Hyundai Buyers Guide
Click a car name to see the crash test details for that model.
Crash Test Data for 2000 Hyundai
| Hyundai Vehicle | Front Star Rating | Side Star Rating | Rollover Resistance Rating | ||
|---|---|---|---|---|---|
| Driver | Passenger | Front Seat | Rear Seat | ||
| 2000 Elantra |  |  |  |  | Not Tested |
| 2000 Sonata | Not Tested | Not Tested | | | Not Tested |
Service Bulletins for 2000 Hyundai
| 2000 HYUNDAI ACCENT | |
|---|---|
| Bulletin Number: 0030004 | |
| SUBJECT REGARDING (DIAGNOSTIC TROUBLE CODE) DTC DIAGNOSTIC FLOW CHART FOR P1611 AND P1613. *TT | |
| Bulletin Number: 0030005 | |
| INFORMATION REGARDING THE FUEL PUMP ASSEMBLY. *TT | |
| Bulletin Number: 0036009 | |
| SUBJECT REGRDING DIAGNOSING TPS RELATED CODES SHOP MANUAL CORRECTION. *TT | |
| Bulletin Number: 0040008 | |
| SUBJECT REGARDING THE AUTOMATIC TRANSAXLE TESTER I DESIGNED TO TROUBLESHOOT THE NEW GENERATION TRANSAXLE FOR ALL 2000 MODELS. *TT | |
| Bulletin Number: 0040016 | |
| SUBJECT REGARDING MANUAL TRANSAXLE SHIFT FEEL IMPROVEMENT - SERVICE KIT PARTS. *TT | |
| Bulletin Number: 0040017 | |
| SUBJECT REGARDING TRANSAXLE DIAGNOSTIC TROUBLE CODES. *TT | |
| Bulletin Number: 0050004 | |
| THIS BULLETIN PROVIDES INSTALLATION PROCEDURES FOR THE MOUNTING BUSHINGS FITTED TO THE FRONT SUSPENSION CROSS MEMBER. *TT | |
| Bulletin Number: 0060003 | |
| THIS BULLETIN DESCRIBES THE REPAIR FOR A RATTLE OR CREAK NOISE HEARD INSIDE THE VEHICLE FROM THE DOOR HINGE AREAS. *TT | |
| Bulletin Number: 00600031 | |
| THIS REVISED BULLETIN DESCRIBES THE REPAIR FOR A RATTLE OR CREAK NOISE HEARD INSIDE THE VEHICLE FROM THE DOOR HINGE AREAS. THE NOISE MAY OCCUR ON ALL FOUR DOORS. *TT | |
| Bulletin Number: 0090001 | |
| INFORMATION ON REVERSING THE WIRES IN THE SPOILER EXTENSION WIRE HARNESS TO MATCH THE VOLTAGE POLARITY OF THE LIGHT EMITTING DIODES (LEDS) IN THE SPOILER BRAKE LIGHT. FAILURES TO REVERSE THE WIRES WILL RESULT IN AN INOPERABLE SPOILER BR | |
| Bulletin Number: 0097001 | |
| THIS BULLETIN PROVIDES UPDATED INFORMATION AND CORRECTIONS TO THE 2000MY ACCENT AIR CONDITIONER KIT INSTALLATION PROCEDURES. *TT | |
| Bulletin Number: 010101 | |
| INFORMATION ON PERFORMING A TEST DRIVE FOR TRANSAXLE SHIFT QUALITY. *TT | |
| Bulletin Number: 0136010 | |
| INFORMATION REGARDING SHOP MANUAL CORRECTION FOR IDLE SPEED ACTUATOR RESISTANCE CHECK. *YH | |
| Bulletin Number: 01360101 | |
| SUBJECT REGARDING SHOP MANUAL CORRECTION FOR IDLE SPEED ACTUATOR RESISTANCE CHECK. *YH | |
| Bulletin Number: 0136013 | |
| SUBJECT ON REGARDING ECM REPROGRAMMING FOR POOR ACCELERATION CONDITION. *YH | |
| Bulletin Number: 0136014 | |
| SOME VEHICLES MAY EXPERIENCE VERY INTERMITTENT CRANK-NO-START; THE CHECK ENGINE LIGHT DOES NOT LIGHT UP AS NORMALLY IS DOES; THE HI-SCAN PRO CANNOT COMMUNICATE WITH THE ENGINE CONTROL MODULE. *TT | |
| Bulletin Number: 01400061 | |
| AUTOMATIC TRANSAXLE PULSE GENERATOR DIAGNOSTIC TROUBLE CODES P0717 AND P0722 - REVISED. *JG | |
| Bulletin Number: 0201010 | |
| FRONT A-PILLAR BRACKET INSTALLATION (CAMPAIGN 055). *TT | |
| Bulletin Number: 02010101 | |
| FRONT A-PILLAR BRACKETS - (CAMPAIGN 055). *TT | |
| Bulletin Number: 0236018 | |
| SUBJECT REGARDING ELECTRONIC CONTROL MODULE REPROGRAMMING TO IMPROVE ACCELERATION AFTER AN INITIAL COLD START. *JG | |
| Bulletin Number: 0240010 | |
| SUBJECT ON AUTOMATIC TRANSAXLE HARSH OR DELAYED PARK REVERSE OR PARK DRIVE ENGAGEMENT. *YH | |
| Bulletin Number: 0240012 | |
| SUBJECT REGARDING AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *YH | |
| Bulletin Number: 0240014 | |
| SUBJECT REGARDING AUTOMATIC TRANSAXLE BELLHOUSING COVER. *JG | |
| Bulletin Number: 0240017 | |
| SUBJECT REGARDING DIAGNOSTIC TROUBLE CODE P0722 - PULSE GENERATOR - B INSPECTION AND TRANSMISSION CONTROL MODULE REPROGRAMMING INSTRUCTIONS. *JG | |
| Bulletin Number: 0240020 | |
| SUBJECT REGARDING AUTOMATIC TRANSAXLE HARSH AND/OR DELAYED SHIFTS. *JG | |
| Bulletin Number: 0336017 | |
| SLOWER THAN USUAL ACCELERATION AFTER AN INITIAL COLD START; GREATER THAN USUAL RPM DROP WHEN ENGAGING DRIVE OR REVERSE; CHECK ENGINE LIGHT ON AND P0116 STORED. *TT | |
| Bulletin Number: 0336024 | |
| RESISTANCE VALUES FOR IDLE SPEED CONTROL ACTUATOR (ISCA). VARIOUS MODELS INCLUDING THE 2004 SONATA. *TT | |
| Bulletin Number: 0340001 | |
| ATM DIODE PIN CORROSION IN THE CONTROL WIRING HARNESS LOCATED BEHIND THE DASH PANEL. *TT | |
| Bulletin Number: 0340007 | |
| ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0745, P0747, P0748, P0750, P0752, P0753, P0755, P0757, P0758, P0760, P0765. *TT *MJ | |
