Ford Buyers Guide

 

Click a car name to see the crash test details for that model.

 

 

 

Crash Test Data for 1997 Ford

Ford Vehicle Front Star Rating Side Star Rating Rollover Resistance Rating
Driver Passenger Front Seat Rear Seat
1997 AerostarNot
Tested
Not
Tested
Not
Tested
1997 AspireNot
Tested
Not
Tested
Not
Tested
1997 Club WagonNot
Tested
Not
Tested
Not
Tested
1997 ContourNot
Tested
1997 Crown VictoriaNot
Tested
1997 EconolineNot
Tested
Not
Tested
Not
Tested
1997 EscortNot
Tested
1997 ExpeditionNot
Tested
Not
Tested
Not
Tested
1997 ExplorerNot
Tested
Not
Tested
Not
Tested
1997 F-150Not
Tested
Not
Tested
Not
Tested
1997 MustangNot
Tested
Not
Tested
Not
Tested
1997 MustangNot
Tested
Not
Tested
Not
Tested
1997 ProbeNot
Tested
Not
Tested
Not
Tested
1997 RangerNot
Tested
Not
Tested
Not
Tested
1997 TaurusNot
Tested
1997 ThunderbirdNot
Tested
1997 WindstarNot
Tested
Not
Tested
Not
Tested

 

