Dodge Buyers Guide

 

Click a car name to see the crash test details for that model.

 

 

 

Crash Test Data for 2003 Dodge

Dodge Vehicle Front Star Rating Side Star Rating Rollover Resistance Rating
Driver Passenger Front Seat Rear Seat
2003 Caravan
2003 DakotaNot
Tested
2003 Dakota
2003 DurangoNot
Tested
Not
Tested
2003 Grand Caravan
2003 Grand Caravan
2003 Intrepid
2003 Neon
2003 RamNot
Tested
Not
Tested
Not
Tested
Not
Tested
Not
Tested
2003 RamNot
Tested
Not
Tested
2003 Ram VanNot
Tested
Not
Tested
2003 Ram WagonNot
Tested
Not
Tested
2003 Stratus
2003 Stratus
2003 ViperNot
Tested
Not
Tested
Not
Tested
Not
Tested
Not
Tested

 

Service Bulletins for 2003 Dodge

2003 DODGE CARAVAN
Bulletin Number: 0200305
RATTLE/KNOCKING SOUND FROM THE FRONT SUSPENSION. *SC
Bulletin Number: 0200403
MUFFLED RATTLE SOUND FROM FRONT SUSPENSION. 2004 VOYAGER INCLUDED. *TT
Bulletin Number: 0200405
CREAKING/SQUAWKING SOUND FROM FRONT STRUT AREA. *TT
Bulletin Number: 02018
POWER SLIDING DOOR AND/OR POWER LIFTGATE WILL POP OFF BUT NOT POWER OPEN. *TT
Bulletin Number: 02020
DELAYED TRANSAXLE ENGAGEMENT AFTER INITIAL START UP. *TT
Bulletin Number: 03014
SERVICE ACTION 03014 - POWERTRAIN CONTROL MODULE (PCM) ELECTRICAL CONNECTOR SEAL INSPECTION/REPAIR PROCEDURE. *TT
Bulletin Number: 0308
DAIMLERCHRYSLER CARGO VAN ORIGINAL EQUIPMENT (OE) FITMENT. BRIDGESTONE TURANZA EL42+ 215/65R16 98T - ARTICLE # 122-076. THIS IS BRIDGESTONE FIRESTONE TECHNICAL BULLETIN. *TT
Bulletin Number: 0500102A
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *YD THIS BULLETIN SUPERSEDES 05-001-02 DATED MARCH 4, 2002. *TT
Bulletin Number: 0500106A
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *KB
Bulletin Number: 0500204
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *TT
Bulletin Number: 0500305
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *TT
Bulletin Number: 0500402
SUBJECT REGARDING REAR BRAKE CYCLIC RUBBING SOUND FROM REAR OF VEHICLE DURING MEDIUM TO LIGHT BRAKE APPLICATION ON VEHICLES WITH REAR DRUM BRAKES. *TT
Bulletin Number: 0500403
ANTI-LOCK BRAKE REAR WHEEL SPEED SENSOR REPLACEMENT. *TT
Bulletin Number: 0500404
ANTI-LOCK BRAKE REAR WHEEL SPEED SENSOR REPLACEMENT. *TT
Bulletin Number: 0703
PROCEDURE TO REMOVE THE INSTRUMENT PANEL WHEN SERVICING THE FRONT BLOWER MOTOR WITHOUT REMOVING THE HVAC ASSEMBLY. UPDATE. *TT
Bulletin Number: 0800504
ERRONEOUS ACTUATION OF HORNS, HEADLAMPS, AND PARKING LAMPS WHILE VEHICLE IS PARKED. *TT
Bulletin Number: 0800505
POWER LIFTGATE (PLG) SERVICE. *TT
Bulletin Number: 0800604
INSTRUMENT PANEL ILLUMINATION. *TT
Bulletin Number: 0800902
SOME VEHICLES NOT EQUIPPED WITH ANTI-SKID BRAKE SYSTEM (ABS) MAY HAVE THE ABS, BRAKE AND TRAC OFF LAMPS ILLUMINATED ON THE INSTRUMENT CLUSTER. *TT
Bulletin Number: 0800902A
CONCERNS WITH THE ABS, BRAKE AND TRAC OFF CLUSTER LAMPS ILLUMINATED ON VEHICLES NOT EQUIPPED WITH ABS BRAKES. *TT
Bulletin Number: 0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
Bulletin Number: 0802002
HEADLAMPS ON WITH WIPERS FEATURE IS INOPERATIVE WHEN THE CUSTOMER ENABLES THE FEATURE USING THE ELECTRONIC VEHICLE INFORMATION CENTER (EVIC) OR THE FEATURE IS ENABLED USING THE DRBIII. *TT
Bulletin Number: 0802103
VEHICLES NOT EQUIPPED WITH ANTI-LOCK BRAKE SYSTEM (ABS) BRAKES MAY HAVE THE ABS, BRAKE, AND TRAC OFF LAMPS ILLUMINATED ON THE INSTRUMENT CLUSTER OR VEHICLES NOT EQUIPPED WITH SENTRY KEY IMMOBILIZER (SKIM) MAY HAVE THE SECURITY/VTA LAMP ILLU
Bulletin Number: 0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
Bulletin Number: 0900704
IRREGULAR ENGINE SNAPPING SOUND. *TT
Bulletin Number: 13
TRANSAXLE WIRING HARNESS CORROSION WHICH COULD CAUSE THE MALFUNCTION INDICATOR LIGHT (MIL) TO ILLUMINATE AND THE TRANSMISSION TO SHIFT INTO 2ND GEAR. *TT
Bulletin Number: 1400207
CLEANING PROCEDURE FOR THE MECHANICAL THROTTLE BODY. *KB
Bulletin Number: 1800504
NO-START, START & STALL MALFUNCTION INDICATOR LAMP ILLUMINATION, DIAGNOSTIC TROUBLE CODES (DTCS) P0508/P0509. *TT
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 1802203
ROUGH/FLUCTUATING IDLE, NO-START, START AND STALL, MALFUNCTION INDICATOR LAMP ILLUMINATION, DIAGNOSTIC TROUBLLE CODES (DTCS) P0508/P0509. *TT
Bulletin Number: 1802303
BATTERY LIGHT ILLUMINATION, ERRONEOUS DIAGNOSTIC TROUBLE CODE (DTC) P1594. *TT
Bulletin Number: 1802603
ENGINE NO START (ENGINE WILL START IMMEDIATELY AFTER CYCLING THE IGNITION KEY), MALFUNCTION INDICATOR LAMP ILLUMINATION WITH FALSE DIAGNOSTIC TROUBLE CODES (DTC) P0016, P0335, P0339, P0340, P0462, P0498, P0499. *TT
Bulletin Number: 1802603A
ENGINE NO START (ENGINE WILL START IMMEDIATELY AFTER CYCLING THE IGNITION KEY), MALFUNCTION INDICATOR LAMP ILLUMINATION WITH FALSE DIAGNOSTIC TROUBLE CODES (DTC) P0016, P0116, P0335, P0339, P0340, P0462, P0498, P0499, P0522, P0622, P1604, P
Bulletin Number: 1802803
VEHICLE WITH PROPERLY FUNCTIONING EVAPORATIVE EMISSIONS SYSTEM REPEATEDLY SETS DIAGNOSTIC TROUBLE CODE P0456 WHEN CUSTOMER REGULARLY COMMUTES ON A STEEP GRADE. *TT
Bulletin Number: 1900103
POP/TICK SOUND IN STEERING WHEEL AREA. *TT *MJ
Bulletin Number: 1900403
STEERING SHUDDER. *TT
Bulletin Number: 1900504
POP/TRICK/CREAK SOUND IN STEERING COLUMN. *MJ *EH
Bulletin Number: 1900603
KNOCKING SOUND FROM LOWER STEERING COLUMN. *TT
Bulletin Number: 1900805
REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC
Bulletin Number: 2100403
TRANSMISSION TRANSFER GEAR WHINE SOUND. *TT
Bulletin Number: 2100405
TRANSMISSION DELAY ENGAGEMENT. *EH
Bulletin Number: 2100503
DELAYED OR TEMPORARY LOSS OF TRANSMISSION ENGAGEMENT AFTER INITIAL START UP ON VARIOUS MODELS INCLUDING THE 2004 PACIFICA, SEBRING CONVERTIBLE, SEBRING SEDAN, INTREPID AND 2003 SX2.0. *TT *MJ
Bulletin Number: 2100503A
DELAYED OR TEMPORARY LOSS OF TRANSMISSION ENGAGEMENT AFTER INITIAL START UP ON VARIOUS MODELS INCLUDING THE 2004 PACIFICA, SEBRING CONVERTIBLE, SEBRING SEDAN, INTREPID AND 2003 SX2.0. *TT
Bulletin Number: 2100603
TRANSMISSION HARSH 4-3 DOWNSHIFT ON VARIOUS MODELS INCLUDING THE 2004 PACIFICA, SEBRING, INTREPID AND 2003 SX2.0. *TT
Bulletin Number: 2100603A
TRANSMISSION HARSH 4-3 DOWNSHIFT. *TT
Bulletin Number: 2100903
AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE. VARIOUS MODELS INCLUDING THE 2004 RAM TRUCK, DURANGO, SEBRING CONVERTIBLE, CHEROKEE, VISION, NEON, AND VOYAGER. *TT *SC
Bulletin Number: 2200102
CHROME WHEEL CARE. *SLC
Bulletin Number: 2300103
UPPER BODY SEAM SEAL WATER LEAK. *TT
Bulletin Number: 2300205
UPPER BODY SEAM SEAL APPEARANCE CONCERN WATER LEAK. *EH
Bulletin Number: 2300403
POWER SLIDING DOOR AND / OR POWER LIFTGATE WILL POP OFF BUT NOT POWER OPEN. *TT
Bulletin Number: 2301004
PASSENGER COMPARTMENT FLOOR WATER LEAK. *TT THIS BULLETIN SUPERSEDES BULLETIN 23-010-04 DATED 04-29-04. *TT
Bulletin Number: 2302007
POWER SLIDING DOOR ADJUSTMENT AND DIAGNOSIS AID. *KB UPDATED 10/26/07. *NJ
Bulletin Number: 30
POWERTRAIN CONTROL MODULE (PCM) ELECTRICAL CONNECTOR SEAL CUSTOMER SATISFACTION NOTIFICATION NO. C30. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: 9002828
Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator, attaching rivet and an instruction sheet are now available as a kit. If the insulator requires replacement lease order 68253
Bulletin Number: C20
POWER STEERING FLUID COOLER HOSES MAY SPLIT AND CAUSE A LOSS OF POWER ASSIST - CUSTOMER SATISFACTION NOTIFICATION NO. C20. *TT
2003 DODGE DAKOTA
Bulletin Number: 01
CUSTOMER SATISFACTION NOTIFICATION - 3/8" TORQUE CONVERTER DRAIN BACK VALVE. *TT
Bulletin Number: 0201004
UPPER BALL JOINT EXTENDED WARRANTY. *TT
Bulletin Number: 02024
HARSH SHIFTS DUE TO A STICKING PRESSURE SENSOR TRANSDUCER. *TT
Bulletin Number: 02026
THE TRANSMISSION MAY OVERHEAT DUE TO A RESTRICTION IN THE TORQUE CONVERTER DRAIN BACK VALVE. *TT
Bulletin Number: 02026A
THE TRANSMISSION MAY OVERHEAT DUE TO A RESTRICTION IN THE TORQUE CONVERTER DRAIN BACK VALVE AND MAY CAUSE DAMAGE TO THE TRANSMISSION. *TT
Bulletin Number: 0500603
REAR BRAKE MOAN. *TT
Bulletin Number: 0703
DISCONNECTING THE PARK BRAKE RELEASE HANDLE WHEN SERVICING THE STEERING COLUMN OPENING COVER. *TT
Bulletin Number: 0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
Bulletin Number: 0802303
INTERMITTENT LOCKING/UNLOCKING OF DOORS WITHOUT ACTIVATING THE POWER DOOR LOCK SWITCH. *TT
Bulletin Number: 0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
Bulletin Number: 10023
POWERTRAIN DIAGNOSTIC INFORMATION. SERVICE INFORMATION TUNEUPS. *TT
Bulletin Number: 10023
STEERING COLUMN SERVICE. INFORMATION. SERVICE INFORMATION TUNEUPS. *TT
Bulletin Number: 1800103
CUSTOMERS MAY COMPLAIN THE VEHICLE WILL NOT SHIFT OUT OF 2ND GEAR WHILE CLIMBING A GRADE. UPDATE TO TRANSMISSION CALIBRATIONS. *TT
Bulletin Number: 1800103A
CUSTOMERS MAY COMPLAIN THE VEHICLE WILL NOT SHIFT OUT OF 2ND GEAR WHILE CLIMBING A GRADE. UPDATE TO TRANSMISSION CALIBRATIONS.
Bulletin Number: 1800503
TRANSMISSION SHIFT/SPEED CONTROL IMPROVEMENTS. *JB
Bulletin Number: 1800503A
TRANSMISSION SHIFT/SPEED CONTROL IMPROVEMENTS/POSSIBLE MALFUNCTION INDICATOR LAMP ILLUMINATION. *TT
Bulletin Number: 1800503B
TRANSMISSION SHIFT/SPEED CONTROL IMPROVEMENTS/POSSIBLE MALFUNCTION INDICATOR LAMP ILLUMINATION. *TT
Bulletin Number: 1800503C
TRANSMISSION SHIFT / SPEED CONTROL IMPROVEMENTS / POSSIBLE MALFUNCTION INDICATOR LAMP ILLUMINATION. *TT
Bulletin Number: 1801504
IDLE FLUCTUATION WHILE TURNING. *TT
Bulletin Number: 1803703
MALFUNCTION INDICATOR LAMP ILLUMINATION, ERRONEOUS DIAGNOSTIC TROUBLE CODE (DTC) P0116, P2172, P2173. *TT
Bulletin Number: 2100202
SUBJECT REGARDING REVISION IN DIAGNOSTIC PROCEDURES AND LABOR OPERATION TIMES FOR RE TRANSMISSIONS. *TT
Bulletin Number: 2101505
45RFE/545RFE TRANS - DELAYED ENGAGEMENT DUE TO COOLER RETURN FILTER REPLACEMENT. *SC
Bulletin Number: 2200102
CHROME WHEEL CARE. *SLC
Bulletin Number: 2301004
PASSENGER COMPARTMENT FLOOR WATER LEAK. *TT THIS BULLETIN SUPERSEDES BULLETIN 23-010-04 DATED 04-29-04. *TT
Bulletin Number: 2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: 9002828
Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator, attaching rivet and an instruction sheet are now available as a kit. If the insulator requires replacement lease order 68253
Bulletin Number: 9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement
Bulletin Number: 9002872
56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2 required to attach Neutral Start Switch
2003 DODGE DURANGO
Bulletin Number: 01
CUSTOMER SATISFACTION NOTIFICATION - 3/8" TORQUE CONVERTER DRAIN BACK VALVE. *TT
Bulletin Number: 0201004
UPPER BALL JOINT EXTENDED WARRANTY. *TT
Bulletin Number: 02026
THE TRANSMISSION MAY OVERHEAT DUE TO A RESTRICTION IN THE TORQUE CONVERTER DRAIN BACK VALVE. *TT
Bulletin Number: 02026A
THE TRANSMISSION MAY OVERHEAT DUE TO A RESTRICTION IN THE TORQUE CONVERTER DRAIN BACK VALVE AND MAY CAUSE DAMAGE TO THE TRANSMISSION. *TT
Bulletin Number: 0422
