Ford Buyers Guide

 

Click a car name to see the crash test details for that model.

 

 

 

Crash Test Data for 1998 Ford

Ford Vehicle Front Star Rating Side Star Rating Rollover Resistance Rating
Driver Passenger Front Seat Rear Seat
1998 ContourNot
Tested
1998 Crown VictoriaNot
Tested
1998 EscortNot
Tested
1998 Escort ZX2Not
Tested
Not
Tested
Not
Tested
1998 ExpeditionNot
Tested
Not
Tested
Not
Tested
1998 ExplorerNot
Tested
Not
Tested
Not
Tested
1998 F-150Not
Tested
Not
Tested
Not
Tested
1998 MustangNot
Tested
1998 RangerNot
Tested
Not
Tested
Not
Tested
1998 TaurusNot
Tested
1998 WindstarNot
Tested
Not
Tested
Not
Tested

 

Service Bulletins for 1998 Ford

1998 FORD AEROMAX
Bulletin Number: 11755
SOME VEHICLES WITH THE CATERPILLAR 3306 ENGINE MAY EXHIBIT THE LOWER RADIATOR HOSE BEING DISCONNECTED FROM THE ENGINE WATER PUMP OUTLET. *TT
Bulletin Number: 97010510638
THE VERTICAL EXHAUST HEAT SHIELD MAY EXHIBIT CRACKING AROUND ITS MOUNTING BOLT HOLE. *YC
Bulletin Number: 97050110609
VEHICLES EQUIPPED WITH THE FD 1460 ENGINE MAY EXHIBIT REAR ENGINE SUPPORT BRACKET ATTACHING BOLTS LOSSENING. *TW
Bulletin Number: 970902971813
UNDER CERTAIN CONDITIONS, ROAD SPLASH AND SPRAY MAY BUILD UP ON THE CAB SIDE WINDOWS. *YC
Bulletin Number: 970902971814
SERVICE TIPS ON AIR BRAKE GOVERNOR OPERTIONAL SPECIFICATIONS. *YC
Bulletin Number: 970902971815
SOME VEHICLES FAN CLUTCH MAY CYCLE ON WHEN ELECTRICAL ACCESSORIES, SUCH AS TURN SIGNALS, HEADLAMPS, ETC. ARE ACTIVATED. *YC
Bulletin Number: 970902971816
THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY WEAR AND/OR COME OFF ON SOME VEHICLES EQUIPPED WITH A DETROIT DIESEL ENGINE AND AIR CONDITIONING. *YC
Bulletin Number: 970902971817
SOME ELECTRONICALLY CONTROLLED DIESEL ENGINES CAN BE MODIFIED TO INCREASE ENGINE OUTPUT BY ALTERING THE ORIGINAL ENGINE MANAGEMENT SYSTEM. *YC
Bulletin Number: 9811333
ENGINEERING IS INVESTIGATING CONDITIONS ON THE HOOD SPRING CONTACTING THE HOOD CAUSING DAMAGE TO THE HOOD AND / OR INSULATION. *TT
Bulletin Number: 9811468
SOME MODELS WITH CAT C10/C12 ENGINES MAY EXHIBIT CRACKS IN THE ENGINE FRONT COVER, NEAR THE FAN HUB PULLEY SUPPORT MOUNTING CONTAC STUDS. *TT
Bulletin Number: 98157
FRONT ENGINE COVER CRACKS. YD
Bulletin Number: 98162
HARD TO MOVE THE HOOD UP AND DOWN.*AK
Bulletin Number: 98201
INTERMITTENT ELECTRICAL ISSUES, SUCH AS DASH LIGHTS FLASHING WHEN THE TURN SIGNAL IS ACTIVATED MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 982014
INFORMATION REGARDING PTO EQUIPMENT ATTACHING SERVICE TIPS. *YC
Bulletin Number: 98202
THE POWER DISTRIBUTION BOX COVER IS NOW AVAILABLE. *YC
Bulletin Number: 982020
CONDITIONS WITH THE TURN SIGNAL HANDLE MAY BECOME LOOSE / BROKEN ON SOME VEHICLES. *YC
Bulletin Number: 982022
DELCO-REMY HAS MADE AVAILABLE A REVISED GENERATOR FOR SERVICE. *YC
Bulletin Number: 982023
HINGES AND HINGE SPRINGS ARE NOW AVAILABLE FOR SERVICE FOR THE OPTIONAL READY LINE ACCESS DOOR, BUTTERFLY DOORS OR TRANSVERSE ACCESS DOORS. *YC
Bulletin Number: 982115
A NEW SERVICE PARTS RELEASED. *YC
Bulletin Number: 982116
THE LOWER RADITTOR HOSE IS BEING PULLED OFF AT THE ENGINE WATER PUMP ON SOME VEHICLES. *YC
Bulletin Number: 982118
A NOISE HEARD DURING DRIVELINE TORQUE.
Bulletin Number: 982322
ILLUMINATION OF THE ANTI-LOCK BRAKE LAMP MAY OCCUR AND/ OR THERE MAY BE FALSE ANTI-LOCK BRAKE SYSTEM (ABS) MESSAGES ON THE OPTIONAL MESSAGE CENTER ON SOME VEHICLES. *YC
Bulletin Number: 98237
SOME VEHICLES EXPERIENCE HEATER SUPPLY TUBES THAT MAY CRACK AND/ OR LEAK COOLANT. *YC
Bulletin Number: 98243
CONCERNS REGARDING THE INSTRUMENT PANEL PLATE CRACKS AT PARKING BRAKE VALVE. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982520
SOME VEHICLES EQUIPPED WITH FRAME-MOUNTED VERTICAL MUFFLER SUPPORTS MAY EXHIBIT A CRACK ALONG THE PIPE BEND. *YC
Bulletin Number: 98257
CONCERNS WITH THE FRONT END ACCESSORY DRIVE BELT ( FEAD )-FEAD BELT MAY WEAR AND/OR COME OFF. *YC
Bulletin Number: 983295
INFORMATION ON THE HEAVY TRUCK TECHNICAL ASSISTANCE HOTLINE. *TT
Bulletin Number: 98424
CONDITION WITH TIRES BEING LOWER THAN EXPECTED TIRE LIFE. *YC
Bulletin Number: 98425
DIAGNOSTIC INFORMATIN AND WIRING SCHEMATICS FOR BOTH THE HORTON AND KYSOR ENGINE COOLING FAN CLUTCHES. *YC
Bulletin Number: 98517
SOME VEHICLES MAY EXHIBIT A LACK OF POWER AND/OR A WHISTLING NOISE. *TT
Bulletin Number: 98518
THE OIL LEVEL INDICATOR MAY BE DIFFICULT TO INSTALL AND/OR WHEN INSTALLED MAY CONTACT THE CRAKSHAFT ON SOME VEHICLES. *YC
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 98711
INFORMATION ON AVAILABILITY OF REVISED COOLANT LEVEL SENSOR. *YC
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 9944
PROCEDURES ON REPAIRING BROKEN RADIATOR COOLANT SUPPLY TANK VENT HOSE NIPPLES. *TT
Bulletin Number: BC2234970501
VEHICLES MAY EXHIBIT REAR ENGINE SUPPORT BRACKET ATTATCHING BOLTS LOOSENING. *TW
Bulletin Number: BC2444970501
VEHICLES EQUIPPED WITH CUMMINS M-11 AND N-14 SELECT PLUS ENGINES MAY EXHIBIT THE AIR OPERATED COOLING FAN RUNNING CONTINUOUSLY IF THE ENGINE ECM FAN CONTROL PARAMETERS ARE SET INCORRECTLY. *TW
1998 FORD AEROSTAR
Bulletin Number: 13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
Bulletin Number: 6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
Bulletin Number: 9811183
INFORMATION REGARDING SERVICE PROCEDURES FOR E4WD TRANSFER CASE REAR BUSHING CONCERNS. *TT
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
1998 FORD ASPIRE
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
1998 FORD B700
Bulletin Number: 11817
SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT
Bulletin Number: 4709
SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT
Bulletin Number: 991311
CONDITIONS WITH POWER STEERING FLUID LEAKING FROM THE BRAKE PUMP RESERVOIR AT 90 DEGREE ELBOW ON SOME VEHICLES. *TT
1998 FORD B800
Bulletin Number: 11817
SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT
Bulletin Number: 4709
SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT
Bulletin Number: 991311
CONDITIONS WITH POWER STEERING FLUID LEAKING FROM THE BRAKE PUMP RESERVOIR AT 90 DEGREE ELBOW ON SOME VEHICLES. *TT
1998 FORD BRONCO
Bulletin Number: 12905
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT
Bulletin Number: 983074
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT
1998 FORD B SERIES
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04217
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT
Bulletin Number: 12564
SUBJECT REGARDING PROPER OPERATION AND INTERPRETATION OF DUAL AIR PRESSURE GAUGE READINGS. *TT
Bulletin Number: 17467
ENGINE OR FUEL SYSTEM CONCERNS WHEN USING FUEL WITH GREATER THAN 5% BIODIESEL CONCENTRATION. *TT
Bulletin Number: 5899
CLARIFICATION PERTAINING TO THE DUAL AIR PRESSURE GAUGE FUNCTION. *TT
Bulletin Number: 970902971814
SERVICE TIPS ON AIR BRAKE GOVERNOR OPERTIONAL SPECIFICATIONS. *YC
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 9844
SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING. *YC
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 98614
THE COOLANT TEMPERATURE GAUGE READING MAY BE INACCURATE. *YC
Bulletin Number: 99133
SUBJECT REGARDING INTERMITTENT ELECTRICAL ISSUES, SUCH AS DASH LIGHTS FLASHING WHEN THE TURN SIGNAL IS ACTIVATED. *TT
Bulletin Number: 991413
VEHICLES EQUIPPED WITH FD1060 OR FD1460 MIDRANGE DIESEL ENGINES MAY EXPERIENCE A VIBRATION OR BUZZ THROUGH THE THROTTLE PEDAL. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 9983
EXPERIENCING VARIOUS INTERMITTENT CONCERNS, SUCH AS LOW COOLANT LEVEL SENSOR LEAKING COOLANT INTO WIRING HARNESS. *TT
1998 FORD CAB CHASSIS
Bulletin Number: 13187
INFORMATION REGARDING E40D/4R100 TRANSMISSION FLUID COOLER FLOW TEST SPECIFICATION. *MJS
Bulletin Number: 6999
SUBJECT REGARDING E40D / 4R100 TRANSMISSION FLUID COOLER FLOW TEST SPECIFICATION. *TT
1998 FORD CARGO
Bulletin Number: 983295
INFORMATION ON THE HEAVY TRUCK TECHNICAL ASSISTANCE HOTLINE. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
1998 FORD CONTOUR
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 00182
SOME VEHICLES MAY EXHIBIT NO FORWARD GEAR RANGES DUE TO THE MISALIGNMENT OF THE FORWARD / COAST CLUTCH CYLINDER SNAP RING WITH RESPECT TO THE LEGS OF THE FORWARD CLUTCH PISTON. *JB
Bulletin Number: 00186
VEHICLES MAY EXPERIENCE NO START CONDITION WHEN THE WIPER SWITCH IS IN THE INTERMITTENT OR LOW-SPEED SETTING DURING VEHICLE START-UP. *JB
Bulletin Number: 0019
INFORMATION REGARDING SEVERAL INTERNAL CHANGES THAT HAVE BEEN IMPLEMENTED ON THE MRX-75 TRANSAXLE TO IMPROVE SHIFT EFFORTS. *MJS
Bulletin Number: 00239
A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. *TT
Bulletin Number: 00252
ON SOME VEHICLES, AN OBJECTIONABLE EXHAUST, SULFUR, OR ROTTEN EGG ODOR FOLLOWING AGGRESSIVE DRIVING, SUCH AS FULL-THROTTLE ACCELERATION MAY OCCUR. *TT
Bulletin Number: 0037
VEHICLE MAY EXPERIENCE THE MALFUNCTION INCIATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES (DTCS). *MJS
Bulletin Number: 00611
SOME BI-FUEL VEHICLES MAY REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT DURING SERVICE AND MAY NOT RUN ON CNG OR LPG., RECALIBRATION OF THE PCM/REPLACEMENT. *MJS
Bulletin Number: 0085
DUE TO AN INTERNAL DESIGN CHANGE TO THE SOLENOID TANK VALVE, THE PRESSURE RELEASE DEVICE (PRD) CAN NO LONGER BE REMOVED FROM THE TANK VALVE WITHOUT FIRST VENTING THE FUEL TANK. **MR
Bulletin Number: 00S03
SAFETY RECALL PERTAINING TO BRAKE PRESSURE CONTROL REDUCING VALVE REPLACEMENT. *JB
Bulletin Number: 01136
SUBJECT REGARDING OVERVIEW OF BI-FUEL CNG VEHICLE PARAMETER IDENTIFICATION DATA (PID), INPUTS AND OUTPUTS AS A DIAGNOSTIC AID FOR BI-FUEL VEHICLES. *TT
Bulletin Number: 0114
EXPERIENCING A SPARK KNOCK OR PRE-IGNITION CONDITION ON VEHICLES WITH AN AUTOMATIC OR MANUAL TRANSMISSION DURING STEADY CRUISE DRIVING OR UNDER LIGHT ACCELERATION. *TT
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 01214
INFORMATION TO AID IN DIAGNOSIS FOR CLARIFICATION OF LOCK-OFF SOLENOID AND SOLENOID TANK VALVE COIL RSISTANCES FOR BI-FUEL VEHICLES. *TT
Bulletin Number: 01231
SOME COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT ROUGH IDLE OR NO START WHEN COLD. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 0162
VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT
Bulletin Number: 01M04
IN THE VEHICLES COVERED BY THE ADDITIONAL COVERAGE PROGRAM, THE FUEL PIPE FLAPPER VALVE MAY STICK WHICH COULD RESULT IN SLOW FILL AND FREQUENT FUEL FILLER NOZZLE SHUT-OFF. *TT
Bulletin Number: 020503
GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996. *TT UPDATE. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 022001
REPLACEMENT SPEAKER INSTALLATION TIPS. *TT
Bulletin Number: 02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH
Bulletin Number: 0224
SOME VEHICLES EQUIPPED WITH THE CD4E TRANSAXLE MAY EXHIBIT HARSH AND DELAYED 1-2/2-3 UPSHIFTS AFTER TRANSAXLE OR TURBINE SHAFT SPEED SENSOR REPLACEMENT, POSSIBLE DIAGNOSTIC TROUBLE CODES 628, 642, 645, 646, 647, 648, P0731, P0732, P0734, P0
Bulletin Number: 0245
INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT
Bulletin Number: 0253
SUBJECT REGARDING ALTERNATIVE FUEL VEHICLE COMPRESSED NATURAL GAS TANK INSPECTION. *TT
Bulletin Number: 03102
COMPRESSED NATURAL GAS (CNG). ROUGH IDLE OR NO START WHEN COLD. VEHICLES EQUIPPED WITH CNG BI-FUEL ENGINE ONLY. *TT
Bulletin Number: 03103
VEHICLES WITHOUT THE COOLANT LOCK-OFF MAY EXHIBIT A NO START CONDITION. *TT
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 031514
THE MALFUNCTION INDICATOR LAMP (MIL) MAY BE ILLUMINATED AND DIAGNOSTIC TROUBLE CODES (DTCS) P1380, P1381, P1383, AND/OR P0340 MAY BE STORED IN MEMORY. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 041516
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE(S) P0420 AND/OR P0430. *TT
Bulletin Number: 041814
STEERING COLUMN SHIPPED WITHOUT CRUSH PAD - REUSE ORIGINAL CRUSH PAD IF NOT DAMAGED. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 090308
MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455
Bulletin Number: 11493
INFORMATION USED WHEN PERFORMING DIAGNOSIS OR PROGRAMMING KEYS ON CERTAIN VEHICLES EQUIPPED WITH THE FIFTH GENERATION PASSIVE ANTI-THEFT (PATS) SYSTEM. *TT
Bulletin Number: 11494
SOME VEHICLES MAY EXPERIENCE HARSH SHIFT EVENTS, USUALLY ON THE 1-3 UPSHIFT OR THE 3-2 DOWNSHIFT. *TT
Bulletin Number: 11499
EXHIBITING A NOISE IN THE FRONT OF THE VEHICLE AND POSSIBLY CAUSED BY A FRONT STABILIZER BAR OR LINK NOISE. *TT
Bulletin Number: 11501
SOME VEHICLES WITH CD4E TRANSAXLES MAY EXHIBIT A NO DRIVE CONCERN WHEN IN THE OVERDRIVE SELECTOR POSITION. *TT
Bulletin Number: 11514
SOME VEHICLES MAY EXHIBIT AN IGNITION KEY HIGH REMOVAL EFFORT. *TT
Bulletin Number: 11520
SOME VEHICLES WITH MTX V6 TRANSAXLE CASES MAY MALFUNCTION DUE TO DIFFERENTIAL GEAR FAILURE POSSIBLY CAUSED BY ABUSIVE DRIVING. *TT
Bulletin Number: 11530
WHEN DIAGNOSING CRANK / NO START ON CERTAIN VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT (PATS) CHECK THE CUSTOMERS KEY RING FOR ANY MAGNETIC OBJECTS LIKE THE MOBILE SPEEDPASS KEY WHICH MAY AFFECT THE SIGNAL TRANSMISSION BETWEEN THE PATS KEY A
Bulletin Number: 11533
SOME VEHICLES BUILT BEFORE 2/2/98 AT KANSAS CITY AND 2/16/98 AT CUAUTITLAN, MEXICO MAY EXHIBIT A NO COMMUNICATION WITH PATS-MODULE CONCERN. *TT
Bulletin Number: 11725
SOME VEHICLES MAY EXHIBIT A KNOCKING OR CLUNKING SOUND DURING RAPID ACCELERATION / DECELERATION AS WHEN LETTING OFF AND PUTTING YOUR FOOT DOWN ON THE ACCELERATOR QUICKLY. *TT
Bulletin Number: 11791
SOME VEHICLES WITH CD4E TRANSMISSION MAY EXHIBIT A CONDITION OF NO CRANK / NO START IN PARK. VEHICLE WILL CRANK AND START IN NEUTRAL. *TT
Bulletin Number: 12075
VEHICLES BUILT PRIOR TO 6/16/98 MAY HAVE A BROKEN/DETACHED IP CLUSTR BEZEL GAPHIDER. THE HIDER IS A HINGED FLAP BETWEEN THE STEERING COLUMN SHROUD AND THE IP BEZEL. *MJS
Bulletin Number: 12076
SOME VEHICLES MAY EXHIBIT A CONDITION OF CHECK ENGINE LIGHT (MIL) ON AND CONTINUOUS DTC PO466 (EVAP SYSTEM MALFUNCTION). *MJS
Bulletin Number: 12105
SOME VEHICLES MAY EXHIBIT AN INOPERATIVE ALTERNATOR. *MJS
Bulletin Number: 12106
SOME VEHICLES MAY NOT ALLOW A SHIFT FROM PARK WHEN BRAKE PEDAL IS DEPRESSED OR THE SHIFT LEVER MAY EXHIBIT A CLICK SOUND EACH TIME BRAKE PEDAL IS DEPRESSED. *MJS
Bulletin Number: 12119
SOME VEHICLES TRANSMISSIONS MAY EXHIBIT A TRANSMISSION FLUID LEAK. *MJS
Bulletin Number: 12135
SOME VEHICLES MAY EXHIBIT A CONCERN WHERE THE MALFUNCTION INDICATOR LAMP (MIL) IS ILLUMINATE WITH DTCS IN THE MEMORY. *MJS
Bulletin Number: 12142
SOME VEHICLES MAY REQUIRE KEY PROGRAMMING FOR THE PASSIVE ANTI-THEFT PATS. *MJS
Bulletin Number: 12164
SOME VEHICLE MAY EXHIBIT A/C OR HEATER BLOWER AIR THAT FLOWS FROM THE DEFROST VENTS ONLY. *MJS
Bulletin Number: 12165
SOME VEHICLES WITH 2.9L ENGINES MAY EXHIBIT A BROKEN OR LEAKING WATER PUMP. *MJS
Bulletin Number: 12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
Bulletin Number: 12192
SOME VEHICLES MAY NOT ALLOW A SHIFT FROM PARK WHEN BRAKE PEDAL IS DEPRESSED. *TT
Bulletin Number: 12229
BRIEF INFORMATION ON TSB 97-26-7 (GAUGE - FUEL - DOES NOT READ BELOW 1/4) APPLIES ONLY TO CERTAIN VEHICLES BUILT BEFORE 2/2/98 AT KANSAS CITY ASSEMBLY PLANT AND 2/16/98 AT CUAUTITLAN ASSEMBLY PLANT. *TT
Bulletin Number: 12299
SOME VEHICLES MAY EXHIBIT A ROUGH ENGINE AND / OR SET VARIOUS DIAGNOSTIC TROUBLE CODES AFTER ATTEMPTING TO REPROGRAM THE PCM WITH NGS CAR VERSION 5.1 OR EARLIER. *TT
Bulletin Number: 12301
SOME 2.5L EQUIPPED VEHICLES MAY EXHIBIT AN INOPERATIVE ALTERNATOR DUE TO RUSTING / CORROSION ON THE BRUSH PATH OF THE SLIP RINGS. *TT
Bulletin Number: 12304
SOME 2.0L EQUIPPED VEHICLES BUILT BEFORE APRIL 1, 1998 MAY EXHIBIT A BROKEN OR LEAKING WATER PUMP. AN IMPROVED WATER PUMP IS NOW AVAILABLE. *TT
Bulletin Number: 12498
SUBJECT ON STEERING COLUMN GAP HIDER SERVICE REPLACEMENT. *TT
Bulletin Number: 12519
CD4E TRANSAXLE MAY EXHIBIT A NO FORWARD DRIVE CONCERN. *TT
Bulletin Number: 12520
SUBJECT REGARDING 60 AMP FUSE BLOWN. *TT
Bulletin Number: 12525
CONCERNS WITH THE LEFT AIR CONDITIONING PANEL REGISTER DISCHARGE TEMPERATURE THAT IS WARMER THAN THE CENTER AND / OR RIGHT VENTS. *TT
Bulletin Number: 12556
SUBJECT REGARDING TECHNICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES. *TT
Bulletin Number: 12560
BIEF INFORMATION REGARDING DIAGNOSTIC CODE RETRIVAL ON BI-FUEL VEHICLES. *TT
Bulletin Number: 12597
INFORMATION ON INSTALLING FUSES AT PRE-DELIVERY. *TT
Bulletin Number: 12598
INFORMATION REGARDING TWO CD4E TRANSAXLES ADDED TO FORD QUALITY RENEWAL (FQR) PROGRAM. *TT
Bulletin Number: 12621
SUBJECT REGARDING IGNITION LOCK SERVICE REPLACEMENT. *TT
Bulletin Number: 12707
SOME VEHICLES MAY EXHIBIT A FRONT BRAKE GROAN. *TT
Bulletin Number: 12726
INFORMATION REGARDING DECKLID RELEASE ISSUES. *TT
Bulletin Number: 12846
SUBJECT ON INSTALLING FUSES AT PDI (PRE-DELIVERY INSPECTION). *TT
Bulletin Number: 12888
CONCERNS WITH FUEL FILLER DOOR NOT CLOSING PROPERLY. *TT
Bulletin Number: 12917
SOME VEHICLES MAY EXHIBIT A CONCERN IN ACTIVATING THE OCTAINE ADJUST FEATURE WHEN USING THE MODULE RECONFIGURATION METHOD. *TT
Bulletin Number: 13178
INFORMATION REGARDING CLUNK/RATTLE ON TIP-IN OR TRANSMISSION GEAR ENGAGEMENT. *MJS
Bulletin Number: 13316
EXHIBITING A DRIVELINE RATTLE OR CLUNKING TYPE NOISE DURING TIP-IN OR TRANSMISSION GEAR ENGAGEMENT. *TT
Bulletin Number: 13336
INFORMATION ON ACTIVATING OCTANE ADJUST FUNCTION WITH NGS/SBDS. *TT
Bulletin Number: 13355
INFORMATION REGARDING A/C PEANUT O-RING COLOR. *TT
Bulletin Number: 13364
CUSTOMER MAY COMMENT ON VIBRATION AT 60 - 70 MPH AT CRUISE. *TT
Bulletin Number: 13379
SOME VEHICLES EQUIPPED WITH 2.5L ENGINE AND CD4E TRANSMISSION MAY EXHIBIT A DRIVELINE RATTLE OR CLUNKING TYPE NOISE DURING TIP-IN OR TRANSMISSION GEAR ENGAGEMENT. *TT
Bulletin Number: 13386
INFORMATION ON INVESTIGATING HARD START / NO START CONDITIONS ACCOMPANIED BY OVERFUELING IN AMBIENTS BELOW 32F/0C, ON VEHICLES WITH VCT EQUIPPED 2.0L ZETEC ENGINES. *TT
Bulletin Number: 13387
VEHICLES WITH REAR DISC BRAKES MAY EXHIBIT A SQUEAK IN THE REAR SUSPENSION AREA. *TT
Bulletin Number: 13454
SUBJECT REGARDING THE SPEED CONTROL SWITCH VOLTAGE READINGS - SERVICE TIP. *TT
Bulletin Number: 13468
SOME VEHICLES EQUIPPED WITH 2.0L ENGINE MAY EXHIBIT A TIMING BELT SHREDDING OR TIMING BELT STRIKING THE FRONT COVER. *TT
Bulletin Number: 13761
SOME VEHICLES EQUIPPED WITH 2.0L ENGINES MAY EXHIBIT SYMPTOMS OF CLUTCH SLIPPAGE OR NO CLUTCH ENGAGEMENT AFTER PERFORMINB REPAIRS TO THE CLUTCH SYSTEM. *MJS
Bulletin Number: 13866
EXPERIENCING A HOOT NOISE FROM THE IDLE IDLE AIR BYPASS SOLENOID ON DECELERATION, USUALLY IN COLD AMBIENT TEMPERATURES. *TT
Bulletin Number: 14355
INFORMATION PERTAINING TO DURATEC OIL PAN INVESTIGATION. *JB
Bulletin Number: 14775
SOME VEHICLES EQUIPPED WITH DAYTIME RUNNING LAMPS (DRL) MAY EXHIBIT THE HIGH BEAM INDICATOR IN THE INSTRUMENT CLUSTER FLASHING WHEN THE DAYTIME RUNNING LAMPS ARE ON. *TT
Bulletin Number: 14836
SOME VEHICLES EQUIPPED WITH CD4E TRANSAXLE, (DOES NOT APPLY TO MTX) MAY EXHIBIT A POWER STEERING GRUNT / MOAN TYPE NOISE WHEN RETURNING FROM A RIGHT TURN. *TT
Bulletin Number: 14877
SOME VEHICLES MAY ILLUMINATE THE MALFUNCTION INDICATOR LAMP OR RUN ROUGH AFTER THE CATALYST IS REMOVED AND / OR REPLACED. THIS MAY BE DUE TO VACUUM LEAKS AS A RESULT OF TOLERANCE STACKUP WITHIN THE EXHAUST / EGR / INTAKE SYSTEM.
Bulletin Number: 15065
SOME VEHICLES MAY EXHIBIT A/C DISCHARGE AIR TEMPERATURES DIFFERENCES OF GREATER THAN 10 DEGREES F FROM REGISTERS ON LEFT SIDE OF DASH THAN ON RIGHT. *TT
Bulletin Number: 15241
SOME VEHICLES MAY EXHIBIT A NOISE THAT APPEARS TO COME FROM THE FRONT WHEEL BEARINGS. *TT
Bulletin Number: 15241
SOME VEHICLES MAY EXHIBIT A NOISE THAT APPEARS TO COME FROM THE FRONT WHEEL BEARINGS. *TT
Bulletin Number: 15390
SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LIGHT AND/OR EGR DIAGNOSTIC TROUBLE CODES 332, P0401, P1407 (LACKOF EGR FLOW). *TT
Bulletin Number: 15636
CONCERN WITH HEADLAMPS AND/OR INSTRUMENT PANEL LAMPS DIMMING SLIGHTLY AT IDLE. *TT
Bulletin Number: 15828
SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE B1213, B1342, B1601, B2431. *TT
Bulletin Number: 15894
SUBJECT REGARDING AUTOMATIC SHIFTER ASSEMBLY OR THE INDICATOR HOUSING REPLACEMENT. *TT
Bulletin Number: 16140
SOME VEHICLES MAY EXHIBIT AN AIR BAG WARNING LAMP FLASHING OUT A 2 DIGIT DIAGNOSTIC TROUBLE CODE AND NO COMMUNICATION WITH AIR BAG MODULE USING SCAN TOOLS. *TT
Bulletin Number: 16880
INOPERATIVE SHIFT INTERLOCK SOLENOID OR REPEAT INSTRUMENT INTERFACE MODULE FAILURE. *TT
Bulletin Number: 17009
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH NO HARD FAULT. *TT
Bulletin Number: 4619
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT
Bulletin Number: 4674
SOME VEHICLES WITH CD4E TRANSMISSION MAY EXHIBIT A CONDITION OF NO CRANK / NO START IN PARK. VEHICLE WILL CRANK AND START IN NEUTRAL. *TT
Bulletin Number: 5139
SOME VEHICLES MAY NOT ALLOW A SHIFT FROM PARK WHEN BRAKE PEDAL IS DEPRESSED OR THE SHIFT LEVER MAY EXHIBIT A CLICK SOUND EACH TIME BRAKE PEDAL IS DEPRESSED. *TT
Bulletin Number: 5140
SOME VEHICLES MAY EXHIBIT AN INOPERATIVE ALTERNATOR. THIS CONCERN IS UNDER INVESTIGATION. *TT
Bulletin Number: 5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
Bulletin Number: 5238
SOME VEHICLES MAY NOT ALLOW A SHIFT FROM PARK WHEN BRAKE PEDAL IS DEPRESSED. *TT
Bulletin Number: 5293
CONCERNS WITH FUEL GAUGE WHICH DOES NOT READ BELOW 1/4. *TT
Bulletin Number: 5306
SOME VEHICLES MAYE XHIBIT EXHIBIT A MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0171 AND P0172 STORED IN MEMORY. *TT
Bulletin Number: 5795
INFORMATION ON SERVICE REPLACEMENT OF THE STEERING COLUMN GAP HIDER. *TT
Bulletin Number: 5823
SOME VEHICLES EQUIPPED WITH A CD4E TRANSAXLE MAY EXHIBIT A TRANSMISSION NO FORWARD ENGAGEMENT. *TT
Bulletin Number: 5844
SOME VEHICLES BUILT BETWEEN AUGUST 1997 AND FEBRUARY 1998 MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) LIGHT ON AND THE BLOWER INOPERATIVE. *TT
Bulletin Number: 5849
SOME VEHICLES MAY EXHIBIT A LEFT AIR CONDITIONING PANEL REGISTER DISCHARGE TEMPERATURE THAT IS WARMER THAN THE CENTER AND / OR RIGHT VENTS. *TT
Bulletin Number: 5890
INFORMATION ON RETRIEVING DIAGNOSTIC CODES FOR BASE ENGINE / GASOLINE FUEL SYSTEM OR THE ALTERNATE FUEL SYSTEM. *TT
Bulletin Number: 5892
SUBJECT REGARDING TECHINICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES WITH GFI ALTERNATE FUEL SYSTEMS. *TT
Bulletin Number: 5963
INFORMATION ON INSTALLING FUSES AT PRE-DELIVERY. *TT
Bulletin Number: 6091738
SOME VEHICLES MAY EXHIBIT A VIBRATION AT 60 - 70 MPH (100 - 115 KPH). *TT
Bulletin Number: 6201
EXPERIENCING A FRONT BRAKE GROAN DURING CITY DRIVING. *TT
Bulletin Number: 6243
ONLINE SERVICE INFORMATION PERTAINING TO VARIOUS DECKLID RELEASE ISSUES. *TT
Bulletin Number: 6320
CONCERNS WITH VIBRATION AT 60 - 70 MPH. *TT
Bulletin Number: 6478
INFORMATION ON THE AVAILABILITY OF FORD QUALITY RENEWAL 2.5L AND 3.0L 4V ENGINES. *TT
Bulletin Number: 6501
SOME VEHICLES BUILT BETWEEN 7/1/98 AND 12/31/98 MAY EXHIBIT A FUEL FILLER DOOR NOT CLOSING PROPERLY. *TT
Bulletin Number: 6546
SOME VEHICLES MAY EXHIBIT A CONCERN IN ACTIVATING THE OCTANE ADJUST FEATURE WHEN USING THE MODULE RECONFIGURATION METHOD. *TT
Bulletin Number: 6567
SUBJECT REGARDING FORD QUALITY RENEWAL (FQR) ASSEMBLIES. *TT
Bulletin Number: 6696
SUBJECT REGARDING FORD QUALITY RENEWAL (FQR) EXCHANGE PROGRAM. *TT
Bulletin Number: 6707
CONCERNS WITH ACTIVATING THE OCTANE ADJUST FUNCTION WITH NGS OR SBDS. *TT
Bulletin Number: 6906
EXHIBITING A STARTER GRINDING NOISE AND / OR LACK OF STARTER DRIVE ENGAGEMENT. *TT
Bulletin Number: 6994
CONCERNS WITH VEHICLES EXHIBITING A DRIVELINE RATTLE OR CLUNKING TYPE NOISE DURING TIP-IN OR TRANSMISSION GEAR ENGAGEMENT. *TT
Bulletin Number: 7249
INFORMATION ON USING PEANUT STYLE A/C FITTINGS. *TT
Bulletin Number: 7344
SOME VEHICLES MAY EXHIBIT A VIBRATION AT 60-70 MPH. *TT
Bulletin Number: 7349
SOME VEHICLES EQUIPPED WITH 2.5L ENGINE AND CD4E TRANSMISSION MAY EXHIBIT A DRIVELINE RATTLE OR CLUNKING TYPE NOISE DURING TIP-IN OR TRANSMISSION GEAR ENGAGEMENT. *TT
Bulletin Number: 7430
INFORMATION REGARDING SPEED CONTROL SWITCH VOLTAGE READINGS - SERVICE TIP. *TT
Bulletin Number: 7451
SOME VEHICLES EQUIPPED WITH 2.0L ENGINE MAY EXHIBIT A TIMING BELT SHREDDING OR TIMING BELT STRIKING THE FRONT COVER. *TT
Bulletin Number: 7923
CLUTCH WILL NOT ENGAGE AFTER SERVICE.
Bulletin Number: 8128
SOME VEHICLES MAY EXPERIENCE A HOOT NOISE FROM THE IDLE IDLE AIR BYPASS SOLENOID ON DECELERATION, USUALLY IN COLD AMBIENT TEMPERATURES. THE IDLE SPEED MAY ALSO REMAIN SLIGHTLY HIGHER OR LOWER THAN DESIRED WHEN THIS NOISE IS PRESENT.
Bulletin Number: 97050110630
SERVICE MANUAL CONTAINS ERRONEOUS PROCEDURE AND ART IN THE ASSEMBLY. *YC
Bulletin Number: 97090297183
EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC
Bulletin Number: 976007
INFORMATION ON SELECTING "SYSTEM DESCRIPTION" WITHIN THE BCE MODULE REPORGRAMMING TOOL - FIXED 7/97. *TT
Bulletin Number: 976011
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 97L14
SPECIAL FIELD ACTION 97L14- WARRANTY GUIDES FOR VEHICLES EQUIPPED WITH 2. OL ZETEC ENGINES. *YC
Bulletin Number: 9810785
INFORMATION REPLACING THE FUEL PUMP / SENDER. *TT
Bulletin Number: 9810799
SUBJECT REGARDING SEAT BELT LOCATOR BUTTON REPLACEMENT. *TT
Bulletin Number: 9811
CONCERNS WITH AUTOMATIC TRANSAXLE PRNDL INDICATOR BEZEL MAY BREAK. *TT
Bulletin Number: 98110
SUBJECT REGARDING PASSIVE ANTI THEFT SYSTEM (PATS) DIAGNOSTIC SERVICE TIPS. *TT
Bulletin Number: 9811093
SOME VEHICLES MAY EXHIBIT INOPERATIVE A/C OR INADEQUATE COOLING. *YC
Bulletin Number: 9811330
SOME VEHICLES WITH ANTI-LOCK BRAKE SYSTEMS (ABS) MAY EXHIBIT A GROWLING / GRINDING NOISE WHEN BACKING UP AN INCLINE OR UNDER HARD ACCELERATION IN REVERSE. *TT
Bulletin Number: 9811332
CONDITIONS WITH A NO START / HARD START OR A HESITATION WHEN ACCELERATING OR DURING TURNS. *TT
Bulletin Number: 9811344
SUBJECT REGARDING CHANGES TO THE ELECTRONIC ENGINE CONTROL SYSTEM. *TT
Bulletin Number: 9811485
CUSTOMER CONCERN OF NOISE IN THE POWER STEERING. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK
Bulletin Number: 98152
TRANSAXLE FAILED. YD
Bulletin Number: 98153
FREQUENT SHUTOFF OF THE FUEL HANDLE WHEN FILLING THE FUEL TANK. AK
Bulletin Number: 98164
A TRANSEAL COATING IS ON THE FRONT AND REAR BUMPERS. THIS COATING MUST BE REMOVED BEFORE DELIVERY TO THE CUSTOMER. YD
Bulletin Number: 98166
THE TEMPERATURE GAUGE READS HIGH IN THE NORMAL RANGE WHEN ENGINE IS AT NORMAL OPERATING TEMPERATURE.
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 98203
CONCERNS WITH THE POTENTIAL EFFECTS OF ADHESIVES USED FOR BODY PANEL REPAIRS. *TT
Bulletin Number: 98203
CONCERNS WITH ADHENSIVES NOT RECOMMENDED FOR BODY PANEL REPAIRS. *YC
Bulletin Number: 982114
CONDITION WITH HIGH EFFORT IGNITION KEY INSERTION/ REMOVAL AND /OR KEY CHIMES SOUND WITH DOOR OPEN AND IGNITION KEY REMOVED. *YC
Bulletin Number: 98213
CONCERNS WITH TEMPERATURE READS HIGH WITHIN NORMAL RANGE WHEN ENGINE IS AT NORMAL OPERATING TEMPERATURE. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982311
MINIMAL CLEARANCE OF THE CD4E TRANSAXLE TO SUBFRAME MAKES TRANSAXLE INSTALLATION AND REMOVAL MORE DIFFICULT. *YC
Bulletin Number: 98242
POWERTRAIN CONTROL MODULE (PCM) REPROGRAMMING INFORMATION WHEN REPLACING TRANSAXLE. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982462
SOME VEHICLES MAY EXHIBIT A NOISE IN THE FRONT OF THE VEHICLE. *YC
Bulletin Number: 982470
SOME VEHICLES WITH CD4E TRANSAXLE MAY EXHIBIT A " NO DRIVE " CONCERNS WHEN IN THE OVERDRIVE SELECTOR POSITION. *YC
Bulletin Number: 982472
SOME VEHICLES MAY EXPERIENCE HARSH SHIFT EVENTS, USUALLY ON THE 1-3 UPSHIFT OR THE 3-2 DOWNSHIFT. *YC
Bulletin Number: 982473
ADDITIONAL INFORMATION REGARDING THE ATTEMPTS TO RETRO- FIT A SERVO CUSHION SPRING TO THE TRANSMISSION. *YC
Bulletin Number: 982510
INFORMATION REGARDING REVISED WATER PUMP REPLACEMENT PROCEDURE. *YC
Bulletin Number: 982511
INFORMATION ON PERFORMING DIAGNOSIS OR PROGRAMMING KEYS ON SOME 1998 VEHICLES. *YC
Bulletin Number: 982513
SOME VEHICLES WITH 2.5L ENGINE MAY EXHIBIT A CUSTOMER CONCERN OF NOISE IN THE POWER STEERING. *YC
Bulletin Number: 982514
CONCERNS WITH THE TIMING ARROWS/FLAGS ON THE BACK OF THE CAMSHAFT SPROCKET (S) ARE MIS-MARKED BY AS MUCH AS 30 DEGREES ROTATION. *YC
Bulletin Number: 982549
INFORMATION USED WHEN PERFORMING TESTS USING SBDS ON VEHICLES BUILT AFTER JANUARY 31, 1998. *TT
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 982687
SOUTHEAST MICHIGAN AREA DEALERS ONLY ENGINEERING IS INVESTIGATING CUSTOMER CONCERNS OF NOISE DURING CRANKING, OR NO CRANK ON 1998 2.5L VEHICLES. *YC
Bulletin Number: 982692
SOME VEHICLES MAY EXHIBIT A DISCHARGED BATTERY. *YC
Bulletin Number: 983075
INFORMATION ON USING ROTUNDA UNIVERSAL LIFTING BRACKET FOR LIFTING AND REMOVAL OF ENGINE. *TT
Bulletin Number: 983081
CONCERNS WITH INCORRECT BRAKE SHOE / LINING ASSEMBLY. *TT
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 983160
ENGINEERING IS INVESTIGATING SOME VEHICLES THAT MAY EXHIBIT VIBRATION WHILE BRAKING. *TT
Bulletin Number: 983213
EXPERIENCING A SQUEAK IN THE REAR SUSPENSION. *TT
Bulletin Number: 983216
SOME VEHICLES MAY EXHIBIT MULTIPLE WHEEL SPEED SENSOR CODES. *TT
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 983311
EXHIBITING A MALFUNCTION INDICATOR LIGHT (MIL) ON WITH VARIOUS CODES AND POSSIBLE DRIVEABILITY CONCERNS. *TT
Bulletin Number: 983566
INFORMATION ON PROGRAMMING / DIAGNOSING ANY PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT
Bulletin Number: 983566
INFORMATION REGARDING PROGRAMMING / DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT
Bulletin Number: 983583
SOME VEHICLES MAY EXPERIENCE A VIBRATION AT HIGHWAY SPEEDS. *TT
Bulletin Number: 9841
DURING REMOVAL THE LICENSE PLATE ATTACHING FASTENERS MAY BREAK. *YC
Bulletin Number: 9843
A CONDITION WITH THE THE FOAM GAP HIDER INSIDE THE LUGGAGE COMPARTMENT MAY BECOME DETACHED FROM THE REAR LIGHT BAR. *YC
Bulletin Number: 9844
SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 98-4812
SOME 1998-1999 CONTOUR/MYSTIQUE/COUGAR EQUIPPED WITH 2.5L DURATEC BUILT BETWEEN 04/01/1998-08/14/1998 EXIBIT ERRATIC INSTUMENTATION OPERATION. *AK
Bulletin Number: 985089
SOME VEHICLES BUILT PRIOR TO 6/16/98 MAY HAVE A BROKEN / DETACHED INSTRUMENT PANEL CLUSTER BEZEL GAPHIDER. *TT
Bulletin Number: 985095
SOME VEHICLES MAY EXHIBIT A CONDITION OF CHECK ENGINE LIGHT ON AND CONTINUOUS DIAGNOSTIC TROUBLE CODE P0446 (EVAP SYSTEM MALFUNCTION). *TT
Bulletin Number: 985136
SOME VEHICLES WITH CD4E TRANSMISSION MAY EXHIBIT A TRANSMISSION FLUID LEAK. *TT
Bulletin Number: 985139
SOME VEHICLES MAY NOT ALLOW A SHIFT FROM PARK WHEN BRAKE PEDAL IS DEPRESSED OR THE SHIFT LEVER MAY EXHIBIT A CLICK SOUND EACH TIME BRAKE PEDAL IS DEPRESSED. *TT
Bulletin Number: 985140
SOME VEHICLES MAY EXHIBIT AN INOPERATIVE ALTERNATOR. *AK
Bulletin Number: 985184
VEHICLES MAY EXHIBIT A CONCERN WHERE THE MALFUNCTION INDICATOR LAMP (MIL) IS ILLUMINATED WITH ONE OR MORE DIAGNOSTIC TROUBLE CODES: P0117, P0122, P0141, P0174-P0175, P0300-P0306, P0320, P0340, P0350-P0360, P0385, P1504-P1507, AND P1518-P15
Bulletin Number: 985187
SOME VEHICLES MAY REQUIRE KEY PROGRAMMING ISSUES FOR THE PASSIVE ANTI-THEFT SYSTEM (PATS). *TT
Bulletin Number: 985196
SOME VEHICLES MAY EXHIBIT A BROKEN OR LEAKING WATER PUMP. *MJS
Bulletin Number: 985197
SOME VEHICLES MAY EXHIBIT A/C OR HEATER BLOWER AIR THAT FLOWS FROM THE DEFROST VENTS ONLY. *MJS
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 985A17
SOME VEHICLES PARKING BRAKE EQUIPPED WITH REAR DISC BRAKES MAY STICK AND/OR BIND WHEN ATTEMPTING TO RELEASE. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 9874
A NEW SILICONE GASKET AND SEALANT. *YC
Bulletin Number: 9881
ISSUE WITH DOOR SPEAKER GRILLES MAY CRACK DURING NORMAL USAGE ON SOME VEHICLES. *YC
Bulletin Number: 9886
AN ENGINE COOLANT LOSS MAY OCCUR FROM THE ENGINE BLOCK HEATER AREA. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 98B21
SUBJECT ON ENGINE BLOCK HEATERS. *TT
Bulletin Number: 98B30
SOME CUSTOMERS MAY COMPLAIN OF COOLING FAN OPERATING CONTINUOUSLY. *TT
Bulletin Number: 98E04
SOME VEHICLES BUILT WITH REAR FUEL LINES MAY ALLOW FUEL TO SEEP AND EVAPORATE AT THE METAL LINE TO NYLON TUBE JOINT AT THE REAR OF THE VEHICLES NEAR THE FUEL FILTER. *TT
Bulletin Number: 98S26S1
SAFETY RECALL INVOLVING CERTAIN VEHICLES WITH AUTOMATIC TRANSAXLE SHIFT INDICATOR (PRNDL) BEZEL. *TT
Bulletin Number: 98S26S2
SAFETY RECALL INVOLVING CERTAIN VEHICLES WITH AUTOMATIC TRANSAXLE SHIFT INDICATOR (PRNDL) BEZEL - PART AVAILABILITY). *TT
Bulletin Number: 99105
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1381 AND / OR P1383 STORED IN MEMORY. THE VEHICLE MAY ALSO HAVE A ROUGH IDLE OR REDUCED POWER CONDITION, AND / OR MAY STALL AT AN IDLE. *TT
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 99121
SUBJECT REGARDING THE MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0302, P0303, P0304, P0305, AND / OR P0306 STORED IN MEMORY. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 9912781
EXPERIENCING VIBRATION AT 60 - 70 MPH (110 - 12- KPH). *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 9913137
CONCERNS WITH 2.5L ENGINE EQUIPPED VEHICLES AND CD4E TRANSAXLE EXHIBITING A STARTER GRINDING NOISE AND / OR LACK OF STARTER DRIVE ENGAGEMENT. *TT
Bulletin Number: 99138
A ROUGH IDLE, STALLING AT AN IDLE, REDUCED POWER AND / OR MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTCS) P1381 AND P1383 MAY BE STORED IM MEMORY ON SOME VEHICLES. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99148
SOME 2.5L VEHICLES EQUIPPED WITH MTX-75 TRANSAXLE MAY NOT MOVE. THIS MAY BE CAUSED BY THE DIFFERENTIAL GEAR FAILING. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99195
SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99201
CONCERNS WITH A HARSH SHIFT FELT AT LARGE THROTTLE OPENINGS (OR AT HEAVY ACCELERATION RATE) ON SOME VEHICLES. *TT
Bulletin Number: 99204
A CONDITION WITH FUEL FILLER DOOR UNABLE TO CLOSE COMPLETELY. *TT
Bulletin Number: 99215
SUBJECT REGARDING VEHICLES THAT HAVE WATER LEAKING ONTO FRONT FLOOR FROM DOOR PANEL AREA. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
Bulletin Number: 99248
CONCERNS WITH THE INTERIOR LAMP STAYING ON. *TT
Bulletin Number: 99249
THIS BULLETIN ADDRESSES AN ISSUE WITH THE AUTOMATIC TRANSMISSION FLUID SEEPING FROM THE VENT, RESULTING IN FLUID COLLECTING ON THE MAIN CONTROL ASSEMBLY. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 9949
CONDITIONS WITH DIAGNOSTIC TROUBLE CODE (DTC) P0460 STORED IN CONTINUOUS MEMORY WITHOUT ANY DRIVEABILITY CONCERNS. *TT
Bulletin Number: 996041
VEHICLES MAY EXHIBIT A HARD TO SHIFT CONDITION IN COLD WEATHER. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: 9989
SOME VEHICLES MAY EXHIBIT A GROANING NOISE FROM THE FRONT BRAKES DURING CITY DRIVING. *TT
Bulletin Number: 9991
INFORMATION ON VEHICLES EXHIBITING A RUBBING NOISE FROM THE REAR OF THE VEHICLE DURING HEAVILY LOADED CONDITIONS, ESPECIALLY WHEN COMBINED WITH AGGRESSIVE CORNERING AND SEVERE BODY ROLL. *TT
Bulletin Number: 99B23
ON SOME VEHICLES, THE WATER PUMP BEARING MAY DETERIORATE AND BECOME LOOSE. THIS IS A OWNER NOTIFICATION PROGRAM FOR WATER PUMP REPLACEMENT. *TT
Bulletin Number: 99M01
OWNER NOTIFICATION PROGRAM PROVIDING ADDITIONAL COVERAGE FOR REPLACEMENT OF THE BLOWER SWITCH, RESISTOR AND ATTACHED WIRE CONNECTORS. THIS ADDITIONAL COVERAGE IS PROVIDED IN CASE THE VEHICLE OWNER EXPERIENCES DURABILITY CONCERNS WITH THES
Bulletin Number: 99M07
OWNER NOTIFICATION PROGRAM FOR ADDITONAL COVERAGE ON HEATER BLOWER SWITCH, RESISTOR AND ATTACHED WIRE CONNECTORS REPLACEMENT. THIS ADDITIONAL COVERAGE IS PROVIDED IN CASE THE VEHICLE OWNER EXPERIENCES DURABILITY CONCERNS WITH THESE COMPO
Bulletin Number: 99M08
OWNER NOTIFICATION PROGRAM PROVIDING ADDITIONAL COVERAGE FOR REPLACEMENT OF THE BLOWER RESISTOR AND ATTACHED WIRE CONNECTOR. THIS ADDITIONAL COVERAGE IS PROVIDED IN CASE THE VEHICLE OWNER EPXERIENCES DURABILITY CONCERNS WITH THESE COMPONE
Bulletin Number: BC106019705
CLIMATE CONTROL SYSTEM VACUUM MOTOR LINKS FALLING OFF MAY BE REPAIRED BY ADDING THE APPROPRIATE SIZE INTERNAL STAR WASHER RETAINER TO THE END OF THE SHAFT AFTER INSTALLING THE LINK. *TW
Bulletin Number: BC2395970501
CUSTOMER COMPLAINTS OF DOORS THAT LOCK INADVERTENTLY. *TW
Bulletin Number: BC2446970501
SOME 96 & 97 VEHICLES MISBUILT WITH 1998 MODEL YEAR FUEL GAUGE. *TW
1998 FORD CROWN VICTORIA
Bulletin Number: 00213
SUBJECT REGARDING CLIMATE CONTROL - EATC - BLOWER MOTOR CONTROL SERVICE TIPS. *JB
Bulletin Number: 00214
INFORMATION REGARDING REVISED ENGINE MOUNTS FOR SEVERE DUTY VEHICLES. *JB
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 0081
INFORMATION REGARDING ROUGH IDLE APPROXIMATELY 20 SECONDS AFTER COLD ENGINE START-UP MAY OCCUR ON SOME VEHICLES. **MR
Bulletin Number: 00B60
ON SOME VEHICLES THE REAR SUSPENSION UPPER CONTROL ARM BRACKETS ON THE FRAME MAY DEVELOP MINOR CRACKS WHEN SUBJECTED TO SEVERE DUTY SERVICE. *JB
Bulletin Number: 00E11
SERVICE ACTION 00E11, SUPPLEMENT #1 - UPDATE INFORMATION REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
Bulletin Number: 00E11
SERVICE ACTION BULLETIN REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
Bulletin Number: 0111
ON SOME VEHICLES, THE ENGINE MOUNTS MAY NOT EXHIBIT SATISFACTORY DURABILITY UNDER SEVERE OPERATING CONDITIONS THAT MAY BE ENCOUNTERED BY POLICE, TAXI OR LIMO / LIVERY VEHICLES SUCH AS EXTENDED IDLING AT HIGH AMBIENT TEMPERATURES. *
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01194
THIS ARITLCE IS TO PROVIDE INFORMATION ON REPLACEMENT OF OLD STYLE HOOD LAMP SWITCH TO THE RVISED MECHANICAL HOOD LAMP SWITCH. *TT
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 012110
SOME VEHICLES EQUIPPED WITH THE ROMEO BUILT 4.6L 2V ENGINE MAY EXHIBIT AN ENGINE OIL LEAK OR OIL WEEPAGE FROM THE CYLINDER HEAD GASKET AT THE RIGHT HAND REAR OR THE LEFT HAND FRONT OF THE ENGINE. *TT
Bulletin Number: 012113
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL
Bulletin Number: 012114
PARTS AND PROCEDURE TO REDUCE THE POTENTIAL OF FUEL TANK PUNCTURES DURING RARE AND EXTREMELY HIGH-SPEED REAR IMPACTS. *TT
Bulletin Number: 01213
VEHICLES MAY EXHIBIT AN INTERMITTENT RAPID FLASHING OF THE TURN SIGNALS. *TT
Bulletin Number: 01221
SOME DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT A ROUGH IDLE, OR NO START IN COLD CONDITIONS. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 0162
VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT
Bulletin Number: 01M02
OWNER NOTIFICATION PROGRAM REGARDING ADDITIONAL COVERAGE ON CERTAIN 4.6L SOHC INTAKE MANIFOLDS. SOME OF THE COMPOSITE INTAKE MANIFOLDS MAY DEVELOP FATIGUE CRACKS AT THE COOLANT CROSSOVER DUCT. *TT
Bulletin Number: 01M02
SOME OF THE COMPOSITE INTAKE MANIFOLDS USED ON 4.6L SOHC ENGINES MAY DEVELOP FATIGUE CRACKS AT THE COOLANT CROSSOVER DUCT. THIS CONDITION COULD RESULT IN ENGINE COOLANT LEAKAGE WHICH, IF NOT SERVICED, MAY CAUSE ENGINE OVERHEATING. COMPL
Bulletin Number: 020503
GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996. *TT UPDATE. *TT
Bulletin Number: 02107
TRANSFER SERVICE TIPS FOR THE FRONT WIPER MOTOR MOUNT BRACKET AND DEPRESSED PARK OUTPUT ARM. *TT
Bulletin Number: 02136
ON SOME VEHICLES, THE BRAKE SHIFT INTERLOCK MAY BE INOPERATIVE, NOW ALLOWING THE OPERATOR TO MOVE THE SHIFT LEVER FROM THE PARK POSITION. STOP LAMP OPERATION MAY ALSO BE AFFECTED. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH
Bulletin Number: 0222
SOME VEHICLES MAY EXHIBIT AN INTAKE MANIFOLD CROSSOVER (FIRST RUNNER) COOLANT SEEPAGE CONDITION. *TT
Bulletin Number: 0245
INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT
Bulletin Number: 0253
SUBJECT REGARDING ALTERNATIVE FUEL VEHICLE COMPRESSED NATURAL GAS TANK INSPECTION. *TT
Bulletin Number: 0297
SOME VEHICLES PRODUCED BEFORE 3/5/2002 MAY EXHIBIT AN INTERMITTENT RAPID FLASHING OF THE TURN SIGNALS. *TT
Bulletin Number: 02B02
INSTALLATION OF OPTIONAL POLICE INTERCEPTOR PACKAGE UPGRADE KIT. *TT UPDATE PART 2. EXPIRATION DATE REMOVED. *TT
Bulletin Number: 030409
POSSIBLE FUEL LEAK AT FILL VALVE - FILL VALVE SERVICE PART REVISIONS - CNG VEHICLES ONLY. *TT
Bulletin Number: 031404
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
Bulletin Number: 03144
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 03183
DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY. *TT
Bulletin Number: 03193
EXCESSIVE MOISTURE IN THE HEADLAMP ASSEMBLY. *TT
Bulletin Number: 03206
SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY. LOSS OF POWER AT HEAVY LOAD, DIAGNOSTIC TROUBLE CODES (DTCS) FOR LEAN FUEL, ROUGH IDLE, HARD START,
Bulletin Number: 0326
REVISED COOLING FAN MOTOR AVAILABLE. *TT
Bulletin Number: 03261
NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT
Bulletin Number: 0349
A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE ON SOME CNG (COMPRESSED NATURAL GAS) VEHICLES. *TT *JB
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 0441
CRACKS IN THE REAR OF THE FRAME SIDE MEMBER BETWEEN THE UPPER AND LOWER TRAILING ARM BRACKETS. *TT
Bulletin Number: 05N04
EXTENDED COVERAGE PROGRAM 05N04 - EXTENDED COVERAGE FOR COMPOSITE INTAKE MANIFOLD. THIS PROGRAM IS BEING PROVIDED AS A SETTLEMENT TO A CLASS ACTION LAWSUIT. THE TERMS OF THE SETTLEMENT EXTEND THE COVERAGE OF THE ALL-COMPOSITE INTAKE MANIF
Bulletin Number: 07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
Bulletin Number: 090308
MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455
Bulletin Number: 11482
FOR CERTAIN MODEL VEHICLES, THE 4R70W TRANSMISSION SOLENOID MOLDED LEADFRAME MUST BE REPLACED WHEN REMOVED. *TT
Bulletin Number: 11530
WHEN DIAGNOSING CRANK / NO START ON CERTAIN VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT (PATS) CHECK THE CUSTOMERS KEY RING FOR ANY MAGNETIC OBJECTS LIKE THE MOBILE SPEEDPASS KEY WHICH MAY AFFECT THE SIGNAL TRANSMISSION BETWEEN THE PATS KEY A
Bulletin Number: 11770
SOME VEHICLES CANNOT COMMUNICATE WITH THE LIGHTING CONTROL MODULE (LCM), DOOR DIAGNOSTIC MODULE (DDM), AND AIRBAG MODULE. *TT
Bulletin Number: 11774
SOME VEHICLES MAY EXHIBIT A RATTLE NOISE FROM THE EXHAUST SYSTEM NVH DAMPER ON THE LEFT HAND DAMPER ONLY. *TT
Bulletin Number: 11807
SOME ENGINES MAY BE OVERFILLED WITH OIL CAUSED BY ISINTERPRETATION OF THE OIL LEVEL INDICATOR (DIPSTICK) MARKINGS. *TT
Bulletin Number: 12083
SOME 4.6L VEHICLES EQUIPPED WITH A 4R70W TRANSMISSION, MAY EXPERIENCE A HARSH REVERSE ENGAGEMENT. *MJS
Bulletin Number: 12092
SOME POLICE VEHICLES MAY EXHIBIT A SAGGING REAR SUSPENSION WHEN VEHICLE IS LOADED WITH EQUIPMENT. *MJS
Bulletin Number: 12111
SOME VEHICES MAY EXHIBIT A POPPING/TICKING NOISE WHEN THE CAR IS SHIFTED FROM REVERSE TO FORWARD GEAR. *MJS
Bulletin Number: 12118
SOME VEHICLES MAY EXHIBIT A HESITATION ON HARD ACCELERATION OR LACKS POWER ON ACCELERATION. *MJS
Bulletin Number: 12120
SOME VEHICLES WITH 4R70W TRANSMISSIONS BUILT FROM 4/16/98 THROUGH 10/30/98 MAY EXHIBIT A LEAK FROM THE VENT AREA OF THE TRANSMISSION. *MJS
Bulletin Number: 12120
SOME VEHICLES WITH 4R700 TRANSMISSIONS BUILT FROM 4/16/98 THROUGH THE END OF THE 1998 MODEL YEAR MAY EXHIBIT A LEAK FROM THE VENT AREA OF THE TRANSMISSION. *TT
Bulletin Number: 12147
SOME CROWN VICTORIA POLICE VEHICLES ENGINE MAY STALL DURING BRAKING OVER RUMBLE STRIPS, THESE VIBRATIONS MAY OPEN THE INERTIA FUEL SWITCH. *MJS
Bulletin Number: 12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
Bulletin Number: 12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
Bulletin Number: 12178
INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. *MJS
Bulletin Number: 12219
FOR ALL VEHICLES WITH LIGHTING CONTROL MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12223
FOR ALL VEHICLES WITH DRIVERS DOOR MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING. *TT
Bulletin Number: 12226
FOR ALL VEHICLES WITH REMOTE KEYLESS ENTRY CONCERNS THAT REQUIRE A MODULE AND / OR TRANSMITTER (KEYFOB) REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE OR KEYFOB. *TT
Bulletin Number: 12230
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12298
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. *TT
Bulletin Number: 12609
INFORMATION REGARDING PINPINT TEST / 4WABS DIAGNOSTIC TROUBLE CODE B1676 (BATTERY VOLTAGE) - UPDATE. *TT
Bulletin Number: 12615
SUBJECT REGARDING FUEL TANK CLUNK. *TT
Bulletin Number: 12704
SUBJECT REGARDING ALL VEHICLES REQUIRES A PARAMETER RESET TO BE PERFORMED ON THE PASSIVE ANTI-THEFT SYSTEM MODULE (PATS / VIC / HEC) WHEN THE POWERTRAIN CONTROL MODULE (PCM) IS REPLACED. *TT
Bulletin Number: 12714
SOME VEHICLES MAY DEVELOP COSMETIC CRACKS IN THE FRAME AT THE REAR UPPER CONTROL ARM ACCESS OPENING WHEN OPERATED UNDER SEVERE DUTY CONDITIONS. *TT
Bulletin Number: 12725
SOME VEHICLES MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT
Bulletin Number: 12743
EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT
Bulletin Number: 12763
EXHIBITING A CONDITION WHERE THE KEYLESS ENTRY FUNCTIONS ARE INOPERATIVE. *TT
Bulletin Number: 12794
CONCERNS WITH AN INTERMITTENT POP / SNAP NOISE FROM THE INSTRUMENT PANEL. *TT
Bulletin Number: 12868
SOME POLICE VEHICLES MAY EXHIBIT A SAGGING REAR SUSPENSION WHEN VEHICLE IS LOADED WITH EQUIPMENT. *TT
Bulletin Number: 12890
BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE THREAD. *TT
Bulletin Number: 12893
SOME VEHICLE MAY EXHIBIT AN EXHAUST MOAN HEAR ON SLIGHT ACCELERATION. *TT
Bulletin Number: 12950
SOME VEHICLE ENGINES MAY CRANK WITHOUT STARTING. *TT
Bulletin Number: 13025
SOME VEHICLES MAY EXHIBIT A BANG POPPING NOISE HEARD FROM THE EXHAUST SYSTEM DURING COOL-DOWN. *TT
Bulletin Number: 13240
INFORMATION REGARDING VIBRATION/EXTENSION HOUSING BUSHING. *MJS
Bulletin Number: 13355
INFORMATION REGARDING A/C PEANUT O-RING COLOR. *TT
Bulletin Number: 13808
SOME VEHICLES BUILT BEFORE JANUARY 1, 1999 AND EQUIPPED WITH A KEYLESS ENTRY SYSTEM, MAY EXHIBIT A CONDITION WHERE ALL THE KEYLESS ENTRY FUNCTIONS ARE INOPERATIVE. *MJS
Bulletin Number: 13925
SOME POLICE VEHICLES MAY EXHIBIT SHIFT CONCERNS DUE TO ENGINE DRIVEABILITY ISSUES. *TT
Bulletin Number: 13928
SOME POLICE VEHICLES, EQUIPPED WITH FULL SIZE WHEEL COVERS, MAY EXHIBIT A CONCERN WITH THE WHEEL COVERS BECOMING LOOSE AFTER BEING REMOVED AND REPLACED SEVERAL TIMES. *TT
Bulletin Number: 14080
SOME VEHICLES WITH FULL SIZE LUXURY WHEEL COVERS MAY EXHIBIT A CLICKING NOISE WHILE DRIVING. **MR
Bulletin Number: 14081
SOME VEHICLES MAY EXHIBIT AN INOPERATIVE KEYLESS ENTRY PAD. **MR
Bulletin Number: 14181
CONCERNS WITH FUEL TANK THUMP. *TT
Bulletin Number: 14181
VEHICLES BUILT UP TO DECEMBER OF 1999 MAY EXHIBIT A CLUNK NOISE FROM THE REAR OF THE VEHICLE WHEN DRIVING OVER SPEED BUMPS. THIS MAY BE CAUSED BY THE FILL-LIMITING VALVE INSIDE THE FUEL TANK. *TT
Bulletin Number: 14821
SOME VEHICLES EQUIPPED WITH 4.6L ROMEO ENGINE MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 14862
INFORMATION ON REPLACING FUEL TANK STRAP BOLTS. *TT
Bulletin Number: 14864
SUBJECT REGARDING CERTAIN VEHICLES WITH 4.6L ROMEO ENGINES EXHIBITING AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 15026
SOME VEHICLES MAY EXHIBIT A STALL AT IDLE AFTER START-UP CONDITION. *TT
Bulletin Number: 15061
SOME VEHICLES BUILT 04/15/2000 OR EARLIER EQUIPPED WITH A KEYLESS ENTRY SYSTEM MAY EXHIBIT AN INOPERATIVE DOOR-MOUNTED KEYPAD, INTERIOR AND EXTERIOR LAMPS THAT SELF-ACTIVATE AND A WEAK OR DISCHARGED VEHICLE BATTERY. *TT
Bulletin Number: 15078
SOME POLICE AND TAXI VEHICLES MAY EXHIBIT EITHER UNDERBODY SHEETMETAL CRACKING IN THE DRIVESHAFT TUNNEL AT THE REAR SEAT KICKUP AND / OR DRIVESHAFT CONTACT WITH THE UNDERBODY. *TT
Bulletin Number: 15113
SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION. *YD
Bulletin Number: 15158
SOME VEHICLES MAY EXHIBIT A FEAD BELT JUMP-OFF TOSS. *YH
Bulletin Number: 15171
INFORMATION REGARDING POLICE OPTION-REAR WINDOW DISABLE-TAMPER RESISTANCE. *YD
Bulletin Number: 15271
DEDICATED CNG REGULATOR BOWL KIT AVAILABLE. *JG
Bulletin Number: 15761
SOME DEDICATED CNG VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS OF HARD START / NO START / ROUGH RUNNING. *TT
Bulletin Number: 15808
SOME VEHICLES EQUIPPED WITH A ONE-TOUCH DOWN MODULE OR A DRIVERS DOOR MOUDLE MAY EXHIBIT A CONDITION WHERE THE DRIVERS WINDOW MOVES DOWN WHEN ONE OF THE OTHER WINDOWS IS OPERATED. *TT
Bulletin Number: 16996
POLICE INTERCEPTOR MAY EXHIBIT LOW CHARGING SYSTEM VOLTAGE AT IDLE. *TT
Bulletin Number: 17757
INTERMITTENT RAPID FLASHING OF THE TURN SIGNALS. *TT
Bulletin Number: 17810
TRANSMISSION FAILURE WHERE THERE IS A LARGE AMOUNT OF METAL OR DEBRIS IN THE PAN. *TT
Bulletin Number: 17871
MULTIPLE DRIVEABILITY CONCERNS UNDER ACCELERATION CAUSED BY IGNITION COIL. *TT
Bulletin Number: 18351
CHARGING SYSTEM LIMITATIONS. *EH
Bulletin Number: 4619
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT
Bulletin Number: 4652
SOME VEHICLES (BUILT BETWEEN FEB 23 AND MAR 20 1998) MAY EXHIBIT A CONCERN OF CANNOT COMMUNICATE WITH THE LIGHTING CONTROL MODULE (LCM), DOOR DIAGNOSTIC MODULE (DDM), AND AIRBAG MODULE. *TT
Bulletin Number: 4656
SOME VEHICLES MAY EXHIBIT A RATTLE NOISE FROM EXHAUST SYSTEM NVH DAMPER ON THE LEFT HAND DAMPER ONLY. *TT
Bulletin Number: 4699
ON SOME VEHICLES, THE ENGINE MAY BE OVERFILLED WITH OIL. THIS MAY BE CAUSED BY MISINTERPRETATION OF THE OIL LEVEL INDICATOR (DIPSTICK) MARKINGS. *TT
Bulletin Number: 5078
SOME VEHICLES EQUIPPED WITH A 4R70W TRANSMISSIONS MAY EXPERIENCE HARSH REVERSE ENGAGEMENT. *TT
Bulletin Number: 5156
SOME VEHICLES MAY EXHIBIT A HESITATION ON HARD ACCELERATION OR LACKS POWER ON ACCELERATION. *TT
Bulletin Number: 5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
Bulletin Number: 5789
REPLACING FRONT BRAKE ROTORS. *TT
Bulletin Number: 6035
SOME VEHICLES EQUIPPED WITH TEVES FOUR WHEEL ANTI-LOCK BRAKES (4WABS) MAY EXHIBIT A YELLOW ANTI-LOCK BRAKE LAMP ILLUMINATED WITH NO DIAGNOSTIC TROUBLE CODES IN MEMORY. *TT
Bulletin Number: 6218
CONDITIONS WITH COSMETIC CRACKS IN THE FRAME AT THE REAR UPPER CONTROL ARM ACCESS OPENING. *TT
Bulletin Number: 6242
EXPERIENCING A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE. *TT
Bulletin Number: 6312
SOME VEHICLES MAY EXPERIENCE A CONDITION WHERE ALL THE KEYLESS ENTRY FUNCTIONS ARE INOPERATIVE (I.E., KEY FOBS, POWER DOOR LOCKS, EXPRESS DOWN WINDOW, AND REMOTE TRUNK RELEASE). *TT
Bulletin Number: 6330
EXPERIENCING A POPPING / SNAPPING NOISE FROM THE INSTRUMENT PANEL. *TT
Bulletin Number: 6459
EXPERIENCING A SAGGING REAR SUSPENSION WHEN VEHICLE IS LOADED WITH EQUIPMENT. *TT
Bulletin Number: 6505
BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE ON NATURAL GAS VEHICLES. *TT
Bulletin Number: 6506
SOME VEHICLES MAY EXHIBIT AN EXHAUST MOAN / ROAR HEARD ON SLIGHT ACCELERATION AND AT SPEEDS NEAR 42 MPH FOR SINGLE EXHAUST AND NEAR 62 MPH ON DUAL EXHAUST CARS. *TT
Bulletin Number: 6617
EXHIBITING AN INTERMITTENT CONCERN WHERE THE WINDOW ONE TOUCH DOWN FEATURE WILL OPERATE FROM WINDOW SWITCH LOCATIONS OTHER THAN THE DRIVER'S DOOR. *TT
Bulletin Number: 6903
SOME POLICE VEHICLES, EQUIPPED WITH FULL SIZE WHEEL COVERS, MAY EXHIBIT A CONCERN WITH THE WHEEL COVERS BECOMING LOOSE AFTER BEING REMOVED AND REPLACED SEVERAL TIMES. *TT
Bulletin Number: 7194
SUBJECT REGARDING FORD QUALITY RENEWAL (FQR) ASSEMBLY LAUNCH OF 4.6L 2V ENGINE. *TT
Bulletin Number: 7249
INFORMATION ON USING PEANUT STYLE A/C FITTINGS. *TT
Bulletin Number: 8024
SOME VEHICLES EQUIPPED WITH A KEYLESS ENTRY SYSTEM, MAY EXHIBIT A CONDITION WHERE ALL THE KEYLESS ENTRY FUNCTIONS ARE INOPERATIVE, INCLUDES REMOTE KEY FOB'S , POWER DOOR LOCKS, EXPRESS DOWN WINDOW AND REMOTE TRUNK RELEASE, VEHICLES BUILT BE
Bulletin Number: 8060
SOME VEHICLES MAY EXHIBIT A SLIGHT STEERING DRIFT / WANDER CONDITION, USUALLY NOTED DURING HIGHWAY DRIVING. *TT
Bulletin Number: 8243
SOME POLICE VEHICLES MAY EXHIBIT SHIFTING CONCERNS DUE TO ENGINE DRIVEABILITY ISSUES. *TT
Bulletin Number: 8243
SOME POLICE VEHICLES MAY EXHIBIT SHIFT CONCERNS DUE TO ENGINE DRIVABILITY ISSUES. **MR
Bulletin Number: 8246
SOME POLICE VEHICLES, EQUIPPED WITH FULL SIZE WHEEL COVERS, MAY EXHIBIT A CONCERN WITH THE WHEEL COVERS BECOMING LOOSE AFTER BEING REMOVED AND REPLACED SEVERAL TIMES. *TT
Bulletin Number: 8300
SOME VEHICLES MAY EXHIBIT A BANG / POPPING NOISE HEARD FROM THE EXHAUST SYSTEM DURING COOL-DOWN. **MR
Bulletin Number: 8382
SOME VEHICLES MAY EXHIBIT A MISS, BUCK / JERK, SURGE IN THE IGNITION COIL / SPARK PLUG BOOT. *TT
Bulletin Number: 8576
SOME VEHICLES WITH FULL SIZE LUXURY WHEELS COVERS MAY EXHIBIT A CLICKING NOISE WHILE DRIVING. **MR
Bulletin Number: 97090297183
EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC
Bulletin Number: 976011
SUBJECT REGARDING FUNCTION TEST CHANGES ON SERVICE BAY DIAGNOSTIC SYSTEM (SBDS). *TT
Bulletin Number: 976011
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 980321
PATS KEY PROGRAMMING. *AK
Bulletin Number: 98110
SUBJECT REGARDING PASSIVE ANTI THEFT SYSTEM (PATS) DIAGNOSTIC SERVICE TIPS. *TT
Bulletin Number: 9811351
SOME VEHICLES WITH 4R70W TRANSMISSION MAY HAVE A HARSH REVERSE ENGAGEMENT. *TT
Bulletin Number: 9811483
SOME POLICE AND EXPORT CARS EQUIPPED WITH PHONELIC PISTON CALIPERS MAY EXHIBIT BRAKE SQUEAL FROM THE REAR WHEN BRAKING. *TT
Bulletin Number: 9811492
VEHICLES BUILT AFTER MARCH 9, 1998 MAY BE MISSING A SCREW AND GROMMET IN THE REAR EDGE OF THE FRONT DOOR TRIM PANELS. *TT
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 9818
FUEL PUMP REPLACEMENT PROCEDURE - SERVICE TIP. *TT
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 98203
CONCERNS WITH ADHENSIVES NOT RECOMMENDED FOR BODY PANEL REPAIRS. *YC
Bulletin Number: 98203
CONCERNS WITH THE POTENTIAL EFFECTS OF ADHESIVES USED FOR BODY PANEL REPAIRS. *TT
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982312
ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 982320
SOME VEHICLES WITH A VERY LOW ODOMETER READING MAY EXPERIENCE A LACK TEMPERATURE CONTROL. *YC
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98241
DIAGNOSTIC SERVICE TIPS ON PASSIVE ANTI THEFT SYSTEM ( PATS ). *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982510
SOME VEHICLES BUILT AFTER MARCH 9-1998, MAY BE MISSING A SCREW AND GROMMET IN THE REAR EDGE OF THE FRONT DOOR TRIM PANELS. *YC
Bulletin Number: 982518
SOME VEHICLES MAY EXHIBT A CONCERN WITH LIGHT SPARK KNOCK / DETONATION WHILE ACCELERATION IN AMBIENT TEMPERTURES GREATER THAN 32 C (90 F). *YC
Bulletin Number: 982525
SOME VEHICLES MAY EXHIBIT BRAKE SQUEAL FROM THE REAR WHEN BRAKING. *YC
Bulletin Number: 982543
SOME VEHICLES WITH ANTI LOCK BRAKES MAY EXHIBIT CUSTOMER CONCERNS OF A MOMENTARY BUZZ TYPE NOISE FROM THE LEFT SIDE OF THE ENGINE COMPARTMENT. THIS COULD BE CAUSED BY ABS BRAKE SYSTEM SELF TESTING. *AK
Bulletin Number: 98258
A VIBRATION / NOISE FELT IN STEERING WHEEL ON RIGHT TURNS.
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 982680
SEAT REGULATOR CONTROL SWITCHES ( LOCATED IN THE DOOR TRIM PANELS ) ARE AVAILABLE FOR SERVICE. *YC
Bulletin Number: 982723
EXHIBITING AN INTERMITTENT STALL CONCERN WITH EITHER NO DIAGNOSTIC TROUBLE CODES (DTC'S) OR DTC P12600 TROUBLE CODE. *YC
Bulletin Number: 983073
SOME VEHICLES MAY EXHIBIT A DRIVE LINE VIBRATION. *TT
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 983300
INFORMATION PERTAINING TO REAR VIEW MIRROR ELECTRONIC COMPASS CALIBRATION INSTRUCTIONS. *TT
Bulletin Number: 983566
INFORMATION ON PROGRAMMING / DIAGNOSING ANY PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT
Bulletin Number: 983566
INFORMATION REGARDING PROGRAMMING / DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT
Bulletin Number: 98412
THE 4R70W TRANSMISSION INSTALLED IN SOME VEHICLES WILL HAVE AN ORANGE
Bulletin Number: 9844
SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING. *YC
Bulletin Number: 98-4828
SUBJECT PERTAINING TO THE SERVICE MANUAL NOT HAVING A PINPOINT TEST FOR "DEGRADED AM RECEPTION OR CONTINUOUS SEEK IN AM" IN THE DIAGNOSIS AND TESTING PORTION OF THE AUDIO CHAPTER. *TT
Bulletin Number: 985017
EXPERIENCING A GRUNT OR SQUEAK NOISE FROM THE FRONT SUSPENSION WHEN TURNING THE STEERING TO FULL LOCK, TO THE LEFT OR THE RIGHT. *TT
Bulletin Number: 985034
POLICE VEHICLES WITH BUCKET SEATS MAY HAVE CUSTOMER CONCERN FOR LEANING SEATS. *TT
Bulletin Number: 985079
SOME POLICE VEHICLES MAY EXHIBIT A SAGGING REAR SUSPENSION WHEN VEHICLE IS LOADED WITH EQUIPMENT. *TT
Bulletin Number: 985099
ON SOME VEHICLES, THE FUEL GAUGES MAY STICK AT FULL OR APPROXIMATELY 3/4 FULL. *TT
Bulletin Number: 985143
SOME VEHICLES WITH 4R70W TRANSMISSIONS BUILT FROM 4/16/98 THROUGH THE END OF THE 1998 MODEL YEAR MAY EXHIBIT A LEAK FROM THE VENT AREA OF THE TRANSMISSION. *TT
Bulletin Number: 985149
SOME POLICE VEHICLES MAY STALL DURING BRAKING OVER RUMBLE STRIPS. THESE VIBRATIONS MAY OPEN THE INERTIA FUEL SWITCH. ENGINEERING IS INVESTIGATING CONCERN. *TT
Bulletin Number: 985166
SOME VEHICLES MAY EXHIBIT A POPPING / TICKING NOISE WHEN THE CAR IS SHIFTED FROM REVERSE TO FORWARD GEAR. *TT
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 986001
INFORMATION REGARDING PUBLICATION CD UPDATE. *AK
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 9874
A NEW SILICONE GASKET AND SEALANT. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 9913125
SONE POLICE VEHICLES AND OTHER VEHICLES WITH 4R70W MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT
Bulletin Number: 9913134
SUBJECT REGARDING POLICY VEHICLES EQUIPPED WITH FULL SIZE WHEEL COVERS EXHIBITING A CONCERN WITH THE WHEEL COVERS BECOMING LOOSE AFTER BEING REMOVED AND REPLACED SEVERAL TIMES. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99185
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99195
SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99219
THIS BULLETIN MENTIONS THAT THE WORKSHOP MANUALS DO NOT CONTAIN A PROCEDURE FOR INSPECTING THE PITMAN ARM BALL JOINT FOR WEAR. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 9945
EXHIBITING A BUZZING AND / OR WHISTLING NOISE FROM RIGHT HAND WINDSHIELD AREA AT 50 MPH. *TT
Bulletin Number: 9947
ENGINE EXPERIENCING ROUGHNESS AT IDLE DUE TO EXHAUST SYSTEM RESONANCE. *TT
Bulletin Number: 99-6193
INFORMATION ON RESETTING THE PASSIVE ANTI-THEFT SYSTEM (PATS). *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: 99910
ADDRESSING CONCERNS WITH THE BRAKE LAMP INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK ON POLICE VEHICLES. *TT
Bulletin Number: 9996
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT
Bulletin Number: 99B03
SUBJECT REGARDING INADVERTENT ACTIVATION OF THE INERTIA SWITCH. *TT
Bulletin Number: 99B03S1
INFORMATION REGARDING THE INERTIA SWITCH. *TT
Bulletin Number: 99B09
SUBJECT PERTAINING TO COSMETIC CRACKS IN FRAME AT THE REAR UPPER CONTROL ARM ACCESS OPENING WHEN SUBJECTED TO SEVERE DUTY OPERATING CONDITIONS. *JB
Bulletin Number: 99B09
VEHICLES MAY DEVELOP COSMETIC CRACKS IN THE FRAME OF THE REAR UPPER CONTROL ARM ACCESS OPENING. *TT
Bulletin Number: 99B09
OWNER NOTIFICATION PROGRAM 99B09 SUPPLEMENT #2 FOR CERTAIN COMMERCIAL VEHICLE FRAME SERVICE. *TT
Bulletin Number: 99E03
EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT
Bulletin Number: CSP 08B04
FORD/LINCOLN MERCURY: CERTAIN 1992-2001 MODEL YEAR CROWN VICTORIA, GRAND MARQUIS, AND TOWN CAR VEHICLES REGISTERED IN THE STATES OF WISCONSIN AND CONNECTICUT UPGRADE MODIFICATIONS FOR HIGH SPEED REAR IMPACTS. *PE
1998 FORD C SERIES
Bulletin Number: 4747
INFORMATION ON ADDITIONS TO THE FORD QUALITY RENEWAL ASSEMBLY PROGRAM.
1998 FORD E-150
Bulletin Number: 05248
VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE. *TT
Bulletin Number: 071110
BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
Bulletin Number: 090308
MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455
Bulletin Number: 11496
SOME VEHICLES EQUIPPED WITH THE 4.2L ENGINE MAY EXHIBIT A VIBRATION OR BOOM, OFF IDLE BETWEEN 870 - 900 RPMS. *TT
Bulletin Number: 13186
INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS
Bulletin Number: 14992
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A DRIVELINE VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50 - 55 MPH. *TT
Bulletin Number: 15038
SOME VEHICLES MAY EXHIBIT RAPID WEAR OF THE FRONT BRAKE PADS (UNDER 10,000 MILES). *TT
Bulletin Number: 15082
INFORMATION USED WHEN SERVICING, OR REPLACING THE CNG FUEL FILL VALVE ON ALL DEDICATED AND BI-FUEL CNG VEHICLES. *TT
Bulletin Number: 15354
SOME VEHICLES MAY EXHIBIT ACCELERATED FRONT DISC BRAKE PAD WEAR UNDER EXTREME LOADING CONDITIONS. *TT
Bulletin Number: 15517
SUBJECT REGARDING EXAGGERATED ENGINE BRAKING ON DECELERATION. *YD
Bulletin Number: 15799
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50-55 MPH. *TT
Bulletin Number: 17381
FRONT BRAKE PAD WEAR. *TT
Bulletin Number: 4619
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT
Bulletin Number: 4628
SOME VEHICLES MAY EXHIBIT REAR AXLE NOISE. *TT
Bulletin Number: 4638
MALFUNCTION INDICATOR LAMP ON, WITH P0300 - P0308 MISFIRE DIAGNOSTIC TROUBLE CODES WITH A 4.6L ENGINE. *TT
Bulletin Number: 6996
INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT
Bulletin Number: 97090297183
EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC
Bulletin Number: 976011
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 980317
SYMPTOMS REGARDING P0300-P0308 MISFIRE DTCS WITH 4.6L ENGINES. *YC
Bulletin Number: 982474
SOME VEHICLES WITH THE 4.2L ENGINE MAY EXHIBIT A VIBRATION OR BOOM, OFF IDLE BETWEEN 870-900 RPMS. *YC
Bulletin Number: 985122
SUBJECT REGARDING THE AVAILABILITY OF THE FQR ANTI-LOCK BRAKING SYSTEM HYDRAULIC CONTROL UNIT (ABS-HCU) ASSEMBLIES. *TT
Bulletin Number: 99131
CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: 99146
CONCERNS WITH THE OIL DIPSTICK AND / OR PCV VALVE DISLODGING FROM THE ENGINE AND / OR ENGINE OIL LEAKING FROM DIPSTICK TUBE. *TT
Bulletin Number: 99207
SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: 99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
Bulletin Number: BC0718961021
INFORMATION ON BRAKE ROTOR TURNING/REPLACING. *TT
Bulletin Number: BC4651961001
VEHICLE MAY NOT START AFTER BEING PARKED IN BELOW FREEZING TEMPS. MAY BE DUE TO MOISTURE FREEZING IN THE FUEL PUMP RELAY CONTAINED WITHIN THE CCRM (CONSTANT CONTROL RELAY MODULE). *TT
Bulletin Number: BC4854961001
REVISED EEC CALIBRATION HAS BEEN INCORPORATED IN PCM CALIBRATION FOR VEHICLES WHICH DISPLAY LACK OF POWER DUE TO TORQUE CONVERTER ENGAGEMENT SCHEDULING, CATALYTIC CONVERTER FAILURES, ROUGH IDLE OR HARD START ON HOT RESTART. *TT
Bulletin Number: BC5075961001
INFORMATION ON ERRATIC OR SELF LOCKING DOOR LOCKS. *TT