Service Bulletins for 1997 Ford

1997 FORD AEROMAX
Bulletin Number: 02169
SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE DEVELOPED FOR DIAGNOSING AND CORRECTING VEHICLE LEAN. *TT
Bulletin Number: 11755
SOME VEHICLES WITH THE CATERPILLAR 3306 ENGINE MAY EXHIBIT THE LOWER RADIATOR HOSE BEING DISCONNECTED FROM THE ENGINE WATER PUMP OUTLET. *TT
Bulletin Number: 8164
INFORMATION ON 5R55E - 4R55E - 4R44E PUMP ALIGNMENT TOOLS. *TT
Bulletin Number: 962216
STEP PLATE - FUEL TANK STEP PLATE VIBRATES - VEHICLES BUILT THROUGH 10/1/96 EQUIPPED WITH 70 AND/OR 120 GALLON REAR-MOUNTED CYLINDRICAL FUEL TANKS WITH TANK-MOUNTED STEP PLATE. *TW
Bulletin Number: 962419
HOOD GRILLE OPENING PANEL - CRACK AT TOP LEFT AND RIGHT CORNERS - VEHICLES BUILT FROM 11/1/95 THROUGH 4/1/96. *TW
Bulletin Number: 96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
Bulletin Number: 97010510638
THE VERTICAL EXHAUST HEAT SHIELD MAY EXHIBIT CRACKING AROUND ITS MOUNTING BOLT HOLE. *YC
Bulletin Number: 97050110609
VEHICLES EQUIPPED WITH THE FD 1460 ENGINE MAY EXHIBIT REAR ENGINE SUPPORT BRACKET ATTACHING BOLTS LOSSENING. *TW
Bulletin Number: 97050110626
THE CENTER SUPPORT BAR TO THE OPTIONAL BUG/DIRT SCREEN MAY CRACK AT EITHER END. *TW
Bulletin Number: 970902971813
UNDER CERTAIN CONDITIONS, ROAD SPLASH AND SPRAY MAY BUILD UP ON THE CAB SIDE WINDOWS. *YC
Bulletin Number: 970902971815
SOME VEHICLES FAN CLUTCH MAY CYCLE ON WHEN ELECTRICAL ACCESSORIES, SUCH AS TURN SIGNALS, HEADLAMPS, ETC. ARE ACTIVATED. *YC
Bulletin Number: 970902971816
THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY WEAR AND/OR COME OFF ON SOME VEHICLES EQUIPPED WITH A DETROIT DIESEL ENGINE AND AIR CONDITIONING. *YC
Bulletin Number: 970902971817
SOME ELECTRONICALLY CONTROLLED DIESEL ENGINES CAN BE MODIFIED TO INCREASE ENGINE OUTPUT BY ALTERING THE ORIGINAL ENGINE MANAGEMENT SYSTEM. *YC
Bulletin Number: 97119
NOISE- AIR LEAK FROM BEHIND INSTRUMENT- PANEL- VEHICLES BUILT THROUGH 10/21/96. *JD
Bulletin Number: 97217
DOORS - BATTERY ACCESS DOORS MAY COME LOOSE - NEW PART AVAILABILITY - VEHICLES BUILT THROUGH 9-96. *TW
Bulletin Number: 97412
COOLING SYSTEM- ENGINE COOLING FAN CRACKS AT CENTER HUB. *JD
Bulletin Number: 97517
ENGINE- DIESEL- FD1060 AND FD1460- WHITE SMOKE FROM EXHAUST- SERVICE TIP. *JD
Bulletin Number: 97518
FRONT END ACCESSORY DRIVE BELT (FEAD)- FEAD BELT MAY WEAR AND/OR COME OFF- VEHICLES EQUIPPED WITH FD1460 ENGINE BUILT THROUGH 12/96. *JD
Bulletin Number: 97630
HARD STARTING- POSSIBLE PLUGGED CATALYTIC CONVERTER/MUFFLER (CCM)- VEHICLES BUILT AFTER 11/29/93 EQUIPPED WITH 1994 EMISSION LEVEL FD1060 OR FD1460 DIESEL ENGINE. *JD
Bulletin Number: 97715
SUN VISOR- OPTIONAL ROOF-MOUNTED SUN VISOR VIBRATES AT HIGHWAY SPEEDS. *JD
Bulletin Number: 97717
WIRING- WIRE HARNESS GROUND- INTERMITTENT OR OPEN. *JD
Bulletin Number: 9811333
ENGINEERING IS INVESTIGATING CONDITIONS ON THE HOOD SPRING CONTACTING THE HOOD CAUSING DAMAGE TO THE HOOD AND / OR INSULATION. *TT
Bulletin Number: 9811468
SOME MODELS WITH CAT C10/C12 ENGINES MAY EXHIBIT CRACKS IN THE ENGINE FRONT COVER, NEAR THE FAN HUB PULLEY SUPPORT MOUNTING CONTAC STUDS. *TT
Bulletin Number: 98157
FRONT ENGINE COVER CRACKS. YD
Bulletin Number: 98162
HARD TO MOVE THE HOOD UP AND DOWN.*AK
Bulletin Number: 98201
INTERMITTENT ELECTRICAL ISSUES, SUCH AS DASH LIGHTS FLASHING WHEN THE TURN SIGNAL IS ACTIVATED MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 98202
THE POWER DISTRIBUTION BOX COVER IS NOW AVAILABLE. *YC
Bulletin Number: 982022
DELCO-REMY HAS MADE AVAILABLE A REVISED GENERATOR FOR SERVICE. *YC
Bulletin Number: 982023
HINGES AND HINGE SPRINGS ARE NOW AVAILABLE FOR SERVICE FOR THE OPTIONAL READY LINE ACCESS DOOR, BUTTERFLY DOORS OR TRANSVERSE ACCESS DOORS. *YC
Bulletin Number: 982115
A NEW SERVICE PARTS RELEASED. *YC
Bulletin Number: 982116
THE LOWER RADITTOR HOSE IS BEING PULLED OFF AT THE ENGINE WATER PUMP ON SOME VEHICLES. *YC
Bulletin Number: 982118
A NOISE HEARD DURING DRIVELINE TORQUE.
Bulletin Number: 98237
SOME VEHICLES EXPERIENCE HEATER SUPPLY TUBES THAT MAY CRACK AND/ OR LEAK COOLANT. *YC
Bulletin Number: 98243
CONCERNS REGARDING THE INSTRUMENT PANEL PLATE CRACKS AT PARKING BRAKE VALVE. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982520
SOME VEHICLES EQUIPPED WITH FRAME-MOUNTED VERTICAL MUFFLER SUPPORTS MAY EXHIBIT A CRACK ALONG THE PIPE BEND. *YC
Bulletin Number: 98257
CONCERNS WITH THE FRONT END ACCESSORY DRIVE BELT ( FEAD )-FEAD BELT MAY WEAR AND/OR COME OFF. *YC
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 98424
CONDITION WITH TIRES BEING LOWER THAN EXPECTED TIRE LIFE. *YC
Bulletin Number: 98425
DIAGNOSTIC INFORMATIN AND WIRING SCHEMATICS FOR BOTH THE HORTON AND KYSOR ENGINE COOLING FAN CLUTCHES. *YC
Bulletin Number: 98518
THE OIL LEVEL INDICATOR MAY BE DIFFICULT TO INSTALL AND/OR WHEN INSTALLED MAY CONTACT THE CRAKSHAFT ON SOME VEHICLES. *YC
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 98711
INFORMATION ON AVAILABILITY OF REVISED COOLANT LEVEL SENSOR. *YC
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99205
SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE. *TT
Bulletin Number: 9944
PROCEDURES ON REPAIRING BROKEN RADIATOR COOLANT SUPPLY TANK VENT HOSE NIPPLES. *TT
Bulletin Number: BC0193970201
REVISED FAN ASSEMBLIES FOR PREMIUM DIESEL ENGINES ARE NOW AVAILABLE. *JD
Bulletin Number: BC0200970201
DASH MOUNTED AIR VALVE ASSEMBLIES, BASE PART #4484, MAY LEAK AIR. NEW VALVE PART. *JD
Bulletin Number: BC0205970201
VEHICLES EQUIPPED WITH THE CUMMINS ELECTRONIC ENGINE THE TACHOMETER MAY BE INOPERATIVE OR ERRATIC. *JD
Bulletin Number: BC0323961101
TACHOMETER INOPERATIVE. *TW
Bulletin Number: BC0323970201
TACHOMETER INOPERATIVE. *JD
Bulletin Number: BC0323972301
TACHOMETER INOPERATIVE. *JD
Bulletin Number: BC0480961113
REPLACEMENT LEVELING VALVE EXTENTION ROD FOR HENDRICKSON AIR-RIDE SUSPENSION. *TW
Bulletin Number: BC0756961017
INFORMATION WHEN TROUBLESHOOTING THE SPEEDOMETER & TACHOMETER. *TT
Bulletin Number: BC0831961009
BATTERY ACCESS PANEL MAY BECOME LOOSE. *TT
Bulletin Number: BC0840961008
COOLANT TEMP GAUGE MAY READ ON THE HIGH OR HOT SIDE OF NORMAL, CAUSED BY LOCATION OF COOLANT TEMP SENSOR. *TT
Bulletin Number: BC1009097020
VEHICLES EQUIPPED WITH THE CUMMINS ELECTRONIC ENGINE THE TACHOMETER MAY BE INOPEATIVE OR ERRATIC. *JD
Bulletin Number: BC1018797230
DIAGNOSE THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD
Bulletin Number: BC1022997230
IF ONE OF THE FOLLOWING SYMPTOMS IS REPROTED ON A VEHICLE EQUIPPED WITH AN ELECTRONIC ENGINE PLEASE CONTACT FORD HEAVY TRUCKS: INTERMITTENT SPEEDOMETER OR SPEED CONTROL FUNCTIONS. *JD
Bulletin Number: BC1026897020
THE DIPSTICK RUBBING AGAINST THE ENGINE CRANKSHAFT. *JD
Bulletin Number: BC1031997020
VEHICLES EQUIPPED WITH THE HENDRICKSON AIR SUSPENSION, IT MAY BE DIFFICULT TO MAINTAIN THE CORRECT VEHICLE RIDE HEIGHT DUE TO THE CURRENT MOUNTING OF THE AIR LEVELING VALVE. *JD
Bulletin Number: BC2234970501
VEHICLES MAY EXHIBIT REAR ENGINE SUPPORT BRACKET ATTATCHING BOLTS LOOSENING. *TW
Bulletin Number: BC2444970501
VEHICLES EQUIPPED WITH CUMMINS M-11 AND N-14 SELECT PLUS ENGINES MAY EXHIBIT THE AIR OPERATED COOLING FAN RUNNING CONTINUOUSLY IF THE ENGINE ECM FAN CONTROL PARAMETERS ARE SET INCORRECTLY. *TW
Bulletin Number: BC3093970225
A/C COMPRESSOR DRIVE BELT OR ALTERNATOR DRIVE BELT ROLLING OFF DRIVE PULLEYS. *TW
Bulletin Number: BC3157970219
FEAD BELT MAY OR ROLL OFF - VEHICLES EQUIPPED WITH FD 1460 ENGINE. *TW
Bulletin Number: BC3163970218
VEHICLES EQUIPPED WITH HENDRICKSON HAS SUSPENSION - MAY BE DIFFICULT TO MAINTAIN CORRECT VEHICLE RIDE HEIGHT. *TW
Bulletin Number: BC3202970214
VEHICLES EQUIPPED WITH POWER STEERING AND A BUG/DIRT SCREEN - THE SCREEN MAY CONTACT THE POWER STEERING COOLER ON THE PASSENGER SIDE CAUSING A NOISE CONCERN AND OVER TIME, MAY WEAR A HOLE IN THE POWER STEERING COOLER, RESULTING IN A FLUID L
Bulletin Number: BC3222970212
CONCERN WITH LOWER ROOF AIR DEFLECTOR SUPPORT BRACKETS. *TW
Bulletin Number: BC3223970212
VEHICLES EQUIPPED WITH DETROIT DIESEL ENGINES MAY EXPERIENCE A CONCERN WITH ENGINE WARNING LAMPS COMING ON INTERMITTENTLY. *TW
Bulletin Number: BC3235970211
FD 1060 ENGINES - DIPSTICK RUBBING AGAINST CRANKSHAFT. *TW
Bulletin Number: BC3275970207
INOPERATIVE HORN OR HORN OPERATES EVEN THOUGH NOT PUSHED. *TW
Bulletin Number: BC3278970207
AIR CONDITIONING COMPRESSOR BELT MAY COME OFF DRIVE PULLY. *TW
Bulletin Number: BC3350972301
ENGINE DERATE (REDUCTION IN ENGINE-POWER) POSSIBLY INTERMITTENT- INTERMITTEN SPEEDOMETER OR SPEED CONTROL FUNCTION. *JD
Bulletin Number: BC3505972301
THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD
Bulletin Number: BC5189961001
INFORMATION ON TROUBLESHOOTING THE SPEEDOMETER & TACHOMETER. *TT
Bulletin Number: BC5193961001
PROCEDURE FOR AIR SUSPENSION LIGHT ON. *TT
1997 FORD AEROSTAR
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 01124
ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01197
SOME VEHICLES EQUIPPED WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / ONNECTING ROD BEARING KNOCK. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 02138
LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
Bulletin Number: 0282
SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. *TT
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 13118
SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT
Bulletin Number: 13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
Bulletin Number: 15887
SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). *TT
Bulletin Number: 5518
INFORMATION ON SERVICING OIL PAN GASKET LEAKS. *TT
Bulletin Number: 6896
SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT
Bulletin Number: 6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
Bulletin Number: 8164
INFORMATION REGARDING PUMP ALIGNMENT TOOLS. **MR
Bulletin Number: 870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
Bulletin Number: 96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
Bulletin Number: 962215
FLUID - NEW MERCON V REQUIRED - TRANSMISSION - 4R44E - DESCRIPTION OF FEATURES AND MAJOR COMPONENTS. *TW
Bulletin Number: 96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
Bulletin Number: 96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
Bulletin Number: 96226
AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW
Bulletin Number: 962410
TRANSMISSION - E40D - 4R70W - 4R44E - 5R55E - NEW DIGITAL TRANSMISSION RANGE SENSOR - DIAGNOSIS SERVICE TIP. *TW
Bulletin Number: 96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
Bulletin Number: 96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
Bulletin Number: 962511
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 962617
BRAKES - BRAKE SERVICE - SERVICE TIPS. *TW
Bulletin Number: 97050110607
ENGINEERING IS INVESTIGATING CONCERNS OF THE REAR ABS LIGHT COMING ON WHEN THE IGNITION IS IN THE ON POSITION.
Bulletin Number: 97090297189
EXPERIENCING A "THUMPING" NOISE OR TEMPEATURE GAUGE FLUCTATION WITH SOME VEHICLES. *YC
Bulletin Number: 97111097234
VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC
Bulletin Number: 9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD
Bulletin Number: 9747
FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD
Bulletin Number: 97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
Bulletin Number: 97610
BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD
Bulletin Number: 97623
BATTERY- DISCHARGED- VEHICLES BUILT THROUGH 2/14/97. *JD
Bulletin Number: 9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
Bulletin Number: 97716
FUEL INJECTION PUMP- BOSCH- SERVICE INFORMATION FOR FD1060/1460 DIESEL ENGINES. *JD
Bulletin Number: 98112
SUBJECT REGARDING A NEW SERVICE CENTER SUPPORT THAT USES A THRUST BEARING (#3 AND #4) IN PLACE OF THRUST WASHERS HAS BEEN RELEASED. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982312
ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98233
CONCERNS WITH FRONT DRIVE AXLE FLUID MAY LEAK OUT OF THE VENT UNDER SOME DRIVING MODES ON SOME VEHICLES. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 983080
INFORMATION REGARDING TRANSFER CASE REAR HOUSING AND DRIVESHAFT REPLACEMENT. *TT
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 9832
FRONT AND REAR BUMPERS MADE OF XENOY PLASTIC HAVE HAD THE CONDUCTIVE PRIMER REMOVED FROM SERVICE PARTS. *YC
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 9844
SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 98514
CONCERNS WITH A WHISTLING OR HISSING NOISE FROM THE MAIN CONTROL AREA OCCURING WHILE IDLING IN DRIVE AND / OR REVERSE ON SOME VEHICLES. *TT
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 985A52
THIS BULLETIN CONTAINS SERVICE TIPS WHEN SERVICING ANY BRAKE RELATED ROUGHNESS / PULL CONCERNS. *TT
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9868
A ROUGH IDLE, STALLING AT AN IDLE AND/OR DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0174, AND/OR P1151 MAY BE STORED IN MEMORY ON SOME VEHICLES WITH A 4.OL ENGINE. *YC
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99183
SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99235
DURING EXTREME COLD AMBIENT TEMPERATURES AND UNDER CERTAIN DRIVING CONDITIONS, MOISTURE IN THE CRANKCASE MAY ENTER THE PCV SYSTEM, FREEZE AND CAUSE PRESURE IN THE ENGINE CRANKCASE. THE PCV FITTING IN THE UPPER INTAKE MANIFOLD MAY FREEZE OR
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: BC0191970201
VEHICLE ELECTRICAL SYSTEM, SEVERAL MEGAFUSES ARE USED. NOW HAS A NEW PLASTIC COVER. *JD
Bulletin Number: BC0324961101
COLD ENGINE KNOCK/TICK NOISE. *TW
Bulletin Number: BC0324970201
COLD ENGINE KNOCK/TICK NOISE. *JD
Bulletin Number: BC0344961127
1996-1997 AEROSTAR INTERIOR TRIM PANELS ARE OCCASIONALLY BEING REPORTED WITH ISSUES OF DAMAGE/DELAMINATION/HOLES. *TW
Bulletin Number: BC0344972301
INTERIOR TRIM PANELS ARE OCCASIONALLY BEING REPORTED WITH ISSUES OF DAMAGE/DELAMINATION/HOLES. *JD
Bulletin Number: BC0407961115
INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED PARTS. *TW
Bulletin Number: BC0490961112
INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED COMPONENT. *TW
Bulletin Number: BC1018997230
BLOCK HEATERS MAY EXPERIENCE COOLANT LEAKS DUE TO INTERFERENCE WITH THE BLOCK. *JD
Bulletin Number: BC1019797230
THE VEHICLES WILL SHIFT 1,2,3,4,5 REGARDLESS OF THROTTLE POSITION. *JD
Bulletin Number: BC1019997230
4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPNIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSES WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD
Bulletin Number: BC1028597020
DISCHARGED BATTERIES ON 97 AEROSTARS MAY BE CAUSED BY AN INTERMITTENT ELECTRICAL DRAW THAT MAY BE DIFFICULT T DUPLICATE. *JD
Bulletin Number: BC105979705
UPDATE INFORMATION FOR 1997 4R44E AND 5R55E TRANSMISSIONS - THERE ARE TWO (2) DIFFERENT SIZE DIRECT CLUTCH STEEL PLATES WHEN SERVICING 4R44E OR 5R55E TRANSMISSIONS. *TW
Bulletin Number: BC2226970501
SERVICING TIP - TRANSMISSION - THERE ARE TWO DIFFERENT SIZE DIRECT CLUTCH STEEL PLATES WHEN SERVICING 4R44E OR 5R55E TRANSMISSIONS. *TW
Bulletin Number: BC2232970501
ENGINEERING IS INVESTIGATING CONDITIONS THAT CAUSE THE ABS LIGHT (RABS) TO ILLUMINATE. *TW
Bulletin Number: BC2394970501
THE AIR OPERATED COOLING FAN MAYU RUN CONTINUOUSLY IF THE ENGINE ECM FAN CONTROL PARAMETERS ARE SET INCORRECTLY. *TW
Bulletin Number: BC2431970501
AEROSTAR E4WD MODELS MAY EXPERIENCE FRONT AXLE LUBRICANT LEAKAGE FROM THE VENT TUBE UNDER SOME DRIVING CONDITIONS. *TW
Bulletin Number: BC2433970501
ENGINES MAY EXHIBIT A DRIVEABILITY CONCERN DESCRIBED AS A SURGE/BUCK/JERK OR HESITATION. *TW
Bulletin Number: BC3234970211
WINDSHIELD CRACKS. *TW
Bulletin Number: BC3244970210
FD 1460 ENGINES - NON-FUNCTIONING AIR INTAKE HEATERS - ENSURE THAT THE DIAGNOSTIC SWITCH IS IN OFF POSITION. *TW
Bulletin Number: BC3301970204
DISCHARGED BATTERIES MAY BE CAUSED BY INTERMITTENT ELECTRICAL DRAW DIFFICULT TO DUPLICATE. *TW
Bulletin Number: BC3441972301
AS OF 1/7/97 THE AUTOMATIC SHIFT LOCK FEATURE TAG THAT WAS AFFIXED AROUND THE GEAR SELECTOR, HAS BEEN DISCONTINUED FOR PRODUTION. *JD
Bulletin Number: BC3483972301
THE VEHICLE WILL SHIFT 1,2,3,4,5 REGARDLESS OF THROTTLE POSTION. *JD
Bulletin Number: BC3485972301
4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPANIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSE WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD
Bulletin Number: BC3491972301
SOME 4.0L ENGINES WITH BLOCK HEATERS MAY EXPERIENCE COOLANT LEAKS DUE TO INTERFERENCE WITH THE BLOCK. *JD
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC9666961001
2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT
Bulletin Number: BC9714961101
DIAGNOSTIC INSTRUCTIONS FOR SERVICING EVAPORATIVE EMISSION PURGE FLOW SYSTEM. *TW
1997 FORD ASPIRE
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 12196
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0300 STORED IN MEMORY. ENGINEERING IS INVESTIGATING. *TT
Bulletin Number: 12526
SOME VEHICLES MAY EXHIBIT REPEAT MISFIRE DIAGNOSTIC TROUBLE CODES P0300 - P0304 AFTER SSM 11543 (REPLACEMENT DISTRIBUTION VANE COVER) HAS BEEN PERFORMED. *TT
Bulletin Number: 12575
INFORMATION ON HEAD GASKET OIL & COOLANT PASSAGES. *TT
Bulletin Number: 5241
INFORMATION ON VEHICLES EXHIBITING A MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0300 STORED IN MEMORY. *TT
Bulletin Number: 5850
SUBJECT REGARDING REPEATED MISFIRE CODES - DTCS P0300 - P0304. *TT
Bulletin Number: 96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
Bulletin Number: 96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
Bulletin Number: 96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
Bulletin Number: 96227
NOISE - CLICK, CLUNK, RATTLE - MTX TRANSAXLE REVERSE GEAR. *TW
Bulletin Number: 96245
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION - DIAGNOSTIC TROUBLE CODE (DTC) P1794 STORED IN CONTINUOUS MEMORY - PROBE WITH 2.5L, ESCORT WITH 1.8L AND ASPIRE. *TW
Bulletin Number: 96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
Bulletin Number: 962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 96262
GLASS - DOOR GLASS WILL NOT ROLL DOWN. *TW
Bulletin Number: 97050110631
CUSTOMER CONCERNS OF MIL (MALFAUNCTION INDICATOR LAMP) AND DTC'S OF P0505 AND/ OR PO140. *YC
Bulletin Number: 9711
THE DOOR GLASS WINDOW MAY NOT ROLL DOWN ON SOME VEHICLES- THIS MAY BE DUE TO THE FOAM PAD BRACKET PULLING AWAY FROM THE DOOR SKIN. *JD
Bulletin Number: 97111097236
SOME VEHICLES AFTER A TRANSAXLE OVERHAUL MAY BE EXPERIENCE NO THIRD GEAR AND/OR REVERSE. *YC
Bulletin Number: 97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
Bulletin Number: 9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 983304
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ON AND CODES P0140 OR P0141 PRESENT WITH NO DRIVEABILITY CONCERNS. *TT
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9874
A NEW SILICONE GASKET AND SEALANT. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 996124
INFORMATION REGARDING DOOR LOCK FREEZING REPAIR. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: BC0304972301
MIL LIGHT ON WITH DTC P0505. *JD
Bulletin Number: BC0304A97020
CONCERNS OF DTC P0505 THAT ARE NOT RESOLVED BY FOLLOWING PP TESTS. *TW
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC9666961001
2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT
1997 FORD B700
Bulletin Number: 11817
SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT
Bulletin Number: 4709
SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT
Bulletin Number: 991311
CONDITIONS WITH POWER STEERING FLUID LEAKING FROM THE BRAKE PUMP RESERVOIR AT 90 DEGREE ELBOW ON SOME VEHICLES. *TT
1997 FORD B800
Bulletin Number: 11817
SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT
Bulletin Number: 4709
SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT
Bulletin Number: 991311
CONDITIONS WITH POWER STEERING FLUID LEAKING FROM THE BRAKE PUMP RESERVOIR AT 90 DEGREE ELBOW ON SOME VEHICLES. *TT
1997 FORD BRONCO
Bulletin Number: 12905
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT
Bulletin Number: 983074
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT
Bulletin Number: BC0053970201
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC0053972301
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC0844961008
E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT
Bulletin Number: BC1015397020
VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC2301970501
NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
1997 FORD B SERIES
Bulletin Number: 02169
SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE DEVELOPED FOR DIAGNOSING AND CORRECTING VEHICLE LEAN. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04217
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT
Bulletin Number: 12564
SUBJECT REGARDING PROPER OPERATION AND INTERPRETATION OF DUAL AIR PRESSURE GAUGE READINGS. *TT
Bulletin Number: 17467
ENGINE OR FUEL SYSTEM CONCERNS WHEN USING FUEL WITH GREATER THAN 5% BIODIESEL CONCENTRATION. *TT
Bulletin Number: 5899
CLARIFICATION PERTAINING TO THE DUAL AIR PRESSURE GAUGE FUNCTION. *TT
Bulletin Number: 6473
SOME MEDIUM TRUCKS PRODUCED AT KENTUCKY ASSEMBLY PLANT MAY EXHIBIT OIL LEAKING OUT OF THE TRANSMISSION SHIFT LEVER. *TT
Bulletin Number: 962218
STARTER - STARTER DOES NOT ENGAGE AND/OR STARTER MAY CYCLE (ENGAGE-DISENGAGE-ENGAGE) WHILE CRANKING - VEHICLES EQUIPPED WITH AN FD ENGINE AND AN ALLISON MD3000 TRANSMISSION BUILT THROUGH 8/1/96, *TW
Bulletin Number: 96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
Bulletin Number: 962529
FEAD BELT - HIGH WEAR AND/OR COMES OFF THE DRIVE PULLEY - VEHICLES BUILT FROM 4/1/92 THROUGH 9/1/96 WITH FD1060 ENGINE. *TW
Bulletin Number: 97115
SERVICE MANUAL- POWERTRAIN CONTROL/EMISSIONS DIAGNOSIS (PC/ED) ON-BOARD DIAGNOSIS II (OBD II)- COVER PAGE REPLACEMENT TO INCLUDE 1997 VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD
Bulletin Number: 97117
HEATER- LACK OF HEAT IN PASSENGER COMPARTMENT- VEHICLES EQUIPPED WITH FD1060 ENGINE- COOLING SYSTEM- ENGINE DOES NOT REACH OPERATING TEMPERATURE- VEHICLES EQUIPPED WITH FD1060 ENGINE. *JD
Bulletin Number: 97118
ENGINE- FD1060 OR FD1460- HIGH VIBRATION AT LOW ENGINE RPM- VIBRATION- HIGH- AT LOW ENGINE RPM- VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD
Bulletin Number: 97218
SUSPENSION - NOISE FROM FRONT SPRING REAR HANGER - REVISED REAR SPRING HANGER INSULATOR PAD - VEHICLES EQUIPPED WITH 6000, 7000 OR 9000 LB AXLES BUILT THROUGH 10/1/97. *TW
Bulletin Number: 97315
NO START- STARTER WILL NOT TURN ENGINE OVER- VEHICLES WITH FD1060 ENGINE. *JD
Bulletin Number: 97411
FEAD BELT- HIGH WEAR AND/OR COMES OFF OF THE DRIVE PULLEY- VEHICLES BUILT FROM 4/1/92 THROUGH 6/1/96 WITH FD1060 ENGINE. *JD
Bulletin Number: 97517
ENGINE- DIESEL- FD1060 AND FD1460- WHITE SMOKE FROM EXHAUST- SERVICE TIP. *JD
Bulletin Number: 97630
HARD STARTING- POSSIBLE PLUGGED CATALYTIC CONVERTER/MUFFLER (CCM)- VEHICLES BUILT AFTER 11/29/93 EQUIPPED WITH 1994 EMISSION LEVEL FD1060 OR FD1460 DIESEL ENGINE. *JD
Bulletin Number: 97716
FUEL INJECTION PUMP- BOSCH- SERVICE INFORMATION FOR FD1060/1460 DIESEL ENGINES. *JD
Bulletin Number: 981511
HARD TO START VEHICLE AT COLD TEMPERATURE.*AK
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 98614
THE COOLANT TEMPERATURE GAUGE READING MAY BE INACCURATE. *YC
Bulletin Number: 99133
SUBJECT REGARDING INTERMITTENT ELECTRICAL ISSUES, SUCH AS DASH LIGHTS FLASHING WHEN THE TURN SIGNAL IS ACTIVATED. *TT
Bulletin Number: 991413
VEHICLES EQUIPPED WITH FD1060 OR FD1460 MIDRANGE DIESEL ENGINES MAY EXPERIENCE A VIBRATION OR BUZZ THROUGH THE THROTTLE PEDAL. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99205
SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 9983
EXPERIENCING VARIOUS INTERMITTENT CONCERNS, SUCH AS LOW COOLANT LEVEL SENSOR LEAKING COOLANT INTO WIRING HARNESS. *TT
Bulletin Number: BC0601961101
MANY MANUAL TRANSMISSIONS THAT ARE REPLACED/REPAIRED UNDER WARRANTY AND RETURNED TO THE WPRC SHOW SIGNS OF IMPROPER/LACK OF MAINTENANCE OR MISDIAGNOSIS. *TW
Bulletin Number: BC0604961101
NEW FUEL HOSE TO REPLACE THE HOSE USED IN THE LOW PRESSURE FUEL RETURN SYSTEM - THE CURRENT HOSE MAY SHOW SIGHN OF DETERIOATION OR CRACKS. *TW
Bulletin Number: BC1018797230
DIAGNOSE THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD
Bulletin Number: BC1029697020
FD 1060 ENGINES THE LOWER COOLANT PIPE, BASE PART NUMBER -8291- WAS CHANGED. *JD
Bulletin Number: BC2312970501
NEW THROTTLE CABLE TO REDUCE VIBRATION ATTHE ACCELERATOR PEDAL. *TW
Bulletin Number: BC3236970211
FD 1060 ENGINES - NEW DESIGN STARTER MOTOR TO ALLEVIATE HARD START/NO START CONCERNS IN COLD AMBIENTS. *TW
Bulletin Number: BC3505972301
THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD
1997 FORD B SERIES (MEDIUM)
Bulletin Number: 13736
SOME VEHICLES MAY EXPERIENCE OIL LEAKING FROM THE SHIFT LEVER. *MJS
1997 FORD CARGO
Bulletin Number: 02169
SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE DEVELOPED FOR DIAGNOSING AND CORRECTING VEHICLE LEAN. *TT
Bulletin Number: 962218
STARTER - STARTER DOES NOT ENGAGE AND/OR STARTER MAY CYCLE (ENGAGE-DISENGAGE-ENGAGE) WHILE CRANKING - VEHICLES EQUIPPED WITH AN FD ENGINE AND AN ALLISON MD3000 TRANSMISSION BUILT THROUGH 8/1/96, *TW
Bulletin Number: 96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
Bulletin Number: 962529
FEAD BELT - HIGH WEAR AND/OR COMES OFF THE DRIVE PULLEY - VEHICLES BUILT FROM 4/1/92 THROUGH 9/1/96 WITH FD1060 ENGINE. *TW
Bulletin Number: 962622
ASSIST HANDLE- INSTRUMENT PANEL-MOUNTED ASSIS HANDLE MAY COME LOOSE- VEHICLES BUILT FROM 8/1/90 THROUGH 6/1/96. *JD
Bulletin Number: 97115
SERVICE MANUAL- POWERTRAIN CONTROL/EMISSIONS DIAGNOSIS (PC/ED) ON-BOARD DIAGNOSIS II (OBD II)- COVER PAGE REPLACEMENT TO INCLUDE 1997 VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD
Bulletin Number: 97117
HEATER- LACK OF HEAT IN PASSENGER COMPARTMENT- VEHICLES EQUIPPED WITH FD1060 ENGINE- COOLING SYSTEM- ENGINE DOES NOT REACH OPERATING TEMPERATURE- VEHICLES EQUIPPED WITH FD1060 ENGINE. *JD
Bulletin Number: 97118
ENGINE- FD1060 OR FD1460- HIGH VIBRATION AT LOW ENGINE RPM- VIBRATION- HIGH- AT LOW ENGINE RPM- VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD
Bulletin Number: 97315
NO START- STARTER WILL NOT TURN ENGINE OVER- VEHICLES WITH FD1060 ENGINE. *JD
Bulletin Number: 97411
FEAD BELT- HIGH WEAR AND/OR COMES OFF OF THE DRIVE PULLEY- VEHICLES BUILT FROM 4/1/92 THROUGH 6/1/96 WITH FD1060 ENGINE. *JD
Bulletin Number: 97517
ENGINE- DIESEL- FD1060 AND FD1460- WHITE SMOKE FROM EXHAUST- SERVICE TIP. *JD
Bulletin Number: 97630
HARD STARTING- POSSIBLE PLUGGED CATALYTIC CONVERTER/MUFFLER (CCM)- VEHICLES BUILT AFTER 11/29/93 EQUIPPED WITH 1994 EMISSION LEVEL FD1060 OR FD1460 DIESEL ENGINE. *JD
Bulletin Number: 98201
INTERMITTENT ELECTRICAL ISSUES, SUCH AS DASH LIGHTS FLASHING WHEN THE TURN SIGNAL IS ACTIVATED MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 98711
INFORMATION ON AVAILABILITY OF REVISED COOLANT LEVEL SENSOR. *YC
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99205
SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE. *TT
1997 FORD CF SERIES
Bulletin Number: BC0601961101
MANY MANUAL TRANSMISSIONS THAT ARE REPLACED/REPAIRED UNDER WARRANTY AND RETURNED TO THE WPRC SHOW SIGNS OF IMPROPER/LACK OF MAINTENANCE OR MISDIAGNOSIS. *TW
Bulletin Number: BC0604961101
NEW FUEL HOSE TO REPLACE THE HOSE USED IN THE LOW PRESSURE FUEL RETURN SYSTEM - THE CURRENT HOSE MAY SHOW SIGHN OF DETERIOATION OR CRACKS. *TW
Bulletin Number: BC1018797230
DIAGNOSE THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD
Bulletin Number: BC1026797230
FD 1060 ENGINE HARD START OR NO START IN EXTREMELY COLD AMBIENTS. *JD
Bulletin Number: BC3236970211
FD 1060 ENGINES - NEW DESIGN STARTER MOTOR TO ALLEVIATE HARD START/NO START CONCERNS IN COLD AMBIENTS. *TW
Bulletin Number: BC3505972301
THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD
1997 FORD CONTOUR
Bulletin Number: 00141
SOME VEHICLES MAY EXPERIENCE A NO START CONDITION AND / OR THE 10 AMP GFI INJECTOR FUSE MAY OPEN. *JB
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 00152
ADDRESSING CONCERNS OF VIBRATION NOISE FROM THE REAR OF VEHICLE AFTER INSTALLATION OF THE COMPRESSED NATURAL GAS (CNG) TANK ON BI-FUEL VEHICLES ONLY. *JB
Bulletin Number: 00182
SOME VEHICLES MAY EXHIBIT NO FORWARD GEAR RANGES DUE TO THE MISALIGNMENT OF THE FORWARD / COAST CLUTCH CYLINDER SNAP RING WITH RESPECT TO THE LEGS OF THE FORWARD CLUTCH PISTON. *JB
Bulletin Number: 0019
INFORMATION REGARDING SEVERAL INTERNAL CHANGES THAT HAVE BEEN IMPLEMENTED ON THE MRX-75 TRANSAXLE TO IMPROVE SHIFT EFFORTS. *MJS
Bulletin Number: 00239
A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. *TT
Bulletin Number: 00611
SOME BI-FUEL VEHICLES MAY REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT DURING SERVICE AND MAY NOT RUN ON CNG OR LPG., RECALIBRATION OF THE PCM/REPLACEMENT. *MJS
Bulletin Number: 0085
DUE TO AN INTERNAL DESIGN CHANGE TO THE SOLENOID TANK VALVE, THE PRESSURE RELEASE DEVICE (PRD) CAN NO LONGER BE REMOVED FROM THE TANK VALVE WITHOUT FIRST VENTING THE FUEL TANK. **MR
Bulletin Number: 00S03
SAFETY RECALL PERTAINING TO BRAKE PRESSURE CONTROL REDUCING VALVE REPLACEMENT. *JB
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 01214
INFORMATION TO AID IN DIAGNOSIS FOR CLARIFICATION OF LOCK-OFF SOLENOID AND SOLENOID TANK VALVE COIL RSISTANCES FOR BI-FUEL VEHICLES. *TT
Bulletin Number: 01231
SOME COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT ROUGH IDLE OR NO START WHEN COLD. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 01M07
SOME VEHICLES MAY EXPERIENCE A LOSS OF FUNCTION WITH THE HEATER BLOWER MOTOR SWITCH IN ONE OR MORE SWITCH POSITIONS. *SLC
Bulletin Number: 020503
GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996. *TT UPDATE. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 022001
REPLACEMENT SPEAKER INSTALLATION TIPS. *TT
Bulletin Number: 02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH
Bulletin Number: 0224
SOME VEHICLES EQUIPPED WITH THE CD4E TRANSAXLE MAY EXHIBIT HARSH AND DELAYED 1-2/2-3 UPSHIFTS AFTER TRANSAXLE OR TURBINE SHAFT SPEED SENSOR REPLACEMENT, POSSIBLE DIAGNOSTIC TROUBLE CODES 628, 642, 645, 646, 647, 648, P0731, P0732, P0734, P0
Bulletin Number: 0253
SUBJECT REGARDING ALTERNATIVE FUEL VEHICLE COMPRESSED NATURAL GAS TANK INSPECTION. *TT
Bulletin Number: 03102
COMPRESSED NATURAL GAS (CNG). ROUGH IDLE OR NO START WHEN COLD. VEHICLES EQUIPPED WITH CNG BI-FUEL ENGINE ONLY. *TT
Bulletin Number: 03103
VEHICLES WITHOUT THE COOLANT LOCK-OFF MAY EXHIBIT A NO START CONDITION. *TT
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 041516
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE(S) P0420 AND/OR P0430. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 11499
EXHIBITING A NOISE IN THE FRONT OF THE VEHICLE AND POSSIBLY CAUSED BY A FRONT STABILIZER BAR OR LINK NOISE. *TT
Bulletin Number: 11725
SOME VEHICLES MAY EXHIBIT A KNOCKING OR CLUNKING SOUND DURING RAPID ACCELERATION / DECELERATION AS WHEN LETTING OFF AND PUTTING YOUR FOOT DOWN ON THE ACCELERATOR QUICKLY. *TT
Bulletin Number: 11791
SOME VEHICLES WITH CD4E TRANSMISSION MAY EXHIBIT A CONDITION OF NO CRANK / NO START IN PARK. VEHICLE WILL CRANK AND START IN NEUTRAL. *TT
Bulletin Number: 12075
VEHICLES BUILT PRIOR TO 6/16/98 MAY HAVE A BROKEN/DETACHED IP CLUSTR BEZEL GAPHIDER. THE HIDER IS A HINGED FLAP BETWEEN THE STEERING COLUMN SHROUD AND THE IP BEZEL. *MJS
Bulletin Number: 12140
SOME VEHICLES EQUIPPED ITH 2.0L MAY REQUIRE REPLACEMENT OF THE LEFT AIR BAG MODULE OR STEERING WHEEL DURING NORMAL REPAIR SITUATIONS. *MJS
Bulletin Number: 12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
Bulletin Number: 12508
SOME VEHICLES MAY REQUIRE STEERING WHEEL AND AIRBAG REPLACEMENT. *TT
Bulletin Number: 12520
SUBJECT REGARDING 60 AMP FUSE BLOWN. *TT
Bulletin Number: 12525
CONCERNS WITH THE LEFT AIR CONDITIONING PANEL REGISTER DISCHARGE TEMPERATURE THAT IS WARMER THAN THE CENTER AND / OR RIGHT VENTS. *TT
Bulletin Number: 12556
SUBJECT REGARDING TECHNICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES. *TT
Bulletin Number: 12707
SOME VEHICLES MAY EXHIBIT A FRONT BRAKE GROAN. *TT
Bulletin Number: 12726
INFORMATION REGARDING DECKLID RELEASE ISSUES. *TT
Bulletin Number: 13178
INFORMATION REGARDING CLUNK/RATTLE ON TIP-IN OR TRANSMISSION GEAR ENGAGEMENT. *MJS
Bulletin Number: 13316
EXHIBITING A DRIVELINE RATTLE OR CLUNKING TYPE NOISE DURING TIP-IN OR TRANSMISSION GEAR ENGAGEMENT. *TT
Bulletin Number: 13364
CUSTOMER MAY COMMENT ON VIBRATION AT 60 - 70 MPH AT CRUISE. *TT
Bulletin Number: 13379
SOME VEHICLES EQUIPPED WITH 2.5L ENGINE AND CD4E TRANSMISSION MAY EXHIBIT A DRIVELINE RATTLE OR CLUNKING TYPE NOISE DURING TIP-IN OR TRANSMISSION GEAR ENGAGEMENT. *TT
Bulletin Number: 13387
VEHICLES WITH REAR DISC BRAKES MAY EXHIBIT A SQUEAK IN THE REAR SUSPENSION AREA. *TT
Bulletin Number: 13454
SUBJECT REGARDING THE SPEED CONTROL SWITCH VOLTAGE READINGS - SERVICE TIP. *TT
Bulletin Number: 13761
SOME VEHICLES EQUIPPED WITH 2.0L ENGINES MAY EXHIBIT SYMPTOMS OF CLUTCH SLIPPAGE OR NO CLUTCH ENGAGEMENT AFTER PERFORMINB REPAIRS TO THE CLUTCH SYSTEM. *MJS
Bulletin Number: 14375
SOME VEHICLES EQUIPPED WITH A 2.5L DURATEC ENGINE MAY EXHIBIT AN ENGINE OVERHEAT CONDITION DUE TO LACK OF CIRCULATION OF COOLANT. *JB
Bulletin Number: 14490
SOME VEHICLES EQUIPPED WITH 2.5L DURATEC (24V) ENGINE MAY EXHIBIT DIAGNOSTIC TROUBLE CODE P0420 AND / OR P0430. *TT
Bulletin Number: 14775
SOME VEHICLES EQUIPPED WITH DAYTIME RUNNING LAMPS (DRL) MAY EXHIBIT THE HIGH BEAM INDICATOR IN THE INSTRUMENT CLUSTER FLASHING WHEN THE DAYTIME RUNNING LAMPS ARE ON. *TT
Bulletin Number: 14877
SOME VEHICLES MAY ILLUMINATE THE MALFUNCTION INDICATOR LAMP OR RUN ROUGH AFTER THE CATALYST IS REMOVED AND / OR REPLACED. THIS MAY BE DUE TO VACUUM LEAKS AS A RESULT OF TOLERANCE STACKUP WITHIN THE EXHAUST / EGR / INTAKE SYSTEM.
Bulletin Number: 15065
SOME VEHICLES MAY EXHIBIT A/C DISCHARGE AIR TEMPERATURES DIFFERENCES OF GREATER THAN 10 DEGREES F FROM REGISTERS ON LEFT SIDE OF DASH THAN ON RIGHT. *TT
Bulletin Number: 15241
SOME VEHICLES MAY EXHIBIT A NOISE THAT APPEARS TO COME FROM THE FRONT WHEEL BEARINGS. *TT
Bulletin Number: 15241
SOME VEHICLES MAY EXHIBIT A NOISE THAT APPEARS TO COME FROM THE FRONT WHEEL BEARINGS. *TT
Bulletin Number: 15390
SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LIGHT AND/OR EGR DIAGNOSTIC TROUBLE CODES 332, P0401, P1407 (LACKOF EGR FLOW). *TT
Bulletin Number: 15636
CONCERN WITH HEADLAMPS AND/OR INSTRUMENT PANEL LAMPS DIMMING SLIGHTLY AT IDLE. *TT
Bulletin Number: 15894
SUBJECT REGARDING AUTOMATIC SHIFTER ASSEMBLY OR THE INDICATOR HOUSING REPLACEMENT. *TT
Bulletin Number: 16880
INOPERATIVE SHIFT INTERLOCK SOLENOID OR REPEAT INSTRUMENT INTERFACE MODULE FAILURE. *TT
Bulletin Number: 4674
SOME VEHICLES WITH CD4E TRANSMISSION MAY EXHIBIT A CONDITION OF NO CRANK / NO START IN PARK. VEHICLE WILL CRANK AND START IN NEUTRAL. *TT
Bulletin Number: 5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
Bulletin Number: 5306
SOME VEHICLES MAYE XHIBIT EXHIBIT A MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0171 AND P0172 STORED IN MEMORY. *TT
Bulletin Number: 5810
SUBJECT ON STEERING WHEEL & AIRBAG REPLACEMENT. *TT
Bulletin Number: 5844
SOME VEHICLES BUILT BETWEEN AUGUST 1997 AND FEBRUARY 1998 MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) LIGHT ON AND THE BLOWER INOPERATIVE. *TT
Bulletin Number: 5849
SOME VEHICLES MAY EXHIBIT A LEFT AIR CONDITIONING PANEL REGISTER DISCHARGE TEMPERATURE THAT IS WARMER THAN THE CENTER AND / OR RIGHT VENTS. *TT
Bulletin Number: 5892
SUBJECT REGARDING TECHINICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES WITH GFI ALTERNATE FUEL SYSTEMS. *TT
Bulletin Number: 6091738
SOME VEHICLES MAY EXHIBIT A VIBRATION AT 60 - 70 MPH (100 - 115 KPH). *TT
Bulletin Number: 6201
EXPERIENCING A FRONT BRAKE GROAN DURING CITY DRIVING. *TT
Bulletin Number: 6243
ONLINE SERVICE INFORMATION PERTAINING TO VARIOUS DECKLID RELEASE ISSUES. *TT
Bulletin Number: 6320
CONCERNS WITH VIBRATION AT 60 - 70 MPH. *TT
Bulletin Number: 6567
SUBJECT REGARDING FORD QUALITY RENEWAL (FQR) ASSEMBLIES. *TT
Bulletin Number: 6906
EXHIBITING A STARTER GRINDING NOISE AND / OR LACK OF STARTER DRIVE ENGAGEMENT. *TT
Bulletin Number: 6994
CONCERNS WITH VEHICLES EXHIBITING A DRIVELINE RATTLE OR CLUNKING TYPE NOISE DURING TIP-IN OR TRANSMISSION GEAR ENGAGEMENT. *TT
Bulletin Number: 7344
SOME VEHICLES MAY EXHIBIT A VIBRATION AT 60-70 MPH. *TT
Bulletin Number: 7349
SOME VEHICLES EQUIPPED WITH 2.5L ENGINE AND CD4E TRANSMISSION MAY EXHIBIT A DRIVELINE RATTLE OR CLUNKING TYPE NOISE DURING TIP-IN OR TRANSMISSION GEAR ENGAGEMENT. *TT
Bulletin Number: 7430
INFORMATION REGARDING SPEED CONTROL SWITCH VOLTAGE READINGS - SERVICE TIP. *TT
Bulletin Number: 7864
WORLD WIDE DIAGNOSTICS SERVICE TIP.
Bulletin Number: 7923
CLUTCH WILL NOT ENGAGE AFTER SERVICE.
Bulletin Number: 96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
Bulletin Number: 96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
Bulletin Number: 96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
Bulletin Number: 962411
TRANSAXLE - CD4E - NEW DESIGN PARKING PAWL RATCHET SPRING AND PARKING CAM ACTUATING LEVER ASSEMBLY. *TW
Bulletin Number: 96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
Bulletin Number: 96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
Bulletin Number: 962511
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 96256
PARKING BRAKE - PARKING BRAKE STICKS AND BINDS - DOES NOT RELEASE - VEHICLES EQUIPPED WITH REAR DISC BRAKES. *TW
Bulletin Number: 962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 962614
TRANSAXLE - CD4E - HARSH SHIFT AND/OR ENGAGEMENT - DIAGNOSTIC TROUBLE CODE 628 OR P0741. *TW
Bulletin Number: 96712
SUBJEC REGARDING THE MTX-75 TRANSAXLES WILL BE INSTALLED CERTAIN MODE YEAR VEHICLES. *TT
Bulletin Number: 97050110616
CONCERNS OF SULPHUR ODOR FROM EXHAUST SYSTEM. *TW
Bulletin Number: 97111097234
VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC
Bulletin Number: 9721
DOOR GLASS - WINDOW BELT LINE MOULDING LOOSE OR FALLS OFF - VEHICLES BUILT THROUGH 10/31/96. *TW
Bulletin Number: 9731
CARPET- POOR FIT AND/OR PULLS FROM UNDERNEATH COWL SIDE TRIM PANEL- VEHICLES BUILT THROUGH 10/18/96. *JD
Bulletin Number: 9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD
Bulletin Number: 9746
TRANSAXLE- CD4E- HARSH SHIFT AND/OR ENGAGEMENT- DIAGNOSTIC TROUBLE CODE (DTC) 628 OR P0741- SERVICE TIP. *JD
Bulletin Number: 9751
INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD
Bulletin Number: 97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
Bulletin Number: 9752
PARKING BRAKE- PARKING BRAKE STICKS AND BINDS- DOES NOT RELEASE- VEHICLES EQUIPPED WITH REAR DISC BRAKES. *JD
Bulletin Number: 9759
LEAK- AUTOMATIC TRANSMISSION FLUID- CD4E TRANSAXLE IN FLUID COLLECTION ON MAIN CONTROL ASSEMBLY. *JD
Bulletin Number: 9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
Bulletin Number: 980309
STALL ON COLD START WHEN COLD. *AK
Bulletin Number: 9810799
SUBJECT REGARDING SEAT BELT LOCATOR BUTTON REPLACEMENT. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK
Bulletin Number: 98164
A TRANSEAL COATING IS ON THE FRONT AND REAR BUMPERS. THIS COATING MUST BE REMOVED BEFORE DELIVERY TO THE CUSTOMER. YD
Bulletin Number: 98166
THE TEMPERATURE GAUGE READS HIGH IN THE NORMAL RANGE WHEN ENGINE IS AT NORMAL OPERATING TEMPERATURE.
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 98207
SOME VEHICLES MAY EXPERIENCE A STALL OR ROUGH IDLE AFTER STARTING IN AMBIENT TEMPERATURES. *YC
Bulletin Number: 98213
CONCERNS WITH TEMPERATURE READS HIGH WITHIN NORMAL RANGE WHEN ENGINE IS AT NORMAL OPERATING TEMPERATURE. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982311
MINIMAL CLEARANCE OF THE CD4E TRANSAXLE TO SUBFRAME MAKES TRANSAXLE INSTALLATION AND REMOVAL MORE DIFFICULT. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982462
SOME VEHICLES MAY EXHIBIT A NOISE IN THE FRONT OF THE VEHICLE. *YC
Bulletin Number: 982514
CONCERNS WITH THE TIMING ARROWS/FLAGS ON THE BACK OF THE CAMSHAFT SPROCKET (S) ARE MIS-MARKED BY AS MUCH AS 30 DEGREES ROTATION. *YC
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 982672
SOME VEHICLES MAY EXHIBIT A CUSTOMERS CONCERN OF A RATTLING SOUND FROM ENGINE TIMING BELT AREA DURING WARM-UP. *YC
Bulletin Number: 983081
CONCERNS WITH INCORRECT BRAKE SHOE / LINING ASSEMBLY. *TT
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 9832
FRONT AND REAR BUMPERS MADE OF XENOY PLASTIC HAVE HAD THE CONDUCTIVE PRIMER REMOVED FROM SERVICE PARTS. *YC
Bulletin Number: 983216
SOME VEHICLES MAY EXHIBIT MULTIPLE WHEEL SPEED SENSOR CODES. *TT
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 983311
EXHIBITING A MALFUNCTION INDICATOR LIGHT (MIL) ON WITH VARIOUS CODES AND POSSIBLE DRIVEABILITY CONCERNS. *TT
Bulletin Number: 983583
SOME VEHICLES MAY EXPERIENCE A VIBRATION AT HIGHWAY SPEEDS. *TT
Bulletin Number: 9841
DURING REMOVAL THE LICENSE PLATE ATTACHING FASTENERS MAY BREAK. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 985089
SOME VEHICLES BUILT PRIOR TO 6/16/98 MAY HAVE A BROKEN / DETACHED INSTRUMENT PANEL CLUSTER BEZEL GAPHIDER. *TT
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
Bulletin Number: 985A17
SOME VEHICLES PARKING BRAKE EQUIPPED WITH REAR DISC BRAKES MAY STICK AND/OR BIND WHEN ATTEMPTING TO RELEASE. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 9874
A NEW SILICONE GASKET AND SEALANT. *YC
Bulletin Number: 9881
ISSUE WITH DOOR SPEAKER GRILLES MAY CRACK DURING NORMAL USAGE ON SOME VEHICLES. *YC
Bulletin Number: 9886
AN ENGINE COOLANT LOSS MAY OCCUR FROM THE ENGINE BLOCK HEATER AREA. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 98B21
SUBJECT ON ENGINE BLOCK HEATERS. *TT
Bulletin Number: 98S26S1
SAFETY RECALL INVOLVING CERTAIN VEHICLES WITH AUTOMATIC TRANSAXLE SHIFT INDICATOR (PRNDL) BEZEL. *TT
Bulletin Number: 98S26S2
SAFETY RECALL INVOLVING CERTAIN VEHICLES WITH AUTOMATIC TRANSAXLE SHIFT INDICATOR (PRNDL) BEZEL - PART AVAILABILITY). *TT
Bulletin Number: 9903
UNDER HOOD WIRE HARNESS. ADDITIONAL 10 YEARS OR 100,000 MILES. FORD. *KB
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 9912781
EXPERIENCING VIBRATION AT 60 - 70 MPH (110 - 12- KPH). *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 9913137
CONCERNS WITH 2.5L ENGINE EQUIPPED VEHICLES AND CD4E TRANSAXLE EXHIBITING A STARTER GRINDING NOISE AND / OR LACK OF STARTER DRIVE ENGAGEMENT. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99195
SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99201
CONCERNS WITH A HARSH SHIFT FELT AT LARGE THROTTLE OPENINGS (OR AT HEAVY ACCELERATION RATE) ON SOME VEHICLES. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99249
THIS BULLETIN ADDRESSES AN ISSUE WITH THE AUTOMATIC TRANSMISSION FLUID SEEPING FROM THE VENT, RESULTING IN FLUID COLLECTING ON THE MAIN CONTROL ASSEMBLY. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 996041
VEHICLES MAY EXHIBIT A HARD TO SHIFT CONDITION IN COLD WEATHER. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: 9989
SOME VEHICLES MAY EXHIBIT A GROANING NOISE FROM THE FRONT BRAKES DURING CITY DRIVING. *TT
Bulletin Number: 99M01
OWNER NOTIFICATION PROGRAM PROVIDING ADDITIONAL COVERAGE FOR REPLACEMENT OF THE BLOWER SWITCH, RESISTOR AND ATTACHED WIRE CONNECTORS. THIS ADDITIONAL COVERAGE IS PROVIDED IN CASE THE VEHICLE OWNER EXPERIENCES DURABILITY CONCERNS WITH THES
Bulletin Number: 99M07
OWNER NOTIFICATION PROGRAM FOR ADDITONAL COVERAGE ON HEATER BLOWER SWITCH, RESISTOR AND ATTACHED WIRE CONNECTORS REPLACEMENT. THIS ADDITIONAL COVERAGE IS PROVIDED IN CASE THE VEHICLE OWNER EXPERIENCES DURABILITY CONCERNS WITH THESE COMPO
Bulletin Number: BC0043970201
ENGINEERING IS INVESTIGATING INCIDENTS OF LOW COOLANT LIGHT ILLUMINATION ON 2.5L CONTOUR/MYSTIQUES. *JD
Bulletin Number: BC0043972301
LOW COOLANT LIGHT ILLUMINATION ON 2.5L VEHICLES. *JD
Bulletin Number: BC0044970201
INTERMITTENT SURGING, BUCKING OR SHUDDER CONCERN, INTERMEDIATE ERRATIC SPEDDOMETER AND/OR POSSIBLY DTC452. *JD
Bulletin Number: BC0044972301
INTERMITTENT SURGING, BUCKING OR SHUDDER CONCERN, INTERMEDIATE ERRATIC SPEEDOMETER AND/OR POSSIBLY DTC 452- INSPECT THE VSS AND SPEEDO GEAR. *JD
Bulletin Number: BC0045970201
BEGINNING DECEMBER 2, 1996 ALL CD4E TRANSAXLES ARE BUILT WITH A REDESIGNED PUMP BODY SEPARATOR PLATE AND PUMP BODY SEPARATOR PLATE GASKET. *JD
Bulletin Number: BC0045972301
BEGINNING DECEMBER 2, 1996 (BEGINNING TRAN SERIAL NUMBER (6337-0001)) ALL CD4E TRANSAXLES ARE BUILT WITH A REDESIGNED PUMP BODY SEPARATOR PLATE AND PUMP BODY SEPARATOR PLATE GASKET. *JD
Bulletin Number: BC0142970201
CONCERNS OF LOCKING DOORS, A REVISED DOOR LOCK BEZEL IS COMING. *JD
Bulletin Number: BC0195970201
BUZZ/RATTLE ON TIP IN DURING CRUISE THAT APPEARS TO COME FROM CENTER OF RIGHT SIDE OF THE INSTRUMENT PANEL. *JD
Bulletin Number: BC0301970201
BUZZ/RATTLE ON TIP IN - INSTRUMENT PANEL AREA. *TW
Bulletin Number: BC0301972301
BUZZ/RATTLE ON TIP IN - INSTRUMENT PANEL AREA. *JD
Bulletin Number: BC0302970201
EGR ISSUES - IF NORMAL PC/ED DIAGNOSIS FAILS, FAILURE MAY BE DUE TO CARBON DEPOSITS. *TW
Bulletin Number: BC0302972301
DTC'S 332 OR P1401 - LACK OF EGR FLOW. *JD
Bulletin Number: BC0303972301
VIBRATION AT IDLE. *JD
Bulletin Number: BC0501961111
SQUEAKS FROM THE REAR SUSPENSION. *TW
Bulletin Number: BC0502961111
CONCERNS OF MOULDING AT BOTTOM OF DOOR WINDOW GLASS COMING LOOSE. *TW
Bulletin Number: BC0783961014
NEW PCM CALIBRATION TO CORRECT LOW SPEED MANEUVER, HIGH AMBIENT TEMP, & START/RUN/STALL CONCERNS. *TT
Bulletin Number: BC0785961014
DIAGNOSING CHARGING OR STARTING SYSTEM CONCERNS OF POTENTIAL CHAFE BETWEEN CIRCUIT 30 & THE SUBFRAME IN THE AREA BETWEEN THE ALTERNATOR & THE MEGA-FUSE. *TT
Bulletin Number: BC0824961010
COMPLAINTS OF STALLING ON 1996 & 1997 VEHICLES W/ 2.0L CD4E. *TT
Bulletin Number: BC1012197020
CONCERNS OF LOCKING DOORS, A REVISED DOOR LOCK BEZEL IS COMING- CUSTOMERS MAY LOCK THEMSELVES OUT OF THE VEHICLE. *JD
Bulletin Number: BC1018897230
THE THIRD/FOURTH SYNCHRONIZER ASSEMBLY SHOULD BE INSTALLED WITH THE LARGE COLLAR FACING OUTWARD (TOWARD REVERSE GEAR). *JD
Bulletin Number: BC1026697230
VEHICLES EXHIBITING HARSH SHIFTS AND/OR HARSH ENGAGEMENT ACCOMPANIED BY DTCS 628 OR P0741. *JD
Bulletin Number: BC1032697020
VEHICLES HAVE A CABIN AIR FILTER THAT MUST BE CHANGED EVERY 15000 MILES. *JD
Bulletin Number: BC105899705
VEHICELS BUILT IN JANUARY 1997 MAY EXHIBIT MIL ILLUMINATION WITH A CODE P0171. *TW
Bulletin Number: BC106019705
CLIMATE CONTROL SYSTEM VACUUM MOTOR LINKS FALLING OFF MAY BE REPAIRED BY ADDING THE APPROPRIATE SIZE INTERNAL STAR WASHER RETAINER TO THE END OF THE SHAFT AFTER INSTALLING THE LINK. *TW
Bulletin Number: BC2243970501
CLIMATE CONTROL SYSTEM - VACUUM MOTOR LINKS FALLING OFF - REPAIR WITH LOCALLY PROCURED STAR WASHER. *TW
Bulletin Number: BC2294970501
VEHICLES MAY EXHIBIT MIL ILLUMINATION WITH A CODE OF P0171 - THIS MAY BE CAUSED BY A DISCONNECTED FUEL PRESSURE REGULATOR VCUUM HOSE. *TW
Bulletin Number: BC2395970501
CUSTOMER COMPLAINTS OF DOORS THAT LOCK INADVERTENTLY. *TW
Bulletin Number: BC2432970501
ENGINE OIL PRESSURE SPECIFICATION. *TW
Bulletin Number: BC2446970501
SOME 96 & 97 VEHICLES MISBUILT WITH 1998 MODEL YEAR FUEL GAUGE. *TW
Bulletin Number: BC3100970224
MICRON FILTER - REMINDER THAT THE FILTER MUST BE CHANGED EVERY 15000 MILES - SYMPTOMS THAT MIGHT INDICATE NEED FOR CHANGE INCLUDE POOR A/C-HEATER PERFORMANCE AND/OR WINDOW FOGGING. *TW
Bulletin Number: BC3162970218
CLICKING NOISE CAUSED BY DIFFERENTIAL LUBE TUBE CONTACTING DIFFERENTIAL CASE. *TW
Bulletin Number: BC3204970214
HARSH SHIFTS AND/OR HARSH ENGAGEMENT ACCOMPANIED BY DTC'S 628 OR P0741. *TW
Bulletin Number: BC3232970211
BATTERY ILLUMINATION AND DECREASED POWER STEERING ASSIST WHEN DRIVING THROUGH DEEP PUDDLES. *TW
Bulletin Number: BC3245970210
REAR APPLIQUES - SERVICE KIT BEING DEVELOPED TO REPAIR DAMAGED APPLIQUES FROM LICENSE PLATE CHANGES. *TW
Bulletin Number: BC3274970207
REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS A
Bulletin Number: BC3490972301
THE THIRD/FOURTH SYNCHRONIZER ASSEMBLY SHOULD BE INSTALLED WITH THE LARGE COLLAR FACING OUTWARD- THE SERVICE MANUAL INCORRECTLY ADVISES TO INSTALL THE THIRD/FOURTH GEAR ASSEMBLY WITH THE SMALL COLLAR FACING OUT. *JD
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC9640961001
CONCERN OF ONE OR MORE INJECTORS STAYING ON AT TIMES.
Bulletin Number: BC9641961001
COMPLAINTS OF STALLING ON VEHICLES WITH 2.0L CD4E ENGINES. *TT
Bulletin Number: BC9666961001
2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT
Bulletin Number: BC9667961001
INVESTIGATING MIL ON ACCOMPANIED BY CODE 1405. *TT
1997 FORD CROWN VICTORIA
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 00213
SUBJECT REGARDING CLIMATE CONTROL - EATC - BLOWER MOTOR CONTROL SERVICE TIPS. *JB
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 00E11
SERVICE ACTION BULLETIN REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
Bulletin Number: 00E11
SERVICE ACTION 00E11, SUPPLEMENT #1 - UPDATE INFORMATION REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01194
THIS ARITLCE IS TO PROVIDE INFORMATION ON REPLACEMENT OF OLD STYLE HOOD LAMP SWITCH TO THE RVISED MECHANICAL HOOD LAMP SWITCH. *TT
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 012114
PARTS AND PROCEDURE TO REDUCE THE POTENTIAL OF FUEL TANK PUNCTURES DURING RARE AND EXTREMELY HIGH-SPEED REAR IMPACTS. *TT
Bulletin Number: 01221
SOME DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT A ROUGH IDLE, OR NO START IN COLD CONDITIONS. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 01M02
OWNER NOTIFICATION PROGRAM REGARDING ADDITIONAL COVERAGE ON CERTAIN 4.6L SOHC INTAKE MANIFOLDS. SOME OF THE COMPOSITE INTAKE MANIFOLDS MAY DEVELOP FATIGUE CRACKS AT THE COOLANT CROSSOVER DUCT. *TT
Bulletin Number: 01M02
SOME OF THE COMPOSITE INTAKE MANIFOLDS USED ON 4.6L SOHC ENGINES MAY DEVELOP FATIGUE CRACKS AT THE COOLANT CROSSOVER DUCT. THIS CONDITION COULD RESULT IN ENGINE COOLANT LEAKAGE WHICH, IF NOT SERVICED, MAY CAUSE ENGINE OVERHEATING. COMPL
Bulletin Number: 020503
GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996. *TT UPDATE. *TT
Bulletin Number: 02107
TRANSFER SERVICE TIPS FOR THE FRONT WIPER MOTOR MOUNT BRACKET AND DEPRESSED PARK OUTPUT ARM. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH
Bulletin Number: 0222
SOME VEHICLES MAY EXHIBIT AN INTAKE MANIFOLD CROSSOVER (FIRST RUNNER) COOLANT SEEPAGE CONDITION. *TT
Bulletin Number: 0253
SUBJECT REGARDING ALTERNATIVE FUEL VEHICLE COMPRESSED NATURAL GAS TANK INSPECTION. *TT
Bulletin Number: 02B02
INSTALLATION OF OPTIONAL POLICE INTERCEPTOR PACKAGE UPGRADE KIT. *TT UPDATE PART 2. EXPIRATION DATE REMOVED. *TT
Bulletin Number: 030409
POSSIBLE FUEL LEAK AT FILL VALVE - FILL VALVE SERVICE PART REVISIONS - CNG VEHICLES ONLY. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 03183
DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY. *TT
Bulletin Number: 03206
SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY. LOSS OF POWER AT HEAVY LOAD, DIAGNOSTIC TROUBLE CODES (DTCS) FOR LEAN FUEL, ROUGH IDLE, HARD START,
Bulletin Number: 03245
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0420 AND/OR P0430. *TT
Bulletin Number: 03261
NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT
Bulletin Number: 0349
A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE ON SOME CNG (COMPRESSED NATURAL GAS) VEHICLES. *TT *JB
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04B26
ABRASION OF THE REAR BRAKE TUBE NEAR THE FLOOR PAN STIFFENING RIB AND THE #3 TRANSMISSION CROSS MEMBER. ADVANCE NOTICE-CUSTOMER SATISFACTION PROGRAM 04B26. *TT
Bulletin Number: 05N04
EXTENDED COVERAGE PROGRAM 05N04 - EXTENDED COVERAGE FOR COMPOSITE INTAKE MANIFOLD. THIS PROGRAM IS BEING PROVIDED AS A SETTLEMENT TO A CLASS ACTION LAWSUIT. THE TERMS OF THE SETTLEMENT EXTEND THE COVERAGE OF THE ALL-COMPOSITE INTAKE MANIF
Bulletin Number: 07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
Bulletin Number: 090308
MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455
Bulletin Number: 12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
Bulletin Number: 12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
Bulletin Number: 12178
INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. *MJS
Bulletin Number: 12219
FOR ALL VEHICLES WITH LIGHTING CONTROL MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12223
FOR ALL VEHICLES WITH DRIVERS DOOR MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING. *TT
Bulletin Number: 12226
FOR ALL VEHICLES WITH REMOTE KEYLESS ENTRY CONCERNS THAT REQUIRE A MODULE AND / OR TRANSMITTER (KEYFOB) REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE OR KEYFOB. *TT
Bulletin Number: 12230
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12298
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. *TT
Bulletin Number: 12725
SOME VEHICLES MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT
Bulletin Number: 12890
BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE THREAD. *TT
Bulletin Number: 13025
SOME VEHICLES MAY EXHIBIT A BANG POPPING NOISE HEARD FROM THE EXHAUST SYSTEM DURING COOL-DOWN. *TT
Bulletin Number: 13240
INFORMATION REGARDING VIBRATION/EXTENSION HOUSING BUSHING. *MJS
Bulletin Number: 13925
SOME POLICE VEHICLES MAY EXHIBIT SHIFT CONCERNS DUE TO ENGINE DRIVEABILITY ISSUES. *TT
Bulletin Number: 13933
SOME VEHICLES MAY EXHIBIT YELLOWING OF THE HEADLAMPS. *TT
Bulletin Number: 14081
SOME VEHICLES MAY EXHIBIT AN INOPERATIVE KEYLESS ENTRY PAD. **MR
Bulletin Number: 14370
INFORMATION ON PROGRAMMING REMOTES AFTER DRIVER DOOR MODULE REPLACEMENT. *JB
Bulletin Number: 14862
INFORMATION ON REPLACING FUEL TANK STRAP BOLTS. *TT
Bulletin Number: 15061
SOME VEHICLES BUILT 04/15/2000 OR EARLIER EQUIPPED WITH A KEYLESS ENTRY SYSTEM MAY EXHIBIT AN INOPERATIVE DOOR-MOUNTED KEYPAD, INTERIOR AND EXTERIOR LAMPS THAT SELF-ACTIVATE AND A WEAK OR DISCHARGED VEHICLE BATTERY. *TT
Bulletin Number: 15113
SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION. *YD
Bulletin Number: 15158
SOME VEHICLES MAY EXHIBIT A FEAD BELT JUMP-OFF TOSS. *YH
Bulletin Number: 15171
INFORMATION REGARDING POLICE OPTION-REAR WINDOW DISABLE-TAMPER RESISTANCE. *YD
Bulletin Number: 15271
DEDICATED CNG REGULATOR BOWL KIT AVAILABLE. *JG
Bulletin Number: 15761
SOME DEDICATED CNG VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS OF HARD START / NO START / ROUGH RUNNING. *TT
Bulletin Number: 16996
POLICE INTERCEPTOR MAY EXHIBIT LOW CHARGING SYSTEM VOLTAGE AT IDLE. *TT
Bulletin Number: 17310
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0420 (CATALYST SYSTEM EFFICIENCY BELOW THRESHOLD - BANK 1) AND/OR P0430 (CATALYST SYSTEM EFFICIENCY BELOW THRESHOLD - BANK 2). *TT
Bulletin Number: 18351
CHARGING SYSTEM LIMITATIONS. *EH
Bulletin Number: 4619
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT
Bulletin Number: 5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
Bulletin Number: 6242
EXPERIENCING A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE. *TT
Bulletin Number: 6505
BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE ON NATURAL GAS VEHICLES. *TT
Bulletin Number: 8060
SOME VEHICLES MAY EXHIBIT A SLIGHT STEERING DRIFT / WANDER CONDITION, USUALLY NOTED DURING HIGHWAY DRIVING. *TT
Bulletin Number: 8243
SOME POLICE VEHICLES MAY EXHIBIT SHIFTING CONCERNS DUE TO ENGINE DRIVEABILITY ISSUES. *TT
Bulletin Number: 8243
SOME POLICE VEHICLES MAY EXHIBIT SHIFT CONCERNS DUE TO ENGINE DRIVABILITY ISSUES. **MR
Bulletin Number: 8257
BRIEF INFORMATION REGARDING VEHICLES THAT EXHIBIT YELLOWING OF THE HEADLAMPS. *TT
Bulletin Number: 8300
SOME VEHICLES MAY EXHIBIT A BANG / POPPING NOISE HEARD FROM THE EXHAUST SYSTEM DURING COOL-DOWN. **MR
Bulletin Number: 8425
SUBJECT REGARDING KEYFOB PROGRAMMING INFORMATION - SERVICE REPLACEMENT DRIVERS DOOR MODULE. *TT
Bulletin Number: 96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
Bulletin Number: 96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
Bulletin Number: 96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
Bulletin Number: 96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
Bulletin Number: 96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
Bulletin Number: 962511
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 97090297182
SOME VEHICLES MAY EXPERIENCE A LEAN RIGHT CONDITION. *YC
Bulletin Number: 97090297183
EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC
Bulletin Number: 97090297185
A VIBRATION/"BUZZING" NOISE MAY BE HEARD OR FELT IN THE STEERING WHEEL ON RIGHT TURNS. *YC
Bulletin Number: 9722
SEAT - FRONT - DRIVER'S SIDE SEAT CUSHION PAD SUPPORT SPRING MAY SAG AND/OR SEAT MAY BECOME UNCOMFORTABLE - FLEET USAGE. *TW
Bulletin Number: 9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD
Bulletin Number: 9751
INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD
Bulletin Number: 97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
Bulletin Number: 9755
MALFUNCTION INDICATOR LAMP (MIL)- MIL ILLUMINATION- DIAGNOSTIC TROUBLE CODE (DTC) P0446 STORED IN MEMORY. *JD
Bulletin Number: 976011
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
Bulletin Number: 9773
VIBRATION- SHUDDER OR VIBRATION UNDER LIGHT TO MODERATE ACCELERATION ABOVE 56 KM/H (35 MPH) WHILE IN 3RD OR 4TH GEAR- VEHICLES EQUIPPED WITH AODE OR 4R70W TRANSMISSION. *JD
Bulletin Number: 97B13
VARIOUS INFORMATION REGARDING INTAKE MANIFOLD INSPECTION / REPLACEMENT. *TT
Bulletin Number: 97M91
INFORMATION REGARDING ADDITIONAL COVERAGE FOR INTAKE MANIFOLD MALFUNCTIONS. *TT
Bulletin Number: 98111
VEHICLES MAY EXHIBIT HARSH RIDE QUALITY OR EXCESSIVE ROAD FEEL THROUGH THE STEERING WHEEL WHILE GOING OVER SHARP BUMPS. *TT
Bulletin Number: 9811483
SOME POLICE AND EXPORT CARS EQUIPPED WITH PHONELIC PISTON CALIPERS MAY EXHIBIT BRAKE SQUEAL FROM THE REAR WHEN BRAKING. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982320
SOME VEHICLES WITH A VERY LOW ODOMETER READING MAY EXPERIENCE A LACK TEMPERATURE CONTROL. *YC
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98245
CONCERNS REGARDING THE FRONT SEAT FEELING LOOSE ON SOME VEHICLE. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982525
SOME VEHICLES MAY EXHIBIT BRAKE SQUEAL FROM THE REAR WHEN BRAKING. *YC
Bulletin Number: 98258
A VIBRATION / NOISE FELT IN STEERING WHEEL ON RIGHT TURNS.
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 983107
BRIEF INFORMATION REGARDING ENGINES BEING ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *TT
Bulletin Number: 9836
INFORMATION CONCERNING VIBRATION-SHUDDER UNDER LIGHT TO MODERATE ACCELERATION ABOVE 56 KM/H (35MPH) IN 3RD OR 4RD GEAR- VEHICLES EQUIPPED WITH AODE OR 4R70W TRANSMISSION.
Bulletin Number: 98410
VEHICLES MAY EXPERIENCE TORQUE CONVERTER CLUTCH SHUDDER OR VIBRATION. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 9847
SUBJECT REGARDING REVISED REMOTE KEYLESS ENTRY (RKE) SYSTEM. *TT
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
Bulletin Number: 985A3
THE ANTI-LOCK BRAKE SYSTEM ( ABS ) MAY ACTIVATE UNDER FALSE ABS CONDITIONS. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9863
SOME VEHICLES MAY EXHIBIT NO TEMPERATURE CONTROL AND/OR A CLICKING NOISE HEARD COMING FROM BEHIND THE INSTRUMENT PANEL NEAR THE GLOVE COMPARTMENT. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 9874
A NEW SILICONE GASKET AND SEALANT. *YC
Bulletin Number: 9887
EXPERIENCING A TORQUE CONVERTER CLUTCH SHUDDER OR VIBRATION. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 98B19S1
OWNER NOTIFICATION PROGRAM 98B19-S1 - BRAKE LINE WEAR ON CERTAIN VEHICLES. CORRECTION TO ORIGINAL TECHNICAL INSTRUCTIONS REGARDING DIAMETER OF REPLACEMENT BRAKE LINES. YD
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 9913125
SONE POLICE VEHICLES AND OTHER VEHICLES WITH 4R70W MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99185
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99195
SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 9947
ENGINE EXPERIENCING ROUGHNESS AT IDLE DUE TO EXHAUST SYSTEM RESONANCE. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: 99910
ADDRESSING CONCERNS WITH THE BRAKE LAMP INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK ON POLICE VEHICLES. *TT
Bulletin Number: 9996
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT
Bulletin Number: 99E03
EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT
Bulletin Number: BC0020961101
FRONT WHEEL RATTLE MAY BE CAUSED BY THE DUST SHIELD RATTLING. *TW
Bulletin Number: BC0072961101
WIRE WHEEL COVER CENTER ORNAMENT SEPARATES FROM THE BACKING PLATE. *TW
Bulletin Number: BC0263970201
LOCKING WIRE WHEEL COVER CENTER ORNAMENT WHERE THE EMBLEM HAS SEPARATED FROM THE BACKING PLATE. NEW REPLACEMENT PART. *JD
Bulletin Number: BC031A497020
INADVERTENT ABS ACTIVATION ON SMOOTH DRY PAVEMENT. *TW
Bulletin Number: BC0696961023
CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT
Bulletin Number: BC0706961022
LIGHT TO MODERATE AXLE NOISE (AXLE WHINE) AT 50 TO 65 MPH (80 TO 105 KPH) DURING ACCELS, DECELS OR CRUISE. *TT
Bulletin Number: BC0773961015
HIGH PITCH WHINING NOISE FROM THE ALTERNATOR MAY BE CAUSED BY A LOOSE ENG GROUND STRAP. *TT
Bulletin Number: BC0774961015
CONCERN FOR INTERMITTENT NO START/OR INTERMITTENT STALL & W/ NO DTC'S. *TT
Bulletin Number: BC0810961011
VEHICLES EQUIPPED W/ AN AODE OR 4R70W TRANS HAS A CONCERN OF SHUDDER FROM THE TRANSMISSION TORQUE CONVERTER CLUTCH IN 3RD OR 4TH GEAR OR DURING 3-4 SHIFT. *TT
Bulletin Number: BC1017097230
WHITE STRESS MARK IN THE DOOR SCUFF PLATE, REPLACE WITH NEW LEVEL PART. *JD
Bulletin Number: BC1017797230
WIND NOISE FROM THE FRONT DOOR AREA ON AFFECTED VEHICLES. *JD
Bulletin Number: BC1017897230
WIND NOISE FROM THE FRONT DOOR AREA AT VARYING SPEEDS AND CONDITIONS ON AFFECTED VEHICLES. *JD
Bulletin Number: BC1020197230
THE POWER POINT ELECTRICAL OUTLET WAS DELETED- DISREGARD THE NOTE IN THE 1997 OWNERS GUIDE ADVISING NOT TO PLUG OPTIONAL ELECTRICAL ACCESSORIES INTO THE CIGARETTE LIGHTER. *JD
Bulletin Number: BC105999705
VEHICLES BUILT BETWEEN 1/4/97 AND 4/14/97 MAY EXHIBIT A CONCERN OF LACK OF POWER. *TW
Bulletin Number: BC2241970501
VEHICLE MAY EXHIBIT A LACK OF POWER. *TW
Bulletin Number: BC2296970501
DIAGNOSTIC INSTRUCTIONS FOR A/C MODE FAILURE. *TW
Bulletin Number: BC3430972301
THE POWER POINT ELECTRICAL OUTLET WAS DELETED. *JD
Bulletin Number: BC3511972301
WIND NOISE FROM THE FRONT DOOR AREA ON AFFECTED VEHICLES. *JD
Bulletin Number: BC3512972301
WIND NOISE FROM THE FRONT DOOR AREA AT VARYING SPEEDS AND CONDITIONS ON AFFECTED VEHICLES. *JD
Bulletin Number: BC3552972301
A WHITE STRESS MARK IN THE DOOR SCUFF PLATE. *JD
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC9679961001
COMPLAINT OF A BUZZ/VIBRATION FELT IN THE STEERING WHEEL WHILE TURNING (USUALLY MORE NOTICEABLE TURNING RIGHT). *TT
Bulletin Number: CSP 08B04
FORD/LINCOLN MERCURY: CERTAIN 1992-2001 MODEL YEAR CROWN VICTORIA, GRAND MARQUIS, AND TOWN CAR VEHICLES REGISTERED IN THE STATES OF WISCONSIN AND CONNECTICUT UPGRADE MODIFICATIONS FOR HIGH SPEED REAR IMPACTS. *PE
1997 FORD C SERIES
Bulletin Number: 97716
FUEL INJECTION PUMP- BOSCH- SERVICE INFORMATION FOR FD1060/1460 DIESEL ENGINES. *JD
1997 FORD E-150
Bulletin Number: 05248
VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE. *TT
Bulletin Number: 071110
BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
Bulletin Number: 090308
MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455
Bulletin Number: 11496
SOME VEHICLES EQUIPPED WITH THE 4.2L ENGINE MAY EXHIBIT A VIBRATION OR BOOM, OFF IDLE BETWEEN 870 - 900 RPMS. *TT
Bulletin Number: 13186
INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS
Bulletin Number: 14992
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A DRIVELINE VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50 - 55 MPH. *TT
Bulletin Number: 15038
SOME VEHICLES MAY EXHIBIT RAPID WEAR OF THE FRONT BRAKE PADS (UNDER 10,000 MILES). *TT
Bulletin Number: 15354
SOME VEHICLES MAY EXHIBIT ACCELERATED FRONT DISC BRAKE PAD WEAR UNDER EXTREME LOADING CONDITIONS. *TT
Bulletin Number: 15517
SUBJECT REGARDING EXAGGERATED ENGINE BRAKING ON DECELERATION. *YD
Bulletin Number: 15799
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50-55 MPH. *TT
Bulletin Number: 17381
FRONT BRAKE PAD WEAR. *TT
Bulletin Number: 4619
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT
Bulletin Number: 4628
SOME VEHICLES MAY EXHIBIT REAR AXLE NOISE. *TT
Bulletin Number: 4638
MALFUNCTION INDICATOR LAMP ON, WITH P0300 - P0308 MISFIRE DIAGNOSTIC TROUBLE CODES WITH A 4.6L ENGINE. *TT
Bulletin Number: 6996
INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT
Bulletin Number: 97090297183
EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC
Bulletin Number: 976011
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 980317
SYMPTOMS REGARDING P0300-P0308 MISFIRE DTCS WITH 4.6L ENGINES. *YC
Bulletin Number: 982474
SOME VEHICLES WITH THE 4.2L ENGINE MAY EXHIBIT A VIBRATION OR BOOM, OFF IDLE BETWEEN 870-900 RPMS. *YC
Bulletin Number: 99131
CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: 99146
CONCERNS WITH THE OIL DIPSTICK AND / OR PCV VALVE DISLODGING FROM THE ENGINE AND / OR ENGINE OIL LEAKING FROM DIPSTICK TUBE. *TT
Bulletin Number: 99207
SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: 99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
Bulletin Number: BC0325961129
SOME FRONT END SERPENTINE BELTS MAY MAKE NOISE WHEN BETWEEN 30 AND 50 DEGREES FAHRENHEIT. *TW
Bulletin Number: BC0325972301
SOME 5.4L FRONT END SERPETNTINE BELTS MAY MAKE SOME NOISE BETWEEN TEMPERATURES FO 30 F-50 F. *JD
Bulletin Number: BC0696961023
CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT
Bulletin Number: BC0750961017
SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT
Bulletin Number: BC0782961014
CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT
Bulletin Number: BC0844961008
E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT
Bulletin Number: BC0853961007
AIRBAG LIGHT ON & CODE 21, MAY BE CAUSED BY AN ELECTROMAGNETIC INTERFERENCE GENERATED WITHIN THE ELECTRICAL SYSTEM. *TT
Bulletin Number: BC0883961004
VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT
Bulletin Number: BC0884961004
FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC5201961001
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Bulletin Number: BC5219961001
INCORRECT INFORMATION IN 1997 EVTM MANUAL. PIN CALL-OUTS ILLUSTRATIONS FOR C224 & C225 ARE IN REVERSE ORDER. *TT
1997 FORD E-250
Bulletin Number: 05248
VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE. *TT
Bulletin Number: 071110
BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
Bulletin Number: 11496
SOME VEHICLES EQUIPPED WITH THE 4.2L ENGINE MAY EXHIBIT A VIBRATION OR BOOM, OFF IDLE BETWEEN 870 - 900 RPMS. *TT
Bulletin Number: 11779
SOME VEHICLES MAY EXHIBIT BRAKE ROTOR CHECKING OR SIGNS OF EXCESSIVE HEAT BUILD-UP. *TT
Bulletin Number: 12835
SUBJECT REGARDING TIRE BALANCE HINT. *TT
Bulletin Number: 13186
INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS
Bulletin Number: 14992
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A DRIVELINE VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50 - 55 MPH. *TT
Bulletin Number: 15113
SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION. *YD
Bulletin Number: 15634
CONCERNS WITH BUMP STEER STEERING FEELING NOTED WHEN FRONT WHEELS / TIRES CONTACT ROAD SURFACE IRREGULARITIES. *TT
Bulletin Number: 15799
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50-55 MPH. *TT
Bulletin Number: 17211
A BUMP STEER STEERING FEELING, NOTED WHEN THE VEHICLE'S FRONT WHEELS/TIRES CONTACT ROAD SURFACE IRREGULARITIES. *TT
Bulletin Number: 4614
INFORMATION ON VEHICLES EXHIBITING ROUGH IDLE / MISS. *TT
Bulletin Number: 4616
BRIEF INFORMATION VEHICLES EXHIBITING HARD START / NO START CONDITION. *TT
Bulletin Number: 4617
BRIEF INFORMATION ON VEHICLES EXHIBITING LACK OF POWER CONDITION. *TT
Bulletin Number: 4625
BRIEF INFORMATION ON VEHICLES EXHIBITING A STALL ON DECELERATION CONDITION. *TT
Bulletin Number: 4629
BRIEF INFORMATION CONCERN VEHICLES EXHBITING EXTERNAL OIL LEAKS. *TT
Bulletin Number: 4638
MALFUNCTION INDICATOR LAMP ON, WITH P0300 - P0308 MISFIRE DIAGNOSTIC TROUBLE CODES WITH A 4.6L ENGINE. *TT
Bulletin Number: 4662
SOME VEHICLES MAY EXHIBIT BRAKE ROTOR CHECKING OR SIGNS OF EXCESSIVE HEAT BUILD-UP. *TT
Bulletin Number: 5046
REPEAT MESSAGE REGARDING VEHICLES EXHIBITING A LACK OF POWER. *TT
Bulletin Number: 5047
REPEAT MESSAGE REGARDING A HARD START / NO START CONDITION. *TT
Bulletin Number: 5050
REPEAT MESSAGE REGARDING A STALL ON DECEL CONDITION. *TT
Bulletin Number: 5250
INFORMATION ON SUPER DUTY MODELS WITH 7.3L DIESEL ENGINES EXHIBITING ROUGH IDLE / MISS CONDITION. *TT
Bulletin Number: 5251
SOME SUPER DUTY VEHICLES WITH 7.3L DIT DIESEL ENGINES MAY EXHIBIT 4X4 LIGHTS ON, 4X4 INOPERATIVE AND / OR MULTIPLE GEM CODES. *TT
Bulletin Number: 5254
INFORMATION ON SUPER DUTY 7.3 DIT DIESEL ENGINE VEHICLES EXHIBITI LACK OF POWER. *TT
Bulletin Number: 5262
SERVICE INFORMATION FOR VEHICLES EXHIBITING STALL ON DECELERATION CONDITION. *TT
Bulletin Number: 6417
ADDRESSING TIRE BALANCE HINTS. *TT
Bulletin Number: 6996
INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT
Bulletin Number: 976011
SUBJECT ON RELATIVE INJECTOR FLOW TEST SUCCESS STORY. *TT
Bulletin Number: 980298
INFORMATION REGARDING THE HOTLINE SURVEY. *YC
Bulletin Number: 9803000
HOTLINE CONTACT ID NUMBER ON OASIS. A NINE DIGIT CONTACT NUMBER IS ATTACHED TO THE OASIS INFORMATION WHEN A VIN AND SYMPTOM CODE IS ENTERED INTO OASIS. *YC
Bulletin Number: 980307
VEHICLE STALLS/QUITS WHILE DRIVING. *AK
Bulletin Number: 980312
EXCESSIVE WHITE SMOKE. VERIFY GLOW PLUG OPERATION BY PERFORMING GLOW PLUG SYSTEM OPERATION CHECK ON THE HARD START/NO START DIAGNOSTIC SHEET. *TT
Bulletin Number: 980317
SYMPTOMS REGARDING P0300-P0308 MISFIRE DTCS WITH 4.6L ENGINES. *YC
Bulletin Number: 980323
CONCERNS WITH EXTERNAL OIL LEAKS. *YC
Bulletin Number: 980325
COLD ENGINE UPPER KNOCK/TICK. *YC
Bulletin Number: 98120
SOME VEHICLES MAY EXPERIENCE BOOM / VIBRATION NOISE OFF IDLE DURING ACCELERATION AND DECELERATION. *TT
Bulletin Number: 982474
SOME VEHICLES WITH THE 4.2L ENGINE MAY EXHIBIT A VIBRATION OR BOOM, OFF IDLE BETWEEN 870-900 RPMS. *YC
Bulletin Number: 98-4722
REPEAT MESSAGE, NO CHANGE- ROUGH IDLE/MISS. *AK
Bulletin Number: 98-4726
REPEAT MESSAGE, NO CHANGE: HARD START/ NO START. *AK
Bulletin Number: 98-4734
LACK OF POWER DUE TO FAILURE OF ENGINE TURBO BOOST
Bulletin Number: 98-4742
VEHICLE STALLS UPON ACCELERATION. *AK
Bulletin Number: 985042
REPEAT MESSAGE REGARDING VEHICLES EXHIBITING ROUGH IDLE / MISS CONDITION. *TT
Bulletin Number: 985058
SUBJECT REGARDING EXTERNAL OIL LEAKS - REPEAT MESSAGE. *TT
Bulletin Number: 98L20
SPECIAL FIELD ACTION REGARDING REVISED WARANTY INFORMATION. *TT
Bulletin Number: 99131
CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: 99146
CONCERNS WITH THE OIL DIPSTICK AND / OR PCV VALVE DISLODGING FROM THE ENGINE AND / OR ENGINE OIL LEAKING FROM DIPSTICK TUBE. *TT
Bulletin Number: 99207
SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: BC0256970201
A RUNNING CHANGE FOR THE 7.3L TO ALLOW BETTER DEFINITION ON CYLINDER CONTRIBUTION TESTS IN PROCESS. *JD
Bulletin Number: BC0693961023
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Bulletin Number: BC0696961023
CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT
Bulletin Number: BC0750961017
SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT
Bulletin Number: BC0782961014
CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT
Bulletin Number: BC0844961008
E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT
Bulletin Number: BC0853961007
AIRBAG LIGHT ON & CODE 21, MAY BE CAUSED BY AN ELECTROMAGNETIC INTERFERENCE GENERATED WITHIN THE ELECTRICAL SYSTEM. *TT
Bulletin Number: BC0883961004
VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT
Bulletin Number: BC0884961004
FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT
Bulletin Number: BC2297970501
