Dodge Buyers Guide

 

Click a car name to see the crash test details for that model.

 

 

 

Crash Test Data for 2002 Dodge

Dodge Vehicle Front Star Rating Side Star Rating Rollover Resistance Rating
Driver Passenger Front Seat Rear Seat
2002 Caravan
2002 DakotaNot
Tested
2002 Dakota
2002 DurangoNot
Tested
Not
Tested
2002 Grand Caravan
2002 Grand Caravan
2002 IntrepidNot
Tested
2002 Neon
2002 RamNot
Tested
Not
Tested
Not
Tested
Not
Tested
Not
Tested
2002 RamNot
Tested
Not
Tested
2002 Ram VanNot
Tested
Not
Tested
2002 Ram WagonNot
Tested
Not
Tested
2002 Stratus
2002 StratusNot
Tested
2002 ViperNot
Tested
Not
Tested
Not
Tested
Not
Tested
Not
Tested

 

Service Bulletins for 2002 Dodge

2002 DODGE CARAVAN
Bulletin Number: 01010
SOME VEHICLES WERE BUILT AND SHIPPED TO DEALERS WITH CAMSHAFTS THAT MAY HAVE AN IMPROPERLY MACHINED OIL GROOVE. *SLC
Bulletin Number: 01011
CONCERNS WITH WIRING HARNESS CHAFING.*SLC
Bulletin Number: 0200305
RATTLE/KNOCKING SOUND FROM THE FRONT SUSPENSION. *SC
Bulletin Number: 0200405
CREAKING/SQUAWKING SOUND FROM FRONT STRUT AREA. *TT
Bulletin Number: 02005
LOUD WHISTLE/SQUEALING SOUND FROM ENGINE COMPARTMENT-2002 RS/RG. *SLC
Bulletin Number: 02012
SOME VEHICLES MAY EXPERIENCE A SLIPPING OR NO DRIVE CONDITION IN REVERSE OR FIRST GEAR. *TT
Bulletin Number: 02012
SOME VEHICLES MAY EXPERIENCE A SLIPPING OR NO DRIVE CONDITION IN REVERSE OR FIRST GEAR. *TT
Bulletin Number: 02013
SUBJECT REGARDING MONRONEY LABEL TIRE DISCREPANCY. *TT
Bulletin Number: 02018
POWER SLIDING DOOR AND/OR POWER LIFTGATE WILL POP OFF BUT NOT POWER OPEN. *TT
Bulletin Number: 02020
DELAYED TRANSAXLE ENGAGEMENT AFTER INITIAL START UP. *TT
Bulletin Number: 0500102A
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *YD THIS BULLETIN SUPERSEDES 05-001-02 DATED MARCH 4, 2002. *TT
Bulletin Number: 0500106A
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *KB
Bulletin Number: 0500204
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *TT
Bulletin Number: 0500305
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *TT
Bulletin Number: 0500402
SUBJECT REGARDING REAR BRAKE CYCLIC RUBBING SOUND FROM REAR OF VEHICLE DURING MEDIUM TO LIGHT BRAKE APPLICATION ON VEHICLES WITH REAR DRUM BRAKES. *TT
Bulletin Number: 0500403
ANTI-LOCK BRAKE REAR WHEEL SPEED SENSOR REPLACEMENT. *TT
Bulletin Number: 0500404
ANTI-LOCK BRAKE REAR WHEEL SPEED SENSOR REPLACEMENT. *TT
Bulletin Number: 0700102
SUBJECT REGARDING BELT LIKE SQUEAL SOUND AT HIGH ENGINE RPM. *TT
Bulletin Number: 0700302
SUBJECT REGARDING COOLING FAN SOUND/VIBRATION. *SLC
Bulletin Number: 0700501
INFORMATION ON BELT-LIKE SQUEAL SOUND AT HIGH ENGINE RPM. *TT
Bulletin Number: 0700701
A CONDITION MAY EXIST AT IDLE, WITH THE COOLING FANS ON, A SOUND MAY BE HEARD AND / OR A VIBRATION MAY BE FELT INSIDE THE VEHICLE. *TT
Bulletin Number: 0800202
INFORMATION ON REMOVABLE FLOOR CONSOLE ELECTRICAL CONNECTOR. *TT
Bulletin Number: 0800504
ERRONEOUS ACTUATION OF HORNS, HEADLAMPS, AND PARKING LAMPS WHILE VEHICLE IS PARKED. *TT
Bulletin Number: 0800604
INSTRUMENT PANEL ILLUMINATION. *TT
Bulletin Number: 0800702
SUBJECT REGARDING REMOTE KEYLESS ENTRY PROGRAMMING PROCEDURES. *SLC
Bulletin Number: 0800902
SOME VEHICLES NOT EQUIPPED WITH ANTI-SKID BRAKE SYSTEM (ABS) MAY HAVE THE ABS, BRAKE AND TRAC OFF LAMPS ILLUMINATED ON THE INSTRUMENT CLUSTER. *TT
Bulletin Number: 0800902A
CONCERNS WITH THE ABS, BRAKE AND TRAC OFF CLUSTER LAMPS ILLUMINATED ON VEHICLES NOT EQUIPPED WITH ABS BRAKES. *TT
Bulletin Number: 0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
Bulletin Number: 0801403
POWERTRAIN WIRING HARNESS BRACKET PACKAGE. *TT
Bulletin Number: 0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
Bulletin Number: 0801601
INFORMATION REGARDING VEHICLES EQUIPPED WITH RADIOS WILL HAVE A NEW LOCKING RADIO ANTENNA CONNECTOR. *SLC
Bulletin Number: 0801701
SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR. *TT
Bulletin Number: 0802101
CONCERN WITH TAIL LAMP EXPERIENCING A LOOSE CONDITION. *TT
Bulletin Number: 0802103
VEHICLES NOT EQUIPPED WITH ANTI-LOCK BRAKE SYSTEM (ABS) BRAKES MAY HAVE THE ABS, BRAKE, AND TRAC OFF LAMPS ILLUMINATED ON THE INSTRUMENT CLUSTER OR VEHICLES NOT EQUIPPED WITH SENTRY KEY IMMOBILIZER (SKIM) MAY HAVE THE SECURITY/VTA LAMP ILLU
Bulletin Number: 0802401
A CONDITION MAY EXIST WHERE THE FUEL GAUGE INDICATOR VISIBLY DROPS 1/4 TO 1/2 TANK WHILE DRIVING. *TT
Bulletin Number: 0802701
INFORMATION REGARDING THE MINIVAN ELECTRICAL SYSTEM. *SLC
Bulletin Number: 0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
Bulletin Number: 0900402
SUBJECT REGARDING STUCK OIL PRESSURE RELIEF VALVE FOR VEHICLES BUILT PRIOR TO JANUARY 1, 2002 EQUIPPED WITH A 3.3 L OR 3.8 L ENGINE. *SLC
Bulletin Number: 0900704
IRREGULAR ENGINE SNAPPING SOUND. *TT
Bulletin Number: 0900801
SUBJECT REGARDING CAMSHAFT / BEARING SERVICE. *TT
Bulletin Number: 1400102
SUBJECT REGARDING FUEL CAP DIFFICULT TO REMOVE. *SLC
Bulletin Number: 1400102A
FUEL CAP DIFFICULT TO REMOVE. *TT
Bulletin Number: 1400207
CLEANING PROCEDURE FOR THE MECHANICAL THROTTLE BODY. *KB
Bulletin Number: 1800802
EXHIBITING ENGINE SAG / HESITATION AND/OR CLOSED THROTTLE START STALL, DIAGNOSTIC TROUBLE CODE P0123. *TT
Bulletin Number: 1801002
SUBJECT REGARDING MALFUNCTION INDICATOR LAMP ILLUMINATION, ERRONOUS DIAGNOSTIC TROUBLE CODE (DTC) P0456, EVAP LEAK MONITOR 0.020 LEAK DETECTED. *SLC
Bulletin Number: 1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 1802303
BATTERY LIGHT ILLUMINATION, ERRONEOUS DIAGNOSTIC TROUBLE CODE (DTC) P1594. *TT
Bulletin Number: 1802304
SURGE WITH TRANSMISSION AT FULL LOCK-UP. *MJ
Bulletin Number: 1802601
SUBJECT REGARDING EXHAUST GAS RECIRCULATION (EGR) SYSTEM ELIMINATION. *TT
Bulletin Number: 1802602A
ENGINE SPARK KNOCK. *TT
Bulletin Number: 1802701
SOME VEHICLES MAY EXHIBIT MODERATE TO SEVERE HIGH WAY SPEED 45-60 MPH VEHICLE SURGE. *TT
Bulletin Number: 1802803
VEHICLE WITH PROPERLY FUNCTIONING EVAPORATIVE EMISSIONS SYSTEM REPEATEDLY SETS DIAGNOSTIC TROUBLE CODE P0456 WHEN CUSTOMER REGULARLY COMMUTES ON A STEEP GRADE. *TT
Bulletin Number: 1900103
POP/TICK SOUND IN STEERING WHEEL AREA. *TT *MJ
Bulletin Number: 1900303
POP/TICK SOUND IN STEERING WHEEL AREA. *TT
Bulletin Number: 1900403
STEERING SHUDDER. *TT
Bulletin Number: 1900504
POP/TRICK/CREAK SOUND IN STEERING COLUMN. *MJ *EH
Bulletin Number: 1900602
SUBJECT REGARDING STEERING SHUDDER. *SLC
Bulletin Number: 1900603
KNOCKING SOUND FROM LOWER STEERING COLUMN. *TT
Bulletin Number: 1900701
INFORMATION ON NEW POWER STEERING FLUID.*SLC
Bulletin Number: 1900801
EXPERIENCING A POP/TICK SOUND HEARD COMING FROM THE STEERING WHEEL AREA WHILE THE VEHICLE IS IN MOTION. *TT
Bulletin Number: 1900805
REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC
Bulletin Number: 1901001
EXPERIENCING A SHUDDER (VIBRATION) FELT INSIDE THE VEHICLE WHILE TURNING THE STEERING WHEEL. *TT
Bulletin Number: 2100102
SOME VEHICLES MAY HAVE A TRANSAXLE THAT WILL NOT MOVE OR SLIPS IN REVERSE OR FIRST GEAR. *TT
Bulletin Number: 2100405
TRANSMISSION DELAY ENGAGEMENT. *EH
Bulletin Number: 2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
Bulletin Number: 2100903
AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE. VARIOUS MODELS INCLUDING THE 2004 RAM TRUCK, DURANGO, SEBRING CONVERTIBLE, CHEROKEE, VISION, NEON, AND VOYAGER. *TT *SC
Bulletin Number: 2200102
CHROME WHEEL CARE. *SLC
Bulletin Number: 2200301A
SOME CUSTOMERS MAY COMPLAIN OF A HOWL/ DRONE/ MOAN/ HUMMING/CYCLIC SOUND WHEN DRIVING AT SPEEDS BETWEEN 45 AND 70 MPH. *TT
Bulletin Number: 2300403
POWER SLIDING DOOR AND / OR POWER LIFTGATE WILL POP OFF BUT NOT POWER OPEN. *TT
Bulletin Number: 2300702
ON SOME VEHICLES, THE QUAD SEAT CUPHOLDER COMPENSATION FLAP IS BROKEN. *TT
Bulletin Number: 2301004
PASSENGER COMPARTMENT FLOOR WATER LEAK. *TT THIS BULLETIN SUPERSEDES BULLETIN 23-010-04 DATED 04-29-04. *TT
Bulletin Number: 2301402
SUBJECT REGARDING QUARTER WINDOW WEATHERSTRIP LOOSE. *SLC
Bulletin Number: 2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
Bulletin Number: 2302007
POWER SLIDING DOOR ADJUSTMENT AND DIAGNOSIS AID. *KB UPDATED 10/26/07. *NJ
Bulletin Number: 2302102
SUBJECT REGARDING ASSIST FEATURE INOPERATIVE ON QUAD OR SPLIT REAR BENCH SEATS. *SLC
Bulletin Number: 2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
Bulletin Number: 2302801
THIS BULLETIN INVOLVES INSTALLING A REVISED POWER SEAT ADJUSTER DRIVE BLOCK SCREW TO THE INBOARD SIDE OF THE POWER SEAT TRACK(S). *TT
Bulletin Number: 2302801A
ON SOME VEHCLES, THE POWER SEAT HAS SLIGHT FORE/AFT MOVEMENT MOST NOTICEABLE DURING ACCELERATION OR BRAKING. *TT
Bulletin Number: 2303102
SUBJECT REGARDING QUAD SEAT RELEASE HANDLE SCREW SHEARED OFF IN SHAFT. *SLC
Bulletin Number: 2303601
SUBJECT REGARDING POWER SLIDING DOOR REVERSES DIRECTION DURING THE POWER CLOSE CYCLE, FALSE OBSTACLE DETECTION. *TT
Bulletin Number: 2400302
SUBJECT REGARDING POOR REAR AIR CONDITIONER PERFORMANCE - LOW OUTPUT FROM HEADLINER VENTS. *SLC
Bulletin Number: 2400702
SUBJECT REGARDING AIR CONDITIONER TEMPERATURE DIFFERENTIAL (STRATIFICATION) BETWEEN LEFT AND RIGHT FRONT PANEL OUTLETS. *TT
Bulletin Number: 2400802
CUSTOMER MAY COMPLAIN THAT THE HVAC DRAIN WATER LEAKS UNDER PASSENGER SIDE CARPET. *TT
Bulletin Number: 2500102A