Bulletin Number: BC5172961001
INFORMATION FOR CONCERNS OF CHECK ENGINE LIGHT 'ON' ON 4.2L/4.6L/5.4L/6.8L VEHICLES. *TT
Bulletin Number: BC5173961001
ON VARIOUS 4.0L APPLICATIONS THE OIL INDICATOR TUBE (DIP STICK) IS COMING INTO CONTACT W/ THE CRANKSHAFT. *TT
Bulletin Number: BC5174961001
INFORMATION TO DIAGNOSE WIND NOISE & WATER LEAKS AT THE LOWER PASSENGER DOOR AREA & 3RD DOOR. *TT
Bulletin Number: BC5175961001
CONCERNS OF A/C GOING TO DEFROST MODE WHEN CLIMBING GRADES OR ACCELERATING ARE LIKELY CAUSED BY VACUUM LEAKS. *TT
Bulletin Number: BC5176961001
CONNECTION BETWEEN THE SENDER (9A299) & THE FUEL PUMP (9350) CHANGED FROM THE EXISTING SPADE TERMINAL TO AN EYELET TERMINAL WHICH IS SECURED UNDER THE TOP SENDER MOUNT SCREW. *TT
Bulletin Number: BC5181961001
ENGINE OIL LEAK AT THE OIL PAN, FRONT COVER &/OR THE FRONT & REAR CRANKSHAFT OIL SEAL. *TT
Bulletin Number: BC5182961001
INFORMATION ON CORRECTING AN OIL PAN GASKET LEAK. *TT
Bulletin Number: BC5183961001
AN OIL LEAK IN THE AREA OF THE ENGINE OIL FILTER MAY BE CAUSED BY A DAMAGED OR MIS-INSTALLED (I.E. ROLLED OVER, PINCHED, SHEARED, NICKED, ETC.) OIL PUMP BODY SEAL. *TT
Bulletin Number: BC5185961001
VEHICLES MAY EXHIBIT A GRINDING NOISE WHILE SHIFTING INTO 4L. *TT
Bulletin Number: BC5186961001
VEHICLES MAY EXPERIENCE AN INTERMITTENT HIGH IDLE AFTER DECEL TO A STOP, WHEN CLUTCH PEDAL IS DEPRESSED W/ NO THROTTLE MOVEMENT. *TT
Bulletin Number: BC5190961001
VEHICLES EXPERIENCING CHAFING ON THE 14401 WIRE HARNESS CAUSING THE ACCESSORY FUSES TO BECOME OPEN (PRIMARILY THE CIGAR FUSE). *TT
Bulletin Number: BC5198961001
IMPROVED REAR SHOCK ABSORBERS FOR CUSTOMERS WHO MAY EXPERIENCE A LOW TONE RATTLING NOISE OR WHOOSH SOUND FROM THE REAR OF THE VEHICLE WHILE TRAVELING LESS THAN 25 MPH & GOING OVER SMALL TO MODERATE BUMPS. *TT
Bulletin Number: BC5204961001
CONCERNS OF CHECK ENGINE LIGHT (MIL) W/CODES P0300 THRU P0308 & ENGINE RUNS ROUGH/MISSES MAY BE DUE TO A SPARK PLUG WIRE BOOT THAT IS NOT FULLY SEATED ON THE SPARK PLUG. *TT
Bulletin Number: BC5207961001
INFORMATION FOR SERVICING THE ELECTRONIC/HYDRAULIC CONTROL UNIT (EHCU) ON 4WABS. *TT
Bulletin Number: BC5209961001
REVISED REAR BRAKE LINING FOR BOTH 9 INCH & 10 INCH APPLICATIONS FOR CONCERNS W/ REAR BRAKE GRAB DURING THE FIRST FEW BRAKE APPLICATIONS WHEN THE BRAKES ARE COLD OR IN THE MORNING AFTER AN OVERNIGHT RAIN. *TT
Bulletin Number: BC5214961001
REVISED HOOD SEAL FOR CONCERNS OF A WIND WHISTLE AT SPEEDS OVER 35 MPH. *TT
Bulletin Number: BC5217961001
INFORMATION ON REPLACED/REPAIRED MANUAL TRANSMISSION UNDER WARRANTY AND RETURNED W/ SIGNS OF IMPROPER/LACK OF MAINTENANCE OR MISDIAGNOSIS. *TT
Bulletin Number: BC5218961001
INFORMATION ON STOWING THE SPARE TIRE STOWAGE. *TT
Bulletin Number: BC5224961001
INFORMATION ON ABS SENSORS RETURNED FOR ANALYSIS ARE IDENTIFIED AS 'NO PROBLEM FOUND'. *TT
Bulletin Number: BC5227961001
INFORMATION FOR AIR BAG DTC B1813 OBSERVE THE AIR BAG LAMP FLASH OUT CODE & PERFORM THE APPROPRIATE PINPOINT TEST FOR THE FLASH OUT CODE. *TT
Bulletin Number: BC9642961001
PROCEDURE FOR VEHICLES EQUIPPED WITH AN AODE OR 4R70W TRANSMISSION HAS A CONCERN OF SHUDDER FROM THE TRANSMISSION TORQUE CONVERTER CLUTCH IN 3RD OR 4TH GEAR OR DURING 3-4 SHIFT. *TT
Bulletin Number: BC9668961001
CONCERN FOR VEHICLES EXHIBITING LEAN CODES P0171 & P0174 (VACUUM LEAK). *TT
Bulletin Number: BC9671961001
PUSH CONNECTION BETWEEN THE FLEXIBLE FUEL VAPOR LINE AT THE CARBON CANISTER & THE METAL FUEL VAPOR LINE MAY NOT SEAT FULLY ON THE FUEL VAPOR LINE. *TT
Bulletin Number: BC9672961001
PROCEDURE FOR BRAKE WARNING INDICATOR STAYS ON RED IN CLUSTER. *TT
Bulletin Number: BC9673961001
PROCEDURE FOR BRAKE EXTERIOR LIGHTS STAY ON (TAIL & HIGH MOUNT STOP LIGHT). *TT
Bulletin Number: BC9674961001
LIGHT TO MODERATE AXLE NOISE (AXLE WHINE) AT 50 TO 65 MPH (80 TO 105 KPH) DURING ACCELS, DECELS OR CRUISE MAY BE DUE TO AXLE NOISE BEING TRANSMITTED FROM THE AXLE INTO THE VEHICLE. *TT
Bulletin Number: BC9676961001
IMPROPER RTV APPLICATION AT THE FRONT/REAR LOWER INTAKE MANIFOLD END SEALS & SIDE GASKETS MAY CAUSE AN OIL/COOLANT LEAK. *TT
Bulletin Number: BC9680961001
CONCERN WHERE THE DOOR GLASS DROPS WHEN CYCLED DOWN ON VEHICLES WITH THE POWER DOOR OPTION. *TT
Bulletin Number: BC9682961001
CONCERNS FOR THE LABOR TIME STANDARD IN TBS 96-19-02 (STEERING - GRUNT NOISE DURING STEERING WHEEL RETURN FROM FULL RIGHT TURN) IS INCORRECT. *TT
Bulletin Number: BC9694961001
INFORMATION ON VEHICLES THAT MAY EXHIBIT A SLIGHT DELAY IN THE FIRST DRIVE AWAY AFTER THE VEHICLE HAS BEEN PARKED OVERNIGHT, OR FOR A LONGER PERIOD OF TIME. *TT
Bulletin Number: BC9695961001
ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) INVALID DIAGNOSTIC CODES U1235 & 155 MAY BE STORED IF THE IGNITION SWITCH IS CYCLED FROM 'OFF' TO 'RUN' EXTREMELY SLOWLY. *TT
1998 FORD E-250
Bulletin Number: 00L07
THIS BULLETIN INVOLVES FUEL DOOR LABEL APPLICATION / REPLACEMENT. *JB
Bulletin Number: 01136
SUBJECT REGARDING OVERVIEW OF BI-FUEL CNG VEHICLE PARAMETER IDENTIFICATION DATA (PID), INPUTS AND OUTPUTS AS A DIAGNOSTIC AID FOR BI-FUEL VEHICLES. *TT
Bulletin Number: 0182
SOME BI-FUEL VEHICLES MAY EXHIBIT A NO START CONDITION. *TT
Bulletin Number: 05248
VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE. *TT
Bulletin Number: 071110
BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
Bulletin Number: 11496
SOME VEHICLES EQUIPPED WITH THE 4.2L ENGINE MAY EXHIBIT A VIBRATION OR BOOM, OFF IDLE BETWEEN 870 - 900 RPMS. *TT
Bulletin Number: 11779
SOME VEHICLES MAY EXHIBIT BRAKE ROTOR CHECKING OR SIGNS OF EXCESSIVE HEAT BUILD-UP. *TT
Bulletin Number: 12835
SUBJECT REGARDING TIRE BALANCE HINT. *TT
Bulletin Number: 13186
INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS
Bulletin Number: 13763
VEHICLES WITHOUT FRONT DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS DUE TO DAMAGED INNER WHEEL BEARING SEALS. *MJS
Bulletin Number: 14992
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A DRIVELINE VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50 - 55 MPH. *TT
Bulletin Number: 15113
SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION. *YD
Bulletin Number: 15591
SOME VEHICLES WITHOUT FRONT BRAKE DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS. *TT
Bulletin Number: 15634
CONCERNS WITH BUMP STEER STEERING FEELING NOTED WHEN FRONT WHEELS / TIRES CONTACT ROAD SURFACE IRREGULARITIES. *TT
Bulletin Number: 15799
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50-55 MPH. *TT
Bulletin Number: 17009
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH NO HARD FAULT. *TT
Bulletin Number: 17211
A BUMP STEER STEERING FEELING, NOTED WHEN THE VEHICLE'S FRONT WHEELS/TIRES CONTACT ROAD SURFACE IRREGULARITIES. *TT
Bulletin Number: 4638
MALFUNCTION INDICATOR LAMP ON, WITH P0300 - P0308 MISFIRE DIAGNOSTIC TROUBLE CODES WITH A 4.6L ENGINE. *TT
Bulletin Number: 4662
SOME VEHICLES MAY EXHIBIT BRAKE ROTOR CHECKING OR SIGNS OF EXCESSIVE HEAT BUILD-UP. *TT
Bulletin Number: 6417
ADDRESSING TIRE BALANCE HINTS. *TT
Bulletin Number: 6996
INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT
Bulletin Number: 980312
EXCESSIVE WHITE SMOKE. VERIFY GLOW PLUG OPERATION BY PERFORMING GLOW PLUG SYSTEM OPERATION CHECK ON THE HARD START/NO START DIAGNOSTIC SHEET. *TT
Bulletin Number: 980317
SYMPTOMS REGARDING P0300-P0308 MISFIRE DTCS WITH 4.6L ENGINES. *YC
Bulletin Number: 98120
SOME VEHICLES MAY EXPERIENCE BOOM / VIBRATION NOISE OFF IDLE DURING ACCELERATION AND DECELERATION. *TT
Bulletin Number: 982474
SOME VEHICLES WITH THE 4.2L ENGINE MAY EXHIBIT A VIBRATION OR BOOM, OFF IDLE BETWEEN 870-900 RPMS. *YC
Bulletin Number: 98L20
SPECIAL FIELD ACTION REGARDING REVISED WARANTY INFORMATION. *TT
Bulletin Number: 99131
CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: 99146
CONCERNS WITH THE OIL DIPSTICK AND / OR PCV VALVE DISLODGING FROM THE ENGINE AND / OR ENGINE OIL LEAKING FROM DIPSTICK TUBE. *TT
Bulletin Number: 99207
SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: DOR-X8B9R-11
This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly ma
1998 FORD E-350
Bulletin Number: 00L07
THIS BULLETIN INVOLVES FUEL DOOR LABEL APPLICATION / REPLACEMENT. *JB
Bulletin Number: 01136
SUBJECT REGARDING OVERVIEW OF BI-FUEL CNG VEHICLE PARAMETER IDENTIFICATION DATA (PID), INPUTS AND OUTPUTS AS A DIAGNOSTIC AID FOR BI-FUEL VEHICLES. *TT
Bulletin Number: 0182
SOME BI-FUEL VEHICLES MAY EXHIBIT A NO START CONDITION. *TT
Bulletin Number: 0511
CRACKS IN THE LEFT OR RIGHT SPRING TOWER FLANGE. *TT SPRING TOWER WELD REPAIR AND REPLACEMENT PROCEDURE. *TT
Bulletin Number: 05248
VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE. *TT
Bulletin Number: 071110
BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
Bulletin Number: 11779
SOME VEHICLES MAY EXHIBIT BRAKE ROTOR CHECKING OR SIGNS OF EXCESSIVE HEAT BUILD-UP. *TT
Bulletin Number: 12261
SUBJECT REGARDING ENGINE DIAGNOSTIC GUIDE FOR WARRANTY REIMBURSEMENT. *TT
Bulletin Number: 12562
SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE P1298. *TT
Bulletin Number: 12835
SUBJECT REGARDING TIRE BALANCE HINT. *TT
Bulletin Number: 13763
VEHICLES WITHOUT FRONT DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS DUE TO DAMAGED INNER WHEEL BEARING SEALS. *MJS
Bulletin Number: 14963
SOME CUT-AWAY VEHICLES MAY EXHIBIT ANTI-SKID BRAKE SYSTEM DIAGNOSTIC TROUBLE CODE C1229, C1230 AND C1237. *TT
Bulletin Number: 14992
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A DRIVELINE VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50 - 55 MPH. *TT
Bulletin Number: 15113
SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION. *YD
Bulletin Number: 15591
SOME VEHICLES WITHOUT FRONT BRAKE DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS. *TT
Bulletin Number: 15634
CONCERNS WITH BUMP STEER STEERING FEELING NOTED WHEN FRONT WHEELS / TIRES CONTACT ROAD SURFACE IRREGULARITIES. *TT
Bulletin Number: 15799
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50-55 MPH. *TT
Bulletin Number: 17009
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH NO HARD FAULT. *TT
Bulletin Number: 17211
A BUMP STEER STEERING FEELING, NOTED WHEN THE VEHICLE'S FRONT WHEELS/TIRES CONTACT ROAD SURFACE IRREGULARITIES. *TT
Bulletin Number: 4662
SOME VEHICLES MAY EXHIBIT BRAKE ROTOR CHECKING OR SIGNS OF EXCESSIVE HEAT BUILD-UP. *TT
Bulletin Number: 5343
THIS BULLETIN STATES THAT REPLACEMENT UNDER WARRANTY OF CERTAIN SPECIFIED COMPONENTS ON ANY 7.3L DIT DIESEL VEHICLE, REQUIRES THAT THE REPLACED COMPONENT BE RETURNED WITH THE APPROPRIATE YEAR DIESEL ENGINE DIAGNOSTIC GUIDE FOR WARRANTY REIM
Bulletin Number: 5901
SERVICE TIPS FOR IDENTIFYING INJECTOR DRIVER MODULE (IDM) FAILURE WITH DIAGNOSTIC TROUBLE CODE P1298. *TT
Bulletin Number: 6417
ADDRESSING TIRE BALANCE HINTS. *TT
Bulletin Number: 7895
WITHOUT FRONT BRAKE DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS DUE TO DAMAGED INNER WHEEL BEARING SEALS.
Bulletin Number: 980312
EXCESSIVE WHITE SMOKE. VERIFY GLOW PLUG OPERATION BY PERFORMING GLOW PLUG SYSTEM OPERATION CHECK ON THE HARD START/NO START DIAGNOSTIC SHEET. *TT
Bulletin Number: 98L20
SPECIAL FIELD ACTION REGARDING REVISED WARANTY INFORMATION. *TT
Bulletin Number: DOR-X8B9R-11
This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly ma
1998 FORD E-450
Bulletin Number: 0511
CRACKS IN THE LEFT OR RIGHT SPRING TOWER FLANGE. *TT SPRING TOWER WELD REPAIR AND REPLACEMENT PROCEDURE. *TT
Bulletin Number: 05248
VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE. *TT
Bulletin Number: 12186
SOME E-450 VEHICLES WITH THE DANA 80 MODEL AXLE MAY EXHIBIT A CUSTOMER CONCERN WITH THE LEVEL OF SOUND (WHINE) THAT IS PRODUCED ABOVE 35 MPH. *MJS
Bulletin Number: 12514
SUBJECT REGARDING DANA 80 AXLE WHINE / DAMPENED DRIVESHAFT. *TT
Bulletin Number: 12562
SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE P1298. *TT
Bulletin Number: 13763
VEHICLES WITHOUT FRONT DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS DUE TO DAMAGED INNER WHEEL BEARING SEALS. *MJS
Bulletin Number: 13822
SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY, MAY EXHIBIT A WHINE ABOVE 35 MPH. *MJS
Bulletin Number: 13822
SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY MAY EXHIBIT A WHINE ABOVE 35 MPH. *TT
Bulletin Number: 14963
SOME CUT-AWAY VEHICLES MAY EXHIBIT ANTI-SKID BRAKE SYSTEM DIAGNOSTIC TROUBLE CODE C1229, C1230 AND C1237. *TT
Bulletin Number: 15591
SOME VEHICLES WITHOUT FRONT BRAKE DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS. *TT
Bulletin Number: 18382
FLUID LEAKING FROM THE VENT ON THE TRANSMISSION MOUNTED PARKING BRAKE ASSEMBLY. *TT
Bulletin Number: 5224
SOME VEHICLES WITH THE DANA 80 MODEL AXLE MAY EXHIBIT A CUSTOMER CONCERN WITH THE LEVEL OF SOUND (WHINE) THAT IS PRODUCED ABOVE 35 MPH. ENGINEERING IS INVESTIGATING. *TT
Bulletin Number: 5816
FOR VEHICLES WITH MODEL 80 REAR AXLES, EXHIBITING A WHINE NOISE CONCERN, A SERVICE KIT WITH A DAMPENED DRIVESHAFT IS AVAILBLE. *TT
Bulletin Number: 5901
SERVICE TIPS FOR IDENTIFYING INJECTOR DRIVER MODULE (IDM) FAILURE WITH DIAGNOSTIC TROUBLE CODE P1298. *TT
Bulletin Number: 6599
SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY MAY EXHIBIT A CONCERN WITH THE AMOUNT OF SOUND, WHINE PRODUCED ABOVE 35 MPH.
Bulletin Number: 7895
WITHOUT FRONT BRAKE DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS DUE TO DAMAGED INNER WHEEL BEARING SEALS.
Bulletin Number: 8048
SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY MAY EXHIBIT A WHINE ABOVE 35 MPH. *TT
Bulletin Number: 8048
SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY, MAY EXHIBIT A WHINE ABOVE 35 MPH. *TT
Bulletin Number: 99E05
EMISSIONS RECALL ON CERTAIN DIESEL CUTAWAY VEHICLES WITH INCORRECT EMISSIONS CALIBRATIONS. *TT
1998 FORD ECONOLINE
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 00154
SOME VEHICLES WITH DANA 80 REAR AXLES MAY EXHIBIT AN EXCESSIVE AMOUNT OF AXLE WHINE NOISE. *JB
Bulletin Number: 00154
INFORMATION ON REAR AXLE WHINE-VEHICLES EQUIPPED WITH DANA 80 AXLES-5.4L/6.8L AND 7.3L. *JB
Bulletin Number: 0022
VEHICLES MAY EXPERIENCE PARTICLE CONTAMINANTS, FROM PRIOR TRANSMISSIION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IF NOT PROPERLY FLUSHED. *MJS
Bulletin Number: 002305
SOME VEHICLES EQUIPPED WITH POWERSTROKE DIESEL MAY EXHIBIT A NOISE ABOVE THE NORMAL SOUND OF THE DIESEL COMBUSTION. THIS NOISE MAY SOUND LIKE A ROD KNOCK, BUT IT IS INTERMITTENT AND IT INCREASES IN INTENSITY AS THE ENGINE WARMS UP TO OPE
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 00235
SOME VEHICLES EQUIPPED WITH A POWERSTROKE DIESEL ENGINE MAY EXHIBIT A NOISE ABOVE THE NORMAL SOUND OF THE DIESEL COMBUSTION. *TT
Bulletin Number: 00239
A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. *TT
Bulletin Number: 00261
SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES. *TT
Bulletin Number: 0038
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS
Bulletin Number: 00510
CUSTOMERS MAY BE CONCERNED THAT VEHICLE LOOKS LIKE IT DOGTRACKS, DUE TO A UNIQUE FEATURE OF THE VEHICLE THAT COMBINE TO CREATE AN OPTICAL ILLUSION OF DOGTRACKING, A CONDITION WHICH THE REAR AXLE IS NOT SQUARE TO THE CHASSIS. *MJS
Bulletin Number: 00610
INFORMATION ON THE 7.3L DIT ENGINES, ROTUNDA TOOL HAS ISSUED AN INJECTOR PERFORMANCE ANALYZER THAT MAY NOW BE PRUCHASED AS AN EFFECTIVE AID IN HELPING TO RESOLVE ROUGH IDLE CONCERNS. *MJS
Bulletin Number: 00611
SOME BI-FUEL VEHICLES MAY REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT DURING SERVICE AND MAY NOT RUN ON CNG OR LPG., RECALIBRATION OF THE PCM/REPLACEMENT. *MJS
Bulletin Number: 0068
VEHICLES MAY EXHIBIT A HESITATION ON ACCELERATION JUST OFF IDLE AND OR MISFIRE CONCERS MAY BE PRESENT ON SOME VEHICLES ACCOMPANIED WITH A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND DIAGNOSTIC TROUBLE CODES (DTCS).
Bulletin Number: 00L05
THIS SERVICE ACTION REQUIRES THE REPLACEMENT OF TWO EMISSION CONTROL LABELS. *TT
Bulletin Number: 01119
SOME VEHICLES WITH HIGH ODOMETER READING OR SEVERE SERVICE MAY EXHIBIT A CREAKING NOISE WHEN TURNING WHEEL OR DRIVING OVER UNEVEN SURFACES ON VEHICLES PRODUCE BEFORE 2/6/2001. *TT
Bulletin Number: 011406
SOME VEHICLES EQUIPPED WITH A POWERSTROKE DIESEL ENGINE MAY EXHIBIT A NOISE ABOVE THE NORMAL SOUND OF THE DIESEL COMBUSTION. *TT
Bulletin Number: 01146
SOME SUPER DUTY F SERIES AND OTHER VEHICLES EQUIPPED WITH A POWERSTROKE DIESEL ENGINE MAY EXHIBIT A NOISE ABOVE THE NORMAL SOUND OF THE DIESEL COMBUSTION. THIS NOISE MAY SOUND LIKE A ROD KNOCK, BUT IT IS INTERMITTENT AND IT INCREASES I
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 032129
SIGNIFICANT CHANGES HAVE BEEN MADE TO THE 7.3L DIT ENGINE EFFECTIVE WITH THE 1998 AND 1999 MODEL YEARS. THE AREAS AFFECTED ARE THE FUEL SYSTEM, HIGH PRESSURE OIL SYSTEM, TURBOCHARGER, AND ENGINE ACCESSORY DRIVE. *TT
Bulletin Number: 032131
ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *TT
Bulletin Number: 032132
SOME VEHICLES EQUIPPED WITH AFTERMARKET MODIFICATIONS MAY EXHIBIT A CRANK BUT NO START OR A HARD START/LONG CRANK CONDITION. *TT
Bulletin Number: 032134
THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE WITH A FALSE DIAGNOSTIC TROUBLE CODE (DTC) P1298 (INJECTOR DRIVE MODULE (IDM) FAILURE). *TT
Bulletin Number: 032137
FOR 7.3L DIT ENGINES, ROTUNDA TOOL HAS ISSUED AN INJECTOR PERFORMANCE ANALYZER THAT MAY NOW BE PURCHASED AS AN EFFECTIVE AID IN HELPING TO RESOLVE ROUGH IDLE CONCERNS. *TT
Bulletin Number: 04E10
EMISSION RECALL 04E10: COMPRESSED NATURAL GAS (CNG) VEHICLES - FITTING CONNECTOR REPLACEMENT. *MJ
Bulletin Number: 11456
CORRECT FUEL PRESSURE TEST ADAPTER. FORD SPECIAL SERVICE MESSAGE. *TT
Bulletin Number: 11482
FOR CERTAIN MODEL VEHICLES, THE 4R70W TRANSMISSION SOLENOID MOLDED LEADFRAME MUST BE REPLACED WHEN REMOVED. *TT
Bulletin Number: 11523
SOME VEHICLES BUILT AFTER 3/10/98 MAY EXHIBIT A BROKEN TEMPERATURE BLEND DOOR. *TT
Bulletin Number: 11524
SOME VEHICLES BUILT THROUGH 3/26/98 MAY EXHIBIT THE LOWER AIR DEFLECTOR DETACHING FROM THE LOWER RADIATOR SUPPORT. *TT
Bulletin Number: 11781
INFORMATION ON SETTING THE CHECK ENGINE LIGHT AND SETTING DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK). *TT
Bulletin Number: 12070
VEHICLES THAT ARE LOADED TO THE UPPER END OF FVW, WITH THE MAJORITY OF THE LOAD BETWEEN THE AXLES, MAY EXHIBIT INNER EDGE TIRE WEAR DUE TO INCORRECT ALIGNMENT. *MJS
Bulletin Number: 12120
SOME VEHICLES WITH 4R700 TRANSMISSIONS BUILT FROM 4/16/98 THROUGH THE END OF THE 1998 MODEL YEAR MAY EXHIBIT A LEAK FROM THE VENT AREA OF THE TRANSMISSION. *TT
Bulletin Number: 12123
VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT, DUE TO INCORRECT FRONT END ALIGNMENT SETTINGS. *MJS
Bulletin Number: 12139
SOME VEHICLES EQUIPPED WITH 4.6L OR 6.8L ENGINES MAY EXHIBIT A COLD START ENGINE NOISE UNTIL WARMED UP. *MJS
Bulletin Number: 12162
SOME VEHICLES EQUIPPED WITH 6.8L ENGINES, MAY EXHIBIT A CUSTOMER CONCERN OR ENGINE ROAR OR ENGINE NOISE FOR THE FIRST FEW MINUTES OF OPERATION AFTER A COLD START. *MJS
Bulletin Number: 12187
SOME VEHICLES MAY EXHIBIT A HARD TO DIAGNOSE SQUEAK/RATTLE NOISE CONCERN. *MJS
Bulletin Number: 12230
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12287
SOME VEHICLES MAY EXHIBIT A CONCERN WITH POOR RANGE OF THE REMOTE KEYLESS ENTRY (RKE) TRANSMITTER. *TT
Bulletin Number: 12593
CONCERNS WITH CRACKS ON THE RIGHT REAR SIDE OF THE #1 FRAME CROSSMEMBER. *TT
Bulletin Number: 12741
SOME VEHICLES UNDER SEVERE DUTY CYCLES MAY EXHIBIT CRACKS ON THE LOWER RADIATOR SUPPORT. *TT
Bulletin Number: 12767
EXHIBITING A VIBRATION THAT MAY BE INTERPRETED AS AN NVH CONDITION. *TT
Bulletin Number: 12835
SUBJECT REGARDING TIRE BALANCE HINT. *TT
Bulletin Number: 12870
SOME CUSTOMERS MAY COMMENT ON A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT
Bulletin Number: 12890
BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE THREAD. *TT
Bulletin Number: 12915
CUSTOMER MAY COMPLAIN OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT
Bulletin Number: 13020
SOME VEHICLES ORDERED BY FLEETS MAY HAVE A DSO (DOMESTIC SPECIAL ORDER) OPTION OF DRL (DAYTIME RUNNING LIGHTS). *TT
Bulletin Number: 13077
INFORMATION ON DIAGNOSING TURBINE SHAFT SPEED (TSS) SENSOR DIAGNOSTIC TROUBLE CODES P0715 / P0717 / AND P0718. *TT
Bulletin Number: 13117
SOME VEHICLES WITH AN ILLUMINATED AIR BAG LAMP MAY HAVE MODIFIED SEAT CONFIGURATIONS. *TT
Bulletin Number: 13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
Bulletin Number: 13187
INFORMATION REGARDING E40D/4R100 TRANSMISSION FLUID COOLER FLOW TEST SPECIFICATION. *MJS
Bulletin Number: 13367
SOME VEHICLES WITH REAR BRAKE DRUMS MAY EXHIBIT BRAKE SQUEAL NOISE. *TT
Bulletin Number: 13398
SOME VEHICLES WITHOUT FRONT BRAKE DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS DUE TO DAMAGED INNER WHEEL BEARING SEALS. *TT
Bulletin Number: 13488
SOME VEHICLES EQUIPPED WITH 7.3L DIT ENGINE MAY EXHIBIT A ROUGH ENGINE IDLE. *TT
Bulletin Number: 13621
IMPROVEMENTS TO MALFUNCTION INDICATOR LAMP (MIL) DIAGNOSTICS. *TT
Bulletin Number: 13763
VEHICLES WITHOUT FRONT DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS DUE TO DAMAGED INNER WHEEL BEARING SEALS. *MJS
Bulletin Number: 13820
INFORMATION ON REPROGRAMMING A PCM WITH THE LATEST CALIBRATION ON CERTAIN VEHICLES EQUIPPED WITH A 7.3L DIESEL ENGINE. A NEW CALIBRATION WAS RECENTLY RELEASED TO PROVIDE IMPROVED MIL DIAGNOSTIC AND TO CORRECT A 4R100 TRANSMISSION SURGE AT
Bulletin Number: 13820
INFORMATION REGARDING (NOT) TO REPROGRAM A PCM WITH THE LATEST CALIBRATION ON A PRE-DECEMBER 1998 BUILD DATE. *MJS
Bulletin Number: 13934
SOME VEHICLES MAY EXHIBIT A-PILLAR SHEET METAL CRACKS AROUND FRONT DOOR HINGES; FRONT DOOR SKIN SEPARATES AND DOOR INNER SHEET METAL CRACKED AROUND FRONT HINGES; OR FRONT DOORS OPEN TOO FAR AND EXTEND INTO THE FRONT FENDERS. *TT
Bulletin Number: 14365
THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT. *JB
Bulletin Number: 15271
DEDICATED CNG REGULATOR BOWL KIT AVAILABLE. *JG
Bulletin Number: 15871
SOME VEHICLES MAY EXHIBIT INTERFERENCE AND / OR STATIC IN THE LAND-MOBILE RADIO. *TT
Bulletin Number: 16258
VEHICLES EQUIPPED WITH A 7.3L ENGINE (AFTER SERIAL NUMBER 0661894) - UNDER VALVE COVER (UVC) HARNESS RETAINER CLIP RELEASED FOR SERVICE. INCLUDES 2003 ECONOLINE, SUPER DUTY, F650/750 AND EXCURSION. *TT
Bulletin Number: 16480
DIAGNOSTIC TROUBLE CODE (DTC) P0340, POSSIBLE FALSE CODE. VARIOUS MODELS INCLUDING 1994-1996 FORD EXCURSION. *TT
Bulletin Number: 16683
FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB
Bulletin Number: 16697
EXHAUST AIR RUSH NOISE AND LOWER POWER. *TT *JB
Bulletin Number: 16916
REPEATED BLOWN FUSES FOR REAR IN VEHICLE CIRCUITS WITH INOPERATIVE REAR BRAKE OR TAIL LAMPS. *TT
Bulletin Number: 17385
AIR BAG LAMP ILLUMINATED. *TT
Bulletin Number: 17467
ENGINE OR FUEL SYSTEM CONCERNS WHEN USING FUEL WITH GREATER THAN 5% BIODIESEL CONCENTRATION. *TT
Bulletin Number: 4664
THIS BULLETIN STATES THAT FOR CERTAIN VEHICLES IT IS NOT POSSIBLE TO SET THE CHECK ENGINE LIGHT AND SET DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK) IF A CUSTOMER REFUELS THE VEHICLE WITH THE ENGINE RUNNING. *
Bulletin Number: 4981
SOME VEHICLES EQUIPPED WITH 5.4L ENGINES MAY EXHIBIT A COLD START ENGINE KNOCK CONCERN UNTIL WARMED UP. *TT
Bulletin Number: 5225
INFORMATION ON VEHICLES EXHIBITING A HARD TO DIAGNOSE SQUEAK / RATTLE NOISE CONCERN. *TT
Bulletin Number: 5257
INFORMATION ON VEHICLES EXHIBITING COLD ENGINE KNOCK. *TT
Bulletin Number: 5371
SOME VEHICLES MAY EXHIBIT A CONCERN WITH POOR RANGE OF THE REMOTE KEYLESS ENTRY (RKE) TRANSMITTER. *TT
Bulletin Number: 5892
SUBJECT REGARDING TECHINICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES WITH GFI ALTERNATE FUEL SYSTEMS. *TT
Bulletin Number: 6290
INFORMATION REGARDING THE IMPROVED RADIATOR SUPPORT. *TT
Bulletin Number: 6417
ADDRESSING TIRE BALANCE HINTS. *TT
Bulletin Number: 6461
CONCERNS OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *T
Bulletin Number: 6505
BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE ON NATURAL GAS VEHICLES. *TT
Bulletin Number: 6538
SOME VEHICLES BUILT BEFORE APRIL 1, 1999 MAY HAVE A CUSTOMER CONCERN OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT
Bulletin Number: 6573
INFORMATION ON VARIOUS ENGINES AVAILABLE FOR THE FORD QUALTY RENEWAL (FQR) ENGINE ASSEMBLY. *TT
Bulletin Number: 6585
SOME VEHICLES EQUIPPED WITH 7.3L DIT DIESEL ENGINES MAY DEVELOP A CRACKED FLEXPLATE. *TT
Bulletin Number: 6731
INFORMATION ON VEHICLES WITH DOS (DOMESTIC SPECIAL ORDER) OPTION FOR DRL (DAYTIME RUNNING LIGHTS). *TT
Bulletin Number: 6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
Bulletin Number: 6999
SUBJECT REGARDING E40D / 4R100 TRANSMISSION FLUID COOLER FLOW TEST SPECIFICATION. *TT
Bulletin Number: 7263
SOME VEHICLES WITH REAR BRAKE DRUMS MAY EXHIBIT BRAKE SQUEAL NOISE. *TT
Bulletin Number: 7310
SOME VEHICLES WITHOUT FRONT BRAKE DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS DUE TO DAMAGED INNER WHEEL BEARING SEALS. *TT
Bulletin Number: 7475
SOME VEHICLES EQUIPPED WITH 73L DIT ENGINE MAY EXHIBIT A ROUGH ENGINE IDLE. *TT
Bulletin Number: 7895
WITHOUT FRONT BRAKE DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS DUE TO DAMAGED INNER WHEEL BEARING SEALS.
Bulletin Number: 8046
INFORMATION ON REPROGRAMMING THE PCM WITH THE LATEST CALIBRATION. *TT
Bulletin Number: 8260
SOME VEHICLES MAY EXHIBIT A-PILLAR SHEET METAL CRACKS AROUND FRONT DOOR HINGES; FRONT DOOR SKIN SEPARATES AND DOOR INNER SHEET METAL CRACKED AROUND FRONT HINGES; OR FRONT DOORS OPEN TOO FAR AND EXTEND INTO THE FRONT FENDERS. *TT
Bulletin Number: 98021698310
SOME VEHICLES SEAT BELTS MAY BE SLOW TO RETRACT. *YC
Bulletin Number: 9811264
CONCERNS WITH TICKING NOISE ON INITIAL COLD START-UP IN PARK AND NEUTRAL POSITION. *TT
Bulletin Number: 9811339
INFORMATION ON THE REVISED FUEL INJECTOR O-RING KIT. *TT
Bulletin Number: 9811341
INFORMATION ON SERVICING AN ILLUMINATED AIR BAG LAMP. *TT
Bulletin Number: 98123
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT
Bulletin Number: 98128
SOME VEHICLES MAY EXHIBIT A "SQUEAKING" NOISE COMING FROM THE STEERING COLUMN WHILE TURNING. *TT
Bulletin Number: 98130
SERVICE PROCEDURE FOR ORANGE SERVICE TAGGED TRANSMISSIONS. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 98151
MALFUNCTION INDICATOR LAMP FAILED. YD
Bulletin Number: 981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 98168
TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD
Bulletin Number: 9818
FUEL PUMP REPLACEMENT PROCEDURE - SERVICE TIP. *TT
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 982019
CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR. *YC
Bulletin Number: 98203
CONCERNS WITH ADHENSIVES NOT RECOMMENDED FOR BODY PANEL REPAIRS. *YC
Bulletin Number: 98203
CONCERNS WITH THE POTENTIAL EFFECTS OF ADHESIVES USED FOR BODY PANEL REPAIRS. *TT
Bulletin Number: 98205
EXHIBITING ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *YC
Bulletin Number: 98209
A " TICKING " NOISE ON INITIAL STARTUP WITH SHIFT SELECTOR IN " P " OR " N " POSITION MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982312
ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 982313
SOME VEHICLES WITH A 7.3L DIRECT INJECTION (DI) TURBO DIESEL ENGINE, ONE OR MORE OF THE FOLLOWING CONCERNS MAY BE PRESENT: ROUGH IDLE, STALLING, HESITATION/ STUMBLE, LOSS / LACK OF POWER, POOR FUEL ECONOMY, AND EXCESSIVE OIL CONSUMPTION.
Bulletin Number: 982314
PREMATURE WEAR OF THE BELT TENSIONER MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 982670
SOME TRANSMISSIONS MAY EXHIBIT STALLING OR NO ENGAGEMENT WHEN PUT INTO GEAR. *YC
Bulletin Number: 982694
CONDITIONS WITH THE ADAPTER TOOL # 014-00931-2 IS INSTALLED ON THE FUEL PUMP INLET AS DESCRIBED, DAMAGE TO THE FUEL PUMP WILL OCCUR. *YC
Bulletin Number: 983084
INFORMATION ON ADDING OR INSTALLING A PULLEY. *TT
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 983180
INFORMATION ON THE NEW 4R100 TRANSMISSION. *TT
Bulletin Number: 983215
SOME VEHICLES WITH MAY EXHIBIT HIGHER THAN NORMAL ENGINE IDLE SPEEDS. *TT
Bulletin Number: 983280
EXPERIENCING A HARSH 1/2 UPSHIFT ON LIGHT THROTTLE. *TT
Bulletin Number: 983281
SOME CUSTOMERS MAY EXPERIENCE A NOISE WHILE TURNING. *TT
Bulletin Number: 983283
ADDRESSING A CONCERN WITH AN AMBER ABS WARNING INDICATOR ILLUMINATED WITH CODE 1095 OR 1096 STORED IN MEMORY OF THE 4WABS MODULE. *TT
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 983312
SOME VEHCILES MAY EXHIBIT A SLOW RETRACTING SEAT BELT. *TT
Bulletin Number: 983315
THE 4R100 TRANSMISSION WILL HAVE AN ORANGE "PRIOR TO REPAIR" TAG ON THE FLUID PAN. *TT
Bulletin Number: 983316
SOME CUSTOMER MAY COMPLAIN OF A TICKING NOISE ON INITIAL COLD START-UP IN PARK POSITION AND NEUTRAL POSITION. *TT
Bulletin Number: 98412
THE 4R70W TRANSMISSION INSTALLED IN SOME VEHICLES WILL HAVE AN ORANGE
Bulletin Number: 98419
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC
Bulletin Number: 98422
SERVICE PROCEDURE FOR ORANGE SERVICE TAGGED TRANSMISSIONS. *YC
Bulletin Number: 98423
SOME VEHICLES MAY EXPERIENCE A HARSH 1/2 SHIFT WHILE DRIVING UNDER LIGHT THROTTLE CONDITIONS. *YC
Bulletin Number: 9844
SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 985035
SOME VEHICLES (BUILT AFTER 1/5/98) AND ALL VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE AND 4R100 TRANSMISSION MAY EXHIBIT A RATTLE / SCRAPPING NOISE IN THE CONVERTER HOUSING AREA OF THE CASE. *TT
Bulletin Number: 985097
SOME VEHICLES WITH 4WABS MAY HAVE AN AMBER ABS WARNING INDICATOR ILLUMINATED WITH CODE C1095 OR C1096 STORED IN MEMORY OF THE 4WABS MODULE. *TT
Bulletin Number: 98510
CONCERNS WITH NO TEMPERATURE CONTROL. *YC
Bulletin Number: 985102
SOME VEHICLES THAT ARE LOADED TO THE UPPER END OF GVW, WITH THE MAJORITY OF THE LOAD BETWEEN THE AXLES, MAY EXHIBIT INNER EDGE TIRE WEAR DUE TO INCORRECT ALIGNMENT. *TT
Bulletin Number: 985143
SOME VEHICLES WITH 4R70W TRANSMISSIONS BUILT FROM 4/16/98 THROUGH THE END OF THE 1998 MODEL YEAR MAY EXHIBIT A LEAK FROM THE VENT AREA OF THE TRANSMISSION. *TT
Bulletin Number: 985153
SOME VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT. *TT
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 9859
A HARD TO TURN IGNITION KEY, AND/OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 98710
A HARSH 1-2 SHIFT WHILE DRIVING UNDER LIGHT THROTTLE CONDITIONS. *YC
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 9878
SIGNIFICANT CHANGES HAVE BEEN MADE TO THE 7.3L DIT ENGINE EFFECTIVE WITH THE 1998 AND 1999 MODEL YEARS. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 99132
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH A FALSE DIAGNOSTIC TROUBLE CODE (DTC) P1298 (INJECTOR DRIVE MODULE (IDM) FAILURE). *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99141
SUBJECT REGARDING A HIGH NUMBER OF BALL JOINTS BEING REPLACED AS THE RESULT OF ROUTINE INSPECTIONS OR OF COMPLAINTS OF TIRE WEAR AND LOOSE FEELINGS IN THE STEERING SYSTEM. *TT
Bulletin Number: 99141
COMPLAINTS OF TIRE WEAR AND LOOSE FEELINGS IN THE STEERING SYSTEM. *TT
Bulletin Number: 991411
SOME VEHICLES MAY EXHIBIT A CRACK ON THE RIGHT REAR SIDE OF THE #1 CROSSMEMBER RESULTING IN A CREAKING NOISE WHILE TURNING THE WHEEL OR DRIVING OVER UNEVEN SURFACES. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99164
CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER. *TT
Bulletin Number: 991811
SUBJECT REGARDING FRONT PASSENGER SIDE STEPWELL COVER NOT FLUSH. *TT
Bulletin Number: 99185
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 992311
EXPERIENCING INTERMITTENT OR LOW RANGE OF THE REMOTE KEYLESS ENTRY (RKE) SYSTEM. *TT
Bulletin Number: 99236
SUBJECT REGARDING 4R100 TRANSMISSION FLEXPLATE REPLACEMENT FOR VEHICLES WITH 7.3L DIESEL ENGINE. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 996034
EXPERIENCING A ENGINE KNOCK AT COLD START-UP. *TT
Bulletin Number: 996835
INFORMATION ON DIAGNOSING VEHICLES WITH 4R100 TRANSMISSIONS EXHIBITING TURBINE SHAFT SPEED (TSS) SENSOR DIAGNOSTIC TROUBLE CODES P0715 / 0717 / 0718. *TT
Bulletin Number: 996890
SOME VEHICLES WITH AN ILLUMINATED AIR BAG LAMP MAY HAVE MODIFIED SEAT CONFIGURATIONS WHICH MAY HAVE BEEN CHANGED BY MODIFIERS OR THE CUSTOMER. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: 9996
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT
Bulletin Number: 9997
SOME VEHICLES MAY EXHIBIT A "SQUEAKING" OR "MOANING" NOISE FROM THE STEERING COLUMN WHILE TURNING. *TT
Bulletin Number: 99E03
EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT
Bulletin Number: DOR-X8B9R-11
This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly ma
1998 FORD ESCORT
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 0059
SUBJECT CONCERNING THE IDLE-VIBRATION- 2.0L AND ZETEC ENGINES- SERVICE TIP. *MJS
Bulletin Number: 0069
SOME VEHICLES MAY EXHIBIT A GRINDING NOISE WHILE BRAKING, BRAKE DRAG AND/OR UNEVEN FRONT BRAKE PAD WEAR MAY OCCUR. *MJS
Bulletin Number: 00E11
SERVICE ACTION BULLETIN REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
Bulletin Number: 00E11
SERVICE ACTION 00E11, SUPPLEMENT #1 - UPDATE INFORMATION REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 020901
ROUGH IDLE, LOW POWER AND / OR STALL AT IDLE, A MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0300 THROUGH P0304 STORED IN MEMORY. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH
Bulletin Number: 0245
INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT
Bulletin Number: 0291
SOME VEHICLES EQUIPPED WITH THE 2.0L SPI ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND DIAGNOSTIC TROUBLE CODES (DTC) P0300 THROUGH P0304 STORED. *TT
Bulletin Number: 031515
IDLE VIBRATION ON VEHICLES EQUIPPED WITH 2.0L SPI OR ZETEC ENGINE ONLY. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04V09
TRW VEHICLE SAFETY SYSTEMS, INC. IS RECALLING CERTAIN SERVICE REPLACEMENT SEATBELT RETRACTORS (DRIVER'S SIDE FRONT RETRACTOR IN GRAY) MANUFACTURED IN DECEMBER 2002 AND SOLD AS A SERVICE REPLACEMENT PART BETWEEN DECEMBER 2002 AND JULY 2004.
Bulletin Number: 090308
MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455
Bulletin Number: 11502
SOME VEHICLES MAY EXHIBIT AN OIL LEAK, MOST NOTICEABLE AT COLD AMBIENT TEMPERATURES. *TT
Bulletin Number: 11518
SOME VEHICLES MAY EXHIBIT CONCERNS CREATED BY WATER INGESTION INTO THE INTEGRATED RELAY CONTROL MODULE (IRCM). *TT
Bulletin Number: 11526
THE WORKSHOP MANUAL REFERENCE TO TRANSMISSION FLUID TEMPERATURE SENSOR RESISTANCE IS INCORRECT. THIS BULLETIN LIST THE CORRECT RESISTANCE. *TT
Bulletin Number: 11769
SOME VEHICLES MAY EXHIBIT BRIEF SPARK KNOCK ON ACCELERATION DURING HOT WEATHER ONCE THE ENGINE HAS THOROUGHLY WARMED UP. *TT
Bulletin Number: 12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
Bulletin Number: 12215
SOME VEHICLES MAY EXHIBIT AN ENGINE IDLE VIBRATION CONCERN WHILE IN GEAR AND LOADED (A/C ON, HEADLIGHTS ON, AND / OR REAR DEFROSTER ON). *TT
Bulletin Number: 12216
THIS BULLETIN MENTIONS THAT FOR ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12241
SOME VEHICLES MAY EXHIBIT A CLICK SOUND WHEN APPLY THE BRAKES WHILE CHANING DIRECTIONS. ENGINEERING IS INVESTIGATING THIS CONCERN. *TT
Bulletin Number: 12294
SUBJECT REGARDING THE NGS FUEL ECONOMY TEST. *TT
Bulletin Number: 12295
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON, STALL AT TIP-IN FROM IDLE, ENGINE HESITATION, AND / OR SURGE CAUSED BY THE MASS AIR FLOW (MAF) SENSOR. *TT
Bulletin Number: 12547
COMPLAINTS THAT FUEL FILL NOZZLE CLICKS OFF OR DIFFICULTY ADDING FUEL. *TT
Bulletin Number: 12594
SOME VEHICLES MAY EXHIBIT TRANSMISSION AND / OR MALFUNCTION INDICATOR LAMP ON CONCERNS RELATING TO THE DIAGNOSIS AND REPLACEMENT OF THE TRANSMISSION RANGE SENSOR (TR). *TT
Bulletin Number: 12597
INFORMATION ON INSTALLING FUSES AT PRE-DELIVERY. *TT
Bulletin Number: 12701
THIS BULLETIN ADDRESSES CONCERNS WITH THE TRANSMISSION RANGE SENSOR. *TT
Bulletin Number: 12834
BRIEF INFORMATION REGARDING TRANSMISSION FLUID. *TT
Bulletin Number: 12846
SUBJECT ON INSTALLING FUSES AT PDI (PRE-DELIVERY INSPECTION). *TT
Bulletin Number: 12892
EXPERIENCING TAPE DECK NOISE. *TT
Bulletin Number: 13107
CONCERNS WITH LACK OF HEAT / THERMOSTAT CONTAMINATION. *TT
Bulletin Number: 13160
VEHICLES MAY EXHIBIT TRANSMISSION AND / OR MALFUNCTION INDICATOR LAMP ON CONCERNS RELATING TO THE DIAGNOSIS AND REPLACEMENT OF THE TRANSMISSION RANGER SENSOR (TRS). *TT
Bulletin Number: 13162
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LIGHT ON WITH A DIAGNOSTIC TROUBLE CODE P1744. *TT
Bulletin Number: 13214
INFORMATION REGARDING BRAKE CALIPER PIN CORROSION. *MJS
Bulletin Number: 13249
SOME VEHICLES MAY EXHIBIT A CONDITION OF THE MALFUNCTION INDICATOR LAMP LIGHT ON AND DIAGNOSTIC TROUBLE CODE P0455 IN MEMORY. *TT
Bulletin Number: 13296
SOME VEHICLES EQUIPPED WITH THE 2.0L SPI ENGINE, WITH MANUAL OR AUTOMATIC TRANSMISSION, MAY EXHIBIT AN RPM FLUCTUATION (IDLE ROLLL) OR POSSIBLE STALL AT IDLE. *TT
Bulletin Number: 13355
INFORMATION REGARDING A/C PEANUT O-RING COLOR. *TT
Bulletin Number: 13421
SOME VEHICLES MAY EXHIBIT GRINDING NOISES, OR GREATER THAN NORMAL BRAKE ROUGHNESS WHEN APPLYING THE BRAKES IMMEDIATELY AFTER INSTALLING MOTORCRAFT BR-18 FRONT BRAKE PAD. *TT
Bulletin Number: 13494
SOME VEHICLES WITH THE 2.0L SPI ENGINE MAY EXHIBIT A LACK OF HEAT AND TEMPERATURE GAUGE READING COLD. *TT
Bulletin Number: 14379
VEHICLES MAY EXPERIENCE INOPERATIVE OR INCORRECT A/C OPERATION AFTER REPLACING THE CCRM. *JB
Bulletin Number: 14846
SOME VEHICLES WITH 2.0L SPI ENGINE ONLY, MAY EXHIBITA BURNING OIL SMELL NOTED FROM OUTSIDE OR FROM WITHIN THE PASSENGER COMPARTMENT. *TT
Bulletin Number: 14993
SOME VEHICLES PRODUCED THROUGH JULY 1999 MAY EXHIBIT REAR SUSPENSION SPRING FAILURE WITH NO RESULTING OPERATIONAL CONCERN. *TT
Bulletin Number: 5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
Bulletin Number: 5260
BRIEF INFORMATION CONCERN IDLE VIBRATION (TYPICALLY IN GEAR) FELT THRU THE STEERING WHEEL AND / OR BODY. *TT
Bulletin Number: 5264
INFORMATION CONCERNING CLICK NOISE FROM FRONT CALIPERS DURING BRAKE APPLICATION. *TT
Bulletin Number: 5294
INFORMATION CONCERNING VEHICLES EXPERIENCING AN ENGINE IDLE VIBRATION WHILE IN GEAR AND LOADED (A/C ON, HEADLIGHTS ON, AND / OR REAR DEFROSTER ON). *TT
Bulletin Number: 5309
INFORMATION REGARDING VEHICLES EXHIBITING A CLICK SOUND WHEN APPLYING THE BRAKES WHILE CHANGING DIRECTION. *TT
Bulletin Number: 5381
BRIEF INFORMATION STATING THAT THE NGS FUEL ECONOMY TEST ON SOME VEHICLES MAY NOT FUNCTION PROPERLY. *TT
Bulletin Number: 5963
INFORMATION ON INSTALLING FUSES AT PRE-DELIVERY. *TT
Bulletin Number: 6416
BRIEF INFORMATION REGARDING TRANSMISSION FLUID APPEARANCE. *TT
Bulletin Number: 6503
SOME VEHICLES MAY EXIBIT ICP (RADIO) CONCERNS OF NOISES COMING FROM THE TAPE DECK. *TT
Bulletin Number: 6932
SOME VEHICLES MAY EXHIBIT TRANSMISSION AND / OR MIL ON CONCERNS RELATING TO THE DIAGNOSIS AND REPLACEMENT OF THE TRANSMISSION RANGE SENSOR. *TT
Bulletin Number: 6934
CONCERNS WITH A MALFUNCTION INDICATOR LIGHT ON WITH A DIAGNOSTIC TROUBLE CODE P1744. *TT
Bulletin Number: 7076
INFORMATION REGARDING BRAKE CALIPER PIN CORROSION. *MJS
Bulletin Number: 7131
SOME VEHICLES MAY EXHIBIT A CONDITION OF THE MALFUNCTION INDICATOR LIGHT ON AND DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSION) IN MEMORY. *TT
Bulletin Number: 7235
VEHICLES EQUIPPED WITH THE 2.0L SPI ENGINE WITH MANUAL OR AUTOMATIC TRANSMISSION MAY EXHIBIT AN RPM FLUCTUATION (IDLE ROLL) OR POSSIBLE STALL AT IDLE. *TT
Bulletin Number: 7249
INFORMATION ON USING PEANUT STYLE A/C FITTINGS. *TT
Bulletin Number: 7292
NNERS OF THE EDSR-OF-THE-MONTH QUALITY AWARD ANNOUNCEMENT FOR SEPTEMBER. *TT
Bulletin Number: 7369
SOME VEHICLES MAY EXHIBIT GRINDING NOISE, OR GREATER THAN NORMAL BRAKE ROUGHNESS, WHEN APPLYING THE BRAKES IMMEDIATELY AFTER INSTALLING MOTORCRAFT FRONT BRAKE PAD PART NUMBER BR-18 (XU2Z-2V001-RA). *T
Bulletin Number: 8316
SOME VEHICLES EQUIPPED WITH COMPACT DISC CHANGER MAY EXHIBIT A 6 DISC CD CHANGER THAT IS NOT EJECTING THE MAGAZINE OR IS NOT RESPONDING TO COMMAND FROM THE RADIO.
Bulletin Number: 976011
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 9811345
ENGINEERING IS INVESTGATING VEHICLES EXHIBITING A CONDITION IN WHICH THE IGNITION KEY IS DIFFICULT TO TURN AND / OR DIFFICULT TO REMOVE THE FROM THE SWITCH. *TT
Bulletin Number: 9811473
SOME VEHICLES MAY EXHIBIT A CUSTOME CONCERN OF STEADY OR INTERMITTENT MISS WITH DIAGNOSTIC TROUBLE CODES P0300 AND P0304. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK
Bulletin Number: 9819
SOME VEHICLES MAY EXHIBIT INTERMITTENT OPERATION OR INOPERATIVE INTERIOR DOME LAMP. *TT
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 982017
EXPERIENCING " SQUEAKING " AND / OR " RATTLING " NOISES MAY OCCUR DURING DIFFERENT DRIVING CHARACTERISTICS AND FROM VARYING POINTS ON THE VEHICLE. *YC
Bulletin Number: 98203
CONCERNS WITH ADHENSIVES NOT RECOMMENDED FOR BODY PANEL REPAIRS. *YC
Bulletin Number: 98203
CONCERNS WITH THE POTENTIAL EFFECTS OF ADHESIVES USED FOR BODY PANEL REPAIRS. *TT
Bulletin Number: 98204
A PORTION OF FOAM TAPE AT THE WINDSHIELD AND INSTRUMENT PANEL (I/P) MAY BE STICKING OUT ON SOME VEHICLES. *YC
Bulletin Number: 982113
AN ERRATIC SHIFT WITH DIAGNOSTIC TROUBLE CODE (DTC) P0712. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982471
SOME VEHICLES MAY EXHIBIT AN OIL LEAK. *AK
Bulletin Number: 982517
CONCERNS WITH THE REAR HATCH DOESNT UNLOCK WHEN USING THE DOOR PANEL SWITCH AND/OR THE ALARM SOUNDS INADVERTENTLY IF THE REAR HATCH DOOR IS UNLOCKED USING THE " TRUNK " BUTTON ON THE KEY FOB ON SOME VEHICLES. *YC
Bulletin Number: 982520
EXPERIENCING WHISTLING / WIND NOISE HEARD AROUND BOTH OUTSIDE REAR VIEW MIRRORS. *YC
Bulletin Number: 982534
SOME VEHICLES MAY EXHIBIT A CUSTOMER CONCERN OF STEADY OR INTERMITTENT MISS WITH DTCS P0300 AND P0304. THIS MAY BE CAUSED BY A SPREAD ELECTRICAL TERMINAL IN CONNECTORS AT INJECTOR. REPAIR TERMINAL/CONNECTOR CONCERN BY USING A SMALL SCRE
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 983091
ENGINEERING IS INVESTIGATING AUTOMATIC TRANSMISSION OIL LEAK CONDITIONS ON SOME VEHICLES. *TT
Bulletin Number: 983092
ENGINEERING IS INVESTIGATING VEHICLES WHICH EXHIBIT A PULL TO THE RIGHT WHILE DRIVING CONDITION. *TT
Bulletin Number: 983092
EXHIBITING A "PULLS TO THE RIGHT WHILE DRIVING" CONDITION. *TT
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 983102
SOME VEHICLES MAY EXPERIENCE A SLOW ACCELERATION FROM A STOP. *TT
Bulletin Number: 983103
CONDITIONS WITH CARPET PULLING OUT FROM UNDERNEATH THE LEFT / RIGHT COWL SIDE TRIM PANEL. *TT
Bulletin Number: 983162
CONCERNS WITH PAINT STAINS ON THE HOOD WHICH MAY BE CAUSED BY WINDSHIELD WASHER SOLVENT LEAKING FROM THE WINDSHIELD WASHER JETS WHILE DRIVING. *TT
Bulletin Number: 983172
CONCERNS WITH SOME VEHICLES EXHIBITING BROKEN INTERIOR DOOR HANDLES. *TT
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 9842
EXPERIENCING A WHISTLING / WINDNOISE HEARD FROM AROUND THE OUTSIDE REAR VIEW MIRROR AREA DURING CERTAIN DRIVING CONDITIONS. *TT
Bulletin Number: 9844
SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9861
DIFFICULTIES REMOVING KEY FROM IGNITION ON SOME VEHICLES. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 9874
A NEW SILICONE GASKET AND SEALANT. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 9912701
ENGINEERING IS INVESTIGATING CONCERNS WITH VEHICLES EXHIBITING DIAGNOSTIC TROUBLE CODES PO705, PO708 OR P1705 (TRANSMISSION RANGE SENSOR).
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99195
SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
Bulletin Number: 99-3370
SUBLECT REGARDING THE VALVE BODY ON SOME VEHICLES WAS REVISED TO ELIMINATE THE OIL PIPE. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 996105
EXPERIENCING WINDNOISE FROM THE DOOR GLASS BELTLINE WEATHERSTRIP AREA. *TT
Bulletin Number: 996877
SOME VEHICLES EQUIPPED WITH 2.0L SPI ENGINE MAY EXHBIT A LACK OF HEAT AND TEMPERATURE GAUGE READING COLD. *TT
Bulletin Number: 99810
EXHIBITING A CLICKING NOISE HEARD WHILE APPLYING THE BRAKES AFTER CHANGING VEHICLE DIRECTION ON SOME VEHICLES. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
1998 FORD E SERIES
Bulletin Number: 01119
SOME VEHICLES WITH HIGH ODOMETER READING OR SEVERE SERVICE MAY EXHIBIT A CREAKING NOISE WHEN TURNING WHEEL OR DRIVING OVER UNEVEN SURFACES ON VEHICLES PRODUCE BEFORE 2/6/2001. *TT
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 012113
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL
Bulletin Number: 01214
INFORMATION TO AID IN DIAGNOSIS FOR CLARIFICATION OF LOCK-OFF SOLENOID AND SOLENOID TANK VALVE COIL RSISTANCES FOR BI-FUEL VEHICLES. *TT
Bulletin Number: 01221
SOME DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT A ROUGH IDLE, OR NO START IN COLD CONDITIONS. *TT
Bulletin Number: 01231
SOME COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT ROUGH IDLE OR NO START WHEN COLD. *TT
Bulletin Number: 01233
SOME DEDICATED AND BI-FUEL CNG VEHICLES MAY EXHIBIT A CONDITION OF FUEL LEAK OR FUEL ODOR AT THE CNG FUEL FILL VALVE AREA. *TT
Bulletin Number: 01234
SOME VEHICLES EQUIPPED WITH AFTERMARKET HIGH-CURRENT DEVICES MAY EXHIBIT DIAGNOSTIC TROUBLE CODES B1876, B1880, B1915 AND/OR B1920 AIRBAG ELECTRONIC CRASH SENSOR MODULE. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 020503
GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996. *TT UPDATE. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02168
REPORTS THAT CERTAIN VEHICLES APPEAR TO BE DOGTRACKING. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
Bulletin Number: 0245
INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT
Bulletin Number: 0253
SUBJECT REGARDING ALTERNATIVE FUEL VEHICLE COMPRESSED NATURAL GAS TANK INSPECTION. *TT
Bulletin Number: 030402
ON SOME DEDICATED CNG VEHICLES, A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE. REVISED SERVICE PARTS. *TT
Bulletin Number: 03102
COMPRESSED NATURAL GAS (CNG). ROUGH IDLE OR NO START WHEN COLD. VEHICLES EQUIPPED WITH CNG BI-FUEL ENGINE ONLY. *TT
Bulletin Number: 03103
VEHICLES WITHOUT THE COOLANT LOCK-OFF MAY EXHIBIT A NO START CONDITION. *TT
Bulletin Number: 03104
BI-FUEL LPG VEHICLES (WITH COOLANT LOCK OFF) MAY EXHIBIT A NO START CONDITION. *TT
Bulletin Number: 031404
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
Bulletin Number: 031410
TURBO PEDESTAL SEAL OIL LEAK AROUND THE EXHAUST BACK PRESSURE (EBP) ACTUATOR. 2003 SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03144
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03171
7.3L DIESEL HIGH PRESSURE OIL PUMP LEAK. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 03183
DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY. *TT
Bulletin Number: 03192
LEAK OIL AROUND THE EXHAUST BACKPRESSURE ACTUATOR (EBP) - 7.3L DIESEL TURBOCHARGER PEDESTALS. *TT
Bulletin Number: 03206
SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY. LOSS OF POWER AT HEAVY LOAD, DIAGNOSTIC TROUBLE CODES (DTCS) FOR LEAN FUEL, ROUGH IDLE, HARD START,
Bulletin Number: 032139
7.3L POWERSTROKE DIESEL ENGINE WITH ENGINE SERIAL NUMBER 661894 THROUGH 1311240 MAY EXHIBIT A KNOCK NOISE ABOVE THE NORMAL SOUND OF THE DIESEL COMBUSTION. THIS BULLETIN ALSO REPLACES 01146. *TT
Bulletin Number: 032145
EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT
Bulletin Number: 032150
HIGH PRESSURE OIL PUMP LEAK ON VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE. *TT
Bulletin Number: 032151
SOME 7.3L DIESEL TURBOCHARGER PEDESTALS MAY LEAK OIL AROUND THE EXHAUST BACK PRESSURE ACTUATOR (EBP). *TT THIS ARTICLE SUPERSEDES TSB 03-21-51 DATED 10/30/2003. *TT
Bulletin Number: 032306
DIAGNOSTIC TROUBLE CODE B1876, B1880, B1915 AND/OR B1920 IN THE ECS MODULE - VEHICLES EQUIPPED WITH AFTERMARKET HIGH CURRENT DEVICES. *TT
Bulletin Number: 03236
DIAGNOSTIC TROUBLE CODES (DTC) B1876, B1880, B1915 AND/OR B1920 AIRBAG ELECTRONIC CRASH SENSOR (ECS) MODULE ON VEHICLES EQUIPPED WITH AFTERMARKET HIGH CURRENT DEVICES. *TT
Bulletin Number: 03261
NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT
Bulletin Number: 0342
POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE, ON SOME DEDICATED CNG VEHICLES. *TT *JB
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04266
A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP. *TT
Bulletin Number: 05417
INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT
Bulletin Number: 07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
Bulletin Number: 11776
SOME VEHICLES WITH 7.3L DIT ENGINES MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
Bulletin Number: 11796
SOME VEHICLES MAY EXHIBIT POWER DOOR LOCKS THAT SELF ACTIVATE, ARE INOPERATIVE, OR REMOTE KEYLESS ENTRY INOPERATIVE DURING OR AFTER WET CONDITIONS. *TT
Bulletin Number: 12070
VEHICLES THAT ARE LOADED TO THE UPPER END OF FVW, WITH THE MAJORITY OF THE LOAD BETWEEN THE AXLES, MAY EXHIBIT INNER EDGE TIRE WEAR DUE TO INCORRECT ALIGNMENT. *MJS
Bulletin Number: 12123
VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT, DUE TO INCORRECT FRONT END ALIGNMENT SETTINGS. *MJS
Bulletin Number: 12134
INFORMATION REGARDING VEHICLES MODELS OF THE 4R100 THAT ARE ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *MJS
Bulletin Number: 12162
SOME VEHICLES EQUIPPED WITH 6.8L ENGINES, MAY EXHIBIT A CUSTOMER CONCERN OR ENGINE ROAR OR ENGINE NOISE FOR THE FIRST FEW MINUTES OF OPERATION AFTER A COLD START. *MJS
Bulletin Number: 12187
SOME VEHICLES MAY EXHIBIT A HARD TO DIAGNOSE SQUEAK/RATTLE NOISE CONCERN. *MJS
Bulletin Number: 12243
SOME VEHICLES WITH GAS ENGINES AND FACTORY INSTALLE DAUXILIARY BATTERY OPTION MAY EXPERIENCE CHARGING TROUBLES WITH THE AUXILIARY BATTERY. *TT
Bulletin Number: 12298
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. *TT
Bulletin Number: 12556
SUBJECT REGARDING TECHNICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES. *TT
Bulletin Number: 12560
BIEF INFORMATION REGARDING DIAGNOSTIC CODE RETRIVAL ON BI-FUEL VEHICLES. *TT
Bulletin Number: 12593
CONCERNS WITH CRACKS ON THE RIGHT REAR SIDE OF THE #1 FRAME CROSSMEMBER. *TT
Bulletin Number: 12741
SOME VEHICLES UNDER SEVERE DUTY CYCLES MAY EXHIBIT CRACKS ON THE LOWER RADIATOR SUPPORT. *TT
Bulletin Number: 12743
EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT
Bulletin Number: 12744
SOME VEHICLES MAY RETREIEVE MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0351 AND / OR P0357 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT
Bulletin Number: 12798
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 12870
SOME CUSTOMERS MAY COMMENT ON A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT
Bulletin Number: 12915
CUSTOMER MAY COMPLAIN OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT
Bulletin Number: 13117
SOME VEHICLES WITH AN ILLUMINATED AIR BAG LAMP MAY HAVE MODIFIED SEAT CONFIGURATIONS. *TT
Bulletin Number: 13285
EXPERIENCING ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 13322
SOME VEHICLES MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 13331
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 13398
SOME VEHICLES WITHOUT FRONT BRAKE DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS DUE TO DAMAGED INNER WHEEL BEARING SEALS. *TT
Bulletin Number: 13832
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT
Bulletin Number: 13870
CONCERNS WITH A NO START CONDITION AFTER INSTALLATION OF A NEW 6.8L ENGINE ASSEMBLY. *TT
Bulletin Number: 13934
SOME VEHICLES MAY EXHIBIT A-PILLAR SHEET METAL CRACKS AROUND FRONT DOOR HINGES; FRONT DOOR SKIN SEPARATES AND DOOR INNER SHEET METAL CRACKED AROUND FRONT HINGES; OR FRONT DOORS OPEN TOO FAR AND EXTEND INTO THE FRONT FENDERS. *TT
Bulletin Number: 14240
SOME VEHICLES MAY EXHIBIT A CLUNK THAT CAN BE FELT OR HEARD THROUGH THE STEERING WHEEL. THE CONDITION IS EXPERIENCED BEST IN A SLIGHT TURN, AT SPEEDS NEAR 20 MPH, ON ROAD SURFACES WITH SLIGHT IRREGULARITIES. ENGINEERING IS ADDRESSING T
Bulletin Number: 14374
SUBJECT REGARDING FRONT SUSPENSION INSPECTION PROCEDURES. *JB
Bulletin Number: 14455
OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT
Bulletin Number: 14514
SOME VEHICLES MAY EXHIBIT A CLUNK THAT CAN BE FELT OR HEARD THROUGH THE STEERING WHEEL. THE CONDITION IS BEST EXPERIENCED IN A SLIGHT TURN, NEAR 20 MPH, ON ROAD SURFACES WITH SLIGHT IRREGULARITIES. *TT
Bulletin Number: 14514
EXPERIENCING A CLUNKING TYPE NOISE THAT CAN BE FELT OR HEAR THROUGH THE STEERING WHEEL. CONDITION BEST EXPERIENCED IN A SLIGHT TURN, NEAR 20 MPH, ON ROAD SURFACES WITH SLIGHT IRREGULARITIES. *TT
Bulletin Number: 14735
SOME VANS / WAGONS WITH 138 INCH WHEELBASE AND 4R70W TRANSMISSION (DRIVE SHAFT >70 INCH) MAY EXHIBIT A VIBRATION BOOM UNDER HEAVY ACCELERATION (WOT) OR A LOADED DRIVE MODE. *TT
Bulletin Number: 14821
SOME VEHICLES EQUIPPED WITH 4.6L ROMEO ENGINE MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 14864
SUBJECT REGARDING CERTAIN VEHICLES WITH 4.6L ROMEO ENGINES EXHIBITING AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 14943
SOME VEHICLES MANUFACTURED AS INCOMPLETE VEHICLES (1FD IN THE FIRST THREE POSITIONS OF VIN) EQUIPPED WITH A POWER SEAT PEDESTAL (OPTION 21Z), BUT MANUFACTURED WITHOUT A SEAT, MAY HAVE A CONDITION OF REPEAT POWE SEAT TRACK FAILURE.
Bulletin Number: 15099
SOME VEHICLES MAY EXHIBIT DRIVELINE CLUNK / THUMP NOISE CONDITION ON INITIAL ACCELERATION FROM A STOP.
Bulletin Number: 15150
SOME E-SERIES EQUIPPED WITH AN RV MODIFIED POWER SEAT MAY EXHIBIT FAILURE OF THE POWER PEDESTAL MOTOR. *ET
Bulletin Number: 15161
SOME VEHICLES MAY EXHIBIT A FUEL LEAK AT CNG FILL VALVE. *YH
Bulletin Number: 15218
INFORMATION ON A REINFORCEMENT KIT FOR VEHICLES EXHIBITING FAILURE OF THE POWER SEAT PEDESTAL MOTOR. *TT
Bulletin Number: 15355
SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT
Bulletin Number: 15373
SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES. *TT
Bulletin Number: 15397
SOME VEHICLES MAY EXHIBIT A CONDITION OF OIL CONTAMINATION IN COOLING SYSTEM. *TT
Bulletin Number: 15761
SOME DEDICATED CNG VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS OF HARD START / NO START / ROUGH RUNNING. *TT
Bulletin Number: 15901
THIS BULLETIN STATES THAT SOME 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER OR LARGER KNOCK SENSOR THREADED HOLD THAN THE ONE IN THE ORIGINAL ENGINE ASSEMBLY. *TT
Bulletin Number: 16040
EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT
Bulletin Number: 16515
OIL LEAK AT HIGH PRESSURE PUMP FITTINGS AND/OR PLUG. THIS INCLUDES SUPER DUTY F-SERIES. OASIS. *TT
Bulletin Number: 16916
REPEATED BLOWN FUSES FOR REAR IN VEHICLE CIRCUITS WITH INOPERATIVE REAR BRAKE OR TAIL LAMPS. *TT
Bulletin Number: 17023
NO TURBINE SHAFT SPEED (TSS) DISPLAYED USING NGS OR WDS. *TT
Bulletin Number: 17254
CLICKING/POPPING NOISE FROM UPPER STEERING COLUMN AREA WHEN TURNING. 2004 E SERIES AND EXPLORER SPORT TRAC ALSO INCLUDED. *TT
Bulletin Number: 17320
BROKEN EXHAUST MANIFOLD STUDS. *TT
Bulletin Number: 17385
AIR BAG LAMP ILLUMINATED. *TT
Bulletin Number: 17777
REAR LEAF SPRING NOISE. *TT
Bulletin Number: 4658
SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
Bulletin Number: 4684
SOME VEHICLES MAY EXHIBIT POWER DOOR LOCKS THAT SELF ACTIVATE, ARE INOPERATIVE, OR REMOTE KEYLESS ENTRY INOPERATIVE DURING OR AFTER WET CONDITIONS. *TT
Bulletin Number: 4747
INFORMATION ON ADDITIONS TO THE FORD QUALITY RENEWAL ASSEMBLY PROGRAM.
Bulletin Number: 5225
INFORMATION ON VEHICLES EXHIBITING A HARD TO DIAGNOSE SQUEAK / RATTLE NOISE CONCERN. *TT
Bulletin Number: 5311
SOME VEHICLES WITH GAS ENGINES AND FACTORY INSTALLED AUXILIARY BATTERY OPTION MAY EXPERIENCE CHARGING TROUBLES WITH THE AUXILIARY BATTERY. *TT
Bulletin Number: 5890
INFORMATION ON RETRIEVING DIAGNOSTIC CODES FOR BASE ENGINE / GASOLINE FUEL SYSTEM OR THE ALTERNATE FUEL SYSTEM. *TT
Bulletin Number: 6290
INFORMATION REGARDING THE IMPROVED RADIATOR SUPPORT. *TT
Bulletin Number: 6350
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 6386
INFORMATION REGARDING THE AVAILABILITY OF ENGINE ASSEMBLY FOR VARIOUS VEHICLES. *TT
Bulletin Number: 6417
ADDRESSING TIRE BALANCE HINTS. *TT
Bulletin Number: 6461
CONCERNS OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *T
Bulletin Number: 6538
SOME VEHICLES BUILT BEFORE APRIL 1, 1999 MAY HAVE A CUSTOMER CONCERN OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT
Bulletin Number: 6599
SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY MAY EXHIBIT A CONCERN WITH THE AMOUNT OF SOUND, WHINE PRODUCED ABOVE 35 MPH.
Bulletin Number: 7310
SOME VEHICLES WITHOUT FRONT BRAKE DUST SHIELDS MAY EXHIBIT PREMATURE WEAR OF THE FRONT WHEEL BEARINGS DUE TO DAMAGED INNER WHEEL BEARING SEALS. *TT
Bulletin Number: 8058
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. **MR
Bulletin Number: 8058
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT
Bulletin Number: 8138
SOME VEHICLES MAY EXHIBIT A NO START CONDITION AFTER INSTALLATION OF A NEW 6.8L ENGINE ASSEMBLY. *TT
Bulletin Number: 8260
SOME VEHICLES MAY EXHIBIT A-PILLAR SHEET METAL CRACKS AROUND FRONT DOOR HINGES; FRONT DOOR SKIN SEPARATES AND DOOR INNER SHEET METAL CRACKED AROUND FRONT HINGES; OR FRONT DOORS OPEN TOO FAR AND EXTEND INTO THE FRONT FENDERS. *TT
Bulletin Number: 870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
Bulletin Number: 976007
BRIEF INFORMATION REGARDING CYLINDER HEAD TEMPERATURE (CHT) AND FAIL SAFE COOLING. *TT
Bulletin Number: 980307
CONDITIONS WITH PRESSURE BEING HIGHER/LOWER THAN EXPECTED. *YC
Bulletin Number: 982733
VEHICLES WITH THE E4OD ARE ADDED TO THE FQR ( FORD QUALITY RENEWAL ) ASSEMBLY PROGRAM. *YC
Bulletin Number: 985072
SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
Bulletin Number: 985153
SOME VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT. *TT
Bulletin Number: 985183
EFFECTIVE NOVEMBER 2, 1998 CERTAIN VEHICLES OF THE 4R100 ARE ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *TT
Bulletin Number: 985199
SOME VEHICLES EQUIPPED WITH 6.8L ENGINE, MAY EXHIBIT A CUSTOMER CONCERN OF ENGINE ROAR OR ENGINE NOISE FOR THE FIRST FEW MINUTES OF OPERATION AFTER A COLD START. *MJS
Bulletin Number: 98L18
SPECIAL FIELD ACTION 98L18-- STOP SALE DELIVERY HOLD-CERTAIN 1998 E-SEIES TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES- IMPORANT VEHICLE INFORMATION LABELS. *YC
Bulletin Number: 98L18S1
INFORMATION ON IMPORTANT VEHICLE INFORMATION LABELS. *TT
Bulletin Number: 991411
SOME VEHICLES MAY EXHIBIT A CRACK ON THE RIGHT REAR SIDE OF THE #1 CROSSMEMBER RESULTING IN A CREAKING NOISE WHILE TURNING THE WHEEL OR DRIVING OVER UNEVEN SURFACES. *TT
Bulletin Number: 996130
INFORMATION ON THE IMPROVED LOWER INTAKE MANIFOLD SIDE GASKETS. *TT
Bulletin Number: 996890
SOME VEHICLES WITH AN ILLUMINATED AIR BAG LAMP MAY HAVE MODIFIED SEAT CONFIGURATIONS WHICH MAY HAVE BEEN CHANGED BY MODIFIERS OR THE CUSTOMER. *TT
Bulletin Number: TSB-11-11-21
FORD: THE BLOWER MOTOR ON SOME VEHICLES ARE OPERATING EITHER INCORRECTLY OR NOT OPERATING OR JUST FUNCTIONING ON ONE SPEED. *PE
1998 FORD E-SERIES
Bulletin Number: 07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
Bulletin Number: TSB-11-11-21
FORD: THE BLOWER MOTOR ON SOME VEHICLES ARE OPERATING EITHER INCORRECTLY OR NOT OPERATING OR JUST FUNCTIONING ON ONE SPEED. *PE
1998 FORD E-SUPER DUTY
Bulletin Number: 6599
SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY MAY EXHIBIT A CONCERN WITH THE AMOUNT OF SOUND, WHINE PRODUCED ABOVE 35 MPH.
1998 FORD EXCURSION
Bulletin Number: 17467
ENGINE OR FUEL SYSTEM CONCERNS WHEN USING FUEL WITH GREATER THAN 5% BIODIESEL CONCENTRATION. *TT
Bulletin Number: 17571
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT
1998 FORD EXPEDITION
Bulletin Number: 00123
SOME VEHICLES MAY EXPERIENCE SPARK KNOCK DURING LIGHT-TO-MODERATE ACCELERATIONS. *TT
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 0017
SUBJECT ON THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODES MAY APPEAR. *MJS
Bulletin Number: 0018
VEHICLES EQUIPPED WITH ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) , MAY EXERIENCE THE BLOWER MOTOR STAYING ON HIGH AFTER DESIRED TEMPERATURE IS REACHED AND/ OR THE SYSTEM DOES NOT MAINTAIN SET TEMPERATURE. *MJS
Bulletin Number: 00189
CONCERNS WITH THE SIGNAL MIRROR REFLECTIVE SURFACE DETERIORATING OVER TIME, DEVELOPING DARK SPOTS DUE TO CHROME PLATING DELAMINATION. *JB
Bulletin Number: 00201
SOME VEHICLES MAY EXHIBIT HESITATION ON ACCELERATION OR WHILE TURNING. *JB
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 00261
SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES. *TT
Bulletin Number: 0038
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS
Bulletin Number: 01128
SOME VEHICLES MAY EXHIBIT A CHECK SUSPENSION LAMP ON WITH DIAGNOSTIC TROUBLE CODES B2140 OR C2140 EVEN AFTER THE AIR SUSPENSION SWITCH IN THE UPPER RH KICK PANEL HAS BEEN TURNED ON. *TT
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 012110
SOME VEHICLES EQUIPPED WITH THE ROMEO BUILT 4.6L 2V ENGINE MAY EXHIBIT AN ENGINE OIL LEAK OR OIL WEEPAGE FROM THE CYLINDER HEAD GASKET AT THE RIGHT HAND REAR OR THE LEFT HAND FRONT OF THE ENGINE. *TT
Bulletin Number: 012112
A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTE OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT
Bulletin Number: 012113
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL
Bulletin Number: 01215
A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTER OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 0142
SOME VEHICLES MAY EXHIBIT THE ENGINE OIL SENDING UNIT CONTACTING THE OIL DRIP SHIELD ATTACHED TO THE FRONT AXLE. *TT
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 0162
VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02193
DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ
Bulletin Number: 02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH
Bulletin Number: 0245
INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT
Bulletin Number: 030709
REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES. *TT
Bulletin Number: 031404
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
Bulletin Number: 03144
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 031513
TIE ROD END INSPECTION PROCEDURE. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 03610
TIE ROD END INSPECTION PROCEDURE. CANADA VEHICLES ONLY. *TT *JB
Bulletin Number: 0392
REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES. *TT
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 0399
TIE ROD END INSPECTION PROCEDURE. *TT
Bulletin Number: 041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 0454
AIR SUSPENSION COMPRESSOR NOISE. *TT
Bulletin Number: 0457