5.7L ENGINE LONG BLOCK REPAIR / REPLACE PROCEDURES. WARRANTY PLANNING & ADMINISTRATION *TT
Bulletin Number: 0500703
BRAKE SHUDDER OR VIBRATION. *TT
Bulletin Number: 0703
DISCONNECTING THE PARK BRAKE RELEASE HANDLE WHEN SERVICING THE STEERING COLUMN OPENING COVER. *TT
Bulletin Number: 0703
PROCEDURES FOR SERVICING THE SEAT BELT LATCH PLATE CINCH BAR. *TT
Bulletin Number: 0801003
SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS. *TT
Bulletin Number: 0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
Bulletin Number: 0802303
INTERMITTENT LOCKING/UNLOCKING OF DOORS WITHOUT ACTIVATING THE POWER DOOR LOCK SWITCH. *TT
Bulletin Number: 0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
Bulletin Number: 10023
STEERING COLUMN SERVICE. INFORMATION. SERVICE INFORMATION TUNEUPS. *TT
Bulletin Number: 10023
POWERTRAIN DIAGNOSTIC INFORMATION. SERVICE INFORMATION TUNEUPS. *TT
Bulletin Number: 10182004
MULTIPLE WIRING CHANGES. *EH
Bulletin Number: 1800503
TRANSMISSION SHIFT/SPEED CONTROL IMPROVEMENTS. *JB
Bulletin Number: 1800503A
TRANSMISSION SHIFT/SPEED CONTROL IMPROVEMENTS/POSSIBLE MALFUNCTION INDICATOR LAMP ILLUMINATION. *TT
Bulletin Number: 1800503B
TRANSMISSION SHIFT/SPEED CONTROL IMPROVEMENTS/POSSIBLE MALFUNCTION INDICATOR LAMP ILLUMINATION. *TT
Bulletin Number: 1800503C
TRANSMISSION SHIFT / SPEED CONTROL IMPROVEMENTS / POSSIBLE MALFUNCTION INDICATOR LAMP ILLUMINATION. *TT
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 1803703
MALFUNCTION INDICATOR LAMP ILLUMINATION, ERRONEOUS DIAGNOSTIC TROUBLE CODE (DTC) P0116, P2172, P2173. *TT
Bulletin Number: 2100202
SUBJECT REGARDING REVISION IN DIAGNOSTIC PROCEDURES AND LABOR OPERATION TIMES FOR RE TRANSMISSIONS. *TT
Bulletin Number: 2200102
CHROME WHEEL CARE. *SLC
Bulletin Number: 2301004
PASSENGER COMPARTMENT FLOOR WATER LEAK. *TT THIS BULLETIN SUPERSEDES BULLETIN 23-010-04 DATED 04-29-04. *TT
Bulletin Number: 2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: 9002828
Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator, attaching rivet and an instruction sheet are now available as a kit. If the insulator requires replacement lease order 68253
Bulletin Number: 9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement
Bulletin Number: 9002872
56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2 required to attach Neutral Start Switch
2003 DODGE GRAND CARAVAN
Bulletin Number: 0308
DAIMLERCHRYSLER CARGO VAN ORIGINAL EQUIPMENT (OE) FITMENT. BRIDGESTONE TURANZA EL42+ 215/65R16 98T - ARTICLE # 122-076. THIS IS BRIDGESTONE FIRESTONE TECHNICAL BULLETIN. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: C20
POWER STEERING FLUID COOLER HOSES MAY SPLIT AND CAUSE A LOSS OF POWER ASSIST - CUSTOMER SATISFACTION NOTIFICATION NO. C20. *TT
2003 DODGE INTREPID
Bulletin Number: 0200103
SQUEAKING SOUND FROM REAR STRUT(S). *TT
Bulletin Number: 02017
REMOTE KEYLESS ENTRY (RKE) TRANSMITTER (KEY FOB) PROGRAMMING. *TT
Bulletin Number: 02020
DELAYED TRANSAXLE ENGAGEMENT AFTER INITIAL START UP. *TT
Bulletin Number: 02025
MALFUNCTION INDICATOR LAMP ILLUMINATION / TRANSMISSION LIMP-IN CONDITION. *TT
Bulletin Number: 0500103
FRONT BRAKE SOUND AND / OR PULSATION WHEN STOPPING. *TT
Bulletin Number: 0500103A
FRONT BRAKE SOUND AND / OR PULSATION WHEN STOPPING. *TT
Bulletin Number: 08
COMPUTER DRIVER CHIP THAT COULD FAIL. REPLACE POWERTRAIN CONTROL MODULE. *TT
Bulletin Number: 0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
Bulletin Number: 0802202
POLICE VEHICLE BODY CONTROL MODULE (BCM). *TT
Bulletin Number: 0802203
HEADLAMP/INSTRUMENT PANEL ILLUMINATION. 2004 MODELS INCLUDED. *TT
Bulletin Number: 0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
Bulletin Number: 0900203
ENGINE STUMBLE AND/OR MISFIRE - MALFUNCTION INDICATOR LAMP ILLUMINATION. *TT
Bulletin Number: 0900204
SHORT DURATION COLD ENGINE START-UP TICKING LIKE SOUND. THIS BULLETIN APPLIES TO VEHICLES BUILT PRIOR TO MARCH 31, 2003. *MN
Bulletin Number: 0900503
SHORT DURATION COLD ENGINE START-UP TICKING LIKE SOUND. *TT
Bulletin Number: 1400103
FUEL TANK SLOW TO FILL. INCLUDING MY2004. *TT
Bulletin Number: 1800604A
GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE. *TT *MJ THIS BULLETIN SUPERSEDES BULLETIN 18-006-04A DATED 04/06/2004. *TT
Bulletin Number: 1800703
GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE. *TT
Bulletin Number: 1800703A
GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE. *TT
Bulletin Number: 1800703B
GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE. 2004 MODELS INCLUDED. *TT
Bulletin Number: 1800703C
GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE. 2004 MODELS INCLUDED. *TT
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 1802102
ON SOME VEHICLES, THERE IS MALFUNCTION INDICATOR LAMP ILLUMINATION WITH POSSIBLE ROUGH RUNNING ENGINE AND ANY OR ALL OF DIAGNOSTIC TROUBLE CODES P2302, P2305, P2308, P2311, P2314 P2317, IGNITION COIL SECONDARY CIRCUIT. *TT
Bulletin Number: 1802907
GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE. *KB
Bulletin Number: 1803202
THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE DUE TO ERRONEOUS DETECTION DIAGNOSTIC TROUBLE CODES (DTC) P0335, P0340, P0462, P0499, P0622, P0660, P1604, P1681, P1698. *TT
Bulletin Number: 1803402
MALFUNCTION INDICATOR LIGHT ILLUMINATION AND ERRONEOUS DIAGNOSTIC TROUBLE CODES (DTC) - TRANSAXLE SHIFT IMPROVEMENTS. *TT
Bulletin Number: 1804203
FLASH-ROUGH IDLE. *PH
Bulletin Number: 2100503
DELAYED OR TEMPORARY LOSS OF TRANSMISSION ENGAGEMENT AFTER INITIAL START UP ON VARIOUS MODELS INCLUDING THE 2004 PACIFICA, SEBRING CONVERTIBLE, SEBRING SEDAN, INTREPID AND 2003 SX2.0. *TT *MJ
Bulletin Number: 2100503A
DELAYED OR TEMPORARY LOSS OF TRANSMISSION ENGAGEMENT AFTER INITIAL START UP ON VARIOUS MODELS INCLUDING THE 2004 PACIFICA, SEBRING CONVERTIBLE, SEBRING SEDAN, INTREPID AND 2003 SX2.0. *TT
Bulletin Number: 2100603
TRANSMISSION HARSH 4-3 DOWNSHIFT ON VARIOUS MODELS INCLUDING THE 2004 PACIFICA, SEBRING, INTREPID AND 2003 SX2.0. *TT
Bulletin Number: 2100603A
TRANSMISSION HARSH 4-3 DOWNSHIFT. *TT
Bulletin Number: 2100804
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION -DIAGNOSTIC TROUBLE CODE (DTC) P1776 SOLENOID SWITCH VALVE LATCHED IN LR POSITION. *MJ THIS BULLETIN REPLACES 21-008-04 DATED JUNE 1, 2004. *TT
Bulletin Number: 2200102
CHROME WHEEL CARE. *SLC
Bulletin Number: 2300203
WIND NOISE FROM SUNROOF OR B-PILLAR WHILE DRIVING. *TT
Bulletin Number: 2301103
SAG OR RATTLE AT REAR OF HEADLINER. *TT
Bulletin Number: 2304702
INTERIOR FRONT DOOR HANDLE/BEZEL REPLACEMENT. *MJ
Bulletin Number: 2400204
AIR CONDITIONER AND HEATER PERFORMANCE. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: C23
VEHICLE EMISSION CONTROL INFORMATION (VECI) LABEL REPLACEMENT - EMISSIONS RECALL NO. C23. *TT
Bulletin Number: C25
CUSTOMER SATISFACTION NOTIFICATION TO REPLACE VEHICLE'S AIR CONDITIONING (A/C) DRIVE BELT TENSIONER BRACKET. *TT
Bulletin Number: TSB-ER-J18
CHRYSLERDODGEEAGLE SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THE CATALYTIC CONVERTERS ON VEHICLES MAY BECOME DAMAGED FROM CONTINUED OPERATION IN LIMP IN MODE FOLLOWING A CAMSHAFT POSITION SENSOR FAULT. THE POWERTRAIN
2003 DODGE MAGNUM
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
2003 DODGE NEON
Bulletin Number: 02020
DELAYED TRANSAXLE ENGAGEMENT AFTER INITIAL START UP. *TT
Bulletin Number: 02025
MALFUNCTION INDICATOR LAMP ILLUMINATION / TRANSMISSION LIMP-IN CONDITION. *TT
Bulletin Number: 03004
IMPROPER RIGHT MOTOR MOUNT THROUGH BOLT THAT COULD RESULT IN A LOSS OF BOLT TORQUE. *TT
Bulletin Number: 03005
RIGHT SIDE COWL WATER LEAK. RAPID RESPONSE TRANSMITTAL. *TT
Bulletin Number: 0300604
FRONT HUB/HALF SHAFT CLICK/POP SOUND. *TT
Bulletin Number: 0703
HORN MOUNTING CHANGE. *TT
Bulletin Number: 08
COMPUTER DRIVER CHIP THAT COULD FAIL. REPLACE POWERTRAIN CONTROL MODULE. *TT
Bulletin Number: 0801003
SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS. *TT
Bulletin Number: 0801303
ERRONEOUS AIRBAG DIAGNOSTIC TROUBLE CODE (DTC) - LOSS OF IGNITION RUN/START. *TT
Bulletin Number: 0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
Bulletin Number: 0802801
MOISTURE ACCUMULATION INSIDE A VENTED HEADLAMP ASSEMBLY CONDITION. *TT
Bulletin Number: 0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
Bulletin Number: 0900704
IRREGULAR ENGINE SNAPPING SOUND. *TT
Bulletin Number: 1100104
EXHAUST TIP ALIGNMENT. 2004 NEON SRT4 ALSO INCLUDED. *TT
Bulletin Number: 1100105
DUAL EXHAUST TIPS ARE NOT IN EQUAL FORE/AFT ALIGNMENT. *EH
Bulletin Number: 110014
EXHAUST TIP ALIGNMENT. 2004 NEON SRT4 ALSO INCLUDED. *TT
Bulletin Number: 1801204
WOT ACCELERATION STUMBLE/NUMBER 4 SPARK PLUG WIRE APPEARANCE. *TT
Bulletin Number: 1801803
MALFUNCTION INDICATOR LAMP ILLUMINATION (MIL), ERRONEOUS DIAGNOSTIC TROUBLE CODES (DTC). *TT
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 1802603
ENGINE NO START (ENGINE WILL START IMMEDIATELY AFTER CYCLING THE IGNITION KEY), MALFUNCTION INDICATOR LAMP ILLUMINATION WITH FALSE DIAGNOSTIC TROUBLE CODES (DTC) P0016, P0335, P0339, P0340, P0462, P0498, P0499. *TT
Bulletin Number: 1802603A
ENGINE NO START (ENGINE WILL START IMMEDIATELY AFTER CYCLING THE IGNITION KEY), MALFUNCTION INDICATOR LAMP ILLUMINATION WITH FALSE DIAGNOSTIC TROUBLE CODES (DTC) P0016, P0116, P0335, P0339, P0340, P0462, P0498, P0499, P0522, P0622, P1604, P
Bulletin Number: 1802902
ENGINE NO START (ENGINE WILL START IMMEDIATELY AFTER CYCLING THE IGNITION KEY), MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE (DTC) P0016, P0335, P0339, P0340, P0462, P0498, P0499, P0522, P0622, P1604, P1681, P
Bulletin Number: 1900204
STEERING COLUMN CLICK SOUND. *TT
Bulletin Number: 1900702
LOWER STEERING COLUMN CLICK SOUND. *TT
Bulletin Number: 1900805
REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC
Bulletin Number: 2100503
DELAYED OR TEMPORARY LOSS OF TRANSMISSION ENGAGEMENT AFTER INITIAL START UP ON VARIOUS MODELS INCLUDING THE 2004 PACIFICA, SEBRING CONVERTIBLE, SEBRING SEDAN, INTREPID AND 2003 SX2.0. *TT *MJ
Bulletin Number: 2100503A
DELAYED OR TEMPORARY LOSS OF TRANSMISSION ENGAGEMENT AFTER INITIAL START UP ON VARIOUS MODELS INCLUDING THE 2004 PACIFICA, SEBRING CONVERTIBLE, SEBRING SEDAN, INTREPID AND 2003 SX2.0. *TT
Bulletin Number: 2100603
TRANSMISSION HARSH 4-3 DOWNSHIFT ON VARIOUS MODELS INCLUDING THE 2004 PACIFICA, SEBRING, INTREPID AND 2003 SX2.0. *TT
Bulletin Number: 2100603A
TRANSMISSION HARSH 4-3 DOWNSHIFT. *TT
Bulletin Number: 2100804
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION -DIAGNOSTIC TROUBLE CODE (DTC) P1776 SOLENOID SWITCH VALVE LATCHED IN LR POSITION. *MJ THIS BULLETIN REPLACES 21-008-04 DATED JUNE 1, 2004. *TT
Bulletin Number: 2200102
CHROME WHEEL CARE. *SLC
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: C24
OWNER'S MANUAL ENGINE OIL RECOMMENDATION CORRECTION - CUSTOMER SATISFACTION NOTIFICATION C24. *TT
2003 DODGE RAM