| Bulletin Number: 0340016 | |
| DIAGNOSTIC TROUBLE CODE (DTC) P0722 - PULSE GENERATOR-B INSPECTION AND TCM REPROGRAMMING. *TT | |
| Bulletin Number: 0340022 | |
| AUTOMATIC TRANSAXLE PULSE GENERATOR DIAGNOSTIC TROUBLE CODES P0717 & P0722. 2004 ACCENT INCLUDED. *TT | |
| Bulletin Number: 0497002 | |
| FD46XG PAG OIL SPECIFICATIONS FOR AIR CONDITIONING COMPONENT REPLACEMENT. *TT | |
| Bulletin Number: 0536003 | |
| DIAGNOSTIC TROUBLE CODE (DTC) P0130 (OXYGEN SENSOR MALFUNCTION); DIAGNOSTIC TROUBLE CODE (DTC) P0503 (SPEED SENSOR MALFUNCTION; REVERSE TO DRIVE LURCH WHILE ROLLING BACKWARDS (ON AUTOMATIC TRANSAXLE EQUIPPED VEHICLES ONLY). *TT | |
| Bulletin Number: 05360031 | |
| 2000-2004 1.5L & 1.6L ACCENT P0130 (OXYGEN SENSOR) AND P0530 (SPEED SENSOR). *SC | |
| Bulletin Number: 0540018 | |
| AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *TT | |
| Bulletin Number: 0640019 | |
| AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODE (DTC) LIST. *KB | |
| Bulletin Number: 0804 | |
| FD46XG POLY ALKYLEN GLYCOL (PAG) OIL SPECIFICATIONS FOR AIR CONDITIONING COMPONENT REPLACEMENT. *NM | |
| Bulletin Number: 0804 | |
| REPLACEMENT CIGARETTE LIGHTER. *NM | |
| Bulletin Number: 113 | |
| INFORMATION REGARDING CRANK-NO-START CAUSED BY SHORT IN THE MAIN HARNESS FOR DASH FUSE #5 CIRCUIT. *YH | |
| Bulletin Number: 151 | |
| AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *TT | |
| Bulletin Number: 158 | |
| REPROGRAMS ARE AVAILABLE FOR AUTOMATIC TRANSAXLE DRIVEABILITY ISSUES. TECHNET TIMES. HYUNDAI. *TT | |
| Bulletin Number: 9900007 | |
| THIS BULLETIN HAS PROCEDURES DESCRIBING HOW TO CONNECT THE POWER CONNECTOR DURING THE PDI PROCESS. *TT | |
| Bulletin Number: 9930004 | |
| THIS BULLETIN PROVIDES FUEL PUMP CHECK CONNECTOR LOCATIONS FOR VARIOUS VEHICLES. *TT | |
| Bulletin Number: TSB-09-AT-013 | |
| HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). AN IMPROPERLY ADJUSTED OR IMPROPERLY OP | |
| 2000 HYUNDAI ELANTRA | |
| Bulletin Number: 0001006 | |
| SUBJECT REGARDING MASS AIR FLOW SENSOR CONNECTOR REPLACEMENT CAMPAIGN. *TT | |
| Bulletin Number: 0020004 | |
| ON SOME VEHICLES, A NOISE MAY BE HEARD FOR THE FIRST FEW MINUTES AFTER STARTING AND DRIVING IN COLD WEATHER FROM THE ENGINE COMPARTMENT. *TT | |
| Bulletin Number: 0040017 | |
| SUBJECT REGARDING TRANSAXLE DIAGNOSTIC TROUBLE CODES. *TT | |
| Bulletin Number: 010101 | |
| INFORMATION ON PERFORMING A TEST DRIVE FOR TRANSAXLE SHIFT QUALITY. *TT | |
| Bulletin Number: 01400061 | |
| AUTOMATIC TRANSAXLE PULSE GENERATOR DIAGNOSTIC TROUBLE CODES P0717 AND P0722 - REVISED. *JG | |
| Bulletin Number: 0236028 | |
| OBD-II READINESS TEST DRIVE CYCLE. *TT | |
| Bulletin Number: 0240010 | |
| SUBJECT ON AUTOMATIC TRANSAXLE HARSH OR DELAYED PARK REVERSE OR PARK DRIVE ENGAGEMENT. *YH | |
| Bulletin Number: 0240012 | |
| SUBJECT REGARDING AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *YH | |
| Bulletin Number: 0240016 | |
| SUBJECT REGARDING AUTOMATIC TRANSAXLE OIL LEAKING FROM OIL PAN GASKET. *JG | |
| Bulletin Number: 0240020 | |
| SUBJECT REGARDING AUTOMATIC TRANSAXLE HARSH AND/OR DELAYED SHIFTS. *JG | |
| Bulletin Number: 0240024 | |
| IMPROVED CLUTCH RELEASE SHAFT UPPER AND LOWER BUSHING. *TT | |
| Bulletin Number: 0250002 | |
| SUBJECT REGARDING FRONT BRAKE CALIPER RATTLE NOISE REPAIR KIT. *TT | |
| Bulletin Number: 0290009 | |
| SUBJECT REGARDING DIAGNOSTIC GUIDE FOR CLIFFORD AND DEI SECURITY SYSTEM. *JG | |
| Bulletin Number: 0340007 | |
| ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0745, P0747, P0748, P0750, P0752, P0753, P0755, P0757, P0758, P0760, P0765. *TT *MJ | |
| Bulletin Number: 0340022 | |
| AUTOMATIC TRANSAXLE PULSE GENERATOR DIAGNOSTIC TROUBLE CODES P0717 & P0722. 2004 ACCENT INCLUDED. *TT | |
| Bulletin Number: 0380003 | |
| INTERIOR DOOR TRIM PANEL FABRIC REPAIR. *TT | |
| Bulletin Number: 0501001 | |
| EXHAUST MANIFOLD ASSEMBLY INSPECTION AND REPLACEMENT CAMPAIGN. *EH | |
| Bulletin Number: 0501001 | |
| EXHAUST MANIFOLD ASSEMBLY INSPECTION AND REPLACEMENT CAMPAIGN - V04. *TT | |
| Bulletin Number: 0540018 | |
| AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *TT | |
| Bulletin Number: 061000 | |
| SUBJECT REGARDING CAMPAIGN 040 - MASS AIR FLOW SENSOR CONNECTION RECALL CAMPAIGN. *TT | |
| Bulletin Number: 091000 | |
| SUBJECT REGARDING A VOLUNTARY CUSTOMER NOTIFICATION (MASS AIR FLOW SENSOR CONNECTION RECALL CAMPAIGN) ON CERTAIN VEHICLES MANUFACTURED BETWEEN JUNE 1, 1999 AND JUNE 16, 2000. *TT | |
| Bulletin Number: 151 | |
| AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *TT | |