WHEN THE AIR CLEANER IS BEING REPLACED, THE DRAIN MECHANISM ON THE BOTTOM OF THE AIR CLEANER CASE IS TO BE CLEANED OF OBSTRUCTIONS. *TW
Bulletin Number: BC3212970213
CAMSHAFT POSITION SENSOR INFORMATION . *TW
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC5201961001
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Bulletin Number: BC5219961001
INCORRECT INFORMATION IN 1997 EVTM MANUAL. PIN CALL-OUTS ILLUSTRATIONS FOR C224 & C225 ARE IN REVERSE ORDER. *TT
Bulletin Number: DOR-X8B9R-11
This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly ma
1997 FORD E-350
Bulletin Number: 032120
7.3L DIT GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE - SERVICE TIP. *TT
Bulletin Number: 032121
A HIGH NUMBER OF HIGH PRESSURE REXROTH PUMPS AND INJECTION PRESSURE REGULATORS (IPR) ARE BEING REPLACED DUE TO OIL LEAKING, WHEN ALL THAT IS REQUIRED IS A NEW GASKET OR SEAL ON EITHER THE PUMP OR IPR. *TT
Bulletin Number: 032123
LOW RPM, NO START, RUNS POORLY, STALL. 7.3L DIT ENGINE. *TT
Bulletin Number: 05248
VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE. *TT
Bulletin Number: 071110
BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
Bulletin Number: 11779
SOME VEHICLES MAY EXHIBIT BRAKE ROTOR CHECKING OR SIGNS OF EXCESSIVE HEAT BUILD-UP. *TT
Bulletin Number: 12261
SUBJECT REGARDING ENGINE DIAGNOSTIC GUIDE FOR WARRANTY REIMBURSEMENT. *TT
Bulletin Number: 12835
SUBJECT REGARDING TIRE BALANCE HINT. *TT
Bulletin Number: 14963
SOME CUT-AWAY VEHICLES MAY EXHIBIT ANTI-SKID BRAKE SYSTEM DIAGNOSTIC TROUBLE CODE C1229, C1230 AND C1237. *TT
Bulletin Number: 14992
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A DRIVELINE VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50 - 55 MPH. *TT
Bulletin Number: 15113
SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION. *YD
Bulletin Number: 15634
CONCERNS WITH BUMP STEER STEERING FEELING NOTED WHEN FRONT WHEELS / TIRES CONTACT ROAD SURFACE IRREGULARITIES. *TT
Bulletin Number: 15799
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50-55 MPH. *TT
Bulletin Number: 17211
A BUMP STEER STEERING FEELING, NOTED WHEN THE VEHICLE'S FRONT WHEELS/TIRES CONTACT ROAD SURFACE IRREGULARITIES. *TT
Bulletin Number: 4614
INFORMATION ON VEHICLES EXHIBITING ROUGH IDLE / MISS. *TT
Bulletin Number: 4616
BRIEF INFORMATION VEHICLES EXHIBITING HARD START / NO START CONDITION. *TT
Bulletin Number: 4617
BRIEF INFORMATION ON VEHICLES EXHIBITING LACK OF POWER CONDITION. *TT
Bulletin Number: 4625
BRIEF INFORMATION ON VEHICLES EXHIBITING A STALL ON DECELERATION CONDITION. *TT
Bulletin Number: 4629
BRIEF INFORMATION CONCERN VEHICLES EXHBITING EXTERNAL OIL LEAKS. *TT
Bulletin Number: 4662
SOME VEHICLES MAY EXHIBIT BRAKE ROTOR CHECKING OR SIGNS OF EXCESSIVE HEAT BUILD-UP. *TT
Bulletin Number: 5046
REPEAT MESSAGE REGARDING VEHICLES EXHIBITING A LACK OF POWER. *TT
Bulletin Number: 5047
REPEAT MESSAGE REGARDING A HARD START / NO START CONDITION. *TT
Bulletin Number: 5050
REPEAT MESSAGE REGARDING A STALL ON DECEL CONDITION. *TT
Bulletin Number: 5250
INFORMATION ON SUPER DUTY MODELS WITH 7.3L DIESEL ENGINES EXHIBITING ROUGH IDLE / MISS CONDITION. *TT
Bulletin Number: 5254
INFORMATION ON SUPER DUTY 7.3 DIT DIESEL ENGINE VEHICLES EXHIBITI LACK OF POWER. *TT
Bulletin Number: 5262
SERVICE INFORMATION FOR VEHICLES EXHIBITING STALL ON DECELERATION CONDITION. *TT
Bulletin Number: 5343
THIS BULLETIN STATES THAT REPLACEMENT UNDER WARRANTY OF CERTAIN SPECIFIED COMPONENTS ON ANY 7.3L DIT DIESEL VEHICLE, REQUIRES THAT THE REPLACED COMPONENT BE RETURNED WITH THE APPROPRIATE YEAR DIESEL ENGINE DIAGNOSTIC GUIDE FOR WARRANTY REIM
Bulletin Number: 6417
ADDRESSING TIRE BALANCE HINTS. *TT
Bulletin Number: 97214
ENGINE - 7.3L DIT - GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE - SERVICE TIP. *TW
Bulletin Number: 97215
DIAGNOSTIC GUIDES FOR OUT-OF-WARRANTY VEHICLES TO BE USED AS A MASTER COPY - DIAGNOSTIC GUIDES NO LONGER AVAILABLE FROM ADISTRA. *TW
Bulletin Number: 97216
LEAK - OIL LEAKAT ENGINE VALLEY PAN AND/OR HIGH PRESSURE OIL PUMP - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE. *TW
Bulletin Number: 9726
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - GASEOUS FUEL PREP (GFP) VEHICLES - POWERTRAIN CONTROL MODULE (PCM) REPROGRAMMING REQUIRED - VEHICLES WITH 2.0L OR 4.9L ENGINE. *TW
Bulletin Number: 97618
LOW RPM- 7.3L DIT ENGINE FAILS TO START- CODE 340 STORED IN MEMORY AND/OR ENGINE FAILS TO ACHIEVE RATED SPEED FOR 2-3 MINUTES AFTER EXTENDED COLD SOAK- F-SERIES BUILT THROUGH 2/9/96 AND ALL ECONOLINES. *JD
Bulletin Number: 980307
VEHICLE STALLS/QUITS WHILE DRIVING. *AK
Bulletin Number: 980312
EXCESSIVE WHITE SMOKE. VERIFY GLOW PLUG OPERATION BY PERFORMING GLOW PLUG SYSTEM OPERATION CHECK ON THE HARD START/NO START DIAGNOSTIC SHEET. *TT
Bulletin Number: 980323
CONCERNS WITH EXTERNAL OIL LEAKS. *YC
Bulletin Number: 980323
DTC'S P1211/1212 ICP PRESSURE HIGHER/LOWER THAN EXPECTED.
Bulletin Number: 980325
COLD ENGINE UPPER KNOCK/TICK. *YC
Bulletin Number: 98-4722
REPEAT MESSAGE, NO CHANGE- ROUGH IDLE/MISS. *AK
Bulletin Number: 98-4726
REPEAT MESSAGE, NO CHANGE: HARD START/ NO START. *AK
Bulletin Number: 98-4734
LACK OF POWER DUE TO FAILURE OF ENGINE TURBO BOOST
Bulletin Number: 98-4742
VEHICLE STALLS UPON ACCELERATION. *AK
Bulletin Number: 985042
REPEAT MESSAGE REGARDING VEHICLES EXHIBITING ROUGH IDLE / MISS CONDITION. *TT
Bulletin Number: 985058
SUBJECT REGARDING EXTERNAL OIL LEAKS - REPEAT MESSAGE. *TT
Bulletin Number: 985A26
EXPERIENCING VIBRATION DURING LIGHT BRAKE APPLICATIONS AT HIGHWAY SPEEDS. *YC
Bulletin Number: 98L20
SPECIAL FIELD ACTION REGARDING REVISED WARANTY INFORMATION. *TT
Bulletin Number: 99E01
SUBJECT REGARDING ON-BOARD DIAGNOSTIC (OBD) SYSTEM UPGRADES. *TT
Bulletin Number: BC0256970201
A RUNNING CHANGE FOR THE 7.3L TO ALLOW BETTER DEFINITION ON CYLINDER CONTRIBUTION TESTS IN PROCESS. *JD
Bulletin Number: BC0693961023
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Bulletin Number: BC0696961023
CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT
Bulletin Number: BC0750961017
SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT
Bulletin Number: BC0782961014
CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT
Bulletin Number: BC0844961008
E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT
Bulletin Number: BC0853961007
AIRBAG LIGHT ON & CODE 21, MAY BE CAUSED BY AN ELECTROMAGNETIC INTERFERENCE GENERATED WITHIN THE ELECTRICAL SYSTEM. *TT
Bulletin Number: BC0883961004
VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT
Bulletin Number: BC0884961004
FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT
Bulletin Number: BC2297970501
WHEN THE AIR CLEANER IS BEING REPLACED, THE DRAIN MECHANISM ON THE BOTTOM OF THE AIR CLEANER CASE IS TO BE CLEANED OF OBSTRUCTIONS. *TW
Bulletin Number: BC2390970501
IF AN E350 REQUIRES ROTOR AND HUB REPLACEMENT, A REVISED THICKER PLATE ROTOR IS NOW AVAILABLE. *TW
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC5201961001
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Bulletin Number: BC5219961001
INCORRECT INFORMATION IN 1997 EVTM MANUAL. PIN CALL-OUTS ILLUSTRATIONS FOR C224 & C225 ARE IN REVERSE ORDER. *TT
Bulletin Number: DOR-X8B9R-11
This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly ma
1997 FORD E-450
Bulletin Number: 05248
VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE. *TT
Bulletin Number: 12186
SOME E-450 VEHICLES WITH THE DANA 80 MODEL AXLE MAY EXHIBIT A CUSTOMER CONCERN WITH THE LEVEL OF SOUND (WHINE) THAT IS PRODUCED ABOVE 35 MPH. *MJS
Bulletin Number: 12514
SUBJECT REGARDING DANA 80 AXLE WHINE / DAMPENED DRIVESHAFT. *TT
Bulletin Number: 13822
SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY, MAY EXHIBIT A WHINE ABOVE 35 MPH. *MJS
Bulletin Number: 13822
SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY MAY EXHIBIT A WHINE ABOVE 35 MPH. *TT
Bulletin Number: 14963
SOME CUT-AWAY VEHICLES MAY EXHIBIT ANTI-SKID BRAKE SYSTEM DIAGNOSTIC TROUBLE CODE C1229, C1230 AND C1237. *TT
Bulletin Number: 18382
FLUID LEAKING FROM THE VENT ON THE TRANSMISSION MOUNTED PARKING BRAKE ASSEMBLY. *TT
Bulletin Number: 5224
SOME VEHICLES WITH THE DANA 80 MODEL AXLE MAY EXHIBIT A CUSTOMER CONCERN WITH THE LEVEL OF SOUND (WHINE) THAT IS PRODUCED ABOVE 35 MPH. ENGINEERING IS INVESTIGATING. *TT
Bulletin Number: 5816
FOR VEHICLES WITH MODEL 80 REAR AXLES, EXHIBITING A WHINE NOISE CONCERN, A SERVICE KIT WITH A DAMPENED DRIVESHAFT IS AVAILBLE. *TT
Bulletin Number: 6599
SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY MAY EXHIBIT A CONCERN WITH THE AMOUNT OF SOUND, WHINE PRODUCED ABOVE 35 MPH.
Bulletin Number: 8048
SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY, MAY EXHIBIT A WHINE ABOVE 35 MPH. *TT
Bulletin Number: 8048
SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY MAY EXHIBIT A WHINE ABOVE 35 MPH. *TT
1997 FORD ECONOLINE
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 00154
INFORMATION ON REAR AXLE WHINE-VEHICLES EQUIPPED WITH DANA 80 AXLES-5.4L/6.8L AND 7.3L. *JB
Bulletin Number: 00154
SOME VEHICLES WITH DANA 80 REAR AXLES MAY EXHIBIT AN EXCESSIVE AMOUNT OF AXLE WHINE NOISE. *JB
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 00239
A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. *TT
Bulletin Number: 00261
SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES. *TT
Bulletin Number: 0038
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS
Bulletin Number: 00510
CUSTOMERS MAY BE CONCERNED THAT VEHICLE LOOKS LIKE IT DOGTRACKS, DUE TO A UNIQUE FEATURE OF THE VEHICLE THAT COMBINE TO CREATE AN OPTICAL ILLUSION OF DOGTRACKING, A CONDITION WHICH THE REAR AXLE IS NOT SQUARE TO THE CHASSIS. *MJS
Bulletin Number: 00610
INFORMATION ON THE 7.3L DIT ENGINES, ROTUNDA TOOL HAS ISSUED AN INJECTOR PERFORMANCE ANALYZER THAT MAY NOW BE PRUCHASED AS AN EFFECTIVE AID IN HELPING TO RESOLVE ROUGH IDLE CONCERNS. *MJS
Bulletin Number: 00611
SOME BI-FUEL VEHICLES MAY REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT DURING SERVICE AND MAY NOT RUN ON CNG OR LPG., RECALIBRATION OF THE PCM/REPLACEMENT. *MJS
Bulletin Number: 00L05
THIS SERVICE ACTION REQUIRES THE REPLACEMENT OF TWO EMISSION CONTROL LABELS. *TT
Bulletin Number: 01119
SOME VEHICLES WITH HIGH ODOMETER READING OR SEVERE SERVICE MAY EXHIBIT A CREAKING NOISE WHEN TURNING WHEEL OR DRIVING OVER UNEVEN SURFACES ON VEHICLES PRODUCE BEFORE 2/6/2001. *TT
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03213
A NO-START OR REDUCED POWER CONDITION MAY OCCUR INTERMITTENTLY. *TT
Bulletin Number: 032131
ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *TT
Bulletin Number: 032132
SOME VEHICLES EQUIPPED WITH AFTERMARKET MODIFICATIONS MAY EXHIBIT A CRANK BUT NO START OR A HARD START/LONG CRANK CONDITION. *TT
Bulletin Number: 032137
FOR 7.3L DIT ENGINES, ROTUNDA TOOL HAS ISSUED AN INJECTOR PERFORMANCE ANALYZER THAT MAY NOW BE PURCHASED AS AN EFFECTIVE AID IN HELPING TO RESOLVE ROUGH IDLE CONCERNS. *TT
Bulletin Number: 04E10
EMISSION RECALL 04E10: COMPRESSED NATURAL GAS (CNG) VEHICLES - FITTING CONNECTOR REPLACEMENT. *MJ
Bulletin Number: 11781
INFORMATION ON SETTING THE CHECK ENGINE LIGHT AND SETTING DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK). *TT
Bulletin Number: 12070
VEHICLES THAT ARE LOADED TO THE UPPER END OF FVW, WITH THE MAJORITY OF THE LOAD BETWEEN THE AXLES, MAY EXHIBIT INNER EDGE TIRE WEAR DUE TO INCORRECT ALIGNMENT. *MJS
Bulletin Number: 12123
VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT, DUE TO INCORRECT FRONT END ALIGNMENT SETTINGS. *MJS
Bulletin Number: 12139
SOME VEHICLES EQUIPPED WITH 4.6L OR 6.8L ENGINES MAY EXHIBIT A COLD START ENGINE NOISE UNTIL WARMED UP. *MJS
Bulletin Number: 12162
SOME VEHICLES EQUIPPED WITH 6.8L ENGINES, MAY EXHIBIT A CUSTOMER CONCERN OR ENGINE ROAR OR ENGINE NOISE FOR THE FIRST FEW MINUTES OF OPERATION AFTER A COLD START. *MJS
Bulletin Number: 12230
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12287
SOME VEHICLES MAY EXHIBIT A CONCERN WITH POOR RANGE OF THE REMOTE KEYLESS ENTRY (RKE) TRANSMITTER. *TT
Bulletin Number: 12593
CONCERNS WITH CRACKS ON THE RIGHT REAR SIDE OF THE #1 FRAME CROSSMEMBER. *TT
Bulletin Number: 12741
SOME VEHICLES UNDER SEVERE DUTY CYCLES MAY EXHIBIT CRACKS ON THE LOWER RADIATOR SUPPORT. *TT
Bulletin Number: 12767
EXHIBITING A VIBRATION THAT MAY BE INTERPRETED AS AN NVH CONDITION. *TT
Bulletin Number: 12835
SUBJECT REGARDING TIRE BALANCE HINT. *TT
Bulletin Number: 12870
SOME CUSTOMERS MAY COMMENT ON A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT
Bulletin Number: 12890
BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE THREAD. *TT
Bulletin Number: 12915
CUSTOMER MAY COMPLAIN OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT
Bulletin Number: 13117
SOME VEHICLES WITH AN ILLUMINATED AIR BAG LAMP MAY HAVE MODIFIED SEAT CONFIGURATIONS. *TT
Bulletin Number: 13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
Bulletin Number: 13367
SOME VEHICLES WITH REAR BRAKE DRUMS MAY EXHIBIT BRAKE SQUEAL NOISE. *TT
Bulletin Number: 13488
SOME VEHICLES EQUIPPED WITH 7.3L DIT ENGINE MAY EXHIBIT A ROUGH ENGINE IDLE. *TT
Bulletin Number: 13934
SOME VEHICLES MAY EXHIBIT A-PILLAR SHEET METAL CRACKS AROUND FRONT DOOR HINGES; FRONT DOOR SKIN SEPARATES AND DOOR INNER SHEET METAL CRACKED AROUND FRONT HINGES; OR FRONT DOORS OPEN TOO FAR AND EXTEND INTO THE FRONT FENDERS. *TT
Bulletin Number: 14365
THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT. *JB
Bulletin Number: 15271
DEDICATED CNG REGULATOR BOWL KIT AVAILABLE. *JG
Bulletin Number: 15871
SOME VEHICLES MAY EXHIBIT INTERFERENCE AND / OR STATIC IN THE LAND-MOBILE RADIO. *TT
Bulletin Number: 16480
DIAGNOSTIC TROUBLE CODE (DTC) P0340, POSSIBLE FALSE CODE. VARIOUS MODELS INCLUDING 1994-1996 FORD EXCURSION. *TT
Bulletin Number: 16683
FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB
Bulletin Number: 16697
EXHAUST AIR RUSH NOISE AND LOWER POWER. *TT *JB
Bulletin Number: 16916
REPEATED BLOWN FUSES FOR REAR IN VEHICLE CIRCUITS WITH INOPERATIVE REAR BRAKE OR TAIL LAMPS. *TT
Bulletin Number: 16945
AN OIL LEAK AT THE TURBOCHARGER PEDESTAL AROUND THE EXHAUST BACKPRESSURE ACTUATOR. *TT
Bulletin Number: 16999
HIGH PRESSURE OIL PUMP LEAK. *TT
Bulletin Number: 17385
AIR BAG LAMP ILLUMINATED. *TT
Bulletin Number: 17467
ENGINE OR FUEL SYSTEM CONCERNS WHEN USING FUEL WITH GREATER THAN 5% BIODIESEL CONCENTRATION. *TT
Bulletin Number: 4664
THIS BULLETIN STATES THAT FOR CERTAIN VEHICLES IT IS NOT POSSIBLE TO SET THE CHECK ENGINE LIGHT AND SET DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK) IF A CUSTOMER REFUELS THE VEHICLE WITH THE ENGINE RUNNING. *
Bulletin Number: 4981
SOME VEHICLES EQUIPPED WITH 5.4L ENGINES MAY EXHIBIT A COLD START ENGINE KNOCK CONCERN UNTIL WARMED UP. *TT
Bulletin Number: 5257
INFORMATION ON VEHICLES EXHIBITING COLD ENGINE KNOCK. *TT
Bulletin Number: 5371
SOME VEHICLES MAY EXHIBIT A CONCERN WITH POOR RANGE OF THE REMOTE KEYLESS ENTRY (RKE) TRANSMITTER. *TT
Bulletin Number: 5892
SUBJECT REGARDING TECHINICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES WITH GFI ALTERNATE FUEL SYSTEMS. *TT
Bulletin Number: 6290
INFORMATION REGARDING THE IMPROVED RADIATOR SUPPORT. *TT
Bulletin Number: 6417
ADDRESSING TIRE BALANCE HINTS. *TT
Bulletin Number: 6461
CONCERNS OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *T
Bulletin Number: 6505
BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE ON NATURAL GAS VEHICLES. *TT
Bulletin Number: 6538
SOME VEHICLES BUILT BEFORE APRIL 1, 1999 MAY HAVE A CUSTOMER CONCERN OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT
Bulletin Number: 6585
SOME VEHICLES EQUIPPED WITH 7.3L DIT DIESEL ENGINES MAY DEVELOP A CRACKED FLEXPLATE. *TT
Bulletin Number: 6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
Bulletin Number: 7263
SOME VEHICLES WITH REAR BRAKE DRUMS MAY EXHIBIT BRAKE SQUEAL NOISE. *TT
Bulletin Number: 7475
SOME VEHICLES EQUIPPED WITH 73L DIT ENGINE MAY EXHIBIT A ROUGH ENGINE IDLE. *TT
Bulletin Number: 8260
SOME VEHICLES MAY EXHIBIT A-PILLAR SHEET METAL CRACKS AROUND FRONT DOOR HINGES; FRONT DOOR SKIN SEPARATES AND DOOR INNER SHEET METAL CRACKED AROUND FRONT HINGES; OR FRONT DOORS OPEN TOO FAR AND EXTEND INTO THE FRONT FENDERS. *TT
Bulletin Number: 96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
Bulletin Number: 96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
Bulletin Number: 96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
Bulletin Number: 962410
TRANSMISSION - E40D - 4R70W - 4R44E - 5R55E - NEW DIGITAL TRANSMISSION RANGE SENSOR - DIAGNOSIS SERVICE TIP. *TW
Bulletin Number: 962418
TRANSMISSION - E40D - REVISED DESIGN FORWARD PLANET THRUST WASHER - SERVICE TIP. *TW
Bulletin Number: 96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
Bulletin Number: 96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
Bulletin Number: 962511
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 962523
RUNS ROUGH - MALFUNCTION INDICATOR LAMP (MIL) ON - DIAGNOSTIC TROUBLE CODES (DTCS) P0300 THROUGH P0308 STORED IN MEMORY - VEHICLES BUILT THROUGH 10/14/96 WITH 4.6L ENGINE. *TW
Bulletin Number: 962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 97090297187
SOME VEHICLES MAY STALL WHEN THE TRANSMISSION IS PLACED INTO GEAR. *YC
Bulletin Number: 971110972313
A NEW DESIGN TRANSMISSION CASE AND EXTENSION HOUSING HAS BEEN RELEASED. *YC
Bulletin Number: 971110972314
EXHIBITING A HARSH 1-2 UPSHIFT DURING LIGHT THROTTLE. *YC
Bulletin Number: 9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD
Bulletin Number: 97410
TRANSMISSION- E4OD- COOLER BYPASS VALVE SERVICE DURING TRANSMISSION OVERHAUL- SERVICE TIP. *JD
Bulletin Number: 9747
FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD
Bulletin Number: 97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
Bulletin Number: 97512
IDLE- ROLLING IDLE- SURGE- VEHICLES BUILT 8/96 THROUGH 12/96 WITH 7.3L ENGINE. *JD
Bulletin Number: 9755
MALFUNCTION INDICATOR LAMP (MIL)- MIL ILLUMINATION- DIAGNOSTIC TROUBLE CODE (DTC) P0446 STORED IN MEMORY. *JD
Bulletin Number: 976011
SUBJECT ON RELATIVE INJECTOR FLOW TEST SUCCESS STORY. *TT
Bulletin Number: 97625
AIR CONDITIONING- NO TEMPERATURE CONTROL- VEHICLES BUILT THROUGH 11/21/96. *JD
Bulletin Number: 9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
Bulletin Number: 97710
POWER WINDOWS- INOPERATIVE- FUSE OPENS- VEHICLES BUILT 9/1/96 THROUGH 1/13/97. *JD
Bulletin Number: 98021698310
SOME VEHICLES SEAT BELTS MAY BE SLOW TO RETRACT. *YC
Bulletin Number: 98113
SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT
Bulletin Number: 9811339
INFORMATION ON THE REVISED FUEL INJECTOR O-RING KIT. *TT
Bulletin Number: 9811341
INFORMATION ON SERVICING AN ILLUMINATED AIR BAG LAMP. *TT
Bulletin Number: 98114
INFORMATION PROVIDED TO AID THE TECHINICIAN IN DIAGNOSING AND REPAIRING VARIOUS DOOR LOCK AND LATCH CONCERNS. *TT
Bulletin Number: 98123
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT
Bulletin Number: 98129
SOME VEHICLES MAY EXHIBIT A 1ST GEAR "TICKING" NOISE. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 98151
MALFUNCTION INDICATOR LAMP FAILED. YD
Bulletin Number: 981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 98168
TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 982019
CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR. *YC
Bulletin Number: 98205
EXHIBITING ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982312
ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 982313
SOME VEHICLES WITH A 7.3L DIRECT INJECTION (DI) TURBO DIESEL ENGINE, ONE OR MORE OF THE FOLLOWING CONCERNS MAY BE PRESENT: ROUGH IDLE, STALLING, HESITATION/ STUMBLE, LOSS / LACK OF POWER, POOR FUEL ECONOMY, AND EXCESSIVE OIL CONSUMPTION.
Bulletin Number: 982314
PREMATURE WEAR OF THE BELT TENSIONER MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982512
SOME VEHICLES WITH HIGHER ODOMETER READINGS MAY EXPERIENCE A HESITATION ON ACCELERATION JUST OFF IDLE AND MISFIRE COMPLAINTS WITH MALFUNCTION INDICATOR LALMP ( MIL ) ON. *YC
Bulletin Number: 982544
SOME MOTOR HOME VEHICLES EQUIPPED WITH E4OD TRANSMISSIONS MAY EXPERIENCE HYDRAULIC SYSTEM MALFUNCTIONS AFTER REPLACING THE TRANSMISSION CASE. *YC
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 983106
INFORMATION REGARDING ENGINE ASSEMBLIES BEING ADDED TO THE FQR (FORD QUALITY RENEWAL) PROGRAM. *TT
Bulletin Number: 983215
SOME VEHICLES WITH MAY EXHIBIT HIGHER THAN NORMAL ENGINE IDLE SPEEDS. *TT
Bulletin Number: 983281
SOME CUSTOMERS MAY EXPERIENCE A NOISE WHILE TURNING. *TT
Bulletin Number: 983283
ADDRESSING A CONCERN WITH AN AMBER ABS WARNING INDICATOR ILLUMINATED WITH CODE 1095 OR 1096 STORED IN MEMORY OF THE 4WABS MODULE. *TT
Bulletin Number: 983312
SOME VEHCILES MAY EXHIBIT A SLOW RETRACTING SEAT BELT. *TT
Bulletin Number: 983570
SOME ENGINES MAY EXHIBIT OIL LEAKAGE. *TT
Bulletin Number: 98418
ABSENCE OF TEMPERATURE CONTROL ON SOME VEHICLES. *YC
Bulletin Number: 98419
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC
Bulletin Number: 98423
SOME VEHICLES MAY EXPERIENCE A HARSH 1/2 SHIFT WHILE DRIVING UNDER LIGHT THROTTLE CONDITIONS. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 985097
SOME VEHICLES WITH 4WABS MAY HAVE AN AMBER ABS WARNING INDICATOR ILLUMINATED WITH CODE C1095 OR C1096 STORED IN MEMORY OF THE 4WABS MODULE. *TT
Bulletin Number: 98510
CONCERNS WITH NO TEMPERATURE CONTROL. *YC
Bulletin Number: 985102
SOME VEHICLES THAT ARE LOADED TO THE UPPER END OF GVW, WITH THE MAJORITY OF THE LOAD BETWEEN THE AXLES, MAY EXHIBIT INNER EDGE TIRE WEAR DUE TO INCORRECT ALIGNMENT. *TT
Bulletin Number: 985153
SOME VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT. *TT
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 9859
A HARD TO TURN IGNITION KEY, AND/OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 98710
A HARSH 1-2 SHIFT WHILE DRIVING UNDER LIGHT THROTTLE CONDITIONS. *YC
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 98E02
REPROGRAMMINGPOWERTRAIN CONTROL MODULE CALIBRATION CODES ON SOME 1997 VEHICLES. *YC
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99141
SUBJECT REGARDING A HIGH NUMBER OF BALL JOINTS BEING REPLACED AS THE RESULT OF ROUTINE INSPECTIONS OR OF COMPLAINTS OF TIRE WEAR AND LOOSE FEELINGS IN THE STEERING SYSTEM. *TT
Bulletin Number: 99141
COMPLAINTS OF TIRE WEAR AND LOOSE FEELINGS IN THE STEERING SYSTEM. *TT
Bulletin Number: 991411
SOME VEHICLES MAY EXHIBIT A CRACK ON THE RIGHT REAR SIDE OF THE #1 CROSSMEMBER RESULTING IN A CREAKING NOISE WHILE TURNING THE WHEEL OR DRIVING OVER UNEVEN SURFACES. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99164
CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER. *TT
Bulletin Number: 991811
SUBJECT REGARDING FRONT PASSENGER SIDE STEPWELL COVER NOT FLUSH. *TT
Bulletin Number: 99185
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 992311
EXPERIENCING INTERMITTENT OR LOW RANGE OF THE REMOTE KEYLESS ENTRY (RKE) SYSTEM. *TT
Bulletin Number: 99236
SUBJECT REGARDING 4R100 TRANSMISSION FLEXPLATE REPLACEMENT FOR VEHICLES WITH 7.3L DIESEL ENGINE. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 996034
EXPERIENCING A ENGINE KNOCK AT COLD START-UP. *TT
Bulletin Number: 996890
SOME VEHICLES WITH AN ILLUMINATED AIR BAG LAMP MAY HAVE MODIFIED SEAT CONFIGURATIONS WHICH MAY HAVE BEEN CHANGED BY MODIFIERS OR THE CUSTOMER. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: 9996
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT
Bulletin Number: 9997
SOME VEHICLES MAY EXHIBIT A "SQUEAKING" OR "MOANING" NOISE FROM THE STEERING COLUMN WHILE TURNING. *TT
Bulletin Number: 99E03
EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT
Bulletin Number: BC0042961101
DIAGNOSTIC INSTRUCTIONS FOR ECONOLINES EQUIPPED WITH A PASSENGER SIDE AIRBAG AND AN ERROR CODE OF 29. *TW
Bulletin Number: BC0052970201
1997 ECONOLINE EQUIPPED WITH 7.3L ENGINES MAY EXPERIENCE AN INOPERATIVE CHARGING SYSTEM. THE TERMINAL B+ CONNECTION AT THE ALTERNATOR MAY BE BROKEN DUE TO HIGH TENSION ON THE TERMINAL FROM THE WIREING HARNESS. *JD
Bulletin Number: BC0052972301
VEHICLES EQUIPPED WITH 7.3L ENGINES MAY EXPERIENCE AN INOPERATIVE CHARGING SYSTEM- THE TERMINAL B+ CONNECTION AT THE ALTERNATOR MAY BE BROKEN DUE TO HIGH TENSION ON THE TERMINAL FROM THE WIRING HARNESS. JD
Bulletin Number: BC0053970201
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC0053972301
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC0054961101
VEHICLES MAY HAVE BEEN BUILT WITH A 240 SECOND MISFIRE DELAY. *TW
Bulletin Number: BC0056972301
SOME VEHICLES WITH AIR CONDITIONING CAN EXHIBIT A COLD START ACCESSORY DRIVE BELT NOISE (CHIRP) CONCERN. *JD
Bulletin Number: BC007191101
ECONOLINES WITH POWER WINDOWS MAY EXPERIENCE AN OPEN 30 AMP FUSE. *TW
Bulletin Number: BC0211970201
POWER WINDOWS MAY EXPERIENCE AN OPEN 30 AMP FUSE. NEW WINDOW REGULATOR MOTOR. *JD
Bulletin Number: BC0315961101
FEAD BELT SQUEAL, COLD ONLY. *TW
Bulletin Number: BC0315970201
FEAD BELT SQUEAL, COLD ONLY. REVISED BELT RELEASED. *JD
Bulletin Number: BC0320961101
ROLLING IDLE/STALL. *TW
Bulletin Number: BC0320970201
ROLLING IDLE/STALL. *JD
Bulletin Number: BC0320972301
ROLLING IDLE/STALL- CYLINDER CONTRIBUTION TEST, AND INJECTOR BUZZ TEST. *JD
Bulletin Number: BC0322961101
HARD STARTING WITH DTC'S P0341, P0344. *TW
Bulletin Number: BC0325972301
SOME 5.4L FRONT END SERPETNTINE BELTS MAY MAKE SOME NOISE BETWEEN TEMPERATURES FO 30 F-50 F. *JD
Bulletin Number: BC0340961127
CERTAIN 1997 VEHCILES MAY HAVE BEEN BUILT WITH THE 240 SECOND MISFIRE DELAY. *TW
Bulletin Number: BC0362961125
IF ON A 1977 ECONOLINE THE KEY CHIMES SOUND 5 TIMES DURING THE START OR DURING VEHICLE OPERATION, THIS INDICATES THAT THE AIRBAG LAMP HAS A FAULT AND THERE IS A FAULT IN THE AIR BAG SYSTEM. *TW
Bulletin Number: BC0363961125
1997 ECONOLINES EQUIPPED WITH PASSENGER SIDE AIR BAG EXHIBITING CODE 29 OR OTHER INTERMITTENT AIR BAG CODES. *TW
Bulletin Number: BC0477961114
ENGINEERING IS INVESTIGATING DEALERSHIP CONCERNS WITH FOULED OR CRACKED SPARK PLUGS. *TW
Bulletin Number: BC0603961101
CORRECTION TO 1997 ECONOLINE EVTM PAGE 60-5 - PIN CALL-OUTS ON ILLUSTRATIONS FOR C224 AND C225 ARE IN REVERSE ORDER. *TW
Bulletin Number: BC0693961023
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Bulletin Number: BC0695961023
'OFF-IDLE' VIBRATION/BOOM/DRONE EMITTING FROM THE EXHAUST SYSTEM ON 4.2L ENGINES. *TT
Bulletin Number: BC0696961023
CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT
Bulletin Number: BC0750961017
SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT
Bulletin Number: BC0754961017
VEHICLES MAY EXPERIENCE FLICKERING INTERIOR COURTESY LIGHTS WHILE TURNING OR GOING OVER BUMPS. *TT
Bulletin Number: BC0782961014
CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT
Bulletin Number: BC0844961008
E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT
Bulletin Number: BC0853961007
AIRBAG LIGHT ON & CODE 21, MAY BE CAUSED BY AN ELECTROMAGNETIC INTERFERENCE GENERATED WITHIN THE ELECTRICAL SYSTEM. *TT
Bulletin Number: BC0883961004
VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT
Bulletin Number: BC0884961004
FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT
Bulletin Number: BC1015297020
VEHICLES MAY EXPERIENCE AN INOPERATIVE CHARGING SYSTEM. *JD
Bulletin Number: BC1015397020
VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC1016997230
REAR RADIO CONTROLS MAY EXPERIENCE INOPERATIVE REAR SPEAKERS. *JD
Bulletin Number: BC1020597230
VEHICLES BUILT BETWEEN AUGUST 1996-SEPTEMBER 1996 WITH SPEED CONTROL AND AIRBAGS MAY EXPERIENCE A NOISE IN THE STEERING WHEEL WHILE TURNING. *JD
Bulletin Number: BC1022397230
VEHICLES WITH 7.3L ENGINE WHICH AS A ROLLING IDLE CONDITION AND HAS A CALIBARATION OF 7-90C-R10, 7-90K-R10, 7-90N-R10. OR 7-90Q-R10, YOU CAN SERVICE THE IDLE CONDITION BY REPROGRAMMING THE PCM WITH THE FEBRUARY SBDS UPDATE DISK. *JD
Bulletin Number: BC1028197020
FLASHING AIRBAG LIGHT AFTER REPLACING THE ECS MODULE. *JD
Bulletin Number: BC2393970501
THE PROPER ADAPTER FOR CONNECTING THE 1997 ECONOLINE 4 WHEEL ANTI-LOCK BRAKE SYSTEM TO THE BREAKOUT BOX IS THE ROTUNDA 007-00108 ABS ADAPTER. *TW
Bulletin Number: BC3213970213
CONTINUOUSLY FLASHING AIRBAG AFTER REPLACING THE ECS MODULE AND NO CODES PRESENT. *TW
Bulletin Number: BC3274970207
REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS A
Bulletin Number: BC3341973101
EFFECTIVE IMMEDIATELY THE 5.8L ENGINE ASSEMBLY FOR THE VEHICLE IS AVAILABLE AS A FORD QUALITY RENEWAL ASSEMBLY. *JD
Bulletin Number: BC3373972301
7.3L ENGINE WHICH HAS A ROLLING IDLE CONDITION AND HAS A CALIBARATION OF 7-90CK-R10 OR 7-90N-R10, CAN SERVICE THE IDLE CONDITION BY REPROGRAMMING THE PCM WITH THE JANUARY SBDS UPDATE DISK.
Bulletin Number: BC3420972301
VEHICLES BUILT BETWEEN AUGUST 1996 - SEPTEMBER 1996 WITH SPEED CONTROL AND AIR BAGS MAY EXPERIENCE A NOISE IN THE STEERING WHEEL WHILE TURNING. *JD
Bulletin Number: BC3551972301
VEHICLES WITHOUT REAR RADIO CONTROLS MAY EXPERIENCE INOPERATIVE REAR SPEAKERS. *JD
Bulletin Number: BC5187961001
EXPERIENCE VEHICLE W/ FLICKERING INTERIOR COURTESY LIGHTS WHILE TURNING OR GOING OVER BUMPS. *TT
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC5201961001
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Bulletin Number: BC5203961001
'OFF-IDLE' VIBRATION/BOOM/DRONE EMITTING FROM THE EXHAUST SYSTEM ON VEHICLES EQUIPPED W/ 4.2L ENGINES. *TT
Bulletin Number: BC5219961001
INCORRECT INFORMATION IN 1997 EVTM MANUAL. PIN CALL-OUTS ILLUSTRATIONS FOR C224 & C225 ARE IN REVERSE ORDER. *TT
Bulletin Number: DOR-X8B9R-11
This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly ma
1997 FORD ESCORT
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 0059
SUBJECT CONCERNING THE IDLE-VIBRATION- 2.0L AND ZETEC ENGINES- SERVICE TIP. *MJS
Bulletin Number: 0069
SOME VEHICLES MAY EXHIBIT A GRINDING NOISE WHILE BRAKING, BRAKE DRAG AND/OR UNEVEN FRONT BRAKE PAD WEAR MAY OCCUR. *MJS
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 020901
ROUGH IDLE, LOW POWER AND / OR STALL AT IDLE, A MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0300 THROUGH P0304 STORED IN MEMORY. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH
Bulletin Number: 0291
SOME VEHICLES EQUIPPED WITH THE 2.0L SPI ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND DIAGNOSTIC TROUBLE CODES (DTC) P0300 THROUGH P0304 STORED. *TT
Bulletin Number: 031515
IDLE VIBRATION ON VEHICLES EQUIPPED WITH 2.0L SPI OR ZETEC ENGINE ONLY. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04V09
TRW VEHICLE SAFETY SYSTEMS, INC. IS RECALLING CERTAIN SERVICE REPLACEMENT SEATBELT RETRACTORS (DRIVER'S SIDE FRONT RETRACTOR IN GRAY) MANUFACTURED IN DECEMBER 2002 AND SOLD AS A SERVICE REPLACEMENT PART BETWEEN DECEMBER 2002 AND JULY 2004.
Bulletin Number: 11518
SOME VEHICLES MAY EXHIBIT CONCERNS CREATED BY WATER INGESTION INTO THE INTEGRATED RELAY CONTROL MODULE (IRCM). *TT
Bulletin Number: 11525
INFORMATION ON THE DIFFERENT TYPES OF REMOTE KEYLESS ENTRY SYSTEMS. *TT
Bulletin Number: 11526
THE WORKSHOP MANUAL REFERENCE TO TRANSMISSION FLUID TEMPERATURE SENSOR RESISTANCE IS INCORRECT. THIS BULLETIN LIST THE CORRECT RESISTANCE. *TT
Bulletin Number: 11769
SOME VEHICLES MAY EXHIBIT BRIEF SPARK KNOCK ON ACCELERATION DURING HOT WEATHER ONCE THE ENGINE HAS THOROUGHLY WARMED UP. *TT
Bulletin Number: 12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
Bulletin Number: 12216
THIS BULLETIN MENTIONS THAT FOR ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12294
SUBJECT REGARDING THE NGS FUEL ECONOMY TEST. *TT
Bulletin Number: 12295
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON, STALL AT TIP-IN FROM IDLE, ENGINE HESITATION, AND / OR SURGE CAUSED BY THE MASS AIR FLOW (MAF) SENSOR. *TT
Bulletin Number: 12594
SOME VEHICLES MAY EXHIBIT TRANSMISSION AND / OR MALFUNCTION INDICATOR LAMP ON CONCERNS RELATING TO THE DIAGNOSIS AND REPLACEMENT OF THE TRANSMISSION RANGE SENSOR (TR). *TT
Bulletin Number: 12834
BRIEF INFORMATION REGARDING TRANSMISSION FLUID. *TT
Bulletin Number: 13107
CONCERNS WITH LACK OF HEAT / THERMOSTAT CONTAMINATION. *TT
Bulletin Number: 13160
VEHICLES MAY EXHIBIT TRANSMISSION AND / OR MALFUNCTION INDICATOR LAMP ON CONCERNS RELATING TO THE DIAGNOSIS AND REPLACEMENT OF THE TRANSMISSION RANGER SENSOR (TRS). *TT
Bulletin Number: 13162
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LIGHT ON WITH A DIAGNOSTIC TROUBLE CODE P1744. *TT
Bulletin Number: 13214
INFORMATION REGARDING BRAKE CALIPER PIN CORROSION. *MJS
Bulletin Number: 13421
SOME VEHICLES MAY EXHIBIT GRINDING NOISES, OR GREATER THAN NORMAL BRAKE ROUGHNESS WHEN APPLYING THE BRAKES IMMEDIATELY AFTER INSTALLING MOTORCRAFT BR-18 FRONT BRAKE PAD. *TT
Bulletin Number: 13494
SOME VEHICLES WITH THE 2.0L SPI ENGINE MAY EXHIBIT A LACK OF HEAT AND TEMPERATURE GAUGE READING COLD. *TT
Bulletin Number: 14846
SOME VEHICLES WITH 2.0L SPI ENGINE ONLY, MAY EXHIBITA BURNING OIL SMELL NOTED FROM OUTSIDE OR FROM WITHIN THE PASSENGER COMPARTMENT. *TT
Bulletin Number: 14993
SOME VEHICLES PRODUCED THROUGH JULY 1999 MAY EXHIBIT REAR SUSPENSION SPRING FAILURE WITH NO RESULTING OPERATIONAL CONCERN. *TT
Bulletin Number: 5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
Bulletin Number: 5264
INFORMATION CONCERNING CLICK NOISE FROM FRONT CALIPERS DURING BRAKE APPLICATION. *TT
Bulletin Number: 5381
BRIEF INFORMATION STATING THAT THE NGS FUEL ECONOMY TEST ON SOME VEHICLES MAY NOT FUNCTION PROPERLY. *TT
Bulletin Number: 6416
BRIEF INFORMATION REGARDING TRANSMISSION FLUID APPEARANCE. *TT
Bulletin Number: 6932
SOME VEHICLES MAY EXHIBIT TRANSMISSION AND / OR MIL ON CONCERNS RELATING TO THE DIAGNOSIS AND REPLACEMENT OF THE TRANSMISSION RANGE SENSOR. *TT
Bulletin Number: 6934
CONCERNS WITH A MALFUNCTION INDICATOR LIGHT ON WITH A DIAGNOSTIC TROUBLE CODE P1744. *TT
Bulletin Number: 7076
INFORMATION REGARDING BRAKE CALIPER PIN CORROSION. *MJS
Bulletin Number: 7292
NNERS OF THE EDSR-OF-THE-MONTH QUALITY AWARD ANNOUNCEMENT FOR SEPTEMBER. *TT
Bulletin Number: 7369
SOME VEHICLES MAY EXHIBIT GRINDING NOISE, OR GREATER THAN NORMAL BRAKE ROUGHNESS, WHEN APPLYING THE BRAKES IMMEDIATELY AFTER INSTALLING MOTORCRAFT FRONT BRAKE PAD PART NUMBER BR-18 (XU2Z-2V001-RA). *T
Bulletin Number: 8316
SOME VEHICLES EQUIPPED WITH COMPACT DISC CHANGER MAY EXHIBIT A 6 DISC CD CHANGER THAT IS NOT EJECTING THE MAGAZINE OR IS NOT RESPONDING TO COMMAND FROM THE RADIO.
Bulletin Number: 96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
Bulletin Number: 96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
Bulletin Number: 96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
Bulletin Number: 9623A1
1997 ESCORT/TRACER - FIX IT RIGHT TIPS - COMMON LOCATIONS OF INTERMITTENT VISUAL CONCERNS. *TW
Bulletin Number: 9623A2
1997 ESCORT/TRACER ELECTRICAL INTERMITTENT - INSPECTION AREAS. *TW
Bulletin Number: 9623A3
1997 ESCORT/TRACER - FIX IT RIGHT TIPS - WATER LEAKS. *TW
Bulletin Number: 9623A4
1997 ESCORT/TRACER - FIX IT RIGHT TIPS - COMMON LOCATIONS OF INTERMITTENT VIBRATION, PULL AND SHUDDER CONCERNS. *TW
Bulletin Number: 9623A5
1997 ESCORT/TRACER - FIX IT RIGHT TIPS - COMMON LOCATIONS OF INTERMITTENT NOISE/SQUEAK AND RATTLE CONCERNS. *TW
Bulletin Number: 9623A6
1997 ESCORT/TRACER - FIX IT RIGHT TIPS - COMMON LOCATIONS OF INTERMITTENT ODOR CONCERNS. *TW
Bulletin Number: 96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
Bulletin Number: 96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
Bulletin Number: 962510
MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307 AND/OR P0308 STORED IN MEMORY. *TW
Bulletin Number: 962511
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 96265
MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, AND/OR P0308 STORED IN MEMORY. *TW
Bulletin Number: 97050110606
THE POWER STEERING TRANSDUCER IS NOW AVAILABLE AS A SERVICEABLE COMPONENT. *TW
Bulletin Number: 97050110628
FUEL DIAGNOSTICS WERE COMPUTER EXHIBITS DTC 300. *YC
Bulletin Number: 9705013906
HOTLINE INFORMATION REGARDING AUDIO REPAIR. *YC
Bulletin Number: 97111097234
VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC
Bulletin Number: 9734
MALFUNCTION INDICATOR LAMP- MIL ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE 0401 STORED IN MEMORY- VEHICLES EQUIPPED WITH 2.0L ENGINE. *JD
Bulletin Number: 9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD
Bulletin Number: 9744
EXHAUST- EXHAUST NOISE FROM BEHIND INSTRUMENT PANEL OR REAR OF ENGINE- 2.0L VEHICLES BUILT THROUGH 9/1/96. *JD
Bulletin Number: 97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
Bulletin Number: 97610
BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD
Bulletin Number: 97612
NOISE- "BUZZING" NOISE HEARD FROM INSTRUMENT PANEL AREA FOR 3 SECONDS AFTER IGNITION SWITCH IS TURNED OFF AND/OR AT ENGINE IDLE SPEED ON DECELERATION WHILE DRIVING- VEHICLES WITH 2.0L ENGINE. *JD
Bulletin Number: 9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
Bulletin Number: 980316
CONDITION REGARDING THE ENGINE MISFIRE CODE ( DTC P0304 ). *YC
Bulletin Number: 9811340
INFORMATION ON REPLACING THE WIRING HARNESS ON SOME VEHICLES. *TT
Bulletin Number: 9811345
ENGINEERING IS INVESTGATING VEHICLES EXHIBITING A CONDITION IN WHICH THE IGNITION KEY IS DIFFICULT TO TURN AND / OR DIFFICULT TO REMOVE THE FROM THE SWITCH. *TT
Bulletin Number: 9811473
SOME VEHICLES MAY EXHIBIT A CUSTOME CONCERN OF STEADY OR INTERMITTENT MISS WITH DIAGNOSTIC TROUBLE CODES P0300 AND P0304. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK
Bulletin Number: 981520
INTEGRATED AIR BAG MONITOR REPLACEMENT SERVICE KIT. YD
Bulletin Number: 9819
SOME VEHICLES MAY EXHIBIT INTERMITTENT OPERATION OR INOPERATIVE INTERIOR DOME LAMP. *TT
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 982017
EXPERIENCING " SQUEAKING " AND / OR " RATTLING " NOISES MAY OCCUR DURING DIFFERENT DRIVING CHARACTERISTICS AND FROM VARYING POINTS ON THE VEHICLE. *YC
Bulletin Number: 982037
INITIAL PRINTING OF 1997 SERVICE MANUAL CONTAINED INCORRECT ALIGNMENT SPECIFICATIONS.GN
Bulletin Number: 98204
A PORTION OF FOAM TAPE AT THE WINDSHIELD AND INSTRUMENT PANEL (I/P) MAY BE STICKING OUT ON SOME VEHICLES. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982534
SOME VEHICLES MAY EXHIBIT A CUSTOMER CONCERN OF STEADY OR INTERMITTENT MISS WITH DTCS P0300 AND P0304. THIS MAY BE CAUSED BY A SPREAD ELECTRICAL TERMINAL IN CONNECTORS AT INJECTOR. REPAIR TERMINAL/CONNECTOR CONCERN BY USING A SMALL SCRE
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 983103
CONDITIONS WITH CARPET PULLING OUT FROM UNDERNEATH THE LEFT / RIGHT COWL SIDE TRIM PANEL. *TT
Bulletin Number: 983162
CONCERNS WITH PAINT STAINS ON THE HOOD WHICH MAY BE CAUSED BY WINDSHIELD WASHER SOLVENT LEAKING FROM THE WINDSHIELD WASHER JETS WHILE DRIVING. *TT
Bulletin Number: 983218
ENGINEERING IS INVESTIGATING IF ANY HEADLAMP CONCERNS EXIST FOR SOME VEHICLES. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
Bulletin Number: 985A12
RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES. *TT
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9861
DIFFICULTIES REMOVING KEY FROM IGNITION ON SOME VEHICLES. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 9874
A NEW SILICONE GASKET AND SEALANT. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99195
SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 996877
SOME VEHICLES EQUIPPED WITH 2.0L SPI ENGINE MAY EXHBIT A LACK OF HEAT AND TEMPERATURE GAUGE READING COLD. *TT
Bulletin Number: 99810
EXHIBITING A CLICKING NOISE HEARD WHILE APPLYING THE BRAKES AFTER CHANGING VEHICLE DIRECTION ON SOME VEHICLES. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: BC0014970201
VEHICLES BUILT THRU 6/96 MAY EXHIBIT A "BUZZING" NOISE FROM THE DASH PANEL AREA FOR APPROXIMATELY 3 SECONDS AFTER THE IGNITION IS SWITCHED OFF. *JD
Bulletin Number: BC0014972301
VEHICLES BUILT THRU 6/96 MAY EXHIBIT A "BUZZING" NOISE FROM THE DASH PANEL AREA FOR APPROXIMATELY 3 SECONDS AFTER THE IGNITION IS SWITCHED OFF. *JD
Bulletin Number: BC0131970201
VEHICLES HAVING A WATER LEAK CONCERN UNDER THE DRIVE AND/OR PASSENGER FRONT SEATS. *JD
Bulletin Number: BC0181970201
INITIAL PRINTING OF THE 1997 SERVICE MANUAL CONTAINED INCORRECT ALIGNMENT SPECIFICATIONS. *JD
Bulletin Number: BC0265970201
EXHIBITING AN AIR BAG WARNING LIGHT. DTC 13 OR 51. *JD
Bulletin Number: BC0267970201
THE CARGO/TRUNK LAMP LENS/COVER HAS BEEN DELETED AS OF 10/1/96. *JD
Bulletin Number: BC0300970201
MIL LIGHT ON WITH DTC'S P0443 AND P1443. *JD
Bulletin Number: BC0407961115
INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED PARTS. *TW
Bulletin Number: BC0490961112
INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED COMPONENT. *TW
Bulletin Number: BC0540961107
VEHICLES MAY EXHIBIT A "CLICK" NOISE FROM THE AREA OF THE FRONT CV JOINTS WHILE SHIFTING BETWEEN DRIVE AND REVERSE. *TW
Bulletin Number: BC0717961021
INFORMATION FOR WHEN REPLACING AN INTERIOR TRIM COMPONENT UNDER WARRANTY. *TT
Bulletin Number: BC0760961016
WAVE SPRING LOCATED UNDER THE FORWARD ONE-WAY CLUTCH IN NO LONGER ONE PIECE. IT HAS BEEN 'SPLIT'. *TT
Bulletin Number: BC0770961015
DIAGNOSING VEHICLES WHICH EXHIBIT THE SYMPTOM OF BRAKE DRAG. *TT
Bulletin Number: BC1016697020
VEHICLES BUILT THRU 6/96 MAY EXHIBIT A "BUZZING" NOISE FORM THE DASH PANEL AREA FOR APPROXIMATELY 3 SECONDS AFTER THE IGNITON IS SWITCHED OFF. *JD
Bulletin Number: BC1018097230
THE ROOF RACK CROSS BAR WAS REVISED TO ELIMINATE THE ADHESIVE STRIP ON THE BOTTOM SURFACE. *JD
Bulletin Number: BC1020297230
ENGINE BLOCK HEATER KIT (#F7CZ-6D008-AA) INSTRUCTION SHEET #7000 HAS A MISPRINT ON INSTALLATION INSTRUCTION #8. *JD
Bulletin Number: BC1020397230
VEHICLES WHICH EXHIBIT AUTOMATIC TRANSMISSION SHIFTER ISSUES RESULTING IN EITHER THE INABILITY TO REMOVE THE IGNITION KEY FROM THE IGNITION LOCK CYLINDER, OR INABILITY TO MOVE THE SHIFTER OUT OF "PARK". *JD
Bulletin Number: BC1023197230
ABS WARNING LIGHT AND NO DIAGNOSTIC CODES SHOULD BE INSPECTED FOR A POOR ELECTRICAL GROUND AT G-302. *JD
Bulletin Number: BC1030797020
HEADLAMP CONCERN. *JD
Bulletin Number: BC105139705
SOME VEHICLES MAY EXHIBIT A MIL (MALFUNCTION INDICATOR LAMP) AND DTC (DIAGNOSTIC TROUBLE CODE) P1443 STORED IN MEMORY WITH NO DRIVEABILITY CONCERNS. *TW
Bulletin Number: BC2231970501
THE POWER STEERING TRANSDUCER IS NOW RELEASED AS A SERVICEABLE COMPONENT. *TW
Bulletin Number: BC2430970501
SOME VEHICLES MAY EXHIBIT A SLIGHT DELAY FROM PARK-TO-REVERSE AND PARK-TO-DRIVE AFTER BEING PARKED FOR A LENGTHY PERIOD OF TIME. *TW
Bulletin Number: BC3080970226
INTERMITTENT MIL LIGHTS MAY BE DUE TO CHAFING OF THE INJECTOR WIRE HARNESS. *TW
Bulletin Number: BC3218970213
HEADLAMP CONCERNS FOR ESCORT/TRACER. *TW
Bulletin Number: BC3218970501
ENGINEERING IS INVESTIGATING IF ANY HEADLAMP CONCERNS EXIST FOR 97 ESCORT/TRACER. *TW
Bulletin Number: BC3340972301
RADIO WIRE HARNESS SHORTED TO GROUND AT THE RADIO CHASSIS. *JD
Bulletin Number: BC3340973101
THE RADIO WIRE HARNESS SHORTED TO GROUND AT THE RADIO CHASSIS. *JD
Bulletin Number: BC3352972301
VEHICLES WHICH EXHIBIT AN ABS WARNING LIGHT AND NO DIAGNOSTIC CODES SHOULD BE INSPECTED FOR A POOR ELECTRICAL GROUND AT G-302. *JD
Bulletin Number: BC3431972301
THE ENGINE BLOCK HEATER KIT INSTRUCTION SHEET #7000 HAS A MISPRINT ON INSTALLATION INSTRUCTION #8. *JD
Bulletin Number: BC3432972301
VEHICLES EXHIBIT AUTOMATIC TRANSMISSION SHIFTER ISSUES RESULTING IN EITHER THE INABILITY TO REMOVE THE IGNITION KEY FORM THE IGNITION LOCK CYLINDER, OR INABILITY TO MOVE THE SHIFTER OUT OF "PARK." *JD
Bulletin Number: BC3514972301
ROOF RACK CROSS BAR WAS REVISED TO ELIMINATE THE ADHESIVE STRIP ON THE BOTTOM SURFACE. *JD
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC9666961001
2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT
Bulletin Number: BC9714961101
DIAGNOSTIC INSTRUCTIONS FOR SERVICING EVAPORATIVE EMISSION PURGE FLOW SYSTEM. *TW
1997 FORD E SERIES
Bulletin Number: 01119
SOME VEHICLES WITH HIGH ODOMETER READING OR SEVERE SERVICE MAY EXHIBIT A CREAKING NOISE WHEN TURNING WHEEL OR DRIVING OVER UNEVEN SURFACES ON VEHICLES PRODUCE BEFORE 2/6/2001. *TT
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 01221
SOME DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT A ROUGH IDLE, OR NO START IN COLD CONDITIONS. *TT
Bulletin Number: 01233
SOME DEDICATED AND BI-FUEL CNG VEHICLES MAY EXHIBIT A CONDITION OF FUEL LEAK OR FUEL ODOR AT THE CNG FUEL FILL VALVE AREA. *TT
Bulletin Number: 01234
SOME VEHICLES EQUIPPED WITH AFTERMARKET HIGH-CURRENT DEVICES MAY EXHIBIT DIAGNOSTIC TROUBLE CODES B1876, B1880, B1915 AND/OR B1920 AIRBAG ELECTRONIC CRASH SENSOR MODULE. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 020503
GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996. *TT UPDATE. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02168
REPORTS THAT CERTAIN VEHICLES APPEAR TO BE DOGTRACKING. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
Bulletin Number: 0253
SUBJECT REGARDING ALTERNATIVE FUEL VEHICLE COMPRESSED NATURAL GAS TANK INSPECTION. *TT
Bulletin Number: 030402
ON SOME DEDICATED CNG VEHICLES, A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE. REVISED SERVICE PARTS. *TT
Bulletin Number: 031404
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
Bulletin Number: 03144
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 03183
DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY. *TT
Bulletin Number: 03206
SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY. LOSS OF POWER AT HEAVY LOAD, DIAGNOSTIC TROUBLE CODES (DTCS) FOR LEAN FUEL, ROUGH IDLE, HARD START,
Bulletin Number: 032122
ROLLING IDLE, SURGE ON VEHICLES BUILT 8/96 THROUGH 12/96 WITH 7.3L ENGINE. *TT
Bulletin Number: 032145
EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT
Bulletin Number: 032306
DIAGNOSTIC TROUBLE CODE B1876, B1880, B1915 AND/OR B1920 IN THE ECS MODULE - VEHICLES EQUIPPED WITH AFTERMARKET HIGH CURRENT DEVICES. *TT
Bulletin Number: 03236
DIAGNOSTIC TROUBLE CODES (DTC) B1876, B1880, B1915 AND/OR B1920 AIRBAG ELECTRONIC CRASH SENSOR (ECS) MODULE ON VEHICLES EQUIPPED WITH AFTERMARKET HIGH CURRENT DEVICES. *TT
Bulletin Number: 03261
NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT
Bulletin Number: 0342
POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE, ON SOME DEDICATED CNG VEHICLES. *TT *JB
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04266
A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP. *TT
Bulletin Number: 05417
INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT
Bulletin Number: 07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
Bulletin Number: 11776
SOME VEHICLES WITH 7.3L DIT ENGINES MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
Bulletin Number: 11796
SOME VEHICLES MAY EXHIBIT POWER DOOR LOCKS THAT SELF ACTIVATE, ARE INOPERATIVE, OR REMOTE KEYLESS ENTRY INOPERATIVE DURING OR AFTER WET CONDITIONS. *TT
Bulletin Number: 12070
VEHICLES THAT ARE LOADED TO THE UPPER END OF FVW, WITH THE MAJORITY OF THE LOAD BETWEEN THE AXLES, MAY EXHIBIT INNER EDGE TIRE WEAR DUE TO INCORRECT ALIGNMENT. *MJS
Bulletin Number: 12123
VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT, DUE TO INCORRECT FRONT END ALIGNMENT SETTINGS. *MJS
Bulletin Number: 12162
SOME VEHICLES EQUIPPED WITH 6.8L ENGINES, MAY EXHIBIT A CUSTOMER CONCERN OR ENGINE ROAR OR ENGINE NOISE FOR THE FIRST FEW MINUTES OF OPERATION AFTER A COLD START. *MJS
Bulletin Number: 12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
Bulletin Number: 12298
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. *TT
Bulletin Number: 12556
SUBJECT REGARDING TECHNICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES. *TT
Bulletin Number: 12593
CONCERNS WITH CRACKS ON THE RIGHT REAR SIDE OF THE #1 FRAME CROSSMEMBER. *TT
Bulletin Number: 12741
SOME VEHICLES UNDER SEVERE DUTY CYCLES MAY EXHIBIT CRACKS ON THE LOWER RADIATOR SUPPORT. *TT
Bulletin Number: 12743
EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT
Bulletin Number: 12744
SOME VEHICLES MAY RETREIEVE MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0351 AND / OR P0357 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT
Bulletin Number: 12798
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 12870
SOME CUSTOMERS MAY COMMENT ON A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT
Bulletin Number: 12915
CUSTOMER MAY COMPLAIN OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT
Bulletin Number: 13117
SOME VEHICLES WITH AN ILLUMINATED AIR BAG LAMP MAY HAVE MODIFIED SEAT CONFIGURATIONS. *TT
Bulletin Number: 13285
EXPERIENCING ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 13322
SOME VEHICLES MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 13331
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 13832
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT
Bulletin Number: 13870
CONCERNS WITH A NO START CONDITION AFTER INSTALLATION OF A NEW 6.8L ENGINE ASSEMBLY. *TT
Bulletin Number: 13934
SOME VEHICLES MAY EXHIBIT A-PILLAR SHEET METAL CRACKS AROUND FRONT DOOR HINGES; FRONT DOOR SKIN SEPARATES AND DOOR INNER SHEET METAL CRACKED AROUND FRONT HINGES; OR FRONT DOORS OPEN TOO FAR AND EXTEND INTO THE FRONT FENDERS. *TT
Bulletin Number: 14240
SOME VEHICLES MAY EXHIBIT A CLUNK THAT CAN BE FELT OR HEARD THROUGH THE STEERING WHEEL. THE CONDITION IS EXPERIENCED BEST IN A SLIGHT TURN, AT SPEEDS NEAR 20 MPH, ON ROAD SURFACES WITH SLIGHT IRREGULARITIES. ENGINEERING IS ADDRESSING T
Bulletin Number: 14374
SUBJECT REGARDING FRONT SUSPENSION INSPECTION PROCEDURES. *JB
Bulletin Number: 14455
OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT
Bulletin Number: 14514
SOME VEHICLES MAY EXHIBIT A CLUNK THAT CAN BE FELT OR HEARD THROUGH THE STEERING WHEEL. THE CONDITION IS BEST EXPERIENCED IN A SLIGHT TURN, NEAR 20 MPH, ON ROAD SURFACES WITH SLIGHT IRREGULARITIES. *TT
Bulletin Number: 14514
EXPERIENCING A CLUNKING TYPE NOISE THAT CAN BE FELT OR HEAR THROUGH THE STEERING WHEEL. CONDITION BEST EXPERIENCED IN A SLIGHT TURN, NEAR 20 MPH, ON ROAD SURFACES WITH SLIGHT IRREGULARITIES. *TT
Bulletin Number: 14735
SOME VANS / WAGONS WITH 138 INCH WHEELBASE AND 4R70W TRANSMISSION (DRIVE SHAFT >70 INCH) MAY EXHIBIT A VIBRATION BOOM UNDER HEAVY ACCELERATION (WOT) OR A LOADED DRIVE MODE. *TT
Bulletin Number: 14943
SOME VEHICLES MANUFACTURED AS INCOMPLETE VEHICLES (1FD IN THE FIRST THREE POSITIONS OF VIN) EQUIPPED WITH A POWER SEAT PEDESTAL (OPTION 21Z), BUT MANUFACTURED WITHOUT A SEAT, MAY HAVE A CONDITION OF REPEAT POWE SEAT TRACK FAILURE.
Bulletin Number: 15099
SOME VEHICLES MAY EXHIBIT DRIVELINE CLUNK / THUMP NOISE CONDITION ON INITIAL ACCELERATION FROM A STOP.
Bulletin Number: 15150
SOME E-SERIES EQUIPPED WITH AN RV MODIFIED POWER SEAT MAY EXHIBIT FAILURE OF THE POWER PEDESTAL MOTOR. *ET
Bulletin Number: 15161
SOME VEHICLES MAY EXHIBIT A FUEL LEAK AT CNG FILL VALVE. *YH
Bulletin Number: 15218
INFORMATION ON A REINFORCEMENT KIT FOR VEHICLES EXHIBITING FAILURE OF THE POWER SEAT PEDESTAL MOTOR. *TT
Bulletin Number: 15355
SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT
Bulletin Number: 15373
SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES. *TT
Bulletin Number: 15397
SOME VEHICLES MAY EXHIBIT A CONDITION OF OIL CONTAMINATION IN COOLING SYSTEM. *TT
Bulletin Number: 15901
THIS BULLETIN STATES THAT SOME 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER OR LARGER KNOCK SENSOR THREADED HOLD THAN THE ONE IN THE ORIGINAL ENGINE ASSEMBLY. *TT
Bulletin Number: 16040
EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT
Bulletin Number: 16515
OIL LEAK AT HIGH PRESSURE PUMP FITTINGS AND/OR PLUG. THIS INCLUDES SUPER DUTY F-SERIES. OASIS. *TT
Bulletin Number: 16916
REPEATED BLOWN FUSES FOR REAR IN VEHICLE CIRCUITS WITH INOPERATIVE REAR BRAKE OR TAIL LAMPS. *TT
Bulletin Number: 17254
CLICKING/POPPING NOISE FROM UPPER STEERING COLUMN AREA WHEN TURNING. 2004 E SERIES AND EXPLORER SPORT TRAC ALSO INCLUDED. *TT
Bulletin Number: 17320
BROKEN EXHAUST MANIFOLD STUDS. *TT
Bulletin Number: 17385
AIR BAG LAMP ILLUMINATED. *TT
Bulletin Number: 17777
REAR LEAF SPRING NOISE. *TT
Bulletin Number: 4658
SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
Bulletin Number: 4684
SOME VEHICLES MAY EXHIBIT POWER DOOR LOCKS THAT SELF ACTIVATE, ARE INOPERATIVE, OR REMOTE KEYLESS ENTRY INOPERATIVE DURING OR AFTER WET CONDITIONS. *TT
Bulletin Number: 5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
Bulletin Number: 6290
INFORMATION REGARDING THE IMPROVED RADIATOR SUPPORT. *TT
Bulletin Number: 6350
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 6417
ADDRESSING TIRE BALANCE HINTS. *TT
Bulletin Number: 6461
CONCERNS OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *T
Bulletin Number: 6538
SOME VEHICLES BUILT BEFORE APRIL 1, 1999 MAY HAVE A CUSTOMER CONCERN OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT
Bulletin Number: 6599
SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY MAY EXHIBIT A CONCERN WITH THE AMOUNT OF SOUND, WHINE PRODUCED ABOVE 35 MPH.
Bulletin Number: 8058
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. **MR
Bulletin Number: 8058
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT
Bulletin Number: 8138
SOME VEHICLES MAY EXHIBIT A NO START CONDITION AFTER INSTALLATION OF A NEW 6.8L ENGINE ASSEMBLY. *TT
Bulletin Number: 8260
SOME VEHICLES MAY EXHIBIT A-PILLAR SHEET METAL CRACKS AROUND FRONT DOOR HINGES; FRONT DOOR SKIN SEPARATES AND DOOR INNER SHEET METAL CRACKED AROUND FRONT HINGES; OR FRONT DOORS OPEN TOO FAR AND EXTEND INTO THE FRONT FENDERS. *TT
Bulletin Number: 870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
Bulletin Number: 976007
BRIEF INFORMATION REGARDING CYLINDER HEAD TEMPERATURE (CHT) AND FAIL SAFE COOLING. *TT
Bulletin Number: 980301
CONDITION WITH ROUGH IDLE. *YC
Bulletin Number: 980301
EXPERIENCING ROUGH IDLE/MISS. *AK
Bulletin Number: 980302
SOME VEHICLES EXPERIENCING HARD START/ NO START. *YC
Bulletin Number: 980303
SYMPTOMS WITH LACK OF POWER. VERIFY ACTUAL ENGINE TURBO-BOOST AS OUTLINED ON THE DIAGNOSTIC SHEET. *AK
Bulletin Number: 980304
COMPLAINTS REGARDING THE FUEL ECONOMY. *YC
Bulletin Number: 980307
CONDITIONS WITH PRESSURE BEING HIGHER/LOWER THAN EXPECTED. *YC
Bulletin Number: 980317
PARK BRAKE CABLE DRAG, CAUSING REAR BRAKE VIBRATION. *AK
Bulletin Number: 980323
CONCERNS WITH EXTERNAL OIL LEAKS. *YC
Bulletin Number: 982733
VEHICLES WITH THE E4OD ARE ADDED TO THE FQR ( FORD QUALITY RENEWAL ) ASSEMBLY PROGRAM. *YC
Bulletin Number: 985072
SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
Bulletin Number: 985153
SOME VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT. *TT
Bulletin Number: 985199
SOME VEHICLES EQUIPPED WITH 6.8L ENGINE, MAY EXHIBIT A CUSTOMER CONCERN OF ENGINE ROAR OR ENGINE NOISE FOR THE FIRST FEW MINUTES OF OPERATION AFTER A COLD START. *MJS
Bulletin Number: 991411
SOME VEHICLES MAY EXHIBIT A CRACK ON THE RIGHT REAR SIDE OF THE #1 CROSSMEMBER RESULTING IN A CREAKING NOISE WHILE TURNING THE WHEEL OR DRIVING OVER UNEVEN SURFACES. *TT
Bulletin Number: 996130
INFORMATION ON THE IMPROVED LOWER INTAKE MANIFOLD SIDE GASKETS. *TT
Bulletin Number: 996890
SOME VEHICLES WITH AN ILLUMINATED AIR BAG LAMP MAY HAVE MODIFIED SEAT CONFIGURATIONS WHICH MAY HAVE BEEN CHANGED BY MODIFIERS OR THE CUSTOMER. *TT
Bulletin Number: BC0053970201
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC0255970201
4X4 FRONT AXLE IS LEAKING THROUGH THE VENT TUBE. *JD
Bulletin Number: BC0256970201
A RUNNING CHANGE FOR THE 7.3L TO ALLOW BETTER DEFINITION ON CYLINDER CONTRIBUTION TESTS IN PROCESS. *JD
Bulletin Number: BC0693961023
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Bulletin Number: BC0695961023
'OFF-IDLE' VIBRATION/BOOM/DRONE EMITTING FROM THE EXHAUST SYSTEM ON 4.2L ENGINES. *TT
Bulletin Number: BC0696961023
CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT
Bulletin Number: BC0750961017
SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT
Bulletin Number: BC0782961014
CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT
Bulletin Number: BC0844961008
E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT
Bulletin Number: BC0853961007
AIRBAG LIGHT ON & CODE 21, MAY BE CAUSED BY AN ELECTROMAGNETIC INTERFERENCE GENERATED WITHIN THE ELECTRICAL SYSTEM. *TT
Bulletin Number: BC0883961004
VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT
Bulletin Number: BC0884961004
FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC5201961001
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Bulletin Number: BC5219961001
INCORRECT INFORMATION IN 1997 EVTM MANUAL. PIN CALL-OUTS ILLUSTRATIONS FOR C224 & C225 ARE IN REVERSE ORDER. *TT
Bulletin Number: TSB-11-11-21
FORD: THE BLOWER MOTOR ON SOME VEHICLES ARE OPERATING EITHER INCORRECTLY OR NOT OPERATING OR JUST FUNCTIONING ON ONE SPEED. *PE
1997 FORD E-SERIES
Bulletin Number: 07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
Bulletin Number: TSB-11-11-21
FORD: THE BLOWER MOTOR ON SOME VEHICLES ARE OPERATING EITHER INCORRECTLY OR NOT OPERATING OR JUST FUNCTIONING ON ONE SPEED. *PE
1997 FORD E-SUPER DUTY
Bulletin Number: 6599
SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY MAY EXHIBIT A CONCERN WITH THE AMOUNT OF SOUND, WHINE PRODUCED ABOVE 35 MPH.
1997 FORD EXCURSION
Bulletin Number: 17467
ENGINE OR FUEL SYSTEM CONCERNS WHEN USING FUEL WITH GREATER THAN 5% BIODIESEL CONCENTRATION. *TT
Bulletin Number: 17571
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT
1997 FORD EXPEDITION
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 0017
SUBJECT ON THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODES MAY APPEAR. *MJS
Bulletin Number: 0018
VEHICLES EQUIPPED WITH ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) , MAY EXERIENCE THE BLOWER MOTOR STAYING ON HIGH AFTER DESIRED TEMPERATURE IS REACHED AND/ OR THE SYSTEM DOES NOT MAINTAIN SET TEMPERATURE. *MJS
Bulletin Number: 00201
SOME VEHICLES MAY EXHIBIT HESITATION ON ACCELERATION OR WHILE TURNING. *JB
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 00261
SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES. *TT
Bulletin Number: 01128
SOME VEHICLES MAY EXHIBIT A CHECK SUSPENSION LAMP ON WITH DIAGNOSTIC TROUBLE CODES B2140 OR C2140 EVEN AFTER THE AIR SUSPENSION SWITCH IN THE UPPER RH KICK PANEL HAS BEEN TURNED ON. *TT
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01166
SOME VEHICLES MAY EXHIBIT WATER IN THE TRANSFER CASE, THIS COULD CAUSE LOW RANGE 4X4 LAMP TO ILLUMINATE, SHORT OF TRANSFER CASE SWITCH, OR WINDSHIELD WIPERS TO BE ERRATIC OR INOPERATIVE. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 01215
A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTER OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 0162
VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02193
DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ
Bulletin Number: 02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH
Bulletin Number: 030709
REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES. *TT
Bulletin Number: 031404
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
Bulletin Number: 03144
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 031513
TIE ROD END INSPECTION PROCEDURE. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 03610
TIE ROD END INSPECTION PROCEDURE. CANADA VEHICLES ONLY. *TT *JB
Bulletin Number: 0392
REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES. *TT
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 0399
TIE ROD END INSPECTION PROCEDURE. *TT
Bulletin Number: 041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 0454
AIR SUSPENSION COMPRESSOR NOISE. *TT
Bulletin Number: 0457
POP/THUMP NOISE AT END OF WINDOW MOVEMENT AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION. *TT
Bulletin Number: 04L19
CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE. *TT
Bulletin Number: 050618
REAR AXLE NOISE REPAIR. *SC
Bulletin Number: 0554
USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE. *TT
Bulletin Number: 05618
REAR AXLE NOISE REPAIR. *TT
Bulletin Number: 07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
Bulletin Number: 090308
MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455
Bulletin Number: 11530
WHEN DIAGNOSING CRANK / NO START ON CERTAIN VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT (PATS) CHECK THE CUSTOMERS KEY RING FOR ANY MAGNETIC OBJECTS LIKE THE MOBILE SPEEDPASS KEY WHICH MAY AFFECT THE SIGNAL TRANSMISSION BETWEEN THE PATS KEY A
Bulletin Number: 11781
INFORMATION ON SETTING THE CHECK ENGINE LIGHT AND SETTING DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK). *TT
Bulletin Number: 11806
SUBJECT REGARDING A MISSING RUBBER STOP BUMPER FROM THE PARKING BRAKE COTNROL. *TT
Bulletin Number: 12139
SOME VEHICLES EQUIPPED WITH 4.6L OR 6.8L ENGINES MAY EXHIBIT A COLD START ENGINE NOISE UNTIL WARMED UP. *MJS
Bulletin Number: 12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
Bulletin Number: 12170
INFORMATION CONCERNING THE OCTANE SHORTING BAR LOCATED ON THE PASSENGER SIDE OF ENGINE COMPARTMENT NEAR THE BULKHEAD IS NOT INTENDED TO BE FUNCTIONAL IN REDUCING DETONATION/SPARK KNOCK. *MJS
Bulletin Number: 12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
Bulletin Number: 12216
THIS BULLETIN MENTIONS THAT FOR ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12227
FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12282
SOME VEHICLES MAY EXHIBIT A REAR WIPER THAT DOES NOT FUNCTION PROPERLY (JAMMED). *TT
Bulletin Number: 12529
SOME VEHICLES MAY EXHIBIT AN AIR BAG LIGHT ON INTERMITTENTLY WITH DIAGNOSTIC TROUBLE CODE B1924. *TT
Bulletin Number: 12572
VEHICLES MAY EXHIBIT A HIGH SPEED DRIVELINE VIBRATION. *TT
Bulletin Number: 12720
SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE FLEXIBLE RUBBER COOLANT HOSE. *TT
Bulletin Number: 12738
SOME VEHICLES MAY EXHIBIT A IDLE VIBRATION.
Bulletin Number: 12743
EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT
Bulletin Number: 12767
EXHIBITING A VIBRATION THAT MAY BE INTERPRETED AS AN NVH CONDITION. *TT
Bulletin Number: 12796
ON SOME VEHICLES, THE DOOR TRIM PANELS MAY HAVE LOOSE OR BROKEN PULL HANDLES. *TT
Bulletin Number: 12797
ADDRESSING CONCERNS OF A LOW SPEED (UNDER 35 MPH) CLICKING NOISE CAUSED BY A CAGE NUT ROCKING ON THE COTTER PIN FOR THE FRONT AXLE HALF SHAFT SPINDLE. *TT
Bulletin Number: 12798
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 12905
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT
Bulletin Number: 12994
SUBJECT REGARDING A/C VACUUM RESERVOIR / CHECK VALVE LOCATION FOR THE AIR CONDITIONING SYSTEM. *TT
Bulletin Number: 13054
EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT
Bulletin Number: 13106
ON SOME VEHICLES THE FRONT BUMPERS MAY EXHIBIT RED STAINING (SPOTS) ON THE BUMER WING ENDS. *TT
Bulletin Number: 13285
EXPERIENCING ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 13322
SOME VEHICLES MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 13331
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 13342
VEHICLES WITH 2.4L, 4.6L, AND 5.4L ENGINES MAY EXHIBIT AN A/C MOAN AT IDLE. *TT
Bulletin Number: 13505
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
Bulletin Number: 13711
SUBJECT REGARDING THE SERVICING OF TRAILER HITCHES ON VEHICLES. *MJS
Bulletin Number: 13712
INFORMATION REGARDING VEHICLES THAT EXPERIENCE THE RADIOS THAT DISPLAY NO DJ-NO DISC OR CD WILL NOT EJECT. *MJS
Bulletin Number: 13744
SOME VEHICLES MAY EXHIBIT A BODY BOOM WHILE DRIVING HIGHWAY SPEEDS. *MJS
Bulletin Number: 13745
SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS
Bulletin Number: 13773
INFORMATION FOR COMPACT DISC PLAYER PROBLEMS, RADIO MAY DISPLAY NO DJ- NO DUSC OR CD WILL NOT EJECT. *MJS
Bulletin Number: 13832
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT
Bulletin Number: 13838
CONCERNS WITH VEHICLES EXHIBITING A WINDSHIELD CREAK / SQUEAK. *TT
Bulletin Number: 14197
SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION. *TT
Bulletin Number: 14359
SUBJECT PERTAINING TO AIR SUSPENSION LEAKS. *JB
Bulletin Number: 14365
THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT. *JB
Bulletin Number: 14372
INFORMATION ON IDLE VIBRATION OR ENGINE DROAN ON ACCELERATION. *JB
Bulletin Number: 14609
SUBJECT REGARDING HIGH IDLE AND/OR CHECK ENGINE LIGHT CONDITION. *JB
Bulletin Number: 14905
SOME VEHICLES MAY EXHIBIT AMBER ANTI-LOCK BRAKE SYSTEM (ABS) LAMP ON WITH UNDEFINED DIAGNOSTIC TROUBLE CODES (DTCS) STORED. *TT
Bulletin Number: 15122
SOME VEHICLES MAY EXHIBIT A VIBRATION AT IDLE AND/OR ENGINE DROANING NOISE ON ACCELERATION FROM A STOP. *SLC
Bulletin Number: 15123
SOME VEHICLES MAY EXHIBIT A DRIVELINE VIBRATION AT SPEEDS BETWEEN 60-70 MPH. *SLC
Bulletin Number: 15152
SOME VEHICLES MAY EXHIBIT COURTESY RAIL LAMPS ABOVE THE 2ND ROW SEATS THAT DO NOT OPERATE PROPERLY OR CAUSE A BATTERY DRAW. *ET
Bulletin Number: 15362
SOME VEHICLES MAY EXHIBIT AIR SUSPENSION MALFUNCTION. *TT
Bulletin Number: 15480
SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION AND/OR PREMATURE SHUTOFF OF THE GAS PUMP WHEN THE VEHICLE IS BEING RE-FUELED. *TT
Bulletin Number: 15504
SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT
Bulletin Number: 15517
SUBJECT REGARDING EXAGGERATED ENGINE BRAKING ON DECELERATION. *YD
Bulletin Number: 15526
SUBJECT REGARDING INOPERATIVE RUNNING BOARD LIGHTS.*YD
Bulletin Number: 15528
SUBJECT REGARDING AIR SUSPENSION COMPRESSOR QUALITY. *YD
Bulletin Number: 15549
INFORMATION REGARDING POP/THUMP NOISE FROM POWER WINDOW. *YH
Bulletin Number: 15605
SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT
Bulletin Number: 15648
SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION AND/OR PREMATURE SHUTOFF OF THE GAS PUMP WHEN THE VEHICLE IS BEING REFUELED. *TT
Bulletin Number: 15651
SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN AIR LEAK AND/OR OVERNIGHT BLEED DOWN OF THE AIR SUSPENSION. *TT
Bulletin Number: 15692
SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT
Bulletin Number: 15708
SOME VEHICLES MAY EXHIBIT WHEELS THAT SEIZE TO THE HUBS AND ARE DIFFICULT TO REMOVE DURING SERVICE. *TT
Bulletin Number: 15727
SOME 4X2 VEHICLES EQUIPPED WITH P275/60/R17 CONTINENTAL GENERAL TIRES MAY EXHIBIT A HIGHWAY SPEED TIRE VIBRATION. *TT
Bulletin Number: 15749
SOME VEHICLES EQUIPPED WITH 4 WHEEL DRIVE MAY EXHIBIT A NOTCHY OR STICKING FEELING IN SLOW SPEED TURNS WITH NO EFFECT ON STEERING EFFORTS OR ASSIST WHILE IN THE AUTOMATIC 4X4 POSITION. *TT
Bulletin Number: 15794
SOME 4X2 VEHICLES EQUIPPED WITH P275/60/R17 CONTINENTAL-GENERAL TIRES MAY EXHIBIT A HIGHWAY SPEED TIRE VIBRATION. *TT
Bulletin Number: 15897
SUBJECT REGARDING DRIVELINE ANGLE-RELATED VIBRATION AT VARIOUS SPEEDS AND LOAD CONDITIONS. *TT
Bulletin Number: 15901
THIS BULLETIN STATES THAT SOME 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER OR LARGER KNOCK SENSOR THREADED HOLD THAN THE ONE IN THE ORIGINAL ENGINE ASSEMBLY. *TT
Bulletin Number: 15939
CONCERNS WITH SPEED BODY BOOM. *TT
Bulletin Number: 16015
SOME VEHICLES WITH AIR SUSPENSION MAY EXHIBIT AN INITIAL OR REPEAT COMPRESSOR DRYER FAILURE. *TT
Bulletin Number: 16683
FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB
Bulletin Number: 17320
BROKEN EXHAUST MANIFOLD STUDS. *TT
Bulletin Number: 17459
COURTESY RAIL LAMPS DO NOT OPERATE CORRECTLY OR CAUSE A BATTERY DRAW. *TT
Bulletin Number: 4619
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT
Bulletin Number: 4626
INFORMATION ON VEHICLES EXHIBITING AND O/D OFF LAMP FLASHING WITH DIAGNOSTIC TROUBLE CODE 62 / 628 / 1728. *TT
Bulletin Number: 4628
SOME VEHICLES MAY EXHIBIT REAR AXLE NOISE. *TT
Bulletin Number: 4631
BRIEF INFORMATION ON VEHICLES EXHIBIT VIBRATION AT CRUISE OVER 50 MPH. *TT
Bulletin Number: 4638
MALFUNCTION INDICATOR LAMP ON, WITH P0300 - P0308 MISFIRE DIAGNOSTIC TROUBLE CODES WITH A 4.6L ENGINE. *TT
Bulletin Number: 4664
THIS BULLETIN STATES THAT FOR CERTAIN VEHICLES IT IS NOT POSSIBLE TO SET THE CHECK ENGINE LIGHT AND SET DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK) IF A CUSTOMER REFUELS THE VEHICLE WITH THE ENGINE RUNNING. *
Bulletin Number: 4698
ON SOME VEHICLES, THE RUBBER STOP BUMPER MAY BE MISSING FROM THE PARKING BRAKE CONTROL, A REPLACEMENT SERVICE PART IS NOW AVAILABLE. *TT
Bulletin Number: 4802
REAR WIPER ARM INSTALLATION. *TT
Bulletin Number: 4981
SOME VEHICLES EQUIPPED WITH 5.4L ENGINES MAY EXHIBIT A COLD START ENGINE KNOCK CONCERN UNTIL WARMED UP. *TT
Bulletin Number: 5128
SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. ENGINEERING IS INVESTIGATING. *TT
Bulletin Number: 5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
Bulletin Number: 5206
FOR CERTAIN VEHICLES THE OCTANE SHORTING BAR LOCATED ON THE PASSENGER SIDE OF ENGINE COMPARTMENT NEAR THE BULKHEAD IS NOT INTENDED TO BE FUNCTIONAL IN REDUCING DETONATION / SPARK KNOCK. *TT
Bulletin Number: 5257
INFORMATION ON VEHICLES EXHIBITING COLD ENGINE KNOCK. *TT
Bulletin Number: 5258
INFORMATION ON VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. *TT
Bulletin Number: 5370
SOME VEHICLES MAY EXHIBIT A REAR WIPER THAT DOES NOT FUNCTION PROPERLY (JAMMED). *TT
Bulletin Number: 5852
VEHICLES EXHIBITING INTERMITTENT ILLUMINATION OF AIR BAG LIGHT WITH DIAGNOSTIC TROUBLE CODE B1924. *TT
Bulletin Number: 6232
SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE COIL RESULTING IN ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE P0304 AND / OR ROUGH IDLE. *TT
Bulletin Number: 6287
SOME VEHICLES MAY EXPERIENCE AN IDLE VIBRATION. *TT
Bulletin Number: 6332
CONDITIONS WITH DOOR TRIM PANEL HAVING LOOSE OR BROKEN PULL HANDLES. *TT
Bulletin Number: 6350
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 6640
EXHIBITING AN AIR BAG LAMP ON INTERMITTENTLY WITH LAMP FAULT CODE (LFC) 24, OR DIAGNOSTIC TROUBLE CODE B1924 AND / OR B1342 STORED IN MEMORY. *TT
Bulletin Number: 6686
SUBJECT REGARDING AIR CONDITIONER VACUUM RESERVOIR / CHECK VALVE LOCATION. *TT
Bulletin Number: 7100
INFORMATION REGARDING TRANSMISSION TROUBLE CODES. *MJS
Bulletin Number: 7155
VEHICLES EQUIPPED WITH WINDSOR ENGINES ONLY MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 7353
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT
Bulletin Number: 7896
SERVICING TRAILER HITCH.
Bulletin Number: 7897
DIAGNOSTIC INFORMATION FOR COMPACT DISC PLAYER PROBLES, NO DISC OR CD WILL NOT EJECT. THIS INDICATES NO COMMUNICATION BETWEEN RADIO AND DISC PLAYER.
Bulletin Number: 7929
DIAGNOSTIC INFORMATION FOR COMPACT DISC PLAYER PROBLEMS.
Bulletin Number: 8058
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. **MR
Bulletin Number: 8058
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT
Bulletin Number: 96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
Bulletin Number: 96228
WINDNOISE - FRONT WINDOW RUN LIP HANGING OUT - VEHICLES BUILT THROUGH 8/14/96. *TW
Bulletin Number: 962410
TRANSMISSION - E40D - 4R70W - 4R44E - 5R55E - NEW DIGITAL TRANSMISSION RANGE SENSOR - DIAGNOSIS SERVICE TIP. *TW
Bulletin Number: 962418
TRANSMISSION - E40D - REVISED DESIGN FORWARD PLANET THRUST WASHER - SERVICE TIP. *TW
Bulletin Number: 96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
Bulletin Number: 962511
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 962518
DOOR - POWER POINT ACCESS DOOR BREAKS - VEHICLES BUILT THROUGH 8/31/96. *TW
Bulletin Number: 962523
RUNS ROUGH - MALFUNCTION INDICATOR LAMP (MIL) ON - DIAGNOSTIC TROUBLE CODES (DTCS) P0300 THROUGH P0308 STORED IN MEMORY - VEHICLES BUILT THROUGH 10/14/96 WITH 4.6L ENGINE. *TW
Bulletin Number: 962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 96S60
REVISED TECHNICAL INSTRUCTIONS CONCERNING RECALL 96S60. *TW
Bulletin Number: 97050110612
RATTLE OR BUZZ IN TAILGATE TRIM PANEL AFTER REMOVAL IF THE RETAINING CLIPS ARE NOT REPLACED AFTER REPAIR. *TW
Bulletin Number: 97050110618
STRESS CRACKS ON WINDSHIELDS. *TW
Bulletin Number: 97050110622
REQUEST FOR INFORMATION ON CONCERNS OF LEATHER SEAT COVERS WRINKLING, FOLDING,LEATHER WEAR OR CRACKING. *TW
Bulletin Number: 97050110632
NEWLY DESIGNED VOLUME KNOB, INCORPORATING A MOMENTARY ON/OFF SWITCH. *TW
Bulletin Number: 970902971811
CONCERNS WITH "SQUEAKING" AND/OR "RATTLING" NOISES MAY OCCUR DURING DIFFERENT DRIVING CHARACTERISTICS AND FROM VARYING POINTS ON THE VEHICLE. *YC
Bulletin Number: 97090297183
EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC
