Ford Buyers Guide
Click a car name to see the crash test details for that model.
Crash Test Data for 2002 Ford
| Ford Vehicle | Front Star Rating | Side Star Rating | Rollover Resistance Rating | ||
|---|---|---|---|---|---|
| Driver | Passenger | Front Seat | Rear Seat | ||
| 2002 Crown Victoria |  | |  | | |
| 2002 Econoline | | | Not Tested | Not Tested |  |
| 2002 Escape | | | | |  |
| 2002 Escort | | | | | Not Tested |
| 2002 EV Ranger | | | Not Tested | Not Tested | Not Tested |
| 2002 Excursion | Not Tested | Not Tested | Not Tested | Not Tested | Not Tested |
| 2002 Expedition | | | Not Tested | Not Tested | |
| 2002 Explorer | | | | | |
| 2002 Explorer Sport | | | | | |
| 2002 Explorer Sport Trac | Not Tested | Not Tested | Not Tested | Not Tested | Not Tested |
| 2002 F-150 | Not Tested | Not Tested | | Not Tested | |
| 2002 F-150 | | | Not Tested | Not Tested | |
| 2002 F-150 | | | | | |
| 2002 Focus | | | | | |
| 2002 Focus | | | |  | |
| 2002 Focus | | | Not Tested | Not Tested | |
| 2002 Mustang | | | | | Not Tested |
| 2002 Mustang | Not Tested | Not Tested | | | Not Tested |
| 2002 Ranger | | | | Not Tested | |
| 2002 Ranger | | | | Not Tested | |
| 2002 Taurus | | | | | |
| 2002 Taurus | | | Not Tested | Not Tested | |
| 2002 Taurus | | | | | |
| 2002 Thunderbird | | | | Not Tested | |
| 2002 Windstar | | | | | |
| 2002 Windstar | | | | | |
| 2002 ZX2 | Not Tested | Not Tested | | | Not Tested |
Service Bulletins for 2002 Ford
| 2002 FORD CROWN VICTORIA | |
|---|---|
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01157 | |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| Bulletin Number: 01181 | |
| BRAKE SHIFT INTERLOCK.*JB | |
| Bulletin Number: 01205 | |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT | |
| Bulletin Number: 012113 | |
| SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL | |
| Bulletin Number: 01213 | |
| VEHICLES MAY EXHIBIT AN INTERMITTENT RAPID FLASHING OF THE TURN SIGNALS. *TT | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 020503 | |
| GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996. *TT UPDATE. *TT | |
| Bulletin Number: 02136 | |
| ON SOME VEHICLES, THE BRAKE SHIFT INTERLOCK MAY BE INOPERATIVE, NOW ALLOWING THE OPERATOR TO MOVE THE SHIFT LEVER FROM THE PARK POSITION. STOP LAMP OPERATION MAY ALSO BE AFFECTED. *TT | |
| Bulletin Number: 0214 | |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| Bulletin Number: 02155 | |
| SOME POLICE PACKAGE EQUIPPED VEHICLES MAY EXHIBIT A LOSS OF 4TH GEAR (OVERDRIVE). *TT | |
| Bulletin Number: 02175 | |
| RESTRAINT SYSTEM-AIR BAG DEPLOYMENT STRATEGY WITH ADVANCED RESTRAINT SYSTEM. *MJ | |
| Bulletin Number: 02176 | |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| Bulletin Number: 02208 | |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0253 | |
| SUBJECT REGARDING ALTERNATIVE FUEL VEHICLE COMPRESSED NATURAL GAS TANK INSPECTION. *TT | |
| Bulletin Number: 0254 | |
| ON SOME VEHICLES EQUIPPED WITH THE 4.6L ENGINE, THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY HYDROPLANE ON THE WATER PUMP PULLEY WHENTHE BELT IS SPLASHED WITH WATER. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 0274 | |
| SOME VEHICLES MAY EXHBIT A SQUEAK / CREAK NOISE COMING FROM THE LEFT FRONT OR RIGHT FRONT DOOR HINGE AREA. *TT | |
| Bulletin Number: 0297 | |
| SOME VEHICLES PRODUCED BEFORE 3/5/2002 MAY EXHIBIT AN INTERMITTENT RAPID FLASHING OF THE TURN SIGNALS. *TT | |
| Bulletin Number: 02B02 | |
| INSTALLATION OF OPTIONAL POLICE INTERCEPTOR PACKAGE UPGRADE KIT. *TT UPDATE PART 2. EXPIRATION DATE REMOVED. *TT | |
| Bulletin Number: 02M01 | |
| CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6 | |
| Bulletin Number: 030409 | |
| POSSIBLE FUEL LEAK AT FILL VALVE - FILL VALVE SERVICE PART REVISIONS - CNG VEHICLES ONLY. *TT | |
| Bulletin Number: 031404 | |
| ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. | |
| Bulletin Number: 03144 | |
| ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 03157 | |
| GRINDING TYPE NOISE FROM THE TIMING CHAIN AREA. *TT | |
| Bulletin Number: 03164 | |
| SOME VEHICLES, EQUIPPED WITH THE 4.6L 2V ENGINE, WITH AN ENGINE BUILD DATE PRIOR TO 8/29/03 MAY EXHIBIT AN ENGINE TICK NOISE THAT IS PRESENT AT ALL TEMPERATURES DURING IDLE. 2004 MODELS INCLUDED. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 03183 | |
| DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY. *TT | |
| Bulletin Number: 03193 | |
| EXCESSIVE MOISTURE IN THE HEADLAMP ASSEMBLY. *TT | |
| Bulletin Number: 03206 | |
| SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY. LOSS OF POWER AT HEAVY LOAD, DIAGNOSTIC TROUBLE CODES (DTCS) FOR LEAN FUEL, ROUGH IDLE, HARD START, | |
| Bulletin Number: 0322 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT | |
| Bulletin Number: 03223 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| Bulletin Number: 03228 | |
| LACK OF AIR CONDITIONER (A/C) COOLING AND RESTRICTED/REDUCED AIR FLOW THROUGH THE A/C VENTS TYPICALLY DURING EXTENDED IDLING CONDITIONS. *TT | |
| Bulletin Number: 03256 | |
| ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003. *MJ | |
| Bulletin Number: 03261 | |
| NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT | |
| Bulletin Number: 0349 | |
| A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE ON SOME CNG (COMPRESSED NATURAL GAS) VEHICLES. *TT *JB | |
| Bulletin Number: 0361 | |
| MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 04111 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. | |
| Bulletin Number: 04136 | |
| DIAGNOSTIC TROUBLE CODE B1342 (RESTRAINTS CONTROL MODULE (RCM) FAULT. *TT UPDATE. *TT | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 041601 | |
| WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04189 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 042407 | |
| NUMEROUS ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR (WSS) DTCS, SUCH AS C1145, C1155, C1165, C1175, C1296, C1297, C1298, C1299 AND C1222. *TT | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 04247 | |
| NUMEROUS ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR (WSS) DIAGNOSTIC TROUBLE CODES (DTCS). *TT | |
| Bulletin Number: 04251 | |
| ALUMINUM CORROSION - SERVICE TIP. *TT | |
| Bulletin Number: 0441 | |
| CRACKS IN THE REAR OF THE FRAME SIDE MEMBER BETWEEN THE UPPER AND LOWER TRAILING ARM BRACKETS. *TT | |
| Bulletin Number: 0522 | |
| MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0420 AND OR P0430. *EH | |
| Bulletin Number: 05310 | |
| SAFETY BELT WEB STOP BUTTON SERVICE. *EH | |
| Bulletin Number: 06216 | |
| LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS. *TT | |
| Bulletin Number: 07212 | |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE | |
| Bulletin Number: 15158 | |
| SOME VEHICLES MAY EXHIBIT A FEAD BELT JUMP-OFF TOSS. *YH | |
| Bulletin Number: 15171 | |
| INFORMATION REGARDING POLICE OPTION-REAR WINDOW DISABLE-TAMPER RESISTANCE. *YD | |
| Bulletin Number: 15271 | |
| DEDICATED CNG REGULATOR BOWL KIT AVAILABLE. *JG | |
| Bulletin Number: 15415 | |
| SOME VEHICLES MAY EXHIBIT AN ENGINE VIBRATION BETWEEN 1100-1300 RPM WHEN THE TRANSMISSION IS PLACED IN EITHER PARK OR NEUTRAL. *TT | |
| Bulletin Number: 15444 | |
| INFORMATION ON CLOCK FUNCTION IN RADIO. *TT | |
| Bulletin Number: 15668 | |
| CONCERNS WITH HESITATION/STUMBLE , COLD ONLY , WHEN SHIFTING FROM PARK TO DRIVE OR PARK TO REVERSE. *TT | |
| Bulletin Number: 15761 | |
| SOME DEDICATED CNG VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS OF HARD START / NO START / ROUGH RUNNING. *TT | |
| Bulletin Number: 15802 | |
| ON SOME VEHICLES THE HEADLAMPS REMAIN ILLUMINATED WHEN WIPERS ARE ACTIVATED AND THEN DEACTIVATED. *TT | |
| Bulletin Number: 15808 | |
| SOME VEHICLES EQUIPPED WITH A ONE-TOUCH DOWN MODULE OR A DRIVERS DOOR MOUDLE MAY EXHIBIT A CONDITION WHERE THE DRIVERS WINDOW MOVES DOWN WHEN ONE OF THE OTHER WINDOWS IS OPERATED. *TT | |
| Bulletin Number: 15812 | |
| OVERSPEED WARNING CHIME ACTIVATION WHEN TRAVELLING ABOVE 70 M PH / 110 KPH. *TT | |
| Bulletin Number: 15875 | |
| SOME RETAIL CUSTOMERS MAY PERCEIVE THE OPERATION OF THE DASH LIGHT DIMMING FEATURE AS BEING FAULTY. *TT | |
| Bulletin Number: 15881 | |
| SUBJECT REGARDING ENGINE STUMBLE / HESITATION COLD ONLY CONDITION. *TT | |
| Bulletin Number: 15893 | |
| SOME VEHICLES MAY EXHIBIT AN INOPERATIVE ENGINE COOLING FAN. *TT | |
| Bulletin Number: 16068 | |
| SOME VEHICLES MAY EXHIBIT AN ENGINE VIBRATION AT 1100-1500 RPM. *TT | |
| Bulletin Number: 16102 | |
| SOME CNG VEHICLES, EQUIPPED WITH AN EXTENDED RANGE REAR TANK, MAY EXHIBIT A REAR RIDE HEIGHT THAT IS BELOW SPECIFICATION. *TT | |
| Bulletin Number: 16378 | |
| IDLE MISS OR SURGE AT HIGHWAY SPEEDS. PREMATURE IGNITION COIL-ON-PLUG (COP) REPLACEMENT / UNDER INVESTIGATION (QSF). *TT | |
| Bulletin Number: 16380 | |
| SERVICE CYLINDER HEAD GASKET FOR 4.6L APPLICATIONS. *TT | |
| Bulletin Number: 16401 | |
| BRAKE BOOSTER PUSH ROD ADJUSTMENT. BRAKE PEDAL FEEL CONDITION. *MJ | |
| Bulletin Number: 16412 | |
| SULPHUR SMELL FROM EXHAUST UNDER INVESTIGATION (QSF). *MJ | |
| Bulletin Number: 16770 | |
| SPEED CONTROL DEACTIVATION SWITCH ADJUSTMENT SERVICE PROCEDURE. *TT | |
| Bulletin Number: 16996 | |
| POLICE INTERCEPTOR MAY EXHIBIT LOW CHARGING SYSTEM VOLTAGE AT IDLE. *TT | |
| Bulletin Number: 17468 | |
| COSMETIC CRACKING OF THE CENTER FLOOR PAN. *TT | |
| Bulletin Number: 17502 | |
| SLOW OR BINDING SIDE DOOR GLASS OPERATION. *TT | |
| Bulletin Number: 17757 | |
| INTERMITTENT RAPID FLASHING OF THE TURN SIGNALS. *TT | |
| Bulletin Number: 17810 | |
| TRANSMISSION FAILURE WHERE THERE IS A LARGE AMOUNT OF METAL OR DEBRIS IN THE PAN. *TT | |
| Bulletin Number: 17871 | |
| MULTIPLE DRIVEABILITY CONCERNS UNDER ACCELERATION CAUSED BY IGNITION COIL. *TT | |
| Bulletin Number: 18351 | |
| CHARGING SYSTEM LIMITATIONS. *EH | |
| Bulletin Number: 18383 | |
| AM/FM AND CELLULAR PHONE RECEPTION INTERFERENCE - SERVICE TIP. *TT | |
| Bulletin Number: 18426 | |
| AM FM AND CELLULAR PHONE RECEPTION INTERFERENCE . *EH | |
| Bulletin Number: TSB 19-2026 | |
| Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo | |
| 2002 FORD E-150 | |
| Bulletin Number: 05173 | |
| MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P1131 AND/OR P1151 - 4.2L ENGINE. *TT | |
| Bulletin Number: 05248 | |
| VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE. *TT | |
| Bulletin Number: 071110 | |
| BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ | |
| Bulletin Number: 14992 | |
| SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A DRIVELINE VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50 - 55 MPH. *TT | |
| Bulletin Number: 15517 | |
| SUBJECT REGARDING EXAGGERATED ENGINE BRAKING ON DECELERATION. *YD | |
| Bulletin Number: 15799 | |
| SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50-55 MPH. *TT | |
| Bulletin Number: 15923 | |
| EXHIBITING A STEERING WHEEL VIBRATION / SHIMMY. *TT | |
| Bulletin Number: 17104 | |
| TICKING/TAPPING NOISE WITH THE ENGINE WARMED UP AND THE TRANSMISSION IN GEAR AT IDLE. 2003 E150 INCLUDED. *TT | |
| Bulletin Number: 17381 | |
| FRONT BRAKE PAD WEAR. *TT | |
| Bulletin Number: 17520 | |
| CLUNK FROM FRONT SUSPENSION. *TT | |
| Bulletin Number: 18250 | |
| INTERMITTENT CLUNK ON 3-2 DOWNSHIFT DURING COASTDOWN/TIP-IN. OASIS. TO INCLUDE 2005 F-150, E-SERIES AND EXPEDITION. *TT | |
| Bulletin Number: 18735 | |
| HEADLIGHT ADJUSTMENT - CHASSIS CAB INCOMPLETE VEHICLES. *TT | |
| Bulletin Number: 19527 | |
| HEADLIGHT ADJUSTMENT NEEDED. *KB | |
| 2002 FORD E-250 | |
| Bulletin Number: 05173 | |
| MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P1131 AND/OR P1151 - 4.2L ENGINE. *TT | |
| Bulletin Number: 05248 | |
| VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE. *TT | |
| Bulletin Number: 071110 | |
| BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ | |
| Bulletin Number: 14992 | |
| SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A DRIVELINE VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50 - 55 MPH. *TT | |
| Bulletin Number: 15634 | |
| CONCERNS WITH BUMP STEER STEERING FEELING NOTED WHEN FRONT WHEELS / TIRES CONTACT ROAD SURFACE IRREGULARITIES. *TT | |
| Bulletin Number: 15799 | |
| SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50-55 MPH. *TT | |
| Bulletin Number: 15890 | |
| SUBJECT REGARDING EARLY WEAR OF THE INNER BRAKE PAD ON THE REAR DISC BRAKES. *TT | |
| Bulletin Number: 17211 | |
| A BUMP STEER STEERING FEELING, NOTED WHEN THE VEHICLE'S FRONT WHEELS/TIRES CONTACT ROAD SURFACE IRREGULARITIES. *TT | |
| Bulletin Number: 17520 | |
| CLUNK FROM FRONT SUSPENSION. *TT | |
| Bulletin Number: 18250 | |
| INTERMITTENT CLUNK ON 3-2 DOWNSHIFT DURING COASTDOWN/TIP-IN. OASIS. TO INCLUDE 2005 F-150, E-SERIES AND EXPEDITION. *TT | |
| Bulletin Number: 18735 | |
| HEADLIGHT ADJUSTMENT - CHASSIS CAB INCOMPLETE VEHICLES. *TT | |
| Bulletin Number: 19527 | |
| HEADLIGHT ADJUSTMENT NEEDED. *KB | |
| Bulletin Number: DOR-X8B9R-11 | |
| This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly ma | |
| 2002 FORD E250 | |
| Bulletin Number: 032306 | |
| DIAGNOSTIC TROUBLE CODE B1876, B1880, B1915 AND/OR B1920 IN THE ECS MODULE - VEHICLES EQUIPPED WITH AFTERMARKET HIGH CURRENT DEVICES. *TT | |
| 2002 FORD E-350 | |
| Bulletin Number: 02L09 | |
| INCORRECT VEHICLE EMISSION CONTROL INFORMATION LABEL INSTALLED. *JG | |
| Bulletin Number: 03911 | |
| ROUGH IDLE AND/OR HESITATION WHEN ACCLERATING ON CERTAIN SUPER DUTY VEHICLES EQUIPPED WITH A 5.4L OR 6.8L ENGINE. *TT | |
| Bulletin Number: 05248 | |
| VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE. *TT | |
| Bulletin Number: 071110 | |
| BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ | |
| Bulletin Number: 14963 | |
| SOME CUT-AWAY VEHICLES MAY EXHIBIT ANTI-SKID BRAKE SYSTEM DIAGNOSTIC TROUBLE CODE C1229, C1230 AND C1237. *TT | |
| Bulletin Number: 14992 | |
| SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A DRIVELINE VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50 - 55 MPH. *TT | |
| Bulletin Number: 15626 | |
| CONCERNS WITH INTERMITTENT ROUGH IDLE ON INITIAL START UP. *TT | |
| Bulletin Number: 15634 | |
| CONCERNS WITH BUMP STEER STEERING FEELING NOTED WHEN FRONT WHEELS / TIRES CONTACT ROAD SURFACE IRREGULARITIES. *TT | |
| Bulletin Number: 15799 | |
| SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50-55 MPH. *TT | |
| Bulletin Number: 15890 | |
| SUBJECT REGARDING EARLY WEAR OF THE INNER BRAKE PAD ON THE REAR DISC BRAKES. *TT | |
| Bulletin Number: 16055 | |
| SOME VEHICLES EQUIPPED WITH A 5.4L ENGINE / 4R100 TRANSMISSION FEDERAL EMISSIONS POWERTRAIN MAY EXHIBIT A ROUGH IDLE AND / OR HESITATION WHEN ACCELERATING. *TT | |
| Bulletin Number: 17211 | |
| A BUMP STEER STEERING FEELING, NOTED WHEN THE VEHICLE'S FRONT WHEELS/TIRES CONTACT ROAD SURFACE IRREGULARITIES. *TT | |
| Bulletin Number: 17520 | |
| CLUNK FROM FRONT SUSPENSION. *TT | |
| Bulletin Number: 18250 | |
| INTERMITTENT CLUNK ON 3-2 DOWNSHIFT DURING COASTDOWN/TIP-IN. OASIS. TO INCLUDE 2005 F-150, E-SERIES AND EXPEDITION. *TT | |
| Bulletin Number: 18735 | |
| HEADLIGHT ADJUSTMENT - CHASSIS CAB INCOMPLETE VEHICLES. *TT | |
| Bulletin Number: 19527 | |
| HEADLIGHT ADJUSTMENT NEEDED. *KB | |
| Bulletin Number: DOR-X8B9R-11 | |
| This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly ma | |
| 2002 FORD E350 | |
| Bulletin Number: 032306 | |
| DIAGNOSTIC TROUBLE CODE B1876, B1880, B1915 AND/OR B1920 IN THE ECS MODULE - VEHICLES EQUIPPED WITH AFTERMARKET HIGH CURRENT DEVICES. *TT | |
| Bulletin Number: 0511 | |
| CRACKS IN THE LEFT OR RIGHT SPRING TOWER FLANGE. *TT SPRING TOWER WELD REPAIR AND REPLACEMENT PROCEDURE. *TT | |
| 2002 FORD E-450 | |
| Bulletin Number: 02L09 | |
| INCORRECT VEHICLE EMISSION CONTROL INFORMATION LABEL INSTALLED. *JG | |
| Bulletin Number: 03911 | |
| ROUGH IDLE AND/OR HESITATION WHEN ACCLERATING ON CERTAIN SUPER DUTY VEHICLES EQUIPPED WITH A 5.4L OR 6.8L ENGINE. *TT | |
| Bulletin Number: 0511 | |
| CRACKS IN THE LEFT OR RIGHT SPRING TOWER FLANGE. *TT SPRING TOWER WELD REPAIR AND REPLACEMENT PROCEDURE. *TT | |
| Bulletin Number: 05248 | |
| VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE. *TT | |
| Bulletin Number: 14963 | |
| SOME CUT-AWAY VEHICLES MAY EXHIBIT ANTI-SKID BRAKE SYSTEM DIAGNOSTIC TROUBLE CODE C1229, C1230 AND C1237. *TT | |
| Bulletin Number: 17520 | |
| CLUNK FROM FRONT SUSPENSION. *TT | |
| Bulletin Number: 17799 | |
| ENGINE ROUGHNESS AND DRIVEABILITY SYMPTOMS. *TT | |
| Bulletin Number: 18250 | |
| INTERMITTENT CLUNK ON 3-2 DOWNSHIFT DURING COASTDOWN/TIP-IN. OASIS. TO INCLUDE 2005 F-150, E-SERIES AND EXPEDITION. *TT | |
| Bulletin Number: 18382 | |
| FLUID LEAKING FROM THE VENT ON THE TRANSMISSION MOUNTED PARKING BRAKE ASSEMBLY. *TT | |
| 2002 FORD ECONOLINE | |
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01T04 | |
| INFORMATION REGARDING IMRC SET SCREW WARRANTY REPAIR.*JB | |
| Bulletin Number: 02M01 | |
| CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6 | |
| Bulletin Number: 03148 | |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04E10 | |
| EMISSION RECALL 04E10: COMPRESSED NATURAL GAS (CNG) VEHICLES - FITTING CONNECTOR REPLACEMENT. *MJ | |
| Bulletin Number: 15110 | |
| INFORMATION REGARDING REAR ENTERTAINMENT SYSTEM LOCK DOWN SCREWS. *SLC | |
| Bulletin Number: 15271 | |
| DEDICATED CNG REGULATOR BOWL KIT AVAILABLE. *JG | |
| Bulletin Number: 15593 | |
| SOME VEHICLES BUILT BETWEEN 11/29/01 AND 11/30/01 MAY EXHIBIT A SERPENTINE BELT SQUEAL. *TT | |
| Bulletin Number: 15686 | |
| CONCERNS OF DIAGNOSTIC TROUBLE CODE P1280 RETRIVED FROMTHE POWER TRAIN CONTROL MODULE (PCM). *TT | |
| Bulletin Number: 15871 | |
| SOME VEHICLES MAY EXHIBIT INTERFERENCE AND / OR STATIC IN THE LAND-MOBILE RADIO. *TT | |
| Bulletin Number: 15912 | |
| SUBJECT REGARDING FAMILY OR REAR SEAT ENTERTAINMENT SYSTEM HANDLE CONCERNS. *TT | |
| Bulletin Number: 16258 | |
| VEHICLES EQUIPPED WITH A 7.3L ENGINE (AFTER SERIAL NUMBER 0661894) - UNDER VALVE COVER (UVC) HARNESS RETAINER CLIP RELEASED FOR SERVICE. INCLUDES 2003 ECONOLINE, SUPER DUTY, F650/750 AND EXCURSION. *TT | |
| Bulletin Number: 16480 | |
| DIAGNOSTIC TROUBLE CODE (DTC) P0340, POSSIBLE FALSE CODE. VARIOUS MODELS INCLUDING 1994-1996 FORD EXCURSION. *TT | |
| Bulletin Number: 16683 | |
| FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB | |
| Bulletin Number: 16697 | |
| EXHAUST AIR RUSH NOISE AND LOWER POWER. *TT *JB | |
| Bulletin Number: 16916 | |
| REPEATED BLOWN FUSES FOR REAR IN VEHICLE CIRCUITS WITH INOPERATIVE REAR BRAKE OR TAIL LAMPS. *TT | |
| Bulletin Number: 17385 | |
| AIR BAG LAMP ILLUMINATED. *TT | |
| Bulletin Number: 17406 | |
| LOW POWER, POOR FUEL ECONOMY, FUEL GELLING COLD, EXCESSIVE WHITE SMOKE COLD, OR HARD START. *MJ THIS OASIS UPDATES PREVIOUS OASIS DATED 12/01/03. *TT | |
| Bulletin Number: 17467 | |
| ENGINE OR FUEL SYSTEM CONCERNS WHEN USING FUEL WITH GREATER THAN 5% BIODIESEL CONCENTRATION. *TT | |
| Bulletin Number: CSP-48B01 | |
| FORD: VEHICLES MISTAKENLY CHARGED $100 POWERTRAIN WARRANTY DEDUCTIBLE FOR FUEL INJECTOR REPAIR OR REPAIRS. NO MODEL OR MODEL YEARS PROVIDED. *PE ECONOLINE, EXCURSION AND F-SERIES SUPER DUTY VEHICLES, MODEL YEARS 2002-2005. UPDATED | |
| Bulletin Number: DOR-X8B9R-11 | |
| This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly ma | |
| Bulletin Number: TSB T2007-03 | |
| MERLIN MULTIPLEX SYSTEM WHEN A PROER/GROUND LUG IS NOT CORRECTLY TIGHTENED OR BECOMES LOOSE FOR ANY REASON; ERRATIC SYSTEM OPERATION IS POSSIBLE. | |
| 2002 FORD ESCAPE | |
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01157 | |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| Bulletin Number: 01181 | |
| BRAKE SHIFT INTERLOCK.*JB | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 0214 | |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| Bulletin Number: 02176 | |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| Bulletin Number: 02208 | |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH | |
| Bulletin Number: 02231 | |
| DRIVEABILITY-INTERMITTENT ENGINE QUIT OR IDLE DIP-NO DIAGNOSTIC TROUBLE CODES (DTCS) PRESENT-VEHICLES EQUIPPED WITH 3.0L DURATEC ENGINE ONLY. *MJ | |
| Bulletin Number: 0224 | |
| SOME VEHICLES EQUIPPED WITH THE CD4E TRANSAXLE MAY EXHIBIT HARSH AND DELAYED 1-2/2-3 UPSHIFTS AFTER TRANSAXLE OR TURBINE SHAFT SPEED SENSOR REPLACEMENT, POSSIBLE DIAGNOSTIC TROUBLE CODES 628, 642, 645, 646, 647, 648, P0731, P0732, P0734, P0 | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0252 | |
| SOME VEHICLES BUILT BEFORE 2/12/2002 MAY EXHIBIT A POWER STEERING FLUID LEAK AT THE RETURN HOSE AND / OR COOLER HOSE AT THE INTERMIEDIATE TUBE ASSEMBLY DURING EXTREME COLD AMBIENT TEMPERATURES -20 TO -28C (-5 TO -20 F), *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 0286 | |
| SOME VEHICLES EQUIPPED WITH THE 3.0L DURATEC ENGINE MAY EXHIBIT AN INTERMITTENT ENGINE QUIT CONDITION. *TT | |
| Bulletin Number: 0293 | |
| SOME VEHICLES BUILT BEFORE 12/15/01 MAY EXHIBIT DOOR LATCHES THAT WILL NOT OPEN. *TT | |
| Bulletin Number: 02M01 | |
| CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6 | |
| Bulletin Number: 031404 | |
| ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. | |
| Bulletin Number: 03144 | |
| ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 03148 | |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 031513 | |
| TIE ROD END INSPECTION PROCEDURE. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 032011 | |
| AIRBAG LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES (DTCS) B1877 (DRIVER PRETENSIONER CIRCUIT OPEN) OR B1881 (PASSENGER PRETENSIONER CIRCUIT OPEN). *TT THIS BULLETIN SUPERSEDES TSB 03-20-11 DATED 2003. *TT | |
| Bulletin Number: 03203 | |
| MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT | |
| Bulletin Number: 0322 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT | |
| Bulletin Number: 03223 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| Bulletin Number: 03252 | |
| ENGINE-COOLING SYSTEM-LOW COOLANT WARNING INDICATOR LAMP ILLUMINAION-COOLANT DEGAS BOTTLE INSPECTION-SERICE TIP. *MJ | |
| Bulletin Number: 0361 | |
| MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 04111 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. | |
| Bulletin Number: 04141 | |
| TRANSMISSION CONTROL INDICATOR LAMP (TCIL) ON WITH DIAGNOSTIC TROUBLE CODE P1783 AND/OR P0733 COLD CLIMATE SHIFT/ENGAGEMENT CONCERNS WITH A CD4E TRANSAXLE. *TT | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 041601 | |
| WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04189 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 04191 | |
| SAFETY BELT BUCKLE AND PRETENSIONER DIAGNOSTIC TROUBLE CODE (DTC) B1877, B1881, B1885 OR B1886. *TT | |
| Bulletin Number: 04208 | |
| CAMSHAFT TICK NOISE - 3.0L 4V ENGINE ONLY. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04214 | |
| STEERING DRIFT/PULL - IMPROVED DIAGNOSTIC AND REPAIR PROCEDURE - SERVICE TIP. *TT | |
| Bulletin Number: 04217 | |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 042210 | |
| STEERING GEAR SQUEAK - WHEN TURNING THE STEERING WHEEL DURING LOW SPEED PARKING MANEUVERS. *TT | |
| Bulletin Number: 04232 | |
| WHEEL SPEED SENSOR REMOVAL TIP. *EH | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 04244 | |
| RESTRAINT SYSTEM - SAFETY BELT BUCKLE AND PRETENSIONER DIAGNOSTIC TROUBLE CODE (DTC) B1877 AND/OR B1881. *TT | |
| Bulletin Number: 042513 | |
| SERVICEABILITY OF INSTRUMENT PANEL REGISTER VENTS. *TT | |
| Bulletin Number: 042612 | |
| SIDE AIR BAG DIAGNOSTIC TROUBLE CODE (DTC) B1994 OR B1998. *TT | |
| Bulletin Number: 05310 | |
| SAFETY BELT WEB STOP BUTTON SERVICE. *EH | |
| Bulletin Number: 0693 | |
| PCM FAILURE - ELECTRICAL ACCESSORIES INTERMITTENT - INOPERATIVE. *TT | |
| Bulletin Number: 14982 | |
| INFORMATION REGARDING ALIGNMENT SPECIFICATIONS. *TT | |
| Bulletin Number: 15112 | |
| CUSTOMERS MAY COMPLAIN OF DIFFICULTY PROGRAMMING A KEY BY USING THE CUSTOMER SPARE KEY PROGRAMMING METHOD. *YD | |
| Bulletin Number: 15159 | |
| SOME VEHICLES MAY EXHIBIT A PCV DISENGAGED AT THE UPPER INTAKE MANIFOLD IN THE EVENT OF AN ENGINE BACKFIRE. *SLC | |
| Bulletin Number: 15224 | |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT HIGH FREQUENCY BRAKE SQUEAL NOISE. *TT | |
| Bulletin Number: 15427 | |
| EXHIBITING A CLICKING TYPE NOISE FROM EITHER OR BOTH OF THE FRONT WHEELS WHEN TURNING AT SLOW SPEEDS AFTER DRIVING FOR APPROXIMATEL 20-30 MINUTES. *TT | |
| Bulletin Number: 15430 | |
| SOME 4X4 VEHICLES MAY EXHIBIT DRIVELINE BINDING, WHEEL HOP ON TIGHT TURNS, OR A CLUNK TYPE NOISE FROM THE DRIVELINE DURING TORQUE REVERSAL. *TT | |
| Bulletin Number: 15434 | |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT ENGINE QUIT CONDITION. *TT | |
| Bulletin Number: 15456 | |
| EXHIBITING A CONDITION OF THE CLIMATE CONTROL SYSTEM DEFAULTING TO DEFROST/WINDSHIELD ON ACCELERATION. *TT | |
| Bulletin Number: 15476 | |
| ON SOME VEHICLES, THE AFTERMARKET/NON-FACTORY INSTALLED TRAILER TOW WIRING MAY BECOME INOPERATIVE. *TT | |
| Bulletin Number: 15482 | |
| SOME VEHICLES EQUIPPED WITH A DURATEC ENGINE MAY EXPERIENCE ENGINE DAMAGE AS A RESULT OF MICROSCOPIC INTERNAL CRACKS IN A BATCH OF INTAKE VALVES. *TT | |
| Bulletin Number: 15524 | |
| SOME VEHICLES MAY EXPERIENCE GEAR SHIFTER BUZZ OR RATTLE WHEN IN 3RD OR 4TH GEAR.*YD | |
| Bulletin Number: 15566 | |
| SOME VEHICLES MAY EXHIBIT A TACKY SURFACE ON THE INSTRUMENT PANEL (IP). *TT | |
| Bulletin Number: 15576 | |
| SOME VEHICLES BUILT BEFORE 12/11/2001 MAY EXHIBIT A SLIGHT LOOSENESS OF THE STEERING WHEEL IN A FORE-AFT DIRECTION. *TT | |
| Bulletin Number: 15589 | |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT ENGINE QUIT CONDITION, USUALLY 1 TIME DURING CLOSED THROTTLE DECEL WITH NO DIAGNOSTIC TROUBLE CODES OR MALFUNCTION INDICATOR LAMPS. *TT | |
| Bulletin Number: 15604 | |
| SOME VEHICLES WITH 3.0L DURATEC ENGINE BUILT BETWEEN JUNE 12, 2000 AND DECEMBER 15, 2000 MAY EXHIBIT AN INTEMITTENT MALFUNCTION INDICATOR LAMP ILLUMINATION AND / OR DIAGNOSTIC TROUBLE CODES P0301 OR P0351. *TT | |
| Bulletin Number: 15685 | |
| SOME VEHICLES EQUIPPED WITH A 2.0L ENGINE AND A MANUAL TRANSMISSION, MAY EXHIBIT A ROLLING IDLE CONDITION IN HIGH AMBIENT TEMPERATURES. *TT | |
| Bulletin Number: 15756 | |
| SUBJECT REGARDING HANGING DOOR WEATHERSTRIP. *TT | |
| Bulletin Number: 15766 | |
| SOME VEHICLES MAY EXHIBIT A CRANK / NO START, POOR IDLE, AND / OR LACK OF POWER, WITH CAMSHAFTS OUT OF TIME. *TT | |
| Bulletin Number: 15800 | |
| SOME VEHICLES MAY EXHIBIT A HIGH ACCELERATOR PEDAL EFFORT JUST OFF IDLE OR TIP IN. *TT | |
| Bulletin Number: 15818 | |
| SOME VEHICLES BUILT 09/2001 THROUGH 11/2001 AND EQUIPPED WITH A 2.0L ZETEC ENGINE MAY EXHIBIT A FEAD BELT NOISE. *TT | |
| Bulletin Number: 15828 | |
| SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE B1213, B1342, B1601, B2431. *TT | |
| Bulletin Number: 15860 | |
| SOME VEHICLES MAY EXHIBIT A BRAKE FLUID LEAK FROM THE MASTER CYLINDER RESERVOIR CAP. *TT | |
| Bulletin Number: 15999 | |
| SOME VEHICLES MAY EXHIBIT CD EJECTING OR LOADING ISSUES WITH THE CDX-6 RADIO. *TT | |
| Bulletin Number: 16016 | |
| SOME VEHICLES MAY EXHIBIT A CLICKING NOISE HEARD ON LEFT OR RIGHT HAND TURNS COMING FROM THE FRONT SUSPENSION. *TT | |
| Bulletin Number: 16046 | |
| SOME VEHICLES MAY EXHIBIT A REAR SHOCK LEAK AND / OR NOISE CONDITION. *TT | |
| Bulletin Number: 16056 | |
| CD4E TRANSAXLE MAY EXHIBIT A FINAL DRIVE WHINE / WARBLE TYPE NOISE MOSTLY IN THE 25-45 MPH SPEED RANGE ON LIGHT THROTTLE ACCELERATION OR DECELERATION. *TT | |
| Bulletin Number: 16103 | |
| THIS BULLETIN STATES THAT THE REAR UNDERBODY HEAT SHIELD IS DISCONTINUED. *TT | |
| Bulletin Number: 16116 | |
| SUBJECT REGARDING THROTTLE BODY SERVICE REPLACEMENT / TRANSMISSION VENT HOSE BRACKET INSTRUCTIONS. *TT | |
| Bulletin Number: 16154 | |
| SOME VEHICLES WITH ALUMINUM WHEELS MAY EXHIBIT A CLICKING NOISE HEARD COMING FROM THE FRONT OF THE VEHICLE DURING LEFT OR RIGHT HAND TURNS. *TT | |
| Bulletin Number: 16209 | |
| CIMATE CONTROL SYSTEM ODOR. *MJ | |
| Bulletin Number: 16266 | |
| FALSE ALARM ACTIVATION. *TT | |
| Bulletin Number: 16405 | |
| BRAKE SQUEAL / ENGINEERING CONTRACT REQUEST. *MJ | |
| Bulletin Number: 16409 | |
| CLICK ON TURNS. *MJ | |
| Bulletin Number: 16410 | |
| TRAILER TOW HARNESS INSTALLATION / SERVICE TIP. *MJ | |
| Bulletin Number: 16413 | |
| PARK BRAKE ADJUSTMENT / CONTACT REQUEST. *MJ | |
| Bulletin Number: 16420 | |
| SQUEAK, CREAK OR RATTLE TYPE NOISE FROM REAR LIFTGATE AREA. *TT | |
| Bulletin Number: 16447 | |
| MUSTY ODOR FROM CLIMATE CONTROL SYSTEM. *TT | |
| Bulletin Number: 16645 | |
| INSTRUMENT PANEL BRAKE LAMP ILLUMINATION AND/OR BRAKE FLUID LEAKING CONDITION. *TT | |
| Bulletin Number: 16696 | |
| WHINING / PROPELLER / HELICOPTER TYPE NOISE FROM FRONT WHEEL / KNUCKLE BEARING AREA. *TT *JB | |
| Bulletin Number: 16717 | |
| AUTOMATIC TRANSAXLE SHUDDER. *TT *JB | |
| Bulletin Number: 16779 | |
| PERCEIVED CONDITION OF NO ENTRY OR UNABLE TO MANUALLY UNLOCK THE DOOR. THIS MAY OCCUR WHEN THE BATTERY IS ALLOWED TO BECOME DISCHARGED OR COMPLETELY DEAD AND THE REMOTE KEYLESS ENTRY (KEYFOB) IS USED WHILE THE BATTERY IS IN THIS STATE. | |
| Bulletin Number: 16811 | |
| INTERMITTENT ELECTRICAL CONDITIONS WITH POWER WINDOWS, LOCKS, FOBS, RADIO, LIGHTING, CRUISE CONTROL OR OTHER ELECTRICAL ACCESSORIES. *TT | |
| Bulletin Number: 16908 | |
| SQUEAKING NOISE FROM THE POWER STEERING RACK WHEN TURNING. *TT | |
| Bulletin Number: 16964 | |
| EXCESSIVE BRAKE PAD/LINING DUST AND WEAR. *TT | |
| Bulletin Number: 17067 | |
| FRONT SEATBELT SLOW TO RETRACT. *TT | |
| Bulletin Number: 17316 | |
| FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP. *TT | |
| Bulletin Number: 17343 | |
| FRONT SAFETY BELT SLOW TO RETRACT AND/OR MISSING WEB STOP BUTTON. *TT | |
| Bulletin Number: 17366 | |
| FINAL DRIVE WHINE MOST NOTICEABLE AT 25-45 MPH DURING LIGHT ACCELERATION OR DECELERATION. *TT | |
| Bulletin Number: 17380 | |
| A CHECK FUEL CAP INDICATOR ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0457 OR A MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DTC P0455 OR P0457. *TT | |
| Bulletin Number: 17457 | |
| EXCESSIVE FRONT ROTOR WEAR AND/OR BRAKE DUST. *TT | |
| Bulletin Number: 17532 | |
| LOW PRESSURE POWER STEERING LINE LEAK AFTER COLD SOAK IN TEMPERATURES OF -23C (-10) OR LOWER. *MJ | |
| Bulletin Number: 17657 | |
| CLUTCH CHATTER WHEN COLD. *TT | |
| Bulletin Number: 17703 | |
| TICKING NOISE FROM LEFT CYLINDER HEAD WITH WARM ENGINE. *TT | |
| Bulletin Number: 18173 | |
| A FINAL DRIVE WHINE AT 25-45 MPH (40-72 KM/H). *TT | |
| Bulletin Number: 18217 | |
| MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT | |
| Bulletin Number: 18280 | |
| AIR BAG WARNING LAMP ON . *EH | |
| Bulletin Number: 18281 | |
| CONDENSATION INSIDE THE FOGLAMPS. *EH | |
| Bulletin Number: 18284 | |
| HIGH AIRFLOW FROM DEFROSTER VENTS WHEN IN FLOOR OR FLOOR DEFROST MODES. *EH | |
| Bulletin Number: 19016 | |
| REPLACE TIMING BELT IDLER PULLEY DURING 2.0L ZETEC ENGINE CYLINDER HEAD REPLACEMENT - SERVICE TIP. *TT | |
| Bulletin Number: TSB-14-0143 | |
| FORD: THE LOWER CONTROL ARM (LCA) FORWARD ATTACHMENT WILL SEPARATE FROM SUBFRAME, CAUSING DIMINISHING DIRECTIONAL CONTROL, DUE TO OPERATING IN HIGH CORROSION AREAS FOR EXTENDED PERIOD OF TIME. MODEL 2001-2004 ESCAPE. *PE | |
| 2002 FORD ESCORT | |
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01157 | |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| Bulletin Number: 01181 | |
| BRAKE SHIFT INTERLOCK.*JB | |
| Bulletin Number: 01242 | |
| SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P1744 WITH NO DRIVEABILITY CONCERNS PRESENT. *TT | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 020901 | |
| ROUGH IDLE, LOW POWER AND / OR STALL AT IDLE, A MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0300 THROUGH P0304 STORED IN MEMORY. *TT | |
| Bulletin Number: 0214 | |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| Bulletin Number: 02176 | |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| Bulletin Number: 02208 | |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0291 | |
| SOME VEHICLES EQUIPPED WITH THE 2.0L SPI ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND DIAGNOSTIC TROUBLE CODES (DTC) P0300 THROUGH P0304 STORED. *TT | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 031515 | |
| IDLE VIBRATION ON VEHICLES EQUIPPED WITH 2.0L SPI OR ZETEC ENGINE ONLY. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04189 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04V09 | |
| TRW VEHICLE SAFETY SYSTEMS, INC. IS RECALLING CERTAIN SERVICE REPLACEMENT SEATBELT RETRACTORS (DRIVER'S SIDE FRONT RETRACTOR IN GRAY) MANUFACTURED IN DECEMBER 2002 AND SOLD AS A SERVICE REPLACEMENT PART BETWEEN DECEMBER 2002 AND JULY 2004. | |
| Bulletin Number: 15554 | |
| INFORMATION REGARDING NO START DUE TO A SEIZED CAMSHAFT. *YH | |
| Bulletin Number: 15858 | |
| SUBJECT REGARDING FUSE BOX COVER AND #7 FUSE LOCATION. *TT | |
| Bulletin Number: 16746 | |
| HIGHER THAN NORMAL IDLE SPEED, RUNS ROUGH AT IDLE AND/OR DIAGNOSTIC TROUBLE CODE (DTC) P0171. *TT | |
| Bulletin Number: 19016 | |
| REPLACE TIMING BELT IDLER PULLEY DURING 2.0L ZETEC ENGINE CYLINDER HEAD REPLACEMENT - SERVICE TIP. *TT | |
| 2002 FORD E SERIES | |
| Bulletin Number: 01157 | |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| Bulletin Number: 01181 | |
| BRAKE SHIFT INTERLOCK.*JB | |
| Bulletin Number: 01205 | |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT | |
| Bulletin Number: 012113 | |
| SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL | |
| Bulletin Number: 01234 | |
| SOME VEHICLES EQUIPPED WITH AFTERMARKET HIGH-CURRENT DEVICES MAY EXHIBIT DIAGNOSTIC TROUBLE CODES B1876, B1880, B1915 AND/OR B1920 AIRBAG ELECTRONIC CRASH SENSOR MODULE. *TT | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 020503 | |
| GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996. *TT UPDATE. *TT | |
| Bulletin Number: 02108 | |
| SOME VEHICLES EQUIPPED WITH THE 5.4L 2V ENGINE MAY EXHIBIT A WHISTLING NOISE FROMTHE FORMED NYLON TUBE INTHE IDLE-AIR BYPASS FLOW CIRCUIT. *TT | |
| Bulletin Number: 0214 | |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| Bulletin Number: 02168 | |
| REPORTS THAT CERTAIN VEHICLES APPEAR TO BE DOGTRACKING. *TT | |
| Bulletin Number: 02174 | |
| BODY-WATERLEAK-COWL TO DASH WASHLEAK-WATER ACCUMULATION AND/OR LEAK AT THE DRIVER'S FLOOR PAN AREA. *MJ | |
| Bulletin Number: 02176 | |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| Bulletin Number: 02221 | |
| ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ | |
| Bulletin Number: 02227 | |
| ENGINE-CYLINDER HEAD DECK LEAK-4.6 AND 5.4L ENGINES-NEW SERVICE-ONLY GASKET AND CYLINDER HEAD KITS AVAILABILITY. *MJ | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0253 | |
| SUBJECT REGARDING ALTERNATIVE FUEL VEHICLE COMPRESSED NATURAL GAS TANK INSPECTION. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 0258 | |
| INOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639. *TT | |
| Bulletin Number: 02E20 | |
| SUBJECT REGARDING DEMONSTRATION/ DELIVERY HOLD: POWERTRAIN CONTROL MODULE REPROGRAMMING. *JG | |
| Bulletin Number: 02L09 | |
| SUBJECT REGARDING INCORRECT VEHICLE EMISSION INFORMATION LABEL INSTALLED . *JG | |
| Bulletin Number: 02T49 | |
| SUBJECT REGARDING SERVICE ENGINE SOON (SES) LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P1441 SET IN PCM HISTORY (INSTALL NEW PCM CALIBRATION) *JG | |
| Bulletin Number: 030402 | |
| ON SOME DEDICATED CNG VEHICLES, A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE. REVISED SERVICE PARTS. *TT | |
| Bulletin Number: 031404 | |
| ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. | |
| Bulletin Number: 031410 | |
| TURBO PEDESTAL SEAL OIL LEAK AROUND THE EXHAUST BACK PRESSURE (EBP) ACTUATOR. 2003 SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 03144 | |
| ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 03164 | |
| SOME VEHICLES, EQUIPPED WITH THE 4.6L 2V ENGINE, WITH AN ENGINE BUILD DATE PRIOR TO 8/29/03 MAY EXHIBIT AN ENGINE TICK NOISE THAT IS PRESENT AT ALL TEMPERATURES DURING IDLE. 2004 MODELS INCLUDED. *TT | |
| Bulletin Number: 03171 | |
| 7.3L DIESEL HIGH PRESSURE OIL PUMP LEAK. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 03183 | |
| DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY. *TT | |
| Bulletin Number: 03192 | |
| LEAK OIL AROUND THE EXHAUST BACKPRESSURE ACTUATOR (EBP) - 7.3L DIESEL TURBOCHARGER PEDESTALS. *TT | |
| Bulletin Number: 03206 | |
| SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY. LOSS OF POWER AT HEAVY LOAD, DIAGNOSTIC TROUBLE CODES (DTCS) FOR LEAN FUEL, ROUGH IDLE, HARD START, | |
| Bulletin Number: 032145 | |
| EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT | |
| Bulletin Number: 032146 | |
| ENGINE OIL PAN CORROSION ON VEHICLES EQUIPPED WITH THE 7.3L DIESEL ENGINE. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT | |
| Bulletin Number: 032148 | |
| SOME 7.3L DIT VEHICLES MAY EXHIBIT THE OCCURRENCE OF P0340 CAMSHAFT POSITION SENSOR FALSE DIAGNOSTIC TROUBLE CODE (DTC). OTHERS MAY EXHIBIT A LATE 4R100 3-4 SHIFT (HANGING IN 3RD GEAR) AT LIGHT THROTTLE DUE TO POTENTIAL LACK OF CONVERTER L | |
| Bulletin Number: 032150 | |
| HIGH PRESSURE OIL PUMP LEAK ON VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE. *TT | |
| Bulletin Number: 032151 | |
| SOME 7.3L DIESEL TURBOCHARGER PEDESTALS MAY LEAK OIL AROUND THE EXHAUST BACK PRESSURE ACTUATOR (EBP). *TT THIS ARTICLE SUPERSEDES TSB 03-21-51 DATED 10/30/2003. *TT | |
| Bulletin Number: 0322 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT | |
| Bulletin Number: 03223 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| Bulletin Number: 03236 | |
| DIAGNOSTIC TROUBLE CODES (DTC) B1876, B1880, B1915 AND/OR B1920 AIRBAG ELECTRONIC CRASH SENSOR (ECS) MODULE ON VEHICLES EQUIPPED WITH AFTERMARKET HIGH CURRENT DEVICES. *TT | |
| Bulletin Number: 03256 | |
| ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003. *MJ | |
| Bulletin Number: 03261 | |
| NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT | |
| Bulletin Number: 0342 | |
| POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE, ON SOME DEDICATED CNG VEHICLES. *TT *JB | |
| Bulletin Number: 0361 | |
| MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 041601 | |
| WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04228 | |
| HARD START OR NO START. *EH | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 04266 | |
| A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP. *TT | |
| Bulletin Number: 0484 | |
| CHASSIS COMPONENT TORQUE UPDATE FOR E-COATED FRAMES. *TT | |
| Bulletin Number: 05417 | |
| INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT | |
| Bulletin Number: 0554 | |
| USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE. *TT | |
| Bulletin Number: 07212 | |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE | |
| Bulletin Number: 15255 | |
| CONCERNS WITH DIAGNOSTIC TROUBLE CODES P1516, P1518, P1519, AND P1520. *TT | |
| Bulletin Number: 15355 | |
| SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT | |
| Bulletin Number: 15373 | |
| SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES. *TT | |
| Bulletin Number: 15397 | |
| SOME VEHICLES MAY EXHIBIT A CONDITION OF OIL CONTAMINATION IN COOLING SYSTEM. *TT | |
| Bulletin Number: 15398 | |
| SOME VEHICLES MAY EXHIBIT A COOLANT LEAK DUE TO A BROKEN RADIATOR HOSE CLAMP. *TT | |
| Bulletin Number: 15597 | |
| CONCERNS WITH MALFUNCTION INDICATOR LAMP ILLUMINATED WITH P0171 - P0174 OR P0172 - P0175 CODES WITH REDUCED PERFORMANCE AND POOR FUEL ECONOMY. *TT | |
| Bulletin Number: 15621 | |
| SOME VEHICLES WITH THE REAR SEAT ENTERTAINMENT SYSTEM MAY EXHIBIT AN INOPERATIVE CONDITION. *TT | |
| Bulletin Number: 15686 | |
| CONCERNS OF DIAGNOSTIC TROUBLE CODE P1280 RETRIVED FROMTHE POWER TRAIN CONTROL MODULE (PCM). *TT | |
| Bulletin Number: 15761 | |
| SOME DEDICATED CNG VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS OF HARD START / NO START / ROUGH RUNNING. *TT | |
| Bulletin Number: 16040 | |
| EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT | |
| Bulletin Number: 16041 | |
| SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ON WITH EITHER P0171 - P0174 OR P0172 - P0175 CODES WITH REDUCED PERFORMANCE AND POOR FUEL ECONOMY. *TT | |
| Bulletin Number: 16087 | |
| SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES P0740, P0741, P0743, AND P1744 (TORQUE CONVERTER CLUTCH). *TT | |
| Bulletin Number: 16170 | |
| SOME VEHICLES EQUIPPED WITH A 4R100 TRANSMISSION AND BUILT BETWEEN JANUARY 1, 2001 AND MAY 1, 2002 MAY EXHIBIT FLASHING TRANSMISSION CONTROL INDICATOR LAMP AND ANY OR ALL TORQUE CONVERTER CLUTCH DIAGNOSTIC TROUBLE CODES P0740, P0741, P0743, | |
| Bulletin Number: 16309 | |
| HIGH SIDE PRESSURE FLUCTUATIONS ON VEHICLES EQUIPPED WITH A FIXED SCROLL A/C COMPRESSOR. *TT | |
| Bulletin Number: 16403 | |
| ENGINE-LIGHT TICK OR RATTLE TYPE NOISE FROM ENGINE AFTER COLD START. *MJ | |
| Bulletin Number: 16407 | |
| WATER PUMP PULLEY BOLTS LOOSE. *MJ | |
| Bulletin Number: 16515 | |