| Bulletin Number: 5NP-S9D9P-10 | |
| THIS BULLETIN PROVIDES INFORMATION ON COMPONENTS, ATTRIBUTES, AND PRECAUTIONS OF THE 7-SPEED DRY-TYPE DUAL CLUTCH TRANSMISSION (DCT). | |
| Bulletin Number: 9901003 | |
| THIS TSB PROVIDES INFORMATION REGARDING THE LOCATION AND CORRECT INFORMATION OF THE EMISSION LABELS. *TT | |
| Bulletin Number: TSB-09-AT-013 | |
| HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). AN IMPROPERLY ADJUSTED OR IMPROPERLY OP | |
| Bulletin Number: V04 | |
| EXHAUST NOISE COMING FROM THE ENGINE COMPARTMENT. VOLUNTARY SERVICE CAMPAIGN V04 INVOLVES INSPECTING AND, IF NECESSARY, REPLACING THE EXHAUST MANIFOLD. *TT | |
| 2000 HYUNDAI HYUNDAI | |
| Bulletin Number: 0097002 | |
| INFORMATION DESCRIBING THE REVISED SYSTEM OPERATION OF THE DEFROST AND DEFROST / FLOOR MODES FOR ALL 2000 MODELS. *TT | |
| Bulletin Number: 14092001 | |
| INFORMATION REGARDING ALIGNMENT SPECIFICATIONS(DEGREES)CHART. ALL MODELS. *YD | |
| Bulletin Number: 9900005 | |
| INFORMATION CONCERNING THE VEHICLE IDENTIFICATION NUMBERS OF ALL MODELS THAT HAVE BEEN SOLD IN THE UNITED STATES. *TT | |
| Bulletin Number: 9900006 | |
| INFORMATION REGARDING A CHANGE IN SHOP MANUAL FORMAT FOR MANUAL AND AUTOMATIC TRANSAXLES. *TT | |
| Bulletin Number: 990312 | |
| SUBJECT REGARDING SP-IIM AUTOMATIC TRANSAXLE FLUID TO IMPROVE TRANSFER DRIVE CLUTCH PERFORMANCE ON 4WD VEHICLES. *TT | |
| Bulletin Number: 9909010 | |
| INFORMATION DESCRIBING AN AUDIO SYSTEM CONNECTOR REPLACEMENT. *TT | |
| Bulletin Number: 9940016 | |
| INFORMATION REGARDING A CHANGE IN THE SHOP MANUAL FORMAT FOR MANUAL AND AUTOMATIC TRANSAXLES. *TT | |
| Bulletin Number: 9950008 | |
| INFORMATION ISSUED TO COMMUNICATE, IN CHART FORM, THE FINAL 1999 AND THE INITIAL 2000 MODEL YEAR VEHICLE ALIGNMENT SPECIFICATIONS. *TT | |
| Bulletin Number: 9950009 | |
| SUBJECT REGARDING TIRE INFLATION PRESSURE PRE-DELIVERY INSPECTION (PDI) INSPECTION. *TT | |
| Bulletin Number: 9990012 | |
| HYUNDAI HAS MADE A CHANGE IN THE CONNECTOR NUMBERING FORMAT FOR ELECTRICAL TROUBLESHOOTING MANUALS. *TT | |
| Bulletin Number: TSB-09-AT-013 | |
| HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). AN IMPROPERLY ADJUSTED OR IMPROPERLY OP | |
| 2000 HYUNDAI SANTA FE | |
| Bulletin Number: DOR-T5K8Y-01 | |
| This SKU is an Air Conditioning Bypass Pulley. The Customer communication requested return of unsold inventory to inspect for potential bracket cracking. Bracket cracks may cause the engine drive belt to slip or jump off the pulley causin | |
| Bulletin Number: DOR-Y5Q6Z-01 | |
| This SKU is an Air Conditioning Bypass Pulley. The Customer communication requested return of unsold inventory to inspect for potential bracket cracking. Bracket cracks may cause the engine drive belt to slip or jump off the pulley causin | |
| 2000 HYUNDAI SONATA | |
| Bulletin Number: 0001005 | |
| SUBJECT REGARDING MASS AIR FLOW SENSOR CONNECTION CAMPAIGN. *TT | |
| Bulletin Number: 0020003 | |
| EXPERIENCING A CRANK NO START, HARD STARTING AFTER FILLING WITH FUEL, OR ERRATIC IDLE SPEEDS. *TT | |
| Bulletin Number: 0040014 | |
| INFORMATION ON DIAGNOSING TRANSAXLE DIAGNOSTIC TROUBLE CODES. *TT | |
| Bulletin Number: 0040015 | |
| SUBJECT REGARDING MANUAL TRANSAXLE SHIFT FEEL IMPROVEMENT KIT SERVICE PARTS. *TT | |
| Bulletin Number: 0050006 | |
| SOME OWNERS MAY EXPERIENCE A METALLIC RUBBING NOISE HEARD FROM THE REAR SUSPENSION WHILE DRIVING THE VEHICLE OVER BUMPS OR AN UNEVEN ROUGH ROAD WITH OCCUPANTS IN THE REAR SEAT. *TT | |
| Bulletin Number: 010101 | |
| INFORMATION ON THE ACUOSTIC WARNING SYSTEM. *TT | |
| Bulletin Number: 01011901 | |
| AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *NM | |
| Bulletin Number: 0136009 | |
| INFORMATION REGARDING SHOP MANUAL CORRECTION FOR IDLE SPEED ACTUATOR RESISTANCE CHECK. *YH | |
| Bulletin Number: 01360091 | |
| SUBJECT REGARDING SHOP MANUAL CORRECTION FOR IDLE SPEED ACTUATOR RESISTANCE CHECK. *YH | |
| Bulletin Number: 0136016 | |
| SUBJECT REGARDING ECM NON-INTERCHANGEABILITY. *YH | |
| Bulletin Number: 0136026 | |
| SUBJECT REGARDING V6 NITROGEN OXIDE NOX DIAGNOSIS. *JG | |
| Bulletin Number: 0140015 | |
| SUBJECT REGARDING DUAL MASS FLYWHEEL, CLUTCH AND STARTER MOTOR PARTS INFORMATION. *YH | |
| Bulletin Number: 0140017 | |
| SUBJECT ON REGARDING MANUAL TRANSAXLE SHIFT FEEL IMPROVEMENT. *YH | |
| Bulletin Number: 0140018 | |
| SUBJECT REGARDING SHUDDER OR VIBRATION DURING ACCELERATION. *YH | |
| Bulletin Number: 0140023 | |
| SUBJECT REGARDING AUTOMATIC TRANSAXLE OIL DRAIN PLUG. *YD | |