Bulletin Number: 97090297187
SOME VEHICLES MAY STALL WHEN THE TRANSMISSION IS PLACED INTO GEAR. *YC
Bulletin Number: 971110972313
A NEW DESIGN TRANSMISSION CASE AND EXTENSION HOUSING HAS BEEN RELEASED. *YC
Bulletin Number: 97111097234
VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC
Bulletin Number: 9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD
Bulletin Number: 97410
TRANSMISSION- E4OD- COOLER BYPASS VALVE SERVICE DURING TRANSMISSION OVERHAUL- SERVICE TIP. *JD
Bulletin Number: 9751
INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD
Bulletin Number: 97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
Bulletin Number: 976007
BRIEF INFORMATION REGARDING CYLINDER HEAD TEMPERATURE (CHT) AND FAIL SAFE COOLING. *TT
Bulletin Number: 976011
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 97614
STEERING COLUMN- HIGH SPEED VIBRATION- 4X2 VEHICLES EQUIPPED WITH 5.4L ENGINE. *JD
Bulletin Number: 97620
MALFUNCTION INDICATOR LAMP (MIL) - ILLUMINATED- DIAGNOSTIC TROUBLE CODE (DTC) P0446 STORED IN CONTINUOUS MEMORY- VEHICLES BUILT THROUGH 1/17/97. *JD
Bulletin Number: 97626
ENGINE- CHECKING ENGINE OIL LEVEL IN OWNER'S GUIDE INCORRECT. *JD
Bulletin Number: 9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
Bulletin Number: 97713
NOISE- "BUZZING"- UNDERHOOD WHEN AIR SUSPENSION IS IN OPERATION. *JD
Bulletin Number: 98021698312
SOME COMPONENTS OF THE FRAME MAY REQUIRE SERVICING DUE TO COLLISION DAMAGE. *YC
Bulletin Number: 980310
EXPERIENCING VIBRATION AT CRUISE OVER 50 MPH. *YC
Bulletin Number: 980317
SYMPTOMS REGARDING P0300-P0308 MISFIRE DTCS WITH 4.6L ENGINES. *YC
Bulletin Number: 9810569
CONCERNS OF SQUEAKY / NOISY PITMAN ARM. *YC
Bulletin Number: 98110
SUBJECT REGARDING PASSIVE ANTI THEFT SYSTEM (PATS) DIAGNOSTIC SERVICE TIPS. *TT
Bulletin Number: 98113
SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT
Bulletin Number: 9811342
INFORMATION ON REMOVING THE RADIO CHASSIS FROM SOME VEHICLES. *TT
Bulletin Number: 9811344
SOME VEHICLES MAY EXHIBIT LOOSE LUGNUTS AND / OR BROKEN WHEEL STUDS. *TT
Bulletin Number: 98123
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK
Bulletin Number: 981515
A CLUNKING NOISE HEARD FROM FRONT ENDCAUSED BY FRONT STABILIZER BAR CONTACTING THE FRAME. *AK
Bulletin Number: 981612
FUEL MAY LEAK FROM THE SPRING LOCK COUPLINGS. YD
Bulletin Number: 981613
TRANSMISSION FLUID LEAKS AT RADIATOR. YD
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 98168
TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD
Bulletin Number: 98169
STEERING -ALIGNMENT-TOE SET PROCEDURE SERVICE TIP. YD
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 982019
CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR. *YC
Bulletin Number: 982110
DURING HIGH IDLE SPEEDS THROTTLE STICKS AFTER STEADY STATE DRIVING IN COLD AMBIENT TEMPERATURES. *YC
Bulletin Number: 982117
A NEW PARKING BRAKE CONTROL RUBBER BUMPER STOP IS NOW AVAILABLE FOR SERVICE. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 982325
THE MALFUCNTION INDICATOR LAMP ( MIL ) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0455 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 98239
EXPERIENCING NO OR INTERMITTENT AUXILLARY A/C MODE / BLOWER CONTROL ON SOME VEHICLES. *YC8
Bulletin Number: 98241
DIAGNOSTIC SERVICE TIPS ON PASSIVE ANTI THEFT SYSTEM ( PATS ). *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982521
CONCERNS OF BREAKAGE OF THE EXHAUST SYSTEM BETWEEN THE MUFFLER AND TAILPIPE MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 98254
SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN INTERMITTENT CHECK SUSPENSION LAMP ON AND DIAGNOSTIC TROUBLE CODE (DTC) C1770 AND/OR C1845 ILLUMINATED. *YC
Bulletin Number: 982544
SOME MOTOR HOME VEHICLES EQUIPPED WITH E4OD TRANSMISSIONS MAY EXPERIENCE HYDRAULIC SYSTEM MALFUNCTIONS AFTER REPLACING THE TRANSMISSION CASE. *YC
Bulletin Number: 982545
IMPORTANT SERVICE INSTRUCTIONS FOR ONP 97-B-17, EXPEDITION ONLY. *YC
Bulletin Number: 982548
BRIEF INFORMATION GIVING THE CORRECT PART NUMBER FOR TSB 98-3-12. *YC
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 982673
IF YOU ENCOUNTER A VEHICLE WITH A MISSING WHEEL HUB O-RING, DO NOT INSTALL A NEW O-RING. *YC
Bulletin Number: 982691
CONCERNS OF ENGINE CHECKLIGHT ON AND DTC P1506 ( IDLE AIR CONTROL OVER SPEED ERROR ) AND/OR FAST IDLE. *YC
Bulletin Number: 982733
VEHICLES WITH THE E4OD ARE ADDED TO THE FQR ( FORD QUALITY RENEWAL ) ASSEMBLY PROGRAM. *YC
Bulletin Number: 982741
SOME VEHICLES MAY EXHIBIT A LOW SPEED ( UNDER 35MPH ) CLICKING NOISE. THIS MAY BE CAUSED BY A CAGE NUT ROCKING ON THE COTTOR PIN FOR FRONT AXLE HALF SHAFT SPINDLE. *AK
Bulletin Number: 983074
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 983170
CONCERNS WITH CODES P0500, P0503, P1501 OR P1503 WHICH MAY BE CAUSED MY A LOOSE SPEEDOMETER DRIVE GEAR. *TT
Bulletin Number: 983284
SOME VEHICLES MAY EXPERIENCE AN AUDIBLE 50 HZ BODY BOOM. *TT
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 983302
THIS BULLETIN MENTIONS HOW SOME HUB O-RINGS MAY BE CUT DURING THE INSTALLATION OF THE WHEELS. *TT
Bulletin Number: 983566
INFORMATION ON PROGRAMMING / DIAGNOSING ANY PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT
Bulletin Number: 983566
INFORMATION REGARDING PROGRAMMING / DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT
Bulletin Number: 983570
SOME ENGINES MAY EXHIBIT OIL LEAKAGE. *TT
Bulletin Number: 983582
SUBJECT REGARDING VEHICLES EXHIBITING ERRATIC AND / OR INACCURATE FUEL GAUGE READINGS. *TT
Bulletin Number: 983582
ERRATIC AND / OR INACCURATE FUEL GAUGE READINGS. *TT
Bulletin Number: 983592
SUBJECT PERTAINING TO RADIO INOPERATIVE CONDITIONS. *TT
Bulletin Number: 98417
COLD AIR MAY BE FELT ON THE FLOOR WHILE IN HEAT MODE ON SOME VEHICLES. *YC
Bulletin Number: 98419
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 98-4725
VIBRATION AT CRUISE OVER 50 MPH. *AK
Bulletin Number: 98-4738
COLD ENGINE KNOCK 5.4L ACTION. *AK
Bulletin Number: 984802
WHEN INSTALLING A REAR WIPER ARM ON SOME VEHICLES, BE SURE TO FOLLOW THE PROCEDURE IN THE 1999 WORKSHOP MANUAL SECTION 501-16-92. *YC
Bulletin Number: 98-4802
INFORMATION ON PROCEDURES TO FOLLOW WHEN INSTALLING A REAR WIPER ARM. *TT
Bulletin Number: 98-4817
SOME 1997-1998 EXPLORER/MOUNTAINEER/EXPEDITION OR NAVIGATOR VEHICLES WITH 4-WD 4X4 SYSTEM MAY EXHIBIT BOTH
Bulletin Number: 985059
EXPERIENCING COLD ENGINE KNOCK (REPEAT / REVISED MESSAGE). *TT
Bulletin Number: 985062
SUBJECT REGARDING IDLE VIBRATION (REPEAT MESSAGE). *TT
Bulletin Number: 985063
SUBJECT REGARDING VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. (REPEAT MESSAGE). *TT
Bulletin Number: 985128
SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. *TT
Bulletin Number: 985185
COLD START ENGINE NOISE
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 9858
THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0503 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 98613
SUBJECT REGARDING COLD AIR FELT ON THE FLOOR WHILE IN HEAT MODE. *YC
Bulletin Number: 9869
CONCERNS WITH HESITATION, STUMBLE, SURGE, MISS, ROUGH IDLE, STALL AT IDLE. *TT
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 9874
A NEW SILICONE GASKET AND SEALANT. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 98B33
OWNER NOTIFICATION FOR REPLACEMENT OF ENGINE CYLINDER HEADS. *TT
Bulletin Number: 98S14
SAFETY RECALL UPDATE TO REPLACE LOCKING LUG NUTS. *TT
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 9912778
INFORMATION REGARDING NEW SERVICE STEERING GEAR. *TT
Bulletin Number: 9912792
CONDITIONS ON BROKENT DOOR PULL HANDLES. *TT
Bulletin Number: 99128
SOME VEHICLES MAY EXHIBIT A WHISTLING NOISE WHILE DRIVING WITH A/C IN THE OFF POSITION AT SPEEDS ABOVE 64 KM/H (40 MPH). *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 991313
SUBJECT REGARDING ANTI-LOCK BRAKE LAMP ILLUMINATION, INCREASED BREAK PEDAL EFFORT AND / OR FALSE ANTI-LOCK BRAKE SYSTEM (ABS) CYCLING AT LOW SPEEDS. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99143
SOME 4X4 VEHICLES BUILT WITH CENTER DISCONNECT FRONT AXLES MAY EXHIBIT A MOANING NOISE FROM THE FRONT DIFFERENTIAL WHILE OPERATING IN 4X2 MODE. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99157
SOME VEHICLES MAY EXHIBIT VIBRATION, SHIMMY AND BODY BOOM AT SPEEDS ABOVE 72 KM/H (45 MPH). *TT
Bulletin Number: 99164
CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER. *TT
Bulletin Number: 99185
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99195
SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 99411
VEHICLES EXPERIENCING INCREASED BRAKE PEDAL EFFORT AND / OR FALSE ABS CYCLING AT LOW SPEEDS, OR ABS LAMP ILLUMINATION. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT
Bulletin Number: 996034
EXPERIENCING A ENGINE KNOCK AT COLD START-UP. *TT
Bulletin Number: 996042
INFORMATION ON USING 1999 PROCEDURES MANUAL FOR SIDE MIRROR REPLACEMENT. *TT
Bulletin Number: 996113
EXPERIENCING FRONT DIFFERENTIAL NOISE. *TT
Bulletin Number: 996139
CONCERNS WITH FRONT DIFFERENTIAL NOISE. *TT
Bulletin Number: 996780
THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT
Bulletin Number: 996876
INFORMATION PERTAINING TO CONDITIONS WITH RED STAINING (SPOTS) ON THE FRONT BUMPER WING ENDS. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: 9996
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT
Bulletin Number: 99B02
INFORMATION ON REPLACING MULTIFUNCTION SWITCH. *TT
Bulletin Number: 99E03
EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT
Bulletin Number: BC0009961101
SOFT PARKING BRAKE PEDAL OR LONG PARKING BRAKE PEDAL FEEL. *TW
Bulletin Number: BC0053970201
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC0053972301
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC0054961101
VEHICLES MAY HAVE BEEN BUILT WITH A 240 SECOND MISFIRE DELAY. *TW
Bulletin Number: BC0056970201
SOME EXPEDITIONS MAY EXPERIENCE SOME BELT CHIRP AT COLD START UP IN AMBIENT TEMPERATURES OF 30-50 DEGREES F. *JD
Bulletin Number: BC0056972301
SOME VEHICLES WITH AIR CONDITIONING CAN EXHIBIT A COLD START ACCESSORY DRIVE BELT NOISE (CHIRP) CONCERN. *JD
Bulletin Number: BC0065961101
4X4 FRONT AXLE LEAKING THROUGH VENT TUBE. *TW
Bulletin Number: BC0121970201
DRIVELINE RATTLE OVER BUMPS. *JD
Bulletin Number: BC0197970201
ENGINE OVERHEATING- WATER PUMP CONCERN DUE TO FREE SPINNING WATER PUMP IMPELLER. *JD
Bulletin Number: BC0254970201
4X4 FRONT AXLE IS LEAKING THROUGH THE VENT TUBE. *JD
Bulletin Number: BC0315961101
FEAD BELT SQUEAL, COLD ONLY. *TW
Bulletin Number: BC0315970201
FEAD BELT SQUEAL, COLD ONLY. REVISED BELT RELEASED. *JD
Bulletin Number: BC0318970201
FRONT DRIVE AXLE FLUID LEAK. *JD
Bulletin Number: BC0318972301
FRONT DRIVE AXLE FLUID LEAK. *JD
Bulletin Number: BC0318A97020
FRONT DRIVE AXLE FLUID LEAK. *TW
Bulletin Number: BC0325961129
SOME FRONT END SERPENTINE BELTS MAY MAKE NOISE WHEN BETWEEN 30 AND 50 DEGREES FAHRENHEIT. *TW
Bulletin Number: BC0325972301
SOME 5.4L FRONT END SERPETNTINE BELTS MAY MAKE SOME NOISE BETWEEN TEMPERATURES FO 30 F-50 F. *JD
Bulletin Number: BC0340961127
CERTAIN 1997 VEHCILES MAY HAVE BEEN BUILT WITH THE 240 SECOND MISFIRE DELAY. *TW
Bulletin Number: BC0474961114
LONG TRAVEL OF PARKING BRAKE PEDAL. *TW
Bulletin Number: BC0477961114
ENGINEERING IS INVESTIGATING DEALERSHIP CONCERNS WITH FOULED OR CRACKED SPARK PLUGS. *TW
Bulletin Number: BC0600961101
ACCELERATOR CABLE CONTACTING THE POWER STEERING RESERVOIR MAY CAUSING ACCELERATOR PEDAL VIBRATION. *TW
Bulletin Number: BC0675961025
VEHICLES MAY EXPERIENCE FLUID LEAKS OUT OF THE FRONT AXLE VENT TUBE. *TT
Bulletin Number: BC0676961025
INFORMATION WHEN ELECTRONIC/HYDRAULIC CONTROL UNIT (EHCU) MALFUNCTIONS. *TT
Bulletin Number: BC0683961024
HIGH OR IRREGULAR GAUGE MOVEMENT OR IRREGULAR LOW FUEL LIGHT BELOW 1/4 FULL. *TT
Bulletin Number: BC0694961023
INFORMATION FOR RECREATIONAL TOWING (ALL WHEELS ON THE GROUND). *TT
Bulletin Number: BC0696961023
CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT
Bulletin Number: BC0743961018
PROCEDURE WHEN AIR SUSPENSION LIGHT IS ON. *TT
Bulletin Number: BC0745961018
CONCERN OF STARTER STAYING ENGAGED, LOOK AT CHAFED WIRE AT THE REAR BRACKET FOR THE RIGHT FRONT UPPER CONTROL ARM. *TT
Bulletin Number: BC0753961017
4X4 VEHICLES MAY EXHIBIT A GRINDING NOISE WHILE SHIFTING INTO 4L. *TT
Bulletin Number: BC0782961014
CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT
Bulletin Number: BC0843961008
INFORMATION ON REPLACING THE COMPASS ASSY FOR ERRATIC/NON-OPERATION. *TT
Bulletin Number: BC0844961008
E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT
Bulletin Number: BC0854961007
REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT
Bulletin Number: BC0884961004
FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT
Bulletin Number: BC1006597230
IF 4X4 FRONT AXLE IS LEAKING THROUGH THE VENT TUBE, ORDER THE NEW FRONT AXLE TUBE ASSEMBLY FROM THE NATIONAL PARTS DEPOT. *JD
Bulletin Number: BC1011097020
OVERHEATING ON 4.6/5.4L VEHICLES MAY BE CAUSED BY POSSIBLE WATER PUMP CONCERN DUE TO FREE SPINNING WATER PUMP IMPELLER.
Bulletin Number: BC1012997020
DRIVELINE RATTLE OVER BUMPS. *JD
Bulletin Number: BC1014697020
BELT CHIRP AT COLD START UP IN AMBIENT TEMPERATURES OF 30-50 DEGREES F. *JD
Bulletin Number: BC1014797020
BELT CHIRP AT COLD START UP IN AMBIENT TEMPERATURES OF 30-50 DEGREES F. *JD
Bulletin Number: BC1015397020
VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC1017397230
PARKING BRAKE PEDAL TRAVEL AND EFFORT ON EXPEDITIONS BROUGHT INTO THE DEALERSHIP WITH CUSTOMER COMPLAINTS CONCERNING PARKING BRAKE. *JD
Bulletin Number: BC1017697230
CHECK ENGINE LIGHT ON WITH DTC P0455 IN CONTINUOUS MEMORY ON VEHICLE APPLICATIONS. *JD
Bulletin Number: BC1017997230
ALL AIR SUSPNESION EXPEDTIONS ARE SHIPPED WITH THE AIR SUSPENSION SWITCH IN THE OFF POSITION. *JD
Bulletin Number: BC1018197230
ENGINEERING IS LOOKING FOR MORE DEFINITION OF VIBRATION CONCERNS ON 4X2 VEHICLES. *JD
Bulletin Number: BC1022497230
INOPERATIVE FLOOR MODE CONCERNS MAY BE DUE TO THE PANEL/FLOOR DOOR VACUUM ACTUATOR LINKAGE DISCONNECTING FROM THE DOOR PIVOT. *JD
Bulletin Number: BC1022797230
THE NGS DISPLAYS INCORRECT DATA FOR THE IGN GEM PID ON THE VEHICLES. *JD
Bulletin Number: BC1025097230
PASSIVE ANTI-THEFT SYSTEM. *JD
Bulletin Number: BC1025597230
VEHICLES EQUIPPED WITH 4-WHEEL DRIVE, ROOF RACK AND BASE SUSPENSION MAY EXPERIENCE CLEARANCE DIFFICULTIES WITH GARAGE/CARPORTS. *JD
Bulletin Number: BC1033797020
CONDENSATE FORMING ON THE OUTSIDE OF THE EVAPORATOR. *JD
Bulletin Number: BC1034197020
RESETTING OF THE TRIPCOMPUTER ON EXPEDITION & NAVIGATOR WHERE THE INFORMATION IS NOT CONTAINED IN THE OWNERS GUIDE. *JD
Bulletin Number: BC1034397020
ILLUMINATION OF THE CHECK ENGINE LIGHT. *JD
Bulletin Number: BC1035197020
THE FUEL GAGE MAY SWING ERRATICALLY ON STEEP SLOPES. *JD
Bulletin Number: BC1035297020
FUEL PUMP SENDER, IN AREAS WITH STEEP SLOPES, THE LOW FUEL WARNING LIGHT MAY PREMATURELY ACTIVATE. *JD
Bulletin Number: BC105819705
SOME EXPEDITIONS MAY EXPERIENCE AN INTERMITTENT VISOR VANITY MIRROR LIGHT OPERATION. *TW
Bulletin Number: BC105849705
VEHICLES WITH PREMIUM RADIOS WILL BE EQUIPPED WITH VOLUME CONTROL/ON-OFF SWITCH. *TW
Bulletin Number: BC105969705
VEHICLES BUILT BEFORE 4/11/97 MAY EXPERIENCE A RATTLE OR CLUNK. *TW
Bulletin Number: BC106039705
INSTRUCTIONS ON HOW TO ENABLE AND DISABLE THE AUTO LOCK FEATURE. *TW
Bulletin Number: BC2225970501
RATTLE OR CLUNK NOISE IN REAR OF VEHICLE CAUSED BY THE BUSHING FALLING OUT OF THE SWAY BAR LINK. *TW
Bulletin Number: BC2226970501
SERVICING TIP - TRANSMISSION - THERE ARE TWO DIFFERENT SIZE DIRECT CLUTCH STEEL PLATES WHEN SERVICING 4R44E OR 5R55E TRANSMISSIONS. *TW
Bulletin Number: BC2245970501
INSTRUCTIONS FOR ENABLING/DISABLING THE AUTOMATIC LOCK FEATURE. *TW
Bulletin Number: BC2305970501
VEHICLES MAY EXPERIENCE AN INTERMITTENT VISOR VANITY MIRROR LIGHT OPERATION. *TW
Bulletin Number: BC2307970501
LOSS OF SOME ACCESSORIES SUCH AS DRIVER'S POWER WINDOW FUNCTION WHEN THE TRANSMISSION IS SHIFTED OUT OF PARK OR NEUTRAL. *TW
Bulletin Number: BC2363970501
THE ONLY AUTHORIZED REPAIR FOR A FRONT FRAME BUMPER MOUNTING BRACKET NEEDING REPLACEMENT IS TO REPLACE THE FRAME. *TW
Bulletin Number: BC2375970501
VEHICLES BUILT BEFORE 3/24/97 MAY EXPERIENCE WIND NOISE AT THE A-PILLAR. *TW
Bulletin Number: BC2382970501
VEHICLES MAY EXPERIENCE A STAINING OF THE ANODIZED ALUMINUM TRIM WITH THE USE OF SOME CAR WASHES WHICH CONTAIN ULTRA VIOLET PROTECTANTS. *TW
Bulletin Number: BC3007970501
REVISION TO THE TECHNICAL INSTRUCTIONS WHEN PERFORMING RECALL 96S60. *TW
Bulletin Number: BC3060970228
INSTRUCTIONS FOR RESETTING THE TRIP COMPUTER. *TW
Bulletin Number: BC3062970228
ILLUMINATION OF CHECK ENGINE LIGHT WITH DTC P0446 MAY BE DUE TO CONTAMINATED CANNISTER, EVAP LINES OR VENT SOLENOID. *TW
Bulletin Number: BC3070970227
CONCERNS OF CONDENSATE FORMING ON OUTSIDE OF EVAPORATOR CASE. *TW
Bulletin Number: BC3090970225
VEHICLES WITH A ROUGH RUNNING/MISS SYMPTOM WITH A MISFIRE DTC ON A PARTICULAR CYLINDER WHERE NORMAL DIAGNOSIS DOES NOT PINPOINT A CAUSE - CHECK FOR DAMAGE TO CAMSHAFT. *TW
Bulletin Number: BC3140970220
INOPERATIVE CD CHANGER MAY BE DUE TO LOOSE 66 PIN CONNECTOR. *TW
Bulletin Number: BC3141970220
VEHICLES BUILT WITH RUNNING BOARDS AFTER 1/30/97 WILL NOT HAVE SEALS ON THE LOWER EDGE OF THE FRONT AND REAR DOORS. *TW
Bulletin Number: BC3153970219
INOPERATIVE OR ERRATIC CRUISE CONTROL OPERATION ALONG WITH HARSH TRANSMISSION SHIFTS. *TW
Bulletin Number: BC3270970207
CHECK ENGINE LIGHT - DTC P0446 - CHECK FOR MOLD FLASHING IN THE 90 DEGREE ELBOW EVAP LINE CONMING OUT OF THE CANNISTER. *TW
Bulletin Number: BC3272970207
VEHICLES ARE EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) - VEHICLE WILL NOT START WITHOUT THE CORRECT IGNITION KEY. *TW
Bulletin Number: BC3277970207
VEHICLES EQUIPPED WITH 4-WHEEL DRIVE, ROOF RACK AND BASE SUSPENSION MAY EXPERIENCE CLEARANCE DIFFICULTIES WITH CERTAIN GARAGES/CARPORTS. *TW
Bulletin Number: BC3282970206
GEM CONCERN - CHECK FOR MORE THAN ONE GEM CONTROLLED COMPONENT THAT IS INOPERATIVE OR FOR A STRING OF FALSE GEM DTC'S RECEIVED IN MEMORY. *TW
Bulletin Number: BC3360972301
INOPERATIVE FLOOR MODE CONCERNS MAY BE DUE TO THE PANEL/FLOOR DOOR VACUUM ACTUATOR LINKAGE DISCONNECTING FROM THE DOOR PIVOT. *JD
Bulletin Number: BC3363972301
THE NGS DISPLAYS INCORRECT DATE FOR THE ING GEM PID ON THE VEHICLES. *JD
Bulletin Number: BC3500972301
LOOKING FOR MORE DEFINITION OF VIBRATION CONCERNS ON 4X2 VEHICLES. *JD
Bulletin Number: BC3510972301
CHECK ENGINE LIGHT ON WITH DTC P0455 IN CONTINUOUS MEMORY ON 1997 5.4L VEHICLE APPLICATIONS. *JD
Bulletin Number: BC3513972301
AIR SUSPENSION VEHICLES ARE SHIPPED WITH THE AIR SUSPENSION SWITCH IN THE OFF POSITION. *JD
Bulletin Number: BC3522972301
PARKING BRAKE PEDAL TRAVEL AND EFFORT ON EXPEDITIONS. *JD
Bulletin Number: BC5168961001
PROCEDURE FOR RESOLVING THE CONCERN OF WATER ENTRY INTO THE TRANSFER CASE. *TT
Bulletin Number: BC5177961001
INFORMATION FOR CONCERNS OS SPEEDOMETER, SPEED CONTROL INOP & VSS (VEHICLE SPEED SENSOR) DTC'S. *TT
Bulletin Number: BC5194961001
REVISED SWITCH BEZEL IS AVAILABLE THAT WILL MINIMIZE CARGO CONTACT W/ THE SWITCH. *TT
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC5196961001
CONCERN OF STARTER STAYING ENGAGED. RED WIRE THAT RUNS FROM THE STARTER RELAY TO THE STARTER MAY CHAFE & CAUSE STARTER TO STAY ENGAGED AFTER CRANK. *TT
Bulletin Number: BC5211961001
INFORMATION FOR HIGH OR IRREGULAR FUEL GAUGE MOVEMENT OR IRREGULAR LOW FUEL FUEL LIGHT BELOW 1/4 FULL. *TT
Bulletin Number: BC9668961001
CONCERN FOR VEHICLES EXHIBITING LEAN CODES P0171 & P0174 (VACUUM LEAK). *TT
Bulletin Number: BC9671961001
PUSH CONNECTION BETWEEN THE FLEXIBLE FUEL VAPOR LINE AT THE CARBON CANISTER & THE METAL FUEL VAPOR LINE MAY NOT SEAT FULLY ON THE FUEL VAPOR LINE. *TT
Bulletin Number: BC9672961001
PROCEDURE FOR BRAKE WARNING INDICATOR STAYS ON RED IN CLUSTER. *TT
Bulletin Number: BC9673961001
PROCEDURE FOR BRAKE EXTERIOR LIGHTS STAY ON (TAIL & HIGH MOUNT STOP LIGHT). *TT
Bulletin Number: BC9674961001
LIGHT TO MODERATE AXLE NOISE (AXLE WHINE) AT 50 TO 65 MPH (80 TO 105 KPH) DURING ACCELS, DECELS OR CRUISE MAY BE DUE TO AXLE NOISE BEING TRANSMITTED FROM THE AXLE INTO THE VEHICLE. *TT
Bulletin Number: BC9676961001
IMPROPER RTV APPLICATION AT THE FRONT/REAR LOWER INTAKE MANIFOLD END SEALS & SIDE GASKETS MAY CAUSE AN OIL/COOLANT LEAK. *TT
Bulletin Number: BC9680961001
CONCERN WHERE THE DOOR GLASS DROPS WHEN CYCLED DOWN ON VEHICLES WITH THE POWER DOOR OPTION. *TT
Bulletin Number: BC9682961001
CONCERNS FOR THE LABOR TIME STANDARD IN TBS 96-19-02 (STEERING - GRUNT NOISE DURING STEERING WHEEL RETURN FROM FULL RIGHT TURN) IS INCORRECT. *TT
Bulletin Number: BC9688961001
INFORMATION FOR WHEN DIAGNOSING CONCERNS W/ FACTORY INSTALLED CELLULAR PHONES. *TT
Bulletin Number: BC9694961001
INFORMATION ON VEHICLES THAT MAY EXHIBIT A SLIGHT DELAY IN THE FIRST DRIVE AWAY AFTER THE VEHICLE HAS BEEN PARKED OVERNIGHT, OR FOR A LONGER PERIOD OF TIME. *TT
Bulletin Number: BC9695961001
ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) INVALID DIAGNOSTIC CODES U1235 & 155 MAY BE STORED IF THE IGNITION SWITCH IS CYCLED FROM 'OFF' TO 'RUN' EXTREMELY SLOWLY. *TT
1997 FORD EXPLORER
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 00201
SOME VEHICLES MAY EXHIBIT HESITATION ON ACCELERATION OR WHILE TURNING. *JB
Bulletin Number: 00213
SUBJECT REGARDING CLIMATE CONTROL - EATC - BLOWER MOTOR CONTROL SERVICE TIPS. *JB
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 00243
ON SOME VEHICLES, THE ACCELERATOR PEDAL BRACKET MAY BECOME LOOSE OR SEPARATED FROM THE DASH PANEL. THIS MAY BE CAUSED BY REPEATED EXCESSIVE FORCE ON THE ACCELERATOR PEDAL, RESULTING IN CRACKING OF THE DASH PANEL SHEET METAL AT THE ACCELER
Bulletin Number: 0083
SOME VEHICLES EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A RUBBING NOISE DURING RIGHT HAND TURNS FROM THE REAR OF THE VEHICLE. **MR
Bulletin Number: 00E11
SERVICE ACTION 00E11, SUPPLEMENT #1 - UPDATE INFORMATION REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
Bulletin Number: 00E11
SERVICE ACTION BULLETIN REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
Bulletin Number: 00L09
SUBJECT PERTAINING TO SUPPLEMENTAL TIRE INFLATION LABEL. *JB
Bulletin Number: 00M11
INFORMATION REGARDING FRONT SWAY BAR LINK . *YH
Bulletin Number: 00M11
SUBJECT REGARDING ADDITIONAL COVERAGE PROGRAM FOR SWAY BAR LINKS. *JB
Bulletin Number: 00M12
SUBJECT REGARDING OWNER NOTIFICATION SUPPLLEMENTAL PROGRAM FOR VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES - CAMSHAFT CHAIN TENSIONER AND LOWER INTAKE MANIFOLD GASKET ADDITIONAL COVERAGE. *TT
Bulletin Number: 00M12
FORD MOTOR COMPANY IS PROVIDING ADDITIONAL COVERAGE FOR THE 4.0L SOHC CAMSHAFT CHAIN TENSIONER AND LOWER INTAKE MANIFOLD GASKET. *TT
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01197
SOME VEHICLES EQUIPPED WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / ONNECTING ROD BEARING KNOCK. *TT
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 0186
ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT
Bulletin Number: 01B77
OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT
Bulletin Number: 01M01
SUBJECT REGARDING ADDITIONAL COVERAGE ON THE FRONT CAM CHAIN GUIDE ASSEMBLY FOR RENTAL VEHICLES WITH 4.0L SINGLE OVERHEAD CAM (SOHC) ENGINES. *TT
Bulletin Number: 01M01
SUBJECT REGARDING ADVANCE NOTICE ON UPCOMING OWNER NOTIFICATION PROGRAM WHICH WILL PROVIDE ADDITIONAL COVERAGE ON THE FRONT CAM CHAIN GUIDE ASSEMBLY ON CERTAIN VEHICLES. *TT
Bulletin Number: 01M01
OWNER NOTIFICATION PROGRAM REGARDING ADDITIONAL COVERAGE PROGRAM FOR FRONT CAM CHAIN GUIDE ASSEMBLY WHICH MAY WEAR OR BREAK AND CAUSE EXCESSIVE CAM CHAIN NOISE THAT DOES NOT GO AWAY AFTER FIVE MINUTES OF ENGINE OPERATION. *TT
Bulletin Number: 01M01
SUBJECT REGARDING OWNER NOTIFICATION PROGRAM 01M01 REGARDING ADDITIONAL COVERAGE FOR FRONT CAM CHAIN GUIDE ASSEMBLY. *TT
Bulletin Number: 02138
LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
Bulletin Number: 0232
SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301. *TT
Bulletin Number: 0242
CERTAIN VEHICLES WITH 4X4 OR ALL-WHEEL DRIVE MAY HAVE A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT
Bulletin Number: 0282
SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. *TT
Bulletin Number: 030508
FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD. *TT
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 03261
NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT
Bulletin Number: 0358
FLUID MAY LEAK OUT OF THE FRONT AXLE VENT TUBE. *TT *JB
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 060199
CUSTOMER MAY COMPLAIN OF AN INTERMITTENT STUMBLE / BUCK / JERK AT 38 MPH WHILE IN HIGH GEAR AND AT VERY LIGHT THROTTLE APPLICATION. *TT
Bulletin Number: 070101
SUBJECT REGARDING OWNER NOTIFICATION PROGRAM 01M01 SUPPLEMENT #2: REVISED TECHNICAL INSTRUCTIONS AND NEW LABOR OPERATION. NLM
Bulletin Number: 090308
MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455
Bulletin Number: 11512
ENGINEERING IS INVESTIGATING CONCERNS OF NOISY FRONT SYSTEM BLOWER MOTORS ON CERTAIN VEHICLES. *TT
Bulletin Number: 11759
SOME VEHICLES MAY COME IN FOR A BENT FRONT SEAT BACK RECLINER LEVER. *TT
Bulletin Number: 11811
SOME VEHICLES BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT
Bulletin Number: 12115
INFORMATION REGARDING THE TIRE INFLATION PRESSURE FOR ALL MODELS DURING PREDELIVERY PROCESS AND DURING MAINTENANCE INTERVALS. *MJS
Bulletin Number: 12150
INFORMATION CONCERNING THE REPLACEMENT OF THE ENGINES ON VEHICLES EQUIPPED WITH A 4.0L SOHC THAT REQUIRE SERVICE. *MJS
Bulletin Number: 12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
Bulletin Number: 12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
Bulletin Number: 12227
FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12230
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12298
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. *TT
Bulletin Number: 12512
BRIEF INFORMATION ON CHECKING TRANSMISSION FLUID LEVEL. *T
Bulletin Number: 12518
CONCERNS WITH THE IN-DASH CD STOPS OPERATING WHEN HOT / RADIO DISPLAY READS CD TOO HOT. *TT
Bulletin Number: 12529
SOME VEHICLES MAY EXHIBIT AN AIR BAG LIGHT ON INTERMITTENTLY WITH DIAGNOSTIC TROUBLE CODE B1924. *TT
Bulletin Number: 12571
EXPERIENCING A WHINNING NOISE FROM THE TRANSFER CASE. *TT
Bulletin Number: 12624
SOME VEHICLES MAY EXHIBIT A HESITATION / LACK OF POWER ON RE-ACCELERATION AFTER DECELERATING FROM 45 - 65 MPH TO A SLOW ROLL CONDITION. *TT
Bulletin Number: 12710
SOME VEHICLES MAY EXHIBIT A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOISE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT
Bulletin Number: 12852
USE KLEENEX BRAND JUNIORS OR LI'L TRAVELERS TO REFILL TISSUES FOR CERTAIN VEHICLES WITH THE HIGH SERIES CENTER CONSOLE FACIAL TISSUE COMPARTMENT. *TT
Bulletin Number: 12905
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT
Bulletin Number: 13049
EXHIBITING A POWER STEERING FLUID LEAK FROM THE STEERING GEAR BOOT(S). *TT
Bulletin Number: 13118
SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT
Bulletin Number: 13154
SUBJECT REGARDING 4.0L ENGINE HOTLINE PHONE NUMBERS. *TT
Bulletin Number: 13154
SUBJECT REGARDING ENGINE HOTLINE PHONE NUMBERS. *TT
Bulletin Number: 13170
INFORMATION REGARDING 4.0 L SOHC CAMSHAFT BOLT TORQUE. *MJS
Bulletin Number: 13171
INFORMATION REGARDING 4.0L SOHC ENGINE NOISE (CAM CHAIN NOISE). *MJS
Bulletin Number: 13172
INFORMATION REGARDING SOHC ENGINE NOISE (CAM CHAIN NOISE). *MJS
Bulletin Number: 13177
INFORMATION REGARDING 4.0L SOHC ENGINE REPAIR PROCEDURE UPDATE. *MJS
Bulletin Number: 13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
Bulletin Number: 13218
INFORMATION REGARDING SEAT THAT WILLL NOT MOVE FORWARD. *MJS
Bulletin Number: 13222
INFORMATION REGARDING NEUTRAL TOW KIT AVAILABLE. *MJS
Bulletin Number: 13260
SERVICE TIPS INFORMATION PROVIDED TO ASSIST WHEN SERVICING VEHICLES WITH SHORT BLOCK ASSEMBLY. *TT
Bulletin Number: 13261
SERVICE TIPS WHEN SERVICING A 4.0L SOHC SHORT BLOCK ASSEMBLY. *TT
Bulletin Number: 13300
SOME VEHICLES WITH 4.0L SOHC ENGINES MAY EXHIBIT A VIBRATION / MOAN / BOOM AT IDLE. *TT
Bulletin Number: 13388
VEHICLES EQUIPPED THE NEUTRAL TOW FEATURE, BE AWARE THAT WHEN THE NEUTRAL TOW FEATURE IS ENABLED AND THE CUSTOMER PLACES THE VEHICLE INTO THE NEUTRAL MODE, THE NEUTRAL TOW INDICATOR WILL GO OUT WHEN THE GEM GOES TO SLEEP. *TT
Bulletin Number: 13404
SOME 4X4 VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *TT
Bulletin Number: 13412
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT
Bulletin Number: 13415
EXHIBITING A SQUEAK TYPE NOISE FROM THE REAR STABILIZER BAR WHILE DRIVING, ESPECIALLY WHEN GOING OVER BUMPS. *TT
Bulletin Number: 13424
SOME VEHICLES EQUIPPED WITH FOUR WHEEL ANTI LOCK BRAKES MAY EXHIBIT WHEEL SPEED PARAMETER IDENTIFICATIONS WHICH READ N/A IMMEDIATELY OR ABOVE 7 MPH. *TT
Bulletin Number: 13426
EXHIBITING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS. *TT
Bulletin Number: 13440
EXPERIENCING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS (PARKING LOT TYPE MANEUVERS). *TT
Bulletin Number: 13482
SOME VEHICLES MAY EXHIBIT A VIBRATION / GROAN ON ACCELERATION OR TAKE-OFF DUE TO THE REAR TRANSMISSION MOUNT BEING TWISTED AND ALLOWING A GROUND OUT CONDITION TO OCCUR. *TT
Bulletin Number: 13484
VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT EXCESSIVE OIL CONSUMPTION AS REPORTED BY THE CUSTOMER. *TT
Bulletin Number: 13504
CONCERNS WITH VEHICLES EXHIBITING AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. ENGINEERING IS CURRENTLY ADDRESSING THIS ISSUE THROUGH THE HIGH MILAGE / TIME-IN-SERVICE CONCERN RESOLUTION PROCESS. *TT
Bulletin Number: 13505
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
Bulletin Number: 13527
SOME VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES MAY EXHIBIT AN OVERHEAT CONDITION THAT MAY BE ATTRIBUTED TO THE THERMOSTAT. ENGINEERING IS CURRENTLY INVESTIGATING THIS ISSUE AND IS LOOKING FOR THERMOSTATS AND COOLANTS SAMPLES FROM THESE
Bulletin Number: 13723
SOME ALL WHEEL DRIVE VEHICLES MAY EXPERIENCE A LOW SPEED WHINING NOISE FROM THE TRANSFER CASE. *MJS
Bulletin Number: 13745
SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS
Bulletin Number: 13752
SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *MJS
Bulletin Number: 13752
SOME 4X4 VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *TT
Bulletin Number: 13857
SOME VEHICLES EQUIPPED WITH 5.0L ENGINES AND ALL WHEEL DRIVE (AWD) TRANSFER CASE MAY EXHIBIT A CONDITION OF 4X4 INDICATORS FLASHING AND MULTIPLE GEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 13879
INFORMATION ON REPLACING A GEM MODULE ON 4X4 VEHICLES EQUIPPED WITH 4.0L SOHC, OHV AND THE NEUTRAL TOW KIT. *TT
Bulletin Number: 14048
SOME VEHICLES MAY EXPERIENCE AN OIL LEAK AT THE REAR CRANKSHAFT AREA AFTER SERVICE. **MR
Bulletin Number: 14056
SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR
Bulletin Number: 14061
SOME VEHICLES MAY COME IN FOR A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE P0171 AND/OR P0174 IN SELF TEST. **MR
Bulletin Number: 14265
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT HESITATION ON ACCELERATION OR WHILE TURNING. *TT
Bulletin Number: 14371
SUBJECT REGARDING POP / CREAK NOISE FROM THE REAR UNDERBODY WHILE DRIVING. *JB
Bulletin Number: 14560
VEHICLES MAY EXPERIENCE START UP TIMING CHAIN NOISE. *JB
Bulletin Number: 14583
CONCERNS WITH BROKEN THERMOSTATS ON ENGINES. *JB
Bulletin Number: 14617
SUBJECT PERTAINING TO BROKEN THERMOSTAT. *JB
Bulletin Number: 14819
SOME 4X4 VEHICLES MAY EXHIBIT A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT
Bulletin Number: 14847
CONCERNS WITH VEHICLES EXHBIT FLUID LEAKAGE FROM THE FRONT AXLE VENT TUBE. *TT
Bulletin Number: 14868
SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC ENGINE MAY EXHIBIT A PRIMARY CHAIN RATTLE NOISE (SOMETIMES DESCRIBED AS A SPARK KNOCK-TYPE NOISE). *TT
Bulletin Number: 15006
SOME VEHICLES WITH 4.0L SOHC ENGINES MAY MAKE A START-UP NOISE FROM THE LEFT FRONT OF THE ENGINE. *TT
Bulletin Number: 15040
SOME EXPLORER / SPORT / SPORT TRAC EQUIPPED WITH A 4.0L SOHC ENGINE MAY EXHIBIT A START-UP NOISE CONDITION FROM THE LEFT FRONT OF THE ENGINE. *TT
Bulletin Number: 15040
SOME VEHICLES INCLUDING 1997 THROUGH 1999 EXPLORER SPORT TRAC EQUIPPED WITH A 4.0L SOHC ENGINE MAY EXHIBIT A START-UP NOISE FROM THE LEFT FRONT OF THE ENGINE. *TT
Bulletin Number: 15168
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT HIGH FREQUENCY BRAKE SQUEAL NOISE. *YH
Bulletin Number: 15249
CONCERNS WITH HIGH BRAKE PEDAL FORCE TO STOP AFTER ROTOR MACHINING. *TT
Bulletin Number: 15532
INFORMATION ON VEHICLES EXHIBITNG FUEL LINE DAMAGE DUE TO PINCHING/SQUEEZING OF THE FUEL RETURN LINE. *TT
Bulletin Number: 15563
INFORMATION REGARDING MALFUNCTION INDICATOR LIGHT ILLUMINATING WITH DIAGNOSTIC TROUBLE CODE P0300/P0301.*YH
Bulletin Number: 15692
SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT
Bulletin Number: 15887
SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). *TT
Bulletin Number: 15910
CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION. *TT
Bulletin Number: 16040
EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT
Bulletin Number: 16385
AIR RIDE CONTROL LAMP ON AFTER SHOCK ABSORBER REPLACEMENT / CONTACT REQUEST. *TT
Bulletin Number: 16735
VARIOUS NOISE ISSUES FROM THE REAR LEAF SPRINGS WHILE DRIVING. *TT
Bulletin Number: 16935
AN UNCOMMANDED SHIFT TO 4X4 LOW. *TT
Bulletin Number: 4619
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT
Bulletin Number: 4623
BRIEF INFORMATION FOR VEHICLES EXHIBITING ENGINE STALL. *TT
Bulletin Number: 4634
STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT
Bulletin Number: 4642
SOME VEHICLES MAY COME IN FOR A BENT FRONT SEAT BACK RECLINER LEVER. *TT
Bulletin Number: 4703
SOME TRUCKS BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND TRUCKS BUILT WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT
Bulletin Number: 5049
BRIEF INFORMATION REGARDING UPPER ENGINE NOISE. *TT
Bulletin Number: 5128
SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. ENGINEERING IS INVESTIGATING. *TT
Bulletin Number: 5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
Bulletin Number: 5249
INFORMATION ON VEHICLES EXHIBITING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT
Bulletin Number: 5256
INFORMATION ON VEHICLES EXHIBITING UPPER ENGINE NOISE. *TT
Bulletin Number: 5272
BRIEF INFORMATION REGARDING ENGINE STALL CONDITION. *TT
Bulletin Number: 5652
COMPLAINTS THAT THE IN-DASH CD STOPS OPERATING WHEN HOT. *TT
Bulletin Number: 5814
SERVICE TIPS FOR CHECKING TRANSMISSION FLUID LEVEL. *TT
Bulletin Number: 5852
VEHICLES EXHIBITING INTERMITTENT ILLUMINATION OF AIR BAG LIGHT WITH DIAGNOSTIC TROUBLE CODE B1924. *TT
Bulletin Number: 6203
SOME VEHICLES MAY EXHIBIT A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT
Bulletin Number: 6429
INFORMATION ON REFILLING TISSUES FOR THE CENTER CONSOLE FACIAL TISSUE COMPARTMENT. *TT
Bulletin Number: 6574
SOME VEHICLES MAY EXHIBIT AN OCCASIONAL HOOT / MOAN FROM THE IDLE AIR CONTROL (IAC) VALVE. *TT
Bulletin Number: 6603
SOME VEHICLES MAY EXHIBIT AN AUDIBLE PINGING OR CREAKING NOISE THAT MAY BE HEARD FROM THE DRIVELINE WHEN ENGINE TORQUE IS INITIALLY APPLIED TO THE DRIVELINE. *TT
Bulletin Number: 6640
EXHIBITING AN AIR BAG LAMP ON INTERMITTENTLY WITH LAMP FAULT CODE (LFC) 24, OR DIAGNOSTIC TROUBLE CODE B1924 AND / OR B1342 STORED IN MEMORY. *TT
Bulletin Number: 6896
SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT
Bulletin Number: 6926
SUBJECT REGARDING THE ENGINE HOTLINE PHONE NUMBERS FOR 1997 - 2000 MODEL YEAR VEHICLES. *TT
Bulletin Number: 6980
SOME VEHICLES MAY EXHIBIT THE CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODE PO420. *TT
Bulletin Number: 6986
INFORMATION REGARDING 4.0L SOHC CAMSHAFT BOLT TORQUE. *TT
Bulletin Number: 6987
SOME VEHICLES MAY EXHIBIT ENGINE NOISE(CAM CHAIN NOISE). *TT
Bulletin Number: 6993
SUBJECT REGARDING 4.0L SOHC ENGINE REPAIR PROCEDURE UPDATE. *TT
Bulletin Number: 6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
Bulletin Number: 7079
INFORMATION REGARDING SEAT THAT WILL NOT MOVE FORWARD. *MJS
Bulletin Number: 7083
INFORMATION REGARDING NEUTRAL TOW KIT AVAILABILITY. *MJS
Bulletin Number: 7138
SERVICE TIP INFORMATION WHEN SERVICING THE 4.0L SOHC SHORT BLOCK ASSEMBLY. *TT
Bulletin Number: 7270
SOME VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES MAY EXHIBIT A VIBRATION / MOAN / BOOM AT IDLE. *TT
Bulletin Number: 7316
SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *TT
Bulletin Number: 7353
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT
Bulletin Number: 7360
SOME VEHICLES MAY EXHIBIT A SQUEAK NOISE FROM THE REAR WHILE DRIVING, ESPECIALLY WHEN GOING BUMPS. *TT
Bulletin Number: 7366
SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION MAY EXHIBIT NEUTRAL GEAR ROLLOVER NOISE (A LIGHT METALLIC RATTLING SOUND FROM THE TRANSMISSION) WHICH OCCURS AT IDLE WITH TRANSMISSION IN NEUTRAL CLUTCH ENGAGED (CLUTCH PEDAL UP). *TT
Bulletin Number: 7367
SOME VEHICLES EQUIPPED WITH FOUR WHEEL ANTI-LOCK BRAKES (4WABS) MAY EXHIBIT WHEEL SPEED PARAMETER IDENTIFICATIONS (PIDS) WHICH READ N/A IMMEDIATELY OR ABOVE 7 MPH WHEN VIEWED USING THE NEW GENERATION STAR (NGS) TESTER. *TT
Bulletin Number: 7468
SOME VEHICLES MAY EXHIBIT A VIBRATION / GROAN ON ACCELERATION OR TAKE OFF.
Bulletin Number: 7471
SOME VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT EXCESSIVE OIL CONSUMPTION AS REPORTED BY THE CUSTOMER. *TT
Bulletin Number: 7494
ALL VEHICLES WITH ELECTRONIC SHIFT ON THE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF WHAT THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
Bulletin Number: 7918
FRONT AXLE PINION LIL SEAL LEAKS.
Bulletin Number: 8119
SOME VEHICLES EQUIPPED WITH 5.0L ENGINE AND ALL WHEEL DRIVE (AWD) TRANSFER CASE MAY EXHIBIT A CONDITION OF 4X4 INDICATORS FLASHING AND MULTIPLE GEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 8149
SUBJECT REGARDING NEUTRAL TOW INOPERATIVE AFTER GEM REPLACEMENT. *TT
Bulletin Number: 8164
INFORMATION REGARDING PUMP ALIGNMENT TOOLS. **MR
Bulletin Number: 8164
INFORMATION ON 5R55E - 4R55E - 4R44E PUMP ALIGNMENT TOOLS. *TT
Bulletin Number: 8493
SOME VEHICLES MAY EXPERIENCE AN OIL LEAK AT THE REAR CRANKSHAFT AREA AFTER SERVICE. **MR
Bulletin Number: 8512
SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR
Bulletin Number: 870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
Bulletin Number: 96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
Bulletin Number: 96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
Bulletin Number: 96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
Bulletin Number: 96226
AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW
Bulletin Number: 962410
TRANSMISSION - E40D - 4R70W - 4R44E - 5R55E - NEW DIGITAL TRANSMISSION RANGE SENSOR - DIAGNOSIS SERVICE TIP. *TW
Bulletin Number: 96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
Bulletin Number: 96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
Bulletin Number: 962511
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 96E57
EMISSIONS RECALL 96E57 - CERTAIN 1996 EXPLORERS EQUIPPED WITH THE 4.0L ENGINES AND BUILT AT THE LOUISVILLE ASSEMBLY PLANT ON 11/18/95 AND CERTAIN 1997 EXPLORERS EQUIPPED WITH THE 4.0L ENGINES AND BUILT AT THE LOUISVILLE ASSEMBLY PLANT FROM
Bulletin Number: 97050110611
VEHICLES MAY EXHIBIT A CENTER CONSOLE SQUEAK. *TW
Bulletin Number: 97050110613
WHEN PERFORMING TSB 97-4-9, DO NOT USE A BAFFLE TO CORRECT HTE ISSUE, USE THE REVISED AXLE COVER PLATE. *TW
Bulletin Number: 97050110634
ENGINEERING IS INVESTIGATING CONCERNS OF BROKEN LIFTGATE GLASS. *YC
Bulletin Number: 97090297183
EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC
Bulletin Number: 97090297189
EXPERIENCING A "THUMPING" NOISE OR TEMPEATURE GAUGE FLUCTATION WITH SOME VEHICLES. *YC
Bulletin Number: 971110972312
CONCERNS WITH "PINGING" OR "CREAKING" BEING HEARD FROM THE DRIVELINE WHEN SHIFTING FROM PARK TO DRIVE OR REVERSE, BETWEEN DRIVE AND REVERSE, OR WHEN ENGAGING THE CLUTCH. *YC
Bulletin Number: 97116
TRANSFER CASE- WATER INGESTION THROUGH VENT TUBE. *JD
Bulletin Number: 97312
CD PLAYER- "SKIPS"- HIGH SERIES CONSOLE- NORMAL DRIVING CONDITIONS. *JD
Bulletin Number: 97314
TRANSFER CASE- BINDING OR SHUDDER- DIAGNOSTICS- VEHICLES WITH 4.0L ENGINE- SERVICE TIP. *JD
Bulletin Number: 9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD
Bulletin Number: 9738
REMOTE KEYLESS ENTRY- RKE INOPERATIVE- VEHICLES BUILT THROUGH 10/30/96. *JD
Bulletin Number: 9747
FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD
Bulletin Number: 9751
INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD
Bulletin Number: 97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
Bulletin Number: 97513
IDLE- "BOOMING" NOISE HEARD AT IDLE- 4.0L ENGINE- VEHICLES BUILT FROM 7/29/96 THROUGH 11/11/96. *JD
Bulletin Number: 97514
CD PLAYER- "SKIPS"- HIGH SERIES CONSOLE- NORMAL DRIVING CONDITIONS. *JD
Bulletin Number: 9755
MALFUNCTION INDICATOR LAMP (MIL)- MIL ILLUMINATION- DIAGNOSTIC TROUBLE CODE (DTC) P0446 STORED IN MEMORY. *JD
Bulletin Number: 976011
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
Bulletin Number: 9776
IDLE- "BOOMING" NOISE HEARD AT IDLE- 4.0L SOHC ENGINE- VEHICLES BUILT FROM 7/29/96 THROUGH 11/11/96. *JD
Bulletin Number: 98021698311
SOME VEHICLES MAY EXHIBIT A DRIFT/PULL, SHOW SIGNS OF TIRE WEAR, OR EXHIBIT POOR RIDE QUALITY. *YC
Bulletin Number: 980313
EXPERIENCING IDLE VIBRATION / EXHAUST BOOM. *YC
Bulletin Number: 980318
CONDITIONS WITH AXLE WIND-UP ON TIGHT TURNS WITH CONTROL TRAC TRANSFER CASE. *YC
Bulletin Number: 980319
CONCERNS WITH FALSE ABS ACTIVATION WHILE LIGHT BRAKING AT LOW SPEEDS. *YC
Bulletin Number: 980324
CONCERNS OF COLD ENGINE UPPER KNOCK / TICK. *YC
Bulletin Number: 980324
COLD ENGINE UPPER KNOCK/TICK. *AK
Bulletin Number: 98112
SUBJECT REGARDING A NEW SERVICE CENTER SUPPORT THAT USES A THRUST BEARING (#3 AND #4) IN PLACE OF THRUST WASHERS HAS BEEN RELEASED. *TT
Bulletin Number: 98113
SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT
Bulletin Number: 98117
SOME VEHICLE MAY EXHIBIT MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) PO171, PO174, P1131 AND / OR P1151 STORED IN MEMORY. *TT
Bulletin Number: 98118
EXPERIENCING AN AUDIBLE NOISE IN ENGINE.
Bulletin Number: 98124
SUBJECT REGARDING AN OVERHEATING CONDITION OCCURRING TO THE LAMP OUTAGE MODULE (LOM-2) WITH THE INSTALLATION OF CERTAIN AFTERMARKET TRAILER KITS THAT IMPROPERLY CONNECT TO THE TAIL AND BRAKE LAMPS CIRCUITS. *TT
Bulletin Number: 98126
SUBJECT REGARDING LAMP OUTAGE MODULE HOUSING AND SURROUNDING PLASTIC COMPONENTS MELTED - EDDIE BAUER AND LIMITED EDITION MODELS EQUIPPED WITH MESSAGE CENTERS AND IMPROPERLY CONNECTED TOW WIRING KITS (VEHICLES BEING TOWED). *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK
Bulletin Number: 981514
A VEHICLE VIBRATES DURING A HOT OR COLD IDLE CONDITION.
Bulletin Number: 981613
TRANSMISSION FLUID LEAKS AT RADIATOR. YD
Bulletin Number: 981617
FLOOR MAT INSTALLATION PROCEDURE SERVICE TIP. YD
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 98165
EVAPORATOR CORE FAILED, CAUSING THE AIR CONDITIONER TO DRIP ON TO PASSENGER FLOOR. YD
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 982019
CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR. *YC
Bulletin Number: 98211
EXPERIENCING A NOISE AND VIBRATION DURING IDLE.
Bulletin Number: 982122
SOME CUSTOMERS HAVE REPORTED THE THROTTLE STUCK AT IDLE ON SOME VEHICLES. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982312
ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 982320
SOME VEHICLES WITH A VERY LOW ODOMETER READING MAY EXPERIENCE A LACK TEMPERATURE CONTROL. *YC
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98234
AIR INTAKE TUBE CONTACTING HOOD INSULATOR CAUSING INSULATOR WEAR. *YC
Bulletin Number: 98238
CONDENSATE MAY LEAK ONTO THE PASSENGER FLOOR ON SOME VEHICLES. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982511
SERVICE TIPS ON COMPOSITE FUEL RAIL. *YC
Bulletin Number: 982515
CONDITIONS WITH THE FRONT SEAT BACK LEVER BENT. *YC
Bulletin Number: 982540
CONCERNS WITH BUILT-IN REAR CHILD SAFETY SEAT MAY NOT EASILY ACCOMMODATE SOME CHILDREN. *YC
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 983074
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT
Bulletin Number: 983092
REAR CRANKSHAFT SEAL OIL LEAK. *AK
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 983109
INFORMATION REGARDING ENGINES ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *TT
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 98-4732
STEERING WHEEL SHIMMIES, VIBRATION OR GRUNT ON SLOW SPEED TURNS..
Bulletin Number: 98-4817
SOME 1997-1998 EXPLORER/MOUNTAINEER/EXPEDITION OR NAVIGATOR VEHICLES WITH 4-WD 4X4 SYSTEM MAY EXHIBIT BOTH
Bulletin Number: 985045
REVISED MESSAGE REGARDING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS ACTION ON SOHC EQUIPPED VEHICLES, PERFORM TSB 98-21-01. *TT
Bulletin Number: 985064
REPEAT MESSAGE REGARDING ENGINE STALLING *TT
Bulletin Number: 985128
SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. *TT
Bulletin Number: 98514
CONCERNS WITH A WHISTLING OR HISSING NOISE FROM THE MAIN CONTROL AREA OCCURING WHILE IDLING IN DRIVE AND / OR REVERSE ON SOME VEHICLES. *TT
Bulletin Number: 985144
ALL VEHICLES EQUIPPED WITH 4.0L SOHC THAT REQUIRE ENGINE SERVICE PLEASE NOTE THAT THE XL2Z-6M289-AA (DRIVE ASSEMBLY-CAMSHAFT-LH) MUST BE USED ON 4.0L SOHC ENGINES IF REPLACEMENT IS REQUIRED. *TT
Bulletin Number: 985157
INFORMATION ON SETTING THE TIRE INFLATION PRESSURE FOR 1991 THROUGH 1999 MODEL YEAR VEHICLES IN THE PRE-DELIVERY PROCESS AND DURING MAINTENANCE INTERVALS. *TT
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 9889
SOME CUSTOMERS NOTICE A GRINDING, WHINING, PULSING, OR FLUTTERING AT THE BRAKE PEDAL AT SPEEDS BELOW 19 KM/H (12 MPH). *YC
Bulletin Number: 98R03
SAFETY RECALL LETTER INFORMING OWNERS OF MODIFICATION TO THE POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM. *TT
Bulletin Number: 98R03
SUBJECT REGARDING POSITIVE CRANKCASE VENTILATION (PCV) TUBE MODIFICATION. *TT
Bulletin Number: 99104
THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0174, P1131, AND / OR P1151 MAY BE PRESENT WITH OR WITHOUT MISFIRE, ROLLING IDLE, ROUGH IDLE, ETC. *TT
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 9913035
VEHICLES MAY EXPERIENCE A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99142
VEHICLES WITH A4WD TRANSMISSION AND 4.0L ENGINE MAY HAVE THE 4X4 INDICATOR LAMPS FLASHING. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99156
SOME VEHICLES MAY EXHIBIT A BURNING ODOR OR SMOKE, AND / OR RUSTLING NOISE OCCURING WHEN THE BLOWER MOTOR IS RUNNING IF LEAVES OR FOREIGN MATERIAL ENTERS THE BLOWER CASE. *TT
Bulletin Number: 99185
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99203
INFORMATION ON REPLACING THE FRONT BUMPER BRACKET. *TT
Bulletin Number: 99206
CONCERNS WITH BURNING ODOR OR SMOKE, AND / OR RUSTLING NOISE WHILE BLOWER MOTOR IS ON. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99223
A NO START CONDITION WHEN VEHICLE IS PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL MAY OCCUR. *TT
Bulletin Number: 99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
Bulletin Number: 99238
A TEMPERATURE GAUGE FLUCTUATION AND / OR A KNOCKING / THUMPING NOISE MAY BE AUDIBLE INTHE PASSENGER COMPARTMENT ON SOME VEHICLES. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT
Bulletin Number: 995157
INFORMATION ON MAINTAINING TIRE PRESSURE. *TT
Bulletin Number: 996777
EXHIBITING A POWER STEERING FLUID LEAK FROM THE STEERING GEAR BOOT(S). *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: 9987
SOME VEHICLES MAY EXHIBIT HARSH DOWNSHIFT FROM 3RD TO 1ST GEAR WHILE STOPPING; HESITATION AFTER ACCELERATION FROM STOP; AND / OR LACK OF POWER AFTER ACCELERATION FROM STOP. *TT
Bulletin Number: 9987
SOME VEHICLES MAY EXHIBIT HARSH DOWNSHIFT FROM 3RD TO 1ST GEAR WHILE STOPPING, HESITATION AFTER ACCELERATION FROM STOP AND / OR LACK OF POWER AFTER ACCELERATION FROM STOP ON VEHICLES WITH 4.0L OR 5.0L ENGINES. *TT
Bulletin Number: 9988
CONCERNS OR ERRATIC OR INSUFFICIENT TEMPERATURE CONTROL. *TT
Bulletin Number: 9996
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT
Bulletin Number: 99S09
RECALL INFORMATION REGARDING SPEED CONTROL CABLE REPLACEMENT. *TT
Bulletin Number: BC0012970201
CUSTOMERS REPORT INOPERABLE REMOTE ENTRY OR KEYLESS ENTRY FEATURE. THE CAUSE HAS BEEN IDENTIFIED AS A STATIC BUILD-UP ON THE SEAT THAT DAMAGES THE RAP MODULE. *JD
Bulletin Number: BC0012972301
CUSTOMERS REPORT INOPERABLE REMOTE ENTRY OR KEYLESS ENTRY FEATURE. *JD
Bulletin Number: BC0050970201
WHEN SERVICING THE LAMP OUTAGE MODULE (LOM) ON THE ABOVE VEHICLES PLEASE VERIFY IF THE VEHICLE HAS 1) AN AFTERMARKET KIT FOR TRAILER TOWING OR 2) AFTERMARKET KIT ALLOWING THE VEHICLE TO BE TOWED. *JD
Bulletin Number: BC0050972301
WHEN SERVICING THE LAMP OUTAGE MODULE (LOM) ON A VEHICLE PLEASE VERIFY IF THE VEHICLE HAS 1) AN AFTERMARKET KIT FOR TRAILER TOWING OR 2) AFTERMARKET KIT ALLOWING THE VEHICLE TO BE TOWED. *JD
Bulletin Number: BC0069961101
CONCERN OF BINDING/AXLE WIND-UP AT LOW SPEED. *TW
Bulletin Number: BC0133970201
REVISED VENT TUBE FOR 1995-97 EXPLORERS & MOUNTAINEERS WITH WATER INGESTION INTO TRANSFER CASE. *JD
Bulletin Number: BC0184970201
PROCEDURE TO PURGE POTENTIAL WATER CONTAMINATION FROM TRANSFER CASE. *JD
Bulletin Number: BC0190970201
VEHICLES BUILT PRIOR TO 10/1/96 MAY HAVE BEEN BUILT WITH WRONG TEMP GAUGE SYSTEM PARTS. *JD
Bulletin Number: BC0206970201
TRANSFER CASE BIND OR SHUDDER. *JD
Bulletin Number: BC0225970201
BINDING/AXLE WIND-UP AT LOW SPEED. *JD
Bulletin Number: BC0257970201
POWER LOCKS CYCLE BY THEMSELVES REMOVE EACH POWER LOCK SWITCH AND MEASURE THE OPEN RESISTANCE. *JD
Bulletin Number: BC0317970201
DRIVELINE WIND-UP IN "4-AUTO" MODE. *JD
Bulletin Number: BC0317972301
DRIVELINE WIND-UP IN "4-AUTO" MODE. *JD
Bulletin Number: BC0317A97020
DRIVELINE WIND-UP IN 4-AUTO MODE. *TW
Bulletin Number: BC0324961101
COLD ENGINE KNOCK/TICK NOISE. *TW
Bulletin Number: BC0324970201
COLD ENGINE KNOCK/TICK NOISE. *JD
Bulletin Number: BC0342961127
WHEN A REAR HEGO (CMS) CONCERN IS NOTED, PLEASE CHECK THE REAR CMS HEGO FOR WIRE CHAFING/DAMAGE AND LOOSE HEGO WIRE. *TW
Bulletin Number: BC0481961113
VEHICLES MAY EXHIBIT AN EXHAUST MANIFOLD IMPINGEMENT NOISE. *TW
Bulletin Number: BC0533961108
INSTRUCTIONS FOR DIAGNOSING FAULTY ABS SENSORS. *TW
Bulletin Number: BC0534961108
DRIVESHAFT DESIGN MAY CAUSE FLOORPAN VIBRATION WHILE AT HIGHWAY SPEEDS OR WITH THROTTLE WIDE OPEN. *TW
Bulletin Number: BC0744961018
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC0755961017
TENSIONER RATTLE . INSTALL A 1 INCH SHORTER MOTORCRAFT BELT (P/N F19Z-8620-C). *TT
Bulletin Number: BC0881961004
THUMP/CLUNK NOISE IN TURNS OR OVER BUMPS MAY BE CAUSED BY THE KEVLAR PATCH WEARING THROUGH ON THE TORSION BAR ADJUSTERS. *TT
Bulletin Number: BC0882961004
INFORMATION FOR ALL BASE ENGINE CONCERNS OF 4.0L SOHC ENGINES. *TT
Bulletin Number: BC1011297020
4.0L OHV/SOHC 4X4 EXPLORERS WITH TRANSFER CASE BIND OR SHUDDER. *JD
Bulletin Number: BC1012797020
REVISED VENT TUBE FOR VEHICLES WITH WATER INGESTION INTO TRANSFER CASE. *JD
Bulletin Number: BC1015097020
LAMP OUTAGE MODULE (LOM) ON THE VEHICLES- PLEASE VERIFY IF THE VEHICLE HAS: 1) AN AFTERMARKET KIT FOR TRAILER TOWING OR 2) AFTERMARKET KIT ALLOWING THE VEHICLE TO BE TOWED. *JD
Bulletin Number: BC1016497020
INOPERABLE REMOTE ENTRY OR KEYLESS ENTRY FEATURE. THE CAUSE HAS BEEN IDENTIFIED AS A STATIC BUILD-UP ON THE SEAT THAT DAMAGES THE RAP MODULE. *JD
Bulletin Number: BC1018997230
BLOCK HEATERS MAY EXPERIENCE COOLANT LEAKS DUE TO INTERFERENCE WITH THE BLOCK. *JD
Bulletin Number: BC1019197230
EXHIBITING A PULSATING, CYCLICAL TYPE OF NOISE COMING FROM THE FRONT AXLE TUBE AREA FROM 0 TO 45 MPH. *JD
Bulletin Number: BC1019297230
VEHICLES MAY EXPERIENCE A HIGH PITCHED WHISTLE DURING HEAVY ACCELERATION AT 3800-5000 RPM WHEN ENGINE IS WARM. *JD
Bulletin Number: BC1019497230
VEHICLES MAY EXHIBIT REVERSE OPERATING CHARACTERISTICS WHEN SWITCHING THE AIR SUSPENSION SWITCH FROM NORMAL TO OFF ROAD. *JD
Bulletin Number: BC1019597230
EXHAUST NOISE HEARD IN THE PASSENGER COMPARTMENT MOST PRESENT A TIP-IN A ND CRUISE AFTER SSM 5238 HAS BEEN PERFORMED. *JD
Bulletin Number: BC1019797230
THE VEHICLES WILL SHIFT 1,2,3,4,5 REGARDLESS OF THROTTLE POSITION. *JD
Bulletin Number: BC1019897230
PERFORMING TSB 96-24-16, THE EXISTING TRANSFER CASE VIBRATION DAMPER SHOULD NOT BE ADAPTED AND REINSTALLED TO THE SERVICE REPLACEMENT TRANSFER CASE.
Bulletin Number: BC1019997230
4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPNIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSES WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD
Bulletin Number: BC1022797230
THE NGS DISPLAYS INCORRECT DATA FOR THE IGN GEM PID ON THE VEHICLES. *JD
Bulletin Number: BC1024097230
INCREASED THROTTLE EFFORTS MAY BE NOTED ON SOME 4.0L SOHC EQUIPPED VEHICLES DUE TO THROTTLE PLATE ALIGNMENT. *JD
Bulletin Number: BC1025297230
FRONT AXLE VENT LEAKS ON 1997 EXSPLORERS BUILT BEFORE 11/1/06. *JD
Bulletin Number: BC1028397020
THE 1997 EXPLORER 4.0L SOHC IS THE ONLY VEHICLE EQUIPPED WITH A NEW STYLE (BLACK PLASTIC) DPFE SENSOR. *JD
Bulletin Number: BC1030297020
ENGINE MAY EXHIBIT A HISS/WHISTLE AT TIP-IN FROM THE THROTTLE BODY/IAC AREA OF THE ENGINE. *JD
Bulletin Number: BC1031297020
SOME VEHICLE ENGINE COMPARTMENT DECALS MAY INCORRECTLY LIST 10W30 FOR OIL VISCOSITY. *JD
Bulletin Number: BC1033197020
VEHICLES WITH REAR CRANKSHAFT SEAL OIL LEAKS. *JD
Bulletin Number: BC1035497020
4.0L SOHC ENGINE COMES FROM THE FACTORY WITH SINGLE PLATINUM PLUGS. *JD
Bulletin Number: BC1035597020
RADIATORS MAY EXHIBIT A COOLANT LEAK AT THE END TANK SEALS IN COLD TEMPERATURES. *JD
Bulletin Number: BC105609705
VEHICLES MAY EXHIBIT SHUDDER/BIND IN TURNS WHILE IN 4X4 AUTO MODE. *TW
Bulletin Number: BC105789705
VEHICLES WITH DTC P0402 IN MEMORY ARE UNDER INVESTIGATION BY ENGINEERING DEPARTMENT. *TW
Bulletin Number: BC105829705
SOME RUNNING BOARD PADS MAY BE WARPED. *TW
Bulletin Number: BC105979705
UPDATE INFORMATION FOR 1997 4R44E AND 5R55E TRANSMISSIONS - THERE ARE TWO (2) DIFFERENT SIZE DIRECT CLUTCH STEEL PLATES WHEN SERVICING 4R44E OR 5R55E TRANSMISSIONS. *TW
Bulletin Number: BC106049705
VEHICLES BUILT AFTER 4/14/97 NO LONGER HAVE A REAR WASHER BOTTLE - REDESIGNED FRONT WASHER BOTTLE WILL SERVICE THE FRONT AND REAR WASHERS. *TW
Bulletin Number: BC2236970501
VEHICLES MAY EXHIBIT A CENTER CONSOLE SQUEAK OR RATTLE. *TW
Bulletin Number: BC2237970501
RECALL 97S67 - MODIFICATION OF THE PCV VALVE REQUIRES A SPECIAL TOOL WHICL WILL SENT TO LISTED PARTS MANAGERS. *TW
Bulletin Number: BC2246970501
VEHICLES BUILT ON OR AFTER 4/14/97 WILL NO LONGER HAVE A REAR WASHER BOTTLE - A REDESIGNED FRONT WASHER BOTTLE WILL SUPPLY THE FLUID TO BOTH WASHERS. *TW
Bulletin Number: BC2301970501
NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW
Bulletin Number: BC2302970501
DTC P0402 IN MEMORY UNDER INVESTIGATION BY ENGINEERING. *TW
Bulletin Number: BC2306970501
SOME RUNNING BOARD PADS MAY WARPED. *TW
Bulletin Number: BC2313970501
MAY 1997 GEM SOFTWARE HAS ERRORS - JUNE SOFTWARE IS CORRECT. *TW
Bulletin Number: BC2383970501
SERVICE FIX FOR VEHICLES WHICH EXHIBIT SHUDDER/BIND IN TURNS WHILE IN 4X4 MODE.
Bulletin Number: BC2384970501
LIFTGATE LOCK CONCERNS ON VEHICLES BUILT THROUGH 12/96. *TW
Bulletin Number: BC2440970501
1997 4.0L SOHC 4X4 EXPLORERS AND 1997 5.0L AWD EXPLORERS/MOUNTAINEERS SHOULD NOT BE EQUIPPED WITH A VIBRATION DAMPER ON THE TRANSFER CASE. *TW
Bulletin Number: BC2442970501
LIFTGATE LOCKS WILL NOT LOCK/UNLOCK WHEN ACTUATED BY THE POWER SWITCHES. *TW
Bulletin Number: BC3092970225
REAR CRANKSHAFT SEAL OIL LEAKS. *TW
Bulletin Number: BC3092970501
ENGINEERING IS INVESTIGATING REAR CRANKSHAFT OIL LEAKS. *TW
Bulletin Number: BC3132970221
INCORRECT OIL VISCOSITY LABEL IN ENGINE COMPARTMENT. *TW
Bulletin Number: BC3134970221
OEM SPARK PLUGS MAY EXHIBIT A CONCERN OF AN OPEN CIRCUIT CAUSED BY AN INTERNAL CRACK. *TW
Bulletin Number: BC3155970219
4.0L SHOC ENGINE QUITS WHILE DRIVING AND WILL NOT RESTART. *TW
Bulletin Number: BC3156970219
EXPLORERS EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A HISS/WHISTLE AT TIP IN. *TW
Bulletin Number: BC3274970207
REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS A
Bulletin Number: BC3282970206
GEM CONCERN - CHECK FOR MORE THAN ONE GEM CONTROLLED COMPONENT THAT IS INOPERATIVE OR FOR A STRING OF FALSE GEM DTC'S RECEIVED IN MEMORY. *TW
Bulletin Number: BC3283970206
DOOR LATCH SWITCH IS CAUSING THE DOOR AJAR LIGHT/CHIME NOT TO WORK PROPERLY. *TW
Bulletin Number: BC3363972301
THE NGS DISPLAYS INCORRECT DATE FOR THE ING GEM PID ON THE VEHICLES. *JD
Bulletin Number: BC3441972301
AS OF 1/7/97 THE AUTOMATIC SHIFT LOCK FEATURE TAG THAT WAS AFFIXED AROUND THE GEAR SELECTOR, HAS BEEN DISCONTINUED FOR PRODUTION. *JD
Bulletin Number: BC3481972301
EXHAUST NOISE HEARD IN THE PASSENGER COMPARTMENT MOST PRESENT AT TIP-IN A ND CRUISE AFTER SSM 5238 HAS BEEN PERFORMED. *JD
Bulletin Number: BC3483972301
THE VEHICLE WILL SHIFT 1,2,3,4,5 REGARDLESS OF THROTTLE POSTION. *JD
Bulletin Number: BC3484972301
WHEN PERFORMING TSB 96-24-16, THE EXISTING TRANSFER CASE VIBRATION DAMPER SHOULD NOT BE ADAPTED AND REINSTALLED TO THE SERVICE REPLACEMENT TRANSFER CASE. *JD
Bulletin Number: BC3485972301
4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPANIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSE WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD
Bulletin Number: BC3491972301
SOME 4.0L ENGINES WITH BLOCK HEATERS MAY EXPERIENCE COOLANT LEAKS DUE TO INTERFERENCE WITH THE BLOCK. *JD
Bulletin Number: BC3493972301
VEHICLES EXHIBITING A PULSATING, CYCLICAL TYPE OF NOISE COMING FROM THE FRONT AXLE TUBE AREA FROM 0 TO 45 MPH. *JD
Bulletin Number: BC3494972301
VARIOUS VEHICLES MAY EXPERIENCE A HIGH PITCHED WHISTLE DURING HEAVY ACCELERATION AT 3800-5000 RPM WHEN ENGINE IS WARM- TO FIX, REMOVE EXISTING MUFFLER AND REPLACE WITH SAME PART. *JD
Bulletin Number: BC5180961001
OWNERS GUIDE ADVISES TO USE A FL-1A OIL FILTER, FL-1A IS INCORRECT. THE CORRECT FILTER IS FL-820. *TT
Bulletin Number: BC5188961001
CONCERN OF A TENSIONER RATTLE W/ 4.0L SOHC, INSTALL A 1 INCH SHORTER MOTORCRAFT BELT (P/N F19Z-8620-C). *TT
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC5225961001
VEHICLES MAY EXPERIENCE A VIBRATION DURING WIDE OPEN THROTTLE ACCELERATION OR WHILE CRUISING AT HIGHWAY SPEEDS. REVISED FRONT DRIVESHAFT. *TT
Bulletin Number: BC5231961101
VEHICLE LEAN. *TW
Bulletin Number: BC5238961101
VEHICLE MAY EXHIBIT AN EXHAUST MANIFOLD IMPINGEMENT NOISE. *TW
Bulletin Number: RCDNN-00V402-817
This recall action involves replacement of the front stabilizer bar links in certain 1995 through 1997 model year Explorer and Mountaineer vehicles. Under certain conditions, predominantly in cold weather areas, a front stabilizer bar
1997 FORD EXPLORER SPORT
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 0186
ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT
Bulletin Number: 0232
SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301. *TT
Bulletin Number: 04217
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT
Bulletin Number: 15006
SOME VEHICLES WITH 4.0L SOHC ENGINES MAY MAKE A START-UP NOISE FROM THE LEFT FRONT OF THE ENGINE. *TT
Bulletin Number: 15040
SOME VEHICLES INCLUDING 1997 THROUGH 1999 EXPLORER SPORT TRAC EQUIPPED WITH A 4.0L SOHC ENGINE MAY EXHIBIT A START-UP NOISE FROM THE LEFT FRONT OF THE ENGINE. *TT
Bulletin Number: 15910
CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION. *TT
1997 FORD EXPLORER SPORT TRAC
Bulletin Number: 0186
ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT
Bulletin Number: 15040
SOME VEHICLES INCLUDING 1997 THROUGH 1999 EXPLORER SPORT TRAC EQUIPPED WITH A 4.0L SOHC ENGINE MAY EXHIBIT A START-UP NOISE FROM THE LEFT FRONT OF THE ENGINE. *TT
Bulletin Number: 15910
CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION. *TT
1997 FORD F-150
Bulletin Number: 0014
VEHICLES MAY EXPERIENCE INNER FENDER WELL- DENTED OR DINGED FROM STONES BEING THROWN INTO WHEELWELL. *MJS
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 0017
SUBJECT ON THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODES MAY APPEAR. *MJS
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 00238
SOME VEHICLES MAY EXHIBIT A NO CRANK / NO START CONDITION IN TEMPERATURES BELOW 12 DEGREES C (10 DEGREES F). *TT
Bulletin Number: 00239
A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. *TT
Bulletin Number: 00261
SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES. *TT
Bulletin Number: 0038
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS
Bulletin Number: 00611
SOME BI-FUEL VEHICLES MAY REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT DURING SERVICE AND MAY NOT RUN ON CNG OR LPG., RECALIBRATION OF THE PCM/REPLACEMENT. *MJS
Bulletin Number: 01111
SOME VEHICLES MAY EXHIBIT A WATER LEAK AROUND THE REAR (SLIDING) WINDOW. *TT
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01166
SOME VEHICLES MAY EXHIBIT WATER IN THE TRANSFER CASE, THIS COULD CAUSE LOW RANGE 4X4 LAMP TO ILLUMINATE, SHORT OF TRANSFER CASE SWITCH, OR WINDSHIELD WIPERS TO BE ERRATIC OR INOPERATIVE. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01182
SOME VEHICLES MAY EXPERIENCE A COSMETIC CRACK IN THE OUTER DOOR PANEL AT THE LOWER REAR CORNER OF WINDOW OPENING.*JB
Bulletin Number: 01192
SOME VEHICLES MAY EXHIBIT A GRABBING CONDITION FROM THE REAR DRUM BRAKES DURING THE FIRST FEW BRAKE APPLICATIONS AFTER EXTENDED HUMIDITY EXPOSURE. *TT
Bulletin Number: 01201
SOME VEHICLES MAY EXHIBIT HIGH IDLE AND/OR PCV SYSTEM ICING AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES ON VEHICLES EQUIPPED WITH 4.2L ENGINE BUILT THORUGH 1/24/2000. *TT
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 01215
A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTER OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT
Bulletin Number: 01218
SOME VEHICLES MAY EXHIBIT A NO CRANK, NO START CONDITION DUE TO CORROSION OF THE STARTER CABLE B+ TERMINAL AT THE STARTER SOLENOID. *TT
Bulletin Number: 01221
SOME DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT A ROUGH IDLE, OR NO START IN COLD CONDITIONS. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 0193
A CONDITION MAY EXIST WHERE A DRIVELINE VIBRATION AND / OR A TRANSMISSION FLUID LEAK FROM THE EXTENSION HOUSING SEAL AREA MAY OCCUR ON SOME VEHICLES. THIS MAY BE CAUSED BY THE EXTENSION HOUSING BUSHING OR SEAL WALKING / SPINNING OUT DUE T
Bulletin Number: 02105
SOME BI-FUEL CANG AND LPG VEHICLES MAY EXHIBIT A NO START CONDITION. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02193
DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ
Bulletin Number: 02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
Bulletin Number: 030402
ON SOME DEDICATED CNG VEHICLES, A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE. REVISED SERVICE PARTS. *TT
Bulletin Number: 03102
COMPRESSED NATURAL GAS (CNG). ROUGH IDLE OR NO START WHEN COLD. VEHICLES EQUIPPED WITH CNG BI-FUEL ENGINE ONLY. *TT
Bulletin Number: 03103
VEHICLES WITHOUT THE COOLANT LOCK-OFF MAY EXHIBIT A NO START CONDITION. *TT
Bulletin Number: 031404
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
Bulletin Number: 03144
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 031513
TIE ROD END INSPECTION PROCEDURE. *TT
Bulletin Number: 03183
DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY. *TT
Bulletin Number: 03206
SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY. LOSS OF POWER AT HEAVY LOAD, DIAGNOSTIC TROUBLE CODES (DTCS) FOR LEAN FUEL, ROUGH IDLE, HARD START,
Bulletin Number: 032125
AFTERMARKET WIRING ALTERATIONS - SERVICE TIP. *TT
Bulletin Number: 0324
DRIVER'S SIDE DOOR GLASS THAT BINDS WHEN OPERATED. *TT
Bulletin Number: 0342
POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE, ON SOME DEDICATED CNG VEHICLES. *TT *JB
Bulletin Number: 03610
TIE ROD END INSPECTION PROCEDURE. CANADA VEHICLES ONLY. *TT *JB
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 0399
TIE ROD END INSPECTION PROCEDURE. *TT
Bulletin Number: 041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04217
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04266
A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP. *TT
Bulletin Number: 0457
POP/THUMP NOISE AT END OF WINDOW MOVEMENT AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION. *TT
Bulletin Number: 04L19
CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE. *TT
Bulletin Number: 050618
REAR AXLE NOISE REPAIR. *SC
Bulletin Number: 05417
INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT
Bulletin Number: 0554
USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE. *TT
Bulletin Number: 05618
REAR AXLE NOISE REPAIR. *TT
Bulletin Number: 07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
Bulletin Number: 090308
MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455
Bulletin Number: 11794
EXPERIENCING A RUBBING OR SQUEAK NOISE AS THE STEERING WHEEL IS TURNED. *TT
Bulletin Number: 11799
SOME SUPERCAB VEHICLES MAY EXHIBIT A MOAN / DROAN IN THE CAB AT 1500 - 1600 RPM OR A CAB VIBRATION AT 1800 - 1900 RPM. *TT
Bulletin Number: 11811
SOME VEHICLES BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT
Bulletin Number: 11814
SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT
Bulletin Number: 12071
SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *MJS
Bulletin Number: 12139
SOME VEHICLES EQUIPPED WITH 4.6L OR 6.8L ENGINES MAY EXHIBIT A COLD START ENGINE NOISE UNTIL WARMED UP. *MJS
Bulletin Number: 12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
Bulletin Number: 12161
SOME VEHICLES BUILT WITH 3-LEAF REAR SPRINGS MAY EXHIBIT A REAR SPRING RATTLE. *MJS
Bulletin Number: 12208
SOME TEXAS DEPARTMENT OF TRANSPORTATION (DOT) TRUCKS MAY ENCOUNTER A RADIO FREQUENCY INTERFERENCE (RFI) CONDITION WHEN USING HAND HELD TWO-WAY RADIOS IN THE RANGE OF 47.18 MHZ. *TT
Bulletin Number: 12590
SOME 4X4 VEHICLES MAY EXHIBIT A MOAN NOISE FROM THE FRONT DIFFERENTIAL WHEN THE VEHICLE IS OPERATING IN 4X2 MODE AND GOES AWAY WHEN OPERATING IN 4X4 MODE. *TT
Bulletin Number: 12601
EXPERIENCING WHISTLING NOISE COMING FROM THE FRONT OF THE VEHICLE AT HIGHWAY SPEEDS. *TT
Bulletin Number: 12720
SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE FLEXIBLE RUBBER COOLANT HOSE. *TT
Bulletin Number: 12725
SOME VEHICLES MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT
Bulletin Number: 12738
SOME VEHICLES MAY EXHIBIT A IDLE VIBRATION.
Bulletin Number: 12879
SUBJECT REGARDING REAR SPRING CLIP KITS FOR VEHICLES EXHIBITING A REAR SPRING RATTLE. *TT
Bulletin Number: 12882
SUBJECT REGARDING THE AVAILABILITY OF REAR SPRING CLIP KITS FOR VEHICLES EXHIBITING REAR SPRING RATTLE. *TT
Bulletin Number: 12905
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT
Bulletin Number: 13054
EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT
Bulletin Number: 13106
ON SOME VEHICLES THE FRONT BUMPERS MAY EXHIBIT RED STAINING (SPOTS) ON THE BUMER WING ENDS. *TT
Bulletin Number: 13186
INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS
Bulletin Number: 13203
INFORMATION REGARDING OUTWARD DENTS IN PICKUP BOX WHEEL WELLS. *MJS
Bulletin Number: 13219
INFORMATION REGARDING STEERING GEAR LEAKS FROM INPUT SHAFT SEALS. *MJS
Bulletin Number: 13238
INFORMATION REGARDING VEHICLES THAT EXHIBIT CRACKS IN THE DOOR SHEET METAL. *MJS
Bulletin Number: 13412
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT
Bulletin Number: 13479
SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT
Bulletin Number: 13505
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
Bulletin Number: 13550
SOME VEHICLES MAY EXHIBIT DENTS ON THE WHEEL WELL SHEET METAL OF THE PCIK-UP BOX AREA WHEN USED IN OFF-ROAD APPLICATIONS. *TT
Bulletin Number: 13745
SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS
Bulletin Number: 13838
CONCERNS WITH VEHICLES EXHIBITING A WINDSHIELD CREAK / SQUEAK. *TT
Bulletin Number: 14365
THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT. *JB
Bulletin Number: 14609
SUBJECT REGARDING HIGH IDLE AND/OR CHECK ENGINE LIGHT CONDITION. *JB
Bulletin Number: 15113
SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION. *YD
Bulletin Number: 15145
SOME VEHICLES EQUIPPED WITH REMOTE LOCKING TAILGATES MAY EXHIBIT A TAILGATE LOCKING ITSELF WHEN THE VEHICLE IS BEING DRIVEN OVER ROUGH ROADS OR IS SLAMMED SHUT. *ET
Bulletin Number: 15260
CONCERNS WITH CORRODED POSITIVE STARTER CABLE. *TT
Bulletin Number: 15271
DEDICATED CNG REGULATOR BOWL KIT AVAILABLE. *JG
Bulletin Number: 15299
SOME VEHICLES MAY EXHIBIT CORROSION AT THE ATTACHMENT POINT OF THE STARTER CABLE B+ TERMINAL, AT THE STARTER SOLENOID. *TT
Bulletin Number: 15570
SOME VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS INCLUDING LACKS POWER, HESITATES, HARD TO START, AND/OR MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND PRODUCE POSSIBLE DIAGNOSTIC TROUBLE CODES P0103, P0172 AND P0175. *TT
Bulletin Number: 15692
SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT
Bulletin Number: 15758
SNOW PACKING OF THE AIR FILTER WHEN DRIVING IN SEVERE SNOW CONDITIONS MAY EXHIBIT LOSS OF POWER AND / OR THE MALFUNCTION INDICATOR LAMP ILLUMINATING. *TT
Bulletin Number: 16416
NO/HARD START IN COLD AMBIENTS / NEW TWO-PIECE BLOCK HEATER CORD RELEASED. *MJ
Bulletin Number: 16602
LOCKING TAILGATE LOCKS ITSELF. *TT
Bulletin Number: 16605
REDUCED POWER STEERING ASSIST AND/OR POWER STEERING LEAKS WHEN DRIVEN IN TEMPERATURES EQUAL TO OR LESS THAN -25 DEGREES CELCIUS. *TT
Bulletin Number: 16835
TAILGATE LOCKING BY ITSELF WHEN SLAMMED SHUT OR WHEN THE VEHICLE IS BEING DRIVEN OVER ROUGH ROADS. *TT
Bulletin Number: 16928
VARIOUS INTERMITTENT ELECTRICAL CONCERNS INCLUDING BUT NOT LIMITED TO SOME ACCESSORIES REMAINING POWERED UP WITH THE KEY OUT OF THE IGNITION, MULTIPLE SYSTEM WARNING LIGHTS WITH SHORT TO POWER OR LOW BATTERY VOLTAGE DIAGNOSTIC TROUBLE CODES
Bulletin Number: 16969
DAMAGED REAR LICENSE PLATE LAMPS DUE TO ROCKS AND/OR GRAVEL HITTING THE LAMP ASSEMBLIES. *TT
Bulletin Number: 17320
BROKEN EXHAUST MANIFOLD STUDS. *TT
Bulletin Number: 17448
REMOTE OIL FILTER ADAPTOR REPLACEMENT - NEW SERVICE PART. *TT
Bulletin Number: 17731
WHINE FROM POWER STEERING. *TT
Bulletin Number: 17777
REAR LEAF SPRING NOISE. *TT
Bulletin Number: 17823
POWER STEERING LEAK - SERVICE TIP. *TT
Bulletin Number: 18466
AXLE WHINE HOWL. THIS INCLUDES 1997-05 FORD VEHICLES. *EH
Bulletin Number: 4619
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT
Bulletin Number: 4628
SOME VEHICLES MAY EXHIBIT REAR AXLE NOISE. *TT
Bulletin Number: 4631
BRIEF INFORMATION ON VEHICLES EXHIBIT VIBRATION AT CRUISE OVER 50 MPH. *TT
Bulletin Number: 4635
COLD ENGINE KNOCK. *TT
Bulletin Number: 4638
MALFUNCTION INDICATOR LAMP ON, WITH P0300 - P0308 MISFIRE DIAGNOSTIC TROUBLE CODES WITH A 4.6L ENGINE. *TT
Bulletin Number: 4682
SOME SUPER CAB VEHICLES MAY EXHIBIT A MOAN / DROAN IN THE CAB AT 1500 - 1600 RPM OR A CAB VIBRATION AT 1800 - 1900 RPM. *TT
Bulletin Number: 4683
SOME VEHICLES MAY EXHIBIT A RUBBING OR SQUEAK NOISE AS THE STEERING WHEEL IS TURNED. *TT
Bulletin Number: 4703
SOME TRUCKS BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND TRUCKS BUILT WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT
Bulletin Number: 4981
SOME VEHICLES EQUIPPED WITH 5.4L ENGINES MAY EXHIBIT A COLD START ENGINE KNOCK CONCERN UNTIL WARMED UP. *TT
Bulletin Number: 5128
SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. ENGINEERING IS INVESTIGATING. *TT
Bulletin Number: 5257
INFORMATION ON VEHICLES EXHIBITING COLD ENGINE KNOCK. *TT
Bulletin Number: 5258
INFORMATION ON VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. *TT
Bulletin Number: 5262
INFORMATION ON DIAGNOSTICING ERRATIC WINDSHIELD WIPER OPERATION. *TT
Bulletin Number: 5267
SUBJECT REGARDING MISFIRE CODES ON ALL ENGINES. *TT
Bulletin Number: 5955