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION, DIAGNOSTIC TROUBLE CODE (DTC) P0442, P0455, OR P0456 - LEAK DETECTION PUMP (LDP), LEAK DETECTED. THIS BULLETIN SUPERSEDES 25-001-02 DATED FEB 11, 2002. *TT
Bulletin Number: 27
THE TRANSAXLE LOW/REVERSE ACCUMULATOR COVER O-RING ON CERTAIN VEHICLES MAY BECOME DISLODGED. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: 9002828
Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator, attaching rivet and an instruction sheet are now available as a kit. If the insulator requires replacement lease order 68253
Bulletin Number: C20
POWER STEERING FLUID COOLER HOSES MAY SPLIT AND CAUSE A LOSS OF POWER ASSIST - CUSTOMER SATISFACTION NOTIFICATION NO. C20. *TT
2002 DODGE DAKOTA
Bulletin Number: 01016
SOME VEHICLES MAY EXHIBIT A TRANSMISSION FILLER TUBE RATTLE CONDITION. *TT
Bulletin Number: 01016A
RAPID REPONSE TRANSMITTAL REGARDING TRANSMISSION FILLER TUBE RATTLE CONDITION. *TT
Bulletin Number: 02005
MISSING TONNEAU COVER. *SLC
Bulletin Number: 02007
SUBJECT REGARDING 4.7L CRANKSHAFT TO BEDPLATE INTERFERENCE. *SLC
Bulletin Number: 0201004
UPPER BALL JOINT EXTENDED WARRANTY. *TT
Bulletin Number: 0500601
SUBJECT REGARDING DISCOLORED BRAKE FLUID. *TT
Bulletin Number: 0703
DISCONNECTING THE PARK BRAKE RELEASE HANDLE WHEN SERVICING THE STEERING COLUMN OPENING COVER. *TT
Bulletin Number: 0800702
SUBJECT REGARDING REMOTE KEYLESS ENTRY PROGRAMMING PROCEDURES. *SLC
Bulletin Number: 0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
Bulletin Number: 0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
Bulletin Number: 0801601
INFORMATION REGARDING VEHICLES EQUIPPED WITH RADIOS WILL HAVE A NEW LOCKING RADIO ANTENNA CONNECTOR. *SLC
Bulletin Number: 0801701
SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR. *TT
Bulletin Number: 0802303
INTERMITTENT LOCKING/UNLOCKING OF DOORS WITHOUT ACTIVATING THE POWER DOOR LOCK SWITCH. *TT
Bulletin Number: 0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
Bulletin Number: 10023
STEERING COLUMN SERVICE. INFORMATION. SERVICE INFORMATION TUNEUPS. *TT
Bulletin Number: 1400102
SUBJECT REGARDING FUEL CAP DIFFICULT TO REMOVE. *SLC
Bulletin Number: 1400102A
FUEL CAP DIFFICULT TO REMOVE. *TT
Bulletin Number: 1800103
CUSTOMERS MAY COMPLAIN THE VEHICLE WILL NOT SHIFT OUT OF 2ND GEAR WHILE CLIMBING A GRADE. UPDATE TO TRANSMISSION CALIBRATIONS. *TT
Bulletin Number: 1800103A
CUSTOMERS MAY COMPLAIN THE VEHICLE WILL NOT SHIFT OUT OF 2ND GEAR WHILE CLIMBING A GRADE. UPDATE TO TRANSMISSION CALIBRATIONS.
Bulletin Number: 1800203
THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE DUE TO ERRONEOUS DETECTION OF A SMALL LEAK IN THE VEHICLE'S EVAPORATIVE SYSTEM. *TT
Bulletin Number: 1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
Bulletin Number: 1801504
IDLE FLUCTUATION WHILE TURNING. *TT
Bulletin Number: 1801602
SUBJECT REGARDING FLASH: MALFUNCTION INDICATOR LAMP ILLUMINATION FOR ERRONEOUS DIAGNOSTIC TROUBLE CODE P0456, EVAP MONITOR SMALL LEAK DETECTED. *SLC
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 1900701
INFORMATION ON NEW POWER STEERING FLUID.*SLC
Bulletin Number: 2100202
SUBJECT REGARDING REVISION IN DIAGNOSTIC PROCEDURES AND LABOR OPERATION TIMES FOR RE TRANSMISSIONS. *TT
Bulletin Number: 2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
Bulletin Number: 2101505
45RFE/545RFE TRANS - DELAYED ENGAGEMENT DUE TO COOLER RETURN FILTER REPLACEMENT. *SC
Bulletin Number: 2200102
CHROME WHEEL CARE. *SLC
Bulletin Number: 2301004
PASSENGER COMPARTMENT FLOOR WATER LEAK. *TT THIS BULLETIN SUPERSEDES BULLETIN 23-010-04 DATED 04-29-04. *TT
Bulletin Number: 2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
Bulletin Number: 2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
Bulletin Number: 2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: 9002828
Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator, attaching rivet and an instruction sheet are now available as a kit. If the insulator requires replacement lease order 68253
Bulletin Number: 9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement
Bulletin Number: 9002872
56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2 required to attach Neutral Start Switch
Bulletin Number: 9002901
Part Description: Seal - Shift Shaft on RFE transmissions Issue Description: This seal (04799346) is replaceable with Seal Kit (68235551AA), which includes a seal and retainer. The Seal Kit is applicable to all (5)45RFE transmissions.
2002 DODGE DURANGO
Bulletin Number: 0201004
UPPER BALL JOINT EXTENDED WARRANTY. *TT
Bulletin Number: 0500601
SUBJECT REGARDING DISCOLORED BRAKE FLUID. *TT
Bulletin Number: 0703
DISCONNECTING THE PARK BRAKE RELEASE HANDLE WHEN SERVICING THE STEERING COLUMN OPENING COVER. *TT
Bulletin Number: 0703
PROCEDURES FOR SERVICING THE SEAT BELT LATCH PLATE CINCH BAR. *TT
Bulletin Number: 0800702
SUBJECT REGARDING REMOTE KEYLESS ENTRY PROGRAMMING PROCEDURES. *SLC
Bulletin Number: 0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
Bulletin Number: 0801003
SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS. *TT
Bulletin Number: 0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
Bulletin Number: 0801601
INFORMATION REGARDING VEHICLES EQUIPPED WITH RADIOS WILL HAVE A NEW LOCKING RADIO ANTENNA CONNECTOR. *SLC
Bulletin Number: 0801701
SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR. *TT
Bulletin Number: 0802303
INTERMITTENT LOCKING/UNLOCKING OF DOORS WITHOUT ACTIVATING THE POWER DOOR LOCK SWITCH. *TT
Bulletin Number: 0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
Bulletin Number: 10023
STEERING COLUMN SERVICE. INFORMATION. SERVICE INFORMATION TUNEUPS. *TT
Bulletin Number: 1400102
SUBJECT REGARDING FUEL CAP DIFFICULT TO REMOVE. *SLC
Bulletin Number: 1400102A
FUEL CAP DIFFICULT TO REMOVE. *TT
Bulletin Number: 1800203
THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE DUE TO ERRONEOUS DETECTION OF A SMALL LEAK IN THE VEHICLE'S EVAPORATIVE SYSTEM. *TT
Bulletin Number: 1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
Bulletin Number: 1801602
SUBJECT REGARDING FLASH: MALFUNCTION INDICATOR LAMP ILLUMINATION FOR ERRONEOUS DIAGNOSTIC TROUBLE CODE P0456, EVAP MONITOR SMALL LEAK DETECTED. *SLC
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 1900701
INFORMATION ON NEW POWER STEERING FLUID.*SLC
Bulletin Number: 1901101
SUBJECT REGARDING CLICKING SOUND IN THE STEERING COLUMN / INTERMEDIATE SHAFT. *TT
Bulletin Number: 2100202
SUBJECT REGARDING REVISION IN DIAGNOSTIC PROCEDURES AND LABOR OPERATION TIMES FOR RE TRANSMISSIONS. *TT
Bulletin Number: 2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
Bulletin Number: 2200102
CHROME WHEEL CARE. *SLC
Bulletin Number: 2300302
A CONDITION MAY EXIST WHERE THE SEAT LUMBAR ADJUSTER IS INOPERATIVE. *TT
Bulletin Number: 2301004
PASSENGER COMPARTMENT FLOOR WATER LEAK. *TT THIS BULLETIN SUPERSEDES BULLETIN 23-010-04 DATED 04-29-04. *TT
Bulletin Number: 2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
Bulletin Number: 2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
Bulletin Number: 2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: 9002828
Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator, attaching rivet and an instruction sheet are now available as a kit. If the insulator requires replacement lease order 68253
Bulletin Number: 9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement
Bulletin Number: 9002872
56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2 required to attach Neutral Start Switch
Bulletin Number: 9002901
Part Description: Seal - Shift Shaft on RFE transmissions Issue Description: This seal (04799346) is replaceable with Seal Kit (68235551AA), which includes a seal and retainer. The Seal Kit is applicable to all (5)45RFE transmissions.
2002 DODGE GRAND CARAVAN
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: B05
SUBJECT REGARDING THE POWERTRAIN CONTROL MODULE (PCM) MAY CAUSE AIR CONDITIONING COMPRESSOR FAILURE FOR RS MODELS. *SLC
Bulletin Number: C20
POWER STEERING FLUID COOLER HOSES MAY SPLIT AND CAUSE A LOSS OF POWER ASSIST - CUSTOMER SATISFACTION NOTIFICATION NO. C20. *TT
2002 DODGE INTREPID
Bulletin Number: 0200103
SQUEAKING SOUND FROM REAR STRUT(S). *TT
Bulletin Number: 02019
INCORRECT SOFTWARE FLASH - TSB 1801502 AND 1803102. *TT
Bulletin Number: 02020
DELAYED TRANSAXLE ENGAGEMENT AFTER INITIAL START UP. *TT
Bulletin Number: 0700202
SUBJECT REGARDING LOW OR NO CABIN HEAD, ENGINE COOLING SYSTEM SYSTEM FILL PROCEDURE. *TT
Bulletin Number: 0703
THE ENGINE COMPARTMENT IN THE FRAME & BUMPERS - FRAME - SPECIFICATIONS - FRAME DIMENSIONS SECTION HAS BEEN UPDATED. *TT
Bulletin Number: 0800702
SUBJECT REGARDING REMOTE KEYLESS ENTRY PROGRAMMING PROCEDURES. *SLC
Bulletin Number: 0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
Bulletin Number: 0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
Bulletin Number: 0801601
INFORMATION REGARDING VEHICLES EQUIPPED WITH RADIOS WILL HAVE A NEW LOCKING RADIO ANTENNA CONNECTOR. *SLC
Bulletin Number: 0801701
SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR. *TT
Bulletin Number: 0802202
POLICE VEHICLE BODY CONTROL MODULE (BCM). *TT
Bulletin Number: 0802203
HEADLAMP/INSTRUMENT PANEL ILLUMINATION. 2004 MODELS INCLUDED. *TT
Bulletin Number: 0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