POP/THUMP NOISE AT END OF WINDOW MOVEMENT AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION. *TT
Bulletin Number: 04L19
CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE. *TT
Bulletin Number: 050618
REAR AXLE NOISE REPAIR. *SC
Bulletin Number: 05417
INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT
Bulletin Number: 0554
USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE. *TT
Bulletin Number: 05618
REAR AXLE NOISE REPAIR. *TT
Bulletin Number: 07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
Bulletin Number: 090308
MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455
Bulletin Number: 11530
WHEN DIAGNOSING CRANK / NO START ON CERTAIN VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT (PATS) CHECK THE CUSTOMERS KEY RING FOR ANY MAGNETIC OBJECTS LIKE THE MOBILE SPEEDPASS KEY WHICH MAY AFFECT THE SIGNAL TRANSMISSION BETWEEN THE PATS KEY A
Bulletin Number: 11781
INFORMATION ON SETTING THE CHECK ENGINE LIGHT AND SETTING DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK). *TT
Bulletin Number: 11783
SUBJECT REGARDING VEHICLES EQUIPPED WITH COMPACT DISC PLAYERS. *TT
Bulletin Number: 11806
SUBJECT REGARDING A MISSING RUBBER STOP BUMPER FROM THE PARKING BRAKE COTNROL. *TT
Bulletin Number: 12120
SOME VEHICLES WITH 4R700 TRANSMISSIONS BUILT FROM 4/16/98 THROUGH THE END OF THE 1998 MODEL YEAR MAY EXHIBIT A LEAK FROM THE VENT AREA OF THE TRANSMISSION. *TT
Bulletin Number: 12120
SOME VEHICLES WITH 4R70W TRANSMISSIONS BUILT FROM 4/16/98 THROUGH 10/30/98 MAY EXHIBIT A LEAK FROM THE VENT AREA OF THE TRANSMISSION. *MJS
Bulletin Number: 12134
INFORMATION REGARDING VEHICLES MODELS OF THE 4R100 THAT ARE ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *MJS
Bulletin Number: 12139
SOME VEHICLES EQUIPPED WITH 4.6L OR 6.8L ENGINES MAY EXHIBIT A COLD START ENGINE NOISE UNTIL WARMED UP. *MJS
Bulletin Number: 12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
Bulletin Number: 12170
INFORMATION CONCERNING THE OCTANE SHORTING BAR LOCATED ON THE PASSENGER SIDE OF ENGINE COMPARTMENT NEAR THE BULKHEAD IS NOT INTENDED TO BE FUNCTIONAL IN REDUCING DETONATION/SPARK KNOCK. *MJS
Bulletin Number: 12216
THIS BULLETIN MENTIONS THAT FOR ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12227
FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12282
SOME VEHICLES MAY EXHIBIT A REAR WIPER THAT DOES NOT FUNCTION PROPERLY (JAMMED). *TT
Bulletin Number: 12529
SOME VEHICLES MAY EXHIBIT AN AIR BAG LIGHT ON INTERMITTENTLY WITH DIAGNOSTIC TROUBLE CODE B1924. *TT
Bulletin Number: 12572
VEHICLES MAY EXHIBIT A HIGH SPEED DRIVELINE VIBRATION. *TT
Bulletin Number: 12591
SOME VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOANING NOISE. *TT
Bulletin Number: 12720
SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE FLEXIBLE RUBBER COOLANT HOSE. *TT
Bulletin Number: 12738
SOME VEHICLES MAY EXHIBIT A IDLE VIBRATION.
Bulletin Number: 12743
EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT
Bulletin Number: 12747
SOME VEHICLES MAY EXHIBIT INACCURATE COMPASS READINGS IF NOT SET AT PRE-DELIVERY INSPECTION (PDI). *TT
Bulletin Number: 12750
SOME VHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP WITH NO DIAGNOSTIC TROUBLE CODES (DTC). *TT
Bulletin Number: 12767
EXHIBITING A VIBRATION THAT MAY BE INTERPRETED AS AN NVH CONDITION. *TT
Bulletin Number: 12776
SOME VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP ON WITH NO DIAGNOSTIC TROUBLE CODES (DTC) DETECTED. *TT
Bulletin Number: 12796
ON SOME VEHICLES, THE DOOR TRIM PANELS MAY HAVE LOOSE OR BROKEN PULL HANDLES. *TT
Bulletin Number: 12797
ADDRESSING CONCERNS OF A LOW SPEED (UNDER 35 MPH) CLICKING NOISE CAUSED BY A CAGE NUT ROCKING ON THE COTTER PIN FOR THE FRONT AXLE HALF SHAFT SPINDLE. *TT
Bulletin Number: 12798
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 12905
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT
Bulletin Number: 12994
SUBJECT REGARDING A/C VACUUM RESERVOIR / CHECK VALVE LOCATION FOR THE AIR CONDITIONING SYSTEM. *TT
Bulletin Number: 13010
SOME VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AND AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOAN CONCERN. *TT
Bulletin Number: 13054
EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT
Bulletin Number: 13106
ON SOME VEHICLES THE FRONT BUMPERS MAY EXHIBIT RED STAINING (SPOTS) ON THE BUMER WING ENDS. *TT
Bulletin Number: 13158
SOME VEHICLES EQUIPPED WITH FOUR WHEEL AIR SUSPENSION MAY REQUIRE A RIDE HEIGHT ADJUSTMENT PROCEDURE BE PERFORMED BEFORE SETTING ALIGNMENT. *TT
Bulletin Number: 13187
INFORMATION REGARDING E40D/4R100 TRANSMISSION FLUID COOLER FLOW TEST SPECIFICATION. *MJS
Bulletin Number: 13285
EXPERIENCING ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 13322
SOME VEHICLES MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 13331
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 13342
VEHICLES WITH 2.4L, 4.6L, AND 5.4L ENGINES MAY EXHIBIT AN A/C MOAN AT IDLE. *TT
Bulletin Number: 13376
EXHIBITING AN INACCURATE COMPASS READINGS IF NOT SET AT PRE-DELIVERY INSPECTION (PDI). *TT
Bulletin Number: 13420
THIS BULLETIN MENTIONS THE WIRING SCHEMATIC FOR VEHICLES WITH HEATED SEATS WAS INADVERTENTLY OMITTED FROM THE ELECTRICAL VACCUM TROUBLESHOOTING MANUAL (EVTM). *TT
Bulletin Number: 13505
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
Bulletin Number: 13711
SUBJECT REGARDING THE SERVICING OF TRAILER HITCHES ON VEHICLES. *MJS
Bulletin Number: 13712
INFORMATION REGARDING VEHICLES THAT EXPERIENCE THE RADIOS THAT DISPLAY NO DJ-NO DISC OR CD WILL NOT EJECT. *MJS
Bulletin Number: 13744
SOME VEHICLES MAY EXHIBIT A BODY BOOM WHILE DRIVING HIGHWAY SPEEDS. *MJS
Bulletin Number: 13745
SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS
Bulletin Number: 13773
INFORMATION FOR COMPACT DISC PLAYER PROBLEMS, RADIO MAY DISPLAY NO DJ- NO DUSC OR CD WILL NOT EJECT. *MJS
Bulletin Number: 13825
SOME VEHICLES MAY EXHIBIT A FRONT WASHER OPERATING WITHOUT COMMAND. *MJS
Bulletin Number: 13832
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT
Bulletin Number: 13838
CONCERNS WITH VEHICLES EXHIBITING A WINDSHIELD CREAK / SQUEAK. *TT
Bulletin Number: 14197
SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION. *TT
Bulletin Number: 14359
SUBJECT PERTAINING TO AIR SUSPENSION LEAKS. *JB
Bulletin Number: 14365
THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT. *JB
Bulletin Number: 14372
INFORMATION ON IDLE VIBRATION OR ENGINE DROAN ON ACCELERATION. *JB
Bulletin Number: 14609
SUBJECT REGARDING HIGH IDLE AND/OR CHECK ENGINE LIGHT CONDITION. *JB
Bulletin Number: 14821
SOME VEHICLES EQUIPPED WITH 4.6L ROMEO ENGINE MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 14864
SUBJECT REGARDING CERTAIN VEHICLES WITH 4.6L ROMEO ENGINES EXHIBITING AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 14905
SOME VEHICLES MAY EXHIBIT AMBER ANTI-LOCK BRAKE SYSTEM (ABS) LAMP ON WITH UNDEFINED DIAGNOSTIC TROUBLE CODES (DTCS) STORED. *TT
Bulletin Number: 15011
EXHIBITING AN UNCOMMANDED SHIFT WHEEL LOW DURING LOW SPEED MANEUVERING. *TT
Bulletin Number: 15122
SOME VEHICLES MAY EXHIBIT A VIBRATION AT IDLE AND/OR ENGINE DROANING NOISE ON ACCELERATION FROM A STOP. *SLC
Bulletin Number: 15123
SOME VEHICLES MAY EXHIBIT A DRIVELINE VIBRATION AT SPEEDS BETWEEN 60-70 MPH. *SLC
Bulletin Number: 15152
SOME VEHICLES MAY EXHIBIT COURTESY RAIL LAMPS ABOVE THE 2ND ROW SEATS THAT DO NOT OPERATE PROPERLY OR CAUSE A BATTERY DRAW. *ET
Bulletin Number: 15225
SOME VEHICLES MAY EXHIBIT A DIFFICULT TO REMOVE WHEEL RIM CONDITION. *TT
Bulletin Number: 15362
SOME VEHICLES MAY EXHIBIT AIR SUSPENSION MALFUNCTION. *TT
Bulletin Number: 15480
SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION AND/OR PREMATURE SHUTOFF OF THE GAS PUMP WHEN THE VEHICLE IS BEING RE-FUELED. *TT
Bulletin Number: 15504
SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT
Bulletin Number: 15517
SUBJECT REGARDING EXAGGERATED ENGINE BRAKING ON DECELERATION. *YD
Bulletin Number: 15526
SUBJECT REGARDING INOPERATIVE RUNNING BOARD LIGHTS.*YD
Bulletin Number: 15528
SUBJECT REGARDING AIR SUSPENSION COMPRESSOR QUALITY. *YD
Bulletin Number: 15549
INFORMATION REGARDING POP/THUMP NOISE FROM POWER WINDOW. *YH
Bulletin Number: 15605
SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT
Bulletin Number: 15648
SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION AND/OR PREMATURE SHUTOFF OF THE GAS PUMP WHEN THE VEHICLE IS BEING REFUELED. *TT
Bulletin Number: 15651
SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN AIR LEAK AND/OR OVERNIGHT BLEED DOWN OF THE AIR SUSPENSION. *TT
Bulletin Number: 15692
SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT
Bulletin Number: 15708
SOME VEHICLES MAY EXHIBIT WHEELS THAT SEIZE TO THE HUBS AND ARE DIFFICULT TO REMOVE DURING SERVICE. *TT
Bulletin Number: 15727
SOME 4X2 VEHICLES EQUIPPED WITH P275/60/R17 CONTINENTAL GENERAL TIRES MAY EXHIBIT A HIGHWAY SPEED TIRE VIBRATION. *TT
Bulletin Number: 15749
SOME VEHICLES EQUIPPED WITH 4 WHEEL DRIVE MAY EXHIBIT A NOTCHY OR STICKING FEELING IN SLOW SPEED TURNS WITH NO EFFECT ON STEERING EFFORTS OR ASSIST WHILE IN THE AUTOMATIC 4X4 POSITION. *TT
Bulletin Number: 15794
SOME 4X2 VEHICLES EQUIPPED WITH P275/60/R17 CONTINENTAL-GENERAL TIRES MAY EXHIBIT A HIGHWAY SPEED TIRE VIBRATION. *TT
Bulletin Number: 15897
SUBJECT REGARDING DRIVELINE ANGLE-RELATED VIBRATION AT VARIOUS SPEEDS AND LOAD CONDITIONS. *TT
Bulletin Number: 15901
THIS BULLETIN STATES THAT SOME 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER OR LARGER KNOCK SENSOR THREADED HOLD THAN THE ONE IN THE ORIGINAL ENGINE ASSEMBLY. *TT
Bulletin Number: 15939
CONCERNS WITH SPEED BODY BOOM. *TT
Bulletin Number: 16015
SOME VEHICLES WITH AIR SUSPENSION MAY EXHIBIT AN INITIAL OR REPEAT COMPRESSOR DRYER FAILURE. *TT
Bulletin Number: 16683
FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB
Bulletin Number: 17320
BROKEN EXHAUST MANIFOLD STUDS. *TT
Bulletin Number: 17448
REMOTE OIL FILTER ADAPTOR REPLACEMENT - NEW SERVICE PART. *TT
Bulletin Number: 17459
COURTESY RAIL LAMPS DO NOT OPERATE CORRECTLY OR CAUSE A BATTERY DRAW. *TT
Bulletin Number: 4619
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT
Bulletin Number: 4626
INFORMATION ON VEHICLES EXHIBITING AND O/D OFF LAMP FLASHING WITH DIAGNOSTIC TROUBLE CODE 62 / 628 / 1728. *TT
Bulletin Number: 4628
SOME VEHICLES MAY EXHIBIT REAR AXLE NOISE. *TT
Bulletin Number: 4631
BRIEF INFORMATION ON VEHICLES EXHIBIT VIBRATION AT CRUISE OVER 50 MPH. *TT
Bulletin Number: 4638
MALFUNCTION INDICATOR LAMP ON, WITH P0300 - P0308 MISFIRE DIAGNOSTIC TROUBLE CODES WITH A 4.6L ENGINE. *TT
Bulletin Number: 4660
SUBJECT REGARDING THE NAGATIVE BATTERY TERMINAL COVER ON SOME VEHICLES. *TT
Bulletin Number: 4664
THIS BULLETIN STATES THAT FOR CERTAIN VEHICLES IT IS NOT POSSIBLE TO SET THE CHECK ENGINE LIGHT AND SET DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK) IF A CUSTOMER REFUELS THE VEHICLE WITH THE ENGINE RUNNING. *
Bulletin Number: 4666
VEHICLES BUILT FROM 5/15/98 THROUGH 7/24/98 THAT ARE EQUIPPED WITH COMPACT DISC PLAYERS SHOULD HAVE THE YELLOW SHIPPING CLIP ON THE COMPACT DISC MAGAZINE REMOVED PRIOR TO VEHICLE DELIVERY. *TT
Bulletin Number: 4694
SOME FACTURY INSTALLED CD CHANGERS MAY HAVE REVISED SHIPPING LOCATIONS FOR THE CD MAGAZINE. *TT
Bulletin Number: 4698
ON SOME VEHICLES, THE RUBBER STOP BUMPER MAY BE MISSING FROM THE PARKING BRAKE CONTROL, A REPLACEMENT SERVICE PART IS NOW AVAILABLE. *TT
Bulletin Number: 4802
REAR WIPER ARM INSTALLATION. *TT
Bulletin Number: 4981
SOME VEHICLES EQUIPPED WITH 5.4L ENGINES MAY EXHIBIT A COLD START ENGINE KNOCK CONCERN UNTIL WARMED UP. *TT
Bulletin Number: 5128
SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. ENGINEERING IS INVESTIGATING. *TT
Bulletin Number: 5206
FOR CERTAIN VEHICLES THE OCTANE SHORTING BAR LOCATED ON THE PASSENGER SIDE OF ENGINE COMPARTMENT NEAR THE BULKHEAD IS NOT INTENDED TO BE FUNCTIONAL IN REDUCING DETONATION / SPARK KNOCK. *TT
Bulletin Number: 5257
INFORMATION ON VEHICLES EXHIBITING COLD ENGINE KNOCK. *TT
Bulletin Number: 5258
INFORMATION ON VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. *TT
Bulletin Number: 5370
SOME VEHICLES MAY EXHIBIT A REAR WIPER THAT DOES NOT FUNCTION PROPERLY (JAMMED). *TT
Bulletin Number: 5852
VEHICLES EXHIBITING INTERMITTENT ILLUMINATION OF AIR BAG LIGHT WITH DIAGNOSTIC TROUBLE CODE B1924. *TT
Bulletin Number: 6232
SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE COIL RESULTING IN ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE P0304 AND / OR ROUGH IDLE. *TT
Bulletin Number: 6282
INFORMATION ON SETTING COMPASS MODULE AT PRE-DELIVERY. *TT
Bulletin Number: 6287
SOME VEHICLES MAY EXPERIENCE AN IDLE VIBRATION. *TT
Bulletin Number: 6315
VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP WITH NO DIAGNOSTIC TROUBLE CODE (DTC) DETECTED. *TT
Bulletin Number: 6332
CONDITIONS WITH DOOR TRIM PANEL HAVING LOOSE OR BROKEN PULL HANDLES. *TT
Bulletin Number: 6350
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 6556
EXHIBITING JERKY OR UNEVEN WINDSHIELD WIPER ARM MOVEMENT. *TT
Bulletin Number: 6640
EXHIBITING AN AIR BAG LAMP ON INTERMITTENTLY WITH LAMP FAULT CODE (LFC) 24, OR DIAGNOSTIC TROUBLE CODE B1924 AND / OR B1342 STORED IN MEMORY. *TT
Bulletin Number: 6686
SUBJECT REGARDING AIR CONDITIONER VACUUM RESERVOIR / CHECK VALVE LOCATION. *TT
Bulletin Number: 6702
VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AND AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOAN CONCERN. *TT
Bulletin Number: 6905
INFORMATION ON REMOVING AND / OR REPLACING THE GENERIC ELECTRONIC MODULE (GEM). *TT
Bulletin Number: 6930
SUBJECT REGARDING VEHICLES WITH FOUR WHEEL AIR SUSPENSION MAY REQUIRE A RIDE HEIGHT ADJUSTMENT PROCEDURE PERFORMED BEFORE SETTING ALIGNMENT. *TT
Bulletin Number: 6999
SUBJECT REGARDING E40D / 4R100 TRANSMISSION FLUID COOLER FLOW TEST SPECIFICATION. *TT
Bulletin Number: 7100
INFORMATION REGARDING TRANSMISSION TROUBLE CODES. *MJS
Bulletin Number: 7155
VEHICLES EQUIPPED WITH WINDSOR ENGINES ONLY MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 7194
SUBJECT REGARDING FORD QUALITY RENEWAL (FQR) ASSEMBLY LAUNCH OF 4.6L 2V ENGINE. *TT
Bulletin Number: 7353
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT
Bulletin Number: 7363
THIS BULLETINS STATES THAT THE WIRING SCHEMATIC FOR THE HEATED SEATS WAS INADVERTENTLY OMITTED FROM THE ELECTRICAL VACUUM TROUBLESHOOTING MANUAL (EVTM). REFER TO EVTM PAGES 119-1 AND 119-2 FOR THE SCHEMATICS. *TT
Bulletin Number: 7823
EXPEDITION AND NAVIGATORS EQUIPPED WITH FOUR WHEEL AIR SUSPENSION MAY REQUIRE A RIDE HEIGHT ADJUSTMENT PROCEDURE BE PERFORMED, BEFORE SETTING ALIGNMENT. WHEN ADJUSTING RIDE HEIGHT REFERENCE THE 1990 EXPEDITION AND NAVIGATOR WORKSHOP MANUAL
Bulletin Number: 7896
SERVICING TRAILER HITCH.
Bulletin Number: 7929
DIAGNOSTIC INFORMATION FOR COMPACT DISC PLAYER PROBLEMS.
Bulletin Number: 8051
SOME VEHICLES MAY EXHIBIT A FRONT WASHER OPERATING WITHOUT COMMAND. *TT
Bulletin Number: 8058
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT
Bulletin Number: 8058
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. **MR
Bulletin Number: 8163
SOME VEHICLES WITH 4.6L, OR 6.8L ENGINES MAY EXHIBIT A ROLLER FINGER FOLLOWER COMING OFF DURING ENGINE CRANKING IN COLD TEMPERATURES BELOW ZERO DEGREES F. A ONE-TIME NOISE FROM THE ENGINE MAY BE HEARD, FOLLOWED BY ROUGH RUNNING / MISSES
Bulletin Number: 97090297183
EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC
Bulletin Number: 976007
BRIEF INFORMATION REGARDING CYLINDER HEAD TEMPERATURE (CHT) AND FAIL SAFE COOLING. *TT
Bulletin Number: 976011
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 98021698312
SOME COMPONENTS OF THE FRAME MAY REQUIRE SERVICING DUE TO COLLISION DAMAGE. *YC
Bulletin Number: 980310
EXPERIENCING VIBRATION AT CRUISE OVER 50 MPH. *YC
Bulletin Number: 980317
SYMPTOMS REGARDING P0300-P0308 MISFIRE DTCS WITH 4.6L ENGINES. *YC
Bulletin Number: 9810569
CONCERNS OF SQUEAKY / NOISY PITMAN ARM. *YC
Bulletin Number: 98110
SUBJECT REGARDING PASSIVE ANTI THEFT SYSTEM (PATS) DIAGNOSTIC SERVICE TIPS. *TT
Bulletin Number: 9811264
CONCERNS WITH TICKING NOISE ON INITIAL COLD START-UP IN PARK AND NEUTRAL POSITION. *TT
Bulletin Number: 98113
SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT
Bulletin Number: 9811342
INFORMATION ON REMOVING THE RADIO CHASSIS FROM SOME VEHICLES. *TT
Bulletin Number: 9811344
SOME VEHICLES MAY EXHIBIT LOOSE LUGNUTS AND / OR BROKEN WHEEL STUDS. *TT
Bulletin Number: 98123
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT
Bulletin Number: 98130
SERVICE PROCEDURE FOR ORANGE SERVICE TAGGED TRANSMISSIONS. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK
Bulletin Number: 981515
A CLUNKING NOISE HEARD FROM FRONT ENDCAUSED BY FRONT STABILIZER BAR CONTACTING THE FRAME. *AK
Bulletin Number: 981612
FUEL MAY LEAK FROM THE SPRING LOCK COUPLINGS. YD
Bulletin Number: 981613
TRANSMISSION FLUID LEAKS AT RADIATOR. YD
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 98168
TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD
Bulletin Number: 98169
STEERING -ALIGNMENT-TOE SET PROCEDURE SERVICE TIP. YD
Bulletin Number: 9818
FUEL PUMP REPLACEMENT PROCEDURE - SERVICE TIP. *TT
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 982019
CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR. *YC
Bulletin Number: 98203
CONCERNS WITH ADHENSIVES NOT RECOMMENDED FOR BODY PANEL REPAIRS. *YC
Bulletin Number: 98203
CONCERNS WITH THE POTENTIAL EFFECTS OF ADHESIVES USED FOR BODY PANEL REPAIRS. *TT
Bulletin Number: 98209
A " TICKING " NOISE ON INITIAL STARTUP WITH SHIFT SELECTOR IN " P " OR " N " POSITION MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 982110
DURING HIGH IDLE SPEEDS THROTTLE STICKS AFTER STEADY STATE DRIVING IN COLD AMBIENT TEMPERATURES. *YC
Bulletin Number: 982117
A NEW PARKING BRAKE CONTROL RUBBER BUMPER STOP IS NOW AVAILABLE FOR SERVICE. *YC
Bulletin Number: 982312
ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 982325
THE MALFUCNTION INDICATOR LAMP ( MIL ) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0455 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 98239
EXPERIENCING NO OR INTERMITTENT AUXILLARY A/C MODE / BLOWER CONTROL ON SOME VEHICLES. *YC8
Bulletin Number: 98241
DIAGNOSTIC SERVICE TIPS ON PASSIVE ANTI THEFT SYSTEM ( PATS ). *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982521
CONCERNS OF BREAKAGE OF THE EXHAUST SYSTEM BETWEEN THE MUFFLER AND TAILPIPE MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 98254
SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN INTERMITTENT CHECK SUSPENSION LAMP ON AND DIAGNOSTIC TROUBLE CODE (DTC) C1770 AND/OR C1845 ILLUMINATED. *YC
Bulletin Number: 982548
BRIEF INFORMATION GIVING THE CORRECT PART NUMBER FOR TSB 98-3-12. *YC
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 982673
IF YOU ENCOUNTER A VEHICLE WITH A MISSING WHEEL HUB O-RING, DO NOT INSTALL A NEW O-RING. *YC
Bulletin Number: 982691
CONCERNS OF ENGINE CHECKLIGHT ON AND DTC P1506 ( IDLE AIR CONTROL OVER SPEED ERROR ) AND/OR FAST IDLE. *YC
Bulletin Number: 982733
VEHICLES WITH THE E4OD ARE ADDED TO THE FQR ( FORD QUALITY RENEWAL ) ASSEMBLY PROGRAM. *YC
Bulletin Number: 982741
SOME VEHICLES MAY EXHIBIT A LOW SPEED ( UNDER 35MPH ) CLICKING NOISE. THIS MAY BE CAUSED BY A CAGE NUT ROCKING ON THE COTTOR PIN FOR FRONT AXLE HALF SHAFT SPINDLE. *AK
Bulletin Number: 983074
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT
Bulletin Number: 983084
INFORMATION ON ADDING OR INSTALLING A PULLEY. *TT
Bulletin Number: 983093
SOME VEHICLES EXHIBITING INACCURATE COMPASS READINGS. *TT
Bulletin Number: 983170
CONCERNS WITH CODES P0500, P0503, P1501 OR P1503 WHICH MAY BE CAUSED MY A LOOSE SPEEDOMETER DRIVE GEAR. *TT
Bulletin Number: 983284
SOME VEHICLES MAY EXPERIENCE AN AUDIBLE 50 HZ BODY BOOM. *TT
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 983302
THIS BULLETIN MENTIONS HOW SOME HUB O-RINGS MAY BE CUT DURING THE INSTALLATION OF THE WHEELS. *TT
Bulletin Number: 983315
THE 4R100 TRANSMISSION WILL HAVE AN ORANGE "PRIOR TO REPAIR" TAG ON THE FLUID PAN. *TT
Bulletin Number: 983316
SOME CUSTOMER MAY COMPLAIN OF A TICKING NOISE ON INITIAL COLD START-UP IN PARK POSITION AND NEUTRAL POSITION. *TT
Bulletin Number: 983566
INFORMATION REGARDING PROGRAMMING / DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT
Bulletin Number: 983566
INFORMATION ON PROGRAMMING / DIAGNOSING ANY PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT
Bulletin Number: 98412
THE 4R70W TRANSMISSION INSTALLED IN SOME VEHICLES WILL HAVE AN ORANGE
Bulletin Number: 98419
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC
Bulletin Number: 98422
SERVICE PROCEDURE FOR ORANGE SERVICE TAGGED TRANSMISSIONS. *YC
Bulletin Number: 9844
SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 98-4725
VIBRATION AT CRUISE OVER 50 MPH. *AK
Bulletin Number: 98-4738
COLD ENGINE KNOCK 5.4L ACTION. *AK
Bulletin Number: 984802
WHEN INSTALLING A REAR WIPER ARM ON SOME VEHICLES, BE SURE TO FOLLOW THE PROCEDURE IN THE 1999 WORKSHOP MANUAL SECTION 501-16-92. *YC
Bulletin Number: 98-4802
INFORMATION ON PROCEDURES TO FOLLOW WHEN INSTALLING A REAR WIPER ARM. *TT
Bulletin Number: 98-4817
SOME 1997-1998 EXPLORER/MOUNTAINEER/EXPEDITION OR NAVIGATOR VEHICLES WITH 4-WD 4X4 SYSTEM MAY EXHIBIT BOTH
Bulletin Number: 985059
EXPERIENCING COLD ENGINE KNOCK (REPEAT / REVISED MESSAGE). *TT
Bulletin Number: 985062
SUBJECT REGARDING IDLE VIBRATION (REPEAT MESSAGE). *TT
Bulletin Number: 985063
SUBJECT REGARDING VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. (REPEAT MESSAGE). *TT
Bulletin Number: 985103
VEHIUCLES WITH 4.0L OHV/SOHC, 5.0L, 4.6L, 5.4L MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ON WITH EVAP SYSTEM DIAGNOSTIC TROUBLE CODES P1450, P0455, P0446. *TT
Bulletin Number: 985128
SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. *TT
Bulletin Number: 985143
SOME VEHICLES WITH 4R70W TRANSMISSIONS BUILT FROM 4/16/98 THROUGH THE END OF THE 1998 MODEL YEAR MAY EXHIBIT A LEAK FROM THE VENT AREA OF THE TRANSMISSION. *TT
Bulletin Number: 985183
EFFECTIVE NOVEMBER 2, 1998 CERTAIN VEHICLES OF THE 4R100 ARE ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *TT
Bulletin Number: 985185
COLD START ENGINE NOISE
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 9858
THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0503 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 986001
INFORMATION REGARDING PUBLICATION CD UPDATE. *AK
Bulletin Number: 9869
CONCERNS WITH HESITATION, STUMBLE, SURGE, MISS, ROUGH IDLE, STALL AT IDLE. *TT
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 9874
A NEW SILICONE GASKET AND SEALANT. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 98B33
OWNER NOTIFICATION FOR REPLACEMENT OF ENGINE CYLINDER HEADS. *TT
Bulletin Number: 98S14
SAFETY RECALL UPDATE TO REPLACE LOCKING LUG NUTS. *TT
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 9912778
INFORMATION REGARDING NEW SERVICE STEERING GEAR. *TT
Bulletin Number: 9912792
CONDITIONS ON BROKENT DOOR PULL HANDLES. *TT
Bulletin Number: 99128
SOME VEHICLES MAY EXHIBIT A WHISTLING NOISE WHILE DRIVING WITH A/C IN THE OFF POSITION AT SPEEDS ABOVE 64 KM/H (40 MPH). *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 991313
SUBJECT REGARDING ANTI-LOCK BRAKE LAMP ILLUMINATION, INCREASED BREAK PEDAL EFFORT AND / OR FALSE ANTI-LOCK BRAKE SYSTEM (ABS) CYCLING AT LOW SPEEDS. *TT
Bulletin Number: 9913138
INFORMATION ON REPLACING AND REMOVING THE GENERIC ELECTRONIC MODULE (GEM). *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99143
SOME 4X4 VEHICLES BUILT WITH CENTER DISCONNECT FRONT AXLES MAY EXHIBIT A MOANING NOISE FROM THE FRONT DIFFERENTIAL WHILE OPERATING IN 4X2 MODE. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99157
SOME VEHICLES MAY EXHIBIT VIBRATION, SHIMMY AND BODY BOOM AT SPEEDS ABOVE 72 KM/H (45 MPH). *TT
Bulletin Number: 99164
CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER. *TT
Bulletin Number: 99185
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99195
SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 99411
VEHICLES EXPERIENCING INCREASED BRAKE PEDAL EFFORT AND / OR FALSE ABS CYCLING AT LOW SPEEDS, OR ABS LAMP ILLUMINATION. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT
Bulletin Number: 99-4694
SUBJECT REGARDING VEHICLES WITH FACTORY INSTALLED CD CHANGERS HAVING REVISED SHIPPING LOCATIONS FOR THE CD MAGAZINE. *TT
Bulletin Number: 996034
EXPERIENCING A ENGINE KNOCK AT COLD START-UP. *TT
Bulletin Number: 996042
INFORMATION ON USING 1999 PROCEDURES MANUAL FOR SIDE MIRROR REPLACEMENT. *TT
Bulletin Number: 996113
EXPERIENCING FRONT DIFFERENTIAL NOISE. *TT
Bulletin Number: 996139
CONCERNS WITH FRONT DIFFERENTIAL NOISE. *TT
Bulletin Number: 996780
THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT
Bulletin Number: 996876
INFORMATION PERTAINING TO CONDITIONS WITH RED STAINING (SPOTS) ON THE FRONT BUMPER WING ENDS. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: 9996
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT
Bulletin Number: 99B02
INFORMATION ON REPLACING MULTIFUNCTION SWITCH. *TT
Bulletin Number: 99E03
EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT
1998 FORD EXPLORER
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 00201
SOME VEHICLES MAY EXHIBIT HESITATION ON ACCELERATION OR WHILE TURNING. *JB
Bulletin Number: 00213
SUBJECT REGARDING CLIMATE CONTROL - EATC - BLOWER MOTOR CONTROL SERVICE TIPS. *JB
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 00243
ON SOME VEHICLES, THE ACCELERATOR PEDAL BRACKET MAY BECOME LOOSE OR SEPARATED FROM THE DASH PANEL. THIS MAY BE CAUSED BY REPEATED EXCESSIVE FORCE ON THE ACCELERATOR PEDAL, RESULTING IN CRACKING OF THE DASH PANEL SHEET METAL AT THE ACCELER
Bulletin Number: 0036
VEHICLES MAY EXPERIENCE BUZZING AND OR GRINDING NOISE DURING 2-3 SHIFT- VEHICLES EQUIPPED WITH M50D TRANSMISSION AND BUILT BEFORE 11/1/99. *MJS
Bulletin Number: 0057
SOME VEHICLES MAY EXPERIENCE A SQUAWKING/EEKING NOISE THAT MAY BE HEARD FROM THE CLUTCH ON ACCELERATION FROM A STOP OR WHEN UNDER LOAD IN FIRST GEAR. *MJS
Bulletin Number: 0083
SOME VEHICLES EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A RUBBING NOISE DURING RIGHT HAND TURNS FROM THE REAR OF THE VEHICLE. **MR
Bulletin Number: 00E11
SERVICE ACTION 00E11, SUPPLEMENT #1 - UPDATE INFORMATION REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
Bulletin Number: 00E11
SERVICE ACTION BULLETIN REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
Bulletin Number: 00L09
SUBJECT PERTAINING TO SUPPLEMENTAL TIRE INFLATION LABEL. *JB
Bulletin Number: 00M12
FORD MOTOR COMPANY IS PROVIDING ADDITIONAL COVERAGE FOR THE 4.0L SOHC CAMSHAFT CHAIN TENSIONER AND LOWER INTAKE MANIFOLD GASKET. *TT
Bulletin Number: 00M12
SUBJECT REGARDING OWNER NOTIFICATION SUPPLLEMENTAL PROGRAM FOR VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES - CAMSHAFT CHAIN TENSIONER AND LOWER INTAKE MANIFOLD GASKET ADDITIONAL COVERAGE. *TT
Bulletin Number: 01114
SOME 4X4 VEHICLES MAY EXHIBIT A HIGH-PITCHED SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT AXLE AREA OF THE VEHICLE AT SPEEDS FROM 16 TO 64 KM/H (10 TO 40 MPH). *TT
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01197
SOME VEHICLES EQUIPPED WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / ONNECTING ROD BEARING KNOCK. *TT
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 012113
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 01411
HIGH-PITCHED FRONT AXLE SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT OF THE VEHICLE AT SPEEDS FROM 16 TO 64 KM/H (10 TO 40 MPH). *TT
Bulletin Number: 0154
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) ACCOMPANIED BY A DIAGNOSTIC TROUBLE CODE (DTC) P0741 AND IN SOME CASES P1728. *TT
Bulletin Number: 0162
VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT
Bulletin Number: 0186
ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT
Bulletin Number: 01B77
OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT
Bulletin Number: 01M01
SUBJECT REGARDING OWNER NOTIFICATION PROGRAM 01M01 REGARDING ADDITIONAL COVERAGE FOR FRONT CAM CHAIN GUIDE ASSEMBLY. *TT
Bulletin Number: 01M01
SUBJECT REGARDING ADDITIONAL COVERAGE ON THE FRONT CAM CHAIN GUIDE ASSEMBLY FOR RENTAL VEHICLES WITH 4.0L SINGLE OVERHEAD CAM (SOHC) ENGINES. *TT
Bulletin Number: 01M01
OWNER NOTIFICATION PROGRAM REGARDING ADDITIONAL COVERAGE PROGRAM FOR FRONT CAM CHAIN GUIDE ASSEMBLY WHICH MAY WEAR OR BREAK AND CAUSE EXCESSIVE CAM CHAIN NOISE THAT DOES NOT GO AWAY AFTER FIVE MINUTES OF ENGINE OPERATION. *TT
Bulletin Number: 01M01
SUBJECT REGARDING ADVANCE NOTICE ON UPCOMING OWNER NOTIFICATION PROGRAM WHICH WILL PROVIDE ADDITIONAL COVERAGE ON THE FRONT CAM CHAIN GUIDE ASSEMBLY ON CERTAIN VEHICLES. *TT
Bulletin Number: 02138
LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
Bulletin Number: 0232
SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301. *TT
Bulletin Number: 0242
CERTAIN VEHICLES WITH 4X4 OR ALL-WHEEL DRIVE MAY HAVE A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT
Bulletin Number: 0245
INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT
Bulletin Number: 0282
SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. *TT
Bulletin Number: 0285
ON SOME VEHICLES, THE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) BLOWS COLD AIR FROM THE FLOOR DUCTS ON VEHICLES PRODUCED BEFORE 9/30/2000 ONLY. *TT
Bulletin Number: 030508
FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD. *TT
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 03199
RATTLE/BUZZ SOUND FROM UNDER THE VEHICLE ON 4.0L SINGLE OVERHEAD CAM (SOHC) ENGINES. *TT
Bulletin Number: 03251
DRIVEABILITY-MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED-DIAGNOSTIC TROUBLE CODES (DTC'S) P0420 AND/OR P0430. *MJ
Bulletin Number: 03261
NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT
Bulletin Number: 0358
FLUID MAY LEAK OUT OF THE FRONT AXLE VENT TUBE. *TT *JB
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 042419
REVISED PROCEDURE FOR ADJUSTING ALIGNMENT ON ALL SUSPENSIONS - NEW RIGHT HAND UPPER CONTROL ARM DESIGN FOR TORSION BAR FRONT SUSPENSIONS. *TT
Bulletin Number: 0475
DRIVEABILITY-MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED-DIAGNOSTIC TROUBLE CODES (DTC'S) P0420 AND/OR P0430. *MJ
Bulletin Number: 070101
SUBJECT REGARDING OWNER NOTIFICATION PROGRAM 01M01 SUPPLEMENT #2: REVISED TECHNICAL INSTRUCTIONS AND NEW LABOR OPERATION. NLM
Bulletin Number: 090308
MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455
Bulletin Number: 11482
FOR CERTAIN MODEL VEHICLES, THE 4R70W TRANSMISSION SOLENOID MOLDED LEADFRAME MUST BE REPLACED WHEN REMOVED. *TT
Bulletin Number: 11512
ENGINEERING IS INVESTIGATING CONCERNS OF NOISY FRONT SYSTEM BLOWER MOTORS ON CERTAIN VEHICLES. *TT
Bulletin Number: 11530
WHEN DIAGNOSING CRANK / NO START ON CERTAIN VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT (PATS) CHECK THE CUSTOMERS KEY RING FOR ANY MAGNETIC OBJECTS LIKE THE MOBILE SPEEDPASS KEY WHICH MAY AFFECT THE SIGNAL TRANSMISSION BETWEEN THE PATS KEY A
Bulletin Number: 11534
SOME VEHICLES MAY EXHIBIT A REPEAT CONCERN OF NO ENGAGEMENT AFTER REPLACING THE 5R55E TRANSMISSION ASSEMBLY. *TT
Bulletin Number: 11759
SOME VEHICLES MAY COME IN FOR A BENT FRONT SEAT BACK RECLINER LEVER. *TT
Bulletin Number: 11809
SOME VEHICLES MAY EXHIBIT A SEAT SQUEAK / RATTLE / ROCK FROM THE FRONT POWER SEAT TRACK. *TT
Bulletin Number: 11811
SOME VEHICLES BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT
Bulletin Number: 12115
INFORMATION REGARDING THE TIRE INFLATION PRESSURE FOR ALL MODELS DURING PREDELIVERY PROCESS AND DURING MAINTENANCE INTERVALS. *MJS
Bulletin Number: 12127
SOME VEHICLES EQUIPPED WITH A DUAL MEDIA (AM/FM/CASS/CD) RADIO MAY EXHIBIT AN AUDIO CONCERN OF NO DISPLAY OR GRAPHICS. *MJS
Bulletin Number: 12146
SOME VEHICLES EQUIPPED WITH 5.0L ENGINES MAY EXHIBIT AN UPPER ENGINE TAPPING NOISE ON COLD START. *MJS
Bulletin Number: 12150
INFORMATION CONCERNING THE REPLACEMENT OF THE ENGINES ON VEHICLES EQUIPPED WITH A 4.0L SOHC THAT REQUIRE SERVICE. *MJS
Bulletin Number: 12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
Bulletin Number: 12227
FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12230
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12289
SOME VEHICLES MAY EXHIBIT A WATER LEAK CONCERN FROM THE MOONROOF. *TT
Bulletin Number: 12298
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. *TT
Bulletin Number: 12500
ON SOME VEHICLES BUILT THROUGH 1/22/99 THE REAR WIPER BLADE MAY FLIP OVER WHEN RAN THROUGH SOFT CLOTH STYLE CAR WASHES. *TT
Bulletin Number: 12510
SOME VEHICLES MAY EXHIBIT A POWER STEERING GRUNT / GROAN / NOISE WHILE TURNING. *TT
Bulletin Number: 12512
BRIEF INFORMATION ON CHECKING TRANSMISSION FLUID LEVEL. *T
Bulletin Number: 12518
CONCERNS WITH THE IN-DASH CD STOPS OPERATING WHEN HOT / RADIO DISPLAY READS CD TOO HOT. *TT
Bulletin Number: 12521
VEHICLES WITH LIMITED SLIP / TRACTION-LOK REAR AXLES MAY EXHIBIT A CHATTER NOISE WHILE TURNING. *TT
Bulletin Number: 12529
SOME VEHICLES MAY EXHIBIT AN AIR BAG LIGHT ON INTERMITTENTLY WITH DIAGNOSTIC TROUBLE CODE B1924. *TT
Bulletin Number: 12554
SUBJECT REGARDING REVOLUTIONS PER MILE TIRE SIZE DATA. *TT
Bulletin Number: 12571
EXPERIENCING A WHINNING NOISE FROM THE TRANSFER CASE. *TT
Bulletin Number: 12573
INFORMATION REGARDING THE AUDIO SYSTEM SELECTIVE LIGHTING FEATURE. *TT
Bulletin Number: 12583
SOME VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT A THUMPING NOISE FROM THE COOLING SYSTEM. *TT
Bulletin Number: 12610
INFORMATION ON REPLACING A FOUR WHEEL ANTI-LOCK BRAKES (4WABS) HYDRAULIC CONTROL UNIT (HUC). *TT
Bulletin Number: 12624
SOME VEHICLES MAY EXHIBIT A HESITATION / LACK OF POWER ON RE-ACCELERATION AFTER DECELERATING FROM 45 - 65 MPH TO A SLOW ROLL CONDITION. *TT
Bulletin Number: 12704
SUBJECT REGARDING ALL VEHICLES REQUIRES A PARAMETER RESET TO BE PERFORMED ON THE PASSIVE ANTI-THEFT SYSTEM MODULE (PATS / VIC / HEC) WHEN THE POWERTRAIN CONTROL MODULE (PCM) IS REPLACED. *TT
Bulletin Number: 12705
SOME 4.0L OHV ENGINES MAY EXHIBIT AN INTERNAL LOW ENGINE NOISE THAT IS DESCRIBED AS A DIESEL AND / OR MARBLES IN A TIN CAN RATTLE. *TT
Bulletin Number: 12710
SOME VEHICLES MAY EXHIBIT A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOISE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT
Bulletin Number: 12755
SOME VEHICLES BUILT BEFORE 1/1/1999 EQUIPPED WITH 5.0L ENGINE MAY EXHIBIT A FRONT ACCESSORY DRIVE (FEAD) BELT NOISE. *TT
Bulletin Number: 12843
SOME 4X4 VEHICLES MAY EXHIBIT A HIGH PITCHED SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT END AT SPEEDS FROM 10 MPH TO 40 MPH. *TT
Bulletin Number: 12852
USE KLEENEX BRAND JUNIORS OR LI'L TRAVELERS TO REFILL TISSUES FOR CERTAIN VEHICLES WITH THE HIGH SERIES CENTER CONSOLE FACIAL TISSUE COMPARTMENT. *TT
Bulletin Number: 12905
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT
Bulletin Number: 12924
SOME VEHICLES MAY REQUIRE RADIATOR HOSE CLAMP REPLACEMENT DURING NORMAL VEHICLE SERVICE. *TT
Bulletin Number: 12947
SOME VEHICLES MAY EXHIBIT A HIGH PITCHED SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT END AT SPEEDS FROM 10 MPH TO 40 MPH. *TT
Bulletin Number: 12997
SOME VEHICLES MAY EXHIBIT NO / LOW A/C PERFORMANCE AT HIGH AMBIENT TEMPERATURES AND PROLONGED IDLE. *TT
Bulletin Number: 13004
SOME 4.0L VEHICLES WITH A4WD MAY EXHIBIT A VIBRATION / PULSATION FELT FROM THE DRIVELINE IN THE STEERING WHEEL AND FLOORPAN ON ACCELERATION / LIGHT TIP-IN AT 25-35 MPH WHEN IN 4 AUTO MODE. *TT
Bulletin Number: 13049
EXHIBITING A POWER STEERING FLUID LEAK FROM THE STEERING GEAR BOOT(S). *TT
Bulletin Number: 13110
INFORMATION REGARDING 4.0L OHV ENGINE-MARBLE TYPE NOISE. *MJS
Bulletin Number: 13110
SOME VEHICLES MAY EXHIBIT AN INTERNAL LOW END NOISE THAT IS DESCRIBED AS A DIESEL AND / OR MARBELS IN A TIN CAN RATTLE. *TT
Bulletin Number: 13112
VIBRATION ON LIGHT TO MODERATE ACCELERATION AT 0 - 45 MPH ON A4WD VEHICLES. *TT
Bulletin Number: 13118
SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT
Bulletin Number: 13154
SUBJECT REGARDING 4.0L ENGINE HOTLINE PHONE NUMBERS. *TT
Bulletin Number: 13154
SUBJECT REGARDING ENGINE HOTLINE PHONE NUMBERS. *TT
Bulletin Number: 13170
INFORMATION REGARDING 4.0 L SOHC CAMSHAFT BOLT TORQUE. *MJS
Bulletin Number: 13171
INFORMATION REGARDING 4.0L SOHC ENGINE NOISE (CAM CHAIN NOISE). *MJS
Bulletin Number: 13172
INFORMATION REGARDING SOHC ENGINE NOISE (CAM CHAIN NOISE). *MJS
Bulletin Number: 13175
INFORMATION REGARDING CLUTCH SQUAWK NOISE ON TAKE OFF. *MJS
Bulletin Number: 13177
INFORMATION REGARDING 4.0L SOHC ENGINE REPAIR PROCEDURE UPDATE. *MJS
Bulletin Number: 13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
Bulletin Number: 13218
INFORMATION REGARDING SEAT THAT WILLL NOT MOVE FORWARD. *MJS
Bulletin Number: 13222
INFORMATION REGARDING NEUTRAL TOW KIT AVAILABLE. *MJS
Bulletin Number: 13223
INFORMATION REGARDING MANUAL A/C SYSTEM- BLOWER WORKS IN HIGH SETTING ONLY. *MJS
Bulletin Number: 13260
SERVICE TIPS INFORMATION PROVIDED TO ASSIST WHEN SERVICING VEHICLES WITH SHORT BLOCK ASSEMBLY. *TT
Bulletin Number: 13261
SERVICE TIPS WHEN SERVICING A 4.0L SOHC SHORT BLOCK ASSEMBLY. *TT
Bulletin Number: 13270
VEHICLES WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN INTERNAL LOW END NOISE THAT IS DESCRIBED AS A DIESEL AND / OR MARBLES IN A TIN CAN RATTLE. *TT
Bulletin Number: 13283
SOME VEHICLES WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN INTERNAL LOW END NOISE THAT IS DESCRIBED AS A DIESEL AND / OR MARBLES IN A TIN CAN RATTLE. *TT
Bulletin Number: 13289
OWNERS OF VEHICLES EQUIPPED WITH 4.0L OHV ENGINE AND MANUAL TRANSMISSION MAY EXHIBIT A SQUAWK NOISE FROM THE CLUTCH ON TAKE OFF. *TT
Bulletin Number: 13300
SOME VEHICLES WITH 4.0L SOHC ENGINES MAY EXHIBIT A VIBRATION / MOAN / BOOM AT IDLE. *TT
Bulletin Number: 13310
THE REAR WIPER BLADE ON SOME VEHICLES BUILT THROUGH 1/22/99 MAY FLIP OVER WHEN RUN THROUGH SOFT CLOTH STYLE CAR WASHES. *TT
Bulletin Number: 13350
SOME VEHICLES WITH A4WD BUILT PRIOR TO 9/13/99 MAY EXHIBIT A VIBRATION / PULSATION AT 0 - 45 MPH. *TT
Bulletin Number: 13388
VEHICLES EQUIPPED THE NEUTRAL TOW FEATURE, BE AWARE THAT WHEN THE NEUTRAL TOW FEATURE IS ENABLED AND THE CUSTOMER PLACES THE VEHICLE INTO THE NEUTRAL MODE, THE NEUTRAL TOW INDICATOR WILL GO OUT WHEN THE GEM GOES TO SLEEP. *TT
Bulletin Number: 13404
SOME 4X4 VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *TT
Bulletin Number: 13412
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT
Bulletin Number: 13415
EXHIBITING A SQUEAK TYPE NOISE FROM THE REAR STABILIZER BAR WHILE DRIVING, ESPECIALLY WHEN GOING OVER BUMPS. *TT
Bulletin Number: 13426
EXHIBITING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS. *TT
Bulletin Number: 13440
EXPERIENCING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS (PARKING LOT TYPE MANEUVERS). *TT
Bulletin Number: 13442
VEHICLES EQUIPPED WITH 4.0L OHV ENGINE AND MANUAL TRANSMISSION MAY EXHIBIT A SQUAWK NOISE FROM THE CLUTCH ON TAKE OFF. *TT
Bulletin Number: 13465
INFORMATION REGARDING CLEAN AIR TUBE RETAINING CLAMPS / THROTTLE BODY CAM. *TT
Bulletin Number: 13482
SOME VEHICLES MAY EXHIBIT A VIBRATION / GROAN ON ACCELERATION OR TAKE-OFF DUE TO THE REAR TRANSMISSION MOUNT BEING TWISTED AND ALLOWING A GROUND OUT CONDITION TO OCCUR. *TT
Bulletin Number: 13484
VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT EXCESSIVE OIL CONSUMPTION AS REPORTED BY THE CUSTOMER. *TT
Bulletin Number: 13504
CONCERNS WITH VEHICLES EXHIBITING AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. ENGINEERING IS CURRENTLY ADDRESSING THIS ISSUE THROUGH THE HIGH MILAGE / TIME-IN-SERVICE CONCERN RESOLUTION PROCESS. *TT
Bulletin Number: 13505
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
Bulletin Number: 13527
SOME VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES MAY EXHIBIT AN OVERHEAT CONDITION THAT MAY BE ATTRIBUTED TO THE THERMOSTAT. ENGINEERING IS CURRENTLY INVESTIGATING THIS ISSUE AND IS LOOKING FOR THERMOSTATS AND COOLANTS SAMPLES FROM THESE
Bulletin Number: 13723
SOME ALL WHEEL DRIVE VEHICLES MAY EXPERIENCE A LOW SPEED WHINING NOISE FROM THE TRANSFER CASE. *MJS
Bulletin Number: 13745
SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS
Bulletin Number: 13752
SOME 4X4 VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *TT
Bulletin Number: 13752
SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *MJS
Bulletin Number: 13757
VEHICLES EQUIPPED WITH LIMITED SLIP/TRACTION-LOK REAR AXLES MAY EXHIBIT A CHATTER NOISE WHILE TURNING. *MJS
Bulletin Number: 13794
VEHICLES EQUIPPED WITH M5OD R1 TRANSMISSIONS MAT EXHIBIT A 2-3 UPSHIFT GRIND. *MJS
Bulletin Number: 13857
SOME VEHICLES EQUIPPED WITH 5.0L ENGINES AND ALL WHEEL DRIVE (AWD) TRANSFER CASE MAY EXHIBIT A CONDITION OF 4X4 INDICATORS FLASHING AND MULTIPLE GEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 13879
INFORMATION ON REPLACING A GEM MODULE ON 4X4 VEHICLES EQUIPPED WITH 4.0L SOHC, OHV AND THE NEUTRAL TOW KIT. *TT
Bulletin Number: 14048
SOME VEHICLES MAY EXPERIENCE AN OIL LEAK AT THE REAR CRANKSHAFT AREA AFTER SERVICE. **MR
Bulletin Number: 14056
SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR
Bulletin Number: 14061
SOME VEHICLES MAY COME IN FOR A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE P0171 AND/OR P0174 IN SELF TEST. **MR
Bulletin Number: 14265
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT HESITATION ON ACCELERATION OR WHILE TURNING. *TT
Bulletin Number: 14371
SUBJECT REGARDING POP / CREAK NOISE FROM THE REAR UNDERBODY WHILE DRIVING. *JB
Bulletin Number: 14489
SOME VEHICLES BUILT THROUGH 01/1999 AND EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A COLD START OR HOT ENGINE DECELERATION NOISE COMING FROM THE #5 CYLINDER. *TT
Bulletin Number: 14489
SOME VEHICLES BUILT THROUGH 01/1999, EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A COLD START OR HOT ENGINE DECELERATION NOISE COMING FROM THE #5 CYLINDER. *TT
Bulletin Number: 14560
VEHICLES MAY EXPERIENCE START UP TIMING CHAIN NOISE. *JB
Bulletin Number: 14583
CONCERNS WITH BROKEN THERMOSTATS ON ENGINES. *JB
Bulletin Number: 14586
SOME 4.0L VEHICLES WITH A4WD BUILT PRIOR TO 9/13/99 MAY EXHIBIT A VIBRATION / PULSATION AT 0-45 MPH ON DRY PAVEMENT UNDER LIGHT TO MODERATE ACCELERATION IN 4 AUTO MODE WHICH MAY CHARACTERISTIC WITH THE CONTROL TRAC 4X4 SYSTEM. *JB
Bulletin Number: 14617
SUBJECT PERTAINING TO BROKEN THERMOSTAT. *JB
Bulletin Number: 14819
SOME 4X4 VEHICLES MAY EXHIBIT A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT
Bulletin Number: 14847
CONCERNS WITH VEHICLES EXHBIT FLUID LEAKAGE FROM THE FRONT AXLE VENT TUBE. *TT
Bulletin Number: 14868
SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC ENGINE MAY EXHIBIT A PRIMARY CHAIN RATTLE NOISE (SOMETIMES DESCRIBED AS A SPARK KNOCK-TYPE NOISE). *TT
Bulletin Number: 15006
SOME VEHICLES WITH 4.0L SOHC ENGINES MAY MAKE A START-UP NOISE FROM THE LEFT FRONT OF THE ENGINE. *TT
Bulletin Number: 15040
SOME EXPLORER / SPORT / SPORT TRAC EQUIPPED WITH A 4.0L SOHC ENGINE MAY EXHIBIT A START-UP NOISE CONDITION FROM THE LEFT FRONT OF THE ENGINE. *TT
Bulletin Number: 15040
SOME VEHICLES INCLUDING 1997 THROUGH 1999 EXPLORER SPORT TRAC EQUIPPED WITH A 4.0L SOHC ENGINE MAY EXHIBIT A START-UP NOISE FROM THE LEFT FRONT OF THE ENGINE. *TT
Bulletin Number: 15155
ON SOME VEHICLES THE REAR WIPER ARM FAILS TO CLEAN BACK GLASS. *ET
Bulletin Number: 15168
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT HIGH FREQUENCY BRAKE SQUEAL NOISE. *YH
Bulletin Number: 15226
SOME VEHICLES EQUIPPED WITH A 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE THAT MAY BE PERCEIVED BY THE CUSTOMER A S ADIESEL TYPE NOISE AND IS KNOWN AS MARBLE NOISE. *TT
Bulletin Number: 15249
CONCERNS WITH HIGH BRAKE PEDAL FORCE TO STOP AFTER ROTOR MACHINING. *TT
Bulletin Number: 15406
CONCERNS WITH REAR WIPERS THAT DO NOT SUFFICIENTLY CLEAN THE BACK GLASS. *TT
Bulletin Number: 15532
INFORMATION ON VEHICLES EXHIBITNG FUEL LINE DAMAGE DUE TO PINCHING/SQUEEZING OF THE FUEL RETURN LINE. *TT
Bulletin Number: 15563
INFORMATION REGARDING MALFUNCTION INDICATOR LIGHT ILLUMINATING WITH DIAGNOSTIC TROUBLE CODE P0300/P0301.*YH
Bulletin Number: 15692
SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT
Bulletin Number: 15887
SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). *TT
Bulletin Number: 15910
CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION. *TT
Bulletin Number: 16385
AIR RIDE CONTROL LAMP ON AFTER SHOCK ABSORBER REPLACEMENT / CONTACT REQUEST. *TT
Bulletin Number: 16735
VARIOUS NOISE ISSUES FROM THE REAR LEAF SPRINGS WHILE DRIVING. *TT
Bulletin Number: 16935
AN UNCOMMANDED SHIFT TO 4X4 LOW. *TT
Bulletin Number: 17312
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0420 AND/OR P0430. *TT
Bulletin Number: 4619
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT
Bulletin Number: 4623
BRIEF INFORMATION FOR VEHICLES EXHIBITING ENGINE STALL. *TT
Bulletin Number: 4634
STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT
Bulletin Number: 4642
SOME VEHICLES MAY COME IN FOR A BENT FRONT SEAT BACK RECLINER LEVER. *TT
Bulletin Number: 4701
SOME VEHICLES MAY EXHIBIT A SEAT SQUEAK / RATTLE / ROCK FROM THE FRONT POWER SEAT TRACK. *TT
Bulletin Number: 4703
SOME TRUCKS BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND TRUCKS BUILT WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT
Bulletin Number: 4747
INFORMATION ON ADDITIONS TO THE FORD QUALITY RENEWAL ASSEMBLY PROGRAM.
Bulletin Number: 5049
BRIEF INFORMATION REGARDING UPPER ENGINE NOISE. *TT
Bulletin Number: 5128
SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. ENGINEERING IS INVESTIGATING. *TT
Bulletin Number: 5133
SOME VEHICLES EQUIPPED WITH A DUAL MEDIA (AM / FM CASS / CD) RADIO MAY EXHIBIT AN AUDIO CONCERN OF NO DISPLAY OR GRAPHICS. *TT
Bulletin Number: 5189
SOME VEHICLES MAY EXHIBIT A HESITATION / LACK OF POWER ON RE-ACCELERATION AFTER DECELERATING FROM HIGHWAY SPEED (45-65 MPH) TO A SLOW ROLL CONDITION (EXIT RAMP / TOLLBOOTH). THIS MAY BE DUE TO THE TRANSMISSION CALIBRATION NOT MAKING THE
Bulletin Number: 5249
INFORMATION ON VEHICLES EXHIBITING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT
Bulletin Number: 5256
INFORMATION ON VEHICLES EXHIBITING UPPER ENGINE NOISE. *TT
Bulletin Number: 5272
BRIEF INFORMATION REGARDING ENGINE STALL CONDITION. *TT
Bulletin Number: 5373
SOME VEHICLES MAY EXHIBIT A WATER LEAK CONCERN FROM THE MOONROOF. *TT
Bulletin Number: 5506
VEHICLE MAY EXHIBIT A HIGH PITCHED SQUEAL / WHISTLE TYPE NOISE FROM THE FRONT END AT SPEEDS FROM 10 MPH TO 40 MPH. *TT
Bulletin Number: 5652
COMPLAINTS THAT THE IN-DASH CD STOPS OPERATING WHEN HOT. *TT
Bulletin Number: 5705
VEHICLE EXHIBITING MULTIPLE GENERIC ELECTRONIC MODULE (GEM) RELATED SYMPTOMS. *TT
Bulletin Number: 5799
COMPLAINTS THAT THE REAR WIPER BLADE FLIPS OVER. *TT
Bulletin Number: 5812
CONCERNS WITH POWER STEERING MAKING A GRUNTING / GROANING NOISE WHILE TURNING. *TT
Bulletin Number: 5814
SERVICE TIPS FOR CHECKING TRANSMISSION FLUID LEVEL. *TT
Bulletin Number: 5845
SOME VEHICLES EQUIPPED WITH LIMITED SLIP / TRACTION-LOCK REAR AXLES MAY EXHIBIT A CHATTER NOISE WHILE TURNING. *TT
Bulletin Number: 5852
VEHICLES EXHIBITING INTERMITTENT ILLUMINATION OF AIR BAG LIGHT WITH DIAGNOSTIC TROUBLE CODE B1924. *TT
Bulletin Number: 6032
SOME VEHICLES MAY EXHIBIT A HIGH PITCHED SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT END AT SPEEDS FROM 10 MPH TO 40 MPH. *TT
Bulletin Number: 6035
SOME VEHICLES EQUIPPED WITH TEVES FOUR WHEEL ANTI-LOCK BRAKES (4WABS) MAY EXHIBIT A YELLOW ANTI-LOCK BRAKE LAMP ILLUMINATED WITH NO DIAGNOSTIC TROUBLE CODES IN MEMORY. *TT
Bulletin Number: 6199
VEHICLE MAY EXPERIENCE A DIESEL / MARBEL TYPE NOISE. *TT
Bulletin Number: 6203
SOME VEHICLES MAY EXHIBIT A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT
Bulletin Number: 6295
VEHICLES MAY EXHIBIT A FRONT ACCESSORY DRIVE (FEAD) BELT NOISE. *TT
Bulletin Number: 6308
INFORMATION PERTAINING TO HARNESS CHAFFING ISSUE. *TT
Bulletin Number: 6429
INFORMATION ON REFILLING TISSUES FOR THE CENTER CONSOLE FACIAL TISSUE COMPARTMENT. *TT
Bulletin Number: 6559
BRIEF INFORMATION REGARDING RADIATOR HOSE CLAMP FOR SERVICE. *TT
Bulletin Number: 6574
SOME VEHICLES MAY EXHIBIT AN OCCASIONAL HOOT / MOAN FROM THE IDLE AIR CONTROL (IAC) VALVE. *TT
Bulletin Number: 6603
SOME VEHICLES MAY EXHIBIT AN AUDIBLE PINGING OR CREAKING NOISE THAT MAY BE HEARD FROM THE DRIVELINE WHEN ENGINE TORQUE IS INITIALLY APPLIED TO THE DRIVELINE. *TT
Bulletin Number: 6640
EXHIBITING AN AIR BAG LAMP ON INTERMITTENTLY WITH LAMP FAULT CODE (LFC) 24, OR DIAGNOSTIC TROUBLE CODE B1924 AND / OR B1342 STORED IN MEMORY. *TT
Bulletin Number: 6692
SOME VEHICLES MAY EXHIBIT NO / LOW AIR CONDITIONER PERFORMANCE AT HIGH AMBIENT TEMPERATURES AND PROLONGED IDLE. *TT
Bulletin Number: 6699
SOME VEHICLES WITH A4WD MAY EXHIBIT A VIBRATION / PULSATION FELT FROM THE DRIVELINE IN THE STEERING WHEEL AND FLOORPAN ON ACCELERATION / LIGHT TIP-IN AT 25-35 MPH WHEN IN 4 AUTO MODE. *TT
Bulletin Number: 6896
SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT
Bulletin Number: 6905
INFORMATION ON REMOVING AND / OR REPLACING THE GENERIC ELECTRONIC MODULE (GEM). *TT
Bulletin Number: 6926
SUBJECT REGARDING THE ENGINE HOTLINE PHONE NUMBERS FOR 1997 - 2000 MODEL YEAR VEHICLES. *TT
Bulletin Number: 6980
SOME VEHICLES MAY EXHIBIT THE CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODE PO420. *TT
Bulletin Number: 6986
INFORMATION REGARDING 4.0L SOHC CAMSHAFT BOLT TORQUE. *TT
Bulletin Number: 6987
SOME VEHICLES MAY EXHIBIT ENGINE NOISE(CAM CHAIN NOISE). *TT
Bulletin Number: 6991
VEHICLES EQUIPPED WITH 4.0L OHV AND MANUAL TRANSMISSION MAY EXHIBIT A SQUAWK NOISE FROM THE CLUTCH ON TAKE OFF. *TT
Bulletin Number: 6993
SUBJECT REGARDING 4.0L SOHC ENGINE REPAIR PROCEDURE UPDATE. *TT
Bulletin Number: 6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
Bulletin Number: 7079
INFORMATION REGARDING SEAT THAT WILL NOT MOVE FORWARD. *MJS
Bulletin Number: 7083
INFORMATION REGARDING NEUTRAL TOW KIT AVAILABILITY. *MJS
Bulletin Number: 7084
SUBJECT ON MANUAL A/C SYSTEM-BLOWER WORKS IN HIGH SETTING ONLY. *MJS
Bulletin Number: 7138
SERVICE TIP INFORMATION WHEN SERVICING THE 4.0L SOHC SHORT BLOCK ASSEMBLY. *TT
Bulletin Number: 7147
EXHIBITING AN INTERNAL LOW END NOISE THAT IS DESCRIBED AS A DIESEL AND / OR MARBLES IN A TIN CAN RATTLE. *TT
Bulletin Number: 7206
VEHICLES EQUIPPED WITH 4.0L OHV ENGINE AND MANUAL TRANSMISSION MAY EXHIBIT A SQUAWK NOISE FROM THE CLUTCH ON TAKE OFF. *TT
Bulletin Number: 7238
A CONDITION WITH THE REAR WIPER BLADE ON VEHICLES BUILT THROUGH 1/22/1999 MAY FLIP OVER WHEN RUN THROUGH SOFT CLOTH STYLE CAR WASHES. *TT
Bulletin Number: 7270
SOME VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES MAY EXHIBIT A VIBRATION / MOAN / BOOM AT IDLE. *TT
Bulletin Number: 7316
SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *TT
Bulletin Number: 7353
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT
Bulletin Number: 7360
SOME VEHICLES MAY EXHIBIT A SQUEAK NOISE FROM THE REAR WHILE DRIVING, ESPECIALLY WHEN GOING BUMPS. *TT
Bulletin Number: 7366
SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION MAY EXHIBIT NEUTRAL GEAR ROLLOVER NOISE (A LIGHT METALLIC RATTLING SOUND FROM THE TRANSMISSION) WHICH OCCURS AT IDLE WITH TRANSMISSION IN NEUTRAL CLUTCH ENGAGED (CLUTCH PEDAL UP). *TT
Bulletin Number: 7440
THIS BULLETIN STATES THAT WHENEVER THE CLEAN AIR TUBE RETAINING CLAMPS ARE REMOVED FOR ANY REPAIR, PROCEDURES MUST BE FOLLOWED TO INSURE PROPER CLEARANCE BETWEEN THE THROTTLE CAM AND THE CLEAN AIR TUBE RETAINING CLAMP BOLT. *TT
Bulletin Number: 7468
SOME VEHICLES MAY EXHIBIT A VIBRATION / GROAN ON ACCELERATION OR TAKE OFF.
Bulletin Number: 7471
SOME VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT EXCESSIVE OIL CONSUMPTION AS REPORTED BY THE CUSTOMER. *TT
Bulletin Number: 7494
ALL VEHICLES WITH ELECTRONIC SHIFT ON THE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF WHAT THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
Bulletin Number: 7885
THE VEHICLE MAY EXHIBIT THE SPEEDOMETER/ODOMETER INOPERATIVE AS WELL AS MALFUNCTION INDICATOR LAMPS ILLUMINATED OR FLASHING AFTER THE GENERIC ELECTRONIC MODULE (GEM), CENTRAL TIMER MODULE (CTM), OR FOR WHEEL ANTI-LOCK BRAKE SYSTEM (4WABS) M
Bulletin Number: 7918
FRONT AXLE PINION LIL SEAL LEAKS.
Bulletin Number: 8008
BUZZING AND GRINDING NOTCHY NOISE WHEN SHIFTING(2-3 UPSHIFT).
Bulletin Number: 8119
SOME VEHICLES EQUIPPED WITH 5.0L ENGINE AND ALL WHEEL DRIVE (AWD) TRANSFER CASE MAY EXHIBIT A CONDITION OF 4X4 INDICATORS FLASHING AND MULTIPLE GEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 8149
SUBJECT REGARDING NEUTRAL TOW INOPERATIVE AFTER GEM REPLACEMENT. *TT
Bulletin Number: 8164
INFORMATION REGARDING PUMP ALIGNMENT TOOLS. **MR
Bulletin Number: 8164
INFORMATION ON 5R55E - 4R55E - 4R44E PUMP ALIGNMENT TOOLS. *TT
Bulletin Number: 8493
SOME VEHICLES MAY EXPERIENCE AN OIL LEAK AT THE REAR CRANKSHAFT AREA AFTER SERVICE. **MR
Bulletin Number: 8512
SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR
Bulletin Number: 870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
Bulletin Number: 97090297183
EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC
Bulletin Number: 976011
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 98021698311
SOME VEHICLES MAY EXHIBIT A DRIFT/PULL, SHOW SIGNS OF TIRE WEAR, OR EXHIBIT POOR RIDE QUALITY. *YC
Bulletin Number: 980313
EXPERIENCING IDLE VIBRATION / EXHAUST BOOM. *YC
Bulletin Number: 980321
PATS KEY PROGRAMMING. *AK
Bulletin Number: 9810930
SOME VEHICLES MAY EXHIBIT AN ENGINE OIL LEAK FROM THE REAR MAIN CRANKSHAFT SEAL. *TT
Bulletin Number: 98110
SUBJECT REGARDING PASSIVE ANTI THEFT SYSTEM (PATS) DIAGNOSTIC SERVICE TIPS. *TT
Bulletin Number: 9811487
ENGINEERING IS INVESTIGATING VEHICLES WITH WINDSHIELD STRESS CRACKS. *TT
Bulletin Number: 98117
SOME VEHICLE MAY EXHIBIT MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) PO171, PO174, P1131 AND / OR P1151 STORED IN MEMORY. *TT
Bulletin Number: 98118
EXPERIENCING AN AUDIBLE NOISE IN ENGINE.
Bulletin Number: 9812061
VEHICLES WITH OHV/SOHC, 5.0L 4.6L, 5.4L MAY EXHIBIT A (MIL) ON WITH EVAP SYSTEM DTC'S P1450,PO455,PO466. THE DECEMBER SBDS RELEASE WILL INCLUDED NEW AUTOMATED STATIC LEAK TEST FOR DIANOSING THESE CONCERNS. *MJS
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK
Bulletin Number: 981514
A VEHICLE VIBRATES DURING A HOT OR COLD IDLE CONDITION.
Bulletin Number: 981613
TRANSMISSION FLUID LEAKS AT RADIATOR. YD
Bulletin Number: 981617
FLOOR MAT INSTALLATION PROCEDURE SERVICE TIP. YD
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 98165
EVAPORATOR CORE FAILED, CAUSING THE AIR CONDITIONER TO DRIP ON TO PASSENGER FLOOR. YD
Bulletin Number: 9818
FUEL PUMP REPLACEMENT PROCEDURE - SERVICE TIP. *TT
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 982019
CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR. *YC
Bulletin Number: 98203
CONCERNS WITH THE POTENTIAL EFFECTS OF ADHESIVES USED FOR BODY PANEL REPAIRS. *TT
Bulletin Number: 98203
CONCERNS WITH ADHENSIVES NOT RECOMMENDED FOR BODY PANEL REPAIRS. *YC
Bulletin Number: 98211
EXPERIENCING A NOISE AND VIBRATION DURING IDLE.
Bulletin Number: 982122
SOME CUSTOMERS HAVE REPORTED THE THROTTLE STUCK AT IDLE ON SOME VEHICLES. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982312
ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 982320
SOME VEHICLES WITH A VERY LOW ODOMETER READING MAY EXPERIENCE A LACK TEMPERATURE CONTROL. *YC
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98238
CONDENSATE MAY LEAK ONTO THE PASSENGER FLOOR ON SOME VEHICLES. *YC
Bulletin Number: 98241
DIAGNOSTIC SERVICE TIPS ON PASSIVE ANTI THEFT SYSTEM ( PATS ). *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982511
SERVICE TIPS ON COMPOSITE FUEL RAIL. *YC
Bulletin Number: 982515
CONDITIONS WITH THE FRONT SEAT BACK LEVER BENT. *YC
Bulletin Number: 982540
CONCERNS WITH BUILT-IN REAR CHILD SAFETY SEAT MAY NOT EASILY ACCOMMODATE SOME CHILDREN. *YC
Bulletin Number: 982550
ENGINEERING IS INVESTIGATING SOME VEHICLES WITH WINDSHIELD STRESS CRACKS. *YC
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 982720
ENGINEERING IS INVESTIGATING CONDITIONS CONCERNING ROOF RACK TAP PLATES. *YC
Bulletin Number: 982732
BRIEF INFORMATION ON PERFORMING THE FUEL ECONOMY TEST. *YC
Bulletin Number: 983074
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 983180
INFORMATION ON THE NEW 4R100 TRANSMISSION. *TT
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 983315
THE 4R100 TRANSMISSION WILL HAVE AN ORANGE "PRIOR TO REPAIR" TAG ON THE FLUID PAN. *TT
Bulletin Number: 98-3423
EXHIBITING A POWER STEERING NOISE. *TT
Bulletin Number: 983566
INFORMATION ON PROGRAMMING / DIAGNOSING ANY PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT
Bulletin Number: 983566
INFORMATION REGARDING PROGRAMMING / DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT
Bulletin Number: 983572
CONCERNS WITH ANTI-LOCK BRAKE SYSTEM (ABS) DIAGNOSTIC TROUBLE CODES AND / OR ABS LIGHT FLASHING WHILE DRIVING. *TT
Bulletin Number: 98412
THE 4R70W TRANSMISSION INSTALLED IN SOME VEHICLES WILL HAVE AN ORANGE
Bulletin Number: 98421
EXHIBITING A SQUEAKING / CREAKING NOISE HEARD FROM THE RIGHT SIDE OF THE INSTRUMENT PANEL WHILE TURNING OR DURING ANY BODY FLEXING. *TT
Bulletin Number: 9844
SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 98-4732
STEERING WHEEL SHIMMIES, VIBRATION OR GRUNT ON SLOW SPEED TURNS..
Bulletin Number: 98-4817
SOME 1997-1998 EXPLORER/MOUNTAINEER/EXPEDITION OR NAVIGATOR VEHICLES WITH 4-WD 4X4 SYSTEM MAY EXHIBIT BOTH
Bulletin Number: 985045
REVISED MESSAGE REGARDING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS ACTION ON SOHC EQUIPPED VEHICLES, PERFORM TSB 98-21-01. *TT
Bulletin Number: 985053
REPEAT / REVISE MESSAGE REGARDING FLASHING 4X4 LIGHTS WITH NO DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 985064
REPEAT MESSAGE REGARDING ENGINE STALLING *TT
Bulletin Number: 985103
VEHIUCLES WITH 4.0L OHV/SOHC, 5.0L, 4.6L, 5.4L MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ON WITH EVAP SYSTEM DIAGNOSTIC TROUBLE CODES P1450, P0455, P0446. *TT
Bulletin Number: 985128
SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. *TT
Bulletin Number: 985133
SOME VEHICLES EQUIPPED WITH A DUAL MEDIA (AM/FM/CASS/CD) RADIO MAY EXHIBIT AN AUDIO CONCERN OF NO DISPLAY OR GRAPHICS. *TT
Bulletin Number: 98514
CONCERNS WITH A WHISTLING OR HISSING NOISE FROM THE MAIN CONTROL AREA OCCURING WHILE IDLING IN DRIVE AND / OR REVERSE ON SOME VEHICLES. *TT
Bulletin Number: 985144
ALL VEHICLES EQUIPPED WITH 4.0L SOHC THAT REQUIRE ENGINE SERVICE PLEASE NOTE THAT THE XL2Z-6M289-AA (DRIVE ASSEMBLY-CAMSHAFT-LH) MUST BE USED ON 4.0L SOHC ENGINES IF REPLACEMENT IS REQUIRED. *TT
Bulletin Number: 985148
SOME VEHICLES EQUIPPED WITH 5.0L ENGINES MAY EXHIBIT AN UPPER ENGINE TAPPING NOISE ON COLD START. *TT
Bulletin Number: 985157
INFORMATION ON SETTING THE TIRE INFLATION PRESSURE FOR 1991 THROUGH 1999 MODEL YEAR VEHICLES IN THE PRE-DELIVERY PROCESS AND DURING MAINTENANCE INTERVALS. *TT
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 985A30
SOME VEHICLES MAY EXPERIENCE THE ANTI-LOCK BRAKE SYSTEM ( ABS ) LAMP MAY ILLUMINATE ON DECELERATION. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 99104
THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0174, P1131, AND / OR P1151 MAY BE PRESENT WITH OR WITHOUT MISFIRE, ROLLING IDLE, ROUGH IDLE, ETC. *TT
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 9912786
INFORMATION REGARDING HARNESS CHAFING ISSUE. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 9913035
VEHICLES MAY EXPERIENCE A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT
Bulletin Number: 9913138
INFORMATION ON REPLACING AND REMOVING THE GENERIC ELECTRONIC MODULE (GEM). *TT
Bulletin Number: 99142
VEHICLES WITH A4WD TRANSMISSION AND 4.0L ENGINE MAY HAVE THE 4X4 INDICATOR LAMPS FLASHING. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99156
SOME VEHICLES MAY EXHIBIT A BURNING ODOR OR SMOKE, AND / OR RUSTLING NOISE OCCURING WHEN THE BLOWER MOTOR IS RUNNING IF LEAVES OR FOREIGN MATERIAL ENTERS THE BLOWER CASE. *TT
Bulletin Number: 991813
EXPERIENCING AN INOPERATIVE OR INACCURATE ODOMETER / SPEEDOMETER READINGS. *TT
Bulletin Number: 99185
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99203
INFORMATION ON REPLACING THE FRONT BUMPER BRACKET. *TT
Bulletin Number: 99206
CONCERNS WITH BURNING ODOR OR SMOKE, AND / OR RUSTLING NOISE WHILE BLOWER MOTOR IS ON. *TT
Bulletin Number: 99211
EXHIBITING A GRUNTING NOISE HEARD FROM THE POWER STEERING SYSTEM DURING SLOW SPEED TURNING, OR WHILE STATIONARY WHEN TURNING TO THE LEFT OR COMING OFF THE STEERING STOPS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99223
A NO START CONDITION WHEN VEHICLE IS PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL MAY OCCUR. *TT
Bulletin Number: 99228
EXPERIENCING WATER LEAK INTO THE VEHICLE THROUGH THE MOONROOF OPENING. *TT
Bulletin Number: 99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
Bulletin Number: 99238
A TEMPERATURE GAUGE FLUCTUATION AND / OR A KNOCKING / THUMPING NOISE MAY BE AUDIBLE INTHE PASSENGER COMPARTMENT ON SOME VEHICLES. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT
Bulletin Number: 995157
INFORMATION ON MAINTAINING TIRE PRESSURE. *TT
Bulletin Number: 996088
EXPERIENCING A GRUNT NOISE WHILE TURNING. *TT
Bulletin Number: 99-6193
INFORMATION ON RESETTING THE PASSIVE ANTI-THEFT SYSTEM (PATS). *TT
Bulletin Number: 996777
EXHIBITING A POWER STEERING FLUID LEAK FROM THE STEERING GEAR BOOT(S). *TT
Bulletin Number: 996884
CUSTOMERS MAY COMPLAIN OF AN INTERNAL LOW END NOISE THAT IS DESCRIBED AS A "DIESEL AND / OR MARBELS IN A TIN CAN RATTLE" ON VEHICLES WITH A 4.OL OVH ENGINE. *TT
Bulletin Number: 996887
SOME 4.0L VEHICLES WITH A4WD MAY EXHIBIT A VIBRATION / PULSATION AT 0-45 MPH ON DRY PAVEMENT UNDER LIGHT TO MODERATE ACCELERATION. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: 9986
SOME VEHICLES MAY EXHIBIT AN OVERDRIVE (O/D) LIGHT FLASHING WITH DIAGNOSTIC TROUBLE CODE (DTC) P0741 AND / OR P1740. *TT
Bulletin Number: 9987
SOME VEHICLES MAY EXHIBIT HARSH DOWNSHIFT FROM 3RD TO 1ST GEAR WHILE STOPPING; HESITATION AFTER ACCELERATION FROM STOP; AND / OR LACK OF POWER AFTER ACCELERATION FROM STOP. *TT
Bulletin Number: 9987
SOME VEHICLES MAY EXHIBIT HARSH DOWNSHIFT FROM 3RD TO 1ST GEAR WHILE STOPPING, HESITATION AFTER ACCELERATION FROM STOP AND / OR LACK OF POWER AFTER ACCELERATION FROM STOP ON VEHICLES WITH 4.0L OR 5.0L ENGINES. *TT