| Bulletin Number: 01500041 | |
| SUBJECT REGARDING NOISE FROM REAR WHEELS. *YH | |
| Bulletin Number: 0201005 | |
| SUBJECT REGARDING SIDE IMPACT AIR BAG WIRE HARNESS ROUTING CAMPAIGN. *JG | |
| Bulletin Number: 020402 | |
| INFORMATION REGARDING SHUDDER OR VIBRATION DESCRIPTION SLIGHTLY DURING MEDIUM TO FULL THROTTLE ACCELERATION. | |
| Bulletin Number: 0236010 | |
| SOME VEHICLES MAY EXPERIENCE CHECK ENGINE LIGHT ILLUMINATION OR DIAGNOSTIC TROUBLE CODES P0133, P0134, P1134, P0153, P0154, OR P1154. *SLC | |
| Bulletin Number: 0236022 | |
| SUBJECT REGARDING ENGINE RPM FLUCTUATION - CRUISE CONTROL CABLE ADJUSTMENT PROCEDURE. *JG | |
| Bulletin Number: 02360221 | |
| VEHICLES MAY EXPERIENCE ENGINE RPM FLUCTUATION - CRUISE CONTROL CABLE ADJUSTMENT PROCEDURE. *TT | |
| Bulletin Number: 0236027 | |
| VERY BRIEF, SLIGHT HEADLAMP DIMMING CONDITION. *TT | |
| Bulletin Number: 0236037 | |
| ECM (ENGINE CONTROL MODULE) REPROGRAMMING FOR ENGINE HESITATION IN THE MORNING AND DIAGNOSTIC TROUBLE CODE P0139. *TT | |
| Bulletin Number: 0240005 | |
| SUBJECT REGARDING DUAL MASS FLYWHEEL, BOLT, CLUTCH AND STARTER MOTOR PARTS INFORMATION. *SLC | |
| Bulletin Number: 0240008 | |
| VEHICLES MAY EXPERIENCE A HARSH OR DELAYED PARK-REVERSE OR PARK-DRIVE ENGAGEMENT IN VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. *SLC | |
| Bulletin Number: 0240011 | |
| INFORMATION REGARDING AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *YH | |
| Bulletin Number: 0240019 | |
| SUBJECT REGARDING AUTOMATIC TRANSAXLE HARSH AND/OR DELAYED SHIFTS. *JG | |
| Bulletin Number: 0240024 | |
| IMPROVED CLUTCH RELEASE SHAFT UPPER AND LOWER BUSHING. *TT | |
| Bulletin Number: 0240026 | |
| ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0743, P0750, P0755, P0760, P0765, P0770. *TT | |
| Bulletin Number: 0250012 | |
| THIS BULLETIN INVOLVES INFORMATION RELATING TO A CHANGE IN THE REAR DRUM BRAKES TO REDUCE BRAKE SQUEAL/SQUEAK NOISE. *JG | |
| Bulletin Number: 0280001 | |
| A CONDITION MAY EXIST WHERE THE FRONT DOOR GLASS DOES NOT RAISE PROPERLY OR WILL NOT STAY FULLY CLOSED AND / OR DOES NOT LOWER PROPERLY. *TT | |
| Bulletin Number: 0290009 | |
| SUBJECT REGARDING DIAGNOSTIC GUIDE FOR CLIFFORD AND DEI SECURITY SYSTEM. *JG | |
| Bulletin Number: 03010111 | |
| 2.5/2.7L V6 ENGINE TITANIUM O2 SENSORS (CAMPAIGN V01) - REVISED TSB. *TT | |
| Bulletin Number: 03010112 | |
| 2.5/2.7L V6 ENGINE TITANIUM O2 SENSORS (CAMPAIGN V01) - REVISED TSB VERSION 2. *TT | |
| Bulletin Number: 0336019 | |
| ECM (ENGINE CONTROL MODULE) REPROGRAMMING FOR ENGINE HESITATION IN THE MORNING AND DIAGNOSTIC TROUBLE CODE P0139. *TT | |
| Bulletin Number: 0336024 | |
| RESISTANCE VALUES FOR IDLE SPEED CONTROL ACTUATOR (ISCA). VARIOUS MODELS INCLUDING THE 2004 SONATA. *TT | |
| Bulletin Number: 0340006 | |
| ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0750, P0755, P0760, P0765, P0770. *TT | |
| Bulletin Number: 0340014 | |
| AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODE (DTC) P1723 ACCOMPANIED WITH MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED; TRANSAXLE HELD IN 2RD GEAR FAIL-SAFE; HARSH SHIFTS INTO REVERSE OR DRIVE. *TT | |
| Bulletin Number: 0436006 | |
| UNSTABLE IDLE (SIMPLE DIAGNOSIS PROCEDURE FOR INTERMITTENTLY STUCK CLOSED EGR SOLENOID VALVE). *TT | |
| Bulletin Number: 0450006 | |
| ANTI-LOCK BRAKING SYSTEM (ABS)TCS ACTIVATION MAY RESULT FROM UNDERINFLATED COMPACT SPARE TIRE. *TT | |
| Bulletin Number: 0497002 | |
| FD46XG PAG OIL SPECIFICATIONS FOR AIR CONDITIONING COMPONENT REPLACEMENT. *TT | |
| Bulletin Number: 0540008 | |
| AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *SC | |
| Bulletin Number: 0550004 | |
| ABS PUMP SELF CHECK NOISE. ALSO INCLUDED: 2003-2005 MODEL XG AND 1999, 2000, 2001, 2003, 2004 AND 2005 MODEL SANTA FE. *SC | |
| Bulletin Number: 061000 | |
| HYUNDAI MOTOR AMERICA IS CONDUCTING A VOLUNTARY CUSTOMER NOTIFICATION (SAFETY RECALL) ON CERTAIN VEHICLES EQUIPPED WITH 2.5L V-6 ENGINES PRODUCED FROM THE START OF PRODUCTION THROUGH JULY 4, 2000 INCLUSIVE, TO MAKE REPAIRS AFFECTING THE MAF | |
| Bulletin Number: 061101 | |
| SUBJECT REGARDING FINAL DRIVE GEAR WHINE NOISE. *YH | |
| Bulletin Number: 0636006 | |
| EXHAUST GAS RECIRCULATION (EGR) SYSTEM DIAGNOSIS. *KB | |
| Bulletin Number: 0640018 | |
| AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES (DTC) LIST. *KB | |
| Bulletin Number: 0650003 | |
| ABS PUMP SELF-CHECK NOISE. *TT | |
| Bulletin Number: 0804 | |
| FD46XG POLY ALKYLEN GLYCOL (PAG) OIL SPECIFICATIONS FOR AIR CONDITIONING COMPONENT REPLACEMENT. *NM | |