SUBJECT REGARDING FRONT DIFFERENTIAL NOISE INVESTIGATION. *TT
Bulletin Number: 6232
SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE COIL RESULTING IN ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE P0304 AND / OR ROUGH IDLE. *TT
Bulletin Number: 6242
EXPERIENCING A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE. *TT
Bulletin Number: 6287
SOME VEHICLES MAY EXPERIENCE AN IDLE VIBRATION. *TT
Bulletin Number: 6477
SUBJECT REGARDING REAR SPRING RATTLE. *TT
Bulletin Number: 6489
SOME VEHICLES BUILT WITH 3-LEAF OR 4-LEAF REAR SPRINGS MAY EXHIBIT A REAR SPRING RATTLE. *TT
Bulletin Number: 6996
INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT
Bulletin Number: 7022
INFORMATION REGARDING OUTWARD DENTS IN PICKUP BOX WHEEL WELLS. *MJS
Bulletin Number: 7080
INFORMATION REGARDING STEERING GEAR LEAKS FROM INPUT SHAFT SEALS. *MJS
Bulletin Number: 7100
INFORMATION REGARDING TRANSMISSION TROUBLE CODES. *MJS
Bulletin Number: 7353
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT
Bulletin Number: 7821
CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING.
Bulletin Number: 870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
Bulletin Number: 96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
Bulletin Number: 962210
WINDSHIELD WASHERS - WASHER HOSE TOO SHORT AND/OR IS TRAPPED BY THE HOOD - VEHICLES BUILT THROUGH 4/15/96. *TW
Bulletin Number: 96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
Bulletin Number: 96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
Bulletin Number: 96226
AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW
Bulletin Number: 962410
TRANSMISSION - E40D - 4R70W - 4R44E - 5R55E - NEW DIGITAL TRANSMISSION RANGE SENSOR - DIAGNOSIS SERVICE TIP. *TW
Bulletin Number: 962418
TRANSMISSION - E40D - REVISED DESIGN FORWARD PLANET THRUST WASHER - SERVICE TIP. *TW
Bulletin Number: 96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
Bulletin Number: 96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
Bulletin Number: 962510
MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307 AND/OR P0308 STORED IN MEMORY. *TW
Bulletin Number: 962511
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 962518
DOOR - POWER POINT ACCESS DOOR BREAKS - VEHICLES BUILT THROUGH 8/31/96. *TW
Bulletin Number: 96252
LOCKS - REPLACE AND/OR REPAIR ANY LOCK COMPONENT - SERVICE TIP. *TW
Bulletin Number: 962523
RUNS ROUGH - MALFUNCTION INDICATOR LAMP (MIL) ON - DIAGNOSTIC TROUBLE CODES (DTCS) P0300 THROUGH P0308 STORED IN MEMORY - VEHICLES BUILT THROUGH 10/14/96 WITH 4.6L ENGINE. *TW
Bulletin Number: 962525
NOISE - RATTLE - SUMMARY OF CONCERNS - SERVICE TIPS. *TW
Bulletin Number: 962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 96265
MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, AND/OR P0308 STORED IN MEMORY. *TW
Bulletin Number: 97090297183
EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC
Bulletin Number: 97090297187
SOME VEHICLES MAY STALL WHEN THE TRANSMISSION IS PLACED INTO GEAR. *YC
Bulletin Number: 971110972313
A NEW DESIGN TRANSMISSION CASE AND EXTENSION HOUSING HAS BEEN RELEASED. *YC
Bulletin Number: 9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD
Bulletin Number: 97410
TRANSMISSION- E4OD- COOLER BYPASS VALVE SERVICE DURING TRANSMISSION OVERHAUL- SERVICE TIP. *JD
Bulletin Number: 9747
FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD
Bulletin Number: 9751
INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD
Bulletin Number: 97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
Bulletin Number: 976007
BRIEF INFORMATION REGARDING CYLINDER HEAD TEMPERATURE (CHT) AND FAIL SAFE COOLING. *TT
Bulletin Number: 976011
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
Bulletin Number: 9779
WIRING- AFTERMARKET WIRING ALTERATIONS- SERVICE TIP. *JD
Bulletin Number: 980310
EXPERIENCING VIBRATION AT CRUISE OVER 50 MPH. *YC
Bulletin Number: 980317
SYMPTOMS REGARDING P0300-P0308 MISFIRE DTCS WITH 4.6L ENGINES. *YC
Bulletin Number: 9810569
CONCERNS OF SQUEAKY / NOISY PITMAN ARM. *YC
Bulletin Number: 98113
SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT
Bulletin Number: 9811342
INFORMATION ON REMOVING THE RADIO CHASSIS FROM SOME VEHICLES. *TT
Bulletin Number: 9811344
SOME VEHICLES MAY EXHIBIT LOOSE LUGNUTS AND / OR BROKEN WHEEL STUDS. *TT
Bulletin Number: 98123
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK
Bulletin Number: 981517
INSTALL A REVISED CHILD SEAT TETHER KIT.
Bulletin Number: 981610
THE SEAT BACK MAY NOT LATCH/ LOCK IN THE DESIRED POSITION AND REMAIN FOLDED FORWARD OVER THE SEAT CUSHION. YD
Bulletin Number: 981612
FUEL MAY LEAK FROM THE SPRING LOCK COUPLINGS. YD
Bulletin Number: 981613
TRANSMISSION FLUID LEAKS AT RADIATOR. YD
Bulletin Number: 981617
FLOOR MAT INSTALLATION PROCEDURE SERVICE TIP. YD
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 98168
TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD
Bulletin Number: 98168
INSTALLATION OF VINYL FLOOR MATS SERVICE TIP. AK
Bulletin Number: 98169
STEERING -ALIGNMENT-TOE SET PROCEDURE SERVICE TIP. YD
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 982110
DURING HIGH IDLE SPEEDS THROTTLE STICKS AFTER STEADY STATE DRIVING IN COLD AMBIENT TEMPERATURES. *YC
Bulletin Number: 982117
A NEW PARKING BRAKE CONTROL RUBBER BUMPER STOP IS NOW AVAILABLE FOR SERVICE. *YC
Bulletin Number: 98231
CONDITION WITH WATER INTRUSION INTO THE GENERIC ELECTRONIC MODULE ( GEM ) MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 982312
ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 982325
THE MALFUCNTION INDICATOR LAMP ( MIL ) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0455 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982512
SOME VEHICLES WITH HIGHER ODOMETER READINGS MAY EXPERIENCE A HESITATION ON ACCELERATION JUST OFF IDLE AND MISFIRE COMPLAINTS WITH MALFUNCTION INDICATOR LALMP ( MIL ) ON. *YC
Bulletin Number: 982548
BRIEF INFORMATION GIVING THE CORRECT PART NUMBER FOR TSB 98-3-12. *YC
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 982673
IF YOU ENCOUNTER A VEHICLE WITH A MISSING WHEEL HUB O-RING, DO NOT INSTALL A NEW O-RING. *YC
Bulletin Number: 983070
SOMVE VEHICLES MAY EXHIBIT A BUZZ / LOW GROWL NOISE COMING FROM THE AREA OF THE TRANSFER CASE MANUAL SHIFT LEVER. *TT
Bulletin Number: 983074
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 983301
THIS BULLETIN PROVIDES PROCEDURES ON NEUTRALIZING THE EXHAUST, TRANSMISSION AND ENGINE MOUNTS. *TT
Bulletin Number: 983302
THIS BULLETIN MENTIONS HOW SOME HUB O-RINGS MAY BE CUT DURING THE INSTALLATION OF THE WHEELS. *TT
Bulletin Number: 983306
CONCERNS OF FRAME STRIKE ON THE REAR AXLE. *TT
Bulletin Number: 983570
SOME ENGINES MAY EXHIBIT OIL LEAKAGE. *TT
Bulletin Number: 983573
SOME VEHICLES MAY EXHIBIT CAB VIBRATION. *TT
Bulletin Number: 98417
COLD AIR MAY BE FELT ON THE FLOOR WHILE IN HEAT MODE ON SOME VEHICLES. *YC
Bulletin Number: 98419
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 98-4717
VEHICLES EXHIBIT CRACKS IN DOOR SHEET METAL AT LOWER REAR OF THE WINDOW OPENING NEAR BELT MOLDING. *AK
Bulletin Number: 98-4725
VIBRATION AT CRUISE OVER 50 MPH. *AK
Bulletin Number: 98-4738
COLD ENGINE KNOCK 5.4L ACTION. *AK
Bulletin Number: 985028
INFORMATION REGARDING A NEW SERVICE PART RELEASED FOR THE LICENSE PLATE LIGHT CIRCUIT WHICH WILL REDUCE THE COSE OF REPAIRS. *TT
Bulletin Number: 985029
SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT
Bulletin Number: 985059
EXPERIENCING COLD ENGINE KNOCK (REPEAT / REVISED MESSAGE). *TT
Bulletin Number: 985062
SUBJECT REGARDING IDLE VIBRATION (REPEAT MESSAGE). *TT
Bulletin Number: 985063
SUBJECT REGARDING VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. (REPEAT MESSAGE). *TT
Bulletin Number: 985128
SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. *TT
Bulletin Number: 985185
COLD START ENGINE NOISE
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 985200
VEHICLES BUILT WITH 3-LEAF REAR SPRINGS MAY EXHIBIT A REAR SPRING RATTLE *MJS
Bulletin Number: 9858
THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0503 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
Bulletin Number: 985A12
RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES. *TT
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 985A51
ON SOME VEHICLES REPEAT REPAIRS MAY BE MADE TO 4-WHEEL ANTI-LOCK BRAKING SYSTEMS (4WABS) DUE TO MISDIAGNOSIS OF 4WABS CONCERNS WHICH MAY RESULT IN REPLACEMENT OF FUNCTIONAL COMPONENTS. *TT
Bulletin Number: 98611
CONCERNS WITH REDUCED POWER, STALLING, HESITATION, AND SURGE. *YC
Bulletin Number: 98613
SUBJECT REGARDING COLD AIR FELT ON THE FLOOR WHILE IN HEAT MODE. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9869
CONCERNS WITH HESITATION, STUMBLE, SURGE, MISS, ROUGH IDLE, STALL AT IDLE. *TT
Bulletin Number: 98812
A VIBRATION AT HIGHWAY SPEEDS MAY BE FELT ON SOME VEHICLES. *YC
Bulletin Number: 98B33
OWNER NOTIFICATION FOR REPLACEMENT OF ENGINE CYLINDER HEADS. *TT
Bulletin Number: 98S14
SAFETY RECALL UPDATE TO REPLACE LOCKING LUG NUTS. *TT
Bulletin Number: 99107
CONDITIONS ON REAR DRUM GRABBING DURING FIRST FEW BRAKE APPLICATIONS WHILE BRAKES ARE COLD. *TT
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99128
SOME VEHICLES MAY EXHIBIT A WHISTLING NOISE WHILE DRIVING WITH A/C IN THE OFF POSITION AT SPEEDS ABOVE 64 KM/H (40 MPH). *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 99131
CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: 9913125
SONE POLICE VEHICLES AND OTHER VEHICLES WITH 4R70W MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT
Bulletin Number: 991313
SUBJECT REGARDING ANTI-LOCK BRAKE LAMP ILLUMINATION, INCREASED BREAK PEDAL EFFORT AND / OR FALSE ANTI-LOCK BRAKE SYSTEM (ABS) CYCLING AT LOW SPEEDS. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99143
SOME 4X4 VEHICLES BUILT WITH CENTER DISCONNECT FRONT AXLES MAY EXHIBIT A MOANING NOISE FROM THE FRONT DIFFERENTIAL WHILE OPERATING IN 4X2 MODE. *TT
Bulletin Number: 99144
VEHICLES MAY EXPERIENCE A MOANING NOISE HEARD AT APPROXIMATELY 1100 RPM WITH THE A/C COMPRESSOR ENGAGED. *TT
Bulletin Number: 99164
CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER. *TT
Bulletin Number: 99185
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT
Bulletin Number: 99188
VEHICLES WITH 4.2L ENGINE (CANADIAN) MAY BACKFIRE ON ACCELERATION AT ALL AMBIENT TEMPERATURE. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99207
SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 99411
VEHICLES EXPERIENCING INCREASED BRAKE PEDAL EFFORT AND / OR FALSE ABS CYCLING AT LOW SPEEDS, OR ABS LAMP ILLUMINATION. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT
Bulletin Number: 996034
EXPERIENCING A ENGINE KNOCK AT COLD START-UP. *TT
Bulletin Number: 996042
INFORMATION ON USING 1999 PROCEDURES MANUAL FOR SIDE MIRROR REPLACEMENT. *TT
Bulletin Number: 996113
EXPERIENCING FRONT DIFFERENTIAL NOISE. *TT
Bulletin Number: 996139
CONCERNS WITH FRONT DIFFERENTIAL NOISE. *TT
Bulletin Number: 996754
THIS ONLINE BULLETIN ADDRESSES CONCERNS WITH CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT
Bulletin Number: 996780
THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT
Bulletin Number: 996876
INFORMATION PERTAINING TO CONDITIONS WITH RED STAINING (SPOTS) ON THE FRONT BUMPER WING ENDS. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: 9996
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT
Bulletin Number: BC0053970201
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC0053972301
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC0056972301
SOME VEHICLES WITH AIR CONDITIONING CAN EXHIBIT A COLD START ACCESSORY DRIVE BELT NOISE (CHIRP) CONCERN. *JD
Bulletin Number: BC0120970201
DIAGNOSIS WINDNOISE AT THE INNER BELT, RAISE DOOR GLASS TO FULL UP POSITION. *JD
Bulletin Number: BC0121970201
DRIVELINE RATTLE OVER BUMPS. *JD
Bulletin Number: BC0124970201
FOR CUSTOMER CONCERNS OF STALL, ROUGH IDLE, LACKS POWER, POOR FUEL ECONOMY, BACKFIRE, SURGE UNDER HEAVY ACCELERATION, LOSS IN FUEL PRESSURE UNDER ACCELERATION OF EXCESSIVE FUEL PRESSURE. *JD
Bulletin Number: BC0197970201
ENGINE OVERHEATING- WATER PUMP CONCERN DUE TO FREE SPINNING WATER PUMP IMPELLER. *JD
Bulletin Number: BC0315961101
FEAD BELT SQUEAL, COLD ONLY. *TW
Bulletin Number: BC0315970201
FEAD BELT SQUEAL, COLD ONLY. REVISED BELT RELEASED. *JD
Bulletin Number: BC0316961101
DRIVELINE CLUNK OR ACCEL OR DECEL. *TW
Bulletin Number: BC0325961129
SOME FRONT END SERPENTINE BELTS MAY MAKE NOISE WHEN BETWEEN 30 AND 50 DEGREES FAHRENHEIT. *TW
Bulletin Number: BC0325972301
SOME 5.4L FRONT END SERPETNTINE BELTS MAY MAKE SOME NOISE BETWEEN TEMPERATURES FO 30 F-50 F. *JD
Bulletin Number: BC0340961127
CERTAIN 1997 VEHCILES MAY HAVE BEEN BUILT WITH THE 240 SECOND MISFIRE DELAY. *TW
Bulletin Number: BC0345970201
DRIVELINE CLUNK, 4.2L BACKFIRE, 4.6L LACK OF POWER, 4.6L MISFIRE/MIL LIGHT ISSUES, AND WINDNOISE. *JD
Bulletin Number: BC0477961114
ENGINEERING IS INVESTIGATING DEALERSHIP CONCERNS WITH FOULED OR CRACKED SPARK PLUGS. *TW
Bulletin Number: BC0676961025
INFORMATION WHEN ELECTRONIC/HYDRAULIC CONTROL UNIT (EHCU) MALFUNCTIONS. *TT
Bulletin Number: BC0693961023
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Bulletin Number: BC0694961023
INFORMATION FOR RECREATIONAL TOWING (ALL WHEELS ON THE GROUND). *TT
Bulletin Number: BC0696961023
CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT
Bulletin Number: BC0697961023
WINDNOISE CONCERNS IN THE RIGHT DOOR A-PILLAR AREA OF THE SUPERCAB. *TT
Bulletin Number: BC0750961017
SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT
Bulletin Number: BC0753961017
4X4 VEHICLES MAY EXHIBIT A GRINDING NOISE WHILE SHIFTING INTO 4L. *TT
Bulletin Number: BC0765961016
INFORMATION ON DIAGNOSING WIND NOISE & WATER LEAKS AT THE LOWER PASSENGER DOOR AREA & 3RD DOOR. *TT
Bulletin Number: BC0782961014
CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT
Bulletin Number: BC0823961010
CONCERN OF WATER ENTRY INTO THE TRANSFER CASE. *TT
Bulletin Number: BC0841961008
CONCERNS OF WINDSHIELD WIPER NOT CLEANING, STREAKING OR SMEARING. *TT
Bulletin Number: BC0844961008
E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT
Bulletin Number: BC0854961007
REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT
Bulletin Number: BC0883961004
VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT
Bulletin Number: BC0884961004
FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT
Bulletin Number: BC0950960927
TECHNICIANS ARE EXPERIENCING DIFFICULTY REMOVING DOOR TRIM PANELS. *TW
Bulletin Number: BC0990961021
INFORMATION ON ENGINE OIL LEAK AT THE OIL PAN, FRONT COVER &/OR THE FRONT & REAR CRANKSHAFT OIL SEAL. *TT
Bulletin Number: BC1012897020
WIND NOISE AT THE INNER BELT, RAISE DOOR GLASS TO FULL UP POSITION. *JD
Bulletin Number: BC1012997020
DRIVELINE RATTLE OVER BUMPS. *JD
Bulletin Number: BC1013297020
STALL, ROUGH IDLE, LACKS POWER, POOR FUEL ECONOMY, BACKFIRE, SURGE UNDER HEAVY ACCELERATION, LOSS IN FUEL PRESSURE UNDER ACCELERATION OR EXCESSIVE FUEL PRESSURE AND/OR MIL ACTIVATION WITH DTCS. *JD
Bulletin Number: BC1015397020
VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC1020097230
THE SECOND PRINTING OF THE 1997 OWNERS GUIDE STATES THAT THE VEHICLES 4X4 LONG WHEELBASE MAY HAVE A SNOWPLOW INSTALLED- THIS IS INCORRECT. *JD
Bulletin Number: BC1022797230
THE NGS DISPLAYS INCORRECT DATA FOR THE IGN GEM PID ON THE VEHICLES. *JD
Bulletin Number: BC105849705
VEHICLES WITH PREMIUM RADIOS WILL BE EQUIPPED WITH VOLUME CONTROL/ON-OFF SWITCH. *TW
Bulletin Number: BC2150970206
INSTRUCTIONS FOR DIAGNOSING FUEL GUAGE CONCERNS. *TW
Bulletin Number: BC2301970501
NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW
Bulletin Number: BC2360970501
FOR CONCERNS OF NOISY/SQUEAKY STEERING AND DIAGNOSIS IS FOR THE PITMAN ARM, RECOMMENDED SERVICE IS TO REPLACE THE PITMAN ARM. *TW
Bulletin Number: BC2363970501
THE ONLY AUTHORIZED REPAIR FOR A FRONT FRAME BUMPER MOUNTING BRACKET NEEDING REPLACEMENT IS TO REPLACE THE FRAME. *TW
Bulletin Number: BC2385970501
F SERIES FLARESIDE WHEN EQUIPPED WITH THE CAB STEP, WILL NOT HAVE MUD FLAPS. *TW
Bulletin Number: BC2391970501
ENGINEERING IS ADDRESSING THE ISSUE OF INTERMITTENT/UNABLE TO ADJUST MIRROR CONCERNS. *TW
Bulletin Number: BC3090970225
VEHICLES WITH A ROUGH RUNNING/MISS SYMPTOM WITH A MISFIRE DTC ON A PARTICULAR CYLINDER WHERE NORMAL DIAGNOSIS DOES NOT PINPOINT A CAUSE - CHECK FOR DAMAGE TO CAMSHAFT. *TW
Bulletin Number: BC3101970224
SOFT BRAKE PEDAL. *TW
Bulletin Number: BC3153970219
INOPERATIVE OR ERRATIC CRUISE CONTROL OPERATION ALONG WITH HARSH TRANSMISSION SHIFTS. *TW
Bulletin Number: BC3242970210
DRIVELINE CLUNKING OR GRUNTING NOISE. *TW
Bulletin Number: BC3279970207
CONCERNS WITH THE MULTI-FUNCTION SWITCH. *TW
Bulletin Number: BC3282970206
GEM CONCERN - CHECK FOR MORE THAN ONE GEM CONTROLLED COMPONENT THAT IS INOPERATIVE OR FOR A STRING OF FALSE GEM DTC'S RECEIVED IN MEMORY. *TW
Bulletin Number: BC3363972301
THE NGS DISPLAYS INCORRECT DATE FOR THE ING GEM PID ON THE VEHICLES. *JD
Bulletin Number: BC3443972301
SECOND PRINTING OF THE 1997 OWNERS GUIDE STATES THAT THE VEHICLES LONG WHEELBASE MAY HAVE A SNOWPLOW INSTALLED- THIS IS INCORRECT. *JD
Bulletin Number: BC3510972301
CHECK ENGINE LIGHT ON WITH DTC P0455 IN CONTINUOUS MEMORY ON 1997 5.4L VEHICLE APPLICATIONS. *JD
Bulletin Number: BC5168961001
PROCEDURE FOR RESOLVING THE CONCERN OF WATER ENTRY INTO THE TRANSFER CASE. *TT
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC5201961001
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Bulletin Number: TSB-14-0147
FORD/LINCOLN: SAFETY RECALL ISSUED DUE TO ONE OR BOTH FUEL TANK STRAPS FRACTURING DUE TO BEING IN HIGH CORROSION AREAS FOR AN EXTENDED PERIOD AND DISLODGING FUEL TANK. MODEL 1997-99 F250, 1997-03 F150, 2004 F150 HERITAGE, 2002-2003 BLACKW
Bulletin Number: TSB-14-0164
FORD/LINCOLN: SAFETY RECALL REGARDING HIGH CORROSION AREAS FOR OPERATING, FOR AN EXTENDED TIME, VEHICLES WHERE BOTH OR ONE STRAP OF FUEL TANK CAN FRACTURE, AFTER CONTACTING GROUND. MODEL 1997-99 F250 LD, 1997-03 F150, 2004 F150 HERITAGE,
1997 FORD F-250
Bulletin Number: 0014
VEHICLES MAY EXPERIENCE INNER FENDER WELL- DENTED OR DINGED FROM STONES BEING THROWN INTO WHEELWELL. *MJS
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 0017
SUBJECT ON THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODES MAY APPEAR. *MJS
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 00238
SOME VEHICLES MAY EXHIBIT A NO CRANK / NO START CONDITION IN TEMPERATURES BELOW 12 DEGREES C (10 DEGREES F). *TT
Bulletin Number: 00239
A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. *TT
Bulletin Number: 00254
SOME VEHICLES MAY EXHIBIT AN ENGINE BUCK, SURGE, OR JERK (ALSO KNOWN AS HITCHING / HESITATION) WHILE THE SPEED CONTROL IS ACTIVE THROUGH ALL ENGINE TEMPERATURES. *TT
Bulletin Number: 00261
SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES. *TT
Bulletin Number: 0038
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS
Bulletin Number: 00611
SOME BI-FUEL VEHICLES MAY REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT DURING SERVICE AND MAY NOT RUN ON CNG OR LPG., RECALIBRATION OF THE PCM/REPLACEMENT. *MJS
Bulletin Number: 01111
SOME VEHICLES MAY EXHIBIT A WATER LEAK AROUND THE REAR (SLIDING) WINDOW. *TT
Bulletin Number: 01166
SOME VEHICLES MAY EXHIBIT WATER IN THE TRANSFER CASE, THIS COULD CAUSE LOW RANGE 4X4 LAMP TO ILLUMINATE, SHORT OF TRANSFER CASE SWITCH, OR WINDSHIELD WIPERS TO BE ERRATIC OR INOPERATIVE. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01182
SOME VEHICLES MAY EXPERIENCE A COSMETIC CRACK IN THE OUTER DOOR PANEL AT THE LOWER REAR CORNER OF WINDOW OPENING.*JB
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 01215
A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTER OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 0193
A CONDITION MAY EXIST WHERE A DRIVELINE VIBRATION AND / OR A TRANSMISSION FLUID LEAK FROM THE EXTENSION HOUSING SEAL AREA MAY OCCUR ON SOME VEHICLES. THIS MAY BE CAUSED BY THE EXTENSION HOUSING BUSHING OR SEAL WALKING / SPINNING OUT DUE T
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02193
DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ
Bulletin Number: 02E17
SUBJECT REGARDING HEATER HOSE TO FUEL RAIL FLEX LINE INSPECTION. *JG
Bulletin Number: 030402
ON SOME DEDICATED CNG VEHICLES, A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE. REVISED SERVICE PARTS. *TT
Bulletin Number: 03103
VEHICLES WITHOUT THE COOLANT LOCK-OFF MAY EXHIBIT A NO START CONDITION. *TT
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 032119
AN ENGINE VIBRATION AND/OR MOANING NOISE AT 2600-3000 RPM. *TT
Bulletin Number: 032120
7.3L DIT GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE - SERVICE TIP. *TT
Bulletin Number: 032121
A HIGH NUMBER OF HIGH PRESSURE REXROTH PUMPS AND INJECTION PRESSURE REGULATORS (IPR) ARE BEING REPLACED DUE TO OIL LEAKING, WHEN ALL THAT IS REQUIRED IS A NEW GASKET OR SEAL ON EITHER THE PUMP OR IPR. *TT
Bulletin Number: 032123
LOW RPM, NO START, RUNS POORLY, STALL. 7.3L DIT ENGINE. *TT
Bulletin Number: 032125
AFTERMARKET WIRING ALTERATIONS - SERVICE TIP. *TT
Bulletin Number: 03213
A NO-START OR REDUCED POWER CONDITION MAY OCCUR INTERMITTENTLY. *TT
Bulletin Number: 032140
ENGINE BUCK, SURGE OR JERK (ALSO KNOWN AS HITCHING/HESITATION) WHILE THE SPEED CONTROL IS ACTIVE THROUGH ALL ENGINE TEMPERATURES. *TT
Bulletin Number: 0342
POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE, ON SOME DEDICATED CNG VEHICLES. *TT *JB
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04217
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04L19
CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE. *TT
Bulletin Number: 05417
INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT
Bulletin Number: 07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
Bulletin Number: 11794
EXPERIENCING A RUBBING OR SQUEAK NOISE AS THE STEERING WHEEL IS TURNED. *TT
Bulletin Number: 11799
SOME SUPERCAB VEHICLES MAY EXHIBIT A MOAN / DROAN IN THE CAB AT 1500 - 1600 RPM OR A CAB VIBRATION AT 1800 - 1900 RPM. *TT
Bulletin Number: 11811
SOME VEHICLES BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT
Bulletin Number: 11814
SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT
Bulletin Number: 12071
SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *MJS
Bulletin Number: 12113
SOME VEHICLES WITH E40D AND CALIFORNIA CALIBRATION 7-90P-R10/11 MAY STALL DURING LONG DECEL CONDITIONS WHILE IN MKANUAL 1 OR 2 GEAR. *MJS
Bulletin Number: 12139
SOME VEHICLES EQUIPPED WITH 4.6L OR 6.8L ENGINES MAY EXHIBIT A COLD START ENGINE NOISE UNTIL WARMED UP. *MJS
Bulletin Number: 12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
Bulletin Number: 12208
SOME TEXAS DEPARTMENT OF TRANSPORTATION (DOT) TRUCKS MAY ENCOUNTER A RADIO FREQUENCY INTERFERENCE (RFI) CONDITION WHEN USING HAND HELD TWO-WAY RADIOS IN THE RANGE OF 47.18 MHZ. *TT
Bulletin Number: 12248
SOME HEAVY DUTY AND SUPER DUTY VEHICLES MAY EXHIBIT VARIOUS TRANSMISSION CONCERNS, INCLUDING STALL ON TRANSMISSION ENGAGEMENT AND / OR A BUZZ NOISE ON ENGAGEMENT. *TT
Bulletin Number: 12590
SOME 4X4 VEHICLES MAY EXHIBIT A MOAN NOISE FROM THE FRONT DIFFERENTIAL WHEN THE VEHICLE IS OPERATING IN 4X2 MODE AND GOES AWAY WHEN OPERATING IN 4X4 MODE. *TT
Bulletin Number: 12601
EXPERIENCING WHISTLING NOISE COMING FROM THE FRONT OF THE VEHICLE AT HIGHWAY SPEEDS. *TT
Bulletin Number: 12720
SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE FLEXIBLE RUBBER COOLANT HOSE. *TT
Bulletin Number: 12738
SOME VEHICLES MAY EXHIBIT A IDLE VIBRATION.
Bulletin Number: 12879
SUBJECT REGARDING REAR SPRING CLIP KITS FOR VEHICLES EXHIBITING A REAR SPRING RATTLE. *TT
Bulletin Number: 12882
SUBJECT REGARDING THE AVAILABILITY OF REAR SPRING CLIP KITS FOR VEHICLES EXHIBITING REAR SPRING RATTLE. *TT
Bulletin Number: 12905
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT
Bulletin Number: 13054
EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT
Bulletin Number: 13106
ON SOME VEHICLES THE FRONT BUMPERS MAY EXHIBIT RED STAINING (SPOTS) ON THE BUMER WING ENDS. *TT
Bulletin Number: 13203
INFORMATION REGARDING OUTWARD DENTS IN PICKUP BOX WHEEL WELLS. *MJS
Bulletin Number: 13238
INFORMATION REGARDING VEHICLES THAT EXHIBIT CRACKS IN THE DOOR SHEET METAL. *MJS
Bulletin Number: 13412
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT
Bulletin Number: 13479
SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT
Bulletin Number: 13505
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
Bulletin Number: 13550
SOME VEHICLES MAY EXHIBIT DENTS ON THE WHEEL WELL SHEET METAL OF THE PCIK-UP BOX AREA WHEN USED IN OFF-ROAD APPLICATIONS. *TT
Bulletin Number: 13745
SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS
Bulletin Number: 13838
CONCERNS WITH VEHICLES EXHIBITING A WINDSHIELD CREAK / SQUEAK. *TT
Bulletin Number: 14365
THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT. *JB
Bulletin Number: 14455
OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT
Bulletin Number: 15113
SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION. *YD
Bulletin Number: 15260
CONCERNS WITH CORRODED POSITIVE STARTER CABLE. *TT
Bulletin Number: 15570
SOME VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS INCLUDING LACKS POWER, HESITATES, HARD TO START, AND/OR MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND PRODUCE POSSIBLE DIAGNOSTIC TROUBLE CODES P0103, P0172 AND P0175. *TT
Bulletin Number: 16515
OIL LEAK AT HIGH PRESSURE PUMP FITTINGS AND/OR PLUG. THIS INCLUDES SUPER DUTY F-SERIES. OASIS. *TT
Bulletin Number: 17571
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT
Bulletin Number: 4614
INFORMATION ON VEHICLES EXHIBITING ROUGH IDLE / MISS. *TT
Bulletin Number: 4616
BRIEF INFORMATION VEHICLES EXHIBITING HARD START / NO START CONDITION. *TT
Bulletin Number: 4617
BRIEF INFORMATION ON VEHICLES EXHIBITING LACK OF POWER CONDITION. *TT
Bulletin Number: 4625
BRIEF INFORMATION ON VEHICLES EXHIBITING A STALL ON DECELERATION CONDITION. *TT
Bulletin Number: 4628
SOME VEHICLES MAY EXHIBIT REAR AXLE NOISE. *TT
Bulletin Number: 4629
BRIEF INFORMATION CONCERN VEHICLES EXHBITING EXTERNAL OIL LEAKS. *TT
Bulletin Number: 4631
BRIEF INFORMATION ON VEHICLES EXHIBIT VIBRATION AT CRUISE OVER 50 MPH. *TT
Bulletin Number: 4633
REAR BRAKE DRAG OR EXCESSIVE WEAR ON REAR BRAKES. *TT
Bulletin Number: 4635
COLD ENGINE KNOCK. *TT
Bulletin Number: 4638
MALFUNCTION INDICATOR LAMP ON, WITH P0300 - P0308 MISFIRE DIAGNOSTIC TROUBLE CODES WITH A 4.6L ENGINE. *TT
Bulletin Number: 4682
SOME SUPER CAB VEHICLES MAY EXHIBIT A MOAN / DROAN IN THE CAB AT 1500 - 1600 RPM OR A CAB VIBRATION AT 1800 - 1900 RPM. *TT
Bulletin Number: 4683
SOME VEHICLES MAY EXHIBIT A RUBBING OR SQUEAK NOISE AS THE STEERING WHEEL IS TURNED. *TT
Bulletin Number: 4703
SOME TRUCKS BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND TRUCKS BUILT WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT
Bulletin Number: 4981
SOME VEHICLES EQUIPPED WITH 5.4L ENGINES MAY EXHIBIT A COLD START ENGINE KNOCK CONCERN UNTIL WARMED UP. *TT
Bulletin Number: 5046
REPEAT MESSAGE REGARDING VEHICLES EXHIBITING A LACK OF POWER. *TT
Bulletin Number: 5047
REPEAT MESSAGE REGARDING A HARD START / NO START CONDITION. *TT
Bulletin Number: 5250
INFORMATION ON SUPER DUTY MODELS WITH 7.3L DIESEL ENGINES EXHIBITING ROUGH IDLE / MISS CONDITION. *TT
Bulletin Number: 5251
SOME SUPER DUTY VEHICLES WITH 7.3L DIT DIESEL ENGINES MAY EXHIBIT 4X4 LIGHTS ON, 4X4 INOPERATIVE AND / OR MULTIPLE GEM CODES. *TT
Bulletin Number: 5254
INFORMATION ON SUPER DUTY 7.3 DIT DIESEL ENGINE VEHICLES EXHIBITI LACK OF POWER. *TT
Bulletin Number: 5257
INFORMATION ON VEHICLES EXHIBITING COLD ENGINE KNOCK. *TT
Bulletin Number: 5258
INFORMATION ON VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. *TT
Bulletin Number: 5262
SERVICE INFORMATION FOR VEHICLES EXHIBITING STALL ON DECELERATION CONDITION. *TT
Bulletin Number: 5262
INFORMATION ON DIAGNOSTICING ERRATIC WINDSHIELD WIPER OPERATION. *TT
Bulletin Number: 5267
SUBJECT REGARDING MISFIRE CODES ON ALL ENGINES. *TT
Bulletin Number: 5316
SOME SUPER DUTY 7.3L E4OD AND 7.3L 4R100 VEHICLES MAY EXHIBIT VARIOUS TRANSMISSION CONCERNS, INCLUDING STALL ON TRANSMISSION ENGAGEMENT AND / OR A BUZZ NOISE ON ENGAGEMENT. *TT
Bulletin Number: 5955
SUBJECT REGARDING FRONT DIFFERENTIAL NOISE INVESTIGATION. *TT
Bulletin Number: 6232
SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE COIL RESULTING IN ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE P0304 AND / OR ROUGH IDLE. *TT
Bulletin Number: 6287
SOME VEHICLES MAY EXPERIENCE AN IDLE VIBRATION. *TT
Bulletin Number: 6477
SUBJECT REGARDING REAR SPRING RATTLE. *TT
Bulletin Number: 6489
SOME VEHICLES BUILT WITH 3-LEAF OR 4-LEAF REAR SPRINGS MAY EXHIBIT A REAR SPRING RATTLE. *TT
Bulletin Number: 7022
INFORMATION REGARDING OUTWARD DENTS IN PICKUP BOX WHEEL WELLS. *MJS
Bulletin Number: 7353
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT
Bulletin Number: 7821
CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING.
Bulletin Number: 96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
Bulletin Number: 962213
EXHAUST - EXHAUST LEAK AT EXHAUST MANIFOLDS - VEHICLES EQUIPPED WITH 7.0L OR 7.5L ENGINE. *TW
Bulletin Number: 96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
Bulletin Number: 96226
AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW
Bulletin Number: 962410
TRANSMISSION - E40D - 4R70W - 4R44E - 5R55E - NEW DIGITAL TRANSMISSION RANGE SENSOR - DIAGNOSIS SERVICE TIP. *TW
Bulletin Number: 962412
BRAKES - REAR PARKING BRAKE CABLE BINDS - VEHICLES BUILT BEFORE 8/20/96 - ALL CHASSIS CAB VEHICLES ARE EXCLUDED. *TW
Bulletin Number: 962418
TRANSMISSION - E40D - REVISED DESIGN FORWARD PLANET THRUST WASHER - SERVICE TIP. *TW
Bulletin Number: 96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
Bulletin Number: 96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
Bulletin Number: 962511
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 962518
DOOR - POWER POINT ACCESS DOOR BREAKS - VEHICLES BUILT THROUGH 8/31/96. *TW
Bulletin Number: 96252
LOCKS - REPLACE AND/OR REPAIR ANY LOCK COMPONENT - SERVICE TIP. *TW
Bulletin Number: 962521
STEERING - CLUNK NOISE FROM STEERING COLUMN ON ACCELERATING AND BRAKING. *TW
Bulletin Number: 962525
NOISE - RATTLE - SUMMARY OF CONCERNS - SERVICE TIPS. *TW
Bulletin Number: 962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 97111097238
SUBJECT ON REAR VIBRATION/SHUDDER WHEN APPLYING BRAKES. *YC
Bulletin Number: 97113
AN ENGINE VIBRATION AND/OR "MOANING" NOISE AT 2600-3000 RPM MAY OCCUR ON SOME VEHICLES. *JD
Bulletin Number: 97214
ENGINE - 7.3L DIT - GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE - SERVICE TIP. *TW
Bulletin Number: 97215
DIAGNOSTIC GUIDES FOR OUT-OF-WARRANTY VEHICLES TO BE USED AS A MASTER COPY - DIAGNOSTIC GUIDES NO LONGER AVAILABLE FROM ADISTRA. *TW
Bulletin Number: 97216
LEAK - OIL LEAKAT ENGINE VALLEY PAN AND/OR HIGH PRESSURE OIL PUMP - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE. *TW
Bulletin Number: 9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD
Bulletin Number: 97410
TRANSMISSION- E4OD- COOLER BYPASS VALVE SERVICE DURING TRANSMISSION OVERHAUL- SERVICE TIP. *JD
Bulletin Number: 9747
FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD
Bulletin Number: 9751
INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD
Bulletin Number: 97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
Bulletin Number: 976007
BRIEF INFORMATION REGARDING CYLINDER HEAD TEMPERATURE (CHT) AND FAIL SAFE COOLING. *TT
Bulletin Number: 976011
CUSTOMER MAY COMPLAIN OF INTERMITTENT STALL / BUCKS / JERKS WHILE DRIVING. *TT
Bulletin Number: 97618
LOW RPM- 7.3L DIT ENGINE FAILS TO START- CODE 340 STORED IN MEMORY AND/OR ENGINE FAILS TO ACHIEVE RATED SPEED FOR 2-3 MINUTES AFTER EXTENDED COLD SOAK- F-SERIES BUILT THROUGH 2/9/96 AND ALL ECONOLINES. *JD
Bulletin Number: 97627
NOISE- "RATCHETING"- FRONT AXLE- 4X4- SELF-ENGAGEMENT OF AUTOMATIC HUB LOCKS- F-250 AND F-350 OVER 8500# GVW. *JD
Bulletin Number: 97629
TRANSMISSION- E4OD- HARSH/DELAYED 2-3 UPSHIFTS- VEHICLES WITH 7.3L DIESEL AND 49-STATE CALIBRATION- F-SERIES BUILT THROUGH 2/3/97 AND ALL 1996 E-350. *JD
Bulletin Number: 9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
Bulletin Number: 97713
NOISE- "BUZZING"- UNDERHOOD WHEN AIR SUSPENSION IS IN OPERATION. *JD
Bulletin Number: 9778
HEADLAMP- HEADLAMP HOUSING MELTS- AMBULANCE AND EMERGENCY VEHICLES ONLY. *JD
Bulletin Number: 9779
WIRING- AFTERMARKET WIRING ALTERATIONS- SERVICE TIP. *JD
Bulletin Number: 980298
INFORMATION REGARDING THE HOTLINE SURVEY. *YC
Bulletin Number: 9803000
HOTLINE CONTACT ID NUMBER ON OASIS. A NINE DIGIT CONTACT NUMBER IS ATTACHED TO THE OASIS INFORMATION WHEN A VIN AND SYMPTOM CODE IS ENTERED INTO OASIS. *YC
Bulletin Number: 980307
VEHICLE STALLS/QUITS WHILE DRIVING. *AK
Bulletin Number: 980310
EXPERIENCING VIBRATION AT CRUISE OVER 50 MPH. *YC
Bulletin Number: 980312
EXCESSIVE WHITE SMOKE. VERIFY GLOW PLUG OPERATION BY PERFORMING GLOW PLUG SYSTEM OPERATION CHECK ON THE HARD START/NO START DIAGNOSTIC SHEET. *TT
Bulletin Number: 980317
SYMPTOMS REGARDING P0300-P0308 MISFIRE DTCS WITH 4.6L ENGINES. *YC
Bulletin Number: 980323
DTC'S P1211/1212 ICP PRESSURE HIGHER/LOWER THAN EXPECTED.
Bulletin Number: 980323
CONCERNS WITH EXTERNAL OIL LEAKS. *YC
Bulletin Number: 980325
COLD ENGINE UPPER KNOCK/TICK. *YC
Bulletin Number: 9810569
CONCERNS OF SQUEAKY / NOISY PITMAN ARM. *YC
Bulletin Number: 98113
SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT
Bulletin Number: 9811335
EXHIBITING A VIBRATION, NOISE OR GROUND OUT CONDITION WHEN TURNING OR UNDER LOAD. *TT
Bulletin Number: 9811342
INFORMATION ON REMOVING THE RADIO CHASSIS FROM SOME VEHICLES. *TT
Bulletin Number: 9811344
SOME VEHICLES MAY EXHIBIT LOOSE LUGNUTS AND / OR BROKEN WHEEL STUDS. *TT
Bulletin Number: 9811346
SOME VEHICLES MAY EXPERIENCE AN INTERMITTENT STALL CONDITION AFTER A LONG DECELERATION WHEN USING THE M1 OR M2 GEAR ON THE E40D OR WHEN USING A LOWER GEAR WITH THE M50D FOR ENGINE BRAKING. *TT
Bulletin Number: 98151
MALFUNCTION INDICATOR LAMP FAILED. YD
Bulletin Number: 981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK
Bulletin Number: 981517
INSTALL A REVISED CHILD SEAT TETHER KIT.
Bulletin Number: 98158
FRONT END SHIMMY MAY OCCUR AT VARIOUS DRIVING SPEEDS AND IS USUALLY INDUCED WHEN HITTING BUMPS, SUCH AS LARGE POTHOLES OR ROUGH RAILROAD CROSSINGS. SHIMMY IS NOT ALWAYS VERIFIED DURING ROAD TEST. *AK
Bulletin Number: 981610
THE SEAT BACK MAY NOT LATCH/ LOCK IN THE DESIRED POSITION AND REMAIN FOLDED FORWARD OVER THE SEAT CUSHION. YD
Bulletin Number: 981612
FUEL MAY LEAK FROM THE SPRING LOCK COUPLINGS. YD
Bulletin Number: 981613
TRANSMISSION FLUID LEAKS AT RADIATOR. YD
Bulletin Number: 981617
FLOOR MAT INSTALLATION PROCEDURE SERVICE TIP. YD
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 98168
TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD
Bulletin Number: 98168
INSTALLATION OF VINYL FLOOR MATS SERVICE TIP. AK
Bulletin Number: 98169
STEERING -ALIGNMENT-TOE SET PROCEDURE SERVICE TIP. YD
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 982110
DURING HIGH IDLE SPEEDS THROTTLE STICKS AFTER STEADY STATE DRIVING IN COLD AMBIENT TEMPERATURES. *YC
Bulletin Number: 982117
A NEW PARKING BRAKE CONTROL RUBBER BUMPER STOP IS NOW AVAILABLE FOR SERVICE. *YC
Bulletin Number: 98231
CONDITION WITH WATER INTRUSION INTO THE GENERIC ELECTRONIC MODULE ( GEM ) MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982312
ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 982313
SOME VEHICLES WITH A 7.3L DIRECT INJECTION (DI) TURBO DIESEL ENGINE, ONE OR MORE OF THE FOLLOWING CONCERNS MAY BE PRESENT: ROUGH IDLE, STALLING, HESITATION/ STUMBLE, LOSS / LACK OF POWER, POOR FUEL ECONOMY, AND EXCESSIVE OIL CONSUMPTION.
Bulletin Number: 982314
PREMATURE WEAR OF THE BELT TENSIONER MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982512
SOME VEHICLES WITH HIGHER ODOMETER READINGS MAY EXPERIENCE A HESITATION ON ACCELERATION JUST OFF IDLE AND MISFIRE COMPLAINTS WITH MALFUNCTION INDICATOR LALMP ( MIL ) ON. *YC
Bulletin Number: 982548
BRIEF INFORMATION GIVING THE CORRECT PART NUMBER FOR TSB 98-3-12. *YC
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 982673
IF YOU ENCOUNTER A VEHICLE WITH A MISSING WHEEL HUB O-RING, DO NOT INSTALL A NEW O-RING. *YC
Bulletin Number: 982740
CONCERNS WITH HIGH PRESSURE OIL PUMPS ARE NOT SERVICEABLE. *YC
Bulletin Number: 983070
SOMVE VEHICLES MAY EXHIBIT A BUZZ / LOW GROWL NOISE COMING FROM THE AREA OF THE TRANSFER CASE MANUAL SHIFT LEVER. *TT
Bulletin Number: 983074
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 983301
THIS BULLETIN PROVIDES PROCEDURES ON NEUTRALIZING THE EXHAUST, TRANSMISSION AND ENGINE MOUNTS. *TT
Bulletin Number: 983302
THIS BULLETIN MENTIONS HOW SOME HUB O-RINGS MAY BE CUT DURING THE INSTALLATION OF THE WHEELS. *TT
Bulletin Number: 983564
EXPERIENCING A SQUEALING NOISE FROM THE FRONT BRAKES WHEN APPLYING THE BRAKES ON SOME VEHICLES. *TT
Bulletin Number: 983570
SOME ENGINES MAY EXHIBIT OIL LEAKAGE. *TT
Bulletin Number: 98413
A GRABBING CONDITION AND / OR SQUEAL NOISE FROM THE REAR BRAKES DURING FIRST FEW BRAKE APPLICATIONS AFTER RAINFALL AND / OR WHILE BRAKES ARE COLD. *TT
Bulletin Number: 98419
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 98-4717
VEHICLES EXHIBIT CRACKS IN DOOR SHEET METAL AT LOWER REAR OF THE WINDOW OPENING NEAR BELT MOLDING. *AK
Bulletin Number: 98-4722
REPEAT MESSAGE, NO CHANGE- ROUGH IDLE/MISS. *AK
Bulletin Number: 98-4725
VIBRATION AT CRUISE OVER 50 MPH. *AK
Bulletin Number: 98-4726
REPEAT MESSAGE, NO CHANGE: HARD START/ NO START. *AK
Bulletin Number: 98-4734
LACK OF POWER DUE TO FAILURE OF ENGINE TURBO BOOST
Bulletin Number: 98-4738
COLD ENGINE KNOCK 5.4L ACTION. *AK
Bulletin Number: 98-4742
VEHICLE STALLS UPON ACCELERATION. *AK
Bulletin Number: 985028
INFORMATION REGARDING A NEW SERVICE PART RELEASED FOR THE LICENSE PLATE LIGHT CIRCUIT WHICH WILL REDUCE THE COSE OF REPAIRS. *TT
Bulletin Number: 985029
SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT
Bulletin Number: 985042
REPEAT MESSAGE REGARDING VEHICLES EXHIBITING ROUGH IDLE / MISS CONDITION. *TT
Bulletin Number: 985058
SUBJECT REGARDING EXTERNAL OIL LEAKS - REPEAT MESSAGE. *TT
Bulletin Number: 985059
EXPERIENCING COLD ENGINE KNOCK (REPEAT / REVISED MESSAGE). *TT
Bulletin Number: 985062
SUBJECT REGARDING IDLE VIBRATION (REPEAT MESSAGE). *TT
Bulletin Number: 985063
SUBJECT REGARDING VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. (REPEAT MESSAGE). *TT
Bulletin Number: 985185
COLD START ENGINE NOISE
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 9858
THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0503 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
Bulletin Number: 985A23
A COMPREHENSIVE PULL AND DRIFT DIAGNOSTIC PROCEDURE HAS BEEN DEVELOPED TO ASSIST TECHNICIANS IN HELPING TO RESOLVE PULL OR DRIFT CONDITIONS. *TT
Bulletin Number: 985A25
A VIBRATION OR SHUDDER MAY BE FELT DURING BRAKING ON SOME VEHICLES. *YC
Bulletin Number: 985A35
THE REAR PARKING BRAKE CABLES MAY BIND AND NOT ALLOW THE REAR BRAKE SHOES TO RETURN FULLY TO THE ANCHOR PINS AFTER THE PARKING BRAKE IS APPLIED. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 98611
CONCERNS WITH REDUCED POWER, STALLING, HESITATION, AND SURGE. *YC
Bulletin Number: 98613
SUBJECT REGARDING COLD AIR FELT ON THE FLOOR WHILE IN HEAT MODE. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9869
CONCERNS WITH HESITATION, STUMBLE, SURGE, MISS, ROUGH IDLE, STALL AT IDLE. *TT
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 98S14
SAFETY RECALL UPDATE TO REPLACE LOCKING LUG NUTS. *TT
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99128
SOME VEHICLES MAY EXHIBIT A WHISTLING NOISE WHILE DRIVING WITH A/C IN THE OFF POSITION AT SPEEDS ABOVE 64 KM/H (40 MPH). *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 991313
SUBJECT REGARDING ANTI-LOCK BRAKE LAMP ILLUMINATION, INCREASED BREAK PEDAL EFFORT AND / OR FALSE ANTI-LOCK BRAKE SYSTEM (ABS) CYCLING AT LOW SPEEDS. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99143
SOME 4X4 VEHICLES BUILT WITH CENTER DISCONNECT FRONT AXLES MAY EXHIBIT A MOANING NOISE FROM THE FRONT DIFFERENTIAL WHILE OPERATING IN 4X2 MODE. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99164
CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER. *TT
Bulletin Number: 99185
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 99411
VEHICLES EXPERIENCING INCREASED BRAKE PEDAL EFFORT AND / OR FALSE ABS CYCLING AT LOW SPEEDS, OR ABS LAMP ILLUMINATION. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT
Bulletin Number: 996034
EXPERIENCING A ENGINE KNOCK AT COLD START-UP. *TT
Bulletin Number: 996042
INFORMATION ON USING 1999 PROCEDURES MANUAL FOR SIDE MIRROR REPLACEMENT. *TT
Bulletin Number: 996113
EXPERIENCING FRONT DIFFERENTIAL NOISE. *TT
Bulletin Number: 996128
SUBJECT REGARDING RIGHT REAR BRAKE CONCERNS UNDER INVESTIGATION. *TT
Bulletin Number: 996139
CONCERNS WITH FRONT DIFFERENTIAL NOISE. *TT
Bulletin Number: 996754
THIS ONLINE BULLETIN ADDRESSES CONCERNS WITH CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT
Bulletin Number: 996780
THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT
Bulletin Number: 996876
INFORMATION PERTAINING TO CONDITIONS WITH RED STAINING (SPOTS) ON THE FRONT BUMPER WING ENDS. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: 9996
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT
Bulletin Number: BC0053970201
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC0053972301
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC0056972301
SOME VEHICLES WITH AIR CONDITIONING CAN EXHIBIT A COLD START ACCESSORY DRIVE BELT NOISE (CHIRP) CONCERN. *JD
Bulletin Number: BC0120970201
DIAGNOSIS WINDNOISE AT THE INNER BELT, RAISE DOOR GLASS TO FULL UP POSITION. *JD
Bulletin Number: BC0121970201
DRIVELINE RATTLE OVER BUMPS. *JD
Bulletin Number: BC0124970201
FOR CUSTOMER CONCERNS OF STALL, ROUGH IDLE, LACKS POWER, POOR FUEL ECONOMY, BACKFIRE, SURGE UNDER HEAVY ACCELERATION, LOSS IN FUEL PRESSURE UNDER ACCELERATION OF EXCESSIVE FUEL PRESSURE. *JD
Bulletin Number: BC0256970201
A RUNNING CHANGE FOR THE 7.3L TO ALLOW BETTER DEFINITION ON CYLINDER CONTRIBUTION TESTS IN PROCESS. *JD
Bulletin Number: BC0315961101
FEAD BELT SQUEAL, COLD ONLY. *TW
Bulletin Number: BC0315970201
FEAD BELT SQUEAL, COLD ONLY. REVISED BELT RELEASED. *JD
Bulletin Number: BC0321961101
POP/CLUNK FROM STEERING LINKAGE OVER BUMPS. *TW
Bulletin Number: BC0321970201
POP/CLUNK FROM STEERING LINKAGE OVER BUMPS. *JD
Bulletin Number: BC0321972301
POP/CLUNK FROM STEERING LINKAGE OVER BUMPS. *JD
Bulletin Number: BC0325972301
SOME 5.4L FRONT END SERPETNTINE BELTS MAY MAKE SOME NOISE BETWEEN TEMPERATURES FO 30 F-50 F. *JD
Bulletin Number: BC0340961127
CERTAIN 1997 VEHCILES MAY HAVE BEEN BUILT WITH THE 240 SECOND MISFIRE DELAY. *TW
Bulletin Number: BC0345970201
DRIVELINE CLUNK, 4.2L BACKFIRE, 4.6L LACK OF POWER, 4.6L MISFIRE/MIL LIGHT ISSUES, AND WINDNOISE. *JD
Bulletin Number: BC0676961025
INFORMATION WHEN ELECTRONIC/HYDRAULIC CONTROL UNIT (EHCU) MALFUNCTIONS. *TT
Bulletin Number: BC0693961023
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Bulletin Number: BC0694961023
INFORMATION FOR RECREATIONAL TOWING (ALL WHEELS ON THE GROUND). *TT
Bulletin Number: BC0696961023
CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT
Bulletin Number: BC0697961023
WINDNOISE CONCERNS IN THE RIGHT DOOR A-PILLAR AREA OF THE SUPERCAB. *TT
Bulletin Number: BC0750961017
SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT
Bulletin Number: BC0753961017
4X4 VEHICLES MAY EXHIBIT A GRINDING NOISE WHILE SHIFTING INTO 4L. *TT
Bulletin Number: BC0782961014
CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT
Bulletin Number: BC0823961010
CONCERN OF WATER ENTRY INTO THE TRANSFER CASE. *TT
Bulletin Number: BC0841961008
CONCERNS OF WINDSHIELD WIPER NOT CLEANING, STREAKING OR SMEARING. *TT
Bulletin Number: BC0844961008
E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT
Bulletin Number: BC0854961007
REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT
Bulletin Number: BC0883961004
VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT
Bulletin Number: BC0884961004
FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT
Bulletin Number: BC1012897020
WIND NOISE AT THE INNER BELT, RAISE DOOR GLASS TO FULL UP POSITION. *JD
Bulletin Number: BC1012997020
DRIVELINE RATTLE OVER BUMPS. *JD
Bulletin Number: BC1013297020
STALL, ROUGH IDLE, LACKS POWER, POOR FUEL ECONOMY, BACKFIRE, SURGE UNDER HEAVY ACCELERATION, LOSS IN FUEL PRESSURE UNDER ACCELERATION OR EXCESSIVE FUEL PRESSURE AND/OR MIL ACTIVATION WITH DTCS. *JD
Bulletin Number: BC1015397020
VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC1020097230
THE SECOND PRINTING OF THE 1997 OWNERS GUIDE STATES THAT THE VEHICLES 4X4 LONG WHEELBASE MAY HAVE A SNOWPLOW INSTALLED- THIS IS INCORRECT. *JD
Bulletin Number: BC1020897230
AVAILABLITY OF THE SBDS "RED DISC" WITH IMPROVMENTS TO 7.3L/E40D 2-3 SHIFT QUALITY AND ENHANCED APCM FUNTIONING HAS BEEN DELAYED TO LATE FEBRUARY FORM THE ORIGINAL JANUARY 1997 DATE. *JD
Bulletin Number: BC1022797230
THE NGS DISPLAYS INCORRECT DATA FOR THE IGN GEM PID ON THE VEHICLES. *JD
Bulletin Number: BC105849705
VEHICLES WITH PREMIUM RADIOS WILL BE EQUIPPED WITH VOLUME CONTROL/ON-OFF SWITCH. *TW
Bulletin Number: BC2297970501
WHEN THE AIR CLEANER IS BEING REPLACED, THE DRAIN MECHANISM ON THE BOTTOM OF THE AIR CLEANER CASE IS TO BE CLEANED OF OBSTRUCTIONS. *TW
Bulletin Number: BC2301970501
NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW
Bulletin Number: BC2360970501
FOR CONCERNS OF NOISY/SQUEAKY STEERING AND DIAGNOSIS IS FOR THE PITMAN ARM, RECOMMENDED SERVICE IS TO REPLACE THE PITMAN ARM. *TW
Bulletin Number: BC2363970501
THE ONLY AUTHORIZED REPAIR FOR A FRONT FRAME BUMPER MOUNTING BRACKET NEEDING REPLACEMENT IS TO REPLACE THE FRAME. *TW
Bulletin Number: BC2391970501
ENGINEERING IS ADDRESSING THE ISSUE OF INTERMITTENT/UNABLE TO ADJUST MIRROR CONCERNS. *TW
Bulletin Number: BC3090970225
VEHICLES WITH A ROUGH RUNNING/MISS SYMPTOM WITH A MISFIRE DTC ON A PARTICULAR CYLINDER WHERE NORMAL DIAGNOSIS DOES NOT PINPOINT A CAUSE - CHECK FOR DAMAGE TO CAMSHAFT. *TW
Bulletin Number: BC3101970224
SOFT BRAKE PEDAL. *TW
Bulletin Number: BC3130970221
DIESEL EXHAUST SMELL IN PASSENGER CABIN MAY BE DUE TO POOR CONNECTION AT THE INLET OR OUTLET TO/FROM THE TURBO. *TW
Bulletin Number: BC3153970219
INOPERATIVE OR ERRATIC CRUISE CONTROL OPERATION ALONG WITH HARSH TRANSMISSION SHIFTS. *TW
Bulletin Number: BC3171970217
UNEXPLAINED GLASS BREAKAGE OF THE LEFT FRONT DOOR. *TW
Bulletin Number: BC3212970213
CAMSHAFT POSITION SENSOR INFORMATION . *TW
Bulletin Number: BC3241970210
EXHAUST LEAKS OR NOISE AT THE JOINT BETWEEN THE Y-PIPE AND THE EXHAUST MANIFOLD. *TW
Bulletin Number: BC3242970210
DRIVELINE CLUNKING OR GRUNTING NOISE. *TW
Bulletin Number: BC3279970207
CONCERNS WITH THE MULTI-FUNCTION SWITCH. *TW
Bulletin Number: BC3287970206
THE CLUTCH MAY BE HARD TO DEPRESS DUE TO DUST/CONTAMINATION ENTERING THE SLAVE CYLINDER. *TW
Bulletin Number: BC3363972301
THE NGS DISPLAYS INCORRECT DATE FOR THE ING GEM PID ON THE VEHICLES. *JD
Bulletin Number: BC3440972301
AVAILABLITY OF THE SBDS "RED DISC" WITH IMPROVEMENTS TO 7.3L/E40D 2-3 SHIFT QUALITY AND ENHANCED APCM FUNCTIONING HAS BEEN DELAYED. *JD
Bulletin Number: BC3443972301
SECOND PRINTING OF THE 1997 OWNERS GUIDE STATES THAT THE VEHICLES LONG WHEELBASE MAY HAVE A SNOWPLOW INSTALLED- THIS IS INCORRECT. *JD
Bulletin Number: BC3510972301
CHECK ENGINE LIGHT ON WITH DTC P0455 IN CONTINUOUS MEMORY ON 1997 5.4L VEHICLE APPLICATIONS. *JD
Bulletin Number: BC5168961001
PROCEDURE FOR RESOLVING THE CONCERN OF WATER ENTRY INTO THE TRANSFER CASE. *TT
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC5201961001
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Bulletin Number: BPI9905
CUSTOMER MAY COMPLAIN THAT THE RAYBESTOS ELECTRONIC BRAKE CONTROLLER DOES NOT WORK, WORKS INCORRECTLY, WORKS INTERMITTENTLY, PULSES THE 4-WAY FLASHERS, AND / OR INTERFERS WITH ANTILOCK BRAKES OPERATION. *TT
Bulletin Number: TSB-14-0147
FORD/LINCOLN: SAFETY RECALL ISSUED DUE TO ONE OR BOTH FUEL TANK STRAPS FRACTURING DUE TO BEING IN HIGH CORROSION AREAS FOR AN EXTENDED PERIOD AND DISLODGING FUEL TANK. MODEL 1997-99 F250, 1997-03 F150, 2004 F150 HERITAGE, 2002-2003 BLACKW
Bulletin Number: TSB-14-0164
FORD/LINCOLN: SAFETY RECALL REGARDING HIGH CORROSION AREAS FOR OPERATING, FOR AN EXTENDED TIME, VEHICLES WHERE BOTH OR ONE STRAP OF FUEL TANK CAN FRACTURE, AFTER CONTACTING GROUND. MODEL 1997-99 F250 LD, 1997-03 F150, 2004 F150 HERITAGE,
1997 FORD F-250 SD
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 0038
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03211
LOSS OF POWER AND MALFUNCTION INDICATOR LAMP MAY ALSO ILLUMINATE WITH DIAGNOSTIC TROUBLE CODES 128 AND 845 OR P0236 AND P0238 STORED IN MEMORY. *TT
Bulletin Number: 032126
MOANING NOISE DURING 1500-2000 RPM ON NEUTRAL ENGINE RUN-UP, OR WHILE DRIVING UNDER LOAD. *TT
Bulletin Number: 032131
ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *TT
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 98113
SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT
Bulletin Number: 98119
CONDITIONS WITH ENGINE STALLING DURING LONG DECEL WHILE IN MANUAL 1 OR MANUAL 2 GEAR ON SOME VEHICLES. *TT
Bulletin Number: 98122
INFORMATION ON THE DEFROSTER PERFORMANCE ENHANCEMENT.
Bulletin Number: 98156
EXHAUST LEAK AT EXHAUST MANIFOLDS--VEHICLE EQUIPPED WITH 7.0L 0R 7.5L ENGINE. *AK
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 98168
TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD
Bulletin Number: 98205
EXHIBITING ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982721
SOME VEHICLES MAY EXPERIENCE A POPPING / SQUEAKING NOISE IN THE STEERING COLUMN WHILE TURNING. *YC
Bulletin Number: 98414
EXPERIENCING AN ENGINE STALL CONDITION ON 1997 CALIFORNIA F SERIES 7.3L DIESEL E40D VEHICLES AFTER A LONG DECEL WHEN USING M1 GEAR FOR ENGINE BRAKING. *YC
Bulletin Number: 98419
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 985176
SOME TRUCKS WITH E40D AND CALIFORNIA CALIBRATION 7-90P-R10/11 MAY STALL DURING LONG DECEL CONDITIONS WHILE IN MANUAL 1 OR 2 GEAR. *TT
Bulletin Number: 985A23
A COMPREHENSIVE PULL AND DRIFT DIAGNOSTIC PROCEDURE HAS BEEN DEVELOPED TO ASSIST TECHNICIANS IN HELPING TO RESOLVE PULL OR DRIFT CONDITIONS. *TT
Bulletin Number: 985A25
A VIBRATION OR SHUDDER MAY BE FELT DURING BRAKING ON SOME VEHICLES. *YC
Bulletin Number: 985A27
LUBRICANT LEAKING FROM REAR AXLE SEAL CONTAMINATING BRAKE SHOES. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 98810
SOME CUSTOMERS MAY REQUIRE A HEAVY DUTY 7-WAY TRAILER WIRING CONNECTOR SYSTEM WHEN THE VEHICLE IS EQUIPPED WITH A 4-WAY CONNECTOR. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99236
SUBJECT REGARDING 4R100 TRANSMISSION FLEXPLATE REPLACEMENT FOR VEHICLES WITH 7.3L DIESEL ENGINE. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
1997 FORD F-350
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 00254
SOME VEHICLES MAY EXHIBIT AN ENGINE BUCK, SURGE, OR JERK (ALSO KNOWN AS HITCHING / HESITATION) WHILE THE SPEED CONTROL IS ACTIVE THROUGH ALL ENGINE TEMPERATURES. *TT
Bulletin Number: 0038
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03211
LOSS OF POWER AND MALFUNCTION INDICATOR LAMP MAY ALSO ILLUMINATE WITH DIAGNOSTIC TROUBLE CODES 128 AND 845 OR P0236 AND P0238 STORED IN MEMORY. *TT
Bulletin Number: 032119
AN ENGINE VIBRATION AND/OR MOANING NOISE AT 2600-3000 RPM. *TT
Bulletin Number: 032120
7.3L DIT GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE - SERVICE TIP. *TT
Bulletin Number: 032121
A HIGH NUMBER OF HIGH PRESSURE REXROTH PUMPS AND INJECTION PRESSURE REGULATORS (IPR) ARE BEING REPLACED DUE TO OIL LEAKING, WHEN ALL THAT IS REQUIRED IS A NEW GASKET OR SEAL ON EITHER THE PUMP OR IPR. *TT
Bulletin Number: 032123
LOW RPM, NO START, RUNS POORLY, STALL. 7.3L DIT ENGINE. *TT
Bulletin Number: 032125
AFTERMARKET WIRING ALTERATIONS - SERVICE TIP. *TT
Bulletin Number: 032126
MOANING NOISE DURING 1500-2000 RPM ON NEUTRAL ENGINE RUN-UP, OR WHILE DRIVING UNDER LOAD. *TT
Bulletin Number: 03213
A NO-START OR REDUCED POWER CONDITION MAY OCCUR INTERMITTENTLY. *TT
Bulletin Number: 032131
ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *TT
Bulletin Number: 032140
ENGINE BUCK, SURGE OR JERK (ALSO KNOWN AS HITCHING/HESITATION) WHILE THE SPEED CONTROL IS ACTIVE THROUGH ALL ENGINE TEMPERATURES. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 12113
SOME VEHICLES WITH E40D AND CALIFORNIA CALIBRATION 7-90P-R10/11 MAY STALL DURING LONG DECEL CONDITIONS WHILE IN MKANUAL 1 OR 2 GEAR. *MJS
Bulletin Number: 12248
SOME HEAVY DUTY AND SUPER DUTY VEHICLES MAY EXHIBIT VARIOUS TRANSMISSION CONCERNS, INCLUDING STALL ON TRANSMISSION ENGAGEMENT AND / OR A BUZZ NOISE ON ENGAGEMENT. *TT
Bulletin Number: 12905
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT
Bulletin Number: 14455
OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT
Bulletin Number: 17571
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT
Bulletin Number: 4614
INFORMATION ON VEHICLES EXHIBITING ROUGH IDLE / MISS. *TT
Bulletin Number: 4616
BRIEF INFORMATION VEHICLES EXHIBITING HARD START / NO START CONDITION. *TT
Bulletin Number: 4617
BRIEF INFORMATION ON VEHICLES EXHIBITING LACK OF POWER CONDITION. *TT
Bulletin Number: 4625
BRIEF INFORMATION ON VEHICLES EXHIBITING A STALL ON DECELERATION CONDITION. *TT
Bulletin Number: 4629
BRIEF INFORMATION CONCERN VEHICLES EXHBITING EXTERNAL OIL LEAKS. *TT
Bulletin Number: 4633
REAR BRAKE DRAG OR EXCESSIVE WEAR ON REAR BRAKES. *TT
Bulletin Number: 5046
REPEAT MESSAGE REGARDING VEHICLES EXHIBITING A LACK OF POWER. *TT
Bulletin Number: 5047
REPEAT MESSAGE REGARDING A HARD START / NO START CONDITION. *TT
Bulletin Number: 5250
INFORMATION ON SUPER DUTY MODELS WITH 7.3L DIESEL ENGINES EXHIBITING ROUGH IDLE / MISS CONDITION. *TT
Bulletin Number: 5251
SOME SUPER DUTY VEHICLES WITH 7.3L DIT DIESEL ENGINES MAY EXHIBIT 4X4 LIGHTS ON, 4X4 INOPERATIVE AND / OR MULTIPLE GEM CODES. *TT
Bulletin Number: 5254
INFORMATION ON SUPER DUTY 7.3 DIT DIESEL ENGINE VEHICLES EXHIBITI LACK OF POWER. *TT
Bulletin Number: 5262
SERVICE INFORMATION FOR VEHICLES EXHIBITING STALL ON DECELERATION CONDITION. *TT
Bulletin Number: 5316
SOME SUPER DUTY 7.3L E4OD AND 7.3L 4R100 VEHICLES MAY EXHIBIT VARIOUS TRANSMISSION CONCERNS, INCLUDING STALL ON TRANSMISSION ENGAGEMENT AND / OR A BUZZ NOISE ON ENGAGEMENT. *TT
Bulletin Number: 96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
Bulletin Number: 962213
EXHAUST - EXHAUST LEAK AT EXHAUST MANIFOLDS - VEHICLES EQUIPPED WITH 7.0L OR 7.5L ENGINE. *TW
Bulletin Number: 96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
Bulletin Number: 96226
AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW
Bulletin Number: 962412
BRAKES - REAR PARKING BRAKE CABLE BINDS - VEHICLES BUILT BEFORE 8/20/96 - ALL CHASSIS CAB VEHICLES ARE EXCLUDED. *TW
Bulletin Number: 962418
TRANSMISSION - E40D - REVISED DESIGN FORWARD PLANET THRUST WASHER - SERVICE TIP. *TW
Bulletin Number: 96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
Bulletin Number: 96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
Bulletin Number: 962511
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 96252
LOCKS - REPLACE AND/OR REPAIR ANY LOCK COMPONENT - SERVICE TIP. *TW
Bulletin Number: 962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 962621
VIBRATION- DRIVELINE RESONANCE/VIBRATION BETWEEN 1400 AND 2000 RPM WITH CONVERTER CLUTCH ENGAGED DURING MEDIUM TO HEAVY THROTTLE CONDITIONS- VEHICLES WITH 7.3L DI TURBO ENGINE AND TRANSMISSION BUILT PRIOR TO 11/13/95 (5L13) TRANSMISSION- E4
Bulletin Number: 97050110621
PART NUMBER INFORMATION FOR THE USE OF A CHILD SEAT TETHER. *TW
Bulletin Number: 97090297187
SOME VEHICLES MAY STALL WHEN THE TRANSMISSION IS PLACED INTO GEAR. *YC
Bulletin Number: 971110972313
A NEW DESIGN TRANSMISSION CASE AND EXTENSION HOUSING HAS BEEN RELEASED. *YC
Bulletin Number: 97111097238
SUBJECT ON REAR VIBRATION/SHUDDER WHEN APPLYING BRAKES. *YC
Bulletin Number: 97113
AN ENGINE VIBRATION AND/OR "MOANING" NOISE AT 2600-3000 RPM MAY OCCUR ON SOME VEHICLES. *JD
Bulletin Number: 97214
ENGINE - 7.3L DIT - GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE - SERVICE TIP. *TW
Bulletin Number: 97215
DIAGNOSTIC GUIDES FOR OUT-OF-WARRANTY VEHICLES TO BE USED AS A MASTER COPY - DIAGNOSTIC GUIDES NO LONGER AVAILABLE FROM ADISTRA. *TW
Bulletin Number: 97216
LEAK - OIL LEAKAT ENGINE VALLEY PAN AND/OR HIGH PRESSURE OIL PUMP - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE. *TW
Bulletin Number: 97310
NOISE- "POPPING/CREAKING"- FRONT FRAME OR SUSPENSION BRACKETS- FRAME- "POPPING/CREAKING"- FASTENER REPLACEMENT. *JD
Bulletin Number: 9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD
Bulletin Number: 9747
FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD
Bulletin Number: 97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
Bulletin Number: 97618
LOW RPM- 7.3L DIT ENGINE FAILS TO START- CODE 340 STORED IN MEMORY AND/OR ENGINE FAILS TO ACHIEVE RATED SPEED FOR 2-3 MINUTES AFTER EXTENDED COLD SOAK- F-SERIES BUILT THROUGH 2/9/96 AND ALL ECONOLINES. *JD
Bulletin Number: 97627
NOISE- "RATCHETING"- FRONT AXLE- 4X4- SELF-ENGAGEMENT OF AUTOMATIC HUB LOCKS- F-250 AND F-350 OVER 8500# GVW. *JD
Bulletin Number: 97629
TRANSMISSION- E4OD- HARSH/DELAYED 2-3 UPSHIFTS- VEHICLES WITH 7.3L DIESEL AND 49-STATE CALIBRATION- F-SERIES BUILT THROUGH 2/3/97 AND ALL 1996 E-350. *JD
Bulletin Number: 9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
Bulletin Number: 9778
HEADLAMP- HEADLAMP HOUSING MELTS- AMBULANCE AND EMERGENCY VEHICLES ONLY. *JD
Bulletin Number: 9779
WIRING- AFTERMARKET WIRING ALTERATIONS- SERVICE TIP. *JD
Bulletin Number: 980307
VEHICLE STALLS/QUITS WHILE DRIVING. *AK
Bulletin Number: 980312
EXCESSIVE WHITE SMOKE. VERIFY GLOW PLUG OPERATION BY PERFORMING GLOW PLUG SYSTEM OPERATION CHECK ON THE HARD START/NO START DIAGNOSTIC SHEET. *TT
Bulletin Number: 980323
CONCERNS WITH EXTERNAL OIL LEAKS. *YC
Bulletin Number: 980325
COLD ENGINE UPPER KNOCK/TICK. *YC
Bulletin Number: 98113
SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT
Bulletin Number: 9811335
EXHIBITING A VIBRATION, NOISE OR GROUND OUT CONDITION WHEN TURNING OR UNDER LOAD. *TT
Bulletin Number: 9811346
SOME VEHICLES MAY EXPERIENCE AN INTERMITTENT STALL CONDITION AFTER A LONG DECELERATION WHEN USING THE M1 OR M2 GEAR ON THE E40D OR WHEN USING A LOWER GEAR WITH THE M50D FOR ENGINE BRAKING. *TT
Bulletin Number: 98115
INFORMATION REGARDING RANDOM HAIRLINE CRACKS, "STAR CRACKING" IN REAR SHEET MOLDING COMPOSITE (SMC) FENDERS - DUAL REAR VEHICLES OPERATING IN SEVERE DUTY CONDITIONS. *TT
Bulletin Number: 98119
CONDITIONS WITH ENGINE STALLING DURING LONG DECEL WHILE IN MANUAL 1 OR MANUAL 2 GEAR ON SOME VEHICLES. *TT
Bulletin Number: 98122
INFORMATION ON THE DEFROSTER PERFORMANCE ENHANCEMENT.
Bulletin Number: 98122
PERFORMANCE ENHANCEMENT FOR DEFROSTER. *TT
Bulletin Number: 98123
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 98151
MALFUNCTION INDICATOR LAMP FAILED. YD
Bulletin Number: 98156
EXHAUST LEAK AT EXHAUST MANIFOLDS--VEHICLE EQUIPPED WITH 7.0L 0R 7.5L ENGINE. *AK
Bulletin Number: 98158
FRONT END SHIMMY MAY OCCUR AT VARIOUS DRIVING SPEEDS AND IS USUALLY INDUCED WHEN HITTING BUMPS, SUCH AS LARGE POTHOLES OR ROUGH RAILROAD CROSSINGS. SHIMMY IS NOT ALWAYS VERIFIED DURING ROAD TEST. *AK
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 98168
TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 98205
EXHIBITING ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982313
SOME VEHICLES WITH A 7.3L DIRECT INJECTION (DI) TURBO DIESEL ENGINE, ONE OR MORE OF THE FOLLOWING CONCERNS MAY BE PRESENT: ROUGH IDLE, STALLING, HESITATION/ STUMBLE, LOSS / LACK OF POWER, POOR FUEL ECONOMY, AND EXCESSIVE OIL CONSUMPTION.
Bulletin Number: 982314
PREMATURE WEAR OF THE BELT TENSIONER MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982740
CONCERNS WITH HIGH PRESSURE OIL PUMPS ARE NOT SERVICEABLE. *YC
Bulletin Number: 983074
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT
Bulletin Number: 983564
EXPERIENCING A SQUEALING NOISE FROM THE FRONT BRAKES WHEN APPLYING THE BRAKES ON SOME VEHICLES. *TT
Bulletin Number: 98413
A GRABBING CONDITION AND / OR SQUEAL NOISE FROM THE REAR BRAKES DURING FIRST FEW BRAKE APPLICATIONS AFTER RAINFALL AND / OR WHILE BRAKES ARE COLD. *TT
Bulletin Number: 98414
EXPERIENCING AN ENGINE STALL CONDITION ON 1997 CALIFORNIA F SERIES 7.3L DIESEL E40D VEHICLES AFTER A LONG DECEL WHEN USING M1 GEAR FOR ENGINE BRAKING. *YC
Bulletin Number: 98419
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 98-4722
REPEAT MESSAGE, NO CHANGE- ROUGH IDLE/MISS. *AK
Bulletin Number: 98-4726
REPEAT MESSAGE, NO CHANGE: HARD START/ NO START. *AK
Bulletin Number: 98-4734
LACK OF POWER DUE TO FAILURE OF ENGINE TURBO BOOST
Bulletin Number: 98-4742
VEHICLE STALLS UPON ACCELERATION. *AK
Bulletin Number: 985042
REPEAT MESSAGE REGARDING VEHICLES EXHIBITING ROUGH IDLE / MISS CONDITION. *TT
Bulletin Number: 985058
SUBJECT REGARDING EXTERNAL OIL LEAKS - REPEAT MESSAGE. *TT
Bulletin Number: 985176
SOME TRUCKS WITH E40D AND CALIFORNIA CALIBRATION 7-90P-R10/11 MAY STALL DURING LONG DECEL CONDITIONS WHILE IN MANUAL 1 OR 2 GEAR. *TT
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
Bulletin Number: 985A25
A VIBRATION OR SHUDDER MAY BE FELT DURING BRAKING ON SOME VEHICLES. *YC
Bulletin Number: 985A27
LUBRICANT LEAKING FROM REAR AXLE SEAL CONTAMINATING BRAKE SHOES. *YC
Bulletin Number: 985A35
THE REAR PARKING BRAKE CABLES MAY BIND AND NOT ALLOW THE REAR BRAKE SHOES TO RETURN FULLY TO THE ANCHOR PINS AFTER THE PARKING BRAKE IS APPLIED. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 98810
SOME CUSTOMERS MAY REQUIRE A HEAVY DUTY 7-WAY TRAILER WIRING CONNECTOR SYSTEM WHEN THE VEHICLE IS EQUIPPED WITH A 4-WAY CONNECTOR. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99236
SUBJECT REGARDING 4R100 TRANSMISSION FLEXPLATE REPLACEMENT FOR VEHICLES WITH 7.3L DIESEL ENGINE. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: BC0053970201
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC0053972301
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC0256970201
A RUNNING CHANGE FOR THE 7.3L TO ALLOW BETTER DEFINITION ON CYLINDER CONTRIBUTION TESTS IN PROCESS. *JD
Bulletin Number: BC0321961101
POP/CLUNK FROM STEERING LINKAGE OVER BUMPS. *TW
Bulletin Number: BC0321970201
POP/CLUNK FROM STEERING LINKAGE OVER BUMPS. *JD
Bulletin Number: BC0321972301
POP/CLUNK FROM STEERING LINKAGE OVER BUMPS. *JD
Bulletin Number: BC0696961023
CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT
Bulletin Number: BC0750961017
SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT
Bulletin Number: BC0844961008
E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT
Bulletin Number: BC0854961007
REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT
Bulletin Number: BC0883961004
VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT
Bulletin Number: BC1015397020
VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC1020897230
AVAILABLITY OF THE SBDS "RED DISC" WITH IMPROVMENTS TO 7.3L/E40D 2-3 SHIFT QUALITY AND ENHANCED APCM FUNTIONING HAS BEEN DELAYED TO LATE FEBRUARY FORM THE ORIGINAL JANUARY 1997 DATE. *JD
Bulletin Number: BC2301970501
NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW
Bulletin Number: BC3130970221
DIESEL EXHAUST SMELL IN PASSENGER CABIN MAY BE DUE TO POOR CONNECTION AT THE INLET OR OUTLET TO/FROM THE TURBO. *TW
Bulletin Number: BC3171970217
UNEXPLAINED GLASS BREAKAGE OF THE LEFT FRONT DOOR. *TW
Bulletin Number: BC3212970213
CAMSHAFT POSITION SENSOR INFORMATION . *TW
Bulletin Number: BC3241970210
EXHAUST LEAKS OR NOISE AT THE JOINT BETWEEN THE Y-PIPE AND THE EXHAUST MANIFOLD. *TW
Bulletin Number: BC3287970206
THE CLUTCH MAY BE HARD TO DEPRESS DUE TO DUST/CONTAMINATION ENTERING THE SLAVE CYLINDER. *TW
Bulletin Number: BC3440972301
AVAILABLITY OF THE SBDS "RED DISC" WITH IMPROVEMENTS TO 7.3L/E40D 2-3 SHIFT QUALITY AND ENHANCED APCM FUNCTIONING HAS BEEN DELAYED. *JD
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC5201961001
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Bulletin Number: BPI9905
CUSTOMER MAY COMPLAIN THAT THE RAYBESTOS ELECTRONIC BRAKE CONTROLLER DOES NOT WORK, WORKS INCORRECTLY, WORKS INTERMITTENTLY, PULSES THE 4-WAY FLASHERS, AND / OR INTERFERS WITH ANTILOCK BRAKES OPERATION. *TT
1997 FORD F-350 SD
Bulletin Number: 982721
SOME VEHICLES MAY EXPERIENCE A POPPING / SQUEAKING NOISE IN THE STEERING COLUMN WHILE TURNING. *YC
1997 FORD F-450 SD
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 14455
OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT
Bulletin Number: 17571
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT
Bulletin Number: 982740
CONCERNS WITH HIGH PRESSURE OIL PUMPS ARE NOT SERVICEABLE. *YC
1997 FORD F47
Bulletin Number: 96226
AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW
Bulletin Number: 97310
NOISE- "POPPING/CREAKING"- FRONT FRAME OR SUSPENSION BRACKETS- FRAME- "POPPING/CREAKING"- FASTENER REPLACEMENT. *JD
Bulletin Number: 9747
FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
1997 FORD F-53
Bulletin Number: 4626
INFORMATION ON VEHICLES EXHIBITING AND O/D OFF LAMP FLASHING WITH DIAGNOSTIC TROUBLE CODE 62 / 628 / 1728. *TT
Bulletin Number: 962413
SUSPENSION - FRONT OR REAR - SIDE-TOSIDE LEVELING PROCEDURES AND ATTITUDE SERVICE KITS FOR F53 RV BASIC STRIPPED CHASSIS. *TW
Bulletin Number: 962414
STEERING - STEERING WHEEL ALIGNMENT - CLEAR VISION. *TW
Bulletin Number: 962418
TRANSMISSION - E40D - REVISED DESIGN FORWARD PLANET THRUST WASHER - SERVICE TIP. *TW
Bulletin Number: 97090297187
SOME VEHICLES MAY STALL WHEN THE TRANSMISSION IS PLACED INTO GEAR. *YC
Bulletin Number: 97515
SPEEDOMETER- SPEEDOMETER/ODOMETER INOPERATIVE/ERRATIC AND/OR HARSH TRANSMISSION SHIFTS- F-53 CLASS "A" F-SUPER DUTY MOTORHOME CHASSIS. *JD
1997 FORD F-550 SD
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 14455
OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT
Bulletin Number: 17571
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT
Bulletin Number: 982721
SOME VEHICLES MAY EXPERIENCE A POPPING / SQUEAKING NOISE IN THE STEERING COLUMN WHILE TURNING. *YC
Bulletin Number: 982740
CONCERNS WITH HIGH PRESSURE OIL PUMPS ARE NOT SERVICEABLE. *YC
1997 FORD F600
Bulletin Number: 01127
SOME VEHICLES EQUIPPED WITH 26 INCH DIAMETER FANS MAY EXHIBIT AN ENGINE OVERHEAT CONDITION. *TT
1997 FORD F700
Bulletin Number: 01127
SOME VEHICLES EQUIPPED WITH 26 INCH DIAMETER FANS MAY EXHIBIT AN ENGINE OVERHEAT CONDITION. *TT
Bulletin Number: 11817
SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT
Bulletin Number: 4709
SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT
Bulletin Number: 962213
EXHAUST - EXHAUST LEAK AT EXHAUST MANIFOLDS - VEHICLES EQUIPPED WITH 7.0L OR 7.5L ENGINE. *TW
Bulletin Number: 98156
EXHAUST LEAK AT EXHAUST MANIFOLDS--VEHICLE EQUIPPED WITH 7.0L 0R 7.5L ENGINE. *AK
Bulletin Number: 991311
CONDITIONS WITH POWER STEERING FLUID LEAKING FROM THE BRAKE PUMP RESERVOIR AT 90 DEGREE ELBOW ON SOME VEHICLES. *TT
1997 FORD F800
Bulletin Number: 01127
SOME VEHICLES EQUIPPED WITH 26 INCH DIAMETER FANS MAY EXHIBIT AN ENGINE OVERHEAT CONDITION. *TT
Bulletin Number: 11817
SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT
Bulletin Number: 4709
SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT
Bulletin Number: 4751
VEHICLE EXHIBITING SIGNS OF FRONT BRAKE HOSE NOT ALIGNED PROPERLY. *TT
Bulletin Number: 962213
EXHAUST - EXHAUST LEAK AT EXHAUST MANIFOLDS - VEHICLES EQUIPPED WITH 7.0L OR 7.5L ENGINE. *TW
Bulletin Number: 98156
EXHAUST LEAK AT EXHAUST MANIFOLDS--VEHICLE EQUIPPED WITH 7.0L 0R 7.5L ENGINE. *AK
Bulletin Number: 991311
CONDITIONS WITH POWER STEERING FLUID LEAKING FROM THE BRAKE PUMP RESERVOIR AT 90 DEGREE ELBOW ON SOME VEHICLES. *TT
1997 FORD F900
Bulletin Number: 991311
CONDITIONS WITH POWER STEERING FLUID LEAKING FROM THE BRAKE PUMP RESERVOIR AT 90 DEGREE ELBOW ON SOME VEHICLES. *TT
1997 FORD FIESTA
Bulletin Number: 12528
SOME VEHICLES MAY EXHIBIT HESITATION OR STUMBLE AT AROUND 2000 RPM DURING WARM UP. *TT
1997 FORD FORD
Bulletin Number: 011801
SUBJECT REGARDING INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *JG
Bulletin Number: 012112
CONCERNS WITH THROTTLE STICKING AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES ON VEHICLES BUILT 12/21/1997 THORUGH 7/15/1999. *TT
Bulletin Number: 13047
ENGINEERING IS INVESTIGATING HIGH MILEAGE SUSPENSION PART RETURN. *TT
Bulletin Number: 13458
SUBJECT REGARDING WHEEL VIBRATION DIAGNOSIS - SERVICE TIP. *TT
Bulletin Number: 5253
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXPERIENCE A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. *TT
Bulletin Number: 7434
SOME VEHICLES MAY EXHIBIT WHEEL / TIRE RELATED VIBRATION THAT IS DIFFICULT TO DIAGNOSE. *TT
Bulletin Number: 9705013528
DISCONNECTION WITH THE AIR BAG AND CLOCKSPRING THE SHORTING BARS SHORT THESE TERMINALS. *YC
Bulletin Number: 9705014116
NEW REAR MAIN SEAL TOOL HAS BEEN RELEASED. *YC
Bulletin Number: 9705018818
INFORMATION ON OPERATING THE ENGINE'S COOLANT TEMPERATURE GAUGE. *YC
Bulletin Number: 976011
INFORMATION SBTS / NGS FUNCTIONALITY ENHANCEMENT. *TT
Bulletin Number: 980321
INFORMATION REGARDING THE PATS KEY PROGRAMMING REGARDING PASSIVE ANTI-THEFT SYSTEM. *AK
Bulletin Number: 982035
FOR AVAILABILITY OF MAJOR ASSEMBLIES, PLEASE REFER TO THE EXCHANGE PROGRAM GUIDE. *TT
Bulletin Number: 98-3425
INFORMATION ON ON USING THE RELATIVE CAM TIMING TEST ON SBDS. *TT
Bulletin Number: 98-4718
ALL VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM--- REPEAT MESSAGE REVISED (SYMPTOM-PATS KEY PROGRAMMING). *AK
Bulletin Number: 985041
REPEAT MESSAGE REGARDING ALL VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM. *TT
Bulletin Number: 985074
SOME 7.3 DIT ENGINES MAY EXHIBIT A ENGINE MISS AFTER EXTENDED IDLING IN COLD TEMPS. *TT
Bulletin Number: 985177
SUBJECT REGARDING ALL 1996 THROUGH 1999 VEHICLES (EXCEPT ASPIRE, PROBE, AND VILLAGER) WITH EEC-V THAT REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT. *TT
Bulletin Number: 9912651
WHEN USING THE NGS WITH THE 5.0 SERVICE CARD ON SOME VEHICLES, THE HELP SELECTION HAS BEEN DELETED FROM THE INITIAL SCREEN. *TT
Bulletin Number: 99-4597
INFORMATION ON PROGRAMMING PCMS. *TT
Bulletin Number: 996103
INFORMATION ON REVISED NGS 5.0 HELP MENU SELECTION. *TT
Bulletin Number: 996765
ENGINEERING IS INVESTIGATING HIGH MILEAGE FIELD DURABILITY ON SHOCKS, BALL JOINTS, CONTROL ARMS, SPRINGS, STA-BAR LINKS, AND STRUTS ON VEHICLES WITH MORE THAN 36K MILES IN SERVICE. IF REPLACING ONE OF THESE COMPONENTS, ENGINEERING WOULD
Bulletin Number: BC0073961101
THE REAR MAIN SEAL REMOVAL TOOL LISTED IN THE SERVICE MANUAL FOR THE 3.0L 4V DURATEC AND 4.6L 4V CONTINENTAL ENGINES IS INCORRECT. *TW
Bulletin Number: BC0111970201
UNITS WITH CATALTYIC CONVERTER/MUFFLERS THAT OPERATE IN COLD WEATHER MAY EXHIBIT LOW POWER DUE TO A PLUGGED CATALYST. *JD
Bulletin Number: BC0845961001
CLARIFIED TECHNICAL INSTRUCTIONS FOR SAFETY RECALL - RCL/96S54 (ATTACHMENT III, DEALER LETTER). *TT
Bulletin Number: BC0846961001
INFORMATION ON PART NUMBER FOR THE ROTUNDA TOOL THAT IS STATED IN SAFETY RECALL RCL/96S48-RCL/96S99. *TT
Bulletin Number: BC1010597020
1995 AND LATER BUILT VEHICLES DO NOT REQUIRE UNDER-DOOR WEATHER STRIPS ENEN THOUGH ATTACHING HOLES FOR THE WEATHER STRIPS MAY OR MAY NOT BE PRESENT. *JD
Bulletin Number: BC1014397020
IGNITION PULSE WHEEL WITH TWO CRANKSHAFT KEY SLOTS- DURATEC ENGINES USE A BLUE PAINT STRIPE- KEY SLOT WITH ORANGE STRIPE. *JD
Bulletin Number: BC1032597020
SPARK PLUGS MAY EXHIBIT A LOW FREQUENCY CONCERN OF AN OPEN CIRCUIT CAUSED BY AN INTERNAL CRACK. *JD
Bulletin Number: BC105779705
NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL TO BE RELEASED IN 3RD QUARTER OF 1997. *TW