Bulletin Number: 0900203
ENGINE STUMBLE AND/OR MISFIRE - MALFUNCTION INDICATOR LAMP ILLUMINATION. *TT
Bulletin Number: 0900204
SHORT DURATION COLD ENGINE START-UP TICKING LIKE SOUND. THIS BULLETIN APPLIES TO VEHICLES BUILT PRIOR TO MARCH 31, 2003. *MN
Bulletin Number: 0900503
SHORT DURATION COLD ENGINE START-UP TICKING LIKE SOUND. *TT
Bulletin Number: 1400102
SUBJECT REGARDING FUEL CAP DIFFICULT TO REMOVE. *SLC
Bulletin Number: 1400102A
FUEL CAP DIFFICULT TO REMOVE. *TT
Bulletin Number: 1400103
FUEL TANK SLOW TO FILL. INCLUDING MY2004. *TT
Bulletin Number: 1800604A
GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE. *TT *MJ THIS BULLETIN SUPERSEDES BULLETIN 18-006-04A DATED 04/06/2004. *TT
Bulletin Number: 1800703
GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE. *TT
Bulletin Number: 1800703A
GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE. *TT
Bulletin Number: 1800703B
GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE. 2004 MODELS INCLUDED. *TT
Bulletin Number: 1800703C
GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE. 2004 MODELS INCLUDED. *TT
Bulletin Number: 1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
Bulletin Number: 1801402
SUBJECT REGARDING TRANSAXLE LIMP-IN, ENGINE MISFIRE, ENGINE NO-START. *SLC
Bulletin Number: 1801502
SUBJECT REGARDING MALFUNCTION INDICATOR LAMP ON FOR MISFIRE DIAGNOSTIC TROUBLE CODE - MAP VALUE STORED IN FREEZE FRAME AND SIMILAR CONDITIONS WINDOW MAY BE INCORRECT. *SLC
Bulletin Number: 1801703
ERRONEOUS MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION - ERRONEOUS DIAGNOSTIC TROUBLE CODES (DTC). *TT
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 1802201
SUBJECT REGARDING OBDII FREEZE FRAME DATA READS INCORRECTLY. *TT
Bulletin Number: 1802401
INFORMATION ON IGNITION SPARK TEST. *TT
Bulletin Number: 1802907
GENERIC POWERTRAIN CONTROL MODULE (PCM) PROCEDURE. *KB
Bulletin Number: 1803102
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION, ERRONEOUS DIAGNOSTIC TROUBLE CODE (DTC) P0153, P0159, P0135, P0141, P0155, P0161, P0131, P0132, P0137, P0138, P0151, P0152, P0157, P0158. *TT
Bulletin Number: 1804203
FLASH-ROUGH IDLE. *PH
Bulletin Number: 1900701
INFORMATION ON NEW POWER STEERING FLUID.*SLC
Bulletin Number: 2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
Bulletin Number: 2200102
CHROME WHEEL CARE. *SLC
Bulletin Number: 2300203
WIND NOISE FROM SUNROOF OR B-PILLAR WHILE DRIVING. *TT
Bulletin Number: 2301103
SAG OR RATTLE AT REAR OF HEADLINER. *TT
Bulletin Number: 2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
Bulletin Number: 2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
Bulletin Number: 2302802
SUBJECT REGARDING AN INOPERATIVE OR INTERMITTENT SUN ROOF. *SLC
Bulletin Number: 2304702
INTERIOR FRONT DOOR HANDLE/BEZEL REPLACEMENT. *MJ
Bulletin Number: 2400204
AIR CONDITIONER AND HEATER PERFORMANCE. *TT
Bulletin Number: 2400901
SUBJECT PERTAINING TO A/C HEATER PERFORMANCE.*SLC
Bulletin Number: 4850306
INFORMATION REGARDING 3.5L ENGINE SUSPECT CONNECTING ROD BEARING.*YHI
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
2002 DODGE LANCER
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
2002 DODGE NEON
Bulletin Number: 01016
ADVANCE SERVICE INFORMATION REGARDING ALARM REMOTE KEYLESS ENTRY MODULE (ARKEM) SHIPPING MODE ELIMINATION. *TT
Bulletin Number: 01017
RAPID RESPONSE TRANSMITTAL REGARDING A/C SYSTEM OVERCHARGE. *TT
Bulletin Number: 02006
SUBJECT REGARDING TRANSMISSION CONTROL MODULE (TCM) FLASH PROCEDURE WILL NOT WORK. *SLC
Bulletin Number: 02010
LEFT FRONT STEERING KNUCKLE/ABS TONE WHEEL INTERFERENCE. *SLC
Bulletin Number: 02012
SOME VEHICLES MAY EXPERIENCE A SLIPPING OR NO DRIVE CONDITION IN REVERSE OR FIRST GEAR. *TT
Bulletin Number: 02012
SOME VEHICLES MAY EXPERIENCE A SLIPPING OR NO DRIVE CONDITION IN REVERSE OR FIRST GEAR. *TT
Bulletin Number: 02020
DELAYED TRANSAXLE ENGAGEMENT AFTER INITIAL START UP. *TT
Bulletin Number: 0300604
FRONT HUB/HALF SHAFT CLICK/POP SOUND. *TT
Bulletin Number: 0500601
SUBJECT REGARDING DISCOLORED BRAKE FLUID. *TT
Bulletin Number: 0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
Bulletin Number: 0801003
SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS. *TT
Bulletin Number: 0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
Bulletin Number: 0801601
INFORMATION REGARDING VEHICLES EQUIPPED WITH RADIOS WILL HAVE A NEW LOCKING RADIO ANTENNA CONNECTOR. *SLC
Bulletin Number: 0801701
SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR. *TT
Bulletin Number: 0801901
SOME VEHICLES EQUIPPED WITH VEHICLE THEFT ALARM WILL NO LONGER DISARM OR ARM THE ALARM FROM THE FRONT PASSENGER DOOR USING THE KEY. *TT
Bulletin Number: 0802301
SUBJECT REGARDING STATIC ON STRONG AM RADIO STATIONS. *TT
Bulletin Number: 0802502
AIR BAG LIGHT ON WITH ERRONEOUS DIAGNOSTIC TROUBLE CODE (DTC) STORED ENERGY FAULT SET. *TT
Bulletin Number: 0802801
MOISTURE ACCUMULATION INSIDE A VENTED HEADLAMP ASSEMBLY CONDITION. *TT
Bulletin Number: 0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
Bulletin Number: 0900502
SUBJECT REGARDING ENGINE OIL IN COOLANT RESERVOIR. *TT
Bulletin Number: 1400102
SUBJECT REGARDING FUEL CAP DIFFICULT TO REMOVE. *SLC
Bulletin Number: 1400102A
FUEL CAP DIFFICULT TO REMOVE. *TT
Bulletin Number: 1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
Bulletin Number: 1801302
SUBJECT REGARDING ENGINE PERFORMANCE ENHANCEMENTS. *SLC
Bulletin Number: 1801302A
ENGINE PERFORMANCE ENHANCEMENTS / ROUGH IDLE IN DRIVE. *TT
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 1900204
STEERING COLUMN CLICK SOUND. *TT
Bulletin Number: 1900701
INFORMATION ON NEW POWER STEERING FLUID.*SLC
Bulletin Number: 1900702
LOWER STEERING COLUMN CLICK SOUND. *TT
Bulletin Number: 1900805
REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC
Bulletin Number: 2100102
SOME VEHICLES MAY HAVE A TRANSAXLE THAT WILL NOT MOVE OR SLIPS IN REVERSE OR FIRST GEAR. *TT
Bulletin Number: 2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
Bulletin Number: 2200102
CHROME WHEEL CARE. *SLC
Bulletin Number: 2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
Bulletin Number: 2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
Bulletin Number: 2303202
SUBJECT REGARDING INSTRUMENT PANEL MAT (PENCIL TRAY) ADHESION. *SLC
Bulletin Number: 27
THE TRANSAXLE LOW/REVERSE ACCUMULATOR COVER O-RING ON CERTAIN VEHICLES MAY BECOME DISLODGED. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: 993
A CONDITION MAY EXIST REGARDING AN INACCURATE ODOMETER READING. *TT
2002 DODGE QUAD
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
2002 DODGE RAM
Bulletin Number: 01024
SUBJECT REGARDING REPORTS OF INOPERATIVE TACHOMETER. *TT
Bulletin Number: 01025
SOME VEHICLES EQUIPPED WITH 4.7L OR 5.9L ENGINES MAY EXHIBIT A CONDITION IN WHICH THE OIL PRESSURE GAUGE MAY INTERMITTENTLY DROP TO ZERO. *TT
Bulletin Number: 0200302
SUBJECT REGARDING A TOE IN SPECIFICATION CHANGE. *SLC
Bulletin Number: 02003A
SUBJECT REGARDING CRANKSHAFT POSITION SENSOR SIGNAL, VEHICLES EQUIPPED WITH THE 3.7 L ENGINE, ALSO REFER TO 02003. *SLC
Bulletin Number: 02006
SUBJECT REGARDING LEFT AND RIGHT CAM SPROCKET BOLTS NOT TORQUED TO CORRECT SPECIFICATION. *SLC
Bulletin Number: 02007
SUBJECT REGARDING 4.7L CRANKSHAFT TO BEDPLATE INTERFERENCE. *SLC
Bulletin Number: 02008
SUBJECT REGARDING TRUCKS THAT WERE BUILT WITH INCORRECT STEERING GEARS. *SLC
Bulletin Number: 0300102
THE FRONT AXLE DISCONNET SYSTEM. *TT
Bulletin Number: 0300202
INFORMATION ON THE USE OF SYNTHETIC REAR AXLE LUBRICANT. *TT
Bulletin Number: 05002
NEW WATER PUMP FOR 3.7L ENGINE - NO LONGER COMMON WITH 4.7L. ADVANCED SERVICE INFORMATION #05-002. *TT
Bulletin Number: 06003
REAR SUSPENSION VIBRATION WHILE DRIVING AT HIGHWAY SPEEDS. *TT
Bulletin Number: 0703
PROCEDURES FOR SERVICING THE SEAT BELT LATCH PLATE CINCH BAR. *TT
Bulletin Number: 0703
PROCEDURE FOR REMOVAL OF THE POWER STEERING PULLEY. *TT
Bulletin Number: 0800403
ELECTRO MECHANICAL INSTRUMENT CLUSTER - ERRONEOUS INDICATOR LAMPS. *TT
Bulletin Number: 0800702
SUBJECT REGARDING REMOTE KEYLESS ENTRY PROGRAMMING PROCEDURES. *SLC
Bulletin Number: 0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
Bulletin Number: 0801601
INFORMATION REGARDING VEHICLES EQUIPPED WITH RADIOS WILL HAVE A NEW LOCKING RADIO ANTENNA CONNECTOR. *SLC
Bulletin Number: 0802302
WEAK AM RADIO RECEPTION. *TT
Bulletin Number: 0802303
INTERMITTENT LOCKING/UNLOCKING OF DOORS WITHOUT ACTIVATING THE POWER DOOR LOCK SWITCH. *TT
Bulletin Number: 0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
Bulletin Number: 0900202
SUBJECT REGARDING CRANKCASE BREATHER OVERFLOW. *SLC
Bulletin Number: 0900601
VEHICLES MAY EXPERIENCE OIL PAN GASKET LEAKS.*SLC
Bulletin Number: 0900802
ENGINE KNOCK OR RATTLE SOUND WHEN CLIMBING A LONG GRADE AND TOWING A HEAVY TRAILER. *TT
Bulletin Number: 0900904
VACUUM PUMP SERVICE. *TT
Bulletin Number: 10023
STEERING COLUMN SERVICE. INFORMATION. SERVICE INFORMATION TUNEUPS. *TT
Bulletin Number: 10023
CORRECT FUSE NUMBER AND CAPACITY FOR THE 2002 INSTRUMENT CLUSTER. SERVICE INFORMATION TUNEUPS. *TT
Bulletin Number: 10182004
STABILIZER BAR LINK NUT TORQUE SPECS CHANGED. *EH
Bulletin Number: 10182004
MINIMUN REAR ROTOR THICKNESS. *EH
Bulletin Number: 10182004
MAINTENANCE SCHEDULE INFORMATION. *EH