Bulletin Number: 9988
CONCERNS OR ERRATIC OR INSUFFICIENT TEMPERATURE CONTROL. *TT
Bulletin Number: 9996
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT
Bulletin Number: 9998
EXPERIENCING DRIFT / PULL TO THE RIGHT CONDITONS. *TT
Bulletin Number: 99S09
RECALL INFORMATION REGARDING SPEED CONTROL CABLE REPLACEMENT. *TT
1998 FORD EXPLORER SPORT
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 0186
ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT
Bulletin Number: 0232
SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301. *TT
Bulletin Number: 0245
INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT
Bulletin Number: 04217
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT
Bulletin Number: 15006
SOME VEHICLES WITH 4.0L SOHC ENGINES MAY MAKE A START-UP NOISE FROM THE LEFT FRONT OF THE ENGINE. *TT
Bulletin Number: 15040
SOME VEHICLES INCLUDING 1997 THROUGH 1999 EXPLORER SPORT TRAC EQUIPPED WITH A 4.0L SOHC ENGINE MAY EXHIBIT A START-UP NOISE FROM THE LEFT FRONT OF THE ENGINE. *TT
Bulletin Number: 15406
CONCERNS WITH REAR WIPERS THAT DO NOT SUFFICIENTLY CLEAN THE BACK GLASS. *TT
Bulletin Number: 15859
SOME VEHICLES WITH 4WABS MAY EXHIBIT DIAGNOSTIC TROUBLE CODES C1233 AND C1234 (ANTI-LOCK BRAKE SENSOR OUTPUT FAILURE). *TT
Bulletin Number: 15910
CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION. *TT
Bulletin Number: 16021
SOME VEHICLES WITH 4WABS MAY EXHIBIT DIAGNOSTIC TROUBLE CODES C1233 AND C1234 (ANTI-LOCK BRAKE SENSOR OUTPUT FAILURES) IN SLIPPERY CONDITIONS. *TT
1998 FORD EXPLORER SPORT TRAC
Bulletin Number: 0186
ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT
Bulletin Number: 15040
SOME VEHICLES INCLUDING 1997 THROUGH 1999 EXPLORER SPORT TRAC EQUIPPED WITH A 4.0L SOHC ENGINE MAY EXHIBIT A START-UP NOISE FROM THE LEFT FRONT OF THE ENGINE. *TT
Bulletin Number: 15859
SOME VEHICLES WITH 4WABS MAY EXHIBIT DIAGNOSTIC TROUBLE CODES C1233 AND C1234 (ANTI-LOCK BRAKE SENSOR OUTPUT FAILURE). *TT
Bulletin Number: 15910
CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION. *TT
1998 FORD F-150
Bulletin Number: 00123
SOME VEHICLES MAY EXPERIENCE SPARK KNOCK DURING LIGHT-TO-MODERATE ACCELERATIONS. *TT
Bulletin Number: 0014
VEHICLES MAY EXPERIENCE INNER FENDER WELL- DENTED OR DINGED FROM STONES BEING THROWN INTO WHEELWELL. *MJS
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 0017
SUBJECT ON THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODES MAY APPEAR. *MJS
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 00238
SOME VEHICLES MAY EXHIBIT A NO CRANK / NO START CONDITION IN TEMPERATURES BELOW 12 DEGREES C (10 DEGREES F). *TT
Bulletin Number: 00239
A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. *TT
Bulletin Number: 00261
SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES. *TT
Bulletin Number: 0038
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS
Bulletin Number: 00611
SOME BI-FUEL VEHICLES MAY REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT DURING SERVICE AND MAY NOT RUN ON CNG OR LPG., RECALIBRATION OF THE PCM/REPLACEMENT. *MJS
Bulletin Number: 00L07
THIS BULLETIN INVOLVES FUEL DOOR LABEL APPLICATION / REPLACEMENT. *JB
Bulletin Number: 01111
SOME VEHICLES MAY EXHIBIT A WATER LEAK AROUND THE REAR (SLIDING) WINDOW. *TT
Bulletin Number: 01136
SUBJECT REGARDING OVERVIEW OF BI-FUEL CNG VEHICLE PARAMETER IDENTIFICATION DATA (PID), INPUTS AND OUTPUTS AS A DIAGNOSTIC AID FOR BI-FUEL VEHICLES. *TT
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01182
SOME VEHICLES MAY EXPERIENCE A COSMETIC CRACK IN THE OUTER DOOR PANEL AT THE LOWER REAR CORNER OF WINDOW OPENING.*JB
Bulletin Number: 01192
SOME VEHICLES MAY EXHIBIT A GRABBING CONDITION FROM THE REAR DRUM BRAKES DURING THE FIRST FEW BRAKE APPLICATIONS AFTER EXTENDED HUMIDITY EXPOSURE. *TT
Bulletin Number: 01201
SOME VEHICLES MAY EXHIBIT HIGH IDLE AND/OR PCV SYSTEM ICING AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES ON VEHICLES EQUIPPED WITH 4.2L ENGINE BUILT THORUGH 1/24/2000. *TT
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 012110
SOME VEHICLES EQUIPPED WITH THE ROMEO BUILT 4.6L 2V ENGINE MAY EXHIBIT AN ENGINE OIL LEAK OR OIL WEEPAGE FROM THE CYLINDER HEAD GASKET AT THE RIGHT HAND REAR OR THE LEFT HAND FRONT OF THE ENGINE. *TT
Bulletin Number: 012112
A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTE OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT
Bulletin Number: 012113
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL
Bulletin Number: 01214
INFORMATION TO AID IN DIAGNOSIS FOR CLARIFICATION OF LOCK-OFF SOLENOID AND SOLENOID TANK VALVE COIL RSISTANCES FOR BI-FUEL VEHICLES. *TT
Bulletin Number: 01215
A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTER OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT
Bulletin Number: 01218
SOME VEHICLES MAY EXHIBIT A NO CRANK, NO START CONDITION DUE TO CORROSION OF THE STARTER CABLE B+ TERMINAL AT THE STARTER SOLENOID. *TT
Bulletin Number: 01221
SOME DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT A ROUGH IDLE, OR NO START IN COLD CONDITIONS. *TT
Bulletin Number: 01231
SOME COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT ROUGH IDLE OR NO START WHEN COLD. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 0142
SOME VEHICLES MAY EXHIBIT THE ENGINE OIL SENDING UNIT CONTACTING THE OIL DRIP SHIELD ATTACHED TO THE FRONT AXLE. *TT
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 0182
SOME BI-FUEL VEHICLES MAY EXHIBIT A NO START CONDITION. *TT
Bulletin Number: 0193
A CONDITION MAY EXIST WHERE A DRIVELINE VIBRATION AND / OR A TRANSMISSION FLUID LEAK FROM THE EXTENSION HOUSING SEAL AREA MAY OCCUR ON SOME VEHICLES. THIS MAY BE CAUSED BY THE EXTENSION HOUSING BUSHING OR SEAL WALKING / SPINNING OUT DUE T
Bulletin Number: 020503
GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996. *TT UPDATE. *TT
Bulletin Number: 02105
SOME BI-FUEL CANG AND LPG VEHICLES MAY EXHIBIT A NO START CONDITION. *TT
Bulletin Number: 02106
SOME BI-FUEL LPG VEHICLES (WITH COOLANT LOCK OFF) MAY EXHIBIT A NO START CONDITION. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02193
DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ
Bulletin Number: 02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
Bulletin Number: 0245
INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT
Bulletin Number: 0253
SUBJECT REGARDING ALTERNATIVE FUEL VEHICLE COMPRESSED NATURAL GAS TANK INSPECTION. *TT
Bulletin Number: 030402
ON SOME DEDICATED CNG VEHICLES, A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE. REVISED SERVICE PARTS. *TT
Bulletin Number: 03102
COMPRESSED NATURAL GAS (CNG). ROUGH IDLE OR NO START WHEN COLD. VEHICLES EQUIPPED WITH CNG BI-FUEL ENGINE ONLY. *TT
Bulletin Number: 03103
VEHICLES WITHOUT THE COOLANT LOCK-OFF MAY EXHIBIT A NO START CONDITION. *TT
Bulletin Number: 03104
BI-FUEL LPG VEHICLES (WITH COOLANT LOCK OFF) MAY EXHIBIT A NO START CONDITION. *TT
Bulletin Number: 031404
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
Bulletin Number: 03144
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 031513
TIE ROD END INSPECTION PROCEDURE. *TT
Bulletin Number: 03183
DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY. *TT
Bulletin Number: 03206
SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY. LOSS OF POWER AT HEAVY LOAD, DIAGNOSTIC TROUBLE CODES (DTCS) FOR LEAN FUEL, ROUGH IDLE, HARD START,
Bulletin Number: 0324
DRIVER'S SIDE DOOR GLASS THAT BINDS WHEN OPERATED. *TT
Bulletin Number: 0342
POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE, ON SOME DEDICATED CNG VEHICLES. *TT *JB
Bulletin Number: 03610
TIE ROD END INSPECTION PROCEDURE. CANADA VEHICLES ONLY. *TT *JB
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 0399
TIE ROD END INSPECTION PROCEDURE. *TT
Bulletin Number: 0416
DRIVELINE CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE ACCELREATION AND/OR BRAKING. *TT
Bulletin Number: 041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04217
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04266
A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP. *TT
Bulletin Number: 0457
POP/THUMP NOISE AT END OF WINDOW MOVEMENT AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION. *TT
Bulletin Number: 04L19
CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE. *TT
Bulletin Number: 050618
REAR AXLE NOISE REPAIR. *SC
Bulletin Number: 05417
INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT
Bulletin Number: 0554
USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE. *TT
Bulletin Number: 05618
REAR AXLE NOISE REPAIR. *TT
Bulletin Number: 07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
Bulletin Number: 090308
MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455
Bulletin Number: 11794
EXPERIENCING A RUBBING OR SQUEAK NOISE AS THE STEERING WHEEL IS TURNED. *TT
Bulletin Number: 11799
SOME SUPERCAB VEHICLES MAY EXHIBIT A MOAN / DROAN IN THE CAB AT 1500 - 1600 RPM OR A CAB VIBRATION AT 1800 - 1900 RPM. *TT
Bulletin Number: 11811
SOME VEHICLES BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT
Bulletin Number: 11814
SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT
Bulletin Number: 12071
SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *MJS
Bulletin Number: 12120
SOME VEHICLES WITH 4R700 TRANSMISSIONS BUILT FROM 4/16/98 THROUGH THE END OF THE 1998 MODEL YEAR MAY EXHIBIT A LEAK FROM THE VENT AREA OF THE TRANSMISSION. *TT
Bulletin Number: 12120
SOME VEHICLES WITH 4R70W TRANSMISSIONS BUILT FROM 4/16/98 THROUGH 10/30/98 MAY EXHIBIT A LEAK FROM THE VENT AREA OF THE TRANSMISSION. *MJS
Bulletin Number: 12139
SOME VEHICLES EQUIPPED WITH 4.6L OR 6.8L ENGINES MAY EXHIBIT A COLD START ENGINE NOISE UNTIL WARMED UP. *MJS
Bulletin Number: 12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
Bulletin Number: 12161
SOME VEHICLES BUILT WITH 3-LEAF REAR SPRINGS MAY EXHIBIT A REAR SPRING RATTLE. *MJS
Bulletin Number: 12208
SOME TEXAS DEPARTMENT OF TRANSPORTATION (DOT) TRUCKS MAY ENCOUNTER A RADIO FREQUENCY INTERFERENCE (RFI) CONDITION WHEN USING HAND HELD TWO-WAY RADIOS IN THE RANGE OF 47.18 MHZ. *TT
Bulletin Number: 12272
SOME VEHICLES BUILT WITH THE 4.2L ENGINE THAT ARE OPERATING IN MEXICO MAY EXHIBIT A BACKFIRE CONCERN. *TT
Bulletin Number: 12590
SOME 4X4 VEHICLES MAY EXHIBIT A MOAN NOISE FROM THE FRONT DIFFERENTIAL WHEN THE VEHICLE IS OPERATING IN 4X2 MODE AND GOES AWAY WHEN OPERATING IN 4X4 MODE. *TT
Bulletin Number: 12591
SOME VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOANING NOISE. *TT
Bulletin Number: 12601
EXPERIENCING WHISTLING NOISE COMING FROM THE FRONT OF THE VEHICLE AT HIGHWAY SPEEDS. *TT
Bulletin Number: 12720
SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE FLEXIBLE RUBBER COOLANT HOSE. *TT
Bulletin Number: 12725
SOME VEHICLES MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT
Bulletin Number: 12738
SOME VEHICLES MAY EXHIBIT A IDLE VIBRATION.
Bulletin Number: 12750
SOME VHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP WITH NO DIAGNOSTIC TROUBLE CODES (DTC). *TT
Bulletin Number: 12776
SOME VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP ON WITH NO DIAGNOSTIC TROUBLE CODES (DTC) DETECTED. *TT
Bulletin Number: 12879
SUBJECT REGARDING REAR SPRING CLIP KITS FOR VEHICLES EXHIBITING A REAR SPRING RATTLE. *TT
Bulletin Number: 12882
SUBJECT REGARDING THE AVAILABILITY OF REAR SPRING CLIP KITS FOR VEHICLES EXHIBITING REAR SPRING RATTLE. *TT
Bulletin Number: 12905
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT
Bulletin Number: 13010
SOME VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AND AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOAN CONCERN. *TT
Bulletin Number: 13054
EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT
Bulletin Number: 13106
ON SOME VEHICLES THE FRONT BUMPERS MAY EXHIBIT RED STAINING (SPOTS) ON THE BUMER WING ENDS. *TT
Bulletin Number: 13186
INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS
Bulletin Number: 13203
INFORMATION REGARDING OUTWARD DENTS IN PICKUP BOX WHEEL WELLS. *MJS
Bulletin Number: 13219
INFORMATION REGARDING STEERING GEAR LEAKS FROM INPUT SHAFT SEALS. *MJS
Bulletin Number: 13238
INFORMATION REGARDING VEHICLES THAT EXHIBIT CRACKS IN THE DOOR SHEET METAL. *MJS
Bulletin Number: 13412
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT
Bulletin Number: 13479
SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT
Bulletin Number: 13505
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
Bulletin Number: 13550
SOME VEHICLES MAY EXHIBIT DENTS ON THE WHEEL WELL SHEET METAL OF THE PCIK-UP BOX AREA WHEN USED IN OFF-ROAD APPLICATIONS. *TT
Bulletin Number: 13745
SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS
Bulletin Number: 13838
CONCERNS WITH VEHICLES EXHIBITING A WINDSHIELD CREAK / SQUEAK. *TT
Bulletin Number: 14039
INFORMATION REGARDING MALFUNCTION INDICATOR LAMP ON -P030X DTC'S CONTACT REQUEST / DETROIT AREA. **MR
Bulletin Number: 14365
THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT. *JB
Bulletin Number: 14609
SUBJECT REGARDING HIGH IDLE AND/OR CHECK ENGINE LIGHT CONDITION. *JB
Bulletin Number: 15113
SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION. *YD
Bulletin Number: 15145
SOME VEHICLES EQUIPPED WITH REMOTE LOCKING TAILGATES MAY EXHIBIT A TAILGATE LOCKING ITSELF WHEN THE VEHICLE IS BEING DRIVEN OVER ROUGH ROADS OR IS SLAMMED SHUT. *ET
Bulletin Number: 15260
CONCERNS WITH CORRODED POSITIVE STARTER CABLE. *TT
Bulletin Number: 15271
DEDICATED CNG REGULATOR BOWL KIT AVAILABLE. *JG
Bulletin Number: 15299
SOME VEHICLES MAY EXHIBIT CORROSION AT THE ATTACHMENT POINT OF THE STARTER CABLE B+ TERMINAL, AT THE STARTER SOLENOID. *TT
Bulletin Number: 15570
SOME VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS INCLUDING LACKS POWER, HESITATES, HARD TO START, AND/OR MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND PRODUCE POSSIBLE DIAGNOSTIC TROUBLE CODES P0103, P0172 AND P0175. *TT
Bulletin Number: 15692
SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT
Bulletin Number: 15742
INFORMATION ON VEHICLES EXHIBITING A PERCEIVED POOR FUEL RANGE / ECONOMY, AND OR A FAULTY FUEL GAUGE. *TT
Bulletin Number: 15758
SNOW PACKING OF THE AIR FILTER WHEN DRIVING IN SEVERE SNOW CONDITIONS MAY EXHIBIT LOSS OF POWER AND / OR THE MALFUNCTION INDICATOR LAMP ILLUMINATING. *TT
Bulletin Number: 15817
SOME VEHICLES EQUIPPED WITH BI-FUEL (CNG/LPG) ALTERNATE FUEL ENGINES MAY EXHIBIT HARD / NO START, RUNS ROUGH OR MISSES AFTER STARTING, AND OR HESITATION ON ACCELERATION WHEN OPERATED IN THE BI-FUEL MODE. *TT
Bulletin Number: 16416
NO/HARD START IN COLD AMBIENTS / NEW TWO-PIECE BLOCK HEATER CORD RELEASED. *MJ
Bulletin Number: 16602
LOCKING TAILGATE LOCKS ITSELF. *TT
Bulletin Number: 16605
REDUCED POWER STEERING ASSIST AND/OR POWER STEERING LEAKS WHEN DRIVEN IN TEMPERATURES EQUAL TO OR LESS THAN -25 DEGREES CELCIUS. *TT
Bulletin Number: 16835
TAILGATE LOCKING BY ITSELF WHEN SLAMMED SHUT OR WHEN THE VEHICLE IS BEING DRIVEN OVER ROUGH ROADS. *TT
Bulletin Number: 16928
VARIOUS INTERMITTENT ELECTRICAL CONCERNS INCLUDING BUT NOT LIMITED TO SOME ACCESSORIES REMAINING POWERED UP WITH THE KEY OUT OF THE IGNITION, MULTIPLE SYSTEM WARNING LIGHTS WITH SHORT TO POWER OR LOW BATTERY VOLTAGE DIAGNOSTIC TROUBLE CODES
Bulletin Number: 16969
DAMAGED REAR LICENSE PLATE LAMPS DUE TO ROCKS AND/OR GRAVEL HITTING THE LAMP ASSEMBLIES. *TT
Bulletin Number: 17009
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH NO HARD FAULT. *TT
Bulletin Number: 17320
BROKEN EXHAUST MANIFOLD STUDS. *TT
Bulletin Number: 17448
REMOTE OIL FILTER ADAPTOR REPLACEMENT - NEW SERVICE PART. *TT
Bulletin Number: 17731
WHINE FROM POWER STEERING. *TT
Bulletin Number: 17777
REAR LEAF SPRING NOISE. *TT
Bulletin Number: 17823
POWER STEERING LEAK - SERVICE TIP. *TT
Bulletin Number: 18466
AXLE WHINE HOWL. THIS INCLUDES 1997-05 FORD VEHICLES. *EH
Bulletin Number: 4619
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT
Bulletin Number: 4628
SOME VEHICLES MAY EXHIBIT REAR AXLE NOISE. *TT
Bulletin Number: 4631
BRIEF INFORMATION ON VEHICLES EXHIBIT VIBRATION AT CRUISE OVER 50 MPH. *TT
Bulletin Number: 4635
COLD ENGINE KNOCK. *TT
Bulletin Number: 4638
MALFUNCTION INDICATOR LAMP ON, WITH P0300 - P0308 MISFIRE DIAGNOSTIC TROUBLE CODES WITH A 4.6L ENGINE. *TT
Bulletin Number: 4660
SUBJECT REGARDING THE NAGATIVE BATTERY TERMINAL COVER ON SOME VEHICLES. *TT
Bulletin Number: 4682
SOME SUPER CAB VEHICLES MAY EXHIBIT A MOAN / DROAN IN THE CAB AT 1500 - 1600 RPM OR A CAB VIBRATION AT 1800 - 1900 RPM. *TT
Bulletin Number: 4683
SOME VEHICLES MAY EXHIBIT A RUBBING OR SQUEAK NOISE AS THE STEERING WHEEL IS TURNED. *TT
Bulletin Number: 4703
SOME TRUCKS BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND TRUCKS BUILT WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT
Bulletin Number: 4981
SOME VEHICLES EQUIPPED WITH 5.4L ENGINES MAY EXHIBIT A COLD START ENGINE KNOCK CONCERN UNTIL WARMED UP. *TT
Bulletin Number: 5128
SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. ENGINEERING IS INVESTIGATING. *TT
Bulletin Number: 5257
INFORMATION ON VEHICLES EXHIBITING COLD ENGINE KNOCK. *TT
Bulletin Number: 5258
INFORMATION ON VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. *TT
Bulletin Number: 5262
INFORMATION ON DIAGNOSTICING ERRATIC WINDSHIELD WIPER OPERATION. *TT
Bulletin Number: 5267
SUBJECT REGARDING MISFIRE CODES ON ALL ENGINES. *TT
Bulletin Number: 5348
SOME VEHICLES EQUIPPED WITH M5OD R2 MANUAL TRANSMISSION MAY EXHIBIT A GEAR SHIFT RATTLE CONDITION IN THIRD GEAR. *TT
Bulletin Number: 5356
SOME VEHICLES BUILT WITH THE 4.2L ENGINE THAT ARE OPERATING IN MEXICO MAY EXHIBIT A BACKFIRE CONCERN. *TT
Bulletin Number: 5955
SUBJECT REGARDING FRONT DIFFERENTIAL NOISE INVESTIGATION. *TT
Bulletin Number: 6232
SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE COIL RESULTING IN ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE P0304 AND / OR ROUGH IDLE. *TT
Bulletin Number: 6242
EXPERIENCING A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE. *TT
Bulletin Number: 6287
SOME VEHICLES MAY EXPERIENCE AN IDLE VIBRATION. *TT
Bulletin Number: 6315
VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP WITH NO DIAGNOSTIC TROUBLE CODE (DTC) DETECTED. *TT
Bulletin Number: 6477
SUBJECT REGARDING REAR SPRING RATTLE. *TT
Bulletin Number: 6489
SOME VEHICLES BUILT WITH 3-LEAF OR 4-LEAF REAR SPRINGS MAY EXHIBIT A REAR SPRING RATTLE. *TT
Bulletin Number: 6702
VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AND AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOAN CONCERN. *TT
Bulletin Number: 6996
INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT
Bulletin Number: 7022
INFORMATION REGARDING OUTWARD DENTS IN PICKUP BOX WHEEL WELLS. *MJS
Bulletin Number: 7080
INFORMATION REGARDING STEERING GEAR LEAKS FROM INPUT SHAFT SEALS. *MJS
Bulletin Number: 7100
INFORMATION REGARDING TRANSMISSION TROUBLE CODES. *MJS
Bulletin Number: 7106
INFORMATION REGARDING THE WINNERS OF THE EDSR OF THE MONTH QUALITY AWARDS FOR THE MONTH OF AUGUST. *MJS
Bulletin Number: 7353
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT
Bulletin Number: 7821
CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING.
Bulletin Number: 8163
SOME VEHICLES WITH 4.6L, OR 6.8L ENGINES MAY EXHIBIT A ROLLER FINGER FOLLOWER COMING OFF DURING ENGINE CRANKING IN COLD TEMPERATURES BELOW ZERO DEGREES F. A ONE-TIME NOISE FROM THE ENGINE MAY BE HEARD, FOLLOWED BY ROUGH RUNNING / MISSES
Bulletin Number: 8482
SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE(S) P030X (CYLINDER #1 THROUGH #8 MISFIRE DETECTED) THAT CANNOT BE RESOLVED USING PROPER DIAGNOSTICS. **MR
Bulletin Number: 870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
Bulletin Number: 97090297183
EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC
Bulletin Number: 976007
BRIEF INFORMATION REGARDING CYLINDER HEAD TEMPERATURE (CHT) AND FAIL SAFE COOLING. *TT
Bulletin Number: 976011
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 980310
EXPERIENCING VIBRATION AT CRUISE OVER 50 MPH. *YC
Bulletin Number: 980317
SYMPTOMS REGARDING P0300-P0308 MISFIRE DTCS WITH 4.6L ENGINES. *YC
Bulletin Number: 9810569
CONCERNS OF SQUEAKY / NOISY PITMAN ARM. *YC
Bulletin Number: 9811001
CONCERNS WITH WATERLEAK CONDITIONS AT THE BACK GLASS ON SOME VEHICLES. *TT
Bulletin Number: 9811286
IMPORTANT INFORMATION ON USING THE NGS (NEW GENERATION STAR) TESTER ON SOME VEHCILES. *TT
Bulletin Number: 98113
SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT
Bulletin Number: 9811342
INFORMATION ON REMOVING THE RADIO CHASSIS FROM SOME VEHICLES. *TT
Bulletin Number: 9811344
SOME VEHICLES MAY EXHIBIT LOOSE LUGNUTS AND / OR BROKEN WHEEL STUDS. *TT
Bulletin Number: 9811452
A CUSTOMER CONERN OF INOPERATIVE CRUISE CONTROL. *YC
Bulletin Number: 98123
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT
Bulletin Number: 98130
SERVICE PROCEDURE FOR ORANGE SERVICE TAGGED TRANSMISSIONS. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK
Bulletin Number: 981517
INSTALL A REVISED CHILD SEAT TETHER KIT.
Bulletin Number: 981610
THE SEAT BACK MAY NOT LATCH/ LOCK IN THE DESIRED POSITION AND REMAIN FOLDED FORWARD OVER THE SEAT CUSHION. YD
Bulletin Number: 981612
FUEL MAY LEAK FROM THE SPRING LOCK COUPLINGS. YD
Bulletin Number: 981613
TRANSMISSION FLUID LEAKS AT RADIATOR. YD
Bulletin Number: 981617
FLOOR MAT INSTALLATION PROCEDURE SERVICE TIP. YD
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 98168
INSTALLATION OF VINYL FLOOR MATS SERVICE TIP. AK
Bulletin Number: 98168
TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD
Bulletin Number: 98169
STEERING -ALIGNMENT-TOE SET PROCEDURE SERVICE TIP. YD
Bulletin Number: 9818
FUEL PUMP REPLACEMENT PROCEDURE - SERVICE TIP. *TT
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 98203
CONCERNS WITH THE POTENTIAL EFFECTS OF ADHESIVES USED FOR BODY PANEL REPAIRS. *TT
Bulletin Number: 98203
CONCERNS WITH ADHENSIVES NOT RECOMMENDED FOR BODY PANEL REPAIRS. *YC
Bulletin Number: 98209
A " TICKING " NOISE ON INITIAL STARTUP WITH SHIFT SELECTOR IN " P " OR " N " POSITION MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 982110
DURING HIGH IDLE SPEEDS THROTTLE STICKS AFTER STEADY STATE DRIVING IN COLD AMBIENT TEMPERATURES. *YC
Bulletin Number: 982117
A NEW PARKING BRAKE CONTROL RUBBER BUMPER STOP IS NOW AVAILABLE FOR SERVICE. *YC
Bulletin Number: 982312
ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 982325
THE MALFUCNTION INDICATOR LAMP ( MIL ) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0455 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982548
BRIEF INFORMATION GIVING THE CORRECT PART NUMBER FOR TSB 98-3-12. *YC
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 982673
IF YOU ENCOUNTER A VEHICLE WITH A MISSING WHEEL HUB O-RING, DO NOT INSTALL A NEW O-RING. *YC
Bulletin Number: 982690
VEHICLES WITH MANUAL TRANSMISSIONS MAY HAVE A CUSTOMER CONCERN OF INOPERATIVE CRUISE CONTROL. *YC
Bulletin Number: 983070
SOMVE VEHICLES MAY EXHIBIT A BUZZ / LOW GROWL NOISE COMING FROM THE AREA OF THE TRANSFER CASE MANUAL SHIFT LEVER. *TT
Bulletin Number: 983074
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT
Bulletin Number: 983082
CONCERNS WITH WATER LEAKING AT THE REAR SLIDING BACKGLASS. *TT
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 983301
THIS BULLETIN PROVIDES PROCEDURES ON NEUTRALIZING THE EXHAUST, TRANSMISSION AND ENGINE MOUNTS. *TT
Bulletin Number: 983302
THIS BULLETIN MENTIONS HOW SOME HUB O-RINGS MAY BE CUT DURING THE INSTALLATION OF THE WHEELS. *TT
Bulletin Number: 983306
CONCERNS OF FRAME STRIKE ON THE REAR AXLE. *TT
Bulletin Number: 983315
THE 4R100 TRANSMISSION WILL HAVE AN ORANGE "PRIOR TO REPAIR" TAG ON THE FLUID PAN. *TT
Bulletin Number: 983316
SOME CUSTOMER MAY COMPLAIN OF A TICKING NOISE ON INITIAL COLD START-UP IN PARK POSITION AND NEUTRAL POSITION. *TT
Bulletin Number: 983573
SOME VEHICLES MAY EXHIBIT CAB VIBRATION. *TT
Bulletin Number: 98412
THE 4R70W TRANSMISSION INSTALLED IN SOME VEHICLES WILL HAVE AN ORANGE
Bulletin Number: 98419
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC
Bulletin Number: 98422
SERVICE PROCEDURE FOR ORANGE SERVICE TAGGED TRANSMISSIONS. *YC
Bulletin Number: 9844
SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 98-4717
VEHICLES EXHIBIT CRACKS IN DOOR SHEET METAL AT LOWER REAR OF THE WINDOW OPENING NEAR BELT MOLDING. *AK
Bulletin Number: 98-4725
VIBRATION AT CRUISE OVER 50 MPH. *AK
Bulletin Number: 98-4738
COLD ENGINE KNOCK 5.4L ACTION. *AK
Bulletin Number: 985028
INFORMATION REGARDING A NEW SERVICE PART RELEASED FOR THE LICENSE PLATE LIGHT CIRCUIT WHICH WILL REDUCE THE COSE OF REPAIRS. *TT
Bulletin Number: 985029
SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT
Bulletin Number: 985059
EXPERIENCING COLD ENGINE KNOCK (REPEAT / REVISED MESSAGE). *TT
Bulletin Number: 985062
SUBJECT REGARDING IDLE VIBRATION (REPEAT MESSAGE). *TT
Bulletin Number: 985063
SUBJECT REGARDING VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. (REPEAT MESSAGE). *TT
Bulletin Number: 985128
SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. *TT
Bulletin Number: 985143
SOME VEHICLES WITH 4R70W TRANSMISSIONS BUILT FROM 4/16/98 THROUGH THE END OF THE 1998 MODEL YEAR MAY EXHIBIT A LEAK FROM THE VENT AREA OF THE TRANSMISSION. *TT
Bulletin Number: 985185
COLD START ENGINE NOISE
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 985200
VEHICLES BUILT WITH 3-LEAF REAR SPRINGS MAY EXHIBIT A REAR SPRING RATTLE *MJS
Bulletin Number: 9858
THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0503 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9869
CONCERNS WITH HESITATION, STUMBLE, SURGE, MISS, ROUGH IDLE, STALL AT IDLE. *TT
Bulletin Number: 98812
A VIBRATION AT HIGHWAY SPEEDS MAY BE FELT ON SOME VEHICLES. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 98B33
OWNER NOTIFICATION FOR REPLACEMENT OF ENGINE CYLINDER HEADS. *TT
Bulletin Number: 98S14
SAFETY RECALL UPDATE TO REPLACE LOCKING LUG NUTS. *TT
Bulletin Number: 99107
CONDITIONS ON REAR DRUM GRABBING DURING FIRST FEW BRAKE APPLICATIONS WHILE BRAKES ARE COLD. *TT
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99128
SOME VEHICLES MAY EXHIBIT A WHISTLING NOISE WHILE DRIVING WITH A/C IN THE OFF POSITION AT SPEEDS ABOVE 64 KM/H (40 MPH). *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 99131
CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: 9913125
SONE POLICE VEHICLES AND OTHER VEHICLES WITH 4R70W MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT
Bulletin Number: 991313
SUBJECT REGARDING ANTI-LOCK BRAKE LAMP ILLUMINATION, INCREASED BREAK PEDAL EFFORT AND / OR FALSE ANTI-LOCK BRAKE SYSTEM (ABS) CYCLING AT LOW SPEEDS. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 991410
SOME VEHICLES MAY EXHIBIT AN INDUCTION BACKFIRE ON ACCELERATIONS AND DECELERATIONS DURING ALL AMBIENT TEMPERATURES. *TT
Bulletin Number: 99143
SOME 4X4 VEHICLES BUILT WITH CENTER DISCONNECT FRONT AXLES MAY EXHIBIT A MOANING NOISE FROM THE FRONT DIFFERENTIAL WHILE OPERATING IN 4X2 MODE. *TT
Bulletin Number: 99144
VEHICLES MAY EXPERIENCE A MOANING NOISE HEARD AT APPROXIMATELY 1100 RPM WITH THE A/C COMPRESSOR ENGAGED. *TT
Bulletin Number: 99164
CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER. *TT
Bulletin Number: 99185
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT
Bulletin Number: 99188
VEHICLES WITH 4.2L ENGINE (CANADIAN) MAY BACKFIRE ON ACCELERATION AT ALL AMBIENT TEMPERATURE. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99207
SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
Bulletin Number: 99241
ON 4X2 VEHICLES WITH 4R70W AND 139 INCH WHEELBASE, A VIBRATION FROM TRANSMISSION AND / OR A TRANSMISSION FLUID LEAK FROM THE EXTENSION HOUSING SEAL MAY OCCUR. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 99411
VEHICLES EXPERIENCING INCREASED BRAKE PEDAL EFFORT AND / OR FALSE ABS CYCLING AT LOW SPEEDS, OR ABS LAMP ILLUMINATION. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT
Bulletin Number: 996034
EXPERIENCING A ENGINE KNOCK AT COLD START-UP. *TT
Bulletin Number: 996042
INFORMATION ON USING 1999 PROCEDURES MANUAL FOR SIDE MIRROR REPLACEMENT. *TT
Bulletin Number: 996113
EXPERIENCING FRONT DIFFERENTIAL NOISE. *TT
Bulletin Number: 996139
CONCERNS WITH FRONT DIFFERENTIAL NOISE. *TT
Bulletin Number: 996754
THIS ONLINE BULLETIN ADDRESSES CONCERNS WITH CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT
Bulletin Number: 996780
THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT
Bulletin Number: 996876
INFORMATION PERTAINING TO CONDITIONS WITH RED STAINING (SPOTS) ON THE FRONT BUMPER WING ENDS. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: 9996
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT
Bulletin Number: BC0717961021
INFORMATION FOR WHEN REPLACING AN INTERIOR TRIM COMPONENT UNDER WARRANTY. *TT
Bulletin Number: BC105849705
VEHICLES WITH PREMIUM RADIOS WILL BE EQUIPPED WITH VOLUME CONTROL/ON-OFF SWITCH. *TW
Bulletin Number: TSB-14-0147
FORD/LINCOLN: SAFETY RECALL ISSUED DUE TO ONE OR BOTH FUEL TANK STRAPS FRACTURING DUE TO BEING IN HIGH CORROSION AREAS FOR AN EXTENDED PERIOD AND DISLODGING FUEL TANK. MODEL 1997-99 F250, 1997-03 F150, 2004 F150 HERITAGE, 2002-2003 BLACKW
Bulletin Number: TSB-14-0164
FORD/LINCOLN: SAFETY RECALL REGARDING HIGH CORROSION AREAS FOR OPERATING, FOR AN EXTENDED TIME, VEHICLES WHERE BOTH OR ONE STRAP OF FUEL TANK CAN FRACTURE, AFTER CONTACTING GROUND. MODEL 1997-99 F250 LD, 1997-03 F150, 2004 F150 HERITAGE,
1998 FORD F-250
Bulletin Number: 00123
SOME VEHICLES MAY EXPERIENCE SPARK KNOCK DURING LIGHT-TO-MODERATE ACCELERATIONS. *TT
Bulletin Number: 0014
VEHICLES MAY EXPERIENCE INNER FENDER WELL- DENTED OR DINGED FROM STONES BEING THROWN INTO WHEELWELL. *MJS
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 0017
SUBJECT ON THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODES MAY APPEAR. *MJS
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 00238
SOME VEHICLES MAY EXHIBIT A NO CRANK / NO START CONDITION IN TEMPERATURES BELOW 12 DEGREES C (10 DEGREES F). *TT
Bulletin Number: 00239
A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. *TT
Bulletin Number: 00261
SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES. *TT
Bulletin Number: 00611
SOME BI-FUEL VEHICLES MAY REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT DURING SERVICE AND MAY NOT RUN ON CNG OR LPG., RECALIBRATION OF THE PCM/REPLACEMENT. *MJS
Bulletin Number: 00L07
THIS BULLETIN INVOLVES FUEL DOOR LABEL APPLICATION / REPLACEMENT. *JB
Bulletin Number: 01111
SOME VEHICLES MAY EXHIBIT A WATER LEAK AROUND THE REAR (SLIDING) WINDOW. *TT
Bulletin Number: 01136
SUBJECT REGARDING OVERVIEW OF BI-FUEL CNG VEHICLE PARAMETER IDENTIFICATION DATA (PID), INPUTS AND OUTPUTS AS A DIAGNOSTIC AID FOR BI-FUEL VEHICLES. *TT
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01182
SOME VEHICLES MAY EXPERIENCE A COSMETIC CRACK IN THE OUTER DOOR PANEL AT THE LOWER REAR CORNER OF WINDOW OPENING.*JB
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 012110
SOME VEHICLES EQUIPPED WITH THE ROMEO BUILT 4.6L 2V ENGINE MAY EXHIBIT AN ENGINE OIL LEAK OR OIL WEEPAGE FROM THE CYLINDER HEAD GASKET AT THE RIGHT HAND REAR OR THE LEFT HAND FRONT OF THE ENGINE. *TT
Bulletin Number: 012112
A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTE OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT
Bulletin Number: 012113
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL
Bulletin Number: 01215
A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTER OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT
Bulletin Number: 0142
SOME VEHICLES MAY EXHIBIT THE ENGINE OIL SENDING UNIT CONTACTING THE OIL DRIP SHIELD ATTACHED TO THE FRONT AXLE. *TT
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 0182
SOME BI-FUEL VEHICLES MAY EXHIBIT A NO START CONDITION. *TT
Bulletin Number: 0193
A CONDITION MAY EXIST WHERE A DRIVELINE VIBRATION AND / OR A TRANSMISSION FLUID LEAK FROM THE EXTENSION HOUSING SEAL AREA MAY OCCUR ON SOME VEHICLES. THIS MAY BE CAUSED BY THE EXTENSION HOUSING BUSHING OR SEAL WALKING / SPINNING OUT DUE T
Bulletin Number: 02106
SOME BI-FUEL LPG VEHICLES (WITH COOLANT LOCK OFF) MAY EXHIBIT A NO START CONDITION. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02193
DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ
Bulletin Number: 02E17
SUBJECT REGARDING HEATER HOSE TO FUEL RAIL FLEX LINE INSPECTION. *JG
Bulletin Number: 030402
ON SOME DEDICATED CNG VEHICLES, A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE. REVISED SERVICE PARTS. *TT
Bulletin Number: 03104
BI-FUEL LPG VEHICLES (WITH COOLANT LOCK OFF) MAY EXHIBIT A NO START CONDITION. *TT
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 0342
POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE, ON SOME DEDICATED CNG VEHICLES. *TT *JB
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04217
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04L19
CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE. *TT
Bulletin Number: 05417
INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT
Bulletin Number: 07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
Bulletin Number: 11794
EXPERIENCING A RUBBING OR SQUEAK NOISE AS THE STEERING WHEEL IS TURNED. *TT
Bulletin Number: 11799
SOME SUPERCAB VEHICLES MAY EXHIBIT A MOAN / DROAN IN THE CAB AT 1500 - 1600 RPM OR A CAB VIBRATION AT 1800 - 1900 RPM. *TT
Bulletin Number: 11811
SOME VEHICLES BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT
Bulletin Number: 11814
SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT
Bulletin Number: 12071
SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *MJS
Bulletin Number: 12120
SOME VEHICLES WITH 4R70W TRANSMISSIONS BUILT FROM 4/16/98 THROUGH 10/30/98 MAY EXHIBIT A LEAK FROM THE VENT AREA OF THE TRANSMISSION. *MJS
Bulletin Number: 12120
SOME VEHICLES WITH 4R700 TRANSMISSIONS BUILT FROM 4/16/98 THROUGH THE END OF THE 1998 MODEL YEAR MAY EXHIBIT A LEAK FROM THE VENT AREA OF THE TRANSMISSION. *TT
Bulletin Number: 12139
SOME VEHICLES EQUIPPED WITH 4.6L OR 6.8L ENGINES MAY EXHIBIT A COLD START ENGINE NOISE UNTIL WARMED UP. *MJS
Bulletin Number: 12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
Bulletin Number: 12208
SOME TEXAS DEPARTMENT OF TRANSPORTATION (DOT) TRUCKS MAY ENCOUNTER A RADIO FREQUENCY INTERFERENCE (RFI) CONDITION WHEN USING HAND HELD TWO-WAY RADIOS IN THE RANGE OF 47.18 MHZ. *TT
Bulletin Number: 12248
SOME HEAVY DUTY AND SUPER DUTY VEHICLES MAY EXHIBIT VARIOUS TRANSMISSION CONCERNS, INCLUDING STALL ON TRANSMISSION ENGAGEMENT AND / OR A BUZZ NOISE ON ENGAGEMENT. *TT
Bulletin Number: 12562
SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE P1298. *TT
Bulletin Number: 12590
SOME 4X4 VEHICLES MAY EXHIBIT A MOAN NOISE FROM THE FRONT DIFFERENTIAL WHEN THE VEHICLE IS OPERATING IN 4X2 MODE AND GOES AWAY WHEN OPERATING IN 4X4 MODE. *TT
Bulletin Number: 12591
SOME VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOANING NOISE. *TT
Bulletin Number: 12601
EXPERIENCING WHISTLING NOISE COMING FROM THE FRONT OF THE VEHICLE AT HIGHWAY SPEEDS. *TT
Bulletin Number: 12720
SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE FLEXIBLE RUBBER COOLANT HOSE. *TT
Bulletin Number: 12738
SOME VEHICLES MAY EXHIBIT A IDLE VIBRATION.
Bulletin Number: 12750
SOME VHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP WITH NO DIAGNOSTIC TROUBLE CODES (DTC). *TT
Bulletin Number: 12776
SOME VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP ON WITH NO DIAGNOSTIC TROUBLE CODES (DTC) DETECTED. *TT
Bulletin Number: 12879
SUBJECT REGARDING REAR SPRING CLIP KITS FOR VEHICLES EXHIBITING A REAR SPRING RATTLE. *TT
Bulletin Number: 12882
SUBJECT REGARDING THE AVAILABILITY OF REAR SPRING CLIP KITS FOR VEHICLES EXHIBITING REAR SPRING RATTLE. *TT
Bulletin Number: 12905
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT
Bulletin Number: 13010
SOME VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AND AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOAN CONCERN. *TT
Bulletin Number: 13054
EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT
Bulletin Number: 13060
SUBJECT REGARDING VEHICLES EXHIBITING REAR BRAKE GRAB AND SHOE WEAR. *TT
Bulletin Number: 13106
ON SOME VEHICLES THE FRONT BUMPERS MAY EXHIBIT RED STAINING (SPOTS) ON THE BUMER WING ENDS. *TT
Bulletin Number: 13203
INFORMATION REGARDING OUTWARD DENTS IN PICKUP BOX WHEEL WELLS. *MJS
Bulletin Number: 13238
INFORMATION REGARDING VEHICLES THAT EXHIBIT CRACKS IN THE DOOR SHEET METAL. *MJS
Bulletin Number: 13412
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT
Bulletin Number: 13479
SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT
Bulletin Number: 13505
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
Bulletin Number: 13550
SOME VEHICLES MAY EXHIBIT DENTS ON THE WHEEL WELL SHEET METAL OF THE PCIK-UP BOX AREA WHEN USED IN OFF-ROAD APPLICATIONS. *TT
Bulletin Number: 13745
SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS
Bulletin Number: 13838
CONCERNS WITH VEHICLES EXHIBITING A WINDSHIELD CREAK / SQUEAK. *TT
Bulletin Number: 14039
INFORMATION REGARDING MALFUNCTION INDICATOR LAMP ON -P030X DTC'S CONTACT REQUEST / DETROIT AREA. **MR
Bulletin Number: 14365
THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT. *JB
Bulletin Number: 14455
OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT
Bulletin Number: 15113
SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION. *YD
Bulletin Number: 15260
CONCERNS WITH CORRODED POSITIVE STARTER CABLE. *TT
Bulletin Number: 15570
SOME VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS INCLUDING LACKS POWER, HESITATES, HARD TO START, AND/OR MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND PRODUCE POSSIBLE DIAGNOSTIC TROUBLE CODES P0103, P0172 AND P0175. *TT
Bulletin Number: 15742
INFORMATION ON VEHICLES EXHIBITING A PERCEIVED POOR FUEL RANGE / ECONOMY, AND OR A FAULTY FUEL GAUGE. *TT
Bulletin Number: 16515
OIL LEAK AT HIGH PRESSURE PUMP FITTINGS AND/OR PLUG. THIS INCLUDES SUPER DUTY F-SERIES. OASIS. *TT
Bulletin Number: 17009
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH NO HARD FAULT. *TT
Bulletin Number: 4628
SOME VEHICLES MAY EXHIBIT REAR AXLE NOISE. *TT
Bulletin Number: 4631
BRIEF INFORMATION ON VEHICLES EXHIBIT VIBRATION AT CRUISE OVER 50 MPH. *TT
Bulletin Number: 4635
COLD ENGINE KNOCK. *TT
Bulletin Number: 4638
MALFUNCTION INDICATOR LAMP ON, WITH P0300 - P0308 MISFIRE DIAGNOSTIC TROUBLE CODES WITH A 4.6L ENGINE. *TT
Bulletin Number: 4660
SUBJECT REGARDING THE NAGATIVE BATTERY TERMINAL COVER ON SOME VEHICLES. *TT
Bulletin Number: 4682
SOME SUPER CAB VEHICLES MAY EXHIBIT A MOAN / DROAN IN THE CAB AT 1500 - 1600 RPM OR A CAB VIBRATION AT 1800 - 1900 RPM. *TT
Bulletin Number: 4683
SOME VEHICLES MAY EXHIBIT A RUBBING OR SQUEAK NOISE AS THE STEERING WHEEL IS TURNED. *TT
Bulletin Number: 4703
SOME TRUCKS BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND TRUCKS BUILT WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT
Bulletin Number: 4981
SOME VEHICLES EQUIPPED WITH 5.4L ENGINES MAY EXHIBIT A COLD START ENGINE KNOCK CONCERN UNTIL WARMED UP. *TT
Bulletin Number: 5257
INFORMATION ON VEHICLES EXHIBITING COLD ENGINE KNOCK. *TT
Bulletin Number: 5258
INFORMATION ON VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. *TT
Bulletin Number: 5262
INFORMATION ON DIAGNOSTICING ERRATIC WINDSHIELD WIPER OPERATION. *TT
Bulletin Number: 5267
SUBJECT REGARDING MISFIRE CODES ON ALL ENGINES. *TT
Bulletin Number: 5348
SOME VEHICLES EQUIPPED WITH M5OD R2 MANUAL TRANSMISSION MAY EXHIBIT A GEAR SHIFT RATTLE CONDITION IN THIRD GEAR. *TT
Bulletin Number: 5901
SERVICE TIPS FOR IDENTIFYING INJECTOR DRIVER MODULE (IDM) FAILURE WITH DIAGNOSTIC TROUBLE CODE P1298. *TT
Bulletin Number: 5955
SUBJECT REGARDING FRONT DIFFERENTIAL NOISE INVESTIGATION. *TT
Bulletin Number: 6232
SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE COIL RESULTING IN ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE P0304 AND / OR ROUGH IDLE. *TT
Bulletin Number: 6287
SOME VEHICLES MAY EXPERIENCE AN IDLE VIBRATION. *TT
Bulletin Number: 6315
VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP WITH NO DIAGNOSTIC TROUBLE CODE (DTC) DETECTED. *TT
Bulletin Number: 6477
SUBJECT REGARDING REAR SPRING RATTLE. *TT
Bulletin Number: 6489
SOME VEHICLES BUILT WITH 3-LEAF OR 4-LEAF REAR SPRINGS MAY EXHIBIT A REAR SPRING RATTLE. *TT
Bulletin Number: 6702
VEHICLES EQUIPPED WITH THE 5.4L ENGINE, 4R100 TRANSMISSION AND AN AUXILIARY TRANSMISSION OIL COOLER MAY EXHIBIT A COASTDOWN MOAN CONCERN. *TT
Bulletin Number: 7022
INFORMATION REGARDING OUTWARD DENTS IN PICKUP BOX WHEEL WELLS. *MJS
Bulletin Number: 7353
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT
Bulletin Number: 7821
CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING.
Bulletin Number: 8163
SOME VEHICLES WITH 4.6L, OR 6.8L ENGINES MAY EXHIBIT A ROLLER FINGER FOLLOWER COMING OFF DURING ENGINE CRANKING IN COLD TEMPERATURES BELOW ZERO DEGREES F. A ONE-TIME NOISE FROM THE ENGINE MAY BE HEARD, FOLLOWED BY ROUGH RUNNING / MISSES
Bulletin Number: 8482
SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE(S) P030X (CYLINDER #1 THROUGH #8 MISFIRE DETECTED) THAT CANNOT BE RESOLVED USING PROPER DIAGNOSTICS. **MR
Bulletin Number: 976007
BRIEF INFORMATION REGARDING CYLINDER HEAD TEMPERATURE (CHT) AND FAIL SAFE COOLING. *TT
Bulletin Number: 980310
EXPERIENCING VIBRATION AT CRUISE OVER 50 MPH. *YC
Bulletin Number: 980312
EXCESSIVE WHITE SMOKE. VERIFY GLOW PLUG OPERATION BY PERFORMING GLOW PLUG SYSTEM OPERATION CHECK ON THE HARD START/NO START DIAGNOSTIC SHEET. *TT
Bulletin Number: 980317
SYMPTOMS REGARDING P0300-P0308 MISFIRE DTCS WITH 4.6L ENGINES. *YC
Bulletin Number: 9810569
CONCERNS OF SQUEAKY / NOISY PITMAN ARM. *YC
Bulletin Number: 9811001
CONCERNS WITH WATERLEAK CONDITIONS AT THE BACK GLASS ON SOME VEHICLES. *TT
Bulletin Number: 9811286
IMPORTANT INFORMATION ON USING THE NGS (NEW GENERATION STAR) TESTER ON SOME VEHCILES. *TT
Bulletin Number: 98113
SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT
Bulletin Number: 9811342
INFORMATION ON REMOVING THE RADIO CHASSIS FROM SOME VEHICLES. *TT
Bulletin Number: 9811344
SOME VEHICLES MAY EXHIBIT LOOSE LUGNUTS AND / OR BROKEN WHEEL STUDS. *TT
Bulletin Number: 9811452
A CUSTOMER CONERN OF INOPERATIVE CRUISE CONTROL. *YC
Bulletin Number: 98130
SERVICE PROCEDURE FOR ORANGE SERVICE TAGGED TRANSMISSIONS. *TT
Bulletin Number: 981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK
Bulletin Number: 981517
INSTALL A REVISED CHILD SEAT TETHER KIT.
Bulletin Number: 981610
THE SEAT BACK MAY NOT LATCH/ LOCK IN THE DESIRED POSITION AND REMAIN FOLDED FORWARD OVER THE SEAT CUSHION. YD
Bulletin Number: 981612
FUEL MAY LEAK FROM THE SPRING LOCK COUPLINGS. YD
Bulletin Number: 981613
TRANSMISSION FLUID LEAKS AT RADIATOR. YD
Bulletin Number: 981617
FLOOR MAT INSTALLATION PROCEDURE SERVICE TIP. YD
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 98168
INSTALLATION OF VINYL FLOOR MATS SERVICE TIP. AK
Bulletin Number: 98168
TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD
Bulletin Number: 98169
STEERING -ALIGNMENT-TOE SET PROCEDURE SERVICE TIP. YD
Bulletin Number: 9818
FUEL PUMP REPLACEMENT PROCEDURE - SERVICE TIP. *TT
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 98203
CONCERNS WITH ADHENSIVES NOT RECOMMENDED FOR BODY PANEL REPAIRS. *YC
Bulletin Number: 98203
CONCERNS WITH THE POTENTIAL EFFECTS OF ADHESIVES USED FOR BODY PANEL REPAIRS. *TT
Bulletin Number: 98209
A " TICKING " NOISE ON INITIAL STARTUP WITH SHIFT SELECTOR IN " P " OR " N " POSITION MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 982110
DURING HIGH IDLE SPEEDS THROTTLE STICKS AFTER STEADY STATE DRIVING IN COLD AMBIENT TEMPERATURES. *YC
Bulletin Number: 982117
A NEW PARKING BRAKE CONTROL RUBBER BUMPER STOP IS NOW AVAILABLE FOR SERVICE. *YC
Bulletin Number: 982312
ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 982313
SOME VEHICLES WITH A 7.3L DIRECT INJECTION (DI) TURBO DIESEL ENGINE, ONE OR MORE OF THE FOLLOWING CONCERNS MAY BE PRESENT: ROUGH IDLE, STALLING, HESITATION/ STUMBLE, LOSS / LACK OF POWER, POOR FUEL ECONOMY, AND EXCESSIVE OIL CONSUMPTION.
Bulletin Number: 982314
PREMATURE WEAR OF THE BELT TENSIONER MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 982325
THE MALFUCNTION INDICATOR LAMP ( MIL ) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0455 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982548
BRIEF INFORMATION GIVING THE CORRECT PART NUMBER FOR TSB 98-3-12. *YC
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 982673
IF YOU ENCOUNTER A VEHICLE WITH A MISSING WHEEL HUB O-RING, DO NOT INSTALL A NEW O-RING. *YC
Bulletin Number: 982690
VEHICLES WITH MANUAL TRANSMISSIONS MAY HAVE A CUSTOMER CONCERN OF INOPERATIVE CRUISE CONTROL. *YC
Bulletin Number: 982740
CONCERNS WITH HIGH PRESSURE OIL PUMPS ARE NOT SERVICEABLE. *YC
Bulletin Number: 983070
SOMVE VEHICLES MAY EXHIBIT A BUZZ / LOW GROWL NOISE COMING FROM THE AREA OF THE TRANSFER CASE MANUAL SHIFT LEVER. *TT
Bulletin Number: 983074
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT
Bulletin Number: 983082
CONCERNS WITH WATER LEAKING AT THE REAR SLIDING BACKGLASS. *TT
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 983301
THIS BULLETIN PROVIDES PROCEDURES ON NEUTRALIZING THE EXHAUST, TRANSMISSION AND ENGINE MOUNTS. *TT
Bulletin Number: 983302
THIS BULLETIN MENTIONS HOW SOME HUB O-RINGS MAY BE CUT DURING THE INSTALLATION OF THE WHEELS. *TT
Bulletin Number: 983315
THE 4R100 TRANSMISSION WILL HAVE AN ORANGE "PRIOR TO REPAIR" TAG ON THE FLUID PAN. *TT
Bulletin Number: 983316
SOME CUSTOMER MAY COMPLAIN OF A TICKING NOISE ON INITIAL COLD START-UP IN PARK POSITION AND NEUTRAL POSITION. *TT
Bulletin Number: 98412
THE 4R70W TRANSMISSION INSTALLED IN SOME VEHICLES WILL HAVE AN ORANGE
Bulletin Number: 98419
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC
Bulletin Number: 98422
SERVICE PROCEDURE FOR ORANGE SERVICE TAGGED TRANSMISSIONS. *YC
Bulletin Number: 9844
SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 98-4717
VEHICLES EXHIBIT CRACKS IN DOOR SHEET METAL AT LOWER REAR OF THE WINDOW OPENING NEAR BELT MOLDING. *AK
Bulletin Number: 98-4725
VIBRATION AT CRUISE OVER 50 MPH. *AK
Bulletin Number: 98-4738
COLD ENGINE KNOCK 5.4L ACTION. *AK
Bulletin Number: 985028
INFORMATION REGARDING A NEW SERVICE PART RELEASED FOR THE LICENSE PLATE LIGHT CIRCUIT WHICH WILL REDUCE THE COSE OF REPAIRS. *TT
Bulletin Number: 985029
SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT
Bulletin Number: 985059
EXPERIENCING COLD ENGINE KNOCK (REPEAT / REVISED MESSAGE). *TT
Bulletin Number: 985062
SUBJECT REGARDING IDLE VIBRATION (REPEAT MESSAGE). *TT
Bulletin Number: 985063
SUBJECT REGARDING VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. (REPEAT MESSAGE). *TT
Bulletin Number: 985143
SOME VEHICLES WITH 4R70W TRANSMISSIONS BUILT FROM 4/16/98 THROUGH THE END OF THE 1998 MODEL YEAR MAY EXHIBIT A LEAK FROM THE VENT AREA OF THE TRANSMISSION. *TT
Bulletin Number: 985185
COLD START ENGINE NOISE
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 9858
THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0503 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9869
CONCERNS WITH HESITATION, STUMBLE, SURGE, MISS, ROUGH IDLE, STALL AT IDLE. *TT
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 98L25
CONCERNS WITH THE SAFETY CERTIFICATION LABEL WITH INCORRECT TOTAL ACCESSORY RESERVE CAPACITY (ARC). *TT
Bulletin Number: 98S14
SAFETY RECALL UPDATE TO REPLACE LOCKING LUG NUTS. *TT
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99128
SOME VEHICLES MAY EXHIBIT A WHISTLING NOISE WHILE DRIVING WITH A/C IN THE OFF POSITION AT SPEEDS ABOVE 64 KM/H (40 MPH). *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 991313
SUBJECT REGARDING ANTI-LOCK BRAKE LAMP ILLUMINATION, INCREASED BREAK PEDAL EFFORT AND / OR FALSE ANTI-LOCK BRAKE SYSTEM (ABS) CYCLING AT LOW SPEEDS. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99143
SOME 4X4 VEHICLES BUILT WITH CENTER DISCONNECT FRONT AXLES MAY EXHIBIT A MOANING NOISE FROM THE FRONT DIFFERENTIAL WHILE OPERATING IN 4X2 MODE. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99164
CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER. *TT
Bulletin Number: 99185
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 99411
VEHICLES EXPERIENCING INCREASED BRAKE PEDAL EFFORT AND / OR FALSE ABS CYCLING AT LOW SPEEDS, OR ABS LAMP ILLUMINATION. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT
Bulletin Number: 996034
EXPERIENCING A ENGINE KNOCK AT COLD START-UP. *TT
Bulletin Number: 996042
INFORMATION ON USING 1999 PROCEDURES MANUAL FOR SIDE MIRROR REPLACEMENT. *TT
Bulletin Number: 996113
EXPERIENCING FRONT DIFFERENTIAL NOISE. *TT
Bulletin Number: 996128
SUBJECT REGARDING RIGHT REAR BRAKE CONCERNS UNDER INVESTIGATION. *TT
Bulletin Number: 996139
CONCERNS WITH FRONT DIFFERENTIAL NOISE. *TT
Bulletin Number: 996754
THIS ONLINE BULLETIN ADDRESSES CONCERNS WITH CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT
Bulletin Number: 996780
THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT
Bulletin Number: 996788
CONCERNS WITH VEHICLES EXHIBITING A REAR BRAKE GRAB AND SHOE WEAR. *TT
Bulletin Number: 996876
INFORMATION PERTAINING TO CONDITIONS WITH RED STAINING (SPOTS) ON THE FRONT BUMPER WING ENDS. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: 9996
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT
Bulletin Number: BPI9905
CUSTOMER MAY COMPLAIN THAT THE RAYBESTOS ELECTRONIC BRAKE CONTROLLER DOES NOT WORK, WORKS INCORRECTLY, WORKS INTERMITTENTLY, PULSES THE 4-WAY FLASHERS, AND / OR INTERFERS WITH ANTILOCK BRAKES OPERATION. *TT
Bulletin Number: TSB-14-0147
FORD/LINCOLN: SAFETY RECALL ISSUED DUE TO ONE OR BOTH FUEL TANK STRAPS FRACTURING DUE TO BEING IN HIGH CORROSION AREAS FOR AN EXTENDED PERIOD AND DISLODGING FUEL TANK. MODEL 1997-99 F250, 1997-03 F150, 2004 F150 HERITAGE, 2002-2003 BLACKW
Bulletin Number: TSB-14-0164
FORD/LINCOLN: SAFETY RECALL REGARDING HIGH CORROSION AREAS FOR OPERATING, FOR AN EXTENDED TIME, VEHICLES WHERE BOTH OR ONE STRAP OF FUEL TANK CAN FRACTURE, AFTER CONTACTING GROUND. MODEL 1997-99 F250 LD, 1997-03 F150, 2004 F150 HERITAGE,
1998 FORD F-250 SD
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 14020
CONCERNS WITH THE MANUAL TEMPERATURE CONTROL KNOB FALLING OFF. *TT
Bulletin Number: 17571
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT
Bulletin Number: 8432
SOME VEHICLES EQUIPPED WITH MANUAL TEMPERATURE CONTROL MAY EXHIBIT A TEMPERATURE CONTROL KNOB THAT FALLS OFF. *TT
Bulletin Number: 982721
SOME VEHICLES MAY EXPERIENCE A POPPING / SQUEAKING NOISE IN THE STEERING COLUMN WHILE TURNING. *YC
1998 FORD F-350
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 032131
ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *TT
Bulletin Number: 12248
SOME HEAVY DUTY AND SUPER DUTY VEHICLES MAY EXHIBIT VARIOUS TRANSMISSION CONCERNS, INCLUDING STALL ON TRANSMISSION ENGAGEMENT AND / OR A BUZZ NOISE ON ENGAGEMENT. *TT
Bulletin Number: 12562
SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE P1298. *TT
Bulletin Number: 12905
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT
Bulletin Number: 14455
OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT
Bulletin Number: 5901
SERVICE TIPS FOR IDENTIFYING INJECTOR DRIVER MODULE (IDM) FAILURE WITH DIAGNOSTIC TROUBLE CODE P1298. *TT
Bulletin Number: 980312
EXCESSIVE WHITE SMOKE. VERIFY GLOW PLUG OPERATION BY PERFORMING GLOW PLUG SYSTEM OPERATION CHECK ON THE HARD START/NO START DIAGNOSTIC SHEET. *TT
Bulletin Number: 98123
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 98168
TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD
Bulletin Number: 98205
EXHIBITING ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982313
SOME VEHICLES WITH A 7.3L DIRECT INJECTION (DI) TURBO DIESEL ENGINE, ONE OR MORE OF THE FOLLOWING CONCERNS MAY BE PRESENT: ROUGH IDLE, STALLING, HESITATION/ STUMBLE, LOSS / LACK OF POWER, POOR FUEL ECONOMY, AND EXCESSIVE OIL CONSUMPTION.
Bulletin Number: 982314
PREMATURE WEAR OF THE BELT TENSIONER MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 982740
CONCERNS WITH HIGH PRESSURE OIL PUMPS ARE NOT SERVICEABLE. *YC
Bulletin Number: 983074
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT
Bulletin Number: 983315
THE 4R100 TRANSMISSION WILL HAVE AN ORANGE "PRIOR TO REPAIR" TAG ON THE FLUID PAN. *TT
Bulletin Number: BPI9905
CUSTOMER MAY COMPLAIN THAT THE RAYBESTOS ELECTRONIC BRAKE CONTROLLER DOES NOT WORK, WORKS INCORRECTLY, WORKS INTERMITTENTLY, PULSES THE 4-WAY FLASHERS, AND / OR INTERFERS WITH ANTILOCK BRAKES OPERATION. *TT
1998 FORD F-350 SD
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 14020
CONCERNS WITH THE MANUAL TEMPERATURE CONTROL KNOB FALLING OFF. *TT
Bulletin Number: 17571
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT
Bulletin Number: 8432
SOME VEHICLES EQUIPPED WITH MANUAL TEMPERATURE CONTROL MAY EXHIBIT A TEMPERATURE CONTROL KNOB THAT FALLS OFF. *TT
Bulletin Number: 982721
SOME VEHICLES MAY EXPERIENCE A POPPING / SQUEAKING NOISE IN THE STEERING COLUMN WHILE TURNING. *YC
1998 FORD F-450 SD
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 12562
SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE P1298. *TT
Bulletin Number: 14020
CONCERNS WITH THE MANUAL TEMPERATURE CONTROL KNOB FALLING OFF. *TT
Bulletin Number: 14455
OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT
Bulletin Number: 17571
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT
Bulletin Number: 5901
SERVICE TIPS FOR IDENTIFYING INJECTOR DRIVER MODULE (IDM) FAILURE WITH DIAGNOSTIC TROUBLE CODE P1298. *TT
Bulletin Number: 8432
SOME VEHICLES EQUIPPED WITH MANUAL TEMPERATURE CONTROL MAY EXHIBIT A TEMPERATURE CONTROL KNOB THAT FALLS OFF. *TT
Bulletin Number: 982721
SOME VEHICLES MAY EXPERIENCE A POPPING / SQUEAKING NOISE IN THE STEERING COLUMN WHILE TURNING. *YC
Bulletin Number: 982740
CONCERNS WITH HIGH PRESSURE OIL PUMPS ARE NOT SERVICEABLE. *YC
1998 FORD F53
Bulletin Number: 002002
SOME VEHICLES MAY INGEST AN EXCESSIVE AMOUNT OF WATER INTO THE AIR FILTER WHILE DRIVING IN THE RAIN. EXCESSIVE WATER CAN CAUSE LOSS OF POWER AND / OR ENGINE STUMBLE. *JB
Bulletin Number: 010604
SOME VEHICLES MAY EXHIBIT AN ERRATIC TRANSMISSION 1-2 UPSHIFT OR 2-1 DOWNSHIFT OR MAY START OUT IN 2ND GEAR. *TT
Bulletin Number: 07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
1998 FORD F-550 SD
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 14020
CONCERNS WITH THE MANUAL TEMPERATURE CONTROL KNOB FALLING OFF. *TT
Bulletin Number: 14455
OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT
Bulletin Number: 17571
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT
Bulletin Number: 8432
SOME VEHICLES EQUIPPED WITH MANUAL TEMPERATURE CONTROL MAY EXHIBIT A TEMPERATURE CONTROL KNOB THAT FALLS OFF. *TT
Bulletin Number: 982721
SOME VEHICLES MAY EXPERIENCE A POPPING / SQUEAKING NOISE IN THE STEERING COLUMN WHILE TURNING. *YC
Bulletin Number: 982740
CONCERNS WITH HIGH PRESSURE OIL PUMPS ARE NOT SERVICEABLE. *YC
1998 FORD F600
Bulletin Number: 01127
SOME VEHICLES EQUIPPED WITH 26 INCH DIAMETER FANS MAY EXHIBIT AN ENGINE OVERHEAT CONDITION. *TT
1998 FORD F700
Bulletin Number: 01127
SOME VEHICLES EQUIPPED WITH 26 INCH DIAMETER FANS MAY EXHIBIT AN ENGINE OVERHEAT CONDITION. *TT
Bulletin Number: 11817
SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT
Bulletin Number: 4709
SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT
Bulletin Number: 991311
CONDITIONS WITH POWER STEERING FLUID LEAKING FROM THE BRAKE PUMP RESERVOIR AT 90 DEGREE ELBOW ON SOME VEHICLES. *TT
1998 FORD F800
Bulletin Number: 01127
SOME VEHICLES EQUIPPED WITH 26 INCH DIAMETER FANS MAY EXHIBIT AN ENGINE OVERHEAT CONDITION. *TT
Bulletin Number: 01B74
SOME VEHICLES EQUIPPED WITH DSO HENDRICKSON AIR SUSPENSION OPTION HAVE EXPERIENCED CRACKED FRAMES AT THE TORQUE ROD ATTACHMENT TO THE LEFT HAND SIDE RAIL. THE STRESSES IMPOSED BY THE TORQUE ROD EXCEED THE MATERIAL YIELD STRENGTH CAUSING C
Bulletin Number: 11817
SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT
Bulletin Number: 4709
SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT
Bulletin Number: 991311
CONDITIONS WITH POWER STEERING FLUID LEAKING FROM THE BRAKE PUMP RESERVOIR AT 90 DEGREE ELBOW ON SOME VEHICLES. *TT
1998 FORD F900
Bulletin Number: 991311
CONDITIONS WITH POWER STEERING FLUID LEAKING FROM THE BRAKE PUMP RESERVOIR AT 90 DEGREE ELBOW ON SOME VEHICLES. *TT
1998 FORD FIESTA
Bulletin Number: 12528
SOME VEHICLES MAY EXHIBIT HESITATION OR STUMBLE AT AROUND 2000 RPM DURING WARM UP. *TT
Bulletin Number: 12813
SOME VEHICLES WITH SUNROOF MAY EXHIIBT WATER LEAKING THROUGH THE INTERIOR LAMP / REMOTE LOCK NOT WORKING. *TT
1998 FORD FORD
Bulletin Number: 011801
SUBJECT REGARDING INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *JG
Bulletin Number: 012112
CONCERNS WITH THROTTLE STICKING AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES ON VEHICLES BUILT 12/21/1997 THORUGH 7/15/1999. *TT
Bulletin Number: 030606
DIAGNOSTIC TROUBLE CODES FOR HIGH OXYGEN SENSOR VOLTAGE (P0132 AND P0152). CURRENT DIAGNOSTIC MAY RESULT IN PREMATURE REPLACEMENT OF THE COMPUVALVE. *TT *JB
Bulletin Number: 13047
ENGINEERING IS INVESTIGATING HIGH MILEAGE SUSPENSION PART RETURN. *TT
Bulletin Number: 13248
INFORMATION REGARDING SBDS EVAP TEST FOR DTC PO455. *MJS
Bulletin Number: 13458
SUBJECT REGARDING WHEEL VIBRATION DIAGNOSIS - SERVICE TIP. *TT
Bulletin Number: 15220
SUBJECT REGARDING 2.5L AND 3.0L 24-V DURATEC ENGINE DISASSEMBLY GUIDELINES. *TT
Bulletin Number: 4678
SUBJECT REGARDING FORD QUALITY RENEWAL (FQR) FOR 1998 4R70W, 4R44E AND 5R55E TRANSMISSION APPLICATIONS. *TT
Bulletin Number: 5253
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXPERIENCE A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. *TT
Bulletin Number: 7130
SOME VEHICLES MAY EXHIBIT A DIAGNOSTIC TROUBLE CODE P0455 CAUSED BY AN EVAPORATIVE SYSTEM LEAK. *TT
Bulletin Number: 7434
SOME VEHICLES MAY EXHIBIT WHEEL / TIRE RELATED VIBRATION THAT IS DIFFICULT TO DIAGNOSE. *TT
Bulletin Number: 976011
FUEL SYSTEM DESCRIPTION: MECHANICAL RETURNLESS FUEL SYSTEM AND RETURNLESS FUEL SYSTEM. *TT
Bulletin Number: 980301
CONDITION WITH ROUGH IDLE. *YC
Bulletin Number: 980321
INFORMATION REGARDING THE PATS KEY PROGRAMMING REGARDING PASSIVE ANTI-THEFT SYSTEM. *AK
Bulletin Number: 9811028
INFORMATION REGARDING THE SHIM-LESS CMP SENSOR. *TT
Bulletin Number: 9811330
INFORMATION REGARDING ENGINE OIL LEVEL. *TT
Bulletin Number: 982035
FOR AVAILABILITY OF MAJOR ASSEMBLIES, PLEASE REFER TO THE EXCHANGE PROGRAM GUIDE. *TT
Bulletin Number: 982527
THE 1998 SBTS CAR VERSION 12.0 CD AND THE 1998 SBTS TRUCK VERSION 10.0 CD BOTH HAVE THE WRONG MONTH PRINTED ON THE LABEL. *YC
Bulletin Number: 983110
THIS BULLETIN IS A REMINDER TO DEALERSHIPS SELECTED TO PARTICIPATE IN AN ELECTRONIC MOUDLE PILOT PROGRAM. *TT
Bulletin Number: 983111
INFORMATION REGARDING EDSR QUALITY AWARDS. *TT
Bulletin Number: 98-3425
INFORMATION ON ON USING THE RELATIVE CAM TIMING TEST ON SBDS. *TT
Bulletin Number: 98-4718
ALL VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM--- REPEAT MESSAGE REVISED (SYMPTOM-PATS KEY PROGRAMMING). *AK
Bulletin Number: 985041
REPEAT MESSAGE REGARDING ALL VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM. *TT
Bulletin Number: 985074
SOME 7.3 DIT ENGINES MAY EXHIBIT A ENGINE MISS AFTER EXTENDED IDLING IN COLD TEMPS. *TT
Bulletin Number: 985121
EFFECTIVE NOVEMBER 16TH, FQR FOR 4.6L (WINDSOR) AND 5.4L (TRITON) ENGINES APPLICATIONS FOR CERTAIN MODEL YEARS WILL BE AVAILABLE AS A FORD QUALITY RENEWAL (FQR) ASSEMBLY. *TT
Bulletin Number: 985177
SUBJECT REGARDING ALL 1996 THROUGH 1999 VEHICLES (EXCEPT ASPIRE, PROBE, AND VILLAGER) WITH EEC-V THAT REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT. *TT
Bulletin Number: 9912651
WHEN USING THE NGS WITH THE 5.0 SERVICE CARD ON SOME VEHICLES, THE HELP SELECTION HAS BEEN DELETED FROM THE INITIAL SCREEN. *TT
Bulletin Number: 9913048
FORD MOTOR CO. DOES NOT CURRENTLY RECOMMEND THE ZETEC E, 1.6, 1.8 AND 2.0 ENGINES (AS FITTED TO 1998.75 MODEL YEAR MONDEO AND FOCUS) FOR USE WITH LPG / CNG CONVERSIONS. THESE ENGINES HAVE MECHANICAL SHIMMED TAPPETS WHICH WILL NOT TOLERAT
Bulletin Number: 99-3370
SUBLECT REGARDING THE VALVE BODY ON SOME VEHICLES WAS REVISED TO ELIMINATE THE OIL PIPE. *TT
Bulletin Number: 99-4597
INFORMATION ON PROGRAMMING PCMS. *TT
Bulletin Number: 99-4612
INFORMATION ON HOTLINE SURVEYS. *TT
Bulletin Number: 996103
INFORMATION ON REVISED NGS 5.0 HELP MENU SELECTION. *TT
Bulletin Number: 996765
ENGINEERING IS INVESTIGATING HIGH MILEAGE FIELD DURABILITY ON SHOCKS, BALL JOINTS, CONTROL ARMS, SPRINGS, STA-BAR LINKS, AND STRUTS ON VEHICLES WITH MORE THAN 36K MILES IN SERVICE. IF REPLACING ONE OF THESE COMPONENTS, ENGINEERING WOULD
1998 FORD FORD TRUCK
Bulletin Number: 982035
FOR AVAILABILITY OF MAJOR ASSEMBLIES, PLEASE REFER TO THE EXCHANGE PROGRAM GUIDE. *TT
Bulletin Number: 982527
THE 1998 SBTS CAR VERSION 12.0 CD AND THE 1998 SBTS TRUCK VERSION 10.0 CD BOTH HAVE THE WRONG MONTH PRINTED ON THE LABEL. *YC
Bulletin Number: 983302
THIS BULLETIN MENTIONS HOW SOME HUB O-RINGS MAY BE CUT DURING THE INSTALLATION OF THE WHEELS. *TT
Bulletin Number: 984548
PROVIDING QUICKER SERVICE FIX INFORMATION. *YC
1998 FORD F SERIES
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 03261
NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04217
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT
Bulletin Number: 11482
FOR CERTAIN MODEL VEHICLES, THE 4R70W TRANSMISSION SOLENOID MOLDED LEADFRAME MUST BE REPLACED WHEN REMOVED. *TT
Bulletin Number: 11675
ROUGH IDLE, MISS AND VARIOUS OTHER DRIVEABILITY CONCERNS ON VEHICLES WITH 7.3L DIT ENGINE. THIS MAY BE RELATED TO INJECTOR BORE SCUFFING CAUSED BY FUEL QUALITY ISSUES. *TT
Bulletin Number: 11776
SOME VEHICLES WITH 7.3L DIT ENGINES MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
Bulletin Number: 11781
INFORMATION ON SETTING THE CHECK ENGINE LIGHT AND SETTING DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK). *TT
Bulletin Number: 12134
INFORMATION REGARDING VEHICLES MODELS OF THE 4R100 THAT ARE ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *MJS
Bulletin Number: 12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
Bulletin Number: 12230
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12298
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. *TT
