Mercury Buyers Guide
Click a car name to see the crash test details for that model.
Crash Test Data for 2004 Mercury
| Mercury Vehicle | Front Star Rating | Side Star Rating | Rollover Resistance Rating | ||
|---|---|---|---|---|---|
| Driver | Passenger | Front Seat | Rear Seat | ||
| 2004 Grand Marquis |  | |  | | |
| 2004 Grand Marquis | | | | | |
| 2004 Marauder | | | | | |
| 2004 Monterey | | | | | |
| 2004 Mountaineer | | | | |  |
| 2004 Sable | | | Not Tested | Not Tested | |
| 2004 Sable | | | | | |
| 2004 Sable | | | | | |
Service Bulletins for 2004 Mercury
| 2004 MERCURY GRAND MARQUIS | |
|---|---|
| Bulletin Number: 031404 | |
| ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 03228 | |
| LACK OF AIR CONDITIONER (A/C) COOLING AND RESTRICTED/REDUCED AIR FLOW THROUGH THE A/C VENTS TYPICALLY DURING EXTENDED IDLING CONDITIONS. *TT | |
| Bulletin Number: 03256 | |
| ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003. *MJ | |
| Bulletin Number: 04145 | |
| ENGINE VIBRATION AT IDLE ON VEHICLES EQUIPPED WITH SINGLE EXHAUST. *TT | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 041515 | |
| DIAGNOSTIC TROUBLE CODE (DTC) P0442. *TT | |
| Bulletin Number: 04155 | |
| SQUEAK OR RUBBING NOISE FROM FRONT SUSPENSION - FRONT SPRING INSULATOR REVISED. *TT | |
| Bulletin Number: 041601 | |
| WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04189 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 0421 | |
| ENGINE KNOCK DURING INITIAL COLD START, THE KNOCK WILL CEASE AFTER THE ENGINE IS FULLY WARMED UP. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 042111 | |
| MALFUNCTION INDICATOR LAMPAND P0460 DTC IN MEMORY. *EH | |
| Bulletin Number: 04217 | |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 042407 | |
| NUMEROUS ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR (WSS) DTCS, SUCH AS C1145, C1155, C1165, C1175, C1296, C1297, C1298, C1299 AND C1222. *TT | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 04247 | |
| NUMEROUS ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR (WSS) DIAGNOSTIC TROUBLE CODES (DTCS). *TT | |
| Bulletin Number: 04251 | |
| ALUMINUM CORROSION - SERVICE TIP. *TT | |
| Bulletin Number: 0476 | |
| NOISE-CLIMATE CONTROL-REGISTER VENT RATTLE WITH A/C BLOWER ON. *MJ | |
| Bulletin Number: 04E12 | |
| EMISSION RELATED SERVICE ACTION 04E12. VEHICLES SERVICED WITH AN INCORRECT RIGHT HAND CATALYTIC CONVERTER. INSPECT AND REPLACE RIGHT HAND CATALYTIC CONVERTER. ATTACHMENTS I-III AND CUSTOMER NOTIFICATION LETTER. *TT | |
| Bulletin Number: 0523 | |
| DELAYED REVERSE ENGAGEMENT. *EH | |
| Bulletin Number: 0524 | |
| IDLE VIBRATION VEHICLES EQUIPPED WITH SINGLE EXHAUST. *EH | |
| Bulletin Number: 0531 | |
| MAF DIAGNOSTIC SERVICE TIP - VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM). *TT | |
| Bulletin Number: 06216 | |
| LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS. *TT | |
| Bulletin Number: 06910 | |
| CATALYTIC CONVERTER BRICK RATTLE OR BUZZING NOISE. *TT | |
| Bulletin Number: 07212 | |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE | |
| Bulletin Number: 13 | |
| STEERING GEAR YOKE PLUG LOCK RING TORQUE. ALSO INCLUDING THE 2004 MERCURY MARAUDER. *MR | |
| Bulletin Number: 17295 | |
| FLICKERING ELECTRONIC INSTRUMENT CLUSTER DISPLAY, ELECTRONIC AUTOMATIC TEMPERATURE CONTROL DISPLAY, RADIO DISPLAY, AND/OR OVERHEAD CONSOLE DISPLAY. *TT | |
| Bulletin Number: 17297 | |
| PASSIVE ANTI-THEFT SYSTEM (PATS) DO NOT COME WITH A STEERING WHEEL LOCK. *TT | |
| Bulletin Number: 17313 | |
| STEERING NIBBLE - SERVICE TIP. *TT | |
| Bulletin Number: 17502 | |
| SLOW OR BINDING SIDE DOOR GLASS OPERATION. *TT | |
| Bulletin Number: 17516 | |
| INTERMITTENT HORN SELF-ACTIVATION. *TT | |
| Bulletin Number: 17545 | |
| COSMETIC CRACKING OF LOWER CONTROL ARM BUSHING SLEEVE. *MJ | |
| Bulletin Number: 17745 | |
| DIAGNOSTIC TROUBLE CODE (DTC) P1233 WITH POSSILE DRIVEABILITY OR NO START CONDITION. *TT | |
| Bulletin Number: 17757 | |
| INTERMITTENT RAPID FLASHING OF THE TURN SIGNALS. *TT | |
| Bulletin Number: 17809 | |
| A NO CRANK/NO START. CONNECTOR C192 OR C146 NOT FULLY CONNECTED. *TT | |
| Bulletin Number: 17810 | |
| TRANSMISSION FAILURE WHERE THERE IS A LARGE AMOUNT OF METAL OR DEBRIS IN THE PAN. *TT | |
| Bulletin Number: 17876 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0442 OR P0456. *TT | |
| Bulletin Number: 18222 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0460 IN CONTINUOUS MEMORY. OASIS. *TT | |
| Bulletin Number: 18383 | |