Bulletin Number: 1400102
SUBJECT REGARDING FUEL CAP DIFFICULT TO REMOVE. *SLC
Bulletin Number: 1400102A
FUEL CAP DIFFICULT TO REMOVE. *TT
Bulletin Number: 1400202
INFORMATION ON TAMPERING WITH VP44 FUEL PUMP ON CUMMINS DIESEL ENGINES. *TT
Bulletin Number: 1400202A
INFORMATION ON TAMPERING WITH VP44 FUEL PUMP ON CUMMINS DIESEL ENGINE. *TT
Bulletin Number: 1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
Bulletin Number: 1801401
SUBJECT REGARDING PERFORMANCE ENHANCEMENTS, HARD STARTING AND / OR IDLE SPEED FLUCTUATIONS FOR SEVERE COLD WEATHER ENVIRONMENTS. *TT
Bulletin Number: 1801901
SOME VEHICLES MAY EXPERIENCE COLD IDLE ENGINE WARMING *SLC
Bulletin Number: 1801902A
REVISION OF FLASH PROCESS FOR NEW ENGINE CONTROL MODULE (ECM) FROM CUMMINS. *SLC THIS BULLETIN SUPERSEDES BULLETIN 18-019-02 DATED JUNE 17, 2002. *TT
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 1802901
SOME VEHICLES MAY EXHIBIT A CONDITION WHERE IN THE OIL PRESSURE GAUGE INTERMITTENTLY DROPS TO ZERO. *TT
Bulletin Number: 1803002
ENGINE UNDERSHOOTS IDLE WHEN THE VEHICLE IS STOPPED, IN GEAR.*MR
Bulletin Number: 1803003
GENERIC CUMMINS ENGINE CONTROL MODULE (PCM) PROCEDURE. *TT
Bulletin Number: 1803003A
GENERIC CUMMINS ENGINE CONTROL MODULE (PCM) PROCEDURE. *TT THIS BULLETIN REPLACED 18-030-03. *TT THIS BULLETIN REPLACED 18-030-03A DATED 10/17/03. TO ALSO INCLUDE 2005 RAM TRUCK. *TT
Bulletin Number: 1803603
ENGINE IDLE FLUCTUATION. *TT
Bulletin Number: 1900701
INFORMATION ON NEW POWER STEERING FLUID.*SLC
Bulletin Number: 2100202
SUBJECT REGARDING REVISION IN DIAGNOSTIC PROCEDURES AND LABOR OPERATION TIMES FOR RE TRANSMISSIONS. *TT
Bulletin Number: 2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
Bulletin Number: 2200102
CHROME WHEEL CARE. *SLC
Bulletin Number: 2200303
VIBRATION AT HIGHWAY SPEEDS. *TT
Bulletin Number: 2300202
SUBJECT REGARDING HOOD DISTORTION/ LOW SPOTS. *TT
Bulletin Number: 2300602
CONCERNS WITH WATER LEAK AT GRAB HANDLE. *TT
Bulletin Number: 2300602A
A CONDITION MAY EXIST WHERE WATER LEAKS AT THE GRAB HANDLE. *TT
Bulletin Number: 2301307
TRAILER TOWING MIRROR - NEW MIRROR GLASS LOCKING TAB - NEW REMOVAL PROCEDURE. *KB
Bulletin Number: 2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
Bulletin Number: 2301502
SUBJECT REGARDING THE OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
Bulletin Number: 2302101
INFORMATION REGARDING BODY FITS. *SLC
Bulletin Number: 2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
Bulletin Number: 2303301
CUSTOMERS MAY NOTICE A SLIGHT ROCKING OR CHUCKING MOVEMENT IN THE SEAT TRACK WHEN THE CUSTOMER ACCELERATES THE VEHICLE OR APPLIES THE BRAKES. *TT
Bulletin Number: 2303502
INFORMATION ON ADDITIONAL PLASTIC RETAINERS TO SECURE THE GRILLE GUARD PLASTIC COVER TO THE VERTICAL BAR. *TT
Bulletin Number: 2303602
A CONDITION MAY EXIST WHERE WATER LEAKS FROM THE REAR WINDOW (BACK LIGHT). *TT
Bulletin Number: 2500106
POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM FREEZES IN EXTREME COLD AMBIENT TEMPERATURES. *TT
Bulletin Number: 2500108
POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM FREEZES IN EXTREME COLD AMBIENT TEMPERATURES -- INVOLVES INSTALLING REVISED PCV SYSTEM COMPONENTS. *NJ
Bulletin Number: 30800203
CONDENSER FAN INOPERATIVE DUE TO OPEN FUSE. *TT
Bulletin Number: 4850306
INFORMATION ON RKE TRANSMITTER PROGRAMMING. *SLC
Bulletin Number: 4850306
INFORMATION ON TRAILER TOW WIRING. *SLC
2002 DODGE RAM 1500
Bulletin Number: 05002
NEW WATER PUMP FOR 3.7L ENGINE - NO LONGER COMMON WITH 4.7L. ADVANCED SERVICE INFORMATION #05-002. *TT
Bulletin Number: 082702
FINAL FITMENT OF THIS SUSPENSION KIT HAS REVEALED A POTENTIAL INTERFERENCE BETWEEN THE SUPPLIED TIE ROD END AND THE FACTORY WHEEL WHICH DOES NOT ALLOW THE O.E. WHEELS TO BE RE-USED. RANCHO IS RECOMMENDING 17 X 18 INCH WHEEL WITH 5 INCHES
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: 9002828
Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator, attaching rivet and an instruction sheet are now available as a kit. If the insulator requires replacement lease order 68253
Bulletin Number: 9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement
Bulletin Number: 9002901
Part Description: Seal - Shift Shaft on RFE transmissions Issue Description: This seal (04799346) is replaceable with Seal Kit (68235551AA), which includes a seal and retainer. The Seal Kit is applicable to all (5)45RFE transmissions.
2002 DODGE RAM 2500
Bulletin Number: 0408
ORIGINAL MINUTE MOUNT WIRING AND E-FORCE ISOLATION MODULE WIRING CONVERSIONS. FISHER. VARIOUS MODELS INCLUDING ALL GM/CHEVROLET AND FORD. 2002 & PRIOR. *TT
Bulletin Number: 05002
NEW WATER PUMP FOR 3.7L ENGINE - NO LONGER COMMON WITH 4.7L. ADVANCED SERVICE INFORMATION #05-002. *TT
Bulletin Number: 07
EMISSIONS RECALL E07-CANISTER PURGE HOSES. THE CANISTER PURGE HOSES ON ABOUT 7,800 OF THE ABOVE VEHICLES MAY DEVELOP CRACKS OVER TIME AND RELEASE EVAPORATIVE HYDROCARBON (HC) WHICH COULD EXCEED FEDERAL EMISSION STANDARDS. *SC
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: 9002828
Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator, attaching rivet and an instruction sheet are now available as a kit. If the insulator requires replacement lease order 68253
Bulletin Number: 9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement
Bulletin Number: 9002872
56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2 required to attach Neutral Start Switch
Bulletin Number: 9002901
Part Description: Seal - Shift Shaft on RFE transmissions Issue Description: This seal (04799346) is replaceable with Seal Kit (68235551AA), which includes a seal and retainer. The Seal Kit is applicable to all (5)45RFE transmissions.
2002 DODGE RAM 3500
Bulletin Number: 0408
ORIGINAL MINUTE MOUNT WIRING AND E-FORCE ISOLATION MODULE WIRING CONVERSIONS. FISHER. VARIOUS MODELS INCLUDING ALL GM/CHEVROLET AND FORD. 2002 & PRIOR. *TT
Bulletin Number: 14-005-12
Heavy Duty Filtration MOPAR Retrofit or Add On Parts Available
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: 9002828
Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator, attaching rivet and an instruction sheet are now available as a kit. If the insulator requires replacement lease order 68253
Bulletin Number: 9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement
Bulletin Number: 9002872
56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2 required to attach Neutral Start Switch
2002 DODGE RAM CLUB CAB
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
2002 DODGE RAM PICKUP
Bulletin Number: 07
EMISSIONS RECALL E07-CANISTER PURGE HOSES. THE CANISTER PURGE HOSES ON ABOUT 7,800 OF THE ABOVE VEHICLES MAY DEVELOP CRACKS OVER TIME AND RELEASE EVAPORATIVE HYDROCARBON (HC) WHICH COULD EXCEED FEDERAL EMISSION STANDARDS. *SC
Bulletin Number: 0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
Bulletin Number: 0801003
SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS. *TT
Bulletin Number: 0801701
SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR. *TT
Bulletin Number: 1400203
DIESEL FUEL TRANSFER PUMP DIAGNOSIS. *TT
Bulletin Number: 1900805
REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC
Bulletin Number: 2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
Bulletin Number: 9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement
2002 DODGE RAM QUAD CAB
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
2002 DODGE RAM VAN
Bulletin Number: 0500601
SUBJECT REGARDING DISCOLORED BRAKE FLUID. *TT
Bulletin Number: 0703
PROCEDURES FOR SERVICING THE SEAT BELT LATCH PLATE CINCH BAR. *TT
Bulletin Number: 0800702
SUBJECT REGARDING REMOTE KEYLESS ENTRY PROGRAMMING PROCEDURES. *SLC
Bulletin Number: 0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
Bulletin Number: 0801003
SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS. *TT
Bulletin Number: 0801601
INFORMATION REGARDING VEHICLES EQUIPPED WITH RADIOS WILL HAVE A NEW LOCKING RADIO ANTENNA CONNECTOR. *SLC
Bulletin Number: 0801701
SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR. *TT
Bulletin Number: 0802303
INTERMITTENT LOCKING/UNLOCKING OF DOORS WITHOUT ACTIVATING THE POWER DOOR LOCK SWITCH. *TT
Bulletin Number: 0900602
CUSTOMER MAY COMPLAIN OF LOW COOLANT, COOLANT SMELL, WHITE SMOKE, MISFIRES, MALFUNCTION INDICATOR LAMP ON AND A CRACKED OR BROKEN SPARK PLUG. *TT
Bulletin Number: 10023
STEERING COLUMN SERVICE. INFORMATION. SERVICE INFORMATION TUNEUPS. *TT
Bulletin Number: 1400102
SUBJECT REGARDING FUEL CAP DIFFICULT TO REMOVE. *SLC
Bulletin Number: 1400102A
FUEL CAP DIFFICULT TO REMOVE. *TT
Bulletin Number: 1800202
ONWERS OF CERTAIN VEHICLES EQUIPPED WITH 9.25 AXLE MAY COMPLAIN THAT VEHICLE SPEED IS INACCURATE. *TT
Bulletin Number: 1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 2100202
SUBJECT REGARDING REVISION IN DIAGNOSTIC PROCEDURES AND LABOR OPERATION TIMES FOR RE TRANSMISSIONS. *TT
Bulletin Number: 2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
Bulletin Number: 2200102
CHROME WHEEL CARE. *SLC
Bulletin Number: 2301502
SUBJECT REGARDING THE OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
Bulletin Number: 2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
Bulletin Number: 2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
Bulletin Number: 2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