Bulletin Number: BC1661970201
REPAIR KIT BOX 4 IS AVAILABLE TO SERVICE 93 AND NEWER VEHICLES WHICH ARE NOT COVERED BY REPAIR KIT BOX 1, 2, & 3. *JD
Bulletin Number: BC5200961001
VEHICLES MAY EXPERIENCE UNEXPLAINED MIL LIGHT CODES &/OR IRREGULAR SHIFTING (A4LD). THE -12A581- (95-96) OR -12B637- (97) WIRE LOOM IS COMING INTO CONTACT W/ THE CENTER WIPER ACCESS PLATE LWR CTR. *TT
Bulletin Number: BC5220961001
INFORMATION ON SERVICING VEHICLES WITH FLUID LEAK FROM THE FRONT AXLE VENT. REVISED COVER PT# F6TZ-4033-BA. *TT
Bulletin Number: BC5221961001
REVISED HOSE PART# F6HZ-9J291-A HAS BEEN DEVELOPED TO REPLACE HOSE THAT SHOWS SIGNS OF DETERIORATION, CRACKS MAY APPEAR IN THE OUTER COVERING OF THE HOSE. *TT
Bulletin Number: BC9685961001
PARTS INFORMATION FOR REPLACING THE MAIN CONTROL. *TT
Bulletin Number: BC9705970201
VEHICLES WITH WATER IN THE ABS CONNECTOR (C1057), BLOW THE WATER AND/OR CORROSION OUT WITH COMPRESSED AIR. *JD
1997 FORD FORD TRUCK
Bulletin Number: 4751
VEHICLE EXHIBITING SIGNS OF FRONT BRAKE HOSE NOT ALIGNED PROPERLY. *TT
Bulletin Number: 982035
FOR AVAILABILITY OF MAJOR ASSEMBLIES, PLEASE REFER TO THE EXCHANGE PROGRAM GUIDE. *TT
Bulletin Number: 983302
THIS BULLETIN MENTIONS HOW SOME HUB O-RINGS MAY BE CUT DURING THE INSTALLATION OF THE WHEELS. *TT
Bulletin Number: BC0014961101
TRUCKS WITH 7.3L ENGINES WITH HARD STARTING CONCERN AND DTC OF 340, 341 OR 344 MAY HAVE A DAMAGED CMP SENSOR. *TW
Bulletin Number: BC0015961101
GLOW PLUG DIAGNOSTIC CHANGES. *TW
Bulletin Number: BC0141970201
VERIFY THE TRANSAXLE INSTALLED IN THE VEHICLE IS THE CORRECT MODEL AND MODEL YEAR FOR THE VEHICLE. *JD
Bulletin Number: BC0845961001
CLARIFIED TECHNICAL INSTRUCTIONS FOR SAFETY RECALL - RCL/96S54 (ATTACHMENT III, DEALER LETTER). *TT
Bulletin Number: BC0846961001
INFORMATION ON PART NUMBER FOR THE ROTUNDA TOOL THAT IS STATED IN SAFETY RECALL RCL/96S48-RCL/96S99. *TT
Bulletin Number: BC5200961001
VEHICLES MAY EXPERIENCE UNEXPLAINED MIL LIGHT CODES &/OR IRREGULAR SHIFTING (A4LD). THE -12A581- (95-96) OR -12B637- (97) WIRE LOOM IS COMING INTO CONTACT W/ THE CENTER WIPER ACCESS PLATE LWR CTR. *TT
Bulletin Number: BC5220961001
INFORMATION ON SERVICING VEHICLES WITH FLUID LEAK FROM THE FRONT AXLE VENT. REVISED COVER PT# F6TZ-4033-BA. *TT
Bulletin Number: BC5221961001
REVISED HOSE PART# F6HZ-9J291-A HAS BEEN DEVELOPED TO REPLACE HOSE THAT SHOWS SIGNS OF DETERIORATION, CRACKS MAY APPEAR IN THE OUTER COVERING OF THE HOSE. *TT
1997 FORD F SERIES
Bulletin Number: 01B77
OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT
Bulletin Number: 02169
SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE DEVELOPED FOR DIAGNOSING AND CORRECTING VEHICLE LEAN. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 03261
NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04217
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT
Bulletin Number: 11675
ROUGH IDLE, MISS AND VARIOUS OTHER DRIVEABILITY CONCERNS ON VEHICLES WITH 7.3L DIT ENGINE. THIS MAY BE RELATED TO INJECTOR BORE SCUFFING CAUSED BY FUEL QUALITY ISSUES. *TT
Bulletin Number: 11776
SOME VEHICLES WITH 7.3L DIT ENGINES MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
Bulletin Number: 11781
INFORMATION ON SETTING THE CHECK ENGINE LIGHT AND SETTING DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK). *TT
Bulletin Number: 12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
Bulletin Number: 12230
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12261
SUBJECT REGARDING ENGINE DIAGNOSTIC GUIDE FOR WARRANTY REIMBURSEMENT. *TT
Bulletin Number: 12298
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. *TT
Bulletin Number: 12556
SUBJECT REGARDING TECHNICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES. *TT
Bulletin Number: 12564
SUBJECT REGARDING PROPER OPERATION AND INTERPRETATION OF DUAL AIR PRESSURE GAUGE READINGS. *TT
Bulletin Number: 12743
EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT
Bulletin Number: 12744
SOME VEHICLES MAY RETREIEVE MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0351 AND / OR P0357 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT
Bulletin Number: 12767
EXHIBITING A VIBRATION THAT MAY BE INTERPRETED AS AN NVH CONDITION. *TT
Bulletin Number: 12798
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 12890
BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE THREAD. *TT
Bulletin Number: 13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
Bulletin Number: 13285
EXPERIENCING ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 13322
SOME VEHICLES MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 13331
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 13342
VEHICLES WITH 2.4L, 4.6L, AND 5.4L ENGINES MAY EXHIBIT AN A/C MOAN AT IDLE. *TT
Bulletin Number: 13832
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT
Bulletin Number: 14484
SOME CALIFORNIA 7.3L ENGINE EQUIPPED VEHICLES MAY EXHIBIT A BUCK / SURGE / JERK (ALSO KNOWN AS HITCHING) DURING HIGHWAY DRIVING AT SPEEDS 40 MPH OR GREATER WITH THE CRUISE CONTROL ENGAGED. *TT
Bulletin Number: 15225
SOME VEHICLES MAY EXHIBIT A DIFFICULT TO REMOVE WHEEL RIM CONDITION. *TT
Bulletin Number: 15355
SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT
Bulletin Number: 15373
SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES. *TT
Bulletin Number: 15397
SOME VEHICLES MAY EXHIBIT A CONDITION OF OIL CONTAMINATION IN COOLING SYSTEM. *TT
Bulletin Number: 15504
SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT
Bulletin Number: 15605
SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT
Bulletin Number: 15708
SOME VEHICLES MAY EXHIBIT WHEELS THAT SEIZE TO THE HUBS AND ARE DIFFICULT TO REMOVE DURING SERVICE. *TT
Bulletin Number: 15901
THIS BULLETIN STATES THAT SOME 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER OR LARGER KNOCK SENSOR THREADED HOLD THAN THE ONE IN THE ORIGINAL ENGINE ASSEMBLY. *TT
Bulletin Number: 16683
FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB
Bulletin Number: 4658
SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
Bulletin Number: 4664
THIS BULLETIN STATES THAT FOR CERTAIN VEHICLES IT IS NOT POSSIBLE TO SET THE CHECK ENGINE LIGHT AND SET DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK) IF A CUSTOMER REFUELS THE VEHICLE WITH THE ENGINE RUNNING. *
Bulletin Number: 5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
Bulletin Number: 5343
THIS BULLETIN STATES THAT REPLACEMENT UNDER WARRANTY OF CERTAIN SPECIFIED COMPONENTS ON ANY 7.3L DIT DIESEL VEHICLE, REQUIRES THAT THE REPLACED COMPONENT BE RETURNED WITH THE APPROPRIATE YEAR DIESEL ENGINE DIAGNOSTIC GUIDE FOR WARRANTY REIM
Bulletin Number: 5892
SUBJECT REGARDING TECHINICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES WITH GFI ALTERNATE FUEL SYSTEMS. *TT
Bulletin Number: 5899
CLARIFICATION PERTAINING TO THE DUAL AIR PRESSURE GAUGE FUNCTION. *TT
Bulletin Number: 6350
SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 6473
SOME MEDIUM TRUCKS PRODUCED AT KENTUCKY ASSEMBLY PLANT MAY EXHIBIT OIL LEAKING OUT OF THE TRANSMISSION SHIFT LEVER. *TT
Bulletin Number: 6505
BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE ON NATURAL GAS VEHICLES. *TT
Bulletin Number: 6585
SOME VEHICLES EQUIPPED WITH 7.3L DIT DIESEL ENGINES MAY DEVELOP A CRACKED FLEXPLATE. *TT
Bulletin Number: 6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
Bulletin Number: 7155
VEHICLES EQUIPPED WITH WINDSOR ENGINES ONLY MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT
Bulletin Number: 8058
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. **MR
Bulletin Number: 8058
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT
Bulletin Number: 962218
STARTER - STARTER DOES NOT ENGAGE AND/OR STARTER MAY CYCLE (ENGAGE-DISENGAGE-ENGAGE) WHILE CRANKING - VEHICLES EQUIPPED WITH AN FD ENGINE AND AN ALLISON MD3000 TRANSMISSION BUILT THROUGH 8/1/96, *TW
Bulletin Number: 962420
LACK OF POWER - ACCELERATOR CABLE DISLODGES FROM ACCELERATOR PEDAL - VEHICLES WITH 7.0L ENGINE - VEHICLES BUILT FROM 8/1/90 THROUGH 6/3/96. *TW
Bulletin Number: 96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
Bulletin Number: 962529
FEAD BELT - HIGH WEAR AND/OR COMES OFF THE DRIVE PULLEY - VEHICLES BUILT FROM 4/1/92 THROUGH 9/1/96 WITH FD1060 ENGINE. *TW
Bulletin Number: 97050110607
ENGINEERING IS INVESTIGATING CONCERNS OF THE REAR ABS LIGHT COMING ON WHEN THE IGNITION IS IN THE ON POSITION.
Bulletin Number: 97050110608
VEHICLES BUILT WITH 4R70W TRANSMISSIONS BEARING A PREFIX OF F7 MUST BE OVERHAULED OR REPLACED WITH A NEW ASSEMBLY AS NO FQR ASSEMBLIES ARE AVAILABLE. *TW
Bulletin Number: 97115
SERVICE MANUAL- POWERTRAIN CONTROL/EMISSIONS DIAGNOSIS (PC/ED) ON-BOARD DIAGNOSIS II (OBD II)- COVER PAGE REPLACEMENT TO INCLUDE 1997 VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD
Bulletin Number: 97117
HEATER- LACK OF HEAT IN PASSENGER COMPARTMENT- VEHICLES EQUIPPED WITH FD1060 ENGINE- COOLING SYSTEM- ENGINE DOES NOT REACH OPERATING TEMPERATURE- VEHICLES EQUIPPED WITH FD1060 ENGINE. *JD
Bulletin Number: 97118
ENGINE- FD1060 OR FD1460- HIGH VIBRATION AT LOW ENGINE RPM- VIBRATION- HIGH- AT LOW ENGINE RPM- VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD
Bulletin Number: 97315
NO START- STARTER WILL NOT TURN ENGINE OVER- VEHICLES WITH FD1060 ENGINE. *JD
Bulletin Number: 97411
FEAD BELT- HIGH WEAR AND/OR COMES OFF OF THE DRIVE PULLEY- VEHICLES BUILT FROM 4/1/92 THROUGH 6/1/96 WITH FD1060 ENGINE. *JD
Bulletin Number: 97517
ENGINE- DIESEL- FD1060 AND FD1460- WHITE SMOKE FROM EXHAUST- SERVICE TIP. *JD
Bulletin Number: 97630
HARD STARTING- POSSIBLE PLUGGED CATALYTIC CONVERTER/MUFFLER (CCM)- VEHICLES BUILT AFTER 11/29/93 EQUIPPED WITH 1994 EMISSION LEVEL FD1060 OR FD1460 DIESEL ENGINE. *JD
Bulletin Number: 9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
Bulletin Number: 97716
FUEL INJECTION PUMP- BOSCH- SERVICE INFORMATION FOR FD1060/1460 DIESEL ENGINES. *JD
Bulletin Number: 980301
EXPERIENCING ROUGH IDLE/MISS. *AK
Bulletin Number: 980302
SOME VEHICLES EXPERIENCING HARD START/ NO START. *YC
Bulletin Number: 980303
SYMPTOMS WITH LACK OF POWER. VERIFY ACTUAL ENGINE TURBO-BOOST AS OUTLINED ON THE DIAGNOSTIC SHEET. *AK
Bulletin Number: 980304
COMPLAINTS REGARDING THE FUEL ECONOMY. *YC
Bulletin Number: 980307
CONDITIONS WITH PRESSURE BEING HIGHER/LOWER THAN EXPECTED. *YC
Bulletin Number: 980323
CONCERNS WITH EXTERNAL OIL LEAKS. *YC
Bulletin Number: 9811337
SUBJECT REGARDING CHANGES TO THE MIDLINE RADIO. *TT
Bulletin Number: 9811339
INFORMATION ON THE REVISED FUEL INJECTOR O-RING KIT. *TT
Bulletin Number: 981511
HARD TO START VEHICLE AT COLD TEMPERATURE.*AK
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 98217
EXPERIENCING FLUID ON BRAKE SHOES AND REAR AXLE SEAL LEAK. *YC
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982544
SOME MOTOR HOME VEHICLES EQUIPPED WITH E4OD TRANSMISSIONS MAY EXPERIENCE HYDRAULIC SYSTEM MALFUNCTIONS AFTER REPLACING THE TRANSMISSION CASE. *YC
Bulletin Number: 982691
CONCERNS OF ENGINE CHECKLIGHT ON AND DTC P1506 ( IDLE AIR CONTROL OVER SPEED ERROR ) AND/OR FAST IDLE. *YC
Bulletin Number: 982733
VEHICLES WITH THE E4OD ARE ADDED TO THE FQR ( FORD QUALITY RENEWAL ) ASSEMBLY PROGRAM. *YC
Bulletin Number: 983106
INFORMATION REGARDING ENGINE ASSEMBLIES BEING ADDED TO THE FQR (FORD QUALITY RENEWAL) PROGRAM. *TT
Bulletin Number: 983170
CONCERNS WITH CODES P0500, P0503, P1501 OR P1503 WHICH MAY BE CAUSED MY A LOOSE SPEEDOMETER DRIVE GEAR. *TT
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 983592
SUBJECT PERTAINING TO RADIO INOPERATIVE CONDITIONS. *TT
Bulletin Number: 985072
SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 98614
THE COOLANT TEMPERATURE GAUGE READING MAY BE INACCURATE. *YC
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99133
SUBJECT REGARDING INTERMITTENT ELECTRICAL ISSUES, SUCH AS DASH LIGHTS FLASHING WHEN THE TURN SIGNAL IS ACTIVATED. *TT
Bulletin Number: 991413
VEHICLES EQUIPPED WITH FD1060 OR FD1460 MIDRANGE DIESEL ENGINES MAY EXPERIENCE A VIBRATION OR BUZZ THROUGH THE THROTTLE PEDAL. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99205
SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 996130
INFORMATION ON THE IMPROVED LOWER INTAKE MANIFOLD SIDE GASKETS. *TT
Bulletin Number: 9983
EXPERIENCING VARIOUS INTERMITTENT CONCERNS, SUCH AS LOW COOLANT LEVEL SENSOR LEAKING COOLANT INTO WIRING HARNESS. *TT
Bulletin Number: 99B29
SOME VEHICLES MAY EXPERIENCE ENGINE COOLANT LEAKS AT THE ENGINE FRONT COVER GASKET. OWNER NOTIFICATION PROGRAM PROVIDING REPLACEMENT OF THE ENGINE FRONT COVER GASKET. *TT
Bulletin Number: 99B29#1
INFORMATION REGARDING REPLACMENT OF ENGINE FRONT COVER GASKET. **MR
Bulletin Number: 99E03
EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT
Bulletin Number: BC0053970201
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC0054961101
VEHICLES MAY HAVE BEEN BUILT WITH A 240 SECOND MISFIRE DELAY. *TW
Bulletin Number: BC0255970201
4X4 FRONT AXLE IS LEAKING THROUGH THE VENT TUBE. *JD
Bulletin Number: BC0256970201
A RUNNING CHANGE FOR THE 7.3L TO ALLOW BETTER DEFINITION ON CYLINDER CONTRIBUTION TESTS IN PROCESS. *JD
Bulletin Number: BC0322961101
HARD STARTING WITH DTC'S P0341, P0344. *TW
Bulletin Number: BC0322970201
1600-1900 RPM MOAN/DRONE WHILE DRIVING. *JD
Bulletin Number: BC0322972301
1600-1900 RPM MOAN/DRONE WHILE DRIVING. *JD
Bulletin Number: BC0601961101
MANY MANUAL TRANSMISSIONS THAT ARE REPLACED/REPAIRED UNDER WARRANTY AND RETURNED TO THE WPRC SHOW SIGNS OF IMPROPER/LACK OF MAINTENANCE OR MISDIAGNOSIS. *TW
Bulletin Number: BC0602961101
INSTRUCTIONS ON SECURING SPARE TIRE TO UNDERBODY OF VEHICLE. *TW
Bulletin Number: BC0604961101
NEW FUEL HOSE TO REPLACE THE HOSE USED IN THE LOW PRESSURE FUEL RETURN SYSTEM - THE CURRENT HOSE MAY SHOW SIGHN OF DETERIOATION OR CRACKS. *TW
Bulletin Number: BC0693961023
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Bulletin Number: BC0694961023
INFORMATION FOR RECREATIONAL TOWING (ALL WHEELS ON THE GROUND). *TT
Bulletin Number: BC0696961023
CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT
Bulletin Number: BC0750961017
SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT
Bulletin Number: BC0782961014
CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT
Bulletin Number: BC0844961008
E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT
Bulletin Number: BC0854961007
REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT
Bulletin Number: BC0883961004
VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT
Bulletin Number: BC0884961004
FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT
Bulletin Number: BC1011097020
OVERHEATING ON 4.6/5.4L VEHICLES MAY BE CAUSED BY POSSIBLE WATER PUMP CONCERN DUE TO FREE SPINNING WATER PUMP IMPELLER.
Bulletin Number: BC1017697230
CHECK ENGINE LIGHT ON WITH DTC P0455 IN CONTINUOUS MEMORY ON VEHICLE APPLICATIONS. *JD
Bulletin Number: BC1018797230
DIAGNOSE THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD
Bulletin Number: BC1022497230
INOPERATIVE FLOOR MODE CONCERNS MAY BE DUE TO THE PANEL/FLOOR DOOR VACUUM ACTUATOR LINKAGE DISCONNECTING FROM THE DOOR PIVOT. *JD
Bulletin Number: BC1026797230
FD 1060 ENGINE HARD START OR NO START IN EXTREMELY COLD AMBIENTS. *JD
Bulletin Number: BC1029097020
ILLUMINATION OF THE CHECK ENGINE LIGHT MAY OCCUR. *JD
Bulletin Number: BC1029697020
FD 1060 ENGINES THE LOWER COOLANT PIPE, BASE PART NUMBER -8291- WAS CHANGED. *JD
Bulletin Number: BC1033797020
CONDENSATE FORMING ON THE OUTSIDE OF THE EVAPORATOR. *JD
Bulletin Number: BC2232970501
ENGINEERING IS INVESTIGATING CONDITIONS THAT CAUSE THE ABS LIGHT (RABS) TO ILLUMINATE. *TW
Bulletin Number: BC2233970501
1997 F SERIES TRUCKS EQUIPPED WITH TRANSMISSIONS BEARING F7 PREFIXES DO NOT HAVE ASSEMBLIES AVAILABLE -REPAIR BY OVERHAUL OR USE NEW ASSEMBLY. *TW
Bulletin Number: BC2308970501
NEW VOLUME CONTROL/ON-OFF SWITCH. *TW
Bulletin Number: BC2312970501
NEW THROTTLE CABLE TO REDUCE VIBRATION ATTHE ACCELERATOR PEDAL. *TW
Bulletin Number: BC2370970501
CUSTOMER COMPLAINTS OF POOR HEATER PERFORMANCE. *TW
Bulletin Number: BC3070970227
CONCERNS OF CONDENSATE FORMING ON OUTSIDE OF EVAPORATOR CASE. *TW
Bulletin Number: BC3071970227
DIAGNOSTICS FOR POOR HEATER PERFORMANCE CONCERNS. *TW
Bulletin Number: BC3172970217
CLUNK/GRUNT NOISE ON 5.4L F-SERIES 3.55 LIMITED SLIP AXLES. *TW
Bulletin Number: BC3230970211
CHECK ENGINE LIGHT - DTC P1450 - CHECK FOR MOLD FLASHING CAUSING A FLOW RESTRICTION IN THE 90 DEGREE ELBOW EVAP LINE COMING OUT OF THE CANNISTER ASSEMBLY AND GOING TO THE FUEL TANK . *TW
Bulletin Number: BC3360972301
INOPERATIVE FLOOR MODE CONCERNS MAY BE DUE TO THE PANEL/FLOOR DOOR VACUUM ACTUATOR LINKAGE DISCONNECTING FROM THE DOOR PIVOT. *JD
Bulletin Number: BC3505972301
THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC5201961001
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Bulletin Number: TB-08-258
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE
1997 FORD F SERIES (LIGHT)
Bulletin Number: 12069
INFORMATION REGARDING A NEW SERVICE PART THAT HAS BEEN RELEASED FOR THE LICENSE PLATE LIGHT CIRCIUT WHICH WILL REDUCE THE COST OF REPAIR. *MJS
Bulletin Number: 12227
FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 15517
SUBJECT REGARDING EXAGGERATED ENGINE BRAKING ON DECELERATION. *YD
Bulletin Number: 962528
BRAKES - AIR COMPRESSOR/AIR PUMP SUPPORT BRACKET BROKEN - VEHICLES WITH 7.0L ENGINE - ENGINE - 7.0L - ACCESSORY DRIVE BELT ROLL - NOISE - RATTLE - AIR BRAKE COMPRESSOR/AIR PUMP SUPPORT BRACKET CRACKED- VEHICLES WITH 7.0L ENGINE. *TW
Bulletin Number: 99-6172
INFORMATION REGARDING STEERING WHEEL LEATHER REPAIR. *TT
Bulletin Number: BC0602961101
INSTRUCTIONS ON SECURING SPARE TIRE TO UNDERBODY OF VEHICLE. *TW
Bulletin Number: BC0693961023
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Bulletin Number: BC0694961023
INFORMATION FOR RECREATIONAL TOWING (ALL WHEELS ON THE GROUND). *TT
Bulletin Number: BC0696961023
CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT
Bulletin Number: BC0750961017
SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT
Bulletin Number: BC0782961014
CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT
Bulletin Number: BC0844961008
E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT
Bulletin Number: BC0854961007
REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT
Bulletin Number: BC0883961004
VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT
Bulletin Number: BC0884961004
FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC5201961001
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Bulletin Number: ONP96B05
OWNER NOTIFICATION PROGRAM 96B05 - SPARE TIRE AND WHEEL ASSEMBLY REPLACEMENT FOR CERTAIN 1997 F150 TRUCKS WITH OFF-ROAD OPTION. *TW
1997 FORD F SERIES (MEDIUM)
Bulletin Number: 13736
SOME VEHICLES MAY EXPERIENCE OIL LEAKING FROM THE SHIFT LEVER. *MJS
Bulletin Number: 97218
SUSPENSION - NOISE FROM FRONT SPRING REAR HANGER - REVISED REAR SPRING HANGER INSULATOR PAD - VEHICLES EQUIPPED WITH 6000, 7000 OR 9000 LB AXLES BUILT THROUGH 10/1/97. *TW
Bulletin Number: BC0693961023
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Bulletin Number: BC0696961023
CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT
Bulletin Number: BC0750961017
SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT
Bulletin Number: BC0782961014
CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT
Bulletin Number: BC0844961008
E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT
Bulletin Number: BC0854961007
REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT
Bulletin Number: BC0883961004
VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT
Bulletin Number: BC3236970211
FD 1060 ENGINES - NEW DESIGN STARTER MOTOR TO ALLEVIATE HARD START/NO START CONCERNS IN COLD AMBIENTS. *TW
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC5201961001
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
1997 FORD F SUPER DUTY
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 0038
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 03211
LOSS OF POWER AND MALFUNCTION INDICATOR LAMP MAY ALSO ILLUMINATE WITH DIAGNOSTIC TROUBLE CODES 128 AND 845 OR P0236 AND P0238 STORED IN MEMORY. *TT
Bulletin Number: 032120
7.3L DIT GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE - SERVICE TIP. *TT
Bulletin Number: 032121
A HIGH NUMBER OF HIGH PRESSURE REXROTH PUMPS AND INJECTION PRESSURE REGULATORS (IPR) ARE BEING REPLACED DUE TO OIL LEAKING, WHEN ALL THAT IS REQUIRED IS A NEW GASKET OR SEAL ON EITHER THE PUMP OR IPR. *TT
Bulletin Number: 032123
LOW RPM, NO START, RUNS POORLY, STALL. 7.3L DIT ENGINE. *TT
Bulletin Number: 032125
AFTERMARKET WIRING ALTERATIONS - SERVICE TIP. *TT
Bulletin Number: 03213
A NO-START OR REDUCED POWER CONDITION MAY OCCUR INTERMITTENTLY. *TT
Bulletin Number: 032145
EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT
Bulletin Number: 04266
A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP. *TT
Bulletin Number: 13412
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT
Bulletin Number: 15871
SOME VEHICLES MAY EXHIBIT INTERFERENCE AND / OR STATIC IN THE LAND-MOBILE RADIO. *TT
Bulletin Number: 16697
EXHAUST AIR RUSH NOISE AND LOWER POWER. *TT *JB
Bulletin Number: 4614
INFORMATION ON VEHICLES EXHIBITING ROUGH IDLE / MISS. *TT
Bulletin Number: 4616
BRIEF INFORMATION VEHICLES EXHIBITING HARD START / NO START CONDITION. *TT
Bulletin Number: 4617
BRIEF INFORMATION ON VEHICLES EXHIBITING LACK OF POWER CONDITION. *TT
Bulletin Number: 4625
BRIEF INFORMATION ON VEHICLES EXHIBITING A STALL ON DECELERATION CONDITION. *TT
Bulletin Number: 4626
INFORMATION ON VEHICLES EXHIBITING AND O/D OFF LAMP FLASHING WITH DIAGNOSTIC TROUBLE CODE 62 / 628 / 1728. *TT
Bulletin Number: 4629
BRIEF INFORMATION CONCERN VEHICLES EXHBITING EXTERNAL OIL LEAKS. *TT
Bulletin Number: 4633
REAR BRAKE DRAG OR EXCESSIVE WEAR ON REAR BRAKES. *TT
Bulletin Number: 96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
Bulletin Number: 962213
EXHAUST - EXHAUST LEAK AT EXHAUST MANIFOLDS - VEHICLES EQUIPPED WITH 7.0L OR 7.5L ENGINE. *TW
Bulletin Number: 96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
Bulletin Number: 962413
SUSPENSION - FRONT OR REAR - SIDE-TOSIDE LEVELING PROCEDURES AND ATTITUDE SERVICE KITS FOR F53 RV BASIC STRIPPED CHASSIS. *TW
Bulletin Number: 962418
TRANSMISSION - E40D - REVISED DESIGN FORWARD PLANET THRUST WASHER - SERVICE TIP. *TW
Bulletin Number: 96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
Bulletin Number: 962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 96B95
OWNER NOTIFICATION PROGRAM 96B95 - ENGINE COOLING SYSTEM RADIATOR REPLACEMENTON CERTAIN 1997 F SUPER DUTY MOTORHOME STRIPPED CHASSIS. *TW
Bulletin Number: 97050110621
PART NUMBER INFORMATION FOR THE USE OF A CHILD SEAT TETHER. *TW
Bulletin Number: 971110972313
A NEW DESIGN TRANSMISSION CASE AND EXTENSION HOUSING HAS BEEN RELEASED. *YC
Bulletin Number: 97214
ENGINE - 7.3L DIT - GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE - SERVICE TIP. *TW
Bulletin Number: 97215
DIAGNOSTIC GUIDES FOR OUT-OF-WARRANTY VEHICLES TO BE USED AS A MASTER COPY - DIAGNOSTIC GUIDES NO LONGER AVAILABLE FROM ADISTRA. *TW
Bulletin Number: 97216
LEAK - OIL LEAKAT ENGINE VALLEY PAN AND/OR HIGH PRESSURE OIL PUMP - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE. *TW
Bulletin Number: 97310
NOISE- "POPPING/CREAKING"- FRONT FRAME OR SUSPENSION BRACKETS- FRAME- "POPPING/CREAKING"- FASTENER REPLACEMENT. *JD
Bulletin Number: 9747
FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD
Bulletin Number: 97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
Bulletin Number: 97617
STEERING- HIGH EFFORT DURING HIGHWAY DRIVING- F SUPER DUTY MOTORHOME CHASSIS VEHICLES BUILT FROM 7/1/93 THROUGH 8/9/96. *JD
Bulletin Number: 97618
LOW RPM- 7.3L DIT ENGINE FAILS TO START- CODE 340 STORED IN MEMORY AND/OR ENGINE FAILS TO ACHIEVE RATED SPEED FOR 2-3 MINUTES AFTER EXTENDED COLD SOAK- F-SERIES BUILT THROUGH 2/9/96 AND ALL ECONOLINES. *JD
Bulletin Number: 97619
FUEL PUMP- AVAILABILITY OF NEW STYLE FUEL PUMP AND SENDER- F SUPER DUTY MOTORHOME CHASSIS- SERVICE TIP. *JD
Bulletin Number: 9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
Bulletin Number: 9778
HEADLAMP- HEADLAMP HOUSING MELTS- AMBULANCE AND EMERGENCY VEHICLES ONLY. *JD
Bulletin Number: 9779
WIRING- AFTERMARKET WIRING ALTERATIONS- SERVICE TIP. *JD
Bulletin Number: 98123
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT
Bulletin Number: 98156
EXHAUST LEAK AT EXHAUST MANIFOLDS--VEHICLE EQUIPPED WITH 7.0L 0R 7.5L ENGINE. *AK
Bulletin Number: 98168
TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 982119
SOME VEHICLES MAY EXHIBIT ERRATIC 4-3 SHIFT HUNTING WHILE ASCENDING A GRADE AND/OR NO 3-4 UPSHIFT AFTER CRESTING A GRADE. *YC
Bulletin Number: 982120
STEERING WHEEL ALIGNMENT- VEHICLES WITH MOTORHOME CHASSIS.
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982314
PREMATURE WEAR OF THE BELT TENSIONER MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 982321
SERVICE PROCEDURES AND VEHICLE ATTITUDE SERVICE KITS HAVE BEEN DEVELOPED TO ASSIST CUSTOMERS AND VEHICLE MODIFIERS WITH SIDE -TO- SIDE LEVELING CONCERNS RELATED TO WEIGHT DISTRIBUTION. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 98419
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 98-4722
REPEAT MESSAGE, NO CHANGE- ROUGH IDLE/MISS. *AK
Bulletin Number: 98-4726
REPEAT MESSAGE, NO CHANGE: HARD START/ NO START. *AK
Bulletin Number: 98-4734
LACK OF POWER DUE TO FAILURE OF ENGINE TURBO BOOST
Bulletin Number: 98-4742
VEHICLE STALLS UPON ACCELERATION. *AK
Bulletin Number: 985185
COLD START ENGINE NOISE
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99236
SUBJECT REGARDING 4R100 TRANSMISSION FLEXPLATE REPLACEMENT FOR VEHICLES WITH 7.3L DIESEL ENGINE. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: BC0053972301
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD
Bulletin Number: BC0256970201
A RUNNING CHANGE FOR THE 7.3L TO ALLOW BETTER DEFINITION ON CYLINDER CONTRIBUTION TESTS IN PROCESS. *JD
Bulletin Number: BC0693961023
INVESTIGATING 7.3L IRREGULAR IDLE. *TT
Bulletin Number: BC0821961010
CONCERNS W/ THE SPEEDOMETER/ODOMETER INDICATION PLUS TRANSMISSION SHIFT CONCERNS DUE TO FAILURE OF THE SPEEDOMETER DRIVE GEAR (E8TZ-2N598-A) LOCATED WITHIN THE TRANSMISSION MOUNTED PARKING BRAKE ASSY. *TT
Bulletin Number: BC0844961008
E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT
Bulletin Number: BC2297970501
WHEN THE AIR CLEANER IS BEING REPLACED, THE DRAIN MECHANISM ON THE BOTTOM OF THE AIR CLEANER CASE IS TO BE CLEANED OF OBSTRUCTIONS. *TW
Bulletin Number: BC3130970221
DIESEL EXHAUST SMELL IN PASSENGER CABIN MAY BE DUE TO POOR CONNECTION AT THE INLET OR OUTLET TO/FROM THE TURBO. *TW
Bulletin Number: BC3212970213
CAMSHAFT POSITION SENSOR INFORMATION . *TW
Bulletin Number: BC3241970210
EXHAUST LEAKS OR NOISE AT THE JOINT BETWEEN THE Y-PIPE AND THE EXHAUST MANIFOLD. *TW
Bulletin Number: BC5166961001
CONCERNS W/ THE SPEEDOMETER/ODOMETER INDICATION PLUS TRANS SHIFT CONCERNS DUE TO A FAILURE OF THE SPEEDOMETER DRIVE GEAR (E8TZ-2N598-A) LOCATED WITHIN THE TRANS MOUNTED PARKING BRAKE ASSY. *TT
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
1997 FORD GRAND MARQUIS
Bulletin Number: 12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
Bulletin Number: 12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
Bulletin Number: 12178
INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. *MJS
Bulletin Number: 98163
LOCKS FAILED. YD
1997 FORD LOUISVILLE
Bulletin Number: 02169
SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE DEVELOPED FOR DIAGNOSING AND CORRECTING VEHICLE LEAN. *TT
Bulletin Number: 11755
SOME VEHICLES WITH THE CATERPILLAR 3306 ENGINE MAY EXHIBIT THE LOWER RADIATOR HOSE BEING DISCONNECTED FROM THE ENGINE WATER PUMP OUTLET. *TT
Bulletin Number: 11800
SOME MODELS EQUIPPED WITH A 5.9L (FD1060) ENGINE MAY EXHIBIT A CRACKED ENGINE OIL DIPSTICK TUBE NEAR THE ENGINE PORT. *TT
Bulletin Number: 4687
SOME VEHICLES EQUIPPED WITH A 5.9L (FD1060) ENGINE MAY EXHIBIT A CRACKED ENGINE OIL DIPSTICK TUBE NEAR THE ENGINE PORT. *TT
Bulletin Number: 962216
STEP PLATE - FUEL TANK STEP PLATE VIBRATES - VEHICLES BUILT THROUGH 10/1/96 EQUIPPED WITH 70 AND/OR 120 GALLON REAR-MOUNTED CYLINDRICAL FUEL TANKS WITH TANK-MOUNTED STEP PLATE. *TW
Bulletin Number: 962527
WINDNOISE - TOP CORNERS OF DRIVER AND PASSENGER DOORS - VEHICLES BUILT THROUGH 8/96. *TW
Bulletin Number: 97010510638
THE VERTICAL EXHAUST HEAT SHIELD MAY EXHIBIT CRACKING AROUND ITS MOUNTING BOLT HOLE. *YC
Bulletin Number: 97050110609
VEHICLES EQUIPPED WITH THE FD 1460 ENGINE MAY EXHIBIT REAR ENGINE SUPPORT BRACKET ATTACHING BOLTS LOSSENING. *TW
Bulletin Number: 97050110623
NEW DESIGN FOR THE GRILL MOUNTED BUG/DIRT SCREEN TO ALLEVIATE PROBLEM OF SCREENS RUBBING ON POWER STEERING COOLER. *TW
Bulletin Number: 97050110624
NEW DESIGN FOR GRILL MOUNTED BUG/DIRT SCREEN TO ALLEVIATE PROBLEM OF SCREEN RUBBING AGAINST POWER STEERING COOLER. *TW
Bulletin Number: 970902971813
UNDER CERTAIN CONDITIONS, ROAD SPLASH AND SPRAY MAY BUILD UP ON THE CAB SIDE WINDOWS. *YC
Bulletin Number: 970902971815
SOME VEHICLES FAN CLUTCH MAY CYCLE ON WHEN ELECTRICAL ACCESSORIES, SUCH AS TURN SIGNALS, HEADLAMPS, ETC. ARE ACTIVATED. *YC
Bulletin Number: 970902971816
THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY WEAR AND/OR COME OFF ON SOME VEHICLES EQUIPPED WITH A DETROIT DIESEL ENGINE AND AIR CONDITIONING. *YC
Bulletin Number: 970902971817
SOME ELECTRONICALLY CONTROLLED DIESEL ENGINES CAN BE MODIFIED TO INCREASE ENGINE OUTPUT BY ALTERING THE ORIGINAL ENGINE MANAGEMENT SYSTEM. *YC
Bulletin Number: 97117
HEATER- LACK OF HEAT IN PASSENGER COMPARTMENT- VEHICLES EQUIPPED WITH FD1060 ENGINE- COOLING SYSTEM- ENGINE DOES NOT REACH OPERATING TEMPERATURE- VEHICLES EQUIPPED WITH FD1060 ENGINE. *JD
Bulletin Number: 97119
NOISE- AIR LEAK FROM BEHIND INSTRUMENT- PANEL- VEHICLES BUILT THROUGH 10/21/96. *JD
Bulletin Number: 97217
DOORS - BATTERY ACCESS DOORS MAY COME LOOSE - NEW PART AVAILABILITY - VEHICLES BUILT THROUGH 9-96. *TW
Bulletin Number: 97412
COOLING SYSTEM- ENGINE COOLING FAN CRACKS AT CENTER HUB. *JD
Bulletin Number: 97517
ENGINE- DIESEL- FD1060 AND FD1460- WHITE SMOKE FROM EXHAUST- SERVICE TIP. *JD
Bulletin Number: 97518
FRONT END ACCESSORY DRIVE BELT (FEAD)- FEAD BELT MAY WEAR AND/OR COME OFF- VEHICLES EQUIPPED WITH FD1460 ENGINE BUILT THROUGH 12/96. *JD
Bulletin Number: 97630
HARD STARTING- POSSIBLE PLUGGED CATALYTIC CONVERTER/MUFFLER (CCM)- VEHICLES BUILT AFTER 11/29/93 EQUIPPED WITH 1994 EMISSION LEVEL FD1060 OR FD1460 DIESEL ENGINE. *JD
Bulletin Number: 97715
SUN VISOR- OPTIONAL ROOF-MOUNTED SUN VISOR VIBRATES AT HIGHWAY SPEEDS. *JD
Bulletin Number: 97716
FUEL INJECTION PUMP- BOSCH- SERVICE INFORMATION FOR FD1060/1460 DIESEL ENGINES. *JD
Bulletin Number: 97717
WIRING- WIRE HARNESS GROUND- INTERMITTENT OR OPEN. *JD
Bulletin Number: 9811333
ENGINEERING IS INVESTIGATING CONDITIONS ON THE HOOD SPRING CONTACTING THE HOOD CAUSING DAMAGE TO THE HOOD AND / OR INSULATION. *TT
Bulletin Number: 9811468
SOME MODELS WITH CAT C10/C12 ENGINES MAY EXHIBIT CRACKS IN THE ENGINE FRONT COVER, NEAR THE FAN HUB PULLEY SUPPORT MOUNTING CONTAC STUDS. *TT
Bulletin Number: 98157
FRONT ENGINE COVER CRACKS. YD
Bulletin Number: 98201
INTERMITTENT ELECTRICAL ISSUES, SUCH AS DASH LIGHTS FLASHING WHEN THE TURN SIGNAL IS ACTIVATED MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 98202
THE POWER DISTRIBUTION BOX COVER IS NOW AVAILABLE. *YC
Bulletin Number: 982022
DELCO-REMY HAS MADE AVAILABLE A REVISED GENERATOR FOR SERVICE. *YC
Bulletin Number: 982023
HINGES AND HINGE SPRINGS ARE NOW AVAILABLE FOR SERVICE FOR THE OPTIONAL READY LINE ACCESS DOOR, BUTTERFLY DOORS OR TRANSVERSE ACCESS DOORS. *YC
Bulletin Number: 982115
A NEW SERVICE PARTS RELEASED. *YC
Bulletin Number: 982116
THE LOWER RADITTOR HOSE IS BEING PULLED OFF AT THE ENGINE WATER PUMP ON SOME VEHICLES. *YC
Bulletin Number: 982118
A NOISE HEARD DURING DRIVELINE TORQUE.
Bulletin Number: 982323
THE MESSAGE CENTER MAY DISPLAY FALSE INFORMATION / ERRORS FROMTHE ANTI-LOCK BRAKE SYSTEM ( ABS). *YC
Bulletin Number: 98237
SOME VEHICLES EXPERIENCE HEATER SUPPLY TUBES THAT MAY CRACK AND/ OR LEAK COOLANT. *YC
Bulletin Number: 98243
CONCERNS REGARDING THE INSTRUMENT PANEL PLATE CRACKS AT PARKING BRAKE VALVE. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982520
SOME VEHICLES EQUIPPED WITH FRAME-MOUNTED VERTICAL MUFFLER SUPPORTS MAY EXHIBIT A CRACK ALONG THE PIPE BEND. *YC
Bulletin Number: 98257
CONCERNS WITH THE FRONT END ACCESSORY DRIVE BELT ( FEAD )-FEAD BELT MAY WEAR AND/OR COME OFF. *YC
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 98424
CONDITION WITH TIRES BEING LOWER THAN EXPECTED TIRE LIFE. *YC
Bulletin Number: 98425
DIAGNOSTIC INFORMATIN AND WIRING SCHEMATICS FOR BOTH THE HORTON AND KYSOR ENGINE COOLING FAN CLUTCHES. *YC
Bulletin Number: 98518
THE OIL LEVEL INDICATOR MAY BE DIFFICULT TO INSTALL AND/OR WHEN INSTALLED MAY CONTACT THE CRAKSHAFT ON SOME VEHICLES. *YC
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 98711
INFORMATION ON AVAILABILITY OF REVISED COOLANT LEVEL SENSOR. *YC
Bulletin Number: 99102
INFORMATION REGARDING HIGH FLOOR HEAT DURING IDLE WITH PTO IN OPERATION. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99205
SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE. *TT
Bulletin Number: 9944
PROCEDURES ON REPAIRING BROKEN RADIATOR COOLANT SUPPLY TANK VENT HOSE NIPPLES. *TT
Bulletin Number: BC0191970201
VEHICLE ELECTRICAL SYSTEM, SEVERAL MEGAFUSES ARE USED. NOW HAS A NEW PLASTIC COVER. *JD
Bulletin Number: BC0193970201
REVISED FAN ASSEMBLIES FOR PREMIUM DIESEL ENGINES ARE NOW AVAILABLE. *JD
Bulletin Number: BC0200970201
DASH MOUNTED AIR VALVE ASSEMBLIES, BASE PART #4484, MAY LEAK AIR. NEW VALVE PART. *JD
Bulletin Number: BC0205970201
VEHICLES EQUIPPED WITH THE CUMMINS ELECTRONIC ENGINE THE TACHOMETER MAY BE INOPERATIVE OR ERRATIC. *JD
Bulletin Number: BC0323961101
TACHOMETER INOPERATIVE. *TW
Bulletin Number: BC0323970201
TACHOMETER INOPERATIVE. *JD
Bulletin Number: BC0323972301
TACHOMETER INOPERATIVE. *JD
Bulletin Number: BC0480961113
REPLACEMENT LEVELING VALVE EXTENTION ROD FOR HENDRICKSON AIR-RIDE SUSPENSION. *TW
Bulletin Number: BC0756961017
INFORMATION WHEN TROUBLESHOOTING THE SPEEDOMETER & TACHOMETER. *TT
Bulletin Number: BC0831961009
BATTERY ACCESS PANEL MAY BECOME LOOSE. *TT
Bulletin Number: BC0840961008
COOLANT TEMP GAUGE MAY READ ON THE HIGH OR HOT SIDE OF NORMAL, CAUSED BY LOCATION OF COOLANT TEMP SENSOR. *TT
Bulletin Number: BC1009097020
VEHICLES EQUIPPED WITH THE CUMMINS ELECTRONIC ENGINE THE TACHOMETER MAY BE INOPEATIVE OR ERRATIC. *JD
Bulletin Number: BC1018797230
DIAGNOSE THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD
Bulletin Number: BC1022997230
IF ONE OF THE FOLLOWING SYMPTOMS IS REPROTED ON A VEHICLE EQUIPPED WITH AN ELECTRONIC ENGINE PLEASE CONTACT FORD HEAVY TRUCKS: INTERMITTENT SPEEDOMETER OR SPEED CONTROL FUNCTIONS. *JD
Bulletin Number: BC1023097230
POOR OR INADEQUATE CAB HEAT ON VEHICLES WITH FD 1060 MAY BE DUE TO MISROUTED HEATER SYSTEM COMPONENTS. *JD
Bulletin Number: BC1026897020
THE DIPSTICK RUBBING AGAINST THE ENGINE CRANKSHAFT. *JD
Bulletin Number: BC1031997020
VEHICLES EQUIPPED WITH THE HENDRICKSON AIR SUSPENSION, IT MAY BE DIFFICULT TO MAINTAIN THE CORRECT VEHICLE RIDE HEIGHT DUE TO THE CURRENT MOUNTING OF THE AIR LEVELING VALVE. *JD
Bulletin Number: BC2234970501
VEHICLES MAY EXHIBIT REAR ENGINE SUPPORT BRACKET ATTATCHING BOLTS LOOSENING. *TW
Bulletin Number: BC2394970501
THE AIR OPERATED COOLING FAN MAYU RUN CONTINUOUSLY IF THE ENGINE ECM FAN CONTROL PARAMETERS ARE SET INCORRECTLY. *TW
Bulletin Number: BC2444970501
VEHICLES EQUIPPED WITH CUMMINS M-11 AND N-14 SELECT PLUS ENGINES MAY EXHIBIT THE AIR OPERATED COOLING FAN RUNNING CONTINUOUSLY IF THE ENGINE ECM FAN CONTROL PARAMETERS ARE SET INCORRECTLY. *TW
Bulletin Number: BC3093970225
A/C COMPRESSOR DRIVE BELT OR ALTERNATOR DRIVE BELT ROLLING OFF DRIVE PULLEYS. *TW
Bulletin Number: BC3157970219
FEAD BELT MAY OR ROLL OFF - VEHICLES EQUIPPED WITH FD 1460 ENGINE. *TW
Bulletin Number: BC3163970218
VEHICLES EQUIPPED WITH HENDRICKSON HAS SUSPENSION - MAY BE DIFFICULT TO MAINTAIN CORRECT VEHICLE RIDE HEIGHT. *TW
Bulletin Number: BC3200970214
A SCRAPING NOISE MAY BE HEARD FROM THE LOWER CAB TO SLEEPER CONNECTION POINT. *TW
Bulletin Number: BC3202970214
VEHICLES EQUIPPED WITH POWER STEERING AND A BUG/DIRT SCREEN - THE SCREEN MAY CONTACT THE POWER STEERING COOLER ON THE PASSENGER SIDE CAUSING A NOISE CONCERN AND OVER TIME, MAY WEAR A HOLE IN THE POWER STEERING COOLER, RESULTING IN A FLUID L
Bulletin Number: BC3222970212
CONCERN WITH LOWER ROOF AIR DEFLECTOR SUPPORT BRACKETS. *TW
Bulletin Number: BC3223970212
VEHICLES EQUIPPED WITH DETROIT DIESEL ENGINES MAY EXPERIENCE A CONCERN WITH ENGINE WARNING LAMPS COMING ON INTERMITTENTLY. *TW
Bulletin Number: BC3235970211
FD 1060 ENGINES - DIPSTICK RUBBING AGAINST CRANKSHAFT. *TW
Bulletin Number: BC3244970210
FD 1460 ENGINES - NON-FUNCTIONING AIR INTAKE HEATERS - ENSURE THAT THE DIAGNOSTIC SWITCH IS IN OFF POSITION. *TW
Bulletin Number: BC3275970207
INOPERATIVE HORN OR HORN OPERATES EVEN THOUGH NOT PUSHED. *TW
Bulletin Number: BC3278970207
AIR CONDITIONING COMPRESSOR BELT MAY COME OFF DRIVE PULLY. *TW
Bulletin Number: BC3350972301
ENGINE DERATE (REDUCTION IN ENGINE-POWER) POSSIBLY INTERMITTENT- INTERMITTEN SPEEDOMETER OR SPEED CONTROL FUNCTION. *JD
Bulletin Number: BC3351972301
POOR OR INADEQUATE CAB HEAT ON VEHICLE WITH FD 1060, MAY BE DUE TO MISROUTED HEATER SYSTEM COMPONENTS. *JD
Bulletin Number: BC3505972301
THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD
Bulletin Number: BC5189961001
INFORMATION ON TROUBLESHOOTING THE SPEEDOMETER & TACHOMETER. *TT
1997 FORD L SERIES
Bulletin Number: 02169
SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE DEVELOPED FOR DIAGNOSING AND CORRECTING VEHICLE LEAN. *TT
Bulletin Number: 12116
INFORMATION ON SERVICING THE AIR CLEANER ELEMENT ON ALL 1995- 1996-1997 L-SERIES EQUIPPED WITH CAT 3306 ENGINES. *MJS
Bulletin Number: 962217
ENGINE - WILL NOT ACCELERATE ABOVE IDLE SPEED - VEHICLES EQUIPPED WITH CUMMINS M11, N14 OR DETROIT DIESEL SERIES 60 ENGINE. *TW
Bulletin Number: 962218
STARTER - STARTER DOES NOT ENGAGE AND/OR STARTER MAY CYCLE (ENGAGE-DISENGAGE-ENGAGE) WHILE CRANKING - VEHICLES EQUIPPED WITH AN FD ENGINE AND AN ALLISON MD3000 TRANSMISSION BUILT THROUGH 8/1/96, *TW
Bulletin Number: 96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
Bulletin Number: 970902971817
SOME ELECTRONICALLY CONTROLLED DIESEL ENGINES CAN BE MODIFIED TO INCREASE ENGINE OUTPUT BY ALTERING THE ORIGINAL ENGINE MANAGEMENT SYSTEM. *YC
Bulletin Number: 97115
SERVICE MANUAL- POWERTRAIN CONTROL/EMISSIONS DIAGNOSIS (PC/ED) ON-BOARD DIAGNOSIS II (OBD II)- COVER PAGE REPLACEMENT TO INCLUDE 1997 VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD
Bulletin Number: 97117
HEATER- LACK OF HEAT IN PASSENGER COMPARTMENT- VEHICLES EQUIPPED WITH FD1060 ENGINE- COOLING SYSTEM- ENGINE DOES NOT REACH OPERATING TEMPERATURE- VEHICLES EQUIPPED WITH FD1060 ENGINE. *JD
Bulletin Number: 97118
ENGINE- FD1060 OR FD1460- HIGH VIBRATION AT LOW ENGINE RPM- VIBRATION- HIGH- AT LOW ENGINE RPM- VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD
Bulletin Number: 97315
NO START- STARTER WILL NOT TURN ENGINE OVER- VEHICLES WITH FD1060 ENGINE. *JD
Bulletin Number: 97411
FEAD BELT- HIGH WEAR AND/OR COMES OFF OF THE DRIVE PULLEY- VEHICLES BUILT FROM 4/1/92 THROUGH 6/1/96 WITH FD1060 ENGINE. *JD
Bulletin Number: 97412
COOLING SYSTEM- ENGINE COOLING FAN CRACKS AT CENTER HUB. *JD
Bulletin Number: 97517
ENGINE- DIESEL- FD1060 AND FD1460- WHITE SMOKE FROM EXHAUST- SERVICE TIP. *JD
Bulletin Number: 97630
HARD STARTING- POSSIBLE PLUGGED CATALYTIC CONVERTER/MUFFLER (CCM)- VEHICLES BUILT AFTER 11/29/93 EQUIPPED WITH 1994 EMISSION LEVEL FD1060 OR FD1460 DIESEL ENGINE. *JD
Bulletin Number: 97716
FUEL INJECTION PUMP- BOSCH- SERVICE INFORMATION FOR FD1060/1460 DIESEL ENGINES. *JD
Bulletin Number: 98214
CONCERNS OF AIR CLEANER COVER MAY RUB A HOLE IN THE HOOD AT THE FRONT EDGE OF THE AIR CLEANER INLET " WAGON WHEEL " ON SOME VEHICLES. *YC
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 991413
VEHICLES EQUIPPED WITH FD1060 OR FD1460 MIDRANGE DIESEL ENGINES MAY EXPERIENCE A VIBRATION OR BUZZ THROUGH THE THROTTLE PEDAL. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99205
SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE. *TT
Bulletin Number: BC0018961101
ON L SERIES EQUIPPED WITH CUSH-N-AIR SEATS, THE DRIVER MAY EXPERIENCE A SIDE TO SIDE MOVEMENT OR WOBBLE OF THE SEAT DUE TO INADEQUATE WELDS. *TW
Bulletin Number: BC0193970201
REVISED FAN ASSEMBLIES FOR PREMIUM DIESEL ENGINES ARE NOW AVAILABLE. *JD
Bulletin Number: BC0465961115
DRIVER MAY EXPERIENCE A SIDE TO SIDE MOVEMENT OR WOBBLE OF THE SEAT. *TW
Bulletin Number: BC0480961113
REPLACEMENT LEVELING VALVE EXTENTION ROD FOR HENDRICKSON AIR-RIDE SUSPENSION. *TW
Bulletin Number: BC0601961101
MANY MANUAL TRANSMISSIONS THAT ARE REPLACED/REPAIRED UNDER WARRANTY AND RETURNED TO THE WPRC SHOW SIGNS OF IMPROPER/LACK OF MAINTENANCE OR MISDIAGNOSIS. *TW
Bulletin Number: BC0604961101
NEW FUEL HOSE TO REPLACE THE HOSE USED IN THE LOW PRESSURE FUEL RETURN SYSTEM - THE CURRENT HOSE MAY SHOW SIGHN OF DETERIOATION OR CRACKS. *TW
Bulletin Number: BC0813961011
THROTTLE POSITION SENSOR &/OR IDLE VALIDATION SWITCH FAILS, IN MAY GENERATE ECM SERVICE CODES OR DRIVEABILITY CONCERNS. A REVISED ONE PIECE SENSOR & SWITCH IS NOW AVAILABLE. *TT
Bulletin Number: BC1018797230
DIAGNOSE THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD
Bulletin Number: BC2312970501
NEW THROTTLE CABLE TO REDUCE VIBRATION ATTHE ACCELERATOR PEDAL. *TW
Bulletin Number: BC3201970214
HENDRICKSON AIR RIDE SUSPENSION WITH TRANSVERSE MOUNTED TORQUE RODS- THE FLAT WASHERS USED ON THE ROD TO AXLE ATTATCHING BOLT MAY DEFORM. *TW
Bulletin Number: BC3236970211
FD 1060 ENGINES - NEW DESIGN STARTER MOTOR TO ALLEVIATE HARD START/NO START CONCERNS IN COLD AMBIENTS. *TW
Bulletin Number: BC3505972301
THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD
1997 FORD L SERIES (HEAVY)
Bulletin Number: BC0813961011
THROTTLE POSITION SENSOR &/OR IDLE VALIDATION SWITCH FAILS, IN MAY GENERATE ECM SERVICE CODES OR DRIVEABILITY CONCERNS. A REVISED ONE PIECE SENSOR & SWITCH IS NOW AVAILABLE. *TT
1997 FORD LTD
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC9666961001
2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT
1997 FORD MOTOR HOME
Bulletin Number: 16683
FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB
1997 FORD MOUNTAINEER
Bulletin Number: 00M11
INFORMATION REGARDING FRONT SWAY BAR LINK . *YH
Bulletin Number: 13745
SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS
Bulletin Number: 13752
SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *MJS
Bulletin Number: 7918
FRONT AXLE PINION LIL SEAL LEAKS.
Bulletin Number: 981617
FLOOR MAT INSTALLATION PROCEDURE SERVICE TIP. YD
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 98165
EVAPORATOR CORE FAILED, CAUSING THE AIR CONDITIONER TO DRIP ON TO PASSENGER FLOOR. YD
Bulletin Number: RCDNN-00V402-817
This recall action involves replacement of the front stabilizer bar links in certain 1995 through 1997 model year Explorer and Mountaineer vehicles. Under certain conditions, predominantly in cold weather areas, a front stabilizer bar
1997 FORD MUSTANG
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 00212
SOME VEHICLES MAY EXHIBIT A HOOD THAT IS HARD TO CLOSE. *JB
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 00241
SOME VEHICLES MAY EXHIBIT A VIBRATION THAT MAY BE HEARD OF FELT AT THE CLUTCH PEDAL BETWEEN IDLE AND 2300 RPM, AND GOES AWAY WHEN DEPRESSING THE CLUTCH AT LEAST 25MM. *TT
Bulletin Number: 00S37S1
SUBJECT REGARDING PARKING BRAKE CONTROL ASSEMBLY MODIFICATION. *TT
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 01235
SOME VEHICLES EQUIPPED WITH THE T45 MANUAL TRANSMISSION MAY EXHIBIT A CONDITION OF BEING STUCK IN REVERSE, DIFFICULT TO SHIFT INTO REVERSE OR MAY POP OUT OF REVERSE. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 0162
VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH
Bulletin Number: 0222
SOME VEHICLES MAY EXHIBIT AN INTAKE MANIFOLD CROSSOVER (FIRST RUNNER) COOLANT SEEPAGE CONDITION. *TT
Bulletin Number: 02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 03261
NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 05N04
EXTENDED COVERAGE PROGRAM 05N04 - EXTENDED COVERAGE FOR COMPOSITE INTAKE MANIFOLD. THIS PROGRAM IS BEING PROVIDED AS A SETTLEMENT TO A CLASS ACTION LAWSUIT. THE TERMS OF THE SETTLEMENT EXTEND THE COVERAGE OF THE ALL-COMPOSITE INTAKE MANIF
Bulletin Number: 07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
Bulletin Number: 11530
WHEN DIAGNOSING CRANK / NO START ON CERTAIN VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT (PATS) CHECK THE CUSTOMERS KEY RING FOR ANY MAGNETIC OBJECTS LIKE THE MOBILE SPEEDPASS KEY WHICH MAY AFFECT THE SIGNAL TRANSMISSION BETWEEN THE PATS KEY A
Bulletin Number: 11804
SUBJECT REGARDING THE SUBWOOFER ENCLOSURE ON COUPES WITH THE MACH 460 AUDIO SYSTEM. *TT
Bulletin Number: 12073
VEHICLES WITH FEDERAL EMISSION EQUIPPED 1998, MAY EXHIBIT A FUEL SMELL IN THE PASSENGER COMPARTMENT AT TIMES. *MJS
Bulletin Number: 12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
Bulletin Number: 12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
Bulletin Number: 12178
INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. *MJS
Bulletin Number: 12195
SOME VEHICLES MAY EXHIBIT A DRIVER AND / OR PASSENGER SIDE DOOR WINDOW THAT TRAVELS BEYOND THE UPSTOP AND EXITS THE GLASS RUN. *TT
Bulletin Number: 12298
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. *TT
Bulletin Number: 12523
SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LIGHT ILLUMINATED ACCOMPANIED WITH OBD-II CODE P0340 SET IN THE PCM MEMORY. *TT
Bulletin Number: 12725
SOME VEHICLES MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT
Bulletin Number: 12742
SOME VEHICLES WITH MANUAL TRANSMISSION EQUIPPED CONVERTIBLES MAY EXHIBIT A BODY VIBRATION / SHAKE. *TT
Bulletin Number: 12771
SOME VEHICLES WITH A MANUAL TRANSMISSION MAY EXHIBIT A FEAD BELT CONCERN (FRONT END ACCESSORY DRIVE). *TT
Bulletin Number: 12899
INFORMATION ON POWER SEAT SWITCH REPLACEMENT. *TT
Bulletin Number: 13061
SOME VEHICLES MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT TOSS. *TT
Bulletin Number: 13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
Bulletin Number: 13186
INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS
Bulletin Number: 13240
INFORMATION REGARDING VIBRATION/EXTENSION HOUSING BUSHING. *MJS
Bulletin Number: 13428
SOME CONVERTIBLES MAY EXHIBIT A RATTLE NOISE FROMTHE DOOR WEDGE WHEN DRIVING ON ROUGH ROADS. *TT
Bulletin Number: 14149
INFORMATION ON CASTER ADJUSTMENT WHEN PERFORMING A FRONT END ALIGNMENT. *TT
Bulletin Number: 14520
INFORMATION PERTAINING TO 4.6L 4V PULLEY INSTRUCTIONS. *TT
Bulletin Number: 14520
SUBJECT REGARDING INSTALLATION OF CRANKSHAFT PULLEY TORQUE SPECIFICATION. *TT
Bulletin Number: 15067
SOME VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION MAY EXHIBIT A POWERTRAIN NOISE DESCRIBED AS A BRIEF ROAR, HOOT OR GROAN BETWEN 2500 - 3500 RPM WHEN THE CLUTCH PEDAL IS HALF WAY DOWN, DURING SHIFTING OR WHEN DEPRESSING AND RELEASING THE CL
Bulletin Number: 15158
SOME VEHICLES MAY EXHIBIT A FEAD BELT JUMP-OFF TOSS. *YH
Bulletin Number: 15178
SOME VEHICLES EXHIBIT THE DOOR GLASS POPPING OFF TRACK. *YH
Bulletin Number: 15205
SOME VEHICLES MAY EXHIBIT THE DOOR GLASS COMING OFF OF THE WINDOW TRACK. *TT
Bulletin Number: 15702
SUBJECT REGARDING SPEED CONTROL LAMP. *TT
Bulletin Number: 17868
INTERMITTENT LOSS OF POWER OR CRANK NO START - POSSIBLE PATS LAMP FLASHING AND DIAGNOSTIC TROUBLE CODES (DTCS) U1147 AND/OR U1262. *TT
Bulletin Number: 4608
SOME VEHICLES MAY EXPERIENCE PASSENGER AND / OR DRIVER SIDE FRONT WINDOW(S) THAT DO NOT ROLL PROPERLY. *TT
Bulletin Number: 4696
SUBJECT REGARDING THE SUBWOOFER ENCLOSURE ON COUPES WITH THE MACH 460 AUDIO SYSTEM. *TT
Bulletin Number: 5031
SOME VEHICLES AND CERTAIN FEDERAL EMISSION EQUIPPED VEHICLES MAY EXHIBIT A FUEL SMELL IN THE PASSENGER COMPARTMENT AT TIMES. *TT
Bulletin Number: 5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
Bulletin Number: 5240
SOME VEHICLES MAY EXHIBIT A DRIVER AND / OR PASSENGER SIDE DOOR WINDOW THAT TRAVELS BEYOND THE UPSTOP AND EXITS THE GLASS RUN. *TT
Bulletin Number: 5847
SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LIGHT ILLUMINATED ACCOMPANIED WITH OBD-II CODE P0340 SET IN THE PCM MEMORY. *TT
Bulletin Number: 6242
EXPERIENCING A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE. *TT
Bulletin Number: 6314
SOME VEHICLES WITH MANUAL TRANSMISSION MAY EXHIBIT A FED BELT CONCERN. *TT
Bulletin Number: 6512
SOME VEHICLES MAY EXHIBIT SOME NORMAL SERVICE CONCERNS WITH POWER SEAT OPERATION. *TT
Bulletin Number: 6996
INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT
Bulletin Number: 6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
Bulletin Number: 7854
ABS DIAGNOSTIC TROUBLE CODES(DTCS) CAN ONLY BE RETRIEVED USING SUPER STARII TESTER OR THE FLASH OUT PROCEDURE BY GROUNDING OUT DIAGNOSTIC CIRCUIT AT TEST CONNECTOR.
Bulletin Number: 8485
INFORMATION REGARDING FREE FLOOR MAT EXCHANGE. **MR
Bulletin Number: 870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
Bulletin Number: 96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
Bulletin Number: 96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
Bulletin Number: 96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
Bulletin Number: 96226
AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW
Bulletin Number: 96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
Bulletin Number: 96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
Bulletin Number: 962511
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 96253
INTERIOR TRIM - CENTER CONSOLE - AVAILABILITY OF GAP HIDER FOR CENTER CONSOLE - VEHICLES BUILT FROM 6/1/96. *TW
Bulletin Number: 962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 96268
BLOWER MOTOR - INTERMITTENT OR INOPERATIVE - TEMPERATURES AT OR BELOW 0 DEGREES C (32 DEGREES F). *TW
Bulletin Number: 97111097234
VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC
Bulletin Number: 9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD
Bulletin Number: 9751
INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD
Bulletin Number: 97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
Bulletin Number: 97610
BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD
Bulletin Number: 9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
Bulletin Number: 9773
VIBRATION- SHUDDER OR VIBRATION UNDER LIGHT TO MODERATE ACCELERATION ABOVE 56 KM/H (35 MPH) WHILE IN 3RD OR 4TH GEAR- VEHICLES EQUIPPED WITH AODE OR 4R70W TRANSMISSION. *JD
Bulletin Number: 97M91
INFORMATION REGARDING ADDITIONAL COVERAGE FOR INTAKE MANIFOLD MALFUNCTIONS. *TT
Bulletin Number: 980308
VEHICLES WITH T45 MANUAL TRANSMISSIONS MAY JUMP OUT OF GEAR. *TT
Bulletin Number: 98110
SUBJECT REGARDING PASSIVE ANTI THEFT SYSTEM (PATS) DIAGNOSTIC SERVICE TIPS. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 982018
THE FRONT END ACCESSORY DRIVE ( FEAD ) BELT MAY BECOME BROKEN OR FRAYED AND / OR DETACH FROM ( OR ROLL OFF OF) THE ENGINE. *YC
Bulletin Number: 98222
EXPERIENCING VIBRATION/ NOISE FELT IN CLUTCH PEDAL WHEN LIGHTLY TOUCHING CLUTCH PEDAL. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98241
DIAGNOSTIC SERVICE TIPS ON PASSIVE ANTI THEFT SYSTEM ( PATS ). *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982464
CONCERNS WITH VEHICLES WITH A T-45 TRANSMISSION MAY SHIFT FROM 4TH TO NEUTRAL WHEN THE CLUTCH IS RELEASED. *YC
Bulletin Number: 98253
CONCERNS WITH THE FRONT WINDOW MAY TRAVEL BEYOND THE UPSTOP AND EXIT THE GLASS RUN ON SOME VEHICLES. *YC
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 982734
SOME VEHICLES MAY EXHIBIT PARTIAL OR NO OPERATION OF THE POWER SEAT WHEN USING THE SEAT SWITCH. *YC
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 983107
BRIEF INFORMATION REGARDING ENGINES BEING ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *TT
Bulletin Number: 983108
EFFECTIVE MARCH 2, 1998M3.8L ENGINE ASSEMBLY IS ADDED TO FQR(FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *AK
Bulletin Number: 983294
SOME VEHICLES MAY HAVE AN EXCESSIVE AMOUNT OF SHIFT LEVER VIBRATION WHILE DRIVING IN 3RD GEAR. *TT
Bulletin Number: 983566
INFORMATION REGARDING PROGRAMMING / DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT
Bulletin Number: 983566
INFORMATION ON PROGRAMMING / DIAGNOSING ANY PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9874
A NEW SILICONE GASKET AND SEALANT. *YC
Bulletin Number: 9887
EXPERIENCING A TORQUE CONVERTER CLUTCH SHUDDER OR VIBRATION. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 99101
CONCERNS WITH ROAD NOISE MAY BE HEARD FROM THE REAR WHEEL AREA AS WELL AS DUST INTRUSION INTO THE LUGGAGE COMPARTMENT AND / OR EVIDENCE OF A WATER LEAK IN THE LUGGAGE COMPARTMENT. *TT
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 9912717
SOME VEHICLES MAY EXHIBIT VIBRATION / SHAKE WHEN DRIVEN ON SMOOTH ROADS AT SPPED AROUND 62 MPH / 100 KPH. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 99131
CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: 9913125
SONE POLICE VEHICLES AND OTHER VEHICLES WITH 4R70W MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99185
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99195
SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99207
SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99225
CONCERNS WITH THE CONVERTIBLE TOP BOOT MAY FIT IMPROPERLY OR BE DIFFICULT TO INSTALL ON SOME VEHICLES DUE TO THE TOP NOT FOLDING DOWN ALL THE WAY INTO THE WELL. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT
Bulletin Number: 9946
CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT
Bulletin Number: 996795
SUBJECT REGARDING VEHICLES EQUIPPED WITH 4.6L ENGINE REGARDLESS OF TRANSMISSION, MAY EXHIBIT A (FRONT END ACCESSORY DRIVE (FEAD) BELT- BELT NOISE, DAMAGE, AND / OR BELT COMES OFF). *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: 9996
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT
Bulletin Number: 99B29
SOME VEHICLES MAY EXPERIENCE ENGINE COOLANT LEAKS AT THE ENGINE FRONT COVER GASKET. OWNER NOTIFICATION PROGRAM PROVIDING REPLACEMENT OF THE ENGINE FRONT COVER GASKET. *TT
Bulletin Number: 99B29#1
INFORMATION REGARDING REPLACMENT OF ENGINE FRONT COVER GASKET. **MR
Bulletin Number: BC0040970201
CURRENTLY INVESTIGATING CRUISE CONTROL SERVO ISSUES AND WOULD LIKE YOUR FEEDBACK. *JD
Bulletin Number: BC0079961101
THE ABS SENSOR RESISTANCE READINGS PROVIDED IN THE 1997 MUSTANG SERVICE MANUAL ARE INCORRECT. *TW
Bulletin Number: BC0250970201
ABS SENSOR RESISTANCE READINGS PROVIDED IN THE 1997 MUSTANG SERVICE MANUAL ARE INCORRECT. *JD
Bulletin Number: BC0314961101
SERPENTINE ACCESSORY DRIVE BELT ROLL-OFF OR LOSS OF ALIGNMENT. *TW
Bulletin Number: BC0351961126
FORD IMPROVEMENT PROGRAM REQUEST FOR INFORMATION ON OIL LEAK AT THE REAR CRANKSHAFT OIL SEAL. *TW
Bulletin Number: BC0351970201
ENGINE OIL LEAK AT THE REAR CRANKSHAFT OIL SEAL. *JD
Bulletin Number: BC0351972301
AN ENGINE OIL LEAK AT THE REAR CRANKSHAFT OIL SEAL. *JD
Bulletin Number: BC0407961115
INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED PARTS. *TW
Bulletin Number: BC0490961112
INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED COMPONENT. *TW
Bulletin Number: BC0696961023
CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT
Bulletin Number: BC0810961011
VEHICLES EQUIPPED W/ AN AODE OR 4R70W TRANS HAS A CONCERN OF SHUDDER FROM THE TRANSMISSION TORQUE CONVERTER CLUTCH IN 3RD OR 4TH GEAR OR DURING 3-4 SHIFT. *TT
Bulletin Number: BC1015697020
CRUISE CONTROL SERVO ISSUES AND WOULD LIKE FEEDBACK. *JD
Bulletin Number: BC1024497230
THE PASSIVE ANTI THEFT SYSTEM IS NOW STANDARD ON ALL 1997 MUSTANGS. *JD
Bulletin Number: BC1025097230
PASSIVE ANTI-THEFT SYSTEM. *JD
Bulletin Number: BC1031397020
VEHICLES BUILT BETWEEN 8/15/96 AND 11/4/96 MAY EXPERIENCE A CONCERN WITH THE COOLING FAN TO THE ELECTRIC MOTOR RETAINER COMING LOOSE OR SEPARTING. *JD
Bulletin Number: BC105879705
INSTRUCTIONS FOR ADJUSTING THE CASTER WHEN PERFORMING A FRONT END ALIGNMENT. *TW
Bulletin Number: BC105949705
VEHICLES MAY ENCOUNTER DIFFICULTY GETTING THE SHIFT LEVER INTO GEAR WHEN THE CLUTCH DISC IS HOT. *TW
Bulletin Number: BC2292970501
INSTRUCTIONS ON HOW TO ADJUST THE CASTER WHEN PERFORMING A FRONT END ALIGNMENT. *TW
Bulletin Number: BC2299970501
VEHICLES BUILT PRIOR TO 3/1/97 MAY ENCOUNTER DIFFICULTY GETTING THE SHIFT LEVER INTO GEAR WHEN THE CLUTCH DISC IS HOT. *TW
Bulletin Number: BC2392970501
VEHICLES EQUIPPED WITH A T-45 TRANSMISSION MAY EXHIBIT A SECOND GEAR TO NEUTRAL MOVEMENT CONDITION. *TW
Bulletin Number: BC3133970221
CONCERN OF COOLING FAN TO ELECTRIC MOTOR COMING LOOSE. *TW
Bulletin Number: BC3221970212
VIBRATION/NOISE FROM THE CLUTCH PEDAL. *TW
Bulletin Number: BC3272970207
VEHICLES ARE EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) - VEHICLE WILL NOT START WITHOUT THE CORRECT IGNITION KEY. *TW
Bulletin Number: BC3286970206
PASSIVE ANTI-THEFT SYSTEM NOW STANDARD ON ALL MUSTANGS - THE UNDERHOOD SWITCH FOR THE ACTIVE ALARM SYSTEM WAS ELIMINATED (INCORRECTLY INCLUDED IN 1997 MUSTANG SERVICE MANUAL). *TW
Bulletin Number: BC3288970206
VEHICLES MAY EXHIBIT A COLD START ENGINE FEAD BELT CHIRP NOISE. *TW
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC9690961001
VEHICLES EQUIPPED W/ A MANUAL TRANS, THE ACCESSORY DRIVE BELT MAY COME OFF OF THE PULLEYS UNDER HIGH RPM CONDITIONS. *TT
Bulletin Number: BC9714961101
DIAGNOSTIC INSTRUCTIONS FOR SERVICING EVAPORATIVE EMISSION PURGE FLOW SYSTEM. *TW
1997 FORD MUSTANG COBRA
Bulletin Number: 11504
SOME VEHICLES WITH A T-45 TRANSMISSION MAY SHIFT FROM 4TH TO NEUTRAL (POP OUT) WHEN THE CLUTCH IS RELEASED. *TT
Bulletin Number: 13302
SOME VEHICLES MAY EXHIBIT A NO CRANK CONDITION. *TT
Bulletin Number: 13950
SOME VEHICLES WITH MANUAL TRANSMISSION OR WITH AUTOMATIC TRANSMISSION MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACH FROM THE ENGINE. *TT
Bulletin Number: 13950
SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION AND WITH AUTOMATIC TRANSMISSION MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACH FROM THE ENGINE. *TT
Bulletin Number: 15901
THIS BULLETIN STATES THAT SOME 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER OR LARGER KNOCK SENSOR THREADED HOLD THAN THE ONE IN THE ORIGINAL ENGINE ASSEMBLY. *TT
Bulletin Number: 7236
EXPERIENCING A NO CRANK CONDITION. *TT
Bulletin Number: 8106
SOME VEHICLES MAY EXHIBIT A NO CRANK CONDITION. *TT
Bulletin Number: 8278
SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION AND WITH AUTOMATIC TRANSMISSION MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACH FROM THE ENGINE. *TT
Bulletin Number: 8278
SOME VEHICLES WITH MANUAL AND AUTOMATIC TRANSMISSIONS MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACHED FROM THE ENGINE. *TT
1997 FORD MUSTANG CONVERTIBLE
Bulletin Number: 0042
VEHICLES MAY EXPERIENCE VIBRATION/SHAKE AT STEADY SPEED APPROXIMATELY 100 KM/H (62 MPS), VEHICLES WITH 3.8 L ENGINE AND CONVERTIBLE TOP. *MJS
Bulletin Number: 12093
SOME VEHICLES MAY EXPERIENCE VIBRATION/SHAKE WHEN DRIVEN ON SMOOTH ROADS AT CONSTANT SPEEDS AROUND 62 MPH/100 KPH. *MJS
Bulletin Number: 12717
EXPERIENCING VIBRATION / SHAKE WHEN DRIVEN ON SMOOTH ROADS AT SPEED AROUND 62 MPH / 100 KPH. *TT
Bulletin Number: 5132
SOME GT CONVERTIBLES MAY EXPERIENCES VIBRATION / SHAKE WHEN DRIVEN ON SMOOTH ROADS AT CONSTANT SPEEDS AROUND 62 MPH / 100 KPH. THE CONDITION MAY BE DUE TO HARMONIC RESONANCE BETWEEN THE ENGINE, BODY AND SUSPENSION. *TT
Bulletin Number: 6227
SOME VEHICLES MAY EXHIBIT CONCERNS OF VIBRATION / SHAKE. *TT
Bulletin Number: 7373
SOME VEHICLES MAY EXHIBIT A RATTLE NOISE FROM THE DOOR WEDGE WHEN DRIVING ON ROUGH ROADS. *TT
Bulletin Number: 985131
SOME GT MODELS MAY EXPERIENCE VIBRATION / SHAKE WHEN DRIVEN ON SMOOTH ROADS AT CONSTANT SPEEDS AROUND 62 MPH / 100 KPH. *TT
Bulletin Number: 9912717
SOME VEHICLES MAY EXHIBIT VIBRATION / SHAKE WHEN DRIVEN ON SMOOTH ROADS AT SPPED AROUND 62 MPH / 100 KPH. *TT
1997 FORD MUSTANG GT
Bulletin Number: 11504
SOME VEHICLES WITH A T-45 TRANSMISSION MAY SHIFT FROM 4TH TO NEUTRAL (POP OUT) WHEN THE CLUTCH IS RELEASED. *TT
Bulletin Number: 13950
SOME VEHICLES WITH MANUAL TRANSMISSION OR WITH AUTOMATIC TRANSMISSION MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACH FROM THE ENGINE. *TT
Bulletin Number: 13950
SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION AND WITH AUTOMATIC TRANSMISSION MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACH FROM THE ENGINE. *TT
Bulletin Number: 8278
SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION AND WITH AUTOMATIC TRANSMISSION MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACH FROM THE ENGINE. *TT
Bulletin Number: 8278
SOME VEHICLES WITH MANUAL AND AUTOMATIC TRANSMISSIONS MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACHED FROM THE ENGINE. *TT
1997 FORD NAVIGATOR
Bulletin Number: 13712
INFORMATION REGARDING VEHICLES THAT EXPERIENCE THE RADIOS THAT DISPLAY NO DJ-NO DISC OR CD WILL NOT EJECT. *MJS
Bulletin Number: 13745
SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS
Bulletin Number: 13773
INFORMATION FOR COMPACT DISC PLAYER PROBLEMS, RADIO MAY DISPLAY NO DJ- NO DUSC OR CD WILL NOT EJECT. *MJS
Bulletin Number: 15122
SOME VEHICLES MAY EXHIBIT A VIBRATION AT IDLE AND/OR ENGINE DROANING NOISE ON ACCELERATION FROM A STOP. *SLC
Bulletin Number: 15123
SOME VEHICLES MAY EXHIBIT A DRIVELINE VIBRATION AT SPEEDS BETWEEN 60-70 MPH. *SLC
Bulletin Number: 7929
DIAGNOSTIC INFORMATION FOR COMPACT DISC PLAYER PROBLEMS.
Bulletin Number: 9810569
CONCERNS OF SQUEAKY / NOISY PITMAN ARM. *YC
Bulletin Number: 98169
STEERING -ALIGNMENT-TOE SET PROCEDURE SERVICE TIP. YD
1997 FORD PROBE
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 00182
SOME VEHICLES MAY EXHIBIT NO FORWARD GEAR RANGES DUE TO THE MISALIGNMENT OF THE FORWARD / COAST CLUTCH CYLINDER SNAP RING WITH RESPECT TO THE LEGS OF THE FORWARD CLUTCH PISTON. *JB
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 0224
SOME VEHICLES EQUIPPED WITH THE CD4E TRANSAXLE MAY EXHIBIT HARSH AND DELAYED 1-2/2-3 UPSHIFTS AFTER TRANSAXLE OR TURBINE SHAFT SPEED SENSOR REPLACEMENT, POSSIBLE DIAGNOSTIC TROUBLE CODES 628, 642, 645, 646, 647, 648, P0731, P0732, P0734, P0
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 11791
SOME VEHICLES WITH CD4E TRANSMISSION MAY EXHIBIT A CONDITION OF NO CRANK / NO START IN PARK. VEHICLE WILL CRANK AND START IN NEUTRAL. *TT
Bulletin Number: 14936
SOME VEHICLES EQUIPPED WITH CD4E AUTO TRANSAXLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODES FOR GEAR RATIO OR HARSH AND DELAYED 1-2 / 2-3 UPSHIFTS AFTER TRANSAXLE OR TURBINE SPEED SENSOR (TSS) REPLACEMENT. *TT
Bulletin Number: 4674
SOME VEHICLES WITH CD4E TRANSMISSION MAY EXHIBIT A CONDITION OF NO CRANK / NO START IN PARK. VEHICLE WILL CRANK AND START IN NEUTRAL. *TT
Bulletin Number: 6583
INFORMATION ON SERVICING THE LEFT STEERING RACK BUSHING. *TT
Bulletin Number: 96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
Bulletin Number: 96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
Bulletin Number: 96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
Bulletin Number: 962411
TRANSAXLE - CD4E - NEW DESIGN PARKING PAWL RATCHET SPRING AND PARKING CAM ACTUATING LEVER ASSEMBLY. *TW
Bulletin Number: 96245
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION - DIAGNOSTIC TROUBLE CODE (DTC) P1794 STORED IN CONTINUOUS MEMORY - PROBE WITH 2.5L, ESCORT WITH 1.8L AND ASPIRE. *TW
Bulletin Number: 96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
Bulletin Number: 962511
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 96254
RESTRAINT SYSTEM - AIR BAG MODULE - DIAGNOSTIC FAULT CODE 51 - IMPROVED DIAGNOSTICS AND REPAIR. *TW
Bulletin Number: 962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 962614
TRANSAXLE - CD4E - HARSH SHIFT AND/OR ENGAGEMENT - DIAGNOSTIC TROUBLE CODE 628 OR P0741. *TW
Bulletin Number: 97111097235
SUBJECT REGARDING MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0505. *YC
Bulletin Number: 9729
NOISE - BUZZ/VIBRATION IN REVERSE AND/OR CLICKING NOISE ACCOMPANIED BY VIBRATION ON RIGHT HAND TURNS DURING ACCLERATION - VEHICLES BUILT THROUGH 1/6/97 WITH 2.0L ENGINE AND CD4E TRANSAXLE. *TW
Bulletin Number: 9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD
Bulletin Number: 9746
TRANSAXLE- CD4E- HARSH SHIFT AND/OR ENGAGEMENT- DIAGNOSTIC TROUBLE CODE (DTC) 628 OR P0741- SERVICE TIP. *JD
Bulletin Number: 9751
INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD
Bulletin Number: 97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
Bulletin Number: 9759
LEAK- AUTOMATIC TRANSMISSION FLUID- CD4E TRANSAXLE IN FLUID COLLECTION ON MAIN CONTROL ASSEMBLY. *JD
Bulletin Number: 9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
Bulletin Number: 9812016
SOME VEHICLES MAY EXHIBIT A CONCERN WHERE THE CHECK ENGINE FALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE IN BELOW FREEZING TEMPERATURES AND DIAGNOSTIC TROUBLE CODE (DTC) P1407 IS STORED IN CONTINUOUS MEMORY.
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 981510
REVISED OIL PUMP INSTALLATION PROCEDURE. YD
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982311
MINIMAL CLEARANCE OF THE CD4E TRANSAXLE TO SUBFRAME MAKES TRANSAXLE INSTALLATION AND REMOVAL MORE DIFFICULT. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 985016
SOME VEHICLES MAY EXHIBIT A CONCERN WHERE THE CHECK ENGINE MALFUNCTION INDICATOR LAMP MAY ILLUMINATE IN BELOW FREEZING TEMPERATURES AND DIAGNOSTIC TROUBLE CODE P1407 IS STORED IN CONTINUOUS MEMORY. *TT
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 9874
A NEW SILICONE GASKET AND SEALANT. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 99129
INFORMATION ON "WHINING" / "BUZZING" NOISE COMING THROUGH ENTERTAINMENT OR TWO-WAY RADIO SPEAKER CAUSED BY THE FUEL PUMP. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99249
THIS BULLETIN ADDRESSES AN ISSUE WITH THE AUTOMATIC TRANSMISSION FLUID SEEPING FROM THE VENT, RESULTING IN FLUID COLLECTING ON THE MAIN CONTROL ASSEMBLY. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: BC0045970201
BEGINNING DECEMBER 2, 1996 ALL CD4E TRANSAXLES ARE BUILT WITH A REDESIGNED PUMP BODY SEPARATOR PLATE AND PUMP BODY SEPARATOR PLATE GASKET. *JD
Bulletin Number: BC0045972301
BEGINNING DECEMBER 2, 1996 (BEGINNING TRAN SERIAL NUMBER (6337-0001)) ALL CD4E TRANSAXLES ARE BUILT WITH A REDESIGNED PUMP BODY SEPARATOR PLATE AND PUMP BODY SEPARATOR PLATE GASKET. *JD
Bulletin Number: BC0132970201
A CLUNK ON LEFT HAND TURNS WHILE ACCELERATING. THIS MAY BE CAUSED BY IMPROPER ALIGNMENT OF THE #1 ENGINE MOUNT. *JD
Bulletin Number: BC0422961119
CONCERNS OF TRANSMISSION POPPING OUT OF 3RD OR 5TH GEAR. *TW
Bulletin Number: BC0760961016
WAVE SPRING LOCATED UNDER THE FORWARD ONE-WAY CLUTCH IN NO LONGER ONE PIECE. IT HAS BEEN 'SPLIT'. *TT
Bulletin Number: BC0763961016
SHOULDER BELT THAT IS SLOW TO RETRACT MAY BE CAUSED BY A TWIST IN THE SEAT BELT WEBBING BEHIND THE 'B' PILLAR TRIM. *TT
Bulletin Number: BC1010397020
HARD TO START/LONG CRANK TIME CONCERN ON 96-97 VEHICLES DUE TO FUEL PRESSURE LEAK DOWN. *JD
Bulletin Number: BC1012697020
CLUNK ON LEFT HAND TURNS WHILE ACCELERATING ON 1997 PROBE 2.0L CD4E VEHICLES. MAY BE CAUSED BY IMPROPER ALIGNMENT OF THE ENGINE MOUNT. *JD
Bulletin Number: BC1017597230
THE LUMBAR BAG INFLATES BUT DOES NOT APPLY ADEQUATE PRESSURE TO THE SEAT BACK MAY BE CAUSED BY IMPROPER POSITIONING OF THE LUMBAR BAG SUPPORT RODS. *JD
Bulletin Number: BC1019097230
OIL PUMP TO CYLINDER BLOCK ALIGNMENT CONCERN ON VEHICLE BUILT BETWEEN 9/5/96 AND 12/9/96 WITH ENGINE SERIAL NUMBER FS200304 THROUGH FS209265. JD
Bulletin Number: BC1026697230
VEHICLES EXHIBITING HARSH SHIFTS AND/OR HARSH ENGAGEMENT ACCOMPANIED BY DTCS 628 OR P0741. *JD
Bulletin Number: BC1030597020
PAINT BLISTER, PEEL OR CRACK CONCERNS. *JD
Bulletin Number: BC1033497020
THE MALFUNCTION INDICATOR LAMP (MIL) ON WITH CODE P0441 STORED IN MEMORY. *JD
Bulletin Number: BC2372970501
A HARD TO START/LONG CRANK TIME CONCERN ON 96-97 PROBE VEHICLES MAY BE DUE TO FUEL PRESSURE LEAK DOWN. *TW
Bulletin Number: BC3081970226
PARTIALLY RESTRICTED VACUUM HOSE TO CANNISTER MAY BE CAUSE OF MALFUNCTION INDICATOR LAMP (MIL) CODE P0441. *TW
Bulletin Number: BC3162970218
CLICKING NOISE CAUSED BY DIFFERENTIAL LUBE TUBE CONTACTING DIFFERENTIAL CASE. *TW
Bulletin Number: BC3204970214
HARSH SHIFTS AND/OR HARSH ENGAGEMENT ACCOMPANIED BY DTC'S 628 OR P0741. *TW
Bulletin Number: BC3492972301
AN OIL PUMP TO CYLINDER BLOCK ALIGNMENT CONCERN ON VEHICLES BUILT BETWEEN 9/5/96 AND 12/9/96 WITH ENGINE SERIAL NUMBER FS200304 THROUGH FS209265. *JD
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC9666961001
2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT
1997 FORD RANGER
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 01124
ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01186
INFORMATION ON CLIMATE CONTROL, LOUD A/C CLUTCH CYCLING NOISE.*JB
Bulletin Number: 01197
SOME VEHICLES EQUIPPED WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / ONNECTING ROD BEARING KNOCK. *TT
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 01212
SOME VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT A LOUD A/C CLUTCH ENGAGEMENT. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 0146
SOME VEHICLES MAY EXHIBIT A CHATTER OR BINDING CONDITION WHEN OPERATING THE POWER SIDE WINDOWS EITHER IN THE DOWN OR UP MODE. *TT
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 0186
ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT
Bulletin Number: 01B77
OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT
Bulletin Number: 02138
LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
Bulletin Number: 0242
CERTAIN VEHICLES WITH 4X4 OR ALL-WHEEL DRIVE MAY HAVE A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT
Bulletin Number: 0282
SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. *TT
Bulletin Number: 030508
FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD. *TT
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 03203
MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT
Bulletin Number: 0358
FLUID MAY LEAK OUT OF THE FRONT AXLE VENT TUBE. *TT *JB
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04217
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT
Bulletin Number: 1014997020
UPDATE TO TSB 96-21-9 ADDITIONAL CALIBRATION ADDED- ANY CALIBRATION REVISION LEVEL FOR A VEHICLE WITH A MANUAL TRANSMISSION THAT IS NOT CALLED OUT IN TSB 96-21-9 SHOULD ALSO BE INCLUDED AS PART OF THAT TSB. *JD
Bulletin Number: 11512
ENGINEERING IS INVESTIGATING CONCERNS OF NOISY FRONT SYSTEM BLOWER MOTORS ON CERTAIN VEHICLES. *TT
Bulletin Number: 11761
SOME VEHICLES WITH 2.3L ENGINES MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP LIGHT WITH DIAGNOSTIC TROUBLE CODE P0340. *TT
Bulletin Number: 12138
VEHICLES MAY EXHIBIT A CLIMATE CONTROL ISSUE OF LACK OF HEAT. *MJS
Bulletin Number: 12152
SOME VEHICLES WITH 4 X 4 OPTION OPERATING IN 4 X 2 MODE MAY EXHIBIT A PING SOUND ON SLIGHT TO MODERATE ACCELERATION IN FORWARD OR REVERSE. *MJS
Bulletin Number: 12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
Bulletin Number: 12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
Bulletin Number: 12230
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12518
CONCERNS WITH THE IN-DASH CD STOPS OPERATING WHEN HOT / RADIO DISPLAY READS CD TOO HOT. *TT
Bulletin Number: 12905
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT
Bulletin Number: 13054
EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT
Bulletin Number: 13118
SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT
Bulletin Number: 13154
SUBJECT REGARDING ENGINE HOTLINE PHONE NUMBERS. *TT
Bulletin Number: 13154