| AM/FM AND CELLULAR PHONE RECEPTION INTERFERENCE - SERVICE TIP. *TT | |
| Bulletin Number: 18426 | |
| AM FM AND CELLULAR PHONE RECEPTION INTERFERENCE . *EH | |
| Bulletin Number: ASI-45182 | |
| SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| Bulletin Number: CSP-14-N-01 | |
| FORD: THE LIGHTING CONTROL MODULE HAS EXTENDED WARRANTY COVERAGE, ON CERTAIN VEHICLES, DUE TO A POSSIBLE CRACK ON SOLDER JOINT THAT CONNECTS RELAY TO CIRCUIT BOARD. MODEL 2003-2005 CROWN VICTORIA, GRAND MARQUIS. *PE | |
| Bulletin Number: CSP-14N01 | |
| FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION REGARDING THE LIGHTING CONTROL MODULE EXTENDED WARRANTY COVERAGE, FOR SOME VEHICLES, TO 15 YEARS OR 250,000 MILES, WHICHEVER OCCURS FIRST. MODEL 2003-2005 VICTORIA, GRAND MAR | |
| Bulletin Number: SSM 46085 | |
| The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate | |
| Bulletin Number: TSB 19-2026 | |
| Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo | |
| 2004 MERCURY MARAUDER | |
| Bulletin Number: 06513 | |
| ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE (DTC) PEWEE, P0302, P0303, P0304, P0305, P0306, P0307, P0308, AND P0316. *TT | |
| Bulletin Number: 17492 | |
| ANTI-LOCK BRAKE SYSTEM (ABS) LIGHT ON WITH DIAGNOSTIC TROUBLE CODE (DTC) C1222 (SPEED WHEEL MISMATCH). *TT | |
| Bulletin Number: 17545 | |
| COSMETIC CRACKING OF LOWER CONTROL ARM BUSHING SLEEVE. *MJ | |
| Bulletin Number: TSB 19-2026 | |
| Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo | |
| 2004 MERCURY MARINER | |
| Bulletin Number: 05310 | |
| SAFETY BELT WEB STOP BUTTON SERVICE. *EH | |
| Bulletin Number: 18281 | |
| CONDENSATION INSIDE THE FOGLAMPS. *EH | |
| Bulletin Number: SSM 46085 | |
| The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate | |
| 2004 MERCURY MONTEREY | |
| Bulletin Number: 02184 | |
| POWER SLIDING DOOR OPERATION AND DIAGNOSTIC SERVICE TIPS. *TT | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 032013 | |
| ROOF RACK SIDE RAIL COVER INSTALLATION INSTRUCTIONS. *TT | |
| Bulletin Number: 03242 | |
| TRAILER TOW SERVICE KIT - SERVICE TIP. *TT | |
| Bulletin Number: 03L17 | |
| DEMONSTRATION/DELIVERY HOLD - SPECIAL FIELD ACTION 03L17. REVISED SMOG EMISSIONS INFORMATION. *TT | |
| Bulletin Number: 04125 | |
| DIAGNOSTIC TROUBLE CODE (DTC) C1991 (MODULE CALIBRATION FAILURE) - ANTI-LOCK BRAKE, ADVANCED TRAC, INTERACTIVE VEHICLE DYNAMICS (IVD), TRACTION CONTROL SYSTEM - SERVICE TIP. ALSO INCLUDES FORD FREESTAR MY2005 AND MERCURY MONTEREY MY2005. | |
| Bulletin Number: 04135 | |
| FRONT DOOR GLASS CLICK/SNAP NOISE AT THE END OF THE UPWARD GLASS POSITION. *TT | |
| Bulletin Number: 04147 | |
| SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS. *TT | |
| Bulletin Number: 04148 | |
| FRONT BLOWER MOTOR WHISTLE NOISE. *TT | |
| Bulletin Number: 041512 | |
| 4F50N TRANSAXLE NO 1-2 UPSHIFT AND DIAGNOSITC TROUBLE CODE P0732. *TT | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 041613 | |
| NOISE FROM FRONT WHEEL HUB BEARING. * AR | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04189 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 042117 | |
| 3RD ROW SEAT STRAP BREAKING. *EH | |
| Bulletin Number: 04217 | |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04229 | |
| ACCESS DOOR WRAPED OR BREAKING OFF FROM THE UNDERSIDE OF THE STEERING WHEEL SHROD. *EH | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 042510 | |
| POWER SLIDING DOORS AND POWER LIFTGATE INOPERATIVE WHEN USING THE OVERHEAD CONSOLE AND/OR REMOTE KEYLESS ENTRY TRANSMITTER OPEN/CLOSE BUTTONS - DIAGNOSTIC TROUBLE CODE (DTC) C1999. *TT | |
| Bulletin Number: 042610 | |
| REAR BRAKE LINING ACCELERATED WEAR. *TT | |
| Bulletin Number: 04262 | |
| FALSE PARKING AID WARNINGS. *TT UPDATE. *TT | |
| Bulletin Number: 0471 | |
| WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT | |
| Bulletin Number: 05145 | |
| ERRATIC FLUID LEVEL READING ON TRANSAXLE DIPSTICK-LEAKS-4F50N, AX4N, AX4S TRANSAXLE. *SC | |
| Bulletin Number: 0531 | |
| MAF DIAGNOSTIC SERVICE TIP - VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM). *TT | |
| Bulletin Number: 05310 | |
| SAFETY BELT WEB STOP BUTTON SERVICE. *EH | |
| Bulletin Number: 05419 | |
| FALSE PARKING AID WARNINGS. *TT | |
| Bulletin Number: 05617 | |
| TRACTION CONTROL LAMP - ABS LAMP - ABS SELF ACTIVATION WITH DTC C1288. *TT UPDATED 11/8/07. *NJ | |
| Bulletin Number: 0598 | |
| A BROKEN OUTER C/V JOINT ON VEHICLES BUILT BEFORE 5/1/2005. *TT | |
| Bulletin Number: 06218 | |