2002 DODGE RAM WAGON
Bulletin Number: 0500601
SUBJECT REGARDING DISCOLORED BRAKE FLUID. *TT
Bulletin Number: 0800702
SUBJECT REGARDING REMOTE KEYLESS ENTRY PROGRAMMING PROCEDURES. *SLC
Bulletin Number: 0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
Bulletin Number: 0801003
SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS. *TT
Bulletin Number: 0801701
SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR. *TT
Bulletin Number: 0802303
INTERMITTENT LOCKING/UNLOCKING OF DOORS WITHOUT ACTIVATING THE POWER DOOR LOCK SWITCH. *TT
Bulletin Number: 1400102
SUBJECT REGARDING FUEL CAP DIFFICULT TO REMOVE. *SLC
Bulletin Number: 1400102A
FUEL CAP DIFFICULT TO REMOVE. *TT
Bulletin Number: 1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
Bulletin Number: 2200102
CHROME WHEEL CARE. *SLC
Bulletin Number: 2301502
SUBJECT REGARDING THE OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
Bulletin Number: 2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
Bulletin Number: 2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
Bulletin Number: 2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
Bulletin Number: 9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement
Bulletin Number: 9002872
56045489A$ - Neutral Safety Switch - Trans Assy 06036369AA Screw and Washer is now available as a service part , 2 required to attach Neutral Start Switch
Bulletin Number: 9002901
Part Description: Seal - Shift Shaft on RFE transmissions Issue Description: This seal (04799346) is replaceable with Seal Kit (68235551AA), which includes a seal and retainer. The Seal Kit is applicable to all (5)45RFE transmissions.
2002 DODGE SPIRIT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
2002 DODGE SPRINTER 2500
Bulletin Number: 0711
REAR AXLE REPAIR VS. REPLACE PROCEDURE CHANGE. *KB
2002 DODGE SPRINTER 3500
Bulletin Number: 0711
REAR AXLE REPAIR VS. REPLACE PROCEDURE CHANGE. *KB
2002 DODGE STRATUS
Bulletin Number: 02001
RAPID RESPONSE TRANSMITAL REGARDING CONSOLE 12V POWER OUTLET INOPERATIVE. *TT
Bulletin Number: 02012
SOME VEHICLES MAY EXPERIENCE A SLIPPING OR NO DRIVE CONDITION IN REVERSE OR FIRST GEAR. *TT
Bulletin Number: 02012
SOME VEHICLES MAY EXPERIENCE A SLIPPING OR NO DRIVE CONDITION IN REVERSE OR FIRST GEAR. *TT
Bulletin Number: 02020
DELAYED TRANSAXLE ENGAGEMENT AFTER INITIAL START UP. *TT
Bulletin Number: 06
ENGINE VACUUM HOSE ROUTING LABEL REPLACEMENT. *TT
Bulletin Number: 0700202
SUBJECT REGARDING LOW OR NO CABIN HEAD, ENGINE COOLING SYSTEM SYSTEM FILL PROCEDURE. *TT
Bulletin Number: 0700202
A VEHICLE MAY EXHIBIT LOW OR NO CABIN HEAT, ENGINE OVERHEATING AND / OR COOLANT BOTTLE DAMAGE AFTER SERVICE HAS BEEN PERFORMED ON THE ENGINE COOLING SYSTEM. *TT
Bulletin Number: 0800303A
SENTRY KEY - KEY IMMOBILIZER SECURITY SYSTEM. *TT THIS BULLETIN REPLACES 08-003-03 REV A. *TT
Bulletin Number: 0800702
SUBJECT REGARDING REMOTE KEYLESS ENTRY PROGRAMMING PROCEDURES. *SLC
Bulletin Number: 0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
Bulletin Number: 0801003
SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS. *TT
Bulletin Number: 0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
Bulletin Number: 0801601
INFORMATION REGARDING VEHICLES EQUIPPED WITH RADIOS WILL HAVE A NEW LOCKING RADIO ANTENNA CONNECTOR. *SLC
Bulletin Number: 0801701
SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR. *TT
Bulletin Number: 0802001
SUBJECT REGARDING REMOTE KEYLESS ENTRY AND IMMOBILIZER SYSTEM CHANGES. *SLC
Bulletin Number: 0802601
SOME VEHICLES MAY EXHIBIT A FLICKERING TRIP COMPUTER AND/OR RADIO DISPLAY, INSTRUMENT PANEL ILLUMINATION, AND/OR OVERHEAD/DOME LIGHTS. *TT
Bulletin Number: 0802804
INTERMITTENT LOSS OF ACCESSORIES (IG1 CIRCUIT) ON INITIAL VEHICLE START. *TT
Bulletin Number: 0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
Bulletin Number: 080403
CONTROL SOLENOIDS FAILURE IN VACUUM HARNESS TURBOCHARGED ENGINES DUE TO OPEN CIRCUIT. 2001 - 2003 CIRRUS ALSO INCLUDED. *TT
Bulletin Number: 0900704
IRREGULAR ENGINE SNAPPING SOUND. *TT
Bulletin Number: 0901104
INCORRECT OIL FILTER USAGE. ALSO INCLUDES 2005 SEBRING AND STRATUS. *TT
Bulletin Number: 1400102
SUBJECT REGARDING FUEL CAP DIFFICULT TO REMOVE. *SLC
Bulletin Number: 1400102A
FUEL CAP DIFFICULT TO REMOVE. *TT
Bulletin Number: 1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
Bulletin Number: 1801405
FLASH: MIL ILLUMINATION DIAGNOSTIC TROUBLE CODES (DTC/DIAGNOSTIC TROUBLE CODE) P0300, P0301, P0302, P0302, P0303, P0304, P0305, P0306-COLD START MISFIRE. *SC
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 1802701
SOME VEHICLES MAY EXHIBIT MODERATE TO SEVERE HIGH WAY SPEED 45-60 MPH VEHICLE SURGE. *TT
Bulletin Number: 1802802
MIL ILLUMINATION - MISFIRE DIAGNOSTIC TROUBLE CODE (DTCS) P0300, P0301, P0302, P0303, P0304. *TT
Bulletin Number: 1900304
STEERING COLUMN CLICK SOUND. *TT
Bulletin Number: 1900402
SUBJECT REGARDING STEERING COLUMN CLICK SOUND. *SLC
Bulletin Number: 1900701
INFORMATION ON NEW POWER STEERING FLUID.*SLC
Bulletin Number: 1900702
LOWER STEERING COLUMN CLICK SOUND. *TT
Bulletin Number: 1900805
REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC
Bulletin Number: 2100102
SOME VEHICLES MAY HAVE A TRANSAXLE THAT WILL NOT MOVE OR SLIPS IN REVERSE OR FIRST GEAR. *TT
Bulletin Number: 2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
Bulletin Number: 2100903
AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE. VARIOUS MODELS INCLUDING THE 2004 RAM TRUCK, DURANGO, SEBRING CONVERTIBLE, CHEROKEE, VISION, NEON, AND VOYAGER. *TT *SC
Bulletin Number: 2200102
CHROME WHEEL CARE. *SLC
Bulletin Number: 2300102
SUBJECT REGARDING FRONT DOOR TRIM PANEL RETENTION/WARPED ALONG BELT LINE CONDITION. *TT
Bulletin Number: 2301203
POP/CLUNK SOUND FROM FRONT OF VEHICLE. *TT THIS BULLETIN SUPERSEDES BULLETIN 23-012-03 DATED 05/23/2004. *TT
Bulletin Number: 2301403
WHEN CYCLING DOOR GLASS UP AND DOWN, A CLICKING NOISE CAN BE HEARD WHEN THE WINDOW TRAVEL CHANGES DIRECTION ON VARIOUS MODELS INCLUDING THE 2004 SEBRING SEDAN AND SEBRING CONVERTIBLE. *TT
Bulletin Number: 2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
Bulletin Number: 2301701
SUBJECT REGARDING WATER LEAK INFORMATION. *TT
Bulletin Number: 2302302
SOME VEHICLES MAY EXPERIENCE THE VINYL SURFACE OF THE INSTRUMENT PANEL BEING DAMAGED OR BLEMISHED. *SLC
Bulletin Number: 2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
Bulletin Number: 2302801A
ON SOME VEHCLES, THE POWER SEAT HAS SLIGHT FORE/AFT MOVEMENT MOST NOTICEABLE DURING ACCELERATION OR BRAKING. *TT
Bulletin Number: 2303204
POWER SEAT WILL NOT ADJUST. *TT
Bulletin Number: 2400103
WINDOWS MAY BEGIN TO FOG WHEN THE HVAC IS IN FLOOR MODE. *TT
Bulletin Number: 2400105
BLOWER MOTOR DOES NOT RUN ON EVERY SPEED. *TT
Bulletin Number: 2400204
AIR CONDITIONER AND HEATER PERFORMANCE. *TT
Bulletin Number: 2401001
EXPERIENCING HONK OR FOG HORN SOUND COMING FROM THE A/C EXPANSION VALVE. *TT
Bulletin Number: 2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
Bulletin Number: 27
THE TRANSAXLE LOW/REVERSE ACCUMULATOR COVER O-RING ON CERTAIN VEHICLES MAY BECOME DISLODGED. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
2002 DODGE STRATUS COUPE
Bulletin Number: 0200202
SUBJECT REGARDING A FRONT STRUT SPRING RATTLE SOUND. *SLC
Bulletin Number: 0800502
SUBJECT REGARDING INTERIOR LIGHTS OR ACCESSORIES NOT FUNCTIONING. *SLC
Bulletin Number: 0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
Bulletin Number: 0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
Bulletin Number: 0801701
SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR. *TT
Bulletin Number: 14
ELECTRICAL FEATURE CHANGES. *TT
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 1802202
MALFUNCTION INDICATOR LAMP ON DUE TO ERRONEOUS DETECTION OF MISFIRE CODES. *TT UPDATE. *TT
Bulletin Number: 2100302
THIS BULLETIN PROVIDES INFORMATION ABOUT ATF+4 USAGE. *TT
Bulletin Number: 2200102
CHROME WHEEL CARE. *SLC
Bulletin Number: 2302901
SOME SUNROOF EQUIPPED VEHICLES MAY EXHIBIT SUNROOF GLASS SHUDDER WHEN THE GLASS IS OPENING OR NOT FULLY CLOSED. *TT
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
2002 DODGE VAN
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
2002 DODGE VIPER
Bulletin Number: 010103
TRANSMISSION AND CLUTCH KIT. GPOP - ISSUE REVIEW SYSTEM. *TT
Bulletin Number: 0500601
SUBJECT REGARDING DISCOLORED BRAKE FLUID. *TT
Bulletin Number: 0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
Bulletin Number: 0801601
INFORMATION REGARDING VEHICLES EQUIPPED WITH RADIOS WILL HAVE A NEW LOCKING RADIO ANTENNA CONNECTOR. *SLC
Bulletin Number: 0801701
SUBJECT REGARDING SAFETY SYSTEMS - VEHICLE MODIFICATIONS / REPAIR. *TT
Bulletin Number: 10023
POWERTRAIN DIAGNOSTIC INFORMATION. SERVICE INFORMATION TUNEUPS. *TT
Bulletin Number: 1801903
ENGINE SPARK KNOCK USING 91 OCTANE GASOLINE. *TT
Bulletin Number: 1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
Bulletin Number: 31-001-16
Do Not Apply Corrosion Protection On Sheet Molding Compound (SMC) Plastic Panels This bulletin involves discussing SMC plastic panels and applying corrosion protection.
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
2002 DODGE VIPER ROADSTER
Bulletin Number: 9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc

 

Recalls for 2002 Dodge

2002 DODGE 3500
NHTSA Campaign ID:TRAILER HITCHES
Manufacturer:KNAPHEIDE MANUFACTURING COMPANY
Manufacture Dates:10/23/2006 - 07/15/2008
Potential Units Affected:108

Defect Description:

KNAPHEIDE IS RECALLING 108 MY 2006-2008 PRO SERIES TRUCK BEDS EQUIPPED WITH AN ICC BUMPER WHICH INCLUDED A PROVISION FOR A BALL HITCH. THERE MAY BE AN INSUFFICIENT WELD ATTACHING THE HITCH CHANNEL TO THE SUPPORTING STRUCTURE.

Consequence:

THIS COULD RESULT IN BENDING OF THE HITCH CHANNEL OR THE HITCH COULD BE PULLED OFF THE VEHICLE, INCREASING THE RISK OF A CRASH.

Action:

KNAPHEIDE WILL OFFER TWO REMEDIES TO ITS CUSTOMERS: (1) FOR THOSE CUSTOMERS WHO DO NOT USE THE HITCH, THE HITCH WILL BE REMOVED FROM THE TRUCK BED AND REPLACED WITH AN ICC BUMPER; OR (2) FOR THOSE CUSTOMERS WHO NEED A HITCH, A RECEIVER HITCH ASSEMBLY WILL BE ADDED TO THE EXISTING HITCH ASSEMBLY AND ALL SUSPECT WELD JOINTS WILL BE RE WELDED. THE RECALL BEGAN ON AUGUST 15, 2008. OWNERS MAY CONTACT KNAPHEIDE AT 1-877-473-5763.
2002 DODGE CARAVAN
NHTSA Campaign ID:STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:10/01/2001 - 08/01/2003
Potential Units Affected:681000

Defect Description:

ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.

Consequence:

POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.

Action:

DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2002 DODGE CARAVAN
NHTSA Campaign ID:EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:04/27/2001 - 07/31/2002
Potential Units Affected:238000

Defect Description:

ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.

Consequence:

THIS COULD RESULT IN A SPEAKER FIRE.

Action:

DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2002 DODGE CARAVAN
NHTSA Campaign ID:CHILD SEAT
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:02/01/2001 - 09/07/2001
Potential Units Affected:52649

Defect Description:

VEHICLE DESCRIPTION: CERTAIN MINI VANS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER MANUALS SUPPLIED WITH THESE VEHICLES DO NOT INDICATE WHICH SEATING POSITIONS ARE EQUIPPED WITH TETHER ANCHORAGES AND CHILD RESTRAINT ANCHORAGE SYSTEMS AS REQUIRED BY THE STANDARD.

Consequence:

IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.

Action:

OWNERS WILL BE PROVIDED WITH THE NECESSARY CHILD RESTRAINT SYSTEM INFORMATION. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 8, 2001. OWNERS WHO DO NOT RECEIVE THE FREE INFORMATION WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2002 DODGE CARAVAN
NHTSA Campaign ID:STRUCTURE
Manufacturer:SOUTHERN COMFORT CONVERSIONS
Manufacture Dates:08/01/2000 - 03/03/2003
Potential Units Affected:3674

Defect Description:

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.

Consequence:

THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.

Action:

DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
2002 DODGE DAKOTA
NHTSA Campaign ID:VISIBILITY:WINDSHIELD WIPER/WASHER
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:04/24/2002 - 09/15/2003
Potential Units Affected:320188

Defect Description:

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.

Consequence:

DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.

Action:

DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2002 DODGE DAKOTA
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
Manufacturer:CHRYSLER LLC
Manufacture Dates:07/01/2000 - 07/18/2002
Potential Units Affected:576418

Defect Description:

ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK" POSITION). THIS CAN ALSO ALLOW THE IGNITION KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE "PARK" POSITION.

Consequence:

EITHER OF THESE CONDITIONS COULD ALLOW THE VEHICLE TO ROLL AWAY CAUSING A CRASH WITHOUT WARNING.

Action:

DEALERS WILL REPLACE THE GEARSHIFT BLOCKER AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
2002 DODGE DAKOTA
NHTSA Campaign ID:ELECTRICAL SYSTEM:WIRING
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:07/01/2000 - 07/31/2003
Potential Units Affected:50082

Defect Description:

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, THE HEADLAMP AND DASH WIRING HARNESS MAY BE CHAFED BY THE ACTUATION OF THE CLUTCH PEDAL. THIS COULD RESULT IN ABNORMAL OPERATION OF THE WIPERS, TURN SIGNALS, HORN OR LIGHTING SYSTEMS.

Consequence:

THIS COULD AFFECT DRIVER VISIBILITY, COULD PREVENT A DRIVER FROM SOUNDING A WARNING BY USING THE HORN, AND, WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL REROUTE THE WIRE HARNESS AND REPAIR THE HARNESS IF NECESSARY. OWNER NOTIFICATION BEGAN NOVEMBER 3, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
2002 DODGE DAKOTA
NHTSA Campaign ID:EQUIPMENT:OTHER:LABELS
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:07/01/2000 - 07/31/2002
Potential Units Affected:35692

Defect Description:

ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Consequence:

IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.

Action:

OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
2002 DODGE DAKOTA
NHTSA Campaign ID:SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:01/07/1999 - 12/31/2002
Potential Units Affected:592707

Defect Description:

ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.

Consequence:

EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.

Action:

DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2002 DODGE DURANGO
NHTSA Campaign ID:ELECTRICAL SYSTEM
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:06/01/2000 - 07/01/2003
Potential Units Affected:35103

Defect Description:

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH FRONT BENCH SEATS ONLY, IF FLUID IS SPILLED FROM THE FLOOR MOUNTED CUP HOLDER, AN UNUSED CONSOLE POWER OUTLET CONNECTOR LOCATED UNDER THE SEAT MAY BECOME CONTAMINATED.

Consequence:

THIS MAY ALLOW DEVELOPMENT OF A HIGH RESISTIVE SHORT CIRCUIT IN THE CONNECTOR, WHICH COULD EVENTUALLY LEAD TO A FIRE.

Action:

DEALERS WILL INSPECT THE CONSOLE WIRING CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT ADDITIONAL FLUID FROM CONTAMINATING THE CONNECTOR FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 30, 2006. OWNERS MAY CONTACT DAIMLER CHRYSLER AT 1-800-853-1403.
2002 DODGE DURANGO
NHTSA Campaign ID:SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:01/07/1999 - 12/31/2002
Potential Units Affected:592707

Defect Description:

ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.

Consequence:

EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.