| OIL LEAK AT HIGH PRESSURE PUMP FITTINGS AND/OR PLUG. THIS INCLUDES SUPER DUTY F-SERIES. OASIS. *TT | |
| Bulletin Number: 16589 | |
| GRADUAL LOSS OF POWER AT CRUISE. FORD SPECIAL SERVICE MESSAGE. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT | |
| Bulletin Number: 16776 | |
| SERVICING MULTIFUNCTION SWITCH WIRING INTERFERENCE. *TT | |
| Bulletin Number: 16818 | |
| THROTTLE CONTROL SPLASH SHIELD INSTALLATION REQUIREMENTS. *TT | |
| Bulletin Number: 16916 | |
| REPEATED BLOWN FUSES FOR REAR IN VEHICLE CIRCUITS WITH INOPERATIVE REAR BRAKE OR TAIL LAMPS. *TT | |
| Bulletin Number: 17023 | |
| NO TURBINE SHAFT SPEED (TSS) DISPLAYED USING NGS OR WDS. *TT | |
| Bulletin Number: 17079 | |
| WATER PUMP PULLEY BOLTS LOOSENING. *TT | |
| Bulletin Number: 17254 | |
| CLICKING/POPPING NOISE FROM UPPER STEERING COLUMN AREA WHEN TURNING. 2004 E SERIES AND EXPLORER SPORT TRAC ALSO INCLUDED. *TT | |
| Bulletin Number: 17259 | |
| ROUGH IDLE AND/OR MISFIRE WITH DIAGNOSTIC TROUBLE CODE P0316 AFTER AN OVERNIGHT SOAK IN EXTREME COLD AND HIGH HUMIDITY CONDITIONS. *TT | |
| Bulletin Number: 17320 | |
| BROKEN EXHAUST MANIFOLD STUDS. *TT | |
| Bulletin Number: 17385 | |
| AIR BAG LAMP ILLUMINATED. *TT | |
| Bulletin Number: 17520 | |
| CLUNK FROM FRONT SUSPENSION. *TT | |
| Bulletin Number: 17777 | |
| REAR LEAF SPRING NOISE. *TT | |
| Bulletin Number: 17905 | |
| MULTIPLE VEHICLES USING FEHP REAR AXLE FLUID. FLUID USAGE CHANGE. *TT | |
| Bulletin Number: 18376 | |
| A COLD WEATHER REVERSE ENGAGEMENT STALL. *TT | |
| Bulletin Number: 19015 | |
| FUEL CONDITIONER. LOW POWER, POOR FUEL ECONOMY, FUEL GELLING IN COLD WEATHER, EXCESSIVE WHITE SMOKE ON COLD START, HARD START, OR COKING OF COMPONENTS EXPOSED TO EXHAUST. *TT | |
| Bulletin Number: 870197 | |
| INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT | |
| Bulletin Number: TSB-11-11-21 | |
| FORD: THE BLOWER MOTOR ON SOME VEHICLES ARE OPERATING EITHER INCORRECTLY OR NOT OPERATING OR JUST FUNCTIONING ON ONE SPEED. *PE | |
| 2002 FORD E-SERIES | |
| Bulletin Number: 07212 | |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE | |
| Bulletin Number: TSB-11-11-21 | |
| FORD: THE BLOWER MOTOR ON SOME VEHICLES ARE OPERATING EITHER INCORRECTLY OR NOT OPERATING OR JUST FUNCTIONING ON ONE SPEED. *PE | |
| 2002 FORD EXCURSION | |
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01157 | |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| Bulletin Number: 01167 | |
| INFORMATION REGARDING COOLING SYSTEM, MOTORCRAFT PREMIUM GOLD ENGINE COOLANT, ONLY FOR VEHICLES PRODUCED AT KENTUCKY TRUCK PLANT. *SLC | |
| Bulletin Number: 01181 | |
| BRAKE SHIFT INTERLOCK.*JB | |
| Bulletin Number: 01185 | |
| SUBJECT REGARDING ENGINE COOLING SYSTEM.*JB | |
| Bulletin Number: 01205 | |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT | |
| Bulletin Number: 012113 | |
| SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 0214 | |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| Bulletin Number: 02176 | |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| Bulletin Number: 02194 | |
| DRIVEABILITY-NO START/REPEAT STARTER FAILURE-REPEAT STARTER REPLACEMENT. ELECTRICAL-STICKING OR BINDING IGNITION LOCK CYLINDER BETWEEN START AND RUN. ENGINE-STARTING-STARTER STAYING ENGAGED AT START UP. *MJ | |
| Bulletin Number: 02208 | |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH | |
| Bulletin Number: 02219 | |
| ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS - SERVICE TIPS. *TT | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 02E20 | |
| SUBJECT REGARDING DEMONSTRATION/ DELIVERY HOLD: POWERTRAIN CONTROL MODULE REPROGRAMMING. *JG | |
| Bulletin Number: 03112 | |
| ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT. INCLUDING 2003 AND 2004 SUPER DUTY F SERIES. *TT | |
| Bulletin Number: 031404 | |
| ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. | |
| Bulletin Number: 031410 | |
| TURBO PEDESTAL SEAL OIL LEAK AROUND THE EXHAUST BACK PRESSURE (EBP) ACTUATOR. 2003 SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 03143 | |
| FRONT HUBS WILL NOT ENGAGE OR DISENGAGE PROPERLY. *TT | |
| Bulletin Number: 03144 | |
| ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 03148 | |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 03192 | |
| LEAK OIL AROUND THE EXHAUST BACKPRESSURE ACTUATOR (EBP) - 7.3L DIESEL TURBOCHARGER PEDESTALS. *TT | |
| Bulletin Number: 03203 | |
| MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT | |
| Bulletin Number: 03205 | |
| NO START/REPEAT STARTER FAILURE OR A STICKING/BINDING IGNITION LOCK CYLINDER, STARTER STAYING ENGAGED AT START UP. ALSO INCLUDES 2003 SUPER DUTY F SERIES. *TT | |
| Bulletin Number: 032145 | |
| EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT | |
| Bulletin Number: 032146 | |
| ENGINE OIL PAN CORROSION ON VEHICLES EQUIPPED WITH THE 7.3L DIESEL ENGINE. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT | |
| Bulletin Number: 032148 | |
| SOME 7.3L DIT VEHICLES MAY EXHIBIT THE OCCURRENCE OF P0340 CAMSHAFT POSITION SENSOR FALSE DIAGNOSTIC TROUBLE CODE (DTC). OTHERS MAY EXHIBIT A LATE 4R100 3-4 SHIFT (HANGING IN 3RD GEAR) AT LIGHT THROTTLE DUE TO POTENTIAL LACK OF CONVERTER L | |
| Bulletin Number: 032150 | |
| HIGH PRESSURE OIL PUMP LEAK ON VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE. *TT | |
| Bulletin Number: 032151 | |
| SOME 7.3L DIESEL TURBOCHARGER PEDESTALS MAY LEAK OIL AROUND THE EXHAUST BACK PRESSURE ACTUATOR (EBP). *TT THIS ARTICLE SUPERSEDES TSB 03-21-51 DATED 10/30/2003. *TT | |
| Bulletin Number: 0345 | |
| (WAIT TO START) LAMP DOES NOT OPERATE PROPERLY ON 2002-2003 MODELS. *TT *JB | |
| Bulletin Number: 03911 | |
| ROUGH IDLE AND/OR HESITATION WHEN ACCLERATING ON CERTAIN SUPER DUTY VEHICLES EQUIPPED WITH A 5.4L OR 6.8L ENGINE. *TT | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 03B03 | |
| ADJUSTABLE ACCELERATOR PEDAL SENSOR REPLACEMENT FOR VEHICLES EXHIBITING A PROBLEM WITH THE ADJUSTABLE ACCELERATOR PEDAL AND A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0221 OR P0122. *TT SUPPLEMENT #1. *T | |
| Bulletin Number: 04116 | |
| FRONT HUBS NOT ENGAGING, NOT STAYING ENGAGED AND/OR UNLOCKING. *TT | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 041601 | |
| WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT | |
| Bulletin Number: 04168 | |
| VACUM PUMP INOPERATIVE OR RUNS CONTINUOSLY - CLIMATE CONTROL DEFAULT TO DEFROST. *AR | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04185 | |
| FRONT HUBS NOT ENGAGING, NOT STAYING ENGAGED AND/OR UNLOCKING. *TT | |
| Bulletin Number: 04189 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 04228 | |
| HARD START OR NO START. *EH | |
| Bulletin Number: 042411 | |
| MEMONTARY RETURN TO IDLE DURING AGGRESSIVE ACCELERATION - DIAGNOSTIC TROUBLE CODE (DTC) P0123. *TT | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 04262 | |
| FALSE PARKING AID WARNINGS. *TT UPDATE. *TT | |
| Bulletin Number: 0471 | |
| WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT | |
| Bulletin Number: 05174 | |
| VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST MODE. *TT | |
| Bulletin Number: 05188 | |
| SERVICE KIT AVAILABLE FOR WIPER MOTOR WIRING. *TT | |
| Bulletin Number: 05417 | |
| INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT | |
| Bulletin Number: 05419 | |
| FALSE PARKING AID WARNINGS. *TT | |
| Bulletin Number: 071110 | |
| BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ | |
| Bulletin Number: 07212 | |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE | |
| Bulletin Number: 14 | |
| FIRESTONE TIRE SAFETY CAMPAIGN. FIRESTONE STEELTEX RADIAL A/T LT265/75R16 LR D OWL AND BSW TIRES. TIRE INSPECTION AND REPLACEMENT. *MR | |
| Bulletin Number: 15133 | |
| SOME VEHICLES MAY EXHIBIT A DIFFICULT TO DIAGNOSE CONDITION WITH THE REAR SEAT ENTERTAINMENT CONDITION. *SLC | |
| Bulletin Number: 15173 | |
| SOME VEHICLES EQUIPPED WITH A 7.3L POWERSTROKE MAY EXHIBIT SOME AND/OR ALL OF THE FOLLOWING DIAGNOSTIC TROUBLE CODES, P0230,P0640,P0670,P1662,P1690. *YH | |
| Bulletin Number: 15199 | |
| SOME VEHICLES MAY EXHIBIT A CONDITION WHERE THE TRANSMISISON TEMPERATURE GAUGE READS IN THE MIDDLE AT START UP. *YD | |
| Bulletin Number: 15297 | |
| SOME VEHICLES MAY EXHIBIT AN INOPERATIVE SIDE POWER MIRROR CONDITION. *TT | |
| Bulletin Number: 15328 | |
| CONCERNS WITH RATTLE NOISE ORIGINATING FROM THE FRONT BRAKE CALIPERS. *TT | |
| Bulletin Number: 15334 | |
| SOME VEHICLES MAY EXHIBIT A POPPING NOISE BENEATH THE DRIVER'S FEET AREA COMING FROM THE FLOORBOARD. *TT | |
| Bulletin Number: 15355 | |
| SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT | |
| Bulletin Number: 15374 | |
| SOME VEHICLES MAY EXHIBIT VARIOUS ELECTRICAL CONDITIONS SUCH AS DOOR AJAR LIGHT ILLUMINATED WHILE ENGINE IS RUNNING AND DOORS ARE CLOSED, 4X4 INDICATOR INOPERATIVE, RADIO STAYING ON WITH ENGINE OFF, AND THE SPEEDOMETER SCALING SYMBOL ILLUMI | |
| Bulletin Number: 15379 | |
| SOME VEHICLES BUILT PRIOR TO 10/11/01 MAY EXHIBIT SCRATCHES AT THE TOP OF THE CARGO DOORS. *TT | |
| Bulletin Number: 15397 | |
| SOME VEHICLES MAY EXHIBIT A CONDITION OF OIL CONTAMINATION IN COOLING SYSTEM. *TT | |
| Bulletin Number: 15398 | |
| SOME VEHICLES MAY EXHIBIT A COOLANT LEAK DUE TO A BROKEN RADIATOR HOSE CLAMP. *TT | |
| Bulletin Number: 15429 | |
| SOME VEHICLES WITH 7.3L DIT ENGINES, MAY EXHIBIT AN INVALID AUXILIARY POWERTRAIN CONTROL MODULE DISPLAY READOUT OF 4100 RPM OR ABOVE. *TT | |
| Bulletin Number: 15446 | |
| SOME VEHICLES MAY EXHIBIT INCREASED STEERING EFFORTS AT VERY LOW SPEEDS OR WHEN STOPPED WITH THE BRAKES APPLIED. *TT | |
| Bulletin Number: 15448 | |
| EXHIBITING A SLIGHT BRAKE PULL TO THE RIGHT ON INITIAL BRAKE APPLICATION AND THEN A SLIGHT BRAKE PULL TO THE LEFT UPON RELEASE OF THE BRAKE PEDAL. *TT | |
| Bulletin Number: 15525 | |
| INFORMATION REGARDING A RATTLE NOISE ORIGINATING FROM THE FRONT BRAKE CALIPER.*YD | |
| Bulletin Number: 15533 | |
| SUBJECT REGARDIDNG SQUEAK AND RATTLE CONDITION. *YD | |
| Bulletin Number: 15566 | |
| SOME VEHICLES MAY EXHIBIT A TACKY SURFACE ON THE INSTRUMENT PANEL (IP). *TT | |
| Bulletin Number: 15574 | |
| SOME VEHICLES MAY EXHIBIT A DIFFICULTY IN PROGRAMMING THE KEY FOB(S). *TT | |
| Bulletin Number: 15578 | |
| SOME VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) LIGHT ON, B2141/B2477, AND/OR AN INACCURATE SPEEDOMETER. *TT | |
| Bulletin Number: 15579 | |
| SOME VEHICLES MAY EXHIBIT CALIPER PIN RATTLE NOISE ORIGINATING FROM THE FRONT BRAKE CALIPERS. *TT | |
| Bulletin Number: 15581 | |
| SOME VEHICLES MAY EXHIBIT AN INOPERATIVE CHARGING SYSTEM AND/OR A NO START CONDITION. *TT | |
| Bulletin Number: 15593 | |
| SOME VEHICLES BUILT BETWEEN 11/29/01 AND 11/30/01 MAY EXHIBIT A SERPENTINE BELT SQUEAL. *TT | |
| Bulletin Number: 15594 | |
| SUPER DUTY ERRATIC COOLANT TEMPERATURE GAUGE READINGS - CONCERNS. *TT | |
| Bulletin Number: 15661 | |
| CONCERNS WITH RATTLE NOISES COMING FROM FRONT BRAKE CALIPERS. *TT | |
| Bulletin Number: 15678 | |
| COOLANT LEAK DUE TO A BROKEN LOWER RADIATOR HOSE CLAMP. *TT | |
| Bulletin Number: 15686 | |
| CONCERNS OF DIAGNOSTIC TROUBLE CODE P1280 RETRIVED FROMTHE POWER TRAIN CONTROL MODULE (PCM). *TT | |
| Bulletin Number: 15694 | |
| INFORMATION ON INOPERATIVE CHARGING SYSTEM AND / OR NO CRANK CONDITION. *TT | |
| Bulletin Number: 15757 | |
| SUBJECT REGARDING VEHICLES EXHIBITING COLD START ROLLING IDLE. *TT | |
| Bulletin Number: 15764 | |
| CONCERNS WITH EXCESSIVE BATTERY DRAW. *TT | |
| Bulletin Number: 15798 | |
| SOME VEHICLES EQUIPPED WITH A 7.3L DI, 4R100 TRANSMISSION AND BUILT BEFORE DECEMBER 10, 2001 MAY REMAIN IN 2ND GEAR WITH THE GEAR SHIFT LEVER IN THE FIRST GEAR POSITION. *TT | |
| Bulletin Number: 15810 | |
| SOME VEHICLES MAY EXHIBIT INOPERATIVE POWER MIRRORS. *TT | |
| Bulletin Number: 15843 | |
| SOME VEHICLES MAY EXHIBIT STEERING WHEEL CLEAR VIEW CONDITION. *TT | |
| Bulletin Number: 15871 | |
| SOME VEHICLES MAY EXHIBIT INTERFERENCE AND / OR STATIC IN THE LAND-MOBILE RADIO. *TT | |
| Bulletin Number: 15882 | |
| SUBJECT REGARDING ROOF RACK SCRATCHES PAINT ON ROOF PANEL. *TT | |
| Bulletin Number: 15883 | |
| SOME VEHICLES EQUIPPED WITH THE DVD FAMILY ENTERTAINMENT SYSTEM MAY EXHIBIT AN INOPERATIVE DVD SYSTEM. *TT | |
| Bulletin Number: 15888 | |
| SOME VEHICLES MAY EXHIBIT A FEAD BELT SQUEAL. *TT | |
| Bulletin Number: 15891 | |
| SUBJECT REGARDING REAR BRAKE BLEED SCREW LOCATION ON 1999 - 2002 MODELS. *TT | |
| Bulletin Number: 15902 | |
| SOME VEHICLES MAY EXHIBIT LACK OF POWER STEERING ASSIST. *TT | |
| Bulletin Number: 15938 | |
| INFORMATION USED WHEN REPLACING THE DRIVERS SEAT MODULE. *TT | |
| Bulletin Number: 16136 | |
| SOME VEHICLES MAY EXHIBIT A REPEAT STARTER FAILURE CONDITION. *TT | |
| Bulletin Number: 16170 | |
| SOME VEHICLES EQUIPPED WITH A 4R100 TRANSMISSION AND BUILT BETWEEN JANUARY 1, 2001 AND MAY 1, 2002 MAY EXHIBIT FLASHING TRANSMISSION CONTROL INDICATOR LAMP AND ANY OR ALL TORQUE CONVERTER CLUTCH DIAGNOSTIC TROUBLE CODES P0740, P0741, P0743, | |
| Bulletin Number: 16187 | |
| ROOF PAINT SCRATCHING FROM LUGGAGE RACK CROSSBARS. *MJ | |
| Bulletin Number: 16258 | |
| VEHICLES EQUIPPED WITH A 7.3L ENGINE (AFTER SERIAL NUMBER 0661894) - UNDER VALVE COVER (UVC) HARNESS RETAINER CLIP RELEASED FOR SERVICE. INCLUDES 2003 ECONOLINE, SUPER DUTY, F650/750 AND EXCURSION. *TT | |
| Bulletin Number: 16291 | |
| LOUD SQUEALING NOISE FROM THE ENGINE AREA WHEN THE ENGINE FAN CLUTCH IS UNDER LOAD WHILE OPERATED IN HOT DUSTY CLIMATES. VEHICLES EQUIPPED WITH A 7.3L ENGINE. *TT | |
| Bulletin Number: 16403 | |
| ENGINE-LIGHT TICK OR RATTLE TYPE NOISE FROM ENGINE AFTER COLD START. *MJ | |
| Bulletin Number: 16480 | |
| DIAGNOSTIC TROUBLE CODE (DTC) P0340, POSSIBLE FALSE CODE. VARIOUS MODELS INCLUDING 1994-1996 FORD EXCURSION. *TT | |
| Bulletin Number: 16515 | |
| OIL LEAK AT HIGH PRESSURE PUMP FITTINGS AND/OR PLUG. THIS INCLUDES SUPER DUTY F-SERIES. OASIS. *TT | |
| Bulletin Number: 16589 | |
| GRADUAL LOSS OF POWER AT CRUISE. FORD SPECIAL SERVICE MESSAGE. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT | |
| Bulletin Number: 16589 | |
| GRADUAL LOSS OF POWER AT CRUISE. USE FUEL ADDITIVE TO PREVENT HIS CONDITION. ALL SUPER DUTY F-SERIES 1999-2003 INCLUDED. OASIS *TT | |
| Bulletin Number: 16597 | |
| COOLANT LEAK DUE TO A BROKEN LOWER RADIATOR HOSE CLAMP. *TT | |
| Bulletin Number: 16662 | |
| LACK OF POWER, SMOKE, OR OIL LEAKS AROUND THE CHARGE AIR COOLER (CAC). 1999-2003 SUPER DUTY/EXCURSION VEHICLES EQUIPPED WITH 7.3 OR 6.0 FORD NAVISTAR DIESEL ENGINE. *TT | |
| Bulletin Number: 16697 | |
| EXHAUST AIR RUSH NOISE AND LOWER POWER. *TT *JB | |
| Bulletin Number: 16859 | |
| SOME VEHICLES BUILT AFTER 12/7/1998 EQUIPPED WITH A 7.3L DIT ENGINE MAY EXHIBIT A HOOT OR HOWLING NOISE FROM THE TURBOCHARGER. 2003 SUPER DUTY F SERIES ALSO INCLUDED. *TT | |
| Bulletin Number: 16921 | |
| COOLANT LEAK DUE TO BROKEN RADIATOR HOSE CLAMP. 1999-2003 MODELS. *TT | |
| Bulletin Number: 16924 | |
| SLIGHT PURGE OF GREASE FROM THE HUB BEARING UNIT. THIS GREASE MAY BE NOTED BETWEEN THE HUB UNIT AND THE INBOARD ROTOR FLANGE AND ON THE INBOARD SIDE OF THE BEARING. 1999-2003 MODELS. *TT | |
| Bulletin Number: 16925 | |
| NO ENGAGEMENT OR DISENGAGEMENT OF HUB LOCKS AFTER REPLACEMENT OR SERVICE. TO INCLUDE 2000-2003 EXCURSIONS. *TT | |
| Bulletin Number: 17316 | |
| FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP. *TT | |
| Bulletin Number: 17406 | |
| LOW POWER, POOR FUEL ECONOMY, FUEL GELLING COLD, EXCESSIVE WHITE SMOKE COLD, OR HARD START. *MJ THIS OASIS UPDATES PREVIOUS OASIS DATED 12/01/03. *TT | |
| Bulletin Number: 17467 | |
| ENGINE OR FUEL SYSTEM CONCERNS WHEN USING FUEL WITH GREATER THAN 5% BIODIESEL CONCENTRATION. *TT | |
| Bulletin Number: 17554 | |
| OIL/DUST FILM AT CAC CONNECTIONS. *MJ | |
| Bulletin Number: 17571 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT | |
| Bulletin Number: 17594 | |
| DIAGNOSTIC TROUBLE CODE (DTC) U1262 (SCP COMMUNICATION BUS FAULT) STORED IN THE INSTRUMENT CLUSTER (IC). *TT | |
| Bulletin Number: 17603 | |
| AIR BAG LIGHT ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B1871 OR B1935 FOLLOWING ECS/RCM REPLACEMENT. *TT | |
| Bulletin Number: 17784 | |
| DOOR AJAR LIGHT WORKING IMPROPERLY AFTER VEHICLE SECURITY MODULE REPLACEMENT. *TT | |
| Bulletin Number: 17829 | |
| TRANSFER CASE SHIFT ISSUES ON VEHICLES WITH AN ELECTRONIC SHIFT ON THE FLY (ESOF) TRANSFER CASE. *TT | |
| Bulletin Number: 18217 | |
| MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT | |
| Bulletin Number: 18223 | |
| VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST. OASIS. TO ALSO INCLUDE 2005 SUPER DUTY F-SERIES, EXCURSION, AND F650/750. *TT | |
| Bulletin Number: 18376 | |
| A COLD WEATHER REVERSE ENGAGEMENT STALL. *TT | |
| Bulletin Number: 19015 | |
| FUEL CONDITIONER. LOW POWER, POOR FUEL ECONOMY, FUEL GELLING IN COLD WEATHER, EXCESSIVE WHITE SMOKE ON COLD START, HARD START, OR COKING OF COMPONENTS EXPOSED TO EXHAUST. *TT | |
| Bulletin Number: CSP-48B01 | |
| FORD: VEHICLES MISTAKENLY CHARGED $100 POWERTRAIN WARRANTY DEDUCTIBLE FOR FUEL INJECTOR REPAIR OR REPAIRS. NO MODEL OR MODEL YEARS PROVIDED. *PE ECONOLINE, EXCURSION AND F-SERIES SUPER DUTY VEHICLES, MODEL YEARS 2002-2005. UPDATED | |
| Bulletin Number: DOR-B8H4Z-11 | |
| This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly ma | |
| 2002 FORD EXPEDITION | |
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01157 | |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| Bulletin Number: 01181 | |
| BRAKE SHIFT INTERLOCK.*JB | |
| Bulletin Number: 01205 | |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT | |
| Bulletin Number: 012113 | |
| SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL | |
| Bulletin Number: 01215 | |
| A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTER OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 02108 | |
| SOME VEHICLES EQUIPPED WITH THE 5.4L 2V ENGINE MAY EXHIBIT A WHISTLING NOISE FROMTHE FORMED NYLON TUBE INTHE IDLE-AIR BYPASS FLOW CIRCUIT. *TT | |
| Bulletin Number: 0212 | |
| SOME VEHICLES MAY EXHIBIT A WEAK HORN CHIRP CONFIRMATION WHEN THE KEY FOB IS USED, OR AN INOPERATIVE HORN WHEN THE ENGINE IS NOT RUNNING. *TT | |
| Bulletin Number: 02121 | |
| WHITE FLAKES COMING FROM THE AIR CONDITIONER VENTS WHEN THE BLOWER MOTOR IS ENGAGED. *TT | |
| Bulletin Number: 0214 | |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| Bulletin Number: 02176 | |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| Bulletin Number: 02193 | |
| DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ | |
| Bulletin Number: 02208 | |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH | |
| Bulletin Number: 02227 | |
| ENGINE-CYLINDER HEAD DECK LEAK-4.6 AND 5.4L ENGINES-NEW SERVICE-ONLY GASKET AND CYLINDER HEAD KITS AVAILABILITY. *MJ | |
| Bulletin Number: 0241 | |
| SUBJECT REGARDING IDLER ARM REPLACEMENT SPECIFICATIONS. *TT | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 0258 | |
| INOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639. *TT | |
| Bulletin Number: 02M01 | |
| CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6 | |
| Bulletin Number: 030709 | |
| REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES. *TT | |
| Bulletin Number: 031404 | |
| ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. | |
| Bulletin Number: 03144 | |
| ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 03148 | |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 031513 | |
| TIE ROD END INSPECTION PROCEDURE. *TT | |
| Bulletin Number: 03164 | |
| SOME VEHICLES, EQUIPPED WITH THE 4.6L 2V ENGINE, WITH AN ENGINE BUILD DATE PRIOR TO 8/29/03 MAY EXHIBIT AN ENGINE TICK NOISE THAT IS PRESENT AT ALL TEMPERATURES DURING IDLE. 2004 MODELS INCLUDED. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 0322 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT | |
| Bulletin Number: 03223 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| Bulletin Number: 03256 | |
| ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003. *MJ | |
| Bulletin Number: 0361 | |
| MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB | |
| Bulletin Number: 03610 | |
| TIE ROD END INSPECTION PROCEDURE. CANADA VEHICLES ONLY. *TT *JB | |
| Bulletin Number: 0392 | |
| REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES. *TT | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 0399 | |
| TIE ROD END INSPECTION PROCEDURE. *TT | |
| Bulletin Number: 04111 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 041601 | |
| WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04189 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 04251 | |
| ALUMINUM CORROSION - SERVICE TIP. *TT | |
| Bulletin Number: 04262 | |
| FALSE PARKING AID WARNINGS. *TT UPDATE. *TT | |
| Bulletin Number: 0454 | |
| AIR SUSPENSION COMPRESSOR NOISE. *TT | |
| Bulletin Number: 0457 | |
| POP/THUMP NOISE AT END OF WINDOW MOVEMENT AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION. *TT | |
| Bulletin Number: 0471 | |
| WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT | |
| Bulletin Number: 04L19 | |
| CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE. *TT | |
| Bulletin Number: 050618 | |
| REAR AXLE NOISE REPAIR. *SC | |
| Bulletin Number: 05417 | |
| INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT | |
| Bulletin Number: 05419 | |
| FALSE PARKING AID WARNINGS. *TT | |
| Bulletin Number: 0554 | |
| USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE. *TT | |
| Bulletin Number: 05618 | |
| REAR AXLE NOISE REPAIR. *TT | |
| Bulletin Number: 07212 | |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE | |
| Bulletin Number: 15094 | |
| INFORMATION REGARDING INTAKE MANIFOLD VALLEY STUFFERS. *TT | |
| Bulletin Number: 15122 | |
| SOME VEHICLES MAY EXHIBIT A VIBRATION AT IDLE AND/OR ENGINE DROANING NOISE ON ACCELERATION FROM A STOP. *SLC | |
| Bulletin Number: 15123 | |
| SOME VEHICLES MAY EXHIBIT A DRIVELINE VIBRATION AT SPEEDS BETWEEN 60-70 MPH. *SLC | |
| Bulletin Number: 15137 | |
| CUSTOMERS MAY COMPLAIN OF WIND NOISE. *YD | |
| Bulletin Number: 15259 | |
| CONCERNS WITH THE LOWER POWER IN HIGH AMBIENT TEMEPRATURES. *TT | |
| Bulletin Number: 15326 | |
| SOME VEHICLES MAY EXHIBIT A POP/CLUNK/CLICK NOISE FROM THE FRONT SUSPENSION WHEN MAKING LOW SPEED TURNS IN EITHER FORWARD OR REVERSE. *TT | |
| Bulletin Number: 15377 | |
| SOME VEHICLES MAY EXHIBIT AN AXLE TUBE SEAL LEAKAGE AND AN AXLE BEARING THAT IS LOOSE IN THE AXLE HOUSING, AND/OR A REPLACEMENT SERVICE BEARING THAT IS LOOSE IN THE HOUSING. *TT | |
| Bulletin Number: 15395 | |
| SOME VEHICLES MAY EXHIBIT A WEAK HORN CHIRP CONFIRMATION WHEN THE TRANSMITTER IS USED TO LOCK THE DOORS AND/OR AN INOPERATIVE HORN WHEN THE VEHICLE'S ENGINE IS NOT RUNNING. *TT | |
| Bulletin Number: 15407 | |
| CONCERNS WITH A POP/CLUNK/CLICK NOISE COMING FROM THE FRONT SUSPENSION WHEN MAKING LOW-SPEED TURNS IN FORWARD OR REVERSE GEARS. *TT | |
| Bulletin Number: 15431 | |
| EXHIBITING LACK OF POWER CONDITION WHEN VEHICLE IS OPERATED IN AMBIENT TEMPERATURES. *TT | |
| Bulletin Number: 15432 | |
| SOME VEHICLES NOT EQUIPPED WITH SIDE AIR BAGS MAY EXHIBIT DIAGNOSTIC TROUBLE CODE B1998 (PASSENGER SIDE AIR BAG CIRCUIT RESISTANCE HIGH) IN THE RESTRAINTS CONTROL MODULE. *TT | |
| Bulletin Number: 15433 | |
| SOME VEHICLES BUILT AFTER 4/10/2001 AND EQUIPPED WITH AIR SUSPENSION , MAY EXHIBIT AN ELECTRONIC VARIABLE ORIFICE (EVO) STEERING DIAGNOSTIC TROUBLE CODE C1917. *TT | |
| Bulletin Number: 15480 | |
| SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION AND/OR PREMATURE SHUTOFF OF THE GAS PUMP WHEN THE VEHICLE IS BEING RE-FUELED. *TT | |
| Bulletin Number: 15502 | |
| CONCERNS WITH POP/CLUNK/CLICK NOISE FROM THE FRONT SUSPENSION WHEN MAKING LOW-SPEED TURNS IN FORWARD OR REVERSE GEARS. *TT | |
| Bulletin Number: 15504 | |
| SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT | |
| Bulletin Number: 15517 | |
| SUBJECT REGARDING EXAGGERATED ENGINE BRAKING ON DECELERATION. *YD | |
| Bulletin Number: 15528 | |
| SUBJECT REGARDING AIR SUSPENSION COMPRESSOR QUALITY. *YD | |
| Bulletin Number: 15549 | |
| INFORMATION REGARDING POP/THUMP NOISE FROM POWER WINDOW. *YH | |
| Bulletin Number: 15605 | |
| SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT | |
| Bulletin Number: 15630 | |
| CONCERNS WITH VEHICLES WITH A 5.4L 2V ENGINE EXHIBITINGNG A LACK OF POWER CONDITION. *TT | |
| Bulletin Number: 15648 | |
| SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION AND/OR PREMATURE SHUTOFF OF THE GAS PUMP WHEN THE VEHICLE IS BEING REFUELED. *TT | |
| Bulletin Number: 15651 | |
| SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN AIR LEAK AND/OR OVERNIGHT BLEED DOWN OF THE AIR SUSPENSION. *TT | |
| Bulletin Number: 15652 | |
| CONCERNS WITH CLIMATE CONTROL SYSTEM AIR DISCHARGED THROUGH THE DEFROSTER DUCTS ONLY, REGARDLESS OF SETTING. *TT | |
| Bulletin Number: 15692 | |
| SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT | |
| Bulletin Number: 15708 | |
| SOME VEHICLES MAY EXHIBIT WHEELS THAT SEIZE TO THE HUBS AND ARE DIFFICULT TO REMOVE DURING SERVICE. *TT | |
| Bulletin Number: 15727 | |
| SOME 4X2 VEHICLES EQUIPPED WITH P275/60/R17 CONTINENTAL GENERAL TIRES MAY EXHIBIT A HIGHWAY SPEED TIRE VIBRATION. *TT | |
| Bulletin Number: 15749 | |
| SOME VEHICLES EQUIPPED WITH 4 WHEEL DRIVE MAY EXHIBIT A NOTCHY OR STICKING FEELING IN SLOW SPEED TURNS WITH NO EFFECT ON STEERING EFFORTS OR ASSIST WHILE IN THE AUTOMATIC 4X4 POSITION. *TT | |
| Bulletin Number: 15794 | |
| SOME 4X2 VEHICLES EQUIPPED WITH P275/60/R17 CONTINENTAL-GENERAL TIRES MAY EXHIBIT A HIGHWAY SPEED TIRE VIBRATION. *TT | |
| Bulletin Number: 15897 | |
| SUBJECT REGARDING DRIVELINE ANGLE-RELATED VIBRATION AT VARIOUS SPEEDS AND LOAD CONDITIONS. *TT | |
| Bulletin Number: 15939 | |
| CONCERNS WITH SPEED BODY BOOM. *TT | |
| Bulletin Number: 16015 | |
| SOME VEHICLES WITH AIR SUSPENSION MAY EXHIBIT AN INITIAL OR REPEAT COMPRESSOR DRYER FAILURE. *TT | |
| Bulletin Number: 16033 | |
| SOME VEHICLES WITH ELECTRONIC SHIFT-ON-THE FLY MAY EXHIBIT AN INADVERTENT 4X4 LOW ENGAGEMENT WHILE DRIVING. *TT | |
| Bulletin Number: 16087 | |
| SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES P0740, P0741, P0743, AND P1744 (TORQUE CONVERTER CLUTCH). *TT | |
| Bulletin Number: 16170 | |
| SOME VEHICLES EQUIPPED WITH A 4R100 TRANSMISSION AND BUILT BETWEEN JANUARY 1, 2001 AND MAY 1, 2002 MAY EXHIBIT FLASHING TRANSMISSION CONTROL INDICATOR LAMP AND ANY OR ALL TORQUE CONVERTER CLUTCH DIAGNOSTIC TROUBLE CODES P0740, P0741, P0743, | |
| Bulletin Number: 16400 | |
| REAR AXLE SEAL LEAK - CONTACT REQUEST. *MJ | |
| Bulletin Number: 16403 | |
| ENGINE-LIGHT TICK OR RATTLE TYPE NOISE FROM ENGINE AFTER COLD START. *MJ | |
| Bulletin Number: 16683 | |
| FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB | |
| Bulletin Number: 16797 | |
| VEHICLES WITH KEYLESS ENTRY PAD MAY EXHIBIT DEAD BATTERY, NO START, INTERIOR LAMP/HEADLAMP SELF-ACTIVATION, OR INOPERATIVE KEYLESS ENTRY PAD. *TT | |
| Bulletin Number: 17316 | |
| FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP. *TT | |
| Bulletin Number: 17320 | |
| BROKEN EXHAUST MANIFOLD STUDS. *TT | |
| Bulletin Number: 17346 | |
| STEERING IDLER ARM NOISE. *TT | |
| Bulletin Number: 17459 | |
| COURTESY RAIL LAMPS DO NOT OPERATE CORRECTLY OR CAUSE A BATTERY DRAW. *TT | |
| Bulletin Number: 17720 | |
| AIRBAG WARNING LAMP ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B1994/B1998 ON VEHICLES WITHOUT SIDE AIR BAGS. *TT | |
| Bulletin Number: 17905 | |
| MULTIPLE VEHICLES USING FEHP REAR AXLE FLUID. FLUID USAGE CHANGE. *TT | |
| Bulletin Number: 18217 | |
| MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT | |
| Bulletin Number: 99263 | |
| CORRECT LUG NUT TORQUE SPECIFICATIONS - INCREASE WHEEL NUT AND STUD SIZE - SERVICE TIP. *TT | |
| Bulletin Number: TSB 19-2026 | |
| Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo | |
| 2002 FORD EXPLORER | |
| Bulletin Number: 002310 | |
| SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT | |
| Bulletin Number: 011002 | |
| SOME 4-DOOR VEHICLES BUILT 11/13/2000 THROUGH 4/2/2001 EQUIPPED WITH THE 5R55W TRANSMISSION MAY EXHIBIT A FLUID LEAK AT THE TRANSMISSION COOLER LINE-TO-TRANSMISSION CASE CONNECTION. THIS MAY BE CAUSED BY COMTAMINATION ON THE COOLER TUBE B | |
| Bulletin Number: 011007 | |
| SOME VEHICLES BUILT 11/13/2000 THORUGH 3/8/2001 EQUIPPED WITH A 5R55W TRANSMISSION MAY EXHIBIT A TRANSMISSION CONTROL INDICATOR LAMP (TCIL) FLASHING WITH VARIOUS DIAGNOSTIC TROUBLE CODES (DTCS) IN SELF TEST. DTC PO713 IS THE CODE THAT IS | |
| Bulletin Number: 01102 | |
| A FLUID LEAK AT THE TRANSMISSION COOLER LINE-TO-TRANSMISSION CASE CONNECTION. THIS MAY BE CAUSED BY CONTAMINATION ON THE COOLER TUBE BETWEEN THE TUBE NUT AND FLARE, CONTAMINATION ON THE TUBE NUT THREADS OR IMPROPER INSTALLATION TORQUE. V | |
| Bulletin Number: 01107 | |
| SOME VEHICLES BUILT 11/13/2000 THROUGH 3/8/2001 EQUIPPED WITH A 5R55W TRANSMISSION MAY EXHIBIT A TRANSMISSION CONTROL INDICATOR LAMP (TCIL) FLASHING WITH VARIOUS DIAGNOSTIC TROUBLE CODES (DTCS) IN SELF TEST. DTC P0713 IS THE CODE THAT IS | |
| Bulletin Number: 01111 | |
| SOME VEHICLES EQUIPPED WITH A 4.0L ENGINE AND 5R55W AUTOMATIC TRANSMISSION BUILT 11/13/2000 THROUGH 5/21/2001 MAY EXHIBIT LIGHT THROTTLE SOFT OR LONG 2-3 UPSHIFTS BETWEEN 16-40 KM/H (10-25 MPH) OR HARSH 3-4 UPSHIFTS BETWEEN 32-56 KM/H (20-3 | |
| Bulletin Number: 011110 | |
| SOME VEHICLES EQUIPPED WITH A CLASS II HITCH MAY EXHIBIT INSUFFICIENT CLEARANCE INT HE RECEIVER TO ATTACH TUBULAR HITCH ACESSORIES TO THE VEHICLE. *TT | |
| Bulletin Number: 01115 | |
| FLUID LEAK IN THE CONVERTER HOUSING AREA ON VEHICLES BUILT 11/13/2000 THROUGH 4/27/2001. *TT | |
| Bulletin Number: 01126 | |
| SOME VEHICLES EQUIPPED WITH THE MANUAL A/C SYSTEM MAY EXHIBIT A CONTINUOUS CLICKING NOISE FROM THE BLEND DOOR ACTUATOR WHENTHE BLOWER SPEED IS SET AT THE #2 POSITION AND THE TEMPERATURE CONTROL KNOB IS SET BETWEEN THE 12:00 AND 2:00 POSITIO | |
| Bulletin Number: 01132 | |
| SOME VEHICLES PRODUCED BEFORE 6/3/2001 MAY EXHIBIT THE MOONROOF OPENING INTERIOR MOLDING COMING LOOSE OR THE SUNSHADE TEARING DURING USE. *TT | |
| Bulletin Number: 01134 | |
| FUEL HESITATION WHILE MAKING HARD SWEEPING RIGHT HAND TURNS (SUCH AS A HIGHWAY ON-RAMP) | |
| Bulletin Number: 01142 | |
| SOME VEHICLES, BUILT PRIOR TO 8/01/2001, MAY EXHIBIT A WHINE OR HOWL NOISE DURING COLD STARTS AT TEMPERATURES BELOW 4 DEGREES C (40 DEGREES F). *TT | |
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01157 | |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| Bulletin Number: 01181 | |
| BRAKE SHIFT INTERLOCK.*JB | |
| Bulletin Number: 01203 | |
| EXHIBIT HARSH 1-2, 3-4 UPSHIFTS AT LIGHT TO MEDIUM THROTTLE ON SOME VEHICLES EQUIPPED WITH A 4.6L ENGINE AND 5R55W AUTOMATIC TRANSMISSION BUILT THROUGH 9/21/2001. *TT | |
| Bulletin Number: 01205 | |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT | |
| Bulletin Number: 01207 | |
| SOME VEHICLES PRODUCED BEFORE 9/6/2001 EQUIPPED WITH THE 5R55W TRANSMISSION MAY EXHIBIT A TICK NOISE EMANATING FROM THE FRONT OR INTERMEDIATE SERVO COVER. *TT | |
| Bulletin Number: 01223 | |
| SOME VEHICLES BUILT PRIOR TO 11/11/2001 EQUIPPED WITH 5R55W TRANSMISSION AND 4.6L ENGINE, MAY EXHIBIT A BUZZING NOISE WHEN THE TORQUE CONVERTER IS ENGAGED. *TT | |
| Bulletin Number: 01245 | |
| SOME VEHICLES EQUIPPED WITH THE 4.0L ENGINE MAY EXHIBIT A CONDITION OF UNABLE TO ACCESS WITH THE SECURILOCK PASSIVE ANTI-THEFT SYSTEM (PATS). *TT | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 0162 | |
| VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT | |
| Bulletin Number: 0186 | |
| ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT | |
| Bulletin Number: 01B77 | |
| OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT | |
| Bulletin Number: 01T02 | |
| LIFTGATE GLASS BRACKET INSPECTION AND TORQUE PROCEDURE. *MR | |
| Bulletin Number: 01T02 | |
| SPECIAL SERVICE INSTRUCTIONS FOR THE LIFTGATE GLASS BRACKET INSPECTION AND TORQUE PROCEDURE. *TT | |
| Bulletin Number: 020801 | |
| RATTLE NOISE FROM PRIMARY CHAIN DRIVE AREA 2000-3000 RPM - 4.0L SOHC ENGINE. *TT | |
| Bulletin Number: 0214 | |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| Bulletin Number: 02171 | |
| PAINT-PREMATURE CLEARCOAT CRACKING-SERVICE TIPS. *MJ | |
| Bulletin Number: 021710 | |
| ELECTRICAL-CENTRAL SECURITY MODULE (CSM) SERVICE TIPS. *MJ | |
| Bulletin Number: 02176 | |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| Bulletin Number: 02216 | |
| EXCESSIVE SULFUR SMELL FROM EXHAUST. *EH | |
| Bulletin Number: 0222 | |
| SOME VEHICLES MAY EXHIBIT AN INTAKE MANIFOLD CROSSOVER (FIRST RUNNER) COOLANT SEEPAGE CONDITION. *TT | |
| Bulletin Number: 0232 | |
| SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301. *TT | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 0258 | |
| INOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639. *TT | |
| Bulletin Number: 0262 | |
| SUBJECT REGARDING 5R55W AUTOMATIC TRANSMISSION HARSH UPSHIFTS DURING LIGHT TO MEDIUM THROTTLE CONCERNS. *TT | |
| Bulletin Number: 0276 | |
| INFORMATION ON DIAGNOSING ENGINE RATTLE NOISE FROM PRIMARY CHAIN DRIVE AREA BETWEEN 2000-3000 RPM ON COLD ENGINE OPERATION ONLY. *TT | |
| Bulletin Number: 0281 | |
| SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC (SINGLE OVER-HEAD CAM) ENGINE MAY EXHIBIT A PRIMARY TIMING CHAIN RATTLE NOISE. *TT | |
| Bulletin Number: 02M01 | |
| CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6 | |
| Bulletin Number: 03106 | |
| THROTTLE CABLE ROUTING AND SPLASH SHIELD MODIFICATION WHEN REPLACING THROTTLE CABLE DURING NORMAL SERVICE. *TT | |
| Bulletin Number: 03126 | |
| LIFTGATE GLASS APPLIQUE DAMAGED/CRACKED - SERVICE PROCEDURE. *TT | |
| Bulletin Number: 03136 | |
| NO CRANK CONDITION. SERVICE TIPS. *TT | |
| Bulletin Number: 031404 | |
| ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. | |
| Bulletin Number: 03144 | |
| ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 03147 | |
| SHUDDER DURING 4/5 UPSHIFT AND/OR 5/4 DOWNSHIFT ON VEHICLES EQUIPPED WITH A 4.6L ENGINE AND 5R55W AUTOMATIC TRANSMISSION. *TT | |
| Bulletin Number: 03148 | |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 03164 | |
| SOME VEHICLES, EQUIPPED WITH THE 4.6L 2V ENGINE, WITH AN ENGINE BUILD DATE PRIOR TO 8/29/03 MAY EXHIBIT AN ENGINE TICK NOISE THAT IS PRESENT AT ALL TEMPERATURES DURING IDLE. 2004 MODELS INCLUDED. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 03198 | |
| CHATTER, SHUDDER, A BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNS ON VEHICLES EQUIPPED WITH THE 9.75 INCH OR 8.8 INCH LIMITED SLIP REAR AXLE. *TT | |
| Bulletin Number: 0322 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT | |
| Bulletin Number: 03223 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| Bulletin Number: 03254 | |
| 5R55W TRANSMISSION - NO 3RD GEAR OR SLIPPING 2-3 SHIFT - DIAGNOSTIC TROUBLE CODE P0733 AND P0745 - VEHICLES BUILT PRIOR TO 3/4/2002. *TT | |
| Bulletin Number: 03256 | |
| ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003. *MJ | |
| Bulletin Number: 03263 | |
| ANTI-LOCK BRAKE SYSTEM (ABS) LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODE (DTC) C1235, C1236, C1237 ON VEHICLES WITH DIFFERENTIAL-MOUNTED RAR WHEEL SPEED SENSOR. *TT | |
| Bulletin Number: 0335 | |
| IDLE AIR CONTROL (IAC) VALVE DIAGNOSTIC SERVICE TIPS. *TT | |
| Bulletin Number: 0357 | |
| FLUID LEAK FROM THE CONVERTER HOUSING AREA. *TT *JB | |
| Bulletin Number: 0361 | |
| MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB | |
| Bulletin Number: 0365 | |
| INTERMITTENT FUEL GAUGE LEVEL DROPPING TO EMPTY WHEN FUEL LEVEL IS NOT ACTUALLY EMPTY. DIAGNOSTIC TROUBLE CODES B1201, B1202, B1204 MAY OR MAY NOT BE PRESENT. *TT *JB | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 04105 | |
| AXLE SEAL LEAKS. LEAKS FROM REAR HALFSHAFT AXLE SEAL. SERVICE TIPS. *TT | |
| Bulletin Number: 04111 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 041601 | |
| WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04189 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 042115 | |
| FUEL GAUGE SLOW TO UPDATE AFTER REFUELING. *EH | |
| Bulletin Number: 042212 | |
| GEAR SELECTOR LEVER - INCREASED EFFORT TO SHIFT FROM DRIVE TO PARK. *TT | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 04251 | |
| ALUMINUM CORROSION - SERVICE TIP. *TT | |
| Bulletin Number: 04259 | |
| REAR POWER WINDOW(S) INOPERATIVE. *TT | |
| Bulletin Number: 04262 | |
| FALSE PARKING AID WARNINGS. *TT UPDATE. *TT | |
| Bulletin Number: 0471 | |
| WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT | |
| Bulletin Number: 0485 | |
| LIFTGATE GLASS APPLIQUE DAMAGED/CRACKED. SERVICE PROCEDURE. *TT | |
| Bulletin Number: 04B15 | |
| REAR AXLE DATE CODE INSPECTION AND SERVICE. VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPER MIX OF REAR AXLE LUBRICANT AND FRICTION MODIFIER ADDITIVE. IF SO, THE CUSTOMER MAY EXPERIENCE NOISE AND VIBRATION WHILE DRIVING. *TT *MJ | |
| Bulletin Number: 050618 | |
| REAR AXLE NOISE REPAIR. *SC | |
| Bulletin Number: 051313 | |
| HARD START/NO START CONDITION DURING COLD AMBEINT TEMPERATURES AFTER SHORT HOT SOAK PERIOD-4.0L ENGINE. *SC | |
| Bulletin Number: 05136 | |
| BACKGLASS DIFFICULT TO CLOSE AND AN INTERMITTENT DOOR AJAR LAMP. *TT | |
| Bulletin Number: 051710 | |
| NOISE FROM REAR WHEEL HUB BEARINGS. *TT | |
| Bulletin Number: 05213 | |
| MALFUNCTION INDICATOR LAMP ON WITH PCM DIAGNOSTIC TROUBLE CODE P0463 AND/OR IC DIAGNOSTIC TROUBLE CODE B1201 - FUEL GAUGE DROPS TO EMPTY OR SLOW TO UPDATE AFTER REFUELING. *TT | |
| Bulletin Number: 0537 | |
| DRIVELINE 1ST ORDER VIBRATION/BOOM/DRONE. *TT | |
| Bulletin Number: 05416 | |
| FRONT SEAT(S) SLIGHT MOVEMENT WHEN ACCELERATING AND/OR DECELERATING. *TT | |
| Bulletin Number: 05419 | |
| FALSE PARKING AID WARNINGS. *TT | |
| Bulletin Number: 05618 | |
| REAR AXLE NOISE REPAIR. *TT | |
| Bulletin Number: 05N04 | |
| EXTENDED COVERAGE PROGRAM 05N04 - EXTENDED COVERAGE FOR COMPOSITE INTAKE MANIFOLD. THIS PROGRAM IS BEING PROVIDED AS A SETTLEMENT TO A CLASS ACTION LAWSUIT. THE TERMS OF THE SETTLEMENT EXTEND THE COVERAGE OF THE ALL-COMPOSITE INTAKE MANIF | |
| Bulletin Number: 06216 | |
| LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS. *TT | |
| Bulletin Number: 07212 | |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE | |
| Bulletin Number: 14710 | |
| SUBJECT REGARDING EDSR BONUS POINTS. *TT | |
| Bulletin Number: 14714 | |
| INFORMATION ON AVAILABILITY OF NEUTRAL TOW KIT. *TT | |
| Bulletin Number: 14723 | |
| SOME VEHICLES MAY EXHIBIT A TINNY RATTLE NOISE COMING FROM THE CENTER STEERING COLUMN AREA WHILE DRIVING OVER BUMPY ROADS. THIS MAY BE DUE TO A FREQUENCY BEING INDUCED INTO THE BRAKE SHIFT INTERLOCK (BSI) SWITCH PINTLE, CREATING AN AUDIBL | |
| Bulletin Number: 14726 | |
| INFORMATION ON THE INTAKE MANIFOLD VALLEY STUFFER BAG. *TT | |
| Bulletin Number: 14741 | |
| MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P1633 AND / OR P1639 WITH NO DRIVEABILITY CONCERN PRESENT. *TT | |
| Bulletin Number: 14741 | |
| MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P1633 AND / OR P1639 WITH NO DRIVEABILITY CONCERN PRESENT. *TT | |
| Bulletin Number: 14742 | |
| SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ON WITH EGR SYSTEM RELATED DIAGNOSTIC TROUBLE CODES P0400, P0401, P0402, P1400, P1401, P1405, P1406, P1408, P1409. *TT | |
| Bulletin Number: 14745 | |
| INFORMATION ON OBTAINING ENGINEERING ASSISTANCE FOR ANTI-LOCK BRAKE SYSTEM. *TT | |
| Bulletin Number: 14759 | |
| INFORMATION REGARDING TRANSMISSION OIL LEVEL CHECKING GUIDELINES. *TT | |
| Bulletin Number: 14795 | |
| SOME VEHICLES MAY EXHIBIT A NOISY AND / OR LOOSE FRONT WHEEL BEARING. *TT | |
| Bulletin Number: 14804 | |
| INFORMATION ON FRONT WHEEL HUB ASSEMBLIES. *TT | |
| Bulletin Number: 14827 | |
| INFORMATION ON VEHICLES EQUIPPED WITH WITH 5R55W TRANSMISSION HAVING A (POWERTRAIN CONTROL MODULE) PCM ADAPTIVE LEARNING STRATEGY FEATURE THAT CONTROLS SHIFT FEEL AND TIMING. *TT | |
| Bulletin Number: 14866 | |
| SOME VEHICLES EQUIPPED WITH 5R55W TRANSMISSION MAY EXHIBIT VARIOUS FIRM AND / OR SOFT SHIFTS. *TT | |
| Bulletin Number: 14868 | |
| SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC ENGINE MAY EXHIBIT A PRIMARY CHAIN RATTLE NOISE (SOMETIMES DESCRIBED AS A SPARK KNOCK-TYPE NOISE). *TT | |
| Bulletin Number: 14871 | |
| SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS OR CHECK ENGINE LAMP (MIL) ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT | |
| Bulletin Number: 14872 | |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT NO CRANK CONDITION AND NO COMMUNICATION FROM THE POWERTRAIN ELECTRONIC CONTROLLER (PTEC) WITH THE WDS / NGS DIAGNOSTIC EQUIPMENT. *TT | |
| Bulletin Number: 14874 | |
| SOME VEHICLES MAY EXHIBIT A TRANSMISSION SHIFTER STUCK IN THE PARK GEAR POSITION. THIS MAY BE DUE TO THE BRAKE SHIFT INTERLOCK SWITCH. *TT | |
| Bulletin Number: 14881 | |
| SOME VEHICLES EQUIPPED WITH 7 PASSENGER SEATING MAY EXHIBIT THE 2ND ROW 40 PERCENT SEAT BACK STAYING IN THE DOWN POSITION. THIS MAY BE DUE TO A RIVET INTERFERENCE AT THE FLOORPAN LATCHES. *TT | |