Bulletin Number: 02021
5.7L ENGINE VALVE SPRING BREAKAGE. *TT
Bulletin Number: 02022
THE TRANSMISSION MAY OVERHEAT DUE TO A RESTRICTION IN THE TORQUE CONVERTER DRAIN BACK VALVE. *TT
Bulletin Number: 02024
HARSH SHIFTS DUE TO A STICKING PRESSURE SENSOR TRANSDUCER. *TT
Bulletin Number: 02026
THE TRANSMISSION MAY OVERHEAT DUE TO A RESTRICTION IN THE TORQUE CONVERTER DRAIN BACK VALVE. *TT
Bulletin Number: 02026A
THE TRANSMISSION MAY OVERHEAT DUE TO A RESTRICTION IN THE TORQUE CONVERTER DRAIN BACK VALVE AND MAY CAUSE DAMAGE TO THE TRANSMISSION. *TT
Bulletin Number: 03002
SERVICE ACTION 03-002 - INOPERATIVE SOFTWARE, SERVICE BULLETIN #18-005-03 REV A, FLASH: TRANSMISSION SHIFT/SPEED CONTROL IMPROVEMENTS/POSSIBLE MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION. *TT
Bulletin Number: 0300202
INFORMATION ON THE USE OF SYNTHETIC REAR AXLE LUBRICANT. *TT
Bulletin Number: 0300304
LAUNCH SHUDDER. *TT
Bulletin Number: 0300404
AXLE WHINE. *TT
Bulletin Number: 03010
SCORED 3.7L ENGINE CRANKSHAFT. *TT
Bulletin Number: 0422
5.7L ENGINE LONG BLOCK REPAIR / REPLACE PROCEDURES. WARRANTY PLANNING & ADMINISTRATION *TT
Bulletin Number: 05002
NEW WATER PUMP FOR 3.7L ENGINE - NO LONGER COMMON WITH 4.7L. ADVANCED SERVICE INFORMATION #05-002. *TT
Bulletin Number: 0500803
BRAKE SHUDDER OR VIBRATION. *TT
Bulletin Number: 0600103
RATTLE SOUND FROM TRANSMISSION WHEN IDLING. *TT
Bulletin Number: 06003
REAR SUSPENSION VIBRATION WHILE DRIVING AT HIGHWAY SPEEDS. *TT
Bulletin Number: 0800403
ELECTRO MECHANICAL INSTRUMENT CLUSTER - ERRONEOUS INDICATOR LAMPS. *TT
Bulletin Number: 0800703
REPLACEMENT OF THE ALTERNATOR SUPPORT BRACKET FOR ACCESSORY DRIVE BELT SQUEAL. *TT
Bulletin Number: 0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
Bulletin Number: 0801903
LAMP OUT INDICATOR WITH AFTERMARKET PICK UP BOX INSTALLATION. *TT
Bulletin Number: 0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
Bulletin Number: 0803103
WATER MAY ENTER THE POWERTRAIN CONTROL MODULE (PCM) CONNECTOR CAUSING CORROSION OF ELECTRICAL TERMINALS ON THE PCM. SETS MALFUNCTION INDICATOR LIGHT. *TT
Bulletin Number: 0900504
GROWLING SOUND ON ACCELERATION. *TT
Bulletin Number: 0900604
LOW ENGINE OIL PRESSURE AT START UP IN TEMPERATURES BELOW FREEZING. *TT
Bulletin Number: 10023
POWERTRAIN DIAGNOSTIC INFORMATION. SERVICE INFORMATION TUNEUPS. *TT
Bulletin Number: 10023
STEERING COLUMN SERVICE. INFORMATION. SERVICE INFORMATION TUNEUPS. *TT
Bulletin Number: 10023
MISSING DIESEL MAINTENANCE SCHEDULE FOR TRUCK SERVICE MANUAL. SERVICE INFORMATION TUNEUPS. *TT
Bulletin Number: 10023
THE 47RE SERVICE INFORMATION HAS BEEN ACCIDENTALLY OMITTED FROM THE 2003 SERVICE MANUAL, BUT IS INCLUDED IN THE ELECTRONIC VERSION OF THE MDS2. SERVICE INFORMATION TUNEUPS. *TT
Bulletin Number: 10182004
MINIMUN REAR ROTOR THICKNESS. *EH
Bulletin Number: 10182004
STABILIZER BAR LINK NUT TORQUE SPECS CHANGED. *EH
Bulletin Number: 1400202
INFORMATION ON TAMPERING WITH VP44 FUEL PUMP ON CUMMINS DIESEL ENGINES. *TT
Bulletin Number: 1400205
INACTIVE THROTTLE BODY IN COLD AMBIENT TEMPERATURES. 2005 DODGE RAM *SC
Bulletin Number: 1400305
CUMMINS DIESEL DIAGNOSTICS. *TT
Bulletin Number: 1400405
ELECTRONIC FUEL CONTROL (EFC) ACTUATOR AVAILABLE FOR SERVICE. *TT
Bulletin Number: 1800304
POOR AIR CONDITIONER PERFORMANCE, SLOW FUEL GAUGE RESPONSE, AND DIAGNOSTIC TROUBLE CODES (DTC'S) P0341 AND P1757. *TT
Bulletin Number: 1801303
MALFUNCTION INDICATOR LAMP AND/OR ENGINE THROTTLE CONTROL (ETC) LIGHT ILLUMINATION, DIAGNOSTIC TROUBLE CODES (DTCS), AND/OR POOR IDLE QUALITY. *TT
Bulletin Number: 1801403
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION, ERRONEOUS DIAGNOSTIC TROUBLE CODES (DTC) P0300 - P0309. *TT
Bulletin Number: 1801503
POWERTRAIN CONTROL MODULE (PCM) SHIFT QUALITY IMPROVEMENTS FOR A NO SHIFT OUT OF THIRD GEAR CONDITION. *TT
Bulletin Number: 1801705
LONG CRANK TIMES IN AMBIENT TEMPERATURES BELOW FREEZING. *TT
Bulletin Number: 1801902A
REVISION OF FLASH PROCESS FOR NEW ENGINE CONTROL MODULE (ECM) FROM CUMMINS. *SLC THIS BULLETIN SUPERSEDES BULLETIN 18-019-02 DATED JUNE 17, 2002. *TT
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 1802206
5.9L TURBO-DIESEL ENGINE SYSTEM ENHANCEMENTS. *TT
Bulletin Number: 1802207
5.9L TURBO - DIESEL ENGINE SYSTEM ENHANCEMENTS. *KB
Bulletin Number: 1802402
SOME 2003 VEHICLES EQUIPPED WITH DUAL REAR WHEELS, BUILT PRIOR TO JULY 15, 2003, MAY HAVE AN INCORRECT NUMBER AS THE SIXTH CHARACTER OF THE VIN. *TT
Bulletin Number: 1803003
GENERIC CUMMINS ENGINE CONTROL MODULE (PCM) PROCEDURE. *TT
Bulletin Number: 1803003A
GENERIC CUMMINS ENGINE CONTROL MODULE (PCM) PROCEDURE. *TT THIS BULLETIN REPLACED 18-030-03. *TT THIS BULLETIN REPLACED 18-030-03A DATED 10/17/03. TO ALSO INCLUDE 2005 RAM TRUCK. *TT
Bulletin Number: 1803703
MALFUNCTION INDICATOR LAMP ILLUMINATION, ERRONEOUS DIAGNOSTIC TROUBLE CODE (DTC) P0116, P2172, P2173. *TT
Bulletin Number: 1901204
STEERING COLUMN SNAPPING OR TICKING SOUND. *TT
Bulletin Number: 2100202
SUBJECT REGARDING REVISION IN DIAGNOSTIC PROCEDURES AND LABOR OPERATION TIMES FOR RE TRANSMISSIONS. *TT
Bulletin Number: 2101505
45RFE/545RFE TRANS - DELAYED ENGAGEMENT DUE TO COOLER RETURN FILTER REPLACEMENT. *SC
Bulletin Number: 2200102
CHROME WHEEL CARE. *SLC
Bulletin Number: 2200506
FRONT END SHIMMY ON 4X4 VEHICLES WHEN TRAVELING OVER ROUGH SURFACES IN THE ROAD. *KB
Bulletin Number: 2300104
BUG DEFLECTOR WIND WHISTLE. *TT
Bulletin Number: 2300505
MUD OR DIRT MAY ACCUMULATE ON THE ROCKER PANEL CAUSING CUSTOMERS TO COMPLAIN THAT THEIR CLOTHING GETS DIRTY WHEN THEY ENTER OR EXIT THE VEHICLE. *TT
Bulletin Number: 2301104
BUG DEFLECTOR LOOSE/RATTLING. *TT
Bulletin Number: 2301307
TRAILER TOWING MIRROR - NEW MIRROR GLASS LOCKING TAB - NEW REMOVAL PROCEDURE. *KB
Bulletin Number: 2301603
BUZZING OR VIBRATING SOUND COMING FROM THE FRONT OF THE VEHICLE. *TT
Bulletin Number: 2301803
WHISTLING SOUND MAY BE PRESENT COMING FROM THE FRONT OF THE INSTRUMENT PANEL NEAR THE BOTTOM OF THE WINDSHIELD WHEN THE HEATER A/C BLOWER IS ON. *TT
Bulletin Number: 2400403
DEFROST DOOR INOPERATIVE. *TT
Bulletin Number: 2500106
POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM FREEZES IN EXTREME COLD AMBIENT TEMPERATURES. *TT
Bulletin Number: 2500108
POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM FREEZES IN EXTREME COLD AMBIENT TEMPERATURES -- INVOLVES INSTALLING REVISED PCV SYSTEM COMPONENTS. *NJ
Bulletin Number: 42
THE POWERTRAIN CONTROL MODULE (PCM) ELECTRICAL CONNECTORS ON CERTAIN TRUCKS MAY ALLOW WATER TO ENTER INTO THE CONNECTORS. WATER AND THE RESULTING CORROSION IN A PCM CONNECTOR CAN CAUSE THE SPEED CONTROL AND/OR TRANSMISSION OVERDRIVE FUNCT
Bulletin Number: 44
CUSTOMER SATISFACTION NO. C44. TRANSMISSION COOLER LINE ON CERTAIN VEHICLES CAN TRANSMIT HIGH PRESSURE PULSES WHEN THE VEHICLE IS OPERATED AT HEAVY LOADS. *TT
Bulletin Number: SB-14-001-10
DODGE: ELECTRONIC FUEL CONTROL ACTUATOR (FCA) AVAILABLE FOR SERVICE/NEW DIAGNOSTICS AVAILABLE FOR DTC P0251. ENGINE SURGES AT IDLE OR MIL ILLUMINATION. FURTHER INVESTIGATION MAY IDENTIFY DTC P0251-CP3 PUMP REGULATOR CONTROL-DIESEL. IF P0
2003 DODGE RAM 1500
Bulletin Number: 05002
NEW WATER PUMP FOR 3.7L ENGINE - NO LONGER COMMON WITH 4.7L. ADVANCED SERVICE INFORMATION #05-002. *TT
Bulletin Number: 08-004
2003-2008 (DR) RAM TRUCK 1500-STEERING SHUDDER DURING PARKING LOT OR LOW VEHICLE SPEED MANEUVERS. *PE
Bulletin Number: 10182004
ADDED DIAGNOSTICS FOR P0421 AND P0431. *EH
Bulletin Number: 1801705
LONG CRANK TIMES IN AMBIENT TEMPERATURES BELOW FREEZING. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: 9002828
Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator, attaching rivet and an instruction sheet are now available as a kit. If the insulator requires replacement lease order 68253
Bulletin Number: 9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement
2003 DODGE RAM 2500
Bulletin Number: 05002
NEW WATER PUMP FOR 3.7L ENGINE - NO LONGER COMMON WITH 4.7L. ADVANCED SERVICE INFORMATION #05-002. *TT
Bulletin Number: 10182004
ADDED DIAGNOSTICS FOR P0421 AND P0431. *EH
Bulletin Number: 1801705
LONG CRANK TIMES IN AMBIENT TEMPERATURES BELOW FREEZING. *TT
Bulletin Number: 28
CUSTOMER SATISFACTION NOTIFICATION TO TIGHTEN THE DIESEL ENGINE COOLING FAN WHICH MAY BECOME LOOSE AND SEPARATE FROM THE PULLEY. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: 9002828
Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator, attaching rivet and an instruction sheet are now available as a kit. If the insulator requires replacement lease order 68253
Bulletin Number: 9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement
Bulletin Number: 9002872
56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2 required to attach Neutral Start Switch
Bulletin Number: ECM K-01
DODGE: CALIFORNIA EMISSIONS RECALL REPROGRAM ECM-OBD READINESS. RECALL AFFECTS RAM TRUCKS AND CAB CHASSIS. CSC LETTER WAS REC'D. *PE
Bulletin Number: SB19-001-11 REVA
DODGE: BULLETIN PROVIDING ALIGNMENT PROCEDURES FOR TIE ROD BALL STUD HOUSING FOR THE RIGHT AND LEFT. MODEL YRS FOR CAB CHASSIS (REG AND MEGA PICKUPS AND 4X4) 2003-2011. *PE
2003 DODGE RAM 3500
Bulletin Number: 04032004
OIL PRESSURE FALLS BELOW NORMAL DURING VEHICLE OPERATION. THIS INCLUDES CHEVROLET AND GMC 4500 SERIES AND ISUZU NPR AND NPRHD MODELS. *EH
Bulletin Number: 05002
NEW WATER PUMP FOR 3.7L ENGINE - NO LONGER COMMON WITH 4.7L. ADVANCED SERVICE INFORMATION #05-002. *TT
Bulletin Number: 10182004
ADDED DIAGNOSTICS FOR P0421 AND P0431. *EH
Bulletin Number: 14-005-12
Heavy Duty Filtration MOPAR Retrofit or Add On Parts Available
Bulletin Number: 1801705
LONG CRANK TIMES IN AMBIENT TEMPERATURES BELOW FREEZING. *TT
Bulletin Number: 28
CUSTOMER SATISFACTION NOTIFICATION TO TIGHTEN THE DIESEL ENGINE COOLING FAN WHICH MAY BECOME LOOSE AND SEPARATE FROM THE PULLEY. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: 9002828
Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator, attaching rivet and an instruction sheet are now available as a kit. If the insulator requires replacement lease order 68253
Bulletin Number: 9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement
Bulletin Number: 9002872
56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2 required to attach Neutral Start Switch
Bulletin Number: ECM K-01
DODGE: CALIFORNIA EMISSIONS RECALL REPROGRAM ECM-OBD READINESS. RECALL AFFECTS RAM TRUCKS AND CAB CHASSIS. CSC LETTER WAS REC'D. *PE
Bulletin Number: SB19-001-11 REVA
DODGE: BULLETIN PROVIDING ALIGNMENT PROCEDURES FOR TIE ROD BALL STUD HOUSING FOR THE RIGHT AND LEFT. MODEL YRS FOR CAB CHASSIS (REG AND MEGA PICKUPS AND 4X4) 2003-2011. *PE
2003 DODGE RAM PICKUP
Bulletin Number: 01
CUSTOMER SATISFACTION NOTIFICATION - 3/8" TORQUE CONVERTER DRAIN BACK VALVE. *TT
Bulletin Number: 1400502
FUEL FILTER/WATER SEPARATOR DRAIN VALVE RESTRICTION. *TT
Bulletin Number: 1800503