Action:

DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2002 DODGE DURANGO
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
Manufacturer:CHRYSLER LLC
Manufacture Dates:07/01/2000 - 07/18/2002
Potential Units Affected:576418

Defect Description:

ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK" POSITION). THIS CAN ALSO ALLOW THE IGNITION KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE "PARK" POSITION.

Consequence:

EITHER OF THESE CONDITIONS COULD ALLOW THE VEHICLE TO ROLL AWAY CAUSING A CRASH WITHOUT WARNING.

Action:

DEALERS WILL REPLACE THE GEARSHIFT BLOCKER AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
2002 DODGE DURANGO
NHTSA Campaign ID:VISIBILITY:WINDSHIELD WIPER/WASHER
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:04/24/2002 - 08/21/2003
Potential Units Affected:320188

Defect Description:

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.

Consequence:

DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.

Action:

DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2002 DODGE GRAND CARAVAN
NHTSA Campaign ID:CHILD SEAT
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:02/01/2001 - 09/07/2001
Potential Units Affected:52649

Defect Description:

VEHICLE DESCRIPTION: CERTAIN MINI VANS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER MANUALS SUPPLIED WITH THESE VEHICLES DO NOT INDICATE WHICH SEATING POSITIONS ARE EQUIPPED WITH TETHER ANCHORAGES AND CHILD RESTRAINT ANCHORAGE SYSTEMS AS REQUIRED BY THE STANDARD.

Consequence:

IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.

Action:

OWNERS WILL BE PROVIDED WITH THE NECESSARY CHILD RESTRAINT SYSTEM INFORMATION. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 8, 2001. OWNERS WHO DO NOT RECEIVE THE FREE INFORMATION WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2002 DODGE GRAND CARAVAN
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:09/01/2001 - 03/11/2002
Potential Units Affected:116029

Defect Description:

ON CERTAIN MINI VANS, THE FUEL TANK CONTROL VALVE WELD JOINT COULD SEPARATE RESULTING IN A POSSIBLE FUEL LEAK.

Consequence:

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERBODY FIRE.

Action:

DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY. OWNER NOTIFICATION BEGAN OCTOBER 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2002 DODGE GRAND CARAVAN
NHTSA Campaign ID:STRUCTURE
Manufacturer:SOUTHERN COMFORT CONVERSIONS
Manufacture Dates:08/01/2000 - 03/03/2003
Potential Units Affected:3674

Defect Description:

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.

Consequence:

THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.

Action:

DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
2002 DODGE GRAND CARAVAN
NHTSA Campaign ID:STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:10/01/2001 - 08/01/2003
Potential Units Affected:681000

Defect Description:

ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.

Consequence:

POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.

Action:

DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2002 DODGE GRAND CARAVAN
NHTSA Campaign ID:EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:04/27/2001 - 07/31/2002
Potential Units Affected:238000

Defect Description:

ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.

Consequence:

THIS COULD RESULT IN A SPEAKER FIRE.

Action:

DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2002 DODGE INTREPID
NHTSA Campaign ID:SEATS:FRONT ASSEMBLY:RECLINER
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:09/01/1997 - 04/27/2002
Potential Units Affected:1066000

Defect Description:

ON CERTAIN PASSENGER VEHICLES, SEAT BACK RECLINER BOLT BREAKAGE CAN OCCUR RESULTING IN THE SEAT BACK RECLINING UNEXPECTEDLY.

Consequence:

IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL REPLACE THE RECLINER BOLTS. OWNER NOTIFICATION BEGAN ON APRIL 23, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2002 DODGE RAM
NHTSA Campaign ID:POWER TRAIN:AXLE ASSEMBLY
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:07/01/2001 - 11/30/2001
Potential Units Affected:46000

Defect Description:

ON CERTAIN 4X4 PICKUP TRUCKS, THE REAR AXLE FLANGE WELD TO THE AXLE TUBE COULD FATIGUE AND ALLOW THE BRAKE CALIPER ASSEMBLY TO ROTATE.

Consequence:

DURING ROTATION, THE BRAKE LINE COULD SEPARATE FROM THE CALIPER RESULTING IN A BRAKE FLUID LOSS IN THE REAR BRAKE HYDRAULIC SYSTEM.

Action:

DEALERS WILL INSTALL REAR BRAKE CALIPER REINFORCEMENTS ON THE REAR AXLE ASSEMBLIES. OWNER NOTIFICATION BEGAN DECEMBER 9, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2002 DODGE RAM
NHTSA Campaign ID:SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:07/01/1997 - 06/30/2003
Potential Units Affected:44588

Defect Description:

ON CERTAIN VAN AND WAGON VEHICLES EQUIPPED WITH 4-WHEEL ANTILOCK BRAKE SYSTEMS (ABS), AFTERMARKET BATTERIES MAY LEAK ELECTROLYTE ONTO THE ABS CONTROL MODULE CONNECTOR, WHICH CAN COMPROMISE SEALING INTEGRITY OF THE CONNECTOR.

Consequence:

THIS MAY ALLOW DEVELOPMENT OF A SHORT CIRCUIT IN THE CONNECTOR, WHICH COULD EVENTUALLY LEAD TO A FIRE.

Action:

DEALERS WILL INSPECT THE ABS CONTROL MODULE CONNECTOR FOR ELECTROLYTE DAMAGE AND REPLACE THE CONNECTOR AS NECESSARY. THE RECALL WILL BEGIN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2002 DODGE RAM 1500
NHTSA Campaign ID:STEERING:COLUMN
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:07/01/2001 - 07/01/2002
Potential Units Affected:287725

Defect Description:

ON CERTAIN PICKUP TRUCKS, THE ELECTRICAL CONNECTOR AT THE BOTTOM OF THE STEERING COLUMN CONTAINS AN UNDER-SIZED TERMINAL FOR THE HVAC BLOWER MOTOR CIRCUIT. LOCALIZED HEATING FROM CURRENT FLOW WITH THE BLOWER SPEED SET ON HIGH MAY CAUSE THE TERMINAL CONTACTS TO RELAX AND LOSE ELECTRICAL CONTACT. THIS CAN CAUSE THE HVAC BLOWER MOTOR TO BECOME INOPERATIVE.

Consequence:

THIS CONDITION COULD CAUSE IMPAIRMENT OF VISIBILITY IN INCLEMENT WEATHER, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL INSTALL A WIRING HARNESS OVERLAY TO CORRECT THIS CONDITION. OWNER NOTIFICATION BEGAN APRIL 15, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2002 DODGE RAM 1500
NHTSA Campaign ID:VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:03/02/2001 - 04/18/2003
Potential Units Affected:195500

Defect Description:

ON CERTAIN PICKUP TRUCKS, THE DETENT SYSTEM ON THE EXTERIOR MIRROR HOUSINGS MAY LOSE THE FUNCTIONALITY.

Consequence:

THIS COULD POTENTIALLY AFFECT REARWARD FIELD OF VISION, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL INSTALL A MIRROR DETENT RETAINER KIT TO CORRECT THIS CONDITION. OWNER NOTIFICATION BEGAN ON APRIL 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
2002 DODGE RAM 1500
NHTSA Campaign ID:TIRES
Manufacturer:DAIMLERCHRYSLER CORPORATION
Manufacture Dates:07/01/1999 - 07/31/2001
Potential Units Affected:214

Defect Description:

ON CERTAIN 4X4 PICKUP TRUCKS EQUIPPED WITH THE SNOW PLOW PREPARATION PACKAGE, THE TIRES SUPPLIED ON SOME VEHICLES MAY HAVE GROSS AXLE WEIGHT RATINGS THAT SLIGHTLY EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Consequence:

Action:

DEALERS WILL PROVIDE REPLACEMENT P245/75R16 TIRES TO MEET THE LOAD CARRYING CAPACITY SPECIFIED ON THE VEHICLE CERTIFICATION LABEL AND ACCOMMODATE THE ADDITION OF A COMMERCIALLY AVAILABLE SNOW PLOW AND HARDWARE. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
2002 DODGE RAM PICKUP
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
Manufacturer:CHRYSLER LLC
Manufacture Dates:07/01/2001 - 07/05/2002
Potential Units Affected:576418

Defect Description:

ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK" POSITION). THIS CAN ALSO ALLOW THE IGNITION KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE "PARK" POSITION.

Consequence:

EITHER OF THESE CONDITIONS COULD ALLOW THE VEHICLE TO ROLL AWAY CAUSING A CRASH WITHOUT WARNING.

Action:

DEALERS WILL REPLACE THE GEARSHIFT BLOCKER AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
2002 DODGE RAM VAN
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
Manufacturer:CHRYSLER LLC
Manufacture Dates:07/01/2000 - 07/18/2002
Potential Units Affected:576418

Defect Description:

ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK" POSITION). THIS CAN ALSO ALLOW THE IGNITION KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE "PARK" POSITION.

Consequence:

EITHER OF THESE CONDITIONS COULD ALLOW THE VEHICLE TO ROLL AWAY CAUSING A CRASH WITHOUT WARNING.

Action:

DEALERS WILL REPLACE THE GEARSHIFT BLOCKER AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
2002 DODGE SPRINTER 2500
NHTSA Campaign ID:STEERING:COLUMN
Manufacturer:SPRINTER ENGINEERING & COMPLIANCE SUPPOR
Manufacture Dates:11/01/2007 - 11/30/2007
Potential Units Affected:10

Defect Description:

SPRINTER IS RECALLING 10 MY 2001-2006 DODGE AND FREIGHTLINER 2500 AND 3500 VEHICLES. THE WELDING SEAM BETWEEN THE BRACKET AND STEERING COLUMN OF AFFECTED SPARE PARTS DOES NOT MEET DESIGN SPECIFICATIONS. THE RESULT OF AN OUT OF SPECIFICATION WELDING SEAM IS THAT THE STEERING COLUMN MAY DETACH FROM ITS INTERIOR VEHICLE MOUNTING BRACKET.

Consequence:

THE OPERATOR MAY LOSE STEERING ABILITY OF THE VEHICLE INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL INSPECT AND REPLACE THE STEERING COLUMNS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 16, 2009. OWNERS MAY CONTACT SPRINTER AT 843-695-5057.
2002 DODGE SPRINTER 2500
NHTSA Campaign ID:INTERIOR LIGHTING
Manufacturer:DAIMLERCHRYSLER MANUFACTURING INTL
Manufacture Dates:01/30/2001 - 10/07/2006
Potential Units Affected:4433

Defect Description:

ON CERTAIN TRUCKS EQUIPPED WITH REAR AIR CONDITIONING SYSTEM, THE INTERIOR LAMP IS EQUIPPED WITH AN 18W LAMP AND A SCATTERING LENS. IN EXTREMELY HOT AND HUMID CONDITIONS, THE COMBINATION OF HEAT AND HUMIDITY, AND THE HEAT FROM THE LAMP DUE TO EXTREME LONG TERM OPERATION, CAN DISTORT THE SCATTERING LENS.

Consequence:

THE SWITCHING CONTACTS OF THE LAMP MAY CAUSE A SHORT CIRCUIT OF THE REAR LAMP INCREASING THE RISK OF A FIRE.