| Bulletin Number: 14890 | |
| SOME VEHICLES MAY EXHIBIT EXCESSIVE EFFORTS WHEN TRYING TO INSERT OR REMOVE THE KEY FROM THE IGNITION LOCK. *TT | |
| Bulletin Number: 14894 | |
| SOME VEHICLES MAY EXHIBIT A REPETITIVE THUMP / KNOCK NOISE FROM THE REAR WHICH IS PROPORTIONAL TO WHEEL SPEED WHEN BRAKE. THIS MAY BE CAUSED BY THE INITIAL FINISH / SPIRAL CUT OF THE REAR BREAK ROTOR(S). *TT | |
| Bulletin Number: 14896 | |
| SOME VEHICLES MAY EXHIBIT AN ERROR INDICATING THAT THERE IS NO COMMUNICATION OR RETURN DIAGNOSTIC TROUBLE CODES (DTC) THAT ARE NOT RELATED TO THE ANTI-LOCK BRAKE (ABS) SYSTEM WHEN RETRIEVING DTCS FROM OR ATTEMPTING TO VIEW PIDS IN THE ABS M | |
| Bulletin Number: 14900 | |
| SOME VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM LIGHT ON WITH DIAGNOSTIC TROUBLE CODE C1230 AND / OR C1237 FROM THE ANTI-LOCK BRAKE SYSTEM. *TT | |
| Bulletin Number: 14901 | |
| SOME VEHICLES MAY EXHIBIT A CONDITION IN WHICH THE REAR DOOR(S) WILL NOT UNLOCK VIA MANUAL OR POWER OPERATION. *TT | |
| Bulletin Number: 14903 | |
| INFORMATION REGARDING TRAILER WIRING - BRAKE CONTROLLER CONNECTOR LOCATION. *TT | |
| Bulletin Number: 14906 | |
| INFORMATION ON PERFORMING ANY PASSTIVE ANTI-THEFT (PATS) SYSTEM FUNCTIONS INCLUDING KEY REPLACEMENTS WITH WDS OR NGS. *TT | |
| Bulletin Number: 14923 | |
| SOME VEHICLES EQUIPPED WITH 5R55W TRANSMISSION MAY EXHIBIT VARIOUS FIRM AND / OR SOFT SHIFTS. *TT | |
| Bulletin Number: 14933 | |
| SOME VEHICLES MAY EXHIBIT A YELLOW FOUR WHEEL ANTI-LOCK BRAKE (4WABS) LAMP ILLUMINATED AND A DIAGNOSTIC TROUBLE CODE (DTC) B1342 (ANTI-LOCK BRAKE CONTROL MODULE FAILURE) IN SELF TEST. *TT | |
| Bulletin Number: 14934 | |
| SOME VEHICLES EQUIPPED WITH 5R55W TRANSMISSION MAY EXHIBIT VARIOUS FIRM AND / OR SOFT SHIFTS. *TT | |
| Bulletin Number: 14947 | |
| SOME VEHICLES MAY EXHIBIT A STEERING WHEEL SHUDDER DURING LOW SPEED TURNING MANEUVERS. *TT | |
| Bulletin Number: 14983 | |
| SOME VEHICLES EQUIPPED WITH 4.0L ENGINE MAY EXHIBIT EXCESSIVE SULPHUR SMELL FROM THE EXHAUST SYSTEM WHILE OEPRATING UNDER DRIVE MODES. *TT | |
| Bulletin Number: 15017 | |
| STIFF STEERING OR POOR STEERING WHEEL RETURNABILITY. *TT | |
| Bulletin Number: 15019 | |
| SOME VEHICLES EQUIPPED WITH 5R55W TRANSMISSION MAY EXHIBIT A WHINE NOISE THAT OCCURS IN 3RD GEAR ONLY. *TT | |
| Bulletin Number: 15030 | |
| SOME VEHICLES MAY EXHIBIT A TRANSMISSION SHIFTER STUCK IN THE PARK GEAR POSITION. *TT | |
| Bulletin Number: 15041 | |
| SOME VEHICLES EQUIPPED WITH 4.0L ENGINE MAY EXHIBIT A ROUGH IDLE CONDITION. *TT | |
| Bulletin Number: 15054 | |
| VEHICLES WITH 4.0L ENGINE MAY EXHIBIT AN INTERMITTENT HESITATION ON ACCELERATION. *TT | |
| Bulletin Number: 15055 | |
| INFORMATION ON THE LOCATION OF THE HEATED SEAT SWITCH. *TT | |
| Bulletin Number: 15058 | |
| SOME VEHICLES EQUIPPED WITH A 5R55W AUTOMATIC TRANSMISSION MAY EXHIBIT A TICK NOISE WHILE AT IDLE IN PARK AND NEUTRAL. *TT | |
| Bulletin Number: 15069 | |
| VEHICLES EQUIPPED WITH THE 5R55W AUTOMATIC TRANSMISSION BUILT PRIOR TO 08/01/2001 MAY EXHIBIT A NEUTRAL OUT CONDITION WHEN COMING TO A STOP. *TT | |
| Bulletin Number: 15080 | |
| SOME VEHICLES WITH FEWER THAN 10,000 MILES MAY EXHIBIT GREASE OOZING FROM THE FRONT DRIVESHAFT CV JOINT. *TT | |
| Bulletin Number: 15084 | |
| STEERING WHEEL SHUDDER DURING LOW-SPEED TURNING MANEUVERS. *TT | |
| Bulletin Number: 15088 | |
| SOME VEHICLES EQUIPPED WITH 5R55W TRANSMISSION MAY EXHIBIT NO TRANSMISSION ENGAGEMENT INTO FORWARD AND / OR REVERSE GEAR. *TT | |
| Bulletin Number: 15090 | |
| SOME VEHICLES MAY DEVELOP YELLOW STAINS ON THE REAR LIFTGATE PAINT, USUALLY NOTICED ON WHITE COLORED VEHICLES. *TT | |
| Bulletin Number: 15091 | |
| SOME VEHICLES MAY EXHIBIT A SCRUNCH NOISE FROM THE UPPER STEERING COLUMN WHEN MAKING NEAR FULL LOCK TURNS. *TT | |
| Bulletin Number: 15093 | |
| EXHIBITING DRIVABILITY CONDITIONS OR CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT | |
| Bulletin Number: 15103 | |
| SOME VEHICLES MAY EXHIBIT A ROUGH IDLE OR ROUGHT IDLE AFTER INITIAL START-UP THAT CLEARS UP AFTER A FEW MINUTES. *TT | |
| Bulletin Number: 15104 | |
| SOME VEHICLES MAY EXHIBIT A ROUGH IDLE OR ROUGH IDLE AFTER INITIAL START-UP THAT CLEARS UP AFTER A FEW MINUTES. *TT | |
| Bulletin Number: 15105 | |
| SOME VEHICLES EQUIPPED WITH A 4.0L ENGINE MAY EXHIBIT AN INTERMITTENT HESITATION ON ACCELERATION. *TT | |
| Bulletin Number: 15107 | |
| SOME VEHICLES MAY REQUIRE EXCESSIVE EFFORT WHEN TRYING TO INSERT THE KEY INTO THE IGNITION LOCK CYLINDER. *TT | |
| Bulletin Number: 15156 | |
| SOME VEHICLES MAY EXHIBIT DAMAGE TO THE RADIO ANTENNA AFTER RUNNING THROUGH CERTAIN CAR WASHES. *YH | |
| Bulletin Number: 15181 | |
| SOME VEHICLES EQUIPPED WITH 4.6L ENGINE AND 5R55W TRANSMISSION MAY EXHIBIT VARIOUS FIRM AND/OR SOFT SHIFTS. *ET | |
| Bulletin Number: 15182 | |
| INFORMATION REGARDING AUTOLOCK ENABLED/DISABLE PROCEDURE CORRECTION. *YD | |
| Bulletin Number: 15191 | |
| INFORMATION REGARDING NEW COMPASS SETTING PROCEDURE, PDI MUST SET ALL. *YD | |
| Bulletin Number: 15193 | |
| SOME VEHICLES MAY EXHIBIT INTERMITTENT DIFFICULTY TURNING THE IGNITION KEY UPON STARTING. *JG | |
| Bulletin Number: 15210 | |
| SOME VEHICLES EQUPPED WITH 4.0L ENGINE MAY EXHIBIT EXCESSIVE SULPHUR SMELL FROMTHE EXHAUST SYSTEM WHILE OPERATING UNDER CERTAIN DRIVE MODES RELATED TO CALIBRATION. *TT | |
| Bulletin Number: 15215 | |
| SOME VEHICLES MAY EXHIBIT DRIVABILITY CONDITIONS OR CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0455 OR P0457 STORED. *TT | |
| Bulletin Number: 15215 | |
| SOME VEHICLES MAY EXHIBIT DRIVABILITY CONDITIONS OR CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0455 OR P0457. *TT | |
| Bulletin Number: 15242 | |
| SOME VEHICLES MAY EXHIBIT UNEVEN AIR DISCHARGE TEMPERATURES IN A/C COOLING MODES. *TT | |
| Bulletin Number: 15248 | |
| SOME OWNERS MAY NOTICE A KNOCKING NOISE FROM THE REAR OF THE VEHICLE WHEN THE BRAKES ARE APPLIED. *TT | |
| Bulletin Number: 15250 | |
| INFORMATION REGARDING MISDIAGNOSIS OF MAIN CONTROLS - INCORRECT PRESSURES. *TT | |
| Bulletin Number: 15251 | |
| SOME 4X4 VEHICLES WITH FEWER THAN 10,000 MILES MAY EXHIBIT GREASE OOZING FROM THE FRONT DRIVESHAFT CV JOINT. *TT | |
| Bulletin Number: 15261 | |
| INFORMATION REGARDING THE SMOKERS PACKAGE. *TT | |
| Bulletin Number: 15263 | |
| CONCERNS WITH A/C PERFORMANCE TEMP. DIFFERENCE SIDE-SIDE AT REGISTERS. *TT | |
| Bulletin Number: 15267 | |
| SOME VEHICLES WITH 5R5W MAY EXHIBIT A NO ENGAGEMENT CONDITION. ENGINEERING IS INVESTIGATING. *TT | |
| Bulletin Number: 15286 | |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT NO CRANK CONDITION AND NO COMMUNICATION FROM THE POWERTRAIN ELECTRONIC CONTROLLER (PTEC) WITH THE WDS / NGS DIAGNOSTIC EQUIPMENT. *TT | |
| Bulletin Number: 15287 | |
| SOME VEHICLES MAY EXHIBIT A FLUTTER/TURBULENCE NOISE CONDITION (I.E., HELICOPTER NOISE) AT HIGHWAY SPEEDS WHEN THE REAR DOOR WINDOWS ARE IN THE DOWN POSITION. *TT | |
| Bulletin Number: 15290 | |
| SOME 4.0L SOHC MAY EXHIBIT AN ENGINE OIL LEAK CONDITION, COMING FROM THE OIL PAN OR LADDER FRAME AREA. *TT | |
| Bulletin Number: 15329 | |
| SOME VEHICLES EQUIPPED WITH 3RD ROW SEATING MAY EXHIBIT A CONDITION WITH THE SEAT RELEASE LATCH STICKING/BINDING. *TT | |
| Bulletin Number: 15335 | |
| CONCERNS WITH SQUEAK AND RATTLE NOISS COMING FROM THE INSTRUMENT PANEL AND FROM THE SIDE DOOR WINDOWS. *TT | |
| Bulletin Number: 15378 | |
| SOME VEHICLES WITH THE 4.0L ENGINE MAY EXHIBIT AN ENGINE FLUTTER NOISE. *TT | |
| Bulletin Number: 15383 | |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT NO CRANK CONDITION AND NO COMMUNICATION FROM THE POWERTRAIN ELECTRONIC CONTROLLER WITH THE WDS/NGS DIAGNOSTIC EQUIPMENT. *TT | |
| Bulletin Number: 15408 | |
| SOME VEHICLES EQUIPPED WITH DUAL AUTOMATIC TEMPERATURE CONTROL (DATC) MAY EXHIBIT INOPERATIVE REDUNDANT STEERING WHEEL CONTROLS (RSWC). *TT | |
| Bulletin Number: 15423 | |
| EXHIBITING ROUGH IDLE, OR ROUGH IDLE UPON INITIAL START-UP THAT CLEARS UP AFTER A FEW MINUTES. *TT | |
| Bulletin Number: 15445 | |
| SOME VEHICLES MAY EXHIBIT A RATTLE NOISE WHEN CLOSING EITHER THE MIDGATE OR THE REAR LIFTGATE. *TT | |
| Bulletin Number: 15470 | |
| CONCERNS WITH SPARK KNOCK NOISE OR CHAIN RATTLE NOISE BETWEEN 2000-3000 RPM, DURING COLD ENGINE OPERATION ONLY. *TT | |
| Bulletin Number: 15486 | |
| SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457 (GROSS LEAK AFTER FUEL FILL). *TT | |
| Bulletin Number: 15489 | |
| SOME VEHICLES EQUIPPED WITH 4.6L ENGINES MAY EXHIBIT A HIGH FREQUENCY WHINE NOISE (HAIR DRYER TYPE NOISE), THAT LASTS FOR 30-60 SECONDS AFTER COLD START. *TT | |
| Bulletin Number: 15504 | |
| SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT | |
| Bulletin Number: 15519 | |
| SOME VEHICLES MAY EXPERIENCED A STRONG SULPHUR ODOR DURING CERTAIN DRIVE MODES.*YD | |
| Bulletin Number: 15532 | |
| INFORMATION ON VEHICLES EXHIBITNG FUEL LINE DAMAGE DUE TO PINCHING/SQUEEZING OF THE FUEL RETURN LINE. *TT | |
| Bulletin Number: 15540 | |
| INFORMATION REGARDING ENGINE WIND NOISE.*YH | |
| Bulletin Number: 15563 | |
| INFORMATION REGARDING MALFUNCTION INDICATOR LIGHT ILLUMINATING WITH DIAGNOSTIC TROUBLE CODE P0300/P0301.*YH | |
| Bulletin Number: 15575 | |
| SOME VEHICLES MAY EXHIBIT THE DRIVERS DOOR UNLOCKING AFTER IT HAS BEEN LOCKED. *TT | |
| Bulletin Number: 15580 | |
| SOME 4 DOOR VEHICLES MAY EXHIBIT A STEERING COLUMN RATTLE AT SPEEDS OF 10-20 MPH ON UNEVEN SURFACES. *TT | |
| Bulletin Number: 15590 | |
| SOME VEHICLES MAY EXHIBIT A BATTERY DRAW AND/OR A DEAD BATTERY CONDITION. *TT | |
| Bulletin Number: 15605 | |
| SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT | |
| Bulletin Number: 15646 | |
| CONCERNS WITH CLUNK NOISE FROM FRONT AXLE AREA. *TT | |
| Bulletin Number: 15647 | |
| SOME VEHICLES EQUIPPED WITH A V6 ENGINE MAY EXHIBIT A STEERING RATTLE NOISE WHICH MAY BE HEARD AND FELT IN THE STEERING WHEEL AND COLUMN. *TT | |
| Bulletin Number: 15683 | |
| SOME VEHICLES MAY EXHIBIT A NEED FOR HEADLAMP AIM ADJUST AFTER DRIVING ON ROUGH ROADS. *TT | |
| Bulletin Number: 15783 | |
| SOME VEHICLES MAY EXHIBIT EXCESSIVE SULPHUR SMEEL FROM THE EXHAUST UNDER CERTAIN DRIVE MODES. *TT | |
| Bulletin Number: 15804 | |
| SOME VEHICLES BUILT SINCE OCTOBER 1, 2001 MAY EXHIBIT A NO START CONDITION OR AN INTERMITTENT NO START CONDITION, AND / OR POSSIBLY NO COMMUNICATION FROM THE POWERTRAIN ELECTRONIC CONTROLLER WITH THE WDS / NGS DIAGNOSTIC EQUIPMENT. *TT | |
| Bulletin Number: 15829 | |
| SUBJECT REGARDING CIGAR LIGHTER REVISED INSTALLATION PROCEDURES. *TT | |
| Bulletin Number: 15853 | |
| SUBJECT REGARDING INTERMITTENT ENGINE QUIT DURING TRANSMISSION ENGAGEMENTS OR PARKING MANEUVERS. *TT | |
| Bulletin Number: 15892 | |
| SUBJECT REGARDING REAR LIFTGATE APPLIQUE (TRIM PANEL) CRACKS. *TT | |
| Bulletin Number: 15899 | |
| SUBJECT REGARDING THEFT LIGHT RELOCATION. *TT | |
| Bulletin Number: 15906 | |
| INFORMATION ON POWER STEERING LEAK CONDITION. *TT | |
| Bulletin Number: 15910 | |
| CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION. *TT | |
| Bulletin Number: 15938 | |
| INFORMATION USED WHEN REPLACING THE DRIVERS SEAT MODULE. *TT | |
| Bulletin Number: 15984 | |
| EXHIBITING SQUEAK / CREAK NOISES DURING FRONT SUSPENSION MOVEMENT. *TT | |
| Bulletin Number: 16029 | |
| SOME VEHICLES MAY EXHIBIT UNINTENDED SMART UNLOCK ACTIVATION WITHOUT KEY IN IGNITION. *TT | |
| Bulletin Number: 16090 | |
| SOME 4DR VEHICLES MAY EXHIBIT SEATING APPEARANCE OR RELATED ISSUES. *TT | |
| Bulletin Number: 16094 | |
| SOME VEHICLES MAY EXHIBIT FUEL DIAGNOSTIC TROUBLE CODES P0171, P0172, P0174, P0175 OR MASS AIR FLOW DIAGNOSTIC TROUBLE CODES P0102, P0103, P0112, P0113. *TT | |
| Bulletin Number: 16195 | |
| CONTACT ST LOUIS ASSEMBLY PLANT/ST LOUIS VICINITY ONLY. *MJ | |
| Bulletin Number: 16304 | |
| SUN VISOR RATTLE / DETROIT AREA DEALERS CONTACT REQUEST. *TT | |
| Bulletin Number: 16309 | |
| HIGH SIDE PRESSURE FLUCTUATIONS ON VEHICLES EQUIPPED WITH A FIXED SCROLL A/C COMPRESSOR. *TT | |
| Bulletin Number: 16427 | |
| LOW SPEED OR STATIONARY NOISE/VIBRATION AT LOWER STEERING SHAFT AREA WHEN TURNING. *MJ | |
| Bulletin Number: 16508 | |
| VIBRATION CONDITION. CONTACT REQUEST ST. LOUIS REGION. OASIS. *TT | |
| Bulletin Number: 16608 | |
| UNINTENDED DOOR UNLOCKS WITHOUT KEY IN IGNITION (QSF). *TT | |
| Bulletin Number: 16617 | |
| OPEN F2.20 5 AMP FUSE WHICH MAY RESULT IN LOSS OF FUNCTION OF SEVERAL SYSTEMS INCLUDING POWER SEATS, ADJUSTABLE PEDALS AND POWER DOOR LOCKS. *TT | |
| Bulletin Number: 16618 | |
| ILLUMINATED AIR BAG WARNING LAMP WITH DIAGNOSTIC TROUBLE CODE (DTC) B2292. *TT | |
| Bulletin Number: 16640 | |
| REAR DRIVELINE PING/CREAK/POP NOISE. *TT | |
| Bulletin Number: 16665 | |
| BLINKING/HALF ILLUMINATED SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AND/OR ANTI-LOCK BRAKE (ABS) WARNING INDICATORS AFTER COLD SOAK DURING AMBIENT TEMPERATURES COLDER THAN 30 DEGREES FAHRENHEIT. *TT | |
| Bulletin Number: 16688 | |
| BACK GLASS HINGE RATTLING/LOOSENESS, GLASS MISALIGNMENT AND/OR GLASS HARD-TO-CLOSE. *TT *JB | |
| Bulletin Number: 16702 | |
| 4X4 CONTROL MODULE NOT INTERCHANGEABLE ISSUES. *TT *JB | |
| Bulletin Number: 16703 | |
| BATTERY LIGHT ON OR AN ALTERNATOR THAT IS NOT CHARGING. *TT *JB | |
| Bulletin Number: 16706 | |
| SQUEAKING ACCELERATOR PEDAL WHILE DRIVING DURING COLD, HOT, DUSTY, AND DRY CONDITIONS. *TT *JB | |
| Bulletin Number: 16708 | |
| AN AUDIBLE CREAK / CLICK / POP (NOT A CLUNK) FROM THE REAR DRIVELINE. *TT *JB | |
| Bulletin Number: 16754 | |
| EXCESSIVE WHINE NOISE FROM THE REAR AXLE AT CRUISE, OR ON ACCELERATION AND/OR DECELERATION. *TT | |
| Bulletin Number: 16771 | |
| ROUGH / ROLLING IDLE AND HESITATION ON ACCELERATION AFTER A FIRST COLD STARTUP. *TT | |
| Bulletin Number: 16806 | |
| FLUID LEAKS FROM THE REAR HALFSHAFT SEAL. 2002-2003 EXPLORER/MOUNTAINEER/AVIATOR ADDED. *TT | |
| Bulletin Number: 16898 | |
| A WHINE NOISE ON TIP-IN AT SPEEDS OF 45 TO 65 MPH. THIS MAY BE DUE TO DRIVELINE STACK-UP TOLERANCE WITH THE DRIVESHAFT AND REAR AXLE. *TT | |
| Bulletin Number: 16918 | |
| ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP ON WITH CODES C1235 AND C1236 OR C1237. *TT | |
| Bulletin Number: 16926 | |
| STABILITY ASSIST (ADVANCETRAC/IVD) SYSTEMS MAY NOT BE RECALIBRATED PROPERLY USING WDS. *TT | |
| Bulletin Number: 16949 | |
| REAR AXLE VIBRATION/DRONE ABOVE 60 MPH. *TT | |
| Bulletin Number: 16967 | |
| CLUSTER LOCKING UP & VARIOUS ACCESSORIES SUCH AS THE RADIO, POWER WINDOWS, POWER LOCKS AND MOONROOF BEING INOPERATIVE. *TT | |
| Bulletin Number: 16968 | |
| DRIVEABILITY CONDITIONS DUE TO CALIBRATION VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE. IDLE AIR CONTROL (IAC) VALVE REPLACEMENT FOR THESE SYMPTOMS IS TYPICALLY NOT EFFECTIVE. *TT | |
| Bulletin Number: 17002 | |
| AN INTERMITTENT OR CONTINUOUS OPEN OF FUSE 1.15. *TT | |
| Bulletin Number: 17011 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND DIAGNOSTIC TROUBLE CODES (DTC'S) P0171, P0172, P0174, OR P0175. *TT | |
| Bulletin Number: 17049 | |
| ROUGH IDLE / ENGINE SHAKE. *TT | |
| Bulletin Number: 17054 | |
| AXLE WHINE AT CRUISE OR DURING ACCELERATION/ DECELERATION. *TT | |
| Bulletin Number: 17069 | |
| ROUGH/ROLLING IDLE OR HESITATION AFTER FIRST STARTUP OR A ROUGH/ROLLING ENGINE SPEED WHEN RETURNING TO IDLE AFTER A SHORT TRIP. *TT | |
| Bulletin Number: 17107 | |
| DRIVELINE VIBRATION ON DRONE/BOOM AT HIGHWAY SPEEDS. *TT | |
| Bulletin Number: 17163 | |
| EXCESSIVE ENGINE COOLING FAN NOISE. *TT | |
| Bulletin Number: 17167 | |
| MULTIPLE VEHICLES WITH 3.0L OR 4.0L ENGINES LACKS POWER/RUNS ROUGH/BLACK SMOKE. 2004 SPORT TRAC INCLUDED. *TT | |
| Bulletin Number: 17215 | |
| THE AMBER ANTI-LOCK BRAKE SYSTEM (ABS) WARNING LIGHT ON WITH DIAGNOSTIC TROUBLE CODES C1235, C1236/C1237 STORED IN MEMORY. *TT | |
| Bulletin Number: 17216 | |
| BREAKAGE OF A LIFTGATE WINDOW HINGE. *TT | |
| Bulletin Number: 17217 | |
| AIR CONDITIONER HOOTING NOISE DURING LIGHT LOAD ACCELERATION AT LOW SPEEDS, FROM 1000-1300 RPM. *TT | |
| Bulletin Number: 17246 | |
| INSTRUMENT CLUSTER LOCKING UP AND ACCESSORIES SUCH AS THE RADIO, POWER WINDOWS, POWER LOCKS AND MOONROOF INOPERATIVE. *TT | |
| Bulletin Number: 17280 | |
| GENERATOR WHISTLE/HOOT NOISE IN COLD AMBIENT TEMPERATURES. *TT | |
| Bulletin Number: 17316 | |
| FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP. *TT | |
| Bulletin Number: 17375 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON AND HARD START/LONG CRANK. *TT | |
| Bulletin Number: 17494 | |
| DISTANCE TO EMPTY NOT DISPLAYED. *TT | |
| Bulletin Number: 17544 | |
| GENERATOR NOISE IN COLD AMBIENT TEMPERATURES. *MJ | |
| Bulletin Number: 17555 | |
| CERTIFIED REAR AXLE AVAILABLE. *MJ | |
| Bulletin Number: 17558 | |
| INTERMITTENT AIR BAG WARNING LAMP ON, MEMORY SEAT, AND/OR ADJUSTABLE PEDAL CONCERNS. *MJ | |
| Bulletin Number: 17560 | |
| REAR AXLE NOISE. ALSO INCLUDES LINCOLN AVIATOR 2002. *MJ | |
| Bulletin Number: 17640 | |
| POOR FIT BETWEEN DRIVER AIR BAG AND STEERING WHEEL. *TT | |
| Bulletin Number: 17641 | |
| REAR 3.55 AXLE NOISE. CERTIFIED REAR AXLE OR IMPROVED GEAR SET AVAILABLE. *TT | |
| Bulletin Number: 17717 | |
| REAR AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNS. *TT | |
| Bulletin Number: 17729 | |
| MESSAGE CENTER DISPLAYS COMPUTING FUEL INSTEAD OF DISTANCE TO EMPTY. *TT | |
| Bulletin Number: 17735 | |
| BELT SLIPPAGE. *TT | |
| Bulletin Number: 17736 | |
| REAR AXLE NOISE. *TT | |
| Bulletin Number: 17905 | |
| MULTIPLE VEHICLES USING FEHP REAR AXLE FLUID. FLUID USAGE CHANGE. *TT | |
| Bulletin Number: 18121 | |
| FUEL GAUGE SLOW TO UPDATE. *TT | |
| Bulletin Number: 18123 | |
| UPDATED REAR HALFSHAFT REMOVAL PROCEDURE. *TT | |
| Bulletin Number: 18171 | |
| NO CRANK/NO START CONDITION WHEN VEHICLE TEMPERATURE IS BELOW FREEZING (32F/0C). *TT | |
| Bulletin Number: 18215 | |
| BROKEN REAR CARGO STORAGE DOOR LIFT HANDLE. VARIOUS MODELS INCLUDING 2005 EXPLORER/MOUNTAINEER. *TT | |
| Bulletin Number: 18217 | |
| MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT | |
| Bulletin Number: 18221 | |
| REAR AXLE NOISE. OASIS. VARIOUS MODELS INCLUDING 2005 EXPLORER, MOUNTAINEER AND AVIATOR. *TT | |
| Bulletin Number: 18224 | |
| RUNS ROUGH OR MISFIRE - DIAGNOSTIC TROUBLE CODES P0300-P0308 OR P0316. *TT | |
| Bulletin Number: 18381 | |
| OPEN FUSE F2.20 (5 AMP) AND/OR F2.1 (30 AMP) WHICH MAY RESULT IN LOSS OF FUNCTION OF SEVERAL SYSTEMS INCLUDING POWER SEATS, ADJUSTABLE PEDALS AND POWER DOOR LOCKS. *TT | |
| Bulletin Number: 18423 | |
| AXLE WHINE HOWL SERVICE WITH INDIVIDUAL PARTS INSTEAD OF AN AXLE ASSEMBLY. *EH | |
| Bulletin Number: 18466 | |
| AXLE WHINE HOWL. THIS INCLUDES 1997-05 FORD VEHICLES. *EH | |
| Bulletin Number: 18478 | |
| AXLE SEAL LEAKS. *EH | |
| Bulletin Number: 18572 | |
| NO START/HARD START N HOT SOAK RESTART. *TT | |
| Bulletin Number: 18719 | |
| MALFUNCTION INDICATOR LAMP COMING ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0172, P0174 AND/OR P0175 (FUEL SYSTEM TOO RICH OR LEAN). *TT | |
| Bulletin Number: 19091 | |
| LOW OIL PRESSURE INDICATION/WARNING, A/C COMPRESSOR INOPERATIVE AND/OR NO CRANK CONDITION ON 4.6L EQUIPPED VEHICLES. *TT | |
| Bulletin Number: 870197 | |
| INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT | |
| Bulletin Number: TSB-08-19-3 | |
| FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE | |
| Bulletin Number: TSB 19-2026 | |
| Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo | |
| 2002 FORD EXPLORER SPORT | |
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01205 | |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT | |
| Bulletin Number: 012113 | |
| SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 0186 | |
| ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT | |
| Bulletin Number: 01B77 | |
| OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT | |
| Bulletin Number: 020801 | |
| RATTLE NOISE FROM PRIMARY CHAIN DRIVE AREA 2000-3000 RPM - 4.0L SOHC ENGINE. *TT | |
| Bulletin Number: 02138 | |
| LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. *TT | |
| Bulletin Number: 02176 | |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| Bulletin Number: 02216 | |
| EXCESSIVE SULFUR SMELL FROM EXHAUST. *EH | |
| Bulletin Number: 02222 | |
| NOISE-GEAR WHINE NOISE IN 1ST AND 2ND GEAR ONLY-VEHICLES EQUIPPED WITH 5R55E TRANSMISSION AND 4.0L ENGINE ONLY. *MJ | |
| Bulletin Number: 0232 | |
| SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301. *TT | |
| Bulletin Number: 0242 | |
| CERTAIN VEHICLES WITH 4X4 OR ALL-WHEEL DRIVE MAY HAVE A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 0258 | |
| INOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639. *TT | |
| Bulletin Number: 0276 | |
| INFORMATION ON DIAGNOSING ENGINE RATTLE NOISE FROM PRIMARY CHAIN DRIVE AREA BETWEEN 2000-3000 RPM ON COLD ENGINE OPERATION ONLY. *TT | |
| Bulletin Number: 0281 | |
| SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC (SINGLE OVER-HEAD CAM) ENGINE MAY EXHIBIT A PRIMARY TIMING CHAIN RATTLE NOISE. *TT | |
| Bulletin Number: 0282 | |
| SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. *TT | |
| Bulletin Number: 0283 | |
| SOME VEHICLES EQUIPPED WITH A 2.3L, 3.0L OR 4.0L ENGINE AND 5R44E OR 5R55E AUTOMATIC TRANSMISSION MAY EXHIBIT A FLUID LEAK AT THE TRANSMISSION SERVO COVERS IN COLD CLIMATES. *TT | |
| Bulletin Number: 02M01 | |
| CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6 | |
| Bulletin Number: 030508 | |
| FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD. *TT | |
| Bulletin Number: 03148 | |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 031912 | |
| STEERING SHUDDER FELT WHEN TURNING, DRIVING AT SLOW SPEEDS OR AT STOP. *TT | |
| Bulletin Number: 031912 | |
| STEERING WHEEL SHUDDER DURING LOW SPEED TURNING MANEUVERS. 2004 EXPLORER SPORT TRAC INCLUDED. *TT | |
| Bulletin Number: 03203 | |
| MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT | |
| Bulletin Number: 0322 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT | |
| Bulletin Number: 03223 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| Bulletin Number: 0335 | |
| IDLE AIR CONTROL (IAC) VALVE DIAGNOSTIC SERVICE TIPS. *TT | |
| Bulletin Number: 0358 | |
| FLUID MAY LEAK OUT OF THE FRONT AXLE VENT TUBE. *TT *JB | |
| Bulletin Number: 0361 | |
| MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 04111 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. | |
| Bulletin Number: 04133 | |
| MOISTURE IN HEADLAMP. *TT | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 04189 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04217 | |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 042419 | |
| REVISED PROCEDURE FOR ADJUSTING ALIGNMENT ON ALL SUSPENSIONS - NEW RIGHT HAND UPPER CONTROL ARM DESIGN FOR TORSION BAR FRONT SUSPENSIONS. *TT | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 0427 | |
| STEERING SHUDDER DURING LOW SPEED MANEUVERS - 4.0L ENGINE. *TT | |
| Bulletin Number: 05310 | |
| SAFETY BELT WEB STOP BUTTON SERVICE. *EH | |
| Bulletin Number: 15358 | |
| CONCERNS WITH ENGINE QUITTING DURING DECELERATION. *TT | |
| Bulletin Number: 15378 | |
| SOME VEHICLES WITH THE 4.0L ENGINE MAY EXHIBIT AN ENGINE FLUTTER NOISE. *TT | |
| Bulletin Number: 15381 | |
| SOME VEHICLES WITH A MANUAL TRANSMISSION MAY EXHIBIT AN ENGINE LOSS OR REDUCTION IN POWER CONDITION ON DECELERATION, BUT WILL IMMEDIATELY RESTART. *TT | |
| Bulletin Number: 15382 | |
| SOME VEHICLES MAY EXHIBIT EITHER A VERY HARD OR VERY SOFT CLUTCH PEDAL FEEL, AND/OR A DIFFICULTY IN SHIFTING GEARS. *TT | |
| Bulletin Number: 15406 | |
| CONCERNS WITH REAR WIPERS THAT DO NOT SUFFICIENTLY CLEAN THE BACK GLASS. *TT | |
| Bulletin Number: 15471 | |
| SOME 4.0L SOHC ENGINES MAY EXHIBIT EXCESSIVE SULPHUR SMELL FROM THE EXHAUST SYSTEM WHILE OPERATING UNDER CERTAIN DRIVE MODES. *TT | |
| Bulletin Number: 15531 | |
| SUBJECT REGARDING ENGINE QUITTING ON DECELERATION/STOPPING.*YD | |
| Bulletin Number: 15532 | |
| INFORMATION ON VEHICLES EXHIBITNG FUEL LINE DAMAGE DUE TO PINCHING/SQUEEZING OF THE FUEL RETURN LINE. *TT | |
| Bulletin Number: 15551 | |
| CUSTOMERS MAY COMPLAIN OF MOISTURE IN HEADLAMP. *YH | |
| Bulletin Number: 15572 | |
| SOME VEHICLES EQUIPPED WITH BELT MINDER MAY EXHIBIT THE BELT MINDER WARNING CHIME STAYING ON AFTER THE DRIVER SEAT BELT BUCKLE HAS BEEN BUCKLED. *TT | |
| Bulletin Number: 15590 | |
| SOME VEHICLES MAY EXHIBIT A BATTERY DRAW AND/OR A DEAD BATTERY CONDITION. *TT | |
| Bulletin Number: 15602 | |
| CONCERNS WITH LOW BRAKE PEDAL/HYDRAULIC CONTROL UNIT BRAKE FLUID LEAK. *TT | |
| Bulletin Number: 15644 | |
| SOME VEHICLES MAY EXHBIT A HARD START/NO START CONDITION WHEN TRYING TO START THE VEHICLE. *TT | |
| Bulletin Number: 15655 | |
| CONCERNS WITH EXCESSIVE SULPHUR SMELL FROM THE EXHAUST WHEN OPERATING UNDER CERTAIN DRIVE MODES. *TT | |
| Bulletin Number: 15689 | |
| SOME VEHICLES MAY EXHIBIT EITHER A VERY HARD OR VERY SOFT CLUTCH PEDAL FEEL. *TT | |
| Bulletin Number: 15723 | |
| SOME VEHICLES MAY EXHIBIT ADHESIVE EXTRUDING FROM THE HEADLINER MATERIAL AROUND THE MOONROOF. *TT | |
| Bulletin Number: 15754 | |
| SOME VEHICLES EQUIPPED WITH 4.0L ENGINE AND MANUAL TRANSMISSION MAY EXHIBIT AN INTERMITTENT STUMBLE DURING DECELERATION AND / OR AT STOPS WHEN THE CLUTCH PEDAL IS DEPRESSED. *TT | |
| Bulletin Number: 15765 | |
| SOME VEHICLES MAY EXHIBIT WIND NOISE AROUND THE FRONT DOORS, NEAR THE TOP REAR-WARD PORTION OF THE DOOR / GLASS AT HIGHWAY SPEEDS, OR IN A CROSS WIND. *TT | |
| Bulletin Number: 15769 | |
| SOME VEHICLES MAY EXHIBIT A CONDITION OF STEERING WHEEL LEATHER PEELING. *TT | |
| Bulletin Number: 15785 | |
| SOME VEHICLES EQUIPPED WITH 5R55E/5R44E TRANSMISSION MAY EXHIBIT A WHINE NOISE IN 1ST GEAR THAT GOES AWAY AFTER THE 1-2 OR 1-3 SHIFT IS COMPLETED. *TT | |
| Bulletin Number: 15835 | |
| RUNNING CHANGE FOR THE UPPER RADIATOR SIGHT SHIELD. *TT | |
| Bulletin Number: 15859 | |
| SOME VEHICLES WITH 4WABS MAY EXHIBIT DIAGNOSTIC TROUBLE CODES C1233 AND C1234 (ANTI-LOCK BRAKE SENSOR OUTPUT FAILURE). *TT | |
| Bulletin Number: 15863 | |
| SUBJECT REGARDING A WHINE NOISE CONDITION FROM THE SPEAKERS WHEN USING THE RADIO OR THE CD WITH THE PIONEER TREMORE / PIONEER ULTIMATE 450 WATT AUDIO SYSTEM. *TT | |
| Bulletin Number: 15869 | |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT SOFT CLUTCH PEDAL WHICH MAY CAUSE DIFFICULTY IN SHIFTING GEARS (A NOTCHY FEEL). *TT | |
| Bulletin Number: 15887 | |
| SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). *TT | |
| Bulletin Number: 15898 | |
| SOME VEHICLES MAY EXHIBIT A HARD START / NO START CONDITION DUE TO FUEL PRESSURE BLEED DOWN. *TT | |
| Bulletin Number: 15905 | |
| SUBJECT REGARDING PIONEER TREMOR / ULTIMATE 450 WATT AUDIO SYSTEM WHINE NOISE. *TT | |
| Bulletin Number: 15910 | |
| CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION. *TT | |
| Bulletin Number: 15936 | |
| SOME VEHICLES EQUPPED WITH 4.0L ENGINE AND AUTOMATIC TRANSMISSION MAY EXHIBIT A ROUGH IDLE, LOW SPEED ENGINE QUIT, HESITATION ON COLD ENGINE TIP-IN AND / OR HESITATION DURING A 5-3 DONWSHIFT. *TT | |
| Bulletin Number: 16021 | |
| SOME VEHICLES WITH 4WABS MAY EXHIBIT DIAGNOSTIC TROUBLE CODES C1233 AND C1234 (ANTI-LOCK BRAKE SENSOR OUTPUT FAILURES) IN SLIPPERY CONDITIONS. *TT | |
| Bulletin Number: 16038 | |
| SOME VEHICLES EQUIPPED WITH A 5R55E AUTOMATIC TRANSMISSION MAY EXHIBIT A GEAR WHINE TYPE NOISE IN 1ST AND / OR 2ND GEARS ONLY. *TT | |
| Bulletin Number: 16040 | |
| EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT | |
| Bulletin Number: 16113 | |
| SOME VEHICLES BUILT AFTER 03/04/2002 AND EQUIPED WITH A MANUAL TRANSMISSION MAY EXHIBIT A HARD TO SHIFT CONDITION. *TT | |
| Bulletin Number: 16121 | |
| SOME VEHICLES MAY EXHIBIT UNEVEN AND / OR PREMATURE FRONT BRAKE PAD WEAR, PARTICULARLY THE FRONT INSIDE PAD. *TT | |
| Bulletin Number: 16124 | |
| SOME VEHICLES BUILT ON OR AFTER 3/4/2002 MAY EXHIBIT INTERMITTENT ENGINE DRIVEABILITY ISSUES. ENGINEER IS INVESTIGATING. *TT | |
| Bulletin Number: 16134 | |
| INFORMATION ON SERVICING THE MULTIFUNCTION SWITCH ON VEHICLES EQUIPPED WITH TILT STEERING COLUMN. *TT | |
| Bulletin Number: 16402 | |
| FRONT BRAKE WEAR - UNDER INVESTIGATION. *MJ | |
| Bulletin Number: 16437 | |
| DIAGNOSTIC TROUBLE CODE (DTC) C1233 & C1234 - REPLACE ANTI-LOCK BRAKE SYSTEM EUC. *MJ | |
| Bulletin Number: 16610 | |
| NO START, NO COMMUNICATION WITH POWER TRAIN CONTROL MODULE (PCM) USING WDS/NGS OR A MISS/BUCK/JERK WHILE DRIVING. *TT | |
| Bulletin Number: 16623 | |
| EXCESSIVE FUEL GAUGE FLUCTUATION WHILE DRIVING (QSF). *TT | |
| Bulletin Number: 16624 | |
| SLOW FUEL FILL CONDITION. *TT | |
| Bulletin Number: 16735 | |
| VARIOUS NOISE ISSUES FROM THE REAR LEAF SPRINGS WHILE DRIVING. *TT | |
| Bulletin Number: 16776 | |
| SERVICING MULTIFUNCTION SWITCH WIRING INTERFERENCE. *TT | |
| Bulletin Number: 16810 | |
| ROUGH IDLE AND/OR CHECK ENGINE LAMP DUE TO CLOSURE HOSE WHICH BECOMES LOOSE OR DISCONNECTED AT THE RIGHT HAND CAM COVER. *TT | |
| Bulletin Number: 17055 | |
| LACKS POWER / BLACK SMOKE / RUNS ROUGH, USUALLY WITH NO MALFUNCTION INDICATOR LAMP ON OR DIAGNOSTIC TROUBLE CODES. *TT | |
| Bulletin Number: 17167 | |
| MULTIPLE VEHICLES WITH 3.0L OR 4.0L ENGINES LACKS POWER/RUNS ROUGH/BLACK SMOKE. 2004 SPORT TRAC INCLUDED. *TT | |
| Bulletin Number: 17198 | |
| WEAR-THROUGH CONDITION ON THE ABRASION SLEEVE OF THE UPPER RADIATOR HOSE NEAR THE AIR CONDITIONING ACCUMULATOR OR TRANSMISSION FLUID DIPSTICK. *TT | |
| Bulletin Number: 17231 | |
| ANTI-LOCK BRAKE SYSTEM (ABS) LIGHT FLASHING WITH DIAGNOSTIC TROUBLE CODE (DTC) B2477 AFTER REPLACEMENT OF THE ABS MODULE. *TT | |
| Bulletin Number: 17253 | |
| WATER LEAK NEAR THE ROOF OPENING PANEL. 2004 EXPLORER SPORT TRAC INCLUDED. *TT | |
| Bulletin Number: 17254 | |
| CLICKING/POPPING NOISE FROM UPPER STEERING COLUMN AREA WHEN TURNING. 2004 E SERIES AND EXPLORER SPORT TRAC ALSO INCLUDED. *TT | |
| Bulletin Number: 17280 | |
| GENERATOR WHISTLE/HOOT NOISE IN COLD AMBIENT TEMPERATURES. *TT | |
| Bulletin Number: 17376 | |
| LACKS POWER/RUNS ROUGH/BLACK SMOKE CONDITION. *TT | |
| Bulletin Number: 17378 | |
| INTERMITTENT ENGINE DRIVEABILITY ISSUES. VEHCLES WITH AUTOMATIC TRANSMISSION BUILT BETWEEN 03/04/2002 AND 12/01/2002. *TT | |
| Bulletin Number: 17379 | |
| ROUGH IDLE, HESITATION ON COLD ENGINE TIP-IN AND/OR HESITATION DURING A 5-3 DOWNSHIFT. *TT | |
| Bulletin Number: 17544 | |
| GENERATOR NOISE IN COLD AMBIENT TEMPERATURES. *MJ | |
| Bulletin Number: 17647 | |
| PAINT PEELING AND/OR BUBBLING ON THE CENTER FINISH PANEL OF THE INSTRUMENT PANEL. *TT | |
| Bulletin Number: 18719 | |
| MALFUNCTION INDICATOR LAMP COMING ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0172, P0174 AND/OR P0175 (FUEL SYSTEM TOO RICH OR LEAN). *TT | |
| Bulletin Number: 870197 | |
| INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT | |
| 2002 FORD EXPLORER SPORT TRAC | |
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01205 | |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT | |
| Bulletin Number: 012113 | |
| SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 012501 | |
| SOME VEHICLES MAY EXHIBIT A STEERING WHEEL SHUDDER DURING LOW SPEED TURNING MANEUVERS. *TT | |
| Bulletin Number: 01251 | |
| STEERING WHEEL SHUDDER DURING LOW-SPEED TURNING. *TT | |
| Bulletin Number: 0186 | |
| ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT | |
| Bulletin Number: 01B77 | |
| OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT | |
| Bulletin Number: 020801 | |
| RATTLE NOISE FROM PRIMARY CHAIN DRIVE AREA 2000-3000 RPM - 4.0L SOHC ENGINE. *TT | |
| Bulletin Number: 02138 | |
| LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. *TT | |
| Bulletin Number: 02171 | |
| PAINT-PREMATURE CLEARCOAT CRACKING-SERVICE TIPS. *MJ | |
| Bulletin Number: 02173 | |
| ELECTRICAL-RADIO-SPEAKER WHINE NOISE-VEHICLES WITH ULTIMATE PIONEER RADIO SYSTEM PRODUCED ON OR AFTER 3/4/2002 ONLY. *MJ | |
| Bulletin Number: 02176 | |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| Bulletin Number: 02216 | |
| EXCESSIVE SULFUR SMELL FROM EXHAUST. *EH | |
| Bulletin Number: 02222 | |
| NOISE-GEAR WHINE NOISE IN 1ST AND 2ND GEAR ONLY-VEHICLES EQUIPPED WITH 5R55E TRANSMISSION AND 4.0L ENGINE ONLY. *MJ | |
| Bulletin Number: 0232 | |
| SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301. *TT | |
| Bulletin Number: 0242 | |
| CERTAIN VEHICLES WITH 4X4 OR ALL-WHEEL DRIVE MAY HAVE A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 0258 | |
| INOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639. *TT | |
| Bulletin Number: 0276 | |
| INFORMATION ON DIAGNOSING ENGINE RATTLE NOISE FROM PRIMARY CHAIN DRIVE AREA BETWEEN 2000-3000 RPM ON COLD ENGINE OPERATION ONLY. *TT | |
| Bulletin Number: 0281 | |
| SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC (SINGLE OVER-HEAD CAM) ENGINE MAY EXHIBIT A PRIMARY TIMING CHAIN RATTLE NOISE. *TT | |
| Bulletin Number: 0282 | |
| SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. *TT | |
| Bulletin Number: 0283 | |
| SOME VEHICLES EQUIPPED WITH A 2.3L, 3.0L OR 4.0L ENGINE AND 5R44E OR 5R55E AUTOMATIC TRANSMISSION MAY EXHIBIT A FLUID LEAK AT THE TRANSMISSION SERVO COVERS IN COLD CLIMATES. *TT | |
| Bulletin Number: 02M01 | |
| CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6 | |
| Bulletin Number: 0305 | |
| EMISSIONS RECALL 03E05: EVAPORATIVE EMISSIONS CANISTER FRESH AIR INLET HOSE CONNECTOR REPLACEMENT.*MR | |
| Bulletin Number: 030508 | |
| FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD. *TT | |
| Bulletin Number: 03148 | |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 031912 | |
| STEERING SHUDDER FELT WHEN TURNING, DRIVING AT SLOW SPEEDS OR AT STOP. *TT | |
| Bulletin Number: 031912 | |
| STEERING WHEEL SHUDDER DURING LOW SPEED TURNING MANEUVERS. 2004 EXPLORER SPORT TRAC INCLUDED. *TT | |
| Bulletin Number: 03195 | |
| POWER REAR WINDOW BOUNCES BACK OPEN WHEN CLOSING. 2004 SPORT TRAC MODEL INCLUDED. *TT | |
| Bulletin Number: 03203 | |
| MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT | |
| Bulletin Number: 0322 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT | |
| Bulletin Number: 03223 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| Bulletin Number: 03235 | |
| BED EXTENDER COMPONENT REPLACEMENT SERVICE TIP. *TT | |
| Bulletin Number: 0335 | |
| IDLE AIR CONTROL (IAC) VALVE DIAGNOSTIC SERVICE TIPS. *TT | |
| Bulletin Number: 0358 | |
| FLUID MAY LEAK OUT OF THE FRONT AXLE VENT TUBE. *TT *JB | |
| Bulletin Number: 0361 | |
| MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 04111 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04213 | |
| SQUEAKING NOISE FROM REAR SWAY BAR LINK. *TT | |
| Bulletin Number: 04217 | |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 042419 | |
| REVISED PROCEDURE FOR ADJUSTING ALIGNMENT ON ALL SUSPENSIONS - NEW RIGHT HAND UPPER CONTROL ARM DESIGN FOR TORSION BAR FRONT SUSPENSIONS. *TT | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 042511 | |
| MOAN/VIBRATION DURING AIR CONDITIONING OPERATION. *TT | |
| Bulletin Number: 0427 | |
| STEERING SHUDDER DURING LOW SPEED MANEUVERS - 4.0L ENGINE. *TT | |
| Bulletin Number: 15358 | |
| CONCERNS WITH ENGINE QUITTING DURING DECELERATION. *TT | |
| Bulletin Number: 15378 | |
| SOME VEHICLES WITH THE 4.0L ENGINE MAY EXHIBIT AN ENGINE FLUTTER NOISE. *TT | |
| Bulletin Number: 15381 | |
| SOME VEHICLES WITH A MANUAL TRANSMISSION MAY EXHIBIT AN ENGINE LOSS OR REDUCTION IN POWER CONDITION ON DECELERATION, BUT WILL IMMEDIATELY RESTART. *TT | |
| Bulletin Number: 15382 | |
| SOME VEHICLES MAY EXHIBIT EITHER A VERY HARD OR VERY SOFT CLUTCH PEDAL FEEL, AND/OR A DIFFICULTY IN SHIFTING GEARS. *TT | |
| Bulletin Number: 15471 | |
| SOME 4.0L SOHC ENGINES MAY EXHIBIT EXCESSIVE SULPHUR SMELL FROM THE EXHAUST SYSTEM WHILE OPERATING UNDER CERTAIN DRIVE MODES. *TT | |
| Bulletin Number: 15531 | |
| SUBJECT REGARDING ENGINE QUITTING ON DECELERATION/STOPPING.*YD | |
| Bulletin Number: 15532 | |
| INFORMATION ON VEHICLES EXHIBITNG FUEL LINE DAMAGE DUE TO PINCHING/SQUEEZING OF THE FUEL RETURN LINE. *TT | |
| Bulletin Number: 15551 | |
| CUSTOMERS MAY COMPLAIN OF MOISTURE IN HEADLAMP. *YH | |
| Bulletin Number: 15572 | |
| SOME VEHICLES EQUIPPED WITH BELT MINDER MAY EXHIBIT THE BELT MINDER WARNING CHIME STAYING ON AFTER THE DRIVER SEAT BELT BUCKLE HAS BEEN BUCKLED. *TT | |
| Bulletin Number: 15590 | |
| SOME VEHICLES MAY EXHIBIT A BATTERY DRAW AND/OR A DEAD BATTERY CONDITION. *TT | |
| Bulletin Number: 15602 | |
| CONCERNS WITH LOW BRAKE PEDAL/HYDRAULIC CONTROL UNIT BRAKE FLUID LEAK. *TT | |
| Bulletin Number: 15644 | |
| SOME VEHICLES MAY EXHBIT A HARD START/NO START CONDITION WHEN TRYING TO START THE VEHICLE. *TT | |
| Bulletin Number: 15655 | |
| CONCERNS WITH EXCESSIVE SULPHUR SMELL FROM THE EXHAUST WHEN OPERATING UNDER CERTAIN DRIVE MODES. *TT | |
| Bulletin Number: 15689 | |
| SOME VEHICLES MAY EXHIBIT EITHER A VERY HARD OR VERY SOFT CLUTCH PEDAL FEEL. *TT | |
| Bulletin Number: 15715 | |
| SOME VEHICLES MAY EXHIBIT A RATTLE FROM THE REAR WINDOW WHEN DRIVING WITHIN THE VENT POSITION. *TT | |
| Bulletin Number: 15723 | |
| SOME VEHICLES MAY EXHIBIT ADHESIVE EXTRUDING FROM THE HEADLINER MATERIAL AROUND THE MOONROOF. *TT | |
| Bulletin Number: 15754 | |
| SOME VEHICLES EQUIPPED WITH 4.0L ENGINE AND MANUAL TRANSMISSION MAY EXHIBIT AN INTERMITTENT STUMBLE DURING DECELERATION AND / OR AT STOPS WHEN THE CLUTCH PEDAL IS DEPRESSED. *TT | |
| Bulletin Number: 15765 | |
| SOME VEHICLES MAY EXHIBIT WIND NOISE AROUND THE FRONT DOORS, NEAR THE TOP REAR-WARD PORTION OF THE DOOR / GLASS AT HIGHWAY SPEEDS, OR IN A CROSS WIND. *TT | |
| Bulletin Number: 15769 | |
| SOME VEHICLES MAY EXHIBIT A CONDITION OF STEERING WHEEL LEATHER PEELING. *TT | |
| Bulletin Number: 15785 | |
| SOME VEHICLES EQUIPPED WITH 5R55E/5R44E TRANSMISSION MAY EXHIBIT A WHINE NOISE IN 1ST GEAR THAT GOES AWAY AFTER THE 1-2 OR 1-3 SHIFT IS COMPLETED. *TT | |
| Bulletin Number: 15813 | |
| SOME VEHICLES EQUIPPED WITH 4WABS MAY EXHIBIT DIAGNOSTIC TROUBLE CODES C1233 AND C1234 (ANTI-LOCK BRAKE SENSOR OUTPUT FAILURE). *TT | |
| Bulletin Number: 15823 | |
| CONCERNS OF WHINE NOISE FROM PSEAKERS, WITH THE PIONEER ULTIMATE 450 WATT AUDIO RADIO SYSTEM. *TT | |
| Bulletin Number: 15835 | |
| RUNNING CHANGE FOR THE UPPER RADIATOR SIGHT SHIELD. *TT | |
| Bulletin Number: 15859 | |
| SOME VEHICLES WITH 4WABS MAY EXHIBIT DIAGNOSTIC TROUBLE CODES C1233 AND C1234 (ANTI-LOCK BRAKE SENSOR OUTPUT FAILURE). *TT | |
| Bulletin Number: 15861 | |
| SUBJECT REGARDING REAR TRANSMISSION EXTENSION HOUSING OIL SEAL LEAKS. *TT | |
| Bulletin Number: 15863 | |
| SUBJECT REGARDING A WHINE NOISE CONDITION FROM THE SPEAKERS WHEN USING THE RADIO OR THE CD WITH THE PIONEER TREMORE / PIONEER ULTIMATE 450 WATT AUDIO SYSTEM. *TT | |
| Bulletin Number: 15869 | |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT SOFT CLUTCH PEDAL WHICH MAY CAUSE DIFFICULTY IN SHIFTING GEARS (A NOTCHY FEEL). *TT | |
| Bulletin Number: 15887 | |
| SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). *TT | |
| Bulletin Number: 15898 | |
| SOME VEHICLES MAY EXHIBIT A HARD START / NO START CONDITION DUE TO FUEL PRESSURE BLEED DOWN. *TT | |
| Bulletin Number: 15905 | |
| SUBJECT REGARDING PIONEER TREMOR / ULTIMATE 450 WATT AUDIO SYSTEM WHINE NOISE. *TT | |
| Bulletin Number: 15910 | |
| CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION. *TT | |
| Bulletin Number: 15936 | |
| SOME VEHICLES EQUPPED WITH 4.0L ENGINE AND AUTOMATIC TRANSMISSION MAY EXHIBIT A ROUGH IDLE, LOW SPEED ENGINE QUIT, HESITATION ON COLD ENGINE TIP-IN AND / OR HESITATION DURING A 5-3 DONWSHIFT. *TT | |
| Bulletin Number: 16021 | |
| SOME VEHICLES WITH 4WABS MAY EXHIBIT DIAGNOSTIC TROUBLE CODES C1233 AND C1234 (ANTI-LOCK BRAKE SENSOR OUTPUT FAILURES) IN SLIPPERY CONDITIONS. *TT | |
| Bulletin Number: 16038 | |
| SOME VEHICLES EQUIPPED WITH A 5R55E AUTOMATIC TRANSMISSION MAY EXHIBIT A GEAR WHINE TYPE NOISE IN 1ST AND / OR 2ND GEARS ONLY. *TT | |
| Bulletin Number: 16040 | |
| EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT | |
| Bulletin Number: 16111 | |
| SOME VEHICLES BUILT PRIOR TO 12/06/2001 MAY EXHIBIT A POPPING NOISE FROM THE FRONT SUSPENSION WHILE BRAKING OR ON ACCELERATION FROM A STOP. *TT | |
| Bulletin Number: 16113 | |
| SOME VEHICLES BUILT AFTER 03/04/2002 AND EQUIPED WITH A MANUAL TRANSMISSION MAY EXHIBIT A HARD TO SHIFT CONDITION. *TT | |
| Bulletin Number: 16121 | |
| SOME VEHICLES MAY EXHIBIT UNEVEN AND / OR PREMATURE FRONT BRAKE PAD WEAR, PARTICULARLY THE FRONT INSIDE PAD. *TT | |
| Bulletin Number: 16124 | |
| SOME VEHICLES BUILT ON OR AFTER 3/4/2002 MAY EXHIBIT INTERMITTENT ENGINE DRIVEABILITY ISSUES. ENGINEER IS INVESTIGATING. *TT | |
| Bulletin Number: 16134 | |
| INFORMATION ON SERVICING THE MULTIFUNCTION SWITCH ON VEHICLES EQUIPPED WITH TILT STEERING COLUMN. *TT | |
| Bulletin Number: 16253 | |
| EQUIPPED WITH A HARD TONNEAU COVER. * MJ | |
| Bulletin Number: 16395 | |
| SQUEAK NOISE FROM THE REAR STABILIZER BAR LINK. *MJ | |
| Bulletin Number: 16396 | |
| NO START/NO COMMUNICATION-CONTACT REQUEST. *MJ | |
| Bulletin Number: 16402 | |
| FRONT BRAKE WEAR - UNDER INVESTIGATION. *MJ | |
| Bulletin Number: 16424 | |