TRANSMISSION SHIFT/SPEED CONTROL IMPROVEMENTS. *JB
Bulletin Number: 1800503A
TRANSMISSION SHIFT/SPEED CONTROL IMPROVEMENTS/POSSIBLE MALFUNCTION INDICATOR LAMP ILLUMINATION. *TT
Bulletin Number: 1800503B
TRANSMISSION SHIFT/SPEED CONTROL IMPROVEMENTS/POSSIBLE MALFUNCTION INDICATOR LAMP ILLUMINATION. *TT
Bulletin Number: 1800503C
TRANSMISSION SHIFT / SPEED CONTROL IMPROVEMENTS / POSSIBLE MALFUNCTION INDICATOR LAMP ILLUMINATION. *TT
Bulletin Number: 1802703
NO THROTTLE RESPONSE, LACK OF POWER WHILE TOWING AND DIAGNOSTIC TROUBLE CODES (DTC) P2638/P0700. *TT
Bulletin Number: 1803502
ENGINE THROTTLE CONTROL LIGHT ILLUMINATION AND / OR MALFUNCTION INDICATOR LIGHT ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE P2181 - COOLING SYSTEM PERFORMANCE. *TT
Bulletin Number: 1900805
REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC
Bulletin Number: 2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
Bulletin Number: 33
CUSTOMER SATISFACTION NOTIFICATION - TORQUE CONVERTER DRAIN BACK VALVE. *TT
Bulletin Number: 9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement
Bulletin Number: C17
THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH ERRORS IN THE AUTOMATIC TRANSMISSION DIAGNOSTIC INFORMATION. AS A RESULT, THE PCM WILL NOT DETECT A TRANSMISSION GOVERNOR PRESSURE SENSOR PROBLEM, OR ILLUMINATE THE MALFUNCTION INDICA
2003 DODGE RAM QUAD CAB
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
2003 DODGE RAM VAN
Bulletin Number: 01
CUSTOMER SATISFACTION NOTIFICATION - 3/8" TORQUE CONVERTER DRAIN BACK VALVE. *TT
Bulletin Number: 02026
THE TRANSMISSION MAY OVERHEAT DUE TO A RESTRICTION IN THE TORQUE CONVERTER DRAIN BACK VALVE. *TT
Bulletin Number: 02026A
THE TRANSMISSION MAY OVERHEAT DUE TO A RESTRICTION IN THE TORQUE CONVERTER DRAIN BACK VALVE AND MAY CAUSE DAMAGE TO THE TRANSMISSION. *TT
Bulletin Number: 0703
PROCEDURES FOR SERVICING THE SEAT BELT LATCH PLATE CINCH BAR. *TT
Bulletin Number: 0801003
SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS. *TT
Bulletin Number: 0802303
INTERMITTENT LOCKING/UNLOCKING OF DOORS WITHOUT ACTIVATING THE POWER DOOR LOCK SWITCH. *TT
Bulletin Number: 10023
STEERING COLUMN SERVICE. INFORMATION. SERVICE INFORMATION TUNEUPS. *TT
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 2100202
SUBJECT REGARDING REVISION IN DIAGNOSTIC PROCEDURES AND LABOR OPERATION TIMES FOR RE TRANSMISSIONS. *TT
Bulletin Number: 2200102
CHROME WHEEL CARE. *SLC
Bulletin Number: 2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
2003 DODGE RAM WAGON
Bulletin Number: 02026
THE TRANSMISSION MAY OVERHEAT DUE TO A RESTRICTION IN THE TORQUE CONVERTER DRAIN BACK VALVE. *TT
Bulletin Number: 02026A
THE TRANSMISSION MAY OVERHEAT DUE TO A RESTRICTION IN THE TORQUE CONVERTER DRAIN BACK VALVE AND MAY CAUSE DAMAGE TO THE TRANSMISSION. *TT
Bulletin Number: 0801003
SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS. *TT
Bulletin Number: 0802303
INTERMITTENT LOCKING/UNLOCKING OF DOORS WITHOUT ACTIVATING THE POWER DOOR LOCK SWITCH. *TT
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 2200102
CHROME WHEEL CARE. *SLC
Bulletin Number: 2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: 9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement
Bulletin Number: 9002872
56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2 required to attach Neutral Start Switch
2003 DODGE SPRINTER
Bulletin Number: 0300204
RINGING SOUND COMING FROM PROPELLER SHAFT WHEN TRANSMISSION IS SHIFTED FROM DRIVE TO REVERSE OR REVERSE TO DRIVE. *TT
Bulletin Number: 0711
REAR AXLE REPAIR VS. REPLACE PROCEDURE CHANGE. *KB
Bulletin Number: 0900306
CRANKSHAFT REPLACEMENT POLICY CHANGE AND MAIN BEARING PART NUMBER INFORMATION. *TT
Bulletin Number: 0900606
NEW CRANKSHAFT AND CENTER BOLT DESIGN. *TT
Bulletin Number: 1400104
COMMON RAIL FUEL INJECTION DIAGNOSIS. *TT
Bulletin Number: 1400105
COMMON RAIL FUEL INJECTION DIAGNOSIS. 2001-2002 DODGE SPRINTER. *SC
Bulletin Number: 2100705
AUTOMATIC TRANSMISSION SHIFTING CONCERNS. 2001-2005 DODGE SPRINTER. *SC
Bulletin Number: 2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: D56
THE MAINTENANCE LOGBOOK DOES NOT CONTAIN THE RECOMMENDED DOT 4 BRAKE FLUID CHANGE INTERVAL FOR COMMERCIAL VEHICLE APPLICATIONS. CUSTOMER SATISFICATION NOTIFICATION D56. MAINTENANCE LOGBOOK ADDENDUM / BRAKE FLUID. *TT
2003 DODGE STRATUS
Bulletin Number: 02020
INCORRECT FASTENERS AT THE REAR ATTACHMENT FOR THE FRONT STABILIZER BAR BUSHING CLAMP. *TT
Bulletin Number: 02020
DELAYED TRANSAXLE ENGAGEMENT AFTER INITIAL START UP. *TT
Bulletin Number: 02025
MALFUNCTION INDICATOR LAMP ILLUMINATION / TRANSMISSION LIMP-IN CONDITION. *TT
Bulletin Number: 022603
DO NOT REPLACE THE AIR BAG COVER IF THE OWNER COMPLAINT IS THAT THE VEHICLE HORN ACTUATES BY ITSELF. REFER TO TSB 08-024-02 TO REPROGRAM THE BCM. *TT
Bulletin Number: 03008
CRANKSHAFT OIL PASSAGE MIS-MACHINED. *TT
Bulletin Number: 0500602
REAR DRUM BRAKE CLUNK SOUND. *TT
Bulletin Number: 06
ENGINE VACUUM HOSE ROUTING LABEL REPLACEMENT. *TT
Bulletin Number: 08
COMPUTER DRIVER CHIP THAT COULD FAIL. REPLACE POWERTRAIN CONTROL MODULE. *TT
Bulletin Number: 0800303A
SENTRY KEY - KEY IMMOBILIZER SECURITY SYSTEM. *TT THIS BULLETIN REPLACES 08-003-03 REV A. *TT
Bulletin Number: 0801003
SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS. *TT
Bulletin Number: 0801202
INFORMATION ON DIAGNOSING RATTLE / SQUEAK FROM THE CENTER OFTHE LOWER INSTRUMENT PANEL. *TT
Bulletin Number: 0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
Bulletin Number: 0802402
HORN SELF ACTIVATION CONDITION. *TT
Bulletin Number: 0802804
INTERMITTENT LOSS OF ACCESSORIES (IG1 CIRCUIT) ON INITIAL VEHICLE START. *TT
Bulletin Number: 0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
Bulletin Number: 080403
CONTROL SOLENOIDS FAILURE IN VACUUM HARNESS TURBOCHARGED ENGINES DUE TO OPEN CIRCUIT. 2001 - 2003 CIRRUS ALSO INCLUDED. *TT
Bulletin Number: 0900704
IRREGULAR ENGINE SNAPPING SOUND. *TT
Bulletin Number: 0901104
INCORRECT OIL FILTER USAGE. ALSO INCLUDES 2005 SEBRING AND STRATUS. *TT
Bulletin Number: 1400402
ERRATIC FUEL GAUGE READING ABOVE 1/4. *TT
Bulletin Number: 1801405
FLASH: MIL ILLUMINATION DIAGNOSTIC TROUBLE CODES (DTC/DIAGNOSTIC TROUBLE CODE) P0300, P0301, P0302, P0302, P0303, P0304, P0305, P0306-COLD START MISFIRE. *SC
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 1802802
MIL ILLUMINATION - MISFIRE DIAGNOSTIC TROUBLE CODE (DTCS) P0300, P0301, P0302, P0303, P0304. *TT
Bulletin Number: 1803302
A MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE WITH ERRONEOUS DIAGNOSTIC TROUBLE CODES (DTC) P0016, P0335, P0339, P0340, P0462, P0498, P0499, P0622, P1604, P1681, P1686. *TT
Bulletin Number: 1900304
STEERING COLUMN CLICK SOUND. *TT
Bulletin Number: 1900702
LOWER STEERING COLUMN CLICK SOUND. *TT
Bulletin Number: 1900805
REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC
Bulletin Number: 2100305
TRANSFER GEAR WHINE SOUND BETWEEN 68 MPH AND 84 MPH EITHER ACCELERATING OR DECELERATING. *EH
Bulletin Number: 2100503
DELAYED OR TEMPORARY LOSS OF TRANSMISSION ENGAGEMENT AFTER INITIAL START UP ON VARIOUS MODELS INCLUDING THE 2004 PACIFICA, SEBRING CONVERTIBLE, SEBRING SEDAN, INTREPID AND 2003 SX2.0. *TT *MJ
Bulletin Number: 2100503A
DELAYED OR TEMPORARY LOSS OF TRANSMISSION ENGAGEMENT AFTER INITIAL START UP ON VARIOUS MODELS INCLUDING THE 2004 PACIFICA, SEBRING CONVERTIBLE, SEBRING SEDAN, INTREPID AND 2003 SX2.0. *TT
Bulletin Number: 2100603
TRANSMISSION HARSH 4-3 DOWNSHIFT ON VARIOUS MODELS INCLUDING THE 2004 PACIFICA, SEBRING, INTREPID AND 2003 SX2.0. *TT
Bulletin Number: 2100603A
TRANSMISSION HARSH 4-3 DOWNSHIFT. *TT
Bulletin Number: 2100903
AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE. VARIOUS MODELS INCLUDING THE 2004 RAM TRUCK, DURANGO, SEBRING CONVERTIBLE, CHEROKEE, VISION, NEON, AND VOYAGER. *TT *SC
Bulletin Number: 2200102
CHROME WHEEL CARE. *SLC
Bulletin Number: 2300303
DRIVER'S WINDOW AUTO-DOWN FUNCTION IS INTERMITTENT. INCLUDING MY2004. *TT
Bulletin Number: 2301203
POP/CLUNK SOUND FROM FRONT OF VEHICLE. *TT THIS BULLETIN SUPERSEDES BULLETIN 23-012-03 DATED 05/23/2004. *TT
Bulletin Number: 2301403
WHEN CYCLING DOOR GLASS UP AND DOWN, A CLICKING NOISE CAN BE HEARD WHEN THE WINDOW TRAVEL CHANGES DIRECTION ON VARIOUS MODELS INCLUDING THE 2004 SEBRING SEDAN AND SEBRING CONVERTIBLE. *TT
Bulletin Number: 2303204
POWER SEAT WILL NOT ADJUST. *TT
Bulletin Number: 2400103
WINDOWS MAY BEGIN TO FOG WHEN THE HVAC IS IN FLOOR MODE. *TT
Bulletin Number: 2400105
BLOWER MOTOR DOES NOT RUN ON EVERY SPEED. *TT
Bulletin Number: 2400204
AIR CONDITIONER AND HEATER PERFORMANCE. *TT
Bulletin Number: 2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
2003 DODGE STRATUS COUPE
Bulletin Number: 0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
Bulletin Number: 0801702A
ACCESSORY SOCKET REPLACEMENT FOR SMOKERS PACKAGE. *TT
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 2100302
THIS BULLETIN PROVIDES INFORMATION ABOUT ATF+4 USAGE. *TT
Bulletin Number: 2200102
CHROME WHEEL CARE. *SLC
Bulletin Number: 2302003
DOOR GLASS RUB/SCREECH/SQUEAK SOUND. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
2003 DODGE VIPER
Bulletin Number: 010103
FLICKERING HEADLAMPS. BCM BODY CONTROL MODULE. GPOP - ISSUE REVIEW SYSTEM. 2004 VIPER INCLUDED. *TT
Bulletin Number: 010103
TRANSMISSION AND CLUTCH KIT. GPOP - ISSUE REVIEW SYSTEM. *TT
Bulletin Number: 03001
INTERMITTENT OPERATION OF THE REMOTE KEYLESS ENTRY (RKE). TT
Bulletin Number: 03006
INTAKE VALVE MACHINING - SUPPLEMENT A. *TT
Bulletin Number: 10023
POWERTRAIN DIAGNOSTIC INFORMATION. SERVICE INFORMATION TUNEUPS. *TT
Bulletin Number: 1100203
EXHAUST RATTLE SOUND WHILE DRIVING. *TT
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 1802403
MALFUNCTION INDICATOR LAMP ILLUMINATION AND/OR POOR IDLE QUALITY FOLLOWING A COLD START. *TT
Bulletin Number: 1803503
HESITATION OR REDUCED POWER AFTER COMPLETING AN UPSHIFT DURING MODERATE ACCELERATION AND/OR AFTER A PROLONGED CLOSED THROTTLE EVENT. *TT
Bulletin Number: 2301705
CONVERTIBLE TOP TONNEAU COVER DAMAGE. *SC
Bulletin Number: 23-030-13
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
Bulletin Number: 31-001-16
Do Not Apply Corrosion Protection On Sheet Molding Compound (SMC) Plastic Panels This bulletin involves discussing SMC plastic panels and applying corrosion protection.
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: C31
CUSTOMER SATISFACTION NOTIFICATION NO. C31 - COOLING FAN MODULE. A CHECK BALL RETAINER IN THE COOLING FAN MODULE MAY BECOME DISLODGED. *TT
Bulletin Number: N1302072013
Advanced Field Action Communication ? N1302072013 Chrysler Group LLC (Chrysler) announced a safety recall on 2003 and 2004 model year (ZB) Dodge Viper vehicles. The above vehicles may experience a front airbag and/or seatbelt pretensioner
2003 DODGE VIPER ROADSTER
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc

 

Recalls for 2003 Dodge

2003 DODGE CARAVAN
NHTSA Campaign ID:STRUCTURE
Manufacturer:SOUTHERN COMFORT CONVERSIONS
Manufacture Dates:08/01/2000 - 03/03/2003
Potential Units Affected:3674

Defect Description:

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.

Consequence:

THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.

Action:

DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
2003 DODGE CARAVAN
NHTSA Campaign ID:LATCHES/LOCKS/LINKAGES:HATCHBACK/LIFTGATE:LOCK
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:08/02/2002 - 12/18/2002
Potential Units Affected:70235

Defect Description:

ON CERTAIN MINIVANS, THE POWER LIFTGATE (PLG) LATCH MAY NOT ENGAGE THE STRIKER ALLOWING THE LIFTGATE TO OPEN WHILE DRIVING.

Consequence:

IN THE EVENT OF A CRASH, AN UNBELTED PASSENGER COULD BE EJECTED FROM THE VEHICLE.

Action:

DEALERS WILL REPLACE THE POWER LIFTGATE CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN APRIL 26, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2003 DODGE CARAVAN
NHTSA Campaign ID:STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:10/01/2001 - 08/01/2003
Potential Units Affected:681000

Defect Description:

ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.

Consequence:

POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.

Action:

DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2003 DODGE DAKOTA
NHTSA Campaign ID:ELECTRICAL SYSTEM:WIRING
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:07/01/2000 - 07/31/2003
Potential Units Affected:50082

Defect Description:

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, THE HEADLAMP AND DASH WIRING HARNESS MAY BE CHAFED BY THE ACTUATION OF THE CLUTCH PEDAL. THIS COULD RESULT IN ABNORMAL OPERATION OF THE WIPERS, TURN SIGNALS, HORN OR LIGHTING SYSTEMS.

Consequence:

THIS COULD AFFECT DRIVER VISIBILITY, COULD PREVENT A DRIVER FROM SOUNDING A WARNING BY USING THE HORN, AND, WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL REROUTE THE WIRE HARNESS AND REPAIR THE HARNESS IF NECESSARY. OWNER NOTIFICATION BEGAN NOVEMBER 3, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
2003 DODGE DAKOTA
NHTSA Campaign ID:VISIBILITY:WINDSHIELD WIPER/WASHER
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:04/24/2002 - 09/15/2003
Potential Units Affected:320188

Defect Description:

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.

Consequence:

DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.