Bulletin Number: 12556
SUBJECT REGARDING TECHNICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES. *TT
Bulletin Number: 12560
BIEF INFORMATION REGARDING DIAGNOSTIC CODE RETRIVAL ON BI-FUEL VEHICLES. *TT
Bulletin Number: 12564
SUBJECT REGARDING PROPER OPERATION AND INTERPRETATION OF DUAL AIR PRESSURE GAUGE READINGS. *TT
Bulletin Number: 12743
EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT
Bulletin Number: 12744
SOME VEHICLES MAY RETREIEVE MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0351 AND / OR P0357 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT
Bulletin Number: 12767
EXHIBITING A VIBRATION THAT MAY BE INTERPRETED AS AN NVH CONDITION. *TT
Bulletin Number: 12798
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 12890
BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE THREAD. *TT
Bulletin Number: 13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
Bulletin Number: 13187
INFORMATION REGARDING E40D/4R100 TRANSMISSION FLUID COOLER FLOW TEST SPECIFICATION. *MJS
Bulletin Number: 13285
EXPERIENCING ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 13322
SOME VEHICLES MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 13331
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 13342
VEHICLES WITH 2.4L, 4.6L, AND 5.4L ENGINES MAY EXHIBIT AN A/C MOAN AT IDLE. *TT
Bulletin Number: 13832
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT
Bulletin Number: 14821
SOME VEHICLES EQUIPPED WITH 4.6L ROMEO ENGINE MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 14864
SUBJECT REGARDING CERTAIN VEHICLES WITH 4.6L ROMEO ENGINES EXHIBITING AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 15225
SOME VEHICLES MAY EXHIBIT A DIFFICULT TO REMOVE WHEEL RIM CONDITION. *TT
Bulletin Number: 15355
SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT
Bulletin Number: 15373
SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES. *TT
Bulletin Number: 15397
SOME VEHICLES MAY EXHIBIT A CONDITION OF OIL CONTAMINATION IN COOLING SYSTEM. *TT
Bulletin Number: 15504
SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT
Bulletin Number: 15605
SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT
Bulletin Number: 15708
SOME VEHICLES MAY EXHIBIT WHEELS THAT SEIZE TO THE HUBS AND ARE DIFFICULT TO REMOVE DURING SERVICE. *TT
Bulletin Number: 15761
SOME DEDICATED CNG VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS OF HARD START / NO START / ROUGH RUNNING. *TT
Bulletin Number: 15901
THIS BULLETIN STATES THAT SOME 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER OR LARGER KNOCK SENSOR THREADED HOLD THAN THE ONE IN THE ORIGINAL ENGINE ASSEMBLY. *TT
Bulletin Number: 16683
FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB
Bulletin Number: 4658
SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
Bulletin Number: 4664
THIS BULLETIN STATES THAT FOR CERTAIN VEHICLES IT IS NOT POSSIBLE TO SET THE CHECK ENGINE LIGHT AND SET DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK) IF A CUSTOMER REFUELS THE VEHICLE WITH THE ENGINE RUNNING. *
Bulletin Number: 4694
SOME FACTURY INSTALLED CD CHANGERS MAY HAVE REVISED SHIPPING LOCATIONS FOR THE CD MAGAZINE. *TT
Bulletin Number: 4747
INFORMATION ON ADDITIONS TO THE FORD QUALITY RENEWAL ASSEMBLY PROGRAM.
Bulletin Number: 5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
Bulletin Number: 5890
INFORMATION ON RETRIEVING DIAGNOSTIC CODES FOR BASE ENGINE / GASOLINE FUEL SYSTEM OR THE ALTERNATE FUEL SYSTEM. *TT
Bulletin Number: 5892
SUBJECT REGARDING TECHINICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES WITH GFI ALTERNATE FUEL SYSTEMS. *TT
Bulletin Number: 5899
CLARIFICATION PERTAINING TO THE DUAL AIR PRESSURE GAUGE FUNCTION. *TT
Bulletin Number: 6350
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 6386
INFORMATION REGARDING THE AVAILABILITY OF ENGINE ASSEMBLY FOR VARIOUS VEHICLES. *TT
Bulletin Number: 6505
BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE ON NATURAL GAS VEHICLES. *TT
Bulletin Number: 6573
INFORMATION ON VARIOUS ENGINES AVAILABLE FOR THE FORD QUALTY RENEWAL (FQR) ENGINE ASSEMBLY. *TT
Bulletin Number: 6585
SOME VEHICLES EQUIPPED WITH 7.3L DIT DIESEL ENGINES MAY DEVELOP A CRACKED FLEXPLATE. *TT
Bulletin Number: 6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
Bulletin Number: 6999
SUBJECT REGARDING E40D / 4R100 TRANSMISSION FLUID COOLER FLOW TEST SPECIFICATION. *TT
Bulletin Number: 7155
VEHICLES EQUIPPED WITH WINDSOR ENGINES ONLY MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 7194
SUBJECT REGARDING FORD QUALITY RENEWAL (FQR) ASSEMBLY LAUNCH OF 4.6L 2V ENGINE. *TT
Bulletin Number: 8058
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT
Bulletin Number: 8058
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. **MR
Bulletin Number: 970902971814
SERVICE TIPS ON AIR BRAKE GOVERNOR OPERTIONAL SPECIFICATIONS. *YC
Bulletin Number: 976011
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 976011
TECHNICIANS EXPERIENCING YELLOW POP-UPS ON SERVICE BAY DIAGNOSTIC SYSTEM (SBDS)." *TT
Bulletin Number: 980307
CONDITIONS WITH PRESSURE BEING HIGHER/LOWER THAN EXPECTED. *YC
Bulletin Number: 9811337
SUBJECT REGARDING CHANGES TO THE MIDLINE RADIO. *TT
Bulletin Number: 9811339
INFORMATION ON THE REVISED FUEL INJECTOR O-RING KIT. *TT
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982691
CONCERNS OF ENGINE CHECKLIGHT ON AND DTC P1506 ( IDLE AIR CONTROL OVER SPEED ERROR ) AND/OR FAST IDLE. *YC
Bulletin Number: 982733
VEHICLES WITH THE E4OD ARE ADDED TO THE FQR ( FORD QUALITY RENEWAL ) ASSEMBLY PROGRAM. *YC
Bulletin Number: 983084
INFORMATION ON ADDING OR INSTALLING A PULLEY. *TT
Bulletin Number: 983170
CONCERNS WITH CODES P0500, P0503, P1501 OR P1503 WHICH MAY BE CAUSED MY A LOOSE SPEEDOMETER DRIVE GEAR. *TT
Bulletin Number: 983180
INFORMATION ON THE NEW 4R100 TRANSMISSION. *TT
Bulletin Number: 983316
SOME CUSTOMER MAY COMPLAIN OF A TICKING NOISE ON INITIAL COLD START-UP IN PARK POSITION AND NEUTRAL POSITION. *TT
Bulletin Number: 9844
SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING. *YC
Bulletin Number: 985072
SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
Bulletin Number: 985183
EFFECTIVE NOVEMBER 2, 1998 CERTAIN VEHICLES OF THE 4R100 ARE ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *TT
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 98614
THE COOLANT TEMPERATURE GAUGE READING MAY BE INACCURATE. *YC
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99133
SUBJECT REGARDING INTERMITTENT ELECTRICAL ISSUES, SUCH AS DASH LIGHTS FLASHING WHEN THE TURN SIGNAL IS ACTIVATED. *TT
Bulletin Number: 991413
VEHICLES EQUIPPED WITH FD1060 OR FD1460 MIDRANGE DIESEL ENGINES MAY EXPERIENCE A VIBRATION OR BUZZ THROUGH THE THROTTLE PEDAL. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 99-4694
SUBJECT REGARDING VEHICLES WITH FACTORY INSTALLED CD CHANGERS HAVING REVISED SHIPPING LOCATIONS FOR THE CD MAGAZINE. *TT
Bulletin Number: 996130
INFORMATION ON THE IMPROVED LOWER INTAKE MANIFOLD SIDE GASKETS. *TT
Bulletin Number: 9983
EXPERIENCING VARIOUS INTERMITTENT CONCERNS, SUCH AS LOW COOLANT LEVEL SENSOR LEAKING COOLANT INTO WIRING HARNESS. *TT
Bulletin Number: 99E03
EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT
Bulletin Number: TB-08-258
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE
1998 FORD F SERIES (LIGHT)
Bulletin Number: 12069
INFORMATION REGARDING A NEW SERVICE PART THAT HAS BEEN RELEASED FOR THE LICENSE PLATE LIGHT CIRCIUT WHICH WILL REDUCE THE COST OF REPAIR. *MJS
Bulletin Number: 12227
FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 15517
SUBJECT REGARDING EXAGGERATED ENGINE BRAKING ON DECELERATION. *YD
Bulletin Number: 6905
INFORMATION ON REMOVING AND / OR REPLACING THE GENERIC ELECTRONIC MODULE (GEM). *TT
Bulletin Number: 9811264
CONCERNS WITH TICKING NOISE ON INITIAL COLD START-UP IN PARK AND NEUTRAL POSITION. *TT
Bulletin Number: 9913138
INFORMATION ON REPLACING AND REMOVING THE GENERIC ELECTRONIC MODULE (GEM). *TT
Bulletin Number: 99-6172
INFORMATION REGARDING STEERING WHEEL LEATHER REPAIR. *TT
1998 FORD F SUPER DUTY
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 04266
A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP. *TT
Bulletin Number: 07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
Bulletin Number: 13412
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT
Bulletin Number: 13472
FOR VEHICLES THAT REQUIRE CONFIGURATION OF THE ELECTRONIC CRASH SENSOR MOUDLE TO SETTINGS OTHER THAN THE PRESET SETTINGS, THE CONFIGURATION INSTRUCTIONS WERE OMITTED FROM THE SHOP MANUAL. *TT
Bulletin Number: 15871
SOME VEHICLES MAY EXHIBIT INTERFERENCE AND / OR STATIC IN THE LAND-MOBILE RADIO. *TT
Bulletin Number: 16697
EXHAUST AIR RUSH NOISE AND LOWER POWER. *TT *JB
Bulletin Number: 98123
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT
Bulletin Number: 982119
SOME VEHICLES MAY EXHIBIT ERRATIC 4-3 SHIFT HUNTING WHILE ASCENDING A GRADE AND/OR NO 3-4 UPSHIFT AFTER CRESTING A GRADE. *YC
Bulletin Number: 982321
SERVICE PROCEDURES AND VEHICLE ATTITUDE SERVICE KITS HAVE BEEN DEVELOPED TO ASSIST CUSTOMERS AND VEHICLE MODIFIERS WITH SIDE -TO- SIDE LEVELING CONCERNS RELATED TO WEIGHT DISTRIBUTION. *YC
Bulletin Number: 9844
SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING. *YC
Bulletin Number: 985185
COLD START ENGINE NOISE
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
1998 FORD GRAND MARQUIS
Bulletin Number: 12083
SOME 4.6L VEHICLES EQUIPPED WITH A 4R70W TRANSMISSION, MAY EXPERIENCE A HARSH REVERSE ENGAGEMENT. *MJS
Bulletin Number: 12111
SOME VEHICES MAY EXHIBIT A POPPING/TICKING NOISE WHEN THE CAR IS SHIFTED FROM REVERSE TO FORWARD GEAR. *MJS
Bulletin Number: 12118
SOME VEHICLES MAY EXHIBIT A HESITATION ON HARD ACCELERATION OR LACKS POWER ON ACCELERATION. *MJS
Bulletin Number: 12120
SOME VEHICLES WITH 4R70W TRANSMISSIONS BUILT FROM 4/16/98 THROUGH 10/30/98 MAY EXHIBIT A LEAK FROM THE VENT AREA OF THE TRANSMISSION. *MJS
Bulletin Number: 12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
Bulletin Number: 12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
Bulletin Number: 12178
INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. *MJS
Bulletin Number: 13808
SOME VEHICLES BUILT BEFORE JANUARY 1, 1999 AND EQUIPPED WITH A KEYLESS ENTRY SYSTEM, MAY EXHIBIT A CONDITION WHERE ALL THE KEYLESS ENTRY FUNCTIONS ARE INOPERATIVE. *MJS
Bulletin Number: 8024
SOME VEHICLES EQUIPPED WITH A KEYLESS ENTRY SYSTEM, MAY EXHIBIT A CONDITION WHERE ALL THE KEYLESS ENTRY FUNCTIONS ARE INOPERATIVE, INCLUDES REMOTE KEY FOB'S , POWER DOOR LOCKS, EXPRESS DOWN WINDOW AND REMOTE TRUNK RELEASE, VEHICLES BUILT BE
Bulletin Number: 976011
SUBJECT REGARDING FUNCTION TEST CHANGES ON SERVICE BAY DIAGNOSTIC SYSTEM (SBDS). *TT
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 98203
CONCERNS WITH ADHENSIVES NOT RECOMMENDED FOR BODY PANEL REPAIRS. *YC
1998 FORD LOUISVILLE
Bulletin Number: 11755
SOME VEHICLES WITH THE CATERPILLAR 3306 ENGINE MAY EXHIBIT THE LOWER RADIATOR HOSE BEING DISCONNECTED FROM THE ENGINE WATER PUMP OUTLET. *TT
Bulletin Number: 11800
SOME MODELS EQUIPPED WITH A 5.9L (FD1060) ENGINE MAY EXHIBIT A CRACKED ENGINE OIL DIPSTICK TUBE NEAR THE ENGINE PORT. *TT
Bulletin Number: 4687
SOME VEHICLES EQUIPPED WITH A 5.9L (FD1060) ENGINE MAY EXHIBIT A CRACKED ENGINE OIL DIPSTICK TUBE NEAR THE ENGINE PORT. *TT
Bulletin Number: 97010510638
THE VERTICAL EXHAUST HEAT SHIELD MAY EXHIBIT CRACKING AROUND ITS MOUNTING BOLT HOLE. *YC
Bulletin Number: 97050110609
VEHICLES EQUIPPED WITH THE FD 1460 ENGINE MAY EXHIBIT REAR ENGINE SUPPORT BRACKET ATTACHING BOLTS LOSSENING. *TW
Bulletin Number: 97050110624
NEW DESIGN FOR GRILL MOUNTED BUG/DIRT SCREEN TO ALLEVIATE PROBLEM OF SCREEN RUBBING AGAINST POWER STEERING COOLER. *TW
Bulletin Number: 970902971813
UNDER CERTAIN CONDITIONS, ROAD SPLASH AND SPRAY MAY BUILD UP ON THE CAB SIDE WINDOWS. *YC
Bulletin Number: 970902971814
SERVICE TIPS ON AIR BRAKE GOVERNOR OPERTIONAL SPECIFICATIONS. *YC
Bulletin Number: 970902971815
SOME VEHICLES FAN CLUTCH MAY CYCLE ON WHEN ELECTRICAL ACCESSORIES, SUCH AS TURN SIGNALS, HEADLAMPS, ETC. ARE ACTIVATED. *YC
Bulletin Number: 970902971816
THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY WEAR AND/OR COME OFF ON SOME VEHICLES EQUIPPED WITH A DETROIT DIESEL ENGINE AND AIR CONDITIONING. *YC
Bulletin Number: 970902971817
SOME ELECTRONICALLY CONTROLLED DIESEL ENGINES CAN BE MODIFIED TO INCREASE ENGINE OUTPUT BY ALTERING THE ORIGINAL ENGINE MANAGEMENT SYSTEM. *YC
Bulletin Number: 9811333
ENGINEERING IS INVESTIGATING CONDITIONS ON THE HOOD SPRING CONTACTING THE HOOD CAUSING DAMAGE TO THE HOOD AND / OR INSULATION. *TT
Bulletin Number: 9811468
SOME MODELS WITH CAT C10/C12 ENGINES MAY EXHIBIT CRACKS IN THE ENGINE FRONT COVER, NEAR THE FAN HUB PULLEY SUPPORT MOUNTING CONTAC STUDS. *TT
Bulletin Number: 98157
FRONT ENGINE COVER CRACKS. YD
Bulletin Number: 98201
INTERMITTENT ELECTRICAL ISSUES, SUCH AS DASH LIGHTS FLASHING WHEN THE TURN SIGNAL IS ACTIVATED MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 982014
INFORMATION REGARDING PTO EQUIPMENT ATTACHING SERVICE TIPS. *YC
Bulletin Number: 98202
THE POWER DISTRIBUTION BOX COVER IS NOW AVAILABLE. *YC
Bulletin Number: 982020
CONDITIONS WITH THE TURN SIGNAL HANDLE MAY BECOME LOOSE / BROKEN ON SOME VEHICLES. *YC
Bulletin Number: 982021
A 41MT HEAVY DUTY STARTER IS NOW AVAILABLE FOR SERVICE FOR THE CAT 3126 ENGINE. *YC
Bulletin Number: 982022
DELCO-REMY HAS MADE AVAILABLE A REVISED GENERATOR FOR SERVICE. *YC
Bulletin Number: 982023
HINGES AND HINGE SPRINGS ARE NOW AVAILABLE FOR SERVICE FOR THE OPTIONAL READY LINE ACCESS DOOR, BUTTERFLY DOORS OR TRANSVERSE ACCESS DOORS. *YC
Bulletin Number: 982115
A NEW SERVICE PARTS RELEASED. *YC
Bulletin Number: 982116
THE LOWER RADITTOR HOSE IS BEING PULLED OFF AT THE ENGINE WATER PUMP ON SOME VEHICLES. *YC
Bulletin Number: 982118
A NOISE HEARD DURING DRIVELINE TORQUE.
Bulletin Number: 982322
ILLUMINATION OF THE ANTI-LOCK BRAKE LAMP MAY OCCUR AND/ OR THERE MAY BE FALSE ANTI-LOCK BRAKE SYSTEM (ABS) MESSAGES ON THE OPTIONAL MESSAGE CENTER ON SOME VEHICLES. *YC
Bulletin Number: 98237
SOME VEHICLES EXPERIENCE HEATER SUPPLY TUBES THAT MAY CRACK AND/ OR LEAK COOLANT. *YC
Bulletin Number: 98243
CONCERNS REGARDING THE INSTRUMENT PANEL PLATE CRACKS AT PARKING BRAKE VALVE. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982520
SOME VEHICLES EQUIPPED WITH FRAME-MOUNTED VERTICAL MUFFLER SUPPORTS MAY EXHIBIT A CRACK ALONG THE PIPE BEND. *YC
Bulletin Number: 98257
CONCERNS WITH THE FRONT END ACCESSORY DRIVE BELT ( FEAD )-FEAD BELT MAY WEAR AND/OR COME OFF. *YC
Bulletin Number: 983295
INFORMATION ON THE HEAVY TRUCK TECHNICAL ASSISTANCE HOTLINE. *TT
Bulletin Number: 98424
CONDITION WITH TIRES BEING LOWER THAN EXPECTED TIRE LIFE. *YC
Bulletin Number: 98425
DIAGNOSTIC INFORMATIN AND WIRING SCHEMATICS FOR BOTH THE HORTON AND KYSOR ENGINE COOLING FAN CLUTCHES. *YC
Bulletin Number: 98517
SOME VEHICLES MAY EXHIBIT A LACK OF POWER AND/OR A WHISTLING NOISE. *TT
Bulletin Number: 98518
THE OIL LEVEL INDICATOR MAY BE DIFFICULT TO INSTALL AND/OR WHEN INSTALLED MAY CONTACT THE CRAKSHAFT ON SOME VEHICLES. *YC
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 98711
INFORMATION ON AVAILABILITY OF REVISED COOLANT LEVEL SENSOR. *YC
Bulletin Number: 99102
INFORMATION REGARDING HIGH FLOOR HEAT DURING IDLE WITH PTO IN OPERATION. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 9944
PROCEDURES ON REPAIRING BROKEN RADIATOR COOLANT SUPPLY TANK VENT HOSE NIPPLES. *TT
Bulletin Number: BC2234970501
VEHICLES MAY EXHIBIT REAR ENGINE SUPPORT BRACKET ATTATCHING BOLTS LOOSENING. *TW
Bulletin Number: BC2394970501
THE AIR OPERATED COOLING FAN MAYU RUN CONTINUOUSLY IF THE ENGINE ECM FAN CONTROL PARAMETERS ARE SET INCORRECTLY. *TW
Bulletin Number: BC2444970501
VEHICLES EQUIPPED WITH CUMMINS M-11 AND N-14 SELECT PLUS ENGINES MAY EXHIBIT THE AIR OPERATED COOLING FAN RUNNING CONTINUOUSLY IF THE ENGINE ECM FAN CONTROL PARAMETERS ARE SET INCORRECTLY. *TW
1998 FORD L SERIES
Bulletin Number: 970902971817
SOME ELECTRONICALLY CONTROLLED DIESEL ENGINES CAN BE MODIFIED TO INCREASE ENGINE OUTPUT BY ALTERING THE ORIGINAL ENGINE MANAGEMENT SYSTEM. *YC
Bulletin Number: 983295
INFORMATION ON THE HEAVY TRUCK TECHNICAL ASSISTANCE HOTLINE. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
1998 FORD MOTOR HOME
Bulletin Number: 13187
INFORMATION REGARDING E40D/4R100 TRANSMISSION FLUID COOLER FLOW TEST SPECIFICATION. *MJS
Bulletin Number: 16683
FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB
Bulletin Number: 6999
SUBJECT REGARDING E40D / 4R100 TRANSMISSION FLUID COOLER FLOW TEST SPECIFICATION. *TT
1998 FORD MOUNTAINEER
Bulletin Number: 12127
SOME VEHICLES EQUIPPED WITH A DUAL MEDIA (AM/FM/CASS/CD) RADIO MAY EXHIBIT AN AUDIO CONCERN OF NO DISPLAY OR GRAPHICS. *MJS
Bulletin Number: 12146
SOME VEHICLES EQUIPPED WITH 5.0L ENGINES MAY EXHIBIT AN UPPER ENGINE TAPPING NOISE ON COLD START. *MJS
Bulletin Number: 13745
SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS
Bulletin Number: 13752
SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *MJS
Bulletin Number: 13757
VEHICLES EQUIPPED WITH LIMITED SLIP/TRACTION-LOK REAR AXLES MAY EXHIBIT A CHATTER NOISE WHILE TURNING. *MJS
Bulletin Number: 7885
THE VEHICLE MAY EXHIBIT THE SPEEDOMETER/ODOMETER INOPERATIVE AS WELL AS MALFUNCTION INDICATOR LAMPS ILLUMINATED OR FLASHING AFTER THE GENERIC ELECTRONIC MODULE (GEM), CENTRAL TIMER MODULE (CTM), OR FOR WHEEL ANTI-LOCK BRAKE SYSTEM (4WABS) M
Bulletin Number: 7918
FRONT AXLE PINION LIL SEAL LEAKS.
Bulletin Number: 981613
TRANSMISSION FLUID LEAKS AT RADIATOR. YD
Bulletin Number: 981617
FLOOR MAT INSTALLATION PROCEDURE SERVICE TIP. YD
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 98165
EVAPORATOR CORE FAILED, CAUSING THE AIR CONDITIONER TO DRIP ON TO PASSENGER FLOOR. YD
1998 FORD MUSTANG
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 00212
SOME VEHICLES MAY EXHIBIT A HOOD THAT IS HARD TO CLOSE. *JB
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 00241
SOME VEHICLES MAY EXHIBIT A VIBRATION THAT MAY BE HEARD OF FELT AT THE CLUTCH PEDAL BETWEEN IDLE AND 2300 RPM, AND GOES AWAY WHEN DEPRESSING THE CLUTCH AT LEAST 25MM. *TT
Bulletin Number: 00S37S1
SUBJECT REGARDING PARKING BRAKE CONTROL ASSEMBLY MODIFICATION. *TT
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 012110
SOME VEHICLES EQUIPPED WITH THE ROMEO BUILT 4.6L 2V ENGINE MAY EXHIBIT AN ENGINE OIL LEAK OR OIL WEEPAGE FROM THE CYLINDER HEAD GASKET AT THE RIGHT HAND REAR OR THE LEFT HAND FRONT OF THE ENGINE. *TT
Bulletin Number: 012113
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL
Bulletin Number: 01235
SOME VEHICLES EQUIPPED WITH THE T45 MANUAL TRANSMISSION MAY EXHIBIT A CONDITION OF BEING STUCK IN REVERSE, DIFFICULT TO SHIFT INTO REVERSE OR MAY POP OUT OF REVERSE. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 0162
VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH
Bulletin Number: 0222
SOME VEHICLES MAY EXHIBIT AN INTAKE MANIFOLD CROSSOVER (FIRST RUNNER) COOLANT SEEPAGE CONDITION. *TT
Bulletin Number: 02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
Bulletin Number: 0245
INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT
Bulletin Number: 031404
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
Bulletin Number: 03144
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 03261
NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 05N04
EXTENDED COVERAGE PROGRAM 05N04 - EXTENDED COVERAGE FOR COMPOSITE INTAKE MANIFOLD. THIS PROGRAM IS BEING PROVIDED AS A SETTLEMENT TO A CLASS ACTION LAWSUIT. THE TERMS OF THE SETTLEMENT EXTEND THE COVERAGE OF THE ALL-COMPOSITE INTAKE MANIF
Bulletin Number: 07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
Bulletin Number: 090308
MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455
Bulletin Number: 11482
FOR CERTAIN MODEL VEHICLES, THE 4R70W TRANSMISSION SOLENOID MOLDED LEADFRAME MUST BE REPLACED WHEN REMOVED. *TT
Bulletin Number: 11530
WHEN DIAGNOSING CRANK / NO START ON CERTAIN VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT (PATS) CHECK THE CUSTOMERS KEY RING FOR ANY MAGNETIC OBJECTS LIKE THE MOBILE SPEEDPASS KEY WHICH MAY AFFECT THE SIGNAL TRANSMISSION BETWEEN THE PATS KEY A
Bulletin Number: 11756
SOME VEHICLES MAY EXHIBIT FLUID LEAKING FROM THE REAR OF THE TRANSMISSION CAUSED BY AN INCORRECT DRIVESHAFT. *TT
Bulletin Number: 11757
SOME VEHICLES MAY EXPERIENCE AN INOPERATIVE CIGARETTE LIGHTER AND POWER POINT. *TT
Bulletin Number: 11804
SUBJECT REGARDING THE SUBWOOFER ENCLOSURE ON COUPES WITH THE MACH 460 AUDIO SYSTEM. *TT
Bulletin Number: 11818
SOME VEHICLES EQUIPPED WITH T45 MANUAL TRANSMISSIONS BUILT 5/15/98 THROUGH 7/23/98 MAY EXHIBIT A CONCERN OF INABILITY TO SHIFT OUT OF REVERSE. *TT
Bulletin Number: 12073
VEHICLES WITH FEDERAL EMISSION EQUIPPED 1998, MAY EXHIBIT A FUEL SMELL IN THE PASSENGER COMPARTMENT AT TIMES. *MJS
Bulletin Number: 12083
SOME 4.6L VEHICLES EQUIPPED WITH A 4R70W TRANSMISSION, MAY EXPERIENCE A HARSH REVERSE ENGAGEMENT. *MJS
Bulletin Number: 12091
SOME VEHICLES EQUIPPED WITH THE 3.8L ENGINE MAY EXHIBIT A CRANKS/NO START CONDITION WITH THE EEC 20A FUSE BLOWN. * MJS
Bulletin Number: 12120
SOME VEHICLES WITH 4R70W TRANSMISSIONS BUILT FROM 4/16/98 THROUGH 10/30/98 MAY EXHIBIT A LEAK FROM THE VENT AREA OF THE TRANSMISSION. *MJS
Bulletin Number: 12120
SOME VEHICLES WITH 4R700 TRANSMISSIONS BUILT FROM 4/16/98 THROUGH THE END OF THE 1998 MODEL YEAR MAY EXHIBIT A LEAK FROM THE VENT AREA OF THE TRANSMISSION. *TT
Bulletin Number: 12124
SOME VEHICLES MAY EXHIBIT A CLICK OR POP NOISE WHEN QUICKLY TURNING THE STEERING WHEEL WHILE TRAVELING OVER B UMPS, OR BRAKING, VEHICLES BUILT FROM 2/2/98 THROUGH 9/25/98. *MJS
Bulletin Number: 12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
Bulletin Number: 12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
Bulletin Number: 12178
INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. *MJS
Bulletin Number: 12193
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LAMP ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE (DTC) P0340 STORED IN MEMORY. *TT
Bulletin Number: 12195
SOME VEHICLES MAY EXHIBIT A DRIVER AND / OR PASSENGER SIDE DOOR WINDOW THAT TRAVELS BEYOND THE UPSTOP AND EXITS THE GLASS RUN. *TT
Bulletin Number: 12298
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. *TT
Bulletin Number: 12523
SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LIGHT ILLUMINATED ACCOMPANIED WITH OBD-II CODE P0340 SET IN THE PCM MEMORY. *TT
Bulletin Number: 12704
SUBJECT REGARDING ALL VEHICLES REQUIRES A PARAMETER RESET TO BE PERFORMED ON THE PASSIVE ANTI-THEFT SYSTEM MODULE (PATS / VIC / HEC) WHEN THE POWERTRAIN CONTROL MODULE (PCM) IS REPLACED. *TT
Bulletin Number: 12725
SOME VEHICLES MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT
Bulletin Number: 12742
SOME VEHICLES WITH MANUAL TRANSMISSION EQUIPPED CONVERTIBLES MAY EXHIBIT A BODY VIBRATION / SHAKE. *TT
Bulletin Number: 12771
SOME VEHICLES WITH A MANUAL TRANSMISSION MAY EXHIBIT A FEAD BELT CONCERN (FRONT END ACCESSORY DRIVE). *TT
Bulletin Number: 12899
INFORMATION ON POWER SEAT SWITCH REPLACEMENT. *TT
Bulletin Number: 13061
SOME VEHICLES MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT TOSS. *TT
Bulletin Number: 13080
SOME VEHICLES EQUIPPED WITH T45 MANUAL TRANSMISSIONS MAY EXHIBIT THE INABILITY TO SHIFT OUT OF REVERSE, REVERSE GEAR JUMP-OUT, WILL NOT SHIFT INTO OR ENGAGE REVERSE GEAR. *TT
Bulletin Number: 13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
Bulletin Number: 13186
INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS
Bulletin Number: 13200
INFORMATION REGARDING 5-SPEED- EXCHANGE TRANSMISSION UNIT. *MJS
Bulletin Number: 13240
INFORMATION REGARDING VIBRATION/EXTENSION HOUSING BUSHING. *MJS
Bulletin Number: 13355
INFORMATION REGARDING A/C PEANUT O-RING COLOR. *TT
Bulletin Number: 13428
SOME CONVERTIBLES MAY EXHIBIT A RATTLE NOISE FROMTHE DOOR WEDGE WHEN DRIVING ON ROUGH ROADS. *TT
Bulletin Number: 14149
INFORMATION ON CASTER ADJUSTMENT WHEN PERFORMING A FRONT END ALIGNMENT. *TT
Bulletin Number: 14520
SUBJECT REGARDING INSTALLATION OF CRANKSHAFT PULLEY TORQUE SPECIFICATION. *TT
Bulletin Number: 14520
INFORMATION PERTAINING TO 4.6L 4V PULLEY INSTRUCTIONS. *TT
Bulletin Number: 14864
SUBJECT REGARDING CERTAIN VEHICLES WITH 4.6L ROMEO ENGINES EXHIBITING AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 15067
SOME VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION MAY EXHIBIT A POWERTRAIN NOISE DESCRIBED AS A BRIEF ROAR, HOOT OR GROAN BETWEN 2500 - 3500 RPM WHEN THE CLUTCH PEDAL IS HALF WAY DOWN, DURING SHIFTING OR WHEN DEPRESSING AND RELEASING THE CL
Bulletin Number: 15158
SOME VEHICLES MAY EXHIBIT A FEAD BELT JUMP-OFF TOSS. *YH
Bulletin Number: 15178
SOME VEHICLES EXHIBIT THE DOOR GLASS POPPING OFF TRACK. *YH
Bulletin Number: 15205
SOME VEHICLES MAY EXHIBIT THE DOOR GLASS COMING OFF OF THE WINDOW TRACK. *TT
Bulletin Number: 15702
SUBJECT REGARDING SPEED CONTROL LAMP. *TT
Bulletin Number: 17577
GEAR WHINE IN 1ST, 3RD AND REVERSE GEARS. *TT
Bulletin Number: 17868
INTERMITTENT LOSS OF POWER OR CRANK NO START - POSSIBLE PATS LAMP FLASHING AND DIAGNOSTIC TROUBLE CODES (DTCS) U1147 AND/OR U1262. *TT
Bulletin Number: 4608
SOME VEHICLES MAY EXPERIENCE PASSENGER AND / OR DRIVER SIDE FRONT WINDOW(S) THAT DO NOT ROLL PROPERLY. *TT
Bulletin Number: 4619
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT
Bulletin Number: 4640
SOME VEHICLES MAY EXHIBIT FLUID LEAKING FROM THE REAR OF THE TRANSMISSION. *TT
Bulletin Number: 4641
SOME VEHICLES MAY EXPERIENCE AN INOPERATIVE CIGARETTE LIGHTER AND POWER POINT. *TT
Bulletin Number: 4696
SUBJECT REGARDING THE SUBWOOFER ENCLOSURE ON COUPES WITH THE MACH 460 AUDIO SYSTEM. *TT
Bulletin Number: 4710
SOME VEHICLES EQUIPPED WITH T45 MANUAL TRANSMISSIONS BUILT 5/15/98 THROUGH 7/23/98 MAY EXHIBIT A CONCERN OF INABILITY TO SHIFT OUT OF REVERSE. *TT
Bulletin Number: 4747
INFORMATION ON ADDITIONS TO THE FORD QUALITY RENEWAL ASSEMBLY PROGRAM.
Bulletin Number: 4749
INFORMATION ON INCORRECT FUSE PANEL LAYOUT. *TT
Bulletin Number: 5031
SOME VEHICLES AND CERTAIN FEDERAL EMISSION EQUIPPED VEHICLES MAY EXHIBIT A FUEL SMELL IN THE PASSENGER COMPARTMENT AT TIMES. *TT
Bulletin Number: 5078
SOME VEHICLES EQUIPPED WITH A 4R70W TRANSMISSIONS MAY EXPERIENCE HARSH REVERSE ENGAGEMENT. *TT
Bulletin Number: 5135
CERTAIN VEHICLES BUILT FROM 2/298 TRHOUGH 9/25/98 MAY EXHIBIT A CLICK OR POP NOISE WHEN QUICKLY TURNING THE STEERING WHEEL WHILE TRAVELING OVER BUMPS, OR BRAKING. THE CLICK OR POP NOISE MAY BE CAUSED BY A STICK / SLIP CONDITION IN THE O
Bulletin Number: 5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
Bulletin Number: 5237
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LAMP ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE (DTC) P0340 STORED IN MEMORY. ENGINEERING IS INVESTIGATING. *TT
Bulletin Number: 5240
SOME VEHICLES MAY EXHIBIT A DRIVER AND / OR PASSENGER SIDE DOOR WINDOW THAT TRAVELS BEYOND THE UPSTOP AND EXITS THE GLASS RUN. *TT
Bulletin Number: 5847
SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LIGHT ILLUMINATED ACCOMPANIED WITH OBD-II CODE P0340 SET IN THE PCM MEMORY. *TT
Bulletin Number: 6242
EXPERIENCING A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE. *TT
Bulletin Number: 6314
SOME VEHICLES WITH MANUAL TRANSMISSION MAY EXHIBIT A FED BELT CONCERN. *TT
Bulletin Number: 6386
INFORMATION REGARDING THE AVAILABILITY OF ENGINE ASSEMBLY FOR VARIOUS VEHICLES. *TT
Bulletin Number: 6411
INFORMATION ON CHECKING DRIVESHAFT RUN OUT. *TT
Bulletin Number: 6460
INFORMATION ON CHECKING DRIVESHAFT RUN OUT. *TT
Bulletin Number: 6512
SOME VEHICLES MAY EXHIBIT SOME NORMAL SERVICE CONCERNS WITH POWER SEAT OPERATION. *TT
Bulletin Number: 6573
INFORMATION ON VARIOUS ENGINES AVAILABLE FOR THE FORD QUALTY RENEWAL (FQR) ENGINE ASSEMBLY. *TT
Bulletin Number: 6996
INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT
Bulletin Number: 6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
Bulletin Number: 7194
SUBJECT REGARDING FORD QUALITY RENEWAL (FQR) ASSEMBLY LAUNCH OF 4.6L 2V ENGINE. *TT
Bulletin Number: 7249
INFORMATION ON USING PEANUT STYLE A/C FITTINGS. *TT
Bulletin Number: 8485
INFORMATION REGARDING FREE FLOOR MAT EXCHANGE. **MR
Bulletin Number: 870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
Bulletin Number: 97090297183
EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC
Bulletin Number: 976011
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 980308
VEHICLES WITH T45 MANUAL TRANSMISSIONS MAY JUMP OUT OF GEAR. *TT
Bulletin Number: 980321
PATS KEY PROGRAMMING. *AK
Bulletin Number: 9810270
SOME MANUAL TRANMISSION VEHICLES MAY EXHIBIT A CONDITION WHERE THE DRIVER CAN SENSE A VIBRATION / NOISE FROM THE CLUTCH PEDAL. *TT
Bulletin Number: 98110
SUBJECT REGARDING PASSIVE ANTI THEFT SYSTEM (PATS) DIAGNOSTIC SERVICE TIPS. *TT
Bulletin Number: 9811213
SOME VEHICLES MAY EXHIBIT ABNORMAL TEMPERATURE GAUGE READINGS. *TT
Bulletin Number: 9811351
SOME VEHICLES WITH 4R70W TRANSMISSION MAY HAVE A HARSH REVERSE ENGAGEMENT. *TT
Bulletin Number: 9811486
INFORMATION ON REPLACEMENT FOR THE CONSOLE GLOVE COMPARTMENT LATCH. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 982018
THE FRONT END ACCESSORY DRIVE ( FEAD ) BELT MAY BECOME BROKEN OR FRAYED AND / OR DETACH FROM ( OR ROLL OFF OF) THE ENGINE. *YC
Bulletin Number: 98203
CONCERNS WITH ADHENSIVES NOT RECOMMENDED FOR BODY PANEL REPAIRS. *YC
Bulletin Number: 98203
CONCERNS WITH THE POTENTIAL EFFECTS OF ADHESIVES USED FOR BODY PANEL REPAIRS. *TT
Bulletin Number: 98222
EXPERIENCING VIBRATION/ NOISE FELT IN CLUTCH PEDAL WHEN LIGHTLY TOUCHING CLUTCH PEDAL. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982312
ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98241
DIAGNOSTIC SERVICE TIPS ON PASSIVE ANTI THEFT SYSTEM ( PATS ). *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982464
CONCERNS WITH VEHICLES WITH A T-45 TRANSMISSION MAY SHIFT FROM 4TH TO NEUTRAL WHEN THE CLUTCH IS RELEASED. *YC
Bulletin Number: 982514
INFORMATION REGARDING THE CONSOLE GLOVE COMPARTMENT LATCH. *YC
Bulletin Number: 98253
CONCERNS WITH THE FRONT WINDOW MAY TRAVEL BEYOND THE UPSTOP AND EXIT THE GLASS RUN ON SOME VEHICLES. *YC
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 982734
SOME VEHICLES MAY EXHIBIT PARTIAL OR NO OPERATION OF THE POWER SEAT WHEN USING THE SEAT SWITCH. *YC
Bulletin Number: 982744
INFORMATION ON REPLACING A POWERTRAIN CONTROL MODULE (PCM), FAILURE TO REESTABLISH COMMUNICATION BETWEEN THE PCM AND THE PATS MODULE MAY RESULT IN A CRANK-NO START WITH CODE P1260. *TT
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 983150
SOME VEHICLES WITH 3.8L AND 4.6L ENGINES MAY HAVE AIRFLOW COMING OUT OF THE DEFROST NOZZLES IN ANY MODE POSITION. *TT
Bulletin Number: 983290
ADDRESSING CONCERNS OF ABNORMAL TEMPERATURE GAUGE READINGS. *TT
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 983566
INFORMATION REGARDING PROGRAMMING / DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT
Bulletin Number: 983566
INFORMATION ON PROGRAMMING / DIAGNOSING ANY PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT
Bulletin Number: 98412
THE 4R70W TRANSMISSION INSTALLED IN SOME VEHICLES WILL HAVE AN ORANGE
Bulletin Number: 9844
SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 985093
SOME VEHICLES EQUIPPED WITH THE 3.8L ENGINE MAY EXHIBIT A CRANK / NO START CONDITION WITH THE EEC 20A FUSE BLOWN. *TT
Bulletin Number: 985135
SOME VEHICLES BUILT FROM 2/2/98 THROUGH 9/25/98 MAY EXHIBIT A CLICK OR POP NOISE WHEN QUICKLY TURNING THE STEERING WHEEL WHILE TRAVELING OVER BUMPS, OR BRAKING. *TT
Bulletin Number: 985143
SOME VEHICLES WITH 4R70W TRANSMISSIONS BUILT FROM 4/16/98 THROUGH THE END OF THE 1998 MODEL YEAR MAY EXHIBIT A LEAK FROM THE VENT AREA OF THE TRANSMISSION. *TT
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 99101
CONCERNS WITH ROAD NOISE MAY BE HEARD FROM THE REAR WHEEL AREA AS WELL AS DUST INTRUSION INTO THE LUGGAGE COMPARTMENT AND / OR EVIDENCE OF A WATER LEAK IN THE LUGGAGE COMPARTMENT. *TT
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 9912717
SOME VEHICLES MAY EXHIBIT VIBRATION / SHAKE WHEN DRIVEN ON SMOOTH ROADS AT SPPED AROUND 62 MPH / 100 KPH. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 99131
CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: 9913125
SONE POLICE VEHICLES AND OTHER VEHICLES WITH 4R70W MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99185
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99195
SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99207
SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99225
CONCERNS WITH THE CONVERTIBLE TOP BOOT MAY FIT IMPROPERLY OR BE DIFFICULT TO INSTALL ON SOME VEHICLES DUE TO THE TOP NOT FOLDING DOWN ALL THE WAY INTO THE WELL. *TT
Bulletin Number: 99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT
Bulletin Number: 99-6193
INFORMATION ON RESETTING THE PASSIVE ANTI-THEFT SYSTEM (PATS). *TT
Bulletin Number: 996795
SUBJECT REGARDING VEHICLES EQUIPPED WITH 4.6L ENGINE REGARDLESS OF TRANSMISSION, MAY EXHIBIT A (FRONT END ACCESSORY DRIVE (FEAD) BELT- BELT NOISE, DAMAGE, AND / OR BELT COMES OFF). *TT
Bulletin Number: 996839
SOME VEHICLES EQUIPPED WITH T-45 MANUAL TRANSMISSIONS MAY EXHIBIT INABILITY TO SHIFT OUT OF REVERSE, REVERSE GEAR JUMP-OUT, WILL NOT SHIFT INTO OR ENGAGE REVERSE GEAR. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: 9996
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT
Bulletin Number: 99S09
RECALL INFORMATION REGARDING SPEED CONTROL CABLE REPLACEMENT. *TT
1998 FORD MUSTANG COBRA
Bulletin Number: 11504
SOME VEHICLES WITH A T-45 TRANSMISSION MAY SHIFT FROM 4TH TO NEUTRAL (POP OUT) WHEN THE CLUTCH IS RELEASED. *TT
Bulletin Number: 12803
CONCERNS WITH A VIBRATION CONDITION BETWEEN 1800 - 2300 RPM. *TT
Bulletin Number: 12831
INFORMATION ON CHECKING DRIVESHAFT RUN OUT. *TT
Bulletin Number: 12869
INFORMATION ON CHECKING DRIVESHAFT RUN OUT. *TT
Bulletin Number: 13302
SOME VEHICLES MAY EXHIBIT A NO CRANK CONDITION. *TT
Bulletin Number: 13950
SOME VEHICLES WITH MANUAL TRANSMISSION OR WITH AUTOMATIC TRANSMISSION MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACH FROM THE ENGINE. *TT
Bulletin Number: 13950
SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION AND WITH AUTOMATIC TRANSMISSION MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACH FROM THE ENGINE. *TT
Bulletin Number: 15901
THIS BULLETIN STATES THAT SOME 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER OR LARGER KNOCK SENSOR THREADED HOLD THAN THE ONE IN THE ORIGINAL ENGINE ASSEMBLY. *TT
Bulletin Number: 6163
SUBJECT PERTAINING TO WHEEL BALANCE. *TT
Bulletin Number: 6388
CUSTOMER MAY EXPRESS CONCERNS ABOUT A VIBRATION CONDITION BETWEEN 1800 AND 2300 RPM. *TT
Bulletin Number: 6641
SOME VEHICLES MAY EXHIBIT A VIBRATION AT HIGHWAY SPEEDS AT 68 MPH. *TT
Bulletin Number: 7236
EXPERIENCING A NO CRANK CONDITION. *TT
Bulletin Number: 8106
SOME VEHICLES MAY EXHIBIT A NO CRANK CONDITION. *TT
Bulletin Number: 8278
SOME VEHICLES WITH MANUAL AND AUTOMATIC TRANSMISSIONS MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACHED FROM THE ENGINE. *TT
Bulletin Number: 8278
SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION AND WITH AUTOMATIC TRANSMISSION MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACH FROM THE ENGINE. *TT
1998 FORD MUSTANG CONVERTIBLE
Bulletin Number: 0042
VEHICLES MAY EXPERIENCE VIBRATION/SHAKE AT STEADY SPEED APPROXIMATELY 100 KM/H (62 MPS), VEHICLES WITH 3.8 L ENGINE AND CONVERTIBLE TOP. *MJS
Bulletin Number: 12093
SOME VEHICLES MAY EXPERIENCE VIBRATION/SHAKE WHEN DRIVEN ON SMOOTH ROADS AT CONSTANT SPEEDS AROUND 62 MPH/100 KPH. *MJS
Bulletin Number: 12717
EXPERIENCING VIBRATION / SHAKE WHEN DRIVEN ON SMOOTH ROADS AT SPEED AROUND 62 MPH / 100 KPH. *TT
Bulletin Number: 5132
SOME GT CONVERTIBLES MAY EXPERIENCES VIBRATION / SHAKE WHEN DRIVEN ON SMOOTH ROADS AT CONSTANT SPEEDS AROUND 62 MPH / 100 KPH. THE CONDITION MAY BE DUE TO HARMONIC RESONANCE BETWEEN THE ENGINE, BODY AND SUSPENSION. *TT
Bulletin Number: 6227
SOME VEHICLES MAY EXHIBIT CONCERNS OF VIBRATION / SHAKE. *TT
Bulletin Number: 7373
SOME VEHICLES MAY EXHIBIT A RATTLE NOISE FROM THE DOOR WEDGE WHEN DRIVING ON ROUGH ROADS. *TT
Bulletin Number: 985131
SOME GT MODELS MAY EXPERIENCE VIBRATION / SHAKE WHEN DRIVEN ON SMOOTH ROADS AT CONSTANT SPEEDS AROUND 62 MPH / 100 KPH. *TT
Bulletin Number: 9912717
SOME VEHICLES MAY EXHIBIT VIBRATION / SHAKE WHEN DRIVEN ON SMOOTH ROADS AT SPPED AROUND 62 MPH / 100 KPH. *TT
1998 FORD MUSTANG GT
Bulletin Number: 11504
SOME VEHICLES WITH A T-45 TRANSMISSION MAY SHIFT FROM 4TH TO NEUTRAL (POP OUT) WHEN THE CLUTCH IS RELEASED. *TT
Bulletin Number: 13950
SOME VEHICLES WITH MANUAL TRANSMISSION OR WITH AUTOMATIC TRANSMISSION MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACH FROM THE ENGINE. *TT
Bulletin Number: 13950
SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION AND WITH AUTOMATIC TRANSMISSION MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACH FROM THE ENGINE. *TT
Bulletin Number: 8278
SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION AND WITH AUTOMATIC TRANSMISSION MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACH FROM THE ENGINE. *TT
Bulletin Number: 8278
SOME VEHICLES WITH MANUAL AND AUTOMATIC TRANSMISSIONS MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACHED FROM THE ENGINE. *TT
1998 FORD NAVIGATOR
Bulletin Number: 13711
SUBJECT REGARDING THE SERVICING OF TRAILER HITCHES ON VEHICLES. *MJS
Bulletin Number: 13712
INFORMATION REGARDING VEHICLES THAT EXPERIENCE THE RADIOS THAT DISPLAY NO DJ-NO DISC OR CD WILL NOT EJECT. *MJS
Bulletin Number: 13744
SOME VEHICLES MAY EXHIBIT A BODY BOOM WHILE DRIVING HIGHWAY SPEEDS. *MJS
Bulletin Number: 13745
SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS
Bulletin Number: 13773
INFORMATION FOR COMPACT DISC PLAYER PROBLEMS, RADIO MAY DISPLAY NO DJ- NO DUSC OR CD WILL NOT EJECT. *MJS
Bulletin Number: 13825
SOME VEHICLES MAY EXHIBIT A FRONT WASHER OPERATING WITHOUT COMMAND. *MJS
Bulletin Number: 15122
SOME VEHICLES MAY EXHIBIT A VIBRATION AT IDLE AND/OR ENGINE DROANING NOISE ON ACCELERATION FROM A STOP. *SLC
Bulletin Number: 15123
SOME VEHICLES MAY EXHIBIT A DRIVELINE VIBRATION AT SPEEDS BETWEEN 60-70 MPH. *SLC
Bulletin Number: 15152
SOME VEHICLES MAY EXHIBIT COURTESY RAIL LAMPS ABOVE THE 2ND ROW SEATS THAT DO NOT OPERATE PROPERLY OR CAUSE A BATTERY DRAW. *ET
Bulletin Number: 7823
EXPEDITION AND NAVIGATORS EQUIPPED WITH FOUR WHEEL AIR SUSPENSION MAY REQUIRE A RIDE HEIGHT ADJUSTMENT PROCEDURE BE PERFORMED, BEFORE SETTING ALIGNMENT. WHEN ADJUSTING RIDE HEIGHT REFERENCE THE 1990 EXPEDITION AND NAVIGATOR WORKSHOP MANUAL
Bulletin Number: 7896
SERVICING TRAILER HITCH.
Bulletin Number: 7897
DIAGNOSTIC INFORMATION FOR COMPACT DISC PLAYER PROBLES, NO DISC OR CD WILL NOT EJECT. THIS INDICATES NO COMMUNICATION BETWEEN RADIO AND DISC PLAYER.
Bulletin Number: 7929
DIAGNOSTIC INFORMATION FOR COMPACT DISC PLAYER PROBLEMS.
Bulletin Number: 9810569
CONCERNS OF SQUEAKY / NOISY PITMAN ARM. *YC
Bulletin Number: 981612
FUEL MAY LEAK FROM THE SPRING LOCK COUPLINGS. YD
Bulletin Number: 981613
TRANSMISSION FLUID LEAKS AT RADIATOR. YD
Bulletin Number: 98168
TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD
Bulletin Number: 98169
STEERING -ALIGNMENT-TOE SET PROCEDURE SERVICE TIP. YD
1998 FORD PROBE
Bulletin Number: 11791
SOME VEHICLES WITH CD4E TRANSMISSION MAY EXHIBIT A CONDITION OF NO CRANK / NO START IN PARK. VEHICLE WILL CRANK AND START IN NEUTRAL. *TT
Bulletin Number: 4674
SOME VEHICLES WITH CD4E TRANSMISSION MAY EXHIBIT A CONDITION OF NO CRANK / NO START IN PARK. VEHICLE WILL CRANK AND START IN NEUTRAL. *TT
1998 FORD RANGER
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 00151
VEHICLES MAY EXPERIENCE VIBRATION FELT AT HIGH SPEEDS WHICH MAY CAUSE THE TRANSMISSION EXTENSION HOUSING SEAL TO LEAK OR THE TRANSMISSION EXTENSION HOUSING BLUSHING TO MOVE OUT OF POSITION OR BECOME DAMAGED ON SOME VEHICLES. *JB
Bulletin Number: 00225
SOME ELECTRIC VEHICLES MAY EXHIBIT A LOW SPEED SHUDDER ON LIGHT ACCELERATION. *JB
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 00242
ON SOME VEHICLES THERE MAY BE A VIBRATION AT HIGH SPEEDS WHICH MAY CAUSE THE TRANSMISSION EXTENSION HOUSING SEAL TO LEAK OR THE TRANSMISSION EXTENSION HOUSING BUSHING TO MOVE OUT OF POSITION OR BECOME DAMAGED. *TT
Bulletin Number: 00248
SOME VEHICLES EQUIPPED WITH A 3.0L ENGINE MAY EXHIBIT SPARK KNOCK (PING) UNDER ACCELERATION. *TT
Bulletin Number: 00262
SOME ELECTRIC VEHICLES (EVS) AND ELECTRIC POSTAL CHASSIS VEHICLES MAY EXHIBIT INTERMITTENT LIGHTING OF THE OIL WARNING LAMP. *TT
Bulletin Number: 0035
VEHICLES MAY EXPERIENCE HIGH IDLE. *MJS
Bulletin Number: 0036
VEHICLES MAY EXPERIENCE BUZZING AND OR GRINDING NOISE DURING 2-3 SHIFT- VEHICLES EQUIPPED WITH M50D TRANSMISSION AND BUILT BEFORE 11/1/99. *MJS
Bulletin Number: 0054
VEHICLES MAY EXHIBIT VARIOUS DRIVING CONDITIONS, HARD TO START, ENGINE HESITATION, ROUGH OR UNUSUAL ROLLING IDLE, ENGINE SURGE OR LACK OF POWER, KNOCK, STUMBLE. *MJS
Bulletin Number: 0057
SOME VEHICLES MAY EXPERIENCE A SQUAWKING/EEKING NOISE THAT MAY BE HEARD FROM THE CLUTCH ON ACCELERATION FROM A STOP OR WHEN UNDER LOAD IN FIRST GEAR. *MJS
Bulletin Number: 0073
SOME VEHICLES EQUIPPED WITH A 3.0L ENGINE MAY EXPERIENCE SPARK KNOCK (PING) UNDER ACCELERATION. **MR
Bulletin Number: 0076
INFORMATION REGARDING LOSS OF REGENERATIVE BREAKING AND HIGH BRAKE PEDAL EFFORTS WHILE DRIVING DOWNHILL WITH TRACTION BATTERY AT HIGH STATE OF CHARGE. *MR
Bulletin Number: 01109
SOME ELECTRIC VEHICLE (EV) RANGERS MAY EXHIBIT A NO-CHARGE CONDITION. THERE ARE SEVERAL POSSIBLE CAUSES WHY THE BATTERY CONTROL MODULE (BCM) MIGHT NOT ALLOW CHARGING (AS INDICATED BY THE OP_STATES). A CHARGING SYSTEM FAULT (C1838) DOES
Bulletin Number: 011111
SOME 4X4 SUPER CAB VEHICLES MAY EXHIBIT A LOW FREQUENCY DRIVESHAFT THUMP TYPE NOISE / VIBRATION ON LIGHT ACCELERATION FROM A STOP, AND / OR WHEN COMING TO A STOP WITH LIGHT TO MODERATE BRAKING. *TT
Bulletin Number: 01118
SUBJECT REGARDING NEW VERSION 3.0 DIAGNOSTIC SOPTWARE AVAILABLE FOR CERTAIN E.V. VEHICLES. *TT
Bulletin Number: 01124
ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01186
INFORMATION ON CLIMATE CONTROL, LOUD A/C CLUTCH CYCLING NOISE.*JB
Bulletin Number: 01193
ON SOME ELECTRIC AND ELECTRIC POSTAL VEHICLES, DIAGNOSTIC TROUBLE CODE B2785 TRACTION INVERTER MODULE (TIM) MAY BE SET AND THE VEHICLE WILL ENTER A POWER LIMITED MODE OF OPERATION. *TT
Bulletin Number: 01197
SOME VEHICLES EQUIPPED WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / ONNECTING ROD BEARING KNOCK. *TT
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 012113
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL
Bulletin Number: 01212
SOME VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT A LOUD A/C CLUTCH ENGAGEMENT. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 01412
HIGH VOLTAGE INSULATED SAFETY GLOVES TESTING AND ORDERING INFORMATION. *TT
Bulletin Number: 0146
SOME VEHICLES MAY EXHIBIT A CHATTER OR BINDING CONDITION WHEN OPERATING THE POWER SIDE WINDOWS EITHER IN THE DOWN OR UP MODE. *TT
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 0186
ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT
Bulletin Number: 0196
SOME 4X4 SUPER CAB VEHICLES MAY EXHIBIT A LOW FREQUENCY THUMP TYPE NOISE / VIBRATION ON LIGHT ACCELERATION FROM A STOP, AND / OR WHEN COMING TO A STOP WITH LIGHT TO MODERATE BRAKING. *TT
Bulletin Number: 01B77
OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT
Bulletin Number: 02138
LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02192
DRIVESHAFT-THUMP/CLUNK HEARD ON LIGHT ACCELERATION FROM A STOP OR WHEN BRAKING AND COMING TO A STOP.
Bulletin Number: 02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
Bulletin Number: 02232
FRAME MOUNTED FRONT BUMPER BRACKETS SERVICE KIT. *TT
Bulletin Number: 0242
CERTAIN VEHICLES WITH 4X4 OR ALL-WHEEL DRIVE MAY HAVE A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT
Bulletin Number: 0245
INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT
Bulletin Number: 0255
HOOTING, EEKING OR MOANING NOISE COMING FROM THE CLUTCH WHEN SHIFTING GEARS. *TT
Bulletin Number: 0282
SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. *TT
Bulletin Number: 030302
DRIVESHAFT - THUMP/CLUNK HEARD ON LIGHT ACCELERATION FROM A STOP OR WHEN BRAKING AND COMING TO A STOP. *TT
Bulletin Number: 03048
THUMP/CLUNK ON LIGHT ACCELERATION FROM STOP OR WHEN BRAKING AND COMING TO A STOP ON CERTAIN 4X4 SUPER CAB EQUIPPED WITH AUTOMATIC TRANSMISSION AND STEEL DRIVESHAFT. *TT
Bulletin Number: 030508
FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD. *TT
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 03203
MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT
Bulletin Number: 0332
THUMP TYPE NOISE/VIBRATION HEARD ON LIGHT ACCELERATION FROM A STOP OR WHEN BRAKING AND COMING TO A STOP. *TT
Bulletin Number: 0358
FLUID MAY LEAK OUT OF THE FRONT AXLE VENT TUBE. *TT *JB
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04217
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04237
DRIVESHAFT THUMP CLUNK ON LIGHT ACCELERATION FROM STOP OR WHEN BRAKING AND COMING TO A STOP. *EH
Bulletin Number: 042419
REVISED PROCEDURE FOR ADJUSTING ALIGNMENT ON ALL SUSPENSIONS - NEW RIGHT HAND UPPER CONTROL ARM DESIGN FOR TORSION BAR FRONT SUSPENSIONS. *TT
Bulletin Number: 11509
SOME VEHICLES MAY EXHIBIT ERRONEOUS DTCS B1398 AND B1302 WHEN DIAGNOSTIC TEST ARE PERFROMED. *TT
Bulletin Number: 11512
ENGINEERING IS INVESTIGATING CONCERNS OF NOISY FRONT SYSTEM BLOWER MOTORS ON CERTAIN VEHICLES. *TT
Bulletin Number: 11811
SOME VEHICLES BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT
Bulletin Number: 12102
SOME MANUAL TRANSMISSIONS MAY EXHIBIT A CONCERN OF ENGINE IDLE HIGH DURING DECELERATION. *MJS
Bulletin Number: 12127
SOME VEHICLES EQUIPPED WITH A DUAL MEDIA (AM/FM/CASS/CD) RADIO MAY EXHIBIT AN AUDIO CONCERN OF NO DISPLAY OR GRAPHICS. *MJS
Bulletin Number: 12128
SOME RANGER SUPERCABS MAY EXHIBIT A BUZZ FROM THE REAR SPEAKERS. *MJS
Bulletin Number: 12138
VEHICLES MAY EXHIBIT A CLIMATE CONTROL ISSUE OF LACK OF HEAT. *MJS
Bulletin Number: 12152
SOME VEHICLES WITH 4 X 4 OPTION OPERATING IN 4 X 2 MODE MAY EXHIBIT A PING SOUND ON SLIGHT TO MODERATE ACCELERATION IN FORWARD OR REVERSE. *MJS
Bulletin Number: 12153
SOME 3.0L AND 4.0L RANGERS WITH 4 X 4 OPERATING IN 4.2 MODE MAY EXHIBIT A SLIGHT OR A ROLLING THUMP/BUMP ON SLIGHT TO MODERATE ACCELERATION. *MJS
Bulletin Number: 12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
Bulletin Number: 12179
INFORMATION REGARDING ENGINEERING THAT IS INTERESTED IN LOCATING ANY 1998 RANGER 126 INCH W/B SUPER CAB WITYH 19.5 GALLON FUEL TANK FOR SERVICE REQUIRING FUEL TANK REPLACEMENT, PRODUCTION DATES MUST BE BETWEEN 5/19/98 AND 7/31/98. *MJS
Bulletin Number: 12230
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12246
SOME VEHICLES BUILT PRIOR TO 11/15/98 MAY REQUIRE EXCESSIVE EFFORT TO LIFT THE OUTSIDE (R/L) DOOR HANDLE. *TT
Bulletin Number: 12264
SOME VEHICLES MAY EXHIBIT A CRANK NO START CONCER, OR THE DIAGNOSTICS HAVE VERIFIED THAT THE FUEL PUMP IS INOPERATIVE. *TT
Bulletin Number: 12518
CONCERNS WITH THE IN-DASH CD STOPS OPERATING WHEN HOT / RADIO DISPLAY READS CD TOO HOT. *TT
Bulletin Number: 12521
VEHICLES WITH LIMITED SLIP / TRACTION-LOK REAR AXLES MAY EXHIBIT A CHATTER NOISE WHILE TURNING. *TT
Bulletin Number: 12554
SUBJECT REGARDING REVOLUTIONS PER MILE TIRE SIZE DATA. *TT
Bulletin Number: 12573
INFORMATION REGARDING THE AUDIO SYSTEM SELECTIVE LIGHTING FEATURE. *TT
Bulletin Number: 12583
SOME VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT A THUMPING NOISE FROM THE COOLING SYSTEM. *TT
Bulletin Number: 12610
INFORMATION ON REPLACING A FOUR WHEEL ANTI-LOCK BRAKES (4WABS) HYDRAULIC CONTROL UNIT (HUC). *TT
Bulletin Number: 12705
SOME 4.0L OHV ENGINES MAY EXHIBIT AN INTERNAL LOW ENGINE NOISE THAT IS DESCRIBED AS A DIESEL AND / OR MARBLES IN A TIN CAN RATTLE. *TT
Bulletin Number: 12749
SOME VEHICLES MAY EXHIBIT A SAG IN THE REAR END. *TT
Bulletin Number: 12782
SOME VEHICLES MAY EXHIBIT SPARK KNOCK UNDER ACCELERATION. *TT
Bulletin Number: 12827
CONCERNS WITH THUMP / BUMP SENSATION ON ACCELERATION. *TT
Bulletin Number: 12843
SOME 4X4 VEHICLES MAY EXHIBIT A HIGH PITCHED SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT END AT SPEEDS FROM 10 MPH TO 40 MPH. *TT
Bulletin Number: 12873
SOME VEHICLES MAY EXHIBIT A SQUEAK SOUND WHILE OPENING OR CLOSING THE FRONT OR REAR (4DR) DOOR(S). *TT
Bulletin Number: 12905
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT
Bulletin Number: 12997
SOME VEHICLES MAY EXHIBIT NO / LOW A/C PERFORMANCE AT HIGH AMBIENT TEMPERATURES AND PROLONGED IDLE. *TT
Bulletin Number: 13018
SOME VEHICLES MAY EXHIBIT A REAR END SAG. *TT
Bulletin Number: 13054
EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT
Bulletin Number: 13110
SOME VEHICLES MAY EXHIBIT AN INTERNAL LOW END NOISE THAT IS DESCRIBED AS A DIESEL AND / OR MARBELS IN A TIN CAN RATTLE. *TT
Bulletin Number: 13110
INFORMATION REGARDING 4.0L OHV ENGINE-MARBLE TYPE NOISE. *MJS
Bulletin Number: 13118
SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT
Bulletin Number: 13154
SUBJECT REGARDING 4.0L ENGINE HOTLINE PHONE NUMBERS. *TT
Bulletin Number: 13154
SUBJECT REGARDING ENGINE HOTLINE PHONE NUMBERS. *TT
Bulletin Number: 13175
INFORMATION REGARDING CLUTCH SQUAWK NOISE ON TAKE OFF. *MJS
Bulletin Number: 13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
Bulletin Number: 13207
INFORMATION REGARDING REAR END SAG. *MJS
Bulletin Number: 13241
INFORMATION REGARDING SLOW RETURN TO IDLE. *MJS
Bulletin Number: 13244
INFORMATION REGARDING WINDNOISE FROM WINDSHIELD/COWL AREA. *MJS
Bulletin Number: 13270
VEHICLES WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN INTERNAL LOW END NOISE THAT IS DESCRIBED AS A DIESEL AND / OR MARBLES IN A TIN CAN RATTLE. *TT
Bulletin Number: 13283
SOME VEHICLES WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN INTERNAL LOW END NOISE THAT IS DESCRIBED AS A DIESEL AND / OR MARBLES IN A TIN CAN RATTLE. *TT
Bulletin Number: 13289
OWNERS OF VEHICLES EQUIPPED WITH 4.0L OHV ENGINE AND MANUAL TRANSMISSION MAY EXHIBIT A SQUAWK NOISE FROM THE CLUTCH ON TAKE OFF. *TT
Bulletin Number: 13412
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT
Bulletin Number: 13423
VEHICLES EQUIPPED WITH MANUAL TRANSMISSION MAY EXHIBIT NEUTRAL GEAR ROLLOVER NOISE WHICH OCCURS AT IDLE WITH TRANSMISSION IN NEUTRAL AND CLUTCH ENGAGED. *TT
Bulletin Number: 13426
EXHIBITING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS. *TT
Bulletin Number: 13440
EXPERIENCING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS (PARKING LOT TYPE MANEUVERS). *TT
Bulletin Number: 13442
VEHICLES EQUIPPED WITH 4.0L OHV ENGINE AND MANUAL TRANSMISSION MAY EXHIBIT A SQUAWK NOISE FROM THE CLUTCH ON TAKE OFF. *TT
Bulletin Number: 13484
VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT EXCESSIVE OIL CONSUMPTION AS REPORTED BY THE CUSTOMER. *TT
Bulletin Number: 13505
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
Bulletin Number: 13528
SOME VEHICLES WITH 3.0L ENGINES MAY EXHIBIT SPARK KNOCK (PING) UNDER ACCELERATION. *TT
Bulletin Number: 13543
SOME VEHICLES EQUIPPED WITH 3.0L ENGINE AND AUTOMATIC / MANUAL TRANSMISSION MAY EXHIBIT TRANSMISSION FLUID LEAKAGE FROM THE TRANSMISSION EXTENSION HOUSING. *TT
Bulletin Number: 13745
SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS
Bulletin Number: 13794
VEHICLES EQUIPPED WITH M5OD R1 TRANSMISSIONS MAT EXHIBIT A 2-3 UPSHIFT GRIND. *MJS
Bulletin Number: 13795
SOME VEHICLES WITH 2.5L MANUAL TRANSMISSION MAY EXHIBIT A HIGH IDLE CONDITION ON DECELERATION AND/OR WHEN THE CLUTCH IS DISENGAGED. *MJS
Bulletin Number: 13835
SOME 3.0L MANUAL TRANSMISSION EQUIPPED VEHICLES MAY EXHIBIT A CONCERN OF ENGINE IDLE HIGH (1500-2000 RPM) DURING DECELERATION. *TT
Bulletin Number: 13844
SOME VEHICLES WITH 2.5L ENGINE MAY EXHIBIT A BELT SQUEAL INITIALLY AT COLD START-UP. *TT
Bulletin Number: 14056
SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR
Bulletin Number: 14072
SOME VEHICLES MAY EXHIBIT AN OIL LEAK AT THE REAR SEAL OF THE TRANSMISSION EXTENSION HOUSING. *TT
Bulletin Number: 14076
SOME VEHICLES MAY EXHIBIT AN ENGINE SPARK KNOCK (PING) ON ACCELERATION. **MR
Bulletin Number: 14366
EXHIBITING SPARK KNOCK (PING) UNDER ACCELERATION. *TT
Bulletin Number: 14366
SOME VEHICLES EQUIPPED WITH 3.0L ENGINE MAY EXHIBIT SPARK KNOCK (PING) UNDER ACCELERATION. *JB
Bulletin Number: 14547
SOME VEHICLES MAY EXHIBIT SURGE, HESITATION OR ROUGH IDLE OR MALFUNCTION INDICATOR LAMP ON W/ DIAGNOSTIC TROUBLE CODES P0171, P0172, P0174, AND P0175. *JB
Bulletin Number: 14583
CONCERNS WITH BROKEN THERMOSTATS ON ENGINES. *JB
Bulletin Number: 14617
SUBJECT PERTAINING TO BROKEN THERMOSTAT. *JB
Bulletin Number: 14847
CONCERNS WITH VEHICLES EXHBIT FLUID LEAKAGE FROM THE FRONT AXLE VENT TUBE. *TT
Bulletin Number: 14898
SOME VEHCLES MAY EXHIBIT A BRAKE PEDAL VIBRATION AND / OR STEERING WHEEL MOVEMENT DURING LIGHT TO MODERATE BRAKING. *TT
Bulletin Number: 15095
INFORMATION PERTAINING TO FUEL OCTAINE PARAMETER ADJUSTMENT WITH NGS. *TT
Bulletin Number: 15097
SUBJECT REGARDING REAR ALIGNMENT OUT OF SPEC CONDITION. *TT
Bulletin Number: 15147
SOME VEHICLES MAY EXHIBIT A BRAKE PEDAL VIBRATION AND/OR STEERING WHEEL MOVEMENT,NOISE,OR BRAKE GRAB/LOCKUP . *ET
Bulletin Number: 15167
SOME VEHICLES MAY EXHIBIT A LOUD COMPRESSOR CYCLING NOISE. *YH
Bulletin Number: 15190
SOME VEHICLES MAY EXHIBIT SURGE, HESITATION, ROUGH IDLE OR MALFUNCTION NDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODES P0171, P0172, NP0174, P0175. *ET
Bulletin Number: 15198
SOME VEHICLES MAY EXHIBIT LOUD A/C CLUTCH CYCLING NOISE CONDITION. *JG
Bulletin Number: 15226
SOME VEHICLES EQUIPPED WITH A 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE THAT MAY BE PERCEIVED BY THE CUSTOMER A S ADIESEL TYPE NOISE AND IS KNOWN AS MARBLE NOISE. *TT
Bulletin Number: 15227
SOME EV VEHICLES MAY EXHIBIT A/C INOPEATIVE OR DIAGNOSTIC TROUBLE CODES RELATED TO A/C SYSTEM. *TT
Bulletin Number: 15455
SOME VEHICLES EQUIPPED WITH A 2.5/3.0L ENGINE MAY EXHIBIT A SURGE, HESITATION, ROUGH IDLE OR MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES P0171, P0174, P0175. *TT
Bulletin Number: 15504
SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT
Bulletin Number: 15605
SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT
Bulletin Number: 15692
SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT
Bulletin Number: 15859
SOME VEHICLES WITH 4WABS MAY EXHIBIT DIAGNOSTIC TROUBLE CODES C1233 AND C1234 (ANTI-LOCK BRAKE SENSOR OUTPUT FAILURE). *TT
Bulletin Number: 15887
SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). *TT
Bulletin Number: 16040
EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT
Bulletin Number: 17254
CLICKING/POPPING NOISE FROM UPPER STEERING COLUMN AREA WHEN TURNING. 2004 E SERIES AND EXPLORER SPORT TRAC ALSO INCLUDED. *TT
Bulletin Number: 17777
REAR LEAF SPRING NOISE. *TT
Bulletin Number: 4634
STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT
Bulletin Number: 4703
SOME TRUCKS BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND TRUCKS BUILT WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT
Bulletin Number: 5133
SOME VEHICLES EQUIPPED WITH A DUAL MEDIA (AM / FM CASS / CD) RADIO MAY EXHIBIT AN AUDIO CONCERN OF NO DISPLAY OR GRAPHICS. *TT
Bulletin Number: 5134
SOME SUPERCABS MAY EXHIBIT A BUZZ FROM THE REAR SPEAKERS. THIS MAY BE THE INTERIOR TRIM VIBRATING AT TIMES. *TT
Bulletin Number: 5230
ENGINEERING IS INTERESTED IN LOCATING CERTAIN SUPER CAB VEHICLES WITH 126 INCH WHEEL BASE AND 19.5 GALLON FUEL TANK FOR SERVICE REQUIRING FUEL TANK REPLACEMENT. *TT
Bulletin Number: 5249
INFORMATION ON VEHICLES EXHIBITING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT
Bulletin Number: 5317
EXPERIENCING EXCESSIVE EFFORT TO LIFT THE OUTSIDE (L/R) DOOR HANDLE ON VEHICLES BUILT PRIOR TO 11/15/1998. *TT
Bulletin Number: 5347
SOME VEHICLES MAY EXHIBIT A CRANK NO START CONCERN, OR THE DIAGNOSTICS HAVE VERIFIED THAT THE FUEL PUMP IS INOPERATIVE. *TT
Bulletin Number: 5382
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LIGHT ON, STALL AT TIP-IN FROM IDLE, ENGINE HESITATION, AND / OR SURGE. *TT
Bulletin Number: 5518
INFORMATION ON SERVICING OIL PAN GASKET LEAKS. *TT
Bulletin Number: 5652
COMPLAINTS THAT THE IN-DASH CD STOPS OPERATING WHEN HOT. *TT
Bulletin Number: 5705
VEHICLE EXHIBITING MULTIPLE GENERIC ELECTRONIC MODULE (GEM) RELATED SYMPTOMS. *TT
Bulletin Number: 6032
SOME VEHICLES MAY EXHIBIT A HIGH PITCHED SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT END AT SPEEDS FROM 10 MPH TO 40 MPH. *TT
Bulletin Number: 6035
SOME VEHICLES EQUIPPED WITH TEVES FOUR WHEEL ANTI-LOCK BRAKES (4WABS) MAY EXHIBIT A YELLOW ANTI-LOCK BRAKE LAMP ILLUMINATED WITH NO DIAGNOSTIC TROUBLE CODES IN MEMORY. *TT
Bulletin Number: 6199
VEHICLE MAY EXPERIENCE A DIESEL / MARBEL TYPE NOISE. *TT
Bulletin Number: 6285
SOME VEHICLES MAY EXHIBIT CONCERNS WITH A SAG IN THE REAR END. *TT
Bulletin Number: 6321
SOME VEHICLES MAY EXHIBIT SPARK KNOCK UNDER ACCELERATION. *TT
Bulletin Number: 6326
SOME VEHICLES MAY EXHIBIT A SAG IN THE REAR END. *TT
Bulletin Number: 6408
SOME VEHICLES WITH 4X4 OPTION WHILE OPERATING IN 4X2 MODE MAY EXHIBIT A LIGHT OR A ROLLING THUMP / BUMP SENSATION ON SLIGHT TO MODERATE ACCELERATION AND DECELERATION. *TT
Bulletin Number: 6468
EXPERIENCING A SQUEAK SOUND WHILE OPENING OR CLOSING THE FRONT OR REAR DOOR(S). *TT
Bulletin Number: 6574
SOME VEHICLES MAY EXHIBIT AN OCCASIONAL HOOT / MOAN FROM THE IDLE AIR CONTROL (IAC) VALVE. *TT
Bulletin Number: 6603
SOME VEHICLES MAY EXHIBIT AN AUDIBLE PINGING OR CREAKING NOISE THAT MAY BE HEARD FROM THE DRIVELINE WHEN ENGINE TORQUE IS INITIALLY APPLIED TO THE DRIVELINE. *TT
Bulletin Number: 6692
SOME VEHICLES MAY EXHIBIT NO / LOW AIR CONDITIONER PERFORMANCE AT HIGH AMBIENT TEMPERATURES AND PROLONGED IDLE. *TT
Bulletin Number: 6727
THIS ONLINE AUTOMOTIVE SERVICE BULLETIN CONTAINS PROCEDURES FOR VEHICLES WITH A REAR END SAG. *TT
Bulletin Number: 6896
SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT
Bulletin Number: 6926
SUBJECT REGARDING THE ENGINE HOTLINE PHONE NUMBERS FOR 1997 - 2000 MODEL YEAR VEHICLES. *TT
Bulletin Number: 6991
VEHICLES EQUIPPED WITH 4.0L OHV AND MANUAL TRANSMISSION MAY EXHIBIT A SQUAWK NOISE FROM THE CLUTCH ON TAKE OFF. *TT
Bulletin Number: 6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
Bulletin Number: 7026
INFORMATION REGARDING REAR END SAG. *MJS
Bulletin Number: 7119
SOME VEHICLES EQUIPPED WITH 2.5L MANUAL TRANSMISSIONS MAY EXHIBIT A HIGH ENGINE IDLE CONDITION ON DECELERATION OR WHEN DISENGAGING THE CLUTCH. *TT
Bulletin Number: 7126
SOME VEHICLES MAY EXHIBIT WINDNOISE HEARD FROM THE COWL / WINDSHIELD AREA. *TT
Bulletin Number: 7147
EXHIBITING AN INTERNAL LOW END NOISE THAT IS DESCRIBED AS A DIESEL AND / OR MARBLES IN A TIN CAN RATTLE. *TT
Bulletin Number: 7206
VEHICLES EQUIPPED WITH 4.0L OHV ENGINE AND MANUAL TRANSMISSION MAY EXHIBIT A SQUAWK NOISE FROM THE CLUTCH ON TAKE OFF. *TT
Bulletin Number: 7353
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT
Bulletin Number: 7366
SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION MAY EXHIBIT NEUTRAL GEAR ROLLOVER NOISE (A LIGHT METALLIC RATTLING SOUND FROM THE TRANSMISSION) WHICH OCCURS AT IDLE WITH TRANSMISSION IN NEUTRAL CLUTCH ENGAGED (CLUTCH PEDAL UP). *TT
Bulletin Number: 7471
SOME VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT EXCESSIVE OIL CONSUMPTION AS REPORTED BY THE CUSTOMER. *TT
Bulletin Number: 7885
THE VEHICLE MAY EXHIBIT THE SPEEDOMETER/ODOMETER INOPERATIVE AS WELL AS MALFUNCTION INDICATOR LAMPS ILLUMINATED OR FLASHING AFTER THE GENERIC ELECTRONIC MODULE (GEM), CENTRAL TIMER MODULE (CTM), OR FOR WHEEL ANTI-LOCK BRAKE SYSTEM (4WABS) M
Bulletin Number: 7886
THE VEHICLE EQUIPPED WITH A3.0L AND AUTOMATIC/MANUAL TRANSMISSION MAY VIBRATE AT HIGH SPEEDS WHICH MAY CAUSE THE TRANSMISSION EXTENSION HOUSING SEALS TO LEAK OR THE TRANSMISSION EXTENSION HOUSING ABUISHING TO SPIN.
Bulletin Number: 8007
A HIGH IDLE CONDITION ON DECELERATION AND/OR WHEN THE CLUTCH IS DISENGAGED.
Bulletin Number: 8008
BUZZING AND GRINDING NOTCHY NOISE WHEN SHIFTING(2-3 UPSHIFT).
Bulletin Number: 8091
SOME VEHICLES EQUIPPED WITH 2.5L ENGINES MAY EXHIBIT A BELT SQUEAL INITIALLY AT COLD START-UP. *TT
Bulletin Number: 8164
INFORMATION ON 5R55E - 4R55E - 4R44E PUMP ALIGNMENT TOOLS. *TT
Bulletin Number: 8164
INFORMATION REGARDING PUMP ALIGNMENT TOOLS. **MR
Bulletin Number: 8377
EXPERIENCE A GROWLING NOISE FROM THE FRONT AXLE IN 4X2 OR 4X4 MODE AFTER ENGAGING 4X4 MODE AND THEN DISENGAGING WITHIN 40 SECONDS. *TT
Bulletin Number: 8512
SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR
Bulletin Number: 8560
SOME VEHICLES MAY EXHIBIT AN OIL LEAK AT THE REAR SEAL OF THE TRANSMISSION EXTENSION HOUSING. **MR
Bulletin Number: 870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
Bulletin Number: 976011
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 976011
TECHNICIANS EXPERIENCING YELLOW POP-UPS ON SERVICE BAY DIAGNOSTIC SYSTEM (SBDS)." *TT
Bulletin Number: 980216983-20
A "BOOMING" NOISE MAY BE HEARD IN THE CAB WHILE DRIVING WITH ENGINE AT 2500-300 RPMS. *YC
Bulletin Number: 9805009
CUSTOMER MAY EXPERIENCE A CRANK AND NO START CONDITION. *TT
Bulletin Number: 9810930
SOME VEHICLES MAY EXHIBIT AN ENGINE OIL LEAK FROM THE REAR MAIN CRANKSHAFT SEAL. *TT
Bulletin Number: 9811303
SOME VEHICLES MAY EXPERIENCE A SQUEEK / CREEK SOUND WITHIN THE CAB OF THE TRUCK WHILE DRIVING. *TT
Bulletin Number: 9811338
SOME VEHICLES MY BE MISSING FENDER HOLES TO MOUNT MUD FLAPS. *TT
Bulletin Number: 9811348
SOME VEHICLES EXHIBITING A THROTTLE PEDAL BUZZING. *TT
Bulletin Number: 9811469
SOME VEHICLES MAY RECEIVE INCORRECT MUD FLAPS DURING INSTALLATION AND WILL NOT FIT PROPERLY TO THE VEHICLE. *TT
Bulletin Number: 9811476
SOME SUPER CAB 4X4 VEHICLES BUILT FROM TWIN CITIES ASSEMBLY PLANTS BETWEEN 08-21-97 AND 03-03-98 MAY EXPERIENCE A NOISE AND / OR VIBRATION CONCERN WHILE DRIVING APPROXIMATELY 35 MPH OR FASTER. *TT
Bulletin Number: 9811479
THE PARTS CATALOG BOOK REFERENCES AN INCORRECT CLUTCH PART NUMBER FOR CERTAIN VEHICLES WITH THE 3.0L ENGINE. *TT
Bulletin Number: 9811488
SOME VEHICLES EQUIPPED WITH A CTM (CENTRAL TIMER MODULE) MAY EXPERIENCE INTERMITTENT WIPER OPERATION WITHOUT COMMAND; DOME LIGHTS REMAINING ON; OR THE DOOR CHIMES REMAINING ON. *TT