| Bulletin Number: 091000 | |
| SUBJECT REGARDING A VOLUNTARY CUSTOMER NOTIFICATION (MASS AIR FLOW SENSOR CONNECTION RECALL CAMPAIGN) ON CERTAIN VEHICLES WITH V-6 ENGINES, MANUFACTURED FROM START OF PRODUCTION THROUGH JULY 4, 2000, INCLUSIVE. *TT | |
| Bulletin Number: 117 | |
| INFORMATION ON EXHAUST GAS RECIRCULATION. *SLC | |
| Bulletin Number: 122 | |
| SUBJECT REGARDING AUTOMATIC TRANSAXLE HARSH OR DELAYED PARK-REVERSE OR PARK-DRIVE ENGAGEMENT. *SLC | |
| Bulletin Number: 133 | |
| THIRD GEAR FAIL-SAFE INFORMATION. *TT | |
| Bulletin Number: 200502 | |
| SUBJECT REGARDING SIDE IMPACT AIR BAG WIRE HARNESS ROUTING. *JG | |
| Bulletin Number: 24092001 | |
| INFORMATION REGARDING NOISE FROM REAR WHEELSD ,PARKING BRAKE ADJUSTMENT. *YD | |
| Bulletin Number: 5NP-S9D9P-10 | |
| THIS BULLETIN PROVIDES INFORMATION ON COMPONENTS, ATTRIBUTES, AND PRECAUTIONS OF THE 7-SPEED DRY-TYPE DUAL CLUTCH TRANSMISSION (DCT). | |
| Bulletin Number: 9960001 | |
| THIS TSB IS BEING ISSUED TO PROVIDE BODY DIMENSION INFORMATION. *TT | |
| Bulletin Number: DOR-T5K8Y-01 | |
| This SKU is an Air Conditioning Bypass Pulley. The Customer communication requested return of unsold inventory to inspect for potential bracket cracking. Bracket cracks may cause the engine drive belt to slip or jump off the pulley causin | |
| Bulletin Number: DOR-Y5Q6Z-01 | |
| This SKU is an Air Conditioning Bypass Pulley. The Customer communication requested return of unsold inventory to inspect for potential bracket cracking. Bracket cracks may cause the engine drive belt to slip or jump off the pulley causin | |
| Bulletin Number: TSB-09-AT-013 | |
| HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). AN IMPROPERLY ADJUSTED OR IMPROPERLY OP | |
| Bulletin Number: TSB-09-AT-018 | |
| HYUNDAI: ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0746, P0748, P0750, P0755, P0760, P0765, P0770. INCORRECT OPERATION OF THE TRANSAXLE SOLENOIDS MAY RESULT IN THE FOLLOWING SYMPTOMS-CHECK ENGINE LIGHT ILLUMINATED | |
| Bulletin Number: TSB-11-BR-002 | |
| HYUNDAI: ALL SONATA HYBRIDS. BRAKE BLEEDING PROCEDURE. *RM | |
| 2000 HYUNDAI TIBURON | |
| Bulletin Number: 0040008 | |
| SUBJECT REGARDING THE AUTOMATIC TRANSAXLE TESTER I DESIGNED TO TROUBLESHOOT THE NEW GENERATION TRANSAXLE FOR ALL 2000 MODELS. *TT | |
| Bulletin Number: 0040017 | |
| SUBJECT REGARDING TRANSAXLE DIAGNOSTIC TROUBLE CODES. *TT | |
| Bulletin Number: 0101006 | |
| SUBJECT REGARDING TIBURON SEAT BELT D-RING GUIDE STOPPER. *YD | |
| Bulletin Number: 010101 | |
| INFORMATION ON PERFORMING A TEST DRIVE FOR TRANSAXLE SHIFT QUALITY. *TT | |
| Bulletin Number: 01400061 | |
| AUTOMATIC TRANSAXLE PULSE GENERATOR DIAGNOSTIC TROUBLE CODES P0717 AND P0722 - REVISED. *JG | |
| Bulletin Number: 0236028 | |
| OBD-II READINESS TEST DRIVE CYCLE. *TT | |
| Bulletin Number: 0240010 | |
| SUBJECT ON AUTOMATIC TRANSAXLE HARSH OR DELAYED PARK REVERSE OR PARK DRIVE ENGAGEMENT. *YH | |
| Bulletin Number: 0240012 | |
| SUBJECT REGARDING AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *YH | |
| Bulletin Number: 0240016 | |
| SUBJECT REGARDING AUTOMATIC TRANSAXLE OIL LEAKING FROM OIL PAN GASKET. *JG | |
| Bulletin Number: 0240020 | |
| SUBJECT REGARDING AUTOMATIC TRANSAXLE HARSH AND/OR DELAYED SHIFTS. *JG | |
| Bulletin Number: 0240024 | |
| IMPROVED CLUTCH RELEASE SHAFT UPPER AND LOWER BUSHING. *TT | |
| Bulletin Number: 0250002 | |
| SUBJECT REGARDING FRONT BRAKE CALIPER RATTLE NOISE REPAIR KIT. *TT | |
| Bulletin Number: 0290003 | |
| INFORMATION ON RHEOSTAT ASSEMBLY REPLACEMENT. *YH | |
| Bulletin Number: 0290009 | |
| SUBJECT REGARDING DIAGNOSTIC GUIDE FOR CLIFFORD AND DEI SECURITY SYSTEM. *JG | |
| Bulletin Number: 0340007 | |
| ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0745, P0747, P0748, P0750, P0752, P0753, P0755, P0757, P0758, P0760, P0765. *TT *MJ | |
| Bulletin Number: 0340022 | |
| AUTOMATIC TRANSAXLE PULSE GENERATOR DIAGNOSTIC TROUBLE CODES P0717 & P0722. 2004 ACCENT INCLUDED. *TT | |
| Bulletin Number: 0501001 | |
| EXHAUST MANIFOLD ASSEMBLY INSPECTION AND REPLACEMENT CAMPAIGN. *EH | |
| Bulletin Number: 0501001 | |
| EXHAUST MANIFOLD ASSEMBLY INSPECTION AND REPLACEMENT CAMPAIGN - V04. *TT | |
| Bulletin Number: 0540018 | |
| AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *TT | |
| Bulletin Number: 0804 | |
| REPLACEMENT CIGARETTE LIGHTER. *NM | |
| Bulletin Number: 151 | |
| AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *TT | |
| Bulletin Number: 9901003 | |
| THIS TSB PROVIDES INFORMATION REGARDING THE LOCATION AND CORRECT INFORMATION OF THE EMISSION LABELS. *TT | |