| ADVANCED TRACTION CONTROL SYSTEM - DURATION ACTIVATION. *KB | |
| Bulletin Number: 071011 | |
| ADVANCED TRACTION CONTROL SYSTEM - SHORT DURATION ACTIVATION. *KB | |
| Bulletin Number: 0712 | |
| POWER STEERING HOSE LEAK NEAR COOLER EXTREME COLD CLIMATE AREAS ONLY -4 DEGREES AND COOLER. *KB | |
| Bulletin Number: 15679 | |
| SLIDING DOOR(S) CONTACTING THE REAR QUARTER GLASS. *TT THIS INFORMATION UPDATES PREVIOUS INFORMATION, DATED 03/01/2002. *TT | |
| Bulletin Number: 17156 | |
| DIAGNOSTIC TROUBLE CODE U1262 (SCP COMMUNICATION BUS FAULT) AND/OR U1135 (SCP INVALID OR MISSING DATA FOR IGNITION SWITCH/STARTER) STORED IN THE INSTRUMENT CLUSTER. *TT | |
| Bulletin Number: 17157 | |
| PASSIVE ANTI-THEFT SYSTEM (PATS) DIAGNOSTIC TROUBLE CODE (DTC) B1600 AND/OR B1602 WITH NO RELATED SYMPTOMS. *TT | |
| Bulletin Number: 17237 | |
| DIAGNOSTIC TROUBLE CODE (DTC) U1130 (SCP INVALID OR MISSING DTA FOR FUEL SYSTEM) STORED IN THE INSTRUMENT CLUSTER. *TT | |
| Bulletin Number: 17242 | |
| TRAILER TOW INSTALLATION AND WIRING HARNESS CONNECTOR INCOMPATIBILITY CONCERNS. *TT | |
| Bulletin Number: 17277 | |
| BEEPING SOUND FROM THE INSTRUMENT PANEL WHEN DRIVING AT/OVER 75 MPH, TRACTION CONTROL OFF INDICATOR ILLUMINATE WHEN VEHICLE IS NOT EQUIPPED WITH TRACTION CONTROL, AND/OR DIAGNOSTIC TROUBLE CODE B2477 (MODULE CONFIGURATION FAILURE) STORED IN | |
| Bulletin Number: 17283 | |
| TIRE PRESSURE MONITOR RESET PROCEDURE FOR BASE CLUSTER. *TT | |
| Bulletin Number: 17284 | |
| LOW TIRE PRESSURE MONITOR RESET FOR MESSAGE CENTER. *TT | |
| Bulletin Number: 17300 | |
| TRACTION CONTROL OR ANTI-LOCK BRAKE SYSTEM (ABS) WARNING LIGHT ON IN THE INSTRUMENT CLUSTER, ACCOMPANIED BY DIAGNOSTIC TROUBLE CODE C1288 (PRESSURE TRANSDUCER MAIN/PRIMARY INPUT CIRCUIT FAILURE). *TT | |
| Bulletin Number: 17358 | |
| GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE. *TT THIS BULLETIN UPDATES PREVIOUS BULLETIN 17358, DATED 11/01/2003 TO INCLUDE 2005 MODELS. *TT | |
| Bulletin Number: 17371 | |
| TRACTION CONTROL/ABS (ANTI-LOCK BRAKE SYSTEM) LIGHT ON WITH DTC (DIAGNOSTIC TROUBLE CODE) C1288. *TT | |
| Bulletin Number: 17397 | |
| FRONT WINDOW MOTORS NOT WORKING. *TT | |
| Bulletin Number: 17538 | |
| TRACTION CONTROL/ABS LIGHT ON WITH DIAGNOSTIC TROUBLE CODE (DTC) C1288. *MJ | |
| Bulletin Number: 17565 | |
| FRONT BRAKE NOISE. *MJ | |
| Bulletin Number: 17584 | |
| REMOTE ENTRY TRANSMITTERS NOT WORKING. *TT | |
| Bulletin Number: 17609 | |
| EXCESSIVE FRONT BRAKE NOISE. *TT | |
| Bulletin Number: 17892 | |
| FRONT WHEEL HUB BEARING HIGH PITCHED WHISTLING/SQUEALING NOISE FROM FRONT EXTERIOR WHILE DRIVING. ALSO INCLUDES 2005 FREESTAR AND MONTEREY. *TT | |
| Bulletin Number: 18135 | |
| 3RD ROW SEAT STRAP BREAKING (STRAP USED FOR STOWING OR ACCESSING THE REAR SEAT). *TT | |
| Bulletin Number: 18246 | |
| ACCELERATED REAR BRAKE WEAR. OASIS. *TT | |
| Bulletin Number: 18274 | |
| TRACTION CONTROL ABS AND PARK BRAKE LAMP. FLICKER FLASH ILLUMINATE. *EH | |
| Bulletin Number: 18335 | |
| INSTRUMENT CLUSTER DTC U1130. *EH | |
| Bulletin Number: 18340 | |
| INSTRUMENT CLUSTER DTC U1262 AND OR U1135. *EH | |
| Bulletin Number: 18520 | |
| STEERING WHEEL. *EH | |
| Bulletin Number: 18834 | |
| RESTRAINT CONTROL MODULE DIAGNOSTIC TROUBLE CODE B2296 - SERVICE TIP. *TT | |
| Bulletin Number: 19004 | |
| REAR CLIMATE CONTROL NOISES - SERVICE TIP. *TT | |
| Bulletin Number: SSM 46085 | |
| The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate | |
| Bulletin Number: TSB-14-0144 | |
| FORD/MERCURY: SHEET METAL SUPPORTING FOLDING 3RD ROW SEAT LATCH STRIKERS WILL EXPERIENCE CORROSION AND COMPROMISE MOUNTING POINT FOR FORWARD PORTION OF 3RD ROW SEAT, IF VEHICLE IS OPERATED IN HIGH CORROSION AREAS FOR EXTENDED PERIOD. MODEL | |
| Bulletin Number: TSB-14-0166 | |
| FORD/MERCURY: SAFETY RECALL REGARDING SHEET METAL SUPPORT FOR FOLDING 3RD ROW SEAT LATCH STRIKERS CAN EXPERIENCE CORROSION AND WILL COMPROMISE MOUNTING POINT CAUSING SEAT TO MOVE. MODEL 2004-07 FREESTAR, MONTEREY. *PE | |
| 2004 MERCURY MOUNTAINEER | |
| Bulletin Number: 031404 | |
| ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. | |
| Bulletin Number: 03144 | |
| ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 03198 | |
| CHATTER, SHUDDER, A BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNS ON VEHICLES EQUIPPED WITH THE 9.75 INCH OR 8.8 INCH LIMITED SLIP REAR AXLE. *TT | |
| Bulletin Number: 03256 | |
| ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003. *MJ | |