| NEW TONNEAU COVER LOCK CYLINDER RETAINER CLIPS RELEASED FOR SERVICE. *MJ | |
| Bulletin Number: 16437 | |
| DIAGNOSTIC TROUBLE CODE (DTC) C1233 & C1234 - REPLACE ANTI-LOCK BRAKE SYSTEM EUC. *MJ | |
| Bulletin Number: 16610 | |
| NO START, NO COMMUNICATION WITH POWER TRAIN CONTROL MODULE (PCM) USING WDS/NGS OR A MISS/BUCK/JERK WHILE DRIVING. *TT | |
| Bulletin Number: 16623 | |
| EXCESSIVE FUEL GAUGE FLUCTUATION WHILE DRIVING (QSF). *TT | |
| Bulletin Number: 16735 | |
| VARIOUS NOISE ISSUES FROM THE REAR LEAF SPRINGS WHILE DRIVING. *TT | |
| Bulletin Number: 16761 | |
| SLOW FUEL FILL CONDITION ON CERTAIN VEHICLES BUILT AFTER 3/3/02. *TT | |
| Bulletin Number: 16776 | |
| SERVICING MULTIFUNCTION SWITCH WIRING INTERFERENCE. *TT | |
| Bulletin Number: 16810 | |
| ROUGH IDLE AND/OR CHECK ENGINE LAMP DUE TO CLOSURE HOSE WHICH BECOMES LOOSE OR DISCONNECTED AT THE RIGHT HAND CAM COVER. *TT | |
| Bulletin Number: 16835 | |
| TAILGATE LOCKING BY ITSELF WHEN SLAMMED SHUT OR WHEN THE VEHICLE IS BEING DRIVEN OVER ROUGH ROADS. *TT | |
| Bulletin Number: 17055 | |
| LACKS POWER / BLACK SMOKE / RUNS ROUGH, USUALLY WITH NO MALFUNCTION INDICATOR LAMP ON OR DIAGNOSTIC TROUBLE CODES. *TT | |
| Bulletin Number: 17167 | |
| MULTIPLE VEHICLES WITH 3.0L OR 4.0L ENGINES LACKS POWER/RUNS ROUGH/BLACK SMOKE. 2004 SPORT TRAC INCLUDED. *TT | |
| Bulletin Number: 17172 | |
| VIBRATION/MOAN CONDITION WHILE DRIVING AT HIGHWAY SPEEDS (75-80 MPH) ON 4X4 VEHICLES EQUIPPED WITH A 4.10 AXLE RATIO. 2004 SPORT TRAC INCLUDED. *TT *MJ | |
| Bulletin Number: 17198 | |
| WEAR-THROUGH CONDITION ON THE ABRASION SLEEVE OF THE UPPER RADIATOR HOSE NEAR THE AIR CONDITIONING ACCUMULATOR OR TRANSMISSION FLUID DIPSTICK. *TT | |
| Bulletin Number: 17231 | |
| ANTI-LOCK BRAKE SYSTEM (ABS) LIGHT FLASHING WITH DIAGNOSTIC TROUBLE CODE (DTC) B2477 AFTER REPLACEMENT OF THE ABS MODULE. *TT | |
| Bulletin Number: 17253 | |
| WATER LEAK NEAR THE ROOF OPENING PANEL. 2004 EXPLORER SPORT TRAC INCLUDED. *TT | |
| Bulletin Number: 17254 | |
| CLICKING/POPPING NOISE FROM UPPER STEERING COLUMN AREA WHEN TURNING. 2004 E SERIES AND EXPLORER SPORT TRAC ALSO INCLUDED. *TT | |
| Bulletin Number: 17280 | |
| GENERATOR WHISTLE/HOOT NOISE IN COLD AMBIENT TEMPERATURES. *TT | |
| Bulletin Number: 17376 | |
| LACKS POWER/RUNS ROUGH/BLACK SMOKE CONDITION. *TT | |
| Bulletin Number: 17378 | |
| INTERMITTENT ENGINE DRIVEABILITY ISSUES. VEHCLES WITH AUTOMATIC TRANSMISSION BUILT BETWEEN 03/04/2002 AND 12/01/2002. *TT | |
| Bulletin Number: 17379 | |
| ROUGH IDLE, HESITATION ON COLD ENGINE TIP-IN AND/OR HESITATION DURING A 5-3 DOWNSHIFT. *TT | |
| Bulletin Number: 17544 | |
| GENERATOR NOISE IN COLD AMBIENT TEMPERATURES. *MJ | |
| Bulletin Number: 17647 | |
| PAINT PEELING AND/OR BUBBLING ON THE CENTER FINISH PANEL OF THE INSTRUMENT PANEL. *TT | |
| Bulletin Number: 17777 | |
| REAR LEAF SPRING NOISE. *TT | |
| Bulletin Number: 18719 | |
| MALFUNCTION INDICATOR LAMP COMING ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0172, P0174 AND/OR P0175 (FUEL SYSTEM TOO RICH OR LEAN). *TT | |
| Bulletin Number: 870197 | |
| INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT | |
| 2002 FORD F-150 | |
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01157 | |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| Bulletin Number: 01181 | |
| BRAKE SHIFT INTERLOCK.*JB | |
| Bulletin Number: 01205 | |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT | |
| Bulletin Number: 012113 | |
| SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL | |
| Bulletin Number: 01215 | |
| A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTER OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 01T04 | |
| INFORMATION REGARDING IMRC SET SCREW WARRANTY REPAIR.*JB | |
| Bulletin Number: 020503 | |
| GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996. *TT UPDATE. *TT | |
| Bulletin Number: 021003 | |
| SOME BI-FUEL CNG VEHICLES MAY EXHIBIT A CRANK NO START CONDITION WHILE OPERATING IN ALTERNATE FUEL MODE WITH THE ALT FUEL LIGHT ON. *TT | |
| Bulletin Number: 02103 | |
| SOME BI-FUEL CNG VEHICLES MAY EXHIBIT A CRANK NO START CONDITION WHILE OPERATING IN ALTERNATE FUEL MODE, WITH THE ALT FUEL LIGHT ON. *TT | |
| Bulletin Number: 02104 | |
| SOME BI-FUEL LPG VEHICLES MAY EXHIBIT A NO START, ROLLING IDLE, SURGING IDLE AND / OR SURGE AT CRUISE CONDITION IN LPG MODE WITH ALT FUEL GREEN LIGHT ON. *TT | |
| Bulletin Number: 02105 | |
| SOME BI-FUEL CANG AND LPG VEHICLES MAY EXHIBIT A NO START CONDITION. *TT | |
| Bulletin Number: 02108 | |
| SOME VEHICLES EQUIPPED WITH THE 5.4L 2V ENGINE MAY EXHIBIT A WHISTLING NOISE FROMTHE FORMED NYLON TUBE INTHE IDLE-AIR BYPASS FLOW CIRCUIT. *TT | |
| Bulletin Number: 02121 | |
| WHITE FLAKES COMING FROM THE AIR CONDITIONER VENTS WHEN THE BLOWER MOTOR IS ENGAGED. *TT | |
| Bulletin Number: 0214 | |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| Bulletin Number: 02177 | |
| COOLING SYSTEM-MOTORCRAFT PREMIUM GOLD ENGINE COOLANT-SERIVCE TIPS. *MJ | |
| Bulletin Number: 02193 | |
| DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ | |
| Bulletin Number: 02215 | |
| HEAVY STATIC OR SIGNAL LOSS ON TWO WAY RADIO COMMUNICATION . BI FUEL LPG VEHICLE ONLY. *EH | |
| Bulletin Number: 02221 | |
| ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ | |
| Bulletin Number: 02227 | |
| ENGINE-CYLINDER HEAD DECK LEAK-4.6 AND 5.4L ENGINES-NEW SERVICE-ONLY GASKET AND CYLINDER HEAD KITS AVAILABILITY. *MJ | |
| Bulletin Number: 0241 | |
| SUBJECT REGARDING IDLER ARM REPLACEMENT SPECIFICATIONS. *TT | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0253 | |
| SUBJECT REGARDING ALTERNATIVE FUEL VEHICLE COMPRESSED NATURAL GAS TANK INSPECTION. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 0258 | |
| INOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639. *TT | |
| Bulletin Number: 030402 | |
| ON SOME DEDICATED CNG VEHICLES, A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE. REVISED SERVICE PARTS. *TT | |
| Bulletin Number: 03102 | |
| COMPRESSED NATURAL GAS (CNG). ROUGH IDLE OR NO START WHEN COLD. VEHICLES EQUIPPED WITH CNG BI-FUEL ENGINE ONLY. *TT | |
| Bulletin Number: 03103 | |
| VEHICLES WITHOUT THE COOLANT LOCK-OFF MAY EXHIBIT A NO START CONDITION. *TT | |
| Bulletin Number: 031404 | |
| ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. | |
| Bulletin Number: 03144 | |
| ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 03148 | |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 031513 | |
| TIE ROD END INSPECTION PROCEDURE. *TT | |
| Bulletin Number: 03164 | |
| SOME VEHICLES, EQUIPPED WITH THE 4.6L 2V ENGINE, WITH AN ENGINE BUILD DATE PRIOR TO 8/29/03 MAY EXHIBIT AN ENGINE TICK NOISE THAT IS PRESENT AT ALL TEMPERATURES DURING IDLE. 2004 MODELS INCLUDED. *TT | |
| Bulletin Number: 03183 | |
| DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY. *TT | |
| Bulletin Number: 03206 | |
| SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY. LOSS OF POWER AT HEAVY LOAD, DIAGNOSTIC TROUBLE CODES (DTCS) FOR LEAN FUEL, ROUGH IDLE, HARD START, | |
| Bulletin Number: 03207 | |
| A VIBRATION AND/OR RATTLE CONDITION WHEN THE ENGINE IS AT IDLE IN GEAR OR WHEN ACCELERATING FROM A SLOW SPEED 32 KM/H (20 MPH). *TT | |
| Bulletin Number: 0322 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT | |
| Bulletin Number: 03223 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| Bulletin Number: 03235 | |
| BED EXTENDER COMPONENT REPLACEMENT SERVICE TIP. *TT | |
| Bulletin Number: 0324 | |
| DRIVER'S SIDE DOOR GLASS THAT BINDS WHEN OPERATED. *TT | |
| Bulletin Number: 03256 | |
| ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003. *MJ | |
| Bulletin Number: 0342 | |
| POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE, ON SOME DEDICATED CNG VEHICLES. *TT *JB | |
| Bulletin Number: 0361 | |
| MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB | |
| Bulletin Number: 03610 | |
| TIE ROD END INSPECTION PROCEDURE. CANADA VEHICLES ONLY. *TT *JB | |
| Bulletin Number: 03910 | |
| VIBRATION AND/OR RATTLE CONDITION WHEN THE ENGINE IS AT IDLE IN GEAR OR WHEN ACCELERATING FROM A SLOW SPEED (20 MPH, 32 KM/H). *TT | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 0399 | |
| TIE ROD END INSPECTION PROCEDURE. *TT | |
| Bulletin Number: 04111 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. | |
| Bulletin Number: 0416 | |
| DRIVELINE CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE ACCELREATION AND/OR BRAKING. *TT | |
| Bulletin Number: 041601 | |
| WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04217 | |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 0422 | |
| WINDNOISE AND/OR A WATER LEAK FROM THE SLIDING BACK GLASS AREA. *TT | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 04251 | |
| ALUMINUM CORROSION - SERVICE TIP. *TT | |
| Bulletin Number: 04266 | |
| A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP. *TT | |
| Bulletin Number: 0457 | |
| POP/THUMP NOISE AT END OF WINDOW MOVEMENT AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION. *TT | |
| Bulletin Number: 0483 | |
| SPLICING NEW WIRE(S) INTO EXISTING ELECTRICAL HARNESS. SERVICE PROCEDURE. *TT | |
| Bulletin Number: 04L19 | |
| CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE. *TT | |
| Bulletin Number: 050618 | |
| REAR AXLE NOISE REPAIR. *SC | |
| Bulletin Number: 05173 | |
| MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P1131 AND/OR P1151 - 4.2L ENGINE. *TT | |
| Bulletin Number: 05417 | |
| INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT | |
| Bulletin Number: 0554 | |
| USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE. *TT | |
| Bulletin Number: 05618 | |
| REAR AXLE NOISE REPAIR. *TT | |
| Bulletin Number: 07212 | |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE | |
| Bulletin Number: 14916 | |
| SOME SUPERCREWS ARE EQUIPPED WITH A DIGITAL MEMO RECORDER MOUNTED ON THE DRIVER'S SIDE SUN VISOR WHICH ALLOWS MEMOS TO BE RECORDED, THEN PLAYED BACK AT A LATER TIME AS A PERSONAL REMINDER. TO ENSURE THAT ANY UNINTENDED MESSAGES ARE NOT LE | |
| Bulletin Number: 15255 | |
| CONCERNS WITH DIAGNOSTIC TROUBLE CODES P1516, P1518, P1519, AND P1520. *TT | |
| Bulletin Number: 15259 | |
| CONCERNS WITH THE LOWER POWER IN HIGH AMBIENT TEMEPRATURES. *TT | |
| Bulletin Number: 15271 | |
| DEDICATED CNG REGULATOR BOWL KIT AVAILABLE. *JG | |
| Bulletin Number: 15324 | |
| SOME VEHICLES MAY EXHIBIT A HIGHER THAN NORMAL BASE IDLE SPEED WHEN THE VEHICLE IS INITIALLY RECEIVED FROM THE ASSEMBLY PLANT. *TT | |
| Bulletin Number: 15344 | |
| SOME VEHICLES EQUIPPED WITH A 4.6L ENGINE AND AUTOMATIC TRANSMISSION MAY EXHIBIT A HIGHER THAN NORMAL IDLE CONDITION, HOT OR COLD. *TT | |
| Bulletin Number: 15409 | |
| SOME VEHICLES MAY EXHIBIT A HIGHER THAN NORMAL BASE IDLE SPEED WHEN INITIALLY RECEIVED FROM THE ASSEMBLY PLANT. *TT | |
| Bulletin Number: 15431 | |
| EXHIBITING LACK OF POWER CONDITION WHEN VEHICLE IS OPERATED IN AMBIENT TEMPERATURES. *TT | |
| Bulletin Number: 15502 | |
| CONCERNS WITH POP/CLUNK/CLICK NOISE FROM THE FRONT SUSPENSION WHEN MAKING LOW-SPEED TURNS IN FORWARD OR REVERSE GEARS. *TT | |
| Bulletin Number: 15692 | |
| SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT | |
| Bulletin Number: 15707 | |
| INFORMATION ON VEHICLE EXHIBITING EVIDENCE OF OIL IN THE AIR INTAKE SYSTEM. *TT | |
| Bulletin Number: 15711 | |
| SOME VEHICLES EQUIPPED WITH A 5-SPEED MAZDA R2 MANUAL TRANSMISSION MAY EXHIBIT A HIGH EFFORT CONDITION WHEN SHIFTING ANY GEAR. *TT | |
| Bulletin Number: 15742 | |
| INFORMATION ON VEHICLES EXHIBITING A PERCEIVED POOR FUEL RANGE / ECONOMY, AND OR A FAULTY FUEL GAUGE. *TT | |
| Bulletin Number: 15758 | |
| SNOW PACKING OF THE AIR FILTER WHEN DRIVING IN SEVERE SNOW CONDITIONS MAY EXHIBIT LOSS OF POWER AND / OR THE MALFUNCTION INDICATOR LAMP ILLUMINATING. *TT | |
| Bulletin Number: 15805 | |
| SOME SUPER CREW VEHICLES MAY EXHIBIT LOOSE, POOR FITTING, OR WRINKLED SEAT COVER UPHOLSTERY. *TT | |
| Bulletin Number: 15817 | |
| SOME VEHICLES EQUIPPED WITH BI-FUEL (CNG/LPG) ALTERNATE FUEL ENGINES MAY EXHIBIT HARD / NO START, RUNS ROUGH OR MISSES AFTER STARTING, AND OR HESITATION ON ACCELERATION WHEN OPERATED IN THE BI-FUEL MODE. *TT | |
| Bulletin Number: 15869 | |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT SOFT CLUTCH PEDAL WHICH MAY CAUSE DIFFICULTY IN SHIFTING GEARS (A NOTCHY FEEL). *TT | |
| Bulletin Number: 15913 | |
| SOME VEHICLES EQUIPPED WITH 5.4L V8 ENGINE MAY EXHIBIT AIR INDUCTION SYSTEM CONDITIONS AS WELL AS ENGINE HESITATION / SURGE AND / OR A MALFUNCTION INDICATOR LAMP ILLUMINATED. *TT | |
| Bulletin Number: 15932 | |
| SOME VEHICLES EQUIPPED WITH 4.2L, 4.6L AND 5.4L ENGINE MAY EXHIBIT A LACK OF POWER CONDITION. *TT | |
| Bulletin Number: 16019 | |
| SOME LIGHTNING AND HARLEY DAVIDSON SUPERCREWS MAY EXHIBIT CHECK ENGINE LIGHT ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0171 OR P0174. *TT | |
| Bulletin Number: 16025 | |
| INFORMATION ON REMOVING STICKER FROM SEAT BELT. *TT | |
| Bulletin Number: 16030 | |
| SOME VEHICLES MAY EXHIBIT AN ILLUMINATED MALFUNCTION INDICATOR LAMP ALONG WITH DIAGNOSTIC TROUBLE CODE P0316 (MISFIRE OCCURED IN THE FIRST 1000 ENGINE REVOLUTIONS). *TT | |
| Bulletin Number: 16033 | |
| SOME VEHICLES WITH ELECTRONIC SHIFT-ON-THE FLY MAY EXHIBIT AN INADVERTENT 4X4 LOW ENGAGEMENT WHILE DRIVING. *TT | |
| Bulletin Number: 16087 | |
| SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES P0740, P0741, P0743, AND P1744 (TORQUE CONVERTER CLUTCH). *TT | |
| Bulletin Number: 16105 | |
| SOME VEHICLES EQUIPPED WITH A 4.6/5.4L ENGINE MAY EXHIBIT AN ILLUMINATED MALFUNCTION INDICATOR LAMP ALONG WITH DIAGNOSTIC TROUBLE CODE P0316 STORED. *TT | |
| Bulletin Number: 16170 | |
| SOME VEHICLES EQUIPPED WITH A 4R100 TRANSMISSION AND BUILT BETWEEN JANUARY 1, 2001 AND MAY 1, 2002 MAY EXHIBIT FLASHING TRANSMISSION CONTROL INDICATOR LAMP AND ANY OR ALL TORQUE CONVERTER CLUTCH DIAGNOSTIC TROUBLE CODES P0740, P0741, P0743, | |
| Bulletin Number: 16172 | |
| SOME VEHICLES WITH 4-WHEEL DISC BRAKES MAY EXHIBIT A MOAN FROM THE REAR BRAKES ON LIGHT BRAKE APPLICATIONS. *TT | |
| Bulletin Number: 16393 | |
| ROLLING IDLE/POOR FUEL ECONOMY. *MJ | |
| Bulletin Number: 16400 | |
| REAR AXLE SEAL LEAK - CONTACT REQUEST. *MJ | |
| Bulletin Number: 16416 | |
| NO/HARD START IN COLD AMBIENTS / NEW TWO-PIECE BLOCK HEATER CORD RELEASED. *MJ | |
| Bulletin Number: 16602 | |
| LOCKING TAILGATE LOCKS ITSELF. *TT | |
| Bulletin Number: 16605 | |
| REDUCED POWER STEERING ASSIST AND/OR POWER STEERING LEAKS WHEN DRIVEN IN TEMPERATURES EQUAL TO OR LESS THAN -25 DEGREES CELCIUS. *TT | |
| Bulletin Number: 16776 | |
| SERVICING MULTIFUNCTION SWITCH WIRING INTERFERENCE. *TT | |
| Bulletin Number: 16818 | |
| THROTTLE CONTROL SPLASH SHIELD INSTALLATION REQUIREMENTS. *TT | |
| Bulletin Number: 16835 | |
| TAILGATE LOCKING BY ITSELF WHEN SLAMMED SHUT OR WHEN THE VEHICLE IS BEING DRIVEN OVER ROUGH ROADS. *TT | |
| Bulletin Number: 16899 | |
| ROLLING IDLE AFTER SHIFTING TO PARK OR NEUTRAL, FROM DRIVE OR REVERSE, WHEN THE ENGINE TEMPERATURE IS 100 - 140 DEGREES F. *TT | |
| Bulletin Number: 16928 | |
| VARIOUS INTERMITTENT ELECTRICAL CONCERNS INCLUDING BUT NOT LIMITED TO SOME ACCESSORIES REMAINING POWERED UP WITH THE KEY OUT OF THE IGNITION, MULTIPLE SYSTEM WARNING LIGHTS WITH SHORT TO POWER OR LOW BATTERY VOLTAGE DIAGNOSTIC TROUBLE CODES | |
| Bulletin Number: 16969 | |
| DAMAGED REAR LICENSE PLATE LAMPS DUE TO ROCKS AND/OR GRAVEL HITTING THE LAMP ASSEMBLIES. *TT | |
| Bulletin Number: 17009 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH NO HARD FAULT. *TT | |
| Bulletin Number: 17063 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTC) P0171, OR P0174. F150 LIGHTING AND F150 HARLEY DAVIDSON SUPERCREW. *TT | |
| Bulletin Number: 17064 | |
| WHINE / HOWL FROM REAR AXLE. *TT | |
| Bulletin Number: 17086 | |
| NOISE FROM THE FRONT END OF THE VEHICLE WHICH APPEARS TO BE COMING FROM THE STEERING IDLER ARM. *TT | |
| Bulletin Number: 17087 | |
| WHINE/HOWL FROM REAR AXLE 40 TO 60 MPH. *TT | |
| Bulletin Number: 17104 | |
| TICKING/TAPPING NOISE WITH THE ENGINE WARMED UP AND THE TRANSMISSION IN GEAR AT IDLE. 2003 E150 INCLUDED. *TT | |
| Bulletin Number: 17259 | |
| ROUGH IDLE AND/OR MISFIRE WITH DIAGNOSTIC TROUBLE CODE P0316 AFTER AN OVERNIGHT SOAK IN EXTREME COLD AND HIGH HUMIDITY CONDITIONS. *TT | |
| Bulletin Number: 17306 | |
| AIR CONDITIONER CONDENSATE LEAK ON PASSENGER FLOOR. *TT | |
| Bulletin Number: 17316 | |
| FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP. *TT | |
| Bulletin Number: 17320 | |
| BROKEN EXHAUST MANIFOLD STUDS. *TT | |
| Bulletin Number: 17346 | |
| STEERING IDLER ARM NOISE. *TT | |
| Bulletin Number: 17372 | |
| HERITAGE F-150 4X2 WITH 8.8 INCH REAR AXLE - WHINE/HOWL NOISE FROM REAR AXLE. *MJ | |
| Bulletin Number: 17655 | |
| EVIDENCE OF OIL IN THE AIR INTAKE SYSTEM. *TT | |
| Bulletin Number: 17656 | |
| CD OR CD6 RADIO OVERHEATING. *TT | |
| Bulletin Number: 17702 | |
| AXLE WHINE 40-60 MPH. *TT | |
| Bulletin Number: 17731 | |
| WHINE FROM POWER STEERING. *TT | |
| Bulletin Number: 17777 | |
| REAR LEAF SPRING NOISE. *TT | |
| Bulletin Number: 17823 | |
| POWER STEERING LEAK - SERVICE TIP. *TT | |
| Bulletin Number: 17905 | |
| MULTIPLE VEHICLES USING FEHP REAR AXLE FLUID. FLUID USAGE CHANGE. *TT | |
| Bulletin Number: 18217 | |
| MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT | |
| Bulletin Number: 18250 | |
| INTERMITTENT CLUNK ON 3-2 DOWNSHIFT DURING COASTDOWN/TIP-IN. OASIS. TO INCLUDE 2005 F-150, E-SERIES AND EXPEDITION. *TT | |
| Bulletin Number: 18466 | |
| AXLE WHINE HOWL. THIS INCLUDES 1997-05 FORD VEHICLES. *EH | |
| Bulletin Number: 20228 | |
| 1999-2008 7.3L/6.0L/6.4L/4.5L DIESEL F-SUPER DUTY - CLEAN THE CHARGE AIR COOLER (CAC) SYSTEM AFTER CERTAIN TURBO OR ENGINE FAILURES - SERVICE TIP. *NJ | |
| Bulletin Number: 870197 | |
| INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT | |
| Bulletin Number: 99263 | |
| CORRECT LUG NUT TORQUE SPECIFICATIONS - INCREASE WHEEL NUT AND STUD SIZE - SERVICE TIP. *TT | |
| Bulletin Number: TSB-14-0147 | |
| FORD/LINCOLN: SAFETY RECALL ISSUED DUE TO ONE OR BOTH FUEL TANK STRAPS FRACTURING DUE TO BEING IN HIGH CORROSION AREAS FOR AN EXTENDED PERIOD AND DISLODGING FUEL TANK. MODEL 1997-99 F250, 1997-03 F150, 2004 F150 HERITAGE, 2002-2003 BLACKW | |
| Bulletin Number: TSB-14-0164 | |
| FORD/LINCOLN: SAFETY RECALL REGARDING HIGH CORROSION AREAS FOR OPERATING, FOR AN EXTENDED TIME, VEHICLES WHERE BOTH OR ONE STRAP OF FUEL TANK CAN FRACTURE, AFTER CONTACTING GROUND. MODEL 1997-99 F250 LD, 1997-03 F150, 2004 F150 HERITAGE, | |
| 2002 FORD F-250 | |
| Bulletin Number: 010901 | |
| SUBJECT PERTAINING TO PASSENGER SEAT MISBUILD.*JB | |
| Bulletin Number: 02177 | |
| COOLING SYSTEM-MOTORCRAFT PREMIUM GOLD ENGINE COOLANT-SERIVCE TIPS. *MJ | |
| Bulletin Number: 02227 | |
| ENGINE-CYLINDER HEAD DECK LEAK-4.6 AND 5.4L ENGINES-NEW SERVICE-ONLY GASKET AND CYLINDER HEAD KITS AVAILABILITY. *MJ | |
| Bulletin Number: 02E20 | |
| SUBJECT REGARDING DEMONSTRATION/ DELIVERY HOLD: POWERTRAIN CONTROL MODULE REPROGRAMMING. *JG | |
| Bulletin Number: 03911 | |
| ROUGH IDLE AND/OR HESITATION WHEN ACCLERATING ON CERTAIN SUPER DUTY VEHICLES EQUIPPED WITH A 5.4L OR 6.8L ENGINE. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04217 | |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04236 | |
| VEHICLE LEAN SAG WHEN OBSERVED FROM REAR OF VEHICLE. *EH | |
| Bulletin Number: 042411 | |
| MEMONTARY RETURN TO IDLE DURING AGGRESSIVE ACCELERATION - DIAGNOSTIC TROUBLE CODE (DTC) P0123. *TT | |
| Bulletin Number: 0471 | |
| WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT | |
| Bulletin Number: 15297 | |
| SOME VEHICLES MAY EXHIBIT AN INOPERATIVE SIDE POWER MIRROR CONDITION. *TT | |
| Bulletin Number: 15311 | |
| SOME 4X4 VEHICLES MAY EXHIBIT A CRANK NO START CONDITION. *TT | |
| Bulletin Number: 15566 | |
| SOME VEHICLES MAY EXHIBIT A TACKY SURFACE ON THE INSTRUMENT PANEL (IP). *TT | |
| Bulletin Number: 15574 | |
| SOME VEHICLES MAY EXHIBIT A DIFFICULTY IN PROGRAMMING THE KEY FOB(S). *TT | |
| Bulletin Number: 15711 | |
| SOME VEHICLES EQUIPPED WITH A 5-SPEED MAZDA R2 MANUAL TRANSMISSION MAY EXHIBIT A HIGH EFFORT CONDITION WHEN SHIFTING ANY GEAR. *TT | |
| Bulletin Number: 15742 | |
| INFORMATION ON VEHICLES EXHIBITING A PERCEIVED POOR FUEL RANGE / ECONOMY, AND OR A FAULTY FUEL GAUGE. *TT | |
| Bulletin Number: 15904 | |
| SOME VEHICLE EQUIPPED WITH A 4.6L ENGINE WITHOUT AIR CONDITIONING MAY EXHIBIT A NO START CONDITION. *TT | |
| Bulletin Number: 15932 | |
| SOME VEHICLES EQUIPPED WITH 4.2L, 4.6L AND 5.4L ENGINE MAY EXHIBIT A LACK OF POWER CONDITION. *TT | |
| Bulletin Number: 15938 | |
| INFORMATION USED WHEN REPLACING THE DRIVERS SEAT MODULE. *TT | |
| Bulletin Number: 16291 | |
| LOUD SQUEALING NOISE FROM THE ENGINE AREA WHEN THE ENGINE FAN CLUTCH IS UNDER LOAD WHILE OPERATED IN HOT DUSTY CLIMATES. VEHICLES EQUIPPED WITH A 7.3L ENGINE. *TT | |
| Bulletin Number: 16403 | |
| ENGINE-LIGHT TICK OR RATTLE TYPE NOISE FROM ENGINE AFTER COLD START. *MJ | |
| Bulletin Number: 16515 | |
| OIL LEAK AT HIGH PRESSURE PUMP FITTINGS AND/OR PLUG. THIS INCLUDES SUPER DUTY F-SERIES. OASIS. *TT | |
| Bulletin Number: 16589 | |
| GRADUAL LOSS OF POWER AT CRUISE. USE FUEL ADDITIVE TO PREVENT HIS CONDITION. ALL SUPER DUTY F-SERIES 1999-2003 INCLUDED. OASIS *TT | |
| Bulletin Number: 16915 | |
| EXCESSIVE DRIVE-AWAY SHUDDER OR VIBRATION UNDER MODERATE TO HEAVY ACCELERATION FROM A STOP. *TT | |
| Bulletin Number: 17009 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH NO HARD FAULT. *TT | |
| Bulletin Number: 17307 | |
| SQUEAKING NOISE COMING FROM THE UPPER DOOR SEAL WHEN DRIVING OVER BUMPS. F250 MODEL INCLUDES 1999-2004 SUPER DUTY F-SERIES. *TT | |
| Bulletin Number: 17554 | |
| OIL/DUST FILM AT CAC CONNECTIONS. *MJ | |
| Bulletin Number: 17603 | |
| AIR BAG LIGHT ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B1871 OR B1935 FOLLOWING ECS/RCM REPLACEMENT. *TT | |
| Bulletin Number: 18217 | |
| MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT | |
| Bulletin Number: 18223 | |
| VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST. OASIS. TO ALSO INCLUDE 2005 SUPER DUTY F-SERIES, EXCURSION, AND F650/750. *TT | |
| Bulletin Number: 18376 | |
| A COLD WEATHER REVERSE ENGAGEMENT STALL. *TT | |
| Bulletin Number: 18406 | |
| SERVICE TIPS BEFORE ARC WELDING ON THE FRAME OR BODY OF A UNIT. *TT | |
| 2002 FORD F-250 SD | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04185 | |
| FRONT HUBS NOT ENGAGING, NOT STAYING ENGAGED AND/OR UNLOCKING. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04227 | |
| DRIVE AWAY SHUDDER OR VIBRATION. *EH | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 05174 | |
| VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST MODE. *TT | |
| Bulletin Number: 05188 | |
| SERVICE KIT AVAILABLE FOR WIPER MOTOR WIRING. *TT | |
| Bulletin Number: 06177 | |
| ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS. *KB | |
| Bulletin Number: 071110 | |
| BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ | |
| Bulletin Number: 15109 | |
| A COLD WEATHER REVERSE ENGAGEMENT STALL. *YD | |
| Bulletin Number: 15328 | |
| CONCERNS WITH RATTLE NOISE ORIGINATING FROM THE FRONT BRAKE CALIPERS. *TT | |
| Bulletin Number: 15525 | |
| INFORMATION REGARDING A RATTLE NOISE ORIGINATING FROM THE FRONT BRAKE CALIPER.*YD | |
| Bulletin Number: 15579 | |
| SOME VEHICLES MAY EXHIBIT CALIPER PIN RATTLE NOISE ORIGINATING FROM THE FRONT BRAKE CALIPERS. *TT | |
| Bulletin Number: 15661 | |
| CONCERNS WITH RATTLE NOISES COMING FROM FRONT BRAKE CALIPERS. *TT | |
| Bulletin Number: 15798 | |
| SOME VEHICLES EQUIPPED WITH A 7.3L DI, 4R100 TRANSMISSION AND BUILT BEFORE DECEMBER 10, 2001 MAY REMAIN IN 2ND GEAR WITH THE GEAR SHIFT LEVER IN THE FIRST GEAR POSITION. *TT | |
| Bulletin Number: 15810 | |
| SOME VEHICLES MAY EXHIBIT INOPERATIVE POWER MIRRORS. *TT | |
| Bulletin Number: 15843 | |
| SOME VEHICLES MAY EXHIBIT STEERING WHEEL CLEAR VIEW CONDITION. *TT | |
| Bulletin Number: 15849 | |
| SOME VEHICLES BUILT FROM 12/01/2001 TO 02/08/2002 MAY EXHIBIT A BROKEN DOOR HANDLE RIVET. *TT | |
| Bulletin Number: 16136 | |
| SOME VEHICLES MAY EXHIBIT A REPEAT STARTER FAILURE CONDITION. *TT | |
| Bulletin Number: 17316 | |
| FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP. *TT | |
| Bulletin Number: 17406 | |
| LOW POWER, POOR FUEL ECONOMY, FUEL GELLING COLD, EXCESSIVE WHITE SMOKE COLD, OR HARD START. *MJ THIS OASIS UPDATES PREVIOUS OASIS DATED 12/01/03. *TT | |
| Bulletin Number: 17571 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT | |
| Bulletin Number: 17784 | |
| DOOR AJAR LIGHT WORKING IMPROPERLY AFTER VEHICLE SECURITY MODULE REPLACEMENT. *TT | |
| Bulletin Number: 17822 | |
| MANUAL TRANSMISSION FLUID LEAK. *TT | |
| Bulletin Number: 17829 | |
| TRANSFER CASE SHIFT ISSUES ON VEHICLES WITH AN ELECTRONIC SHIFT ON THE FLY (ESOF) TRANSFER CASE. *TT | |
| Bulletin Number: 18735 | |
| HEADLIGHT ADJUSTMENT - CHASSIS CAB INCOMPLETE VEHICLES. *TT | |
| Bulletin Number: 19621 | |
| LACK OF POWER DUE TO LOW FUEL PRESSURE, FUEL TANK LINER SEPERATION. *KB | |
| Bulletin Number: 19728 | |
| LACK OF POWER DUE TO LOW FUEL PRESSURE - FUEL TANK LINER SEPERATION. *KB | |
| Bulletin Number: 20052 | |
| 1999-2008 F250-F550 SUPER DUTY 4X4 WITH ELECTRONIC SHIFT TRANSFER CASE NOT ENGAGING 4X4. *NJ | |
| Bulletin Number: 20228 | |
| 1999-2008 7.3L/6.0L/6.4L/4.5L DIESEL F-SUPER DUTY - CLEAN THE CHARGE AIR COOLER (CAC) SYSTEM AFTER CERTAIN TURBO OR ENGINE FAILURES - SERVICE TIP. *NJ | |
| Bulletin Number: ASI-44408 | |
| FORD: THE RESTRAINT CONTROL MODULE (RCM) WHEN USING VCM II, WOULD HAVE AN ERROR CODE 35 AND DIAGNOSTIC TROUBLE CODE (DTC) B1035, AND DIFFICULTY ATTEMPTING PROGRAMMABLE MODULE INSTALLATION (PMI). MODEL 2001-2004 F-SUPER DUTY. *PE | |
| Bulletin Number: DOR-B8H4Z-11 | |
| This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly ma | |
| Bulletin Number: LP-09L02 | |
| FORD TRUCKS SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. VEHICLES HAVE EXPERIENCED SEVERE STEERING WHEEL AND FRONT WHEEL VIBRATIONS AND OSCILLATIONS AFTER TRAVELING OVER A BUMP OR DIP IN THE ROAD. MODELS 2006 F-250/350 SU | |
| 2002 FORD F-350 | |
| Bulletin Number: 010901 | |
| SUBJECT PERTAINING TO PASSENGER SEAT MISBUILD.*JB | |
| Bulletin Number: 02177 | |
| COOLING SYSTEM-MOTORCRAFT PREMIUM GOLD ENGINE COOLANT-SERIVCE TIPS. *MJ | |
| Bulletin Number: 02227 | |
| ENGINE-CYLINDER HEAD DECK LEAK-4.6 AND 5.4L ENGINES-NEW SERVICE-ONLY GASKET AND CYLINDER HEAD KITS AVAILABILITY. *MJ | |
| Bulletin Number: 02E20 | |
| SUBJECT REGARDING DEMONSTRATION/ DELIVERY HOLD: POWERTRAIN CONTROL MODULE REPROGRAMMING. *JG | |
| Bulletin Number: 031603 | |
| REAR AXLE POPPING/CHATTER NOISE - DANA 80 MODEL DUAL REAR WHEEL (DRW). *AR | |
| Bulletin Number: 03163 | |
| SOME VEHICLES EQUIPPED WITH THE DUAL REAR WHEEL (DRW) REAR AXLE MAY EXHIBIT A TACTILE POPPING OR AUDIBLE CHATTERING NOISE. THIS POPPING NOISE/FEEL RESULTS FROM THE CLUTCH PLATES AND DISCS (IN THE LIMITED SLIP DIFFERENTIAL CASE) STICKING AN | |
| Bulletin Number: 03174 | |
| STEERING WHEEL FIGHT AFTER RIDING OVER BUMPS/RUTS. 2003, 2004 F450 AND F550 MODELS INCLUDED. *TT | |
| Bulletin Number: 03911 | |
| ROUGH IDLE AND/OR HESITATION WHEN ACCLERATING ON CERTAIN SUPER DUTY VEHICLES EQUIPPED WITH A 5.4L OR 6.8L ENGINE. *TT | |
| Bulletin Number: 04236 | |
| VEHICLE LEAN SAG WHEN OBSERVED FROM REAR OF VEHICLE. *EH | |
| Bulletin Number: 042411 | |
| MEMONTARY RETURN TO IDLE DURING AGGRESSIVE ACCELERATION - DIAGNOSTIC TROUBLE CODE (DTC) P0123. *TT | |
| Bulletin Number: 0471 | |
| WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT | |
| Bulletin Number: 15221 | |
| SOME VEHICLES EQUIPPED WITH 5.4L GAS ENGINE MAY EXHIBIT A DIAGNOSTIC TROUBLE CODE B1345 RETRIEVED DURING SELF TEST FROM THE TO HEC MODULE (INSTRUMENT PANEL). *TT | |
| Bulletin Number: 15240 | |
| SOME DRWS EQUIPPED WITH ANGLED BRASS VALVE STEMS MAY EXHIBIT A VALVE CORE THAT STICKS OPEN WHEN ACTUATED. *TT | |
| Bulletin Number: 15297 | |
| SOME VEHICLES MAY EXHIBIT AN INOPERATIVE SIDE POWER MIRROR CONDITION. *TT | |
| Bulletin Number: 15311 | |
| SOME 4X4 VEHICLES MAY EXHIBIT A CRANK NO START CONDITION. *TT | |
| Bulletin Number: 15566 | |
| SOME VEHICLES MAY EXHIBIT A TACKY SURFACE ON THE INSTRUMENT PANEL (IP). *TT | |
| Bulletin Number: 15574 | |
| SOME VEHICLES MAY EXHIBIT A DIFFICULTY IN PROGRAMMING THE KEY FOB(S). *TT | |
| Bulletin Number: 15687 | |
| CERTAIN SUPER DUTY VEHICLES EQUIPPED WITH LPG ENGINE MAY EXHIBIT A DEAD BATTERY CONDITION AFTER LEAVING THE VEHICLE PARKED FOR 2 OR 3 DAYS. *TT | |
| Bulletin Number: 15932 | |
| SOME VEHICLES EQUIPPED WITH 4.2L, 4.6L AND 5.4L ENGINE MAY EXHIBIT A LACK OF POWER CONDITION. *TT | |
| Bulletin Number: 15938 | |
| INFORMATION USED WHEN REPLACING THE DRIVERS SEAT MODULE. *TT | |
| Bulletin Number: 16077 | |
| SOME VEHICLES BUILT AT CUAUTITLAN ASSEMBLY PLANT BETWEEN JANUARY 14, 2002 AND MAY 21, 2002 MAY EXHIBIT A KNOCK NOISE DUE TO AN INCORRECTLY INSTALLED STEERING DAMPER. *TT | |
| Bulletin Number: 16291 | |
| LOUD SQUEALING NOISE FROM THE ENGINE AREA WHEN THE ENGINE FAN CLUTCH IS UNDER LOAD WHILE OPERATED IN HOT DUSTY CLIMATES. VEHICLES EQUIPPED WITH A 7.3L ENGINE. *TT | |
| Bulletin Number: 16403 | |
| ENGINE-LIGHT TICK OR RATTLE TYPE NOISE FROM ENGINE AFTER COLD START. *MJ | |
| Bulletin Number: 16518 | |
| ACCESSORY DRIVE BELT SQUEALING NOISE FROM THE ENGINE AREA WHEN THE ENGINE FAN CLUTCH IS ENGAGED WHILE OPERATED IN HOT DUSTY CLIMATES. VARIOUS MODELS INCLUDING 2003 F450/550. *TT | |
| Bulletin Number: 16915 | |
| EXCESSIVE DRIVE-AWAY SHUDDER OR VIBRATION UNDER MODERATE TO HEAVY ACCELERATION FROM A STOP. *TT | |
| Bulletin Number: 17554 | |
| OIL/DUST FILM AT CAC CONNECTIONS. *MJ | |
| Bulletin Number: 17603 | |
| AIR BAG LIGHT ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B1871 OR B1935 FOLLOWING ECS/RCM REPLACEMENT. *TT | |
| Bulletin Number: 18217 | |
| MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT | |
| Bulletin Number: 18223 | |
| VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST. OASIS. TO ALSO INCLUDE 2005 SUPER DUTY F-SERIES, EXCURSION, AND F650/750. *TT | |
| Bulletin Number: 18376 | |
| A COLD WEATHER REVERSE ENGAGEMENT STALL. *TT | |
| Bulletin Number: 18406 | |
| SERVICE TIPS BEFORE ARC WELDING ON THE FRAME OR BODY OF A UNIT. *TT | |
| 2002 FORD F-350 SD | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04185 | |
| FRONT HUBS NOT ENGAGING, NOT STAYING ENGAGED AND/OR UNLOCKING. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04227 | |
| DRIVE AWAY SHUDDER OR VIBRATION. *EH | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 05174 | |
| VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST MODE. *TT | |
| Bulletin Number: 05188 | |
| SERVICE KIT AVAILABLE FOR WIPER MOTOR WIRING. *TT | |
| Bulletin Number: 06177 | |
| ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS. *KB | |
| Bulletin Number: 071110 | |
| BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ | |
| Bulletin Number: 07312 | |
| WATER IN THE FUEL TANK BEHIND REAR AXLE - 6.0L, 6.4L AND 7.3L DIESEL ENGINE. *KB UPDATED 2/29/08. *NJ | |
| Bulletin Number: 15109 | |
| A COLD WEATHER REVERSE ENGAGEMENT STALL. *YD | |
| Bulletin Number: 15328 | |
| CONCERNS WITH RATTLE NOISE ORIGINATING FROM THE FRONT BRAKE CALIPERS. *TT | |
| Bulletin Number: 15525 | |
| INFORMATION REGARDING A RATTLE NOISE ORIGINATING FROM THE FRONT BRAKE CALIPER.*YD | |
| Bulletin Number: 15579 | |
| SOME VEHICLES MAY EXHIBIT CALIPER PIN RATTLE NOISE ORIGINATING FROM THE FRONT BRAKE CALIPERS. *TT | |
| Bulletin Number: 15607 | |
| CONCERNS WITH TR4050 MANUAL TRANSMISSION EXHIBITING A NO ENGAGEMENT FROM 1ST TO 2ND GEAR. *TT | |
| Bulletin Number: 15661 | |
| CONCERNS WITH RATTLE NOISES COMING FROM FRONT BRAKE CALIPERS. *TT | |
| Bulletin Number: 15798 | |
| SOME VEHICLES EQUIPPED WITH A 7.3L DI, 4R100 TRANSMISSION AND BUILT BEFORE DECEMBER 10, 2001 MAY REMAIN IN 2ND GEAR WITH THE GEAR SHIFT LEVER IN THE FIRST GEAR POSITION. *TT | |
| Bulletin Number: 15810 | |
| SOME VEHICLES MAY EXHIBIT INOPERATIVE POWER MIRRORS. *TT | |
| Bulletin Number: 15825 | |
| SOME VEHICLES MAY EXHIBIT ONE OR BOTH HEADLAMPS CRACKED AT THE FRONT SIDE OF THE HEADLAMP LENS AREA. *TT | |
| Bulletin Number: 15827 | |
| SOME VEHICLES EQUIPPED WITH LPG ENGINE MAY EXHIBIT THE TWO FUEL GAUGES DISPLAYING DIFFERENT FUEL LEVELS. *TT | |
| Bulletin Number: 15843 | |
| SOME VEHICLES MAY EXHIBIT STEERING WHEEL CLEAR VIEW CONDITION. *TT | |
| Bulletin Number: 15849 | |
| SOME VEHICLES BUILT FROM 12/01/2001 TO 02/08/2002 MAY EXHIBIT A BROKEN DOOR HANDLE RIVET. *TT | |
| Bulletin Number: 16136 | |
| SOME VEHICLES MAY EXHIBIT A REPEAT STARTER FAILURE CONDITION. *TT | |
| Bulletin Number: 17316 | |
| FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP. *TT | |
| Bulletin Number: 17406 | |
| LOW POWER, POOR FUEL ECONOMY, FUEL GELLING COLD, EXCESSIVE WHITE SMOKE COLD, OR HARD START. *MJ THIS OASIS UPDATES PREVIOUS OASIS DATED 12/01/03. *TT | |
| Bulletin Number: 17571 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT | |
| Bulletin Number: 17784 | |
| DOOR AJAR LIGHT WORKING IMPROPERLY AFTER VEHICLE SECURITY MODULE REPLACEMENT. *TT | |
| Bulletin Number: 17822 | |
| MANUAL TRANSMISSION FLUID LEAK. *TT | |
| Bulletin Number: 17829 | |
| TRANSFER CASE SHIFT ISSUES ON VEHICLES WITH AN ELECTRONIC SHIFT ON THE FLY (ESOF) TRANSFER CASE. *TT | |
| Bulletin Number: 18735 | |
| HEADLIGHT ADJUSTMENT - CHASSIS CAB INCOMPLETE VEHICLES. *TT | |
| Bulletin Number: 19621 | |
| LACK OF POWER DUE TO LOW FUEL PRESSURE, FUEL TANK LINER SEPERATION. *KB | |
| Bulletin Number: 19728 | |
| LACK OF POWER DUE TO LOW FUEL PRESSURE - FUEL TANK LINER SEPERATION. *KB | |
| Bulletin Number: 20052 | |
| 1999-2008 F250-F550 SUPER DUTY 4X4 WITH ELECTRONIC SHIFT TRANSFER CASE NOT ENGAGING 4X4. *NJ | |
| Bulletin Number: 20228 | |
| 1999-2008 7.3L/6.0L/6.4L/4.5L DIESEL F-SUPER DUTY - CLEAN THE CHARGE AIR COOLER (CAC) SYSTEM AFTER CERTAIN TURBO OR ENGINE FAILURES - SERVICE TIP. *NJ | |
| Bulletin Number: ASI-44408 | |
| FORD: THE RESTRAINT CONTROL MODULE (RCM) WHEN USING VCM II, WOULD HAVE AN ERROR CODE 35 AND DIAGNOSTIC TROUBLE CODE (DTC) B1035, AND DIFFICULTY ATTEMPTING PROGRAMMABLE MODULE INSTALLATION (PMI). MODEL 2001-2004 F-SUPER DUTY. *PE | |
| Bulletin Number: DOR-B8H4Z-11 | |
| This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly ma | |
| Bulletin Number: LP-09L02 | |
| FORD TRUCKS SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. VEHICLES HAVE EXPERIENCED SEVERE STEERING WHEEL AND FRONT WHEEL VIBRATIONS AND OSCILLATIONS AFTER TRAVELING OVER A BUMP OR DIP IN THE ROAD. MODELS 2006 F-250/350 SU | |
| 2002 FORD F-450 SD | |
| Bulletin Number: 010901 | |
| SUBJECT PERTAINING TO PASSENGER SEAT MISBUILD.*JB | |
| Bulletin Number: 02177 | |
| COOLING SYSTEM-MOTORCRAFT PREMIUM GOLD ENGINE COOLANT-SERIVCE TIPS. *MJ | |
| Bulletin Number: 02227 | |
| ENGINE-CYLINDER HEAD DECK LEAK-4.6 AND 5.4L ENGINES-NEW SERVICE-ONLY GASKET AND CYLINDER HEAD KITS AVAILABILITY. *MJ | |
| Bulletin Number: 02E20 | |
| SUBJECT REGARDING DEMONSTRATION/ DELIVERY HOLD: POWERTRAIN CONTROL MODULE REPROGRAMMING. *JG | |
| Bulletin Number: 03174 | |
| STEERING WHEEL FIGHT AFTER RIDING OVER BUMPS/RUTS. 2003, 2004 F450 AND F550 MODELS INCLUDED. *TT | |
| Bulletin Number: 03911 | |
| ROUGH IDLE AND/OR HESITATION WHEN ACCLERATING ON CERTAIN SUPER DUTY VEHICLES EQUIPPED WITH A 5.4L OR 6.8L ENGINE. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04185 | |
| FRONT HUBS NOT ENGAGING, NOT STAYING ENGAGED AND/OR UNLOCKING. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04227 | |
| DRIVE AWAY SHUDDER OR VIBRATION. *EH | |
| Bulletin Number: 042411 | |
| MEMONTARY RETURN TO IDLE DURING AGGRESSIVE ACCELERATION - DIAGNOSTIC TROUBLE CODE (DTC) P0123. *TT | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 0471 | |
| WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT | |
| Bulletin Number: 05174 | |
| VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST MODE. *TT | |
| Bulletin Number: 05188 | |
| SERVICE KIT AVAILABLE FOR WIPER MOTOR WIRING. *TT | |
| Bulletin Number: 15109 | |
| A COLD WEATHER REVERSE ENGAGEMENT STALL. *YD | |
| Bulletin Number: 15297 | |
| SOME VEHICLES MAY EXHIBIT AN INOPERATIVE SIDE POWER MIRROR CONDITION. *TT | |
| Bulletin Number: 15311 | |
| SOME 4X4 VEHICLES MAY EXHIBIT A CRANK NO START CONDITION. *TT | |
| Bulletin Number: 15566 | |
| SOME VEHICLES MAY EXHIBIT A TACKY SURFACE ON THE INSTRUMENT PANEL (IP). *TT | |
| Bulletin Number: 15574 | |
| SOME VEHICLES MAY EXHIBIT A DIFFICULTY IN PROGRAMMING THE KEY FOB(S). *TT | |
| Bulletin Number: 15687 | |
| CERTAIN SUPER DUTY VEHICLES EQUIPPED WITH LPG ENGINE MAY EXHIBIT A DEAD BATTERY CONDITION AFTER LEAVING THE VEHICLE PARKED FOR 2 OR 3 DAYS. *TT | |
| Bulletin Number: 15753 | |
| SOME SUPER DUTYS EQUIPPED WITH A 7.3L DIT ENGINE MAY EXHIBIT A LACK OF POWER CONDITION DRIVING AT 60 KPH. *TT | |
| Bulletin Number: 15798 | |
| SOME VEHICLES EQUIPPED WITH A 7.3L DI, 4R100 TRANSMISSION AND BUILT BEFORE DECEMBER 10, 2001 MAY REMAIN IN 2ND GEAR WITH THE GEAR SHIFT LEVER IN THE FIRST GEAR POSITION. *TT | |
| Bulletin Number: 15810 | |
| SOME VEHICLES MAY EXHIBIT INOPERATIVE POWER MIRRORS. *TT | |
| Bulletin Number: 15825 | |
| SOME VEHICLES MAY EXHIBIT ONE OR BOTH HEADLAMPS CRACKED AT THE FRONT SIDE OF THE HEADLAMP LENS AREA. *TT | |
| Bulletin Number: 15827 | |
| SOME VEHICLES EQUIPPED WITH LPG ENGINE MAY EXHIBIT THE TWO FUEL GAUGES DISPLAYING DIFFERENT FUEL LEVELS. *TT | |
| Bulletin Number: 15843 | |
| SOME VEHICLES MAY EXHIBIT STEERING WHEEL CLEAR VIEW CONDITION. *TT | |
| Bulletin Number: 15849 | |
| SOME VEHICLES BUILT FROM 12/01/2001 TO 02/08/2002 MAY EXHIBIT A BROKEN DOOR HANDLE RIVET. *TT | |
| Bulletin Number: 16078 | |
| SOME VEHICLES MAY EXHIBIT A NOISE AT THE FRONT SUSPENSION WHILE DRIVING OVER BUMPS OR AN ENGINE OIL LEAK THROUGH THE ENGINE OIL PAN. *TT | |
| Bulletin Number: 16136 | |
| SOME VEHICLES MAY EXHIBIT A REPEAT STARTER FAILURE CONDITION. *TT | |
| Bulletin Number: 16291 | |
| LOUD SQUEALING NOISE FROM THE ENGINE AREA WHEN THE ENGINE FAN CLUTCH IS UNDER LOAD WHILE OPERATED IN HOT DUSTY CLIMATES. VEHICLES EQUIPPED WITH A 7.3L ENGINE. *TT | |
| Bulletin Number: 16403 | |
| ENGINE-LIGHT TICK OR RATTLE TYPE NOISE FROM ENGINE AFTER COLD START. *MJ | |
| Bulletin Number: 16518 | |
| ACCESSORY DRIVE BELT SQUEALING NOISE FROM THE ENGINE AREA WHEN THE ENGINE FAN CLUTCH IS ENGAGED WHILE OPERATED IN HOT DUSTY CLIMATES. VARIOUS MODELS INCLUDING 2003 F450/550. *TT | |
| Bulletin Number: 17316 | |
| FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP. *TT | |
| Bulletin Number: 17406 | |
| LOW POWER, POOR FUEL ECONOMY, FUEL GELLING COLD, EXCESSIVE WHITE SMOKE COLD, OR HARD START. *MJ THIS OASIS UPDATES PREVIOUS OASIS DATED 12/01/03. *TT | |
| Bulletin Number: 17554 | |
| OIL/DUST FILM AT CAC CONNECTIONS. *MJ | |
| Bulletin Number: 17571 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT | |
| Bulletin Number: 17603 | |
| AIR BAG LIGHT ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B1871 OR B1935 FOLLOWING ECS/RCM REPLACEMENT. *TT | |
| Bulletin Number: 17784 | |
| DOOR AJAR LIGHT WORKING IMPROPERLY AFTER VEHICLE SECURITY MODULE REPLACEMENT. *TT | |
| Bulletin Number: 17822 | |
| MANUAL TRANSMISSION FLUID LEAK. *TT | |
| Bulletin Number: 17829 | |
| TRANSFER CASE SHIFT ISSUES ON VEHICLES WITH AN ELECTRONIC SHIFT ON THE FLY (ESOF) TRANSFER CASE. *TT | |
| Bulletin Number: 18217 | |
| MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT | |
| Bulletin Number: 18223 | |
| VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST. OASIS. TO ALSO INCLUDE 2005 SUPER DUTY F-SERIES, EXCURSION, AND F650/750. *TT | |
| Bulletin Number: 18376 | |
| A COLD WEATHER REVERSE ENGAGEMENT STALL. *TT | |
| Bulletin Number: 18406 | |
| SERVICE TIPS BEFORE ARC WELDING ON THE FRAME OR BODY OF A UNIT. *TT | |
| Bulletin Number: 18735 | |
| HEADLIGHT ADJUSTMENT - CHASSIS CAB INCOMPLETE VEHICLES. *TT | |
| Bulletin Number: 20052 | |
| 1999-2008 F250-F550 SUPER DUTY 4X4 WITH ELECTRONIC SHIFT TRANSFER CASE NOT ENGAGING 4X4. *NJ | |
| Bulletin Number: ASI-44408 | |
| FORD: THE RESTRAINT CONTROL MODULE (RCM) WHEN USING VCM II, WOULD HAVE AN ERROR CODE 35 AND DIAGNOSTIC TROUBLE CODE (DTC) B1035, AND DIFFICULTY ATTEMPTING PROGRAMMABLE MODULE INSTALLATION (PMI). MODEL 2001-2004 F-SUPER DUTY. *PE | |
| 2002 FORD F53 | |
| Bulletin Number: 020909 | |
| EXCESSIVE AMOUNT OF WATER INTO THE AIR FILTER AND A LOSS OF POWER WHILE DRIVING IN THE RAIN. 1999-2004 SUPER DUTY F-53 STRIPPED CHAS. *TT | |
| Bulletin Number: 02141 | |
| SOME VEHICLES BUILT BEFORE 10/15/2001 MAY EXHIBIT A SQUEAK NOISE FROM THE REAR LEAF SPRINGS. THIS BULLETIN INVOLVES REPLACEMENT OF THE REAR LEAF SPRING TIP LINER. *TT | |
| Bulletin Number: 021712 | |
| CONCERNS WITH MOTORHOME GENERATORS SHUTTING OFF WHEN FUEL TANK READS 1/4 FULL. *TT | |
| Bulletin Number: 0263 | |
| INFORMATION ON GEL-LIKE SUBSTANCE FLOATING ON TOP OF FLUID IN MASTER CYLINDER. *TT | |
| Bulletin Number: 0272 | |