| Bulletin Number: TSB-09-AT-013 | |
| HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). AN IMPROPERLY ADJUSTED OR IMPROPERLY OP | |
| Bulletin Number: V04 | |
| EXHAUST NOISE COMING FROM THE ENGINE COMPARTMENT. VOLUNTARY SERVICE CAMPAIGN V04 INVOLVES INSPECTING AND, IF NECESSARY, REPLACING THE EXHAUST MANIFOLD. *TT | |
| 2000 HYUNDAI XG | |
| Bulletin Number: 0550004 | |
| ABS PUMP SELF CHECK NOISE. ALSO INCLUDED: 2003-2005 MODEL XG AND 1999, 2000, 2001, 2003, 2004 AND 2005 MODEL SANTA FE. *SC | |
| Bulletin Number: TSB-09-AT-013 | |
| HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). AN IMPROPERLY ADJUSTED OR IMPROPERLY OP | |
Recalls for 2000 Hyundai
| 2000 HYUNDAI ACCENT | |
|---|---|
| NHTSA Campaign ID: | STRUCTURE:FRAME AND MEMBERS |
| Manufacturer: | HYUNDAI MOTOR COMPANY |
| Manufacture Dates: | 09/16/1999 - 10/19/2001 |
| Potential Units Affected: | 67565 |
Defect Description:CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE 3-DOOR HATCHBACK EXCEEDED THE PERFORMANCE CRITERION IN THE STANDARD MIDWAY ALONG THE LENGTH OF THE WINDSHIELD SUPPORT PILLAR (A-PILLAR). Consequence:AN OCCUPANT'S HEAD THAT CONTACTS THE A-PILLAR DURING A CRASH COULD EXPERIENCE AN INCREASED RISK OF A HEAD INJURY AS A RESULT OF THIS CONDITION. Action:DEALERS WILL INSTALL NEW ENERGY MANAGEMENT BRACKETS TO SUPPORT THE A-PILLAR COVERS AND INCREASE THE ENERGY ABSORBING PERFORMANCE OF THE A-PILLAR IN THE RELEVANT AREA. OWNER NOTIFICATION BEGAN OCTOBER 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151. | |
| 2000 HYUNDAI ACCENT | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | HYUNDAI MOTOR COMPANY |
| Manufacture Dates: | 08/30/1999 - 06/05/2001 |
| Potential Units Affected: | 49371 |
Defect Description:VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 1.5 LITER OR 1.6 LITER ENGINES THAT WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, COLORADO, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, MAINE, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WHILE DRIVING AT A STEADY THROTTLE OPENING FOR AN EXTENDED PERIOD OF TIME DURING EXTREMELY COLD AMBIENT TEMPERATURES (BELOW APPROXIMATELY -5 DEGREES FAHRENHEIT WITH HIGH HUMIDITY), MOISTURE IN THE COMBUSTION CHAMBER BLOWBY GASES CAN FREEZE AND BLOCK THE POSITIVE CRANKCASE VENTILATION (PCV) VALVE AND HOSE. IF THE PCV HOSE FREEZES, COMBUSTION CHAMBER GASES ARE FORCED THROUGH THE BREATHER HOSE INTO THE AIR INTAKE HOSE AND THEN INTO THE THROTTLE BODY. Consequence:MOISTURE IN THE COMBUSTION CHAMBER BLOWBY GASES MAY FREEZE INSIDE THE THROTTLE BODY BORE AND THROTTLE BODY IDLE SPEED CONTROL CIRCUIT RESULTING IN THE THROTTLE VALVE NOT CLOSING FULLY AND A HIGHER THAN NORMAL IDLE SPEED WHEN THE ACCELERATOR PEDAL IS RELEASED. Action:DEALERS WILL INSTALL A NEW, RELOCATED PCV HOSE AND WILL ADDITIONALLY INSTALL A HEATED THROTTLE BODY ON THE 2000-2001 ACCENTS EQUIPPED WITH 1.5 LITER ENGINES THAT WERE PRODUCED THROUGH JANUARY 31, 2001. OWNER NOTIFICATION BEGAN APRIL 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151. | |
| 2000 HYUNDAI ACCENT | |
|---|---|
| NHTSA Campaign ID: | VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES |
| Manufacturer: | HYUNDAI CARIBBEAN-PUERTO RICO |
| Manufacture Dates: | 11/11/1999 - 01/15/2000 |
| Potential Units Affected: | 400 |
Defect Description:VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE PROTECTIVE RUBBER BOOT WHICH COVERS THE BALL JOINT CONNECTION BETWEEN THE WINDSHIELD WIPER MOTOR DRIVE ARM AND THE WINDSHIELD WIPER DRAG LINK CAN STICK TO THE SURFACE OF THE DRIVE ARM. IF THE RUBBER BOOT STICKS AND THE WIPER MOTOR IS TURNED ON, BINDING OF THE INTERFACE BETWEEN THE DRIVE ARM AND DRAG LINK RESULTS, CAUSING THE BALL JOINT CONNECTION TO DISENGAGE. Consequence:IF THE CONNECTION DISENGAGES, THE WINDSHIELD WIPERS ARE INOPERATIVE. INOPERATIVE WINDSHIELD WIPERS CAN CONTRIBUTE TO REDUCED VISIBILITY DURING INCLEMENT WEATHER. Action:DEALERS WILL REPLACE THE PROTECTIVE RUBBER BOOT AND WILL LUBRICATE THE NEW PROTECTIVE RUBBER BOOT WHERE IT CONTACTS THE DRIVE ARM. | |
| 2000 HYUNDAI ACCENT | |
|---|---|
| NHTSA Campaign ID: | VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES |
| Manufacturer: | HYUNDAI MOTOR COMPANY |
| Manufacture Dates: | 11/11/1999 - 01/15/2000 |
| Potential Units Affected: | 16264 |
