding to the violations described in ARB’s http://www.arb.ca.gov/newsrel/in_use_compliance_letter.pdf">
September 18, 2015 letter to VW concerning illegal defeat devices in
their 2-liter diesel-powered vehicles, model years 2009-2015.
This submission initiates a review by ARB of up to 20 business days
of all elements of the plan. Based on ARB’s review, VW may be
required to revise and resubmit all, or specific elements of the recall
plan. ARB will also consult with U.S. EPA during this process to develop a
national recall plan.
Required elements of a recall plan include,
but are not limited to, the projected timeline of the full recall process
from initiation to completion (including how owners are located), the
content of a company’s communications with them about the recall, and
a plan for following up on the progress of the recall campaign. The recall
plan must set out the projected time to fix each vehicle.
The
remedy proposed in the recall must not only fix the violation in question,
it must also address the safety, drivability, vehicle durability and fuel
efficiency of the cars involved.
Detailed Legal
Requirements:
The required elements for an approvable recall plan are
detailed in the California Code of Regulations (13 CCR 2113-2121 and 40 CFR
§85.1803) and include but are not limited to:
a. The
description of the vehicles and affected California and U.S. population
b. Description of the nonconformity and the specific
recalibration and hardware corrective actions to return the vehicles to the
certified configuration (i.e., no defeat device and emission
compliant)
c. A description of the method by which the
manufacturer will determine the names and addresses of vehicle owners and
the method for notifying the service facilities and vehicle owners of the
recall
d. A description of the procedure to be
followed by the vehicle owner to obtain correction. This shall
include the date on or after which the owner can have the nonconformity
remedied, the time reasonably necessary to perform the labor, and the
designation of the facilities that can perform the work
e.
A copy of the owner’s notification letter
f.
A description of the system by which the manufacturer will assure
adequate supply of parts
g. A copy of all instructions
that will be sent to those performing the repair
h. A
description of the impact of the proposed repairs or adjustments on fuel
economy, drivability, performance and safety of each vehicle recalled and a
brief summary of the data, technical studies, or engineering evaluations
which support the data
i. The estimate of the capture
rate from the proposed recall and registration tracking of repaired and
unrepaired Vehicle Identification Numbers at the DMV.
j.
A description of the impact of the proposed changes on the average
emissions from the vehicle to be recalled. The description shall
include:
i. Average noncompliance emission levelsk. A repair label shall be affixed to each vehicle that is corrected per the approved recall plan (13 CCR 2116)
ii. Average emission reduction per pollutant from the recall repair
iii. An estimate of the average emission level per pollutant for the vehicle adjusted for the capture rate
l. A description of the impact of the proposed changes on the On Board Diagnostic (OBD) system performance on the vehicle to be recalled. The description shall include:
i. OBD demonstration testing for all major monitorsm. The manufacturer shall require those who perform the repair to provide the owner for each vehicle or engine with a certificate indicating that a noncomplying vehicle or engine has been corrected under the recall program (13 CCR 2117)
ii. Identification and disclosure of all OBD monitoring requirements that are not met in the recall calibration
n. The manufacturer shall report on the progress of the recall campaign by submitting subsequent reports for six consecutive quarters commencing with the quarter after the recall campaign begins. Such reports shall be submitted no later than 25 days after the close of each calendar quarter (13 CCR 2119)