Bulletin Number: 98121
SUBJECT REGARDING POWER WINDOW TRAVELLING 25 - 127 MM (1-5 INCHES) DOWNWARD WHEN USING ONE-TOUCHDOWN MODE. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 98155
SQUEAKING AND CREAKING NOISE COMING FROM CAB WHILE DRIVING. YD
Bulletin Number: 98158
THE DRIVER'S AND PASSENGER'S DOOR GLASS CHATTER WHEN OPERATING THE WINDOW IN DOWN MODE.
Bulletin Number: 981613
TRANSMISSION FLUID LEAKS AT RADIATOR. YD
Bulletin Number: 981616
LEFT REAR SIDE OF VEHICLE APPEARS LOW. *AK
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 98165
EVAPORATOR CORE FAILED, CAUSING THE AIR CONDITIONER TO DRIP ON TO PASSENGER FLOOR. YD
Bulletin Number: 9818
FUEL PUMP REPLACEMENT PROCEDURE - SERVICE TIP. *TT
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 982013
SOME VEHICLES MAY EXHIBIT REDUCED A/C AIR FLOW, REDUCED DRIVING RANGE, AND/ OR REDUCED A/C PERFORMANCE. *YC
Bulletin Number: 98203
CONCERNS WITH THE POTENTIAL EFFECTS OF ADHESIVES USED FOR BODY PANEL REPAIRS. *TT
Bulletin Number: 98203
CONCERNS WITH ADHENSIVES NOT RECOMMENDED FOR BODY PANEL REPAIRS. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982312
ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98238
CONDENSATE MAY LEAK ONTO THE PASSENGER FLOOR ON SOME VEHICLES. *YC
Bulletin Number: 982453
SOME VEHICLES MAY EXHIBIT ERRONEOUS DTCS B1398 & B1302 WHEN DIAG. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982516
LIFT EFFORT IS EXCESSIVE ON THE DRIVER AND / OR PASSENGER OUTSIDE DOOR HANDLE. *YC
Bulletin Number: 982521
INFORMATION ON THE PARTS CATALOG BOOK REFERENCES AN INCORRECT CLUTCH PART NUMBER FOR SOME VEHICLES WITH THE 3.0L ENGINE. *YC
Bulletin Number: 982526
SOME VEHICLES MAY EXPERIENCE VARIOUS CONCERNS SUCH AS INTERMITTENT WINDSHIELD WIPER OPERATION WITHOUT COMMAND, DOME LIGHTS REMAINING ON, AND/OR THE DOOR CHIMES REMAING ON. *YC
Bulletin Number: 982530
SOME VEHICLES MAY RECEIVE INCORRECT MUD FLAPS DURING INSTALLATION AND WILL NOT FIT PROPERLY TO THE VEHICLE. *YC
Bulletin Number: 982537
EXPERIENCING A NOISE AND / OR VIBRATION CONCERN WHILE DRIVING APPROXIMATELY 35MPYH OR FASTER. *YC
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 982671
SOME VEHICLES MAY EXPERIENCE POOR RADIO RECEPTION ( AM/FM). *YC
Bulletin Number: 982730
EXHIBITING A BROKEN SEAT BACK HANDLE LEVER. *YC
Bulletin Number: 983071
BRIEF INFORMATION REGARDING THE IMPROVED SAIL MOUNT MANUAL MIRROR. *TT
Bulletin Number: 983074
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 983140
EXPERIENCING A SQUEAKING / CREEKING SOUND INSIDE THE PASSENGER COMPARTMENT WHEN THE VEHICLE IS MOVING. *TT
Bulletin Number: 98315
ON SOME VEHICLES, THE SERVICE BAY DIAGNOSTIC SYSTEM (SBDS) AND/OR NEW GENERATION STAR (NGS) TESTER MAY NOT BE ABLE TO READ THE SIGNAL FROM THE HEATED OXYGEN SENSOR (HO2S). *YC
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 983572
CONCERNS WITH ANTI-LOCK BRAKE SYSTEM (ABS) DIAGNOSTIC TROUBLE CODES AND / OR ABS LIGHT FLASHING WHILE DRIVING. *TT
Bulletin Number: 9839
THE DRIVER'S AND/OR PASSENGER DOOR GLASS MAY
Bulletin Number: 9844
SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 98-4732
STEERING WHEEL SHIMMIES, VIBRATION OR GRUNT ON SLOW SPEED TURNS..
Bulletin Number: 985019
EXHIBITING A CONDITION OF PULLS TO THE RIGHT. *TT
Bulletin Number: 985045
REVISED MESSAGE REGARDING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS ACTION ON SOHC EQUIPPED VEHICLES, PERFORM TSB 98-21-01. *TT
Bulletin Number: 985085
SOME VEHICLES WITH POWER WINDOWS MAY EXHIBIT WINDOW CHATTERING OR JERKING MOTION WHEN OPERATING IN THE DOWN MODE. *AK *TT
Bulletin Number: 98512
EXPERIENCING A SQUEAKING / RATTLING NOISE HEAR FROM THE VEHICLE WHILE THE VEHICLE IS MOVING. *YC
Bulletin Number: 98513
A VIBRATION OR BIZZING MAY BE FELT THROUGH THE THROTTLE PEDAL ON SOME VEHICLES. *TT
Bulletin Number: 985133
SOME VEHICLES EQUIPPED WITH A DUAL MEDIA (AM/FM/CASS/CD) RADIO MAY EXHIBIT AN AUDIO CONCERN OF NO DISPLAY OR GRAPHICS. *TT
Bulletin Number: 985134
SOME SUPERCABS MAY EXHIBIT A BUZZ FROM THE REAR SPEAKERS. *TT
Bulletin Number: 98514
CONCERNS WITH A WHISTLING OR HISSING NOISE FROM THE MAIN CONTROL AREA OCCURING WHILE IDLING IN DRIVE AND / OR REVERSE ON SOME VEHICLES. *TT
Bulletin Number: 985161
SOME 3.0L MANUAL TRANSMISSION EQUIPPED VEHICLES MAY EXHIBIT A CONCERN OF ENGINE IDLE HIGH (1500 - 2000 RPM) DURING DECELERATION. *TT
Bulletin Number: 985174
SOME VEHICLES WITH 4X4 OPTION IN 4X2 MODE MAY EXHIBIT A PING SOUND ON SLIGHT TO MODERATE ACCELERATION IN FORWARD OR REVERSE. *TT
Bulletin Number: 985175
SOME VEHICLES WITH 4X4 OPTION OPERATING IN 4X2 MAY EXHIBIT A SLIGHT OR A ROLLING THUMP / BUMP ON SLIGHT TO MODERATE ACCELERATION. *TT
Bulletin Number: 985178
SOME VEHICLES MAY EXHIBIT A CLIMATE CONTROL ISSUE OF LACK OF HEAT. *TT
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9866
IT MAY BE DIFFICULT TO INSTALL MUD FLAPS ONTO SOME VEHICLES. *YC
Bulletin Number: 9867
INFORMATION ON THE REVISED MANUAL OUTSIDE REARVIEW MIRRORS BUILT THROUGH 2/13/98. *TT
Bulletin Number: 98813
SOME VEHICLES MAY EXHIBIT INTERMITTENT OR NO 4X4 ENGAGEMENT , EVEN WHILE THE 4X4 ILLUMINATED, AND/OR A CLUNKING NOISE HEARD WHILE SHIFTING INTO 4X4 ON THE FLY. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 98B25
OWNER NOTIFICATION PROGRAM 98B25-1998 RANGER FOUR-WHEEL ABS INVOICING/WINDOW STICKER CUSTOMER SATISFACTION PROGRAM.
Bulletin Number: 98L22
SUBJECT ON REVISED SAFETY CERTIFICATION LABELS. *TT
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 99134
EXPERIENCING A THUMP AND / OR BUMP SENSATION ON LIGHT ACCELERATION AND / OR DECELERATION ON SOME VEHICLES. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99161
EXPERIENCING AN AUDIBLE PINGING OR CREAKING (NOT A CLUNKING NOISE) HEARD FROM THE DRIVELINE WHEN ENGINE TORQUE IS INITIALLY APPLIED TO THE DRIVELINE SUCH AS WHEN SHIFTING FROM PARK TO DRIVE OR REVERSE, BETWEEN DRIVE AND REVERSE. *TT
Bulletin Number: 99162
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0125 STORED IN MEMORY, AND / OR LACK OF HEAT WITH THE CLIMATE CONTROL. *TT
Bulletin Number: 99163
THIS BULLETIN MENTIONS CLARIFICATION ON HOW TO OBTAIN RANGER ELECTRIC VEHICLE (EV) TRACTION BATTERY MODULES. *TT
Bulletin Number: 99164
INFORMATION ON JUMP START PROCEDURES FOR RANGER ELECTRIC VEHICLE (EV) AUXILIARY BATTERY. *TT
Bulletin Number: 99167
INFORMATION ON POSSIBLE BATTERY OVERCHARGE WHILE USING NGS TESTER. *TT
Bulletin Number: 991813
EXPERIENCING AN INOPERATIVE OR INACCURATE ODOMETER / SPEEDOMETER READINGS. *TT
Bulletin Number: 99183
SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99221
SOME VEHICLES MAY APPEAR TO BE LOW IN THE REAR. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
Bulletin Number: 99238
A TEMPERATURE GAUGE FLUCTUATION AND / OR A KNOCKING / THUMPING NOISE MAY BE AUDIBLE INTHE PASSENGER COMPARTMENT ON SOME VEHICLES. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT
Bulletin Number: 995157
INFORMATION ON MAINTAINING TIRE PRESSURE. *TT
Bulletin Number: 996125
SUBJECT REGARDING FUEL SYSTEM DIAGNOSTIC. *TT
Bulletin Number: 996780
THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT
Bulletin Number: 996884
CUSTOMERS MAY COMPLAIN OF AN INTERNAL LOW END NOISE THAT IS DESCRIBED AS A "DIESEL AND / OR MARBELS IN A TIN CAN RATTLE" ON VEHICLES WITH A 4.OL OVH ENGINE. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: 9986
SOME VEHICLES MAY EXHIBIT AN OVERDRIVE (O/D) LIGHT FLASHING WITH DIAGNOSTIC TROUBLE CODE (DTC) P0741 AND / OR P1740. *TT
Bulletin Number: 99B17
OWNER NOTIFICATION PROGRAM REGARDING RANGER ELECTRIC-VEHICLE COMPONENT UPGRADES. *TT
Bulletin Number: 99M05
SOME VEHICLES MAY EXPERIENCE PREMATURE TRACTION BATTERY WEAR-OUT. FORD IS PROVIDING FULL BATTERY COVERAGE. *TT
Bulletin Number: 99S09
RECALL INFORMATION REGARDING SPEED CONTROL CABLE REPLACEMENT. *TT
1998 FORD RANGER EV
Bulletin Number: 00B37
SUBJECT ON THE OWNER NOTIFICATION PROGRAM 00B37, THE CURRENT TRACTIONH BATTERY MAY PREMATURELY TRIGGER THE LOS (LIMITED OPERATING STRATEGY). *MJS
Bulletin Number: 01B69
OWNER NOTIFICATION PROGRAM NOTIFYING OWNERS THAT THEIR VEHICLE MAY HAVE AN ELECTRIC COOLANT PUMP THAT COULD MALFUNCTION UNDER CERTAIN DUTY CYCLES. THIS PRORAM INVOLVES POSSIBLE REPLACEMENT OF THE ELECTRIC COOLANT PUMP. *TT
Bulletin Number: 01B69S1
OWNER NOTIFICATION PROGRAM (SUPPLEMENT #1) REGARDING ELECTRIC COOLANT PUMP REPLACEMENT. REVISED TO REFLECT ELECTRIC COOLANT PUMP REPLACEMENT FOR ALL AFFECTED 1998 MODEL YEAR VEHICLES, WITHOUT THE NEED OF PERFORMING A WIGGLE TEST.
Bulletin Number: 01B70
ONWER NOTIFICATION PROGRAM REGARDING INTERMITTENT OIL WARNING LAMP - TIM SOFTWARE UPDATE. *TT
Bulletin Number: 01B76
SUBJECT REGARDING BATTERY CONTROL MODULE (BCM) SOFTWARE UPDATE FOR CERTAIN ELECTRIC VEHICLES EQUIPPED WITH A LEAD ACID TRACTION BATTERY. *TT
Bulletin Number: 0265
ELECTRIC VEHICLE (EV) COLD WEATHER BATTERY PERFORMANCE. *TT
1998 FORD SHO (TAURUS)
Bulletin Number: 13802
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INTEGRATED CONTROL PANEL (ICP) ILLUMINATION. AUDIO AND CLIMATE CONTROLS CONTINUE TO OPERATE DURING THE ICP'S LOSS OF ILLUMINATION CONDITION. THIS MAY BE CAUSED BY A FAULTY INTERNAL RIBBO
Bulletin Number: 8016
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INTEGRATED CONTROL PANEL (ICP) ILLUMINATION. **MR**
Bulletin Number: 8016
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INSTRUMENT CONTROL PANEL (ICP).
1998 FORD STRIPPED CHASSIS
Bulletin Number: 13187
INFORMATION REGARDING E40D/4R100 TRANSMISSION FLUID COOLER FLOW TEST SPECIFICATION. *MJS
Bulletin Number: 6999
SUBJECT REGARDING E40D / 4R100 TRANSMISSION FLUID COOLER FLOW TEST SPECIFICATION. *TT
1998 FORD SUPER DUTY F SERIES
Bulletin Number: 00610
INFORMATION ON THE 7.3L DIT ENGINES, ROTUNDA TOOL HAS ISSUED AN INJECTOR PERFORMANCE ANALYZER THAT MAY NOW BE PRUCHASED AS AN EFFECTIVE AID IN HELPING TO RESOLVE ROUGH IDLE CONCERNS. *MJS
Bulletin Number: 032137
FOR 7.3L DIT ENGINES, ROTUNDA TOOL HAS ISSUED AN INJECTOR PERFORMANCE ANALYZER THAT MAY NOW BE PURCHASED AS AN EFFECTIVE AID IN HELPING TO RESOLVE ROUGH IDLE CONCERNS. *TT
Bulletin Number: 12573
INFORMATION REGARDING THE AUDIO SYSTEM SELECTIVE LIGHTING FEATURE. *TT
Bulletin Number: 13488
SOME VEHICLES EQUIPPED WITH 7.3L DIT ENGINE MAY EXHIBIT A ROUGH ENGINE IDLE. *TT
Bulletin Number: 13505
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
Bulletin Number: 13548
INFORMATION ON THE IDLE KICKER FEATURE, WHICH UNDER CONDITIONS WILL AUTOMATICALLY ELEVATE THE IDLE SPEED AFTER 130 SECONDS OF IDLING AT COLD TEMPERATURES. *TT
Bulletin Number: 13820
INFORMATION ON REPROGRAMMING A PCM WITH THE LATEST CALIBRATION ON CERTAIN VEHICLES EQUIPPED WITH A 7.3L DIESEL ENGINE. A NEW CALIBRATION WAS RECENTLY RELEASED TO PROVIDE IMPROVED MIL DIAGNOSTIC AND TO CORRECT A 4R100 TRANSMISSION SURGE AT
Bulletin Number: 16480
DIAGNOSTIC TROUBLE CODE (DTC) P0340, POSSIBLE FALSE CODE. VARIOUS MODELS INCLUDING 1994-1996 FORD EXCURSION. *TT
Bulletin Number: 17777
REAR LEAF SPRING NOISE. *TT
Bulletin Number: 7353
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT
Bulletin Number: 7475
SOME VEHICLES EQUIPPED WITH 73L DIT ENGINE MAY EXHIBIT A ROUGH ENGINE IDLE. *TT
Bulletin Number: 996034
EXPERIENCING A ENGINE KNOCK AT COLD START-UP. *TT
1998 FORD TAURUS
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 00191
SOME VEHICLES MAY EXPERIENCE A SEPARATION BETWEEN LAYERS OF THE INSTRUMENT PANEL. *JB
Bulletin Number: 00203
A SEPARATION BETWEEN LAYERS OF THE INSTRUMENT PANEL.*JB
Bulletin Number: 00263
SOME VEHICLES MAY EXHIBIT A POWER WINDOW THAT WILL NOT OPERATE DOWNWARD BECAUSE IT'S STUCK / BOUND TO THE WEATHERSHIP HEADER. *TT
Bulletin Number: 0035
VEHICLES MAY EXPERIENCE HIGH IDLE. *MJS
Bulletin Number: 00E11
SERVICE ACTION 00E11, SUPPLEMENT #1 - UPDATE INFORMATION REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
Bulletin Number: 00E11
SERVICE ACTION BULLETIN REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
Bulletin Number: 01116
SOME VEHICLES MAY EXHIBIT COOLING SYSTEM CONDITIONS SUCH CONTAMINATED / CORRODED COOLANT; LEAKING / DISCOLORED COOLANT OVERFLOW BOTTLES; VIBRATION FROM ENGINE; LEAKING HEATER CORE; COOLANT OVERFLOW; HIGH TEMPERATURE GAUGE READINGS, ETC.
Bulletin Number: 01124
ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 012113
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 0162
VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02153
SOME VEHICLES EQUIPPED WITH THE 3.0L 4V DURATEC ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P1518, INTAKE MANIFOLD RUNNER CONTROL. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02183
EXHAUST SYSTEM Y-PIPE CRACK AT THE NOISE VIBRATION HARNESS BRACKET. *MJ
Bulletin Number: 02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH
Bulletin Number: 02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
Bulletin Number: 02236
ERRATIC OPERATION OF THE COOL/WARM FUNCTION OF THE TEMPERATURE CONTROL SYSTEM - REPAIR PROCEDURE FOR STRATIFICATION (SECONDARY) TEMPERATURE BLEND DOOR. *TT
Bulletin Number: 0245
INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT
Bulletin Number: 03123
TORQUE CONVERTER CLUTCH NOT ENGAGING WHEN COMMANDED AND/OR DIAGNOSTIC TROUBLE CODES P0741 OR P1744 STORED IN MEMORY. MODELS FROM 1996 TO 2003. *TT
Bulletin Number: 031404
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
Bulletin Number: 03141
IN VEHICLE LOCTITE SERVICE PROCEDURE FOR CAMSHAFT TUBE AND GEAR. *TT
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 090308
MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455
Bulletin Number: 11530
WHEN DIAGNOSING CRANK / NO START ON CERTAIN VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT (PATS) CHECK THE CUSTOMERS KEY RING FOR ANY MAGNETIC OBJECTS LIKE THE MOBILE SPEEDPASS KEY WHICH MAY AFFECT THE SIGNAL TRANSMISSION BETWEEN THE PATS KEY A
Bulletin Number: 11764
SUBJECT REGARDING VEHICLES WHICH WILL BE DELIVERED WITH COVERS OVER THE FRONT BRAKE ROTORS. *TT
Bulletin Number: 11773
SUBJECT REGARDING SERVICE EVAPORATOR ASSEMBLIES. *TT
Bulletin Number: 11795
SOME VEHICLES MAY EXHIBIT A HARD / NO START CONCERN WHEN PARKED IN A STEEP NOSE-UP POSITION WITH LESS THAN 1/4 TANK OF FUEL AND FOR AN EXTENDED PERIOD OF TIME. *TT
Bulletin Number: 11803
SOME VEHICLES WITH MANUAL LOCKS BUILT BETWEEN 4/7/98 AND 7/17/98 MAY HAVE A CONCERN OF EXCESSIVE POWER DRAIN OR DEAD BATTERY. *TT
Bulletin Number: 12066
SOME VEHICLES WERE CALIBRATED WITH INCREASED AIR FLOW AT CLOSED THROTTLE TO PREVENT TIP-IN BUMPS, A RESULT MAY BE REDUCED DECELERATION FEEL AND LESS ENGINE RPM REDUCTION AT CLOSED THROTTLE WITH THE VEHICLE MOVING. *MJS
Bulletin Number: 12079
VEHICLES MAY EXHIBIT A BUZZ OR RATTLE CONDITION ON A COLD START OR DURING A LOW RPM STEAD SPEED. *MJS
Bulletin Number: 12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
Bulletin Number: 12163
SOME VEHICLES MAY EXHIBIT A SLIGHT VIBRATION DURING ACCELERATION ONLY. *MJS
Bulletin Number: 12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
Bulletin Number: 12178
INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. *MJS
Bulletin Number: 12189
INFORMATION ON INSTALLATION A NEW FUEL PUMP , ENSURE THAT THE PUMP HAS PLASTIC SHEATHING OVER THE WIRES. *MJS
Bulletin Number: 12238
SOME VEHICLES MAY EXHIBIT AN INOPERATIVE POWER WINDOW CONCERNS. *TT
Bulletin Number: 12515
VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODES P0135 OR P0155 CAUSED BY THE POWERTRAIN CONTROL MODULE CALIBRATION (PCM). *TT
Bulletin Number: 12545
INFORMATION ON DETERMINING ONBOARD VAPOR RECOVERY (ORVR) VS. NON-ORVR. *TT
Bulletin Number: 12559
CONCERNS WITH REVERSE CLUTCH THAT COULD BECOME SHEARED OR TORN IN EXTREMELY COLD TEMPERATURES. *TT
Bulletin Number: 12570
SOME VEHICLES MAY EXHIBIT FRONT OUTER TIE RODS SQUEAK AND / OR POP NOISE OVER BUMPS AND / OR TURNING. *TT
Bulletin Number: 12603
VEHICLE MAY EXHIBIT A DIAHNOSTIC TROUBLE CODE P0135 OR P0155 CAUSED BY THE POWERTRAIN CONTROL MODULE (PCM) CALIBRATION. *TT
Bulletin Number: 12614
SUBJECT REGARDING REDESIGNED TRANSAXLE PUMP GASKET TO REMOVE GASKET MATERIAL THAT COULD BREAK OFF AND STICK VALVES IN THE VALVE BODY. *TT
Bulletin Number: 12616
INFORMATION ON TRANSAXLE SERVICE CASE REPLACEMENT WITH OSS (OUTPUT SHAFT SPEED SENSOR) HOLE. *TT
Bulletin Number: 12704
SUBJECT REGARDING ALL VEHICLES REQUIRES A PARAMETER RESET TO BE PERFORMED ON THE PASSIVE ANTI-THEFT SYSTEM MODULE (PATS / VIC / HEC) WHEN THE POWERTRAIN CONTROL MODULE (PCM) IS REPLACED. *TT
Bulletin Number: 12784
INFORMATION ON REMOVING REAR TIE DOWN BRACKETS DURING PDI AS REQUIRED. *TT
Bulletin Number: 13101
SUBJECT REGARDING THE SBDS RELATIVE CAM TIMING TEST. *TT
Bulletin Number: 13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
Bulletin Number: 13250
INFORMATION REGARDING SLIGHT VIBRATION UPON ACCELERATION. *MJS
Bulletin Number: 13381
SUBJECT REGARDING SERVICE TIP FOR SUN VISOR BRACKET BREAKAGE. *TT
Bulletin Number: 13472
FOR VEHICLES THAT REQUIRE CONFIGURATION OF THE ELECTRONIC CRASH SENSOR MOUDLE TO SETTINGS OTHER THAN THE PRESET SETTINGS, THE CONFIGURATION INSTRUCTIONS WERE OMITTED FROM THE SHOP MANUAL. *TT
Bulletin Number: 13802
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INTEGRATED CONTROL PANEL (ICP) ILLUMINATION. AUDIO AND CLIMATE CONTROLS CONTINUE TO OPERATE DURING THE ICP'S LOSS OF ILLUMINATION CONDITION. THIS MAY BE CAUSED BY A FAULTY INTERNAL RIBBO
Bulletin Number: 13802
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INSTRUMENT CONTROL PANEL (ICP) ILLUMINATION. *MJS
Bulletin Number: 14087
SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE P1518 AND/OR P1519, RELATED TO INTAKE MANIFOLD RUNNER CONTROL (IMRC). **MR
Bulletin Number: 14220
SOME VEHICLES EQUIPPED WITH AN AX4N TRANSAXLE MAY EXHIBIT A SHUDDER DURING A 3-4 SHIFT. *TT
Bulletin Number: 14220
INFORMATION USED TO SERVICE AX4N TRANSAXLE EQUIPPED VEHICLES EXHIBITING SHUDDER DURING 3-4 SHIFT. *TT
Bulletin Number: 14355
EXHIBITING AN OIL LEAK FROM THE ENGINE OIL PAN. *TT
Bulletin Number: 14355
INFORMATION PERTAINING TO DURATEC OIL PAN INVESTIGATION. *JB
Bulletin Number: 14584
SUBJECT REGARDING FLEX FUEL VECHICLE OIL AND FUEL RECOMMENDATIONS. *JB
Bulletin Number: 14856
SOME VEHICLES EQUPPED WITH 3.0L 2V VULCAN OR 4V DURATEC ENGINE MAY EXHIBIT AN EXHAUST RUST-THRU, WELD FATIGUE CONDITION BETWEEN THE TWO TOEBOARD CATALYSTS WHERE A TIE-IN BRACKET IS WELDED TO THE FORMED INLET PIPE OF THE REAR BANK TOEBOARD C
Bulletin Number: 15059
CONCERNS WITH VEHICLES EQUIPPED WITH A AX4N / 4F50N TRANSAXLE EXHIBITING A SHUDDER DURING A 3-4 SHIFT. *TT
Bulletin Number: 15370
SOME VEHICLES MAY EXHIBIT A GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK. *TT
Bulletin Number: 15390
SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LIGHT AND/OR EGR DIAGNOSTIC TROUBLE CODES 332, P0401, P1407 (LACKOF EGR FLOW). *TT
Bulletin Number: 15392
SOME VEHICLES MAY EXHIBIT A PARK PULLOUT CLUNK NOISE WHEN SHIFTING FROM PARK TO ANOTHER GEAR POSITION. *TT
Bulletin Number: 15820
SOME VEHICLES EQUIPPED WITH AN AX4N/4F50N TRANSAXLE MAY EXHIBIT A SHUDDER DURING A 3-4 SHIFT. *TT
Bulletin Number: 15879
SOME SHO VEHICLES MAY EXHIBIT A TICKING NOISE ORIGINATING FROM THE VALVE COVER AREA. *TT
Bulletin Number: 17358
GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE. *TT THIS BULLETIN UPDATES PREVIOUS BULLETIN 17358, DATED 11/01/2003 TO INCLUDE 2005 MODELS. *TT
Bulletin Number: 18614
SURGE, IDLE ROLL, ROUGH IDLE ONLY WHEN THE ENGINE COOLING FANS ARE OPERATING. *TT
Bulletin Number: 4619
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT
Bulletin Number: 4647
IMPORTANT PRE-DELIVERY INFORMATION REGARDING SOME VEHICLES DELIVERED WITH COVERS OVER THE FRONT BRAKE ROTORS. *TT
Bulletin Number: 4655
INFORMATION ON THE SERVICE EVAPORATOR ASSEMBLIES. *TT
Bulletin Number: 4677
SOME VEHICLES MAY EXHIBIT A HARD / NO START CONCERN WHEN PARKED IN A STEEP NOSE-UP POSITION WITH LESS THAN 1/4 TANK OF FUEL AND FOR AN EXTENDED PERIOD OF TIME. *TT
Bulletin Number: 4695
SOME VEHICLES WITH MANUAL LOCKS BUILT BETWEEN 4/7/98 AND 7/17/98 MAY HAVE A CONCERN OF EXCESSIVE POWER DRAIN OR DEAD BATTERY. *TT
Bulletin Number: 5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
Bulletin Number: 5226
INFORMATION ON INSTALLING A NEW FUEL PUMP ON CERTAIN VEHICLES. *TT
Bulletin Number: 5301
INFORMATION ON VEHICLES EXHIBITING AN INOPERATIVE POWER WINDOW. *TT
Bulletin Number: 5304
INFORMATION ON FRONT DISC BRAKE ROTOR PROTECTORS CURRENTLY BEING INSTALLED ON CERTAIN VEHICLES. *TT
Bulletin Number: 5518
INFORMATION ON SERVICING OIL PAN GASKET LEAKS. *TT
Bulletin Number: 5897
EXPERIENCING A SQUEAKING AND / OR POPPING NOISE FROM THE FRONT OUTER TIRE RODS. *TT
Bulletin Number: 6283
IMPORTANT INFORMATION ON REMOVING REAR TIE DOWN BRACKETS DURING PRE-DELIVERY. *TT
Bulletin Number: 6478
INFORMATION ON THE AVAILABILITY OF FORD QUALITY RENEWAL 2.5L AND 3.0L 4V ENGINES. *TT
Bulletin Number: 6567
SUBJECT REGARDING FORD QUALITY RENEWAL (FQR) ASSEMBLIES. *TT
Bulletin Number: 6579
INFORMATION DIAGNOSING VEHICLES THAT MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P1309 STORED IN MEMORY. *TT
Bulletin Number: 6612
SOME VEHICLES MAY EXHIBIT FRONT SUSPENSION NOISE DUE TO FRONT STRUT, FRONT SWAY BAR LINKS OR SYMPTOMS SUCH AS PREMATURE REAR BRAKE PAD WEAR DUE TO SEIZED REAR BRAKE CALIPERS OR SLIDES. *TT
Bulletin Number: 6646
SOME VEHICLES WITH 3.0L 4-VALVE ENGINES BUILT BETWEEN 12/17/97 AND 6/30/99 MAY EXHIBIT A HARD START / LONG CRANK OR A ROUGH IDLE AFTER A COLD START. *TT
Bulletin Number: 6696
SUBJECT REGARDING FORD QUALITY RENEWAL (FQR) EXCHANGE PROGRAM. *TT
Bulletin Number: 6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
Bulletin Number: 7249
INFORMATION ON USING PEANUT STYLE A/C FITTINGS. *TT
Bulletin Number: 7292
NNERS OF THE EDSR-OF-THE-MONTH QUALITY AWARD ANNOUNCEMENT FOR SEPTEMBER. *TT
Bulletin Number: 7306
SERVICE TIP FOR VEHICLES BUILT 11/1/1997 - 2/15/1999 WITH SINGLE ILLUMINATED VANITY MIRROR SUN VISORS ONLY, MAY EXHIBIT A BROKEN SUNVISOR STOWAGE BRACKET. *TT
Bulletin Number: 7855
VEHICLES MAY EXHIBIT INTERMITTENT INSTRUMENT CONTROL PANEL (ICP) ILLUMINATION.
Bulletin Number: 8016
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INTEGRATED CONTROL PANEL (ICP) ILLUMINATION. **MR**
Bulletin Number: 8199
SOME VEHICLES MAY EXHIBIT A RATTLING OR CLUNKING NOISE FROM THE FRONT END (FRONT STABILIZER LINK) UNDER NORMAL DRIVING CONDITIONS.
Bulletin Number: 8316
SOME VEHICLES EQUIPPED WITH COMPACT DISC CHANGER MAY EXHIBIT A 6 DISC CD CHANGER THAT IS NOT EJECTING THE MAGAZINE OR IS NOT RESPONDING TO COMMAND FROM THE RADIO.
Bulletin Number: 8583
SOME VEHICLES MAY EXHIBIT DTC P1518 AND / OR P1519, RELATED TO INTAKE MANIFOLD RUNNER CONTROL (IMRC). *MR
Bulletin Number: 870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
Bulletin Number: 97090297183
EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC
Bulletin Number: 97090297184
SOME VEHICLES MAY EXPERIENCE STATIC IN THE AM BAND OF THE RADIO WHILE DRIVING. *YC
Bulletin Number: 97111097231
DIAGNOSTIC AND INSPECTION PROCEDURE FOR FRONT SUSPENSION NOISE. *YC
Bulletin Number: 97111097237
CONCERNS WITH HARSH ENGAGEMENTS AND HARSH SHIFTS WITH DIAGNOSTIC TROUBLE CODES (DTCS) 628, P0741 AND/OR P1744. *YC
Bulletin Number: 976011
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 9802169837
SOME VEHICLES MAY EXPERIENCE AN NO FORWARD OR REVERSE MOVEMENT. *YC
Bulletin Number: 9802169838
TRANSAXLES USE A NEW TRANSMISSION FLUID. *YC
Bulletin Number: 980321
PATS KEY PROGRAMMING. *AK
Bulletin Number: 98110
SUBJECT REGARDING PASSIVE ANTI THEFT SYSTEM (PATS) DIAGNOSTIC SERVICE TIPS. *TT
Bulletin Number: 9811156
SOME VEHICLES MAY EXHIBIT AN OVERHEAT CONDITION WITH POSSIBLE ENGINE FAILURE. *TT
Bulletin Number: 9811481
SOME VEHICLES EQUIPPED WITH 3.0L 4-VALVE ENGINES MAY EXHIBIT A CUSTOMER CONCERN OF A MOAN NOISE AT IDLE. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 98164
A TRANSEAL COATING IS ON THE FRONT AND REAR BUMPERS. THIS COATING MUST BE REMOVED BEFORE DELIVERY TO THE CUSTOMER. YD
Bulletin Number: 9818
FUEL PUMP REPLACEMENT PROCEDURE - SERVICE TIP. *TT
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 98203
CONCERNS WITH ADHENSIVES NOT RECOMMENDED FOR BODY PANEL REPAIRS. *YC
Bulletin Number: 98203
CONCERNS WITH THE POTENTIAL EFFECTS OF ADHESIVES USED FOR BODY PANEL REPAIRS. *TT
Bulletin Number: 982112
SOME VEHICLES EXPERIENCE A HARD START/LONG CRANK TIME CONDITION. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982312
ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 982320
SOME VEHICLES WITH A VERY LOW ODOMETER READING MAY EXPERIENCE A LACK TEMPERATURE CONTROL. *YC
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98241
DIAGNOSTIC SERVICE TIPS ON PASSIVE ANTI THEFT SYSTEM ( PATS ). *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 98251
CONCERNS OF A POSSIBLE CHAFING OF THE FUEL PUMP ASSEMBLY WIRES RESULTING IN AN OPEN FUSE AND/OR INOPERABLE FUEL PUMP ASSEMBLY OR A NO START CONDITION. *YC
Bulletin Number: 982511
SERVICE TIPS ON COMPOSITE FUEL RAIL. *YC
Bulletin Number: 982513
EXHIBITING AN INOPERATIVE POWER WINDOW. *YC
Bulletin Number: 982514
CONCERNS WITH THE TIMING ARROWS/FLAGS ON THE BACK OF THE CAMSHAFT SPROCKET (S) ARE MIS-MARKED BY AS MUCH AS 30 DEGREES ROTATION. *YC
Bulletin Number: 982523
SOME ENGINE VALVES MAY EXHIBIT A CUSTOMER CONCERN OF A MOAN NOISE AT IDLE. *AK
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 982675
A REVISED FORWARD CLUTCH INNER SEAL FOR THE AXOD, AXODE, AX4S & AX4N TRANSAXLE IS AVAILABLE WITH IMPROVED SEALING AND REDUCED CHANCE OF THE SEAL ROLLING DURING INSTALLATION. *YC
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 983112
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT NEUTRAL CONDITION AFTER DRIVING AND COMING TO A STOP. *TT
Bulletin Number: 983113
SOME VEHICLES MAY EXHIBIT AN OVERHEAT CONDITON AND / OR A THERMOSTAT STUCK-CLOSED. *TT
Bulletin Number: 983221
EXHIBITING A VIBRATION AT SPPEDS OF 45 MPH AND ABOVE WITH THE CRUISE ON.
Bulletin Number: 983293
INFORMATION REGARDING INCORRECT PIN POINT TEST. *TT
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 983496
SOME VEHICLES MAY EXHIBIT B1522 OR GEM "HOOD SW" PID CONCERNS. *TT
Bulletin Number: 983566
INFORMATION ON PROGRAMMING / DIAGNOSING ANY PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT
Bulletin Number: 983566
INFORMATION REGARDING PROGRAMMING / DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT
Bulletin Number: 98411
SERVICE PROCEDURE FOR BLUE SERVICE TAGGED TRANSAXLES. *YC
Bulletin Number: 9844
SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 984647
SOME VEHICLES WILL BE DELIVERED WITH COVERS OVER THE FRONT BRAKE ROTORS. *YC
Bulletin Number: 98-4731
CLUNK OR PLOP COMING FROM FRONT END. *AK
Bulletin Number: 98-4737
ENGINE SPARK KNOCK ON ACCELERATION. *AK
Bulletin Number: 98-4741
FUEL GAUGE ACCURACY OR FUEL GAUGE ERRATIC OPERATION. *AK
Bulletin Number: 98-4803
SOME 1996-1998 TAURUS/SABLE VEHICLES WITH 3.0L 4-V ENGINE MAY EXHIBIT A CONCERN OF MOAN NOISE AT IDLE.
Bulletin Number: 985083
SOME VEHICLES (3.0L 4 VALVE ONLY) MAY EXHIBIT A CATALYTIC CONVERTER BUZZ OR RATTLE CONDITION ON A COLD START OR DURING A LOW RPM STEADY SPEED. *TT
Bulletin Number: 985084
A CONDITION MAY EXIST WHERE REDUCED DECELERATION FEEL AND LESS ENGINE RPM REDUCTION AT CLOSED THROTTLE WITH THE VEHCLE MOVING; SPEED CONTROL NOT RESPONDING QUICKLY WHEN SWITCHED TO OFF OR DECEL MAY ALSO BE NOTED. *TT
Bulletin Number: 9851
EXERPEINCING A MOANING NOISE HEARD FROM THE POWER STEERING DURING ENGINE IDLE. *TT
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 9853
COOLING SYSTEM CONCERNS SUCH AS: STUCK THERMOSTAT; VIBRATION OR THUMPING FROM ENGINE'; LEAKING RADIATOR OR HEATER CORE; COOLANT SMELL; ... ;LACK OF HEAT. *TT
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9865
TORQUE CONVERTER CLUTCH NOT ENGAGING AND/OR DIAGNOSTIC TROUBLE CODE (DTC) P0741 OR P1744 STORED IN MEMORY. *YC
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 9874
A NEW SILICONE GASKET AND SEALANT. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99126
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ON WITH SPARK KNOCK; ROLLING IDLE; AND / OR MISFIRE CODES STORED IN MEMORY. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99183
SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT
Bulletin Number: 99184
SOME VEHICLES EQUIPPED WITH AX4S TRANSAXLE, MAY EXHIBIT A HARSH 2-3 DOWNSHIFT MAY OCCUR WHEN COASTING AROUND A CORNER AND THEN ACCELERATING. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99195
SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 9941
EXPERIENCING A MOANING NOISE FROM THE POWER STEERING DURING ENGINE IDLE. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 996040
SUBJECT REGARDING ELECTRONIC CRASH SENSOR (ECS) MODULE LOCATION. *TT
Bulletin Number: 996123
CONCERNS WITH BUZZ OR VIBRATION WITH THE GEAR SELECTOR IN PARK. *TT
Bulletin Number: 99-6193
INFORMATION ON RESETTING THE PASSIVE ANTI-THEFT SYSTEM (PATS). *TT
Bulletin Number: 996735
SOME VEHICLES EQUIPPED WITH THE AX4S TRANSAXLE MAY EXHIBIT A HARSH 3-2 DOWNSHIFT WHEN COASTING AROUND A CORNER AND THEN STEPPING INTO THE THROTTLE TO ACCELERATE AWAY FROM THE CORNER. *TT
Bulletin Number: 996874
SUBJECT PERTAINING TO THE SBDS RELATIVE CAM TIMING TEST WHICH HAS BEEN TEMPORARILY REMOVED FROM USE ON SOME VEHICLES DUE TO NOISE CONCERNS. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: 9985
SERVICE TIP INFORMATION REGARDING THE REDESIGNED AX4N PUMP GASKET. *TT
Bulletin Number: 99B05
INFORMATION ON REPLACING GENERIC ELECTRONIC MODULE (GEM). *TT
1998 FORD TAURUS SHO
Bulletin Number: 00E11
SERVICE ACTION BULLETIN REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
Bulletin Number: 00E11
SERVICE ACTION 00E11, SUPPLEMENT #1 - UPDATE INFORMATION REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
Bulletin Number: 03144
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 12066
SOME VEHICLES WERE CALIBRATED WITH INCREASED AIR FLOW AT CLOSED THROTTLE TO PREVENT TIP-IN BUMPS, A RESULT MAY BE REDUCED DECELERATION FEEL AND LESS ENGINE RPM REDUCTION AT CLOSED THROTTLE WITH THE VEHICLE MOVING. *MJS
Bulletin Number: 12251
SOME VEHICLES MAY INTERMITTENTLY EXHIBIT A MOMENTARY HIGH IDLE IN PARK OR NEUTRAL. THIS CONCERN MAY BE AN INSUFFICIENT CONNECTION BETWEEN THE HARNESS WIRES AND TERMINALS IN THE THROTTLE POSITION CONNECTOR. *TT
Bulletin Number: 12257
SOME VEHICLES MAY INTERMITTENTLY EXHIBIT A MOMENTARY HIGH IDLE IN PARK OR NEUTRAL. THERE MAY BE AN INSUFFICIENT CONNECTION BETWEEN THE HARNESS WIRES AND TERMINALS IN THE THROTTLE POSITION CONNECTOR. *TT
Bulletin Number: 12570
SOME VEHICLES MAY EXHIBIT FRONT OUTER TIE RODS SQUEAK AND / OR POP NOISE OVER BUMPS AND / OR TURNING. *TT
Bulletin Number: 12784
INFORMATION ON REMOVING REAR TIE DOWN BRACKETS DURING PDI AS REQUIRED. *TT
Bulletin Number: 13381
SUBJECT REGARDING SERVICE TIP FOR SUN VISOR BRACKET BREAKAGE. *TT
Bulletin Number: 13802
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INSTRUMENT CONTROL PANEL (ICP) ILLUMINATION. *MJS
Bulletin Number: 5249
INFORMATION ON VEHICLES EXHIBITING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT
Bulletin Number: 5339
CONCERNS WITH A MOMENTARY HIGH IDLE IN PARK OR NEUTRAL. *TT
Bulletin Number: 5897
EXPERIENCING A SQUEAKING AND / OR POPPING NOISE FROM THE FRONT OUTER TIRE RODS. *TT
Bulletin Number: 6283
IMPORTANT INFORMATION ON REMOVING REAR TIE DOWN BRACKETS DURING PRE-DELIVERY. *TT
Bulletin Number: 99126
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ON WITH SPARK KNOCK; ROLLING IDLE; AND / OR MISFIRE CODES STORED IN MEMORY. *TT
Bulletin Number: 996040
SUBJECT REGARDING ELECTRONIC CRASH SENSOR (ECS) MODULE LOCATION. *TT
Bulletin Number: 996123
CONCERNS WITH BUZZ OR VIBRATION WITH THE GEAR SELECTOR IN PARK. *TT
1998 FORD THUNDERBIRD
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
1998 FORD WINDSOR
Bulletin Number: 982515
SOME VEHICLES MAY EXHIBIT A RATTLE NOISE FROM LH OR RH FRONT DOOR, GLASS-RUN RETAINER. *YC
1998 FORD WINDSTAR
Bulletin Number:
CLIMATE CONTROL IS INVESTIGATING CONCERNS OF BROKEN AND OR BINDING BLEND DOORS ON SOME VEHICLES. *TT
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 0071
SOME VEHICLES IN CERTAIN OF DELIVERY FLEET SERVICE THAT REQUIRES VERY FREQUENT PARKING BRAKE APPLICATION MAY EXHIBIT A PARKING BRAKE ASSEMBLY THAT RATTLES OR FEELS LOOSE AT THE FLOOR PAN MOUNTING. **MR
Bulletin Number: 0072
VEHICLES EXHIBITING A NOISY LIFTGATE OR SHEET METAL STREE CRACKS WHERE THE LIFT ASSEMBLY ATTACHES TO THE LIFTGATE. **MR
Bulletin Number: 00E11
SERVICE ACTION BULLETIN REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
Bulletin Number: 00E11
SERVICE ACTION 00E11, SUPPLEMENT #1 - UPDATE INFORMATION REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
Bulletin Number: 01124
ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 011701
INFORMATION REGARDING REPLACEMENT APPLICATION CHART. *ET
Bulletin Number: 01171
TRANSAXLE - AX4S - REPLACEMENT APPLICATION CHART - WINDSTAR VEHICLES ONLY. *NLM
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 012113
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 0156
SOME VEHICLES MAY EXHIBIT A POWER STEERING FLUID LEAK FROM THE END SEALS OF THE STEERING RACK AND PINION. *TT
Bulletin Number: 02132
GRUNT / POPPING NOISE COMING FROM THE FRONT SUSPENSION AT SPEEDS BELOW 20 MPH WHEN TURNING. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02152
SOME VEHICLES MAY EXHIBIT A POPPING / GRINDING NOISE FROM THE FRONT OF THE VEHICLE WHEN GOING OVER BUMPS OR MAKING TURNS. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH
Bulletin Number: 02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
Bulletin Number: 0245
INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT
Bulletin Number: 03123
TORQUE CONVERTER CLUTCH NOT ENGAGING WHEN COMMANDED AND/OR DIAGNOSTIC TROUBLE CODES P0741 OR P1744 STORED IN MEMORY. MODELS FROM 1996 TO 2003. *TT
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 03203
MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04L23
LITERATURE PROGRAM 04L23. CUSTOMER MAINTENANCE REMINDER - ALUMINUM WHEEL LUG NUT TORQUE. *TT
Bulletin Number: 090308
MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455
Bulletin Number: 11474
SOME MODEL YEAR VEHICLES MAY EXHIBIT A CUSTOMER CONCERN OF REAR END NOISE OVER BUMPS. *TT
Bulletin Number: 11505
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT
Bulletin Number: 11507
CUSTOMER CONCERN OF ERRATIC DOWNSHIFT. *TT
Bulletin Number: 12065
SOME VEHICLES BUILT MAY 1, 1998 TO JULY 3, 1998 MAY HAVE A LOOSE OVERHEAD CONSOLE. *MJS
Bulletin Number: 12076
SOME VEHICLES MAY EXHIBIT A CONDITION OF CHECK ENGINE LIGHT (MIL) ON AND CONTINUOUS DTC PO466 (EVAP SYSTEM MALFUNCTION). *MJS
Bulletin Number: 12099
VEHICLES WITH THE AX4S TRANSAXLE HAVE AN INLINE TRANSMISSION COOLER BYPASS VALVE LOCATED IN THE COOLER LINE NEAR THE RADIATOR COOLER. *MJS
Bulletin Number: 12114
SOME VEHICLES MAY EXHIBIT A FRONT END GRIND/CRUNCH NOISE DURING A SLOW SPEED TURN. *MJS
Bulletin Number: 12169
SOME VEHICLES MAY EXHIBIT A NGS ERROR MESSAGE AFTER NGS/SBTS PCM REPROGRAMMING. *MJS
Bulletin Number: 12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
Bulletin Number: 12178
INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. *MJS
Bulletin Number: 12227
FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12230
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12263
INFORMATION USED WHEN PERFORMING REAR WIPER PINPOINT TESTS. *TT
Bulletin Number: 12559
CONCERNS WITH REVERSE CLUTCH THAT COULD BECOME SHEARED OR TORN IN EXTREMELY COLD TEMPERATURES. *TT
Bulletin Number: 12606
EXPERIENCING RATTLE / CHUCK NOISE FROM LIFTGATE AREA DUE TO LUBRICANT THAT HAS BEEN APPLIED TO THE LIFTGATE WEDGES. *TT
Bulletin Number: 12616
INFORMATION ON TRANSAXLE SERVICE CASE REPLACEMENT WITH OSS (OUTPUT SHAFT SPEED SENSOR) HOLE. *TT
Bulletin Number: 12808
SOME VEHICLES MAY EXHIBIT ABS (ANTI-LOCK BRAKE SYSTEM) LOW SPEED FALSE ACTIVATION WITH NO DTC (DIAGNOSTIC TROUBLE CODE). *TT
Bulletin Number: 13024
SOME VEHICLES EQUIPPED WITH THE AX4S TRANSAXLE MAY EXHIBIT A HARSH 3-2 DOWNSHIFT WHEN COASTING AROUND A CORNER AND THEN STEPPING INTO THE THROTTLE TO ACCELERATE AWAY FROM THE CORNER. *TT
Bulletin Number: 13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
Bulletin Number: 13186
INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS
Bulletin Number: 13242
INFORMATION REGARDING TSB 97-20-08 FOR 3.8L ENGINES ONLY. *MJS
Bulletin Number: 13256
INFORMATION REGARDING STARBUSRT WHEEL CAPS LOOSE/RATTLE. *MJS
Bulletin Number: 13294
SOME VEHICLES MAY EXHIBIT A RATTLE NOISE FROM THE LIFTGATE AREA. *TT
Bulletin Number: 13309
SOME VEHICLES WITH 3.8L ENGINE MAY EXHIBIT BLACK SOOT ON THE LOWER SECTION OF THE RIGHT REAR QUARTER PANEL. *TT
Bulletin Number: 13396
SOME VEHICLES EQUIPPED WITH STARBURST TYPE WHEEL CAPS MAY EXHIBIT WHEEL CAPS THAT RATTLE OR APPEAR LOOSE. *TT
Bulletin Number: 13777
VEHICLES USED IN FLEETS THAT INCLUDES FREQUENT PARKING BRAKE APPLICATION MAY EXHIBIT A PARKING BRAKE ASSEMBLY THAT RATTLES OR FEELS LOOSE AT THE FLOOR PANEL MOUNTING. *MJS
Bulletin Number: 13787
SOME VEHICLES MAY EXHIBIT NOISY LIFTGATE OR SHEET METAL STRESS WHERE THE LIFT ASSEMBLY ATTACHED TO THE LIFTGATE. *MJS
Bulletin Number: 13812
SOME FLEET CUSTOMERS MAY WANT TO DISABLE THE CHILD LOCK FEATURE ON THE SLIDING DOORS AND PREVENT IT FROM BEING ACCIDENTLY RE-ACTIVATED. *TT
Bulletin Number: 13931
SOME VEHICLES MAY EXHIBIT THE METAL TABS ON THE LIFTGATE INNER PANEL THAT BOND TO THE OUTER SKIN SEPARATING AND CAUSING A RATTLE IN THE LIFTGATE. *TT
Bulletin Number: 14222
CONCERNS WITH SUBFRAME CLUNK ON ACCELERATION / DECELERATION FROM FRONT OF VEHICLE. *TT
Bulletin Number: 14656
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT
Bulletin Number: 14773
INFORMATION ON INDEXING ORANGE DOT ON TORQUE CONVERTER TO FLEXPLATE. *TT
Bulletin Number: 15370
SOME VEHICLES MAY EXHIBIT A GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK. *TT
Bulletin Number: 15373
SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES. *TT
Bulletin Number: 15392
SOME VEHICLES MAY EXHIBIT A PARK PULLOUT CLUNK NOISE WHEN SHIFTING FROM PARK TO ANOTHER GEAR POSITION. *TT
Bulletin Number: 15682
EXHIBITING INTERMITTENT ANTI-SKID BRAKE SYSTEM AND / OR RED BRAKE LAMP ON AT TIMES WHILE DRIVING. *TT
Bulletin Number: 15719
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT
Bulletin Number: 15767
SUBJECT REGARDING POWER STEERING LINE PART ORDERING INFORMATION. *TT
Bulletin Number: 16678
AX4S TRANSAXLE MAY EXHIBIT NO REVERSE ENGAGEMENT CONDITION. *TT *JB
Bulletin Number: 16987
SLIGHT AMOUNT OF FLUID RESIDUE ON THE OUTSIDE OF THE REAR WHEEL CYLINDER DUST BOOT ON VEHICLES WITH REAR DRUM BRAKES. *TT
Bulletin Number: 17358
GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE. *TT THIS BULLETIN UPDATES PREVIOUS BULLETIN 17358, DATED 11/01/2003 TO INCLUDE 2005 MODELS. *TT
Bulletin Number: 4618
BRIEF INFORMATION VEHICLES EXHIBITING PREMATURE LOW FUEL WARNING, SLOW FUEL FILL. *TT
Bulletin Number: 4619
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT
Bulletin Number: 4620
BRIEF INFORMATION ON VEHICLES EXHIBITING HARSH LIGHT THROTTLE 1-2 SHIFT. *TT
Bulletin Number: 4639
INFORMATION ON DIAGNOSTIC PROCEDURES FOR VEHICLES EXHIBITING CHECK ENGINE LAMP ON AND MISFIRE DIAGNOSTIC TROUBLE CODES P0300 - P0306. *TT
Bulletin Number: 5039
INFORMATION REGARDING A PCM REPROGRAMMING ERROR OCCURING ON VEHICLES IF AN INCORRECT CALIBRATION QUALIFIER IS SELECTED. *TT
Bulletin Number: 5039
A PCM REPROGRAMMING ERROR WILL OCCUR ON VEHICLES IF AN INCORRECT CALIBRATION QUALIFIER IS SELECTED. *TT
Bulletin Number: 5131
SUBJECT REGARDING VEHICLES WITH THE AX4S TRANSAXLE HAVING AN INLINE TRANSMISSION COOLER BYPASS VALVE LOCATED IN THE COOLER LINE NEAR THE RADIATOR COOLER. *TT
Bulletin Number: 5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
Bulletin Number: 5205
SOME VEHICLES MAY EXHIBIT A NGS ERROR MESSAGE, TOTAL CHECKSUM ERROR AFTER NGS / SBTS PCM REPROGRAMMING. *TT
Bulletin Number: 5266
SUBJECT REGARDING HARSH LIGHT THROTTLE 1-2 UPSHIFT CONDITION. *TT
Bulletin Number: 5271
SUBJECT REGARDING ENGINE STALL ON DECELERATION OR DURING SLOW SPEED MANEUVERING. *TT
Bulletin Number: 5346
MANUAL CORRECTION WHEN PERFORMING REAR WIPER MOTOR PINPOINT TEST. *TT
Bulletin Number: 5518
INFORMATION ON SERVICING OIL PAN GASKET LEAKS. *TT
Bulletin Number: 6386
INFORMATION REGARDING THE AVAILABILITY OF ENGINE ASSEMBLY FOR VARIOUS VEHICLES. *TT
Bulletin Number: 6392
SOME VEHICLES MAY EXHIBIT ABS (ANTI-LOCK BRAKE SYSTEM) LOW SPEED FALSE ACTIVATION WITH NO (DTC) DIAGNOSTIC TROUBLE CODE. *TT
Bulletin Number: 6573
INFORMATION ON VARIOUS ENGINES AVAILABLE FOR THE FORD QUALTY RENEWAL (FQR) ENGINE ASSEMBLY. *TT
Bulletin Number: 6996
INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT
Bulletin Number: 6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
Bulletin Number: 7047
INFORMATION REGARDING THE TORQUE CONVERTER CLUTCH SOLENOID. *MJS
Bulletin Number: 7120
SOME VEHICLES MAY EXHIBIT BLACK SOOT EMITTED FROM THE TAILPIPE LEAVING DEPOSITS ON RIGHT REARL LOWER QUARTER PANEL. *TT
Bulletin Number: 7134
SOME VEHICLES BUILT FROM 5/20/98 TO 12/31/98 EQUIPPED WITH STARBURST TYPE WHEEL COVERS MAY EXHIBIT A LOOSE WHEEL CAP OR RATTLE NOISE FROM THE WHEEL CAPS. *TT
Bulletin Number: 7211
EXHIBITING A RATTLE NOISE FROM THE LIFTGATE AREA. *TT
Bulletin Number: 7292
NNERS OF THE EDSR-OF-THE-MONTH QUALITY AWARD ANNOUNCEMENT FOR SEPTEMBER. *TT
Bulletin Number: 7309
SUBJECT REGARDING STARBURST TYPE WHEEL CAPS THAT RATTLE OR APPEAR LOOSE. *TT
Bulletin Number: 7965
PARKING BRAKE ASSEMBLY THAT RATTLES OR FEELS LOOSE AT THE FLOOR PANEL MOUNTING.
Bulletin Number: 7971
NOISY LIFTGATE OR SHEET METAL STRESS WHERE THE LIFT ASSEMBLY ATTACHES TO THE LIFTGATE.
Bulletin Number: 8036
SOME FLEET CUSTOMERS MAY WANT TO DISABLE THE CHILD LOCK FEATURE ON THE SLIDING DOORS AND PREVENT IT FROM BEING ACCIDENTLY RE-ACTIVATED. *TT
Bulletin Number: 8249
SOME VEHICLES MAY EXHIBIT THE METAL TABS ON THE LIFTGATE INNER PANEL THAT BOND TO THE OUTER SKIN SEPARATING AND CAUSING A RATTLE IN THE LIFTGATE. *TT
Bulletin Number: 870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
Bulletin Number: 971110972310
EXPERIENCING A COOLANT LEAK FROM THE UPPER RADIATOR HOSE. *YC
Bulletin Number: 97111097237
CONCERNS WITH HARSH ENGAGEMENTS AND HARSH SHIFTS WITH DIAGNOSTIC TROUBLE CODES (DTCS) 628, P0741 AND/OR P1744. *YC
Bulletin Number: 97120897251
THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY SLIP MOMENTARILY IN WET CONDITIONS CAUSING A REDUCTION IN POWER STEERING ASSIST OR THE GENERATOR LAMP. *YC
Bulletin Number: 9751
INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD
Bulletin Number: 97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
Bulletin Number: 976011
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 98021698316
PROVIDED INFORMATION TO CLARIFY CALIBRATIONS VS. PCM VS. CATALYST ASSEMBLIES. *YC
Bulletin Number: 980304
INTERMITTENT NO FORWARD ENGAGEMENT WITH OR WITHOUT DTC P1784 ACTION. *AK
Bulletin Number: 980306
SOME VEHICLES EXPERIENCE A PREMATURE LOW FUEL WARNING, SLOW FUEL FILL. *YC
Bulletin Number: 980311
CHECK ENGINE LAMP ON AND MISFIRE DTC (S) P0300-P0306. *YC
Bulletin Number: 98-0316
CONCERNS WITH SLOW FUEL FILL, DISTORTED FUEL TANK, FUEL GAGE ERRATIC, FUEL ODOR. *TT
Bulletin Number: 980322
EXPERIENCING HARSH LIGHT THROTTLE 1-2 SHIFT. *YC
Bulletin Number: 980351
EXHIBITING A STALLING CONDITION DURING DECELERATIONG TO A STOP AND LOW SPEED PARKING LOT MANEUVERS. *TT
Bulletin Number: 9811257
SOME VEHICLES EQUIPPED WITH 3RD ROW MAP LIGHTS MAY EXHIBIT LOOSE FITTING LIGHTS. *TT
Bulletin Number: 9811302
A CONCERN HAS BEEN FOUND ON THE TRANSAXLE ID TAG MAY EXHIBIT A HARSH 1-2 SHIFT ON LIGHT THROTTLE ONLY. *YC
Bulletin Number: 9811349
VEHICLES WITH POWER DOOR LOCKS MAY EXHIBIT AN INTERMITTENT OPERATION OR GRIND WHEN CYCLED. *TT
Bulletin Number: 9811451
VEHICLES MAY EXHIBIT A HIGH PICH WHISTLE FROM THE HEATER CORE HOUSING CASE. *YC
Bulletin Number: 9811472
SOME VEHICLES MAY EXHIBIT A CUSTOMER CONCERN OF VIBRATION ABOVE 45 MPH. *TT
Bulletin Number: 9811484
SOME HIGH MILEAGE VEHICLE MAY EXHIBIT A CUSTOMER CONCERN OF INOPERATIVE OVERDRIVE CANCEL LIGHT. *TT
Bulletin Number: 98125
VEHICLE MAY EXHIBIT A "WHISTLING" NOISE HEARD FROM THE A/C PLENUM. *TT
Bulletin Number: 98127
EXPERIENCING ACCELERATOR PEDAL "BUZZING" NOISE AND / OR EXHAUST "DRONING" NOISE AT APPROXIMATELY 1700 RPM WHLE DRIVING. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK
Bulletin Number: 981519
TRACTION CONTROL LAMP FLASING INTERMITTENTLY WITH DIAGNOSTIC TROUBLE CODES U1009 AND/OR U1027. *AK
Bulletin Number: 98153
THIS TSB IS BEING REPUBLISHED IN ITS ENTIRETY TO REVISE THE POWER TRAIN CONTROL MODULE (PCM) CALIBRATION CROSS REFERENCE AND REVISE PCM SERVICE PART NUMBERS. *AK
Bulletin Number: 981617
FLOOR MAT INSTALLATION PROCEDURE SERVICE TIP. YD
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 9818
FUEL PUMP REPLACEMENT PROCEDURE - SERVICE TIP. *TT
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 982011
CONCERNS OF WEBBING TWISTS OR BINDS ON INTEGRATED CHILD SAFETY SEAT (ICS) BELT. *YC
Bulletin Number: 98203
CONCERNS WITH ADHENSIVES NOT RECOMMENDED FOR BODY PANEL REPAIRS. *YC
Bulletin Number: 98203
CONCERNS WITH THE POTENTIAL EFFECTS OF ADHESIVES USED FOR BODY PANEL REPAIRS. *TT
Bulletin Number: 98221
INTERMITTENT NEUTRAL CONDITION AFTER DRIVING AND COMING TO A STOP. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98235
SOME VEHICLES EXPERIENCE OVERHEAD CONSOLE LOOSE OR HANGS DOWN. *YC
Bulletin Number: 982451
SOME CUSTOMERS HAVE CONCERNS OF ERRATIC DOWNSHIFT. *AK
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982465
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEEZING TEMPERATURES. *YC
Bulletin Number: 982511
SERVICE TIPS ON COMPOSITE FUEL RAIL. *YC
Bulletin Number: 982512
SOME VEHICLES MAY EXHIBIT A CUSTOMER CONCERN OF INOPERATIVE OVERDRIVE CANCEL LIGHT. *YC
Bulletin Number: 982533
SOME VEHICLES MAY EXHIBIT A CUSTOMER CONCERN OF VIBRATION ABOVE 45 MPH. *AK
Bulletin Number: 982535
EXHIBITING A CUSTOMER CONCERN OF REAR END NOISE OVER BUMPS. *YC
Bulletin Number: 98256
SOME VEHICLES MAY STALL DURING DECELERATION WHEN COMING TO A STOP. *YC
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 982675
A REVISED FORWARD CLUTCH INNER SEAL FOR THE AXOD, AXODE, AX4S & AX4N TRANSAXLE IS AVAILABLE WITH IMPROVED SEALING AND REDUCED CHANCE OF THE SEAL ROLLING DURING INSTALLATION. *YC
Bulletin Number: 982677
SOME VEHICLES MAY EXHIBIT A HIGH PITCH WHISTLE FROM THE HEATER CORE HOUSING CASE. *YC
Bulletin Number: 983090
INFORMATION REGARDING VEHICLES EXHIBITING A STALL ON DECEL CONDITION. *TT
Bulletin Number: 983094
SOME VEHICLES WITH POWER DOOR LOCKS MAY EXHIBIT AN INTERMITTENT OPERATION OR GRIND WHEN CYCLED. *TT
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 983101
SOME VEHICLES MAY EXHIBIT A NOISE WHILE TURNING OR BRAKING. *TT
Bulletin Number: 983141
SOME VEHICLES MAY EXHIBIT A HARST 1 - 2 SHIFT ON LIGHT THROTTLE ONLY. *TT
Bulletin Number: 983171
CONDITIONS WITH THE FUEL GAU-GE NOT READING FULL OR THE GAUGE MAY PREMATURELY DROP TO THE 3/4 MARK. *TT
Bulletin Number: 983292
SOME VEHICLES EQUIPPED WITH 3RD ROW MAP LIGHTS MAY EXHIBIT LOOSE FITTING LIGHTS. *TT
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 983303
CONCERNS OF BROKEN AND OR BINDING BLEND DOOR. *TT
Bulletin Number: 983314
TSB97-16-10 (MIL ILLUMONATED-DIAGNASTIC TROUBLE CODES (DTCS) PO300 THROUGH PO306 COMPREHENSIVE DIAGNOSTIC PROCEDURES-3.8L ENGINE) DOES NOT APPLY TO 19881/2 MODEL YEAR WINDSTAR VEHICLES.*AK
Bulletin Number: 983580
VEHICLES MAY EXHIBIT A HARSH 1-2 SHIFT ON LIGHT THROTTLE ONLY. *TT
Bulletin Number: 983581
SOME VEHICLES MAY EXHIBIT CONDITIONS OF EXHAUST DRONE AT 1700 RPM. *TT
Bulletin Number: 98411
SERVICE PROCEDURE FOR BLUE SERVICE TAGGED TRANSAXLES. *YC
Bulletin Number: 98416
EXPERIENCING A GRINDING NOISE OR INOPERATIVE DOOR LOCK MAY OCCUR WHEN CYCLING THE POWER FRONT DOOR LOCKS ON SOME VEHICLES. *TT
Bulletin Number: 9844
SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 98-4721
PREMATURE LOW FUEL WARNING, SLOW FUEL FILL ACTION. *AK
Bulletin Number: 98-4723
ENGINE CHECK LAMP ON, AND MISFIRE DTC (S) PO300-PO306 ACTION.
Bulletin Number: 98-4743
FUEL TANK PROBLEMS. *AK
Bulletin Number: 984989
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ON CONDITION WITH DIAGNOSTIC TROUBLE CODE P1450 DUE TO AN OBSTRUCTION IN THE CANISTER VENT HOSE. *TT
Bulletin Number: 984993
SOME VEHICLES, WITH BUILD DATES ON / AFTER 9/8/97, MAY EXHIBIT A HARSH OR JERKY 3-2 TRANSMISSION DOWNSHIFT UNDER CERTAIN LOW SPEED OPERATING CONDITIONS. *TT
Bulletin Number: 985018
EXPERIENCNG A WHINE NOISE COMING FROM THE FRONT END ACCESSORY DRIVE (FEAD). *TT
Bulletin Number: 985020
SOME VEHICLES BUILT THROUGH 9/8/97 MAY EXHIBIT A CONDITION OF MULTIPLE DIAGOSTIC TROUBLE CODES. THIS MAY BE CAUSED BY BRAKE FLUID AND WATER CONTAMINATION OF CIRCUIT 361 AND CONNECTOR C102 UNDER THE MASTER CYLINDER. *AK
Bulletin Number: 985026
SOME VEHICLES BUILT MAY 1, 1998 TO JULY 3, 1998 MAY HAVE A LOOSE OVERHEAD CONSOLE. *TT
Bulletin Number: 985056
REPEAT MESSAGE REGARDING PREMATURE LOW FUEL WARNING, SLOW FUEL FILL. *TT
Bulletin Number: 985086
SOME VEHICLES MAY EXHIBIT A CUSTOMER CONCERN DESCRIBED AS AN AIR CONDITIONER HISS NOISE. *TT
Bulletin Number: 985095
SOME VEHICLES MAY EXHIBIT A CONDITION OF CHECK ENGINE LIGHT ON AND CONTINUOUS DIAGNOSTIC TROUBLE CODE P0446 (EVAP SYSTEM MALFUNCTION). *TT
Bulletin Number: 985137
SOME VEHICLES MAY EXHIBIT A FRONT END GRIND / CRUNCH NOISE DURING A SLOW SPEED TURN. *TT
Bulletin Number: 98515
SOME VEHICLES MAY EXHIBIT A SQUEAKING, RATTLING, CHIRPING, TICKING AND / OR BUZZING NOISE HEARD FROM THE INSTRUMENT PANEL AREA. *YC
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 9854
SOME VEHICLES MAY EXHIBIT A LOUND SQUEAKING AND / OR CREAKING HEARD FROM THE DRIVER'S SEAT DURING DRIVER MOVEMENT. *TT
Bulletin Number: 9855
WET CARPET AND/OR HEADLINER IN CARGO AREA. *YC
Bulletin Number: 9857
SOME VEHICLES MAY STALL DURING DECELERATION WHEN COMING TO A STOP, DURING SLOW SPEED PARKING MANEUVERS AND/OR COASTING THROUGH SLOW SWEEPING TURNS. *YC
Bulletin Number: 985A28
SOME VEHICLES EXPERIENCE THE PARKING BRAKE MAY NOT RELEASE. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 9876
DAMAGED OR WORN CLOTH OR VINYL DOOR TRIM PANEL INSERTS CAN NOW BE REPLACED WITHOUT REPLACING THE DOOR PANEL. *YC
Bulletin Number: 9879
A VIBRATION MAY BE FELT WHEN THE VEHICLE IS DRIVEN AT HIGHWAY SPEEDS. *YC
Bulletin Number: 98811
A LOOSE FAN CONTROL SWITCH ON THE AUXILIARY CLIMATE CONTROL UNIT MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 9898A
EXHIBITING DRIVEABILITY CONDITION: HARSH 1-2 UP-SHIFT ON VERY LIGHT THROTTLE ONLY. *YC
Bulletin Number: 98B24
SUBJECT ON SECOND - ROW SEAT STANDARD EQUIPMENT WINDOW STICKER DISCREPANCY. *YC
Bulletin Number: 98E03
EMISSION RECALL ON REPROGRAMMING POWERTRAIN CONTROL MODULE CALIBRATION CODES. *TT
Bulletin Number: 98E03
REPROGRAMMING POWERTRAIN CONTROL MODULE CALIBRATION CODES ON SOME VEHICLES. *YC
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 9913073
CLIMATE CONTROL IS INVESTIGATING CONCERNS OF BROKEN AND / OR BINDING BLEND DOORS. *TT
Bulletin Number: 99131
CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99154
CONCERNS WITH THE LOW FUEL LAMP ILLUMINATING TOO EARLY OCCURRING WITH A 19-26 L (5-7 GALLON) FUEL RESERVE ON VEHICLES EQUIPPED WITH A 95 L (25 GALLON) FUEL TANIK. *TT
Bulletin Number: 99183
SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT
Bulletin Number: 99184
SOME VEHICLES EQUIPPED WITH AX4S TRANSAXLE, MAY EXHIBIT A HARSH 2-3 DOWNSHIFT MAY OCCUR WHEN COASTING AROUND A CORNER AND THEN ACCELERATING. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99195
SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99207
SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 996735
SOME VEHICLES EQUIPPED WITH THE AX4S TRANSAXLE MAY EXHIBIT A HARSH 3-2 DOWNSHIFT WHEN COASTING AROUND A CORNER AND THEN STEPPING INTO THE THROTTLE TO ACCELERATE AWAY FROM THE CORNER. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: BC0717961021
INFORMATION FOR WHEN REPLACING AN INTERIOR TRIM COMPONENT UNDER WARRANTY. *TT
Bulletin Number: BC1022097230
ADAPTERS ARE AVAILABLE TO CONVERT WINDSTAR "J HOOK" WINDSHIELD WIPER ARMS TO A CONVENTIONAL PIN STYLE TO ALLOW THE USE AFTER MARKET BOOTED WINTER BLADES. *JD
Bulletin Number: BC1022697230
THE REMOTE ANTI-THEFT PERSONALITY MODULE HAVE TWO OPTION LEVELS. *JD
Bulletin Number: BC1031597020
POWER STEERING LINE LEAKS ON 95/96 3.8L TRAILER TOW EQUIPPED TUBE AND FIN COOLER SYSTEMS SEE OASIS MESSAGE 4685. *JD
Bulletin Number: BC105909705
INSTRUCTIONS ON HOW TO IDENTIFY FUEL TANK SIZES. *TW
Bulletin Number: BC106059705
VEHICLES EQUIPPED WITH TRACTION CONTROL MAY EXPERIENCE A FLASHING TRAC OFF LIGHT AT INTERMITTENT TIMEW WHILE DRIVING. *TW
Bulletin Number: BC2230970501
VEHICLES EQUIPPED WITH TRACTION CONTROL EXPERIENCING A FLASHING TRAC OFF LIGHT AT INTERMITTENT TIMES WHILE DRIVING. *TW
Bulletin Number: BC2295970501
INSTRUCTIONS ON HOW TO IDENTIFY 20 GALLON OR 25 GALLON FUEL TANKS - 1996 SERVICE MANUAL INCORRECTLY LISTS FUEL TANK AT 16 GALLONS. *TW
Bulletin Number: BC2380970501
HARSH 1-2 UPSHIFT. *TW
Bulletin Number: BC3150970219
POWER STEERING LEAK AT THE CONSTANT TENSION CLAMPS. *TW
Bulletin Number: BC3274970207
REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS A
Bulletin Number: BC3362972301
REMOTE ANTI-THEFT PERSONALITY MODULE HAVE TWO OPTION LEVELS. *JD
Bulletin Number: BC3370972301
THE ILLUMINATION OF MALFUNCTION INDICATOR LIGHT, ON AND DIAGNOSTIC TROUBLE CODES P1131, P1151, P1132, P1152. *JD
Bulletin Number: BC3381972301
ADAPTERS ARE AVAILABLE TO CONVERT VEHICLE "J HOOK" WINDSHIELD WIPER ARMS TO A CONVENTIONAL PIN STYLE. *JD
Bulletin Number: BPI9904
CONDITIONS WITH THE TRAC OFF LAMP ILLUMINATING INTERMITTENTLY AND THER MAY ALSO BE STORED TROUBLE CODES U1009 AND / OR U1027.
Bulletin Number: CSP-15-N-02
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
Bulletin Number: TSB-14-0146
FORD: ON SOME MINIVANS, REAR AXLE WILL FRACTURE, IN HIGH CORROSION AREA, AFTER OPERATING FOR AN EXTENDED TIME PERIOD, AND VEHICLE HANDLING ABILITY WILL BE AFFECTED. MODEL 1998-2003 WINDSTAR. *PE
Bulletin Number: TSB-14-0167
FORD: SAFETY RECALL CONCERNING REAR AXLE FRACTURING IF VEHICLE IS OPERATED IN HIGH CORROSION AREAS FOR AND EXTENDED PERIOD. MODEL 1998-03 WINDSTAR. *PE
1998 FORD ZX2 (ESCORT)
Bulletin Number: 0037
VEHICLE MAY EXPERIENCE THE MALFUNCTION INCIATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES (DTCS). *MJS
Bulletin Number: 0051
VEHICLES MAY EXHIBIT ENGINE HESITATION OR SURGE WHEN THE A/C COMPRESSOR CYCLES MAY OCCUR. *MJS
Bulletin Number: 0059
SUBJECT CONCERNING THE IDLE-VIBRATION- 2.0L AND ZETEC ENGINES- SERVICE TIP. *MJS
Bulletin Number: 0069
SOME VEHICLES MAY EXHIBIT A GRINDING NOISE WHILE BRAKING, BRAKE DRAG AND/OR UNEVEN FRONT BRAKE PAD WEAR MAY OCCUR. *MJS
Bulletin Number: 031514
THE MALFUNCTION INDICATOR LAMP (MIL) MAY BE ILLUMINATED AND DIAGNOSTIC TROUBLE CODES (DTCS) P1380, P1381, P1383, AND/OR P0340 MAY BE STORED IN MEMORY. *TT
Bulletin Number: 031515
IDLE VIBRATION ON VEHICLES EQUIPPED WITH 2.0L SPI OR ZETEC ENGINE ONLY. *TT
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 11478
THIS BULLETIN MENTIONS THAT TSB-98-04-02 (WHISTLING / WIND NOISE HEARD AROUND BOTH OUTSIDE REAR VIEW MIRRORS) APPLIES ONLY TO CERTAIN MODEL VEHICLES. *TT
Bulletin Number: 11525
INFORMATION ON THE DIFFERENT TYPES OF REMOTE KEYLESS ENTRY SYSTEMS. *TT
Bulletin Number: 11527
SOME VEHICLES MAY EXHIBIT DAMAGE TO THE DOOR TRIM PANELS. *TT
Bulletin Number: 11771
SOME MANUAL TRANSMISSION VEHICLES MAY EXHIBIT A CONCERN OF HESITATION / SURGE DUE TO A/C CYCLING AT STEADY SPEED. *TT
Bulletin Number: 12076
SOME VEHICLES MAY EXHIBIT A CONDITION OF CHECK ENGINE LIGHT (MIL) ON AND CONTINUOUS DTC PO466 (EVAP SYSTEM MALFUNCTION). *MJS
Bulletin Number: 12215
SOME VEHICLES MAY EXHIBIT AN ENGINE IDLE VIBRATION CONCERN WHILE IN GEAR AND LOADED (A/C ON, HEADLIGHTS ON, AND / OR REAR DEFROSTER ON). *TT
Bulletin Number: 12236
SOME VEHICLES BUILT BETWEEN 02/98 AND 07/98 MAY EXHIBIT A STRONG WINDHSIELD BUZZING SOUND WHEN THE VEHICLES IS RUNNING AT SPEEDS ABOVE 50 MPH AND THE AMBIENT TEMPERATURE IS ABOVE 100 DEGREES FAHRENHEIT. *TT
Bulletin Number: 12241
SOME VEHICLES MAY EXHIBIT A CLICK SOUND WHEN APPLY THE BRAKES WHILE CHANING DIRECTIONS. ENGINEERING IS INVESTIGATING THIS CONCERN. *TT
Bulletin Number: 12294
SUBJECT REGARDING THE NGS FUEL ECONOMY TEST. *TT
Bulletin Number: 12295
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON, STALL AT TIP-IN FROM IDLE, ENGINE HESITATION, AND / OR SURGE CAUSED BY THE MASS AIR FLOW (MAF) SENSOR. *TT
Bulletin Number: 12535
VEHICLES EQUIPPED WITH THE 2.0L ZETEC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON AND POSSIBLE DIAGNOSTIC TROUBLE CODES (DTC) P0180, P0181, P0182 AND / OR P0183 AFTER REPLACING THE 9D930 ENGINE WIRING HARNESS AND / OR THE 12A581 ELECTRONIC E
Bulletin Number: 12547
COMPLAINTS THAT FUEL FILL NOZZLE CLICKS OFF OR DIFFICULTY ADDING FUEL. *TT
Bulletin Number: 12594
SOME VEHICLES MAY EXHIBIT TRANSMISSION AND / OR MALFUNCTION INDICATOR LAMP ON CONCERNS RELATING TO THE DIAGNOSIS AND REPLACEMENT OF THE TRANSMISSION RANGE SENSOR (TR). *TT
Bulletin Number: 12701
THIS BULLETIN ADDRESSES CONCERNS WITH THE TRANSMISSION RANGE SENSOR. *TT
Bulletin Number: 12834
BRIEF INFORMATION REGARDING TRANSMISSION FLUID. *TT
Bulletin Number: 13160
VEHICLES MAY EXHIBIT TRANSMISSION AND / OR MALFUNCTION INDICATOR LAMP ON CONCERNS RELATING TO THE DIAGNOSIS AND REPLACEMENT OF THE TRANSMISSION RANGER SENSOR (TRS). *TT
Bulletin Number: 13162
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LIGHT ON WITH A DIAGNOSTIC TROUBLE CODE P1744. *TT
Bulletin Number: 13249
SOME VEHICLES MAY EXHIBIT A CONDITION OF THE MALFUNCTION INDICATOR LAMP LIGHT ON AND DIAGNOSTIC TROUBLE CODE P0455 IN MEMORY. *TT
Bulletin Number: 13386
INFORMATION ON INVESTIGATING HARD START / NO START CONDITIONS ACCOMPANIED BY OVERFUELING IN AMBIENTS BELOW 32F/0C, ON VEHICLES WITH VCT EQUIPPED 2.0L ZETEC ENGINES. *TT
Bulletin Number: 13468
SOME VEHICLES EQUIPPED WITH 2.0L ENGINE MAY EXHIBIT A TIMING BELT SHREDDING OR TIMING BELT STRIKING THE FRONT COVER. *TT
Bulletin Number: 14379
VEHICLES MAY EXPERIENCE INOPERATIVE OR INCORRECT A/C OPERATION AFTER REPLACING THE CCRM. *JB
Bulletin Number: 15256
SOME VEHICLES WITH AUTOMATIC TRANSAXLES MAY EXHIBIT A CLUNK NOISE ON INITIAL REVERSE ENGAGEMENT COLD. *TT
Bulletin Number: 4619
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT
Bulletin Number: 4653
SOME MANUAL TRANSMISSION VEHICLES MAY EXHIBIT A CONCERN OF HESITATION / SURGE. *TT
Bulletin Number: 5294
INFORMATION CONCERNING VEHICLES EXPERIENCING AN ENGINE IDLE VIBRATION WHILE IN GEAR AND LOADED (A/C ON, HEADLIGHTS ON, AND / OR REAR DEFROSTER ON). *TT
Bulletin Number: 5298
INFORMATION ON VEHICLES EXHIBITING A STRONG BUZZING SOUND WHEN THE VEHICLE IS RUNNING AT SPEEDS ABOVE 50 MPH AND THE AMBIENT TEMPERATURE IS ABOVE 100 DEGREES FAHRENHEIT. *TT
Bulletin Number: 5309
INFORMATION REGARDING VEHICLES EXHIBITING A CLICK SOUND WHEN APPLYING THE BRAKES WHILE CHANGING DIRECTION. *TT
Bulletin Number: 5381
BRIEF INFORMATION STATING THAT THE NGS FUEL ECONOMY TEST ON SOME VEHICLES MAY NOT FUNCTION PROPERLY. *TT
Bulletin Number: 5855
VEHICLES MAY EXHIBIT A CHECK ENGINE LIGHT ON AND DTC P0180, P0181, P0182 AND / OR P0183 AFTER REPLACING THE 9D930 ENGINE WIRING HARNESS AND / OR THE 12A581 ELECTRONIC ENGINE CONTROL (EEC) WIRING HARNESS. *TT
Bulletin Number: 6416
BRIEF INFORMATION REGARDING TRANSMISSION FLUID APPEARANCE. *TT
Bulletin Number: 6932
SOME VEHICLES MAY EXHIBIT TRANSMISSION AND / OR MIL ON CONCERNS RELATING TO THE DIAGNOSIS AND REPLACEMENT OF THE TRANSMISSION RANGE SENSOR. *TT
Bulletin Number: 6934
CONCERNS WITH A MALFUNCTION INDICATOR LIGHT ON WITH A DIAGNOSTIC TROUBLE CODE P1744. *TT
Bulletin Number: 7131
SOME VEHICLES MAY EXHIBIT A CONDITION OF THE MALFUNCTION INDICATOR LIGHT ON AND DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSION) IN MEMORY. *TT
Bulletin Number: 7451
SOME VEHICLES EQUIPPED WITH 2.0L ENGINE MAY EXHIBIT A TIMING BELT SHREDDING OR TIMING BELT STRIKING THE FRONT COVER. *TT
Bulletin Number: 97L14
SPECIAL FIELD ACTION 97L14- WARRANTY GUIDES FOR VEHICLES EQUIPPED WITH 2. OL ZETEC ENGINES. *YC
Bulletin Number: 9811477
CUSTOMER CONCERN OF POOR ACCELERATION. *TT
Bulletin Number: 9819
SOME VEHICLES MAY EXHIBIT INTERMITTENT OPERATION OR INOPERATIVE INTERIOR DOME LAMP. *TT
Bulletin Number: 982017
EXPERIENCING " SQUEAKING " AND / OR " RATTLING " NOISES MAY OCCUR DURING DIFFERENT DRIVING CHARACTERISTICS AND FROM VARYING POINTS ON THE VEHICLE. *YC
Bulletin Number: 98204
A PORTION OF FOAM TAPE AT THE WINDSHIELD AND INSTRUMENT PANEL (I/P) MAY BE STICKING OUT ON SOME VEHICLES. *YC
Bulletin Number: 98206
A HESITATION OR SURGE WHEN THE A/C COMPRESSOR CYCLES MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 982538
SOME VEHICLES MAY EXHIBIT A CUSTOMER CONCERN OF POOR ACCELERATION. *YC
Bulletin Number: 985095
SOME VEHICLES MAY EXHIBIT A CONDITION OF CHECK ENGINE LIGHT ON AND CONTINUOUS DIAGNOSTIC TROUBLE CODE P0446 (EVAP SYSTEM MALFUNCTION). *TT
Bulletin Number: 9861
DIFFICULTIES REMOVING KEY FROM IGNITION ON SOME VEHICLES. *YC
Bulletin Number: 9886
AN ENGINE COOLANT LOSS MAY OCCUR FROM THE ENGINE BLOCK HEATER AREA. *YC
Bulletin Number: 99105
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1381 AND / OR P1383 STORED IN MEMORY. THE VEHICLE MAY ALSO HAVE A ROUGH IDLE OR REDUCED POWER CONDITION, AND / OR MAY STALL AT AN IDLE. *TT
Bulletin Number: 99123
SOME VEHICLES MAY EXHIBIT A STALL AFTER A COLD ENGINE START WHEN THE TRAMISSION IS INITIALLY SHIFTED INTO GEAR. *TT
Bulletin Number: 9912701
ENGINEERING IS INVESTIGATING CONCERNS WITH VEHICLES EXHIBITING DIAGNOSTIC TROUBLE CODES PO705, PO708 OR P1705 (TRANSMISSION RANGE SENSOR).
Bulletin Number: 99138
A ROUGH IDLE, STALLING AT AN IDLE, REDUCED POWER AND / OR MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTCS) P1381 AND P1383 MAY BE STORED IM MEMORY ON SOME VEHICLES. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 996105
EXPERIENCING WINDNOISE FROM THE DOOR GLASS BELTLINE WEATHERSTRIP AREA. *TT
Bulletin Number: 99810
EXHIBITING A CLICKING NOISE HEARD WHILE APPLYING THE BRAKES AFTER CHANGING VEHICLE DIRECTION ON SOME VEHICLES. *TT