Defect Description:VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE PROTECTIVE RUBBER BOOT WHICH COVERS THE BALL JOINT CONNECTION BETWEEN THE WINDSHIELD WIPER MOTOR DRIVE ARM AND THE WINDSHIELD WIPER DRAG LINK CAN STICK TO THE SURFACE OF THE DRIVE ARM. IF THE RUBBER BOOT STICKS AND THE WIPER MOTOR IS TURNED ON, BINDING OF THE INTERFACE BETWEEN THE DRIVE ARM AND DRAG LINK RESULTS, CAUSING THE BALL JOINT CONNECTION TO DISENGAGE. Consequence:IF THE CONNECTION DISENGAGES, THE WINDSHIELD WIPERS ARE INOPERATIVE. INOPERATIVE WINDSHIELD WIPERS CAN CONTRIBUTE TO REDUCED VISIBILITY DURING INCLEMENT WEATHER. Action:DEALERS WILL REPLACE THE PROTECTIVE RUBBER BOOT AND WILL LUBRICATE THE NEW PROTECTIVE RUBBER BOOT WHERE IT CONTACTS THE DRIVE ARM. | |
| 2000 HYUNDAI ELANTRA | |
|---|---|
| NHTSA Campaign ID: | ELECTRICAL SYSTEM:WIRING |
| Manufacturer: | HYUNDAI MOTOR COMPANY |
| Manufacture Dates: | 06/01/1999 - 06/16/2000 |
| Potential Units Affected: | 165977 |
Defect Description:VEHICLE DESCRIPTION: SOME SONATA VEHICLES EQUIPPED WITH 2.5 LITER V-6 ENGINES AND ALL ELANTRA MODEL VEHICLES MAY HAVE EXPERIENCED INTERMITTENT LOW-SPEED ENGINE STALLING, WHICH COULD OCCUR IF THE MAF (MASS AIR FLOW) SENSOR ELECTRICAL SIGNAL IS INTERRUPTED AS A RESULT OF ENGINE VIBRATION TRANSMITTED TO THE MAF SENSOR CONNECTOR WIRING HARNESS. Consequence:THIS CONDITION CAN CAUSE THE ENGINE TO STALL, INCREASING THE RISK OF A CRASH. Action:DEALERS WILL RE-ROUTE THE MAF SENSOR CONNECTOR WIRING HARNESS. | |
| 2000 HYUNDAI LD15 BERING | |
|---|---|
| NHTSA Campaign ID: | TIRES:VALVE |
| Manufacturer: | HYUNDAI TRUCK AMERICA |
| Manufacture Dates: | 07/14/1999 - 01/19/2000 |
| Potential Units Affected: | 1401 |
Defect Description:ON CERTAIN CAB-OVER CLASS 4 TRUCKS, THE SNAP-IN TIRE VALVE STEMS IN THE WHEELS OF THESE TRUCKS CAN LEAK AIR. Consequence:THIS CAN CAUSE A LOSS OF TIRE AIR PRESSURE, LEAD TO A RUPTURE OF THE TIRE, AND CAUSE A LOSS OF CONTROL OF THE VEHICLE. Action:DEALERS WILL INSTALL NEW TIRE VALVE STEMS. OWNER NOTIFICATION BEGAN DECEMBER 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI TRUCK AT 1-609-395-2300. | |
| 2000 HYUNDAI SONATA | |
|---|---|
| NHTSA Campaign ID: | AIR BAGS:SIDE/WINDOW |
| Manufacturer: | HYUNDAI MOTOR COMPANY |
| Manufacture Dates: | 03/01/1998 - 07/23/2001 |
| Potential Units Affected: | 145355 |
Defect Description:ON CERTAIN PASSENGER VEHICLES, AN INTERMITTENT CONDITION THAT LEADS TO THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WARNING LIGHT ILLUMINATION COULD RESULT FROM MOTION OF THE SIDE IMPACT AIR BAG WIRING HARNESS AND SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR WHICH MOUNT TO THE ADJUSTABLE SEAT CUSHION ASSEMBLY. THIS CONDITION ONLY RELATES TO THE SIDE IMPACT AIR BAGS AND COULD PREVENT AIR BAG DEPLOYMENT DURING A CRASH WHERE SUCH DEPLOYMENT SHOULD OCCUR. Consequence:NON-DEPLOYMENT OF THE SRS SIDE IMPACT AIR BAG COULD INCREASE THE RISK OF INJURY DURING A SIDE IMPACT CRASH. Action:DEALERS WILL MORE SECURELY FASTEN THE SIDE IMPACT AIR BAG WIRING HARNESSES AND CONNECTORS TO THE VEHICLE'S FRONT SEAT CUSHION FRAMES. OWNER NOTIFICATION BEGAN MAY 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151. | |
| 2000 HYUNDAI SONATA | |
|---|---|
| NHTSA Campaign ID: | SUSPENSION |
| Manufacturer: | Hyundai Motor Company |
| Manufacture Dates: | 09/15/1998 - 11/20/2003 |
| Potential Units Affected: | 188282 |
Defect Description:HYUNDAI IS RECALLING 188,282 MY 2001-2004 SONATA AND MY 2001-2004 XG300 AND XG350 VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE JURISDICTIONS DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUB-FRAME ON THE VEHICLES, AND MAY RESULT IN THINNING OR PERFORATION OF THE SUB-FRAME STEEL. THE CORROSION IS FREQUENTLY VISIBLE AND OFTEN DISCOVERED DURING INSPECTION OR ROUTINE MAINTENANCE, AND OWNERS MAY ALSO HEAR NOISES OR NOTICE TIRE MISALIGNMENT AND STEERING PULL. IF THESE SIGNALS ARE UNDETECTED OR UNHEEDED, THE CORROSION MAY PROGRESS AND THE FORWARD MOUNTING OF THE LOWER CONTROL ARM MAY DETACH FROM THE SUB-FRAME. Consequence:IF THAT HAPPENS, THE VEHICLE MAY LOSE DRIVE POWER TO THE WHEELS, AND THE FRONT WHEEL MAY MAKE CONTACT WITH THE FENDER OR WHEEL WELL, THEREBY INCREASING THE RISK OF A CRASH. Action:DEALERS WILL MEASURE THE THICKNESS OF THE FRONT SUB-FRAME AND INSPECT THE FRONT SUB-FRAME FOR CORROSION DAMAGE AND, IF NECESSARY, THE FRONT SUB-FRAME WILL BE REPLACED WITH A NEW SUB-FRAME THAT INCORPORATES ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT SUB-FRAME DOES NOT REQUIRE REPLACEMENT, THE DEALER WILL ADD DRAINAGE HOLES TO THE SUB-FRAME AND WILL TREAT THE SUB-FRAME WITH RUST-PROOFING MATERIAL TO STOP THE CORROSION PROCESS. THIS PROCEDURE WILL BE PERFORMED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151. | |
| 2000 HYUNDAI SONATA | |