| Bulletin Number: 03263 | |
| ANTI-LOCK BRAKE SYSTEM (ABS) LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODE (DTC) C1235, C1236, C1237 ON VEHICLES WITH DIFFERENTIAL-MOUNTED RAR WHEEL SPEED SENSOR. *TT | |
| Bulletin Number: 03L17 | |
| DEMONSTRATION/DELIVERY HOLD - SPECIAL FIELD ACTION 03L17. REVISED SMOG EMISSIONS INFORMATION. *TT | |
| Bulletin Number: 04105 | |
| AXLE SEAL LEAKS. LEAKS FROM REAR HALFSHAFT AXLE SEAL. SERVICE TIPS. *TT | |
| Bulletin Number: 04142 | |
| NO CRANK WITH DIAGNOSTIC TROUBLE CODE B1601 AND/OR B1213. PATS SECURITY ACCESS ISSUES WITH 4.0L ENGINE. *TT | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 041601 | |
| WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT | |
| Bulletin Number: 041715 | |
| FRONT AXLE TUBE LEAK. *EH | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04189 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 041910 | |
| OIL LEAK FROM OIL FILTER ADAPTER - 4.0L SOHC ENGINE BUILT BEFORE 4/1/2004. *TT | |
| Bulletin Number: 04195 | |
| FRONT WINDOW CLUNK NOISE. *TT | |
| Bulletin Number: 04197 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTC'S) P0172 AND/OR P0175. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 042112 | |
| ROUGH IDLE IN DRIVE. *EH | |
| Bulletin Number: 042115 | |
| FUEL GAUGE SLOW TO UPDATE AFTER REFUELING. *EH | |
| Bulletin Number: 04217 | |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04219 | |
| MALFUNCTION INDICATOR LAMP (MIL) AND ELECTRONIC THROTTLE CONTROL (ETC) LAMPS ON WITH BOTH DIAGNOSTIC TROUBLE CODE (DTC) P2106 AND P2135. *TT | |
| Bulletin Number: 042212 | |
| GEAR SELECTOR LEVER - INCREASED EFFORT TO SHIFT FROM DRIVE TO PARK. *TT | |
| Bulletin Number: 04225 | |
| THROTTLE PEDAL RESPONSE ON TIP IN VEHICLES BUILT BEFORE 10/4/2004 EQUIPPED WITH A 4.0L ENGINE. *EH | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 04251 | |
| ALUMINUM CORROSION - SERVICE TIP. *TT | |
| Bulletin Number: 04255 | |
| RATTLING NOISE - RIGHT FRONT FENDER WHILE DRIVING. *TT | |
| Bulletin Number: 04259 | |
| REAR POWER WINDOW(S) INOPERATIVE. *TT | |
| Bulletin Number: 04262 | |
| FALSE PARKING AID WARNINGS. *TT UPDATE. *TT | |
| Bulletin Number: 04268 | |
| INCREASED EFFORT DURING LOW SPEED SHARP TURNS ON 4X4 VEHICLES. *TT | |
| Bulletin Number: 0471 | |
| WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT | |
| Bulletin Number: 0485 | |
| LIFTGATE GLASS APPLIQUE DAMAGED/CRACKED. SERVICE PROCEDURE. *TT | |
| Bulletin Number: 04B15 | |
| REAR AXLE DATE CODE INSPECTION AND SERVICE. VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPER MIX OF REAR AXLE LUBRICANT AND FRICTION MODIFIER ADDITIVE. IF SO, THE CUSTOMER MAY EXPERIENCE NOISE AND VIBRATION WHILE DRIVING. *TT *MJ | |
| Bulletin Number: 04B17 | |
| SOME OF THE VEHICLES WERE BUILT WITH INSTRUMENT CLUSTERS THAT WERE NOT CONFIGURED PROPERLY FOR USE WITH A REVISED TPMS MODULE. THE TIRE PRESSURE MODULE SYSTEM (TPMS) IS FULLY FUNCTIONAL, BUT THERE IS NO VISUAL INDICATION TO A DRIVER IF THE | |
| Bulletin Number: 04B22 | |
| IMPROPERLY FORMULATED TRANSMISSION FLUID THAT, OVER TIME, MAY CAUSE DELAYED/HARSH REVERSE ENGAGEMENTS. CUSTOMER SATISFACTION PROGRAM 04B22. 5R55S/E & 5R44E TRANSMISSION FLUID ADDITIVE. *TT SUPPLEMENT #1. *TT SUPPLEMENT #2. *TT SUPP | |
| Bulletin Number: 050618 | |
| REAR AXLE NOISE REPAIR. *SC | |
| Bulletin Number: 051016 | |
| NO START/HARD START ON COLD SOAK - 4.0L ENGINE. *TT | |
| Bulletin Number: 05136 | |
| BACKGLASS DIFFICULT TO CLOSE AND AN INTERMITTENT DOOR AJAR LAMP. *TT | |
| Bulletin Number: 051710 | |
| NOISE FROM REAR WHEEL HUB BEARINGS. *TT | |
| Bulletin Number: 05213 | |
| MALFUNCTION INDICATOR LAMP ON WITH PCM DIAGNOSTIC TROUBLE CODE P0463 AND/OR IC DIAGNOSTIC TROUBLE CODE B1201 - FUEL GAUGE DROPS TO EMPTY OR SLOW TO UPDATE AFTER REFUELING. *TT | |
| Bulletin Number: 05262 | |
| MIL ON WITH DTC P0191 WITH OR WITHOUT VARIOUS DRIVABILITY SYMPTOMS AND/OR ADDITIONAL DTCS. *TT | |
| Bulletin Number: 052624 | |
| VIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT. *TT | |
| Bulletin Number: 0531 | |
| MAF DIAGNOSTIC SERVICE TIP - VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM). *TT | |
| Bulletin Number: 0537 | |
| DRIVELINE 1ST ORDER VIBRATION/BOOM/DRONE. *TT | |
| Bulletin Number: 0538 | |
| INCREASED TURNING EFFORT DURING LOW SPEED SHARP TURNS FALSE 4X4 ENGAGEMENT. *EH | |
| Bulletin Number: 0539 | |
| MIL ON AND/ OR RUNS ROUGH/MISFIRE DTCS P0300-P0308 P0316 AND OR P0171/P0174 4.6L ENGINE. *EH | |
| Bulletin Number: 05416 | |