SUBJECT REGARDING 4.0L ENGINE HOTLINE PHONE NUMBERS. *TT
Bulletin Number: 13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
Bulletin Number: 13244
INFORMATION REGARDING WINDNOISE FROM WINDSHIELD/COWL AREA. *MJS
Bulletin Number: 13412
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT
Bulletin Number: 13423
VEHICLES EQUIPPED WITH MANUAL TRANSMISSION MAY EXHIBIT NEUTRAL GEAR ROLLOVER NOISE WHICH OCCURS AT IDLE WITH TRANSMISSION IN NEUTRAL AND CLUTCH ENGAGED. *TT
Bulletin Number: 13426
EXHIBITING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS. *TT
Bulletin Number: 13440
EXPERIENCING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS (PARKING LOT TYPE MANEUVERS). *TT
Bulletin Number: 13484
VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT EXCESSIVE OIL CONSUMPTION AS REPORTED BY THE CUSTOMER. *TT
Bulletin Number: 13505
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
Bulletin Number: 13745
SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS
Bulletin Number: 14056
SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR
Bulletin Number: 14583
CONCERNS WITH BROKEN THERMOSTATS ON ENGINES. *JB
Bulletin Number: 14617
SUBJECT PERTAINING TO BROKEN THERMOSTAT. *JB
Bulletin Number: 14847
CONCERNS WITH VEHICLES EXHBIT FLUID LEAKAGE FROM THE FRONT AXLE VENT TUBE. *TT
Bulletin Number: 15167
SOME VEHICLES MAY EXHIBIT A LOUD COMPRESSOR CYCLING NOISE. *YH
Bulletin Number: 15198
SOME VEHICLES MAY EXHIBIT LOUD A/C CLUTCH CYCLING NOISE CONDITION. *JG
Bulletin Number: 15887
SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). *TT
Bulletin Number: 16040
EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT
Bulletin Number: 17254
CLICKING/POPPING NOISE FROM UPPER STEERING COLUMN AREA WHEN TURNING. 2004 E SERIES AND EXPLORER SPORT TRAC ALSO INCLUDED. *TT
Bulletin Number: 17777
REAR LEAF SPRING NOISE. *TT
Bulletin Number: 4634
STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT
Bulletin Number: 4644
SOME VEHICLES WITH 2.3L ENGINES MAY EXPERIENCE A MALFUNCTION INDICATOR LIGHT WITH DIAGNOSTIC TROUBLE CODE P0340. *TT
Bulletin Number: 5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
Bulletin Number: 5249
INFORMATION ON VEHICLES EXHIBITING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT
Bulletin Number: 5518
INFORMATION ON SERVICING OIL PAN GASKET LEAKS. *TT
Bulletin Number: 5652
COMPLAINTS THAT THE IN-DASH CD STOPS OPERATING WHEN HOT. *TT
Bulletin Number: 6574
SOME VEHICLES MAY EXHIBIT AN OCCASIONAL HOOT / MOAN FROM THE IDLE AIR CONTROL (IAC) VALVE. *TT
Bulletin Number: 6603
SOME VEHICLES MAY EXHIBIT AN AUDIBLE PINGING OR CREAKING NOISE THAT MAY BE HEARD FROM THE DRIVELINE WHEN ENGINE TORQUE IS INITIALLY APPLIED TO THE DRIVELINE. *TT
Bulletin Number: 6896
SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT
Bulletin Number: 6926
SUBJECT REGARDING THE ENGINE HOTLINE PHONE NUMBERS FOR 1997 - 2000 MODEL YEAR VEHICLES. *TT
Bulletin Number: 6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
Bulletin Number: 7126
SOME VEHICLES MAY EXHIBIT WINDNOISE HEARD FROM THE COWL / WINDSHIELD AREA. *TT
Bulletin Number: 7353
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT
Bulletin Number: 7366
SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION MAY EXHIBIT NEUTRAL GEAR ROLLOVER NOISE (A LIGHT METALLIC RATTLING SOUND FROM THE TRANSMISSION) WHICH OCCURS AT IDLE WITH TRANSMISSION IN NEUTRAL CLUTCH ENGAGED (CLUTCH PEDAL UP). *TT
Bulletin Number: 7471
SOME VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT EXCESSIVE OIL CONSUMPTION AS REPORTED BY THE CUSTOMER. *TT
Bulletin Number: 8164
INFORMATION ON 5R55E - 4R55E - 4R44E PUMP ALIGNMENT TOOLS. *TT
Bulletin Number: 8164
INFORMATION REGARDING PUMP ALIGNMENT TOOLS. **MR
Bulletin Number: 8512
SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR
Bulletin Number: 870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
Bulletin Number: 96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
Bulletin Number: 962215
FLUID - NEW MERCON V REQUIRED - TRANSMISSION - 4R44E - DESCRIPTION OF FEATURES AND MAJOR COMPONENTS. *TW
Bulletin Number: 96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
Bulletin Number: 96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
Bulletin Number: 96226
AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW
Bulletin Number: 96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
Bulletin Number: 96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
Bulletin Number: 962511
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 97050110607
ENGINEERING IS INVESTIGATING CONCERNS OF THE REAR ABS LIGHT COMING ON WHEN THE IGNITION IS IN THE ON POSITION.
Bulletin Number: 97050110627
ROUGH IDLE ACCOMPANIED BY STALLS/ QUITS AT IDLE. *YC
Bulletin Number: 9705014158
VEHICLES INCLUDES GRAPHICS FOR A SPEED CONTROL INDICATOR LIGHT. *YC
Bulletin Number: 97090297189
EXPERIENCING A "THUMPING" NOISE OR TEMPEATURE GAUGE FLUCTATION WITH SOME VEHICLES. *YC
Bulletin Number: 971110972312
CONCERNS WITH "PINGING" OR "CREAKING" BEING HEARD FROM THE DRIVELINE WHEN SHIFTING FROM PARK TO DRIVE OR REVERSE, BETWEEN DRIVE AND REVERSE, OR WHEN ENGAGING THE CLUTCH. *YC
Bulletin Number: 9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD
Bulletin Number: 9737
DOOR HANDLE- OUTSIDE DOOR HANDLE HAS EXTENDED TRAVEL- VEHICLES BUILT THROUGH 11/1/96. *JD
Bulletin Number: 9747
FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD
Bulletin Number: 97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
Bulletin Number: 97615
BRAKES- "SQUEALING" NOISE AND/OR STICKING DURING FIRST FEW BRAKE APPLICATIONS AFTER A RAINFALL AND/OR WHEN BRAKES ARE COLD. *JD
Bulletin Number: 9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
Bulletin Number: 980319
CONCERNS WITH FALSE ABS ACTIVATION WHILE LIGHT BRAKING AT LOW SPEEDS. *YC
Bulletin Number: 980324
CONCERNS OF COLD ENGINE UPPER KNOCK / TICK. *YC
Bulletin Number: 98112
SUBJECT REGARDING A NEW SERVICE CENTER SUPPORT THAT USES A THRUST BEARING (#3 AND #4) IN PLACE OF THRUST WASHERS HAS BEEN RELEASED. *TT
Bulletin Number: 9811284
EXPERIENCING A LONG CRANK HARD START CONDITION. *TT
Bulletin Number: 9811488
SOME VEHICLES EQUIPPED WITH A CTM (CENTRAL TIMER MODULE) MAY EXPERIENCE INTERMITTENT WIPER OPERATION WITHOUT COMMAND; DOME LIGHTS REMAINING ON; OR THE DOOR CHIMES REMAINING ON. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 981516
OUTSIDE REARVIEW MIRROR MANUAL REPLACEMENT.
Bulletin Number: 98158
THE DRIVER'S AND PASSENGER'S DOOR GLASS CHATTER WHEN OPERATING THE WINDOW IN DOWN MODE.
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 98165
EVAPORATOR CORE FAILED, CAUSING THE AIR CONDITIONER TO DRIP ON TO PASSENGER FLOOR. YD
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 982111
HIGHTER THAN EXPECTED ENGINE RPMS DURING A 2-3 PARTIAL BACKOUT UPSHIFT OR AFTER A 3-2 OR4-2 WIDE OPEN THROTTLE DOWNSHIFT MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982312
ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98238
CONDENSATE MAY LEAK ONTO THE PASSENGER FLOOR ON SOME VEHICLES. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982526
SOME VEHICLES MAY EXPERIENCE VARIOUS CONCERNS SUCH AS INTERMITTENT WINDSHIELD WIPER OPERATION WITHOUT COMMAND, DOME LIGHTS REMAINING ON, AND/OR THE DOOR CHIMES REMAING ON. *YC
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 982671
SOME VEHICLES MAY EXPERIENCE POOR RADIO RECEPTION ( AM/FM). *YC
Bulletin Number: 983071
BRIEF INFORMATION REGARDING THE IMPROVED SAIL MOUNT MANUAL MIRROR. *TT
Bulletin Number: 983074
CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 983226
EXPERIENCING A LONG CRANK HARD START CONDITIONS. *TT
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 9839
THE DRIVER'S AND/OR PASSENGER DOOR GLASS MAY
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 98-4732
STEERING WHEEL SHIMMIES, VIBRATION OR GRUNT ON SLOW SPEED TURNS..
Bulletin Number: 985045
REVISED MESSAGE REGARDING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS ACTION ON SOHC EQUIPPED VEHICLES, PERFORM TSB 98-21-01. *TT
Bulletin Number: 985085
SOME VEHICLES WITH POWER WINDOWS MAY EXHIBIT WINDOW CHATTERING OR JERKING MOTION WHEN OPERATING IN THE DOWN MODE. *AK *TT
Bulletin Number: 98514
CONCERNS WITH A WHISTLING OR HISSING NOISE FROM THE MAIN CONTROL AREA OCCURING WHILE IDLING IN DRIVE AND / OR REVERSE ON SOME VEHICLES. *TT
Bulletin Number: 985174
SOME VEHICLES WITH 4X4 OPTION IN 4X2 MODE MAY EXHIBIT A PING SOUND ON SLIGHT TO MODERATE ACCELERATION IN FORWARD OR REVERSE. *TT
Bulletin Number: 985178
SOME VEHICLES MAY EXHIBIT A CLIMATE CONTROL ISSUE OF LACK OF HEAT. *TT
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 9856
SOME VEHICLES MAY EXPERIENCE A HARD START/LONG CRANK TIME AND/OR A STUMBLE/HESITATION AFTER COLD START ON ACCELERATION. *YC
Bulletin Number: 985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
Bulletin Number: 985A21
ISSUES WITH THE REAR ANTI-LOCK BRAKE SYSTEM ( RABS ) LAMP MAY ILLUMINATE AFTER FRONT WHEEL LOCK UP DURING 4X4 OPERATION. *YC
Bulletin Number: 985A36
A GRABBING AND/OR STICKING CONDITION DURING THE FIRST FEW BRAKE APPLICATIONS WHEN THE BRAKES ARE COLD OR IN THE MORNING AFTER AN OVERNIGHT RAIN MAY OCCUR ON SOME VEHICLES. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9867
INFORMATION ON THE REVISED MANUAL OUTSIDE REARVIEW MIRRORS BUILT THROUGH 2/13/98. *TT
Bulletin Number: 9868
A ROUGH IDLE, STALLING AT AN IDLE AND/OR DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0174, AND/OR P1151 MAY BE STORED IN MEMORY ON SOME VEHICLES WITH A 4.OL ENGINE. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99161
EXPERIENCING AN AUDIBLE PINGING OR CREAKING (NOT A CLUNKING NOISE) HEARD FROM THE DRIVELINE WHEN ENGINE TORQUE IS INITIALLY APPLIED TO THE DRIVELINE SUCH AS WHEN SHIFTING FROM PARK TO DRIVE OR REVERSE, BETWEEN DRIVE AND REVERSE. *TT
Bulletin Number: 99162
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0125 STORED IN MEMORY, AND / OR LACK OF HEAT WITH THE CLIMATE CONTROL. *TT
Bulletin Number: 99183
SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99235
DURING EXTREME COLD AMBIENT TEMPERATURES AND UNDER CERTAIN DRIVING CONDITIONS, MOISTURE IN THE CRANKCASE MAY ENTER THE PCV SYSTEM, FREEZE AND CAUSE PRESURE IN THE ENGINE CRANKCASE. THE PCV FITTING IN THE UPPER INTAKE MANIFOLD MAY FREEZE OR
Bulletin Number: 99238
A TEMPERATURE GAUGE FLUCTUATION AND / OR A KNOCKING / THUMPING NOISE MAY BE AUDIBLE INTHE PASSENGER COMPARTMENT ON SOME VEHICLES. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 995157
INFORMATION ON MAINTAINING TIRE PRESSURE. *TT
Bulletin Number: 996125
SUBJECT REGARDING FUEL SYSTEM DIAGNOSTIC. *TT
Bulletin Number: 996780
THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: BC0185970201
SOME VEHICLES MAY NOT BE PUT INTO ALIGNMENT- CAMBER READINGS. *JD
Bulletin Number: BC0324961101
COLD ENGINE KNOCK/TICK NOISE. *TW
Bulletin Number: BC0324970201
COLD ENGINE KNOCK/TICK NOISE. *JD
Bulletin Number: BC0324972301
REAR BRAKES "GRAB" WHEN COLD OR DAMP. *JD
Bulletin Number: BC0407961115
INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED PARTS. *TW
Bulletin Number: BC0490961112
INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED COMPONENT. *TW
Bulletin Number: BC0692961023
VEHICLES MAY EXPERIENCE UNEXPLAINED MIL LIGHT CODES &/OR IRREGULAR SHIFTING (A4LD). *TT
Bulletin Number: BC0764961016
THE OIL INDICATOR TUBE (DIP STICK) IS COMING INTO CONTACT W/ THE CRANK SHAFT, CAUSING A TICKING SOUND. *TT
Bulletin Number: BC1018997230
BLOCK HEATERS MAY EXPERIENCE COOLANT LEAKS DUE TO INTERFERENCE WITH THE BLOCK. *JD
Bulletin Number: BC1019197230
EXHIBITING A PULSATING, CYCLICAL TYPE OF NOISE COMING FROM THE FRONT AXLE TUBE AREA FROM 0 TO 45 MPH. *JD
Bulletin Number: BC1019797230
THE VEHICLES WILL SHIFT 1,2,3,4,5 REGARDLESS OF THROTTLE POSITION. *JD
Bulletin Number: BC1019997230
4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPNIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSES WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD
Bulletin Number: BC1021097230
SOME VEHICLES WITH 4R44E TRANSMISSION MAY HAVE INCORRECT ID TAG NUMBERS ON THE MAIN CONTROLS. *JD
Bulletin Number: BC1022797230
THE NGS DISPLAYS INCORRECT DATA FOR THE IGN GEM PID ON THE VEHICLES. *JD
Bulletin Number: BC105889705
1997 RANGER VEHICLES DO NOT HAVE TAILGATE TAPE STRIPES. *TW
Bulletin Number: BC105939705
VEHICLES MAY EXPERIENCE A MOAN IN THE PASSENGER COMPARTMENT AT OR NEAR 2800 RPM. *TW
Bulletin Number: BC105979705
UPDATE INFORMATION FOR 1997 4R44E AND 5R55E TRANSMISSIONS - THERE ARE TWO (2) DIFFERENT SIZE DIRECT CLUTCH STEEL PLATES WHEN SERVICING 4R44E OR 5R55E TRANSMISSIONS. *TW
Bulletin Number: BC106009705
1997 4X4 RANGERS RABS (REAR ANTI LOCK BRAKING SYSTEM) LAMP MAY ILLUMINATE AFTER FRONT WHEEL LOCK-UP DURING 4X4 OPERATION. *TW
Bulletin Number: BC2226970501
SERVICING TIP - TRANSMISSION - THERE ARE TWO DIFFERENT SIZE DIRECT CLUTCH STEEL PLATES WHEN SERVICING 4R44E OR 5R55E TRANSMISSIONS. *TW
Bulletin Number: BC2232970501
ENGINEERING IS INVESTIGATING CONDITIONS THAT CAUSE THE ABS LIGHT (RABS) TO ILLUMINATE. *TW
Bulletin Number: BC2242970501
RABS (REAR ANTI LOCK BRAKING SYSTEM) LAMP MAY ILLUMINATE AFTER FRONT WHEEL LOCK-UP DURING 4X4 OPERATION. *TW
Bulletin Number: BC2293970501
1997 RANGERS ARE NOT EQUIPPED WITH TAILGATE STRIPES. *TW
Bulletin Number: BC2298970501
VEHICLES MAY EXPERIENCE A MOAN IN THE PASSENGER COMPARTMENT NEAR 2800 RPM - TO FIX, INSTALL A VIBRATION DAMPER TO A/C SUCTION LINE. *TW
Bulletin Number: BC2301970501
NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW
Bulletin Number: BC2361970501
AUTHORIZED WARRANTY PART REPLACEMENT OF BRAKE PADS TO CORRECT EXCESSIVE BRAKE NOISE. *TW
Bulletin Number: BC2381970501
WHEN REMOVING STICKERS/LABELS FROM THE PRIVACY QUARTER GLASS WINDOWS, DO NOT USE ANY SHARP OR RAZOR LIKE EDGES. *TW
Bulletin Number: BC3170970217
RANGER 4X4 WITH REAR ANTI-LOCK BRAKING SYSTEM - VEHICLES MAY EXPERIENCE ILLUMINATION OF THE ABS WARNING LIGHT WHEN BRAKING UNDER 4X4 MODE ON SLIPPERY/ICY SURFACES WITH FRONT WHEEL LOCK UP. *TW
Bulletin Number: BC3282970206
GEM CONCERN - CHECK FOR MORE THAN ONE GEM CONTROLLED COMPONENT THAT IS INOPERATIVE OR FOR A STRING OF FALSE GEM DTC'S RECEIVED IN MEMORY. *TW
Bulletin Number: BC3363972301
THE NGS DISPLAYS INCORRECT DATE FOR THE ING GEM PID ON THE VEHICLES. *JD
Bulletin Number: BC3382972301
VEHICLES WITH AN UNUSUAL NEGATIVE CAMBER READING, AND CANNOT BE ADJUSTED TO WITHIN THE PROPER CAMBER SPECIFICATION, CAN BE REPAIRED BY NEW SPRINGS. *JD
Bulletin Number: BC3441972301
AS OF 1/7/97 THE AUTOMATIC SHIFT LOCK FEATURE TAG THAT WAS AFFIXED AROUND THE GEAR SELECTOR, HAS BEEN DISCONTINUED FOR PRODUTION. *JD
Bulletin Number: BC3442972301
SOME 1997 2.3L RANGERS WITH 4R44E TRANSMISSION MAY HAVE INCORRECT ID TAG NUMBERS ON THE MAIN CONTROLS. *JD
Bulletin Number: BC3483972301
THE VEHICLE WILL SHIFT 1,2,3,4,5 REGARDLESS OF THROTTLE POSTION. *JD
Bulletin Number: BC3485972301
4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPANIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSE WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD
Bulletin Number: BC3491972301
SOME 4.0L ENGINES WITH BLOCK HEATERS MAY EXPERIENCE COOLANT LEAKS DUE TO INTERFERENCE WITH THE BLOCK. *JD
Bulletin Number: BC3493972301
VEHICLES EXHIBITING A PULSATING, CYCLICAL TYPE OF NOISE COMING FROM THE FRONT AXLE TUBE AREA FROM 0 TO 45 MPH. *JD
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC9666961001
2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT
Bulletin Number: BC9714961101
DIAGNOSTIC INSTRUCTIONS FOR SERVICING EVAPORATIVE EMISSION PURGE FLOW SYSTEM. *TW
1997 FORD SUPER DUTY F SERIES
Bulletin Number: 00610
INFORMATION ON THE 7.3L DIT ENGINES, ROTUNDA TOOL HAS ISSUED AN INJECTOR PERFORMANCE ANALYZER THAT MAY NOW BE PRUCHASED AS AN EFFECTIVE AID IN HELPING TO RESOLVE ROUGH IDLE CONCERNS. *MJS
Bulletin Number: 032137
FOR 7.3L DIT ENGINES, ROTUNDA TOOL HAS ISSUED AN INJECTOR PERFORMANCE ANALYZER THAT MAY NOW BE PURCHASED AS AN EFFECTIVE AID IN HELPING TO RESOLVE ROUGH IDLE CONCERNS. *TT
Bulletin Number: 13488
SOME VEHICLES EQUIPPED WITH 7.3L DIT ENGINE MAY EXHIBIT A ROUGH ENGINE IDLE. *TT
Bulletin Number: 13505
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT
Bulletin Number: 16480
DIAGNOSTIC TROUBLE CODE (DTC) P0340, POSSIBLE FALSE CODE. VARIOUS MODELS INCLUDING 1994-1996 FORD EXCURSION. *TT
Bulletin Number: 16945
AN OIL LEAK AT THE TURBOCHARGER PEDESTAL AROUND THE EXHAUST BACKPRESSURE ACTUATOR. *TT
Bulletin Number: 16999
HIGH PRESSURE OIL PUMP LEAK. *TT
Bulletin Number: 17777
REAR LEAF SPRING NOISE. *TT
Bulletin Number: 7353
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT
Bulletin Number: 7475
SOME VEHICLES EQUIPPED WITH 73L DIT ENGINE MAY EXHIBIT A ROUGH ENGINE IDLE. *TT
Bulletin Number: 996034
EXPERIENCING A ENGINE KNOCK AT COLD START-UP. *TT
1997 FORD TAURUS
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 00191
SOME VEHICLES MAY EXPERIENCE A SEPARATION BETWEEN LAYERS OF THE INSTRUMENT PANEL. *JB
Bulletin Number: 00203
A SEPARATION BETWEEN LAYERS OF THE INSTRUMENT PANEL.*JB
Bulletin Number: 00263
SOME VEHICLES MAY EXHIBIT A POWER WINDOW THAT WILL NOT OPERATE DOWNWARD BECAUSE IT'S STUCK / BOUND TO THE WEATHERSHIP HEADER. *TT
Bulletin Number: 00E11
SERVICE ACTION BULLETIN REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
Bulletin Number: 00E11
SERVICE ACTION 00E11, SUPPLEMENT #1 - UPDATE INFORMATION REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
Bulletin Number: 01116
SOME VEHICLES MAY EXHIBIT COOLING SYSTEM CONDITIONS SUCH CONTAMINATED / CORRODED COOLANT; LEAKING / DISCOLORED COOLANT OVERFLOW BOTTLES; VIBRATION FROM ENGINE; LEAKING HEATER CORE; COOLANT OVERFLOW; HIGH TEMPERATURE GAUGE READINGS, ETC.
Bulletin Number: 01124
ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 0162
VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02153
SOME VEHICLES EQUIPPED WITH THE 3.0L 4V DURATEC ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P1518, INTAKE MANIFOLD RUNNER CONTROL. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02183
EXHAUST SYSTEM Y-PIPE CRACK AT THE NOISE VIBRATION HARNESS BRACKET. *MJ
Bulletin Number: 02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH
Bulletin Number: 02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
Bulletin Number: 02236
ERRATIC OPERATION OF THE COOL/WARM FUNCTION OF THE TEMPERATURE CONTROL SYSTEM - REPAIR PROCEDURE FOR STRATIFICATION (SECONDARY) TEMPERATURE BLEND DOOR. *TT
Bulletin Number: 03123
TORQUE CONVERTER CLUTCH NOT ENGAGING WHEN COMMANDED AND/OR DIAGNOSTIC TROUBLE CODES P0741 OR P1744 STORED IN MEMORY. MODELS FROM 1996 TO 2003. *TT
Bulletin Number: 031404
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.
Bulletin Number: 03141
IN VEHICLE LOCTITE SERVICE PROCEDURE FOR CAMSHAFT TUBE AND GEAR. *TT
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 090308
MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455
Bulletin Number: 11530
WHEN DIAGNOSING CRANK / NO START ON CERTAIN VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT (PATS) CHECK THE CUSTOMERS KEY RING FOR ANY MAGNETIC OBJECTS LIKE THE MOBILE SPEEDPASS KEY WHICH MAY AFFECT THE SIGNAL TRANSMISSION BETWEEN THE PATS KEY A
Bulletin Number: 11773
SUBJECT REGARDING SERVICE EVAPORATOR ASSEMBLIES. *TT
Bulletin Number: 11793
SOME VEHICLES MAY EXHIBIT A HARD / NO START CONCERN WHEN PARKED IN A STEEP NOSE-UP POSITION WITH LESS THAN 1/4 TANK OF FUEL AND FOR AN EXTENDED PERIOD OF TIME. *TT
Bulletin Number: 12079
VEHICLES MAY EXHIBIT A BUZZ OR RATTLE CONDITION ON A COLD START OR DURING A LOW RPM STEAD SPEED. *MJS
Bulletin Number: 12154
SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS
Bulletin Number: 12163
SOME VEHICLES MAY EXHIBIT A SLIGHT VIBRATION DURING ACCELERATION ONLY. *MJS
Bulletin Number: 12169
SOME VEHICLES MAY EXHIBIT A NGS ERROR MESSAGE AFTER NGS/SBTS PCM REPROGRAMMING. *MJS
Bulletin Number: 12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
Bulletin Number: 12178
INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. *MJS
Bulletin Number: 12189
INFORMATION ON INSTALLATION A NEW FUEL PUMP , ENSURE THAT THE PUMP HAS PLASTIC SHEATHING OVER THE WIRES. *MJS
Bulletin Number: 12238
SOME VEHICLES MAY EXHIBIT AN INOPERATIVE POWER WINDOW CONCERNS. *TT
Bulletin Number: 12559
CONCERNS WITH REVERSE CLUTCH THAT COULD BECOME SHEARED OR TORN IN EXTREMELY COLD TEMPERATURES. *TT
Bulletin Number: 12570
SOME VEHICLES MAY EXHIBIT FRONT OUTER TIE RODS SQUEAK AND / OR POP NOISE OVER BUMPS AND / OR TURNING. *TT
Bulletin Number: 12616
INFORMATION ON TRANSAXLE SERVICE CASE REPLACEMENT WITH OSS (OUTPUT SHAFT SPEED SENSOR) HOLE. *TT
Bulletin Number: 13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
Bulletin Number: 13250
INFORMATION REGARDING SLIGHT VIBRATION UPON ACCELERATION. *MJS
Bulletin Number: 13802
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INSTRUMENT CONTROL PANEL (ICP) ILLUMINATION. *MJS
Bulletin Number: 13802
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INTEGRATED CONTROL PANEL (ICP) ILLUMINATION. AUDIO AND CLIMATE CONTROLS CONTINUE TO OPERATE DURING THE ICP'S LOSS OF ILLUMINATION CONDITION. THIS MAY BE CAUSED BY A FAULTY INTERNAL RIBBO
Bulletin Number: 14087
SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE P1518 AND/OR P1519, RELATED TO INTAKE MANIFOLD RUNNER CONTROL (IMRC). **MR
Bulletin Number: 14584
SUBJECT REGARDING FLEX FUEL VECHICLE OIL AND FUEL RECOMMENDATIONS. *JB
Bulletin Number: 14856
SOME VEHICLES EQUPPED WITH 3.0L 2V VULCAN OR 4V DURATEC ENGINE MAY EXHIBIT AN EXHAUST RUST-THRU, WELD FATIGUE CONDITION BETWEEN THE TWO TOEBOARD CATALYSTS WHERE A TIE-IN BRACKET IS WELDED TO THE FORMED INLET PIPE OF THE REAR BANK TOEBOARD C
Bulletin Number: 15142
SOME VEHICLES MAY EXHIBIT A HARSH 2-3 SHIFT AFTER INSTALLING A REMANUFACTURED AUTOMATIC TRANSAXLE. *YH
Bulletin Number: 15370
SOME VEHICLES MAY EXHIBIT A GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK. *TT
Bulletin Number: 15390
SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LIGHT AND/OR EGR DIAGNOSTIC TROUBLE CODES 332, P0401, P1407 (LACKOF EGR FLOW). *TT
Bulletin Number: 15392
SOME VEHICLES MAY EXHIBIT A PARK PULLOUT CLUNK NOISE WHEN SHIFTING FROM PARK TO ANOTHER GEAR POSITION. *TT
Bulletin Number: 15879
SOME SHO VEHICLES MAY EXHIBIT A TICKING NOISE ORIGINATING FROM THE VALVE COVER AREA. *TT
Bulletin Number: 17358
GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE. *TT THIS BULLETIN UPDATES PREVIOUS BULLETIN 17358, DATED 11/01/2003 TO INCLUDE 2005 MODELS. *TT
Bulletin Number: 18614
SURGE, IDLE ROLL, ROUGH IDLE ONLY WHEN THE ENGINE COOLING FANS ARE OPERATING. *TT
Bulletin Number: 4619
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT
Bulletin Number: 4621
SOME VEHICLES MAY EXHIBIT CONTAMINATED / CORRODED COOLANT, HIGH OR FLUCTUATING TEMP GAUGE, COOLANT ODOR, COOLANT OVERFLOW, BLOWN OR LEAKING HOSES, BLOWN HEAD GASKET, FAILED ENGINE, LACK OF HEAT. *TT
Bulletin Number: 4630
SUBJECT REGARDING GENERAL STALLING CONCERNS. *TT
Bulletin Number: 4636
DIAGNOSING HARD START / LONG CRANK CONDITION. *TT
Bulletin Number: 4655
INFORMATION ON THE SERVICE EVAPORATOR ASSEMBLIES. *TT
Bulletin Number: 4676
SOME VEHICLES MAY EXHIBIT A HARD / NO START CONCERN WHEN PARKED IN A STEEP NOSE-UP POSITION WITH LESS THAN 1/4 TANK OF FUEL AND FOR AN EXTENDED PERIOD OF TIME. *TT
Bulletin Number: 5048
REPEAT MESSAGE REGARDING CONTAMINATED / CORRODED COOLANT, HIGH OR FLUCTUATING TEMP GAUGE; COOLANT ODOR, COOLANT OVERFLOW, BLOWN OR LEAKING HOSES, BLOWN HEAD GASKET, FAILED ENGINE, LACK OF HEAT. *TT
Bulletin Number: 5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
Bulletin Number: 5205
SOME VEHICLES MAY EXHIBIT A NGS ERROR MESSAGE, TOTAL CHECKSUM ERROR AFTER NGS / SBTS PCM REPROGRAMMING. *TT
Bulletin Number: 5226
INFORMATION ON INSTALLING A NEW FUEL PUMP ON CERTAIN VEHICLES. *TT
Bulletin Number: 5255
SOME VEHICLES MAY EXHIBIT CONTAMINATED / CORRODED COOLANT, HIGH OR FLUCTUATING TEMP GAUGE, COOLANT ODOR, COOLANT OVERFLOW, BLOWN OR LEAKING HOSES, BLOWN HEAD GASKET, FAILED ENGINE, AND OR LACK OF HEAT. *TT
Bulletin Number: 5301
INFORMATION ON VEHICLES EXHIBITING AN INOPERATIVE POWER WINDOW. *TT
Bulletin Number: 5518
INFORMATION ON SERVICING OIL PAN GASKET LEAKS. *TT
Bulletin Number: 5897
EXPERIENCING A SQUEAKING AND / OR POPPING NOISE FROM THE FRONT OUTER TIRE RODS. *TT
Bulletin Number: 6612
SOME VEHICLES MAY EXHIBIT FRONT SUSPENSION NOISE DUE TO FRONT STRUT, FRONT SWAY BAR LINKS OR SYMPTOMS SUCH AS PREMATURE REAR BRAKE PAD WEAR DUE TO SEIZED REAR BRAKE CALIPERS OR SLIDES. *TT
Bulletin Number: 6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
Bulletin Number: 7292
NNERS OF THE EDSR-OF-THE-MONTH QUALITY AWARD ANNOUNCEMENT FOR SEPTEMBER. *TT
Bulletin Number: 7855
VEHICLES MAY EXHIBIT INTERMITTENT INSTRUMENT CONTROL PANEL (ICP) ILLUMINATION.
Bulletin Number: 8016
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INTEGRATED CONTROL PANEL (ICP) ILLUMINATION. **MR**
Bulletin Number: 8016
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INSTRUMENT CONTROL PANEL (ICP).
Bulletin Number: 8199
SOME VEHICLES MAY EXHIBIT A RATTLING OR CLUNKING NOISE FROM THE FRONT END (FRONT STABILIZER LINK) UNDER NORMAL DRIVING CONDITIONS.
Bulletin Number: 8316
SOME VEHICLES EQUIPPED WITH COMPACT DISC CHANGER MAY EXHIBIT A 6 DISC CD CHANGER THAT IS NOT EJECTING THE MAGAZINE OR IS NOT RESPONDING TO COMMAND FROM THE RADIO.
Bulletin Number: 8583
SOME VEHICLES MAY EXHIBIT DTC P1518 AND / OR P1519, RELATED TO INTAKE MANIFOLD RUNNER CONTROL (IMRC). *MR
Bulletin Number: 870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
Bulletin Number: 96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
Bulletin Number: 96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
Bulletin Number: 96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
Bulletin Number: 96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
Bulletin Number: 96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
Bulletin Number: 962511
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 962515
NOISE-"CREAKING" IN A-PILLAR WHEN GOING OVER BUMPS AND/OR TURNING-VEHICLES BUILT THROUGH 12/31/96. *JD
Bulletin Number: 96261
BODY - PRODUCT CHANGES FOR 1997 TAURUS/SABLE AND TAURUS SHO VEHICLES ELECTRICAL - PRODUCT CHANGES FOR 1997 TAURUS/SABLE AND TAURUS SHO VEHICLES MISCELLANEOUS - PRODUCT CHANGES FOR 1997 TAURUS/SABLE AND TAURUS SHO VEHICLES. *TW
Bulletin Number: 962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 962613
TRANSAXLE - AX4S - EXTENDED 2-3 SHIFT AND/OR HIGHER THAN EXPECTED ENGINE RPM DURING 2-3 SHIFT AT LIGHT TO MEDIUM THROTTLE AND/OR NO 2-3 SHIFT - VEHICLES EQUIPPED WITH 3.0L ENGINE - SERVICE TIP. *TW
Bulletin Number: 9705011635
INFORMATION IN TSB 97-09-04 IS INCORRECT. *YC
Bulletin Number: 9705019584
CONCERNS OF GRUNT OR GROAN DURING WHEEL RETURN. *YC
Bulletin Number: 97090297181
SOME VEHICLES DURING WET WEATHER CONDITIONS AND/OR WHEN DRIVING THROUGH PUDDLES AND /OR THE CRANKSHAFT PULLEY MAY BE DAMAGED. *YC
Bulletin Number: 97090297183
EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC
Bulletin Number: 97090297184
SOME VEHICLES MAY EXPERIENCE STATIC IN THE AM BAND OF THE RADIO WHILE DRIVING. *YC
Bulletin Number: 97111097231
DIAGNOSTIC AND INSPECTION PROCEDURE FOR FRONT SUSPENSION NOISE. *YC
Bulletin Number: 97111097234
VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC
Bulletin Number: 97111097237
CONCERNS WITH HARSH ENGAGEMENTS AND HARSH SHIFTS WITH DIAGNOSTIC TROUBLE CODES (DTCS) 628, P0741 AND/OR P1744. *YC
Bulletin Number: 9723
FRAME - SUBFRAME INSULATORS - CLUNK ON HEAVY ACCELERATION AND/OR DECELERATION HEARD OR FELT IN FLOOR PAN AREA - VEHICLES BUILT THROUGH 2/28/97. *TW
Bulletin Number: 9724
STEERING - GRUNTING OR GROANING NOISE DURING STEERING WHEEL RETURN FROM FULL RIGHT TURN - VEHICLES BUILT THROUGH 11/8/96. *TW
Bulletin Number: 9725
SUSPENSION - CLUNKING NOISE FROM FRONT SUSPENSION - TAURUS SABLE BUILT THROUGH 1/14/97 - CONTINENTAL BUILT THROUGH 12/16/96. *TW
Bulletin Number: 9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD
Bulletin Number: 9751
INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD
Bulletin Number: 97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
Bulletin Number: 976011
EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 9761
LOCKS- REMOTE KEYLESS ENTRY (RKE)- LOCATION OF RKE FOBS- SERVICE TIP- VEHICLES BUILT AFTER 3/17/97. *JD
Bulletin Number: 97610
BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD
Bulletin Number: 9763
STEERING- STEERING COLUMN- AIR BAG SLIDING CONTACT SERVICING- SERVICE TIP. *JD
Bulletin Number: 9765
HESITATION- ON ACCELERATION- VEHICLES WITH 3.0L 4-VALVE ENGINE. *JD
Bulletin Number: 9767
MALFUNCTION INDICATOR LAMP (MIL)- DIAGNOSTIC TROUBLE CODES (DTCS) P0172, P0175, P1130, P1150 AND/OR P1152 STORED IN MEMORY AND/OR STALL ON LOW SPEED ACCELERATION OR DECELERATION- 3.4L SHO VEHICLES ONLY. *JD
Bulletin Number: 9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
Bulletin Number: 9772
HESITATION- ON ACCELERATION- VEHICLES WITH 3.0L 4-VALVE ENGINE. *JD
Bulletin Number: 9802169837
SOME VEHICLES MAY EXPERIENCE AN NO FORWARD OR REVERSE MOVEMENT. *YC
Bulletin Number: 9802169838
TRANSAXLES USE A NEW TRANSMISSION FLUID. *YC
Bulletin Number: 980305
VEHICLES EXPERIENCING COOLANT ODOR, COOLANT OVERFLOW, HIGH OR FLUCTUATING TEMP GAUGE READINGS, BLOWN OR LEAKING HOSES, BLOWN HEAD GASKET, FAILED ENGINE, AND LACK OF HEAT. *YC
Bulletin Number: 980312
ENGINE CHECK LAMP ON WITH MISFIRE DTC(S).
Bulletin Number: 980314
EXPERIENCING A HARD START / LONG CRANK. *YC
Bulletin Number: 98110
SUBJECT REGARDING PASSIVE ANTI THEFT SYSTEM (PATS) DIAGNOSTIC SERVICE TIPS. *TT
Bulletin Number: 9811481
SOME VEHICLES EQUIPPED WITH 3.0L 4-VALVE ENGINES MAY EXHIBIT A CUSTOMER CONCERN OF A MOAN NOISE AT IDLE. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 98164
A TRANSEAL COATING IS ON THE FRONT AND REAR BUMPERS. THIS COATING MUST BE REMOVED BEFORE DELIVERY TO THE CUSTOMER. YD
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 982112
SOME VEHICLES EXPERIENCE A HARD START/LONG CRANK TIME CONDITION. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982320
SOME VEHICLES WITH A VERY LOW ODOMETER READING MAY EXPERIENCE A LACK TEMPERATURE CONTROL. *YC
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98241
DIAGNOSTIC SERVICE TIPS ON PASSIVE ANTI THEFT SYSTEM ( PATS ). *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 98251
CONCERNS OF A POSSIBLE CHAFING OF THE FUEL PUMP ASSEMBLY WIRES RESULTING IN AN OPEN FUSE AND/OR INOPERABLE FUEL PUMP ASSEMBLY OR A NO START CONDITION. *YC
Bulletin Number: 982513
EXHIBITING AN INOPERATIVE POWER WINDOW. *YC
Bulletin Number: 982514
CONCERNS WITH THE TIMING ARROWS/FLAGS ON THE BACK OF THE CAMSHAFT SPROCKET (S) ARE MIS-MARKED BY AS MUCH AS 30 DEGREES ROTATION. *YC
Bulletin Number: 982523
SOME ENGINE VALVES MAY EXHIBIT A CUSTOMER CONCERN OF A MOAN NOISE AT IDLE. *AK
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 982675
A REVISED FORWARD CLUTCH INNER SEAL FOR THE AXOD, AXODE, AX4S & AX4N TRANSAXLE IS AVAILABLE WITH IMPROVED SEALING AND REDUCED CHANCE OF THE SEAL ROLLING DURING INSTALLATION. *YC
Bulletin Number: 982742
SOME VEHICLES MAY EXHIBIT A STEERING GROAN NOISE. *YC
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 983112
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT NEUTRAL CONDITION AFTER DRIVING AND COMING TO A STOP. *TT
Bulletin Number: 983221
EXHIBITING A VIBRATION AT SPPEDS OF 45 MPH AND ABOVE WITH THE CRUISE ON.
Bulletin Number: 983496
SOME VEHICLES MAY EXHIBIT B1522 OR GEM "HOOD SW" PID CONCERNS. *TT
Bulletin Number: 983566
INFORMATION REGARDING PROGRAMMING / DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT
Bulletin Number: 983566
INFORMATION ON PROGRAMMING / DIAGNOSING ANY PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 98-4724
CONTAMINATED/CORRODED COOLANT, HIGH OR FLUCTUATING TEMPERATURE GAUGE. *AK
Bulletin Number: 98-4731
CLUNK OR PLOP COMING FROM FRONT END. *AK
Bulletin Number: 98-4735
HARD START/LONG CRANK.
Bulletin Number: 98-4737
ENGINE SPARK KNOCK ON ACCELERATION. *AK
Bulletin Number: 98-4741
FUEL GAUGE ACCURACY OR FUEL GAUGE ERRATIC OPERATION. *AK
Bulletin Number: 98-4803
SOME 1996-1998 TAURUS/SABLE VEHICLES WITH 3.0L 4-V ENGINE MAY EXHIBIT A CONCERN OF MOAN NOISE AT IDLE.
Bulletin Number: 984984
SOME VEHICLES EQUIPPED WITH 3.0L 2-VALVE ENGINES MAY EXHIBIT A SPARK KNOCK CONCERN ON ACCELERATION. *TT
Bulletin Number: 985065
REPEAT MESSAGE REGARDING HARD START / LONG CRANK CONDITION. *TT
Bulletin Number: 985083
SOME VEHICLES (3.0L 4 VALVE ONLY) MAY EXHIBIT A CATALYTIC CONVERTER BUZZ OR RATTLE CONDITION ON A COLD START OR DURING A LOW RPM STEADY SPEED. *TT
Bulletin Number: 9851
EXERPEINCING A MOANING NOISE HEARD FROM THE POWER STEERING DURING ENGINE IDLE. *TT
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9865
TORQUE CONVERTER CLUTCH NOT ENGAGING AND/OR DIAGNOSTIC TROUBLE CODE (DTC) P0741 OR P1744 STORED IN MEMORY. *YC
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 9874
A NEW SILICONE GASKET AND SEALANT. *YC
Bulletin Number: 9884
THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE FOR MISFIRES AT HIGH ENGINE RPMS DURNG ENGINE WARM UP. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 98B18
OWNER NOTIFICATION PROGRAM 98B18- COOLING SYSTEM BY-PASS KIT INSTALLATION. *AK
Bulletin Number: 98B23
THE OWNER NOTIFICATION PROGRAM 98B23 CONTAINED INCORRECT LABOR ALLOWANCE AND COOLANT PART NUMBER INFORMATION
Bulletin Number: 98B23S1
INSTALLATION OF COOLING SYSTEM BY-PASS KIT. *TT
Bulletin Number: 98B26
COOLING SYSTEM BY-PASS KIT INSTALLATION ON CERTAIN TAURUS VEHICLES EQUIPPED WITH 3.0L VULCAN METHANOL ENGINES. GASOLINE OR ETHANOL ENGINES ARE COVERED BY OWNER NOTIFICATION PROGRAM 98B23.*AK
Bulletin Number: 98B27
COOLANT BY-PASS KIT REPLACEMENT ON CERTAIN TAURUS VEHICLES. ENGINES PREVIOUSLY REPAIRED WITH 98B18 SERVICE BY-PASS KIT.
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99127
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P1135 OR P1155 STORED IN MEMORY AND / OR A LONG CRANK / SLOW START. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99183
SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT
Bulletin Number: 99184
SOME VEHICLES EQUIPPED WITH AX4S TRANSAXLE, MAY EXHIBIT A HARSH 2-3 DOWNSHIFT MAY OCCUR WHEN COASTING AROUND A CORNER AND THEN ACCELERATING. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99195
SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99234
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 9941
EXPERIENCING A MOANING NOISE FROM THE POWER STEERING DURING ENGINE IDLE. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 996123
CONCERNS WITH BUZZ OR VIBRATION WITH THE GEAR SELECTOR IN PARK. *TT
Bulletin Number: 996735
SOME VEHICLES EQUIPPED WITH THE AX4S TRANSAXLE MAY EXHIBIT A HARSH 3-2 DOWNSHIFT WHEN COASTING AROUND A CORNER AND THEN STEPPING INTO THE THROTTLE TO ACCELERATE AWAY FROM THE CORNER. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: 99B01
EXPERIENCING A LOSS OF AIR CONDITIONING FUNCTION, DUE TO A FRACTURE OF THE COMPRESSOR'S INTERNAL ROTOR. *TT
Bulletin Number: BC0011970201
A BUZZ NOISE IN AX4S TRANSAXLES ON 1996/97 TAURUS/SABLE AND WINDSTARS. *JD
Bulletin Number: BC0011972301
BUZZ NOISE IN AX4S TRANSAXLES. *JD
Bulletin Number: BC0042970201
FOR 1996 3.OL 2-VALVE VEHICLES STOP UPDATING THE PROCESSOR TO THE R-12 CALIBRATION. *JD
Bulletin Number: BC0042972301
FOR 1996 3.0L 2-VALVE VEHICLES STOP UPDATING THE PROCESSOR TO THE R-12 CALIBRATION. THIS UPDATE MAY CAUSE THE VEHICLE TO STALL ON COLD ENGAGEMENT. *JD
Bulletin Number: BC0130970201
REMOVING OR REPLACING ONE OF THE FRONT STRUT SPRINGS ON A 1996/97 TAURUS OR SABLE VEHICLE USE ROTUNDA #014-00781 STRUT SPRING COMPRESSOR MASTER SET. *JD
Bulletin Number: BC0144970201
RESIDUAL BRAKE PRESSURE ON THE REAR BRAKES OF A 1996-1997 TAURUS OR SABLE, MAKE SURE TO SUPPORT THE REAR CONTROL ARMS TO REMAIN AT THE NORMAL RIDE HEIGHT POSITION. IF THE REAR CONTRAL ARM ON THE DRIVERS SIDE IS ALLOWED TO HANG ALL THE WAY D
Bulletin Number: BC0152970201
WATER LEAK IN THE REAR OF A TAURUS OR SABLE WAGON, CHECK FOR WATER ENTERING IN AT THE REAR HATCH HINGES. *JD
Bulletin Number: BC0180970201
THE CRANKSHAFT DAMPER BOLT, FOUND UNDERNEATH THE PULLEY HAS A STANDARD RIGHT AND LEFT HAND THREAD. TO AVOID DAMAGE TO PLASTIC, AVOID USING HEAT. *JD
Bulletin Number: BC0196970201
NOISY FUEL PUMPS ON 1996/1997 TAURUS/SABLE VEHICLES. REVISED FUEL PUMP TO ALEVIATE NOISE. *JD
Bulletin Number: BC0251970201
ABS INDICATOR ILLUMINATION WITH DTC C1095. *JD
Bulletin Number: BC0252970201
UNEVEN IDLE RPM, STALL, ROUGH RUNNING, SURGE, AND/OR SPARK KNOCK WHEN THE COOLING FANS COME ON AT A IDLE. *JD
Bulletin Number: BC0253970201
OWNER GUIDE LISTS THAT THE 3.0L 2V VULCAN ENGINE USES A FL-400-S OIL FILTER AND THE 3.0L 4V DURATEC USES A FL-820-S FILTER. *JD
Bulletin Number: BC0264970201
THE REAR MAIN SEAL REMOVAL TOOL LISTED IN THE SERVICE MANUAL FOR THE 3.0L 4V DURATIC AND 4.6L CONTINENTAL ENGINES, IS INCORRECT. *JD
Bulletin Number: BC0307972301
BATTERY GOES DEAD- CHECK THE CURRENT DRAW WITH AN AMMETER. *JD
Bulletin Number: BC0307A97020
BATTERY OES DEAD OVERNIGHT. *TW
Bulletin Number: BC0308961101
THUMP/CLUNK NOISE FROM FRONT SUSPENSION AREA. *TW
Bulletin Number: BC0308970201
THUMP/CLUNK NOISE FROM FRONT SUSPENSION AREA. *JD
Bulletin Number: BC0308972301
THUMP/CLUNK NOISE FROM FRONT SUSPENSION AREA. *JD
Bulletin Number: BC0308A97020
THUMP/KLUNK NOISE FROM FRONT SUSPENSION AREA. *TW
Bulletin Number: BC0309970201
SURGE AT STEADY STATE CRUISE (POWER TRAIN SHUFFLE), MISFIRE CODES,STALLS AT HIGH AMBIENT TEMPERATURES. *TW
Bulletin Number: BC0309972301
SURGE AT STEADY CRUISE (POWER TRAIN SHUFFLE), MISFIRE CODES, STALLS AT HIGH AMBIENT TEMPERATURES. *JD
Bulletin Number: BC0503961108
DIAGNOSTIC PROCEDURE FOR SYSTEM INDICATORS KIT WITH DTCS C1165 AND/OR C1175. *TW
Bulletin Number: BC0535961108
THE EGR TUBE TORQUE SPECIFICATIONS IN SERVICE MANUAL ARE INCORRECT. *TW
Bulletin Number: BC0541961107
VEHICLES MAY EXHIBIT A WHISTLE CONDITION FROM THE A/C EVAPORATOR. *TW
Bulletin Number: BC0680961024
VEHICLES SHIPPED W/ LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC0713961021
CONCERNS OF A SURGE (POWERTRAIN SHUFFLE) AT 35-40 MPH. *TT
Bulletin Number: BC0762961016
REPETITIVE THUMPING/KNOCKING NOISE PROPORTIONAL TO WHEEL SPEED WHEN BRAKING. *TT
Bulletin Number: BC0850961007
CONCERNS OF VEHICLE STALL, HESITATION STUMBLE, ROUGH IDLE, MISSING, FUEL PRESSURE, OR FUEL PRESSURE RELATED CHECK THE REAR GROUND. *TT
Bulletin Number: BC0851961007
PROCEDURE FOR CONCERNS OF RIDE QUALITY. *TT
Bulletin Number: BC1010197020
NOISY FUEL PUMPS ON 1996/97 VEHICLES. A REVISED FUEL PUMP HAS BEEN RELEASED WITH A MODIFIED MANIFOLD OUTLET TO REDUCE NOISE. *JD
Bulletin Number: BC1010297020
ENGINES ARE EQUIPPED WITH A UNIQUE CRANKSHAFT PULLEY ASSEMBLY WHICH THREADS INTO THE CRANKSHAFT DAMPER USING A LEFT-HANDED THREAD. HEATING THE CRANKSHAFT PULLEY WILL DAMAGE THE RUBBER COMPONENTS. *JD
Bulletin Number: BC101209702
VERIFY THE TRANSAXLE INSTALLED IN THE VEHICLE IS THE CORRECT MODEL AND MODEL YEAR FOR THE VEHICLE. *JD
Bulletin Number: BC1012397020
RESIDUAL BRAKE PRESURE ON THE REAR BRAKES OF A 1996-1997 VEHICLE, MAKE SURE TO SUPPORT THE REAR CONTROL ARMS TO REMAIN AT THE NORMAL RIDE HEIGHT POSITION- SUPPORT DURING LIFTING PROCESS. *JD
Bulletin Number: BC1012497020
REMOVING OR REPLACING ONE OF THE FRONT STRUT SPRING ON A VEHICLE US A ROTUNDA #014-00781 STRUT SPRING COMPRESSOR MASTER SET. *JD
Bulletin Number: BC1013997010
MAY HAVE NO AUDIO IN CDDJ MODE. *JD
Bulletin Number: BC1016397230
BUZZ NOISE IN AX4S TRANSAXLES AT ALL SPEEDS OR IDLE ON VEHICLES. *JD
Bulletin Number: BC1019697230
REPLACING FRONT OR REAR STRUTS ON A 1996/97 VEHICLE, THE REPLACEMENT STRUT MAY APPEAR TO BE APPROXIMATELY 2" TOO SHORT WHEN COMPARED TO THE STRUT IN THE VEHICLE. *JD
Bulletin Number: BC1021497230
WATER LEAK AT THE RIGHT FRONT FLOOR, CHECK FOR A BROKEN COWL TOP INNER PANEL SHIELD. *JD
Bulletin Number: BC1025097230
PASSIVE ANTI-THEFT SYSTEM. *JD
Bulletin Number: BC1029897020
KNOCK OR WOP NOISE FROM THE ENGINE COMPARTMENT NEAR THE FRONT OF THE ENGINE. *JD
Bulletin Number: BC1030097020
WHISTLE OR SQUEAL NOISE IN THE ENGINE COMPARTMENT ON 1997 VEHICLES BUILT BEFORE 11/1/96 WITH THE 2-VALVE ENGINE. *JD
Bulletin Number: BC1030697020
GROAN OR MOAN NOISE FROM THE POWER STEERING WHEN RETURNING FROM A RIGHT TURN. *JD
Bulletin Number: BC1032697020
VEHICLES HAVE A CABIN AIR FILTER THAT MUST BE CHANGED EVERY 15000 MILES. *JD
Bulletin Number: BC105739705
WHEN PERFORMING THE AIR BAG DEACTIVATION PROCEDURE, THE SERVICE MANUALS DO NOT CLEARLY STATE WHICH SIMULATORS TO USE ON THE PASSENGER SIDE AIR BAG. *TW
Bulletin Number: BC2224970501
VEHICLES MAY EXPERIENCE A KNOCK OR WOP NOISE IN THE PASSENGER COMPARTMENT. *TW
Bulletin Number: BC2310970501
DEACTIVATION PROCEDURE - CLARIFICATION OF INSTRUCTIONS IN SERVICE MANUAL. *TW
Bulletin Number: BC2311970501
SOME VEHICLES MAY EXHIBIT A CLUNKING NOISE FROM THE REAR SUSPENSION WHEN DRIVING OVER BUMPS. *TW
Bulletin Number: BC2380970501
HARSH 1-2 UPSHIFT. *TW
Bulletin Number: BC3061970228
REPEAT POWER STEERING GRUNT/GROAN AFTER COMPLETION OF TSB 97-02-04. *TW
Bulletin Number: BC3100970224
MICRON FILTER - REMINDER THAT THE FILTER MUST BE CHANGED EVERY 15000 MILES - SYMPTOMS THAT MIGHT INDICATE NEED FOR CHANGE INCLUDE POOR A/C-HEATER PERFORMANCE AND/OR WINDOW FOGGING. *TW
Bulletin Number: BC3142970220
GROAN OR MOAN NOISE FROM THE POWER STEERING WHEN RETURNING FROM A RIGHT TURN. *TW
Bulletin Number: BC3205970214
CONCERN OF WATER INGESTION IN ENGINE. *TW
Bulletin Number: BC3272970207
VEHICLES ARE EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) - VEHICLE WILL NOT START WITHOUT THE CORRECT IGNITION KEY. *TW
Bulletin Number: BC3410972301
WATER LEAK AT THE RIGHT FRONT FLOOR ON VEHICLES, CHECK FOR A BROKEN COWL TOP INNER PANEL SHIELD. *JD
Bulletin Number: BC3482972301
REPLACING FRONT REAR STRUTS ON A VEHICLE, THE REPLACEMENT STRUT MAY APPEAR TO BE APPOXIMATELY 2" TOO SHORT. *JD
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC9584961001
INFORMATION FOR CONCERNS OF GRUNT OR GROAN DURING WHEEL RETURN FROM FULL RIGHT TURN. *TT
Bulletin Number: BC9683961001
PROCEDURE FOR UPDATING THE CALIBRATION FROM R-11 TO R-12 FOR STALLING ON DECEL & MISFIRE CODES ON 3.0L VEHICLES. *TT
1997 FORD TAURUS SHO
Bulletin Number: 00E11
SERVICE ACTION BULLETIN REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
Bulletin Number: 00E11
SERVICE ACTION 00E11, SUPPLEMENT #1 - UPDATE INFORMATION REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT
Bulletin Number: 03144
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 12570
SOME VEHICLES MAY EXHIBIT FRONT OUTER TIE RODS SQUEAK AND / OR POP NOISE OVER BUMPS AND / OR TURNING. *TT
Bulletin Number: 13802
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INSTRUMENT CONTROL PANEL (ICP) ILLUMINATION. *MJS
Bulletin Number: 15128
SOME VEHICLES MAY EXHIBIT A HARSH 2-3 SHIFT AFTER INSTALLING A REMANUFACTURED TRANSAXLE. *SLC
Bulletin Number: 5249
INFORMATION ON VEHICLES EXHIBITING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT
Bulletin Number: 5897
EXPERIENCING A SQUEAKING AND / OR POPPING NOISE FROM THE FRONT OUTER TIRE RODS. *TT
Bulletin Number: 980314
EXPERIENCING A HARD START / LONG CRANK. *YC
Bulletin Number: 99127
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P1135 OR P1155 STORED IN MEMORY AND / OR A LONG CRANK / SLOW START. *TT
Bulletin Number: 996123
CONCERNS WITH BUZZ OR VIBRATION WITH THE GEAR SELECTOR IN PARK. *TT
1997 FORD TAURUS (SHO)
Bulletin Number: 8016
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INTEGRATED CONTROL PANEL (ICP) ILLUMINATION. **MR**
1997 FORD TEMPO
Bulletin Number: BC3274970207
REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS A
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC9666961001
2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT
1997 FORD THUNDERBIRD
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH
Bulletin Number: 0222
SOME VEHICLES MAY EXHIBIT AN INTAKE MANIFOLD CROSSOVER (FIRST RUNNER) COOLANT SEEPAGE CONDITION. *TT
Bulletin Number: 02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 03261
NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 05N04
EXTENDED COVERAGE PROGRAM 05N04 - EXTENDED COVERAGE FOR COMPOSITE INTAKE MANIFOLD. THIS PROGRAM IS BEING PROVIDED AS A SETTLEMENT TO A CLASS ACTION LAWSUIT. THE TERMS OF THE SETTLEMENT EXTEND THE COVERAGE OF THE ALL-COMPOSITE INTAKE MANIF
Bulletin Number: 07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
Bulletin Number: 12098
SOME VEHICLES WITH NON-FUNCTIONAL WINDSHIELD WIPERS MAY REQUIRE WIPER MOTOR REPLACEMENT. *MJS
Bulletin Number: 13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
Bulletin Number: 13186
INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS
Bulletin Number: 6996
INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT
Bulletin Number: 6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
Bulletin Number: 870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
Bulletin Number: 96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
Bulletin Number: 96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
Bulletin Number: 96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
Bulletin Number: 96226
AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW
Bulletin Number: 96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
Bulletin Number: 96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
Bulletin Number: 962511
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 96252
LOCKS - REPLACE AND/OR REPAIR ANY LOCK COMPONENT - SERVICE TIP. *TW
Bulletin Number: 962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 97050110617
VEHICLES MAY EXPERIENCE ILLUMINATION OF THE ENGINE COOLING INDICATOR LIGHT. *TW
Bulletin Number: 97090297184
SOME VEHICLES MAY EXPERIENCE STATIC IN THE AM BAND OF THE RADIO WHILE DRIVING. *YC
Bulletin Number: 97111097234
VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC
Bulletin Number: 9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD
Bulletin Number: 9751
INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD
Bulletin Number: 97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
Bulletin Number: 9753
VIBRATION- TIRES- VIBRATION FELT WHILE DRIVING AT HIGHWAY SPEEDS- VEHICLES BUILT THROUGH 12/20/96 EQUIPPED WITH 16 INCH GOODYEAR TIRES. *JD
Bulletin Number: 97610
BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD
Bulletin Number: 9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
Bulletin Number: 9773
VIBRATION- SHUDDER OR VIBRATION UNDER LIGHT TO MODERATE ACCELERATION ABOVE 56 KM/H (35 MPH) WHILE IN 3RD OR 4TH GEAR- VEHICLES EQUIPPED WITH AODE OR 4R70W TRANSMISSION. *JD
Bulletin Number: 97M91
INFORMATION REGARDING ADDITIONAL COVERAGE FOR INTAKE MANIFOLD MALFUNCTIONS. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 98163
LOCKS FAILED. YD
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 98216
A STEERING WHEEL MOVEMENT FELT WHEN DRIVING OVER ROUGH SURFACES.
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 982312
ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC
Bulletin Number: 982323
INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 983107
BRIEF INFORMATION REGARDING ENGINES BEING ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *TT
Bulletin Number: 983108
EFFECTIVE MARCH 2, 1998M3.8L ENGINE ASSEMBLY IS ADDED TO FQR(FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *AK
Bulletin Number: 983224
SOME VEHICLES MAY HAVE WATER CONTAMINATION IN THE AIR FILTER AND / OR THE MASS AIR FLOW SENSOR. *TT
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 9834
AIR INLET-WATER IN AIR INLET ELBOW-MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATES DUE TO WATER CONTAMINATION OF AIR FILTER AND/OR MASS AIR FLOW SENSOR (MAF)- VEHICLE SWITH 4.6L ENGINE. *AK
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 985111
SOME VEHICLES WITH NON-FUNCTIONAL WINDSHIELD WIPERS MAY REQUIRE WIPER MOTOR REPLACEMENT. *TT
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
Bulletin Number: 985A18
SOME VEHICLES MAY EXHIBIT BRAKE ROUGHNESS (BRAKE PEDAL PULSATION, STEERING WHEEL SHAKE AND / OR NIBBLE) UNDER LIGHT BRAKE APPLICATIONS FROM 105 TO 0 KM/H (65 TO 0 MPH). *YC
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 9874
A NEW SILICONE GASKET AND SEALANT. *YC
Bulletin Number: 9887
EXPERIENCING A TORQUE CONVERTER CLUTCH SHUDDER OR VIBRATION. *YC
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 99129
INFORMATION ON "WHINING" / "BUZZING" NOISE COMING THROUGH ENTERTAINMENT OR TWO-WAY RADIO SPEAKER CAUSED BY THE FUEL PUMP. *TT
Bulletin Number: 99131
CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99207
SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 99242
INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: 9996
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT
Bulletin Number: 99B29
SOME VEHICLES MAY EXPERIENCE ENGINE COOLANT LEAKS AT THE ENGINE FRONT COVER GASKET. OWNER NOTIFICATION PROGRAM PROVIDING REPLACEMENT OF THE ENGINE FRONT COVER GASKET. *TT
Bulletin Number: 99B29#1
INFORMATION REGARDING REPLACMENT OF ENGINE FRONT COVER GASKET. **MR
Bulletin Number: BC0192970201
LOW COOLANT LIGHT STAYS ON. THE LOW FLUIDS MODULE IN THE CLUSTER NOT MAKING ELECTRICAL CONTACT WTH THE FLEX CURCUIT IN THE CLUSTER. *JD
Bulletin Number: BC0226970201
ERRATIC SHIFTHING OF THE TRANSMISSION. *JD
Bulletin Number: BC0407961115
INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED PARTS. *TW
Bulletin Number: BC0490961112
INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED COMPONENT. *TW
Bulletin Number: BC0696961023
CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT
Bulletin Number: BC0810961011
VEHICLES EQUIPPED W/ AN AODE OR 4R70W TRANS HAS A CONCERN OF SHUDDER FROM THE TRANSMISSION TORQUE CONVERTER CLUTCH IN 3RD OR 4TH GEAR OR DURING 3-4 SHIFT. *TT
Bulletin Number: BC1023897230
VEHICLE EXHIBITS A PULL WHILE BRAKING, FOLLOW PROCEDURES OUTLINED IN 06-00-4 & PINPOINT TEST "A" ON 06-00-5 OF THE 1997 SERVICE MANUAL. *JD
Bulletin Number: BC1024397230
VEHICLES BUILT BETWEEN AUGUST 1996 AND JANUARY 1997 MAY EXHIBIT FLASHING LOW COOLANT AND LOW WASHER FLUID LAMPS AFTER ENGINE START.JD
Bulletin Number: BC105709705
INSTRUCTIONS FOR RE-INSTALLING LOOSE FENDER CLADDING. *TW
Bulletin Number: BC105869705
OCCASIONAL FLASHING OF THE LOW COOLANT AND LOW WASHER FLUID WARNING LAMPS SIMULTANEOUSLY DURING LOW TEMPERATURES. *TW
Bulletin Number: BC2291970501
COMPLAINTS OF FLASHING LOW COOLANT AND LOW WASHER FLUID WARNING LAMPS. *TW
Bulletin Number: BC2364970501
INSTRUCTIONS FOR REMOVING AND REINSTALLING A LOOSE FENDER CLADDING. *TW
Bulletin Number: BC3243970210
ENGINE COOLING LIGHT ON - POSSIBLE OIL LEAK AT UPPER JAM NUT ON THE UPPER TRANSMISSION COOLER LINE. *TW
Bulletin Number: BC3274970207
REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS A
Bulletin Number: BC3281970206
VEHICLES EXHIBIT A PULL WHILE BRAKING - CHECK FOR KINKED BRAKE LINES , REPLACE IF NECESSARY - REPLACE LOWER ARM AND STRUT BUSHINGS ON THE SIDE THE VEHICLE PULL TO. *TW
Bulletin Number: BC3285970206
VEHICLES MAY EXHIBIT FLASHINIG COOLANT AND LOW WASHER FLUID LAMPS AFTER ENGINE START AND DURING EXTREMELY LOW TEMPERATURES. *TW
Bulletin Number: BC3288970206
VEHICLES MAY EXHIBIT A COLD START ENGINE FEAD BELT CHIRP NOISE. *TW
Bulletin Number: BC5195961001
FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC9714961101
DIAGNOSTIC INSTRUCTIONS FOR SERVICING EVAPORATIVE EMISSION PURGE FLOW SYSTEM. *TW
1997 FORD WINDSOR
Bulletin Number: 982515
SOME VEHICLES MAY EXHIBIT A RATTLE NOISE FROM LH OR RH FRONT DOOR, GLASS-RUN RETAINER. *YC
Bulletin Number: 982675
A REVISED FORWARD CLUTCH INNER SEAL FOR THE AXOD, AXODE, AX4S & AX4N TRANSAXLE IS AVAILABLE WITH IMPROVED SEALING AND REDUCED CHANCE OF THE SEAL ROLLING DURING INSTALLATION. *YC
1997 FORD WINDSTAR
Bulletin Number:
CLIMATE CONTROL IS INVESTIGATING CONCERNS OF BROKEN AND OR BINDING BLEND DOORS ON SOME VEHICLES. *TT
Bulletin Number: 0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
Bulletin Number: 01124
ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT
Bulletin Number: 01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
Bulletin Number: 01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
Bulletin Number: 011701
INFORMATION REGARDING REPLACEMENT APPLICATION CHART. *ET
Bulletin Number: 01171
TRANSAXLE - AX4S - REPLACEMENT APPLICATION CHART - WINDSTAR VEHICLES ONLY. *NLM
Bulletin Number: 01181
BRAKE SHIFT INTERLOCK.*JB
Bulletin Number: 01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT
Bulletin Number: 01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
Bulletin Number: 0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
Bulletin Number: 02132
GRUNT / POPPING NOISE COMING FROM THE FRONT SUSPENSION AT SPEEDS BELOW 20 MPH WHEN TURNING. *TT
Bulletin Number: 0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT
Bulletin Number: 02152
SOME VEHICLES MAY EXHIBIT A POPPING / GRINDING NOISE FROM THE FRONT OF THE VEHICLE WHEN GOING OVER BUMPS OR MAKING TURNS. *TT
Bulletin Number: 02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
Bulletin Number: 02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH
Bulletin Number: 02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
Bulletin Number: 03123
TORQUE CONVERTER CLUTCH NOT ENGAGING WHEN COMMANDED AND/OR DIAGNOSTIC TROUBLE CODES P0741 OR P1744 STORED IN MEMORY. MODELS FROM 1996 TO 2003. *TT
Bulletin Number: 03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Bulletin Number: 03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT
Bulletin Number: 03203
MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT
Bulletin Number: 0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT
Bulletin Number: 042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT
Bulletin Number: 04L23
LITERATURE PROGRAM 04L23. CUSTOMER MAINTENANCE REMINDER - ALUMINUM WHEEL LUG NUT TORQUE. *TT
Bulletin Number: 11474
SOME MODEL YEAR VEHICLES MAY EXHIBIT A CUSTOMER CONCERN OF REAR END NOISE OVER BUMPS. *TT
Bulletin Number: 11505
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT
Bulletin Number: 12099
VEHICLES WITH THE AX4S TRANSAXLE HAVE AN INLINE TRANSMISSION COOLER BYPASS VALVE LOCATED IN THE COOLER LINE NEAR THE RADIATOR COOLER. *MJS
Bulletin Number: 12114
SOME VEHICLES MAY EXHIBIT A FRONT END GRIND/CRUNCH NOISE DURING A SLOW SPEED TURN. *MJS
Bulletin Number: 12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS
Bulletin Number: 12178
INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. *MJS
Bulletin Number: 12227
FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12230
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT
Bulletin Number: 12559
CONCERNS WITH REVERSE CLUTCH THAT COULD BECOME SHEARED OR TORN IN EXTREMELY COLD TEMPERATURES. *TT
Bulletin Number: 12616
INFORMATION ON TRANSAXLE SERVICE CASE REPLACEMENT WITH OSS (OUTPUT SHAFT SPEED SENSOR) HOLE. *TT
Bulletin Number: 12808
SOME VEHICLES MAY EXHIBIT ABS (ANTI-LOCK BRAKE SYSTEM) LOW SPEED FALSE ACTIVATION WITH NO DTC (DIAGNOSTIC TROUBLE CODE). *TT
Bulletin Number: 13024
SOME VEHICLES EQUIPPED WITH THE AX4S TRANSAXLE MAY EXHIBIT A HARSH 3-2 DOWNSHIFT WHEN COASTING AROUND A CORNER AND THEN STEPPING INTO THE THROTTLE TO ACCELERATE AWAY FROM THE CORNER. *TT
Bulletin Number: 13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
Bulletin Number: 13186
INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS
Bulletin Number: 13242
INFORMATION REGARDING TSB 97-20-08 FOR 3.8L ENGINES ONLY. *MJS
Bulletin Number: 13309
SOME VEHICLES WITH 3.8L ENGINE MAY EXHIBIT BLACK SOOT ON THE LOWER SECTION OF THE RIGHT REAR QUARTER PANEL. *TT
Bulletin Number: 13931
SOME VEHICLES MAY EXHIBIT THE METAL TABS ON THE LIFTGATE INNER PANEL THAT BOND TO THE OUTER SKIN SEPARATING AND CAUSING A RATTLE IN THE LIFTGATE. *TT
Bulletin Number: 14222
CONCERNS WITH SUBFRAME CLUNK ON ACCELERATION / DECELERATION FROM FRONT OF VEHICLE. *TT
Bulletin Number: 14656
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT
Bulletin Number: 14773
INFORMATION ON INDEXING ORANGE DOT ON TORQUE CONVERTER TO FLEXPLATE. *TT
Bulletin Number: 15370
SOME VEHICLES MAY EXHIBIT A GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK. *TT
Bulletin Number: 15373
SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES. *TT
Bulletin Number: 15392
SOME VEHICLES MAY EXHIBIT A PARK PULLOUT CLUNK NOISE WHEN SHIFTING FROM PARK TO ANOTHER GEAR POSITION. *TT
Bulletin Number: 15682
EXHIBITING INTERMITTENT ANTI-SKID BRAKE SYSTEM AND / OR RED BRAKE LAMP ON AT TIMES WHILE DRIVING. *TT
Bulletin Number: 15719
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT
Bulletin Number: 15767
SUBJECT REGARDING POWER STEERING LINE PART ORDERING INFORMATION. *TT
Bulletin Number: 16987
SLIGHT AMOUNT OF FLUID RESIDUE ON THE OUTSIDE OF THE REAR WHEEL CYLINDER DUST BOOT ON VEHICLES WITH REAR DRUM BRAKES. *TT
Bulletin Number: 17358
GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE. *TT THIS BULLETIN UPDATES PREVIOUS BULLETIN 17358, DATED 11/01/2003 TO INCLUDE 2005 MODELS. *TT
Bulletin Number: 4639
INFORMATION ON DIAGNOSTIC PROCEDURES FOR VEHICLES EXHIBITING CHECK ENGINE LAMP ON AND MISFIRE DIAGNOSTIC TROUBLE CODES P0300 - P0306. *TT
Bulletin Number: 5131
SUBJECT REGARDING VEHICLES WITH THE AX4S TRANSAXLE HAVING AN INLINE TRANSMISSION COOLER BYPASS VALVE LOCATED IN THE COOLER LINE NEAR THE RADIATOR COOLER. *TT
Bulletin Number: 5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT
Bulletin Number: 5518
INFORMATION ON SERVICING OIL PAN GASKET LEAKS. *TT
Bulletin Number: 6392
SOME VEHICLES MAY EXHIBIT ABS (ANTI-LOCK BRAKE SYSTEM) LOW SPEED FALSE ACTIVATION WITH NO (DTC) DIAGNOSTIC TROUBLE CODE. *TT
Bulletin Number: 6996
INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT
Bulletin Number: 6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
Bulletin Number: 7120
SOME VEHICLES MAY EXHIBIT BLACK SOOT EMITTED FROM THE TAILPIPE LEAVING DEPOSITS ON RIGHT REARL LOWER QUARTER PANEL. *TT
Bulletin Number: 8249
SOME VEHICLES MAY EXHIBIT THE METAL TABS ON THE LIFTGATE INNER PANEL THAT BOND TO THE OUTER SKIN SEPARATING AND CAUSING A RATTLE IN THE LIFTGATE. *TT
Bulletin Number: 870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
Bulletin Number: 96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
Bulletin Number: 962214
SERVICE MANUAL - POWERTRAIN CONTROL/EMISSIONS DIAGNOSIS (PC/ED) ON BOARD DIAGNOSIS II (OBD II) - COVER PAGE REPLACEMENT TO INCLUDE 1997 WINDSTAR. *TW
Bulletin Number: 96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
Bulletin Number: 96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
Bulletin Number: 96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
Bulletin Number: 96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
Bulletin Number: 962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
Bulletin Number: 962613
TRANSAXLE - AX4S - EXTENDED 2-3 SHIFT AND/OR HIGHER THAN EXPECTED ENGINE RPM DURING 2-3 SHIFT AT LIGHT TO MEDIUM THROTTLE AND/OR NO 2-3 SHIFT - VEHICLES EQUIPPED WITH 3.0L ENGINE - SERVICE TIP. *TW
Bulletin Number: 97110
SUSPENSION-DIAGNOSTIC AAN INSPECTION FOR FRONT SUSPENSION NOISE (S)- SERVICE TIP. *AK TIP.
Bulletin Number: 971110972311
CONDITIONS WITH NOISE COMING FROM THE RIGHT UPPER A-PILLAR AREA DURING TURNS. *YC
Bulletin Number: 97111097234
VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC
Bulletin Number: 97111097237
CONCERNS WITH HARSH ENGAGEMENTS AND HARSH SHIFTS WITH DIAGNOSTIC TROUBLE CODES (DTCS) 628, P0741 AND/OR P1744. *YC
Bulletin Number: 97115
SERVICE MANUAL- POWERTRAIN CONTROL/EMISSIONS DIAGNOSIS (PC/ED) ON-BOARD DIAGNOSIS II (OBD II)- COVER PAGE REPLACEMENT TO INCLUDE 1997 VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD
Bulletin Number: 97120897251
THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY SLIP MOMENTARILY IN WET CONDITIONS CAUSING A REDUCTION IN POWER STEERING ASSIST OR THE GENERATOR LAMP. *YC
Bulletin Number: 97211
BRAKES - ANTI-LOCK - ABS PUMP MOTOR ACTIVATION WHILE BRAKING OVER A BUMP OR AN INCLINE - VEHICLES WITH TRACTION CONTROL - VEHICLES BUILT THROUGH 9/15/96. *TW
Bulletin Number: 9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD
Bulletin Number: 9751
INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD
Bulletin Number: 97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
Bulletin Number: 97516
ENGINE- 3.8L - "CHIRPING" NOISE DURING NORMAL ENGINE OPERATION. *JD
Bulletin Number: 97610
BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD
Bulletin Number: 97624
AIR CONDITIONING- WATER DRIPPING ONTO FLOOR DRAIN TUBE DURING A/C SYSTEM OPERATION. *JD
Bulletin Number: 9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
Bulletin Number: 9775
HOOD- SERVICE REPAIR TIPS. *JD
Bulletin Number: 980304
INTERMITTENT NO FORWARD ENGAGEMENT WITH OR WITHOUT DTC P1784 ACTION. *AK
Bulletin Number: 980311
CHECK ENGINE LAMP ON AND MISFIRE DTC (S) P0300-P0306. *YC
Bulletin Number: 98-0316
CONCERNS WITH SLOW FUEL FILL, DISTORTED FUEL TANK, FUEL GAGE ERRATIC, FUEL ODOR. *TT
Bulletin Number: 9811349
VEHICLES WITH POWER DOOR LOCKS MAY EXHIBIT AN INTERMITTENT OPERATION OR GRIND WHEN CYCLED. *TT
Bulletin Number: 9811484
SOME HIGH MILEAGE VEHICLE MAY EXHIBIT A CUSTOMER CONCERN OF INOPERATIVE OVERDRIVE CANCEL LIGHT. *TT
Bulletin Number: 98125
VEHICLE MAY EXHIBIT A "WHISTLING" NOISE HEARD FROM THE A/C PLENUM. *TT
Bulletin Number: 98127
EXPERIENCING ACCELERATOR PEDAL "BUZZING" NOISE AND / OR EXHAUST "DRONING" NOISE AT APPROXIMATELY 1700 RPM WHLE DRIVING. *TT
Bulletin Number: 9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
Bulletin Number: 981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK
Bulletin Number: 981519
TRACTION CONTROL LAMP FLASING INTERMITTENTLY WITH DIAGNOSTIC TROUBLE CODES U1009 AND/OR U1027. *AK
Bulletin Number: 98153
THIS TSB IS BEING REPUBLISHED IN ITS ENTIRETY TO REVISE THE POWER TRAIN CONTROL MODULE (PCM) CALIBRATION CROSS REFERENCE AND REVISE PCM SERVICE PART NUMBERS. *AK
Bulletin Number: 981617
FLOOR MAT INSTALLATION PROCEDURE SERVICE TIP. YD
Bulletin Number: 982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
Bulletin Number: 982011
CONCERNS OF WEBBING TWISTS OR BINDS ON INTEGRATED CHILD SAFETY SEAT (ICS) BELT. *YC
Bulletin Number: 98221
INTERMITTENT NEUTRAL CONDITION AFTER DRIVING AND COMING TO A STOP. *YC
Bulletin Number: 982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
Bulletin Number: 98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
Bulletin Number: 982465
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEEZING TEMPERATURES. *YC
Bulletin Number: 982511
SERVICE TIPS ON COMPOSITE FUEL RAIL. *YC
Bulletin Number: 982512
SOME VEHICLES MAY EXHIBIT A CUSTOMER CONCERN OF INOPERATIVE OVERDRIVE CANCEL LIGHT. *YC
Bulletin Number: 982535
EXHIBITING A CUSTOMER CONCERN OF REAR END NOISE OVER BUMPS. *YC
Bulletin Number: 98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC
Bulletin Number: 982675
A REVISED FORWARD CLUTCH INNER SEAL FOR THE AXOD, AXODE, AX4S & AX4N TRANSAXLE IS AVAILABLE WITH IMPROVED SEALING AND REDUCED CHANCE OF THE SEAL ROLLING DURING INSTALLATION. *YC
Bulletin Number: 982677
SOME VEHICLES MAY EXHIBIT A HIGH PITCH WHISTLE FROM THE HEATER CORE HOUSING CASE. *YC
Bulletin Number: 983094
SOME VEHICLES WITH POWER DOOR LOCKS MAY EXHIBIT AN INTERMITTENT OPERATION OR GRIND WHEN CYCLED. *TT
Bulletin Number: 9831
REPAIRS TO VINYL COVERED SURFACES. *YC
Bulletin Number: 983101
SOME VEHICLES MAY EXHIBIT A NOISE WHILE TURNING OR BRAKING. *TT
Bulletin Number: 983108
EFFECTIVE MARCH 2, 1998M3.8L ENGINE ASSEMBLY IS ADDED TO FQR(FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *AK
Bulletin Number: 9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC
Bulletin Number: 983303
CONCERNS OF BROKEN AND OR BINDING BLEND DOOR. *TT
Bulletin Number: 983581
SOME VEHICLES MAY EXHIBIT CONDITIONS OF EXHAUST DRONE AT 1700 RPM. *TT
Bulletin Number: 98416
EXPERIENCING A GRINDING NOISE OR INOPERATIVE DOOR LOCK MAY OCCUR WHEN CYCLING THE POWER FRONT DOOR LOCKS ON SOME VEHICLES. *TT
Bulletin Number: 9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
Bulletin Number: 98-4723
ENGINE CHECK LAMP ON, AND MISFIRE DTC (S) PO300-PO306 ACTION.
Bulletin Number: 985020
SOME VEHICLES BUILT THROUGH 9/8/97 MAY EXHIBIT A CONDITION OF MULTIPLE DIAGOSTIC TROUBLE CODES. THIS MAY BE CAUSED BY BRAKE FLUID AND WATER CONTAMINATION OF CIRCUIT 361 AND CONNECTOR C102 UNDER THE MASTER CYLINDER. *AK
Bulletin Number: 985086
SOME VEHICLES MAY EXHIBIT A CUSTOMER CONCERN DESCRIBED AS AN AIR CONDITIONER HISS NOISE. *TT
Bulletin Number: 985137
SOME VEHICLES MAY EXHIBIT A FRONT END GRIND / CRUNCH NOISE DURING A SLOW SPEED TURN. *TT
Bulletin Number: 98515
SOME VEHICLES MAY EXHIBIT A SQUEAKING, RATTLING, CHIRPING, TICKING AND / OR BUZZING NOISE HEARD FROM THE INSTRUMENT PANEL AREA. *YC
Bulletin Number: 9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
Bulletin Number: 9855
WET CARPET AND/OR HEADLINER IN CARGO AREA. *YC
Bulletin Number: 985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
Bulletin Number: 985A28
SOME VEHICLES EXPERIENCE THE PARKING BRAKE MAY NOT RELEASE. *YC
Bulletin Number: 985A48
ON SOME VEHICLES THE ANTI-LOCK BRAKE SYSTEM (ABS) PUMP MOTOR MAY RUN WHILE APPLYING THE BRAKE WHEN TURNING AND DRIVING OVER A BUMP. *TT
Bulletin Number: 985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
Bulletin Number: 9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
Bulletin Number: 9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
Bulletin Number: 9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
Bulletin Number: 99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT
Bulletin Number: 991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT
Bulletin Number: 99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
Bulletin Number: 9913073
CLIMATE CONTROL IS INVESTIGATING CONCERNS OF BROKEN AND / OR BINDING BLEND DOORS. *TT
Bulletin Number: 99131
CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: 99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
Bulletin Number: 99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
Bulletin Number: 99183
SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT
Bulletin Number: 99184
SOME VEHICLES EQUIPPED WITH AX4S TRANSAXLE, MAY EXHIBIT A HARSH 2-3 DOWNSHIFT MAY OCCUR WHEN COASTING AROUND A CORNER AND THEN ACCELERATING. *TT
Bulletin Number: 99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
Bulletin Number: 99195
SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT
Bulletin Number: 99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
Bulletin Number: 99207
SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT
Bulletin Number: 99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
Bulletin Number: 9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT
Bulletin Number: 996735
SOME VEHICLES EQUIPPED WITH THE AX4S TRANSAXLE MAY EXHIBIT A HARSH 3-2 DOWNSHIFT WHEN COASTING AROUND A CORNER AND THEN STEPPING INTO THE THROTTLE TO ACCELERATE AWAY FROM THE CORNER. *TT
Bulletin Number: 99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
Bulletin Number: 99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
Bulletin Number: BC0011970201
A BUZZ NOISE IN AX4S TRANSAXLES ON 1996/97 TAURUS/SABLE AND WINDSTARS. *JD
Bulletin Number: BC0011972301
BUZZ NOISE IN AX4S TRANSAXLES. *JD
Bulletin Number: BC0083970201
IF RED BRAKE LAMP OR THE YELLOW ABS LAMP IS ON, VERIFY THE MASTER CYLINDER IS FULL WITH BRAKE FLUID. *JD
Bulletin Number: BC0122970201
UNIQUE COLD START UP STRATEGY THAT WILL RAISE INITIAL COLD FAST IDLE TO 2100 RPM. *JD
Bulletin Number: BC0141970201
VERIFY THE TRANSAXLE INSTALLED IN THE VEHICLE IS THE CORRECT MODEL AND MODEL YEAR FOR THE VEHICLE. *JD
Bulletin Number: BC0680961024
VEHICLES SHIPPED W/ LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC0990961021
INFORMATION ON ENGINE OIL LEAK AT THE OIL PAN, FRONT COVER &/OR THE FRONT & REAR CRANKSHAFT OIL SEAL. *TT
Bulletin Number: BC101209702
VERIFY THE TRANSAXLE INSTALLED IN THE VEHICLE IS THE CORRECT MODEL AND MODEL YEAR FOR THE VEHICLE. *JD
Bulletin Number: BC1013097020
COLD START UP STRATEGY THAT WILL RAISE INITIAL COLD FAST IDLE TO 2100 RPM. *JD
Bulletin Number: BC1013697020
INOPERTIVE AUTOLOCK SYSTEM. *JD
Bulletin Number: BC1014497020
COMPLAINTS OF THE RED BRAKE LAMP OR THE YELLOW ABS LAMP ON, CHECKING THE MASTER CYLINDER BRAKE FLUID LEVEL SHOULD BE THE FIRST STEP. *JD
Bulletin Number: BC1016397230
BUZZ NOISE IN AX4S TRANSAXLES AT ALL SPEEDS OR IDLE ON VEHICLES. *JD
Bulletin Number: BC1017197230
VEHICLES BUILT BETWEEN 2/95 AND 9/01/96 MAY EXPERIENCE ROUGH/HARSH OR IRREGULAR SHIFTS DUE TO WATER ENTRY INTO THE TRANSAXLE RANGE SENSOR. *JD
Bulletin Number: BC1022097230
ADAPTERS ARE AVAILABLE TO CONVERT WINDSTAR "J HOOK" WINDSHIELD WIPER ARMS TO A CONVENTIONAL PIN STYLE TO ALLOW THE USE AFTER MARKET BOOTED WINTER BLADES. *JD
Bulletin Number: BC1024997230
A HARSH 1-2 SHIFT ON LIGHT THROTTLE, AT NORMAL SHIFT SPEEDS OF 10-15 MPH. *JD
Bulletin Number: BC1031597020
POWER STEERING LINE LEAKS ON 95/96 3.8L TRAILER TOW EQUIPPED TUBE AND FIN COOLER SYSTEMS SEE OASIS MESSAGE 4685. *JD
Bulletin Number: BC105909705
INSTRUCTIONS ON HOW TO IDENTIFY FUEL TANK SIZES. *TW
Bulletin Number: BC2295970501
INSTRUCTIONS ON HOW TO IDENTIFY 20 GALLON OR 25 GALLON FUEL TANKS - 1996 SERVICE MANUAL INCORRECTLY LISTS FUEL TANK AT 16 GALLONS. *TW
Bulletin Number: BC2380970501
HARSH 1-2 UPSHIFT. *TW
Bulletin Number: BC3274970207
REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS A
Bulletin Number: BC3370972301
THE ILLUMINATION OF MALFUNCTION INDICATOR LIGHT, ON AND DIAGNOSTIC TROUBLE CODES P1131, P1151, P1132, P1152. *JD
Bulletin Number: BC3381972301
ADAPTERS ARE AVAILABLE TO CONVERT VEHICLE "J HOOK" WINDSHIELD WIPER ARMS TO A CONVENTIONAL PIN STYLE. *JD
Bulletin Number: BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT
Bulletin Number: BC9666961001
2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT
Bulletin Number: BPI9904
CONDITIONS WITH THE TRAC OFF LAMP ILLUMINATING INTERMITTENTLY AND THER MAY ALSO BE STORED TROUBLE CODES U1009 AND / OR U1027.
1997 FORD ZX2 (ESCORT)
Bulletin Number: 0059
SUBJECT CONCERNING THE IDLE-VIBRATION- 2.0L AND ZETEC ENGINES- SERVICE TIP. *MJS
Bulletin Number: 0069
SOME VEHICLES MAY EXHIBIT A GRINDING NOISE WHILE BRAKING, BRAKE DRAG AND/OR UNEVEN FRONT BRAKE PAD WEAR MAY OCCUR. *MJS
Bulletin Number: 12295
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON, STALL AT TIP-IN FROM IDLE, ENGINE HESITATION, AND / OR SURGE CAUSED BY THE MASS AIR FLOW (MAF) SENSOR. *TT
Bulletin Number: 12594
SOME VEHICLES MAY EXHIBIT TRANSMISSION AND / OR MALFUNCTION INDICATOR LAMP ON CONCERNS RELATING TO THE DIAGNOSIS AND REPLACEMENT OF THE TRANSMISSION RANGE SENSOR (TR). *TT
Bulletin Number: 12834
BRIEF INFORMATION REGARDING TRANSMISSION FLUID. *TT
Bulletin Number: 13160
VEHICLES MAY EXHIBIT TRANSMISSION AND / OR MALFUNCTION INDICATOR LAMP ON CONCERNS RELATING TO THE DIAGNOSIS AND REPLACEMENT OF THE TRANSMISSION RANGER SENSOR (TRS). *TT
Bulletin Number: 13162
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LIGHT ON WITH A DIAGNOSTIC TROUBLE CODE P1744. *TT
Bulletin Number: 15256
SOME VEHICLES WITH AUTOMATIC TRANSAXLES MAY EXHIBIT A CLUNK NOISE ON INITIAL REVERSE ENGAGEMENT COLD. *TT
Bulletin Number: 5381
BRIEF INFORMATION STATING THAT THE NGS FUEL ECONOMY TEST ON SOME VEHICLES MAY NOT FUNCTION PROPERLY. *TT
Bulletin Number: 6416
BRIEF INFORMATION REGARDING TRANSMISSION FLUID APPEARANCE. *TT
Bulletin Number: 6932
SOME VEHICLES MAY EXHIBIT TRANSMISSION AND / OR MIL ON CONCERNS RELATING TO THE DIAGNOSIS AND REPLACEMENT OF THE TRANSMISSION RANGE SENSOR. *TT
Bulletin Number: 6934
CONCERNS WITH A MALFUNCTION INDICATOR LIGHT ON WITH A DIAGNOSTIC TROUBLE CODE P1744. *TT
Bulletin Number: 98204
A PORTION OF FOAM TAPE AT THE WINDSHIELD AND INSTRUMENT PANEL (I/P) MAY BE STICKING OUT ON SOME VEHICLES. *YC