|---|---|
| NHTSA Campaign ID: | ELECTRICAL SYSTEM:WIRING |
| Manufacturer: | HYUNDAI MOTOR COMPANY |
| Manufacture Dates: | 07/01/1998 - 07/04/2000 |
| Potential Units Affected: | 165977 |
Defect Description:VEHICLE DESCRIPTION: SOME SONATA VEHICLES EQUIPPED WITH 2.5 LITER V-6 ENGINES AND ALL ELANTRA MODEL VEHICLES MAY HAVE EXPERIENCED INTERMITTENT LOW-SPEED ENGINE STALLING, WHICH COULD OCCUR IF THE MAF (MASS AIR FLOW) SENSOR ELECTRICAL SIGNAL IS INTERRUPTED AS A RESULT OF ENGINE VIBRATION TRANSMITTED TO THE MAF SENSOR CONNECTOR WIRING HARNESS. Consequence:THIS CONDITION CAN CAUSE THE ENGINE TO STALL, INCREASING THE RISK OF A CRASH. Action:DEALERS WILL RE-ROUTE THE MAF SENSOR CONNECTOR WIRING HARNESS. | |
| 2000 HYUNDAI SONATA | |
|---|---|
| NHTSA Campaign ID: | AIR BAGS |
| Manufacturer: | HYUNDAI MOTOR COMPANY |
| Manufacture Dates: | 03/01/1998 - 11/22/2000 |
| Potential Units Affected: | 86513 |
Defect Description:VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WARNING LIGHT COULD ILLUMINATE DUE TO MOTION OF THE SIDE IMPACT AIR BAG WIRING HARNESS AND SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR THAT MOUNT TO THE ADJUSTABLE SEAT CUSHION ASSEMBLY. THIS CONDITION ONLY RELATES TO THE DRIVER AND/OR PASSENGER SEAT-MOUNTED SIDE IMPACT AIR BAG(S). Consequence:THIS CONDITION COULD PREVENT SEAT MOUNTED SIDE IMPACT AIR BAG DEPLOYMENT DURING AN ACCIDENT WHERE SUCH DEPLOYMENT SHOULD OCCUR. NON-DEPLOYMENT OF THE SRS SIDE IMPACT AIR BAGS COULD INCREASE THE RISK OF INJURY DURING AN ACCIDENT WHERE SIDE IMPACT AIR BAG DEPLOYMENT IS INTENDED. Action:DEALERS WILL MORE SECURELY FASTEN THE FRONT SEAT SIDE IMPACT AIR BAG WIRING HARNESS AND CONNECTORS TO THE VEHICLE'S FRONT SEAT CUSHION FRAMES. OWNER NOTIFICATION WILL OCCUR IN SIX MAILINGS ON MAY 27, JUNE 3, JUNE 10, JUNE 17, JUNE 24, AND JULY 1, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151. | |
| 2000 HYUNDAI TIBURON | |
|---|---|
| NHTSA Campaign ID: | SEAT BELTS:FRONT:WEBBING |
| Manufacturer: | HYUNDAI MOTOR COMPANY |
| Manufacture Dates: | 03/01/1996 - 08/28/2000 |
| Potential Units Affected: | 42782 |
Defect Description:VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE DRIVER AND FRONT PASSENGER SEAT BELTS MAY NOT EXTEND AND RETRACT SMOOTHLY THROUGH THE D-RING GUIDES MOUNTED ON THE BODY PILLARS AFT OF THE DOORS. IF THE SEAT BELTS DO NOT EXTEND AND RETRACT SMOOTHLY, THEY MAY TWIST IN THE D-RING GUIDES AND MAKE IT INCONVENIENT TO EXTEND AND RETRACT THE SEAT BELTS. Consequence:IF THE SEAT BELTS ARE INCONVENIENT TO USE, THE SEAT OCCUPANT MAY NOT BE INCLINED TO WEAR THE SEAT BELTS PROPERLY, INCREASING THE RISK OF INJURY IN THE EVENT OF A CRASH. Action:DEALERS WILL INSTALL A STOPPER OVER EACH FRONT SEAT BELT D-RING GUIDE TO ASSIST THE SEAT BELT TO SMOOTHLY EXTEND AND RETRACT. OWNER NOTIFICATION BEGAN DECEMBER 10, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151. | |
| 2000 HYUNDAI CARIBBEAN ELANTRA | |
|---|---|
| NHTSA Campaign ID: | ELECTRICAL SYSTEM:WIRING |
| Manufacturer: | HYUNDAI CARIBBEAN-PUERTO RICO |
| Manufacture Dates: | 06/01/1999 - 06/16/2000 |
| Potential Units Affected: | 1421 |
Defect Description:VEHICLE DESCRIPTION: SOME SONATA VEHICLES EQUIPPED WITH 2.5 LITER V-6 ENGINES AND ALL ELANTRA MODEL VEHICLES MAY HAVE EXPERIENCED INTERMITTENT LOW-SPEED ENGINE STALLING, WHICH COULD OCCUR IF THE MAF (MASS AIR FLOW) SENSOR ELECTRICAL SIGNAL IS INTERRUPTED AS A RESULT OF ENGINE VIBRATION TRANSMITTED TO THE MAF SENSOR CONNECTOR WIRING HARNESS. Consequence:THIS CONDITION CAN CAUSE THE ENGINE TO STALL, INCREASING THE RISK OF A CRASH. Action:DEALERS WILL RE-ROUTE THE MAF SENSOR CONNECTOR WIRING HARNESS. | |
| 2000 HYUNDAI TRANSLEAD TRAILER VAN | |
|---|---|
| NHTSA Campaign ID: | STRUCTURE:BODY |
| Manufacturer: | HYUNDAI TRANSLEAD |
| Manufacture Dates: | 10/01/1996 - 12/31/2000 |
| Potential Units Affected: | 2860 |
Defect Description:VEHICLE DESCRIPTION: 53' DRY FREIGHT TRAILER VANS EQUIPPED WITH LASCO TRANSLUCENT FIBERGLASS ROOFS. THE ROOF PANELS CAN BECOME WHOLLY OR PARTIALLY DETACHED DURING OPERATION AND THE TRAILER BODIES COULD PARTIALLY COLLAPSE. Consequence:CONTINUED OPERATION OF A TRAILER WITH A ROOF HOLE, CRACK, TEAR, OR SEPARATION COULD RESULT IN A ROOF FAILURE, CAUSING DAMAGE TO THE VEHICLE, INJURY TO ITS OPERATOR, AND POSSIBLE INJURY AND DAMAGE TO ADJACENT VEHICLES AND THEIR PASSENGERS. Action:DEALERS WILL REPLACE THE LASCO FRPS WITH KEMLITE FRPS OR ALUMINUM PANELS. OWNER NOTIFICATION BEGAN AUGUST 28, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI TRANSLEAD AT 1-819-574-1500. | |