| FRONT SEAT(S) SLIGHT MOVEMENT WHEN ACCELERATING AND/OR DECELERATING. *TT | |
| Bulletin Number: 05419 | |
| FALSE PARKING AID WARNINGS. *TT | |
| Bulletin Number: 0561 | |
| WRENCH LAMP ON AND NO DIAGNOSTIC TROUBLE CODE (DTC) STORED. *TT | |
| Bulletin Number: 05612 | |
| DELAYED OR HARSH REVERSE ENGAGEMENTS - 5R55S TRANSMISSION - VEHICLES BUILT PRIOR TO 09/23/2004. *TT | |
| Bulletin Number: 05618 | |
| REAR AXLE NOISE REPAIR. *TT | |
| Bulletin Number: 06167 | |
| MIL ON WITH DTC P0463 OR ERRATIC FUEL GAUGE OPERATION. *KB | |
| Bulletin Number: 061710 | |
| MIL ON WITH P0463 OR ERRATIC FUEL GAUGE OPERATION. *KB | |
| Bulletin Number: 06216 | |
| LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS. *TT | |
| Bulletin Number: 0637 | |
| LOW TIRE INDICATOR ON - TPMS SYSTEM SENSOR WAKE UP. *TT | |
| Bulletin Number: 07212 | |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE | |
| Bulletin Number: 17030 | |
| VEHICLES WITH A SILVER VALVE STEM TIRE PRESSURE MONITOR SYSTEM (TPMS) MAY EXHIBIT A WARNING LIGHT/MESSAGE ON. *TT | |
| Bulletin Number: 17054 | |
| AXLE WHINE AT CRUISE OR DURING ACCELERATION/ DECELERATION. *TT | |
| Bulletin Number: 17107 | |
| DRIVELINE VIBRATION ON DRONE/BOOM AT HIGHWAY SPEEDS. *TT | |
| Bulletin Number: 17165 | |
| INTERMITTENT DIAGNOSTIC TROUBLE CODE (DTC) P2106 WITH THE MALFUNCTION INDICATOR LAMP (MIL) ON. *TT | |
| Bulletin Number: 17215 | |
| THE AMBER ANTI-LOCK BRAKE SYSTEM (ABS) WARNING LIGHT ON WITH DIAGNOSTIC TROUBLE CODES C1235, C1236/C1237 STORED IN MEMORY. *TT | |
| Bulletin Number: 17217 | |
| AIR CONDITIONER HOOTING NOISE DURING LIGHT LOAD ACCELERATION AT LOW SPEEDS, FROM 1000-1300 RPM. *TT | |
| Bulletin Number: 17276 | |
| A POPPING OR CREAKING NOISE THAT APPEARS TO BE COMING FROM THE FRONT EXTERIOR OF THE VEHICLE. *TT | |
| Bulletin Number: 17285 | |
| MALFUNCTION INDICATOR LAMP/ETC LAMP LIT WITH P0606 AND ONE OR SEVERAL P21XX-SERIES DIAGNOSTIC TROUBLE CODES AT LOW TIME IN SERVICE. *TT | |
| Bulletin Number: 17311 | |
| MALFUNCTION INDICATOR LAMP ON AND/OR ELECTRONIC THROTTLE CONTROL LAMP (ETC) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P2106. *TT | |
| Bulletin Number: 17316 | |
| FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP. *TT | |
| Bulletin Number: 17326 | |
| ENGINE AUXILIARY OIL COOLER LINE AND THE RIGHT SIDE MOTOR MOUNT SQUEAKING NOISE FROM FRONT EXTERIOR WHILE DRIVING OVER BUMPS. *TT | |
| Bulletin Number: 17411 | |
| TIRE PRESSURE MONITORING SYSTEM (TPMS) MODULE CONFIGURATION - SERVICE TIP. *MJ | |
| Bulletin Number: 17422 | |
| MULTIPLE ELECTRICAL CONCERNS - FUSE 2.17 OPEN. *MJ | |
| Bulletin Number: 17455 | |
| 4X4 INOPERATIVE AND/OR INDICATORS BLINKING. *TT | |
| Bulletin Number: 17494 | |
| DISTANCE TO EMPTY NOT DISPLAYED. *TT | |
| Bulletin Number: 17544 | |
| GENERATOR NOISE IN COLD AMBIENT TEMPERATURES. *MJ | |
| Bulletin Number: 17555 | |
| CERTIFIED REAR AXLE AVAILABLE. *MJ | |
| Bulletin Number: 17558 | |
| INTERMITTENT AIR BAG WARNING LAMP ON, MEMORY SEAT, AND/OR ADJUSTABLE PEDAL CONCERNS. *MJ | |
| Bulletin Number: 17560 | |
| REAR AXLE NOISE. ALSO INCLUDES LINCOLN AVIATOR 2002. *MJ | |
| Bulletin Number: 17561 | |
| DELAYED CRANK WITH NO START, DIAGNOSTIC TROUBLE CODES (DTC) U0300/P0606/P2105/P2107, MALFUNCTION INDICATOR MODULE (MIL) AND WRENCH LIGHT ON. *MJ | |
| Bulletin Number: 17592 | |
| AN INTERMITTENT NO START AND/OR MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTC'S) P1233, P1234, P1235, P1236, P1237 OR P1238. *TT | |
| Bulletin Number: 17626 | |
| STANDARD ABS (NOT ADVANCE TRAC/IVD) BUILT PRIOR TO 2/9/2004 MAY EXHIBIT AN INTERMITTENT AMBER ABS LIGHT ON WITH DIAGNOSTIC TROUBLE CODE (DTC'S) B2900, U1900 AND POSSIBLY C1805 STORED IN MEMORY. *TT | |
| Bulletin Number: 17640 | |
| POOR FIT BETWEEN DRIVER AIR BAG AND STEERING WHEEL. *TT | |
| Bulletin Number: 17641 | |
| REAR 3.55 AXLE NOISE. CERTIFIED REAR AXLE OR IMPROVED GEAR SET AVAILABLE. *TT | |
| Bulletin Number: 17664 | |
| INTERMITTENT HARD START, LONG CRANK TIME OR MULTIPLE CRANK ATTEMPTS BEFORE STARTING. *TT | |
| Bulletin Number: 17666 | |
| DIAGNOSTIC TROUBLE CODE (DTC) U0300 (INTERNAL CONTROL MODULE SOFTWARE INCOMPATIBILITY) STORED IN THE PCM WITH NO OTHER DTC'S PRESENT. *TT | |
| Bulletin Number: 17670 | |
| MALFUNCTION INDICATOR (DTC) LAMP ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P2106. *TT | |
| Bulletin Number: 17680 | |
| REAR LIFTGATE RATTLE / LIGHT POPPING NOISE. *TT | |
| Bulletin Number: 17717 | |