| SOME MOTORHOME CHASSIS VEHICLES MAY EXHIBIT THE AIR CONDITION AIR COMING OUT OF DEFROST OR A PERCEIVED AIR CONDITIONER CUTTING OUT WHEN TRAVELING ON A LONG UPHILL GRADE. *TT | |
| Bulletin Number: 0299 | |
| SOME VEHICLES MAY INGEST AN EXCESSIVE AMOUNT OF WATER INTO THE AIR FILTER WHILE DRIVING IN THE RAIN. *TT | |
| Bulletin Number: 031404 | |
| ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. | |
| Bulletin Number: 04112 | |
| POPPING NOISE AND/OR SWAY/LEAN DURING LOW SPEED TURNING MANEUVERS. ALSO INCLUDING FORD F53 MY2004. *TT | |
| Bulletin Number: 041601 | |
| WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT | |
| Bulletin Number: 07212 | |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE | |
| Bulletin Number: 15398 | |
| SOME VEHICLES MAY EXHIBIT A COOLANT LEAK DUE TO A BROKEN RADIATOR HOSE CLAMP. *TT | |
| Bulletin Number: 15925 | |
| SOME MOTORHOMES MAY EXHIBIT A POPPING NOISE ORIGINATING FROMTHE FRONT END OF THE VEHICLE WHILE TURNING THE STEERING WHEEL. *TT | |
| Bulletin Number: 16022 | |
| SOME MOTORHOMES MAY EXHIBIT A POPPING NOISE ORIGINATING FROM THE FRONT END OF THE VEHICLE WHILE TURNING THE STEERING WHEEL OR OVER BUMPS. *TT | |
| Bulletin Number: 16071 | |
| SOME MOTORHOMES MAY EXHIBIT A POPPING NOISE IN THE FRONT END. *TT | |
| 2002 FORD F-550 SD | |
| Bulletin Number: 010901 | |
| SUBJECT PERTAINING TO PASSENGER SEAT MISBUILD.*JB | |
| Bulletin Number: 02227 | |
| ENGINE-CYLINDER HEAD DECK LEAK-4.6 AND 5.4L ENGINES-NEW SERVICE-ONLY GASKET AND CYLINDER HEAD KITS AVAILABILITY. *MJ | |
| Bulletin Number: 02E20 | |
| SUBJECT REGARDING DEMONSTRATION/ DELIVERY HOLD: POWERTRAIN CONTROL MODULE REPROGRAMMING. *JG | |
| Bulletin Number: 03174 | |
| STEERING WHEEL FIGHT AFTER RIDING OVER BUMPS/RUTS. 2003, 2004 F450 AND F550 MODELS INCLUDED. *TT | |
| Bulletin Number: 03911 | |
| ROUGH IDLE AND/OR HESITATION WHEN ACCLERATING ON CERTAIN SUPER DUTY VEHICLES EQUIPPED WITH A 5.4L OR 6.8L ENGINE. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04185 | |
| FRONT HUBS NOT ENGAGING, NOT STAYING ENGAGED AND/OR UNLOCKING. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04227 | |
| DRIVE AWAY SHUDDER OR VIBRATION. *EH | |
| Bulletin Number: 042411 | |
| MEMONTARY RETURN TO IDLE DURING AGGRESSIVE ACCELERATION - DIAGNOSTIC TROUBLE CODE (DTC) P0123. *TT | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 0471 | |
| WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT | |
| Bulletin Number: 05174 | |
| VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST MODE. *TT | |
| Bulletin Number: 05188 | |
| SERVICE KIT AVAILABLE FOR WIPER MOTOR WIRING. *TT | |
| Bulletin Number: 15109 | |
| A COLD WEATHER REVERSE ENGAGEMENT STALL. *YD | |
| Bulletin Number: 15297 | |
| SOME VEHICLES MAY EXHIBIT AN INOPERATIVE SIDE POWER MIRROR CONDITION. *TT | |
| Bulletin Number: 15311 | |
| SOME 4X4 VEHICLES MAY EXHIBIT A CRANK NO START CONDITION. *TT | |
| Bulletin Number: 15574 | |
| SOME VEHICLES MAY EXHIBIT A DIFFICULTY IN PROGRAMMING THE KEY FOB(S). *TT | |
| Bulletin Number: 15687 | |
| CERTAIN SUPER DUTY VEHICLES EQUIPPED WITH LPG ENGINE MAY EXHIBIT A DEAD BATTERY CONDITION AFTER LEAVING THE VEHICLE PARKED FOR 2 OR 3 DAYS. *TT | |
| Bulletin Number: 15798 | |
| SOME VEHICLES EQUIPPED WITH A 7.3L DI, 4R100 TRANSMISSION AND BUILT BEFORE DECEMBER 10, 2001 MAY REMAIN IN 2ND GEAR WITH THE GEAR SHIFT LEVER IN THE FIRST GEAR POSITION. *TT | |
| Bulletin Number: 15810 | |
| SOME VEHICLES MAY EXHIBIT INOPERATIVE POWER MIRRORS. *TT | |
| Bulletin Number: 15825 | |
| SOME VEHICLES MAY EXHIBIT ONE OR BOTH HEADLAMPS CRACKED AT THE FRONT SIDE OF THE HEADLAMP LENS AREA. *TT | |
| Bulletin Number: 15827 | |
| SOME VEHICLES EQUIPPED WITH LPG ENGINE MAY EXHIBIT THE TWO FUEL GAUGES DISPLAYING DIFFERENT FUEL LEVELS. *TT | |
| Bulletin Number: 15843 | |
| SOME VEHICLES MAY EXHIBIT STEERING WHEEL CLEAR VIEW CONDITION. *TT | |
| Bulletin Number: 15849 | |
| SOME VEHICLES BUILT FROM 12/01/2001 TO 02/08/2002 MAY EXHIBIT A BROKEN DOOR HANDLE RIVET. *TT | |
| Bulletin Number: 16078 | |
| SOME VEHICLES MAY EXHIBIT A NOISE AT THE FRONT SUSPENSION WHILE DRIVING OVER BUMPS OR AN ENGINE OIL LEAK THROUGH THE ENGINE OIL PAN. *TT | |
| Bulletin Number: 16136 | |
| SOME VEHICLES MAY EXHIBIT A REPEAT STARTER FAILURE CONDITION. *TT | |
| Bulletin Number: 16291 | |
| LOUD SQUEALING NOISE FROM THE ENGINE AREA WHEN THE ENGINE FAN CLUTCH IS UNDER LOAD WHILE OPERATED IN HOT DUSTY CLIMATES. VEHICLES EQUIPPED WITH A 7.3L ENGINE. *TT | |
| Bulletin Number: 16403 | |
| ENGINE-LIGHT TICK OR RATTLE TYPE NOISE FROM ENGINE AFTER COLD START. *MJ | |
| Bulletin Number: 16518 | |
| ACCESSORY DRIVE BELT SQUEALING NOISE FROM THE ENGINE AREA WHEN THE ENGINE FAN CLUTCH IS ENGAGED WHILE OPERATED IN HOT DUSTY CLIMATES. VARIOUS MODELS INCLUDING 2003 F450/550. *TT | |
| Bulletin Number: 17316 | |
| FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP. *TT | |
| Bulletin Number: 17406 | |
| LOW POWER, POOR FUEL ECONOMY, FUEL GELLING COLD, EXCESSIVE WHITE SMOKE COLD, OR HARD START. *MJ THIS OASIS UPDATES PREVIOUS OASIS DATED 12/01/03. *TT | |
| Bulletin Number: 17554 | |
| OIL/DUST FILM AT CAC CONNECTIONS. *MJ | |
| Bulletin Number: 17571 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT | |
| Bulletin Number: 17603 | |
| AIR BAG LIGHT ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B1871 OR B1935 FOLLOWING ECS/RCM REPLACEMENT. *TT | |
| Bulletin Number: 17784 | |
| DOOR AJAR LIGHT WORKING IMPROPERLY AFTER VEHICLE SECURITY MODULE REPLACEMENT. *TT | |
| Bulletin Number: 17822 | |
| MANUAL TRANSMISSION FLUID LEAK. *TT | |
| Bulletin Number: 17829 | |
| TRANSFER CASE SHIFT ISSUES ON VEHICLES WITH AN ELECTRONIC SHIFT ON THE FLY (ESOF) TRANSFER CASE. *TT | |
| Bulletin Number: 18217 | |
| MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT | |
| Bulletin Number: 18223 | |
| VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST. OASIS. TO ALSO INCLUDE 2005 SUPER DUTY F-SERIES, EXCURSION, AND F650/750. *TT | |
| Bulletin Number: 18376 | |
| A COLD WEATHER REVERSE ENGAGEMENT STALL. *TT | |
| Bulletin Number: 18406 | |
| SERVICE TIPS BEFORE ARC WELDING ON THE FRAME OR BODY OF A UNIT. *TT | |
| Bulletin Number: 18735 | |
| HEADLIGHT ADJUSTMENT - CHASSIS CAB INCOMPLETE VEHICLES. *TT | |
| Bulletin Number: 20052 | |
| 1999-2008 F250-F550 SUPER DUTY 4X4 WITH ELECTRONIC SHIFT TRANSFER CASE NOT ENGAGING 4X4. *NJ | |
| Bulletin Number: ASI-44408 | |
| FORD: THE RESTRAINT CONTROL MODULE (RCM) WHEN USING VCM II, WOULD HAVE AN ERROR CODE 35 AND DIAGNOSTIC TROUBLE CODE (DTC) B1035, AND DIFFICULTY ATTEMPTING PROGRAMMABLE MODULE INSTALLATION (PMI). MODEL 2001-2004 F-SUPER DUTY. *PE | |
| 2002 FORD F-650 | |
| Bulletin Number: 02177 | |
| COOLING SYSTEM-MOTORCRAFT PREMIUM GOLD ENGINE COOLANT-SERIVCE TIPS. *MJ | |
| Bulletin Number: 02181 | |
| SUSPENSION-VEHICLE LEAN CORRECTION PROCEDURE. *MJ | |
| Bulletin Number: 02219 | |
| ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS - SERVICE TIPS. *TT | |
| Bulletin Number: 02226 | |
| NOISE-KNOCKING/CACKLING COMING FROM ENGINE-VEHICLES WITH 7.3L ENGINE-AVAILABILITY OF FUEL SYSTEM ACCUMULATOR. *MJ | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 0261 | |
| CLUTCH PEDAL CONCERNS WHICH GOES TO THE FLOOR AND / OR WILL NOT FULLY DISENGAGE. *TT | |
| Bulletin Number: 0263 | |
| INFORMATION ON GEL-LIKE SUBSTANCE FLOATING ON TOP OF FLUID IN MASTER CYLINDER. *TT | |
| Bulletin Number: 030705 | |
| CLUTCH PEDAL GOES TO FLOOR - CLUTCH WILL NOT FULLY DISENGAGE. *TT | |
| Bulletin Number: 032146 | |
| ENGINE OIL PAN CORROSION ON VEHICLES EQUIPPED WITH THE 7.3L DIESEL ENGINE. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT | |
| Bulletin Number: 032147 | |
| SOME MEDIUM DUTY VEHICLES EQUIPPED WITH THE 7.3L POWERSTROKE DIESEL ENGINE MAY EXHIBIT KNOCKING OR CACKLING NOISE COMING FROM THE ENGINE. AVAILABILITY OF FUEL SYSTEM ACCUMULATOR. *TT | |
| Bulletin Number: 032150 | |
| HIGH PRESSURE OIL PUMP LEAK ON VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE. *TT | |
| Bulletin Number: 0333 | |
| FLYWHEEL HOUSING DAMAGE ON VEHICLES EQUIPPED WITH CATERPILLAR ENGINE AND SPICER 7 SPEED MANUAL TRANSMISSION. *TT | |
| Bulletin Number: 04168 | |
| VACUM PUMP INOPERATIVE OR RUNS CONTINUOSLY - CLIMATE CONTROL DEFAULT TO DEFROST. *AR | |
| Bulletin Number: 05174 | |
| VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST MODE. *TT | |
| Bulletin Number: 15534 | |
| INFORMATION REGARDING FAILURE OF THE CLUTCH MASTER CYLINDER.*YH | |
| Bulletin Number: 15566 | |
| SOME VEHICLES MAY EXHIBIT A TACKY SURFACE ON THE INSTRUMENT PANEL (IP). *TT | |
| Bulletin Number: 15698 | |
| SUBJECT REGARDING REAR AXLE OIL PINION SEAL LEAK. *TT | |
| Bulletin Number: 15841 | |
| SOME VEHICLES MAY EXHIBIT DRIVELINE VIBRATION AT ANY SPEED. *TT | |
| Bulletin Number: 15862 | |
| SUBJECT PERTAINS TO A LEAN / SAG TO THE LEFT CONDITION. *TT | |
| Bulletin Number: 15921 | |
| CONCERNS WITH ENGINE OIL LEAKING FROM CYLINDER HEAD. *TT | |
| Bulletin Number: 16258 | |
| VEHICLES EQUIPPED WITH A 7.3L ENGINE (AFTER SERIAL NUMBER 0661894) - UNDER VALVE COVER (UVC) HARNESS RETAINER CLIP RELEASED FOR SERVICE. INCLUDES 2003 ECONOLINE, SUPER DUTY, F650/750 AND EXCURSION. *TT | |
| Bulletin Number: 16291 | |
| LOUD SQUEALING NOISE FROM THE ENGINE AREA WHEN THE ENGINE FAN CLUTCH IS UNDER LOAD WHILE OPERATED IN HOT DUSTY CLIMATES. VEHICLES EQUIPPED WITH A 7.3L ENGINE. *TT | |
| Bulletin Number: 16397 | |
| DRIVELINE NOISE. *MJ | |
| Bulletin Number: 17406 | |
| LOW POWER, POOR FUEL ECONOMY, FUEL GELLING COLD, EXCESSIVE WHITE SMOKE COLD, OR HARD START. *MJ THIS OASIS UPDATES PREVIOUS OASIS DATED 12/01/03. *TT | |
| Bulletin Number: 18217 | |
| MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT | |
| Bulletin Number: 18223 | |
| VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST. OASIS. TO ALSO INCLUDE 2005 SUPER DUTY F-SERIES, EXCURSION, AND F650/750. *TT | |
| Bulletin Number: 18735 | |
| HEADLIGHT ADJUSTMENT - CHASSIS CAB INCOMPLETE VEHICLES. *TT | |
| Bulletin Number: 19015 | |
| FUEL CONDITIONER. LOW POWER, POOR FUEL ECONOMY, FUEL GELLING IN COLD WEATHER, EXCESSIVE WHITE SMOKE ON COLD START, HARD START, OR COKING OF COMPONENTS EXPOSED TO EXHAUST. *TT | |
| 2002 FORD F750 | |
| Bulletin Number: 02177 | |
| COOLING SYSTEM-MOTORCRAFT PREMIUM GOLD ENGINE COOLANT-SERIVCE TIPS. *MJ | |
| Bulletin Number: 02181 | |
| SUSPENSION-VEHICLE LEAN CORRECTION PROCEDURE. *MJ | |
| Bulletin Number: 02219 | |
| ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS - SERVICE TIPS. *TT | |
| Bulletin Number: 02226 | |
| NOISE-KNOCKING/CACKLING COMING FROM ENGINE-VEHICLES WITH 7.3L ENGINE-AVAILABILITY OF FUEL SYSTEM ACCUMULATOR. *MJ | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 0261 | |
| CLUTCH PEDAL CONCERNS WHICH GOES TO THE FLOOR AND / OR WILL NOT FULLY DISENGAGE. *TT | |
| Bulletin Number: 0263 | |
| INFORMATION ON GEL-LIKE SUBSTANCE FLOATING ON TOP OF FLUID IN MASTER CYLINDER. *TT | |
| Bulletin Number: 030705 | |
| CLUTCH PEDAL GOES TO FLOOR - CLUTCH WILL NOT FULLY DISENGAGE. *TT | |
| Bulletin Number: 032146 | |
| ENGINE OIL PAN CORROSION ON VEHICLES EQUIPPED WITH THE 7.3L DIESEL ENGINE. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT | |
| Bulletin Number: 032147 | |
| SOME MEDIUM DUTY VEHICLES EQUIPPED WITH THE 7.3L POWERSTROKE DIESEL ENGINE MAY EXHIBIT KNOCKING OR CACKLING NOISE COMING FROM THE ENGINE. AVAILABILITY OF FUEL SYSTEM ACCUMULATOR. *TT | |
| Bulletin Number: 032150 | |
| HIGH PRESSURE OIL PUMP LEAK ON VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE. *TT | |
| Bulletin Number: 0333 | |
| FLYWHEEL HOUSING DAMAGE ON VEHICLES EQUIPPED WITH CATERPILLAR ENGINE AND SPICER 7 SPEED MANUAL TRANSMISSION. *TT | |
| Bulletin Number: 04168 | |
| VACUM PUMP INOPERATIVE OR RUNS CONTINUOSLY - CLIMATE CONTROL DEFAULT TO DEFROST. *AR | |
| Bulletin Number: 05174 | |
| VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST MODE. *TT | |
| Bulletin Number: 15534 | |
| INFORMATION REGARDING FAILURE OF THE CLUTCH MASTER CYLINDER.*YH | |
| Bulletin Number: 15566 | |
| SOME VEHICLES MAY EXHIBIT A TACKY SURFACE ON THE INSTRUMENT PANEL (IP). *TT | |
| Bulletin Number: 15698 | |
| SUBJECT REGARDING REAR AXLE OIL PINION SEAL LEAK. *TT | |
| Bulletin Number: 15841 | |
| SOME VEHICLES MAY EXHIBIT DRIVELINE VIBRATION AT ANY SPEED. *TT | |
| Bulletin Number: 15862 | |
| SUBJECT PERTAINS TO A LEAN / SAG TO THE LEFT CONDITION. *TT | |
| Bulletin Number: 15921 | |
| CONCERNS WITH ENGINE OIL LEAKING FROM CYLINDER HEAD. *TT | |
| Bulletin Number: 16258 | |
| VEHICLES EQUIPPED WITH A 7.3L ENGINE (AFTER SERIAL NUMBER 0661894) - UNDER VALVE COVER (UVC) HARNESS RETAINER CLIP RELEASED FOR SERVICE. INCLUDES 2003 ECONOLINE, SUPER DUTY, F650/750 AND EXCURSION. *TT | |
| Bulletin Number: 16291 | |
| LOUD SQUEALING NOISE FROM THE ENGINE AREA WHEN THE ENGINE FAN CLUTCH IS UNDER LOAD WHILE OPERATED IN HOT DUSTY CLIMATES. VEHICLES EQUIPPED WITH A 7.3L ENGINE. *TT | |
| Bulletin Number: 16397 | |
| DRIVELINE NOISE. *MJ | |
| Bulletin Number: 17406 | |
| LOW POWER, POOR FUEL ECONOMY, FUEL GELLING COLD, EXCESSIVE WHITE SMOKE COLD, OR HARD START. *MJ THIS OASIS UPDATES PREVIOUS OASIS DATED 12/01/03. *TT | |
| Bulletin Number: 18217 | |
| MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT | |
| Bulletin Number: 18223 | |
| VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST. OASIS. TO ALSO INCLUDE 2005 SUPER DUTY F-SERIES, EXCURSION, AND F650/750. *TT | |
| Bulletin Number: 18735 | |
| HEADLIGHT ADJUSTMENT - CHASSIS CAB INCOMPLETE VEHICLES. *TT | |
| Bulletin Number: 19015 | |
| FUEL CONDITIONER. LOW POWER, POOR FUEL ECONOMY, FUEL GELLING IN COLD WEATHER, EXCESSIVE WHITE SMOKE ON COLD START, HARD START, OR COKING OF COMPONENTS EXPOSED TO EXHAUST. *TT | |
| 2002 FORD FOCUS | |
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01157 | |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| Bulletin Number: 01183 | |
| SUBJECT REGARDING REAR LIFTGATE SPOILER REMOVAL AND INSTALLATION.*JB | |
| Bulletin Number: 01205 | |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT | |
| Bulletin Number: 012101 | |
| CONCERNS WITH HEADLAMP MOISTURE/CONDENSATION IN LENS ASSEMBLY. *TT | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 020901 | |
| ROUGH IDLE, LOW POWER AND / OR STALL AT IDLE, A MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0300 THROUGH P0304 STORED IN MEMORY. *TT | |
| Bulletin Number: 0213 | |
| SOME 2001 VEHICLES EQUIPPED WITH A 2.0L SPI ENGINE MAY EXHIBIT A PULSING OR TICKING NOISE ORIGINATING FROM THE ENGINE COMPARTMENT AND / OR MAY HAVE A MALFUNCTION INDICATOR LAMP LIGHT ON WITH DIAGNOSTIC TROUBLE CODE P0401 OR P0402 CODE. * | |
| Bulletin Number: 0214 | |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| Bulletin Number: 02182 | |
| TRIM-IGNITION LOCK CYLINDER DIFFICULT TO TURN, UNABLE TO REMOVE STICKING IGNITION KEY-IGNITION LOCK CYLINDER REMOVAL PROCEDURE. *MJ | |
| Bulletin Number: 02208 | |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 0258 | |
| INOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639. *TT | |
| Bulletin Number: 0291 | |
| SOME VEHICLES EQUIPPED WITH THE 2.0L SPI ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND DIAGNOSTIC TROUBLE CODES (DTC) P0300 THROUGH P0304 STORED. *TT | |
| Bulletin Number: 02M01 | |
| CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6 | |
| Bulletin Number: 030301 | |
| ELECTRICAL - HORN INOPERATIVE - VEHICLES EQUIPPED WITH 2.0L ENGINE ONLY. *TT | |
| Bulletin Number: 03135 | |
| REAR TIRE INNER EDGE WEAR. 2004 MODEL INCLUDED. *TT | |
| Bulletin Number: 03148 | |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 031511 | |
| INTERMEDIATE AXLE SHAFT BEARING REPLACEMENT. *TT | |
| Bulletin Number: 03152 | |
| DIAGNOSTIC TROUBLE CODES (DTC) P0402 AND/OR P0403 OR RUNS ROUGH IN WET WEATHER CONDITIONS. *TT | |
| Bulletin Number: 03153 | |
| FRONT END CREAKING, CRUNCHING, GRINDING AND OR RATTLING NOISE FROM THE FRONT SUSPENSION WHILE DRIVING AT SLOW SPEEDS AND/OR WHILE TURNING. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 03182 | |
| WATER IN CLIMATE CONTROL HEATER BLOWER MOTOR CASE, WHICH CAN BE ASSOCIATED WITH AN INOPERABLE HEATER BLOWER MOTOR RESISTER, BLOWER MOTOR, OR A BLOWN BLOWER MOTOR FUSE. *TT | |
| Bulletin Number: 031911 | |
| HARD START, NO START, BATTERY LAMP FLICKER. *TT | |
| Bulletin Number: 03202 | |
| FRONT END CREAKING, CRUNCHING, GRINDING AND/OR RATTLING NOISE FROM THE FRONT SUSPENSION WHILE DRIVING AT SLOW SPEEDS AND/OR WHILE TURNING. *TT *MJ | |
| Bulletin Number: 0322 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT | |
| Bulletin Number: 03223 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| Bulletin Number: 03225 | |
| DIFFICULT TO OPEN OR UNABLE TO OPEN HOOD CONDITION. *TT | |
| Bulletin Number: 0331 | |
| INOPERATIVE HORN CONDITION. *TT | |
| Bulletin Number: 0344 | |
| ROUGH IDLE, ROLLING IDLE, STALL, HIGH IDLE, OR BACK FIRE MAINLY AFTER A COLD START. ALSO HESITATION OR SURGE AT STEADY CRUISE, OR MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED CONDITION. *TT *JB | |
| Bulletin Number: 0361 | |
| MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB | |
| Bulletin Number: 0367 | |
| MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES P1381/P0011 AND/OR P1383/P0012 STORED IN MEMORY. *TT *JB | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 04111 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. | |
| Bulletin Number: 04147 | |
| SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS. *TT | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 04152 | |
| LOSS OF INTERMITTENT WIPER OR WIPER PARK FUNCTION. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04189 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 042119 | |
| TRANSAXLE NOISE AT IDLE IN NEUTRAL WITH CLUTCH PEDAL RELEASED PREMATURE CLUTCH. *EH | |
| Bulletin Number: 04215 | |
| DIFFICULTY CHANGING GEARS - UNABLE TO ENGAGE GEARS. *TT | |
| Bulletin Number: 042410 | |
| ENGINE VIBRATION AT IDLE. *TT | |
| Bulletin Number: 0455 | |
| TURN SIGNAL CANCEL CONCERN. *TT | |
| Bulletin Number: 0456 | |
| FUEL DELIVERY MODULE (FDM) REPLACEMENT PROCEDURE. *TT | |
| Bulletin Number: 0481 | |
| CLUNKING OR RATTLE NOISE IN THE TRANSAXLE, MAINLY AT IDLE IN NEUTRAL, WITH CLUTCH PEDAL RELEASED. *TT | |
| Bulletin Number: 05105 | |
| REAR BRAKE SQUEAL. *TT | |
| Bulletin Number: 05310 | |
| SAFETY BELT WEB STOP BUTTON SERVICE. *EH | |
| Bulletin Number: 0581 | |
| DIFFICULT OR UNABLE TO SHIFT INTO 5TH GEAR. *TT | |
| Bulletin Number: 0627 | |
| MANIFOLD OR CATALYTIC CONVERTER HEAT SHIELDS LOOSE/MISSING. *TT | |
| Bulletin Number: 14381 | |
| A HALFSHAFT BEARING NOISE (WHINE / MOAN, WHISTLING, HUMMING, DRUMMING OR RATTLING) FROM THE DRIVETRAIN WHICH APPEARS TO BE EMANATING FROM THE TRANSMISSION. *JB | |
| Bulletin Number: 15308 | |
| SOME VEHICLES BUILT AFTER 10/01/2001 MAY EXHIBIT A DIFFICULT TO TURN IGNITION KEY. *TT | |
| Bulletin Number: 15402 | |
| SUBJECT REGARDING NORTH AMERICAN FOCUS NOT EQUIPPED WITH ACTIVE ANTI-THEFT ALARM SYSTEM. *TT | |
| Bulletin Number: 15403 | |
| SOME VEHICLES EQUIPPED WITH AN IN-DASH 6 DISC RADIO MAY EXHIBIT A SYSTEM CD ERROR E3 OR A STUCK DISC. *TT | |
| Bulletin Number: 15419 | |
| SOME VEHICLES MAY EXHIBIT AN ENGINE VIBRATION AT IDLE, MOST NOTICEABLE WHEN ENGAGED IN REVERSE. *TT | |
| Bulletin Number: 15421 | |
| SOME VEHICLES MAY EXHIBIT A DIFFICULT TO TURN, UNABLE TO REMOVE, OR STICKING IGNITION KEY. *TT | |
| Bulletin Number: 15509 | |
| SOME VEHICLES MAY EXHIBIT AN EXTERIOR MIRROR THAT IS LOOSE OR SHAKES WHEN DRIVING. *TT | |
| Bulletin Number: 15514 | |
| SOME VEHICLES MAY EXHIBIT AN ENGINE VIBRATION AT IDLE, MOST NOTICEABLE WHEN ENGAGED IN REVERSE. *TT | |
| Bulletin Number: 15516 | |
| SOME VEHICLES EQUIPPED WITH A FACTORY POWER ROOF OPENING PANEL MAY EXHIBIT AN INOPERATIVE OR INCOMPLETE TRAVEL OF THE ROOF PANEL. *TT | |
| Bulletin Number: 15554 | |
| INFORMATION REGARDING NO START DUE TO A SEIZED CAMSHAFT. *YH | |
| Bulletin Number: 15555 | |
| SUBJECT ON DRIVER OR PASSENGER FRONT DOOR DIFFICULT TO CLOSE, AND /OR SOME SQUEAK/RATTLE FROM THE HINGE AREA. *YH | |
| Bulletin Number: 15558 | |
| INFORMATION REGARDING DIAGNOSTIC TROUBLE CODE B2496 (PANIC FEATURE DOES NOT OPERATE CORRECTLY). *YH | |
| Bulletin Number: 15639 | |
| SOME VEHICLES MAY EXHIBIT ENGINE VIBRATION AT IDLE IN DRIVE, NEUTRAL AND REVERSE. *TT | |
| Bulletin Number: 15642 | |
| ABS/ADVANCE TRAC LIGHT ON AND DIAGNOSTIC TROUBLE CODE C1937 OR THE STABILITY ASSIST SYSTEM ACTIVE/FAIL LAMP FLASHING. *TT | |
| Bulletin Number: 15710 | |
| INFORMATION ON VEHICLES WITH PROGRAMMABLE MODULES. *TT | |
| Bulletin Number: 15712 | |
| SOME VEHICLES MAY EXHIBIT A LOCKED REAR SEAT BELT RETRACTOR AFTER MOVING THE REAR SEAT FROM THE FOLD DOWN POSITION TO THE SEATING POSITION. *TT | |
| Bulletin Number: 15733 | |
| SUBJECT REGARDING INTERIOR DOOR LOCK STRATEGY. *TT | |
| Bulletin Number: 15762 | |
| SOME VEHICLES EQUIPPED WITH 15 INCH FIRESTONE TIRES MAY EXHIBIT SIGNS OF DIAGONAL WEAR OR CUPPING OF THE REAR TIRES. *TT | |
| Bulletin Number: 15766 | |
| SOME VEHICLES MAY EXHIBIT A CRANK / NO START, POOR IDLE, AND / OR LACK OF POWER, WITH CAMSHAFTS OUT OF TIME. *TT | |
| Bulletin Number: 15782 | |
| SOME VEHICLES MAY EXHIBIT DOOR LOCKS THAT MAY INADVERTENTLY LOCK ON THEIR OWN. *TT | |
| Bulletin Number: 15816 | |
| INFORMATION PERTAINING TO VEHICLE PULL OR DRIFT TO THE LEFT OR RIGHT WHILE TRAVELING. *TT | |
| Bulletin Number: 15818 | |
| SOME VEHICLES BUILT 09/2001 THROUGH 11/2001 AND EQUIPPED WITH A 2.0L ZETEC ENGINE MAY EXHIBIT A FEAD BELT NOISE. *TT | |
| Bulletin Number: 15819 | |
| SOME VEHICLES EQUIPPED WITH 15 INCH FIRESTONE TIRES MAY EXHIBIT SIGNS OF DIAGNONAL WEAR OR CUPPING ON THE REAR TIRES. *TT | |
| Bulletin Number: 15828 | |
| SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE B1213, B1342, B1601, B2431. *TT | |
| Bulletin Number: 15848 | |
| SUBJECT REGARDING AIR CONDITIONER ADD ON KITS NOT AVAILABLE. *TT | |
| Bulletin Number: 15874 | |
| DPFE SENSOR PULSING OR TICKING NOISE FROM ENGINE COMPARTMENT. *TT | |
| Bulletin Number: 15917 | |
| CONCERNS WITH FRONT SUSPENSION CREAK, CRUNCH NOISE WHILE TURNING AT SLOW SPEEDS. *TT | |
| Bulletin Number: 15993 | |
| SOME SVT BUILT PRIOR TO 3/27/2002 ARE EQUIPPED WITH FRONT SEAT BACK TRIM COVER AND FOAM PAD SEAT BACK WITH VELCRO TO RETAIN THE TRIM COVER UNDER THE SEAT. *TT | |
| Bulletin Number: 16032 | |
| INFORMATION ON NORTH AMERICAN BUILT VEHICLES WHICH WERE NOT EQUIPPED WITH A PERIMETER / ACTIVE ANTI-THEFT ALARM SYSTEM. *TT | |
| Bulletin Number: 16043 | |
| SOME VEHICLES WITH 15 INCH FIRESTONE TIRES MAY EXHIBIT SIGNS OF DIAGONAL WEAR OR CUPPING ON THE REAR TIRES. *TT | |
| Bulletin Number: 16086 | |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT SELF-ACTIVATION OF THE POWER DOOR LOCKS. *TT | |
| Bulletin Number: 16089 | |
| SOME WAGONS MAY EXHIBIT THE LIFTGATE NOT STAYING IN THE FULLY UPRIGHT POSITION IN COLD CLIMATES. *TT | |
| Bulletin Number: 16098 | |
| SOME VEHICLES MAY EXHIBIT A VERTICAL CRACK IN THE OUTSIDE MIRROR GLASS WITH NO VISIBLE SIGNS OF IMPACT, ESPECIALLY DURING COLD AMBIENT TEMPERATURES. *TT | |
| Bulletin Number: 16157 | |
| SOME VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSAXLE AND 2.0L ZETEC ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0122, THROTTLE POSITION CIRCUIT LOW INPUT. *TT | |
| Bulletin Number: 16287 | |
| DISCOLORATION OF THE YELLOW-COLORED, EXTENDED-LIFE, FACTORY-FILL COOLANT. *TT | |
| Bulletin Number: 16404 | |
| UNABLE TO COMMUNICATE WITH/REPROGRAM POWERTRAIN CONTROL MODULE (PCM). *MJ | |
| Bulletin Number: 16408 | |
| SPI ENGINE - OIL LEAK - CONTRACT REQUEST. *MJ | |
| Bulletin Number: 16429 | |
| NOISE (WHINE/MOAN, WHISTLING, HUMMING, DRUMMING OR RATTLING) FROM THE DRIVETRAIN WHICH APPEARS TO BE EMANATING FROM THE TRANSMISSION. *TT | |
| Bulletin Number: 16436 | |
| HIGH DECKLID CLOSING EFFORT. *MJ | |
| Bulletin Number: 16594 | |
| NOISE FROM THE RIGHT HALFSHAFT SUPPORT BEARING. ENGINEERING IS INVESTIGATING VIA THE QUICKER SERVICE FIX PROCESS. *TT | |
| Bulletin Number: 16685 | |
| EXCESSIVE FRONT BRAKE PAD WEAR, FRONT BRAKE CREEP/GROAN NOISE, FRONT BRAKE DUST, AND/OR ROTOR WEAR CONCERN. *TT *JB | |
| Bulletin Number: 16739 | |
| AIRBAG LAMP ILLUMINATED CONDITION WITH DIAGNOSTIC TROUBLE CODES (DTCS) B1881, B2434, B2438, AND C1947. *TT | |
| Bulletin Number: 16746 | |
| HIGHER THAN NORMAL IDLE SPEED, RUNS ROUGH AT IDLE AND/OR DIAGNOSTIC TROUBLE CODE (DTC) P0171. *TT | |
| Bulletin Number: 16778 | |
| FRONT END CREAKING, CRUNCHING NOISE AT LOW SPEEDS WHILE TURNING. *TT | |
| Bulletin Number: 16785 | |
| CONDENSATION AND/OR WATER ACCUMULATION WITHIN THE FOG LAMP ASSEMBLY. *TT | |
| Bulletin Number: 16796 | |
| INTERMITTENT WIPERS INOPERATIVE. *TT | |
| Bulletin Number: 16861 | |
| LIGHT RATTLING/CHUCKING NOISE FROM THE REAR SUSPENSION WHILE DRIVING OVER SMALL REPETITIVE BUMPS (WASHBOARD) AT SPEEDS LESS THAN 30 MPH. *TT | |
| Bulletin Number: 16878 | |
| COOLANT LEAK FROM A CRACKED COOLANT DEGAS BOTTLE. ENGINEERING IS INVESTIGATING. *TT | |
| Bulletin Number: 16881 | |
| CHECK ENGINE LIGHT ON AND DIAGNOSTIC TROUBLE CODE P0460 (FUEL LEVEL SENSOR CIRCUIT MALFUNCTION) - SERVICE TIPS. *TT | |
| Bulletin Number: 16888 | |
| SQUEAK AND RATTLE CONDITION FROM THE INSTRUMENT PANEL. *TT | |
| Bulletin Number: 16909 | |
| LOSS OF INTERMITTENT WIPER OR WIPER PARK FUNCTIONS. *TT | |
| Bulletin Number: 16926 | |
| STABILITY ASSIST (ADVANCETRAC/IVD) SYSTEMS MAY NOT BE RECALIBRATED PROPERLY USING WDS. *TT | |
| Bulletin Number: 16956 | |
| NOISE FROM RIGHT HALFSHAFT SUPPORT BEARING. *TT | |
| Bulletin Number: 16970 | |
| HARSH TRANSMISSION ENGAGEMENT WITH POSSIBLE MALFUNCTION INDICATOR LAMP (MIL) AND DIAGNOSTIC TROUBLE CODE (DTC) P0705 (TR CIRCUIT FAILURE). *TT | |
| Bulletin Number: 16978 | |
| AIRBAG LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) B1932 (AIR BAG DRIVER CIRCUIT OPEN) OR B2232 (AIR BAG DRIVER CIRCUIT OPEN - LOOP #2). *TT | |
| Bulletin Number: 17028 | |
| 3-4 SHIFT FLARE/NEUTRAL - SERVICE TIP. *TT | |
| Bulletin Number: 17059 | |
| HOOD RELEASE CABLE BREAKING/BINDING IN COLD WEATHER. *TT | |
| Bulletin Number: 17062 | |
| INABILITY TO SHIFT GEARS DUE TO LOOSE SHIFT CABLES. ENGINEERING IS INVESTIGATING. *TT | |
| Bulletin Number: 17256 | |
| PREMATURE CLUTCH WEAR. *TT | |
| Bulletin Number: 17278 | |
| EXCESSIVE FRONT BRAKE PAD WEAR, FRONT BRAKE CREEP/GROAN NOISE, FRONT BRAKE DUST AND/OR ROTOR WEAR. *TT | |
| Bulletin Number: 17282 | |
| HARSH TRANSMISSION ENGAGEMENT WITH POSSIBLE MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODE (DTC) P0705 (TR CIRCUIT FAILURE). *TT | |
| Bulletin Number: 17298 | |
| REAR SHOCK NOISE FROM THE REAR OF THE VEHICLE OVER BUMPS. *TT | |
| Bulletin Number: 17302 | |
| VEHICLES NOT EQUIPPED WITH ANTI-LOCK BRAKE SYSTEM (ABS) MAY HAVE THE RED BRAKE LIGHT AND AMBER ABS LIGHT ON AFTER HYBRID ELECTRONC CLUSTER (HEC - INSTRUMENT CLUSTER) REPLACEMENT. *TT | |
| Bulletin Number: 17436 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0133 (02 SENSOR SLOW RESPONSE). *TT | |
| Bulletin Number: 17505 | |
| RUNS ROUGH AND/OR MALFUNCTION INDICATOR LAMP (MIL) ON CONDITION WITH DIAGNOSTIC TROUBLE CODES (DTCS) P402 AND/OR P0403 (EGR FLOW EXCESSIVE DETECTED/EGR CONTROL CIRCUIT) IN WET WEATHER OR IN A CAR WASH. *TT | |
| Bulletin Number: 17507 | |
| CLUNKING FOR RATTLING NOISE IN THE TRANSMISSION. *TT | |
| Bulletin Number: 17515 | |
| AUTOMATIC TURN SIGNAL CANCELLATION INOPERATIVE. *TT | |
| Bulletin Number: 17536 | |
| BELT SQUEAL. *MJ | |
| Bulletin Number: 17591 | |
| DIAGONAL WEAR OR CUPPING ON THE REAR TIRES. *TT | |
| Bulletin Number: 17652 | |
| 2ND OR 4TH GEAR MISSED WHEN SHIFTING AND/OR INTERMITTENT NEUTRALING WHEN SHIFTING INTO 4TH GEAR. *TT | |
| Bulletin Number: 17697 | |
| GEAR RATTLE OR GEAR ROLLOVER NOISE FROM THE TRANSAXLE AT IDLE, IN NEUTRAL, WITH THE CLUTCH PEDAL UP (ENGAGED). *TT | |
| Bulletin Number: 17778 | |
| LOSS OF POWER, HESITATION AND/OR MISFIRE AFTER COLD START. *TT | |
| Bulletin Number: 17804 | |
| GRINDING WHEN SHIFTING INTO THIRD GEAR. *TT | |
| Bulletin Number: 17842 | |
| 2ND OR 4TH GEAR MISSED WHEN SHIFTING AND/OR INTERMITTENT NEUTRALING WHEN SHIFTING INTO 4TH GEAR. *TT | |
| Bulletin Number: 17918 | |
| INOPERATIVE SPEED CONTROL SYSTEM. *TT | |
| Bulletin Number: 18273 | |
| A/C CONDENASTION LEAK. *EH | |
| Bulletin Number: 18321 | |
| HARSH TRANSMISSION ENGAGEMENT AND OR DTC P0705. *EH | |
| Bulletin Number: 18352 | |
| AIR BAG LIGHT IN WITH ALL OR ANY COMBINATION OF DTC B1881 B2434 B2438 AND OR C1947. *EH | |
| Bulletin Number: 18379 | |
| BRAKE AND ANTI-LOCK BRAKE SYSTEM LIGHTS ON AFTER HEC (HYBRID ELECTRONIC CLUSTER) REPLACEMENT. *TT | |
| Bulletin Number: 18411 | |
| MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0133, P1131 OR P2195. *TT | |
| Bulletin Number: 18413 | |
| UNABLE TO REMOVE IGNITION KEY - SERVICE TIP. *TT | |
| Bulletin Number: 18425 | |
| NO CRANK ON START CHARGING SYSTEM WARNING INDICATOR ON DRIVEABILITY CONCERNS AND OR MALFUNCTION INDICATOR LAMP ON. *EH | |
| Bulletin Number: 18463 | |
| VENT LEAK. *EH | |
| Bulletin Number: 18477 | |
| HARSH TRANSMISSION ENGAGEMENT AND OR DTC P0705. *EH | |
| Bulletin Number: 18581 | |
| ERRATIC INSTRUMENT CLUSTER GAUGES AND/OR WARNING INDICATORS - SERVICE TIP. *TT | |
| Bulletin Number: 19016 | |
| REPLACE TIMING BELT IDLER PULLEY DURING 2.0L ZETEC ENGINE CYLINDER HEAD REPLACEMENT - SERVICE TIP. *TT | |
| Bulletin Number: TSB-14-0148 | |
| FORD: ON SOME VEHICLES, OPERATING FOR AN EXTENDED TIME IN HIGH CORROSION AREA, A SAFETY RECALL 05S27 WAS ISSUED, WHERE REAR DOOR LATCHES EXPERIENCE CORROSION IN PAWL PIVOT AREA PREVENTING PROPER ENGAGEMENT OF PAWL INTO CATCH. MODEL 2000-0 | |
| Bulletin Number: TSB-14-0162 | |
| FORD: REAR DOOR LATCHES ARE EXPERIENCING CORROSION IN PAWL PIVOT AREA THAT PREVENT PROPER ENGAGEMENT OF PAWL INTO CATCH, WHEN OPERATED IN AREAS CAUSING HIGH CORROSION. MODEL 2000-05 FOCUS. *PE | |
| Bulletin Number: TSB-14-0163 | |
| FORD: DUE TO HIGH CORROSION AREAS, WHERE VEHICLES ARE OPERATED FOR EXTENDED PERIODS, LOWER CONTROL ARM (LCA) CAN SEPARATE FROM FORWARD ATTACHMENT OF SUBFRAME. MODEL 2001-04 ESCAPE. *PE | |
| 2002 FORD FOCUS SVT | |
| Bulletin Number: 030404 | |
| ROUGH, ROLLING, OR HIGH IDLE OR STALL - MAINLY AFTER COLD START, ENGINE - INTAKE SEPARATION AT RUBBER BOOTS - SVT MODELS ONLY. *TT | |
| Bulletin Number: 03E02 | |
| POWERTRAIN CONTROL MODULE REPROGRAMMING - EMISSIONS RECALL 03E02. *TT | |
| 2002 FORD FORD | |
| Bulletin Number: 011801 | |
| SUBJECT REGARDING INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *JG | |
| Bulletin Number: 020102 | |
| SOME VEHICLES MAY EXHIBIT A WEAK HORN CHIRP CONFIRMATION WHEN THE KEY FOB IS USED, OR AN INOPERATIVE HORN WHEN THE ENGINE IS NOT RUNNING. *TT | |
| Bulletin Number: 021004 | |
| SOME BI-FUEL LPG VEHICLES MAY EXHIBIT A NO START, ROLLING IDLE, SURGING IDLE AND / OR SURGE AT CRUISE CONDITION IN LPG MODE WITH ALT FUEL GREEN LIGHT ON. *TT | |
| Bulletin Number: 02133 | |
| SOME THINK NEIGHBORS MAY EXHIBIT A GAUGE MALFUNCTION, FAILURE TO CHARGE, REDUCED MILEAGE RANGE, OR INABILITY TO MOVE FORWARD OR REVERSE. *TT | |
| Bulletin Number: 021705 | |
| SUBJECT REGARDING AIR BAG DEPLOYMENT STRATEGY WITH ADVANCED RESTRAINT SYSTEM. *TT | |
| Bulletin Number: 0264 | |
| CONCERNS REGARDING 2002 THINK NEIGHBOR WATER LEAKS FROM ROOF OR WINDSHIELD AREA. *TT | |
| Bulletin Number: 030606 | |
| DIAGNOSTIC TROUBLE CODES FOR HIGH OXYGEN SENSOR VOLTAGE (P0132 AND P0152). CURRENT DIAGNOSTIC MAY RESULT IN PREMATURE REPLACEMENT OF THE COMPUVALVE. *TT *JB | |
| Bulletin Number: 15154 | |
| SOME VEHICLES BUILT FROM MAY 20,2001 THROUGH AUGUST 03,2001 EQUIPPED WITH THE CD6 IN-DASH RADIO MAY NOT ACCEPT CD'S OR READ FULL IN THE RADIO DISPLAY. *ET | |
| Bulletin Number: 15220 | |
| SUBJECT REGARDING 2.5L AND 3.0L 24-V DURATEC ENGINE DISASSEMBLY GUIDELINES. *TT | |
| Bulletin Number: 15483 | |
| SOME 2002 THINK NEIGHBORS MAY EXHIBIT A CRACKED COWL, OR OTHER BODY PANEL IF BRAKE FLUID IS ALLOWED TO CONTACT THE PLASTIC BODY PANELS. *TT | |
| Bulletin Number: 15487 | |
| CONCERNS WITH TIRE BALANCE WHEN VEHICLE IS EXHIBITING A VIBRATION CONDITION. *TT | |
| Bulletin Number: 15610 | |
| SUBJECT REGARDING 2002 THINK NEIGHBOR EXHIBITING A DIAGNOSTIC TROUBLE CODE 51. *TT | |
| Bulletin Number: 15619 | |
| FOR SOME THINK NEIGHBOR, THE INSTRUMENT GAUGE MAY NOT BE PROGRAMMED CORRECTLY FOR THE TYPE OF BATTERIES INSTALLED IN THE VEHICLE. *TT | |
| Bulletin Number: 15703 | |
| SOME THINK NEIGHBOR VEHICLES MAY EXHIBIT THE CHARGE ICON ILLUMINATED WHEN THE VEHICLE ISNOT ON CHARGE AND THE CHARGE CORD IS NOT CONNECTED TO THE VEHICLE. *TT | |
| Bulletin Number: 15718 | |
| SOME 2002 THINK NEIGHBOR MAY EXHIBIT AN INSTRUMENT GAUGE WHICH FAILS TO UPDATE STATE OF CHARGE ON BATTERY LEVEL INDICATOR. *TT | |
| Bulletin Number: 15774 | |
| SUBJECT REGARDING THINK NEIGHBOR BRAKE CHANGES. *TTY | |
| Bulletin Number: 15790 | |
| SUBJECT REGARDING 2002 THINK NEIGHBOR BRAKE LIGHT ILLUMINATION. *TT | |
| Bulletin Number: 15801 | |
| SOME THINK NEIGHBOR MAY EXHIBIT A HUM NOISE FROM THE CHARGER. *TT | |
| Bulletin Number: 15803 | |
| SOME THINK NEIGHBOR MAY EXPERIENCE THE LOSS OF DIAGNOSTIC TROUBLE CODES WHEN PULLING THEM OUT OF MEMORY FROM THE CLUSTER. *TT | |
| Bulletin Number: 15811 | |
| SOME THINK NEIGHBOR MAY EXHIBIT ACCELERATOR PEDAL SQUEAK DURING ACTIVATION OF THE ACCELERATOR. *TT | |
| Bulletin Number: 15845 | |
| SUBJECT REGARDING THINK NEIGHBOR ELECTRICAL LEAKS FROM THE BATTERY PACK TO THE FRAME WITH LEAKAGE ICON ILLUMINATION. *TT | |
| Bulletin Number: 15847 | |
| SOME THINK NEIGHBOR MAY EXHIBIT THE LOSS OF THE BATTERY WATER MAINTENANCE REMINDER ICON ILLUMINATING, HOWEVER, THE ICON MAY THEN RESET ITSELF AND TURN OFF. *TT | |
| Bulletin Number: 16108 | |
| SOME THINK NEIGHBOR VEHICLES MAY EXHIBIT IMPROPER OPERATION OF THE MULTIFUNCTION SWITCH DUE TO THE LIMITING CLIP NOT INSTALLED DURING THE MANUFACTURE PROCESS. *TT | |
| Bulletin Number: 16109 | |
| SOME THINK NEIGHBORS MAY EXHIBIT AN INOPERATIVE HORN. *TT | |
| Bulletin Number: 16127 | |
| SOME THINK NEIGHBOR MAY NOT ENABLE DUE TO A DAMAGED CHARGER FUSE CAP, MALFUNCTIONING CHARGER, OR INOPERATIVE CHARGER FUSE. *TT | |
| Bulletin Number: 16143 | |
| SOME THINK NEIGHBORS MAY EXHIBIT A VEHICLE NO ENABLE CONDITION DUE TO FRETTING CORROSION BETWEEN THE 23 PIN HARNESS CONNECTOR AND THE MOTOR CONTROLLER. *TT | |
| Bulletin Number: 16672 | |
| REVERSE SENSING SYSTEM WARNING INCONSISTENT OR INOPERATIVE. *TT *JB | |
| 2002 FORD F SERIES | |
| Bulletin Number: 02M01 | |
| CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6 | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 03261 | |
| NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 15199 | |
| SOME VEHICLES MAY EXHIBIT A CONDITION WHERE THE TRANSMISISON TEMPERATURE GAUGE READS IN THE MIDDLE AT START UP. *YD | |
| Bulletin Number: 15355 | |
| SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT | |
| Bulletin Number: 15373 | |
| SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES. *TT | |
| Bulletin Number: 15397 | |
| SOME VEHICLES MAY EXHIBIT A CONDITION OF OIL CONTAMINATION IN COOLING SYSTEM. *TT | |
| Bulletin Number: 15504 | |
| SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT | |
| Bulletin Number: 15594 | |
| SUPER DUTY ERRATIC COOLANT TEMPERATURE GAUGE READINGS - CONCERNS. *TT | |
| Bulletin Number: 15605 | |
| SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT | |
| Bulletin Number: 15693 | |
| SUBJECT REGARDING CONNECTING ROD COMMONIZATION FOR 2002 SUPER DUTY AND LIGHT DUTY. *TT | |
| Bulletin Number: 15708 | |
| SOME VEHICLES MAY EXHIBIT WHEELS THAT SEIZE TO THE HUBS AND ARE DIFFICULT TO REMOVE DURING SERVICE. *TT | |
| Bulletin Number: 15757 | |
| SUBJECT REGARDING VEHICLES EXHIBITING COLD START ROLLING IDLE. *TT | |
| Bulletin Number: 15761 | |
| SOME DEDICATED CNG VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS OF HARD START / NO START / ROUGH RUNNING. *TT | |
| Bulletin Number: 16094 | |
| SOME VEHICLES MAY EXHIBIT FUEL DIAGNOSTIC TROUBLE CODES P0171, P0172, P0174, P0175 OR MASS AIR FLOW DIAGNOSTIC TROUBLE CODES P0102, P0103, P0112, P0113. *TT | |
| Bulletin Number: 16683 | |
| FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB | |
| Bulletin Number: 16891 | |
| CLEAR GEL-LIKE SUBSTANCE IN THE HYDRAULIC BRAKE MASTER CYLINDER RESERVOIR. THIS SUBSTANCE IS A SILICONE BASE LUBRICANT USED DURING ASSEMBLY OF THE MASTER CYLINDER. *TT | |
| Bulletin Number: TB-08-258 | |
| JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE | |
| 2002 FORD F SERIES (HEAVY) | |
| Bulletin Number: 15448 | |
| EXHIBITING A SLIGHT BRAKE PULL TO THE RIGHT ON INITIAL BRAKE APPLICATION AND THEN A SLIGHT BRAKE PULL TO THE LEFT UPON RELEASE OF THE BRAKE PEDAL. *TT | |
| Bulletin Number: CSP-48B01 | |
| FORD: VEHICLES MISTAKENLY CHARGED $100 POWERTRAIN WARRANTY DEDUCTIBLE FOR FUEL INJECTOR REPAIR OR REPAIRS. NO MODEL OR MODEL YEARS PROVIDED. *PE ECONOLINE, EXCURSION AND F-SERIES SUPER DUTY VEHICLES, MODEL YEARS 2002-2005. UPDATED | |
| 2002 FORD F SERIES (LIGHT) | |
| Bulletin Number: 15398 | |
| SOME VEHICLES MAY EXHIBIT A COOLANT LEAK DUE TO A BROKEN RADIATOR HOSE CLAMP. *TT | |
| Bulletin Number: 15517 | |
| SUBJECT REGARDING EXAGGERATED ENGINE BRAKING ON DECELERATION. *YD | |
| 2002 FORD F SUPER DUTY | |
| Bulletin Number: 01185 | |
| SUBJECT REGARDING ENGINE COOLING SYSTEM.*JB | |
| Bulletin Number: 02219 | |
| ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS - SERVICE TIPS. *TT | |
| Bulletin Number: 031404 | |
| ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 031910 | |
| BRAKE PULL. 4X4 F-250/350 AND EXCURSION VEHICLES ONLY. *TT | |
| Bulletin Number: 03192 | |
| LEAK OIL AROUND THE EXHAUST BACKPRESSURE ACTUATOR (EBP) - 7.3L DIESEL TURBOCHARGER PEDESTALS. *TT | |
| Bulletin Number: 03203 | |
| MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT | |
| Bulletin Number: 032151 | |
| SOME 7.3L DIESEL TURBOCHARGER PEDESTALS MAY LEAK OIL AROUND THE EXHAUST BACK PRESSURE ACTUATOR (EBP). *TT THIS ARTICLE SUPERSEDES TSB 03-21-51 DATED 10/30/2003. *TT | |
| Bulletin Number: 03222 | |
| SQUEAKING AND/OR SQUEALING NOISE FROM THE CENTER BEARING WHILE DRIVING ON VEHICLES BUILT WITH A MULTI-PIECE DRIVESHAFT. *TT | |
| Bulletin Number: 0345 | |
| (WAIT TO START) LAMP DOES NOT OPERATE PROPERLY ON 2002-2003 MODELS. *TT *JB | |
| Bulletin Number: 03B03 | |
| ADJUSTABLE ACCELERATOR PEDAL SENSOR REPLACEMENT FOR VEHICLES EXHIBITING A PROBLEM WITH THE ADJUSTABLE ACCELERATOR PEDAL AND A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0221 OR P0122. *TT SUPPLEMENT #1. *T | |
| Bulletin Number: 041601 | |
| WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT | |
| Bulletin Number: 04168 | |
| VACUM PUMP INOPERATIVE OR RUNS CONTINUOSLY - CLIMATE CONTROL DEFAULT TO DEFROST. *AR | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04239 | |
| WATER LEAK - ROOF FLANGE AREA - WATER ACCUMULATION IN HEADLINER AND/OR LEAK AT THE CAB FLOOR PAN AREA. *TT | |
| Bulletin Number: 04262 | |
| FALSE PARKING AID WARNINGS. *TT UPDATE. *TT | |
| Bulletin Number: 04266 | |
| A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP. *TT | |
| Bulletin Number: 05417 | |
| INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT | |
| Bulletin Number: 0554 | |
| USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE. *TT | |
| Bulletin Number: 07212 | |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE | |
| Bulletin Number: 15173 | |
| SOME VEHICLES EQUIPPED WITH A 7.3L POWERSTROKE MAY EXHIBIT SOME AND/OR ALL OF THE FOLLOWING DIAGNOSTIC TROUBLE CODES, P0230,P0640,P0670,P1662,P1690. *YH | |
| Bulletin Number: 15374 | |
| SOME VEHICLES MAY EXHIBIT VARIOUS ELECTRICAL CONDITIONS SUCH AS DOOR AJAR LIGHT ILLUMINATED WHILE ENGINE IS RUNNING AND DOORS ARE CLOSED, 4X4 INDICATOR INOPERATIVE, RADIO STAYING ON WITH ENGINE OFF, AND THE SPEEDOMETER SCALING SYMBOL ILLUMI | |
| Bulletin Number: 15398 | |
| SOME VEHICLES MAY EXHIBIT A COOLANT LEAK DUE TO A BROKEN RADIATOR HOSE CLAMP. *TT | |
| Bulletin Number: 15412 | |
| SOME VEHICLES MAY EXHIBIT A CRANK/NO START CONDITION DUE TO FAILURE OF FUEL PUMP FUSE #40 OR AN ENGINE REMAINS AT IDLE CONDITION WITH DIAGNOSTIC TROUBLE CODE P0211. *TT | |
| Bulletin Number: 15533 | |
| SUBJECT REGARDIDNG SQUEAK AND RATTLE CONDITION. *YD | |
| Bulletin Number: 15578 | |
| SOME VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) LIGHT ON, B2141/B2477, AND/OR AN INACCURATE SPEEDOMETER. *TT | |
| Bulletin Number: 15678 | |
| COOLANT LEAK DUE TO A BROKEN LOWER RADIATOR HOSE CLAMP. *TT | |
| Bulletin Number: 15871 | |
| SOME VEHICLES MAY EXHIBIT INTERFERENCE AND / OR STATIC IN THE LAND-MOBILE RADIO. *TT | |
| Bulletin Number: 16597 | |
| COOLANT LEAK DUE TO A BROKEN LOWER RADIATOR HOSE CLAMP. *TT | |
| Bulletin Number: 16697 | |
| EXHAUST AIR RUSH NOISE AND LOWER POWER. *TT *JB | |
| Bulletin Number: 16835 | |
| TAILGATE LOCKING BY ITSELF WHEN SLAMMED SHUT OR WHEN THE VEHICLE IS BEING DRIVEN OVER ROUGH ROADS. *TT | |
| Bulletin Number: 16891 | |
| CLEAR GEL-LIKE SUBSTANCE IN THE HYDRAULIC BRAKE MASTER CYLINDER RESERVOIR. THIS SUBSTANCE IS A SILICONE BASE LUBRICANT USED DURING ASSEMBLY OF THE MASTER CYLINDER. *TT | |