 

Recalls for 1997 Ford

1997 FORD AEROMAX
NHTSA Campaign ID:SERVICE BRAKES, AIR:SUPPLY:LOW PRESSURE WARNING
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:03/31/1995 - 07/29/1996
Potential Units Affected:500

Defect Description:

THE AIR BRAKE SYSTEM WAS MANUFACTURED HAVING AIR BRAKE PRESSURE RELEASE TIMES OF APPROXIMATELY 1.5 SECONDS. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS."

Consequence:

THIS CONDITION CAN RESULT IN SLIGHT TRAILER BRAKE DRAG AND TIRE SCUFFING INCREASING THE RISK OF A VEHICLE ACCIDENT.

Action:

DEALERS WILL INSTALL A QUICK RELEASE VALVE IN THE AIR PRESSURE RELEASE SYSTEMS.
1997 FORD AEROMAX
NHTSA Campaign ID:SERVICE BRAKES, AIR
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:04/29/1996 - 12/21/1997
Potential Units Affected:1687

Defect Description:

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH OPTIONAL WABCO AIR DRYER. THE AIR BRAKE SYSTEM WAS PLUMBED SO THAT THE SYSTEMS DID NOT PROVIDE AIR RESERVOIR ISOLATION. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS."

Consequence:

THE AIR BRAKE RESERVOIR PRESSURE COULD BE DEPLETED, ACTIVATING THE EMERGENCY SPRING BRAKE. WITH THE EMERGENCY SPRING BRAKE DEPLOYED, THE VEHICLE WOULD STOP AND COULD NOT BE MOVED UNTIL THE BRAKE AIR SYSTEM WAS REPAIRED.

Action:

DEALERS WILL REPAIR THE AIR LINE PLUMBING TO INSTALL A CHECK VALVE.
1997 FORD AEROSTAR
NHTSA Campaign ID:POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:01/31/1992 - 01/20/1997
Potential Units Affected:75000

Defect Description:

VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.

Consequence:

THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, AND, IF THE EXPELLED FLUID CONTACTS THE EXHAUST SYSTEM, A VEHICLE FIRE COULD OCCUR.

Action:

DEALERS WILL INSTALL A NEW TRANSFER CASE REAR OUTPUT SHAFT BUSHING AND AN ALUMINUM DRIVESHAFT WILL BE INSTALLED.
1997 FORD AEROSTAR
NHTSA Campaign ID:ELECTRICAL SYSTEM:IGNITION:SWITCH
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:08/12/1991 - 08/22/1997
Potential Units Affected:762201

Defect Description:

VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.

Consequence:

THIS CAN CAUSE OVER HEATING AND THE POTENTIAL FOR A VEHICLE FIRE.

Action:

DEALERS WILL INSTALL A JUMPER HARNESS WITH A RELAY WHICH WILL RE-ROUTE AND ACTIVATE ALL A2 ACCESSORIES THROUGH THE RELAY.
1997 FORD AEROSTAR
NHTSA Campaign ID:VEHICLE SPEED CONTROL:CABLES
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:08/14/1996 - 08/22/1997
Potential Units Affected:36500

Defect Description:

VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH 3.0L ENGINES. AN ACCELERATOR CABLE WAS KINKED DURING INSTALLATION, CAUSING THE CORE WIRES TO EVENTUALLY FRAY.

Consequence:

THIS COULD INCREASE THE FRICTION IN THE CABLE, CAUSING THE THROTTLE TO BE SLOW TO RETURN TO IDLE. THIS CONDITION COULD RESULT IN A STUCK THROTTLE.

Action:

DEALERS WILL INSTALL A NEW ACCELERATOR CABLE.
1997 FORD CONTOUR
NHTSA Campaign ID:FUEL SYSTEM, OTHER:STORAGE
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:04/18/1996 - 12/17/1996
Potential Units Affected:1800

Defect Description:

VEHICLE DESCRIPTION: BI-FUEL VEHICLES MODIFIED TO RUN ON EITHER GASOLINE OR COMPRESSED NATURAL GAS (CNG). THE NATURAL GAS FUEL TANKS HAVE A SOLENOID SHUT-OFF VALVE THAT STOPS FUEL FLOW FROM THE FUEL TANK IN THE EVENT OF CERTAIN MODERATE TO SEVERE COLLISIONS. IF THE VEHICLE IS IN A COLLISION AND THE NATURAL GAS FUEL LINE IS DAMAGED, THE SYSTEM COULD LEAK NATURAL GAS.

Consequence:

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Action:

FORD HAS REQUESTED OWNERS OF THESE VEHICLES TO HAVE THE CNG FUEL SYSTEM DISABLED UNDER A PREVIOUS RECALL CAMPAIGN AND TO ONLY USE GASOLINE FUEL UNTIL A PERMANENT CORRECTIVE ACTION IS DEVELOPED. OWNERS ARE BEING ALERTED TO THIS SOLENOID VALVE CONCERN AT THIS TIME. THE TIMING OF CORRECTIVE ACTIONS IS BEING DELAYED TO ALLOW BOTH CONDITIONS TO BE REMEDIED AT ONE TIME. IN THE MEANTIME, THERE IS NOT RISK AS LONG AS THE NATURAL GAS SYSTEM HAS BEEN DISABLED AND THE VHEICLE IS ONLY OPERATED ON GASOLINE.
1997 FORD CONTOUR
NHTSA Campaign ID:SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:04/01/1996 - 08/24/1998
Potential Units Affected:436200

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES NOT EQUIPPED WITH THE ANTI-LOCK BRAKING SYSTEM (ABS). A PRESSURE CONSCIOUS REDUCING VALVE (PCRV) IN THE REAR BRAKES MAY BE SUBJECT TO CORROSION AND RESULT IN MALFUNCTION, WHEN OPERATED IN AREAS THAT USE SALT COMPOUNDS ON THE ROADWAY FOR DE-ICING OR DUST CONTROL.

Consequence:

IF BOTH PCRV'S MALFUNCTION, VEHICLE HANDLING COULD BE ADVERSELY AFFECTED DURING BRAKING AS A RESULT OF THE REAR WHEELS LOCKING, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL INSTALL IMPROVED PCRV'S IN THE REAR BRAKE SYSTEM. THIS RECALL WAS EXPANDED IN SEPTEMBER 2000 TO INCLUDE 1999 AND 2000 FORD CONTOUR, MERCURY MYSTIQUE AND COUGAR VEHICLES.
1997 FORD CONTOUR
NHTSA Campaign ID:ELECTRICAL SYSTEM
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:06/01/1996 - 05/31/1998
Potential Units Affected:342962

Defect Description:

ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.

Consequence:

THE OPEN CIRCUIT COULD LEAD TO ELECTRICAL ARCING THAT COULD MELT THE CONNECTOR HOUSING MATERIAL CREASING THE POTENTIAL FOR A FIRE.

Action:

DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS. OWNER NOTIFICATION BEGAN AUGUST 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
1997 FORD CONTOUR
NHTSA Campaign ID:VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:CONTROLS/WIRING
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:08/01/1994 - 02/07/1997
Potential Units Affected:566979

Defect Description:

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1995-1997 FORD CONTOUR AND MERCURY MYSTIQUE VEHICLES. THE HEATER BLOWER RESISTOR COULD OVERHEAT CAUSING THE ATTACHED ELECTRICAL CONNECTOR TO MELT.

Consequence:

THIS COULD CREATE THE POTENTIAL FOR A FIRE.

Action:

FORD WILL PROVIDE ADDITIONAL WARRANTY COVERAGE FOR THE HEATER BLOWER SWITCH FOR 10 YEARS FROM ORIGINAL DATE OF SALE OF THE VEHICLE OR 150,000 MILES, WHICHEVER COMES FIRST. DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS FREE OF CHARGE.
1997 FORD CONTOUR
NHTSA Campaign ID:EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:04/20/1995 - 08/24/1998
Potential Units Affected:605581

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TERMINALS AT THE HEADLIGHT SWITCH AND WIRING HARNESS CONNECTOR CAN EXPERIENCE HEAT DAMAGE AS A RESULT OF OVERHEATING.

Consequence:

THE DAMAGE COULD RESULT IN DISTORTION OF THE TERMINAL CAUSING AN OPEN CIRCUIT IN THE INSTRUMENT PANEL ILLUMINATION, PARKING LAMP, AND TAIL LAMP CIRCUITS.

Action:

DEALERS WILL INSTALL A HEADLAMP SWITCH WIRING CONNECTOR CONTAINING BRONZE TERMINALS AND AN INSPECTION, AND REPLACEMENT IF NECESSARY, OF THE HEADLAMP SWITCH.
1997 FORD CONTOUR
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:07/18/1994 - 01/12/1998
Potential Units Affected:175000

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FLOOR SHIFT AUTOMATIC TRANSMISSION CONTROL CAN BE DAMAGED IF SUBJECTED TO CERTAIN INTERIOR CLEANING PRODUCTS. THE GEAR POSITION INDICATOR CAN DETERIORATE AND NOT CORRECTLY INDICATE THE ACTUAL GEAR POSITION.

Consequence:

THIS CONDITION CAN RESULT IN INCORRECT GEAR SELECTION.

Action:

DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FLOOR SHIFT CONTROL.
1997 FORD CROWN VICTORIA
NHTSA Campaign ID:LATCHES/LOCKS/LINKAGES:HOOD:LATCH
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:03/01/1991 - 10/07/1996
Potential Units Affected:125000

Defect Description:

VEHICLE DESCRIPTION: POLICE AND TAXI VEHICLES. THE HOOD LATCH STRIKER CAN WEAR OR BECOME DETACHED FROM THE HOOD.

Consequence:

EITHER OF THESE CONDITIONS CAN RESULT IN THE HOOD OPENING WITHOUT WARNING WHILE THE VEHICLE IS BEING OPERATED IMPAIRING THE DRIVER'S VISIBILITY.

Action:

DEALERS WILL INSTALL AN IMPROVED HOOD LATCH STRIKER (VEHICLES WITH 1992 MODEL HOODS) OR REVISED STRIKER PLATE ATTACHING FASTENERS (VEHICLES WITH 1993-1997 MODEL HOODS).
1997 FORD CROWN VICTORIA
NHTSA Campaign ID:SEAT BELTS:FRONT:ANCHORAGE
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1129

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET FRONT PASSENGER SIDE SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW VEHICLE SAFETY SYSTEMS, INC. (TRW) MANUFACTURED FROM JUNE 1, 1998 THROUGH MAY 21, 2000. SOME OF THESE SEAT BELT ASSEMBLIES MAY HAVE BEEN INSTALLED AS SERVICE REPLACEMENT EQUIPMENT ON THE VEHICLES INVOLVED IN THE RECALL.

Consequence:

IN THE EVENT OF A COLLISION, THESE SEAT BELTS MAY NOT RESTRAIN AN OCCUPANT INCREASING THE RISK OF INJURY.

Action:

DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE SERVICE SEAT BELT ASSEMBLIES THAT WERE INSTALLED IN THESE VEHICLES FROM JANUARY 1 THROUGH JUNE 13, 2000.
1997 FORD CROWN VICTORIA
NHTSA Campaign ID:SEAT BELTS:FRONT:ANCHORAGE
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1167

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET DRIVER'S SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW VEHICLE SAFETY SYSTEMS, INC. (TRW) MANUFACTURED FROM JUNE 1, 1998 THROUGH MAY 21, 2000. SOME OF THESE SEAT BELT ASSEMBLIES MAY HAVE BEEN INSTALLED AS SERVICE REPLACEMENT EQUIPMENT ON THE VEHICLES INVOLVED IN THE RECALL.

Consequence:

IN THE EVENT OF A COLLISION, THESE SEAT BELTS MAY NOT RESTRAIN AN OCCUPANT INCREASING THE RISK OF INJURY.

Action:

DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE SERVICE SEAT BELT ASSEMBLIES THAT WERE INSTALLED IN THESE VEHICLES FROM JANUARY 1 THROUGH JUNE 13, 2000.
1997 FORD CROWN VICTORIA
NHTSA Campaign ID:SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:03/19/1997 -
Potential Units Affected:43626

Defect Description:

ON CERTAIN PASSENGER VEHICLES BUILT WITH ELECTRONIC TRACTION CONTROL, THE REAR BRAKE LINE MAY CHAFE DUE TO CONTACT BETWEEN IT AND A FLOOR PAN STIFFENING RIB, AND A BRAKE FLUID LEAK MAY OCCUR.

Consequence:

THE BRAKE PEDAL MAY DEVELOP A "SPONGY" FEEL AND DROPS OF BRAKE FLUID MAY BE OBSERVED BENEATH THE VEHICLE. OVER TIME BRAKE PERFORMANCE MAY BE COMPROMISED AND STOPPING DISTANCES COULD BE EXTENDED WHICH COULD LEAD TO A CRASH.

Action:

DEALERS WILL INSPECT THE SUBJECT VEHICLES FOR CONTACT BETWEEN THE BRAKE TUBE AND FLOOR PAN STIFFENING RIB. IF CONTACT IS EVIDENT, BUT NO ABRASION OR LEAKS EXIST, THE BRAKE TUBE WILL BE REPOSITIONED TO PRECLUDE FURTHER CONTACT AND POTENTIAL ABRASION. IF INDICATION OF ABRASION OR A LEAK IS EVIDENT, DEALERS WILL REPAIR THE BRAKE LINE. THIS CAMPAIGN BEGAN ON JULY 15, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
1997 FORD CROWN VICTORIA
NHTSA Campaign ID:SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:167742

Defect Description:

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH FEDERAL REGULATION 573. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. FORD IS INITIATING AN OWNER NOTIFICATION PROGRAM FOR OWNERS OF CERTAIN 1995-1997 CROWN VICTORIA MODEL VEHICLES WITH POLICE, TAXI, AND COMMERCIAL FLEET PACKAGES AND TOWN CAR VEHICLES WITH THE LIVERY PACKAGE. THESE VEHICLES MAY HAVE INSUFFICIENT CLEARANCE BETWEEN THE BRAKE LINE AND THE UNDERBODY FRONT FLOOR PAN ASSEMBLY WHICH COULD CAUSE WEAR OF THE BRAKE LINES.

Consequence:

THIS COULD LEAD TO BRAKE FLUID LOSS FOR THE REAR BRAKES AND, POTENTIALLY, INCREASED STOPPING DISTANCES.

Action:

DEALERS WILL INSPECT THE BRAKE LINES FOR WEAR, INSTALL TWO NEW TUBE BUNDLE CLIPS, AND CHECK THE BRAKE LINES FOR PROPER CLEARANCES. IF THE BRAKE LINES ARE WORN, THE DAMAGED SECTION OF THE BRAKE LINE WILL BE REPLACED.
1997 FORD CROWN VICTORIA
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:02/05/1992 - 02/28/1998
Potential Units Affected:3600000

Defect Description:

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

THIS COULD RESULT IN AN UNDERHOOD FIRE.

Action:

DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1997 FORD CROWN VICTORIA
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:07/01/1992 - 10/21/2002
Potential Units Affected:350000

Defect Description:

IN ORDER TO ENHANCE POLICE OFFICE SAFETY, MODEL YEAR 1992-2003 CROWN VICTORIA POLICE INTERCEPTOR (CVPI) VEHICLES WILL BE EQUIPPED WITH SHIELDS DESIGNED TO HELP PROTECT THE FUEL TANK IN HIGH-SPEED REAR-IMPACT CRASHES. FORD ALSO WILL BE OFFERING AN OPTIONAL TRUNK PACKAGE DESIGNED TO IMPROVE THE SAFE TRANSPORT OF SHARP-EDGED, HEAVY EQUIPMENT IN THESE VEHICLES.

Consequence:

SOME HIGH-SPEED REAR-IMPACT CRASHES HAVE RESULTED IN FUEL TANK PUNCTURES AND FIRES IN CVPI VEHICLES.

Action:

FORD HAS ADVISED US THAT SHIELD KITS HAVE BEEN AVAILABLE SINCE LATE OCTOBER AND WILL BE INSTALLED ON POLICE INTERCEPTOR VEHICLES AT NO COST. THE OPTIONAL TRANK PACKAGE WILL BE AVAILABLE BY THE END OF 2002. FORD HAS ESTABLISHED A NEW WEB SITE AT WWW.CVPI.COM TO ANSWER ADDITIONAL QUESTIONS ABOUT THE SAFE USE OF CPVI VEHICLES.
1997 FORD CROWN VICTORIA
NHTSA Campaign ID:VEHICLE SPEED CONTROL:CRUISE CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:02/05/1992 - 10/31/1997
Potential Units Affected:225000

Defect Description:

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Consequence:

AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Action:

DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
1997 FORD CROWN VICTORIA
NHTSA Campaign ID:FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:4218

Defect Description:

ON CERTAIN NATURAL GAS VEHICLES, IF A FLAME FROM A VEHICLE INTERIOR FIRE BECOMES LOCALLY DIRECTED AT THE NATURAL GAS FUEL TANK LOCATED IMMEDIATELY BEHIND THE REAR SEAT, THE FLAME COULD DAMAGE THE FIBERGLASS WRAP ON THE TANK WEAKENING THE TANK.

Consequence:

IF THE STRENGTH OF THE TANK IS SIGNIFICANTLY COMPROMISED, IT COULD RUPTURE, INCREASING THE RISK OF A FIRE.

Action:

DEALERS WILL INSTALL AN INSULATOR BEHIND THE CURRENT SEAT BACK. OWNER NOTIFICATION BEGAN ON JANUARY 7, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
1997 FORD CROWN VICTORIA
NHTSA Campaign ID:SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:03/15/1996 - 12/14/1998
Potential Units Affected:175000

Defect Description:

VEHICLE DESCRIPTION: CERTAIN 1996-1999 FORD CROWN VICTORIA POLICE, FLEET, NATURAL GAS, AND 1996-1999 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT WERE PRODUCED WITH A LOWER CONTROL ARM BALL JOINT CONTAINING A ONE PIECE BEARING; AND 1990-1996 FORD CROWN VICTORIA POLICE, FLEET, AND NGV VEHICLES AND 1990-1996 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT HAVE BEEN SERVICED WITH EITHER A BALL JOINT CONTAINING THE ONE-PIECE BEARING OR A FRONT LOWER CONTROL ARM CONTAINING A BALL JOINT WITH A ONE-PIECE BEARING. THE ONE-PIECE BEARING WITHIN THE LOWER CONTROL ARM BALL JOINT CAN WEAKEN SLOWLY DURING USE AND EVENTUALLY CRACK. THIS COULD RESULT IN SEPARATION OF THE BALL AND CAP OF THE JOINT, ALLOWING THE CONTROL ARM TO DROP TO THE GROUND.

Consequence:

IF THIS OCCURS WHILE THE VEHICLE IS MOVING, REDUCED STEERING CONTROL COULD OCCUR, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL REPLACE THE LOWER CONTROL ARM BALL JOINTS (2).
1997 FORD CVPI
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:07/01/1992 - 10/21/2002
Potential Units Affected:350000

Defect Description:

IN ORDER TO ENHANCE POLICE OFFICE SAFETY, MODEL YEAR 1992-2003 CROWN VICTORIA POLICE INTERCEPTOR (CVPI) VEHICLES WILL BE EQUIPPED WITH SHIELDS DESIGNED TO HELP PROTECT THE FUEL TANK IN HIGH-SPEED REAR-IMPACT CRASHES. FORD ALSO WILL BE OFFERING AN OPTIONAL TRUNK PACKAGE DESIGNED TO IMPROVE THE SAFE TRANSPORT OF SHARP-EDGED, HEAVY EQUIPMENT IN THESE VEHICLES.

Consequence:

SOME HIGH-SPEED REAR-IMPACT CRASHES HAVE RESULTED IN FUEL TANK PUNCTURES AND FIRES IN CVPI VEHICLES.

Action:

FORD HAS ADVISED US THAT SHIELD KITS HAVE BEEN AVAILABLE SINCE LATE OCTOBER AND WILL BE INSTALLED ON POLICE INTERCEPTOR VEHICLES AT NO COST. THE OPTIONAL TRANK PACKAGE WILL BE AVAILABLE BY THE END OF 2002. FORD HAS ESTABLISHED A NEW WEB SITE AT WWW.CVPI.COM TO ANSWER ADDITIONAL QUESTIONS ABOUT THE SAFE USE OF CPVI VEHICLES.
1997 FORD E150
NHTSA Campaign ID:EQUIPMENT ADAPTIVE
Manufacturer:MOBILITY WORKS
Manufacture Dates:01/01/1997 - 08/01/2004
Potential Units Affected:1660

Defect Description:

ON CERTAIN VANS EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT.

Consequence:

IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES TO A WHEELCHAIR OCCUPANT.

Action:

DEALERS WILL INSPECT AND REPLACE THE WHEELCHAIR SECUREMENT RETRACTORS AS NECESSARY. SURE-LOK WILL HANDLE THE REPAIRS FOR THIS CAMPAIGN. OWNERS SHOULD CONTACT SURE-LOCK AT 1-908-231-1804 OR MOBILITYWORKS AT 1-800-769-8267.
1997 FORD E-150
NHTSA Campaign ID:VEHICLE SPEED CONTROL:CRUISE CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:09/03/1991 - 09/15/2003
Potential Units Affected:225000

Defect Description:

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Consequence:

AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Action:

DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
1997 FORD E-150
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:04/09/1996 - 11/14/2000
Potential Units Affected:151000

Defect Description:

VEHICLE DESCRIPTION: ON CERTAIN VANS WITH AMBULANCE PREP PACKAGES OR OTHER SEVERE-DUTY APPLICATIONS INVOLVING OPERATION AT OR NEAR THE GROSS VEHICLE WEIGHT WITH FREQUENT TWISTING OF THE VEHICLE BODY, SUCH AS OFF-ROAD, ROUGH ROAD OR SPEED BUMP EVENTS, THE 35 GALLON MID-SHIP FUEL TANK COULD DEVELOP A CRACK WHERE IT CONTACTS THE FRAME CROSS MEMBER. IF THE FUEL TANK CRACKS, FUEL LEAKAGE COULD OCCUR.

Consequence:

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Action:

DEALERS WILL INSPECT THE FUEL TANK AND, IF CRACKED, WILL REPLACE THE TANK. INSULATOR PADS WILL BE INSTALLED ON ALL VEHICLES TO REDUCE THE STRESS LEVELS IN THE FUEL TANK. OWNER NOTIFICATION BEGAN APRIL 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
1997 FORD E-150
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:04/09/1996 - 08/02/2002
Potential Units Affected:3600000

Defect Description:

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

THIS COULD RESULT IN AN UNDERHOOD FIRE.

Action:

DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1997 FORD E-150
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:4500000

Defect Description:

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Action:

FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1997 FORD E-150
NHTSA Campaign ID:EQUIPMENT ADAPTIVE
Manufacturer:ALL IN ONE MOBILITY, INC.
Manufacture Dates: -
Potential Units Affected:13

Defect Description:

ALL IN ONE MOBILITY IS RECALLING CERTAIN MODEL YEAR 1997 THROUGH 2008 CONVERSION VANS EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THERE IS A POSSIBILITY OF A DEFECTIVE WELD AT THE JOINT BETWEEN THE PIVOTING PLATE AND THE PIVOTING PLATE PIN.

Consequence:

THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.

Action:

ALL IN ONE MOBILITY WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 22, 2010. OWNERS MAY CONTACT ALL IN ONE MOBILITY AT 1-503-255-5005.
1997 FORD E250
NHTSA Campaign ID:EQUIPMENT ADAPTIVE
Manufacturer:MOBILITY WORKS
Manufacture Dates:01/01/1997 - 08/01/2004
Potential Units Affected:1660

Defect Description:

ON CERTAIN VANS EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT.

Consequence:

IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES TO A WHEELCHAIR OCCUPANT.

Action:

DEALERS WILL INSPECT AND REPLACE THE WHEELCHAIR SECUREMENT RETRACTORS AS NECESSARY. SURE-LOK WILL HANDLE THE REPAIRS FOR THIS CAMPAIGN. OWNERS SHOULD CONTACT SURE-LOCK AT 1-908-231-1804 OR MOBILITYWORKS AT 1-800-769-8267.
1997 FORD E-250
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:4500000

Defect Description:

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Action:

FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1997 FORD E-250
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:04/09/1996 - 08/02/2002
Potential Units Affected:3600000

Defect Description:

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

THIS COULD RESULT IN AN UNDERHOOD FIRE.

Action:

DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1997 FORD E-250
NHTSA Campaign ID:VEHICLE SPEED CONTROL:CRUISE CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:09/03/1991 - 09/15/2003
Potential Units Affected:225000

Defect Description:

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Consequence:

AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Action:

DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
1997 FORD E350
NHTSA Campaign ID:EQUIPMENT ADAPTIVE
Manufacturer:MOBILITY WORKS
Manufacture Dates:01/01/1997 - 08/01/2004
Potential Units Affected:1660

Defect Description:

ON CERTAIN VANS EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT.

Consequence:

IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES TO A WHEELCHAIR OCCUPANT.

Action:

DEALERS WILL INSPECT AND REPLACE THE WHEELCHAIR SECUREMENT RETRACTORS AS NECESSARY. SURE-LOK WILL HANDLE THE REPAIRS FOR THIS CAMPAIGN. OWNERS SHOULD CONTACT SURE-LOCK AT 1-908-231-1804 OR MOBILITYWORKS AT 1-800-769-8267.
1997 FORD E-350
NHTSA Campaign ID:VEHICLE SPEED CONTROL:CRUISE CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:09/03/1991 - 09/15/2003
Potential Units Affected:225000

Defect Description:

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Consequence:

AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Action:

DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
1997 FORD E-350
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:04/09/1996 - 11/14/2000
Potential Units Affected:151000

Defect Description:

VEHICLE DESCRIPTION: ON CERTAIN VANS WITH AMBULANCE PREP PACKAGES OR OTHER SEVERE-DUTY APPLICATIONS INVOLVING OPERATION AT OR NEAR THE GROSS VEHICLE WEIGHT WITH FREQUENT TWISTING OF THE VEHICLE BODY, SUCH AS OFF-ROAD, ROUGH ROAD OR SPEED BUMP EVENTS, THE 35 GALLON MID-SHIP FUEL TANK COULD DEVELOP A CRACK WHERE IT CONTACTS THE FRAME CROSS MEMBER. IF THE FUEL TANK CRACKS, FUEL LEAKAGE COULD OCCUR.

Consequence:

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Action:

DEALERS WILL INSPECT THE FUEL TANK AND, IF CRACKED, WILL REPLACE THE TANK. INSULATOR PADS WILL BE INSTALLED ON ALL VEHICLES TO REDUCE THE STRESS LEVELS IN THE FUEL TANK. OWNER NOTIFICATION BEGAN APRIL 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
1997 FORD E-350
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:4500000

Defect Description:

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Action:

FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1997 FORD E-350
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:04/09/1996 - 08/02/2002
Potential Units Affected:3600000

Defect Description:

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

THIS COULD RESULT IN AN UNDERHOOD FIRE.

Action:

DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1997 FORD E-450
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:4500000

Defect Description:

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Action:

FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1997 FORD E-450
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1200000

Defect Description:

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Consequence:

OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Action:

DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
1997 FORD E-550
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:4500000

Defect Description:

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Action:

FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1997 FORD ECONOLINE
NHTSA Campaign ID:VEHICLE SPEED CONTROL:CRUISE CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:09/03/1991 - 09/15/2003
Potential Units Affected:225000

Defect Description:

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Consequence:

AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Action:

DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
1997 FORD ECONOLINE
NHTSA Campaign ID:ELECTRICAL SYSTEM:BATTERY:CABLES
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:06/10/1996 - 09/05/1996
Potential Units Affected:5000

Defect Description:

THE BATTERY CABLE HARNESS DOES NOT HAVE ADEQUATE PROTECTION FROM CONTACTING AND BEING DAMAGED BY THE RIGHT ENGINE MOUNT.

Consequence:

IF THE BATTERY CABLE OR STARTER WIRE INSULATION IS DAMAGED BY SUCH CONTACT, A SHORT TO GROUND CAN OCCUR RESULTING IN OVERHEATING OF THE WIRING AND POSSIBLE IGNITION OF SURROUNDING COMPONENTS.

Action:

DEALERS WILL INSPECT FOR CHAFING OF THE CABLE AND WILL ADD INSULATION AND A TIE STRAP TO THE BATTERY CABLE HARNESS.
1997 FORD ESCORT
NHTSA Campaign ID:AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:11/02/1995 - 09/05/1997
Potential Units Affected:396217

Defect Description:

ON CERTAIN PASSENGER VEHICLES, THE INTEGRATED AIR BAG MONITOR (IABM) CAN BE CONTAMINATED WITH WATER OR OTHER LIQUIDS AND COULD EXPERIENCE INTERNAL ELECTRICAL SHORTING.

Consequence:

THIS MAY, IN TURN, CAUSE THE AIR BAG READINESS LIGHT TO ILLUMINATE AND IN VERY RARE OCCURRENCES, AIR BAG DEPLOYMENT, MELTED WIRING, OR FIRE MAY OCCUR.

Action:

DEALERS WILL INSTALL THE SHIELD OVER THE IABM AND APPLY NYOGEL GREASE TO THE CONNECTOR. OWNER NOTIFICATION BEGAN FEBRUARY 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
1997 FORD E-SERIES
NHTSA Campaign ID:ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1176000

Defect Description:

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

Consequence:

IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.

Action:

DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
1997 FORD EXCURSION
NHTSA Campaign ID:ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1176000

Defect Description:

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

Consequence:

IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.

Action:

DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
1997 FORD EXPEDITION
NHTSA Campaign ID:SUSPENSION:REAR
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:07/22/1996 - 10/10/1996
Potential Units Affected:25000

Defect Description:

THE REAR AXLE TRACK BAR BRACKET CAN SEPARATE FROM THE FRAME DUE TO MISSING WELDS OR INADEQUATE WELD PENETRATION.

Consequence:

IF BOTH BRACKETS SEPARATE, THE REAR AXLE CAN MOVE LATERALLY UNTIL THE TIRES CONTACT EITHER THE FRAME OR THE WHEELHOUSE RESULTING IN EITHER TIRE DAMAGE OR A SIGNIFICANT REDUCTION IN VEHICLE HANDLING PERFORMANCE.

Action:

DEALERS WILL INSTALL A TRACK BAR BRACKET REINFORCEMENT KIT AND INSPECTION OF THE AXLE TUBES. THE SUSPECT AXLE TUBES DO NOT HAVE A STAMPED DATE CODE ON THE TUBE. AXLES WITHOUT DATE CODES ON THE TUBES WILL BE REPLACED.
1997 FORD EXPEDITION
NHTSA Campaign ID:STEERING:GEAR BOX:SHAFT SECTOR
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:03/01/1996 - 09/30/1996
Potential Units Affected:171446

Defect Description:

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, IF THE INTERMEDIATE SHAFT YOKE SEPARATES FROM THE STEERING GEAR INPUT SHAFT, THE STEERING SYSTEM BECOMES DISCONNECTED.

Consequence:

THIS COULD RESULT IN LOSS OF STEERING CONTROL, POTENTIALLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Action:

DEALERS WILL INSPECT THE STEERING INTERMEDIATE SHAFT YOKE TO DETERMINE IF THE YOKE IS FULLY SEATED ON THE STEERING GEAR INPUT SHAFT. IF THE YOKE IS FULLY SEATED NO SERVICE IS REQUIRED. IF THE YOKE IS NOT FULLY SEATED AND BOLT GROOVE AND SPLINE IS VISIBLE, THE INTERMEDIATE SHAFT AND BOLT WILL BE REPLACED AS WELL AS THE BOLT AT THE STEERING COLUMN CONNECTION. OWNER NOTIFICATION BEGAN ON MAY 30, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
1997 FORD EXPEDITION
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:07/22/1996 - 08/22/1997
Potential Units Affected:866000

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. IF THE AUTOMATIC TRANSMISSION SHIFT CABLE ASSEMBLY WAS NOT FULLY ATTACHED TO THE STEERING COLUMN BRACKET, THE SHIFT CABLE ASSEMBLY CAN COME OUT OF THE BRACKET. THE VEHICLE OPERATOR WOULD THEN NOT BE ABLE TO SHIFT THE TRANSMISSION FROM ONE OF THE DRIVE GEAR POSITIONS INTO THE PARK POSITION EVEN THOUGH THE GEAR SHIFT SELECTOR WOULD INDICATE "PARK."

Consequence:

THE CONDITION WOULD NOT ALLOW A DISENGAGEMENT OF THE TRANSMISSION FROM THE PARK POSITION OR AFFECT PROPER NEUTRAL START SWITCH OPERATION. UNINTENDED VEHICLE MOVEMENT COULD OCCUR IF THE PARKING BRAKE WAS NOT SET.

Action:

DEALERS WILL MAKE THE PROPER ATTACHMENT OF THE TRANSMISSION SHIFT CONTROL CABLE TO THE STEERING COLUMN BRACKET AND ADD A TIE STRAP TO THAT CONNECTION.
1997 FORD EXPEDITION
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: - 08/20/2002
Potential Units Affected:4500000

Defect Description:

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.

Consequence:

A FIRE AT THE SWITCH COULD OCCUR.

Action:

BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
1997 FORD EXPEDITION
NHTSA Campaign ID:WHEELS:LUGS/NUTS/BOLTS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:12/01/1995 - 04/14/1998
Potential Units Affected:1520000

Defect Description:

VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES AND LIGHT DUTY PICKUP TRUCKS. THE LUG NUTS ON THESE VEHICLES MAY NOT CREATE SUFFICIENT CLAMP LOAD ALLOWING WHEEL MOVEMENT IN RELATION TO THE HUB/ROTOR MOUNTING SURFACE.

Consequence:

THIS CAN RESULT IN THE LOOSENING OF LUG NUTS, STUD FATIGUE FAILURE, AND THE POTENTIAL FOR A WHEEL SEPARATION FROM THE VEHICLE, INCREASING THE RISK OF A VEHICLE CRASH.

Action:

OWNERS OF THESE VEHICLES WILL BE RECEIVING TWO NOTIFICATIONS. THE FIRST NOTIFICATION, WHICH BEGAN IN MAY 1998, WILL PROVIDE AN INTERIM REPAIR PROCEDURE UNTIL PARTS BECOME AVAILABLE. THIS INTERIM PROCEDURE CAN BE COMPLETED BY OWNERS OR THEIR DEALERS. IT SPECIFIES THAT THE LUG NUT TORQUE MUST BE VERIFIED TO BE 100 LBS. THEN THE LUG NUTS NEED TO BE TIGHTENED AN ADDITIONAL 1/8 TO 1/4 TURN MORE. THERE WILL BE A SECOND OWNER NOTIFICATION, WHICH IS EXPECTED TO BEGIN JULY 20, 1998, UNDER WHICH DEALERS WILL INSPECT THE WHEEL STUDS AND REPLACE THE WHEEL LUG NUTS.
1997 FORD EXPEDITION
NHTSA Campaign ID:TRAILER HITCHES
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:07/22/1996 - 12/09/1999
Potential Units Affected:565800

Defect Description:

VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES. THE TRAILER HITCH ASSEMBLY TO THE FRAME ATTACHING BOLTS COULD LOSE THE CLAMP LOAD.

Consequence:

THE TRAILER HITCH COULD THEN SEPARATE FROM THE VEHICLE.

Action:

DEALERS WILL REPLACE THE TRAILER HITCH MOUNTING BOLTS AND NUT PLATES.
1997 FORD EXPEDITION
NHTSA Campaign ID:EXTERIOR LIGHTING
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:20637

Defect Description:

VEHICLE DESCRIPTION: MINI VANS, LIGHT PICKUP TRUCKS, AND SPORT UTILITY VEHICLES. OFF LEASE CANADIAN VEHICLES EQUIPPED WITH DAYTIME RUNNING LIGHTS WHICH MEET CANADIAN REQUIREMENTS AND NOT THE PHOTOMETRIC REQUIREMENTS OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." ACCORDING TO FORD, THE VEHICLES WERE IMPORTED INTO THE U.S. ERRONEOUSLY.

Consequence:

THE LIGHT GIVEN OFF FROM THE DAYTIME RUNNING LIGHTS IS BRIGHTER THAN ALLOWED BY U.S. STANDARDS.

Action:

DEALERS WILL BE ADVISED TO DEACTIVATE THE RUNNING LIGHT FUNCTION AND TO COMPLETE ANY OUTSTANDING SAFETY RECALLS ON THESE VEHICLES.
1997 FORD EXPLORER
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:08/01/1996 - 02/01/1998
Potential Units Affected:320000

Defect Description:

VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH 4.0L SINGLE OVERHEAD CAM ENGINES. THE ENGINE FUEL LINES CAN BE DAMAGED IF THE VEHICLE IS JUMP STARTED AND THE GROUND CABLE IS ATTACHED TO THE FUEL LINE BRACKET THAT IS LOCATED NEAR THE BATTERY. SINCE THE BRACKET IS NOT GROUNDED, THE STAINLESS STEEL FUEL LINE BRAID COULD ACT AS A GROUND POTENTIALLY OVERHEATING THE PTFE INNER LINER OF THE FUEL LINE RESULTING IN DAMAGE TO THE FUEL LINE.

Consequence:

THE FUEL LINES CAN LEAK, AND IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD POTENTIALLY RESULT.

Action:

DEALERS WILL INSTALL A WARNING LABEL ON THE FUEL LINE BRACKET ADVISING OWNERS NOT TO USE IT FOR A JUMP START GROUND. ALSO A REVISED BOLT WILL BE INSTALLED IN THE ALTERNATOR BRACKET TO PROVIDE A CONVENIENT JUMP START GROUND LOCATION.
1997 FORD EXPLORER
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:02/02/1996 - 02/17/1997
Potential Units Affected:23000

Defect Description:

VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH 5.0L ENGINES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, IDAHO, IOWA, MAINE, MICHIGAN (UPPER PENINSULA ONLY), MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. THESE VEHICLES, WHEN OPERATED FOR EXTENDED PERIODS OF TIME AT HIGHWAY SPEEDS AND TEMPERATURES BELOW -20 DEGREES FARENHEIT, DO NOT RETURN TO IDLE DUE TO ICE IN THE THROTTLE BODY.

Consequence:

ALTHOUGH THE VEHICLE CAN BE CONTROLLED BY EITHER APPLYING THE SERVICE BRAKES OR SHIFTING THE TRANSMISSION TO NEUTRAL, INCREASED BRAKE PEDAL EFFORTS OR SOME INCREASE IN STOPPING DISTANCE CAN RESULT.

Action:

DEALERS WILL INSTALL A REVISED PCV SYSTEM WITH WATER HEATED VACUUM SOURCE.
1997 FORD EXPLORER
NHTSA Campaign ID:TIRES:TREAD/BELT
Manufacturer:BRIDGESTONE/FIRESTONE, INC.
Manufacture Dates: -
Potential Units Affected:14400000

Defect Description:

TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.

Consequence:

IF THE TREAD SEPARATES FROM THE TIRE, THE DRIVER CAN LOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH CAUSING INJURY OR DEATH.

Action:

THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON AUGUST 29, 2001. HOWEVER, CUSTOMERS SHOULD CONTACT FIRESTONE CUSTOMER SERVICE AT 1-800-465-1904 FOR POSSIBLE ASSISTANCE.
1997 FORD EXPLORER
NHTSA Campaign ID:SUSPENSION
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:08/11/1994 - 10/31/1996
Potential Units Affected:810000

Defect Description:

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER CERTAIN CONDITIONS, A FRONT SWAY BAR LINK CAN FRACTURE.

Consequence:

VEHICLE HANDLING COULD BE AFFECTED, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL REPLACE BOTH THE LEFT AND RIGHT FRONT SWAY BAR LINKS.
1997 FORD EXPLORER
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:05/29/1996 - 10/20/1998
Potential Units Affected:220000

Defect Description:

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES AND STILL RETAIN THE ORIGINAL THROTTLE BODY (PART NUMBERS 97JF-9E926AB OR 97JF-9E926-AC). SOME OF THE ORIGINAL THROTTLE BODIES INSTALLED ALLOWED A GAP BETWEEN THE PLATE AND BORE TO BE BUILT TOO NARROW. THIS REDUCED CLEARANCE ALLOWED THE ENGINE DEPOSITS NORMALLY PRESENT IN THE THROTTLE BODY TO CONTACT OR BRIDGE THE GAP. IF THE ENGINE DEPOSITS BRIDGED THE GAP BETWEEN THE THROTTLE PLATE AND BORE AND THEN HARDENED, ON THE INITIAL APPLICATION OF THE ACCELERATOR PEDAL AFTER THE ENGINE HAS COOLED, THE OPERATOR WOULD NEED TO APPLY ADDITIONAL FORCE TO THE ACCELERATOR PEDAL TO BREAK THE BRIDGE.

Consequence:

THIS COULD RESULT IN ENGINE SURGE WHEN THE ACCELERATOR PEDAL BREAKS FREE.

Action:

DEALERS WILL REPLACE THE ORIGINAL THROTTLE BODIES.
1997 FORD EXPLORER
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:08/11/1994 - 08/30/2002
Potential Units Affected:4500000

Defect Description:

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Action:

FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1997 FORD EXPLORER
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:05/29/1996 - 03/04/1999
Potential Units Affected:898739

Defect Description:

VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR 5.0L ENGINES OR 1998-1999 RANGERS EQUIPPED WITH 2.5L, 3.0L FFV/EFI OR 4.0L ENGINES AND CRUISE CONTROL BUILT FROM JANUARY 5, 1998 THROUGH MARCH 4, 1999; 1998-1999 MUSTANGS EQUIPPED WITH 3.8L, 4.6L 2-VALVE OR 4-VALVE ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; 1999 F250/F350/F450/F550 (OVER 8,500 LBS.) TRUCKS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; AND 1999 F-53 STRIPPED CHASSIS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999. A CRUISE CONTROL CABLE CAN INTERFERE WITH THE SPEED CONTROL SERVO PULLEY AND NOT ALLOW THE THROTTLE TO RETURN TO IDLE WHEN DISENGAGING THE CRUISE CONTROL.

Consequence:

IF THE CRUISE CONTROL IS USED AND THIS CONDITION IS PRESENT, A STUCK THROTTLE COULD RESULT, WHICH COULD POTENTIALLY RESULT IN A CRASH.

Action:

DEALERS WILL REPLACE THE CRUISE CONTROL CABLES. AT THE PRESENT TIME, THE REPLACEMENT CABLES ARE NOT AVAILABLE. CUSTOMERS ARE BEING ADVISED NOT TO USE THE CRUISE CONTROL SYSTEM UNTIL A REPLACEMENT CAN BE MADE.
1997 FORD EXPLORER
NHTSA Campaign ID:EXTERIOR LIGHTING
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:20637

Defect Description:

VEHICLE DESCRIPTION: MINI VANS, LIGHT PICKUP TRUCKS, AND SPORT UTILITY VEHICLES. OFF LEASE CANADIAN VEHICLES EQUIPPED WITH DAYTIME RUNNING LIGHTS WHICH MEET CANADIAN REQUIREMENTS AND NOT THE PHOTOMETRIC REQUIREMENTS OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." ACCORDING TO FORD, THE VEHICLES WERE IMPORTED INTO THE U.S. ERRONEOUSLY.

Consequence:

THE LIGHT GIVEN OFF FROM THE DAYTIME RUNNING LIGHTS IS BRIGHTER THAN ALLOWED BY U.S. STANDARDS.

Action:

DEALERS WILL BE ADVISED TO DEACTIVATE THE RUNNING LIGHT FUNCTION AND TO COMPLETE ANY OUTSTANDING SAFETY RECALLS ON THESE VEHICLES.
1997 FORD F-150
NHTSA Campaign ID:SEAT BELTS:FRONT:ANCHORAGE
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:08/14/1995 - 04/30/1996
Potential Units Affected:133000

Defect Description:

THE SEAT ELT ANCHORAGE ATTACHMENTS ARE MISSING OR MISINSTALLED ON THESE VEHICLES.

Consequence:

A LOOSE FASTENER CAN EVENTUALLY DETACH AND WOULD NOT PROPERLY RESTRAIN AN OCCUPANT IN THE EVENT OF A VEHICLE ACCIDENT.

Action:

DEALERS WILL INSPECT AND, AS NECESSARY, REPAIR THE SEAT BELT ANCHORAGE ATTACHMENTS.
1997 FORD F-150
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:06/20/1995 - 08/04/2004
Potential Units Affected:1100000

Defect Description:

FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.

Consequence:

AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.

Action:

FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
1997 FORD F-150
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: - 08/20/2002
Potential Units Affected:4500000

Defect Description:

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.

Consequence:

A FIRE AT THE SWITCH COULD OCCUR.

Action:

BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
1997 FORD F-150
NHTSA Campaign ID:STEERING:GEAR BOX:SHAFT SECTOR
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:03/01/1996 - 09/30/1996
Potential Units Affected:171446

Defect Description:

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, IF THE INTERMEDIATE SHAFT YOKE SEPARATES FROM THE STEERING GEAR INPUT SHAFT, THE STEERING SYSTEM BECOMES DISCONNECTED.

Consequence:

THIS COULD RESULT IN LOSS OF STEERING CONTROL, POTENTIALLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Action:

DEALERS WILL INSPECT THE STEERING INTERMEDIATE SHAFT YOKE TO DETERMINE IF THE YOKE IS FULLY SEATED ON THE STEERING GEAR INPUT SHAFT. IF THE YOKE IS FULLY SEATED NO SERVICE IS REQUIRED. IF THE YOKE IS NOT FULLY SEATED AND BOLT GROOVE AND SPLINE IS VISIBLE, THE INTERMEDIATE SHAFT AND BOLT WILL BE REPLACED AS WELL AS THE BOLT AT THE STEERING COLUMN CONNECTION. OWNER NOTIFICATION BEGAN ON MAY 30, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
1997 FORD F-150
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:11/01/1995 - 08/31/1997
Potential Units Affected:670509

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS MANUFACTURED AT THE KANSAS CITY OR NORFOLK ASSEMBLY PLANTS. THE FRONT FUEL LINE ASSEMBLY COULD HAVE A HOLE RUBBED THROUGH IN ONE OF TWO LOCATIONS. THE FIRST LOCATION IS BELOW THE FUEL RAIL CONNECTION WHERE THE FLEXIBLE HOSE IS CRIMPED TO THE STEEL TUBE. THE BRACKET THAT ATTACHES THE FRONT FUEL LINE TO THE TRANSMISSION COULD HAVE BEEN BENT DURING ASSEMBLY. THE SECOND LOCATION IS AT THE REAR STEEL TUBE SECTION FORWARD OF THE REAR BRACKET. DURING INSTALLATION THE REAR STEEL TUBES OF THE FRONT FUEL LINE ASSEMBLY COULD HAVE BEEN BENT DOWNWARD. IN VEHICLES EQUIPPED WITH A MANUAL 4XZ4 TRANSFER CASE SHIFTER, THE SHIFTER LINKAGE MAY CONTACT THE STEEL TUBES AS IT IS BEING SHIFTED BETWEEN 4H, 4L, 2L AND NEUTRAL.

Consequence:

THIS CONDITION COULD RESULT IN FUEL LEAKAGE. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Action:

DEALERS WILL INSPECT THESE LINES AND REPLACE THE FRONT FUEL LINE ASSEMBLY IF NECESSARY. OWNER NOTIFICATION BEGAN OCTOBER 27, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
1997 FORD F-150
NHTSA Campaign ID:SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:08/19/1996 - 08/23/1996
Potential Units Affected:1200

Defect Description:

THE RETAINER CLIP THAT HOLDS THE MASTER CYLINDER PUSH ROD TO THE BRAKE PEDAL ARM IS MISSING.

Consequence:

A LOSS OF SERVICE BRAKING CAN OCCUR INCREASING THE RISK OF A VEHICLE ACCIDENT.

Action:

DEALERS WILL INSPECT TO VERIFY THAT THE RETAINER CLIPS ARE INSTALLED AND IF CLIPS ARE MISSING WILL INSTALL CLIPS.
1997 FORD F-150
NHTSA Campaign ID:EQUIPMENT:OTHER:LABELS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:12/15/1995 - 03/11/1996
Potential Units Affected:134770

Defect Description:

THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Consequence:

INCORRECT INFLATION PRESSURES COULD CAUSE PREMATURE WEAR OF THE REAR TIRES. .

Action:

OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.
1997 FORD F-150
NHTSA Campaign ID:EXTERIOR LIGHTING
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:20637

Defect Description:

VEHICLE DESCRIPTION: MINI VANS, LIGHT PICKUP TRUCKS, AND SPORT UTILITY VEHICLES. OFF LEASE CANADIAN VEHICLES EQUIPPED WITH DAYTIME RUNNING LIGHTS WHICH MEET CANADIAN REQUIREMENTS AND NOT THE PHOTOMETRIC REQUIREMENTS OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." ACCORDING TO FORD, THE VEHICLES WERE IMPORTED INTO THE U.S. ERRONEOUSLY.

Consequence:

THE LIGHT GIVEN OFF FROM THE DAYTIME RUNNING LIGHTS IS BRIGHTER THAN ALLOWED BY U.S. STANDARDS.

Action:

DEALERS WILL BE ADVISED TO DEACTIVATE THE RUNNING LIGHT FUNCTION AND TO COMPLETE ANY OUTSTANDING SAFETY RECALLS ON THESE VEHICLES.
1997 FORD F-150
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:11/26/1995 - 07/08/1996
Potential Units Affected:22000

Defect Description:

VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, MONTANA, NORTH DAKOTA, MINNESOTA, WISCONSIN, MICHIGAN (UPPER PENINSULA), NEW YORK, MAINE, VERMONT, AND NEW HAMPSHIRE. OPERATION AT HIGHWAY SPEEDS DURING EXTREME COLD, NORTHERN CLIMATE WINTER CONDITIONS, CAN RESULT IN ICE FORMING IN THE THROTTLE BODY OF THE ENGINE.

Consequence:

THIS ICE CAN CAUSE THE THROTTLE PLATE TO REMAIN IN THE HIGHWAY CRUISING POSITION AFTER THE ACCELERATOR IS RELEASED OR THE SPEED CONTROL IS DEACTIVATED. UNDER SUCH CONDITIONS, THE VEHICLE STOPPING DISTANCES WOULD BE INCREASED POSSIBLY RESULTING IN AN ACCIDENT.

Action:

DEALERS WILL INSTALL A FOAM INSULATING SLEEVE ON THE LINE FROM THE PCV TO THE HOSE FITTING ON THE THROTTLE PLATE.
1997 FORD F-150
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:11/26/1995 - 02/19/1998
Potential Units Affected:202000

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY 4-WHEEL DRIVE PICKUP TRUCKS. IF THE VEHICLE IS OVERLOADED, THE REAR LEAF SPRINGS CAN BE OVERSTRESSED. A FATIGUE FRACTURE OF THE SPRING CAN OCCUR. THE CENTER LEAF OF THE SPRING CAN FRACTURE AT THE FORWARD EDGE OF THE SPRING SEAT AND, IN SOME CASES, CONTACT THE FUEL TANK.

Consequence:

FUEL TANK CONTACT CAN DAMAGE THE TANK AND RESULT IN FUEL LEAKAGE. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Action:

DEALERS WILL INSPECT THE REAR SPRINGS AND INSTALL AN ADDITIONAL CLIP ON THE FORWARD END OF THE REAR SPRINGS TO PREVENT FUEL TANK CONTACT IN THE EVENT OF A LEAF FRACTURE. ANY FRACTURED SPRINGS WILL BE REPLACED.
1997 FORD F-150
NHTSA Campaign ID:SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:11/26/1995 - 02/19/1998
Potential Units Affected:202000

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY 4-WHEEL DRIVE PICKUP TRUCKS. IF THE VEHICLE IS OVERLOADED, THE REAR LEAF SPRINGS CAN BE OVERSTRESSED. A FATIGUE FRACTURE OF THE SPRING CAN OCCUR. THE CENTER LEAF OF THE SPRING CAN FRACTURE AT THE FORWARD EDGE OF THE SPRING SEAT AND, IN SOME CASES, CONTACT THE FUEL TANK.

Consequence:

FUEL TANK CONTACT CAN DAMAGE THE TANK AND RESULT IN FUEL LEAKAGE. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Action:

DEALERS WILL INSPECT THE REAR SPRINGS AND INSTALL AN ADDITIONAL CLIP ON THE FORWARD END OF THE REAR SPRINGS TO PREVENT FUEL TANK CONTACT IN THE EVENT OF A LEAF FRACTURE. ANY FRACTURED SPRINGS WILL BE REPLACED.
1997 FORD F-150
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:02/16/1996 - 03/04/1996
Potential Units Affected:15500

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE TRANSMISSION BRACKET END FITTING CAN SEPARATE FROM THE SHIFT CABLE ASSEMBLY RESULTING IN OPERATOR INABILITY TO SHIFT THE TRANSMISSION FROM ONE OF THE DRIVE GEAR POSITIONS INTO THE PARK POSITION.

Consequence:

THIS CONDITION CAN RESULT IN UNINTENDED VEHICLE MOVEMENT IF THE PARKING BRAKE IS NOT SET.

Action:

DEALERS WILL INSTALL A NEW TRANSMISSION SHIFT CONTROL CABLE.
1997 FORD F-150
NHTSA Campaign ID:WHEELS:LUGS/NUTS/BOLTS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:12/01/1995 - 04/14/1998
Potential Units Affected:1520000

Defect Description:

VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES AND LIGHT DUTY PICKUP TRUCKS. THE LUG NUTS ON THESE VEHICLES MAY NOT CREATE SUFFICIENT CLAMP LOAD ALLOWING WHEEL MOVEMENT IN RELATION TO THE HUB/ROTOR MOUNTING SURFACE.

Consequence:

THIS CAN RESULT IN THE LOOSENING OF LUG NUTS, STUD FATIGUE FAILURE, AND THE POTENTIAL FOR A WHEEL SEPARATION FROM THE VEHICLE, INCREASING THE RISK OF A VEHICLE CRASH.

Action:

OWNERS OF THESE VEHICLES WILL BE RECEIVING TWO NOTIFICATIONS. THE FIRST NOTIFICATION, WHICH BEGAN IN MAY 1998, WILL PROVIDE AN INTERIM REPAIR PROCEDURE UNTIL PARTS BECOME AVAILABLE. THIS INTERIM PROCEDURE CAN BE COMPLETED BY OWNERS OR THEIR DEALERS. IT SPECIFIES THAT THE LUG NUT TORQUE MUST BE VERIFIED TO BE 100 LBS. THEN THE LUG NUTS NEED TO BE TIGHTENED AN ADDITIONAL 1/8 TO 1/4 TURN MORE. THERE WILL BE A SECOND OWNER NOTIFICATION, WHICH IS EXPECTED TO BEGIN JULY 20, 1998, UNDER WHICH DEALERS WILL INSPECT THE WHEEL STUDS AND REPLACE THE WHEEL LUG NUTS.
1997 FORD F-150
NHTSA Campaign ID:VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:11/29/1995 - 11/02/1997
Potential Units Affected:45000

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH A 4.2L ENGINE AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN ONE OF THE FOLLOWING STATES: ALASKA, MONTANA, NORTH DAKOTA, MINNESOTA, WISCONSIN, NEW YORK, VERMONT, NEW HAMPSHIRE, MAINE, MICHIGAN, IDAHO, WYOMING, SOUTH DAKOTA, COLORADO, NEBRASKA, KANSAS, IOWA, MISSOURI, ILLINOIS, INDIANA, OHIO, PENNSYLVANIA, AND MASSACHUSETTS. THE THROTTLE IS UNABLE TO RETURN TO IDLE DUE TO ICE FORMING IN THE THROTTLE BODY WHEN THE TEMPERATURE RANGES FROM -10 TO -40 DEGREES FAHRENHEIT.

Consequence:

INCREASED BRAKE PEDAL EFFORTS OR SOME INCREASE IN STOPPING DISTANCE COULD RESULT.

Action:

DEALERS WILL INSTALL A REVISED PCV SYSTEM ON THESE VEHICLES.
1997 FORD F-150
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:07/22/1996 - 08/22/1997
Potential Units Affected:866000

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. IF THE AUTOMATIC TRANSMISSION SHIFT CABLE ASSEMBLY WAS NOT FULLY ATTACHED TO THE STEERING COLUMN BRACKET, THE SHIFT CABLE ASSEMBLY CAN COME OUT OF THE BRACKET. THE VEHICLE OPERATOR WOULD THEN NOT BE ABLE TO SHIFT THE TRANSMISSION FROM ONE OF THE DRIVE GEAR POSITIONS INTO THE PARK POSITION EVEN THOUGH THE GEAR SHIFT SELECTOR WOULD INDICATE "PARK."

Consequence:

THE CONDITION WOULD NOT ALLOW A DISENGAGEMENT OF THE TRANSMISSION FROM THE PARK POSITION OR AFFECT PROPER NEUTRAL START SWITCH OPERATION. UNINTENDED VEHICLE MOVEMENT COULD OCCUR IF THE PARKING BRAKE WAS NOT SET.

Action:

DEALERS WILL MAKE THE PROPER ATTACHMENT OF THE TRANSMISSION SHIFT CONTROL CABLE TO THE STEERING COLUMN BRACKET AND ADD A TIE STRAP TO THAT CONNECTION.
1997 FORD F-250
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:06/20/1995 - 08/04/2004
Potential Units Affected:1100000

Defect Description:

FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.

Consequence:

AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.

Action:

FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
1997 FORD F-250
NHTSA Campaign ID:STEERING:GEAR BOX:SHAFT SECTOR
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:03/01/1996 - 09/30/1996
Potential Units Affected:171446

Defect Description:

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, IF THE INTERMEDIATE SHAFT YOKE SEPARATES FROM THE STEERING GEAR INPUT SHAFT, THE STEERING SYSTEM BECOMES DISCONNECTED.

Consequence:

THIS COULD RESULT IN LOSS OF STEERING CONTROL, POTENTIALLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Action:

DEALERS WILL INSPECT THE STEERING INTERMEDIATE SHAFT YOKE TO DETERMINE IF THE YOKE IS FULLY SEATED ON THE STEERING GEAR INPUT SHAFT. IF THE YOKE IS FULLY SEATED NO SERVICE IS REQUIRED. IF THE YOKE IS NOT FULLY SEATED AND BOLT GROOVE AND SPLINE IS VISIBLE, THE INTERMEDIATE SHAFT AND BOLT WILL BE REPLACED AS WELL AS THE BOLT AT THE STEERING COLUMN CONNECTION. OWNER NOTIFICATION BEGAN ON MAY 30, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
1997 FORD F-250
NHTSA Campaign ID:EQUIPMENT:OTHER:LABELS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:12/15/1995 - 03/11/1996
Potential Units Affected:134770

Defect Description:

THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Consequence:

INCORRECT INFLATION PRESSURES COULD CAUSE PREMATURE WEAR OF THE REAR TIRES. .

Action:

OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.
1997 FORD F-250
NHTSA Campaign ID:SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:08/19/1996 - 08/23/1996
Potential Units Affected:1200

Defect Description:

THE RETAINER CLIP THAT HOLDS THE MASTER CYLINDER PUSH ROD TO THE BRAKE PEDAL ARM IS MISSING.

Consequence:

A LOSS OF SERVICE BRAKING CAN OCCUR INCREASING THE RISK OF A VEHICLE ACCIDENT.

Action:

DEALERS WILL INSPECT TO VERIFY THAT THE RETAINER CLIPS ARE INSTALLED AND IF CLIPS ARE MISSING WILL INSTALL CLIPS.
1997 FORD F-250
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:11/01/1995 - 08/31/1997
Potential Units Affected:670509

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS MANUFACTURED AT THE KANSAS CITY OR NORFOLK ASSEMBLY PLANTS. THE FRONT FUEL LINE ASSEMBLY COULD HAVE A HOLE RUBBED THROUGH IN ONE OF TWO LOCATIONS. THE FIRST LOCATION IS BELOW THE FUEL RAIL CONNECTION WHERE THE FLEXIBLE HOSE IS CRIMPED TO THE STEEL TUBE. THE BRACKET THAT ATTACHES THE FRONT FUEL LINE TO THE TRANSMISSION COULD HAVE BEEN BENT DURING ASSEMBLY. THE SECOND LOCATION IS AT THE REAR STEEL TUBE SECTION FORWARD OF THE REAR BRACKET. DURING INSTALLATION THE REAR STEEL TUBES OF THE FRONT FUEL LINE ASSEMBLY COULD HAVE BEEN BENT DOWNWARD. IN VEHICLES EQUIPPED WITH A MANUAL 4XZ4 TRANSFER CASE SHIFTER, THE SHIFTER LINKAGE MAY CONTACT THE STEEL TUBES AS IT IS BEING SHIFTED BETWEEN 4H, 4L, 2L AND NEUTRAL.

Consequence:

THIS CONDITION COULD RESULT IN FUEL LEAKAGE. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Action:

DEALERS WILL INSPECT THESE LINES AND REPLACE THE FRONT FUEL LINE ASSEMBLY IF NECESSARY. OWNER NOTIFICATION BEGAN OCTOBER 27, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
1997 FORD F-250
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:07/22/1996 - 08/22/1997
Potential Units Affected:866000

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. IF THE AUTOMATIC TRANSMISSION SHIFT CABLE ASSEMBLY WAS NOT FULLY ATTACHED TO THE STEERING COLUMN BRACKET, THE SHIFT CABLE ASSEMBLY CAN COME OUT OF THE BRACKET. THE VEHICLE OPERATOR WOULD THEN NOT BE ABLE TO SHIFT THE TRANSMISSION FROM ONE OF THE DRIVE GEAR POSITIONS INTO THE PARK POSITION EVEN THOUGH THE GEAR SHIFT SELECTOR WOULD INDICATE "PARK."

Consequence:

THE CONDITION WOULD NOT ALLOW A DISENGAGEMENT OF THE TRANSMISSION FROM THE PARK POSITION OR AFFECT PROPER NEUTRAL START SWITCH OPERATION. UNINTENDED VEHICLE MOVEMENT COULD OCCUR IF THE PARKING BRAKE WAS NOT SET.

Action:

DEALERS WILL MAKE THE PROPER ATTACHMENT OF THE TRANSMISSION SHIFT CONTROL CABLE TO THE STEERING COLUMN BRACKET AND ADD A TIE STRAP TO THAT CONNECTION.
1997 FORD F-250
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1200000

Defect Description:

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Consequence:

OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Action:

DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
1997 FORD F-250
NHTSA Campaign ID:TIRES:BEAD
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:09/01/1996 - 07/17/1997
Potential Units Affected:31600

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND CHASSIS. THE TIRES ON THESE VEHICLES WERE DAMAGED DURING MOUNTING ONTO THE WHEELS. ONLY TRUCKS PRODUCED AT THE CUAUTITLAN, MEXICO PLANT BETWEEN SEPTEMBER 1, 1996, AND JULY 17, 1997, WERE AFFECTED BY THE DEFECT.

Consequence:

THE BEAD AREA OF THE TIRE WAS CUT WHICH COULD RESULT IN AIR LOSS. SUDDEN AIR LOSS COULD OCCUR RESULTING IN A LOSS OF VEHICLE CONTROL.

Action:

DUE TO THE AGE OF THE VEHICLES AND THIS RECALL AFFECTING ORIGINAL EQUIPMENT TIRES ONLY, FORD WILL NO LONGER ACCEPT CLAIMS FOR THIS CAMPAIGN.
1997 FORD F-250
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: - 08/20/2002
Potential Units Affected:4500000

Defect Description:

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.

Consequence:

A FIRE AT THE SWITCH COULD OCCUR.

Action:

BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
1997 FORD F-250
NHTSA Campaign ID:WHEELS:LUGS/NUTS/BOLTS
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:12/01/1995 - 04/14/1998
Potential Units Affected:1520000

Defect Description:

VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES AND LIGHT DUTY PICKUP TRUCKS. THE LUG NUTS ON THESE VEHICLES MAY NOT CREATE SUFFICIENT CLAMP LOAD ALLOWING WHEEL MOVEMENT IN RELATION TO THE HUB/ROTOR MOUNTING SURFACE.

Consequence:

THIS CAN RESULT IN THE LOOSENING OF LUG NUTS, STUD FATIGUE FAILURE, AND THE POTENTIAL FOR A WHEEL SEPARATION FROM THE VEHICLE, INCREASING THE RISK OF A VEHICLE CRASH.

Action:

OWNERS OF THESE VEHICLES WILL BE RECEIVING TWO NOTIFICATIONS. THE FIRST NOTIFICATION, WHICH BEGAN IN MAY 1998, WILL PROVIDE AN INTERIM REPAIR PROCEDURE UNTIL PARTS BECOME AVAILABLE. THIS INTERIM PROCEDURE CAN BE COMPLETED BY OWNERS OR THEIR DEALERS. IT SPECIFIES THAT THE LUG NUT TORQUE MUST BE VERIFIED TO BE 100 LBS. THEN THE LUG NUTS NEED TO BE TIGHTENED AN ADDITIONAL 1/8 TO 1/4 TURN MORE. THERE WILL BE A SECOND OWNER NOTIFICATION, WHICH IS EXPECTED TO BEGIN JULY 20, 1998, UNDER WHICH DEALERS WILL INSPECT THE WHEEL STUDS AND REPLACE THE WHEEL LUG NUTS.
1997 FORD F-250 SD
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:4500000

Defect Description:

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Action:

FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1997 FORD F-250 SD
NHTSA Campaign ID:ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1176000

Defect Description:

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

Consequence:

IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.

Action:

DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
1997 FORD F-350
NHTSA Campaign ID:SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:08/19/1996 - 08/23/1996
Potential Units Affected:1200

Defect Description:

THE RETAINER CLIP THAT HOLDS THE MASTER CYLINDER PUSH ROD TO THE BRAKE PEDAL ARM IS MISSING.

Consequence:

A LOSS OF SERVICE BRAKING CAN OCCUR INCREASING THE RISK OF A VEHICLE ACCIDENT.

Action:

DEALERS WILL INSPECT TO VERIFY THAT THE RETAINER CLIPS ARE INSTALLED AND IF CLIPS ARE MISSING WILL INSTALL CLIPS.
1997 FORD F-350
NHTSA Campaign ID:TIRES:BEAD
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates:09/01/1996 - 07/17/1997
Potential Units Affected:31600

Defect Description:

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND CHASSIS. THE TIRES ON THESE VEHICLES WERE DAMAGED DURING MOUNTING ONTO THE WHEELS. ONLY TRUCKS PRODUCED AT THE CUAUTITLAN, MEXICO PLANT BETWEEN SEPTEMBER 1, 1996, AND JULY 17, 1997, WERE AFFECTED BY THE DEFECT.

Consequence:

THE BEAD AREA OF THE TIRE WAS CUT WHICH COULD RESULT IN AIR LOSS. SUDDEN AIR LOSS COULD OCCUR RESULTING IN A LOSS OF VEHICLE CONTROL.

Action:

DUE TO THE AGE OF THE VEHICLES AND THIS RECALL AFFECTING ORIGINAL EQUIPMENT TIRES ONLY, FORD WILL NO LONGER ACCEPT CLAIMS FOR THIS CAMPAIGN.
1997 FORD F-350
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1200000

Defect Description:

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Consequence:

OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Action:

DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
1997 FORD F-350 SD
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:4500000

Defect Description:

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Action:

FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
1997 FORD F-350 SD
NHTSA Campaign ID:ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1176000

Defect Description:

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

Consequence:

IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.

Action:

DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
1997 FORD F-450 SD
NHTSA Campaign ID:ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:1176000

Defect Description:

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

Consequence:

IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.

Action:

DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
1997 FORD F-450 SD
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:FORD MOTOR COMPANY
Manufacture Dates: -
Potential Units Affected:4500000

Defect Description:

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence:

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Action:

FORD WILL NOTIFY OWNERS THAT