| REAR AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNS. *TT | |
| Bulletin Number: 17728 | |
| ANTI-LOCK BRAKE SYSTEM (ABS) LIGHT ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B2900, U1900 AND C1805. *TT | |
| Bulletin Number: 17736 | |
| REAR AXLE NOISE. *TT | |
| Bulletin Number: 17883 | |
| DELAYED/HARSH REVERSE ENGAGEMENT. *TT | |
| Bulletin Number: 17905 | |
| MULTIPLE VEHICLES USING FEHP REAR AXLE FLUID. FLUID USAGE CHANGE. *TT | |
| Bulletin Number: 18121 | |
| FUEL GAUGE SLOW TO UPDATE. *TT | |
| Bulletin Number: 18171 | |
| NO CRANK/NO START CONDITION WHEN VEHICLE TEMPERATURE IS BELOW FREEZING (32F/0C). *TT | |
| Bulletin Number: 18202 | |
| UNINTENDED 4X4 ENGAGEMENT DURING LOW SPEED PARKING LOT TURNS. VARIOUS MODELS INCLUDING THE 2005 EXPLORER AND MOUNTAINEER. *TT | |
| Bulletin Number: 18215 | |
| BROKEN REAR CARGO STORAGE DOOR LIFT HANDLE. VARIOUS MODELS INCLUDING 2005 EXPLORER/MOUNTAINEER. *TT | |
| Bulletin Number: 18217 | |
| MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT | |
| Bulletin Number: 18221 | |
| REAR AXLE NOISE. OASIS. VARIOUS MODELS INCLUDING 2005 EXPLORER, MOUNTAINEER AND AVIATOR. *TT | |
| Bulletin Number: 18254 | |
| SPEED CONTROL INOPERATIVE OR NOT HOLDING THE SET SPEED. OASIS. VARIOUS MODELS INCLUDING 2005 EXPLORER, SPORT TRAC, MOUNTAINEER AND AVIATOR. *TT | |
| Bulletin Number: 18381 | |
| OPEN FUSE F2.20 (5 AMP) AND/OR F2.1 (30 AMP) WHICH MAY RESULT IN LOSS OF FUNCTION OF SEVERAL SYSTEMS INCLUDING POWER SEATS, ADJUSTABLE PEDALS AND POWER DOOR LOCKS. *TT | |
| Bulletin Number: 18573 | |
| NO START/HARD START ON COLD SOAK. *TT | |
| Bulletin Number: 18719 | |
| MALFUNCTION INDICATOR LAMP COMING ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0172, P0174 AND/OR P0175 (FUEL SYSTEM TOO RICH OR LEAN). *TT | |
| Bulletin Number: SSM 46085 | |
| The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate | |
| Bulletin Number: TSB-08-19-3 | |
| FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE | |
| Bulletin Number: TSB-12-7-4 | |
| FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112. *PE | |
| Bulletin Number: TSB 19-2026 | |
| Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo | |
| 2004 MERCURY SABLE | |
| Bulletin Number: 01431 | |
| COLD ENGINE HARD START/NO START AND/OR SLIGHT SURGING AT IDLE. DIAGNOSTIC TROUBLE CODE P0300 (MISFIRE). 3.0L 2-VALVE ENGINE (GAS AND FFV). *TT | |
| Bulletin Number: 031404 | |
| ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 031506 | |
| WATER IN THE BLOWER CASE OR ON THE PASSENGER SIDE FLOOR, AN INOPERATIVE CLIMATE CONTROL BLOWER MOTOR, A MOTOR THAT OPERATES ON HIGH SPEED ONLY, AND/OR A BLOWER MOTOR RESISTOR FAILURE. VEHICLES BUILT 5/1/2001 TO 12/15/2003. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 041410 | |
| MALFUNCTION INDICATOR LAMP ILLUMINATION DUE TO WIRE HARNESS CHAFING. *TT | |
| Bulletin Number: 0415 | |
| LOWER ENGINE OIL LEAKS 3.0L 2V VULCAN ENGINE. DIAGNOSTIC SERVICE TIPS. *TT | |
| Bulletin Number: 041512 | |
| 4F50N TRANSAXLE NO 1-2 UPSHIFT AND DIAGNOSITC TROUBLE CODE P0732. *TT | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 04158 | |
| WIPER MOTOR CONTINUOUS OPERATION. *TT | |
| Bulletin Number: 041601 | |
| WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04189 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 04208 | |
| CAMSHAFT TICK NOISE - 3.0L 4V ENGINE ONLY. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04217 | |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04223 | |
| GRUNTING NOISE FROM FRONT POWER WINDOW GLASS IS POWERED TO THE FULL UP POSITION. *EH | |
| Bulletin Number: 04224 | |
| ACCELERATION PEDAL VIBRATION. *EH UPDATES. *TT | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 04251 | |
| ALUMINUM CORROSION - SERVICE TIP. *TT | |
| Bulletin Number: 042512 | |
| NO CRANK - BATTERY DISCHARGED ON 3.0L 4V ENGINE. *TT | |
| Bulletin Number: 0464 | |
| UNCOMMANDED DECKLID OPENING, DOME-LIGHT ILLUMINATED, CHIME SOUNDING, AND/OR MULTIPLE DOOR AJAR WARNING. *MJ | |
| Bulletin Number: 051113 | |
| VARIOUS DRIVEABILITY CONDITIONS-3.0L 2V AND FLEX FUEL ENGINE. *SC | |
| Bulletin Number: 05145 | |
| ERRATIC FLUID LEVEL READING ON TRANSAXLE DIPSTICK-LEAKS-4F50N, AX4N, AX4S TRANSAXLE. *SC | |
| Bulletin Number: 052218 | |
| SPARK KNOCK, HESITATION ABOVE 3000 RPM, LOSS OF POWER, MISFIRE, AND POSSIBLE ENGINE DAMAGE DUE TO DETONATION AND PRE-IGNITION - 3.0L-2V VULCAN GAS/FFV. *TT | |
| Bulletin Number: 05224 | |
| POWER LOCK CONCERNS - SERVICE TIP. *TT | |