 

Recalls for 1998 Ford

1998 FORD A9513
NHTSA Campaign ID:WHEELS:RIM
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:10/21/1997 - 12/18/1997
Potential Units Affected:11

Defect Description:

VEHICLE DESCRIPTION: TRAILERS EQUIPPED WITH AFTERMARKET ALUMINUM DUAL WHEELS, 22.5X8.25, ONE-PIECE, TUBELESS, SUPPLIED BY ACCURIDE/AKW. CERTAIN DESIGN REVISIONS COMBINED WITH PROCESS CONDITIONS CAUSED FATIGUE CRACKS IN THESE WHEELS.

Consequence:

THIS CONDITION CAN CAUSE FAILURE OF THESE WHEELS.

Action:

ACCURIDE/AKW WILL REPLACE THESE WHEELS.
1998 FORD AEROMAX
NHTSA Campaign ID:SERVICE BRAKES, AIR
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:04/29/1996 - 12/21/1997
Potential Units Affected:1687

Defect Description:

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH OPTIONAL WABCO AIR DRYER. THE AIR BRAKE SYSTEM WAS PLUMBED SO THAT THE SYSTEMS DID NOT PROVIDE AIR RESERVOIR ISOLATION. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS."

Consequence:

THE AIR BRAKE RESERVOIR PRESSURE COULD BE DEPLETED, ACTIVATING THE EMERGENCY SPRING BRAKE. WITH THE EMERGENCY SPRING BRAKE DEPLOYED, THE VEHICLE WOULD STOP AND COULD NOT BE MOVED UNTIL THE BRAKE AIR SYSTEM WAS REPAIRED.

Action:

DEALERS WILL REPAIR THE AIR LINE PLUMBING TO INSTALL A CHECK VALVE.
1998 FORD AEROMAX
NHTSA Campaign ID:SERVICE BRAKES, AIR
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:11/05/1996 - 12/18/1997
Potential Units Affected:8400

Defect Description:

VEHICLE DESCRIPTION: MEDIUM DUTY TANDEM REAR AXLE TRUCKS WITH ABS. THESE VEHICLES FAIL TO COMPLY WITH FMVSS NO. 121, "AIR BRAKE SYSTEMS." THE AIR BRAKE SYSTEM WAS PLUMBED SO THAT COMPLETE AIR RESERVOIR ISOLATION WAS NOT PROVIDED. SOME VEHICLES WERE BUILT WITH AN AIR LINE FROM THE SYSTEM ECU RELAY VALVE MODULE TEE FITTING, INCORRECTLY CONNECTED TO THE SYSTEM SUPPLY TANK, RATHER THAN THE SYSTEM AUXILIARY PRIMARY TANK.

Consequence:

A LEAKAGE OR FAILURE CAN CAUSE A PRESSURE LOSS IN THE SECONDARY TANK RESULTING IN THE DRAINING OF THE PRIMARY TANK ALSO, AND THUS A COMPLETE LOSS OF VEHICLE SYSTEM AIR PRESSURE, DIMINISHING BRAKE EFFECTIVENESS, AND INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL INSPECT THE VEHICLE TO DETERMINE WHETHER THE VEHICLE HAS THE INCORRECTLY ROUTED AIR LINE. THOSE WITH THE CONDITION WILL BE CORRECTLY PLUMBED AND THE AIR BRAKE SYSTEM TESTED TO VERIFY PROPER RESERVOIR ISOLATION.
1998 FORD AT9513
NHTSA Campaign ID:WHEELS:RIM
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:10/21/1997 - 12/18/1997
Potential Units Affected:11

Defect Description:

VEHICLE DESCRIPTION: TRAILERS EQUIPPED WITH AFTERMARKET ALUMINUM DUAL WHEELS, 22.5X8.25, ONE-PIECE, TUBELESS, SUPPLIED BY ACCURIDE/AKW. CERTAIN DESIGN REVISIONS COMBINED WITH PROCESS CONDITIONS CAUSED FATIGUE CRACKS IN THESE WHEELS.

Consequence:

THIS CONDITION CAN CAUSE FAILURE OF THESE WHEELS.

Action:

ACCURIDE/AKW WILL REPLACE THESE WHEELS.
1998 FORD AT9522
NHTSA Campaign ID:WHEELS:RIM
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:10/21/1997 - 12/18/1997
Potential Units Affected:11

Defect Description:

VEHICLE DESCRIPTION: TRAILERS EQUIPPED WITH AFTERMARKET ALUMINUM DUAL WHEELS, 22.5X8.25, ONE-PIECE, TUBELESS, SUPPLIED BY ACCURIDE/AKW. CERTAIN DESIGN REVISIONS COMBINED WITH PROCESS CONDITIONS CAUSED FATIGUE CRACKS IN THESE WHEELS.

Consequence:

THIS CONDITION CAN CAUSE FAILURE OF THESE WHEELS.

Action:

ACCURIDE/AKW WILL REPLACE THESE WHEELS.
1998 FORD B800
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:03/03/1997 - 04/14/1997
Potential Units Affected:2400

Defect Description:

VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS AND SCHOOL BUS CHASSIS-COWLS EQUIPPED WITH AUTOMATIC TRANSMISSIONS. THE WELDS THAT ATTACH THE KEY TO THE TOP OF THE STEERING COLUMN MOUNTED AUTOMATIC TRANSMISSION SHIFT LINKAGE MAY NOT ADEQUATELY RETAIN THE KEY, ALLOWING THE TRANSMISSION TO BE IN A GEAR OTHER THAN THAT INDICATED ON THE "PRNDL", OR IN SOME CASES, "RNDL."

Consequence:

THE DOMESTIC SPECIAL ORDER (DSO) PARK BRAKE MAY NOT ENGAGE WHEN THE SHIFT LEVER IS PLACED IN THE PARK POSITION, OR IN THE VEHICLE MOVING IN AN UNINTENDED DIRECTION WHEN THE ACCELERATOR IS PRESSED. IN SOME VEHICLES THE DSO PARKING BRAKE MECHANISM ALSO MAY NOT BE PROPERLY ADJUSTED, WHICH CAN RESULT IN THE PARK BRAKE NOT ENGAGING WHEN THE SHIFT LEVER IS PLACED IN THE PARK POSITION, INCREASING THE RISK OF A VEHICLE CRASH.

Action:

DEALERS WILL REPLACE THE STEERING COLUMN SHIFT TUBE AND, IF SO EQUIPPED, TO HAVE THE DSO PARK BRAKE LINKAGE ADJUSTED.
1998 FORD CONTOUR
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:07/14/1997 - 04/30/1998
Potential Units Affected:159565

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ACCELERATOR CABLE MAY HAVE BEEN MANUFACTURED WITH A BURR ON OR NEAR THE END OF THE CABLE SLEEVE INTERIOR. THIS BURR COULD FRAY THE CORE WIRE RESULTING IN THE ACCELERATOR NOT RETURNING TO IDLE WHEN THE ACCELERATOR IS RELEASED.

Consequence:

THIS CONDITION CAN RESULT IN THE THROTTLE STICKING, BINDING, OR CAUSING HIGH ENGINE RPM.

Action:

DEALERS WILL INSTALL A REVISED ACCELERATOR CABLE THAT HAS A FLARED CONDUIT SLEEVE END AND MOLDED ON END FITTING.
1998 FORD CONTOUR
NHTSA Campaign ID:SUSPENSION:FRONT:SPRINGS:COIL SPRINGS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:09/09/1996 - 04/18/1998
Potential Units Affected:108000

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT AT THE KANSAS CITY ASSEMBLY PLANT AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS MAY FRACTURE AS A RESULT OF CORROSION IN HIGH CORROSION ENVIRONMENTS. DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.

Consequence:

SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.

Action:

DEALERS WILL INSTALL SPRING CATCHER BRACKETS. OWNER NOTIFICATION BEGAN OCTOBER 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
1998 FORD CONTOUR
NHTSA Campaign ID:EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:04/20/1995 - 08/24/1998
Potential Units Affected:605581

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TERMINALS AT THE HEADLIGHT SWITCH AND WIRING HARNESS CONNECTOR CAN EXPERIENCE HEAT DAMAGE AS A RESULT OF OVERHEATING.

Consequence:

THE DAMAGE COULD RESULT IN DISTORTION OF THE TERMINAL CAUSING AN OPEN CIRCUIT IN THE INSTRUMENT PANEL ILLUMINATION, PARKING LAMP, AND TAIL LAMP CIRCUITS.

Action:

DEALERS WILL INSTALL A HEADLAMP SWITCH WIRING CONNECTOR CONTAINING BRONZE TERMINALS AND AN INSPECTION, AND REPLACEMENT IF NECESSARY, OF THE HEADLAMP SWITCH.
1998 FORD CONTOUR
NHTSA Campaign ID:ELECTRICAL SYSTEM
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:06/01/1996 - 05/31/1998
Potential Units Affected:342962

Defect Description:

ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.

Consequence:

THE OPEN CIRCUIT COULD LEAD TO ELECTRICAL ARCING THAT COULD MELT THE CONNECTOR HOUSING MATERIAL CREASING THE POTENTIAL FOR A FIRE.

Action:

DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS. OWNER NOTIFICATION BEGAN AUGUST 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
1998 FORD CONTOUR
NHTSA Campaign ID:FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:05/20/1997 - 04/14/2000
Potential Units Affected:3750

Defect Description:

VEHICLE DESCRIPTION: BI-FUEL VEHICLES. THESE VEHICLES MAY HAVE A FUEL TANK FILLER PIPE GROMMET THAT COULD HAVE BEEN DAMAGED DURING THE INSTALLATION OF THE BI-FUEL SYSTEM. IF THE GROMMET IS DAMAGED, FUEL COULD LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE. DEALERS WILL REPLACE THE FUEL TANK FILLER PIPE GROMMET.

Consequence:

IF THE GROMMET IS DAMAGED, FUEL COULD LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Action:

DEALERS WILL REPLACE THE FUEL TANK FILLER PIPE GROMMET.
1998 FORD CONTOUR
NHTSA Campaign ID:EXTERIOR LIGHTING:HEADLIGHTS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:01/13/1997 - 01/14/1998
Potential Units Affected:571800

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TEXT AND/OR GRAPHICS FOR THE VEHICLE HEADLAMP AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES ARE NOT SUFFICIENTLY CLEAR. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence:

IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY BE CONFUSED BY THE AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES CAUSING THE HEADLAMPS TO BE IMPROPERLY AIMED.

Action:

OWNER GUIDES CONTAINING REVISED AIMING INSTRUCTIONS WILL BE MAILED TO OWNERS OF THESE VEHICLES.
1998 FORD CONTOUR
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:07/18/1994 - 01/12/1998
Potential Units Affected:175000

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FLOOR SHIFT AUTOMATIC TRANSMISSION CONTROL CAN BE DAMAGED IF SUBJECTED TO CERTAIN INTERIOR CLEANING PRODUCTS. THE GEAR POSITION INDICATOR CAN DETERIORATE AND NOT CORRECTLY INDICATE THE ACTUAL GEAR POSITION.

Consequence:

THIS CONDITION CAN RESULT IN INCORRECT GEAR SELECTION.

Action:

DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FLOOR SHIFT CONTROL.
1998 FORD CONTOUR
NHTSA Campaign ID:SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:04/01/1996 - 08/24/1998
Potential Units Affected:436200

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES NOT EQUIPPED WITH THE ANTI-LOCK BRAKING SYSTEM (ABS). A PRESSURE CONSCIOUS REDUCING VALVE (PCRV) IN THE REAR BRAKES MAY BE SUBJECT TO CORROSION AND RESULT IN MALFUNCTION, WHEN OPERATED IN AREAS THAT USE SALT COMPOUNDS ON THE ROADWAY FOR DE-ICING OR DUST CONTROL.

Consequence:

IF BOTH PCRV'S MALFUNCTION, VEHICLE HANDLING COULD BE ADVERSELY AFFECTED DURING BRAKING AS A RESULT OF THE REAR WHEELS LOCKING, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL INSTALL IMPROVED PCRV'S IN THE REAR BRAKE SYSTEM. THIS RECALL WAS EXPANDED IN SEPTEMBER 2000 TO INCLUDE 1999 AND 2000 FORD CONTOUR, MERCURY MYSTIQUE AND COUGAR VEHICLES.
1998 FORD CONTOUR
NHTSA Campaign ID:AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:01/02/1997 - 08/24/1998
Potential Units Affected:280481

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSOR WIRING PIGTAIL INSULATION CAN BECOME BRITTLE AND CRACK OVER TIME DUE TO ACCUMULATION OF WATER IN THE PIGTAIL PROTECTIVE CONVOLUTE IN COMBINATION WITH HIGH UNDERHOOD TEMPERATURES RELATED TO THE ROUTING OF THE WIRING PIGTAIL NEAR THE RADIATOR. THIS CAN RESULT IN ENVIRONMENTAL STRESS CRACKING OF THE INSULATION.

Consequence:

IN SOME CASES, THE AIR BAG WARNING LIGHT CAN ILLUMINATE AND THE AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM DISABLED.

Action:

DEALERS WILL INSTALL AIR BAG SENSORS WITH REVISED WIRING INSULATION. IN ADDITION, VEHICLES WHICH HAVE THE AIR BAG WARNING LIGHT ILLUMINATED WILL HAVE A NEW AIR BAG DIAGNOSTIC MONITOR INSTALLED.
1998 FORD CONTOUR
NHTSA Campaign ID:SUSPENSION:FRONT:SPRINGS:COIL SPRINGS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:09/09/1996 - 04/18/1998
Potential Units Affected:203426

Defect Description:

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1998 FORD CONTOUR/MERCURY MYSTIQUE PASSENGER VEHICLES BUILT AT THE KANSAS CITY ASSEMBLY PLANT. THE FRONT COIL SPRINGS COULD POTENTIALLY FRACTURE DUE TO CORROSION.

Consequence:

SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.

Action:

FORD IS EXTENDING THE WARRANTY FOR FRONT COIL SPRING REPLACEMENT FOR THE FRONT COIL SPRINGS FOR 10 YEARS FROM ORIGINAL DATE OF SALE OF A VEHICLE OR 150,000 MILES, WHICHEVER COMES FIRST.
1998 FORD CROWN VICTORIA
NHTSA Campaign ID:SEAT BELTS:FRONT:ANCHORAGE
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1167

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET DRIVER'S SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW VEHICLE SAFETY SYSTEMS, INC. (TRW) MANUFACTURED FROM JUNE 1, 1998 THROUGH MAY 21, 2000. SOME OF THESE SEAT BELT ASSEMBLIES MAY HAVE BEEN INSTALLED AS SERVICE REPLACEMENT EQUIPMENT ON THE VEHICLES INVOLVED IN THE RECALL.

Consequence:

IN THE EVENT OF A COLLISION, THESE SEAT BELTS MAY NOT RESTRAIN AN OCCUPANT INCREASING THE RISK OF INJURY.

Action:

DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE SERVICE SEAT BELT ASSEMBLIES THAT WERE INSTALLED IN THESE VEHICLES FROM JANUARY 1 THROUGH JUNE 13, 2000.
1998 FORD CROWN VICTORIA
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:07/01/1992 - 10/21/2002
Potential Units Affected:350000

Defect Description:

IN ORDER TO ENHANCE POLICE OFFICE SAFETY, MODEL YEAR 1992-2003 CROWN VICTORIA POLICE INTERCEPTOR (CVPI) VEHICLES WILL BE EQUIPPED WITH SHIELDS DESIGNED TO HELP PROTECT THE FUEL TANK IN HIGH-SPEED REAR-IMPACT CRASHES. FORD ALSO WILL BE OFFERING AN OPTIONAL TRUNK PACKAGE DESIGNED TO IMPROVE THE SAFE TRANSPORT OF SHARP-EDGED, HEAVY EQUIPMENT IN THESE VEHICLES.

Consequence:

SOME HIGH-SPEED REAR-IMPACT CRASHES HAVE RESULTED IN FUEL TANK PUNCTURES AND FIRES IN CVPI VEHICLES.

Action:

FORD HAS ADVISED US THAT SHIELD KITS HAVE BEEN AVAILABLE SINCE LATE OCTOBER AND WILL BE INSTALLED ON POLICE INTERCEPTOR VEHICLES AT NO COST. THE OPTIONAL TRANK PACKAGE WILL BE AVAILABLE BY THE END OF 2002. FORD HAS ESTABLISHED A NEW WEB SITE AT WWW.CVPI.COM TO ANSWER ADDITIONAL QUESTIONS ABOUT THE SAFE USE OF CPVI VEHICLES.
1998 FORD CROWN VICTORIA
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:02/05/1992 - 02/28/1998
Potential Units Affected:3600000

Defect Description:

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

THIS COULD RESULT IN AN UNDERHOOD FIRE.

Action:

DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1998 FORD CROWN VICTORIA
NHTSA Campaign ID:FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:4218

Defect Description:

ON CERTAIN NATURAL GAS VEHICLES, IF A FLAME FROM A VEHICLE INTERIOR FIRE BECOMES LOCALLY DIRECTED AT THE NATURAL GAS FUEL TANK LOCATED IMMEDIATELY BEHIND THE REAR SEAT, THE FLAME COULD DAMAGE THE FIBERGLASS WRAP ON THE TANK WEAKENING THE TANK.

Consequence:

IF THE STRENGTH OF THE TANK IS SIGNIFICANTLY COMPROMISED, IT COULD RUPTURE, INCREASING THE RISK OF A FIRE.

Action:

DEALERS WILL INSTALL AN INSULATOR BEHIND THE CURRENT SEAT BACK. OWNER NOTIFICATION BEGAN ON JANUARY 7, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
1998 FORD CROWN VICTORIA
NHTSA Campaign ID:VEHICLE SPEED CONTROL:CRUISE CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:02/05/1992 - 10/31/1997
Potential Units Affected:225000

Defect Description:

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Consequence:

AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Action:

DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
1998 FORD CROWN VICTORIA
NHTSA Campaign ID:SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:03/15/1996 - 12/14/1998
Potential Units Affected:175000

Defect Description:

VEHICLE DESCRIPTION: CERTAIN 1996-1999 FORD CROWN VICTORIA POLICE, FLEET, NATURAL GAS, AND 1996-1999 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT WERE PRODUCED WITH A LOWER CONTROL ARM BALL JOINT CONTAINING A ONE PIECE BEARING; AND 1990-1996 FORD CROWN VICTORIA POLICE, FLEET, AND NGV VEHICLES AND 1990-1996 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT HAVE BEEN SERVICED WITH EITHER A BALL JOINT CONTAINING THE ONE-PIECE BEARING OR A FRONT LOWER CONTROL ARM CONTAINING A BALL JOINT WITH A ONE-PIECE BEARING. THE ONE-PIECE BEARING WITHIN THE LOWER CONTROL ARM BALL JOINT CAN WEAKEN SLOWLY DURING USE AND EVENTUALLY CRACK. THIS COULD RESULT IN SEPARATION OF THE BALL AND CAP OF THE JOINT, ALLOWING THE CONTROL ARM TO DROP TO THE GROUND.

Consequence:

IF THIS OCCURS WHILE THE VEHICLE IS MOVING, REDUCED STEERING CONTROL COULD OCCUR, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL REPLACE THE LOWER CONTROL ARM BALL JOINTS (2).
1998 FORD CROWN VICTORIA
NHTSA Campaign ID:EQUIPMENT:MECHANICAL:JACKS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:06/18/1997 - 06/15/2000
Potential Units Affected:875000

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES HAVE JACKING INSTRUCTIONS WHICH, IF FOLLOWED, COULD CAUSE THE VEHICLE OPERATOR TO PLACE THE JACK ON A FRAME WELD WHEN ATTEMPTING TO RAISE A REAR WHEEL. IF THE VEHICLE IS JACKED UP WITH THE JACK PLACED ON THE FRAME WELD AND IF THE VEHICLE IS FREE TO ROLL (WHEELS NOT BLOCKED OR CHOCKED), THE JACK COULD YIELD AND THE VEHICLE MAY DROP SUDDENLY.

Consequence:

IF THIS OCCURS AND ANY PORTION OF THE OPERATOR'S BODY IS UNDER THE VEHICLE, THE POTENTIAL FOR PERSONAL INJURY EXISTS.