Action:

DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2003 DODGE DAKOTA
NHTSA Campaign ID:EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:10/31/2002 - 11/08/2002
Potential Units Affected:3640

Defect Description:

ON CERTAIN PICKUP TRUCKS, THE CENTRAL TIMER MODULE (CTM) HAS AN IMPROPERLY SIZED CIRCUIT BOARD TRACE THAT COULD POTENTIALLY CAUSE THE RIGHT HEADLAMP LOW BEAM TO BECOME INOPERATIVE.

Consequence:

IF THE LIGHTS FAIL, A VISIBILITY PROBLEM COULD OCCUR, INCREASING THE RISK OF A VEHICLE CRASH.

Action:

DEALERS WILL REPLACE THE CTM. OWNER NOTIFICATION BEGAN DECEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2003 DODGE DAKOTA
NHTSA Campaign ID:SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:01/07/1999 - 12/31/2002
Potential Units Affected:592707

Defect Description:

ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.

Consequence:

EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.

Action:

DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2003 DODGE DURANGO
NHTSA Campaign ID:EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:10/31/2002 - 11/08/2002
Potential Units Affected:3640

Defect Description:

ON CERTAIN PICKUP TRUCKS, THE CENTRAL TIMER MODULE (CTM) HAS AN IMPROPERLY SIZED CIRCUIT BOARD TRACE THAT COULD POTENTIALLY CAUSE THE RIGHT HEADLAMP LOW BEAM TO BECOME INOPERATIVE.

Consequence:

IF THE LIGHTS FAIL, A VISIBILITY PROBLEM COULD OCCUR, INCREASING THE RISK OF A VEHICLE CRASH.

Action:

DEALERS WILL REPLACE THE CTM. OWNER NOTIFICATION BEGAN DECEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2003 DODGE DURANGO
NHTSA Campaign ID:SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:01/07/1999 - 12/31/2002
Potential Units Affected:592707

Defect Description:

ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.

Consequence:

EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.

Action:

DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2003 DODGE DURANGO
NHTSA Campaign ID:VISIBILITY:WINDSHIELD WIPER/WASHER
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:04/24/2002 - 08/21/2003
Potential Units Affected:320188

Defect Description:

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.

Consequence:

DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.

Action:

DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2003 DODGE DURANGO
NHTSA Campaign ID:ELECTRICAL SYSTEM
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:06/01/2000 - 07/01/2003
Potential Units Affected:35103

Defect Description:

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH FRONT BENCH SEATS ONLY, IF FLUID IS SPILLED FROM THE FLOOR MOUNTED CUP HOLDER, AN UNUSED CONSOLE POWER OUTLET CONNECTOR LOCATED UNDER THE SEAT MAY BECOME CONTAMINATED.

Consequence:

THIS MAY ALLOW DEVELOPMENT OF A HIGH RESISTIVE SHORT CIRCUIT IN THE CONNECTOR, WHICH COULD EVENTUALLY LEAD TO A FIRE.

Action:

DEALERS WILL INSPECT THE CONSOLE WIRING CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT ADDITIONAL FLUID FROM CONTAMINATING THE CONNECTOR FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 30, 2006. OWNERS MAY CONTACT DAIMLER CHRYSLER AT 1-800-853-1403.
2003 DODGE GRAND CARAVAN
NHTSA Campaign ID:STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:10/01/2001 - 08/01/2003
Potential Units Affected:681000

Defect Description:

ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.

Consequence:

POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.

Action:

DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2003 DODGE GRAND CARAVAN
NHTSA Campaign ID:STRUCTURE
Manufacturer:SOUTHERN COMFORT CONVERSIONS
Manufacture Dates:08/01/2000 - 03/03/2003
Potential Units Affected:3674

Defect Description:

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.

Consequence:

THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.

Action:

DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
2003 DODGE RAM
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:08/05/2002 - 12/24/2002
Potential Units Affected:19500

Defect Description:

CERTAIN PICKUP TRUCKS, EQUIPPED WITH CUMMINS DIESEL ENGINES AND MANUAL TRANSMISSIONS, MAY EXPERIENCE AN ELEVATED IDLE SPEED AFTER EXTENDED CRUISE CONTROL USE.

Consequence:

THIS CAN RESULT IN UNINTENDED ACCELERATION AND A REDUCTION IN BRAKING EFFECTIVENESS, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL REPROGRAM THE SOFTWARE IN THE CUMMINS ENGINE CONTROLLER. OWNER NOTIFICATION BEGAN ON MARCH 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2003 DODGE RAM
NHTSA Campaign ID:SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:07/01/1997 - 06/30/2003
Potential Units Affected:44588

Defect Description:

ON CERTAIN VAN AND WAGON VEHICLES EQUIPPED WITH 4-WHEEL ANTILOCK BRAKE SYSTEMS (ABS), AFTERMARKET BATTERIES MAY LEAK ELECTROLYTE ONTO THE ABS CONTROL MODULE CONNECTOR, WHICH CAN COMPROMISE SEALING INTEGRITY OF THE CONNECTOR.

Consequence:

THIS MAY ALLOW DEVELOPMENT OF A SHORT CIRCUIT IN THE CONNECTOR, WHICH COULD EVENTUALLY LEAD TO A FIRE.

Action:

DEALERS WILL INSPECT THE ABS CONTROL MODULE CONNECTOR FOR ELECTROLYTE DAMAGE AND REPLACE THE CONNECTOR AS NECESSARY. THE RECALL WILL BEGIN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2003 DODGE RAM 1500
NHTSA Campaign ID:AIR BAGS:PASSENGER SIDE FRONTAL
Manufacturer:Chrysler (FCA US LLC)
Manufacture Dates:08/29/2002 - 07/25/2003
Potential Units Affected:385686

Defect Description:

Chrysler (FCA US LLC) is recalling certain model year 2003 Dodge Ram 1500, 2500, and 3500 trucks manufactured August 29, 2002, to July 25, 2003 to address a safety defect in the passenger side frontal air bag inflator which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag. This recall addresses both the passenger side frontal air bags that were originally installed in the vehicles, as well as replacement air bags that may have been installed as replacement service parts. A replacement air bag may have been installed, as one example, if a vehicle had been in a crash necessitating the replacement of the passenger side frontal air bag.

Consequence:

In the event of a crash necessitating deployment of the passenger┐s frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Action:

Chrysler will notify owners, and dealers will replace the passenger frontal air bag, free of charge. The recall began on March 16, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R26. Note: This recall partially supersedes recall 14V770.
2003 DODGE RAM 2500
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:08/05/2002 - 12/24/2002
Potential Units Affected:19500

Defect Description:

CERTAIN PICKUP TRUCKS, EQUIPPED WITH CUMMINS DIESEL ENGINES AND MANUAL TRANSMISSIONS, MAY EXPERIENCE AN ELEVATED IDLE SPEED AFTER EXTENDED CRUISE CONTROL USE.

Consequence:

THIS CAN RESULT IN UNINTENDED ACCELERATION AND A REDUCTION IN BRAKING EFFECTIVENESS, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL REPROGRAM THE SOFTWARE IN THE CUMMINS ENGINE CONTROLLER. OWNER NOTIFICATION BEGAN ON MARCH 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2003 DODGE RAM 2500
NHTSA Campaign ID:AIR BAGS:PASSENGER SIDE FRONTAL
Manufacturer:Chrysler (FCA US LLC)
Manufacture Dates:08/29/2002 - 07/25/2003
Potential Units Affected:385686

Defect Description:

Chrysler (FCA US LLC) is recalling certain model year 2003 Dodge Ram 1500, 2500, and 3500 trucks manufactured August 29, 2002, to July 25, 2003 to address a safety defect in the passenger side frontal air bag inflator which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag. This recall addresses both the passenger side frontal air bags that were originally installed in the vehicles, as well as replacement air bags that may have been installed as replacement service parts. A replacement air bag may have been installed, as one example, if a vehicle had been in a crash necessitating the replacement of the passenger side frontal air bag.

Consequence:

In the event of a crash necessitating deployment of the passenger┐s frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Action:

Chrysler will notify owners, and dealers will replace the passenger frontal air bag, free of charge. The recall began on March 16, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R26. Note: This recall partially supersedes recall 14V770.
2003 DODGE RAM 2500
NHTSA Campaign ID:STEERING:LINKAGES:TIE ROD ASSEMBLY
Manufacturer:CHRYSLER GROUP LLC
Manufacture Dates: -
Potential Units Affected:242780

Defect Description:

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008-2011 DODGE RAM 2500/3500 4X4, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH MARCH 28, 2011; MODEL YEAR 2008-2011 DODGE RAM 3500 CAB CHASSIS 4X2, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH MARCH 28, 2011; AND MODEL YEAR 2008 DODGE RAM 1500 MEGA CAB 4X4, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH AUGUST 15, 2008, BECAUSE THE LEFT TIE ROD BALL STUD MAY FRACTURE. THIS CONDITION TENDS TO OCCUR DURING LOW SPEED PARKING LOT TYPE MANEUVERS WHEN THE CUSTOMER IS MAKING A TIGHT TURN. ADDITIONALLY, MODEL YEAR 2003-2008 DODGE RAM 2500/3500 VEHICLES MAY HAVE RECEIVED THE AFFECTED TIE ROD ASSEMBLY AS A REPLACEMENT PART DURING NORMAL SERVICE.

Consequence:

THIS CONDITION COULD RESULT IN THE POTENTIAL LOSS OF DIRECTIONAL STABILITY IN THE LEFT HAND FRONT WHEEL, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL INSPECT THE TIE ROD ENDS FOR RELATIVE ORIENTATION AND REPLACE THE LEFT OUTER TIE ROD AS REQUIRED AND PERFORM A FRONT END TOE ALIGNMENT AS NEEDED. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 3, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
2003 DODGE RAM 2500
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:06/01/2002 - 07/31/2005
Potential Units Affected:250433

Defect Description:

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH DIESEL ENGINES AND AUTOMATIC TRANSMISSIONS, IN AN ATTEMPT TO EXIT THE VEHICLE QUICKLY WITHOUT SHUTTING OFF THE ENGINE AND REMOVING THE KEY, THE DRIVER MAY INADVERTENTLY LEAVE THE AUTOMATIC TRANSMISSION SHIFT CONTROL IN INDICATED REVERSE.

Consequence:

THIS ERROR IS AN UNINTENDED ACTION THAT MAY RESULT IN A LACK OF TRANSMISSION PARK PAWL ENGAGEMENT AND POSSIBLY DELAYED REARWARD MOVEMENT OF THE VEHICLE.

Action:

DEALERS WILL PERFORM A SOFTWARE MODIFICATION TO EQUIP THESE VEHICLES WITH AN OUT-OF-PARK ALARM. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2003 DODGE RAM 2500
NHTSA Campaign ID:WHEELS:CENTER SECTION
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:03/24/2003 - 04/07/2003
Potential Units Affected:1086

Defect Description:

CERTAIN HEAVY DUTY PICKUP TRUCKS, THE ALUMINUM WHEELS MAY HAVE EXCESSIVE POROSITY IN THE CENTER HUB AREA WHICH CAN CAUSE A WHEEL TO CRACK.

Consequence:

THIS COULD CAUSE A LOSS OF VEHICLE CONTROL AND RESULT IN A CRASH WITHOUT WARNING.

Action:

DEALERS WILL INSPECT THE WHEELS AND REPLACE THEM IF NECESSARY. OWNER NOTIFICATION IS EXPECTED TO BEGIN JUNE 17, 2003.. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
2003 DODGE RAM 2500
NHTSA Campaign ID:STEERING:LINKAGES:TIE ROD ASSEMBLY
Manufacturer:Chrysler Group LLC
Manufacture Dates:02/12/2002 - 02/13/2008
Potential Units Affected:706664

Defect Description:

Chrysler Group LLC (Chrysler) is recalling certain model year 2003-2008 Dodge RAM 2500 4x4 and 3500 4x4, model year 2007-2008 Dodge RAM 3500 4x2 Cab Chassis and model year 2006-2008 Dodge RAM 1500 Mega Cab 4x4 trucks manufactured February 12, 2002, through February 13, 2008. The left tie rod assembly may break.

Consequence:

A failure of the tie rod assembly may result in a loss of steering control, increasing the risk of a crash.

Action:

Chrysler notified owners and launched its recall campaign in January 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N62.
2003 DODGE RAM 3500
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:08/05/2002 - 12/24/2002
Potential Units Affected:19500

Defect Description:

CERTAIN PICKUP TRUCKS, EQUIPPED WITH CUMMINS DIESEL ENGINES AND MANUAL TRANSMISSIONS, MAY EXPERIENCE AN ELEVATED IDLE SPEED AFTER EXTENDED CRUISE CONTROL USE.