| Bulletin Number: 05227 | |
| POWER WINDOW CONCERNS - SERVICE TIP. *TT | |
| Bulletin Number: 05310 | |
| SAFETY BELT WEB STOP BUTTON SERVICE. *EH | |
| Bulletin Number: 0607 | |
| EXTENDED WARRANTY COVERAGE FOR VEHICLES WITH HARD START WHEN OPERATING ON E85 FUEL, POWERTRAIN CONTROL MODULE (PCM) CALIBRATION. WARRANTY EXTENDED FOR 10 YEARS OR 100,000 MILES WHICH EVER COMES FIRST. SAMPLE CONSUMER LETTER ATTACHED. *KB | |
| Bulletin Number: 17210 | |
| NO START OR ENGINE QUIT CONDITION AFTER CLOSING LUGGAGE COMPARTMENT LID. *TT | |
| Bulletin Number: 17225 | |
| STEERING COLUMN LOCK DISCONTINUED. *TT | |
| Bulletin Number: 17234 | |
| ENGINE OIL LEAKS FROM THE FILTER AREA ON VEHICLES WITH A 3.0L 2-VALVE ENGINE. *TT | |
| Bulletin Number: 17358 | |
| GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE. *TT THIS BULLETIN UPDATES PREVIOUS BULLETIN 17358, DATED 11/01/2003 TO INCLUDE 2005 MODELS. *TT | |
| Bulletin Number: 17480 | |
| A NO START/HARD START CONDITION DURING A COLD START. *TT | |
| Bulletin Number: 17481 | |
| HESITATION WHEN ACCELERATING OR DURING TRANSMISSION UPSHIFT. ON 3.0L 2-VALVE ENGINE WITH POWERTRAIN CONTROL MODULE (PCM) TEAR TAG PTF3. *TT | |
| Bulletin Number: 17511 | |
| NOISE FROM FRONT SUSPENSION AREA. *TT | |
| Bulletin Number: 17512 | |
| AN INTERMITTENT MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0462 (FUEL LEVEL SENSOR A CIRCUIT LOW) OR P2067 (FUEL LEVEL SENSOR B CIRCUIT LOW) CAUSED BY AN IMPROPERLY INSTALLED REMOTE START SYSTEM. *TT | |
| Bulletin Number: 17551 | |
| AIR BAG SYSTEM WARNING LIGHT ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B1884. *MJ | |
| Bulletin Number: 17653 | |
| FUEL GAUGE READS EMPTY WITH FUEL IN TANK. *TT | |
| Bulletin Number: 17682 | |
| VIBRATION IN ACCELERATOR PEDAL 40-42 MPH. *TT | |
| Bulletin Number: 17692 | |
| HARD START/NO START COLD AND/OR MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P2196/P2198. *TT | |
| Bulletin Number: 17705 | |
| SPEEDOMETER CONCERNS. *TT | |
| Bulletin Number: 17802 | |
| MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0300 (RANDOM MISFIRE DETECTED). *TT | |
| Bulletin Number: 17867 | |
| VIBRATION IN ACCELERATOR PEDAL 40-42 MPH ON 2004-2005 TAURUS/SABLE MODELS. *TT | |
| Bulletin Number: 17914 | |
| WINDSHIELD WIPER CONTINUES TO RUN. *TT | |
| Bulletin Number: 17960 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0171/P0174, P1131/P1151, AND/OR P2195/P2197 IN CONTINUOUS MEMORY. *TT | |
| Bulletin Number: 18411 | |
| MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0133, P1131 OR P2195. *TT | |
| Bulletin Number: 18471 | |
| RKE INOPERATIVE. *EH | |
| Bulletin Number: 18614 | |
| SURGE, IDLE ROLL, ROUGH IDLE ONLY WHEN THE ENGINE COOLING FANS ARE OPERATING. *TT | |
| Bulletin Number: 19087 | |
| TENTHS DIGIT NOT DISPLAYED ON ODOMETER AFTER 10,000 MILES/KILOMETERS. *TT | |
| Bulletin Number: TSB 19-2026 | |
| Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo | |
Recalls for 2004 Mercury
| 2004 MERCURY GRAND MARQUIS | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturer: | Ford Motor Company |
| Manufacture Dates: | 10/03/2001 - 08/02/2005 |
| Potential Units Affected: | 296004 |
Defect Description:Ford Motor Company (Ford) is recalling certain model year 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles manufactured October 3, 2001, to August 2, 2005. The affected vehicles have a lighting control module (LCM) that may fail, resulting in a loss of headlights. Consequence:A loss of headlights can reduce driver visibility and increase the risk of a crash. Action:Ford will notify owners, and dealers will replace the LCM, free of charge. The recall began April 14, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S39. | |
| 2004 MERCURY MARINER | |
|---|---|
| NHTSA Campaign ID: | POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL) |
| Manufacturer: | Ford Motor Company |
| Manufacture Dates: | 03/31/2001 - 09/01/2009 |
| Potential Units Affected: | 57 |
Defect Description:Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning. Consequence:If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders. Action:Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28. | |
| 2004 MERCURY MARINER | |
|---|---|
| NHTSA Campaign ID: | POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT |
| Manufacturer: | Ford Motor Company |
| Manufacture Dates: | 03/31/2001 - 09/01/2009 |
| Potential Units Affected: | 57 |