| Bulletin Number: 16913 | |
| REPEAT P0122, P0123, P0221 DIAGNOSTIC TROUBLE CODES AFTER REPLACEMENT OF THE ACCELERATOR PEDAL SENSOR. *TT | |
| Bulletin Number: 16921 | |
| COOLANT LEAK DUE TO BROKEN RADIATOR HOSE CLAMP. 1999-2003 MODELS. *TT | |
| Bulletin Number: 17020 | |
| DRIVESHAFT CENTER BEARING NOISE. *TT | |
| Bulletin Number: 19015 | |
| FUEL CONDITIONER. LOW POWER, POOR FUEL ECONOMY, FUEL GELLING IN COLD WEATHER, EXCESSIVE WHITE SMOKE ON COLD START, HARD START, OR COKING OF COMPONENTS EXPOSED TO EXHAUST. *TT | |
| Bulletin Number: ASI-44408 | |
| FORD: THE RESTRAINT CONTROL MODULE (RCM) WHEN USING VCM II, WOULD HAVE AN ERROR CODE 35 AND DIAGNOSTIC TROUBLE CODE (DTC) B1035, AND DIFFICULTY ATTEMPTING PROGRAMMABLE MODULE INSTALLATION (PMI). MODEL 2001-2004 F-SUPER DUTY. *PE | |
| Bulletin Number: CSP-48B01 | |
| FORD: VEHICLES MISTAKENLY CHARGED $100 POWERTRAIN WARRANTY DEDUCTIBLE FOR FUEL INJECTOR REPAIR OR REPAIRS. NO MODEL OR MODEL YEARS PROVIDED. *PE ECONOLINE, EXCURSION AND F-SERIES SUPER DUTY VEHICLES, MODEL YEARS 2002-2005. UPDATED | |
| 2002 FORD MOTOR HOME | |
| Bulletin Number: 15264 | |
| SOME MOTORHOME STRIPPED CHASSIS MAY HAVE A CUSTOMER COMPLAINT OF POWER STEERING WHINE. *TT | |
| Bulletin Number: 16683 | |
| FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB | |
| Bulletin Number: TSB-10-12-11 | |
| FORD: SOME MOTORHOME CHASSIS VEHICLES EQUIPPED WITH A 6.8L ENGINE MAY EXHIBIT HESITATION, LOSS OF RPM AND/OR LOW IDLE RPM DRIVEABILITY CONCERNS. REPROGRAM THE POWERTRAIN CONTROL MODULE (PCM) TO THE LATEST CALIBRATION USING IDS RELEASE 67. | |
| 2002 FORD MOUNTAINEER | |
| Bulletin Number: 01134 | |
| FUEL HESITATION WHILE MAKING HARD SWEEPING RIGHT HAND TURNS (SUCH AS A HIGHWAY ON-RAMP) | |
| Bulletin Number: 0322 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT | |
| Bulletin Number: 0361 | |
| MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB | |
| Bulletin Number: 05310 | |
| SAFETY BELT WEB STOP BUTTON SERVICE. *EH | |
| Bulletin Number: 15181 | |
| SOME VEHICLES EQUIPPED WITH 4.6L ENGINE AND 5R55W TRANSMISSION MAY EXHIBIT VARIOUS FIRM AND/OR SOFT SHIFTS. *ET | |
| Bulletin Number: 15193 | |
| SOME VEHICLES MAY EXHIBIT INTERMITTENT DIFFICULTY TURNING THE IGNITION KEY UPON STARTING. *JG | |
| Bulletin Number: 18423 | |
| AXLE WHINE HOWL SERVICE WITH INDIVIDUAL PARTS INSTEAD OF AN AXLE ASSEMBLY. *EH | |
| Bulletin Number: 18466 | |
| AXLE WHINE HOWL. THIS INCLUDES 1997-05 FORD VEHICLES. *EH | |
| Bulletin Number: 18478 | |
| AXLE SEAL LEAKS. *EH | |
| 2002 FORD MUSTANG | |
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01157 | |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| Bulletin Number: 01181 | |
| BRAKE SHIFT INTERLOCK.*JB | |
| Bulletin Number: 01205 | |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT | |
| Bulletin Number: 012113 | |
| SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 0214 | |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| Bulletin Number: 021702 | |
| SOME VEHICLES EQUIPPED WITH A 4.6L 2V ENGINE BUILT BEFORE MAY 17, 2002, MAY EXHIBIT AN OIL LEAK COMING FROM THE CRANKCASE / VALVE COVER AREA. *TT | |
| Bulletin Number: 02172 | |
| ENGINE-OIL LEAK FROM POSITIVE CRANKCASE VENTILATION (PCV) VALVE AREA-VEHICLES BUILT BEFORE 5/17/2002 EQUIPPED WITH 4.6L 2V ENGINE ONLY. *MJ | |
| Bulletin Number: 02176 | |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| Bulletin Number: 02178 | |
| NOISE-WINDNOISE FROM THE A PILLAR AREA. *MJ | |
| Bulletin Number: 02208 | |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH | |
| Bulletin Number: 02221 | |
| ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0254 | |
| ON SOME VEHICLES EQUIPPED WITH THE 4.6L ENGINE, THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY HYDROPLANE ON THE WATER PUMP PULLEY WHENTHE BELT IS SPLASHED WITH WATER. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 0258 | |
| INOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639. *TT | |
| Bulletin Number: 02M01 | |
| CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6 | |
| Bulletin Number: 030105 | |
| PASSENGER SEAT RUBS AGAINST DOOR PANEL. *TT | |
| Bulletin Number: 031404 | |
| ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. | |
| Bulletin Number: 03144 | |
| ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 03164 | |
| SOME VEHICLES, EQUIPPED WITH THE 4.6L 2V ENGINE, WITH AN ENGINE BUILD DATE PRIOR TO 8/29/03 MAY EXHIBIT AN ENGINE TICK NOISE THAT IS PRESENT AT ALL TEMPERATURES DURING IDLE. 2004 MODELS INCLUDED. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 0322 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT | |
| Bulletin Number: 03223 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| Bulletin Number: 03256 | |
| ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003. *MJ | |
| Bulletin Number: 03261 | |
| NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT | |
| Bulletin Number: 0361 | |
| MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB | |
| Bulletin Number: 0395 | |
| POPPING TYPE NOISE WHILE TURNING INTO OR OUT OF AN INCLINE, SUCH AS TURNING INTO A DRIVEWAY, AT LOW SPEEDS (BELOW 15 MPH (25 KM/H). *TT | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 041003 | |
| EXHAUST LEAK - CRACKED OR SEPARATED RIGHT SIDE EXHAUST PIPE - 3.8L AND 3.9L ENGINES. *TT | |
| Bulletin Number: 04103 | |
| EXHAUST LEAK. RIGHT SIDE EXHAUST PIPE ON 3.8L OR 3.9L ENGINE. *TT | |
| Bulletin Number: 04111 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. | |
| Bulletin Number: 0412 | |
| HEADLINER SAGGING IN REAR OF VEHICLE. *TT | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 04156 | |
| TR3650 MANUAL TRANSMISSION - JUMPS OUT OF GEAR 2ND AND/OR 3RD - CLASH NOISE AND/OR RASPY FEEL ON GEAR ENGAGEMENT. *TT | |
| Bulletin Number: 041601 | |
| WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04189 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 04198 | |
| MANUAL TRANSMISSION HARD TO SHIFT INTO FIRST/REVERSE FROM A STOP. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 04248 | |
| STEERING RACK NOISE. *TT SQUEAK/CREAK NOISE FROM STEERING RACK WHEN TURNING. *SC | |
| Bulletin Number: 05310 | |
| SAFETY BELT WEB STOP BUTTON SERVICE. *EH | |
| Bulletin Number: 06216 | |
| LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS. *TT | |
| Bulletin Number: 07212 | |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE | |
| Bulletin Number: 15158 | |
| SOME VEHICLES MAY EXHIBIT A FEAD BELT JUMP-OFF TOSS. *YH | |
| Bulletin Number: 15373 | |
| SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES. *TT | |
| Bulletin Number: 15463 | |
| CONCERNS WITH VEHICLES EXHIBITING DOOR GLASS INOPERATIVE CONDITION. *TT | |
| Bulletin Number: 15585 | |
| SOME CONVERTIBLES MAY EXHIBIT A CONDITION WHERE THE CONVERTIBLE TOP LIFTS UNEVENLY. *TT | |
| Bulletin Number: 15669 | |
| CONCERNS WITH A TR3650 MANUAL TRANSMISSION EXHIBITING CLASH/GRINDING SOUND DURING THE FIRST FEW MILES OF DRIVING. *TT | |
| Bulletin Number: 15702 | |
| SUBJECT REGARDING SPEED CONTROL LAMP. *TT | |
| Bulletin Number: 15788 | |
| SUBJECT REGARDING P0460 DIAGNOSTIC TROUBLE CODE AND MALFUNCTION INDICATOR LAMP ILLUMINATION. *TT | |
| Bulletin Number: 15922 | |
| SUBJECT REGARDING INACCURATE SPEEDOMETER. *TT | |
| Bulletin Number: 15934 | |
| SOME VEHICLES WITH THE TR6350 MANUAL TRANSMISSION MAY EXHIBIT A LIGHT TICKING / RATTLE NOISE WHILE DRIVING AFTER A COLD ENGINE START. *TT | |
| Bulletin Number: 15969 | |
| SOME VEHICLES MAY EXHIBIT A WIND NOISE FROM EITHER SIDE OF THE A-PILLAR AREA. *TT | |
| Bulletin Number: 16067 | |
| SOME VEHICLES WITH MANUAL TRANSMISSION MAY EXHIBIT A HARD TO SHIFT INTO GEAR CONDITION PARITCULARLY FROM A STOP INTO FIRST OR REVERSE GEAR. *TT | |
| Bulletin Number: 16069 | |
| SOME COBRAS MAY EXHIBIT A CLUNK NOISE FROM THE DRIVELINE DURING A QUICK ACCLERATION JUST AFTER COAST (TIP-IN CLUNK). *TT | |
| Bulletin Number: 16316 | |
| CONVERTIBLE TOP LIFTS UNEVENLY. *TT | |
| Bulletin Number: 16380 | |
| SERVICE CYLINDER HEAD GASKET FOR 4.6L APPLICATIONS. *TT | |
| Bulletin Number: 16644 | |
| SOME VEHICLES EQUIPPED WITH A 3.8L ENGINE AND THE T5 TRANSMISSION MAY EXHIBIT HIGH IDLE BETWEEN SHIFTS. *TT | |
| Bulletin Number: 16907 | |
| LOOSE DOOR TRIM PANEL OR A NOISE FROM THE DOOR TRIM PANEL AREA WHEN DRIVING OVER BUMPS. *TT | |
| Bulletin Number: 17104 | |
| TICKING/TAPPING NOISE WITH THE ENGINE WARMED UP AND THE TRANSMISSION IN GEAR AT IDLE. 2003 E150 INCLUDED. *TT | |
| Bulletin Number: 17171 | |
| CONVERTIBLE TOP LIFTING UNEVENLY. *TT | |
| Bulletin Number: 17286 | |
| THUMP NOISE WHEN AIR CONDITIONING CLUTCH ENGAGES. *TT | |
| Bulletin Number: 17453 | |
| CONDENSATION AND/OR WATER ACCUMULATION IN THE HEADLAMP ASSEMBLY. *TT | |
| Bulletin Number: 17510 | |
| DRIVELINE CLUNK DURING GEAR CHANGES AND/OR QUICK ACCELERATION AFTER COAST (TIP-IN) CLUNK. *TT | |
| Bulletin Number: 17531 | |
| THUMP NOISE WHEN A/C CLUTCH ENGAGES. *MJ | |
| Bulletin Number: 17577 | |
| GEAR WHINE IN 1ST, 3RD AND REVERSE GEARS. *TT | |
| Bulletin Number: 17868 | |
| INTERMITTENT LOSS OF POWER OR CRANK NO START - POSSIBLE PATS LAMP FLASHING AND DIAGNOSTIC TROUBLE CODES (DTCS) U1147 AND/OR U1262. *TT | |
| Bulletin Number: 18229 | |
| POP/CLUNK OR SQUEALING NOISE FROM THE STEERING GEAR WHEN TURNING, DRIVING OVER BUMPS, OR BRAKING. OASIS. *TT | |
| 2002 FORD MUSTANG GT | |
| Bulletin Number: 15716 | |
| INFORMATION ON OIL CAPACITY CHANGED. *TT | |
| Bulletin Number: 15717 | |
| SOME VEHICLES MAY EXHIBIT AN OIL LEAK COMING FROM THE CAMSHAFT / VALVE COVER AREA WHERE THE POSITIVE CRANKCASE VENTILATION (PCF) VALVE MOUNTS. *TT | |
| 2002 FORD NAVIGATOR | |
| Bulletin Number: 15122 | |
| SOME VEHICLES MAY EXHIBIT A VIBRATION AT IDLE AND/OR ENGINE DROANING NOISE ON ACCELERATION FROM A STOP. *SLC | |
| Bulletin Number: 15123 | |
| SOME VEHICLES MAY EXHIBIT A DRIVELINE VIBRATION AT SPEEDS BETWEEN 60-70 MPH. *SLC | |
| Bulletin Number: 15137 | |
| CUSTOMERS MAY COMPLAIN OF WIND NOISE. *YD | |
| Bulletin Number: 16400 | |
| REAR AXLE SEAL LEAK - CONTACT REQUEST. *MJ | |
| Bulletin Number: 16403 | |
| ENGINE-LIGHT TICK OR RATTLE TYPE NOISE FROM ENGINE AFTER COLD START. *MJ | |
| 2002 FORD RANGER | |
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01157 | |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| Bulletin Number: 01181 | |
| BRAKE SHIFT INTERLOCK.*JB | |
| Bulletin Number: 01205 | |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT | |
| Bulletin Number: 012113 | |
| SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 0186 | |
| ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT | |
| Bulletin Number: 0196 | |
| SOME 4X4 SUPER CAB VEHICLES MAY EXHIBIT A LOW FREQUENCY THUMP TYPE NOISE / VIBRATION ON LIGHT ACCELERATION FROM A STOP, AND / OR WHEN COMING TO A STOP WITH LIGHT TO MODERATE BRAKING. *TT | |
| Bulletin Number: 020801 | |
| RATTLE NOISE FROM PRIMARY CHAIN DRIVE AREA 2000-3000 RPM - 4.0L SOHC ENGINE. *TT | |
| Bulletin Number: 021010 | |
| SOME 4X2 VEHICLES MAY EXHIBIT A PULL TO RIGHT OR LEFT WHILE BRAKING. *TT | |
| Bulletin Number: 02109 | |
| A THUMP OR BUMP SENSATION FELT IMMEDIATELY ON ACCELERATION FROM A STOP OR UPON BRAKING WHEN COMING TO A COMPLETE STOP. *TT | |
| Bulletin Number: 02138 | |
| LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. *TT | |
| Bulletin Number: 02176 | |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| Bulletin Number: 02191 | |
| THUMP/BUMP ON ACCELERATION FROM A STOP OR WHEN BRAKING FROM DRIVESHAFT AREA-4X2 AUTOMATIC TRANSMISSION SUPER CAB EDGE MODELS ONLY. *MJ | |
| Bulletin Number: 02192 | |
| DRIVESHAFT-THUMP/CLUNK HEARD ON LIGHT ACCELERATION FROM A STOP OR WHEN BRAKING AND COMING TO A STOP. | |
| Bulletin Number: 022110 | |
| MANUAL SHIFT LEVER OUTER BOOT DETACHMENT - FX4 MODELS EQUIPPED WITH MANUAL TRANSMISSION ONLY. *TT | |
| Bulletin Number: 02221 | |
| ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ | |
| Bulletin Number: 02222 | |
| NOISE-GEAR WHINE NOISE IN 1ST AND 2ND GEAR ONLY-VEHICLES EQUIPPED WITH 5R55E TRANSMISSION AND 4.0L ENGINE ONLY. *MJ | |
| Bulletin Number: 02224 | |
| VIBRATION-ENGINE VIBRATION AT IDLE-VEHICLES EQUIPPED WITH 3.0L ENGINE-VEHICLES BUILT BEFORE 11/26/2001 ONLY. *MJ | |
| Bulletin Number: 02232 | |
| FRAME MOUNTED FRONT BUMPER BRACKETS SERVICE KIT. *TT | |
| Bulletin Number: 0232 | |
| SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301. *TT | |
| Bulletin Number: 0242 | |
| CERTAIN VEHICLES WITH 4X4 OR ALL-WHEEL DRIVE MAY HAVE A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0255 | |
| HOOTING, EEKING OR MOANING NOISE COMING FROM THE CLUTCH WHEN SHIFTING GEARS. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 0258 | |
| INOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639. *TT | |
| Bulletin Number: 0276 | |
| INFORMATION ON DIAGNOSING ENGINE RATTLE NOISE FROM PRIMARY CHAIN DRIVE AREA BETWEEN 2000-3000 RPM ON COLD ENGINE OPERATION ONLY. *TT | |
| Bulletin Number: 0281 | |
| SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC (SINGLE OVER-HEAD CAM) ENGINE MAY EXHIBIT A PRIMARY TIMING CHAIN RATTLE NOISE. *TT | |
| Bulletin Number: 0282 | |
| SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. *TT | |
| Bulletin Number: 0283 | |
| SOME VEHICLES EQUIPPED WITH A 2.3L, 3.0L OR 4.0L ENGINE AND 5R44E OR 5R55E AUTOMATIC TRANSMISSION MAY EXHIBIT A FLUID LEAK AT THE TRANSMISSION SERVO COVERS IN COLD CLIMATES. *TT | |
| Bulletin Number: 02M01 | |
| CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6 | |
| Bulletin Number: 030302 | |
| DRIVESHAFT - THUMP/CLUNK HEARD ON LIGHT ACCELERATION FROM A STOP OR WHEN BRAKING AND COMING TO A STOP. *TT | |
| Bulletin Number: 03048 | |
| THUMP/CLUNK ON LIGHT ACCELERATION FROM STOP OR WHEN BRAKING AND COMING TO A STOP ON CERTAIN 4X4 SUPER CAB EQUIPPED WITH AUTOMATIC TRANSMISSION AND STEEL DRIVESHAFT. *TT | |
| Bulletin Number: 030508 | |
| FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD. *TT | |
| Bulletin Number: 03148 | |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 03203 | |
| MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT | |
| Bulletin Number: 0322 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT | |
| Bulletin Number: 03223 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| Bulletin Number: 03231 | |
| INOPERABLE LATCHES, LOCKS AND/OR LIFT STRUTS ON VEHICLES EQUIPPED WITH A HARD TONNEAU COVER. *TT | |
| Bulletin Number: 03235 | |
| BED EXTENDER COMPONENT REPLACEMENT SERVICE TIP. *TT | |
| Bulletin Number: 0327 | |
| DIAGNOSTIC TROUBLE CODES (DTC) B1877 (DRIVER PRETENSIONER CIRCUIT RESISTANCE HIGH) AND/OR B1881 (PASSENGER PRETENSIONER CIRCUIT RESISTANCE HIGH), INDICATING A HIGH RESISTANCE IN THE SAFETY BELT PRETENSIONER CIRCUIT. *TT | |
| Bulletin Number: 0332 | |
| THUMP TYPE NOISE/VIBRATION HEARD ON LIGHT ACCELERATION FROM A STOP OR WHEN BRAKING AND COMING TO A STOP. *TT | |
| Bulletin Number: 0335 | |
| IDLE AIR CONTROL (IAC) VALVE DIAGNOSTIC SERVICE TIPS. *TT | |
| Bulletin Number: 0358 | |
| FLUID MAY LEAK OUT OF THE FRONT AXLE VENT TUBE. *TT *JB | |
| Bulletin Number: 0361 | |
| MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB | |
| Bulletin Number: 0369 | |
| DIAGNOSTIC TROUBLE CODE B1877 AND/OR B1881 INDICATING A HIGH RESISTANCE IN THE SAFETY BELT PRETENSIONER CIRCUIT. *TT *JB | |
| Bulletin Number: 0369 | |
| SAFETY BELT PRETENSIONER DIAGNOSTIC TROUBLE CODES (DTC) B1877 AND/OR B1881. *TT | |
| Bulletin Number: 0393 | |
| BUZZ/HOWL IN THE TRANSFER CASE SHIFT LEVER WHILE DRIVING, AND/OR SHIFT LEVER BOOT DETACHMENT DUE TO INSUFFICIENT RETENTION OF THE BOOT(S). *TT | |
| Bulletin Number: 0394 | |
| PULL TO RIGHT OR LEFT CONDITION WHILE BRAKING ON 4.2 (NON-EDGE) COIL SPRING EQUIPPED VEHICLES. *TT | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 04111 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. | |
| Bulletin Number: 04147 | |
| SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS. *TT | |
| Bulletin Number: 0415 | |
| LOWER ENGINE OIL LEAKS 3.0L 2V VULCAN ENGINE. DIAGNOSTIC SERVICE TIPS. *TT | |
| Bulletin Number: 041610 | |
| GRABBING CONDITION FROM REAR DRUM BRAKES. *AR *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04217 | |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04237 | |
| DRIVESHAFT THUMP CLUNK ON LIGHT ACCELERATION FROM STOP OR WHEN BRAKING AND COMING TO A STOP. *EH | |
| Bulletin Number: 042419 | |
| REVISED PROCEDURE FOR ADJUSTING ALIGNMENT ON ALL SUSPENSIONS - NEW RIGHT HAND UPPER CONTROL ARM DESIGN FOR TORSION BAR FRONT SUSPENSIONS. *TT | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 04251 | |
| ALUMINUM CORROSION - SERVICE TIP. *TT | |
| Bulletin Number: 0486 | |
| BOOM/VIBRATION AT 1800-2200 RPM, ROUGH IDLE. *TT | |
| Bulletin Number: 0513 | |
| INSIDE DOOR PULL HANDLE LOOSE - VEHICLES BUILT BEFORE 11/15/2002 AND EQUIPPED WITH POWER WINDOWS/DOOR LOCKS. *TT | |
| Bulletin Number: 052212 | |
| BUCK/JERK AND MISS DURING DRIVE CYCLE ABOVE 3000 RPM - NO DTC - 3.0L 2V GAS AND FFV ENGINE. *TT | |
| Bulletin Number: 06116 | |
| POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT - SERVICE TIP. *TT | |
| Bulletin Number: 06166 | |
| POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT. *KB | |
| Bulletin Number: 14868 | |
| SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC ENGINE MAY EXHIBIT A PRIMARY CHAIN RATTLE NOISE (SOMETIMES DESCRIBED AS A SPARK KNOCK-TYPE NOISE). *TT | |
| Bulletin Number: 15290 | |
| SOME 4.0L SOHC MAY EXHIBIT AN ENGINE OIL LEAK CONDITION, COMING FROM THE OIL PAN OR LADDER FRAME AREA. *TT | |
| Bulletin Number: 15313 | |
| SOME VEHICLES EQUIPPED WITH A 2.3L ENGINE MAY EXHIBIT POOR IDLE QUALITY, HESITATION/SURGE ON LIGHT ACCELERATION. *TT | |
| Bulletin Number: 15314 | |
| ON SOME VEHICLES, THE ENGINE TEMPERATURE GAUGE MAY EXHIBIT A DOWNWARD MOVEMENT TO THE COOL REGION OF THE GAGE. *TT | |
| Bulletin Number: 15378 | |
| SOME VEHICLES WITH THE 4.0L ENGINE MAY EXHIBIT AN ENGINE FLUTTER NOISE. *TT | |
| Bulletin Number: 15381 | |
| SOME VEHICLES WITH A MANUAL TRANSMISSION MAY EXHIBIT AN ENGINE LOSS OR REDUCTION IN POWER CONDITION ON DECELERATION, BUT WILL IMMEDIATELY RESTART. *TT | |
| Bulletin Number: 15470 | |
| CONCERNS WITH SPARK KNOCK NOISE OR CHAIN RATTLE NOISE BETWEEN 2000-3000 RPM, DURING COLD ENGINE OPERATION ONLY. *TT | |
| Bulletin Number: 15486 | |
| SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457 (GROSS LEAK AFTER FUEL FILL). *TT | |
| Bulletin Number: 15504 | |
| SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT | |
| Bulletin Number: 15532 | |
| INFORMATION ON VEHICLES EXHIBITNG FUEL LINE DAMAGE DUE TO PINCHING/SQUEEZING OF THE FUEL RETURN LINE. *TT | |
| Bulletin Number: 15563 | |
| INFORMATION REGARDING MALFUNCTION INDICATOR LIGHT ILLUMINATING WITH DIAGNOSTIC TROUBLE CODE P0300/P0301.*YH | |
| Bulletin Number: 15605 | |
| SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT | |
| Bulletin Number: 15625 | |
| CONCERNS WITH 5R44E AUTOMATIC TRANSMISSION FLUID LEAK. *TT | |
| Bulletin Number: 15692 | |
| SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT | |
| Bulletin Number: 15785 | |
| SOME VEHICLES EQUIPPED WITH 5R55E/5R44E TRANSMISSION MAY EXHIBIT A WHINE NOISE IN 1ST GEAR THAT GOES AWAY AFTER THE 1-2 OR 1-3 SHIFT IS COMPLETED. *TT | |
| Bulletin Number: 15813 | |
| SOME VEHICLES EQUIPPED WITH 4WABS MAY EXHIBIT DIAGNOSTIC TROUBLE CODES C1233 AND C1234 (ANTI-LOCK BRAKE SENSOR OUTPUT FAILURE). *TT | |
| Bulletin Number: 15859 | |
| SOME VEHICLES WITH 4WABS MAY EXHIBIT DIAGNOSTIC TROUBLE CODES C1233 AND C1234 (ANTI-LOCK BRAKE SENSOR OUTPUT FAILURE). *TT | |
| Bulletin Number: 15863 | |
| SUBJECT REGARDING A WHINE NOISE CONDITION FROM THE SPEAKERS WHEN USING THE RADIO OR THE CD WITH THE PIONEER TREMORE / PIONEER ULTIMATE 450 WATT AUDIO SYSTEM. *TT | |
| Bulletin Number: 15869 | |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT SOFT CLUTCH PEDAL WHICH MAY CAUSE DIFFICULTY IN SHIFTING GEARS (A NOTCHY FEEL). *TT | |
| Bulletin Number: 15880 | |
| SOME VEHICLES MAY EXHIBIT A DISENGAGED FAN CLUTCH BEARING SQUEAL NOISE IN COLD WEATHER. *TT | |
| Bulletin Number: 15887 | |
| SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). *TT | |
| Bulletin Number: 15905 | |
| SUBJECT REGARDING PIONEER TREMOR / ULTIMATE 450 WATT AUDIO SYSTEM WHINE NOISE. *TT | |
| Bulletin Number: 15929 | |
| SOME XLT MODLES MAY EXHIBIT WRINKLED, LOOSE, OR BAGGY FABRIC ON THE FRONT SEATING SURFACE. *TT | |
| Bulletin Number: 16020 | |
| SOME VEHICLES EQUIPPED WITH PASIVE ANTI-THEFT SYSTEM MAY EXHIBIT A NO CRANK / NO START CONDITION AND NO COMMUNICATION WITH NGS OR WDS FROM THE POWER TRAIN CONTROL MODULE (PCM). *TT | |
| Bulletin Number: 16021 | |
| SOME VEHICLES WITH 4WABS MAY EXHIBIT DIAGNOSTIC TROUBLE CODES C1233 AND C1234 (ANTI-LOCK BRAKE SENSOR OUTPUT FAILURES) IN SLIPPERY CONDITIONS. *TT | |
| Bulletin Number: 16038 | |
| SOME VEHICLES EQUIPPED WITH A 5R55E AUTOMATIC TRANSMISSION MAY EXHIBIT A GEAR WHINE TYPE NOISE IN 1ST AND / OR 2ND GEARS ONLY. *TT | |
| Bulletin Number: 16040 | |
| EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT | |
| Bulletin Number: 16064 | |
| SOME VEHICLES WITH MANUAL TRANSMISSION MAY EXHIBIT A DIFFICULT TO ENGAGE INTO 4X4 LOW CONDITION WHEN THE AMBIENT TEMPERATURE IS 0 DEGREES F (-18 C) OR COLDER. *TT | |
| Bulletin Number: 16091 | |
| SOME VEHICLES EQUIPPED WITH A 3.0L EFI (NON-FFV) ENGINE, MAY EXHIBIT AN ENGINE QUIT CONDITION UPON DECELERATION AND / OR AT A STOP. *TT | |
| Bulletin Number: 16094 | |
| SOME VEHICLES MAY EXHIBIT FUEL DIAGNOSTIC TROUBLE CODES P0171, P0172, P0174, P0175 OR MASS AIR FLOW DIAGNOSTIC TROUBLE CODES P0102, P0103, P0112, P0113. *TT | |
| Bulletin Number: 16099 | |
| SOME VEHICLES EQUIPPED WITH A 2.3L ENGINE AND NO AIR CONDITIONING, MAY SET DIAGNOSTIC TROUBLE CODES P1460 (WIDE OPEN THROTTLE AIR CONDITIONER OUTPUT PRIMARY CIRCUIT MALFUNCTION) AND P1474 (LOW FAN CONTROL (LFC) PRIMARY CIRCUIT FAILURE. *T | |
| Bulletin Number: 16110 | |
| SOME VEHICLES EQUIPPED WITH A 2.3L ENGINE MAY EXHIBIT AN ENGINE OIL LEAK CONDITION. *TT | |
| Bulletin Number: 16113 | |
| SOME VEHICLES BUILT AFTER 03/04/2002 AND EQUIPED WITH A MANUAL TRANSMISSION MAY EXHIBIT A HARD TO SHIFT CONDITION. *TT | |
| Bulletin Number: 16148 | |
| SOME VEHICLES MAY AN AUTOMATIC TRANSMISSION MAY EXHIBIT A SHIFT LEVER THAT WILL NOT RELEASE OUT OF THE PARK POSITION. *TT | |
| Bulletin Number: 16253 | |
| EQUIPPED WITH A HARD TONNEAU COVER. * MJ | |
| Bulletin Number: 16305 | |
| ENGINE TIMING SERVICE TOOLS / SERVICE TIP. *TT | |
| Bulletin Number: 16396 | |
| NO START/NO COMMUNICATION-CONTACT REQUEST. *MJ | |
| Bulletin Number: 16424 | |
| NEW TONNEAU COVER LOCK CYLINDER RETAINER CLIPS RELEASED FOR SERVICE. *MJ | |
| Bulletin Number: 16437 | |
| DIAGNOSTIC TROUBLE CODE (DTC) C1233 & C1234 - REPLACE ANTI-LOCK BRAKE SYSTEM EUC. *MJ | |
| Bulletin Number: 16461 | |
| TOOL KIT CONTAINS THE TIMING PEG USED TO LOCK THE CRANKSHAFT IN PLACE WHEN PERFORMING CRANKSHAFT PULLEY OR ENGINE TIMING SERVICE. *TT | |
| Bulletin Number: 16510 | |
| P225/70R15 FIRESTONE WILDERNESS HT TIRE MAY EXHIBIT EXCESSIVE TIRE CUPPING/FEATHERING ON THE OUTSIDE EDGES OF THE FRONT TIRES. OASIS. *TT | |
| Bulletin Number: 16610 | |
| NO START, NO COMMUNICATION WITH POWER TRAIN CONTROL MODULE (PCM) USING WDS/NGS OR A MISS/BUCK/JERK WHILE DRIVING. *TT | |
| Bulletin Number: 16626 | |
| HESITATION OR SURGE CONDITION DURING CRUISE WITH THE AIR CONDITIONER ON. *TT | |
| Bulletin Number: 16743 | |
| COOLANT LEAK DUE TO A BROKEN RADIATOR HOSE CLAMP(S). *TT | |
| Bulletin Number: 16889 | |
| AN RCM DIAGNOSTIC TROUBLE CODE B1881, B1882, OR B1883. *TT | |
| Bulletin Number: 17127 | |
| TRANSMISSION WHINE IN 5TH GEAR. *TT | |
| Bulletin Number: 17198 | |
| WEAR-THROUGH CONDITION ON THE ABRASION SLEEVE OF THE UPPER RADIATOR HOSE NEAR THE AIR CONDITIONING ACCUMULATOR OR TRANSMISSION FLUID DIPSTICK. *TT | |
| Bulletin Number: 17221 | |
| SPARK KNOCK, DETONATION, OR PING CONDITION ON TIP-IN OR DURING STEADY STATE OPERATION AT OR NEAR WIDE OPEN THROTTLE. *TT | |
| Bulletin Number: 17227 | |
| ACCESSORY DRIVE BELT NOISE ON 3.0L VEHICLES BUILT PRIOR TO 9/18/2003. *TT | |
| Bulletin Number: 17234 | |
| ENGINE OIL LEAKS FROM THE FILTER AREA ON VEHICLES WITH A 3.0L 2-VALVE ENGINE. *TT | |
| Bulletin Number: 17254 | |
| CLICKING/POPPING NOISE FROM UPPER STEERING COLUMN AREA WHEN TURNING. 2004 E SERIES AND EXPLORER SPORT TRAC ALSO INCLUDED. *TT | |
| Bulletin Number: 17255 | |
| HARD START/LONG CRANK WHEN COLD OR STUMBLES/SURGES DURING DRIVE-AWAY. POSSIBLE DIAGNOSTIC TROUBLE CODES P0171, AND P0174 OR P0172 AND P0175. *TT | |
| Bulletin Number: 17490 | |
| EXCESSIVE FRONT TIRE HEAL AND TOE WEAR AT LOW MILEAGE. ON GOODYEAR P245/75R16 TIRES. *TT | |
| Bulletin Number: 17604 | |
| COOLING SYSTEM FAN NOISE WHEN COLD. *TT | |
| Bulletin Number: 17718 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0171, P0172, P0174 OR P0175. *TT | |
| Bulletin Number: 17777 | |
| REAR LEAF SPRING NOISE. *TT | |
| Bulletin Number: 18375 | |
| HIGH IDLE AT COLD START. *TT | |
| Bulletin Number: 870197 | |
| INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT | |
| Bulletin Number: TSB 19-2026 | |
| Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo | |
| 2002 FORD SUPER DUTY | |
| Bulletin Number: 15757 | |
| SUBJECT REGARDING VEHICLES EXHIBITING COLD START ROLLING IDLE. *TT | |
| Bulletin Number: 15902 | |
| SOME VEHICLES MAY EXHIBIT LACK OF POWER STEERING ASSIST. *TT | |
| Bulletin Number: 16258 | |
| VEHICLES EQUIPPED WITH A 7.3L ENGINE (AFTER SERIAL NUMBER 0661894) - UNDER VALVE COVER (UVC) HARNESS RETAINER CLIP RELEASED FOR SERVICE. INCLUDES 2003 ECONOLINE, SUPER DUTY, F650/750 AND EXCURSION. *TT | |
| 2002 FORD SUPER DUTY F | |
| Bulletin Number: 01173 | |
| VIBRATION - DRIVELINE DRONE OR VIBRATION - FELT AT 80-96 KH/M (50-60 MPH) - VEHICLES EQUIPPED WITH 228 INCH WHEELBASE AND 6.8L ENGINE ONLY. *NLM | |
| Bulletin Number: 16662 | |
| LACK OF POWER, SMOKE, OR OIL LEAKS AROUND THE CHARGE AIR COOLER (CAC). 1999-2003 SUPER DUTY/EXCURSION VEHICLES EQUIPPED WITH 7.3 OR 6.0 FORD NAVISTAR DIESEL ENGINE. *TT | |
| 2002 FORD SUPER DUTY F SERIES | |
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01157 | |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| Bulletin Number: 01167 | |
| INFORMATION REGARDING COOLING SYSTEM, MOTORCRAFT PREMIUM GOLD ENGINE COOLANT, ONLY FOR VEHICLES PRODUCED AT KENTUCKY TRUCK PLANT. *SLC | |
| Bulletin Number: 01181 | |
| BRAKE SHIFT INTERLOCK.*JB | |
| Bulletin Number: 01205 | |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT | |
| Bulletin Number: 012113 | |
| SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 02104 | |
| SOME BI-FUEL LPG VEHICLES MAY EXHIBIT A NO START, ROLLING IDLE, SURGING IDLE AND / OR SURGE AT CRUISE CONDITION IN LPG MODE WITH ALT FUEL GREEN LIGHT ON. *TT | |
| Bulletin Number: 02108 | |
| SOME VEHICLES EQUIPPED WITH THE 5.4L 2V ENGINE MAY EXHIBIT A WHISTLING NOISE FROMTHE FORMED NYLON TUBE INTHE IDLE-AIR BYPASS FLOW CIRCUIT. *TT | |
| Bulletin Number: 0214 | |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| Bulletin Number: 02176 | |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| Bulletin Number: 02194 | |
| DRIVEABILITY-NO START/REPEAT STARTER FAILURE-REPEAT STARTER REPLACEMENT. ELECTRICAL-STICKING OR BINDING IGNITION LOCK CYLINDER BETWEEN START AND RUN. ENGINE-STARTING-STARTER STAYING ENGAGED AT START UP. *MJ | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 03112 | |
| ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT. INCLUDING 2003 AND 2004 SUPER DUTY F SERIES. *TT | |
| Bulletin Number: 031410 | |
| TURBO PEDESTAL SEAL OIL LEAK AROUND THE EXHAUST BACK PRESSURE (EBP) ACTUATOR. 2003 SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 03143 | |
| FRONT HUBS WILL NOT ENGAGE OR DISENGAGE PROPERLY. *TT | |
| Bulletin Number: 03144 | |
| ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 03148 | |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 03205 | |
| NO START/REPEAT STARTER FAILURE OR A STICKING/BINDING IGNITION LOCK CYLINDER, STARTER STAYING ENGAGED AT START UP. ALSO INCLUDES 2003 SUPER DUTY F SERIES. *TT | |
| Bulletin Number: 032145 | |
| EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT | |
| Bulletin Number: 032146 | |
| ENGINE OIL PAN CORROSION ON VEHICLES EQUIPPED WITH THE 7.3L DIESEL ENGINE. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT | |
| Bulletin Number: 032148 | |
| SOME 7.3L DIT VEHICLES MAY EXHIBIT THE OCCURRENCE OF P0340 CAMSHAFT POSITION SENSOR FALSE DIAGNOSTIC TROUBLE CODE (DTC). OTHERS MAY EXHIBIT A LATE 4R100 3-4 SHIFT (HANGING IN 3RD GEAR) AT LIGHT THROTTLE DUE TO POTENTIAL LACK OF CONVERTER L | |
| Bulletin Number: 032150 | |
| HIGH PRESSURE OIL PUMP LEAK ON VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE. *TT | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 15141 | |
| SOME VEHICLES MAY EXPERIENCE THE SEAT AND SEAT BACK MAY LOSE ITS MEMORY POSITION AND NOT LATCH OR LOCK IN THE DESIRED POSITION. *YH | |
| Bulletin Number: 15429 | |
| SOME VEHICLES WITH 7.3L DIT ENGINES, MAY EXHIBIT AN INVALID AUXILIARY POWERTRAIN CONTROL MODULE DISPLAY READOUT OF 4100 RPM OR ABOVE. *TT | |
| Bulletin Number: 15446 | |
| SOME VEHICLES MAY EXHIBIT INCREASED STEERING EFFORTS AT VERY LOW SPEEDS OR WHEN STOPPED WITH THE BRAKES APPLIED. *TT | |
| Bulletin Number: 15450 | |
| SOME VEHICLES MAY INTERMITTENTLY EXHIBIT AN INVALID APCM DISPLAY READOUT OF 4100 RPM OR ABOVE. *TT | |
| Bulletin Number: 15581 | |
| SOME VEHICLES MAY EXHIBIT AN INOPERATIVE CHARGING SYSTEM AND/OR A NO START CONDITION. *TT | |
| Bulletin Number: 15593 | |
| SOME VEHICLES BUILT BETWEEN 11/29/01 AND 11/30/01 MAY EXHIBIT A SERPENTINE BELT SQUEAL. *TT | |
| Bulletin Number: 15686 | |
| CONCERNS OF DIAGNOSTIC TROUBLE CODE P1280 RETRIVED FROMTHE POWER TRAIN CONTROL MODULE (PCM). *TT | |
| Bulletin Number: 15694 | |
| INFORMATION ON INOPERATIVE CHARGING SYSTEM AND / OR NO CRANK CONDITION. *TT | |
| Bulletin Number: 15888 | |
| SOME VEHICLES MAY EXHIBIT A FEAD BELT SQUEAL. *TT | |
| Bulletin Number: 16087 | |
| SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES P0740, P0741, P0743, AND P1744 (TORQUE CONVERTER CLUTCH). *TT | |
| Bulletin Number: 16170 | |
| SOME VEHICLES EQUIPPED WITH A 4R100 TRANSMISSION AND BUILT BETWEEN JANUARY 1, 2001 AND MAY 1, 2002 MAY EXHIBIT FLASHING TRANSMISSION CONTROL INDICATOR LAMP AND ANY OR ALL TORQUE CONVERTER CLUTCH DIAGNOSTIC TROUBLE CODES P0740, P0741, P0743, | |
| Bulletin Number: 16480 | |
| DIAGNOSTIC TROUBLE CODE (DTC) P0340, POSSIBLE FALSE CODE. VARIOUS MODELS INCLUDING 1994-1996 FORD EXCURSION. *TT | |
| Bulletin Number: 16589 | |
| GRADUAL LOSS OF POWER AT CRUISE. FORD SPECIAL SERVICE MESSAGE. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT | |
| Bulletin Number: 16859 | |
| SOME VEHICLES BUILT AFTER 12/7/1998 EQUIPPED WITH A 7.3L DIT ENGINE MAY EXHIBIT A HOOT OR HOWLING NOISE FROM THE TURBOCHARGER. 2003 SUPER DUTY F SERIES ALSO INCLUDED. *TT | |
| Bulletin Number: 16924 | |
| SLIGHT PURGE OF GREASE FROM THE HUB BEARING UNIT. THIS GREASE MAY BE NOTED BETWEEN THE HUB UNIT AND THE INBOARD ROTOR FLANGE AND ON THE INBOARD SIDE OF THE BEARING. 1999-2003 MODELS. *TT | |
| Bulletin Number: 16925 | |
| NO ENGAGEMENT OR DISENGAGEMENT OF HUB LOCKS AFTER REPLACEMENT OR SERVICE. TO INCLUDE 2000-2003 EXCURSIONS. *TT | |
| Bulletin Number: 17017 | |
| FAST FAN CLUTCH CYCLING AND/OR BELT NOISE. *TT | |
| Bulletin Number: 17320 | |
| BROKEN EXHAUST MANIFOLD STUDS. *TT | |
| Bulletin Number: 17777 | |
| REAR LEAF SPRING NOISE. *TT | |
| 2002 FORD TAURUS | |
| Bulletin Number: 0109-01 | |
| 2002 TAURUS/SABLE HEATER HOSE CLAMPS UPGRADE PRIOR TO SALE. *NLM | |
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01157 | |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| Bulletin Number: 01181 | |
| BRAKE SHIFT INTERLOCK.*JB | |
| Bulletin Number: 01205 | |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT | |
| Bulletin Number: 012113 | |
| SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 01T05 | |
| ON SOME VEHICLES, THE HEATER HOSE CLAMP MAY BE IMPROPERLY POSITIONED ONTHE HEATER HOSES LEADING TO AND FROM THE HEATER CORE. *TT | |
| Bulletin Number: 02111 | |
| FUEL PRESSURE RELIEF VALVE (SCHRADER VALVE) DISCONTINUED. *TT | |
| Bulletin Number: 0214 | |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| Bulletin Number: 02175 | |
| RESTRAINT SYSTEM-AIR BAG DEPLOYMENT STRATEGY WITH ADVANCED RESTRAINT SYSTEM. *MJ | |
| Bulletin Number: 02176 | |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| Bulletin Number: 02208 | |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH | |
| Bulletin Number: 02221 | |
| ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ | |
| Bulletin Number: 02223 | |
| DRIVEABILITY-MALFUNCTION INDICATOR LAMP (MIL) WITH P0316 WHEN USING WINTER BLEND REFORMULATED FUELS AT TEMPERATURES ABOVE 50 DEGREES F (10 DEGREES C) DURING WINTER MONTHS-ROUGH OR ROLLING IDLE AFTER HOT SOAK RESTART P0191. TRANSAXLE-AX4S-1 | |
| Bulletin Number: 02236 | |
| ERRATIC OPERATION OF THE COOL/WARM FUNCTION OF THE TEMPERATURE CONTROL SYSTEM - REPAIR PROCEDURE FOR STRATIFICATION (SECONDARY) TEMPERATURE BLEND DOOR. *TT | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 0284 | |
| VEHICLES BUILT AFTER 4/8/2002 WILL NO LONGER BE EQUIPPED WITH THE FUEL PRESSURE RELIEF VALVE (SHRADER VALVE). *TT | |
| Bulletin Number: 02M01 | |
| CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6 | |
| Bulletin Number: 03111 | |
| ENGINE COOLING FAN INDUCED BODY BOOM, ROUGH ENGINE IDLE SENSATION OR UNUSUAL ENGINE NOISE AT IDLE WHEN THE ENGINE COOLING FAN IS IN THE HIGH SPEED MODE. *TT | |
| Bulletin Number: 03123 | |
| TORQUE CONVERTER CLUTCH NOT ENGAGING WHEN COMMANDED AND/OR DIAGNOSTIC TROUBLE CODES P0741 OR P1744 STORED IN MEMORY. MODELS FROM 1996 TO 2003. *TT | |
| Bulletin Number: 03144 | |
| ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 03148 | |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 031506 | |
| WATER IN THE BLOWER CASE OR ON THE PASSENGER SIDE FLOOR, AN INOPERATIVE CLIMATE CONTROL BLOWER MOTOR, A MOTOR THAT OPERATES ON HIGH SPEED ONLY, AND/OR A BLOWER MOTOR RESISTOR FAILURE. VEHICLES BUILT 5/1/2001 TO 12/15/2003. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 0322 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT | |
| Bulletin Number: 03223 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| Bulletin Number: 0325 | |
| GRUNTING NOISE FROM FRONT POWER WINDOW AFTER GLASS IS POWERED TO THE FULL-UP POSITION. *TT | |
| Bulletin Number: 0335 | |
| IDLE AIR CONTROL (IAC) VALVE DIAGNOSTIC SERVICE TIPS. *TT | |
| Bulletin Number: 0361 | |
| MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 04111 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. | |
| Bulletin Number: 0415 | |
| LOWER ENGINE OIL LEAKS 3.0L 2V VULCAN ENGINE. DIAGNOSTIC SERVICE TIPS. *TT | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 041712 | |
| MALFUNCTION INDICATOR LAMP MIL AND DIAGNOSTIC TROUBLE CODES DTCS P0172 P0175. *EH | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04189 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 04208 | |
| CAMSHAFT TICK NOISE - 3.0L 4V ENGINE ONLY. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 04223 | |
| GRUNTING NOISE FROM FRONT POWER WINDOW GLASS IS POWERED TO THE FULL UP POSITION. *EH | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 04251 | |
| ALUMINUM CORROSION - SERVICE TIP. *TT | |
| Bulletin Number: 042514 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0316 OR P030X - NO CRANK BATTERY DISCHARGED. *TT | |
| Bulletin Number: 05145 | |
| ERRATIC FLUID LEVEL READING ON TRANSAXLE DIPSTICK-LEAKS-4F50N, AX4N, AX4S TRANSAXLE. *SC | |
| Bulletin Number: 052212 | |
| BUCK/JERK AND MISS DURING DRIVE CYCLE ABOVE 3000 RPM - NO DTC - 3.0L 2V GAS AND FFV ENGINE. *TT | |
| Bulletin Number: 05224 | |
| POWER LOCK CONCERNS - SERVICE TIP. *TT | |
| Bulletin Number: 05227 | |
| POWER WINDOW CONCERNS - SERVICE TIP. *TT | |
| Bulletin Number: 05310 | |
| SAFETY BELT WEB STOP BUTTON SERVICE. *EH | |
| Bulletin Number: 15189 | |
| INFORMATION REGARDING WORKSHOP MANUAL UPDATE 2002 TAURUS AND SABLE P/S PUMP 3.0L 2V. *YD | |
| Bulletin Number: 15239 | |
| INFORMATION ON PRE DELIVERY TEMPORARY FAST IDLE. *TT | |
| Bulletin Number: 15280 | |
| SOME VEHICLESMAY EXHIBIT AN INTERMITTENT STICKING/BINDING IGNITION KEY LOCK CYLINDER AT OR NEAR THE START POSITION. *JG | |
| Bulletin Number: 15370 | |
| SOME VEHICLES MAY EXHIBIT A GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK. *TT | |
| Bulletin Number: 15392 | |
| SOME VEHICLES MAY EXHIBIT A PARK PULLOUT CLUNK NOISE WHEN SHIFTING FROM PARK TO ANOTHER GEAR POSITION. *TT | |
| Bulletin Number: 15482 | |
| SOME VEHICLES EQUIPPED WITH A DURATEC ENGINE MAY EXPERIENCE ENGINE DAMAGE AS A RESULT OF MICROSCOPIC INTERNAL CRACKS IN A BATCH OF INTAKE VALVES. *TT | |
| Bulletin Number: 15680 | |
| SOME VEHICLES EQUIPPED WITH A 3.0L 2V ENGINE MAY EHXIBIT A RUNS ROUGH, CHECK ENGINE LIGHT AND / OR DIAGNOSTIC TROUBLE CODE P0316 AFTER HOT SOAK RESTART. *TT | |
| Bulletin Number: 15724 | |
| CONCERNS WITH FUEL GAUGE NOT READING FULL AFTER FILLING FUEL TANK. *TT | |
| Bulletin Number: 15745 | |
| SOME VEHICLES EQUIPPED WITH A 3.0L 2V ENGINE MAY EXHIBIT A RUNS ROUGH, CHECK ENGINE LIGHT, AND / OR DIAGNOSTIC TROUBLE CODE P0316 AFTER A HOT SOAK RESTART. *TT | |
| Bulletin Number: 15820 | |
| SOME VEHICLES EQUIPPED WITH AN AX4N/4F50N TRANSAXLE MAY EXHIBIT A SHUDDER DURING A 3-4 SHIFT. *TT | |
| Bulletin Number: 15828 | |
| SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE B1213, B1342, B1601, B2431. *TT | |
| Bulletin Number: 15873 | |
| SUBJECT REGARDING A WATER LEAK CONDITION AT THE COWL AREA OF THE VEHICLE. *TT | |
| Bulletin Number: 15915 | |
| SOME VEHICLES EQUIPPED WITH A 3.0L 2V ENGINE MAY EXHIBIT A ROUGH RUN CONDITION AND DIAGNOSTIC TROUBLE CODE P0316 AFTER A HOT RESTART. *TT | |
| Bulletin Number: 16035 | |
| SOME VEHICLES MAY EXHIBIT A ROUGH ENGINE IDLE, ENGINE IDLE ROUGHNESS OR IDLE RPM DIP WITH THE AIR CONDITIONER ON, A DIAGNOSTIC TROUBLE CODE P0191 OR 1-2 UPSHIFT. *TT | |
| Bulletin Number: 16057 | |
| SOME VEHICLES EQUIPPED WITH A 3.0L 4V ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ILLUMINATION WITH A DIAGNOSTIC TROUBLE CODE P0191 (FUEL RAIL PRESSURE SENSOR CIRCUIT PERFORMANCE) IN MEMORY. *TT | |
| Bulletin Number: 16094 | |
| SOME VEHICLES MAY EXHIBIT FUEL DIAGNOSTIC TROUBLE CODES P0171, P0172, P0174, P0175 OR MASS AIR FLOW DIAGNOSTIC TROUBLE CODES P0102, P0103, P0112, P0113. *TT | |
| Bulletin Number: 16190 | |
| LACK OF A/C COOLING. *MJ | |
| Bulletin Number: 16315 | |
| HEADLINER GRAB HANDLES LOOSEN. *TT | |
| Bulletin Number: 16613 | |
| VEHICLES WITH VERY LOW ODOMETER MILES, MAY EXHIBIT A HIGHER THAN NORMAL TEMPORARY START-UP FAST IDLE (1600-2500 RPM THAT DECREASES SLOWLY). NO SERVICE NECESSARY. *TT | |
| Bulletin Number: 16678 | |
| AX4S TRANSAXLE MAY EXHIBIT NO REVERSE ENGAGEMENT CONDITION. *TT *JB | |
| Bulletin Number: 16679 | |
| NEW PUSH TYPE FUEL CLIP AND CONNECTOR REMOVAL INSTRUCTIONS. *TT *JB | |
| Bulletin Number: 16710 | |
| RATTLING OR CLUNKING NOISE FROM THE FRONT SUSPENSION UNDER NORMAL DRIVING CONDITIONS. *TT *JB | |
| Bulletin Number: 16982 | |
| CLUNKING/POPPING NOISE FROM THE PASSENGER SIDE OF THE ENGINE COMPARTMENT UPON ACCELERATION AND/OR DECELERATION. *TT | |
| Bulletin Number: 17094 | |
| RATTLING OR CLUNKING NOISE FROM THE FRONT SUSPENSION UNDER NORMAL DRIVING CONDITIONS. *TT | |
| Bulletin Number: 17224 | |
| INTERMITTENT ROLLING IDLE ON VEHICLES EQUIPPED WITH A 3.0L 2-VALVE ENGINE. *TT | |
| Bulletin Number: 17225 | |
| STEERING COLUMN LOCK DISCONTINUED. *TT | |
| Bulletin Number: 17234 | |
| ENGINE OIL LEAKS FROM THE FILTER AREA ON VEHICLES WITH A 3.0L 2-VALVE ENGINE. *TT | |
| Bulletin Number: 17281 | |
| SURGE AT CRUISE. *TT | |
| Bulletin Number: 17355 | |
| FUEL GAUGE WHICH DOES NOT READ COMPLETELY FULL WHEN THE FUEL TANK IS FILLED. *TT | |
| Bulletin Number: 17358 | |
| GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE. *TT THIS BULLETIN UPDATES PREVIOUS BULLETIN 17358, DATED 11/01/2003 TO INCLUDE 2005 MODELS. *TT | |
| Bulletin Number: 17416 | |
| FUEL GAUGE DOES NOT READ FULL. *MJ | |
| Bulletin Number: 17434 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH CONTINUOUS MEMORY DIAGNOSTIC TROUBLE CODES (DTC'S) P0172/P0175 (SYSTEM TOO RICH). *TT | |
| Bulletin Number: 17503 | |
| SURGE AT A STEADY SPEED BETWEEN 35 AND 45 MPH WITH NO OTHER DRIVEABILITY CONCERNS. *TT | |
| Bulletin Number: 17564 | |
| FUEL GAUGE DOES NOT READ FULL AFTER FILLING TANK. *MJ | |
| Bulletin Number: 17681 | |
| AUTOLOCKS AND (RKE) REMOTE KEYLESS ENTRY INOPERATIVE. *TT | |
| Bulletin Number: 17703 | |
| TICKING NOISE FROM LEFT CYLINDER HEAD WITH WARM ENGINE. *TT | |
| Bulletin Number: 17960 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0171/P0174, P1131/P1151, AND/OR P2195/P2197 IN CONTINUOUS MEMORY. *TT | |
| Bulletin Number: 18411 | |
| MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0133, P1131 OR P2195. *TT | |
| Bulletin Number: 18471 | |