Action:

DEALERS WILL REPLACE THE REAR INTERIOR LAMPS FREE OF CHARGE WITH A MODIFIED VERSION WHICH IS NOT SUBJECT TO THE IMPACTS OF HEAT AND HUMIDITY. THE RECALL BEGAN ON DECEMBER 17, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER MANUFACTURING INTERNATIONAL AT 1-843-695-5041.
2002 DODGE SPRINTER 2500
NHTSA Campaign ID:ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Manufacturer:SPRINTER ENGINEERING & COMPLIANCE SUPPOR
Manufacture Dates: -
Potential Units Affected:665

Defect Description:

MERCEDES-BENZ USA (MBUSA) IS RECALLING CERTAIN MODEL YEAR 2002- 2003 SPRINTER 2500 AND 3500 VANS SOLD AS DODGE AND FREIGHTLINER VEHICLES. THE INTAKE MANIFOLDS MAY HAVE CORRODED. A CHEMICAL REACTION INVOLVING SULFUR IN THE DIESEL FUEL THAT TAKES PLACE UNDER CERTAIN CONDITIONS CAN LEAD TO THE FORMATION OF SULFURIC ACID IN THE EXHAUST CHANNEL OF THE INTAKE MANIFOLD.

Consequence:

INTAKE MANIFOLD CORROSION MAY LEAD TO AN EXHAUST GAS LEAK, DAMAGE TO THE FUEL RETURN LINE WHICH COULD CAUSE A FUEL LEAK, AND HEAT DAMAGE TO THE INSULATION AT THE FIRE WALL. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Action:

DEALERS WILL INSPECT AND REPLACE THE INTAKE MANIFOLD FREE OF CHARGE. CHRYSLER, LLC WILL NOTIFY OWNERS OF DODGE SPRINTERS AND MBUSA WILL NOTIFY OWNERS FREIGHTLINER SPRINTERS. THIS RECALL IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE RECALL CAMPAIGN 09V-418). THE SAFETY RECALL BEGAN ON OCTOBER 11, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403 OR SPRINTER AT 1-843-695-5031.
2002 DODGE SPRINTER 2500
NHTSA Campaign ID:ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Manufacturer:SPRINTER ENGINEERING & COMPLIANCE SUPPOR
Manufacture Dates:10/01/2001 - 09/30/2003
Potential Units Affected:14423

Defect Description:

SPRINTER IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2003 VANS SOLD AS DODGE AND FREIGHTLINER VEHICLES. THE INTAKE MANIFOLDS MAY HAVE CORRODED. A CHEMICAL REACTION INVOLVING SULFUR IN THE DIESEL FUEL THAT TAKES PLACE UNDER CERTAIN CONDITIONS CAN LEAD TO THE FORMATION OF SULFURIC ACID IN THE EXHAUST CHANNEL OF THE INTAKE MANIFOLD.

Consequence:

INTAKE MANIFOLD CORROSION MAY LEAD TO AN EXHAUST GAS LEAK, DAMAGE TO THE FUEL RETURN LINE WHICH COULD CAUSE A FUEL LEAK, AND HEAT DAMAGE TO THE INSULATION AT THE FRONT WALL.

Action:

DEALERS WILL INSPECT AND REPLACE THE INTAKE MANIFOLD FREE OF CHARGE. CHRYSLER, LLC IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. THE RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403 OR SPRINTER AT 843-695-5031.
2002 DODGE SPRINTER 3500
NHTSA Campaign ID:STEERING:COLUMN
Manufacturer:SPRINTER ENGINEERING & COMPLIANCE SUPPOR
Manufacture Dates:11/01/2007 - 11/30/2007
Potential Units Affected:10

Defect Description:

SPRINTER IS RECALLING 10 MY 2001-2006 DODGE AND FREIGHTLINER 2500 AND 3500 VEHICLES. THE WELDING SEAM BETWEEN THE BRACKET AND STEERING COLUMN OF AFFECTED SPARE PARTS DOES NOT MEET DESIGN SPECIFICATIONS. THE RESULT OF AN OUT OF SPECIFICATION WELDING SEAM IS THAT THE STEERING COLUMN MAY DETACH FROM ITS INTERIOR VEHICLE MOUNTING BRACKET.

Consequence:

THE OPERATOR MAY LOSE STEERING ABILITY OF THE VEHICLE INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL INSPECT AND REPLACE THE STEERING COLUMNS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 16, 2009. OWNERS MAY CONTACT SPRINTER AT 843-695-5057.
2002 DODGE SPRINTER 3500
NHTSA Campaign ID:ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Manufacturer:SPRINTER ENGINEERING & COMPLIANCE SUPPOR
Manufacture Dates:10/01/2001 - 09/30/2003
Potential Units Affected:14423

Defect Description:

SPRINTER IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2003 VANS SOLD AS DODGE AND FREIGHTLINER VEHICLES. THE INTAKE MANIFOLDS MAY HAVE CORRODED. A CHEMICAL REACTION INVOLVING SULFUR IN THE DIESEL FUEL THAT TAKES PLACE UNDER CERTAIN CONDITIONS CAN LEAD TO THE FORMATION OF SULFURIC ACID IN THE EXHAUST CHANNEL OF THE INTAKE MANIFOLD.

Consequence:

INTAKE MANIFOLD CORROSION MAY LEAD TO AN EXHAUST GAS LEAK, DAMAGE TO THE FUEL RETURN LINE WHICH COULD CAUSE A FUEL LEAK, AND HEAT DAMAGE TO THE INSULATION AT THE FRONT WALL.

Action:

DEALERS WILL INSPECT AND REPLACE THE INTAKE MANIFOLD FREE OF CHARGE. CHRYSLER, LLC IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. THE RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403 OR SPRINTER AT 843-695-5031.
2002 DODGE SPRINTER 3500
NHTSA Campaign ID:ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Manufacturer:SPRINTER ENGINEERING & COMPLIANCE SUPPOR
Manufacture Dates: -
Potential Units Affected:665

Defect Description:

MERCEDES-BENZ USA (MBUSA) IS RECALLING CERTAIN MODEL YEAR 2002- 2003 SPRINTER 2500 AND 3500 VANS SOLD AS DODGE AND FREIGHTLINER VEHICLES. THE INTAKE MANIFOLDS MAY HAVE CORRODED. A CHEMICAL REACTION INVOLVING SULFUR IN THE DIESEL FUEL THAT TAKES PLACE UNDER CERTAIN CONDITIONS CAN LEAD TO THE FORMATION OF SULFURIC ACID IN THE EXHAUST CHANNEL OF THE INTAKE MANIFOLD.

Consequence:

INTAKE MANIFOLD CORROSION MAY LEAD TO AN EXHAUST GAS LEAK, DAMAGE TO THE FUEL RETURN LINE WHICH COULD CAUSE A FUEL LEAK, AND HEAT DAMAGE TO THE INSULATION AT THE FIRE WALL. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Action:

DEALERS WILL INSPECT AND REPLACE THE INTAKE MANIFOLD FREE OF CHARGE. CHRYSLER, LLC WILL NOTIFY OWNERS OF DODGE SPRINTERS AND MBUSA WILL NOTIFY OWNERS FREIGHTLINER SPRINTERS. THIS RECALL IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE RECALL CAMPAIGN 09V-418). THE SAFETY RECALL BEGAN ON OCTOBER 11, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403 OR SPRINTER AT 1-843-695-5031.
2002 DODGE STRATUS
NHTSA Campaign ID:AIR BAGS:PASSENGER SIDE FRONTAL
Manufacturer:Mitsubishi Motors North America, Inc.
Manufacture Dates:07/29/2000 - 06/14/2002
Potential Units Affected:16315

Defect Description:

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2001-2002 Chrysler Sebring and Dodge Stratus vehicles, equipped with beige interiors. The affected vehicles were previously repaired for a recall issue using an incorrect part. The incorrect part may not prevent the passenger side sun visor from detaching if the passenger frontal air bag deploys and the passenger side sun visor is folded down in a certain position.

Consequence:

If the passenger side sun visor detaches and is propelled rearward, there is an increased risk of occupant injury.

Action:

Chrysler will notify the affected owners. Dealers will install the correct tether strap to retain the passenger sun visor, free of charge. The recall began July 26, 2016, owners will be sent a second email when parts are available. Owners may contact Chrysler customer service at 1-800-853-1403.
2002 DODGE STRATUS
NHTSA Campaign ID:AIR BAGS:PASSENGER SIDE FRONTAL
Manufacturer:Mitsubishi Motors North America, Inc.
Manufacture Dates:04/17/2000 - 02/22/2005
Potential Units Affected:443442

Defect Description:

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2000-2005 Eclipse vehicles manufactured April 5, 1999, to December 17, 2004, 2001-2005 Eclipse Spyder vehicles manufactured January 19, 2000, to March 18, 2005, 2001-2005 Chrysler Sebring vehicles manufactured April 17, 2000, to February 21, 2005, and 2001-2005 Dodge Stratus vehicles manufactured April 17, 2000, to February 22, 2005. In the affected vehicles, the passenger side sun visor may be folded down in such a position that, if the passenger frontal air bag deploys, the passenger side sun visor may detach.

Consequence:

If the passenger side sun visor detaches and is propelled rearward, there is an increased risk of occupant injury.

Action:

MMNA will notify their owners, and Chrysler will notify the Chrysler and Dodge owners. Dealers will install a tether strap to retain the passenger sun visor, free of charge. The recall began on July 20, 2015. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-15-005. Chrysler and Dodge owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R30.
2002 DODGEN MOTORHOME
NHTSA Campaign ID:SEAT BELTS:FRONT:RETRACTOR
Manufacturer:DODGEN INDUSTRIES, INC.
Manufacture Dates:11/07/2001 - 12/06/2001
Potential Units Affected:1

Defect Description:

ONE 22' ESCORT MOTOR HOME EQUIPPED WITH PASSENGER SEAT BELTS WITH RETRACTORS, THE COVER HALVES FOR THE RETRACTABLE PORTION OF THE BELT CAN SEPARATE COMPLETELY AND RELEASE THE SEAT BELT CONNECTOR. IF THIS OCCURS, ONE OF THE LOAD BEARING PINS IN THE CONNECTOR COULD SEPARATE FROM THE CONNECTOR AND RENDER THE SEAT BELT UNUSABLE. IN THE EVENT OF A CRASH, THE SEAT OCCUPANT WOULD NOT BE PROPERLY RESTRAINED RESULTING IN AN INJURY. THE SEAT BELT SUPPLIER, AM-SAFE, WILL PROVIDE A SNAP ON "OVER-COVER" TO OWNERS TO PREVENT THE SEAT BELT COVER FROM SEPARATING.

Consequence:

IF THIS OCCURS, ONE OF THE LOAD BEARING PINS IN THE CONNECTOR COULD SEPARATE FROM THE CONNECTOR AND RENDER THE SEAT BELT UNUSABLE. IN THE EVENT OF A CRASH, THE SEAT OCCUPANT WOULD NOT BE PROPERLY RESTRAINED RESULTING IN AN INJURY.

Action:

THIS MOTOR HOME HAS BEEN CORRECTED.