Action:

OWNERS WILL BE PROVIDED WITH A REVISED JACK INSTRUCTION AND STOWAGE CARD AND JACK WARNING LABEL, AS WELL AS A SUPPLEMENT TO THE OWNER GUIDE.
1998 FORD CROWN VICTORIA
NHTSA Campaign ID:SEAT BELTS:FRONT:ANCHORAGE
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1129

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET FRONT PASSENGER SIDE SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW VEHICLE SAFETY SYSTEMS, INC. (TRW) MANUFACTURED FROM JUNE 1, 1998 THROUGH MAY 21, 2000. SOME OF THESE SEAT BELT ASSEMBLIES MAY HAVE BEEN INSTALLED AS SERVICE REPLACEMENT EQUIPMENT ON THE VEHICLES INVOLVED IN THE RECALL.

Consequence:

IN THE EVENT OF A COLLISION, THESE SEAT BELTS MAY NOT RESTRAIN AN OCCUPANT INCREASING THE RISK OF INJURY.

Action:

DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE SERVICE SEAT BELT ASSEMBLIES THAT WERE INSTALLED IN THESE VEHICLES FROM JANUARY 1 THROUGH JUNE 13, 2000.
1998 FORD CVPI
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:07/01/1992 - 10/21/2002
Potential Units Affected:350000

Defect Description:

IN ORDER TO ENHANCE POLICE OFFICE SAFETY, MODEL YEAR 1992-2003 CROWN VICTORIA POLICE INTERCEPTOR (CVPI) VEHICLES WILL BE EQUIPPED WITH SHIELDS DESIGNED TO HELP PROTECT THE FUEL TANK IN HIGH-SPEED REAR-IMPACT CRASHES. FORD ALSO WILL BE OFFERING AN OPTIONAL TRUNK PACKAGE DESIGNED TO IMPROVE THE SAFE TRANSPORT OF SHARP-EDGED, HEAVY EQUIPMENT IN THESE VEHICLES.

Consequence:

SOME HIGH-SPEED REAR-IMPACT CRASHES HAVE RESULTED IN FUEL TANK PUNCTURES AND FIRES IN CVPI VEHICLES.

Action:

FORD HAS ADVISED US THAT SHIELD KITS HAVE BEEN AVAILABLE SINCE LATE OCTOBER AND WILL BE INSTALLED ON POLICE INTERCEPTOR VEHICLES AT NO COST. THE OPTIONAL TRANK PACKAGE WILL BE AVAILABLE BY THE END OF 2002. FORD HAS ESTABLISHED A NEW WEB SITE AT WWW.CVPI.COM TO ANSWER ADDITIONAL QUESTIONS ABOUT THE SAFE USE OF CPVI VEHICLES.
1998 FORD E150
NHTSA Campaign ID:EQUIPMENT ADAPTIVE
Manufacturer:MOBILITY WORKS
Manufacture Dates:01/01/1997 - 08/01/2004
Potential Units Affected:1660

Defect Description:

ON CERTAIN VANS EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT.

Consequence:

IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES TO A WHEELCHAIR OCCUPANT.

Action:

DEALERS WILL INSPECT AND REPLACE THE WHEELCHAIR SECUREMENT RETRACTORS AS NECESSARY. SURE-LOK WILL HANDLE THE REPAIRS FOR THIS CAMPAIGN. OWNERS SHOULD CONTACT SURE-LOCK AT 1-908-231-1804 OR MOBILITYWORKS AT 1-800-769-8267.
1998 FORD E-150
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:04/09/1996 - 08/02/2002
Potential Units Affected:3600000

Defect Description:

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

THIS COULD RESULT IN AN UNDERHOOD FIRE.

Action:

DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1998 FORD E-150
NHTSA Campaign ID:VEHICLE SPEED CONTROL:CRUISE CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:09/03/1991 - 09/15/2003
Potential Units Affected:225000

Defect Description:

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Consequence:

AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Action:

DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
1998 FORD E-150
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:04/09/1996 - 11/14/2000
Potential Units Affected:151000

Defect Description:

VEHICLE DESCRIPTION: ON CERTAIN VANS WITH AMBULANCE PREP PACKAGES OR OTHER SEVERE-DUTY APPLICATIONS INVOLVING OPERATION AT OR NEAR THE GROSS VEHICLE WEIGHT WITH FREQUENT TWISTING OF THE VEHICLE BODY, SUCH AS OFF-ROAD, ROUGH ROAD OR SPEED BUMP EVENTS, THE 35 GALLON MID-SHIP FUEL TANK COULD DEVELOP A CRACK WHERE IT CONTACTS THE FRAME CROSS MEMBER. IF THE FUEL TANK CRACKS, FUEL LEAKAGE COULD OCCUR.

Consequence:

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Action:

DEALERS WILL INSPECT THE FUEL TANK AND, IF CRACKED, WILL REPLACE THE TANK. INSULATOR PADS WILL BE INSTALLED ON ALL VEHICLES TO REDUCE THE STRESS LEVELS IN THE FUEL TANK. OWNER NOTIFICATION BEGAN APRIL 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
1998 FORD E-150
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:4500000

Defect Description:

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Action:

FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1998 FORD E250
NHTSA Campaign ID:EQUIPMENT ADAPTIVE
Manufacturer:MOBILITY WORKS
Manufacture Dates:01/01/1997 - 08/01/2004
Potential Units Affected:1660

Defect Description:

ON CERTAIN VANS EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT.

Consequence:

IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES TO A WHEELCHAIR OCCUPANT.

Action:

DEALERS WILL INSPECT AND REPLACE THE WHEELCHAIR SECUREMENT RETRACTORS AS NECESSARY. SURE-LOK WILL HANDLE THE REPAIRS FOR THIS CAMPAIGN. OWNERS SHOULD CONTACT SURE-LOCK AT 1-908-231-1804 OR MOBILITYWORKS AT 1-800-769-8267.
1998 FORD E-250
NHTSA Campaign ID:VEHICLE SPEED CONTROL:CRUISE CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:09/03/1991 - 09/15/2003
Potential Units Affected:225000

Defect Description:

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Consequence:

AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Action:

DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
1998 FORD E-250
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:04/09/1996 - 08/02/2002
Potential Units Affected:3600000

Defect Description:

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

THIS COULD RESULT IN AN UNDERHOOD FIRE.

Action:

DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1998 FORD E-250
NHTSA Campaign ID:EQUIPMENT:OTHER:LABELS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:03/31/1998 - 09/20/2000
Potential Units Affected:4500

Defect Description:

VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."

Consequence:

THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.

Action:

OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
1998 FORD E-250
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:4500000

Defect Description:

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Action:

FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1998 FORD E350
NHTSA Campaign ID:EQUIPMENT ADAPTIVE
Manufacturer:MOBILITY WORKS
Manufacture Dates:01/01/1997 - 08/01/2004
Potential Units Affected:1660

Defect Description:

ON CERTAIN VANS EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT.

Consequence:

IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES TO A WHEELCHAIR OCCUPANT.

Action:

DEALERS WILL INSPECT AND REPLACE THE WHEELCHAIR SECUREMENT RETRACTORS AS NECESSARY. SURE-LOK WILL HANDLE THE REPAIRS FOR THIS CAMPAIGN. OWNERS SHOULD CONTACT SURE-LOCK AT 1-908-231-1804 OR MOBILITYWORKS AT 1-800-769-8267.
1998 FORD E-350
NHTSA Campaign ID:EQUIPMENT:OTHER:LABELS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:03/31/1998 - 09/20/2000
Potential Units Affected:4500

Defect Description:

VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."

Consequence:

THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.

Action:

OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
1998 FORD E-350
NHTSA Campaign ID:EQUIPMENT ADAPTIVE
Manufacturer:ONENESS MOBILITY SERVICES, LLC
Manufacture Dates: -
Potential Units Affected:19

Defect Description:

ONENESS MOBILITY IS RECALLING 19 MY 1998, AND 2005-2006 E-350 VANS BUILT ON FORD CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Consequence:

A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

Action:

ONENESS MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR ONENESS MOBILITY AT 1-818-267-3000.
1998 FORD E-350
NHTSA Campaign ID:EQUIPMENT ADAPTIVE
Manufacturer:Cummings Mobility Conversion & Supply, I
Manufacture Dates:11/20/2006 - 09/10/2010
Potential Units Affected:66

Defect Description:

Cummings Mobility Conversion & Supply, Inc. (Cummings) is recalling various model year 1994-2011 Ford and Chevrolet vans equipped with Braun NCL-2, and NVL-2 wheel chair lifts manufactured November 20, 2006, through September 10, 2010. Over time, and with frequent use, the roll stop latches on the outer barrier of the lifts in these vans may become bent or misaligned.

Consequence:

A wheelchair occupant may defeat or ride over the insufficiently latched roll stop. If this occurs when the lift platform is in an elevated position, the wheelchair's occupant could fall and sustain injury.

Action:

Braun Corporation notified all the vehicle owners, and Cummings Mobility replaced the recalled parts with new parts, free of charge. The recall was completed as of April 10, 2014. Owners may contact Cummings customer service at 1-800-639-5438.
1998 FORD E-350
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:04/09/1996 - 11/14/2000
Potential Units Affected:151000

Defect Description:

VEHICLE DESCRIPTION: ON CERTAIN VANS WITH AMBULANCE PREP PACKAGES OR OTHER SEVERE-DUTY APPLICATIONS INVOLVING OPERATION AT OR NEAR THE GROSS VEHICLE WEIGHT WITH FREQUENT TWISTING OF THE VEHICLE BODY, SUCH AS OFF-ROAD, ROUGH ROAD OR SPEED BUMP EVENTS, THE 35 GALLON MID-SHIP FUEL TANK COULD DEVELOP A CRACK WHERE IT CONTACTS THE FRAME CROSS MEMBER. IF THE FUEL TANK CRACKS, FUEL LEAKAGE COULD OCCUR.

Consequence:

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Action:

DEALERS WILL INSPECT THE FUEL TANK AND, IF CRACKED, WILL REPLACE THE TANK. INSULATOR PADS WILL BE INSTALLED ON ALL VEHICLES TO REDUCE THE STRESS LEVELS IN THE FUEL TANK. OWNER NOTIFICATION BEGAN APRIL 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
1998 FORD E-350
NHTSA Campaign ID:VEHICLE SPEED CONTROL:CRUISE CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:09/03/1991 - 09/15/2003
Potential Units Affected:225000

Defect Description:

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Consequence:

AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Action:

DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
1998 FORD E-350
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:4500000

Defect Description:

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Action:

FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1998 FORD E-350
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:04/09/1996 - 08/02/2002
Potential Units Affected:3600000

Defect Description:

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

THIS COULD RESULT IN AN UNDERHOOD FIRE.

Action:

DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1998 FORD E-450
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:4500000

Defect Description:

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Action:

FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1998 FORD E-450
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1200000

Defect Description:

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Consequence:

OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Action:

DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
1998 FORD E-550
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:4500000

Defect Description:

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Action:

FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1998 FORD ECONOLINE
NHTSA Campaign ID:EQUIPMENT:OTHER:LABELS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:03/31/1998 - 09/20/2000
Potential Units Affected:4500

Defect Description:

VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."

Consequence:

THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.

Action:

OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
1998 FORD ECONOLINE
NHTSA Campaign ID:VEHICLE SPEED CONTROL:CRUISE CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:09/03/1991 - 09/15/2003
Potential Units Affected:225000

Defect Description:

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Consequence:

AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Action:

DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
1998 FORD E-SERIES
NHTSA Campaign ID:ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1176000

Defect Description:

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

Consequence:

IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.

Action:

DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
1998 FORD EXCURSION
NHTSA Campaign ID:ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1176000

Defect Description:

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

Consequence:

IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.

Action:

DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
1998 FORD EXPEDITION
NHTSA Campaign ID:EXTERIOR LIGHTING
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:20637

Defect Description:

VEHICLE DESCRIPTION: MINI VANS, LIGHT PICKUP TRUCKS, AND SPORT UTILITY VEHICLES. OFF LEASE CANADIAN VEHICLES EQUIPPED WITH DAYTIME RUNNING LIGHTS WHICH MEET CANADIAN REQUIREMENTS AND NOT THE PHOTOMETRIC REQUIREMENTS OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." ACCORDING TO FORD, THE VEHICLES WERE IMPORTED INTO THE U.S. ERRONEOUSLY.

Consequence:

THE LIGHT GIVEN OFF FROM THE DAYTIME RUNNING LIGHTS IS BRIGHTER THAN ALLOWED BY U.S. STANDARDS.

Action:

DEALERS WILL BE ADVISED TO DEACTIVATE THE RUNNING LIGHT FUNCTION AND TO COMPLETE ANY OUTSTANDING SAFETY RECALLS ON THESE VEHICLES.
1998 FORD EXPEDITION
NHTSA Campaign ID:TRAILER HITCHES
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:07/22/1996 - 12/09/1999
Potential Units Affected:565800

Defect Description:

VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES. THE TRAILER HITCH ASSEMBLY TO THE FRAME ATTACHING BOLTS COULD LOSE THE CLAMP LOAD.

Consequence:

THE TRAILER HITCH COULD THEN SEPARATE FROM THE VEHICLE.

Action:

DEALERS WILL REPLACE THE TRAILER HITCH MOUNTING BOLTS AND NUT PLATES.
1998 FORD EXPEDITION
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:07/22/1996 - 08/22/1997
Potential Units Affected:866000

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. IF THE AUTOMATIC TRANSMISSION SHIFT CABLE ASSEMBLY WAS NOT FULLY ATTACHED TO THE STEERING COLUMN BRACKET, THE SHIFT CABLE ASSEMBLY CAN COME OUT OF THE BRACKET. THE VEHICLE OPERATOR WOULD THEN NOT BE ABLE TO SHIFT THE TRANSMISSION FROM ONE OF THE DRIVE GEAR POSITIONS INTO THE PARK POSITION EVEN THOUGH THE GEAR SHIFT SELECTOR WOULD INDICATE "PARK."

Consequence:

THE CONDITION WOULD NOT ALLOW A DISENGAGEMENT OF THE TRANSMISSION FROM THE PARK POSITION OR AFFECT PROPER NEUTRAL START SWITCH OPERATION. UNINTENDED VEHICLE MOVEMENT COULD OCCUR IF THE PARKING BRAKE WAS NOT SET.

Action:

DEALERS WILL MAKE THE PROPER ATTACHMENT OF THE TRANSMISSION SHIFT CONTROL CABLE TO THE STEERING COLUMN BRACKET AND ADD A TIE STRAP TO THAT CONNECTION.
1998 FORD EXPEDITION
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: - 08/20/2002
Potential Units Affected:4500000

Defect Description:

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.

Consequence:

A FIRE AT THE SWITCH COULD OCCUR.

Action:

BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
1998 FORD EXPEDITION
NHTSA Campaign ID:WHEELS:LUGS/NUTS/BOLTS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:12/01/1995 - 04/14/1998
Potential Units Affected:1520000

Defect Description:

VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES AND LIGHT DUTY PICKUP TRUCKS. THE LUG NUTS ON THESE VEHICLES MAY NOT CREATE SUFFICIENT CLAMP LOAD ALLOWING WHEEL MOVEMENT IN RELATION TO THE HUB/ROTOR MOUNTING SURFACE.

Consequence:

THIS CAN RESULT IN THE LOOSENING OF LUG NUTS, STUD FATIGUE FAILURE, AND THE POTENTIAL FOR A WHEEL SEPARATION FROM THE VEHICLE, INCREASING THE RISK OF A VEHICLE CRASH.

Action:

OWNERS OF THESE VEHICLES WILL BE RECEIVING TWO NOTIFICATIONS. THE FIRST NOTIFICATION, WHICH BEGAN IN MAY 1998, WILL PROVIDE AN INTERIM REPAIR PROCEDURE UNTIL PARTS BECOME AVAILABLE. THIS INTERIM PROCEDURE CAN BE COMPLETED BY OWNERS OR THEIR DEALERS. IT SPECIFIES THAT THE LUG NUT TORQUE MUST BE VERIFIED TO BE 100 LBS. THEN THE LUG NUTS NEED TO BE TIGHTENED AN ADDITIONAL 1/8 TO 1/4 TURN MORE. THERE WILL BE A SECOND OWNER NOTIFICATION, WHICH IS EXPECTED TO BEGIN JULY 20, 1998, UNDER WHICH DEALERS WILL INSPECT THE WHEEL STUDS AND REPLACE THE WHEEL LUG NUTS.
1998 FORD EXPLORER
NHTSA Campaign ID:SEATS:FRONT ASSEMBLY:RECLINER
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:05/13/1997 - 12/24/2000
Potential Units Affected:1552880

Defect Description:

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES AND DOES NOT JAM IN THE SEAT BACK FRAME, THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH AN OBJECT BEHIND THE SEAT, SUCH AS THE SECOND ROW SEAT CUSHION.

Consequence:

THE DRIVER COULD POTENTIALLY LOSE CONTACT WITH THE STEERING WHEEL OR FOOT PEDALS DURING SUCH AN EVENT, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL REPLACE THE DRIVER SEAT UPPER BOLT WITH A METAL SPACER AND BOLT. IN ADDITION, SEATS WITH TUBULAR BACK FRAMES WILL HAVE THE FULLY THREADED LOWER RECLINER BOLT REPLACED WITH A PARTIALLY THREADED BOLT. OWNER NOTIFICATION BEGAN ON AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
1998 FORD EXPLORER
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1200000

Defect Description:

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Consequence:

OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Action:

DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
1998 FORD EXPLORER
NHTSA Campaign ID:ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT CONTROLLER
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:08/05/1997 - 08/27/1997
Potential Units Affected:1100

Defect Description:

VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES, EDDIE BAUER AND LIMITED EDITIONS. THE KEY-IN-IGNITION/DOOR OPEN WARNING CHIME MAY NOT FUNCTION WHEN THE DOOR IS OPENED. THIS DOES NOT FULLY COMPLY WITH FMVSS NO. 114, "THEFT PROTECTION."

Consequence:

THE STANDARD SPECIFIED THAT A WARNING TO THE DRIVER SHALL BE ACTUATED WHENEVER THE KEY HAS BEEN LEFT IN THE LOCKING SYSTEM AND THE DRIVER'S DOOR IS OPENED.

Action:

DEALERS WILL INSTALL A JUMPER WIRE TO PROVIDE THE NECESSARY GROUND CIRCUIT IN THESE VEHICLES.
1998 FORD EXPLORER
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:05/29/1996 - 10/20/1998
Potential Units Affected:220000

Defect Description:

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES AND STILL RETAIN THE ORIGINAL THROTTLE BODY (PART NUMBERS 97JF-9E926AB OR 97JF-9E926-AC). SOME OF THE ORIGINAL THROTTLE BODIES INSTALLED ALLOWED A GAP BETWEEN THE PLATE AND BORE TO BE BUILT TOO NARROW. THIS REDUCED CLEARANCE ALLOWED THE ENGINE DEPOSITS NORMALLY PRESENT IN THE THROTTLE BODY TO CONTACT OR BRIDGE THE GAP. IF THE ENGINE DEPOSITS BRIDGED THE GAP BETWEEN THE THROTTLE PLATE AND BORE AND THEN HARDENED, ON THE INITIAL APPLICATION OF THE ACCELERATOR PEDAL AFTER THE ENGINE HAS COOLED, THE OPERATOR WOULD NEED TO APPLY ADDITIONAL FORCE TO THE ACCELERATOR PEDAL TO BREAK THE BRIDGE.

Consequence:

THIS COULD RESULT IN ENGINE SURGE WHEN THE ACCELERATOR PEDAL BREAKS FREE.

Action:

DEALERS WILL REPLACE THE ORIGINAL THROTTLE BODIES.
1998 FORD EXPLORER
NHTSA Campaign ID:TIRES:TREAD/BELT
Manufacturer:BRIDGESTONE/FIRESTONE, INC.
Manufacture Dates: -
Potential Units Affected:14400000

Defect Description:

TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.

Consequence:

IF THE TREAD SEPARATES FROM THE TIRE, THE DRIVER CAN LOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH CAUSING INJURY OR DEATH.

Action:

THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON AUGUST 29, 2001. HOWEVER, CUSTOMERS SHOULD CONTACT FIRESTONE CUSTOMER SERVICE AT 1-800-465-1904 FOR POSSIBLE ASSISTANCE.
1998 FORD EXPLORER
NHTSA Campaign ID:EXTERIOR LIGHTING
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:20637

Defect Description:

VEHICLE DESCRIPTION: MINI VANS, LIGHT PICKUP TRUCKS, AND SPORT UTILITY VEHICLES. OFF LEASE CANADIAN VEHICLES EQUIPPED WITH DAYTIME RUNNING LIGHTS WHICH MEET CANADIAN REQUIREMENTS AND NOT THE PHOTOMETRIC REQUIREMENTS OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." ACCORDING TO FORD, THE VEHICLES WERE IMPORTED INTO THE U.S. ERRONEOUSLY.

Consequence:

THE LIGHT GIVEN OFF FROM THE DAYTIME RUNNING LIGHTS IS BRIGHTER THAN ALLOWED BY U.S. STANDARDS.

Action:

DEALERS WILL BE ADVISED TO DEACTIVATE THE RUNNING LIGHT FUNCTION AND TO COMPLETE ANY OUTSTANDING SAFETY RECALLS ON THESE VEHICLES.
1998 FORD EXPLORER
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:08/01/1996 - 02/01/1998
Potential Units Affected:320000

Defect Description:

VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH 4.0L SINGLE OVERHEAD CAM ENGINES. THE ENGINE FUEL LINES CAN BE DAMAGED IF THE VEHICLE IS JUMP STARTED AND THE GROUND CABLE IS ATTACHED TO THE FUEL LINE BRACKET THAT IS LOCATED NEAR THE BATTERY. SINCE THE BRACKET IS NOT GROUNDED, THE STAINLESS STEEL FUEL LINE BRAID COULD ACT AS A GROUND POTENTIALLY OVERHEATING THE PTFE INNER LINER OF THE FUEL LINE RESULTING IN DAMAGE TO THE FUEL LINE.

Consequence:

THE FUEL LINES CAN LEAK, AND IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD POTENTIALLY RESULT.

Action:

DEALERS WILL INSTALL A WARNING LABEL ON THE FUEL LINE BRACKET ADVISING OWNERS NOT TO USE IT FOR A JUMP START GROUND. ALSO A REVISED BOLT WILL BE INSTALLED IN THE ALTERNATOR BRACKET TO PROVIDE A CONVENIENT JUMP START GROUND LOCATION.
1998 FORD EXPLORER
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:08/11/1994 - 08/30/2002
Potential Units Affected:4500000

Defect Description:

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Action:

FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1998 FORD EXPLORER
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:05/29/1996 - 03/04/1999
Potential Units Affected:898739

Defect Description:

VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR 5.0L ENGINES OR 1998-1999 RANGERS EQUIPPED WITH 2.5L, 3.0L FFV/EFI OR 4.0L ENGINES AND CRUISE CONTROL BUILT FROM JANUARY 5, 1998 THROUGH MARCH 4, 1999; 1998-1999 MUSTANGS EQUIPPED WITH 3.8L, 4.6L 2-VALVE OR 4-VALVE ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; 1999 F250/F350/F450/F550 (OVER 8,500 LBS.) TRUCKS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; AND 1999 F-53 STRIPPED CHASSIS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999. A CRUISE CONTROL CABLE CAN INTERFERE WITH THE SPEED CONTROL SERVO PULLEY AND NOT ALLOW THE THROTTLE TO RETURN TO IDLE WHEN DISENGAGING THE CRUISE CONTROL.

Consequence:

IF THE CRUISE CONTROL IS USED AND THIS CONDITION IS PRESENT, A STUCK THROTTLE COULD RESULT, WHICH COULD POTENTIALLY RESULT IN A CRASH.

Action:

DEALERS WILL REPLACE THE CRUISE CONTROL CABLES. AT THE PRESENT TIME, THE REPLACEMENT CABLES ARE NOT AVAILABLE. CUSTOMERS ARE BEING ADVISED NOT TO USE THE CRUISE CONTROL SYSTEM UNTIL A REPLACEMENT CAN BE MADE.
1998 FORD EXPLORER
NHTSA Campaign ID:LATCHES/LOCKS/LINKAGES:HOOD:LATCH
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:04/25/1997 - 05/17/1999
Potential Units Affected:854288

Defect Description:

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE SECONDARY HOOD LATCH MAY CORRODE AT THE LATCH PIVOT AND STICK IN THE OPEN POSITION.

Consequence:

IF THIS OCCURS AND THE PRIMARY HOOD LATCH IS EITHER NOT ENGAGED OR IS RELEASED, A HOOD FLY-UP COULD OCCUR.

Action:

DEALERS WILL INSTALL A SECONDARY HOOD LATCH WITH COMPONENTS THAT ARE COATED PRIOR TO ASSEMBLY FOR IMPROVED LATCH PIVOT CORROSION PROTECTION.
1998 FORD F-150
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: - 08/20/2002
Potential Units Affected:4500000

Defect Description:

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.

Consequence:

A FIRE AT THE SWITCH COULD OCCUR.

Action:

BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
1998 FORD F-150
NHTSA Campaign ID:SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:11/26/1995 - 02/19/1998
Potential Units Affected:202000

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY 4-WHEEL DRIVE PICKUP TRUCKS. IF THE VEHICLE IS OVERLOADED, THE REAR LEAF SPRINGS CAN BE OVERSTRESSED. A FATIGUE FRACTURE OF THE SPRING CAN OCCUR. THE CENTER LEAF OF THE SPRING CAN FRACTURE AT THE FORWARD EDGE OF THE SPRING SEAT AND, IN SOME CASES, CONTACT THE FUEL TANK.

Consequence:

FUEL TANK CONTACT CAN DAMAGE THE TANK AND RESULT IN FUEL LEAKAGE. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Action:

DEALERS WILL INSPECT THE REAR SPRINGS AND INSTALL AN ADDITIONAL CLIP ON THE FORWARD END OF THE REAR SPRINGS TO PREVENT FUEL TANK CONTACT IN THE EVENT OF A LEAF FRACTURE. ANY FRACTURED SPRINGS WILL BE REPLACED.
1998 FORD F-150
NHTSA Campaign ID:EQUIPMENT:OTHER:LABELS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:03/31/1998 - 09/20/2000
Potential Units Affected:4500

Defect Description:

VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."

Consequence:

THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.

Action:

OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
1998 FORD F-150
NHTSA Campaign ID:WHEELS:LUGS/NUTS/BOLTS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:12/01/1995 - 04/14/1998
Potential Units Affected:1520000

Defect Description:

VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES AND LIGHT DUTY PICKUP TRUCKS. THE LUG NUTS ON THESE VEHICLES MAY NOT CREATE SUFFICIENT CLAMP LOAD ALLOWING WHEEL MOVEMENT IN RELATION TO THE HUB/ROTOR MOUNTING SURFACE.

Consequence:

THIS CAN RESULT IN THE LOOSENING OF LUG NUTS, STUD FATIGUE FAILURE, AND THE POTENTIAL FOR A WHEEL SEPARATION FROM THE VEHICLE, INCREASING THE RISK OF A VEHICLE CRASH.

Action:

OWNERS OF THESE VEHICLES WILL BE RECEIVING TWO NOTIFICATIONS. THE FIRST NOTIFICATION, WHICH BEGAN IN MAY 1998, WILL PROVIDE AN INTERIM REPAIR PROCEDURE UNTIL PARTS BECOME AVAILABLE. THIS INTERIM PROCEDURE CAN BE COMPLETED BY OWNERS OR THEIR DEALERS. IT SPECIFIES THAT THE LUG NUT TORQUE MUST BE VERIFIED TO BE 100 LBS. THEN THE LUG NUTS NEED TO BE TIGHTENED AN ADDITIONAL 1/8 TO 1/4 TURN MORE. THERE WILL BE A SECOND OWNER NOTIFICATION, WHICH IS EXPECTED TO BEGIN JULY 20, 1998, UNDER WHICH DEALERS WILL INSPECT THE WHEEL STUDS AND REPLACE THE WHEEL LUG NUTS.
1998 FORD F-150
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:11/26/1995 - 02/19/1998
Potential Units Affected:202000

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY 4-WHEEL DRIVE PICKUP TRUCKS. IF THE VEHICLE IS OVERLOADED, THE REAR LEAF SPRINGS CAN BE OVERSTRESSED. A FATIGUE FRACTURE OF THE SPRING CAN OCCUR. THE CENTER LEAF OF THE SPRING CAN FRACTURE AT THE FORWARD EDGE OF THE SPRING SEAT AND, IN SOME CASES, CONTACT THE FUEL TANK.

Consequence:

FUEL TANK CONTACT CAN DAMAGE THE TANK AND RESULT IN FUEL LEAKAGE. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Action:

DEALERS WILL INSPECT THE REAR SPRINGS AND INSTALL AN ADDITIONAL CLIP ON THE FORWARD END OF THE REAR SPRINGS TO PREVENT FUEL TANK CONTACT IN THE EVENT OF A LEAF FRACTURE. ANY FRACTURED SPRINGS WILL BE REPLACED.
1998 FORD F-150
NHTSA Campaign ID:VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:11/29/1995 - 11/02/1997
Potential Units Affected:45000

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH A 4.2L ENGINE AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN ONE OF THE FOLLOWING STATES: ALASKA, MONTANA, NORTH DAKOTA, MINNESOTA, WISCONSIN, NEW YORK, VERMONT, NEW HAMPSHIRE, MAINE, MICHIGAN, IDAHO, WYOMING, SOUTH DAKOTA, COLORADO, NEBRASKA, KANSAS, IOWA, MISSOURI, ILLINOIS, INDIANA, OHIO, PENNSYLVANIA, AND MASSACHUSETTS. THE THROTTLE IS UNABLE TO RETURN TO IDLE DUE TO ICE FORMING IN THE THROTTLE BODY WHEN THE TEMPERATURE RANGES FROM -10 TO -40 DEGREES FAHRENHEIT.

Consequence:

INCREASED BRAKE PEDAL EFFORTS OR SOME INCREASE IN STOPPING DISTANCE COULD RESULT.

Action:

DEALERS WILL INSTALL A REVISED PCV SYSTEM ON THESE VEHICLES.
1998 FORD F-150
NHTSA Campaign ID:EXTERIOR LIGHTING
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:20637

Defect Description:

VEHICLE DESCRIPTION: MINI VANS, LIGHT PICKUP TRUCKS, AND SPORT UTILITY VEHICLES. OFF LEASE CANADIAN VEHICLES EQUIPPED WITH DAYTIME RUNNING LIGHTS WHICH MEET CANADIAN REQUIREMENTS AND NOT THE PHOTOMETRIC REQUIREMENTS OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." ACCORDING TO FORD, THE VEHICLES WERE IMPORTED INTO THE U.S. ERRONEOUSLY.

Consequence:

THE LIGHT GIVEN OFF FROM THE DAYTIME RUNNING LIGHTS IS BRIGHTER THAN ALLOWED BY U.S. STANDARDS.

Action:

DEALERS WILL BE ADVISED TO DEACTIVATE THE RUNNING LIGHT FUNCTION AND TO COMPLETE ANY OUTSTANDING SAFETY RECALLS ON THESE VEHICLES.
1998 FORD F-150
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:06/20/1995 - 08/04/2004
Potential Units Affected:1100000

Defect Description:

FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.

Consequence:

AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.

Action:

FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
1998 FORD F-150
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:07/22/1996 - 08/22/1997
Potential Units Affected:866000

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. IF THE AUTOMATIC TRANSMISSION SHIFT CABLE ASSEMBLY WAS NOT FULLY ATTACHED TO THE STEERING COLUMN BRACKET, THE SHIFT CABLE ASSEMBLY CAN COME OUT OF THE BRACKET. THE VEHICLE OPERATOR WOULD THEN NOT BE ABLE TO SHIFT THE TRANSMISSION FROM ONE OF THE DRIVE GEAR POSITIONS INTO THE PARK POSITION EVEN THOUGH THE GEAR SHIFT SELECTOR WOULD INDICATE "PARK."

Consequence:

THE CONDITION WOULD NOT ALLOW A DISENGAGEMENT OF THE TRANSMISSION FROM THE PARK POSITION OR AFFECT PROPER NEUTRAL START SWITCH OPERATION. UNINTENDED VEHICLE MOVEMENT COULD OCCUR IF THE PARKING BRAKE WAS NOT SET.

Action:

DEALERS WILL MAKE THE PROPER ATTACHMENT OF THE TRANSMISSION SHIFT CONTROL CABLE TO THE STEERING COLUMN BRACKET AND ADD A TIE STRAP TO THAT CONNECTION.
1998 FORD F-250
NHTSA Campaign ID:EQUIPMENT:OTHER:LABELS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:03/31/1998 - 09/20/2000
Potential Units Affected:4500

Defect Description:

VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."

Consequence:

THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.

Action:

OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
1998 FORD F-250
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1200000

Defect Description:

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Consequence:

OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Action:

DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
1998 FORD F-250
NHTSA Campaign ID:WHEELS:LUGS/NUTS/BOLTS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:12/01/1995 - 04/14/1998
Potential Units Affected:1520000

Defect Description:

VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES AND LIGHT DUTY PICKUP TRUCKS. THE LUG NUTS ON THESE VEHICLES MAY NOT CREATE SUFFICIENT CLAMP LOAD ALLOWING WHEEL MOVEMENT IN RELATION TO THE HUB/ROTOR MOUNTING SURFACE.

Consequence:

THIS CAN RESULT IN THE LOOSENING OF LUG NUTS, STUD FATIGUE FAILURE, AND THE POTENTIAL FOR A WHEEL SEPARATION FROM THE VEHICLE, INCREASING THE RISK OF A VEHICLE CRASH.

Action:

OWNERS OF THESE VEHICLES WILL BE RECEIVING TWO NOTIFICATIONS. THE FIRST NOTIFICATION, WHICH BEGAN IN MAY 1998, WILL PROVIDE AN INTERIM REPAIR PROCEDURE UNTIL PARTS BECOME AVAILABLE. THIS INTERIM PROCEDURE CAN BE COMPLETED BY OWNERS OR THEIR DEALERS. IT SPECIFIES THAT THE LUG NUT TORQUE MUST BE VERIFIED TO BE 100 LBS. THEN THE LUG NUTS NEED TO BE TIGHTENED AN ADDITIONAL 1/8 TO 1/4 TURN MORE. THERE WILL BE A SECOND OWNER NOTIFICATION, WHICH IS EXPECTED TO BEGIN JULY 20, 1998, UNDER WHICH DEALERS WILL INSPECT THE WHEEL STUDS AND REPLACE THE WHEEL LUG NUTS.
1998 FORD F-250
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:06/20/1995 - 08/04/2004
Potential Units Affected:1100000

Defect Description:

FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.

Consequence:

AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.

Action:

FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
1998 FORD F-250
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: - 08/20/2002
Potential Units Affected:4500000

Defect Description:

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.

Consequence:

A FIRE AT THE SWITCH COULD OCCUR.

Action:

BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
1998 FORD F-250
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:07/22/1996 - 08/22/1997
Potential Units Affected:866000

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. IF THE AUTOMATIC TRANSMISSION SHIFT CABLE ASSEMBLY WAS NOT FULLY ATTACHED TO THE STEERING COLUMN BRACKET, THE SHIFT CABLE ASSEMBLY CAN COME OUT OF THE BRACKET. THE VEHICLE OPERATOR WOULD THEN NOT BE ABLE TO SHIFT THE TRANSMISSION FROM ONE OF THE DRIVE GEAR POSITIONS INTO THE PARK POSITION EVEN THOUGH THE GEAR SHIFT SELECTOR WOULD INDICATE "PARK."

Consequence:

THE CONDITION WOULD NOT ALLOW A DISENGAGEMENT OF THE TRANSMISSION FROM THE PARK POSITION OR AFFECT PROPER NEUTRAL START SWITCH OPERATION. UNINTENDED VEHICLE MOVEMENT COULD OCCUR IF THE PARKING BRAKE WAS NOT SET.

Action:

DEALERS WILL MAKE THE PROPER ATTACHMENT OF THE TRANSMISSION SHIFT CONTROL CABLE TO THE STEERING COLUMN BRACKET AND ADD A TIE STRAP TO THAT CONNECTION.
1998 FORD F-250 SD
NHTSA Campaign ID:ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1176000

Defect Description:

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

Consequence:

IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.

Action:

DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
1998 FORD F-350
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1200000

Defect Description:

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Consequence:

OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Action:

DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
1998 FORD F-350 SD
NHTSA Campaign ID:ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1176000

Defect Description:

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

Consequence:

IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.

Action:

DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
1998 FORD F450 CLASSIC TRAVELER
NHTSA Campaign ID:STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
Manufacturer:FONTAINE MODIFICATION CO.
Manufacture Dates: -
Potential Units Affected:293

Defect Description:

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH REYCO GRANNING MODEL 345P AIR RIDE SUSPENSIONS, THE BRACKET SUPPORTING THE HORIZONTAL TRACK ROD AT THE FRAME ATTACHMENT CAN BECOME LOOSE AND EVENTUALLY CRACK AND BREAK.

Consequence:

THIS CONDITION COULD CAUSE THE TRACK ROD TO BE INEFFECTIVE IN MAINTAINING LATERAL CONTROL BETWEEN THE AXLE AND FRAME RESULTING IN VEHICLE HANDLING PROBLEMS INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL INSPECT THE BRACKET AND NUT/BOLT HARDWARE. IF THE BOLTS ARE LOOSE OR THE BRACKET HAS CRACKED, THE BOLTS, NUTS, AND BRACKETS WILL BE REPLACED. IF THE BOLTS ARE INSTALLED CORRECTLY AND ARE TIGHT, THEY WILL BE REMOVED AND REPLACED WITH NEW BOLTS AND LOCKTITE. THE RECALL BEGAN ON FEBRUARY 22, 2008. OWNERS MAY CONTACT FONTAINE AT 1-704-409-1605. THIS RECALL HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON FORD F450 AND F550 PICKUP TRUCKS MANUFACTURED BY FORD MOTOR COMPANY.
1998 FORD F-450 SD
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1200000

Defect Description:

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Consequence:

OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Action:

DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
1998 FORD F-450 SD
NHTSA Campaign ID:ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1176000

Defect Description:

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

Consequence:

IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.

Action:

DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
1998 FORD F53
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:10/06/1997 - 12/17/1999
Potential Units Affected:3600000

Defect Description:

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

THIS COULD RESULT IN AN UNDERHOOD FIRE.

Action:

DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1998 FORD F550 CLASSIC TRAVELER
NHTSA Campaign ID:STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
Manufacturer:FONTAINE MODIFICATION CO.
Manufacture Dates: -
Potential Units Affected:293

Defect Description:

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH REYCO GRANNING MODEL 345P AIR RIDE SUSPENSIONS, THE BRACKET SUPPORTING THE HORIZONTAL TRACK ROD AT THE FRAME ATTACHMENT CAN BECOME LOOSE AND EVENTUALLY CRACK AND BREAK.

Consequence:

THIS CONDITION COULD CAUSE THE TRACK ROD TO BE INEFFECTIVE IN MAINTAINING LATERAL CONTROL BETWEEN THE AXLE AND FRAME RESULTING IN VEHICLE HANDLING PROBLEMS INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL INSPECT THE BRACKET AND NUT/BOLT HARDWARE. IF THE BOLTS ARE LOOSE OR THE BRACKET HAS CRACKED, THE BOLTS, NUTS, AND BRACKETS WILL BE REPLACED. IF THE BOLTS ARE INSTALLED CORRECTLY AND ARE TIGHT, THEY WILL BE REMOVED AND REPLACED WITH NEW BOLTS AND LOCKTITE. THE RECALL BEGAN ON FEBRUARY 22, 2008. OWNERS MAY CONTACT FONTAINE AT 1-704-409-1605. THIS RECALL HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON FORD F450 AND F550 PICKUP TRUCKS MANUFACTURED BY FORD MOTOR COMPANY.
1998 FORD F-550 SD
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1200000

Defect Description:

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Consequence:

OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Action:

DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
1998 FORD F-550 SD
NHTSA Campaign ID:ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1176000

Defect Description:

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

Consequence:

IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.

Action:

DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
1998 FORD F700
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:03/03/1997 - 04/14/1997
Potential Units Affected:2400

Defect Description:

VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS AND SCHOOL BUS CHASSIS-COWLS EQUIPPED WITH AUTOMATIC TRANSMISSIONS. THE WELDS THAT ATTACH THE KEY TO THE TOP OF THE STEERING COLUMN MOUNTED AUTOMATIC TRANSMISSION SHIFT LINKAGE MAY NOT ADEQUATELY RETAIN THE KEY, ALLOWING THE TRANSMISSION TO BE IN A GEAR OTHER THAN THAT INDICATED ON THE "PRNDL", OR IN SOME CASES, "RNDL."

Consequence:

THE DOMESTIC SPECIAL ORDER (DSO) PARK BRAKE MAY NOT ENGAGE WHEN THE SHIFT LEVER IS PLACED IN THE PARK POSITION, OR IN THE VEHICLE MOVING IN AN UNINTENDED DIRECTION WHEN THE ACCELERATOR IS PRESSED. IN SOME VEHICLES THE DSO PARKING BRAKE MECHANISM ALSO MAY NOT BE PROPERLY ADJUSTED, WHICH CAN RESULT IN THE PARK BRAKE NOT ENGAGING WHEN THE SHIFT LEVER IS PLACED IN THE PARK POSITION, INCREASING THE RISK OF A VEHICLE CRASH.

Action:

DEALERS WILL REPLACE THE STEERING COLUMN SHIFT TUBE AND, IF SO EQUIPPED, TO HAVE THE DSO PARK BRAKE LINKAGE ADJUSTED.
1998 FORD F700
NHTSA Campaign ID:SUSPENSION:FRONT:WHEEL BEARING
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:03/18/1997 - 06/18/1997
Potential Units Affected:1600

Defect Description:

VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS AND CHASSIS-CABS. AN AUTOMATIC LOCKING FRONT WHEEL BEARING ADJUSTING NUT WAS DAMAGED DURING INSTALLATION OR REMOVAL BY INCORRECT TOOLS OR AN INCORRECT TORQUE SPECIFICATION WAS USED.

Consequence:

THIS CONDITION CAN CAUSE THE NUT TO ROTATE FREELY AND LOSE TORQUE. IT COULD ROTATE UNTIL IT IS NO LONGER CONNECTED TO THE FRONT SPINDLE AND ALLOW THE FRONT WHEEL TO SEPARATE FROM THE VEHICLE.

Action:

DEALERS WILL REPLACE THE FRONT WHEEL BEARING ADJUSTING NUTS WITH CASTLE NUTS AND COTTER PINS.
1998 FORD F800
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:03/03/1997 - 04/14/1997
Potential Units Affected:2400

Defect Description:

VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS AND SCHOOL BUS CHASSIS-COWLS EQUIPPED WITH AUTOMATIC TRANSMISSIONS. THE WELDS THAT ATTACH THE KEY TO THE TOP OF THE STEERING COLUMN MOUNTED AUTOMATIC TRANSMISSION SHIFT LINKAGE MAY NOT ADEQUATELY RETAIN THE KEY, ALLOWING THE TRANSMISSION TO BE IN A GEAR OTHER THAN THAT INDICATED ON THE "PRNDL", OR IN SOME CASES, "RNDL."

Consequence:

THE DOMESTIC SPECIAL ORDER (DSO) PARK BRAKE MAY NOT ENGAGE WHEN THE SHIFT LEVER IS PLACED IN THE PARK POSITION, OR IN THE VEHICLE MOVING IN AN UNINTENDED DIRECTION WHEN THE ACCELERATOR IS PRESSED. IN SOME VEHICLES THE DSO PARKING BRAKE MECHANISM ALSO MAY NOT BE PROPERLY ADJUSTED, WHICH CAN RESULT IN THE PARK BRAKE NOT ENGAGING WHEN THE SHIFT LEVER IS PLACED IN THE PARK POSITION, INCREASING THE RISK OF A VEHICLE CRASH.

Action:

DEALERS WILL REPLACE THE STEERING COLUMN SHIFT TUBE AND, IF SO EQUIPPED, TO HAVE THE DSO PARK BRAKE LINKAGE ADJUSTED.
1998 FORD F800
NHTSA Campaign ID:SUSPENSION:FRONT:WHEEL BEARING
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:03/18/1997 - 06/18/1997
Potential Units Affected:1600

Defect Description:

VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS AND CHASSIS-CABS. AN AUTOMATIC LOCKING FRONT WHEEL BEARING ADJUSTING NUT WAS DAMAGED DURING INSTALLATION OR REMOVAL BY INCORRECT TOOLS OR AN INCORRECT TORQUE SPECIFICATION WAS USED.

Consequence:

THIS CONDITION CAN CAUSE THE NUT TO ROTATE FREELY AND LOSE TORQUE. IT COULD ROTATE UNTIL IT IS NO LONGER CONNECTED TO THE FRONT SPINDLE AND ALLOW THE FRONT WHEEL TO SEPARATE FROM THE VEHICLE.

Action:

DEALERS WILL REPLACE THE FRONT WHEEL BEARING ADJUSTING NUTS WITH CASTLE NUTS AND COTTER PINS.
1998 FORD L8501
NHTSA Campaign ID:WHEELS:RIM
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:10/21/1997 - 12/18/1997
Potential Units Affected:11

Defect Description:

VEHICLE DESCRIPTION: TRAILERS EQUIPPED WITH AFTERMARKET ALUMINUM DUAL WHEELS, 22.5X8.25, ONE-PIECE, TUBELESS, SUPPLIED BY ACCURIDE/AKW. CERTAIN DESIGN REVISIONS COMBINED WITH PROCESS CONDITIONS CAUSED FATIGUE CRACKS IN THESE WHEELS.

Consequence:

THIS CONDITION CAN CAUSE FAILURE OF THESE WHEELS.

Action:

ACCURIDE/AKW WILL REPLACE THESE WHEELS.
1998 FORD LOUISVILLE
NHTSA Campaign ID:SERVICE BRAKES, AIR
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:04/29/1996 - 12/21/1997
Potential Units Affected:1687

Defect Description:

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH OPTIONAL WABCO AIR DRYER. THE AIR BRAKE SYSTEM WAS PLUMBED SO THAT THE SYSTEMS DID NOT PROVIDE AIR RESERVOIR ISOLATION. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS."

Consequence:

THE AIR BRAKE RESERVOIR PRESSURE COULD BE DEPLETED, ACTIVATING THE EMERGENCY SPRING BRAKE. WITH THE EMERGENCY SPRING BRAKE DEPLOYED, THE VEHICLE WOULD STOP AND COULD NOT BE MOVED UNTIL THE BRAKE AIR SYSTEM WAS REPAIRED.

Action:

DEALERS WILL REPAIR THE AIR LINE PLUMBING TO INSTALL A CHECK VALVE.
1998 FORD LOUISVILLE
NHTSA Campaign ID:SERVICE BRAKES, AIR
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:11/05/1996 - 12/18/1997
Potential Units Affected:8400

Defect Description:

VEHICLE DESCRIPTION: MEDIUM DUTY TANDEM REAR AXLE TRUCKS WITH ABS. THESE VEHICLES FAIL TO COMPLY WITH FMVSS NO. 121, "AIR BRAKE SYSTEMS." THE AIR BRAKE SYSTEM WAS PLUMBED SO THAT COMPLETE AIR RESERVOIR ISOLATION WAS NOT PROVIDED. SOME VEHICLES WERE BUILT WITH AN AIR LINE FROM THE SYSTEM ECU RELAY VALVE MODULE TEE FITTING, INCORRECTLY CONNECTED TO THE SYSTEM SUPPLY TANK, RATHER THAN THE SYSTEM AUXILIARY PRIMARY TANK.

Consequence:

A LEAKAGE OR FAILURE CAN CAUSE A PRESSURE LOSS IN THE SECONDARY TANK RESULTING IN THE DRAINING OF THE PRIMARY TANK ALSO, AND THUS A COMPLETE LOSS OF VEHICLE SYSTEM AIR PRESSURE, DIMINISHING BRAKE EFFECTIVENESS, AND INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL INSPECT THE VEHICLE TO DETERMINE WHETHER THE VEHICLE HAS THE INCORRECTLY ROUTED AIR LINE. THOSE WITH THE CONDITION WILL BE CORRECTLY PLUMBED AND THE AIR BRAKE SYSTEM TESTED TO VERIFY PROPER RESERVOIR ISOLATION.
1998 FORD MOUNTAINEER
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1200000

Defect Description:

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Consequence:

OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Action:

DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
1998 FORD MUSTANG
NHTSA Campaign ID:PARKING BRAKE:CONVENTIONAL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:10/04/1993 - 10/10/2000
Potential Units Affected:434000

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS. IF A VEHICLE IS PARKED WITH THE PARKING BRAKE NOT FULLY APPLIED AND NOT IN FIRST GEAR, AS DIRECTED IN THE OWNER GUIDE, AND THE SELF ADJUSTMENT PAWL SUBSEQUENTLY SKIPS ONE OR TWO TEETH, THE VEHICLE COULD MOVE ON SOME GRADES.

Consequence:

THIS COULD RESULT IN UNINTENDED VEHICLE MOVEMENT AND A VEHICLE CRASH WITHOUT PRIOR WARNING.

Action:

DEALERS WILL MODIFY THE PARKING BRAKE CONTROL AND INSTALL A PLATE OR OVER-BRACKET TO THE CONTROL TO LOCK THE SELF ADJUST MECHANISM IN POSITION FOLLOWING ADJUSTMENT.
1998 FORD MUSTANG
NHTSA Campaign ID:STEERING:GEAR BOX:SHAFT SECTOR
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:09/15/1997 - 09/18/1997
Potential Units Affected:2250

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI-VANS. THE RACK AND PINION STEERING GEARS MAY HAVE DAMAGED INPUT SHAFT BEARINGS.

Consequence:

THIS CONDITION CAN INCREASE STEERING EFFORTS, AFFECTING STEERING CONTROL.

Action:

DEALERS WILL INSPECT THE DATE CODE ON THE RACK AND PINION STEERING GEAR, AND, IF NECESSARY, REPLACE THOSE RACK AND PINION ASSEMBLIES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. THE DATE CODES FOR WINDSTAR MODEL VEHICLES ARE 97JB09 OR 97JC08; THE DATE CODES FOR MUSTANG MODEL VEHICLES ARE 97J09B OR 97J08B.
1998 FORD MUSTANG
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:03/02/1998 - 03/04/1999
Potential Units Affected:898739

Defect Description:

VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR 5.0L ENGINES OR 1998-1999 RANGERS EQUIPPED WITH 2.5L, 3.0L FFV/EFI OR 4.0L ENGINES AND CRUISE CONTROL BUILT FROM JANUARY 5, 1998 THROUGH MARCH 4, 1999; 1998-1999 MUSTANGS EQUIPPED WITH 3.8L, 4.6L 2-VALVE OR 4-VALVE ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; 1999 F250/F350/F450/F550 (OVER 8,500 LBS.) TRUCKS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; AND 1999 F-53 STRIPPED CHASSIS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999. A CRUISE CONTROL CABLE CAN INTERFERE WITH THE SPEED CONTROL SERVO PULLEY AND NOT ALLOW THE THROTTLE TO RETURN TO IDLE WHEN DISENGAGING THE CRUISE CONTROL.

Consequence:

IF THE CRUISE CONTROL IS USED AND THIS CONDITION IS PRESENT, A STUCK THROTTLE COULD RESULT, WHICH COULD POTENTIALLY RESULT IN A CRASH.

Action:

DEALERS WILL REPLACE THE CRUISE CONTROL CABLES. AT THE PRESENT TIME, THE REPLACEMENT CABLES ARE NOT AVAILABLE. CUSTOMERS ARE BEING ADVISED NOT TO USE THE CRUISE CONTROL SYSTEM UNTIL A REPLACEMENT CAN BE MADE.
1998 FORD MUSTANG
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:08/04/1997 - 11/02/1997
Potential Units Affected:8000

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 4.6L ENGINES. SOME OF THESE VEHICLES HAS MISSING OR INADEQUATE BRAZE JOINTS BETWEEN THE FUEL RAIL BODY AND THE FUEL RAIL MOUNTING BRACKET(S).

Consequence:

IF THE BRACKET SEPARATES FROM THE RAIL, THE RAIL CAN LIFT ONE OR MORE OF THE INJECTORS, AND FUEL LEAKAGE WILL RESULT. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Action:

DEALERS WILL REPLACE THE FUEL RAIL ON THESE VEHICLES.
1998 FORD NAVIGATOR
NHTSA Campaign ID:EXTERIOR LIGHTING
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:20637

Defect Description:

VEHICLE DESCRIPTION: MINI VANS, LIGHT PICKUP TRUCKS, AND SPORT UTILITY VEHICLES. OFF LEASE CANADIAN VEHICLES EQUIPPED WITH DAYTIME RUNNING LIGHTS WHICH MEET CANADIAN REQUIREMENTS AND NOT THE PHOTOMETRIC REQUIREMENTS OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." ACCORDING TO FORD, THE VEHICLES WERE IMPORTED INTO THE U.S. ERRONEOUSLY.

Consequence:

THE LIGHT GIVEN OFF FROM THE DAYTIME RUNNING LIGHTS IS BRIGHTER THAN ALLOWED BY U.S. STANDARDS.

Action:

DEALERS WILL BE ADVISED TO DEACTIVATE THE RUNNING LIGHT FUNCTION AND TO COMPLETE ANY OUTSTANDING SAFETY RECALLS ON THESE VEHICLES.
1998 FORD RANGER
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:08/05/1997 - 09/19/1997
Potential Units Affected:2000

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH 4.0L ENGINES. THE FLEXIBLE SECTION OF THE CHASSIS MOUNTED FUEL LINE THAT CONNECTS TO THE ENGINE WAS ROUTED TOO CLOSE TO THE EXHAUST MANIFOLD. THE LINE COULD CONTACT THE MANIFOLD.

Consequence:

THIS COULD POTENTIALLY RESULT IN DAMAGE TO THE FUEL LINE, OR IN SOME CASES, CAUSE A FUEL LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Action:

DEALERS WILL INSTALL AN ADDITIONAL CLIP TO HOLD THE FUEL LINE IN THE INTENDED DESIGN POSITION.
1998 FORD RANGER
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:12/02/1997 - 12/16/1998
Potential Units Affected:326

Defect Description:

VEHICLE DESCRIPTION: ELECTRIC VEHICLES. THE TRANSAXLE MAY HAVE BEEN MANUFACTURED WITH THE PARK DETENT SPRING MISALIGNED. IF THE SPRING IS MISALIGNED, THE PARK MECHANISM MAY NOT ENGAGE WHEN THE SHIFT LEVER IS PLACED IN THE PARK POSITION.

Consequence:

IF THE PARK MECHANISM DOES NOT ENGAGE AND THE VEHICLE OPERATOR HAS NOT APPLIED THE PARKING BRAKE, THE VEHICLE COULD ROLL FREE AS IF IN NEUTRAL.

Action:

DEALERS WILL INSPECT THE TRANSAXLE AND ANY WITH MISALIGNED PARK DETENT SPRINGS WILL BE REPLACED.
1998 FORD RANGER
NHTSA Campaign ID:EQUIPMENT:OTHER:LABELS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:05/28/1997 - 01/15/1998
Potential Units Affected:11500

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY FOUR-WHEEL DRIVE PICKUP TRUCKS EQUIPPED WITH OFF-ROAD OPTION. THE TIRE AND RIM IDENTIFICATION INFORMATION IS INCORRECT ON THESE VEHICLES. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Consequence:

THE 16" TIRES COULD NOT BE INFLATED ON THE SPECIFIED 15X7.0J RIM.

Action:

OWNERS WILL BE SENT A SAFETY CERTIFICAITON LABEL PARTIAL OVERLAY WHICH WILL CONTAIN THE CORRECT RIM SIZE, AND INSTRUCTIONS FOR AFFIXING THIS LABEL TO THE VEHICLE. IF AN OWNER SO DESIRES, THEIR FORD DEALER CAN INSTALL THE LABEL FOR THEM.
1998 FORD RANGER
NHTSA Campaign ID:TIRES:TREAD/BELT
Manufacturer:BRIDGESTONE/FIRESTONE, INC.
Manufacture Dates: -
Potential Units Affected:14400000

Defect Description:

TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.

Consequence:

IF THE TREAD SEPARATES FROM THE TIRE, THE DRIVER CAN LOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH CAUSING INJURY OR DEATH.

Action:

THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON AUGUST 29, 2001. HOWEVER, CUSTOMERS SHOULD CONTACT FIRESTONE CUSTOMER SERVICE AT 1-800-465-1904 FOR POSSIBLE ASSISTANCE.
1998 FORD RANGER
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:04/08/1997 - 08/27/2002
Potential Units Affected:3600000

Defect Description:

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

THIS COULD RESULT IN AN UNDERHOOD FIRE.

Action:

DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1998 FORD RANGER
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:01/05/1998 - 03/04/1999
Potential Units Affected:898739

Defect Description:

VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR 5.0L ENGINES OR 1998-1999 RANGERS EQUIPPED WITH 2.5L, 3.0L FFV/EFI OR 4.0L ENGINES AND CRUISE CONTROL BUILT FROM JANUARY 5, 1998 THROUGH MARCH 4, 1999; 1998-1999 MUSTANGS EQUIPPED WITH 3.8L, 4.6L 2-VALVE OR 4-VALVE ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; 1999 F250/F350/F450/F550 (OVER 8,500 LBS.) TRUCKS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; AND 1999 F-53 STRIPPED CHASSIS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999. A CRUISE CONTROL CABLE CAN INTERFERE WITH THE SPEED CONTROL SERVO PULLEY AND NOT ALLOW THE THROTTLE TO RETURN TO IDLE WHEN DISENGAGING THE CRUISE CONTROL.

Consequence:

IF THE CRUISE CONTROL IS USED AND THIS CONDITION IS PRESENT, A STUCK THROTTLE COULD RESULT, WHICH COULD POTENTIALLY RESULT IN A CRASH.

Action:

DEALERS WILL REPLACE THE CRUISE CONTROL CABLES. AT THE PRESENT TIME, THE REPLACEMENT CABLES ARE NOT AVAILABLE. CUSTOMERS ARE BEING ADVISED NOT TO USE THE CRUISE CONTROL SYSTEM UNTIL A REPLACEMENT CAN BE MADE.
1998 FORD RANGER EV
NHTSA Campaign ID:POWER TRAIN:DRIVELINE:DRIVESHAFT
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:10/27/1997 - 07/25/2000
Potential Units Affected:1260

Defect Description:

VEHICLE DESCRIPTION: ELECTRIC LIGHT DUTY PICKUP TRUCKS. IF THE TRANSAXLE ATTACHING BOLTS BEGIN TO LOOSEN, THE DRIVER COULD NOTICE A JERKING MOTION AND/OR A CLUNKING SOUND. IF NOT SERVICED PROMPTLY, ALL NINE BOLTS COULD ULTIMATELY FALL OUT OR FRACTURE AND THE TRANSAXLE COULD DROP. IF THE TRANSAXLE DROPS, THE VEHICLE MAY NO LONGER BE IN THE GEAR INDICATED.

Consequence:

IF THIS OCCURS, THE SHIFT LEVER COULD BE PUT INTO "PARK" AND THE VEHICLE WOULD STILL BE FREE TO ROLL AS IF IN "NEUTRAL," INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL REPLACE THE MOUNTING BOLTS WITH LONGER BOLTS THAT INCLUDE A THREAD LOCK MATERIAL. WHEN INSTALLED, THE NEW BOLTS WILL BE TIGHTENED TO A HIGHER TORQUE. OWNER NOTIFICATION BEGAN MAY 8, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
1998 FORD RANGER EV
NHTSA Campaign ID:ELECTRICAL SYSTEM:BATTERY:CABLES
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:12/01/1997 - 04/01/1998
Potential Units Affected:26

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY ELECTRIC PICKUP TRUCKS EQUIPPED WITH THE OPTIONAL TRACTION BATTERY HEATER SYSTEM. THIS BATTERY HEATER COULD HAVE A LOOSE CRIMP CONNECTION WHERE THE POWER WIRES ARE ATTACHED TO ONE OF THE HEATER ELEMENTS.

Consequence:

THE LOOSE CONNECTION COULD ARC IGNITING SURROUNDING MATERIALS.

Action:

DEALERS WILL DISABLE THE BATTERY PACK HEATERS.
1998 FORD TAURUS
NHTSA Campaign ID:EXTERIOR LIGHTING:HEADLIGHTS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:06/09/1997 - 02/12/1998
Potential Units Affected:571800

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TEXT AND/OR GRAPHICS FOR THE VEHICLE HEADLAMP AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES ARE NOT SUFFICIENTLY CLEAR. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence:

IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY BE CONFUSED BY THE AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES CAUSING THE HEADLAMPS TO BE IMPROPERLY AIMED.

Action:

OWNER GUIDES CONTAINING REVISED AIMING INSTRUCTIONS WILL BE MAILED TO OWNERS OF THESE VEHICLES.
1998 FORD TAURUS
NHTSA Campaign ID:SEAT BELTS:FRONT:ANCHORAGE
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:07/31/1998 - 08/07/1998
Potential Units Affected:7000

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL SEAT TRACKS. THE FRONT SEAT BELT BUCKLE ATTACHING STUD MAY HAVE BEEN IMPROPERLY HEAT TREATED. THIS HEAT TREATMENT MAY HAVE RESULTED IN CRACKS DEVELOPING IN THE STUD.

Consequence:

IF THE STUD IS CRACKED, IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.

Action:

DEALERS WILL REPLACE THE SEAT BELT BUCKLE MOUNTING BRACKET AND STUD ASSEMBLY.
1998 FORD WINDSTAR
NHTSA Campaign ID:STEERING:GEAR BOX:SHAFT SECTOR
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:09/10/1997 - 09/12/1997
Potential Units Affected:2250

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI-VANS. THE RACK AND PINION STEERING GEARS MAY HAVE DAMAGED INPUT SHAFT BEARINGS.

Consequence:

THIS CONDITION CAN INCREASE STEERING EFFORTS, AFFECTING STEERING CONTROL.

Action:

DEALERS WILL INSPECT THE DATE CODE ON THE RACK AND PINION STEERING GEAR, AND, IF NECESSARY, REPLACE THOSE RACK AND PINION ASSEMBLIES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. THE DATE CODES FOR WINDSTAR MODEL VEHICLES ARE 97JB09 OR 97JC08; THE DATE CODES FOR MUSTANG MODEL VEHICLES ARE 97J09B OR 97J08B.
1998 FORD WINDSTAR
NHTSA Campaign ID:SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:12/06/1996 - 05/31/1997
Potential Units Affected:174000

Defect Description:

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. MINI VANS SOLD DURING THE MONTHS OF DECEMBER 1996, AND JANUARY, FEBRUARY AND MAY 1997. FRONT BRAKE CALIPER ANCHOR PLATE TO HUB AND SPINDLE ASSEMBLY BOLTS MAY BE LOOSE AS A RESULT OF AN INCOMPLETE TIGHTENING OPERATION AT THE ASSEMBLY PLANT.

Consequence:

WHEN THE BOLTS ARE LOOSE, A NOTICEABLE NOISE AND/OR VIBRATION IS EVIDENT WHICH PROVIDES WARNING TO THE VEHICLE DRIVER. VEHICLE BRAKING IS NOT DEGRADED.

Action:

DEALERS WILL TIGHTEN THE FRONT BRAKE CALPIER ANCHOR PLATE BOLTS. OWNERS CAN CONTACT FORD AT 1-800-392-3673.
1998 FORD WINDSTAR
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:11/24/1996 - 03/01/1997
Potential Units Affected:100000

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AX4S AUTOMATIC TRANSAXLES. THE LOW/INTERMEDIATE SERVO COVER CAN SEPARATE FROM THE TRANSAXLE WHILE THE VEHICLE IS BEING DRIVEN. IF THIS OCCURS, TRANSMISSION FLUID WILL LEAK CONTACTING THE CATALYTIC CONVERTER.

Consequence:

THE CATALYTIC CONVERTER TEMPERATURE MAY BE HOT ENOUGH TO IGNITE THE TRANSMISSION FLUID AND CAUSE A VEHICLE FIRE.

Action:

DEALERS WILL INSPECT THE TRANSMISSION AND REPLACE THESE SERVO COVERS.
1998 FORD WINDSTAR
NHTSA Campaign ID:STRUCTURE:BODY
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:15900

Defect Description:

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: MINIVANS. THE OVERHEAD CONSOLE REAR RETAINING BRACKET CAN DEVELOP CRACKS AND SEPARATE, ALLOWING THE OVERHEAD CONSOLE TO BECOME LOOSE AND POSSIBLY FALL DOWN.

Consequence:

IF THE CONSOLE DOES FALL DOWN, IT COULD DISTRACT THE DRIVER OR POSSIBLY STRIKE A FRONT SEAT OCCUPANT.

Action:

DEALERS WILL INSTALL A REDESIGNED RETAINING BRACKET IN THE SAME LOCATION AS THE ORIGINAL RETAINING BRACKET.
1998 FORD WINDSTAR
NHTSA Campaign ID:SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:09/01/2007 - 07/03/2003
Potential Units Affected:492650

Defect Description:

FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997 THROUGH FEBRUARY 28, 2003 AND CURRENTLY REGISTERED OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. AFTER MANY YEARS OF VEHICLE SERVICE IN THESE AREAS, CORROSION CAN WEAKEN THE REAR AXLE, MAKING IT SUSCEPTIBLE TO TORSIONAL STRESS. CORROSION AND STRESS CAN LEAD TO CRACKS WHICH IF UNDETECTED CAN PROPAGATE AND RESULT IN A COMPLETE FRACTURE OF THE AXLE.

Consequence:

A FRACTURED AXLE CAN AFFECT VEHICLE HANDLING AND INCREASE THE RISK OF A CRASH.

Action:

AS PARTS BECOME AVAILABLE, DEALERS WILL INSPECT AND IF NECESSARY INSTALL THE REAR AXLE REINFORCEMENT BRACKETS FREE OF CHARGE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 20, 2010. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
1998 FORD WINDSTAR
NHTSA Campaign ID:EXTERIOR LIGHTING
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:20637

Defect Description:

VEHICLE DESCRIPTION: MINI VANS, LIGHT PICKUP TRUCKS, AND SPORT UTILITY VEHICLES. OFF LEASE CANADIAN VEHICLES EQUIPPED WITH DAYTIME RUNNING LIGHTS WHICH MEET CANADIAN REQUIREMENTS AND NOT THE PHOTOMETRIC REQUIREMENTS OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." ACCORDING TO FORD, THE VEHICLES WERE IMPORTED INTO THE U.S. ERRONEOUSLY.

Consequence:

THE LIGHT GIVEN OFF FROM THE DAYTIME RUNNING LIGHTS IS BRIGHTER THAN ALLOWED BY U.S. STANDARDS.

Action:

DEALERS WILL BE ADVISED TO DEACTIVATE THE RUNNING LIGHT FUNCTION AND TO COMPLETE ANY OUTSTANDING SAFETY RECALLS ON THESE VEHICLES.
1998 FORD WINDSTAR
NHTSA Campaign ID:SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:06/16/1996 - 05/31/1999
Potential Units Affected:789723

Defect Description:

VEHICLE DESCRIPTION: MINIVANS. THE BRAKE FLUID MASTER CYLINDER IS RECESSED AND ORIENTED IN THE ENGINE COMPARTMENT SO THAT THE BRAKE FLUID WARNING STATEMENT EMBOSSED ON BOTH THE TOP OF THE FILLER CAP AND THE SIDE OF THE RESERVOIR BODY ARE NOT ENTIRELY VISIBLE BY DIRECT VIEW. THESE VEHICLES MAY NOT FULLY COMPLY WITH REQUIREMENTS OF FMVSS NO. 135, "PASSENGER CAR BRAKE SYSTEMS."

Consequence:

Action:

OWNERS WILL BE PROVIDED WITH NEW LABELS AND INSTALLATION INSTRUCTIONS.
1998 FORD WINDSTAR
NHTSA Campaign ID:POWER TRAIN:AXLE ASSEMBLY
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:09/01/1997 - 07/03/2003
Potential Units Affected:27000

Defect Description:

FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997, THROUGH JULY 3, 2003, AND CURRENTLY REGISTERED OR ORIGINALLY SOLD IN VIRGINIA. OVER TIME, CORROSION CAN WEAKEN THE REAR AXLE MAKING IT SUSCEPTIBLE TO TORSIONAL STRESS. CORROSION AND STRESS CAN LEAD TO CRACKS WHICH, IF UNDETECTED, CAN INCREASE AND RESULT IN A COMPLETE FRACTURE OF THE AXLE.

Consequence:

A FRACTURED AXLE CAN AFFECT VEHICLE HANDLING AND INCREASE THE RISK OF A CRASH.

Action:

FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND INSTALL REAR AXLE REINFORCEMENT BRACKETS, OR REPLACE THE AXLES, AS NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2012. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
1998 FORD WINDSTAR
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:06/16/1995 - 10/24/2002
Potential Units Affected:4500000

Defect Description:

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Action:

FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1998 FORD WINDSTAR
NHTSA Campaign ID:CHILD SEAT
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:01/20/1997 - 01/29/1997
Potential Units Affected:202

Defect Description:

VEHICLE DESCRIPTION: MINIVAN EQUIPPED WITH SECOND ROW BENCH SEATS WITH OPTIONAL INTEGRATED CHILD SEAT (ICS). THE HEADREST LOCKOUT MECHANISM ON THE SEATS MAY NOT ENGAGE AND LOCK THE HEADRESTS IN THE "DOWN" POSITION, AS INTENDED, WHEN THE ICS IS DEPLOYED. A VEHICLE OCCUPANT COULD MOVE THE HEADREST TO THE "UP" POSITION.

Consequence:

AS A RESULT OF THE HEADREST BEING IN THE "UP" POSITION, A CHILD SEATED IN THE ICS WOULD RECEIVE LESS THAN THE INTENDED PROTECTION IN THE CHILD HEAD AREA IN THE EVENT OF A CRASH.

Action:

THE SECOND ROW BENCH SEATS HAVE BEEN REPLACED WITH SEATS BUILT WITH REVISED HEADREST LOCKOUT MECHANISMS.
1998 FORD WINDSTAR
NHTSA Campaign ID:SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY
Manufacturer:Ford Motor Company
Manufacture Dates:09/02/1997 - 07/03/2003
Potential Units Affected:283413

Defect Description:

Ford Motor Company (Ford) is recalling certain model year 1998-2003 Windstar vehicles manufactured September 2, 1997, to July 3, 2003. The affected vehicles were previously remedied to safeguard against the rear axle cracking from corrosion, however, the remedy brackets may have been misinstalled. The incorrect bracket installations may limit the effectiveness of the service repair for NHTSA recalls 10V-385, 12V-193, and 12V-195.

Consequence:

If the brackets were not installed properly, the rear axle may fracture, affecting the vehicle handling and increasing the risk of a crash.

Action:

Ford will notify owners, and dealers will inspect the brackets to verify their proper installation. If a bracket is found to have been misinstalled, the rear axle will be replaced. These repairs will be performed free of charge. The began on October 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S27.
1998 FORD WINDSTAR
NHTSA Campaign ID:SUSPENSION:FRONT:SPRINGS:COIL SPRINGS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:08/28/1996 - 07/03/1998
Potential Units Affected:198583

Defect Description:

ON CERTAIN MINIVANS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS COULD FRACTURE AS A RESULT OF CORROSION. DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.

Consequence:

SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.

Action:

DEALERS WILL INSTALL PROTECTIVE SHIELDS AROUND THE FRONT COIL SPRINGS. OWNER NOTIFICATION BEGAN SEPTEMBER 6, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
1998 FORD WINDSTAR
NHTSA Campaign ID:SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:9192

Defect Description:

FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997, THROUGH JULY 3, 2003, REGISTERED IN PUERTO RICO. DUE TO INCREASED STRESSES CAUSED BY HIGH CYCLES OF TORSIONAL LOADING, SPECIFIC TO THIS MARKET, THE REAR AXLE CAN CRACK.

Consequence:

A FRACTURED AXLE MAY RESULT IN A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Action:

FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND INSTALL A REINFORCEMENT BRACKET ON THE REAR AXLE OR REPLACE THE AXLES, AS NECESSARY. THIS SERVICE WILL BE PROVIDED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 1, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
1998 FORD WINDSTAR
NHTSA Campaign ID:SUSPENSION:FRONT:SPRINGS:COIL SPRINGS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:12/13/1993 - 07/03/1998
Potential Units Affected:948492

Defect Description:

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1995-1998 FORD WINDSTAR MINIVANS. THE FRONT COIL SPRINGS COULD POTENTIALLY FRACTURE DUE TO CORROSION. NOTE: THE 1997-1998 WINDSTAR MINI VANS ARE ALSO COVERED BY NHTSA SAFETY RECALL 01V-199/FORD RECALL 01S19. THE MINI VANS COVERED BY THE SAFETY RECALL WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA.

Consequence:

SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.

Action:

FORD IS EXTENDING THE WARRANTY FOR FRONT COIL SPRING REPLACEMENT TO A TOTAL OF 10 YEARS OF SERVICE FROM THE WARRANTY START DATE, WITH UNLIMITED MILEAGE. THIS COVERAGE IS AUTOMATICALLY TRANSFERRED TO SUBSEQUENT OWNERS AT NO CHARGE. IF EITHER FRONT COIL SPRING FRACTURES DURING THE COVERAGE PERIOD NOTED ABOVE, THE DEALER WILL REPLACE BOTH SPRINGS AT NO CHARGE TO THE OWNER.