| RKE INOPERATIVE. *EH | |
| Bulletin Number: 18614 | |
| SURGE, IDLE ROLL, ROUGH IDLE ONLY WHEN THE ENGINE COOLING FANS ARE OPERATING. *TT | |
| Bulletin Number: 18719 | |
| MALFUNCTION INDICATOR LAMP COMING ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0172, P0174 AND/OR P0175 (FUEL SYSTEM TOO RICH OR LEAN). *TT | |
| Bulletin Number: 870197 | |
| INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT | |
| Bulletin Number: CSP-13B04 | |
| FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPEED CONTROL CABLE IS SUSCEPTIBLE TO DAMAGE AND CAN DISCONNECT DURING HOOD MAINTENANCE AND ALSO INTERFERE WITH FULL THROTTLE RETURN TO IDLE AFTER RELEASING ACCELERATOR PEDAL. MODELS 20 | |
| Bulletin Number: TSB 19-2026 | |
| Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo | |
| 2002 FORD THUNDERBIRD | |
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01157 | |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| Bulletin Number: 01205 | |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT | |
| Bulletin Number: 012111 | |
| SOME VEHICLES MAY EXHIBIT AN ENGINE OVERHEATING CONDITION AND / OR THE MALFUNCTION INDICATOR LAMP (MIL) MAY ALSO BE ILLUMINATED WITH CODES P1285 AND P1299 STORED IN MEMORY. *TT | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 0162 | |
| VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT | |
| Bulletin Number: 02161 | |
| ENGINE FLOODING, EXTENDED ENGINE CRANKING TIME REQUIRED TO START, OR HARD START CONDITION. *TT | |
| Bulletin Number: 02162 | |
| WATER/MOISTURE IN COP WELLS - DTC P0301-P0308 - 3.9L ENGINE - VEHICLES BUILT THROUGH 5/1/2004. *TT | |
| Bulletin Number: 02176 | |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| Bulletin Number: 02208 | |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH | |
| Bulletin Number: 022114 | |
| WATER LEAK DIAGNOSIS - REMOVABLE ROOF AND CONVERTIBLE TOP - SERVICE TIP. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 0257 | |
| SOME VEHICLES MAY EXHIBIT CALIBRATION LOSS OF ERRATIC OPERATION OF THE POWER WINDOW SHORT DROP GLASS FUNCTION. *TT | |
| Bulletin Number: 0266 | |
| SOME VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSION MAY EXHIBIT A FLUID LEAK AROUND THE FLUID PAN DRAIN PLUG. *TT | |
| Bulletin Number: 0295 | |
| EXCESSIVE ELECTRICAL SYSTEM CURRENT DRAW WHICH COULD RESULT IN A DISCHARGED BATTERY AND A NO CRANK CONDITION. *TT SERVICE TIPS. *TT | |
| Bulletin Number: 02E21 | |
| SUBJECT REGARDING CATALYST MONITOR SENSOR CONNECTOR INSPECTION. *JG | |
| Bulletin Number: 031404 | |
| ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. | |
| Bulletin Number: 03144 | |
| ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 03148 | |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 0334 | |
| LACK OF COOLING FROM DRIVER AND/OR PASSENGER SIDE VENTS ON VEHICLES EQUIPPED WITH DUAL AUTOMATIC TEMPERATURE CONTROL (DATC) ONLY. *TT | |
| Bulletin Number: 0335 | |
| IDLE AIR CONTROL (IAC) VALVE DIAGNOSTIC SERVICE TIPS. *TT | |
| Bulletin Number: 0373 | |
| ENGINE FLOOD DURING COLD START, EXTENDED CRANKING TIME, OR HARD TO START ENGINE WHEN COLD. *TT | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 0708 | |
| AUTOMATIC TRANSMISSION SOLENOID EMISSIONS WARRANTY EXTENSION. SAMPLE CONSUMER LETTER ATTACHED. *KB | |
| Bulletin Number: 15149 | |
| SOME VEHICLES TIRE PRESSURE INFORMATION AND WRAP GUARD REMOVAL TIPS. *ET | |
| Bulletin Number: 15203 | |
| SOME VEHICLES EQUIPPED WITH THE 3.9L 4V MAY EXHIBIT AN OIL LEAK FROM THE ENGINE OIL FILTER. *TT | |
| Bulletin Number: 15250 | |
| INFORMATION REGARDING MISDIAGNOSIS OF MAIN CONTROLS - INCORRECT PRESSURES. *TT | |
| Bulletin Number: 15265 | |
| SOME VEHICLES MAY EXHIBIT AN ENGINE OVERHEAT CONDITION DUE TO CONCERNS WITH INOPERATIVE HYDRAULIC COOLING FAN. *TT | |
| Bulletin Number: 15272 | |
| INFORMATION ON BATTERY ACCESS. *TT | |
| Bulletin Number: 15276 | |
| INFORMATION REGARDING DROP GLASS FUNCTION. *TT | |
| Bulletin Number: 15332 | |
| SOME VEHICLES MAY EXHIBIT A DIFFICULT TO PULL DOWN, AND LATCH CONVERTIBLE TOP. *TT | |
| Bulletin Number: 15387 | |
| SOME VEHICLES MAY EXHIBIT A CONDITION OF DUAL AUTOMATIC TEMPERATURE CONTROL (DATC) OPERATING AT FULL HEAT IN ALL MODES, AND/OR NO TEMPERATURE CONTROL FROM SIDE TO SIDE. *TT | |
| Bulletin Number: 15466 | |
| SOME VEHICLES MAY EXHIBIT INACCURATE FUEL LEVEL CONDITION WITH APPROXIMATELY 1/4 TANK READING ON THE FUEL GAUGE. *TT | |
| Bulletin Number: 15588 | |
| SOME VEHICLES EQUIPPED WITH 3.9L V8 ENGINE ONLY, MAY EXHIBIT A RATTLING NOISE FROM THE HYDRAULIC COOLING FAN PUMP. *TT | |
| Bulletin Number: 15615 | |
| SOME VEHICLE OWNERS MAY QUESTION THE OPERATION AND/OR FUNCTION OF THE SUPPLEMENTAL PARKING LAMPS. *TT | |
| Bulletin Number: 15616 | |
| CONCERNS WITH DRIVELINE VIBRATION. *TT | |
| Bulletin Number: 15741 | |
| VEHICLES EQUIPPED WITH THE 3.9L 4V MAY EXHIBIT AN OIL LEAK FROM THE ENGINE OIL FILTER. *TT | |
| Bulletin Number: 15772 | |
| SOME VEHICLES MAY EXHIBIT A ENGINE MISSING OR ROUGH RUNNING CONDITION. *TT | |
| Bulletin Number: 15806 | |
| SOME VEHICLES MAY EXHIBIT SMALL AMOUNTS OF MOISTURE ENTERING THE CONVERTIBLE TOP STOWAGE COMPARTMENT EVEN THOUGH THE REMOVABLE HARD TOP ROOF IS INSTALLED. *TT | |
| Bulletin Number: 15826 | |
| SOME VEHICLES, BUILT BETWEEN 10/1/01 AND 1/31/02, WITH A 5R55N TRANSMISSION MAY EXHIBIT A TRANSMISSION FLUID LEAK AT THE CONVERTER HOUSING. *TT | |
| Bulletin Number: 15876 | |
| SUBJECT REGARDING DIAGNOSTIC TROUBLE CODE P1129 DURING KEY ON ENGINE RUNNING (KOER) - NO MALFUNCTION INDICATOR LAMP. *TT | |
| Bulletin Number: 15900 | |
| SOME VEHICLES MAY EXHIBIT A WHISTLING OR BUZZING NOISE ORIGINATING FROM THE CLIMATE CONTROL SYSTEM WHEN THE BLOWER MOTOR IS RUNNING AT 2 OR 3 BAR SPEED. *TT | |
| Bulletin Number: 15924 | |
| CONCERNS REGARDING PAINT PROTECTION FROM REMOVABLE TOP. *TT | |
| Bulletin Number: 15935 | |
| SUBJECT REGARDING SUPPLEMENTAL PARKING LAMPS INSTALLATION FOR VEHICLES NOT ORIGINALLY EQUIPPED. *TT | |
| Bulletin Number: 16045 | |
| SOME 3.9L V8 ENGINES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP WITH DIAGNOSTIC TROUBLE CODE P0340 (CAMSHAFT POSITION SENSOR) STORED. *TT | |
| Bulletin Number: 16084 | |
| INFORMATION ON PASSENGER SEAT BELTS NOT EQUIPPED WITH A PLASTIC BUTTON. *TT | |
| Bulletin Number: 16168 | |
| SOME VEHICLES MAY EXHIBIT A SQUEAK OR RUBBING NOISE WHILE TURNING THE STEERING WHEEL. *TT | |
| Bulletin Number: 16581 | |
| INTERMITTENT ENGINE QUIT ON DECEL/STOPS/TURNS. OASIS. *TT | |
| Bulletin Number: 16694 | |
| POWER SEAT FUNCTION - CONTACT REQUEST / DETROIT REGION. *TT *JB | |
| Bulletin Number: 17061 | |
| INTERMITTENT DRIVABILITY SYMPTOMS - REDUCED POWER ON DECELERATION. *TT | |
| Bulletin Number: 17170 | |
| MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0133 AND/OR P0153. *TT | |
| Bulletin Number: 17258 | |
| SQUEAKING NOISE WHEN SWITCHING CLIMATE CONTROL BETWEEN PANEL, FLOOR AND PANEL/FLOOR MODES. *TT | |
| Bulletin Number: 17375 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON AND HARD START/LONG CRANK. *TT | |
| Bulletin Number: 18320 | |
| VIBRATION FELT FOR A FEW MILES OF DRIVING AFTER PARKING. *EH | |
| Bulletin Number: 18515 | |
| MOISTURE IN STORAGE COMPARTMENT. *EH | |
| Bulletin Number: 18615 | |
| UNUSUAL ENGINE NOISE OR ENGINE KNOCK CONCERNS DUE TO REGULAR FUEL. *TT | |
| Bulletin Number: 22114 | |
| REMOVBLE ROOF AND CONVERTIBLE TOP. *EH | |
| Bulletin Number: 7867 | |
| DRIVELINE VIBRATION (A HIGH FREQUENCY BUZZ) THAT IS FELT THROUGH THE SEAT AND FLOORPAN AT HIGHWAY SPEEDS. *TT | |
| 2002 FORD WINDSTAR | |
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 01157 | |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| Bulletin Number: 01181 | |
| BRAKE SHIFT INTERLOCK.*JB | |
| Bulletin Number: 01205 | |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT | |
| Bulletin Number: 012113 | |
| SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL | |
| Bulletin Number: 01246 | |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| Bulletin Number: 02132 | |
| GRUNT / POPPING NOISE COMING FROM THE FRONT SUSPENSION AT SPEEDS BELOW 20 MPH WHEN TURNING. *TT | |
| Bulletin Number: 02139 | |
| BATTERY DRAIN SERVICE TIPS. *TT | |
| Bulletin Number: 0214 | |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| Bulletin Number: 02152 | |
| SOME VEHICLES MAY EXHIBIT A POPPING / GRINDING NOISE FROM THE FRONT OF THE VEHICLE WHEN GOING OVER BUMPS OR MAKING TURNS. *TT | |
| Bulletin Number: 02175 | |
| RESTRAINT SYSTEM-AIR BAG DEPLOYMENT STRATEGY WITH ADVANCED RESTRAINT SYSTEM. *MJ | |
| Bulletin Number: 02176 | |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| Bulletin Number: 02184 | |
| POWER SLIDING DOOR OPERATION AND DIAGNOSTIC SERVICE TIPS. *TT | |
| Bulletin Number: 02208 | |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH | |
| Bulletin Number: 02221 | |
| ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 0256 | |
| THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT | |
| Bulletin Number: 0275 | |
| INFORMATION ON LOW TIRE WARNING INDICATOR ILLUMINATION WITH NO DIAGNOSTIC TROUBLE CODES PRESENT. *TT | |
| Bulletin Number: 02M01 | |
| CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6 | |
| Bulletin Number: 030104 | |
| CREASE IN THE HEADLINER ABOVE THE LEFT A-PILLAR. *TT | |
| Bulletin Number: 030504 | |
| AIR BAG WARNING LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTC) CODE B2290. *TT *JB | |
| Bulletin Number: 030707 | |
| SLOW TO FILL FUEL TANK - SERVICE TIPS. *TT | |
| Bulletin Number: 03123 | |
| TORQUE CONVERTER CLUTCH NOT ENGAGING WHEN COMMANDED AND/OR DIAGNOSTIC TROUBLE CODES P0741 OR P1744 STORED IN MEMORY. MODELS FROM 1996 TO 2003. *TT | |
| Bulletin Number: 03148 | |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 03161 | |
| CHECK ENGINE LIGHT ON AND LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) P0171/P0174 (SYSTEM TOO LEAN BANK 1 OR 2) STORED IN MEMORY. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 03203 | |
| MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT | |
| Bulletin Number: 0322 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT | |
| Bulletin Number: 03223 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| Bulletin Number: 03242 | |
| TRAILER TOW SERVICE KIT - SERVICE TIP. *TT | |
| Bulletin Number: 0354 | |
| AIR BAG WARNING LAMP ILLUMINATED WITH THE DIAGNOSTIC TROUBLE CODE B2290. *TT *JB | |
| Bulletin Number: 0361 | |
| MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 03C05 | |
| REPLACEMENT OF LOWER SEAT-TO-FLOOR LATCHES ON VEHICLES EQUIPPED WITH 2ND AND 3RD ROW SEATS. DEMONSTRATION / DELIVERY HOLD. COMPLIANCE RECALL 03C05. *TT | |
| Bulletin Number: 04111 | |
| STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. | |
| Bulletin Number: 04136 | |
| DIAGNOSTIC TROUBLE CODE B1342 (RESTRAINTS CONTROL MODULE (RCM) FAULT. *TT UPDATE. *TT | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04189 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 04192 | |
| SPARK KNOCK ON ACCELERATION - VEHICLES EQUIPPED WITH 3.8L ENGINE ONLY. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 042421 | |
| SAFETY BELT RETRACTION SPEED. *TT | |
| Bulletin Number: 04262 | |
| FALSE PARKING AID WARNINGS. *TT UPDATE. *TT | |
| Bulletin Number: 0471 | |
| WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT | |
| Bulletin Number: 05145 | |
| ERRATIC FLUID LEVEL READING ON TRANSAXLE DIPSTICK-LEAKS-4F50N, AX4N, AX4S TRANSAXLE. *SC | |
| Bulletin Number: 05310 | |
| SAFETY BELT WEB STOP BUTTON SERVICE. *EH | |
| Bulletin Number: 05419 | |
| FALSE PARKING AID WARNINGS. *TT | |
| Bulletin Number: 15110 | |
| INFORMATION REGARDING REAR ENTERTAINMENT SYSTEM LOCK DOWN SCREWS. *SLC | |
| Bulletin Number: 15191 | |
| INFORMATION REGARDING NEW COMPASS SETTING PROCEDURE, PDI MUST SET ALL. *YD | |
| Bulletin Number: 15194 | |
| SOME VEHICLES MAY EXHIBIT A DISCHARGED BATTERY AFTER EXTENDED PARKING, OVER 30 DAYS, IF SO, PULL POWER DRAIN FULL FUSE NUMBER 6. *YD | |
| Bulletin Number: 15288 | |
| SOME VEHICLES MAY EXHIBIT TRANSMISSION FLUID LEAKING AT THE QUICK CONNECT FOR THE TRANSMISSION COOLER LINES. *TT | |
| Bulletin Number: 15289 | |
| SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ON, NO START OR ERRATIC TRANSAXLE SHIFT CONDITION. *TT | |
| Bulletin Number: 15350 | |
| EXHIBITING INSTRUMENT PANEL BEEPING SOUND, TRAC-CONTROL OFF LAMP ON, AND CODE B2477 STORED IN THE INSTRUMENT CLUSTER MODULE. *TT | |
| Bulletin Number: 15370 | |
| SOME VEHICLES MAY EXHIBIT A GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK. *TT | |
| Bulletin Number: 15373 | |
| SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES. *TT | |
| Bulletin Number: 15392 | |
| SOME VEHICLES MAY EXHIBIT A PARK PULLOUT CLUNK NOISE WHEN SHIFTING FROM PARK TO ANOTHER GEAR POSITION. *TT | |
| Bulletin Number: 15420 | |
| CONCERNS WITH LOW TIRE WARNING LAMP ON. *TT | |
| Bulletin Number: 15438 | |
| SOME VEHICLES MAY EXHIBIT INOPERATIVE/FLICKERING DOME LAMP, LAMP STAYING ON ALL THE TIME, COMING ON BY ITSELF, OR INOPERATIVE WITH ANY DOOR AJAR INPUTS TO THE DOME LAMP. *TT | |
| Bulletin Number: 15439 | |
| CONCERNS WITH THE HEADLAMPS THAT TURN ON AND A BLOWER MOTOR THAT WILL OPERATE WITH THE IGNITION SWITCH IN THE OFF POSITION. *TT | |
| Bulletin Number: 15440 | |
| SOME VEHICLES MAY EXHIBIT INTERMITTENT UNCOMMANDED ACTIVATION OF THE PERIMETER ANTI-THEFT SYSTEM. *TT | |
| Bulletin Number: 15441 | |
| SOME VEHICLES EQUIPPED WITH LOW TIRE PRESSURE WARNING SYSTEM, MAY ILLUMINATE THE LOW TIRE WARNING LAMP WHEN THE TIRE PRESSURES ARE ADJUSTED OR THE TIRES ARE ROTATED. *TT | |
| Bulletin Number: 15442 | |
| SOME VEHICLES EQUIPPED WITH 3.8L ENGINES MAY EXHIBIT A DIAGNOSTIC TROUBLE CODE P0460 INCONTINUOUS MEMORY. *TT | |
| Bulletin Number: 15464 | |
| CONCERNS WITH RATTLE/SQUEAK NOISE FROM SLIDING DOORS. *TT | |
| Bulletin Number: 15515 | |
| SOME VEHICLES MAY EXHIBIT A WHISTLE/WHINE NOISE FROM THE STEERING SYSTEM DURING WARM UP. *TT | |
| Bulletin Number: 15542 | |
| SOME VEHICLES MAY EXPERIENCE LOW TIRE WARNING LAMP ILLUMINATING.*YH | |
| Bulletin Number: 15544 | |
| CONCERNS WITH OIL IN THE COOLING SYSTEM. *YH | |
| Bulletin Number: 15553 | |
| SUBJECT REGARDING SLOW/HARD TO FILL FUEL TANK. *YH | |
| Bulletin Number: 15568 | |
| SOME VEHICLES WITH REMOTE KEYLESS ENTRY (RKE) MAY EXHIBIT AN INABILITY TO UNLOCK ONE OR MORE DOORS. *TT | |
| Bulletin Number: 15583 | |
| SOME VEHICLES MAY EXHIBIT A LOOSE REAR WIPER ARM. *TT | |
| Bulletin Number: 15621 | |
| SOME VEHICLES WITH THE REAR SEAT ENTERTAINMENT SYSTEM MAY EXHIBIT AN INOPERATIVE CONDITION. *TT | |
| Bulletin Number: 15662 | |
| CHECK ENGINE LIGHT ON AND DIAGNOSTIC TROUBLE CODE P0460. *TT | |
| Bulletin Number: 15679 | |
| SLIDING DOOR(S) CONTACTING THE REAR QUARTER GLASS. *TT THIS INFORMATION UPDATES PREVIOUS INFORMATION, DATED 03/01/2002. *TT | |
| Bulletin Number: 15682 | |
| EXHIBITING INTERMITTENT ANTI-SKID BRAKE SYSTEM AND / OR RED BRAKE LAMP ON AT TIMES WHILE DRIVING. *TT | |
| Bulletin Number: 15710 | |
| INFORMATION ON VEHICLES WITH PROGRAMMABLE MODULES. *TT | |
| Bulletin Number: 15719 | |
| SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT | |
| Bulletin Number: 15722 | |
| SOME VEHICLES MAY EXHIBIT AN INOPERATIVE SLIDING DOOR LOCK. *TT | |
| Bulletin Number: 15796 | |
| AN AIR BAG LAMP ILLUMINATED AND / OR DIAGNOSTIC TROUBLE CODES B2296 OR B2295. *TT | |
| Bulletin Number: 15814 | |
| SUBJECT REGARDING REAR BRAKE LAMP ILLUMINATION AFTER EXITING VEHICLE. *TT | |
| Bulletin Number: 15820 | |
| SOME VEHICLES EQUIPPED WITH AN AX4N/4F50N TRANSAXLE MAY EXHIBIT A SHUDDER DURING A 3-4 SHIFT. *TT | |
| Bulletin Number: 15822 | |
| SOME VEHICLES MAY EXHIBIT A SQUEAL NOISE FROM THE FRONT BRAKES WHEN STOPPING. *TT | |
| Bulletin Number: 15824 | |
| SOME VEHICLES MAY EXHIBIT A PARTIAL LATCH CONDITION WHEN USING THE POWER SLIDING DOORS FEATURE. *TT | |
| Bulletin Number: 15828 | |
| SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE B1213, B1342, B1601, B2431. *TT | |
| Bulletin Number: 15842 | |
| SOME VEHICLES BUILT MARCH 1, 2001 THROUGH JANUARY 2002 MAY EXHIBIT A WHISTLE / WHINE NOISE FROM THE STEERING SYSTEM DURING WARM UP. *TT | |
| Bulletin Number: 15855 | |
| SOME VEHICLES MAY EXHIBIT A CONDITION OF POPPING OR GRINDING NOISE ORIGINATING FROM THE FRONT END OF THE VEHICLE. *TT | |
| Bulletin Number: 15864 | |
| INFORMATION PERTAINING TO A HARD START / LONG CRANK CONDITION. *TT | |
| Bulletin Number: 15872 | |
| SUBJECT REGARDING DIAGNOSTIC TROUBLE CODE P0156 - H02 / CATALYST MONITOR SENSOR (CMS) CIRCUIT FAILURE) CONTAMINATION. *TT | |
| Bulletin Number: 15885 | |
| SOME VEHICLES MAY EXHIBIT AN EXTERIOR NOISE ORIGINATING FROM THE FRONT OF THE VEHICLE. *TT | |
| Bulletin Number: 15909 | |
| SU0BJECT REGARDING NOISE FROM FRONT OF VEHICLE. *TT | |
| Bulletin Number: 15912 | |
| SUBJECT REGARDING FAMILY OR REAR SEAT ENTERTAINMENT SYSTEM HANDLE CONCERNS. *TT | |
| Bulletin Number: 15926 | |
| SOME VEHICLES MAY EXHIBIT A INTERMITTENT HARD START AND / OR LONG CRANKING TIMES OF 4 TO 10 SECONDS. *TT | |
| Bulletin Number: 15933 | |
| SOME VEHICLES MAY EXHIBIT A SQUEAL NOISE FROM THE FRONT BRAKES DURING BRAKE APPLICATION. *TT | |
| Bulletin Number: 16014 | |
| SOME VEHICLES MAY EXHIBIT A RATTLE NOISE FROM THE REAR SUSPENSION. *TT | |
| Bulletin Number: 16097 | |
| SOME VEHICLES MAY EXHIBIT A FRONT SEAT BACK FRAME(S) BENDING. *TT | |
| Bulletin Number: 16119 | |
| SOME VEHICLES MAY EXHIBIT THE REAR BRAKE LAMPS REMAINING ILLUMINATED AFTER EXITING THE VEHICLE. *TT | |
| Bulletin Number: 16274 | |
| COMPASS DISPLAYS INCORRECT DIRECTION READING. *TT | |
| Bulletin Number: 16382 | |
| CLUNK/SQUEAK FROM THE FRONT STABILIZER BAR AREA (QSF). *TT | |
| Bulletin Number: 16383 | |
| SQUEAK NOISE FROM THE FRONT SPRING AREA. *TT | |
| Bulletin Number: 16423 | |
| SERVICING BODY SIDE MOLDING OR CLADDING / CONTACT REQUEST. *MJ | |
| Bulletin Number: 16611 | |
| POWER SEAT THAT MOVES IN A ARC RATHER THAN STRAIGHT FORWARD OR BACK. *TT | |
| Bulletin Number: 16919 | |
| STABILITY ASSIST SYSTEMS (ADVANCETRAC) MAY NOT BE RECALIBRATED PROPERLY USING WDS. *TT | |
| Bulletin Number: 16920 | |
| LEAN DIAGNOSTIC TROUBLE CODES P0171/P0174 STORED. NEW SERVICE ISOLATOR BOLT ASSEMBLY RELEASED FOR SERVICE. *TT | |
| Bulletin Number: 16987 | |
| SLIGHT AMOUNT OF FLUID RESIDUE ON THE OUTSIDE OF THE REAR WHEEL CYLINDER DUST BOOT ON VEHICLES WITH REAR DRUM BRAKES. *TT | |
| Bulletin Number: 17016 | |
| FRONT CALIPER SEEPAGE IN EXTREME COLD TEMPERATURES. *TT | |
| Bulletin Number: 17056 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON / NO START / ERRATIC SHIFTING. *TT | |
| Bulletin Number: 17104 | |
| TICKING/TAPPING NOISE WITH THE ENGINE WARMED UP AND THE TRANSMISSION IN GEAR AT IDLE. 2003 E150 INCLUDED. *TT | |
| Bulletin Number: 17277 | |
| BEEPING SOUND FROM THE INSTRUMENT PANEL WHEN DRIVING AT/OVER 75 MPH, TRACTION CONTROL OFF INDICATOR ILLUMINATE WHEN VEHICLE IS NOT EQUIPPED WITH TRACTION CONTROL, AND/OR DIAGNOSTIC TROUBLE CODE B2477 (MODULE CONFIGURATION FAILURE) STORED IN | |
| Bulletin Number: 17358 | |
| GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE. *TT THIS BULLETIN UPDATES PREVIOUS BULLETIN 17358, DATED 11/01/2003 TO INCLUDE 2005 MODELS. *TT | |
| Bulletin Number: 17525 | |
| WINDSHIELD COWL PANEL GRILLE (LEAF SCREEN) BREAKING AT THE GRILLE OPENING. *TT | |
| Bulletin Number: 17585 | |
| TRAILER TOW ELECTRIC BRAKE SWITCH/MODULE CONNECTOR MAY BE DIFFICULT TO LOCATE IN THE VEHICLE AND FOR CERTAIN 1999-2001 VEHICLES, THE LOCATION IS NOT CLEARLY IDENTIFIED IN THE WIRING DIAGRAM MANUAL. *TT | |
| Bulletin Number: 17744 | |
| POWER STEERING NOISE. *TT | |
| Bulletin Number: 2214 | |
| ROOF DITCH MATERIAL CRACKING. THIS INCLUDES 1997-2003 F-150 AND 2002 BLACKWOOD MODELS. *EH SERVICE TIP. *TT | |
| Bulletin Number: CSP-15-N-02 | |
| SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| Bulletin Number: TSB-14-0145 | |
| FORD: A SAFETY RECALL HAS BEEN ISSUED ON MINIVANS WHERE LOWER CONTROL ARM (LCA) OF FRONT SUBFRAME ATTACHING REAR FLANGE OR REAR BODY MOUNT CAN SEPARATE DUE TO CORROSION. MODEL 1999-2003 WINDSTAR. *PE | |
| Bulletin Number: TSB-14-0146 | |
| FORD: ON SOME MINIVANS, REAR AXLE WILL FRACTURE, IN HIGH CORROSION AREA, AFTER OPERATING FOR AN EXTENDED TIME PERIOD, AND VEHICLE HANDLING ABILITY WILL BE AFFECTED. MODEL 1998-2003 WINDSTAR. *PE | |
| Bulletin Number: TSB-14-0167 | |
| FORD: SAFETY RECALL CONCERNING REAR AXLE FRACTURING IF VEHICLE IS OPERATED IN HIGH CORROSION AREAS FOR AND EXTENDED PERIOD. MODEL 1998-03 WINDSTAR. *PE | |
| Bulletin Number: TSB-14-0168 | |
| FORD: SAFETY RECALL ON FRONT SUBFRAME LOWER CONTROL ARM (LCA) REAR ATTACHING FLANGE OR REAR BODY MOUNT THAT CAN SEPARATE FROM SUBFRAME IF VEHICLE IS OPERATED, FOR EXTENDED PERIOD, IN HIGH CORROSION AREAS. MODEL 1999-03 WINDSTAR. | |
| 2002 FORD ZX2 (ESCORT) | |
| Bulletin Number: 01156 | |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| Bulletin Number: 0245 | |
| INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| Bulletin Number: 031501 | |
| INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| Bulletin Number: 031514 | |
| THE MALFUNCTION INDICATOR LAMP (MIL) MAY BE ILLUMINATED AND DIAGNOSTIC TROUBLE CODES (DTCS) P1380, P1381, P1383, AND/OR P0340 MAY BE STORED IN MEMORY. *TT | |
| Bulletin Number: 031515 | |
| IDLE VIBRATION ON VEHICLES EQUIPPED WITH 2.0L SPI OR ZETEC ENGINE ONLY. *TT | |
| Bulletin Number: 03181 | |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| Bulletin Number: 0398 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| Bulletin Number: 041514 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 04174 | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| Bulletin Number: 04189 | |
| REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| Bulletin Number: 042107 | |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| Bulletin Number: 15743 | |
| INFORMATION ON VEHICLES NOT EQUIPPED WITH THE UPSHIFT INDICATOR LAMP. *TT | |
| Bulletin Number: 15818 | |
| SOME VEHICLES BUILT 09/2001 THROUGH 11/2001 AND EQUIPPED WITH A 2.0L ZETEC ENGINE MAY EXHIBIT A FEAD BELT NOISE. *TT | |
| Bulletin Number: 15858 | |
| SUBJECT REGARDING FUSE BOX COVER AND #7 FUSE LOCATION. *TT | |
Recalls for 2002 Ford
| 2002 FORD CROWN VICTORIA | |
|---|---|
| NHTSA Campaign ID: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 05/10/2001 - 03/22/2002 |
| Potential Units Affected: | 574 |
Defect Description:ON CERTAIN NATURAL GAS MODEL VEHICLES, A T-FITTING THAT CONNECTS FUEL TANKS #3 AND #4 CAN DEVELOP A LEAK WHEN THE SOLENOID VALVES ARE ENERGIZED, SUCH AS WHEN THE IGNITION SWITCH IS IN THE ON POSITION OR DURING REFUELING. Consequence:A GAS LEAK OF SUFFICIENT QUANTITY CONCENTRATED IN AN AREA TO CREATE A COMBUSTIBLE MIXTURE AND IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE. Action:DEALERS WILL INSTALL A REDESIGNED "T" FITTING ON #4 FUEL TANK AND TESTED FOR LEAKAGE. OWNER NOTIFICATION BEGAN SEPTEMBER 13, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332. | |
| 2002 FORD CROWN VICTORIA | |
|---|---|
| NHTSA Campaign ID: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 4218 |
Defect Description:ON CERTAIN NATURAL GAS VEHICLES, IF A FLAME FROM A VEHICLE INTERIOR FIRE BECOMES LOCALLY DIRECTED AT THE NATURAL GAS FUEL TANK LOCATED IMMEDIATELY BEHIND THE REAR SEAT, THE FLAME COULD DAMAGE THE FIBERGLASS WRAP ON THE TANK WEAKENING THE TANK. Consequence:IF THE STRENGTH OF THE TANK IS SIGNIFICANTLY COMPROMISED, IT COULD RUPTURE, INCREASING THE RISK OF A FIRE. Action:DEALERS WILL INSTALL AN INSULATOR BEHIND THE CURRENT SEAT BACK. OWNER NOTIFICATION BEGAN ON JANUARY 7, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. | |
| 2002 FORD CROWN VICTORIA | |
|---|---|
| NHTSA Campaign ID: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 07/01/1992 - 10/21/2002 |
| Potential Units Affected: | 350000 |
Defect Description:IN ORDER TO ENHANCE POLICE OFFICE SAFETY, MODEL YEAR 1992-2003 CROWN VICTORIA POLICE INTERCEPTOR (CVPI) VEHICLES WILL BE EQUIPPED WITH SHIELDS DESIGNED TO HELP PROTECT THE FUEL TANK IN HIGH-SPEED REAR-IMPACT CRASHES. FORD ALSO WILL BE OFFERING AN OPTIONAL TRUNK PACKAGE DESIGNED TO IMPROVE THE SAFE TRANSPORT OF SHARP-EDGED, HEAVY EQUIPMENT IN THESE VEHICLES. Consequence:SOME HIGH-SPEED REAR-IMPACT CRASHES HAVE RESULTED IN FUEL TANK PUNCTURES AND FIRES IN CVPI VEHICLES. Action:FORD HAS ADVISED US THAT SHIELD KITS HAVE BEEN AVAILABLE SINCE LATE OCTOBER AND WILL BE INSTALLED ON POLICE INTERCEPTOR VEHICLES AT NO COST. THE OPTIONAL TRANK PACKAGE WILL BE AVAILABLE BY THE END OF 2002. FORD HAS ESTABLISHED A NEW WEB SITE AT WWW.CVPI.COM TO ANSWER ADDITIONAL QUESTIONS ABOUT THE SAFE USE OF CPVI VEHICLES. | |
| 2002 FORD CVPI | |
|---|---|
| NHTSA Campaign ID: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 07/01/1992 - 10/21/2002 |
| Potential Units Affected: | 350000 |
Defect Description:IN ORDER TO ENHANCE POLICE OFFICE SAFETY, MODEL YEAR 1992-2003 CROWN VICTORIA POLICE INTERCEPTOR (CVPI) VEHICLES WILL BE EQUIPPED WITH SHIELDS DESIGNED TO HELP PROTECT THE FUEL TANK IN HIGH-SPEED REAR-IMPACT CRASHES. FORD ALSO WILL BE OFFERING AN OPTIONAL TRUNK PACKAGE DESIGNED TO IMPROVE THE SAFE TRANSPORT OF SHARP-EDGED, HEAVY EQUIPMENT IN THESE VEHICLES. Consequence:SOME HIGH-SPEED REAR-IMPACT CRASHES HAVE RESULTED IN FUEL TANK PUNCTURES AND FIRES IN CVPI VEHICLES. Action:FORD HAS ADVISED US THAT SHIELD KITS HAVE BEEN AVAILABLE SINCE LATE OCTOBER AND WILL BE INSTALLED ON POLICE INTERCEPTOR VEHICLES AT NO COST. THE OPTIONAL TRANK PACKAGE WILL BE AVAILABLE BY THE END OF 2002. FORD HAS ESTABLISHED A NEW WEB SITE AT WWW.CVPI.COM TO ANSWER ADDITIONAL QUESTIONS ABOUT THE SAFE USE OF CPVI VEHICLES. | |
| 2002 FORD E-150 | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL:CRUISE CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 09/03/1991 - 09/15/2003 |
| Potential Units Affected: | 225000 |
Defect Description:FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY. Consequence:AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND. Action:DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673. | |
| 2002 FORD E-150 | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 4500000 |
Defect Description:FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING. Action:FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
| 2002 FORD E-150 | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 04/09/1996 - 08/02/2002 |
| Potential Units Affected: | 3600000 |
Defect Description:ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:THIS COULD RESULT IN AN UNDERHOOD FIRE. Action:DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
| 2002 FORD E-250 | |
|---|---|
| NHTSA Campaign ID: | EQUIPMENT:OTHER:LABELS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 05/30/2001 - 07/26/2002 |
| Potential Units Affected: | 28456 |
Defect Description:CERTAIN VANS AND WAGONS FAIL TO CONFORM TO THE REQUIREMENTS OF PART 567, "CERTIFICATION." FOR CERTAIN 2003 E250 VANS BUILT WITH LT225/75R16E TIRES, THE REAR AXLE RATING IS INCORRECTLY LISTED ON THE LABEL. IN ADDITION, THE TIRE PRESSURE IS INCORRECTLY LISTED ON THE LABEL FOR THE REAR TIRES ON CERTAIN 2002 E350 WAGONS AND FOR THE FRONT TIRES ON CERTAIN 2002 E250 VANS BUILT WITH THESE TIRES. Consequence:FAILURE TO FOLLOW PROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION RECOMMENDATION CAN RESULT IN TIRE FAILURE, INCREASING THE RISK OF A CRASH. Action:OWNERS WILL BE PROVIDED WITH SUPPLEMENTARY TIRE LABELS CONTAINING CORRECT INFORMATION AND INSTALLATION INSTRUCTIONS. IF AN OWNER SO DESIRES, THEIR DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON JULY 8, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. | |
| 2002 FORD E-250 | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 04/09/1996 - 08/02/2002 |
| Potential Units Affected: | 3600000 |
Defect Description:ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:THIS COULD RESULT IN AN UNDERHOOD FIRE. Action:DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
| 2002 FORD E-250 | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 4500000 |
Defect Description:FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING. Action:FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
| 2002 FORD E-250 | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL:CRUISE CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 09/03/1991 - 09/15/2003 |
| Potential Units Affected: | 225000 |
Defect Description:FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY. Consequence:AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND. Action:DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673. | |
| 2002 FORD E250 | |
|---|---|
| NHTSA Campaign ID: | EQUIPMENT ADAPTIVE |
| Manufacturer: | ACCUBUILT, INC. |
| Manufacture Dates: | 09/26/2002 - 05/23/2003 |
| Potential Units Affected: | 501 |
Defect Description:ON CERTAIN VANS BUILT ON FORD E250/E350 CHASSIS AND EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT. Consequence:IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES TO A WHEELCHAIR OCCUPANT. Action:DEALERS WILL INSPECT AND REPLACE THE WHEELCHAIR SECUREMENT RETRACTORS AS NECESSARY. SURE-LOK IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS SHOULD CONTACT SURE-LOCK AT 1-908-231-1804 OR ACCUBUILT AT 419-222-1501. | |
| 2002 FORD E-350 | |
|---|---|
| NHTSA Campaign ID: | EQUIPMENT:OTHER:LABELS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 05/30/2001 - 07/26/2002 |
| Potential Units Affected: | 28456 |
Defect Description:CERTAIN VANS AND WAGONS FAIL TO CONFORM TO THE REQUIREMENTS OF PART 567, "CERTIFICATION." FOR CERTAIN 2003 E250 VANS BUILT WITH LT225/75R16E TIRES, THE REAR AXLE RATING IS INCORRECTLY LISTED ON THE LABEL. IN ADDITION, THE TIRE PRESSURE IS INCORRECTLY LISTED ON THE LABEL FOR THE REAR TIRES ON CERTAIN 2002 E350 WAGONS AND FOR THE FRONT TIRES ON CERTAIN 2002 E250 VANS BUILT WITH THESE TIRES. Consequence:FAILURE TO FOLLOW PROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION RECOMMENDATION CAN RESULT IN TIRE FAILURE, INCREASING THE RISK OF A CRASH. Action:OWNERS WILL BE PROVIDED WITH SUPPLEMENTARY TIRE LABELS CONTAINING CORRECT INFORMATION AND INSTALLATION INSTRUCTIONS. IF AN OWNER SO DESIRES, THEIR DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON JULY 8, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. | |
| 2002 FORD E-350 | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 04/09/1996 - 08/02/2002 |
| Potential Units Affected: | 3600000 |
Defect Description:ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:THIS COULD RESULT IN AN UNDERHOOD FIRE. Action:DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
| 2002 FORD E-350 | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL:CRUISE CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 09/03/1991 - 09/15/2003 |
| Potential Units Affected: | 225000 |
Defect Description:FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY. Consequence:AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND. Action:DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673. | |
| 2002 FORD E-350 | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 4500000 |
Defect Description:FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING. Action:FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
| 2002 FORD E350 | |
|---|---|
| NHTSA Campaign ID: | EQUIPMENT ADAPTIVE |
| Manufacturer: | ACCUBUILT, INC. |
| Manufacture Dates: | 09/26/2002 - 05/23/2003 |
| Potential Units Affected: | 501 |
Defect Description:ON CERTAIN VANS BUILT ON FORD E250/E350 CHASSIS AND EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT. Consequence:IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES TO A WHEELCHAIR OCCUPANT. Action:DEALERS WILL INSPECT AND REPLACE THE WHEELCHAIR SECUREMENT RETRACTORS AS NECESSARY. SURE-LOK IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS SHOULD CONTACT SURE-LOCK AT 1-908-231-1804 OR ACCUBUILT AT 419-222-1501. | |
| 2002 FORD E-450 | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 4500000 |
Defect Description:FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING. Action:FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
| 2002 FORD E-450 | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 1200000 |
Defect Description:ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT. Consequence:OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE. Action:DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388) | |
| 2002 FORD E-550 | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 4500000 |
Defect Description:FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING. Action:FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
| 2002 FORD E-550 | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 155584 |
Defect Description:ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT. Consequence:OVERHEATING COULD RESULT IN SMOKE, BURN, OR AN UNDERHOOD FIRE. Action:DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON MARCH 12, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017, 05V388, AND 06V286) | |
| 2002 FORD ECONOLINE | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL:CRUISE CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 09/03/1991 - 09/15/2003 |
| Potential Units Affected: | 225000 |
Defect Description:FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY. Consequence:AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND. Action:DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673. | |
| 2002 FORD ECONOLINE | |
|---|---|
| NHTSA Campaign ID: | FUEL SYSTEM, GASOLINE:STORAGE |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 06/18/2001 - 03/20/2003 |
| Potential Units Affected: | 64 |
Defect Description:ON CERTAIN CUTAWAY CHASSIS CAB WITH THE SCHOOL BUS OPTION, TWO BRACKETS AND TWO OUTRIGGER MEMBERS ARE MISSING IN THE AREA OF THE FUEL TANK. Consequence:THE BRACKETS AND OUTRIGGER MEMBERS ARE INTENDED TO ENHANCE CRASH PERFORMANCE. Action:FORD WILL SEND TECHNICIANS TO THE OWNER'S LOCATION TO INSPECT AND ADD THE BRACKETS AND OUTRIGGERS AS REQUIRED. OWNER NOTIFICATION BEGAN ON SEPTEMBER 3, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. | |
| 2002 FORD ESCAPE | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL:CABLES |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 05/30/2001 - 01/23/2004 |
| Potential Units Affected: | 470245 |
Defect Description:ON CERTAIN SPORT UTILITY VEHICLES BUILT WITH 3.0L V6 ENGINES, THE ACCELERATOR CABLE MAY PREVENT THE THROTTLE FROM RETURNING TO THE IDLE POSITION. Consequence:AN UNEXPECTED INCREASE IN ENGINE IDLE SPEED MAY INCREASE STOPPING DISTANCE AND MAY RESULT IN A VEHICLE CRASH. Action:DEALERS WILL REPLACE THE ACCELERATOR CABLE. THE RECALL BEGAN ON JANUARY 10, 2005. OWNERS SHOULD CONTACT FORD AT 1-866-436-7332. | |
| 2002 FORD ESCAPE | |
|---|---|
| NHTSA Campaign ID: | POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL) |
| Manufacturer: | Ford Motor Company |
| Manufacture Dates: | 03/31/2001 - 09/01/2009 |
| Potential Units Affected: | 57 |
Defect Description:Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning. Consequence:If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders. Action:Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28. | |
| 2002 FORD ESCAPE | |
|---|---|
| NHTSA Campaign ID: | STRUCTURE:FRAME AND MEMBERS |
| Manufacturer: | Ford Motor Company |
| Manufacture Dates: | 10/22/1999 - 12/19/2003 |
| Potential Units Affected: | 348950 |
Defect Description:Ford Motor Company (Ford) is recalling certain model year 2001-2004 Escape vehicles manufactured October 22, 1999, through January 23, 2004, originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. These vehicles may experience excessive corrosion at the forward attachment of the lower control arm. Consequence:A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash. Action:Ford will notify owners, and dealers will install a newly designed reinforcement cross-brace, free of charge. The recall began on May 30, 2014. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 14S02. | |
| 2002 FORD ESCAPE | |
|---|---|
| NHTSA Campaign ID: | SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 10/22/1999 - 07/19/2002 |
| Potential Units Affected: | 244530 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 2001-2002 ESCAPE VEHICLES MANUFACTURED FROM OCTOBER 22, 1999, THROUGH JULY 19, 2002, EQUIPPED WITH A BRAKE MASTER CYLINDER RESERVOIR CAP THAT COULD LEAK BRAKE FLUID. IF BRAKE FLUID LEAKS FROM THE CAP, IT COULD COME IN CONTACT WITH THE ANTILOCK BRAKE SYSTEM (ABS) MODULE WIRING HARNESS CONNECTOR. Consequence:CORROSION CAN DEVELOP IN THE ELECTRICAL CONNECTOR LEADING TO MELTING, SMOKE OR A FIRE. Action:DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER RESERVOIR CAP AND THE ABS ELECTRICAL SYSTEM WILL BE MODIFIED. AN INTERIM LETTER WAS MAILED ON JANUARY 20, 2012. DUE TO A PARTS DELAY, HOWEVER, THE REMEDY MAY NOT BE AVAILABLE CURRENTLY. IF PARTS ARE NOT AVAILABLE, FORD WILL INSTRUCT OWNERS TO PARK THEIR VEHICLES OUTSIDE UNTIL SUCH TIME AS PARTS BECOME AVAILABLE. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. THIS RECALL CAMPAIGN IS RELATED TO 07V-156. | |
| 2002 FORD ESCAPE | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL:CABLES |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 529719 |
Defect Description:Ford Motor Company is recalling certain model year 2001 through 2004 Escape vehicles equipped with 3.0L V6 engines and speed control manufactured from October 22, 1999, through January 23, 2004. Inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. This risk exists regardless of whether or not speed control (cruise control) is used. Consequence:A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death. Action:Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. The safety recall began August 3, 2012. Remedy parts are expected to be available in mid-August 2012. Until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. Owners may contact Ford at 1-866-436-7332. | |
| 2002 FORD ESCAPE | |
|---|---|
| NHTSA Campaign ID: | POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM) |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 01/31/2000 - 09/11/2002 |
| Potential Units Affected: | 321903 |
Defect Description:ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.0L V6 ENGINES, DURING DECELERATION, THE ENGINE CAN STALL. Consequence:SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR. Action:DEALERS WILL REPROGRAM THE POWER CONTROL MODULE (PCM) WITH THE APPROPRIATE CALIBRATION. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. | |
| 2002 FORD ESCAPE | |
|---|---|
| NHTSA Campaign ID: | ENGINE AND ENGINE COOLING |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 529719 |
Defect Description:Ford Motor Company is recalling certain model year 2001 through 2004 Escape vehicles equipped with 3.0L V6 engines and speed control manufactured from October 22, 1999, through January 23, 2004. Inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. This risk exists regardless of whether or not speed control (cruise control) is used. Consequence:A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death. Action:Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. The safety recall began August 3, 2012. Remedy parts are expected to be available in mid-August 2012. Until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. Owners may contact Ford at 1-866-436-7332. | |
| 2002 FORD ESCAPE | |
|---|---|
| NHTSA Campaign ID: | LATCHES/LOCKS/LINKAGES:DOORS:LATCH |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 262113 |
Defect Description:CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION. Consequence:IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH. Action:DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. | |
| 2002 FORD ESCAPE | |
|---|---|
| NHTSA Campaign ID: | SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 10/22/1999 - 01/23/2004 |
| Potential Units Affected: | 446460 |
Defect Description:ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT. Consequence:AN ELECTRICAL SHORT MIGHT CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, AND IN SOME CASES, THE MODULE MAY OVERHEAT RESULTING IN BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION COULD OCCUR EITHER WHEN THE VEHICLE IGNITION SWITCH IS IN THE OFF POSITION OR WHILE THE VEHICLE IS BEING OPERATED. Action:DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR TO THE ABS MODULE FOR MISSING OR DISLODGED WIRE SEALS, AND REPAIR OR REPLACE THE HARNESS CONNECTOR AS APPROPRIATE. THE DEALER WILL ALSO INSPECT THE CONNECTOR ON THE ABS MODULE AND REPLACE IT IF IT IS FOUND TO BE CORRODED OR DAMAGED. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673. | |
| 2002 FORD ESCAPE | |
|---|---|
| NHTSA Campaign ID: | POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT |
| Manufacturer: | Ford Motor Company |
| Manufacture Dates: | 03/31/2001 - 09/01/2009 |
| Potential Units Affected: | 57 |
Defect Description:Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning. Consequence:If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders. Action:Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28. | |