Defect Description:Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning. Consequence:If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders. Action:Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28. | |
| 2004 MERCURY MONTEREY | |
|---|---|
| NHTSA Campaign ID: | WHEELS:CAP/COVER/HUB |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 02/23/2004 - 05/13/2004 |
| Potential Units Affected: | 34013 |
Defect Description:CERTAIN MINIVANS MAY HAVE BEEN PRODUCED WITH FRONT WHEEL HUB ASSEMBLIES THAT WERE NOT HEAT TREATED CORRECTLY. THIS CONDITION MAY LEAD TO THE DEVELOPMENT OF SMALL CRACKS IN THE HUB. Consequence:IF THE CRACKS WERE TO PROGRESS, THIS COULD EVENTUALLY RESULT IN WHEEL SEPARATION. WHEEL SEPARATION MAY LEAD TO LOSS OF VEHICLE CONTROL, AND POTENTIALLY RESULT IN A VEHICLE CRASH. Action:DEALERS WILL REPLACE THE FRONT HUB, ROTORS, AND WHEEL BEARINGS. THE RECALL BEGAN SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. | |
| 2004 MERCURY MONTEREY | |
|---|---|
| NHTSA Campaign ID: | SEATS |
| Manufacturer: | Ford Motor Company |
| Manufacture Dates: | 03/24/2003 - 11/07/2006 |
| Potential Units Affected: | 196667 |
Defect Description:Ford is recalling certain model year 2004-2007 Freestar and Mercury Monterey vehicles manufactured from March 24, 2003, through November 7, 2006, equipped with a third row seat and originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. The third row stowable seat can experience corrosion and structural degradation at the seat anchor mechanism mounted to the rear wheel wells. As a result of the corrosion, the third row seat may not fully latch into its seating position. Consequence:In the event that the vehicle is crashed into from the rear, an unlatched seat may increase the risk of personal injury. Action:Ford will notify owners, and dealers will install new third row seat latch striker mounting brackets, free of charge. The recall began on March 28, 2013. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332. | |
| 2004 MERCURY MONTEREY | |
|---|---|
| NHTSA Campaign ID: | POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 206452 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 2004 AND 2005 FORD FREESTAR AND MERCURY MONTEREY VEHICLES. THE TORQUE CONVERTER OUTPUT SHAFT MAY FAIL. Consequence:THIS CONDITION RESULTS IN A SUDDEN LOSS OF MOTIVE POWER WITH NO WARNING, INCREASING THE RISK OF A CRASH. Action:FORD WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE TORQUE CONVERTER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 9, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. | |
| 2004 MERCURY MONTEREY | |
|---|---|
| NHTSA Campaign ID: | STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 03/24/2003 - 10/27/2003 |
| Potential Units Affected: | 23996 |
Defect Description:ON CERTAIN MINIVANS, THE POWER STEERING LOW-PRESSURE LINE MAY NOT BE FULLY SEATED AT THE RACK AND PINION STEERING GEAR. Consequence:IF THIS LINE BECOMES DISCONNECTED, IT MAY CREATE THE POTENTIAL FOR FLUID TO COME INTO CONTACT WITH THE EXHAUST SYSTEM, WHICH COULD RESULT IN SMOKE OR FIRE. Action:DEALERS WILL INSPECT THE POWER STEERING LOW-PRESSURE LINE TO ENSURE THAT IT IS SEATED PROPERLY AT THE RACK AND PINION STEERING GEAR. OWNER NOTIFICATION BEGAN NOVEMBER 10, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. | |
| 2004 MERCURY MONTEREY | |
|---|---|
| NHTSA Campaign ID: | POWER TRAIN:AUTOMATIC TRANSMISSION |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 206452 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 2004 AND 2005 FORD FREESTAR AND MERCURY MONTEREY VEHICLES. THE TORQUE CONVERTER OUTPUT SHAFT MAY FAIL. Consequence:THIS CONDITION RESULTS IN A SUDDEN LOSS OF MOTIVE POWER WITH NO WARNING, INCREASING THE RISK OF A CRASH. Action:FORD WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE TORQUE CONVERTER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 9, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. | |
| 2004 MERCURY SABLE | |
|---|---|
| NHTSA Campaign ID: | SEATS:FRONT ASSEMBLY:POWER ADJUST |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 11/17/2003 - 01/15/2004 |
| Potential Units Affected: | 24277 |
Defect Description:CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER ADJUSTABLE SEATS MAY HAVE BEEN INADEQUATELY WELDED. Consequence:THE SEAT MAY NOT PERFORM AS INTENDED DURING A CRASH WHICH COULD INCREASE THE RISK OF INJURY. Action:DEALERS WILL REPLACE THE UPPER SUPPORT ASSEMBLY ON THE POWER SEATS. THE RECALL BEGAN ON JULY 20, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. | |