Consequence:

THIS CAN RESULT IN UNINTENDED ACCELERATION AND A REDUCTION IN BRAKING EFFECTIVENESS, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL REPROGRAM THE SOFTWARE IN THE CUMMINS ENGINE CONTROLLER. OWNER NOTIFICATION BEGAN ON MARCH 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2003 DODGE RAM 3500
NHTSA Campaign ID:STEERING:LINKAGES:TIE ROD ASSEMBLY
Manufacturer:Chrysler Group LLC
Manufacture Dates:02/12/2002 - 02/13/2008
Potential Units Affected:706664

Defect Description:

Chrysler Group LLC (Chrysler) is recalling certain model year 2003-2008 Dodge RAM 2500 4x4 and 3500 4x4, model year 2007-2008 Dodge RAM 3500 4x2 Cab Chassis and model year 2006-2008 Dodge RAM 1500 Mega Cab 4x4 trucks manufactured February 12, 2002, through February 13, 2008. The left tie rod assembly may break.

Consequence:

A failure of the tie rod assembly may result in a loss of steering control, increasing the risk of a crash.

Action:

Chrysler notified owners and launched its recall campaign in January 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N62.
2003 DODGE RAM 3500
NHTSA Campaign ID:STEERING:LINKAGES:TIE ROD ASSEMBLY
Manufacturer:CHRYSLER GROUP LLC
Manufacture Dates: -
Potential Units Affected:242780

Defect Description:

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008-2011 DODGE RAM 2500/3500 4X4, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH MARCH 28, 2011; MODEL YEAR 2008-2011 DODGE RAM 3500 CAB CHASSIS 4X2, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH MARCH 28, 2011; AND MODEL YEAR 2008 DODGE RAM 1500 MEGA CAB 4X4, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH AUGUST 15, 2008, BECAUSE THE LEFT TIE ROD BALL STUD MAY FRACTURE. THIS CONDITION TENDS TO OCCUR DURING LOW SPEED PARKING LOT TYPE MANEUVERS WHEN THE CUSTOMER IS MAKING A TIGHT TURN. ADDITIONALLY, MODEL YEAR 2003-2008 DODGE RAM 2500/3500 VEHICLES MAY HAVE RECEIVED THE AFFECTED TIE ROD ASSEMBLY AS A REPLACEMENT PART DURING NORMAL SERVICE.

Consequence:

THIS CONDITION COULD RESULT IN THE POTENTIAL LOSS OF DIRECTIONAL STABILITY IN THE LEFT HAND FRONT WHEEL, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL INSPECT THE TIE ROD ENDS FOR RELATIVE ORIENTATION AND REPLACE THE LEFT OUTER TIE ROD AS REQUIRED AND PERFORM A FRONT END TOE ALIGNMENT AS NEEDED. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 3, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
2003 DODGE RAM 3500
NHTSA Campaign ID:WHEELS:CENTER SECTION
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:03/24/2003 - 04/07/2003
Potential Units Affected:1086

Defect Description:

CERTAIN HEAVY DUTY PICKUP TRUCKS, THE ALUMINUM WHEELS MAY HAVE EXCESSIVE POROSITY IN THE CENTER HUB AREA WHICH CAN CAUSE A WHEEL TO CRACK.

Consequence:

THIS COULD CAUSE A LOSS OF VEHICLE CONTROL AND RESULT IN A CRASH WITHOUT WARNING.

Action:

DEALERS WILL INSPECT THE WHEELS AND REPLACE THEM IF NECESSARY. OWNER NOTIFICATION IS EXPECTED TO BEGIN JUNE 17, 2003.. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
2003 DODGE RAM 3500
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:06/01/2002 - 07/31/2005
Potential Units Affected:250433

Defect Description:

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH DIESEL ENGINES AND AUTOMATIC TRANSMISSIONS, IN AN ATTEMPT TO EXIT THE VEHICLE QUICKLY WITHOUT SHUTTING OFF THE ENGINE AND REMOVING THE KEY, THE DRIVER MAY INADVERTENTLY LEAVE THE AUTOMATIC TRANSMISSION SHIFT CONTROL IN INDICATED REVERSE.

Consequence:

THIS ERROR IS AN UNINTENDED ACTION THAT MAY RESULT IN A LACK OF TRANSMISSION PARK PAWL ENGAGEMENT AND POSSIBLY DELAYED REARWARD MOVEMENT OF THE VEHICLE.

Action:

DEALERS WILL PERFORM A SOFTWARE MODIFICATION TO EQUIP THESE VEHICLES WITH AN OUT-OF-PARK ALARM. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2003 DODGE RAM 3500
NHTSA Campaign ID:AIR BAGS:PASSENGER SIDE FRONTAL
Manufacturer:Chrysler (FCA US LLC)
Manufacture Dates:08/29/2002 - 07/25/2003
Potential Units Affected:385686

Defect Description:

Chrysler (FCA US LLC) is recalling certain model year 2003 Dodge Ram 1500, 2500, and 3500 trucks manufactured August 29, 2002, to July 25, 2003 to address a safety defect in the passenger side frontal air bag inflator which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag. This recall addresses both the passenger side frontal air bags that were originally installed in the vehicles, as well as replacement air bags that may have been installed as replacement service parts. A replacement air bag may have been installed, as one example, if a vehicle had been in a crash necessitating the replacement of the passenger side frontal air bag.

Consequence:

In the event of a crash necessitating deployment of the passenger┐s frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Action:

Chrysler will notify owners, and dealers will replace the passenger frontal air bag, free of charge. The recall began on March 16, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R26. Note: This recall partially supersedes recall 14V770.
2003 DODGE SPRINTER 2500
NHTSA Campaign ID:SERVICE BRAKES, HYDRAULIC
Manufacturer:Daimler Vans USA, LLC
Manufacture Dates:06/30/2003 - 08/31/2006
Potential Units Affected:17501

Defect Description:

Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2003-2006 Dodge and Freightliner Sprinter 2500 and 3500 vans manufactured June 30, 2003, to August 31, 2006. The instrument cluster on the affected vehicles fails to illuminate the BRAKE warning lamp in the instrument cluster during the vehicle start up bulb-function check. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 105, "Hydraulic and Electric Brake Systems."

Consequence:

Without the BRAKE lamp illuminating during the vehicle start up bulb-function check, the driver has no confirmation that the lamp is working and therefore may not know whether or not the lamp will illuminate if the brake fluid level is low. If the operator is unaware that the vehicle has low brake fluid, there would be an increased risk of a crash.

Action:

DVUSA will notify owners, and DVUSA and Dodge dealers will correct the instrument cluster software, as necessary, free of charge. An interim notification was sent to owners on January 6, 2017. A second notice will be mailed to owners once the remedy becomes available. The recall began on July 27, 2017. Owners may contact DVUSA customer service at 1-770-705-2070.
2003 DODGE SPRINTER 2500
NHTSA Campaign ID:STEERING:COLUMN
Manufacturer:SPRINTER ENGINEERING & COMPLIANCE SUPPOR
Manufacture Dates:11/01/2007 - 11/30/2007
Potential Units Affected:10

Defect Description:

SPRINTER IS RECALLING 10 MY 2001-2006 DODGE AND FREIGHTLINER 2500 AND 3500 VEHICLES. THE WELDING SEAM BETWEEN THE BRACKET AND STEERING COLUMN OF AFFECTED SPARE PARTS DOES NOT MEET DESIGN SPECIFICATIONS. THE RESULT OF AN OUT OF SPECIFICATION WELDING SEAM IS THAT THE STEERING COLUMN MAY DETACH FROM ITS INTERIOR VEHICLE MOUNTING BRACKET.

Consequence:

THE OPERATOR MAY LOSE STEERING ABILITY OF THE VEHICLE INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL INSPECT AND REPLACE THE STEERING COLUMNS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 16, 2009. OWNERS MAY CONTACT SPRINTER AT 843-695-5057.
2003 DODGE SPRINTER 2500
NHTSA Campaign ID:ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Manufacturer:SPRINTER ENGINEERING & COMPLIANCE SUPPOR
Manufacture Dates:10/01/2001 - 09/30/2003
Potential Units Affected:14423

Defect Description:

SPRINTER IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2003 VANS SOLD AS DODGE AND FREIGHTLINER VEHICLES. THE INTAKE MANIFOLDS MAY HAVE CORRODED. A CHEMICAL REACTION INVOLVING SULFUR IN THE DIESEL FUEL THAT TAKES PLACE UNDER CERTAIN CONDITIONS CAN LEAD TO THE FORMATION OF SULFURIC ACID IN THE EXHAUST CHANNEL OF THE INTAKE MANIFOLD.

Consequence:

INTAKE MANIFOLD CORROSION MAY LEAD TO AN EXHAUST GAS LEAK, DAMAGE TO THE FUEL RETURN LINE WHICH COULD CAUSE A FUEL LEAK, AND HEAT DAMAGE TO THE INSULATION AT THE FRONT WALL.

Action:

DEALERS WILL INSPECT AND REPLACE THE INTAKE MANIFOLD FREE OF CHARGE. CHRYSLER, LLC IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. THE RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403 OR SPRINTER AT 843-695-5031.
2003 DODGE SPRINTER 2500
NHTSA Campaign ID:ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Manufacturer:SPRINTER ENGINEERING & COMPLIANCE SUPPOR
Manufacture Dates:10/01/2001 - 09/30/2003
Potential Units Affected:665

Defect Description:

MERCEDES-BENZ USA (MBUSA) IS RECALLING CERTAIN MODEL YEAR 2002- 2003 SPRINTER 2500 AND 3500 VANS SOLD AS DODGE AND FREIGHTLINER VEHICLES. THE INTAKE MANIFOLDS MAY HAVE CORRODED. A CHEMICAL REACTION INVOLVING SULFUR IN THE DIESEL FUEL THAT TAKES PLACE UNDER CERTAIN CONDITIONS CAN LEAD TO THE FORMATION OF SULFURIC ACID IN THE EXHAUST CHANNEL OF THE INTAKE MANIFOLD.

Consequence:

INTAKE MANIFOLD CORROSION MAY LEAD TO AN EXHAUST GAS LEAK, DAMAGE TO THE FUEL RETURN LINE WHICH COULD CAUSE A FUEL LEAK, AND HEAT DAMAGE TO THE INSULATION AT THE FIRE WALL. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Action:

DEALERS WILL INSPECT AND REPLACE THE INTAKE MANIFOLD FREE OF CHARGE. CHRYSLER, LLC WILL NOTIFY OWNERS OF DODGE SPRINTERS AND MBUSA WILL NOTIFY OWNERS FREIGHTLINER SPRINTERS. THIS RECALL IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE RECALL CAMPAIGN 09V-418). THE SAFETY RECALL BEGAN ON OCTOBER 11, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403 OR SPRINTER AT 1-843-695-5031.
2003 DODGE SPRINTER 2500
NHTSA Campaign ID:INTERIOR LIGHTING
Manufacturer:DAIMLERCHRYSLER MANUFACTURING INTL
Manufacture Dates:01/30/2001 - 10/07/2006
Potential Units Affected:4433

Defect Description:

ON CERTAIN TRUCKS EQUIPPED WITH REAR AIR CONDITIONING SYSTEM, THE INTERIOR LAMP IS EQUIPPED WITH AN 18W LAMP AND A SCATTERING LENS. IN EXTREMELY HOT AND HUMID CONDITIONS, THE COMBINATION OF HEAT AND HUMIDITY, AND THE HEAT FROM THE LAMP DUE TO EXTREME LONG TERM OPERATION, CAN DISTORT THE SCATTERING LENS.

Consequence:

THE SWITCHING CONTACTS OF THE LAMP MAY CAUSE A SHORT CIRCUIT OF THE REAR LAMP INCREASING THE RISK OF A FIRE.

Action:

DEALERS WILL REPLACE THE REAR INTERIOR LAMPS FREE OF CHARGE WITH A MODIFIED VERSION WHICH IS NOT SUBJECT TO THE IMPACTS OF HEAT AND HUMIDITY. THE RECALL BEGAN ON DECEMBER 17, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER MANUFACTURING INTERNATIONAL AT 1-843-695-5041.
2003 DODGE SPRINTER 2500
NHTSA Campaign ID:ELECTRICAL SYSTEM: INSTRUMENT PANEL
Manufacturer:Daimler Vans USA, LLC
Manufacture Dates:06/30/2003 - 08/31/2006
Potential Units Affected:17501

Defect Description:

Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2003-2006 Dodge and Freightliner Sprinter 2500 and 3500 vans manufactured June 30, 2003, to August 31, 2006. The instrument cluster on the affected vehicles fails to illuminate the BRAKE warning lamp in the instrument cluster during the vehicle start up bulb-function check. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 105, "Hydraulic and Electric Brake Systems."