| 2002 FORD E SERIES | |
|---|---|
| NHTSA Campaign ID: | STRUCTURE |
| Manufacturer: | SOUTHERN COMFORT CONVERSIONS |
| Manufacture Dates: | 08/01/2000 - 03/03/2003 |
| Potential Units Affected: | 3674 |
Defect Description:CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT. Consequence:THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE. Action:DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096. | |
| 2002 FORD E-SERIES | |
|---|---|
| NHTSA Campaign ID: | ENGINE AND ENGINE COOLING:ENGINE:DIESEL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 1176000 |
Defect Description:ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL. Consequence:IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING. Action:DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332. | |
| 2002 FORD EXCURSION | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 03/25/1999 - 11/01/2002 |
| Potential Units Affected: | 4500000 |
Defect Description:FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING. Action:FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
| 2002 FORD EXCURSION | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:BRAKE LIGHTS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 26715 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE. Consequence:NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH. Action:DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. | |
| 2002 FORD EXCURSION | |
|---|---|
| NHTSA Campaign ID: | ENGINE AND ENGINE COOLING:ENGINE:DIESEL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 1176000 |
Defect Description:ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL. Consequence:IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING. Action:DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332. | |
| 2002 FORD EXCURSION | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:TAIL LIGHTS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 26715 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE. Consequence:NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH. Action:DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. | |
| 2002 FORD EXCURSION | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 1200000 |
Defect Description:ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT. Consequence:OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE. Action:DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388) | |
| 2002 FORD EXPEDITION | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - 08/20/2002 |
| Potential Units Affected: | 4500000 |
Defect Description:ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN. Consequence:A FIRE AT THE SWITCH COULD OCCUR. Action:BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286) | |
| 2002 FORD EXPEDITION | |
|---|---|
| NHTSA Campaign ID: | STRUCTURE |
| Manufacturer: | SOUTHERN COMFORT CONVERSIONS |
| Manufacture Dates: | 08/01/2000 - 03/03/2003 |
| Potential Units Affected: | 3674 |
Defect Description:CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT. Consequence:THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE. Action:DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096. | |
| 2002 FORD EXPLORER | |
|---|---|
| NHTSA Campaign ID: | VISIBILITY:GLASS, SIDE/REAR |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 02/05/2001 - 03/30/2001 |
| Potential Units Affected: | 50224 |
Defect Description:THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS COULD ROTATE OUT OF POSITION IF EITHER THE URETHANE BOND OR TORQUE ARE NOT SUFFICIENT. Consequence:ROTATION OF THE BRACKETS COULD POTENTIALLY CAUSE THE LIFT CYLINDERS TO DETACH FROM THE GLASS OR, IN SOME CASES, COULD POTENTIALLY CAUSE THE LIFTGATE GLASS TO BREAK. EITHER CONDITION IS MOST LIKELY TO OCCUR WHEN THE GLASS IS BEING CLOSED. Action:FORD DEALERS WILL INSPECT THE VEHICLES FOR THE POSITION OF BOTH THE LEFT AND RIGHT LIFTGATGE GLASS LIFT CYLINDER BRACKETS. IF THE BRACKETS ARE IN THE PROPER POSITION, THE BRACKET RETAINERS WILL BE TIGHTENED TO A HIGHER TORQUE. IN CASES WHERE THE BRACKET IS NOT PROPERLY POSITION, THE BRACKET MUST BE RE-ALIGNED. | |
| 2002 FORD EXPLORER | |
|---|---|
| NHTSA Campaign ID: | STRUCTURE |
| Manufacturer: | SOUTHERN COMFORT CONVERSIONS |
| Manufacture Dates: | 08/01/2000 - 03/03/2003 |
| Potential Units Affected: | 3674 |
Defect Description:CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT. Consequence:THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE. Action:DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096. | |
| 2002 FORD EXPLORER | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 08/11/1994 - 08/30/2002 |
| Potential Units Affected: | 4500000 |
Defect Description:FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING. Action:FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
| 2002 FORD EXPLORER | |
|---|---|
| NHTSA Campaign ID: | STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 08/01/2000 - 06/23/2003 |
| Potential Units Affected: | 955732 |
Defect Description:ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK. Consequence:IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR. Action:DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. | |
| 2002 FORD EXPLORER | |
|---|---|
| NHTSA Campaign ID: | TIRES:SIDEWALL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 08/14/2000 - 04/27/2001 |
| Potential Units Affected: | 52000 |
Defect Description:VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY. Consequence:OVER TIME, THE TIRE COULD FAIL, INCREASING THE RISK OF A CRASH. Action:DEALERS WILL INSPECT THE TIRES AND, IF ANY SLICES ARE FOUND, THE CUT TIRES WILL BE REPLACED. OWNER NOTIFICATION BEGAN JUNE 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. | |
| 2002 FORD EXPLORER SPORT | |
|---|---|
| NHTSA Campaign ID: | SEATS:FRONT ASSEMBLY:RECLINER |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 8585 |
Defect Description:ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES, THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH AN OBJECT BEHIND THE SEAT, SUCH AS THE SECOND ROW SEAT CUSHION. Consequence:THE DRIVER COULD POTENTIALLY LOSE CONTACT WITH THE STEERING WHEEL OR FOOT PEDALS DURING SUCH AN EVENT, INCREASING THE RISK OF A CRASH. Action:DEALERS WILL REPLACE THE DRIVER SEAT UPPER BOLT WITH A METAL SPACER AND BOLT. IN ADDITION, SEATS WITH TUBULAR BACK FRAMES WILL HAVE THE FULLY THREADED LOWER RECLINER BOLT REPLACED WITH A PARTIALLY THREADED BOLT. THE RECALL BEGAN ON APRIL 10, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673. THIS IS A SUPPLEMENT TO A PREVIOUS RECALL CAMPAIGN (03V281). | |
| 2002 FORD EXPLORER SPORT | |
|---|---|
| NHTSA Campaign ID: | SEATS:FRONT ASSEMBLY:RECLINER |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 09/24/1999 - 08/16/2002 |
| Potential Units Affected: | 1552880 |
Defect Description:ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES AND DOES NOT JAM IN THE SEAT BACK FRAME, THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH AN OBJECT BEHIND THE SEAT, SUCH AS THE SECOND ROW SEAT CUSHION. Consequence:THE DRIVER COULD POTENTIALLY LOSE CONTACT WITH THE STEERING WHEEL OR FOOT PEDALS DURING SUCH AN EVENT, INCREASING THE RISK OF A CRASH. Action:DEALERS WILL REPLACE THE DRIVER SEAT UPPER BOLT WITH A METAL SPACER AND BOLT. IN ADDITION, SEATS WITH TUBULAR BACK FRAMES WILL HAVE THE FULLY THREADED LOWER RECLINER BOLT REPLACED WITH A PARTIALLY THREADED BOLT. OWNER NOTIFICATION BEGAN ON AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. | |
| 2002 FORD EXPLORER SPORT | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 09/24/1999 - 08/16/2002 |
| Potential Units Affected: | 3600000 |
Defect Description:ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:THIS COULD RESULT IN AN UNDERHOOD FIRE. Action:DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
| 2002 FORD EXPLORER SPORT TRAC | |
|---|---|
| NHTSA Campaign ID: | SEATS:FRONT ASSEMBLY:RECLINER |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 09/24/1999 - 08/16/2002 |
| Potential Units Affected: | 1552880 |
Defect Description:ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES AND DOES NOT JAM IN THE SEAT BACK FRAME, THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH AN OBJECT BEHIND THE SEAT, SUCH AS THE SECOND ROW SEAT CUSHION. Consequence:THE DRIVER COULD POTENTIALLY LOSE CONTACT WITH THE STEERING WHEEL OR FOOT PEDALS DURING SUCH AN EVENT, INCREASING THE RISK OF A CRASH. Action:DEALERS WILL REPLACE THE DRIVER SEAT UPPER BOLT WITH A METAL SPACER AND BOLT. IN ADDITION, SEATS WITH TUBULAR BACK FRAMES WILL HAVE THE FULLY THREADED LOWER RECLINER BOLT REPLACED WITH A PARTIALLY THREADED BOLT. OWNER NOTIFICATION BEGAN ON AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. | |
| 2002 FORD EXPLORER SPORT TRAC | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 09/24/1999 - 08/16/2002 |
| Potential Units Affected: | 3600000 |
Defect Description:ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:THIS COULD RESULT IN AN UNDERHOOD FIRE. Action:DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
| 2002 FORD F-150 | |
|---|---|
| NHTSA Campaign ID: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 06/20/1995 - 08/04/2004 |
| Potential Units Affected: | 1100000 |
Defect Description:FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE. Consequence:AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD. Action:FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21 | |
| 2002 FORD F-150 | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - 08/20/2002 |
| Potential Units Affected: | 4500000 |
Defect Description:ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN. Consequence:A FIRE AT THE SWITCH COULD OCCUR. Action:BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286) | |
| 2002 FORD F-250 | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 1200000 |
Defect Description:ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT. Consequence:OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE. Action:DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388) | |
| 2002 FORD F-250 | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:BRAKE LIGHTS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 26715 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE. Consequence:NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH. Action:DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. | |
| 2002 FORD F-250 | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:TAIL LIGHTS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 26715 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE. Consequence:NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH. Action:DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. | |
| 2002 FORD F-250 SD | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 4500000 |
Defect Description:FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING. Action:FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
| 2002 FORD F-250 SD | |
|---|---|
| NHTSA Campaign ID: | ENGINE AND ENGINE COOLING:ENGINE:DIESEL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 1176000 |
Defect Description:ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL. Consequence:IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING. Action:DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332. | |
| 2002 FORD F-250 SD | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:TAIL LIGHTS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 26715 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE. Consequence:NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH. Action:DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. | |
| 2002 FORD F-250 SD | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:BRAKE LIGHTS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 26715 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE. Consequence:NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH. Action:DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. | |
| 2002 FORD F-350 | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:BRAKE LIGHTS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 26715 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE. Consequence:NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH. Action:DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. | |
| 2002 FORD F-350 | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:TAIL LIGHTS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 26715 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE. Consequence:NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH. Action:DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. | |
| 2002 FORD F-350 | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 1200000 |
Defect Description:ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT. Consequence:OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE. Action:DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388) | |
| 2002 FORD F-350 SD | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:TAIL LIGHTS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 26715 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE. Consequence:NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH. Action:DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. | |
| 2002 FORD F-350 SD | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 4500000 |
Defect Description:FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING. Action:FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
| 2002 FORD F-350 SD | |
|---|---|
| NHTSA Campaign ID: | ENGINE AND ENGINE COOLING:ENGINE:DIESEL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 1176000 |
Defect Description:ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL. Consequence:IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING. Action:DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332. | |
| 2002 FORD F-350 SD | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:BRAKE LIGHTS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 26715 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE. Consequence:NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH. Action:DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. | |
| 2002 FORD F450 CLASSIC TRAVELER | |
|---|---|
| NHTSA Campaign ID: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturer: | FONTAINE MODIFICATION CO. |
| Manufacture Dates: | - |
| Potential Units Affected: | 293 |
Defect Description:ON CERTAIN PICKUP TRUCKS EQUIPPED WITH REYCO GRANNING MODEL 345P AIR RIDE SUSPENSIONS, THE BRACKET SUPPORTING THE HORIZONTAL TRACK ROD AT THE FRAME ATTACHMENT CAN BECOME LOOSE AND EVENTUALLY CRACK AND BREAK. Consequence:THIS CONDITION COULD CAUSE THE TRACK ROD TO BE INEFFECTIVE IN MAINTAINING LATERAL CONTROL BETWEEN THE AXLE AND FRAME RESULTING IN VEHICLE HANDLING PROBLEMS INCREASING THE RISK OF A CRASH. Action:DEALERS WILL INSPECT THE BRACKET AND NUT/BOLT HARDWARE. IF THE BOLTS ARE LOOSE OR THE BRACKET HAS CRACKED, THE BOLTS, NUTS, AND BRACKETS WILL BE REPLACED. IF THE BOLTS ARE INSTALLED CORRECTLY AND ARE TIGHT, THEY WILL BE REMOVED AND REPLACED WITH NEW BOLTS AND LOCKTITE. THE RECALL BEGAN ON FEBRUARY 22, 2008. OWNERS MAY CONTACT FONTAINE AT 1-704-409-1605. THIS RECALL HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON FORD F450 AND F550 PICKUP TRUCKS MANUFACTURED BY FORD MOTOR COMPANY. | |
| 2002 FORD F-450 SD | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 4500000 |
Defect Description:FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING. Action:FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
| 2002 FORD F-450 SD | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 1200000 |
Defect Description:ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT. Consequence:OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE. Action:DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388) | |
| 2002 FORD F-450 SD | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:BRAKE LIGHTS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 26715 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE. Consequence:NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH. Action:DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. | |
| 2002 FORD F-450 SD | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:TAIL LIGHTS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 26715 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE. Consequence:NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH. Action:DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. | |
| 2002 FORD F-450 SD | |
|---|---|
| NHTSA Campaign ID: | ENGINE AND ENGINE COOLING:ENGINE:DIESEL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 1176000 |
Defect Description:ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL. Consequence:IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING. Action:DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332. | |
| 2002 FORD F53 | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 11/09/1999 - 12/27/2002 |
| Potential Units Affected: | 3600000 |
Defect Description:ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:THIS COULD RESULT IN AN UNDERHOOD FIRE. Action:DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
| 2002 FORD F550 CLASSIC TRAVELER | |
|---|---|
| NHTSA Campaign ID: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturer: | FONTAINE MODIFICATION CO. |
| Manufacture Dates: | - |
| Potential Units Affected: | 293 |
Defect Description:ON CERTAIN PICKUP TRUCKS EQUIPPED WITH REYCO GRANNING MODEL 345P AIR RIDE SUSPENSIONS, THE BRACKET SUPPORTING THE HORIZONTAL TRACK ROD AT THE FRAME ATTACHMENT CAN BECOME LOOSE AND EVENTUALLY CRACK AND BREAK. Consequence:THIS CONDITION COULD CAUSE THE TRACK ROD TO BE INEFFECTIVE IN MAINTAINING LATERAL CONTROL BETWEEN THE AXLE AND FRAME RESULTING IN VEHICLE HANDLING PROBLEMS INCREASING THE RISK OF A CRASH. Action:DEALERS WILL INSPECT THE BRACKET AND NUT/BOLT HARDWARE. IF THE BOLTS ARE LOOSE OR THE BRACKET HAS CRACKED, THE BOLTS, NUTS, AND BRACKETS WILL BE REPLACED. IF THE BOLTS ARE INSTALLED CORRECTLY AND ARE TIGHT, THEY WILL BE REMOVED AND REPLACED WITH NEW BOLTS AND LOCKTITE. THE RECALL BEGAN ON FEBRUARY 22, 2008. OWNERS MAY CONTACT FONTAINE AT 1-704-409-1605. THIS RECALL HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON FORD F450 AND F550 PICKUP TRUCKS MANUFACTURED BY FORD MOTOR COMPANY. | |
| 2002 FORD F-550 SD | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:BRAKE LIGHTS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 26715 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE. Consequence:NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH. Action:DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. | |
| 2002 FORD F-550 SD | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 4500000 |
Defect Description:FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING. Action:FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
| 2002 FORD F-550 SD | |
|---|---|
| NHTSA Campaign ID: | ENGINE AND ENGINE COOLING:ENGINE:DIESEL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 1176000 |
Defect Description:ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL. Consequence:IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING. Action:DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332. | |
| 2002 FORD F-550 SD | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:TAIL LIGHTS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 26715 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE. Consequence:NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH. Action:DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. | |
| 2002 FORD F-550 SD | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 1200000 |
Defect Description:ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT. Consequence:OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE. Action:DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388) | |
| 2002 FORD F-650 | |
|---|---|
| NHTSA Campaign ID: | SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 05/16/2000 - 12/11/2001 |
| Potential Units Affected: | 546 |
Defect Description:CERTAIN MEDIUM DUTY PICKUP TRUCKS EQUIPPED WITH AIR BRAKES THAT INCLUDE THE OPTIONAL TRAILER PACKAGE FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS." THE AIR BRAKE LINES CONNECTED TO THE TRACTOR PROTECTION VALVE ARE MISROUTED. Consequence:A LEAK IN THE PRIMARY AIR CIRCUIT OR SECONDARY AIR CIRCUIT COULD RESULT IN A REDUCTION OR LOSS OF THE TRAILER BRAKE EFFECTIVENESS, INCREASING THE RISK OF A CRASH. Action:DEALERS WILL RE-ROUTE THE AIR LINES CONNECTED TO THE TRACTOR PROTECTION VALVE. OWNER NOTIFICATION BEGAN JANUARY 31, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-248-0186. | |
| 2002 FORD F750 | |
|---|---|
| NHTSA Campaign ID: | SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 05/16/2000 - 12/11/2001 |
| Potential Units Affected: | 546 |
Defect Description:CERTAIN MEDIUM DUTY PICKUP TRUCKS EQUIPPED WITH AIR BRAKES THAT INCLUDE THE OPTIONAL TRAILER PACKAGE FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS." THE AIR BRAKE LINES CONNECTED TO THE TRACTOR PROTECTION VALVE ARE MISROUTED. Consequence:A LEAK IN THE PRIMARY AIR CIRCUIT OR SECONDARY AIR CIRCUIT COULD RESULT IN A REDUCTION OR LOSS OF THE TRAILER BRAKE EFFECTIVENESS, INCREASING THE RISK OF A CRASH. Action:DEALERS WILL RE-ROUTE THE AIR LINES CONNECTED TO THE TRACTOR PROTECTION VALVE. OWNER NOTIFICATION BEGAN JANUARY 31, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-248-0186. | |
| 2002 FORD FOCUS | |
|---|---|
| NHTSA Campaign ID: | LATCHES/LOCKS/LINKAGES:DOORS:LATCH |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 04/07/1999 - 09/02/2002 |
| Potential Units Affected: | 589932 |
Defect Description:CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY. Consequence:IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR. Action:DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673. | |
| 2002 FORD FOCUS SVT | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL:CRUISE CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 11/06/2001 - 04/08/2002 |
| Potential Units Affected: | 534 |
Defect Description:ON CERTAIN PASSENGER VEHICLES BUILT WITH MANUAL TRANSAXLES, THERE IS THE POTENTIAL FOR THE SPEED CONTROL CABLE TO HANG UP AT THE THROTTLE BODY BRACKET DURING HIGH, WIDE OPEN THROTTLE OPERATION, PREVENTING THE THROTTLE FROM RETURNING TO THE CLOSED POSITION WHEN THE ACCELERATOR IS RELEASED. Consequence:IF THIS CONDITION WERE TO OCCUR, IT MAY BE NECESSARY TO DEPRESS THE CLUTCH AND APPLY THE BRAKE TO BRING THE VEHICLE TO A STOP. Action:DEALERS WILL REPLACE THE THROTTLE BODY AND CHECK FOR PROPER OPERATION. OWNER NOTIFICATION BEGAN APRIL 25, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332. | |
| 2002 FORD F SERIES | |
|---|---|
| NHTSA Campaign ID: | STRUCTURE |
| Manufacturer: | SOUTHERN COMFORT CONVERSIONS |
| Manufacture Dates: | 08/01/2000 - 03/03/2003 |
| Potential Units Affected: | 3674 |
Defect Description:CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT. Consequence:THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE. Action:DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096. | |
| 2002 FORD LIMO COACH | |
|---|---|
| NHTSA Campaign ID: | EQUIPMENT |
| Manufacturer: | TURTLE TOP |
| Manufacture Dates: | 08/02/1999 - 09/01/2007 |
| Potential Units Affected: | 1817 |
Defect Description:TURTLE TOP IS RECALLING CERTAIN MODEL YEAR 2001-2007 TRANSIT BUSES BUILT ON VARIOUS GM AND FORD CHASSIS FROM AUGUST 2, 1999 THROUGH SEPTEMBER 1, 2007, EQUIPPED WITH TRANS/AIR TA73 EVAPORATORS. THE EVAPORATOR UTILIZES A POWER RESISTOR TO REGULATE BLOWER SPEED. SHOULD A SHORT OCCUR IN THE "LOW OR MEDIUM SPEED" CIRCUIT WHILE THE BLOWER IS IN HIGH SPEED, THE SHORT WILL CAUSE THE SUPPLY VOLTAGE TO FEEDBACK THROUGH THE RESISTOR TO GROUND, NOT DRAWING ENOUGH CURRENT TO TRIP THE FUSE. Consequence:THIS WOULD CAUSE THE RESISTOR TEMPERATURE TO RISE TO A POINT WHERE IT WILL MELT AND POSSIBLY IGNITE THE PLASTIC BLOWER HOUSING TO WHICH IT IS MOUNTED. THE OVERHEATING CAN RESULT IN A FIRE. Action:TRANS/AIR, IN COOPERATION WITH TURTL TOP, WILL INSTALL A THERMAL SHUTDOWN DEVICE IN SERIES WITH THE SPEED RESISTORS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT TRANS/AIR WARRANTY AND SERVICE CENTER AT 1-800-673-2446. | |
| 2002 FORD MOUNTAINEER | |
|---|---|
| NHTSA Campaign ID: | STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 08/01/2000 - 06/23/2003 |
| Potential Units Affected: | 955732 |
Defect Description:ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK. Consequence:IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR. Action:DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. | |
| 2002 FORD MPV | |
|---|---|
| NHTSA Campaign ID: | EQUIPMENT |
| Manufacturer: | TURTLE TOP |
| Manufacture Dates: | 08/02/1999 - 09/01/2007 |
| Potential Units Affected: | 1817 |
Defect Description:TURTLE TOP IS RECALLING CERTAIN MODEL YEAR 2001-2007 TRANSIT BUSES BUILT ON VARIOUS GM AND FORD CHASSIS FROM AUGUST 2, 1999 THROUGH SEPTEMBER 1, 2007, EQUIPPED WITH TRANS/AIR TA73 EVAPORATORS. THE EVAPORATOR UTILIZES A POWER RESISTOR TO REGULATE BLOWER SPEED. SHOULD A SHORT OCCUR IN THE "LOW OR MEDIUM SPEED" CIRCUIT WHILE THE BLOWER IS IN HIGH SPEED, THE SHORT WILL CAUSE THE SUPPLY VOLTAGE TO FEEDBACK THROUGH THE RESISTOR TO GROUND, NOT DRAWING ENOUGH CURRENT TO TRIP THE FUSE. Consequence:THIS WOULD CAUSE THE RESISTOR TEMPERATURE TO RISE TO A POINT WHERE IT WILL MELT AND POSSIBLY IGNITE THE PLASTIC BLOWER HOUSING TO WHICH IT IS MOUNTED. THE OVERHEATING CAN RESULT IN A FIRE. Action:TRANS/AIR, IN COOPERATION WITH TURTL TOP, WILL INSTALL A THERMAL SHUTDOWN DEVICE IN SERIES WITH THE SPEED RESISTORS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT TRANS/AIR WARRANTY AND SERVICE CENTER AT 1-800-673-2446. | |
| 2002 FORD MPV BUS | |
|---|---|
| NHTSA Campaign ID: | EQUIPMENT |
| Manufacturer: | TURTLE TOP |
| Manufacture Dates: | 08/02/1999 - 09/01/2007 |
| Potential Units Affected: | 1817 |
Defect Description:TURTLE TOP IS RECALLING CERTAIN MODEL YEAR 2001-2007 TRANSIT BUSES BUILT ON VARIOUS GM AND FORD CHASSIS FROM AUGUST 2, 1999 THROUGH SEPTEMBER 1, 2007, EQUIPPED WITH TRANS/AIR TA73 EVAPORATORS. THE EVAPORATOR UTILIZES A POWER RESISTOR TO REGULATE BLOWER SPEED. SHOULD A SHORT OCCUR IN THE "LOW OR MEDIUM SPEED" CIRCUIT WHILE THE BLOWER IS IN HIGH SPEED, THE SHORT WILL CAUSE THE SUPPLY VOLTAGE TO FEEDBACK THROUGH THE RESISTOR TO GROUND, NOT DRAWING ENOUGH CURRENT TO TRIP THE FUSE. Consequence:THIS WOULD CAUSE THE RESISTOR TEMPERATURE TO RISE TO A POINT WHERE IT WILL MELT AND POSSIBLY IGNITE THE PLASTIC BLOWER HOUSING TO WHICH IT IS MOUNTED. THE OVERHEATING CAN RESULT IN A FIRE. Action:TRANS/AIR, IN COOPERATION WITH TURTL TOP, WILL INSTALL A THERMAL SHUTDOWN DEVICE IN SERIES WITH THE SPEED RESISTORS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT TRANS/AIR WARRANTY AND SERVICE CENTER AT 1-800-673-2446. | |
| 2002 FORD ODYSSEY | |
|---|---|
| NHTSA Campaign ID: | EQUIPMENT |
| Manufacturer: | TURTLE TOP |
| Manufacture Dates: | 08/02/1999 - 09/01/2007 |
| Potential Units Affected: | 1817 |
Defect Description:TURTLE TOP IS RECALLING CERTAIN MODEL YEAR 2001-2007 TRANSIT BUSES BUILT ON VARIOUS GM AND FORD CHASSIS FROM AUGUST 2, 1999 THROUGH SEPTEMBER 1, 2007, EQUIPPED WITH TRANS/AIR TA73 EVAPORATORS. THE EVAPORATOR UTILIZES A POWER RESISTOR TO REGULATE BLOWER SPEED. SHOULD A SHORT OCCUR IN THE "LOW OR MEDIUM SPEED" CIRCUIT WHILE THE BLOWER IS IN HIGH SPEED, THE SHORT WILL CAUSE THE SUPPLY VOLTAGE TO FEEDBACK THROUGH THE RESISTOR TO GROUND, NOT DRAWING ENOUGH CURRENT TO TRIP THE FUSE. Consequence:THIS WOULD CAUSE THE RESISTOR TEMPERATURE TO RISE TO A POINT WHERE IT WILL MELT AND POSSIBLY IGNITE THE PLASTIC BLOWER HOUSING TO WHICH IT IS MOUNTED. THE OVERHEATING CAN RESULT IN A FIRE. Action:TRANS/AIR, IN COOPERATION WITH TURTL TOP, WILL INSTALL A THERMAL SHUTDOWN DEVICE IN SERIES WITH THE SPEED RESISTORS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT TRANS/AIR WARRANTY AND SERVICE CENTER AT 1-800-673-2446. | |
| 2002 FORD RANGER | |
|---|---|
| NHTSA Campaign ID: | POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 05/03/2001 - 01/28/2002 |
| Potential Units Affected: | 1096 |
Defect Description:ON SOME MANUAL TRANSMISSION TRUCKS EQUIPPED WITH THE FX4 PACKAGE, THE REAR AXLE DIFFERENTIAL CASE COULD FRACTURE UNDER A HIGH TORQUE EVENT SUCH AS WHEN CUSTOMERS ACCELERATE RAPIDLY FROM A STOP OR WHEN A SPINNING TIRE SUDDENLY GAINS TRACTION. Consequence:DIFFERENTIAL FRACTURES COULD POTENTIALLY RESULT IN WHEEL LOCK-UP. Action:DEALERS WILL REPLACE THE REAR AXLE ASSEMBLY. OWNER NOTIFICATION BEGAN MARCH 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. | |
| 2002 FORD RANGER | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 01/05/1994 - 12/05/2002 |
| Potential Units Affected: | 4500000 |
Defect Description:FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING. Action:FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
| 2002 FORD RANGER | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 04/08/1997 - 08/27/2002 |
| Potential Units Affected: | 3600000 |
Defect Description:ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:THIS COULD RESULT IN AN UNDERHOOD FIRE. Action:DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
| 2002 FORD TAURUS | |
|---|---|
| NHTSA Campaign ID: | SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 05/03/1999 - 09/14/2001 |
| Potential Units Affected: | 369614 |
Defect Description:CERTAIN PASSENGER VEHICLES EQUIPPED WITH ADJUSTABLE PADELS ARE BEING RECALLED IN ORDER TO ADJUST THE BRAKE AND ACCELERATOR PEDALS TO A MINIMUM OF 50 MM OF LATERAL SEPARATION. SIMULTANEOUS APPLICATION OF BOTH THE BRAKE AND ACCELERATOR PEDALS COULD RESULT IN AN INCREASE IN ENGINE RPM. Consequence:THIS COULD RESULT IN A CUSTOMER EXPERIENCING AN "UNINTENDED VEHICLE SPEED INCREASE" OR A PERCEIVED "UNABLE TO STOP" CONDITION. Action:OWNERS WILL BE INSTRUCTED AS TO THE PROPER WAY TO SET THE POSITION OF THE PEDALS AND TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE SPACING BETWEEN THE BRAKE AND ACCELERATOR PEDALS MEASURED. IF THE SPACING IS FOUND TO BE LESS THAN 50 MM, THE DEALER WILL ADJUST THE PEDALS TO INCREASE THE DISTANCE BETWEEN THEM TO GREATER THAN 50 MM. OWNER NOTIFICATION BEGAN OCTOBER 28, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332. | |
| 2002 FORD TAURUS | |
|---|---|
| NHTSA Campaign ID: | VISIBILITY:WINDSHIELD |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 10/29/2001 - 04/27/2002 |
| Potential Units Affected: | 67894 |
Defect Description:CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING." THE WINDSHIELDS MAY POTENTIALLY EXHIBIT INCREASED WIND NOISE, WATER LEAKAGE, AND SQUEAKS AND RATTLES. Consequence:POTENTIAL LOSS OF WINDSHIELD RETENTION MAY ALSO REDUCE OCCUPANT PROTECTION IN THE EVENT OF A CRASH. Action:DEALERS WILL REPLACE THESE WINDSHIELDS. OWNER NOTIFICATION BEGAN ON MARCH 31, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD/MERCURY AT 1-800-392-3673. | |
| 2002 FORD TAURUS | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 05/03/1999 - 03/31/2003 |
| Potential Units Affected: | 938789 |
Defect Description:CERTAIN PASSENGER VEHICLES ARE BEING RECALLED TO CORRECT A PROBLEM WITH A MALFUNCTIONING STOP LAMP SWITCH AND/OR ASSOCIATED WIRING. THIS MALFUNCTIONING COULD RENDER THE STOP LAMPS INOPERABLE OR CAUSE THEM TO STAY ON ALL THE TIME. THIS COULD CAUSE CONFUSION TO A FOLLOWING DRIVER, WHICH COULD LEAD TO A CRASH. Consequence:IN ADDITION, IF THE SWITCH AND/OR ASSOCIATED WIRING FAIL IN THE OPEN POSITION, THE BRAKE LIGHTS WILL NOT ACTUATE AND THE DRIVER WILL NOT BE ABLE TO SHIFT THE VEHICLE OUT OF "PARK" IF THEY FAIL IN THE CLOSED POSITION, THE BRAKE LIGHTS WILL REMAIN ON, WHICH WILL NOT ALLOW THE SPEED CONTROL TO BE ACTIVATED. THIS COULD ALSO CAUSE THE BATTERY TO DISCHARGE. Action:DEALERS WILL REMOVE THE STOP LAMP SWITCH AND ASSOCIATED WIRING ASSEMBLY AND INSTALL A NEWLY DESIGNED STOP LAMP SWITCH AND WIRE ASSEMBLY. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON APRIL 5, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. | |
| 2002 FORD TERRA TRANSIT | |
|---|---|
| NHTSA Campaign ID: | EQUIPMENT |
| Manufacturer: | TURTLE TOP |
| Manufacture Dates: | 08/02/1999 - 09/01/2007 |
| Potential Units Affected: | 1817 |
Defect Description:TURTLE TOP IS RECALLING CERTAIN MODEL YEAR 2001-2007 TRANSIT BUSES BUILT ON VARIOUS GM AND FORD CHASSIS FROM AUGUST 2, 1999 THROUGH SEPTEMBER 1, 2007, EQUIPPED WITH TRANS/AIR TA73 EVAPORATORS. THE EVAPORATOR UTILIZES A POWER RESISTOR TO REGULATE BLOWER SPEED. SHOULD A SHORT OCCUR IN THE "LOW OR MEDIUM SPEED" CIRCUIT WHILE THE BLOWER IS IN HIGH SPEED, THE SHORT WILL CAUSE THE SUPPLY VOLTAGE TO FEEDBACK THROUGH THE RESISTOR TO GROUND, NOT DRAWING ENOUGH CURRENT TO TRIP THE FUSE. Consequence:THIS WOULD CAUSE THE RESISTOR TEMPERATURE TO RISE TO A POINT WHERE IT WILL MELT AND POSSIBLY IGNITE THE PLASTIC BLOWER HOUSING TO WHICH IT IS MOUNTED. THE OVERHEATING CAN RESULT IN A FIRE. Action:TRANS/AIR, IN COOPERATION WITH TURTL TOP, WILL INSTALL A THERMAL SHUTDOWN DEVICE IN SERIES WITH THE SPEED RESISTORS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT TRANS/AIR WARRANTY AND SERVICE CENTER AT 1-800-673-2446. | |
| 2002 FORD THUNDERBIRD | |
|---|---|
| NHTSA Campaign ID: | SEAT BELTS:FRONT:WEBBING |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 03/14/2001 - 04/24/2002 |
| Potential Units Affected: | 15355 |
Defect Description:ON CERTAIN PASSENGER VEHICLES, THE DRIVER'S SIDE SEAT BELT CONTACTED THE SEAT RECLINER DURING A 35 MPH NCAP FULL-FRONTAL BARRIER IMPACT TEST. Consequence:THE EDGE OF THE RECLINER MECHANISM CAUSED A PARTIAL CUT IN THE LAP PORTION OF THE WEBBING. IF THE WEBBING IS CUT, IT INCREASES THE RISK OF INJURY IN A CRASH. Action:DEALERS WILL INSTALL AN INSERT BEHIND THE DRIVER SIDE SEAT LOWER TRIM PANEL. OWNER NOTIFICATION BEGAN JUNE 21, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332. | |
| 2002 FORD WINDSTAR | |
|---|---|
| NHTSA Campaign ID: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 425288 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 1999-2003 WINDSTAR VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, UTAH, VERMONT, WEST VIRGINIA, AND WISCONSIN. A SEPARATION OF A FRONT LOWER CONTROL ARM REAR ATTACHING BRACKET MAY RESULT IN A LOWER CONTROL ARM SEPARATION. A SEPARATION OF BOTH FRONT SUBFRAME REAR BODY MOUNTS MAY RESULT IN SEPARATION OF THE STEERING INTERMEDIATE SHAFT. Consequence:THIS COULD RESULT IN REDUCED STEERING CONTROL INCREASING THE RISK OF A CRASH. Action:DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS, AND BOTH BODY MOUNT ATTACHMENTS AT THE REAR OF THE FRONT SUBFRAME, AND MAKE THE NECESSARY REPAIRS FREE OF CHARGE. IF REPAIRS CANNOT BE MADE TO A VEHICLE, FORD WILL OFFER TO REPURCHASE THE VEHICLE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 21, 2011. OWNERS MAY CONTACT FORD AT 1-866-436-7332. | |
| 2002 FORD WINDSTAR | |
|---|---|
| NHTSA Campaign ID: | SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY |
| Manufacturer: | Ford Motor Company |
| Manufacture Dates: | 09/02/1997 - 07/03/2003 |
| Potential Units Affected: | 283413 |
Defect Description:Ford Motor Company (Ford) is recalling certain model year 1998-2003 Windstar vehicles manufactured September 2, 1997, to July 3, 2003. The affected vehicles were previously remedied to safeguard against the rear axle cracking from corrosion, however, the remedy brackets may have been misinstalled. The incorrect bracket installations may limit the effectiveness of the service repair for NHTSA recalls 10V-385, 12V-193, and 12V-195. Consequence:If the brackets were not installed properly, the rear axle may fracture, affecting the vehicle handling and increasing the risk of a crash. Action:Ford will notify owners, and dealers will inspect the brackets to verify their proper installation. If a bracket is found to have been misinstalled, the rear axle will be replaced. These repairs will be performed free of charge. The began on October 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S27. | |
| 2002 FORD WINDSTAR | |
|---|---|
| NHTSA Campaign ID: | SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 09/01/2007 - 07/03/2003 |
| Potential Units Affected: | 492650 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997 THROUGH FEBRUARY 28, 2003 AND CURRENTLY REGISTERED OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. AFTER MANY YEARS OF VEHICLE SERVICE IN THESE AREAS, CORROSION CAN WEAKEN THE REAR AXLE, MAKING IT SUSCEPTIBLE TO TORSIONAL STRESS. CORROSION AND STRESS CAN LEAD TO CRACKS WHICH IF UNDETECTED CAN PROPAGATE AND RESULT IN A COMPLETE FRACTURE OF THE AXLE. Consequence:A FRACTURED AXLE CAN AFFECT VEHICLE HANDLING AND INCREASE THE RISK OF A CRASH. Action:AS PARTS BECOME AVAILABLE, DEALERS WILL INSPECT AND IF NECESSARY INSTALL THE REAR AXLE REINFORCEMENT BRACKETS FREE OF CHARGE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 20, 2010. OWNERS MAY CONTACT FORD AT 1-866-436-7332. | |
| 2002 FORD WINDSTAR | |
|---|---|
| NHTSA Campaign ID: | POWER TRAIN:AXLE ASSEMBLY |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 09/01/1997 - 07/03/2003 |
| Potential Units Affected: | 27000 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997, THROUGH JULY 3, 2003, AND CURRENTLY REGISTERED OR ORIGINALLY SOLD IN VIRGINIA. OVER TIME, CORROSION CAN WEAKEN THE REAR AXLE MAKING IT SUSCEPTIBLE TO TORSIONAL STRESS. CORROSION AND STRESS CAN LEAD TO CRACKS WHICH, IF UNDETECTED, CAN INCREASE AND RESULT IN A COMPLETE FRACTURE OF THE AXLE. Consequence:A FRACTURED AXLE CAN AFFECT VEHICLE HANDLING AND INCREASE THE RISK OF A CRASH. Action:FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND INSTALL REAR AXLE REINFORCEMENT BRACKETS, OR REPLACE THE AXLES, AS NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2012. OWNERS MAY CONTACT FORD AT 1-866-436-7332. | |
| 2002 FORD WINDSTAR | |
|---|---|
| NHTSA Campaign ID: | SUSPENSION:FRONT:CONTROL ARM |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 23000 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 1999-2003 WINDSTAR VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATE OF VIRGINIA. CORROSION-RELATED FRACTURES OF THE FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS AND BODY MOUNT ATTACHMENTS MAY OCCUR. Consequence:A SEPARATION OF A FRONT LOWER CONTROL ARM REAR ATTACHING BRACKET MAY RESULT IN A LOWER CONTROL ARM SEPARATION. A SEPARATION OF BOTH FRONT SUBFRAME REAR BODY MOUNTS MAY RESULT IN SEPARATION OF THE STEERING INTERMEDIATE SHAFT. EITHER CONDITION COULD RESULT IN SIGNIFICANT LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH. Action:DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS AND BOTH BODY MOUNT ATTACHMENTS AT THE REAR OF THE FRONT SUBFRAME AND MAKE THE NECESSARY REPAIRS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 18, 2012. OWNERS MAY CONTACT FORD AT 1-866-436-7332. | |
| 2002 FORD WINDSTAR | |
|---|---|
| NHTSA Campaign ID: | SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | - |
| Potential Units Affected: | 9192 |
Defect Description:FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997, THROUGH JULY 3, 2003, REGISTERED IN PUERTO RICO. DUE TO INCREASED STRESSES CAUSED BY HIGH CYCLES OF TORSIONAL LOADING, SPECIFIC TO THIS MARKET, THE REAR AXLE CAN CRACK. Consequence:A FRACTURED AXLE MAY RESULT IN A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH. Action:FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND INSTALL A REINFORCEMENT BRACKET ON THE REAR AXLE OR REPLACE THE AXLES, AS NECESSARY. THIS SERVICE WILL BE PROVIDED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 1, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. | |
| 2002 FORD WINDSTAR | |
|---|---|
| NHTSA Campaign ID: | SEATS:MID/REAR ASSEMBLY |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 03/07/2001 - 11/05/2002 |
| Potential Units Affected: | 257119 |
Defect Description:CERTAIN MINIVANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." DURING TESTING, A THIRD ROW BENCH FLOOR-TO-SEAT LATCH RELEASED BEFORE THE STRENGTH REQUIREMENT WAS MET. IDENTICAL LATCHES ARE USED IN THE SECOND ROW OF SEATS. Consequence:IF THE LATCHES ON TH4E SECOND OR THIRD ROW SEATS OF THE VEHICLE RELEASE IN A CRASH, THE POTENTIAL FOR OCCUPANT INJURY IS INCREASED. Action:DEALERS WILL REPLACE THE SEAT-TO-FLOOR LATCHES ON THE SECOND AND THIRD ROW OF SEATS. OWNER NOTIFICATION BEGAN ON NOVEMBER 21, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. | |
| 2002 FORD WINDSTAR | |
|---|---|
| NHTSA Campaign ID: | VEHICLE SPEED CONTROL |
| Manufacturer: | FORD MOTOR COMPANY |
| Manufacture Dates: | 06/16/1995 - 10/24/2002 |
| Potential Units Affected: | 4500000 |
Defect Description:FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. Consequence:A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING. Action:FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751. | |