Consequence:

Without the BRAKE lamp illuminating during the vehicle start up bulb-function check, the driver has no confirmation that the lamp is working and therefore may not know whether or not the lamp will illuminate if the brake fluid level is low. If the operator is unaware that the vehicle has low brake fluid, there would be an increased risk of a crash.

Action:

DVUSA will notify owners, and DVUSA and Dodge dealers will correct the instrument cluster software, as necessary, free of charge. An interim notification was sent to owners on January 6, 2017. A second notice will be mailed to owners once the remedy becomes available. The recall began on July 27, 2017. Owners may contact DVUSA customer service at 1-770-705-2070.
2003 DODGE SPRINTER 3500
NHTSA Campaign ID:ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Manufacturer:SPRINTER ENGINEERING & COMPLIANCE SUPPOR
Manufacture Dates: -
Potential Units Affected:665

Defect Description:

MERCEDES-BENZ USA (MBUSA) IS RECALLING CERTAIN MODEL YEAR 2002- 2003 SPRINTER 2500 AND 3500 VANS SOLD AS DODGE AND FREIGHTLINER VEHICLES. THE INTAKE MANIFOLDS MAY HAVE CORRODED. A CHEMICAL REACTION INVOLVING SULFUR IN THE DIESEL FUEL THAT TAKES PLACE UNDER CERTAIN CONDITIONS CAN LEAD TO THE FORMATION OF SULFURIC ACID IN THE EXHAUST CHANNEL OF THE INTAKE MANIFOLD.

Consequence:

INTAKE MANIFOLD CORROSION MAY LEAD TO AN EXHAUST GAS LEAK, DAMAGE TO THE FUEL RETURN LINE WHICH COULD CAUSE A FUEL LEAK, AND HEAT DAMAGE TO THE INSULATION AT THE FIRE WALL. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Action:

DEALERS WILL INSPECT AND REPLACE THE INTAKE MANIFOLD FREE OF CHARGE. CHRYSLER, LLC WILL NOTIFY OWNERS OF DODGE SPRINTERS AND MBUSA WILL NOTIFY OWNERS FREIGHTLINER SPRINTERS. THIS RECALL IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE RECALL CAMPAIGN 09V-418). THE SAFETY RECALL BEGAN ON OCTOBER 11, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403 OR SPRINTER AT 1-843-695-5031.
2003 DODGE SPRINTER 3500
NHTSA Campaign ID:ELECTRICAL SYSTEM: INSTRUMENT PANEL
Manufacturer:Daimler Vans USA, LLC
Manufacture Dates:06/30/2003 - 08/31/2006
Potential Units Affected:17501

Defect Description:

Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2003-2006 Dodge and Freightliner Sprinter 2500 and 3500 vans manufactured June 30, 2003, to August 31, 2006. The instrument cluster on the affected vehicles fails to illuminate the BRAKE warning lamp in the instrument cluster during the vehicle start up bulb-function check. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 105, "Hydraulic and Electric Brake Systems."

Consequence:

Without the BRAKE lamp illuminating during the vehicle start up bulb-function check, the driver has no confirmation that the lamp is working and therefore may not know whether or not the lamp will illuminate if the brake fluid level is low. If the operator is unaware that the vehicle has low brake fluid, there would be an increased risk of a crash.

Action:

DVUSA will notify owners, and DVUSA and Dodge dealers will correct the instrument cluster software, as necessary, free of charge. An interim notification was sent to owners on January 6, 2017. A second notice will be mailed to owners once the remedy becomes available. The recall began on July 27, 2017. Owners may contact DVUSA customer service at 1-770-705-2070.
2003 DODGE SPRINTER 3500
NHTSA Campaign ID:SERVICE BRAKES, HYDRAULIC
Manufacturer:Daimler Vans USA, LLC
Manufacture Dates:06/30/2003 - 08/31/2006
Potential Units Affected:17501

Defect Description:

Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2003-2006 Dodge and Freightliner Sprinter 2500 and 3500 vans manufactured June 30, 2003, to August 31, 2006. The instrument cluster on the affected vehicles fails to illuminate the BRAKE warning lamp in the instrument cluster during the vehicle start up bulb-function check. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 105, "Hydraulic and Electric Brake Systems."

Consequence:

Without the BRAKE lamp illuminating during the vehicle start up bulb-function check, the driver has no confirmation that the lamp is working and therefore may not know whether or not the lamp will illuminate if the brake fluid level is low. If the operator is unaware that the vehicle has low brake fluid, there would be an increased risk of a crash.

Action:

DVUSA will notify owners, and DVUSA and Dodge dealers will correct the instrument cluster software, as necessary, free of charge. An interim notification was sent to owners on January 6, 2017. A second notice will be mailed to owners once the remedy becomes available. The recall began on July 27, 2017. Owners may contact DVUSA customer service at 1-770-705-2070.
2003 DODGE SPRINTER 3500
NHTSA Campaign ID:STEERING:COLUMN
Manufacturer:SPRINTER ENGINEERING & COMPLIANCE SUPPOR
Manufacture Dates:11/01/2007 - 11/30/2007
Potential Units Affected:10

Defect Description:

SPRINTER IS RECALLING 10 MY 2001-2006 DODGE AND FREIGHTLINER 2500 AND 3500 VEHICLES. THE WELDING SEAM BETWEEN THE BRACKET AND STEERING COLUMN OF AFFECTED SPARE PARTS DOES NOT MEET DESIGN SPECIFICATIONS. THE RESULT OF AN OUT OF SPECIFICATION WELDING SEAM IS THAT THE STEERING COLUMN MAY DETACH FROM ITS INTERIOR VEHICLE MOUNTING BRACKET.

Consequence:

THE OPERATOR MAY LOSE STEERING ABILITY OF THE VEHICLE INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL INSPECT AND REPLACE THE STEERING COLUMNS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 16, 2009. OWNERS MAY CONTACT SPRINTER AT 843-695-5057.
2003 DODGE SPRINTER 3500
NHTSA Campaign ID:ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Manufacturer:SPRINTER ENGINEERING & COMPLIANCE SUPPOR
Manufacture Dates:10/01/2001 - 09/30/2003
Potential Units Affected:14423

Defect Description:

SPRINTER IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2003 VANS SOLD AS DODGE AND FREIGHTLINER VEHICLES. THE INTAKE MANIFOLDS MAY HAVE CORRODED. A CHEMICAL REACTION INVOLVING SULFUR IN THE DIESEL FUEL THAT TAKES PLACE UNDER CERTAIN CONDITIONS CAN LEAD TO THE FORMATION OF SULFURIC ACID IN THE EXHAUST CHANNEL OF THE INTAKE MANIFOLD.

Consequence:

INTAKE MANIFOLD CORROSION MAY LEAD TO AN EXHAUST GAS LEAK, DAMAGE TO THE FUEL RETURN LINE WHICH COULD CAUSE A FUEL LEAK, AND HEAT DAMAGE TO THE INSULATION AT THE FRONT WALL.

Action:

DEALERS WILL INSPECT AND REPLACE THE INTAKE MANIFOLD FREE OF CHARGE. CHRYSLER, LLC IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. THE RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403 OR SPRINTER AT 843-695-5031.
2003 DODGE STRATUS
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:06/11/2003 - 07/25/2003
Potential Units Affected:5911

Defect Description:

ON CERTAIN PASSENGER VEHICLES, THE FUEL RETURN LINE HOSE FITTING ON THE ELECTRIC FUEL PUMP MAY BE RESTRICTED, CAUSING EXCESSIVE FUEL PRESSURE TO BUILD UP IN THE FUEL INJECTION SYSTEM. EXCESSIVE FUEL PRESSURE MAY RESULT IN A LEAK IN THE FUEL RETURN HOSE.

Consequence:

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Action:

DEALERS WILL INSPECT THE FUEL PUMP PRESSURE. THOSE VEHICLES EXHIBITING HIGHER THAN NORMAL FUEL PUMP PRESSURE WILL RECEIVE FUEL PUMP MODIFICATIONS. OWNER NOTIFICATION BEGAN ON DECEMBER 15, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
2003 DODGE STRATUS
NHTSA Campaign ID:AIR BAGS:PASSENGER SIDE FRONTAL
Manufacturer:Mitsubishi Motors North America, Inc.
Manufacture Dates:04/17/2000 - 02/22/2005
Potential Units Affected:443442

Defect Description:

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2000-2005 Eclipse vehicles manufactured April 5, 1999, to December 17, 2004, 2001-2005 Eclipse Spyder vehicles manufactured January 19, 2000, to March 18, 2005, 2001-2005 Chrysler Sebring vehicles manufactured April 17, 2000, to February 21, 2005, and 2001-2005 Dodge Stratus vehicles manufactured April 17, 2000, to February 22, 2005. In the affected vehicles, the passenger side sun visor may be folded down in such a position that, if the passenger frontal air bag deploys, the passenger side sun visor may detach.

Consequence:

If the passenger side sun visor detaches and is propelled rearward, there is an increased risk of occupant injury.

Action:

MMNA will notify their owners, and Chrysler will notify the Chrysler and Dodge owners. Dealers will install a tether strap to retain the passenger sun visor, free of charge. The recall began on July 20, 2015. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-15-005. Chrysler and Dodge owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R30.
2003 DODGE VIPER
NHTSA Campaign ID:EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:08/01/2002 - 08/31/2003
Potential Units Affected:1739

Defect Description:

ON CERTAIN PASSENGER VEHICLES, THE MULTIFUNCTION SWITCH PARK LAMP CONTACTS MAY CORRODE.

Consequence:

THIS CORROSION COULD CAUSE THE PARK LAMPS, HEAD LAMPS AND/OR INSTRUMENT PANEL LAMPS TO FLICKER OR BECOME INOPERATIVE. THIS COULD AFFECT DRIVER VISIBILITY, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL REFLASH THE SOFTWARE IN THE BODY CONTROL MODULE. OWNER NOTIFICATION BEGAN ON DECEMBER 1, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
2003 DODGE VIPER
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:07/01/2002 - 09/18/2002
Potential Units Affected:69

Defect Description:

ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP WIRING MAY BECOME CHAFED BY AN UNDERBODY HEAT SHIELD.

Consequence:

THIS COULD CAUSE THE FUEL PUMP FUSE TO OPEN, RESULTING IN AN ENGINE STALL, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL INSTALL A PROTECTIVE WRAP ON THE FUEL PUMP WIRING HARNESS AND COVER THE EDGE OF THE HEAT SHIELD. OWNER NOTIFICATION BEGAN SEPTEMBER 9, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2003 DODGE VIPER
NHTSA Campaign ID:AIR BAGS:FRONTAL
Manufacturer:Chrysler (FCA US LLC)
Manufacture Dates:11/01/2001 - 06/30/2004
Potential Units Affected:752644

Defect Description:

Chrysler (FCA US LLC) is recalling certain model year 2002-2003 Jeep Liberty vehicles manufactured January 9, 2001, to March 28, 2003, 2002-2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, to May 23 2003, and 2003-2004 Dodge Viper vehicles manufactured November 1, 2001, to June 30, 2004. Due to electrical noise beyond the tolerance of the air bag electronic control module (ECM), a component in the ECM may fail, causing the front air bags, side air bags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Consequence:

Inadvertent deployment of the air bags may increase the risk of injury and the possibility of a vehicle crash.

Action:

Chrysler dealers will replace the air bag control module and side impact sensors as required, free of charge. These parts are not currently available, however, an interim repair is available free of charge that reduces the risk of an inadvertent deployment. This recall remedy was applied during earlier recall campaigns of these vehicles under safety recalls 12V527 and 13V040. All owners that have not had the recall repair performed under safety recalls 12V527 or 13V040 are strongly encouraged to have it performed and not wait for the final remedy to be deployed to the field. The recall began on December 29, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R06.
2003 DODGE VIPER
NHTSA Campaign ID:AIR BAGS
Manufacturer:Chrysler Group LLC
Manufacture Dates:11/01/2001 - 06/30/2004
Potential Units Affected:3644

Defect Description:

Chrysler is recalling certain model year 2003 and 2004 Dodge Viper vehicles manufactured from November 1, 2001, through June 30, 2004. A component in the air bag control module may fail causing the front airbags and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Consequence:

Inadvertent deployment of the airbags and/or seat belt pretensioners could increase the risk of personal injury and the possibility of a crash.

Action:

Chrysler will notify owners, and dealers will repair the vehicles free of charge. An interim notification iwas sent to owners on March 18, 2013. The recall began on March 26, 2014. Owners may contact Chrysler at 1-800-853-1403.